2008 Mini Cooper

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2017· ENGINE

  CAR TAKES A WHILE TO "WARM UP" HOWEVER AFTER A VERY SHORT DRIVE THE HOOD IS HOT TO THE TOUCH. IT ALSO SMELLS HOT. I LOOKED ON LINE AND SEEN SEVERAL COMPLAINTS AND THERE IS ACTUALLY AN AFTER MARKET 'DEFLECTOR' TO CHANNEL HEAT FROM THE HOOD. I HAVE NOTICED THE PLASTIC HOOD SCOOP IS DEFORMED FROM HEAT. I FEEL IT IS A MATTER OF TIME BEFORE A FIRE OR OTHER REACTION, E.G., HEAT CAUSES ANOTHER PART TO FAIL AND CAR WONT STOP, ACCELERATE OR OTHER CAUSING A CRASH. I ALSO NOTICED THE HEADLIGHT WIRING TO BE FRAYED AS IF IT HAS BEEN HOT.

• 12/28/2012· ENGINEFire

  TL* THE CONTACT OWNS A 2008 MINI COOPER S. THE CONTACT STATED THAT SMOKE WAS SEEN COMING FROM THE ENGINE. THE VEHICLE WAS UNABLE TO COOL DOWN SO THE CONTACT HAD THE VEHICLE TOWED TO A DEALER FOR DIAGNOSIS BUT THEY WERE UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE RECURRED AND HE WAS UNABLE TO DRIVE THE VEHICLE FOR MORE THAN A FEW MILES WITHOUT IT OVERHEATING. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 7,400. THE CURRENT MILEAGE WAS APPROXIMATELY 8,234. THE VIN WAS UNAVAILABLE.

• 12/26/2012· ENGINE

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

• 12/25/2013· POWER TRAIN,ENGINE

  LOUD ENGINE NOISE COMING FROM CHAIN TENSIONER AT STARTUP. SOUNDS LIKE DIESEL ENGINE. ALSO HAPPENS DURING COLD ENGINE START. *TR

• 12/19/2012· ENGINE

  MINI COOPERS YEARS 2008 AND 2009 HAVE A ISSUE WHICH I BELIEVE IS KNOWN BY MINI USA, BUT THEY HAVE FAILED TO INITIATE A VOLUNTARY RECALL. THESE VEHICLES HAVE A TIMING CHAIN THAT CAN PREMATURELY FAIL (IN MY CASE AT APPROXIMATELY 25,000 MILES). IF THE TIMING CHAIN FAILS WHILE THE VEHICLE IS BEING DRIVEN, IT WILL CAUSE THE VEHICLE TO SLOWLY COME TO A FULL STOP. IN THE EVENT THE VEHICLE IS BEING DRIVEN IN A HIGHWAY, THIS STOP COULD CAUSE A SEVERE ACCIDENT THAT POTENTIALLY CAN INVOLVE MANY VEHICLES. THIS IS A VERY SERIOUS ISSUE, BECAUSE MOST MINI OWNERS WOULD NOT EXPECT A TIMING CHAIN TO FAIL SO PREMATURELY. *TR

• 12/17/2015· ENGINE

  IN THE SPRING 2014 I PURCHASED A 2008 MINI COOPER 2D HATCH WITH AROUND 98,0000 MILES FOR $14,000 WITH WARRANTY IN IVRINGTON, NJ FROM SPRINGFIELD AUTO GROUP AUTO SALES. IN JANUARY 2015 I HAD A TUNE UP DONE AND THE MECHANIC REPORTED TO ME AFTER DOING A ENGINE DIAGNOSTIC TEST THAT THERE WAS A PROBLEM WITH MY IMMEDIATELY REPORTED THE PROBLEM TO MY WARRANTY COMPANY THAT WAS PROVIDED THROUGH MY THE CAR LOAN COMPANY CREDIT ACCEPTANCE. THE WARRANTY COMPANY REFUSED TO PAY FOR ENGINE TO BE DROPPED OUT OF THE CAR TO FIND OUT WHAT THE PROBLEM WAS. THEY ADVISE ME THAT I WOULD HAVE TO PAY FOR THE ENGINE TO BE DROPPED OUT OF THE CAR TO BE AND CHECKED OUT BEFORE THEY PAY FOR ANYTHING. IN OCTOBER 2015 THE MINI COOPER ENGINE FINALLY BROKE DOWN WHILE DRIVING I HAD TO PULLED IT OVER WHILE DRIVING UP ROUTE 280. THE WRECKER SERVICE TOOK THE MINI TO A MECHANIC. THE MECHANIC STATED THE TIMING CHAIN HAD BROKE AND THERE WAS MAJOR ENGINE DAMAGE AND THE REPAIR BILL WILL BE FROM 2K TO REBUILD THE ENGINE AND 8K FOR A NEW ONE AND I STILL OWN 11K TO BANK FOR THE CAR. THE CAR HAS APPROXIMATELY 106K MILES ON IT. I'VE HEARD OF A LOT OF COMPLAINTS WITH THOSE MINIS WITH THOSE SAME ISSUES HAPPENING ANYWHERE FROM 30K MILES TO OVER 100K MILES FROM 2007-2010 MODELS. NOTHING ELSE HAS BEEN SPENT ON THE CAR FOR REPAIR. I'M NOT WASTING ANYMORE MONEY ON THAT JUNK MINI COOPER. IT'S TO LATE FOR THE LEMON LAW TO BE APPLIED. CAN ANYTHING GET DONE SO THAT I CAN IMPLEMENT A LAWSUIT AND RECEIVE ANY MONEY FOR THAT FROM BMW OR AND THE DEALER OR IS IT A WASTE OF TIME? THANK YOU IN ADVANCE. *TR

