2007 Ford Freestar

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/28/2007· POWER TRAIN

  WHILE TRAVELING ON I-81 SOUTHBOUND, MY 2004 FORD FREESTAR VAN WENT OUT OF GEAR AND THE VAN LOST POWER. WHEN WE COASTED TO THE SHOULDER THE VAN WOULD NOT GO INTO GEAR. THE FORD DEALERSHIP THAT IS WORKING ON THE VAN BELIEVES IT IS THE TRANS TORQUE CONVERTER. *TR

• 12/27/2017· POWER TRAIN

  "TAKATA RECALL" WHILE DRIVING MY VAN I LOST TO GO TO THE BANK, WHEN I WENT TO PUT MY FOOT ON THE GAS PEDAL IT WOULD NOT GO. THERE WAS NO MOVEMENT. IT MADE THIS FUNNY SOUND UNDER THE HOOD. I HAD NO WARNING, IT SHIFTED GEARS, MY HUSBAND EVEN PLUGGED IN THE CODE READER AND NOTHING CAME UP. AS WE ARE LOOKING INTO THE ISSUE THE TORKE CONVERTER WENT OUT IN THE TRANSMISSION. SO NOW THIS NEEDS TO BE REPLACED. WE WE'RE ON A IT STREET AT A STOP LIGHT GETTING READY TO MAKE A LEFT HAND TURN.

• 12/22/2018· ELECTRICAL SYSTEMFire

  PASSENGER SIDE MIRROR BURNED, SMOLDERED WITH A GREAT DEAL OF SMOKE. COULD SEE ORANGE GLOW BEHIND THE MIRROR. SMELLED LIKE AN ELECTRICAL BURN. CAR WAS PARKED, NO KEY IN IGNITION, HAPPENED RIGHT AFTER UNLOCKING CAR WITH KEY FOB.

• 12/16/2015· POWER TRAIN

  WHEN I TOUCHED THE TRANSMISSION GEAR SHIFT ONE MORNING, THE CAR BEGAN ROLLING DOWN MY DRIVEWAY & ROLLED INTO THE STREET. I HAD A HARD TIME STOPPING THE VEHICLE BECAUSE THE ENGINE WAS NOT YET RUNNING & THE POWER BRAKES WERE NOT ON. THE GEAR SHIFT LEVER WOULD NOT HOLD IN PARK OR ANY OF THE OTHER GEARS. I HAD THE VEHICLE TOWED TO A TRANSMISSION REPAIR SHOP. WHEN I TOLD THE MECHANIC WHAT HAD HAPPENED, HE SAID IT WAS THE TRANSMISSION TORQUE CONVERTER & SAID, "THIS IS A COMMON PROBLEM WITH THIS VEHICLE." "I HAVE REPLACED HUNDREDS OF THEM OVER THE YEARS. OTHER INDEPENDENT TRANSMISSION REPAIR SHOPS HAVE SAID THE SAME THING. WHEN I ASKED THE CLERK AT THE LOCAL FORD DEALER PARTS DEPT., THEY WOULD NOT TELL ME HOW MANY OF THE TORQUE CONVERTERS THEY HAVE REPLACED. NOR COULD I GET ANY INFORMATION FROM THEIR TRANSMISSION REPAIR MECHANICS. MY INDEPENDENT MECHANIC DID SHOW ME THE DEFECTIVE PART OF MY TRANSMISSION & DEMONSTRATED HOW THE SPLINE IN THE CONVERTER HAD WORN OUT BECAUSE IT WAS NOT PROPER HEAT TREATED FOR PROPER HARDENING & THUS THE PART MALFUNCTIONED. NEEDLESS TO SAY, THE PUMP SHAFT GEAR WHICH INSERTS ITSELF IN THE SPLINE DOES NOT HAVE THIS MALFUNCTION. THEREFORE, ANY TRANSMISSION MECHANIC OR LAYMEN CAN ONLY COME TO THE CONCLUSION THAT THIS PART #06050700015 IS A DEFECTIVE PART & SHOULD HAVE BEEN RECALLED. THIS MALFUNCTION IS CORRECTED WITH AN AFTER-MARKET PART. I HAD TO PAY $1200 TO HAVE THIS DEFECTIVE PART REMOVED & REPLACED. YOU CAN IMAGINE THE HUNDREDS OR THOUSANDS DOLLARS FORD OWNER ALL OVER THE COUNTRY HAVE HAD TO REPLACE THIS DEFECTIVE PART. I HAVE SPOKEN TO TWO FORD MOTOR CO. CUSTOMER SERVICE REPRS. & THEY SAY, "THERE IS NOTHING THEY CAN DO ABOUT IT." I ALSO WROTE A REGISTERED LETTER TO FORD MOTOR CO. CORPORATE OFFICE & RECEIVED A MAIL REPLY WITH THE SAME RESPONSE. INITIALLY I WAS ONLY ASKING FORD MO. TO COMPENSATE ME $250. FOR THE DEFECTIVE PART & NOT THE $1200.

