2007 Ford Five Hundred

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2010· POWER TRAIN

  CAR: 2007 FORD 500 LIMITED. MOVING SHIFT LEVER FROM PARK TO REVERSE OR TO DRIVE, AFTER ABOUT 1 SECOND THE CAR "LURCHES" FORWARD OR BACKWARD. I KEEP THE BRAKE LOCKED DOWN WHEN CHANGING GEARS FOR SEVERAL SECONDS UNTIL IM SURE IT WONT JUMP BUT I HAVE TO REMEMBER TO DO IT. THIS IS DANGEROUS. WHEN THIS FIRST STARTED HAPPENING, I ALMOST RAN OVER SOMEONE. I HOPE YOU CAN IDENTIFY THE PROBLEM AND LET ME KNOW OR HAVE FORD PUT OUT A SAFETY RECALL AND A FIX FOR THE PROBLEM. THANKS *TR

• 12/30/2007· TIRES

  I HAVE A 2007 FORD FIVE HUNDRED WITH CONTINENTAL P215-60R17 TIRES. ON DEC 14, 2007, AFTER MY TIRES HAD BEEN ROTATED AT TOWN EAST FORD IN MESQUITE TEXAS, I NOTICED A LARGE BUBBLE IN THE RIGHT FRONT TIRE ALONG THE SEAM OF THE TIRE. SAID TIRE ID# DOT CODE A3KT 3MT 3906.THE TIRES HAD APPROX 21,250 MILES AT THE TIME. THEY HAVE BEEN ROTATED AT LEAST 4 TIMES SINCE I PURCHASED THE CAR AND I CAN SHOW THAT THE TIRE INFLATION IS CHECKED REGULARLY WHEN I GET THE OIL CHANGED. TOWN EAST FORD TOLD ME THE TIRE WAS NOT COVERED UNDER WARRANTY AS IT WAS CONSIDERED ROAD HAZARD. ORIGINALLY I WAS TOLD IT WAS DUE TO POTHOLES, THEN LATER THAT IT WAS DUE TO A NAIL THAT CAUSED LOW TIRE PRESSURE. I WAS NEVER INFORMED OF A NAIL, NOR DID THEY SHOW ME THE DAMAGE. I CONTEND THE TIRE IS FAULTY; I HAD TO REPLACE THE TIRE AT MY OWN COST. I AM CURRENTLY SENDING CORRESPONDENCE TO TOWN EAST FORD, CONTINENTAL TIRE, NHTSA, AND FORD MOTOR COMPANY. *TR

• 12/19/2012· POWER TRAIN,VEHICLE SPEED CONTROL

  AT VERY LOW SPEEDS (EXAMPLE IN A PARKING LOT) TRYING TO PARK THE CAR IT WILL SURGE REALLY HARD EVEN WHEN FOOT IS ON BRAKE.. MAKES PARKING VERY DANGEROUS.. I ALMOST HIT A PERSON AND ALMOST WRECKED INTO ANOTHER CAR ANOTHER TIME.. WHEN SHIFTING FROM PARK TO REVERSE WITH FOOT ON BRAKE THE RPMS GO AWAY UP AND IT IS AS IF SOMEONE IS FLOORING THE GAS PEDAL. *TR

• 12/18/2015· ELECTRICAL SYSTEM

  WHILE DRIVING ONE DAY, MY CLUSTER PANEL WENT DARK. AT FIRST I THOUGHT IT MAY BE THE BATTERY, WHICH WOULD ALSO CAUSE THE CAR TO DIE. HOWEVER, THE CAR WAS STILL RUNNING. WHEN I DROVE IT TO MY MECHANIC, IT DID THE SAME THING BUT BEGAN FLICKERING ON AND OFF THE WHOLE WAY THERE. NOT ONLY WAS IT ANNOYING, BUT I COULD NOT SEE MY SPEED NOR MY GAS GAUGE. ADDITIONALLY, WHEN I TRIED TO USE MY EMERGENCY LIGHTS, THEY WOULD ALSO GO OFF WHENEVER THE PANEL WENT OUT. THE REPAIR OF THE WHOLE CLUSTER PANEL IS NOT CHEAP. AN ESTIMATE FOR ME WAS $900 FROM MY MECHANIC. SINCE IT WILL HAVE TO BE PROGRAMMED HOWEVER, I WILL HAVE TO TAKE IT TO FORD WHICH IS A PAIN IN ITSELF. THERE ARE COUNTLESS REVIEWS ON THIS PROBLEM, IT SHOULD NOT BE LEFT UP TO THE CONSUMER TO TAKE ON SUCH A SIGNIFICANT EXPENSE. MY CAR HAS ROUGHLY 62,000 MILES ON IT.

