2007 Toyota FJ Cruiser

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2021· UNKNOWN OR OTHER

  Frame Rust, I just spent about $6000 for upper engine repair only to find out that the shop has now reported that the frame on the 2007 FJ Cruiser is not safe to drive any longer. Frame is rusted through multiple locations on the frame from side to rear - Frame is so bad that if I hit a bump just right It could cause an accident. I washed vehicle weekly to prevent rusting, it did not help. I am not reporting engine repair I am reporting the Frames rusted through issue and now I have no money to buy a vehicle and no vehicle to drive. Toyota has recalled other vehicles with this known issue but not the FJ Cruiser why, They even lost the law suite for frame rust Issues, They should be accountable for these vehicles as well. I was quoted approx. $2000 more to fix the frame.

• 12/29/2020· STEERING,SUSPENSION,UNKNOWN OR OTHER

  SEVERE SUSPENSION BRACKET RUST ON MULTIPLE REAR AND FRONT COMPONENTS. I LUCKILY WAS ABLE TO AVOID AN ACCIDENT WHEN BRAKING BUT MY ENTIRE CAR SWAYED WHEN THE REAR LATERAL SUPPORT BAR BRACKET BROKE RIGHT OFF THE MOUNT THAT IS WELDED TO THE REAR DUE TO RUST. I THEN INSPECTED AND FOUND MULTIPLE RUST AREAS ON FRAME AND OTHER SUSPENSION BRACKETS. MAKING THIS VEHICLE UNSAFE TO DRIVE. I AM AWARE OF TOYOTA'S ONGOING DILEMMA WITH USING THIS HORRIBLE UNTREATED STEEL AND HOPE THE NHTSA ADDRESSES THIS ISSUE. THIS IS NOT NORMAL CORROSION THIS IS AN ABSOLUTE NEGLECT IN SAFETY BY NOT HAVING THIS STEEL TREATED ON SUCH CRITICAL COMPONENTS OF A VEHICLES FRAME. HAD THIS INCIDENT HAPPEN ON THE HIGHWAY AT SPEEDS OF 55 MPH OR GREATER. SERIOUS INJURY AND/OR DEATH CAN OCCUR. IF I AM NOT THE ONLY CONSUMER HAVING THIS ISSUE ON TOYOTA FJ CRUSIER VEHICLES. I HOPE THE NHTSA ENFORCES A RECAL ON THESE FRAMES AND/OR CRITICAL SUSPENSION COMPONENTS. MY VEHICLE IS 16 YEARS OLD, I PURCHASED IT FROM A DEALER WHOM RECIEVED IT FROM THE ORIGINAL OWNER WITH 57,000 MILES ON IT. NOW CURRENTLY AFTER 4 YEARS OF OWNING THIS FJ CRUISER I ONLY HAVE 71,000 MILES ON IT. HAD THIS BRACKET CAUGHT ONTO MY BRAKE LINES WHICH IS LOCATED DIRECTLY BELOW THIS REAR BRACKET I WOULD HAVE LOST ALL ABILITY TO STOP MY VEHICLE.

• 12/29/2009· VISIBILITY

  WINDSHIELD CRACKED FROM POSSIBLE COLD WEATHER CONDITION. *TR

• 12/28/2015· ELECTRICAL SYSTEM,VISIBILITY/WIPER

  WINDSHIELD WIPERS HAVE FAILED TO WORK FOR LONG PERIODS OR HAVE TO PLAY WITH SWITCH TO WORK RIGHT. TOOK CAR IN YEARS AGO WHILE UNDER WARRANTY TO FIX AND RESOLVED PROBLEM FOR A FEW YEARS BUT IS NOW REOCCURRING. ALSO DRIVERS SIDE DOOR WINDOW SWITCH INTERMITTENLY WORKS. I DONT KNOW IF THIS IS CONNECTED TO WIPER SWITCH BUT HAVE SEEN RECALLS ON OTHER TOYOTAS THAT HAVE THIS PROBLEM AND HAD A RECALL BUT NONE FOR FJ. SPECIFICS TURN ON CAR, TURN ON SLECTOR SWITCH FOR WIPERS "SLOW THRU HIGH IT DONT MATTER". WIPERS DONT WORK.

• 12/28/2007· POWER TRAIN

  I WAS DRIVING DOWN THE ROAD WHEN THE REAR DIFFERENTIAL BROKE IN MY REAR AXLE. I TOOK THE VEHICLE TO A LOCAL DEALERSHIP WHERE I WAS AND THE WARRANTY WAS DENIED. I FIXED THE VEHICLE WITH AFTER MARKET PARTS AND FILED A CLAIM WITH THE MANUFACTURE ONLY TO GET DENIED AGAIN. TOOK THE VEHICLE TO A LOCAL DEALERSHIP WHEN I GOT HOME AND THEY SAID THEY WOULD HAVE FIXED IT UNDER WARRANTY. *TR

• 12/26/2019· STRUCTURE,SERVICE BRAKES

  DURING 2019-2020 STATE INSPECTION OF 2007 FJ CRUISER WITH 78000 MILES BY DEALER WAS TOLD THAT FRAME IS SO RUSTED THAT IT PROBABLY WOULD NOT PASS THE NEXT INSPECTION. EXPLANATION GIVEN WAS THAT TOYOTA DOES NOT MAKE THEIR FRAMES AS THICK AS OTHER MAKES. THIS VEHICLE WAS USED AS A DAILY DRIVER, NOT MUCH OFF-ROAD AND NO SERIOUS OFF-ROADING. I WORK FROM HOME, SO MOST YEARS LESS THAN 5000 MILES DRIVEN. ALSO HAVE HAD TO REPLACE FRONT BRAKE CALIPERS FOR THE PAST 3 YEARS.