• 12/16/2013· ENGINE

  THE CAR STARTS VERY ROUGH ESPECIALLY IN COLDER WEATHER. I WAS TOLD BY A MINI DEALERSHIP THAT COULD HAVE BEEN DUE TO LACK OF OIL, WHICH IS NOT THE CASE AS THE OIL WAS JUST CHANGED. ALSO WHEN IN TRAFFIC COMING TO A STOP THE CAR WILL DROP IDLE AND STALL OUT. THE CAR WILL STALL IN NEUTRAL OR WITH CLUTCH FULLY PRESSED IN. RESEARCHING ONLINE AND WATCHING SOME VIDEOS, IT SEEMS MUCH LIKE THE TIMING TENSION/CHAIN ISSUES KNOWN BUT NOT YET HAVING MUCH DONE WITH THEM. IT WOULD BE NICE IF BMW/MINI WOULD SORT OUT THE ISSUE ESPECIALLY IF ITS A DESIGN FLAW. KINDA DISAPPOINTED AS ITS NOT THAT OLD AND HAS FEWER THEN 50K MILES ON THE ENGINE. *TR

• 12/16/2010· ENGINE AND ENGINE COOLING

  2008 MINI COOPER S. NO ENGINE MODIFICATION. LOUD KNOCKING NOISE ON START UP AND CONTINUES FOR ABOUT 5 MINS OF DRIVING AND THEN GOES AWAY. MILE IS UNDER 8900 MILES. *TR

• 12/16/2009· ELECTRICAL SYSTEM

  MY 2008 MINI COOPER SPEEDOMETER IS OFF BY APPROXIMATELY 6 MILES AN HOUR. SO THAT IF I AM ACTUALLY DRIVING AT 50 MPH THE SPEEDOMETER WILL SHOW 56 MPH. ADDITIONALLY, IF I DRIVE 100 MILES, THE ODOMETER WILL ACTUALLY SHOW AS IF I DROVE 106 MILES. THIS IS BOTH A SAFETY ISSUE AS THE INSTRUMENTATION IS WRONG, AS WELL AS A FRAUD ISSUE AS THE CAR LOSES VALUE BECAUSE OF THE PERCEIVED ADDITIONAL MILES DRIVEN AND WOULD BE OUT OF WARRANTY SOONER BECAUSE OF THE PERCEIVED MILEAGE AMOUNT. ALSO, IF THIS WERE A LEASE AND I WENT OVER THE AMOUNT ALLOTTED BY SAID LEASE, MINI WOULD PENALIZE THE DRIVE PER THE MILEAGE. BMW/MINI HAS TOLD ME THAT THEY ARE AWARE OF THE ISSUE AND SAY ITS NOT A PROBLEM AS THEY GIVE ALOT OF LEEWAY FOR THE ACCURACY OF THE SPEEDOMETER. *TR

• 12/14/2009· ENGINE AND ENGINE COOLING

  NOISE IN ENGINE AFTER COLD START. ENGINE WAS REPLACED BY MINI OF PEABODY MA AFTER A INTERNAL ENGINE FAILURE. THIS IS A 2008 COOPER S JCW AND THE ENGINE HAS BEEN NOISY SINCE IT WAS REPLACED. NOISE GOES AWAY AFTER IT WARMS UP. DEALER TELLS ME NOTHING IS WRONG. ORIGINAL ENGINE FAILED AT 8,000 MILES AND SO DID THE TRANSMISSION AND HAD TO BE REPLACED AS WELL. NOW AT 17,000 MILES TRANSMISSION OK BUT ENGINE SOUNDS LIKE IT IS KNOCKING AT START UP. *TR

• 12/09/2016· ENGINE

  THE TURBO OIL FEED LINE IS INHERENTLY FLAWED AND PREMATURELY FAILS BECAUSE OF A BAD DESIGN. THIS FAILURE CAUSES HOT OIL TO LEAK ALL OVER A HOT TURBO. I WAS LUCKY ENOUGH TO NOT HAVE MY ENGINE CATCH FIRE WITH THE FAILED O-RING ON MINE. I WAS DRIVING ON THE HIGHWAY WHEN LARGE CLOUDS OF SMOKE BEGIN TO FLOW FROM THE ENGINE COMPARTMENT. I WAS FORCED TO PULL OVER AND GET TOWED HOME. I WAS OUT OF WARRANTY BUT STILL VERY LOW MILEAGE (48K) WHEN MINE FAILED. *TR

• 12/07/2022· AIR BAGS

  Supplemental Restraint System (SRS) Airbag Warning Light has come on indicating a malfunction with this safety system and consequently that the airbag safety system may not deploy in the event of an accident. This problem is not unique to my specific vehicle and appears to be a very common issue amongst BMW Mini vehicles as evidenced by much discussion on forums across the internet.

• 12/07/2015· POWER TRAIN,AIR BAGS,ENGINECrash

  TL* THE CONTACT OWNS A 2008 MINI COOPER. WHEN SHIFTING INTO FIRST GEAR, THE VEHICLE EASILY SWITCHED INTO THE REVERSE POSITION. THE CONTACT WAS INVOLVED IN A CRASH. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 46,000.

• 12/05/2011· AIR BAGS

  TL* THE CONTACT OWNS A 2008 MINI COOPER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT SPORADICALLY ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 26,000.

• 12/04/2023· ELECTRICAL SYSTEM

  The contact owns a 2008 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 12/02/2019· AIR BAGS

  PASSENGER SIDE AIRBAG SEAT MAT IS DEFECTIVE. JUST STOPPED WORKING. COST TO REPLACE IS OVER $2000. SO, THE WARNING LIGHT FOR DEFECTIVE AIRBAG SENSOR REMAINS ON.

• 12/01/2015· ENGINE

  ON 15 AUG 2015 I PURCHASED A 2008 MINI COOPER 2D HATC WITH 122,629 MILES FOR $6,325 WITH NO WARRANTY IN STANFORD, NC FROM KARAS AUTO SALES, INC. ON 27 OCT 2015 THE MINI COOPER BROKE DOWN WHILE DRIVING AND PULLED IT OVER BESIDE THE ROAD. THE WRECKER SERVICE TOOK THE MINI TO A MECHANIC. THE MECHANIC STATED THE TIMING CHAIN HAD BROKE AND THERE WAS MAJOR ENGINE DAMAGE AND THE REPAIR BILL WILL BE FROM 8K TO 10K IN REPAIR COST. MINI HAD APPROXIMATELY 125K MILES ON IT. I'VE HEARD OF A LOT OF COMPLAINTS WITH THOSE MINIS WITH THOSE SAME ISSUES HAPPENING ANYWHERE FROM 30K MILES TO OVER 100K MILES FROM 2007-2010 MODELS. NOTHING ELSE HAS BEEN SPENT ON THE CAR FOR REPAIR. I'M NOT WASTING ANYMORE MONEY ON THAT JUNK MINI COOPER. IT'S TO LATE FOR THE LEMON LAW TO BE APPLIED. CAN ANYTHING GET DONE SO THAT I CAN IMPLEMENT A LAWSUIT AND RECEIVE ANY MONEY FOR THAT FROM BMW OR AND THE DEALER OR IS IT A WASTE OF TIME? THANK YOU IN ADVANCE.

