2006 Toyota Highlander

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/28/2020· POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  WHILE DRIVING MY VEHICLE ALL THE LIGHTS ON MY DASHBOARD ILLUMINATED. MY VEHICLE LOST POWER AND I HAD TO PULL OVER. IT DIED THERE. I WAS ON BELFIELD AVE AND GRATZ STREET IN PHILADELPHIA, PA . I SUBSEQUENTLY HAD IT TOWEDBACK TO MY RESIDENCE.

• 12/26/2025· SERVICE BRAKES

  Toyota’s part number 44050-48190 brake actuator assembly failed, as it has in other models and is very commonly doing in the Highlander model. It is triggering other warning lights issues in the vehicle. Vehicle safety is at risk. Many others have reported the same issue.

• 12/22/2014· AIR BAGSCrash

  I SWERVED TO AVOID A DEER AND HIT A CONCRETE ABUTMENT ON THE SIDE OF THE ROAD. THE TOYOTA HIGHLANDER WAS TOTALED .THE HIGHLANDER AIRBAG DID NOT WORK PROPERLY; I HIT THE STEERING WHEEL COLUMN VERY HARD AND RECEIVED A CONCUSSION. ALSO A DAMAGED DISK IN MY NECK, WHIPLASH, CHEST CONTUSIONS, AND FACIAL ABRASIONS. *TR

• 12/21/2024· SERVICE BRAKES

  Car is lunging forward while braking.I just had to put a new abs module and pump on the vehicle which was very expensive.Since I know there was a recall but I was not notified.Is there a way to get toyota to pay for the new pump and module ?

• 12/18/2012· SERVICE BRAKES

  TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKE AND ABS WARNING LIGHTS ILLUMINATED. THE CONTACT STOPPED THE VEHICLE AND SHUT THE ENGINE OFF. THE VEHICLE WAS ABLE TO BE RESTARTED BUT WOULD NOT SHIFT OUT OF PARK. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE BRAKE SWITCH WOULD HAVE TO BE REPLACED. AFTER THE BRAKE SWITCH WAS REPLACED, THE TECHNICIAN ADVISED THAT THE FAILURE CONTINUED AND WOULD HAVE TO DIAGNOSED A SECOND TIME. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 29,100.

• 12/17/2014· ENGINE

  DRIVING DOWN THE ROAD AT NORMAL SPEED, I NOTICED THE CAR OVERHEATING. THIS HAD NEVER HAPPENED. PULLING INTO A 70 YEAR OLD SERVICE CENTER IN CRANSTON, RHODE ISLAND, I LEFT THE CAR WITH RELIABLE SERVICE PEOPLE AND THEY CHECKED IT OUT. IT SEEMS THAT THE BOLTS HAD COME LOOSE FROM THE ENGINE AND FLUID WAS GOING INTO THE PISTONS,THEY REPORTED TO ME THAT THE THREADS IN THE ENGINE WERE FAULTY, I THINK THEY SAID ALUMINUM, AND THEY SHOULD HAVE BEEN METAL. I AM NOT MECHANICALLY INCLINED SO I DON'T UNDERSTAND THE WHOLE PROBLEM. THEY SAID THAT THE ENGINE HEAD WAS NOT SECURE AND THIS HAS HAPPENED TO OTHER TOYOTA ENGINES. ANYWAY, AT 70 YRS OLD, IT TOOK ALL THE MONEY I HAD TO REPAIR IT AND THEY INSISTED THAT I LOOK FOR A RECALL, BECAUSE THAT SHOULD HAVE NEVER HAPPENED. $1842.00 LATER, THE CAR IS RUNNING LIKE IT SHOULD NOW. IF TOYOTA DOESN'T TAKE CARE OF ME, I WILL SPEND THE REST OF MY LIFE SPREADING THE WORD. I WILL START AT THE RHODE ISLAND DEALERS, GO ON LINE AND CONTACT ALL THE PROPER AREAS. THIS SHOULD NOT HAVE HAPPENED TO MY TOYOTA.THIS IS THE CAR THAT THEY ADVERTISE WILL LAST 265000 MILES IF MAINTAINED PROPERLY. I BOUGHT THE CAR AT EARL STEWART TOYOTA IN LAKE PARK, FLORIDA. [XXX] TOLD ME HE WAS SORRY THAT THIS HAPPENED, TO REPORT IT TO TOYOTA. MY WIFE PASSED AWAY AND IT MOVED BACK TO MY HOME STATE IN RHODE ISLAND. THE CAR WAS MAINTAINED BY TOYOTA ALWAYS THRU MY WARRANTY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/14/2008· STEERING