• 12/26/2019· SUSPENSION,STRUCTURE,SERVICE BRAKES

  BOUGHT MY FJ NEW IN 2007.WHEN I DID I ASKED IF THEY HAD RUSTY JONES OR UNDERCOATING AND WAS TOLD WITH THE NEW ALLOYS I DIDNT NEED IT. 3 WEEKS AGO I WAS HAVING MY MECHANIC CHECK THE BRAKES AND HE CALLED ME DOWN TO SHOW ME A BREAK IN THE FRAME CONNECTING TO THE BODY.THANKFULLY HE FOUND IT BECAUSE I WAS SUPPOSED TO GO TO BOSTON THE NEXT DAY. THE TRUCK ONLY HAS 139,000 MILES ON IT AND THE FRAME IS COMPLETELY RUSTED OUT SO ITS NOT SAFE TO DRIVE.I BROUGHT IT TO THE DEALER I PURCHASED IT FROM AND 2 REPS CAME DOWN FROM NH TO LOOK AT WHO BASICALLY TOLD ME I HAD A GOOD RIDE WITH IT AND THEY WOULD DO NOTHING.I THEN CALLED TOYOTA CEC AND WAS TOLD THE SAME. I BROUGHT TO A WELDER WHO SPECIALIZES IN THIS TYPE OF WORK AND WAS TOLD 5000+ IN LABOR ALONE AND THATS WITHOUT SEEING UNDER THE GAS TANK SO HE SAID IT WOULDNT BE WORTH IT AS HE BANGED OF THE RUST IN OTHER SPOTS AND THERE WAS NO METAL TO WELD TO LEFT.BRAKE AND FUEL LINES ARE SWELLED FROM THE RUSTY METAL TUBING.I CONSIDER MYSELF LUCKY AS I OFTEN TAKE MY GRANDKIDS IN THE FJ. SO NOW IM LEFT WITH MY OTHER FJ THAT I BOUGHT NEW IN 2008 WHICH IS OK UNDERNEATH.THE ISSUE IS WITH ALL THE 2007 FJ FRAMES LIKE THEIR TUNDRAS AND TACOMAS. I HAVE OPENED A CASE WITH TOYOTA BUT THERE ARE SO MANY THERE SHOULD BE A RECALL AS THESE ARE UNSAFE TO DRIVE.THE BODY IS READY TO COLLAPSE ON THE FRAME. I WAS TOLD PRIVATELY THAT TOYOTA CHOOSES TO IGNORE THE ISSUE AS THEY NO LONGER MAKE THE FJS BUT STILL SELL TACOMAS AND TUNDRAS. ## VIN PASSED ## 2007 TOYOTA FJ CRUISER ##

• 12/26/2010· SERVICE BRAKES, HYDRAULIC

  MY 2007 TOYOTA FJ CRUISER HAS A DEFINITE AND VERY SERIOUS BRAKE PROBLEM! ON AT LEAST 6 TO 8 OCCASIONS BRAKES HAVE LOCKED UP AND CAUSED TEMPORARY LOSS OF CONTROL OF THE VEHICLE! ON SOME OCCASIONS, I FEEL THAT A LESS-EXPERIENCED DRIVER COULD HAVE CRASHED!! ONE OCCASION WAS AT 55 MPH WHILE PASSING ANOTHER VEHICLE. THIS OCCASIONAL SCARY EXPERIENCE HAS BEEN REPORTED BY NUMEROUS OWNERS OF THIS VEHICLE ON THE FJ CRUISER FORUM, BUT THIS DANGEROUS CONDITION IS NOT BEING ADDRESSED BY TOYOTA!!! HELP!!!!! *TR

• 12/25/2020· STRUCTURE

  UNDER CARRIAGE, IS RUSTING AWAY ! VEHICLE, ONLY HAS 97,000 MILES ON IT. MECHANIC, SAID THE VEHICLE IS FALLING APART, WITH RUST...

• 12/23/2011· SEAT BELTS

  I BELIEVE THAT SEAT BELTS ARE ONE OF THE MOST IMPORTANT SAFETY FEATURES ON A CAR AND SHOULD LAST THE LIFE OF A CAR. I AM VERY SURPRISED THAT THE SEAT BELTS ON THIS CAR STARTED TO SHOW A FAILING TREND AT ALMOST 40000 MILES. BOTH PASSENGER AND DRIVER SIDES ARE FAILING, RETRACTING AND LOCKING-UP ISSUES. PASSENGER SIDE COMPLETELY FAILED YESTERDAY, IT IS LOCKED UP. COST TO FIX IS VERY EXPENSIVE. .MANY FJ OWNERS ARE REPORTING THE SAME PROBLEM, I ENCOURAGE THOSE WITH THE SAME ISSUE TO FILE A COMPLAINT RATHER THAN POSTING IT ON FJ CRUISER FORUM. IT SHOULD BE A RECALL ISSUE AND TOYOTA SHOULD ASSUME SUCH A RESPONSIBILITY FOR FIXING AN IMPORTANT SAFETY FEATURE. *TR

• 12/20/2019· STRUCTURE

  FRAME IS RUSTING TO THE POINT IT IS ABOUT TO BREAK.