• 11/30/2015· ENGINE

  AS MANY OTHERS HAVE POSTED HERE, MY ENGINE BEGAN RATTLING LOUDLY WHEN I WOULD START IT UP. TO ALLEVIATE THIS, I WOULD TOP OFF THE OIL AND GET FREQUENT OIL CHANGES, IN FACT, MORE OFTEN THAN MINI/BMW SUGGESTED IT SHOULD GET AN OIL CHANGE. THIS WOULD USUALLY TAKE CARE OF THE RATTLE. ONE NIGHT, THE ENGINE RATTLE KEPT INCREASING AND SUDDENLY THE CAR STOPPED IN THE MIDDLE OF A BUSY STREET JUST 20 FEET FROM RAILROAD TRACKS WITHOUT ANY WARNING LIGHTS OR INDICATIONS WHATSOEVER. I HAD IT TOWED TO A NEARBY MECHANICS SHOP I TRUST (NOT THE DEALERSHIP). THE TIMING CHAIN HAD BROKEN AND BENT THE VALVES AND I'M IN THE PROCESS OF HAVING A NEW ENGINE PUT IN (WITH THE SAME FAULTY TIMING CHAIN) TO THE TUNE OF $6,500. I CALLED MINI/BMW USA BECAUSE MY MECHANIC SAID HE'S SEEN THIS PROBLEM FREQUENTLY IN MY MODEL. MINI SAID THEY WOULD NOT DO ANYTHING FOR ME UNLESS THE CAR WAS DIAGNOSED BY THE MINI DEALERSHIP, AND EVEN THEN THERE WOULD BE NO GUARANTEE THEY WOULD COVER ANYTHING BECAUSE OF "MY VEHICLE'S AGE." MINI/BMW USA WOULDN'T EVEN ACKNOWLEDGE THAT THERE HAVE BEEN FREQUENT REPORTS OF TIMING TENSIONER/CHAINS HAVING PROBLEMS. I'M EVEN MORE SURPRISED HOW FREQUENT THIS PROBLEM IS NOW THAT I'M LOOKING ON THE NHTSA WEBSITE. THIS NEEDS TO BE A RECALL AND SOMETHING THAT MINI/BMW SHOULD COVER AND RESPOND TO, SINCE THERE HAVE BEEN SEVERAL CLASS ACTION LAWSUITS AGAINST THE COMPANY BECAUSE OF THIS.

• 11/26/2012· STRUCTURE,ENGINE

  AS I WAS DRIVING MY CAR STARTED CHUGGING. I PULLED OVER AND KEPT CHUGGING. I STOPPED THE CAR, LOOKED UNDER THE HOOD AND SAW IF SOMETHING WAS WRONG. DID NOT SEE ANYTHING. STARTED IT UP AGAIN AND ONCE I ACCELERATED IT STOPPED CHUGGING. DROVE IT VERY SCARCELY AND BROUGHT IT INTO THE DEALERSHIP. WAS TOLD IT WAS A TIMING CHAIN. VERY LUCKY THAT IT HAS NOT SNAPPED OR SKIPPED BECAUSE YOU WOULD HAVE POSSIBLY LOSE CONTROL. THE CAR ONLY HAS 36000 MILES ON IT AND HAS HAD THE OIL LEVEL TOPPED OFF EVERY FEW FILL UPS. THEY DO NOT LOOK AT THIS AS A MANUFACTURING DEFECT, EVEN THOUGH IT HAS HAPPENED ON QUITE A FEW CARS. MY LOCAL MECHANIC SAID HE HAS NEVER HEARD OF A TIMING CHAIN SNAPPING OR STRETCHING TO WHERE IT NEEDS TO BE REPLACED AT 36000 MILES. IT IS DANGEROUS AND ALSO VERY COSTLY TO PAY FOR. *TR

• 11/26/2011· ENGINE AND ENGINE COOLING

  I DROVE LESS THAN A MILE AND SMOKE STARTED COMING OUT OF THE ENGINE. THE TURBOCHARGER WAS LEAKING OIL ONTO THE ENGINE, WHICH ALMOST CAUSED THE CAR TO CATCH ON FIRE. *TR

• 11/23/2012· ENGINE

  BEGAN TO HEAR LOUD KNOCKING NOISE FROM ENGINE OF MY 4 YEAR OLD MINI @ 66000 MILES. HAVE HAD MY MINI SERVICED ACCORDING TO THE SCHEDULE AT THE SAME DEALERSHIP FOR 4 YEARS. AFTER HEARING THE NOISE DID RESEARCH ONLINE TO NOTICE THAT MINIS HAVE A TIMING BELT /TENSIONER ISSUE. NOTICED ON THE SAME NIGHT THAT MY OIL LIGHT CAME ON AND THE INTERESTING THING IS THAT I JUST HAD MY OIL CHANGED IN AUGUST OF 2012 AND THIS WAS NOVEMBER 2012. TOOK CAR TO DEALER AND THE SERVICER SAID THEY HAD HEARD OF SOME MINI'S TIMING CHAINS FAILING AT 14K MILES. AFTER DIAGNOSIS HE NOTES THAT IT IS THE TIMING CHAIN AND THAT THE OIL FILTER GASKET WAS LEAKING WHICH CAUSED THE TIMING CHAIN TO FAIL. THIS IS NOT CORRECT AS MY VEHICLE HAS NEVER LEAKED OIL, AND I HAD JUST GOTTEN MY OIL CHANGED 3 MONTHS EARLIER AND NO MENTION WAS MADE BY MY SERVICE TECHNICIAN. THIS SEEMS TO BE A COMMON ISSUE IN MINIS AND THEY ARE NOT PROVIDING ANY KIND OF RELIEF. *TR