  I TURNED ON THE CAR AND THE STEERING WHEEL LOCKED UP OR WAS NOT POWERSTEERING ANY LONGER AND FOR A 55 YEAR OLD WOMAN DRIVING THIS CAR IS IMPOSSIBLE. *TR

• 12/12/2011· ELECTRICAL SYSTEM,HYBRID PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. THE CONTACT STATED THAT THE LIGHTS ON THE INSTRUMENT PANEL REMAINED ILLUMINATED AND THE CONTACT WAS UNABLE TO START THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER BUT NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS NOT AVAILABLE. UPDATED 02/09/12*LJ THE DEALER REPLACED THE INVERTER ASSEMBLY. UPDATED 02/29/12

• 12/11/2008· FUEL SYSTEM, GASOLINE

  TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE SHOULD GET 35 MILES PER GALLON IN THE CITY; HOWEVER, IT ONLY GETS 21 MILES. HE CALLED THE DEALER AND WAS ADVISED TO CALL THE TOYOTA MANUFACTURER. THE MANUFACTURER STATED THAT THEY APPRECIATED HIS INPUT AND COMMENTS. THE CONTACT FEELS THAT A RECALL SHOULD BE ISSUED. THE FAILURE MILEAGE WAS 31,000.

• 12/10/2009· VISIBILITY

  TODAY MY REAR WINDOW ON DRIVER'S SIDE MALFUNCTIONED DUE TO THE CONNECTING TAB OUT OF ALIGNMENT. I DO NOT HAVE CHILDREN, I AM THE SOLE DRIVER OF THIS VEHICLE, SO EXPLAIN TO ME HOW A 3 YEAR OLD AUTO THAT IS NOT ABUSED,THAT ALL OF A SUDDEN I HAVE A BILL FOR $160.89 TO COGGIN TOYOTA AT THE AVENUES, JACKSONVILLE,FL. I AM RECENTLY WIDOWED, ON A FIXED INCOME AND IN THE PROCESS OF MOVING WITH ONE OF MY CHILDREN. LOVE THE CAR, DRIVES LIKE A DREAM, NO PREVIOUS MAJOR PROBLEMS. I WOULD APPRECIATE CONSIDERING SOME COMPENSATION REGARDING THIS BILL THAT COMES AT A VERY EMOTIONAL TIME OF MY LIFE. PLEASE CONSIDER MY REQUEST. *TR

• 12/07/2012· EXTERIOR LIGHTING

  DAY RUNNING LIGHTS ARE BURNING THROUGH THE LENSES OF BOTH HEADLIGHTS. THE LENSES HAVE LARGE WHITE SPOTS ON THE AREA IN FRONT OF THE RUNNING LIGHT BULBS. THE BULBS OF THE RUNNING LIGHTS ARE BULGING . THERE MAY BE A FIRE HAZARD. *TR

• 12/07/2010· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH WHEN THE BEGAN VEHICLE LOOSING POWER. THE HYBRID WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE THEN STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED AS A FAILURE IN THE BATTERY CELL. THE DEALER ADVISED THE CONTACT THAT THE INVERTER WOULD NEED TO BE REPLACED. THE CONTACT STATED THAT THE DEALER HAD REPLACED THE BATTERY A FEW MONTHS PRIOR TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ENGINEER INSPECTED THE VEHICLE AND ADVISED THAT THE TOWING COMPANY CAUSED MORE DAMAGED TO THE VEHICLE BATTERY WHILE ATTEMPTING TO GET THE VEHICLE STARTED. THE FAILURE AND THE CURRENT MILEAGE WAS 29,500.