• 11/26/2013· POWER TRAIN

  WITHOUT ANY WARNING THE VAN WILL JUST LOSE POWER DURING TRAVEL. THIS HAPPENS EVERY FEW DAYS. MECHANICS DON'T KNOW WHY. *TR

• 11/26/2013· POWER TRAIN

  TRAVELING ON THE PA INTERSTATE VAN LOST ALL POWER. TOWED NEED COMPLETE TRANSMISSION REBUILD DUE TO FAILURE OF TORQUE CONVERTER. WE WERE LUCKY WE WERE NOT HURT. THERE WAS NO WARNING AT ALL THAT THERE WAS A ISSUE. VAN IS A NIGHTMARE. *TR

• 11/26/2013· ELECTRICAL SYSTEM

  INTERMITTENTLY LOCKS OUT THE IGNITION CAUSED BY THE FACTORY INSTALLED ANTI-THEFT SYSTEM. NOT EVER SURE WHEN THE CAR MIGHT START. THIS VAN IS A NIGHTMARE. *TR

• 11/26/2013· POWER TRAIN,ELECTRICAL SYSTEM,STRUCTURE

  WATER LEAKS DOWN THE HOOD THRU THE COWL. VANS PCM HAD TO BE REPLACED. THERE IS A TSB ON THIS. POOR DESIGN OF HOOD ALLOWS WATER TO LEAK INTO COWL AND INTO THE PCM. HAD PCM REPLACED AT $500 PLUS. THIS VAN IS A NIGHTMARE. *TR

• 11/21/2017· POWER TRAIN

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 25 MPH, WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE CONTACT HEARD A RATTLING NOISE UNDER THE HOOD. THE CONTACT STATED THAT THE RATTLING NOISE SEIZED ONCE THE SPEED WAS REDUCED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO HOMER SKELTON FORD OF MILLINGTON (9030 US-51, MILLINGTON, TN 38053 (901) 873-3673) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.

• 10/28/2014· STRUCTURE

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE HEADLAMP COVERS WERE MADE OF PLASTIC, WHICH CAUSED THE LIGHTS TO BECOME VERY DIM WHEN ACTIVATED. AFTER CLEANING THE HEADLAMP COVERS, THERE WAS A YELLOWISH TINT ON THEM THAT BECAME PERMANENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

• 10/20/2011· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  MY HUSBAND WAS DRIVING HOME FROM WORK WHEN ALL OF A SUDDEN NO WARNING, NO CHECK ENGINE LIGHT NOTHING, HE LOSES ALL GEARS AND SPEED. THERE WAS A LOT OF CARS BEHIND HIM, THE ROAD HE WAS ON IS VERY BUSY WITH SEVERAL HILLS AND BLIND SPOTS. WE HAVE CHECKED INTO THIS PROBLEM WITH FORD AND THEY STATE THAT YES THEY ARE AWARE OF A DESIGN PROBLEM WITH THE HOOD BY THE WIND SHIELD WIPERS THAT ALLOWS WATER TO GO IN, DRAIN DOWN THE FIRE WALL AND LEAK INTO THE PCM MODULE AND THE TRANSMISSION. THIS WATER SHORTS THEM OUT AND WITH NO WARNING YOU LOSE SPEED AND GEARS TO CONTINUE DRIVING. THIS IS A HUGE SAFETY ISSUE, I JUST THANK GOD OUR CHILDREN WERE NOT IN THE VAN, AND THAT HE WAS ABLE TO GET THE VAN OFF TO THE SIDE OF THE ROAD.