• 12/16/2011· FUEL SYSTEM, GASOLINE,POWER TRAINCrash

  WAS STOPPED AT A DRIVE-THRU WINDOW AND WHEN I WENT TO PULL UP TO RECEIVE MY FOOD, THE CAR LURCHED AHEAD OF THE WINDOW. I PUT THE CAR IN REVERSE TO PICK UP MY FOOD AND IT LURCHED SO FAST BACKWARD THAT I HAD NO CONTROL OF IT, EVEN WITH MY FOOT ON THE BRAKE. THIS CAUSED A CRASH INTO THE FRONT OF ANOTHER CAR. I HAVE NEVER HAD AN ACCIDENT AND I AM A CAREFUL DRIVER. I RECEIVED A MOVING VIOLATION AND THERE WAS DAMAGE DONE TO BOTH CARS. ENOUGH DAMAGE THAT OUR INSURANCE COMPANY IS INVOLVED. FORD SHOULD DO SOMETHING ABOUT THESE LURCH PROBLEMS BEFORE SOMEONE IS KILLED. THANK GOODNESS NO ONE WAS IN FRONT OF ME OR THEY WOULD HAVE BEEN KILLED, PLEASE, FORD, DO SOMETHING ABOUT THESE FORDS THAT HAVE THIS PROBLEM. *TR

• 12/14/2011· ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

  AT A STOPLIGHT WITH THE BRAKE ON THE ENGINE REVVED UP AND THE CAR JUMPED FORWARD ABOUT 20 FEET BEFORE I COULD STOP IT. AT THE NEXT LIGHT THE SAME THING HAPPENED. AT MY FINAL DESTINATION APPROXIMATELY 2 MILES AWAY MY SON (WHO WAS WITH ME THE WHOLE TIME = I WAS TAKING HIM BACK TO COLLEGE) TOLD ME TO LET THE CAR RUN TO SEE IF IT WOULD DO IT AGAIN. WITH THE CAR IN DRIVE AND MY FOOT ON THE BRAKE (HARD) IT REVVED UP 2 MORE TIMES IN LESS THAN 2 MINUTES TO AT LEAST 1500 RPM AND WAS VERY DIFFICULT TO HOLD BACK. I TOOK IT IN TO THE DEALER THE NEXT DAY AND THEY REPLACED THE THROTTLE BODY AT A COST OF $800. AFTER CALLING FORD AND REPORTING THE SITUATION THEY REFUSED TO DOCUMENT THIS OR MAKE A CASE NUMBER UNTIL I TOLD THEM I KNEW THERE WAS A TECHNICAL BULLETIN ON THIS ACCORDING TO THE DEALER. THEY GAVE ME A CASE NUMBER [XXX] BUT WERE RUDE TO ME AND COULD NOT ANSWER IF THE REPLACEMENT PART ADDRESSED THE ISSUE AND HAS BEEN FIXED. I DO NOT KNOW IF IT WILL HAPPEN IN THE NEXT MILE, NEXT 100,000 MILES, OR NEVER AGAIN IF THEY WILL NOT SAY IF REPLACEMENT PARTS HAVE CORRECTED A PROBLEM. IF A CAR OR PEDESTRIAN WERE IN FRONT OF ME WHEN THIS HAPPENED I WOULD HAVE HAD AN ACCIDENT WITHOUT DOUBT. THIS CAR HAS A SAFETY PROBLEM AND THE INCIDENT HAPPENED ON NOV. 27, 2011. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/09/2015· WHEELS

  TL* THE CONTACT OWNS A 2007 FORD FIVE HUNDRED. WHILE DRIVING VARIOUS SPEEDS, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR PASSENGER SIDE WHEEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO LOCATE THE ORIGIN OF THE NOISE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

• 11/29/2010· FUEL SYSTEM, GASOLINE

  I HAVE A 2007 FORD FIVE HUNDRED THAT HAD LESS THAN 60,000 MILES WHEN THE THROTTLE BODY BEGAN TO FAIL. THIS CAUSES THE CAR TO JERK FORWARD AND BACKWARD AS I AM TAKING MY FOOT OFF THE BRAKE. I HAVE ALMOST HIT A PEDESTRIAN ONCE AND OTHER VEHICLES ON MORE THAN ONE OCCASION. I TOOK THE CAR TO THE FORD DEALERSHIP, WAS TOLD IT WAS THE THROTTLE BODY AND THERE WAS NOT A RECALL EVEN THOUGH THIS WAS VERY PREVALENT IN THE FORD FREESTYLES. I WAS ALSO TOLD IT WOULD COST AT LEAST $700.00 TO FIX. THEY DID CLEAN THE THROTTLE BODY FOR WHICH I PAID $70.00. THAT WAS ABOUT 2 MONTHS AGO AND IT IS JERKING AGAIN. THIS IS DANGEROUS AS I CANNOT KEEP MY CAR FROM JERKING NO MATTER HOW SLOWLY I MOVE MY FOOT FROM THE BRAKE OR NOT COMPLETELY. *TR

• 11/27/2019· ELECTRICAL SYSTEM

  THE ANTI THEFT IS ON

• 11/26/2013· FUEL SYSTEM, GASOLINE,POWER TRAIN,ENGINE

  WRENCH INDICATOR LIGHT CAME ON AND CAR BEGAN TO SPOTTER AND SURGE. THE NEXT DAY I TOOK IT TO THE FORD DEALERSHIP AND THE WRENCH LIGHT AND CHECK ENGINE CAME ON. CAR STALLED OUT 2 TIMES ON THE WAY TO THE DEALER. DEALER WANTS $950 TO REPLACE THROTTLE BODY. *TR

• 11/19/2015· FUEL/PROPULSION SYSTEM

  AT A STANDSTILL, CAR SEEMS TO WANT TO SURGE FORWARD, HAVE TO BRAKE TO KEEP FROM HITTING OTHER CAR.