• 12/04/2006· POWER TRAIN

  I PURCHASED A TOYOTA HIGHLANDER SPORT 4 MONTHS AGO. I BOUGHT THE V6 ENGINE. I BECAME CONCERNED ABOUT A HESITATION PROBLEM WHERE THE CAR HOLDS BACK WHEN STARTING FROM A STOP AND THEN LURCHES. THIS IS DANGEROUS AT STOP LIGHTS AND ENTERING FREEWAYS. THE TOYOTA DEALER SAYS THE CAR DOES THIS ON PURPOSE BUT THEY DON'T KNOW WHY. THIS SOUNDS LIKE AN EXCISE FOR A FLAW IN THE DESIGN. I CHECKED WWW.CARSURVEY.COM, WHICH LISTS CONSUMER COMPLAINTS AND FOUND MANY COMPLAINTS ABOUT THE EXACT SAME PROBLEM. THIS IS CLEARLY A SAFETY ISSUE THAT TOYOTA IS IGNORING!! PLEASE DO SOMETHING AND CHECK THE ABOVE SITE TO SEE MORE COMPLAINTS. THANK YOU GARY MACKMAN. *NM

• 12/03/2010· CHILD SEAT

  I AM WRITING TO REPORT A DEFECT IN THE BRITAX DECATHLON CAR SEAT LOWER LATCH SYSTEM. THE BELT ON MY SYSTEM IS TWISTED AND WILL NOT PERFORM PROPERLY IN A CRASH. I HAVE NOTIFIED BRITAX AND THEY SENT ME A REPLACEMENT BELT BUT WITHOUT ANY INSTRUCTIONS AND HAVE NOT ISSUED A RECALL. I AM CONCERNED ABOUT ALL THE OTHER CAR SEATS ON THE ROAD AND THE CHILDREN WHO ARE AT RISK OF SERIOUS INJURY. A REPRESENTATIVE FROM THE PA TRAFFIC INJURY PREVENTION PROJECT (TIPP) AT THE PA CHAPTER OF THE AMERICAN ACADEMY OF PEDIATRICS INSPECTED THE CAR SEAT ON TUESDAY OCTOBER 26, 2010 AND FOUND THAT ?THE LOWER ANCHOR ATTACHMENT IS BACKWARDS ON ONE SIDE AND CANNOT BE USED CORRECTLY TO INSTALL CHILD SEAT USING LOWER ANCHORS.? HER NAME IS [XXX] AND SHE CAN BE REACHED AT [XXX]. SHE SAID THAT IT WAS A MANUFACTURING DEFECT AND THE SEATS SHOULD BE RECALLED. THE IDENTIFIERS FOR THE CAR SEAT ARE: DATE OF MFG: 04-05-2007 MAKE DECATHLON MODEL E9L 4769 SERIAL NUMBER E9L4769017324 BATCH NUMBER J00088948 PURCHASED FROM BABYUNIVERSE.COM IN MAY 2007 MY CONTACT AT BRITAX IS [XXX] CONSUMER SERVICE MANAGERBRITAX [XXX] 13501 SOUTH RIDGE DRIVE CHARLOTTE NC 28273 US-CUSTOMERSERVICE@BRITAX.COM (RELATED VEHICLE INFORMATION: MODEL YEAR=2006, MAKE=TOYOTA, MODEL=HIGHLANDER). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 11/27/2009· VEHICLE SPEED CONTROLCrash