• 10/19/2011· ENGINE AND ENGINE COOLING,POWER TRAIN

  SUDDEN FAILURE OF THE TRANSMISSION. *TR

• 09/23/2024· SEATS

  The contact owns a 2007 Ford Freestar. The contact received notification of NHTSA Campaign Number: 13V081000 (Seats); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The VIN was unavailable.

• 09/05/2018· POWER TRAIN

  TORQUE CONVERTER IS SHOWING SIGNS OF FAILURE WITH VAN A LESS THAN 50K MILES. A TRANSMISSION FLUSH AND SERVICE INCLUDING FORD'S FRICTION MODIFIER DID NOT FIX.

• 09/04/2013· POWER TRAIN

  PULLED IN TO DRIVEWAY TO PICK UP A PASSENGER, STOPPED AND PUT IT IN REVERSE AND BANG, THE MOTOR DIED. RESTARTED AND SAME THING. GOT IT TO GO FORWARD BUT SAME PROBLEM, STARTS FINE AND RUNS UNTIL YOU PUT IT IN GEAR, AND IT DIES. *JB

• 08/27/2012· VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM

  WHILE PARKING THE CAR, THE ENGINE/GAS SURGED TAKING ME SLIGHTLY FORWARD UNTIL I PUT ON THE BRAKE. THE FIRST TIME HAPPENED IN MAY, BUT IT CONTINUES TO HAPPEN ESPECIALLY WHEN I AM GOING SLOWLY (PARKING ETC) BOTH IN FORWARD AND REVERSE AND HAVE THE AIR CONDITIONING ON. *TR

• 08/27/2010· POWER TRAIN

  THIS IS MY SECOND COMPLAINT FORM SUBMISSION FOR THE PROBLEM. LAST FALL MY 2007 FORD FREESTAR BROKEN DOWN DUE TO TRANSMISSION MALFUNCTION. I WAS TOLD THAT FORD HAS ALOT OF PROBLEMS WITH TRANSMISSIONS. I NEED TO KNOW WHAT ELSE I CAN DO TO REIMBURSED FOR THE FAILURE OF THE TRANSMISSION. I WAS ON MY WAY TO COLLEGE CLASSES WHEN THE VAN BROKEN DOWN. *TR

• 08/26/2015· ENGINE

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE STALLED. THE VEHICLE WAS UNABLE TO RESTART. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS UNKNOWN WHAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,430. THE VIN WAS NOT AVAILABLE. UPDATED 11/09/15*LJ *CN

• 08/02/2018· ENGINE

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED AS THE ACCELERATOR PEDAL WAS DEPRESSED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 89,000. *JS

• 08/02/2016· STRUCTURE

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE WHEELS SEIZED WHILE DRIVING, WHICH RESULTED IN A LOSS OF CONTROL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUBFRAME WAS SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 142,900.

• 07/30/2012· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE ACCELERATED ABNORMALLY WHEN IN REVERSE AND WITH THE BRAKES DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE VEHICLE WAS IN NEED OF MAINTENANCE AND NEEDED A TUNE UP PERFORMED. THE REPAIRS WERE PERFORMED ON THE VEHICLE BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 95,000 AND THE CURRENT MILEAGE WAS 105,000.

• 07/23/2012· POWER TRAIN

  DRIVING AT HIGHWAY SPEEDS IN TRAFFIC WITH THREE CHILDREN IN THE CAR, WHEN THE TORQUE CONVERTER/TRANSMISSION FAILED WITH NO WARNING OR INDICATION OF PREVIOUS PROBLEM. VEHICLE WOULD NOT RESPOND TO ACCELERATOR. FORTUNATELY,WAS ABLE TO COAST OFF EXIT RAMP SAFELY. WOULD NOT GO FORWARD OR BACKWARD. 300 MILES FROM HOME. TOWING, CAR RENTAL AND REPAIRS. DEALER SAID RECALL NOT APPLIED TO THIS YEAR BUT SAME PROBLEMS AS PREVIOUS YEARS. FORD SHOULD FIX THIS BEFORE SOMEONE IS KILLED. THEY ARE AWARE OF THE SITUATION.