• 11/21/2016· ENGINE

  IN SEPTEMBER, 2013, MY 2008 MINI COOPER HARDTOP, WITH THE N12 ENGINE, HAD THE TIMING CHAIN FAIL UNDER OPERATION. THIS CAUSED THE ENGINE TO STOP, AT HIGHWAY SPEED, AFFECTING STEERING, BRAKING AND ALL ABILITY TO MANEUVER THE VEHICLE OUT OF TRAFFIC. TWO VEHICLES BARELY AVOIDED MY DISABLED VEHICLE. I CONTACTED MINI USA AND THEY REFUSED TO ACKNOWLEDGE THE FACTORY DEFECT IN THE TIMING-CHAIN TENSIONER THAT CAUSES THE TIMING CHAIN TO FAIL. I PAID OVER $8000 FOR A REPLACEMENT N12 ENGINE. WITH LESS THAN 10,000 MILES ON THE REPLACEMENT ENGINE, IN JULY, 2016, THE TIMING CHAIN FAILED AGAIN. THIS TIME THE VEHICLE WAS CROSSING A BRIDGE AND THERE WAS NO PLACE TO TRY TO PULL OFF. THE SITUATION WAS VERY DANGEROUS AND LEFT MY FAMILY VULNERABLE TO ONCOMING TRAFFIC. I CONTACTED MINI USA AGAIN, AND ALTHOUGH THEY HAVE ADMITTED TO THE TIMING CHAIN DEFECT ON THEIR N14 ENGINE, IN THE S SERIES VEHICLE, THEY STILL REFUSE TO ISSUE A RECALL FOR THE N12 ENGINES IN WHICH THE TIMING CHAIN FAILURES ARE MORE NUMEROUS. THIS DEFECT CAUSES THE VEHICLE TO BECOME INOPERABLE AT SPEED WHICH IS UNSAFE IN THE EXTREME. MINI USA NEEDS TO ISSUE A SAFETY RECALL FOR EVERY VEHICLE EQUIPPED WITH THE N12 ENGINES.

• 11/21/2010· ENGINE AND ENGINE COOLING

  WHEN STARTING THE CAR COLD (FIRST THING IN THE MORNING OR AFTER IT HAS BEEN OFF FOR A LONG TIME), THE ENGINE MAKES A LOUD RATTLING NOISE SORT OF LIKE A TRACTOR NOISE WHEN ACCELERATING. IT GOES AWAY AFTER A COUPLE OF MINUTES OF CONTINUOUS DRIVING, BUT SOMETIMES WHEN TURNING AND ACCELERATING AT THE SAME TIME, IT ALSO MAKES THE SAME NOISE.

• 11/18/2013· ENGINE

  TURBO OIL SUPPLY LINE IS LEAKING OIL ON MY 2008 COOPER S, THE DEALER HAS RECOMMEND REPLACEMENT AT A COST OF $900. I INITIALLY TOOK THE CAR IN FOR A RECALL TO INSTALL A HEAT SHIELD ON THE SAME OIL LINE, SOME ONLINE RESEARCH (INCLUDING MANY OFFICIAL COMPLAINTS HERE) HAS SUGGESTED THAT THE LACK OF A HEAT SHIELD HAS CAUSED THIS FAILURE, YET IT IS NOT COVERED UNDER THE RECALL. YET ANOTHER UNFORTUNATE DEFECT IN THE MINI DESIGN, I'VE ALREADY BEEN THROUGH THE TIMING CHAIN/TENSIONER DEBACLE. *TR

• 11/18/2010· ENGINE AND ENGINE COOLING

  NOTICED A STRANGE SOUND, ALMOST LIKE WHEEL BEARINGS WERE GRINDING. ON NOVEMBER 11, 2010, WHEN STARTING THE VEHICLE, CHECK ENGINE LIGHT CAME ON, AND ENGINE DID NOT SEEM TO HAVE AS MUCH POWER AS IT SHOULD. TOOK TO THE MINI DEALERSHIP AND THEY SAID THE ENGINE LIGHT WAS ON BECAUSE THE TURBO WAS DAMAGED. APPARENTLY THE OIL SUPPLY HOSE TO THE TURBO WAS EITHER BLOCKED OR CUT, AND WAS NOT PROVIDING OIL TO THE TURBO. AS A RESULT OF THE LACK OF OIL, THE BEARINGS IN THE TURBO WERE RUINED. HAD TO REPLACE THE ENTIRE TURBO. AFTER THE TURBO WAS REPLACED WE WERE TOLD THE TIMING CHAIN WAS GOING BAD. WAS TOLD THE TIMING CHAIN, TENSIONERS, AND GUIDES NEEDED TO BE REPLACED. I'VE READ WHERE THE TIMING CHAIN HAS BEEN A CONTINUING PROBLEM WITH MINI COOPERS, AND THAT, IF FIXED, IT WILL GO BAD AGAIN AND COULD CAUSE A SEVERE ENGINE PROBLEM, RESULTING IN FAILURE. I ALSO WONDER IF THE TIMING CHAIN IS ALREADY DAMAGED ENOUGH TO CAUSE THE OIL SUPPLY HOSE TO THE TURBO TO BE DAMAGED.