  I WAS IN A PARKING LOT, MADE A RIGHT TURN TO PULL INTO A PARKING SPACE. I SLOWED DOWN BUT IT SEEMED THE CAR ACCELERATED. IN A MATTER OF SECONDS, THE CAR WENT THROUGH A ROW OF BUSHES AND SLAMMED INTO A TREE. THE ENTIRE FRONT END OF THE CAR HAD TO BE REPLACED. *TR

• 11/24/2014· EXTERIOR LIGHTING

  I AM IN THE MILITARY AND HAD MY CAR IN STORAGE FROM 2008-2012 WHILE STATIONED OVERSEAS. I JUST TOOK MY CAR IN FOR THE 60,000 MILE SERVICE AND WAS TOLD MY HEADLIGHT COVER WAS FOGGY. WHEN I GOT HOME AFTER PICKING UP MY CAR I HAD NOTICED THERE WHERE TWO BURN MARKS THAT HAD MELTED THE PLASTIC HEADLIGHT COVERS WHERE THE HIGH-BEAM LIGHTS ARE. I HAD CALLED TOYOTA HEADQUARTERS AND THEY REFERRED ME TO THE HAWAII DEALERSHIP SINCE THEY COULD NOT LOCATE MY VIN NUMBER. I CALLED THE HAWAII DEALERSHIP, AND HAD NO LUCK THERE EITHER. THIS IS UNSAT AND IS A CONTINUOUS PROBLEM FOR THIS YEAR OF TOYOTA HIGHLANDER. THIS IS A SAFETY ISSUE AND A HAZARD. I DO NOT KEEP MY HEADLIGHTS ON 24 HOURS SEVEN DAYS A WEEK, SO WHY IS THIS HAPPENING. IN ADDITION, MY CAR ONLY HAS 66,600 MILES FOR BEING A 2006 MODEL. AS I SAID THIS CAR WAS IN STORAGE FOR 4.5 YEARS DUE TO MY OVERSEAS DUTY ASSIGNMENT. I FEEL THAT I SHOULD NOT HAVE TO PAY FOR THIS SINCE I HAVE NO CONTROL OF THIS AND, IT IS A DEFECT IN THE MODEL / YEAR OF THE HIGHLANDER. *TR

• 11/23/2020· UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

  AFTER BEING DRIVEN OR IDLING FOR AWHILE, THE CAR STARTS CUTTING OUT. IT ACTS LIKE IT ISN'T GETTING GAS. I HAVE TO PUMP THE ACCELERATOR OR PUSH IT TO THE FLOOR. HILLS ESPECIALLY CAUSE IT TO STALL. IT WAS SO BAD, I HAD IT TOWED. THE SCAN SHOWED A OXYGEN SENSOR PROBLEM. HAD THAT REPLACED. IT DROVE OK FOR AWHILE. IT HAS RESUMED THE STALLING. WHEN I READ THE RECALL, IT SOUNDED LIKE MY CAR WOULD BE INCLUDED. THE VIN # SHOWS IT NOT BEING ON THE LIST. PLEASE VERIFY BECAUSE IT CUTS OUT, ACTING LIKE IT ISN'T GETTING FUEL. THE AREA I WAS IN WAS A COUNTRY ROAD WITH NO SHOULDERS TO PULL OFF ON. IT ALSO HAPPENED ON A 4 LANE HIGHWAY. IF IT IS NOT A RECALL, ANY SUGGESTION WILL BE APPRECIATED. THE EXACT DAYS IN SEPTEMBER ARE AN EDUCATED GUESS. THANK YOU.