• 12/20/2010· SERVICE BRAKES, HYDRAULIC

  TL*THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. WHEN THE VEHICLE STOPPED THE ANTI LOCK AND TRACTION CONTROL LIGHTS BEGAN ILLUMINATING ON THE DASHBOARD. WHILE EXAMINING THE VEHICLE HE NOTICED THAT THE FRONT DRIVERS SIDE WHEEL SPEED SENSOR WAS BROKEN. HE ATTEMPTED TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER BUT THE VEHICLE WOULD NOT ACCELERATE BECAUSE THE WHEELS WERE LOCKED. WHILE TOWING THE VEHICLE A LOUD POPPING NOISE WAS HEARD AND ALL OF THE WHEELS EXCEPT THE FRONT DRIVERS SIDE WHEELS BEGAN TO TURN. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE SPEED SENSOR WIRE WAS REPLACED. THE FAILURE MILEAGE WAS 24,000 AND THE CURRENT MILEAGE WAS 26,000. UPDATED 02/02/11 *CN

• 12/19/2014· POWER TRAIN

  THIS IS A COMPLAINT UPON TOYOTA AND AS THEY HAVE BEEN AWARE OF MANUFACTURED DEFECT IN THE REAR DIFFERENTIAL GEARS AND BEARINGS OF MOST IF NOT ALL 2007 FJ CRUISERS. ALL THAT ARE MADE IN 2006 FOR SALE IN 2007 HAVE OR WILL HAVE A DIFFERENTIAL GO OUT AS IT IS A "2000 DOLLAR TIME BOMB WAITING TO HAPPEN AS THE TOYOTA SERVICE MANAGER STATED" I ASKED THE MANAGER IF ANY ASSISTANCE HAS BEEN GIVEN TO ANY OF THESE REPAIRS AS IT IS A COMMON PROBLEM WITH ALL 07'S AND HE SAID TOYOTA JUST ASSISTED ONE THEY DID A FEW MONTHS BACK AND IT WAS OUT OF WARRANTY. WITH THIS INFORMATION IT SEEMED IT COULD BE A POSSIBILITY SINCE TOYOTA IS VERY AWARE OF THE MANUFACTURED DEFECT OF THE REAR DIFFERENTIAL. SO I LEFT THE TOYOTA DEALERSHIP AND MADE MY CALL RIGHT AWAY AS TO JUST BE FRUSTRATED AS THEY STATED THEY COULD NOT ASSIST IN ANYWAY OTHER THAN FILE A CLAIM. STILL THE CASE EVEN AFTER MENTIONING THAT TOYOTA ASSISTED IN PAYING FOR SOME OF THE COST OF THIS DEFECTIVE PART REPLACEMENT OF ANOTHER SAME YEAR NOT THAT LONG AGO AND STILL GOT A BIG NO WAY CAN WE HELP IN ANYWAY WITH COSTS AS IT IS NOT A SAFETY HAZARD, BUT TO ME IT COULD BE A SAFETY HAZARD AS I HAVE HEARD THAT THE REAR DIFFERENTIAL CAN GO OUT AND NO POWERTRAIN AT ALL AT ANY GIVEN MOMENT AND COULD IN THE MIDDLE OF AN INTERSECTION TURNING, UP A HILL, PASSING ANOTHER VEHICLE, PULLING A TRAILER, ETC. MY DIFFERENTIAL COVER IS ALSO STARTING TO GET HOT AND SMELL FROM I IMAGINE FRICTION. ANYHOW SO MANY INCIDENTS OF THE SAME CASE WITH THE SAME YEAR AND SAME PROBLEM, ITS HARD TO SAY HOW MANY REALLY COMPLAINTS AND CLAIMS THEY HAVE GOTTEN. I HAVE BEEN TOLD MORE THAN A THOUSAND CASES. PLEASE TAKE THIS SERIOUS AND TOYOTA NEEDS TO OWN UP TO IT FOR ALLOWING A TIME BOMB WAITING TO HAPPEN AND SOME OF THOSE CUSTOMERS HAD IT HAPPEN AS SOON AS 65,000 MILES JUST OUT OF WARRANTY. MANY OTHERS EXPERIENCE THE SAME PROBLEM EVEN AT EARLIER MILEAGE JUST OUT OF WARRANTY. *TR

• 12/18/2020· SUSPENSION,STRUCTURE

  MY SON WAS DRIVING HOME FROM SCHOOL WHEN HE HEARD A RATTLE/BANG WHEN HE TOOK A CORNER OR WENT OVER A BUMP. HE TOLD ME ABOUT THE NOISE AS SOON AS HE GOT HOME. WE TOOK THE FJ OUT FOR A DRIVE AND I HEARD THE NOISE COMING FROM THE DRIVER'S SIDE. UPON INSPECTING THE EXTERIOR DRIVERS SIDE I FOUND THAT THE LEFT SIDE, REAR TRAILING ARM MOUNTING POINT AND A SECTION OF THE FJ'S FRAME, HAD TORN AWAY FROM THE FRAME. THE TRAILING ARMS WAS NOT FLOATING, UNATTACHED. WE ARE VERY LUCK THAT THE TRAILING DID NOT DROP WHILE MY SON WAS DRIVING HOME, AS IT WOULD HAVE BEEN DRIVEN INTO THE PAVEMENT, POSSIBLY CAUSING A CATASTROPHIC ACCIDENT. I HAVE CALLED TOYOTA CORPORATE, WHO CAN PROVIDE NOT SOLUTION ON HOW TO REPAIR THIS ISSUE. AGAIN, I AM LUCKY MY SON WAS ON SECONDARY ROADS AND NOT THE HIGHWAY AND THE TRAILING ARM FELL TO THE PAVEMENT.