• 11/18/2015· VISIBILITYFire

  TL* THE CONTACT OWNS A 2007 FORD FIVE HUNDRED. WHILE THE VEHICLE WAS PARKED AND TURNED OFF, THE PASSENGER SIDE MIRROR CAUGHT FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

• 11/16/2011· FUEL SYSTEM, GASOLINE

  AUTOMOBILE LUNGED FORWARD WITHOUT TOUCHING GAS WHEN AIR CONDITIONER OR HEAT ON. TOOK CAR TO DEALERSHIP AND THEY CLEANED THROTTLE PLATE, FUEL INJECTION THROTTLE BODY AND REPROGRAMMED POWERTRAIN CONTROL. SEEN ONLINE OTHERS HAD THIS SAME PROBLEM . CAR ONLY HAS 47,000 MILES. *TR

• 11/10/2023· POWER TRAIN

  It's starting not going into highway gears (5&6) just revs real high and when it does finally, it kicks really hard. Sounds and feels like it's going to drop out from under the car.

• 11/10/2011· TRACTION CONTROL SYSTEM

  TL* THE CONTACT OWNS A 2007 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE TRACTION CONTROL WARNING LIGHT CONSTANTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC BUT THERE WERE NO FAILURE CODES GENERATED. THE CONTACT STATED THAT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WOULD BE TAKEN BACK TO THE DEALER FOR DIAGNOSTICS BUT THE DEALER WAS NEVER ABLE TO LOCATE THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER FOR POSSIBLE REPAIRS AND ANSWERS TO ANY FURTHER QUESTIONS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 23,030. UPDATED11/29/11 *BF UPDATED 12/12/11

• 11/09/2009· FUEL SYSTEM, GASOLINE

  2007 FORD FIVE HUNDRED SURGES FORWARD IN PARKING LOTS, STOP LIGHTS, GOING FROM PARK TO DRIVE OR PARK TO REVERSE. ALMOST HITTING CARS, PEDESTRIANS WHEN IT SURGES BACKWARD AND FORWARD. *TR

• 11/07/2013· POWER TRAIN,ENGINE

  TL* THE CONTACT OWNS A 2007 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED THEN THE VEHICLE PRODUCED A LOUD NOISE AND FAILED TO ACCELERATE. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION. THE VEHICLE WAS DIAGNOSED WITH AN ISSUE WITH THE TRANSMISSION BUT THE EXACT DIAGNOSIS WAS UNKNOWN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE INCIDENT. THE FAILURE MILEAGE WAS 126,489.

• 11/07/2011· STEERING,SUSPENSION,WHEELS

  MY FORD BEGAN ACTING STRANGELY WHEN TURNING, AND WOULD HYDROPLANE BADLY WHEN RAINING. I TOOK IT TO MY INDEPENDENT GARAGE AND THEY FOUND THAT THE LEFT LOWER BALL JOINT RETAINING NUT HAD WORKED LOOSE. THAT CAUSED THE LEFT FRONT WHEEL TO MOVE IN TOWARD THE BALL JOINT AND THE JOINT OR NUT TORE THE TIRE DOWN TO THE STEEL BELT. THE SERVICE MANAGER INDICATED THAT IT APPEARED THAT THE NUT WAS NOT TORQUED CORRECTLY AT THE FACTORY. OF COURSE, I HAD TO HAVE THE BALL JOINT REPLACED AND TWO NEW TIRES. I DID NOTIFY FORD MOTOR CO. *TR

• 11/06/2014· POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

  THE CAR WILL SURGE WHEN YOU PUT IT IN GEAR. DOES IT IN DRIVE AND REVERSE. I HAVE TO KEEP MY FOOT ON THE BRAKE UNTIL I AM AWAY FROM A CAR OR BUILDING AS IT WILL JUMP INTO THEM. I NEVER KNOW WHEN ITS GOING TO DO IT. I ESTIMATED WHEN IT STARTED AND IS STILL DOING IT. *TR