• 11/23/2011· ENGINE AND ENGINE COOLING

  MY SON WAS DRIVING OUR 2006 TOYOTA HIGHLANDER. HE DROVE APPROX 2 MILES FROM OUR HOUSE AT AN AVERAGE SPEED OF 35 MPH WHEN THE TEMPERATURE GAUGE SUDDENLY WENT PAST THE RED LINE. HE DROVE OUR CAR APPROX 2 MILES BACK TO OUR HOUSE. WE THEN HAD IT TOWED TO SAVANNAH TOYOTA WHERE THEY CHECKED THE ENGINE AND FOUND THE HEAD WARPED AND THE BOLTS STRIPPED . I WENT TO SAVANNAH TOYOTA AND TOLD THEM THAT I HAD JUST HAD THE CAR THERE FOR AN OIL CHANGE A MONTH PRIOR. AT THE TIME OF OIL CHANGE, SERVICE WRITER NOTED UNDER THE HOOD THAT HE THOUGHT THAT MAYBE THE WATER PUMP MAY BE LEAKING AS THERE WAS FLUID ON THE UPPER PART OF HOOD. THERE WAS NO NOTIFICATION OF ANY PROBLEM WITH THE WATER PUMP. A MONTH LATER, THE ABOVE OVERHEAT CONDITION OCCURRED. WHEN WE WERE INFORMED THAT THE ENGINE WAS BURNED UP AND THE ENGINE NEEDED TO BE REPLACED AT A COST OF 5000.00. WE HAD THE VEHICLE TOWED TO OUR REGULAR MECHANIC AND WAS TOLD THAT THERE WAS NOTHING WRONG WITH THE ENGINE BLOCK, JUST THE HEAD NEEDS TO BE REPLACED AT A COST OF APPROX. 2200.00.SAVANNAH TOYOTA DID CHARGE US $600 TO CHECK WHAT CAUSED THE PROBLEM AND IF THE ENGINE COULD BE SAVED. WE WERE TOLD THAT THE ENGINE BLOCK BOLTS WERE STRIPPED AND COULD NOT BE RE-INSTALLED. AFTER DIS-ASSEMBLING THE ENGINE TO EVALUATE THE PROBLEM THEY DID NOT EVEN REASSEMBLE OUR ENGINE. THE CAR WAS NO LONGER UNDER WARRANTY AT 70,000 MILES. WE HAVE NOT YET REPAIRED THE PROBLEM CAR HAS BEEN PARKED SINCE 3-20-11 TO DATE 11-22-2011 . *TR

• 11/23/2010· ELECTRICAL SYSTEM

  TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH THE VEHICLE COMPLETELY STALLED AND COASTED UNTIL IT STOPPED. THE VEHICLE WAS TOWED TO A DEALER WHO INSPECTED THE VEHICLE AND INFORMED THE CONTACT THAT THERE WAS AN INVERTER FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000. UPDATED 02/08/11*LJ UPDATED 11/30/2011 *LN

• 11/20/2015· STEERING

  TL* THE CONTACT OWNS A 2005 TOYOTA HIGHLANDER. WHILE MAKING A RIGHT TURN AT APPROXIMATELY 5 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER AND THE INSTRUMENT PANEL ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 142,085. UPDATED 04/06/16*LJ,UPDATED 4/25/18*JB *TR

• 11/20/2006· LATCHES/LOCKS/LINKAGES,EQUIPMENT

  DT*: THE CONTACT STATED THE KEY FOB ONLY WORKED INTERMITTENTLY TO OPEN THE DRIVER DOOR. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO WAS UNABLE TO DUPLICATE THE PROBLEM. THE VEHICLE WAS THEN TAKEN TO A SECOND SERVICE DEALER, WHO STATED THAT THE KEY FOB WAS RECEIVING INTERFERENCE FROM THE SURROUNDING ENVIRONMENT. THE MANUFACTURER WAS ALSO NOTIFIED. UPDATED 12/15/06. *JB