• 12/18/2007· VISIBILITY

  NEW 2007 TOYOTA FJ CRUISER, PURCHASE ON 10/26/2007 ON NOV 7TH A TRUCK THREW A ROCK AND IT PUT A 2 1/2" DIAMETER CRACK ON THE PASSENGERS SIDE. TWO WEEKS LATER GOT AN ESTIMATE $268.00 FROM WINDSHIELD DOCTOR/NAPA THE VERY NEXT DAY ANOTHER ROCK CHIP JUST UNDER THE REARVIEW MIRROR. SAID IF IT BREAKS THIS EASY NO USE GETTING A NEW WINDSHIELD, THEN ABOUT 2 WEEKS LATER A ROCK CHIP ON THE DRIVERS SIDE. ON 12/16/07, THE FIRST CRACK SPREAD FROM ONE SIDE TO THE OTHER ACROSS THE LOWER 1/3 OF THE WINDSHIELD. TODAY 12/17 WENT AND GOT ANOTHER ESTIMATE FROM A DIFFERENT SHOP TO SEE IF PRICE WOULD BE LOWER FOR A NEW WINDSHIELD AND ITS $415.00 WITHOUT MY DEDUCT AND $350.00 WITH MY DEDUCTIBLE. THIS IS RIDICULOUS WE HAVE NOT EVEN HAD THE FJ 8 WEEKS AND THE WINDSHIELD HAS BEEN CHIPPED 3 TIMES ALREADY. WHAT A POOR DESIGN BY TOYOTA, LOOKING AT SOME OF THE FJ WEB FORUMS - THIS IS A VERY COMMON COMPLAINT AMONG FJ OWNERS!!! WILL TOYOTA HELP WITH COST OF NEW WINDSHIELD? THE TRUCK IS NOT EVEN 2 MONTHS OLD YET!! *TR

• 12/17/2021· SUSPENSION,SERVICE BRAKES

  I purchased the vehicle with a clean carfax on 12/2/2021 Flew from Phoenix to Dallas to pick it up. Drove the vehicle from Dallas to Phoenix. The Brakes malfunctioned on the drive home. Fortunately it was late at night and not many vehicles on the road. Took car to mechanic on 12/4/2021. The frame, brakes, suspension, exhaust and engine mounts had been sprayed over to cover severe rust and rot of the the frame and undercarriage. The vehicle cost 14k The repairs to be done 20k The vehicle is not roadworthy and has not been driven since ai got back to Phoenix. The dealership purposely didn’t disclose the frame or brake damage. The dealership sold this vehicle knowing it was for my daughter and 3 year old granddaughter

• 12/17/2020· ELECTRICAL SYSTEM,SEATS

  DRIVER SEAT AND PASSENGER SEAT HEATING UNIT IS COMING ON WITHOUT THE SWITCH TURNED ON.

• 12/17/2011· SEAT BELTS

  PURCHASED CERTIFIED USED TOYOTA AND NEVER TRIED TO USE REAR SEAT BELTS. WHEN WE TRIED TO USE SEAT BELTS ALL THE REAR SEAT BELTS WERE NOT WORKING" WOULD NOT LATCH". *TR

• 12/16/2019· SUSPENSION

  DRIVER REAR LOWER CONTROL LINK MOUNT BROKEN. NORMAL CITY DRIVING. NO HARD STOPS NO FAST TAKE OFF FROM STOP SIGN. ALSO HAVE BROKEN BODY MOUNTS. I HAD TO REPLACE UPPER MOUNT TWO YEARS AGO. THIS TRUCK GETS DRIVEN ON SURFACE STREETS ONLY 40MPH TOP SPEED ON MY ROUTE TO WORK.

• 12/16/2019· SUSPENSION

  EXCESSIVE RUST ON LOWER CONTROL ARM MOUNT

• 12/16/2008· STRUCTURE

  I HAVE BULGING AND CRACKING ON MY INNER FENDER APRONS ON MY TRUCK, THEY HAVE BEEN PROGRESSIVELY GETTING WORSE. WHEN THEY STARTED I HAD ZERO MODIFICATIONS AND HAD ONLY DRIVEN ON MILD DIRT ROADS. AND SOME SAND. TOYOTA HAS SINCE DENIED ME REPAIR BECAUSE OF SOME MODIFICATIONS I HAVE INSTALLED. TOYOTA ALSO IS ON THE 3RD FENDER DESIGN SO THEY OBVIOUSLY KNOW THERE IS A PROBLEM BUT THEY WANT TO BLAME THE OWNERS FOR IT. *TR