• 11/04/2007· AIR BAGS,EQUIPMENT

  VEHICLE MISSING SIDE CURTAIN AIR BAGS FRONT AND REAR ALTHOUGH LISTED ON USED CAR DEALER STICKER. *JB

• 10/30/2009· VEHICLE SPEED CONTROL

  2007 FORD FIVE HUNDRED OPERATING ON THE MA. TURNPIKE... STEPPED ON ACCELERATOR TO KICK INTO PASSING GEAR TO PASS A TRAILER TRUCK AND ACCELERATED TO APP 75 MPH...... LIFTED FOOT OFF ACCELERATOR, BUT CAR STAYED IN PASSING GEAR AND ACCELERATED FURTHER..(TO APP 90 MPH BEFORE EPISODE ENDED) APPLIED BRAKES AND FOUGHT THE ACCELERATION WHILE TRYING TO BRAKE... TRIED PUSHING THE "OFF" SWITCH FOR CRUISE CONTROL (EVEN THOUGH I WAS NOT USING CRUISE CONTROL TO NO AVAIL..... TRIED LIFTING GAS PEDAL UP WITH TOE OF MY FOOT...NO RESULTS.... HAVE NO FLOOR MATS IN THE CAR THAT MIGHT HAVE TANGLED...... FINALLY STOMPED THE GAS TO THE FLOOR SEVERAL TIMES IN A RAPID SUCCESSION AND ACCELERATOR LET UP..... AFTER CHANGING MY SHORTS, TRIED TO DUPLICATE THE EPISODE.... BUT IT DID NOT GET STUCK AGAIN EVEN THOUGH I STOMPED IT INTO PASSING GEAR SEVERAL TIMES.... IT HAS NOT HAPPENED AGAIN SINCE THEN (1 DAY AGO OR APP. 300 MILES OF DRIVING).. *TR

• 10/29/2013· ENGINE

  ENGINE MOUNTS , ANTI TORQUE MOUNTS , BROKE OR LOOSE. ENGINE SHIFTS A GOOD 12 INCHES TOWARDS FIREWALL. VEHICLE HAS 45000 MILES, AND IS 5 YEARS OLD. *TR

• 10/29/2012· VEHICLE SPEED CONTROL,ENGINE

  I PUT MY CAR IN REVERSE TO BACK INTO A PARKING SPACE AND THE CAR ENGINE ACCELERATE AS IF IT I WAS ON THE GAS PEDAL GOING 50, EXCEPT I WAS ON THE BRAKE. IF I AM SITTING AT A RED LIGHT THE CAR ENGINE ACCELERATE I NOTICED THAT THE RPM NEEDLE WILL GO UP TO 3 SOMETIME 4 IF I AM NOT CAREFUL TO KEEP CONTROL OF THE CAR IT WILL TAKE OFF SO I HAVE TO BE CAREFUL TO KEEP MY FOOT ON THE BRAKES. *TR

• 10/28/2011· ENGINE AND ENGINE COOLING

  WHEN I SHIFT FROM A STOPPED POSITION, EITHER INTO DRIVE OR REVERSE, THE CAR LUNGES OR JUMPS FORWARD. IT MAKES IT VERY DIFFICULT TO CONTROL. THE DEALER KNOWS ABOUT THE PROBLEM AND SAYS THAT FORD KNOWS ABOUT THE PROBLEM, BUT REFUSES TO FIX IT UNLESS A GOD AWFUL AMOUNT OF MONEY IS PAID IN REPAIR COSTS. THEN HE SAYS IT MAY HAPPEN AGAIN! *TR

• 10/22/2019· ELECTRICAL SYSTEM

  INSTRUMENT CLUSTER FLASHES THEN GOES BLACK WHILE DRIVING. INTERIOR EXTERIOR AND GAUGE LIGHTS GO BRIGHT AND DIM AND GO OUT ALTOGETHER WHILE DRIVING. CAR DIES WHILE MOVING. BATTERIES ONLY LAST 1 YEAR FROM BEING DRAINED. NO ALTERNATOR ISSUE PER 3 DIFFERENT MECHANICS.

• 10/22/2011· ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROLCrash

  FORD FIVE HUNDRED STARTED LURCHING OR LUNGING WHEN PLACED IN GEAR. FROM A PARKED POSITION.. THE CAR LURCHED BACK INTO THE WALL OF THE CARPORT CRUSHING THE BACK BUMPER. ON ANOTHER OCCASION THE CAR LURCHED WHEN THE DOOR WAS OPEN AND KNOCKED INTO THE CARPORT POST. VERY DANGEROUS. *TR

• 10/20/2011· POWER TRAIN

  THE VEHICLE LUNGES WHEN SHIFT LEVER IS MOVED FROM PARK TO DRIVE OR REVERSE UPON STARTING. IT DOES NOT HAPPEN EVERYTIME, BUT WHEN IT DOES HAPPEN, IT IS A MARKED MOVE, ENOUGH TO GO THRU A GARAGE, JUMP A CURB OR HIT A PASSERBY. IT SEEMS TO HAPPEN MORE OFTEN WHEN THE CAR IS STARTED, AND THEN WAITING A FEW SECONDS BEFORE MOVING THE SHIFT (TIME TO PUT ON SEAT BELT). PUT YOUR FOOT ON BRAKE, SHIFT TO GEAR AND WONDER IF IT WILL JUMP OR NOT. IT BECAME NOTICABLE AT ABOUT 65,000 MILES AND HAS BECOME WORSE. THE CAR HAS ABOUT 76,000 MILES ON IT NOW. IT SEEMS OTHER FORD 500 OWNERS ARE EXPERIENCE SIMILAR PROBLEMS. I WOULD HOPE FORD DOES SOMETHING TO RECTIFY THIS ISSUE. *TR

• 10/18/2010· SUSPENSION

  CAR HAS DEVELOPED A NOISE IN FRONT END. A KNOCKING WHEN TURNING WHEEL AT SLOW SPEEDS. IT HAS A SUSPENSION PROBLEM I AM CONCERNED FOR OUR SAFETY. *TR

• 10/11/2019· EXTERIOR LIGHTING

  DRIVER SIDE HEADLIGHT SOCKET BURNS OUT THE BULB. THE BULB HAS BEEN REPLACED THREE TIMES IN THE PAST THREE MONTHS. THE ENTIRE LIGHT SOCKET UNIT NEEDS TO BE REPLACED. THE SERVICE TECH INFORMED ME THAT WAS A PROBLEM WITH THIS MODEL VEHICLE.