• 11/17/2023· ELECTRICAL SYSTEM

  The contact owns a 2008 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

• 11/17/2009· AIR BAGS

  "PASSENGER AIRBAG OFF" LIGHT WILL ILLUMINATE, INDICATING THAT PASSENGER AIRBAG IS TURNED OFF, WHEN A FULL SIZED ADULT IS OCCUPYING THE PASSENGER SEAT WITH SEAT BELT BUCKLED. *TR

• 11/16/2015· ENGINE

  AFTER MINI/BMW REPAIRED THE TIMING CHAIN TENSIONER AND THE TIMING CHAIN, MY TURBO OIL SUPPLY LINE DEVELOPED A SIGNIFICANT LEAK (WITHIN A WEEK/ WITHIN 200 MILES OF MINI SERVICE) CAUSING SMOKE TO ESCAPE FROM THE BONNET, OIL TO COVER THE FRONT ENGINE/TURBO/EXHAUST. OIL NOW PUDDLES BENEATH THE CAR WHEN PARKED. THE CAR HAS 89,XXX MILES. I FIRST NOTICED THE SMELL OF BURNING OIL WHEN DRIVING ACROSS TOWN AT A SPEED OF 40MPH. WHEN PARKING THE VEHICLE, UPON IDLE THE SMOKE BILLOWED FROM THE BONNET OF THE CAR. ACCORDING TO MINI FORUMS, THIS PROBLEM OF A FAILED O-RING IN THE TURBO OIL SUPPLY LINE IS A KNOWN PROBLEM RESULTING IN NUMEROUS FAILURES THAT CAN LEAD TO CATASTROHIC DAMAGE TO THE TURBO, CATALYTIC CONVERTER, AND ENGINE.

• 11/16/2015· AIR BAGS

  I BOUGHT THIS CAR USED WITH 86,100 MILES ON IT. WHEN DRIVING WITHIN THE FIRST 500 MILES, THE AIRBAG LIGHT AND SEAT BELT RESTRAINT SYSTEM INDICATED ON MY DASH (BOTH THE TACHOMETER AND THE SPEEDOMETER). AN ALERT FOR THE AIRBAG APPEARS AS AN ICON ON THE TACHOMETER. I TOOK THE CAR TO THE DEALERSHIP WHO INDICATED THE AUTO GOT WET WHICH CAUSED THE AIR BAG MODULE TO FAIL, WHICH NOW NEEDS REPLACEMENT AT A RIDICULOUSLY HIGH COST.

• 11/16/2015· AIR BAGS

  AIR BAG WARNING WITH THE FAULT CODE 93C3 WHICH HAS CAUSED A RECALL OF 91 THOUSAND VEHICLES... MY MINI S IS NOT A RECALL CAR. (ON THE SAME GRID AS THE RECALLED MINI'S...SAME OEM REPAIR PARTS) MINI USA REPRESENTATIVE [JAMIE] SUGGESTED I REMOVE THE AIR BAG AND PUT A SIGN UP IN THE DASH INDICATING 'NO AIR BAG" IF I DID NOT WANT TO PAY THE $1500.00+ IN REPAIIR COST... AND THAT WILL ALLOW ME TO PASS THE STATE INSPECTION.

• 11/13/2012· EQUIPMENT ADAPTIVE/MOBILITY,ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES

  DEAR NHTSA, I NEARLY LOST MY LIFE 3WKS BACK, MY CAR IS FILLED WITH AFTERMARKET PRDT. MY CARS COMPUTER IS FAILED ALSO, WHICH WON'T ALERT OR RECORD ANY INCIDENT. I TRIED TALKING TO MINIUSA&CARMAX, THEY WONT LISTEN. I HAVE AN HEART CONDITION NOW COZ OF THE NEAR DEATH EXPERIENCE. I DEVELOPED A LOW HIGH BP 80/103 & FAST HEARTBEAT, WHICH I AM TAKING MED. AFTER THE INCIDENT. I WROTE LETTERS&POSTED ON THEIR FACEBOOK PAGE NO RESPONSE. I NEED HELP! I USED TO BE A PROUD OWNER OF 2008 MINI COOPER! NOW MY CAR TURNED INTO A DEATH TRAP! ITS NOTHING BUT A NIGHTMARE, SO FAR 3 TIMES CAR WAS TURNED OFF IN THE MIDDLE OF THE ROAD & FREEWAY, WHEN IT HAPPENED I APPLIED MY (ALL THREE TIMES) BREAK WHICH WENT TO THE FLOOR, DIDN'T WORK, BOUGHT THE CAR FROM CARMAX WITH A WARRANTY (EXTENDED), ALSO THE CAR HAS 53,100 MILES ONLY! CALLED CARMAX BURBANK OFFICE NO RESPONSE, THEN CALLED CARMAX OFFICE OF THE PRESIDENT AFTER A GREAT DEAL GOT RESPONSE FROM A REP. NOW THE CAR IS WITH UNIVERSAL CITY MINI OF NOHO! CARS BREAK SYS. IS AN AFTER MARKET PROD. MY CAR COMPUTER/DASH DISPLAY CHECK ENGINE LIGHT OR SIGNAL COMES ON EVERY 3-4 MONTHS, WHEN IT DOES, THE LIGHT WILL STAY ON FOR A DAY OR TWO, THEN IT DISAPPEARS, WHEN I MENTIONED THIS TO MINI DEALERSHIP, CAR KEY RECORDS ALL THE ACTIVITIES OF THE CARS ENGINE AND INCIDENTS, WHEN THE REP. AT DEALERSHIP DOWNLOADED THE CAR KEY, HE COULDN'T FIND A SINGLE INCIDENT, THEN I SHOWED HIM THE PIC I TOOK.. HE WAS SURPRISED... " THIS CAR IS NOTHING BUT A LEMON" POORLY HANDLED BY CARMAX AND MINI. THIS CAR WILL KILL SOMEONE, IF YOU LET IT DRIVE. PLEASE SAVE MY LIFE AND OTHERS. LTRS WERE SENT TO CARMAX&MINI USA CEO'S TOM FOLLIARD CEO OF CARMAX,[XXX] AND [XXX]. NONE OF THEM, EVEN BOTHERED TO REPLY, RESPOND OR TRIED TO REACH OUT TO RESOLVE THIS MATTER: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 11/11/2017· ENGINE

  TIMING CHAIN TENSIONER FAILURE. I HAD TO REPLACE CHAIN, TENSIONERS AND CRANK GEAR ON MY 2008 MINI WITH 81,000 MILES.