• 12/16/2008· STRUCTURE

  THE PROBLEM IS THE INNER FENDER IN MY 2007 FJ. IT HAS BULGES AND WILL EVENTUALLY CRACK. OTHER OWNERS HAVE HAD IT CRACKED, SO I AM WAITING TO SEE HOW LONG THAT TAKES TO HAPPEN. I HAVEN'T TAKEN IT IN TO GET FIXED YET, BUT TOYOTA IS CLAIMING THAT IT'S NOT A DESIGN ISSUE. THE ONLY PROBLEM IS A NUMEROUS OTHER OWNERS HAVE THE SAME ISSUE. *TR

• 12/15/2014· POWER TRAIN

  TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THERE WAS AN ABNORMAL GRINDING NOISE COMING FROM THE REAR OF THE VEHICLE. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR DIFFERENTIAL AND BOTH REAR BEARINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

• 12/15/2008· STRUCTURE

  2007 TOYOTA FJ CRUISER FENDER BULGES AND CRACKING ON MY VEHICLE WITHOUT MODIFICATION ON THE VEHICLE. FENDER CRACKING/BULGES WAS NOT ALSO DUE TO EXCESSIVE OR EVEN OFF-ROADING, JUMPING OR OTHER VEHICLE ACTIVITIES. *TR

• 12/13/2022· FUEL/PROPULSION SYSTEM

  Serviced 99% of the time at Toyota dealer. Within a week of having the vehicle serviced by the dealer, I noticed a rattling/banging. One gas strap had completely rusted through, and the other was hanging on by about a quarter inch of material. I always ask the dealer to inspect the frame due to the history of rust problems on FJs—they have never flagged anything but I inspect it as I can myself, but have no way to lift the vehicle up thoroughly. I also have the service fluid applied by Rust Check to prevent/inhibit deterioration. On a sidebar, this summer I was traveling on the interstate when the rear-most crossmember rusted out while I was using a hitch haul to move a dresser to South Carolina.

• 12/13/2010· SERVICE BRAKES, HYDRAULIC,SERVICE BRAKES, ELECTRIC,EQUIPMENT,TRACTION CONTROL SYSTEM

  SUMMARY: THE PRIMARY SAFETY SYSTEM (BRAKES) IN MY 2007 TOYOTA FJ CRUISER FAILED TWICE. THE LOCAL TOYOTA DEALERSHIP UTILIZING TOYOTA NATIONAL RESOURCES WERE UNABLE TO ISOLATE THE PROBLEM. THE SOLUTION WAS TO COMPLETELY REPLACE BRAKE SYSTEM AND CHARGE IT TO ME. THE LACK OF AVAILABILITY OF PARTS NATIONALLY (BACKORDER) RESULTED IN A COMPLETELY UNREASONABLE REPAIR TIMEFRAME. THE VEHICLE WAS OUT OF SERVICE FOR 49 DAYS AND COST $2503.99 TO REPAIR. OCTOBER 1, 2010 DRIVING IN TRAFFIC DEPRESS BRAKE. THE PEDAL GOES COMPLETELY TO FLOOR BOARD. NO INDICATION OF PROBLEMS VIA INTERIOR WARNING LIGHTS. OCTOBER 6, 2010 PROBLEM DETERMINED TO BE BRAKE MASTER CYLINDER. PART ORDERED (47025-35111 CYLINDER SUB-ASSEMBLY) THROUGH INTERNET SITE OF LAKELAND TOYOTA IN FLORIDA. THE COST OF THE PART IS $981.37 AND THE PART IS ON BACKORDER. ESTIMATED DELIVER IS 10/26/10. OCTOBER 26, 2010 PART ARRIVES AND IS INSTALLED. MULTIPLE WARNING LIGHTS ARE INDICATED ON INTERIOR DISPLAY. NOVEMBER 1, 2010 TOYOTA DEALERSHIP DETERMINES THE NEW MASTER CYLINDER ASSEMBLIES COMPUTER IS DEFECTIVE. NOVEMBER 4, 2010 TOYOTA DEALERSHIP REPLACES NEW MASTER CYLINDER COMPUTER WITH MY OLD COMPUTER. THE RESULT IS THE WARNING LIGHTS TURNING OFF AND INDICATES THE PROBLEM HAS BEEN FIXED. THE MECHANIC TAKE THE VEHICLE ON A TEST DRIVE ACTIVATES THE ANTILOCK BRAKES WHICH RESULTS IN AN UNEXPECTED LOSS OF VEHICLE CONTROL. THE SERVICE MANAGER REFUSES TO RETURN THE VEHICLE CLAIMING IT IS UNSAFE TO DRIVE. NO WARNING LIGHTS ARE INDICATED ON THE VEHICLE. NOVEMBER 10, 2010 TOYOTA DEALERSHIP DETERMINED THAT THE MASTER CYLINDER WITHIN THE NEW MASTER CYLINDER ASSEMBLIES IS FAULTY. BRAKE SOLENOID COMPONENTS ARE ALSO DETERMINED TO BE FAULTY AND A CONTRIBUTING FACTOR IN THE LOSS OF VEHICLE CONTROL. TOYOTA RECOMMENDS THAT COMPLETE BRAKE ASSEMBLY (47050-35072 $1823.87) BE REPLACED. THIS IS VIRTUALLY THE ENTIRE BRAKE SYSTEM OF THE VEHICLE. THIS ASSEMBLY IS ON BACKORDER AS WELL. NOVEMBER 18, 2010 VEHICLE REPAIRED AND RETURNED. *TR

• 12/12/2007· STRUCTURE

  INNER FENDER (CRUMPLE ZONE) BULDGE AND TEAR LEFT SIDE. *TR

• 12/10/2022· UNKNOWN OR OTHER

  This is a 2007 vehicle I have owned since 2009. One of the two Fuel Tank straps broke in April of 2021. This left one strap holding the tank in place. This happened while driving allowing the tank to drag on ground. I stopped before it became a more serious problem. The strap was completely rusted through. Both straps were replaced. The remaining strap had serious rust as well.