• 07/22/2014· STEERING

  STEERING KNUCKLE-WHEN DRIVING GOING TO MAKE TURNS EITHER WAY THE STEERING GETS HARD,ACTS LIKE THERE NO POWER STEERING.WAS TOLD TO SPRAY WITH WD40,DID THAT MAKES IT EASER BUT YOU HAVE TO DO IT ONCE A WEEK. *TR

• 07/22/2010· VEHICLE SPEED CONTROL

  TL*THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE THE CONTACT WAS DRIVING IN REVERSE LESS THAN 5 MPH, THE VEHICLE UNEXPECTEDLY SURGED FORWARD WHEN SHIFTING FROM THE REVERSE GEAR INTO THE DRIVE POSITION. THE BRAKES WERE ENGAGED AND THE VEHICLE STOPPED. THE FAILURE OCCURRED WHENEVER THE GEAR SELECTOR WAS SHIFTED FROM REVERSE GEAR INTO ANY GEAR RANGE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE TECHNICIAN STATED THAT THE FAILURE WAS RELATED TO THE AIR FILTER. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS IN THE PROCESS OF TAKING THE VEHICLE BACK TO THE AUTHORIZED DEALER FOR FURTHER DIAGNOSIS. THE FAILURE MILEAGE WAS 92,000.

• 07/21/2012· VEHICLE SPEED CONTROL,ENGINE

  VEHICLE LUNGES FORWARD AND TACHOMETER SHOWS MOMENTARY ENGINE RPMS UP TO 2500 CAUSING VEHICLE TO SURGE. USING THE BRAKE PEDAL TO CONTROL THE UNEXPECTED MOTION STALLS OUT THE ENGINE WHICH WHEN RESTARTED CAN ONLY DRIVE AT VERY REDUCED SPEED. FORD DEALERSHIP REPLACED THROTTLE BODY AND REPROGRAMMED SENSOR FOR MORE TOLERANCE AS PER NEW FORD SPECS. SERVICE ADVISOR ATTRIBUTED THE BAD THROTTLE BODY TO LOW QUALITY GASOLINE. *TR

• 07/19/2017· POWER TRAIN

  NOISE FROM THE TRANSMISSION. CAR WILL SURGE JUMP WHILE IN GEAR.MY CAR ONLY HAS 48000 MILES

• 07/17/2012· POWER TRAIN

  DRIVING ON FREEWAY AND SUDDENLY CAR WOULD NOT ACCELERATE! IT WAS RUSH HOUR AND I WAS TERRIFIED. MIRACULOUSLY, I WAS ABLE TO COAST TO THE SHOULDER WITHOUT MAJOR INCIDENT. AT THAT TIME, CAR WOULD NOT ENTER ANY GEARS. UPON ACCELERATION THE CAR WOULD JUST REV, BUT WOULD NOT MOVE, EVEN IN REVERSE. FORTUNATELY, I HADN'T PICKED UP MY CHILDREN FROM SCHOOL YET! I COULDN'T IMAGINE BEING STRANDED ON THE SIDE OF THE FREEWAY WITH THEM. IT WAS SCARY ENOUGH FOR ME! CAR WAS TOWED TO LOCAL FORD DEALERSHIP, WHERE IT TOOK THEM A WEEK TO REBUILD/REPLACE THE TORQUE CONVERTER. THANKFULLY, IT WAS COVERED UNDER WARRANTY, BUT IT STILL COST ME $100 DEDUCTIBLE, PLUS THE ENORMOUS INCONVENIENCE OF NOT HAVING A CAR. I HAD 3 YOUNG CHILDREN AND A FULL TIME JOB AND NO CAR FOR A WEEK. FORD REFUSED TO PROVIDE ME A RENTAL. CONSIDERING SOME OF THE OTHER HORROR STORIES, I GUESS I GOT OFF PRETTY LUCKY. TOO MANY OF THESE STORIES OUT THERE, FORD NEEDS TO RECALL!! *TR