• 11/10/2014· AIR BAGS,SEAT BELTS

  AIRBAG AND SEATBELT LIGHT REMAIN ON IN THE VEHICLE. I WILL NOT PAY THE OUTRAGEOUS AMOUNT OF MONEY THE DEALERSHIP WANTS THE FIX OR REPLACE WHATEVER IS WRONG WITH IT. MAYBE ILL BE THE FIRST PERSON INJURED BECAUSE OF THIS FAULT THAT A RECALL ACTUALLY IS ISSUED FOR THIS DEFECT. *TR

• 11/09/2015· AIR BAGS

  THE MILEAGE ON THE VEHICLE 16600MILES. THE WARNING LIGHT FOR THE FRONT PASSENGER AIRBAG GOES ON INTERMITTENTLY. THE LIGHT FOR THE FRONT PASSENGER AIRBAG ILLUMINATES "OFF". TOOK TO DEALERSHIP AND FOUND THE PASSENGER SEAT MAT FAULTY. STARTED FLICKERING WHILE DRIVING BUT NOW THE LIGHT IS ON CONSTANTLY WHEN START CAR AND DRIVING. I HAVE READ THAT THERE IS A RECALL FOR THIS PROBLEM FOR VEHICLES MANUFACTURED UP TO JULY 2008. MY MINI S SHOWS A PRODUCTION DATE 8/01/08. I HAD THIS CAR BUILT TO MY SPECIFICATION IN JULY 2008. I HAVE PAID FOR THE PART BECAUSE I BELIEVE THIS IS FOR THE SAFETY FOR WHOM EVER RIDES WITH ME BUT THE PART IS ON BACKORDER AND WE ARE WAITING FOR IT TO ARRIVE FROM GERMANY. BMW/MINI HAVE NOT RESOLVED THE ISSUE IF IT IS STILL HAPPENING. THE COST TO REPAIR IS APPROX.$ 2153.00. IF I WAIT TILL I GET A RECALL AND THERE IS A FATALITY.....? IF AT A LATER DATE A RECALL IS MADE FOR MY VEHICLE CAN I GET THE FULL COST REIMBURSED?

• 11/05/2013· ELECTRICAL SYSTEM,AIR BAGS

  I CAN'T TELL EXACTLY THE MILEAGE OF THE CAR BY THE TIME THE ALARM POP UP, BUT IT WAS ABOUT 64K AS SPECIFIED ABOVE. AT THAT TIME THE PASSENGER AIR BAG ALARM COMES "ON" THE CAR WITH A PASSENGER SEATED. IT ALL STARTED INTERMITTENT BUT AFTER A WEEK THE LIGHT REMAINS ON ALL THE TIME, ALONG WITH THE WARNING "PASSENGER AIR BAG OFF". BOTH LIGHTS (THE ALARM AND THE WARNING) REMAINS ON ALL THE TIME. I BROUGHT THE CAR TO THE SERVICE DEPT. AND AFTER 117.00 FOR A DIAGNOSTIC, THEY CONCLUDE THAT THE "SENSOR MAT (OC3) SIB 657506" (WHATEVER THAT IS) WAS BROKEN AND NEEDS REPLACEMENT. THEY ARE CHARGING A TOTAL OF $2,608 FOR PARTS AND LABOR (INCLUDING TAXES). AFTER THIS TROUBLE AND A STRETCHED TIMING CHAIN THAT WAS DIAGNOSE WERE COVERED THE THREE DAYS THE CAR SPENT AT THE SERVICE DEPARTMENT, I ASKED MINI OF AMERICA TO CALL ME BACK, BUT AFTER SOME E-MAILS BACK AND FORWARD, THE. *TR

• 11/05/2008· ENGINE AND ENGINE COOLING

  VERY NOISY DRIVE TRAIN UPON INITIAL START-UP; MORE SIGNIFICANT WHEN ENGINE IS COLD. NOISE ABATES AS ENGINE WARMS. *TR

• 11/03/2015· ENGINE

  WHEN STARTING CAR, I GET A GRINDING, RATTLING NOISE FROM THE ENGINE. I HAVE BEEN TOLD THIS IS THE CHAIN TENSIONER ON THE CAR

• 11/02/2013· ENGINE

  BOUGHT CAR FROM DEALERSHIP AFTER A LOT OF RESEARCH ON ISSUES WITH THESE CARS AN COMPLAINTS. BROUGHT VARRO MINI DEALERSHIP AND ASKED ABOUT TIMING CHAIN AND TENSIONER AND WAS TOLD MINE WAS FINE EVEN THOUGH THEY NEVER OPENED UP COVER TO INSPECT CHAIN OR TENSIONER. HAVE BEEN BACK THREE DIFFERENT TIMES WITH MULTIPLE ISSUES WITH TIMING CHAIN/TENSIONER HORRIBLE RATTLE. MINI SAYS THERE IS NO KNOWN DEFECTS WITH TIMING CHAIN/ TENSIONERS EVER BROUGHT UP. I THEN WAS TOLD BY MY BROTHER THAT HE I TAKING HIS MINI IN FOR A SERVICE ACTION ON THE TIMING CHAIN/TENSIONER, TURBO HEAT SHIELD, THERMOSTAT HOUSING. WE HAVE EXACT SAME CAR, SAME BUILD DATE, AND ROLLED OUT FROM SAME FACTORY BUT MINI STATES OURS ISN'T COVERED UNDER THE SERVICE ACTION EVEN THOUGH WE HAVE THE EXACT SAME CAR AND EVERYTHING. AND MY BROTHER IS ALSO OUT OF WARRANTY BUT THEIRS IS GETTING FIXED FREE. PLEASE HELP. I AM AWARE OF THE FREEMAN-SKEEN CLASS ACTION LAWSUIT AND HAVE FILE A COMPLAINT WITH BBB SO I GUESS I'LL HAVE TO FIND LEGAL HELP SINCE THEY DON'T PAY ATTENTION TO NHTSA COMPLAINTS. *TR