• 12/10/2021· STRUCTURE

  Frame ha rusted to the point of failure after only 14 years.

• 12/09/2017· STRUCTURE

  CRACKED SECONDARY STRUCTURE WITHIN THE ENGINE BAY ON BOTH THE DRIVER SIDE AND THE PASSENGER SIDE.

• 12/09/2012· WHEELS

  WHEELS ON TOYOTA 2007 FJ CRUISER, THE PAINT ON WHEELS STARTED BUBBLING, I THEN EXPERIENCED AIR PRESSURE LOSS IN ALL 5 TIRES INCLUDING SPARE TIRE. I HAVE TO CONSTANTLY CHECK TIRE PRESSURE AS ALL WHEELS CONTINUALLY LEAK AIR. CAUSING DIFFERENT AIR PRESSURE IN TIRES. THIS IS A FACTORY DEFECT AND COULD CAUSE LOSS OF CONTROL AT ANY GIVEN TIME. *TR

• 12/07/2022· STRUCTURE

  took the vehicle to a toyota dealership which stated the frame is dangerous and rusted very badly. they told me to file a complaint since the delaer was not covered under the lemon law

• 12/07/2022· SUSPENSION,STRUCTURE

  the frame and associated components are severly corroded putting the vehicle in danger of the back axel detaching . i was informed of this by a repair shop who were concerned of the safety of operating vehicle. there is some type of coverage for related vehicles but not for this model. i think this is the same platform which was recalled under a truck model. toyota refuses any coverage or help for this problem. the vehicle has 70k miles but is unsafe to operate. photos are available. although the top of the vehicle is what you would expect with 70k miles, it is unsafe to operate because the back axel could fall off at any time

• 12/05/2007· TIRES

  TL*THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER WITH DUNLOP GRAND TREK TIRES. WHILE DRIVING 40 MPH, THE DRIVERS SIDE REAR TIRE BLEW OUT. THE TIRE SHOP STATED THAT ALL THE TIRES SHOULD BE REPLACED DUE TO THE INNER BEAD BEING DAMAGED OR FLAWED. THERE IS A SAFETY RECALL FOR TIRES BEAD (NHTSA CAMPAIGN ID # 06V235000). THE CURRENT MILEAGE WAS 18,826 AND FAILURE MILEAGE WAS 18,250. UPDATED 03/05/08. *LJ

• 12/04/2020· STRUCTURE

  UPON STATE INSPECTION, SEVERE RUST AND CORROSION WAS DISCOVERED ON THE FRAME. NOT ONLY DID IT FAIL INSPECTION, MY MECHANIC STRONGLY URGED ME NOT TO DRIVE IT, AS THE REAR AXLE HAS A POSSIBILITY OF FALLING OUT.

• 12/01/2010· SERVICE BRAKES, HYDRAULIC

  1. I WAS DRIVING HOME FROM WORK AND WAS ON THE HIGHWAY. THE CARS IN FRONT OF ME CAME TO AN ABRUPT STOP, CAUSING ME TO SLAM MY BREAKS WHILE I WAS DOING 40-ISH. 2. THIS CAUSED THE CAR TO BAKE STUMBLE AS THE BREAKS SLOWED THE CAR, THEN CAME LOSE CAUSING THE CAR TO LUNGE FORWARD, THEN MOMENTARILY BRAKE, THEN LOSE BRAKING AGAIN. THIS CAUSED ME TO ALMOST SLAM IN TO THE CAR IN FRONT OF ME. 3. I HAVE NOT TAKEN CORRECTIVE ACTION AS THIS SHOULD ADDRESSED BY TOYOTA AS THERE ARE MANY MANY PEOPLE DESCRIBING THE SAME ISSUE. *TR

• 11/29/2014· SERVICE BRAKES

  BAD VIBRATION WHEN APPLYING THE BRAKES. END RESULT WAS THE ROTORS,BRAKE PADS, AND BOTH CALIPERS HAD TO BE REPLACED!! AN $800.00 BILL! DEALER STATED IT WAS PROBABLY DUE TO ROAD SALT ERROSION!! THESE VEHICLES ARE PROMOTED AS OFF-ROAD/4WD GO ANYWHERE VEHICLES! I HAVE NEVER HAD TO REPLACE CALIPERS ON ANY VEHICLE I'VE EVER OWNED. I FEEL IT HAS TO DO WITH THE QUALITY OF STEEL THEY USE IN THESE VEHICLES AS I'VE HAD TO ALSO REPLACE THE TRANSMISSION COOLERS LINES DUE TO RUST ERROSION/LEAKING OF THE METAL LINES! THE FRAME,SKID PLATES AND UNDER FRAME METAL ARE ALL FLAKING WITH RUST ERROSION. *TR