• 07/16/2015· POWER TRAIN

  DRIVEN CAR STARTED TO SOUND LIKE BROKEN AXLE,TOOK TO FORD DEALER GEORGE WALL SHREWSBURY,N.J. IT COST A $ 150.00 THEY HELD CAR FOR 2 DAYS AND TOLD US THAT THERE WAS NOTHING WRONG WITH THE CAR. NOISE KEPT GETTING WORST FREND FOR CHRYSLER LISTENED TO IT AND DROVE IT HE SAID IT WAS TRANSMISSION PROBLEM. I HAD NEW TRANSMISSION PUT IN CAR AT COST OF $3500.00. I KEPT CALLING FORD WITH NO LUCK. THIS VEHICLE WAS MANUFACTURED IN JUNE06,2006

• 07/15/2015· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHEN THE CONTACT ACTIVATED THE VENT CONTROL FOR THE AIR CONDITIONER, THERE WAS A PROGRESSIVE FAILURE AND THE VEHICLE SURGED FORWARD. THE CONTACT HAD TO ENSURE THAT THE BRAKE PEDAL WAS APPLIED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE IDLED VERY POORLY WHILE DRIVING AT A LOW RATE OF SPEED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA ACTION NUMBER: PE11018 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

• 07/15/2013· SUSPENSION,POWER TRAIN

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT HE BEGAN TO DRIVE IN REVERSE AND HEARD A LOUD BANGING SOUND. THE CONTACT STATED THAT HE PUT THE VEHICLE IN PARK AND EXIT THE VEHICLE; HOWEVER, IT BEGAN TO ROLL BACKWARDS. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION .THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 54,423. ...UPDATED 08/22/13 *BF THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER. AN INSPECTION REVEALED, THE RIGHT FRONT AXLE WAS BROKEN.

• 07/15/2010· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS 2007 FORD FREESTAR. THE CONTACT STATED THAT SEVERAL TIMES WHEN HE WOULD SHIFT INTO REVERSE OR DRIVE, THE VEHICLE WOULD ABNORMALLY ACCELERATE WITHOUT WARNING. THE DEALER DIAGNOSED THE FAILURE AS A DEFECTIVE THROTTLE BODY. THE VEHICLE WAS NOT YET REPAIRED. THE FAILURE MILEAGE WAS 37,000 AND THE CURRENT MILEAGE WAS 43,000.

• 07/07/2016· POWER TRAIN

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DEPRESSING THE ACCELERATOR PEDAL AT ANY SPEED, THE VEHICLE DID NOT RESPOND AND A WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A MECHANIC WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 103,000.

• 07/05/2018· SEATS

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE THE VEHICLE WAS BEING REVERSED WITH PASSENGERS SEATED IN THE THIRD ROW, THE THIRD ROW SEAT ATTACHMENT BOLT FRACTURED. THE CONTACT STATED THAT THE SEAT SHIFTED AND WAS NO LONGER SECURELY FASTENED TO THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

• 07/05/2011· POWER TRAIN,VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT WAS DRIVING IN REVERSE AT APPROXIMATELY 5 MPH INTO A PARKING SPACE WITH THE BRAKE PEDAL ENGAGED WHEN THE VEHICLE BEGAN TO LUNGE UNEXPECTEDLY. THE FAILURE OCCURRED SPORADICALLY WHILE DRIVING AT LOW SPEED. THE VEHICLE RECENTLY STALLED WITH THE ILLUMINATION OF THE ENGINE WARNING INDICATOR. THE VEHICLE RESTARTED AND RESUMED AS NORMAL. THE CONTACT NOTIFIED THE DEALER AND THEY RECOMMENDED THE VEHICLE BE DIAGNOSED TO DETERMINE THE CAUSE OF FAILURE. THE CONTACT PLANNED TO TAKE THE VEHICLE FOR DIAGNOSIS. THE MANUFACTURER WAS NOT MADE AWARE OF THE DEFECT. THERE WAS AN OPEN INVESTIGATION RELATED TO THE FAILURE UNDER NHTSA ACTION NUMBER PE10033 (VEHICLE SPEED CONTROL; POWER TRAIN: AUTOMATIC TRANSMISSION: CONTROL MODULE/TCM,). THE FAILURE MILEAGE WAS 90,000.