• 10/11/2012· VEHICLE SPEED CONTROLCrash

  TL* THE CONTACT OWNS A 2007 FORD FIVE HUNDRED. THE CONTACT STATED THAT WHILE IN REVERSE THE VEHICLE LUNGED BACKWARD AND CRASHED INTO A MAILBOX. THE FAILURE RECURRED CONSTANTLY WHEN THE VEHICLE WAS PLACED IN DRIVE OR REVERSE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSE THAT THERE WAS A FAILURE WITH THE TPS SENSOR WITHIN THE THROTTLE BODY. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.

• 10/04/2014· STEERING,POWER TRAIN,ELECTRICAL SYSTEM

  WHILE DRIVING DOWN THE STREET AT MIDNIGHT THE CAR WARNING LIGHTS STARTED TO COME ON (ABS, BATTERY, TRACTION CONTROL, AND FINALLY THE FACTORY STEREO/GPS UNIT) ONE BY ONE. THEN FOLLOWED BY THE DASHBOARD ILLUMINATION GOING OUT WHICH MEANS I NOW HAD NO TAILLIGHTS. THEN FINALLY LOST ALL ACCELERATION AND THE CAR JUST STOPPED. LUCKILY, I WAS ABLE TO ILLEGALLY PARK THE CAR BLOCKING A DRIVEWAY AND FIRE HYDRANT. HAD I BEEN ON THE HIGHWAY I MAY HAVE HAD A COMPLETELY DIFFERENT ENDING. A WEEK AFTER THE MECHANIC REPLACED THE ALTERNATOR THE ELECTRICAL SYSTEM SHUT DOWN AGAIN ONLY I GOT NO LIGHTS ON, IT JUST DIED. AFTER HAVING THE CAR FOR A WEEK MY MECHANIC REPLACED A FAULTY GROUND AND THE BATTERY. THE CAR STILL DOESN'T WORK PROPERLY. HE HAS NO IDEA WHY. *TR

• 10/04/2010· ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROLCrash

  I PURCHASED A FORD 500 07 IN MARCH OF 2010. PRIOR TO THE 60,000 MILE WARRANTY ENDING, I TOOK THE CAR BACK TWICE FOR A SURGING PROBLEM GOING FROM DRIVE/REVERSE. THE FIRST TIME THE SHOP COULD NOT FIND A PROBLEM. THE SECOND TIME THE SERVICE MGR. AND DAUGHTER DID A TEST DRIVE. RIGHT OFF THE BAT THE CAR SURGED. HE CALLED ME AND TOLD ME TO BRING THE CAR BACK ONE MORNING SO HE COULD KEEP IT ALL DAY. I COULD NOT DO THIS AT THE TIME, THIS IS MY ONLY MEANS OF TRANSPORTATION. ON 10/2/10 WHILE BACKING UP IN THE EMERGENCY LANE ON THE INTERSTATE. MY CAR ACCELERATED ON IT OWN, WHILE MOVING BACKWARDS. I HIT THE BRAKE THE ACCELERATOR WENT TO THE FLOOR. I LIFTED MY FOOT OFF THE BRAKE IT TOOK OFF AGAIN. THE RPM HAND WAS GOING CRAZY. I HAD NO CONTROL. THE CAR WENT INTO A SPIN, I ENDED UP IN THE DITCH WHILE HITTING ANOTHER CAR. LUCKILY WE ARE STILL ALIVE. *TR....UPDATED 08/08/16 *BF *TR

• 10/03/2007· FUEL SYSTEM, GASOLINE,STRUCTURE

  TL*THE CONTACT OWNS A 2007 FORD FIVE HUNDRED. DURING AN INSPECTION, THE CONTACT REALIZED THAT THE PLATE NUT WAS NOT PLACED DEEP ENOUGH INTO THE PANEL, WHICH PREVENTED THE FUEL FILLER NECK FROM BEING SECURELY FASTENED TO THE FENDER. THE DEALER STATED THAT THE FUEL FILLER NECK ADAPTER WAS NOT SECURELY ATTACHED. THE DEALER ATTEMPTED TO TIGHTEN THE BOLTS, HOWEVER, IT CREATED A LARGER GAP. THE CURRENT MILEAGE WAS 1,500 AND FAILURE MILEAGE WAS 500. THE CONSUMER STATED THERE IS A STILL A 1/8" GAP BETWEEN FUEL FILLER AND NECK ADAPTOR AND RIGHT REAR FENDER PANEL. THE DEALER STATED REAR MUFFLER HANGER HAS CORROSION. UPDATED 10/18/07 *TR