• 11/28/2017· POWER TRAIN,UNKNOWN OR OTHER,ENGINE

  VEHICLE WILL NOT CHANGED GEAR FROM PARK TO DRIVE

• 11/27/2019· SUSPENSION,STRUCTURE

  FRAME IS RUSTING OUT- TRUCK ONLY HAS 142K ON IT. TOLD TODAY IT WILL PROBABLY FAIL INSPECTION NEXT YEAR AS IT BARELY PASSED TODAY. THIS IS A HUGE SAFETY CONCERN AND AFFECTS THE STRUCTURAL INTEGRITY OF THE VEHICLE TOYOTA HAS SETTLED WITH TACOMA, TUNDRA OWNERS BUT IGNORES ISSUE WITH FJ

• 11/25/2008· STRUCTURE

  I OWN A 2007 TOYOTA FJ CRUISER. IT IS A MULTI-PURPOSE 4X4 VEHICLE. I USE IT OFF-ROAD OCCASIONALLY. THERE ARE RIPS ASSOCIATED WITH METAL FATIGUE IN THE INNER FENDER APRONS AT APPROXIMATELY 18,000 MILES. I HAVE SOME SLIGHT MOVEMENT IS THE FENDERS AND WIDE SEAMS OF THE HOOD. I HAVE TAKEN IT TO A DEALERSHIP, HOWEVER THEY WILL NOT REPAIR IT BECAUSE THERE IN NO KNOW FIX FOR THE PROBLEM. *TR

• 11/23/2019· STRUCTURE

  THE VEHICLE HAS BEEN TAKEN GOOD CARE OF BUT, THE FRAME IS PREMATURELY RUSTING AT CONNECTING POINTS TO THE BODY CAUSING THE VEHICLE TO UNSAFE TO DRIVE. THE VEHICLE LOOKS AND RUNS WELL BUT MIGHT BE A SAFETY RISK IN SUDDEN STOPS OF ACCIDENTS CAUSING VEHICLE BODY TO DISLODGE FROM FRAME.

• 11/21/2018· POWER TRAIN

  TAKATA RECALL- REAR DIFFERENTIAL WENT BAD, NO HARD DRIVING, AND CHANGING FLUID FREQUENTLY.

• 11/20/2020· STRUCTURE

  TOYOTA'S HAVE BEEN HAVING RUST ISSUES WITH FRAMES. A GOVERNMENT MANDATED FIX FOR TUNDRAS AND TACOMAS HAVE BEEN APPROVED, BUT NOT FOR FJ CRUISERS, EVEN THOUGH IT'S A SIMILAR MODEL. I NEED TO HAVE MY FRAME RUST ISSUES FIXED IN ORDER TO PASS INSPECTION.

• 11/20/2007· STRUCTURE

  I HAVE TWO RIPS IN THE SIDE WALL OF THE ENGINE BAY. THE TEARS ARE AT THE CRUSH ZONES OF THE BODY SIDE WALLS. *TR

• 11/17/2020· FUEL SYSTEM, GASOLINE,STRUCTURE

  TL* THE CONTACT OWNS A 2007 TOYOTA FJ CRUISER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR TIRE REPAIRS AND THE MECHANIC FOUND THAT THE FUEL TANK STRAPS WERE SEVERELY CORRODED AND THE SUBFRAME WAS ALSO SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 71,000.*DT THE CONSUMER PROVIDED PHOTOS. *TR

• 11/17/2020· SUSPENSION,POWER TRAIN,SERVICE BRAKES

  SEVERE RUST ISSUES. ENTIRE REAR DIFFERENTIAL REQUIRED REPLACEMENT. ALL POWER STEERING AND AUTOMATIC TRANSMISSION LINES NEEDED REPLACEMENT, FUEL LINES ARE NEXT FUEL TANK STRAPS RUSTED AND BROKE OFF, TANK FELL DOWN. BRAKE PAD PINS REQUIRED CUTTING OFF. PROTECTION PLATES RUSTED OFF. EXHAUST SYSTEM COMPONENTS REQUIRED REPLACEMENT DUE TO RUST. ENTIRE FRAME AND ENGINE COMPARTMENT COVERED IN RUST. ALL THESE ITEMS HAVE CAUSED MULTIPLE SAFETY ISSUES. MULTIPLE STRAPS AND CONNECTIONS FOR VARIOUS COMPONENTS ARE NO LONGER USABLE DUE TO RUST.

• 11/17/2020· STEERING,SUSPENSION,UNKNOWN OR OTHER

  GAS TANK STRAPS BROKE FRAME DETERIATED ON FJ CRUSIER WITH ONLY 72000 MILES ON IT WOULD HAVE NEVER KNOWN HOW UNSAFE FRAME IS IF STRAPS GAS TANK HANGING

• 11/15/2007· VISIBILITY,STRUCTURE

  INNER FENDER STRUCTURE IS BULGING, STARTED ON PASSENGER SIDE ABOUT OCT 15TH & ON DRIVERS SIDE ABOUT TWO WEEKS LATER. THIS IS A WELL KNOW PROBLEM AMONG INFORMED FJ CRUISER OWNERS. ALSO SOME OF THE ONES TOYOTA HAS REPAIRED & UPGRADED ARE ALSO FAILING. ALSO POOR QUALITY WINDSHIELD THAT WAS PITTED & CHIPPED WITHIN A FEW WEEKS OF PURCHASE. *TR