• 07/05/2011· POWER TRAIN

  MY 2007 FORD FREESTYLE HAD BEEN SURGING FORWARD. I THOUGHT I WAS CRAZY. THEN 6/21/11 IT WOULD ONLY DRIVE 35MPH. I HAD TO REPLACE THE THROTTLE BODY. *KB

• 07/04/2008· POWER TRAIN,VEHICLE SPEED CONTROL

  MY 2007 VAN HAS STOPPED DRIVING ON OVER 6 OCCASIONS WHILE I AM DRIVING, IT HAS BEEN REPAIRED 4X AND ALWAYS TOLD IT WAS A NEW ISSUE. ON THE LAST OCCASION I LEFT THE VAN ON THE ROAD GOT MY MOM TO PICK ME UP. I HAVE 3 KIDS THAT I DRIVE IN THE VEHICLE AND FORD WILL NOT TAKE ANY RESPONSIBILITY, I THINK 4 ATTEMPTS TO FIX A VAN IS MORE THEN FAIR ON MY PART, IT IS EVIDENT THAT FORD DOES NOT KNOW WHAT THE PROBLEM IS, AND I WILL NOT BE THEIR GUINEA PIG. *TR

• 06/24/2013· POWER TRAIN

  TRANSMISSION FAILED WITH NO SIGNS. I AM PREGNANT AND HAD MY 3 OTHER CHILDREN WITH ME. CHECKED ONLINE AND FOUND OUT THAT FORD IS USING A FAULTY TORQUE CONVERTER/TRANSMISSION. *TR

• 06/08/2012· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE WOULD UNEXPECTEDLY JERK FORWARD. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 90,258. THE VIN WAS NOT AVAILABLE.

• 06/08/2011· POWER TRAIN

  MY FORD FREESTAR HAS SPORADIC ISSUES, I HAVE NOTICED THAT THIS ISSUE ONLY HAPPENS WHEN IT RAINS. I HAVE TAKEN IT TO MECHANIC AND THEY ARE NOT ABLE TO LOCATE THE PROBLEM. I HAVE BEEN DOING RESEARCH ONLINE AND NOTICE THAT THERE IS A LOT OF COMPLAINTS ABOUT THIS ISSUE AND NOTHING IS BEING DONE ABOUT IT. WE GET THE PCM REPLACED AND THEN BECAUSE OF THE DEFECT IT GETS WET AGAIN. WHEN WILL THIS ISSUE BE RESOLVED? *TR

• 06/03/2016· POWER TRAIN

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 30 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TORQUE CONVERTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

• 05/23/2011· SUSPENSION

  2007 FORD FREESTAR SEL FRONT WHEEL BEARING HUBS MAKING A VERY HIGH PITCH WHISTLING NOISE. OBVIOUSLY THIS IS A VERY WELL KNOWN PROBLEM BY THE NUMBER OF COMPLAINTS LISTED ONLINE. I THINK THIS SHOULD BE A RECALL ITEM. *TR

• 05/02/2012· POWER TRAIN

  FORD'S RECALL 11S25 SAYS IT PERTAINS TO 2004-05 MODEL YEARS ON THE TORQUE CONVERTER FAILURE. MINE IS A 2006 FREESTAR AND IT HAS THE SAME EXACT PROBLEM. THE TORQUE CONVERTER FAILED ON IT DRIVING DOWN THE HIGHWAY. WHY IS YEAR NOT COVERED ? *JS

• 04/27/2011· POWER TRAIN

  I HAVE NOTICED THAT THIS ISSUE ONLY OCCURS WHEN IT RAINS. I HAVE TAKE IT TO SEVERAL MECHANIC AND THEY WHERE NOT ABLE TO PIN POINT THE ISSUE SINCE IT DOES NOT HAPPEN REGULARLY. WHILE DOING SOME RESEARCH ON THE INTERNET I HAVE NOTICED THAT THIS IS A COMMON THING AMONG FORD FREE STAR. I PLAN TO TAKE MY VEHICLE TO A MECHANIC WITH THE INFORMATION REGARDING PCM ISSUE, IF THIS A COMMON DEFECT I HOPE THERE WILL BE A RECALL. THIS IS AFAMILY VEHICLE I DRIVE MY CHILDREN IN IT EVERYDAY AND THIS IS A POTENTIAL HAZARD IF MY VAN WAS TO DIE ON THE INTERSTATE. *TR