• 10/01/2010· FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL

  I OWN A FORD 500 2007. THE ENGINE SEEMS TO REV UP WITH OUT PRESSING THE GAS PEDAL. IF YOU ARE AT A STOP SIGN AND RELEASE THE BRAKE THE CAR WILL LUNGE FORWARD ON ITS OWN. I SPOKE TO A MECHANIC ABOUT THIS PROBLEM AND HE HAS ENCOUNTERED IT BEFORE WITH OTHER 500'S. HE TOLD ME ITS THE THROTTLE BODY. HE TOLD ME WHEN HE ORDERS THEM THEY ARE ON BACK ORDER. *TR

• 10/01/2009· AIR BAGSCrash

  SIDE/FRONT DRIVER IMPACT, GOING APPROXIMATELY 35 MPH, AND NO AIR BAGS DEPLOYED. THE CAR WAS DAMAGED TO THE POINT THAT THE INSURANCE COMPANY TOTALED THE CAR. THIS WAS NOT A MINOR ACCIDENT. *TR

• 09/30/2011· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2007 FORD FIVE HUNDRED. THE CONTACT STATED THAT THE ALTERNATOR WAS USING MOST OF THE VEHICLE POWER AND CAUSING THE BATTERY TO FAIL. THE CONTACT HAD TO PURCHASE TWO BATTERIES IN A ONE MONTH PERIOD AS A RESULT OF THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THEY COULD NOT REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 85,000.

• 09/30/2010· POWER TRAIN

  WE HAVE A 2007 FORD FIVE HUNDRED AND HAVE HAD ISSUES WITH THE THROTTLE BODY CAUSING A SURGE AND LUNGE WHEN WE PUT THE CAR FROM IDLE TO REVERSE OR DRIVE. THE CAR WILL LUNGE FORWARD SUDDENLY CAUSING SOME NEAR ACCIDENTS. ON TWO SEPARATE OCCASIONS WHEN THE TEMPERATURES ARE IN THE 90'S AND THE AC IS ON FULL BLAST THE CAR WILL SURGE AND LUNGE IN REVERSE AND THEN STALL. THE MECHANIC SAID IT WAS DO TO AN ISSUE WITH THE THROTTLE BODY AND THAT THERE HAVE BEEN MANY OTHER SIMILAR COMPLAINTS. I WAS THINKING THAT THERE SHOULD BE SOME SORT OF RECALL FOR THE THROTTLE BODY IN FORD FIVE HUNDREDS, BECAUSE THIS IS A MAJOR SAFETY ISSUE! *TR

• 09/28/2009· POWER TRAIN

  ENGINE IDLE SPEED IS EXCESSIVE AT INTERMITTENT INTERVALS WHILE TRANSMISSION IS IN REVERSE, CAUSES VEHICLE TO INADVERTENTLY ACCELERATE AT INAPPROPRIATE SPEEDS. LOCAL REPAIR SHOP SCANNED VEHICLES REPAIR CODES, DETERMINED IT TO BE A TRANSMISSION FAILURE. AUTHORIZED DEALERSHIP, SAID NOTHING WAS WRONG WITH THE VEHICLE AFTER THEY SCANNED IT. VEHICLE, WENT INTO A "CREEP MODE" IMMEDIATELY FOLLOWING ONE OF THE INSTANCES, BUT THE COMPUTER RESET ITSELF AFTER SEVERAL MINUTES.*TR

• 09/27/2007· AIR BAGS

  TL*THE CONTACT OWNS A 2007 FORD FIVE HUNDRED. THE STICKER ON THE WINDOW STATED THAT THE VEHICLE WAS EQUIPPED WITH SIDE CURTAIN AIR BAGS, HOWEVER, IT WAS NOT. THE DEALER WOULD NOT INSTALL THE AIR BAGS. THE FAILURE MILEAGE WAS 19,600 AND CURRENT MILEAGE WAS 20,000. EQ-10204261-4200. DATE RECEIVED 12/12/07. UPDATED 12/12/07 *TR

• 09/26/2011· FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL

  DEFECTIVE THROTTLE BODY CAUSING "LUNGING ISSUES" ALMOST HAD THREE ACCIDENTS, JUST FROM THE LUNGING. ONCE I LET OFF THE GAS PEDAL THE CAR WOULD TURN OFF, DEALER ADVISED THAT IT DUE TO A DEFECTIVE THROTTLE BODY THAT THEY WILL REPLACE COSTING ME $900. *TR