• 11/14/2007· STRUCTURE

  WITHIN 6 MONTHS AFTER PURCHASING MY VOODOO BLUE 2007 FJ CRUISER, I BEGAN NOTICING RANDOM PAINT CHIPPING ON THE BODY OF MY VEHICLE. I HAVE NEVER PUT MY CAR THROUGH A CAR WASH, NOR HAS IT EVER BEEN OFF-ROADED. I BROUGHT THIS TO THE ATTENTION OF MY SALES REP AT THE TOYOTA DEALERSHIP WHERE I PURCHASED IT AND HE PROCEEDED TO ASK ME IF I HAD EVER DRIVEN THROUGH ANY CONSTRUCTION SITES, WHICH I HAD NOT. HE THEN REFERRED ME TO A TOYOTA PAINT SPECIALIST WHO THEN PROCEEDED TO TELL ME THAT THIS IS VERY COMMON BECAUSE LEAD IS NO LONGER AN INGREDIENT IN THE PAINT, WHICH IS CAUSING IT TO BECOME VERY BRITTLE. SINCE I AM LEASING THE CAR I WAS CONCERNED THAT I WOULD BE CHARGED AT LEASE TERMINATION FOR THIS BUT WAS ASSURED BY THE SPECIALIST THAT THIS WAS CONSIDERED "NORMAL WEAR AND TEAR" ON THE CAR. HE SUGGESTED THAT I PURCHASE TOUCH-UP PAINT AND APPLY AS NEEDED. HOWEVER, IT HAS NOW BEEN WELL OVER A YEAR AND THE PAINT NOT ONLY CONTINUES TO CHIP FURTHER, BUT I'VE BEGUN TO NOTICE A FEW SMALL AREAS WHERE THERE IS ALSO CORROSION DEVELOPING. AT THIS POINT I PLAN TO BRING THE TRUCK BACK IN TO GET SOMETHING IN WRITING CONCERNING THIS PROBLEM AND LIABILITY. I DO NOT WANT TO GET SCREWED AT THE END OF MY LEASE TERM. I HAVE NEVER HEARD OF PAINT CHIPPING IN THIS WAY, ESPECIALLY NOT ON A NEW VEHICLE. I EVEN PURCHASED A 2007 PRIUS RECENTLY AND HAVE HAD NO ISSUES WHATSOEVER WITH THE PAINT ON THAT VEHICLE AND IT IS DRIVEN UNDER THE SAME CONDITIONS AS THE FJ - CITY AND HIGHWAY ONLY. *TR

• 11/12/2013· STRUCTURE

  CRACKS HAVE APPEARED ON BOTH DRIVER AND PASSENGER SIDES ON THE INSIDE OF FRONT FENDERS. THERE HAVE BEEN NUMEROUS REPORTS OF THIS ON THE INTERNET INCLUDING FORUMS AND EVEN FACEBOOK PAGES. IN SOME CASES THE FENDERS HAVE BULGED OUT. I CONTACTED TOYOTA AND THEY CLAIM THEY HAVE NEVER HEARD OF THIS PROBLEM. THEY COULD NOT TELL ME IF THIS COMPROMISES THE STRUCTURAL SAFETY OF THE VEHICLE. THIS ISSUE SEEMS TO BE IN THE 2007 AND EARLY 2008 MODELS. I LOOKED AT A FRIEND'S 2007 FJ CRUISER AND HE ALSO HAS THESE CRACKS. IT IS INTERESTING THAT TOYOTA HAS NO KNOWLEDGE OF THIS ISSUE BUT SEEMS TO HAVE REMEDIED IT IN NEWER MODELS. THE FOLLOWING IS TOYOTA'S RESPONSE (IN PART) TO MY COMPLAINT: "WE ARE UNABLE TO WEIGH THE LEGITIMACY OF THE INFORMATION FOUND DURING YOUR ONLINE RESEARCH, AS THE DETAILS OF THE INDIVIDUAL CONCERNS ARE NOT KNOWN TO US. FOR THAT REASON WE ENCOURAGE YOU TO CONTACT OUR OFFICES REGARDING YOUR TOYOTA VEHICLE, SALES, OR SERVICE EXPERIENCE SO THAT IT CAN BE FULLY ADDRESSED, AND ANY TRENDS IDENTIFIED. THE WARRANTY FOR THE FENDERS IS THE WARRANTY COVERAGE FOR THE FRONT INSIDE FENDERS IS 3 YEARS OR 36,000 MILES, WHICHEVER OCCURS FIRST FROM THE VEHICLE'S DATE OF FIRST USE. OUR RECORDS INDICATE THAT DATE IS SEPTEMBER 2, 2007. ONCE THE VEHICLE IS BEYOND THESE WARRANTY PARAMETERS, THE COST OF REPAIRS BECOMES THE OWNER'S RESPONSIBILITY. PLEASE BE AWARE THE INFORMATION YOU HAVE PROVIDED IS USED IN COMBINATION WITH WARRANTY CLAIMS AND OTHER CUSTOMER CONTACTS TO TRACK TRENDS WITH OUR VEHICLES. IF IN THE FUTURE A SPECIAL SERVICE CAMPAIGN (SSC)/RECALL OR WARRANTY ENHANCEMENT IS ISSUED THAT WOULD COVER YOUR SPECIFIC ISSUE, AND YOU HAVE ALREADY MADE REPAIRS TO THE VEHICLE, TOYOTA WOULD REVIEW YOUR REPAIRS FOR REIMBURSEMENT AT THAT TIME. " *TR