• 04/25/2022· SEATS

  The contact owns a 2007 Ford Freestar. The contact stated that he discovered two large holes located on both sides of the third-row seats. The contact stated that the holes were located at the seat anchors; the structural degradation at the seat anchor were mounted to the rear wheel wells. The contact then discovered that his vehicle was placed under NHTSA Campaign Number: 13V081000 (Seats). The contact then notified the dealer and was informed that the part to repair the vehicle was not available and also that the corrosion on the vehicle was too severe to complete the repair. The manufacturer was also notified of the failure and referred the contact to the Better Business Bureau for further assistance. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The failure mileage was approximately 100,000. Parts distribution disconnect.

• 04/23/2013· ENGINE

  WHILE DRIVING ON A FOUR LANE IN CHARLESTON SC MY VAN STARTED JERKING AND I LOST ALL POWER AND FELT LIKE I WAS GOING TO HAVE A HEART ATTACK ! IT DID COAST ENOUGH TO GET TO THE SIDE OF THE ROAD. AFTER IT SAT FOR SEVERAL MINUTES IT STARTED UP FINE. BUT LET ME TELL YOU I ONLY LIVE 5 MILES FROM THE FIRST POWER SHUT DOWN BUT IT HAPPENED 3 MORE TIMES BEFORE I GOT HOME. *TR

• 04/20/2017· STRUCTURE

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE REAR QUARTER PANELS ON THE VEHICLE WERE RUSTED AND CORRODED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V081000 (STRUCTURE). THE CONTACT INDICATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 120,000.

• 04/11/2012· ENGINE AND ENGINE COOLING,POWER TRAIN

  I WAS AT A BUSY INTERSECTION IN MY TOWN. WHEN THE LIGHT TURNED GREEN, I STARTED THROUGH THE INTERSECTION BUT SUDDENLY THERE WAS NO POWER. I WAS STALLED BUT EVENTUALLY DISCOVERED THAT I COULD PUT THE VEHICLE INTO 3RD GEAR AND COULD EKE MY WAY THROUGH THE INTERSECTION. I HAD MY 5 YEAR OLD SON IN THE CAR, PEOPLE WERE HONKING, IT WAS A MESS. FORTUNATELY, WE DIDN'T GET HIT. I TOOK THE FORD FREESTAR TO TWO SHOPS THAT BOTH TOLD ME THE TRANSMISSION HAD FAILED AND NEEDED TO BE REPLACED. THE SHOP I TOOK IT TO ALSO TOLD ME THE RADIATOR WAS LEAKING INTO THE TRANSMISSION SO THE RADIATOR NEEDED TO BE REPLACED AS WELL. THE WHOLE ORDEAL COST ME $4,900 FOR THE CAR REPAIR + RENTAL CAR. I'M VERY GLAD MY CHILD AND I DIDN'T GET HURT, AND I AM DEFINITELY UPSET THAT A CAR THAT WAS ONLY A FEW YEARS OLD WOULD REQUIRE SUCH AN EXPENSIVE REPAIR. ALTHOUGH I GOT THE CAR FIXED, I WONDER IF THE TRANSMISSION WILL FAIL AGAIN. *TR

• 04/10/2012· POWER TRAIN

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT WAS STATED THAT WHILE DRIVING 20 MPH, HE DEPRESSED THE ACCELERATOR PEDAL AND THE VEHICLE DECELERATED. THERE WAS AN INCREASE IN THE ENGINE RPMS DURING THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE DEALER STATED THAT THE TRANSMISSION TORQUE CONVERTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 69,375 AND THE CURRENT MILEAGE IS 114,000. UPDATED 05/01/2012*LJ UPDATED 05/04/12

• 04/07/2016· POWER TRAIN

  TRANSMISSION JUST STOPPED WORKING WITH ROUGHLY 77,835 MILES, IN A STATIONARY MODE PARKED. FORD TRANSMISSION THEY PUT IN HAD A BETTER WARRANTY THAN ON THE NEW CAR.

• 04/03/2013· POWER TRAIN

  TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH WHEN THE TRANSMISSION FAILED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE THE CONTACT WAS ADVISED THAT THE POWER TRAIN REQUIRED REPLACEMENT. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.