• 09/26/2010· ENGINE AND ENGINE COOLING

  AT LOW SPEEDS, USUALLY WHILE EASING INTO MY GARAGE, OR WHILE BACKING OUT, THE ENGINE OF MY 2007 FORD 500 SURGES CAUSING THE VEHICLE TO LURCH. I TOOK THE CAR TO MY DEALER WHO DIAGNOSED THE PROBLEM AS "INTERNAL FAILURE WITH THROTTLE BODY ASSEMBLY" AND RECOMMENDED REPLACEMENT FOR AN ESTIMATED COST OF MORE THAN $800. I PAID $97.20 TO HAVE THE PROBLEM IDENTIFIED. IT SEEMS THIS IS A BASIC SAFETY ISSUE THAT THE MANUFACTURER SHOULD FIX IF IT IS HAPPENING REGULARLY. I AM LOOKING FOR INFORMATION TO GO BACK TO THE DEALER AND ASK THAT THEY FIX IT WITHOUT CHARGE. *TR

• 09/25/2011· ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

  THIS CAR HAS LUNGED FORWARD AND BACKWARD ALMOST CAUSING SEVERAL ACCIDENTS. DEALERSHIP SAY THEY DON'T KNOW WHAT IS CAUSING IT. WARRANTY IS WORTHLESS. AIR CONDITIONER WENT OUT WHEN TEMP'S WERE OVER 105 DEGREES. OVER $1000 TO REPAIR. *TR

• 09/25/2011· POWER TRAIN,VEHICLE SPEED CONTROL

  CAR WILL "JUMP" WHEN SHIFTING INTO DRIVE OR REVERSE GEARS!! SOMETIMES THE CAR WONT IMMEDIATELY ACCELERATE WHEN APPLYING GAS. WAS TOLD MY MULTIPLE MECHANICS THAT I WAS THE THROTTLE BODY CONTROL CAUSING THIS BUT FORD WONT DO ANYTHING ABOUT THIS!! *TR

• 09/23/2010· VEHICLE SPEED CONTROL

  TL*THE CONTACT OWNS A 2007 FORD FIVE HUNDRED. WHILE THE VEHICLE WAS IN REVERSE OR DRIVE THE VEHICLE SUDDENLY ACCELERATED. HE HAD TO DEPRESS THE BRAKES VERY QUICKLY IN ORDER TO SLOW DOWN OR STOP THE VEHICLE. THE DEALER WAS CONTACTED AND STATED THAT THE THROTTLE BODY NEEDED TO BE REPLACED, BUT THE PARTS WERE ON BACK ORDER. THE MANUFACTURER WAS CONTACTED BUT THERE WASN'T A FAVORABLE RESPONSE. THE FAILURE MILEAGE WAS 65,360.

• 09/20/2012· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  THE VEHICLE SURGES/LUNGES FORWARD/BACKWARD WHEN GOING FROM PARK TO REVERSE/DRIVE WITHOUT ANY GAS BEING APPLIED. WHEN BRAKE IS APPLIED THE VEHICLE STILL DOESN'T STOP AND I HAVE NO CONTROL OF THE CAR WHEN IT HAPPENS. THE CAR MAINLY DOES IT WHEN THE AIR CONDITION IS ON, BUT WILL DO IT OTHER TIMES AS WELL. THE CAR HAS SHUT OFF TWICE WHILE DRIVING WITH THE WRENCH LIGHT APPEARING ON THE INSTRUMENT CLUSTER. WHEN I TRIED TO RESTART THE CAR IT SHUT OFF AGAIN. WHEN I TURNED THE AIR CONDITIONING OFF THE CAR STOPPED SHUTTING OFF. THIS IS VERY DANGEROUS AND SHOULD BE RECALLED BY FORD, BEFORE SOMEONE GETS SERIOUSLY HURT. I'M HAVING TO PAY OUT $800 FOR A PART THAT HAS BEEN REPORTED BY THOUSANDS OF OTHER FORD OWNERS. FORD NEEDS TO RECALL THIS PART. *TR

• 09/18/2011· FUEL SYSTEM, GASOLINE

  LAST YEAR I BEGAN NOTICING THAT THIS CAR UPON PUTTING IN GEAR TRYING TO EXIT MY GARAGE WOULD SURGE FORWARD OR BACKWARD, WHATEVER WAY I WAS POINTED ,ABRUPTLY. IT DOES NOT MATTER WHETHER I AM IN RESERVE OR DRIVE . I WOULD HAVE TO APPLY BRAKES TO STOP IT. SOMETIMES MORE THAN ONCE. THIS WOULD HAPPEN IF I WAS BACKING OUT OR DRIVING FORWARD. IT DID NOT GO AWAY AND IN FACT BECAME WORSE. IT FINALLY LUNGED BACKWARD AS WE WERE LEAVING A PARKING LOT AND THE ENGINE STOPPED. A WRETCH SYMBOL CAME ON. WE TOOK IT TO FORD. THEY REPLACED THROTTLE BODY PART. WAS FINE UNTIL THE LAST MONTH OR SO AND NOW IS WORSE. HAVE APPROX. 77 K MILES ON IT NOW. I HAVE SCHEDULED TO TAKE IT BACK TO FORD. I FEEL THIS IS DANGEROUS AS THIS SURGING AND LUNGING COULD RESULT IN SOMEONES INJURY. THERE IS OBVIOUSLY A DEFECT SOMEWHERE IN THIS PART. I HAVE NOTICED THROUGHOUT THE INTERNET THAT ARE MANY SUCH COMPLAINTS OF THIS SAME PROBLEM. *TT