• 11/19/2019· SERVICE BRAKES

  I PURCHASED THIS VEHICLE FROM A PRIVATE USED CAR LOT. THEY TOLD ME ALL SERVICE WAS COMPLETED THROUGH TOYOTA SO I HAD FAITH IN TOYOTA REPAIRING ANY PROBLEMS, WITHIN THE FIRST YEAR THE ABS SYSTEM STARTED MAKEING STRAINGE NOICES AND THE BREAKS WERE NOT VERY EFFEECTIVE, I HAVE NO CHOICE BUT TO CONTINUE DRIVING SINCE THIS IS MY FAMILY PRIMARY VEHICLE AS A RETIRED DISABLE VET, I CALLED TOYOTA AND THEY TOLD ME TOO BAD THAT THE PREVIOUS OWNER COULD OF HAD THE EXTENDED WARENTIY BUT THEY DIDNT DO IT, NOW IM STUCK DRIVING A DANGERIOUS VEHICLE WITH MY FAMILY WHICH INCLUDES 2 BOYS THAT ARE SPECIAL NEEDS AND MYSELF A 100% DISABLED VET. NOT HAPPY WITH TOYOTA.

• 11/16/2021· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  While normally driving on the highway and without no warning the vehicle the power steering stops working , it just dies with no power and dash lights warning start to flash and Check Hybrid System turns on. I am not a mechanic nor a technician . The mechanic disconnected the ground cable after waiting about 5 minutes and it resets the system. He told me that it has something that may be caused by some electrical problem . He thinks that it has to do with a recall about some soldering electrical part in the inverter control. This has happened in 3 more occasion and I've been lucky and i have time to let it go to side of the road and i disconnect the ground wire for 5 minutes and connect it back and it resets and then starts to work normal. Since the vehicle stalls completely i fear that this could cause an accident or lost of life due to other vehicles coming behind at high speeds . Please i need help!

• 11/15/2012· VISIBILITY

  THE WEBASTO SUNROOF HAD A SAFETY RECALL THAT I DIDN'T RESPOND TO IN TIME. THE SERIAL NUMBER IS 6256887. THE FORM SAID IF I WAITED TO LONG I WOULD NEED TO FILE A CLAIM...I SHOULD HAVE PAID MORE ATTENTION TO THE FINE PRINT! *TR

• 11/15/2010· SERVICE BRAKES, HYDRAULIC

  TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THERE WAS NO HYDRAULIC PRESSURE ON THE BRAKE PEDAL AND THE PEDAL TRAVELED TOO FAR INTO THE FLOORBOARD WHEN DEPRESSED. THE CONTACT BELIEVED THAT THERE WAS EITHER AIR IN THE BRAKING SYSTEM OR A DEFECTIVE MASTER CYLINDER. THE PROBLEM WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE BRAKES WERE BLED TWICE BUT THE FAILURE CONTINUED. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED HIM TO TAKE THE VEHICLE TO THE DEALER BUT OFFERED NO FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 150 AND THE CURRENT MILEAGE WAS APPROXIMATELY 35,000.

• 11/14/2012· VISIBILITY/WIPER

  TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE DRIVER SIDE WINDOW MADE NOISE WHENEVER IT WAS THE ROLLED UP OR DOWN. THE VEHICLE WAS INSPECTED BY THE DEALER WHO DIAGNOSE THAT THE MASTER WINDOW SWITCH HAD FAILED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 65,000.

• 11/13/2011· VISIBILITY

  THE DRIVER SUN VISOR WILL NOT STAY UP AND FALLS DOWN OBSTRUCTING MY VIEW WHILE DRIVING. WHILE DOING RESEARCH ON THE INTERNET THERE SEEMS TO BE A LARGE NUMBER OF COMPLAINTS OF THIS SAME DEFAULT OF TOYOTA HIGHLANDERS SUN VISORS FALLING DOWNING AND NOT REMAINING SEATED IN THE UPRIGHT POSITION. THERE IS NOT ANY GARAGE DOOR OPENERS OR ANY OTHER DEVICES ON THE VISOR TO CAUSE EXTRA HEAVINESS THAT WOULD LEAD TO THE FAILING OF THE VISOR. I HAVE TO PUT TAPE ON THE VISOR TO PROVIDE MYSELF WITH AN UNOBSTRUCTED VIEW TO SAFELY DRIVE. *TR