• 10/31/2012· FUEL/PROPULSION SYSTEM

  WHILE DRIVING I NOTICED THE SMELL OF GASOLINE THAT BECAME INCREASINGLY STRONGER. AFTER I ARRIVED HOME I BEGAN LOOKING FOR THE SOURCE OF THE GASOLINE SMELL. WHAT I FOUND WAS THE HIGH PRESSURE FUEL LINE THAT SUPPLIES FUEL TO THE INJECTOR RAIL WAS LEAKING. THE WAY THE HOSE WAS ROUTED ON THE BACK OF THE ENGINE, ALLOWED THE HOSE TO REST ON A RETAINING CLIP FOR ANOTHER HOSE. THE RETAINING CLIP HAD WORN A GROOVE INTO THE HIGH PRESSURE LINE AND GASOLINE WAS SPRAYING ACROSS THE BACK OF THE ENGINE AND DOWN ONTO THE ENGINE EXHAUST. *TR

• 10/28/2020· AIR BAGS

  THE FRONT PASSENGER SEAT OCCUPANT DETECTION MAT SENSOR HAS FAILED. THE FRONT PASSENGER AIR BAG IS NOT ACTIVATE IN A CRASH WHEN THE SEAT IS OCCUPIED. RECALLS ACTIVE FOR THIS EXACT ISSUE FOR THE SAME MAKE IN OTHER YEARS AND MODELS ARE CURRENTLY RECALLED HOWEVER OTHERS ARE EXCLUDED.

• 10/27/2013· ENGINE

  IT HAS OIL LEAKS AROUND TURBO LINE WHICH THE OILS MAKE SMOKES AS THE OIL DRIP CONTACTS WITH DOWN PIPE. THIS MAY RESULT IN SERIOUS DAMAGE TO THE CAR. *TR

• 10/27/2011· ENGINE AND ENGINE COOLINGFire

  THE VEHICLE WAS DRIVEN APPROXIMATELY 1 MILE, THEN STOPPED AT A GAS STATION TO ADD AIR TO A LOW TIRE. WHILE THE CAR WAS IDLING, WHITE SMOKE CAME FROM THE ENGINE, FOLLOWED BY DARK SMOKE. WHEN THE HOOD WAS OPENED, WE SAW A SMALL FLAME COMING FROM INSIDE THE FRONT OF THE ENGINE. WE RAN TO GET A FIRE EXTINGUISHER FROM THE GAS STATION ATTENDANT; BY THE TIME WE RETURNED, FLAMES WERE VISIBLY SHOOTING UP OUT OF THE ENGINE. WE WERE ABLE TO EXTINGUISH THE FIRE WITH A HAND-HELD FIRE EXTINGUISHER. THERE WERE NO INJURIES AND THE FIRE DEPARTMENT WAS NOT CALLED. THE VEHICLE WAS TOWED TO THE NEAREST MINI DEALER. THE SERVICE ATTENDANT DECLARED THAT HE HAD NO EXPERIENCE WITH ANY ENGINE FIRES IN HIS TENURE WITH MINI. AFTER AN INVESTIGATION (PICTURES TAKEN BY SERVICE AND EMAILED TO MINI CORPORATE), THE AUXILIARY WATER PUMP WAS FOUND TO BE THE SOURCE. IT WAS REPLACED, ALONG WITH A NUMBER OF CONNECTORS AND HOSES, AND THE ENGINE WAS CLEANED OF FIRE EXTINGUISHER POWDER. WHEN I ASKED SEVERAL TIMES ABOUT THIS PROBLEM, THE ONLY ANSWER I RECEIVED WAS THAT THIS STAFFER HAD NEVER HEARD OF A CAR FIRE LIKE THIS IN HIS TIME (3 YEARS) AT MINI.

• 10/26/2015· ENGINE

  PURCHASED AT 61,000 MILES 9/9/14; HAD SYNTHETIC OIL CHANGE 5/15; 9/29/15 CAR BEGAN TO HAVE A RATTLE BUT UNSURE IF IT WAS FRONT OF CAR OR BACK OF CAR. RATTLING STOPPED ON ACCELERATION. NO WARNING LIGHTS CAME ON. 10/4/15 CAR DIED AT 69,362 MILES WHILE DRIVING ON A TWO LANE ROAD ON A CURVE. WAS ABLE TO COAST TO GETTING HALF THE CAR OFF THE ROAD. BYPASSERS PUSHED ME OFF THE REST OF THE WAY. TOWED TO MECHANIC WHO SAID IT WAS THE TIMING CHAIN GUARD THAT SPLIT OFF. CALLED MINI THEY SAID THEIR DEALERSHIP SERVICE DEPT HAD TO LOOK AT IT. HAD IT TOWED TO OH 70 MILES AWAY. THEY TOLD ME I HAD AN OIL LEAK WHICH CAUSED THE FOLLOWING TO BE DAMAGED - CRANK SHAFT, HARMONIC BALANCER, CYLINDER HEAD, TIMING CHAIN AND GUARD AND MAYBE OTHER STUFF BUT THEY COULDN'T TELL WITHOUT FURTHER EXAMINATION. TOLD $5,000 PLUS TO FIX, BUT I SEE MINI ESTIMATE STATES $3,500-4,500. MY LOCAL MECHANIC FOUND NO EVIDENCE OF AN OIL LEAK CAUSING THE TROUBLE, NOR DID I HAVE AN OIL SPOT WHERE I PARKED MY CAR IN THE GARAGE OR WORK PARKING LOT. NO OIL OR ENGINE LIGHT CAME ON.

• 10/25/2013· ENGINE

  WHILE DRIVING MY MINI THE CHECK ENGINE LIGHT CAME ON. I TOOK IT TO A LOCAL REPAIR SHOP THAT SPECIALIZES IN MINI'S. THE MANAGER TOLD ME THAT THE CRANKCASE VALVE NEEDS TO BE REPLACED AND IT IS BUILT INTO THE VALVE COVER. UPON INSPECTION THE MECHANIC ALSO DISCOVERED MY TIMING CHAIN IS ALMOST RUINED ALSO. I HAVE BEEN HEARING THE TIMING CHAIN RATTLE UPON START UP. *TR