• 09/17/2010· FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL

  THE THROTTLE BODY ON OUR 2007 FORD 500 STUCK CLOSED CAUSING ENGINE TO STALL. THE THROTTLE BODY HAD TO BE REPLACED. FORTUNATELY THIS HAPPENED ON A 2 LANE ROAD BUT MY WIFE HAD JUST GOT OFF A HIGH SPEED INTERSTATE HIGHWAY. FAILURE CAUSED RAPID DECELERATION OF THE VEHICLE LEAVING HER STRANDED IN THE TRAFFIC LANE. THIS WOULD PROBABLY HAVE RESULTED IN AN ACCIDENT IF THIS WOULD HAVE HAPPENED ON THE INTERSTATE. THE CAR HAS AROUND 37,000 MILES ON IT. *TR

• 09/17/2008· SERVICE BRAKES, HYDRAULIC

  2007 FORD FIVE HUNDRED WITH 35750 MILES DEALER STATES THE CAR NEEDS REAR BRAKES AND REAR ROTORS. THE REAR BRAKES PADS ARE SHOT AND THE ROTORS ARE GROOVED. DEALER STATES THIS IS NOT COVERED UNDER WARRANTY UNDER THE FORD CAMPAIGN OF 07N10. DEALER STATES THIS CAMPAIGN ISSUE EXISTED ONLY WITH FORD FIVE HUNDRED MANUFACTURED ON OR BEFORE NOVEMBER 28, 2006. OURS SUPPOSEDLY WAS BUILT FEBRUARY 2007. FORD STATES THIS PROBLEM WILL NOT EXIST ON ANY FORD FIVE HUNDRED'S MANUFACTURED AFTER THE DATE OF NOVEMBER 28,2006. *TR

• 09/16/2012· POWER TRAIN,ENGINE

  CAR ACCELERATES WHEN AIR CONDITIONING IS ON (MORE SO WHEN TURNING WHEEL) WHETHER IN DRIVE OR REVERSE. ALREADY HAD ACCIDENT IN REVERSE. NOTED SEVERAL COMPLAINS ABOUT THIS FROM OWNERS ON GOOGLE. ALMOST HAD ANOTHER ACCIDENT IN JACK IN THE BOX DRIVE THRU WHERE CAR ACCELERATED UNEXPECTEDLY. MISSED CAR IN FRONT OF ME BY INCHES. HAD FOOT ON BRAKE, CAR WAS IN DRIVE BUT NOT MOVING WHEN THIS HAPPEN. ACCELERATION OVER POWERED BRAKE PRESSURE. VERY, VERY SCARY. PLEASE HELP. OTHERWISE LOVE CAR. PLEASE CONTACT MY COUSIN. SEE BELOW. *TR

• 09/15/2010· POWER TRAIN,ELECTRICAL SYSTEM

  CAR: 2007 FORD 500 LIMITED. MOVING SHIFT LEVER FROM PARK TO REVERSE OR TO DRIVE, AFTER ABOUT 1 SECOND THE CAR "LURCHES" FORWARD OR BACKWARD. I KEEP THE BRAKE LOCKED DOWN WHEN CHANGING GEARS FOR SEVERAL SECONDS UNTIL I'M SURE IT WON'T JUMP.THIS IS DANGEROUS. WHEN THIS FIRST STARTED HAPPENING, I ALMOST RAN OVER SOMEONE IN A PARKING LOT AS I WANTED TO BACK OUT OF A PARKING SPOT. I TOOK THIS IN FOR SERVICE AND MENTIONED IT TO THE SERVICE MANAGER. AS HE DROVE THE CAR AROUND TO THE BACK, HE SAID HE NOTICED IT TOO AND ASKED THE TRANSMISSION MAN TO LOOK IT OVER. SINCE I WAS HAVING THE TRANSMISSION OIL CHANGED, HE THOUGHT IT MIGHT BE RELATED TO OLD FLUID. (CAR HAD ABOUT 70K MILES AT THE TIME). ITS ABOUT 5K MILES SINCE THE SERVICE AND THE CARIS AS BAD OR WORSE THAN IT HAS EVER BEEN. I BELIEVE THE PROBLEM IS RELATED TO THE COMPUTER GETTING A WRONG SIGNAL FROM ONE OF THE THROTTLE SENSORS AND CAUSING THE ENGINE TO SURGE. DEALER SAID HE HAD NOT SEEN THE PROBLEM BEFORE AND DIDN'T KNOW WHAT TO DO. THE PROBLEM IS STILL OCCURRING BUT SINCE ONLY MY WIFE AND I DRIVE THE CAR, WE ARE COMPENSATING BY HOLDING THE BRAKE FOR SEVERAL SECONDS AFTER MOVING THE SHIFT LEVER. I HOPE YOU CAN IDENTIFY THE PROBLEM AND LET ME KNOW OR HAVE FORD PUT OUT A SAFETY RECALL AND A FIX FOR THE PROBLEM. THANKS *TR