• 10/24/2011· ENGINE AND ENGINE COOLINGFire

  SHORTLY AFTER THE TEMPERATURE LIGHT CAME ON, SMOKE STARTED COMING OUT OF THE EXHAUST. I PULLED OVER ALMOST IMMEDIATELY ON THE SIDE OF THE BUSY HIGHWAY I WAS ON. HOWEVER, IN JUST THAT SHORT TIME, SMOKE WAS ALREADY COMING OUT OF THE FRONT OF THE CAR AND OUT OF THE CAR VENTS. AT LEAST ONE BYSTANDER SAID HE SAW A FIRE BEFORE I SHUT OFF THE ENGINE. HE CALLED THE FIRE DEPARTMENT AND PARAMEDICS FOR FEAR THAT I MIGHT BE INJURED. PLEASE NOTE THAT THIS WAS NOT A MINI COOPER S. I AM REQUESTING THAT YOU EXPAND YOUR CURRENT INVESTIGATION OF MINI ENGINE FIRES TO INCLUDE THE STANDARD MODEL (MINI COOPER). *TR

• 10/19/2011· ENGINE AND ENGINE COOLINGFire

  I BOUGHT CAR NEW IN NOV 2007. CAR WAS USED AS TRANSPORTATION EVERY DAY TO AND FROM WORK (~100 MI TOTAL). CAR WAS WELL CARED FOR, SERVICE WAS PERFORMED AS REQUIRED, ETC. IN SEPT 2008 AFTER SITTING UNDRIVEN FOR 10 DAYS WHILE I WAS AWAY ON VACATION, I DROVE 50 MI TO WORK AND THERE WERE NO SIGNS OF TROUBLE EXCEPT THAT AN INDICATOR FOR A BLOWN HEADLAMP CAME ON WHEN I INITIALLY STARTED UP. WHEN I ARRIVED AT WORK AND PULLED INTO A PARKING SPACE I NOTICED WISPS OF SMOKE COMING FROM THE GRILL AND INTAKE AND SUSPECTED OVERHEATING. I PEERED INTO THE INTAKE AND SAW GLOWING ORANGE, AND SMELLED THE SMOKE AND REALIZED THIS WAS A FIRE NOT AN OVERHEATING. I HAD A COLLEAGUE CALL 911 AND GRABBED A FIRE EXTINGUISHER. WHEN I GOT BACK TO THE CAR SMOKE WAS POURING OUT OF THE HOOD. NOT WANTING TO OPEN THE HOOD I AIMED THE FIRE EXTINGUISHER INTO THE GRILL, INTAKE, AND GAPS BUT IT DIDN'T DO MUCH. AT THAT POINT I GRABBED VALUABLES FROM CAR AND WALKED AWAY. FLAMES BEGAN COMING OUT OF THE HOOD OVER THE WINDSHIELD. CAR WAS COMPLETELY ENGULFED WITHIN 10 MINUTES. THERE WERE NO INJURIES OR PROPERTY DAMAGE EXCEPT FOR THE CAR ITSELF. INSURANCE DECLARED IT A TOTAL LOSS. MINI WAS NOTIFIED. I HAVE PHOTOS OF IN-PROGRESS AND AFTERMATH. HAVING SEEN THE RECENT PUBLICITY ABOUT THE INVESTIGATION INTO THE ENGINE FIRES I THOUGHT I SHOULD LOG MY VERY RELEVANT EXPERIENCE. *TR

• 10/19/2010· ENGINE AND ENGINE COOLING

  TL*THE CONTACT OWNS A 2008 MINI COOPER S. THE CONTACT HEARD AN EXTREMELY LOUD KNOCKING SOUND WHENEVER HE STARTED THE VEHICLE. THE KNOCKING NOISE WAS NOT PRESENT WHILE THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE TIMING BELT AND OTHER COMPONENTS WERE REPLACED AT THE HIS EXPENSE. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE VIN WAS UNAVAILABLE WHEN THE COMPLAINT WAS FILED. THE CURRENT MILEAGE WAS APPROXIMATELY 40,000. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.

• 10/19/2008· ENGINE AND ENGINE COOLING

  ENGINE COMPARTMENT OF 08 MINI COOPER S GETS SO HOT IT HAS MELT THE HOOD SCOOP. MY HOOD SCOOPING IS BOWING DOWN AND THE CAR HAS 2700 MILES ON IT. I SUGGEST A RECALL AND A HEAT SHIELD TO RESOLVE THIS ISSUE. TOO MANY COMPLAINTS ON THE FORUMS. *TR

• 10/17/2017· STEERING

  TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING VARIOUS SPEEDS, SPECIFICALLY WHEN ATTEMPTING TO TURN THE VEHICLE, THE POWER STEERING SUDDENLY FAILED AND CAUSED STEERING CONTROL TO BECOME DIFFICULT. THE CONTACT STATED THAT THE POWER STEERING PUMP WOULD OVERHEAT, WHICH CAUSED THE CONTACT TO PARK THE VEHICLE UNTIL IT COOLED IN ORDER FOR THE POWER STEERING TO FUNCTION CORRECTLY. THE CONTACT CALLED MINI OF KENNESAW (2275 BARRETT LAKES BLVD, KENNESAW, GA 30144; 678-496-9565) WHO ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT COVERED UNDER THE EXTENDED WARRANTY OR A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

• 10/17/2011· ENGINE AND ENGINE COOLING

  ON AUGUST 15, 2011, I DROVE MY VEHICLE TO WORK AS I DO EVERY MORNING. ON THE WAY, I STOPPED FOR GAS. AFTER FILLING UP THE VEHICLE WOULD NOT START. IT SHOULD ALSO BE NOTED THAT THE ENGINE WAS VERY, VERY HOT AND THE COOLANT OVERFLOW TANK WAS OVERFLOWING. THE CAR WAS TOWED TO THE CLOSEST DEALERSHIP AND, AFTER INVESTIGATING, IT WAS DETERMINED THAT THE ENGINE WAS STARVED OF OIL, HAD SEIZED, AND WOULD NEED TO BE COMPLETELY REPLACED. THIS VEHICLE HAS ALWAYS RECEIVED REGULAR SCHEDULED MAINTENANCE SINCE IT WAS PURCHASED NEW FROM MINI IN 2008. THE LAST SERVICE WAS PERFORMED BY THE DEALERSHIP ON A LEAKING OIL PAN GASKET. FURTHERMORE, THERE HAD BEEN NO WARNING SIGNALS WHATSOEVER THAT THE ENGINE WAS IN DANGER. *TR