• 11/10/2011· STEERING,SUSPENSION,WHEELS

  I BROUGHT 2006-1007 HIGHLANDER HYBRID VEHICLE IN 2005 FROM THE BEGINNING I AM HAVING DIFFICULTIES WITH THE STEERING I TOLD DEALER MULTIPLE TIMES, TOYOTA COMPANY MULTIPLE TIMES ABOUT THE STEERING PROBLEM. AS SOON AS I DRIVE ABOVE 25 MPH MY CAR PULLS TOWARDS RIGHT VERY BADLY I HAVE TO APPLY LOT OF PRESSURE ON THE STEERING TO PUT ON THE ROAD. DUE TO THIS I SPENT 1000S OF DOLLARS TO DO WHEEL ALIGNMENT AND STEERING CHECK DUE TO THIS I SPENT 1000S OF DOLLARS ON MY TIRES I HAVE TO CHANGE MY TIRES EVERY TWO YEARS EVEN THOUGH THE MANUFACTURER GIVES WARRANTY FOR 6 YEARS 65K MILES. *TR

• 11/08/2011· EXTERIOR LIGHTINGFire

  TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. THE CONTACT STATED THAT THE HEADLIGHT BECAME EXCESSIVELY HOT AND MELTED THE COVER. THE DEALER NOTIFIED THE MANUFACTURER AND THE MANUFACTURER AGREED TO COVER THE COST OF THE PARTS NEEDED FOR REPAIRS BUT NOT THE LABOR COSTS. NO REPAIRS WERE PERFORMED. THE CURRENT AND THE FAILURE MILEAGES WERE 86,900.

• 11/04/2021· SERVICE BRAKESCrash

  I was driving the car then as I hit the brakes it felt like they were not engaging until I applied more pressure. Then as I was almost home the abs and traction control lights came on. Took it to a specialist and they said that the abs module would have to be replaced. There are tons of people apparently with my same year and model with the same concern

• 11/04/2017· UNKNOWN OR OTHER,VISIBILITY/WIPER

  THE DRIVERS SIDE SUN VISOR FALLS DOWN WHETHER IN MOTION OR STOPPED, IT CAUSES A BLOCKED VISION WHICH CAN CAUSE COLLISIONS.

• 11/03/2014· SERVICE BRAKES

  TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD AN ABNORMAL NOISE WHEN DEPRESSING THE BRAKE PEDAL AND THE BRAKES FAILED TO RESPOND. THE VEHICLE WAS SHIFTED INTO NEUTRAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO DEALER WHO DIAGNOSED THAT THE HYBRID WAS CALIBRATING AND WAS PERFORMING NORMALLY. IN ADDITION, THE CONTACT STATED THAT THE VSC AND ABS WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO DIAGNOSED THAT THE ACTUATOR AND THE HYBRID PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

• 11/02/2014· ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  OUR 2006 TOYOTA HIGHLANDER HYBRID WOULD NOT START ON SEVERAL OCCASIONS. THE CAR HAD BEEN RUNNING FOR SOME TIME , TURNED OFF FOR 5 MINUTES AND THEN IT WOULD NOT RESTART. AFTER SITTING FOR A FEW HOURS IT RESTARTED. SOME TIMES IT HAD TO BE JUMPED AND THE CODE READ "SHIFT TO PARK" EVEN THOUGH IT WAS ALREADY IN PARK. I TOOK IT IN AND EVERYTHING CHECKED OUT AND OF COURSE THEY SAID THAT THEY NEVER HEARD OF THIS HAPPENING BEFORE. *TR

• 10/30/2007· VEHICLE SPEED CONTROL

  I ACCELERATED TO AVOID A COLLISION AT LOW SPEED IN AN INTERSECTION. THE CAR HESITATED ABOUT 2 SECONDS AFTER I PRESSED THE GAS PEDAL, THEN LURCHED FORWARD, SPINNING THE DRIVE WHEELS. THE LENGTH OF DELAY OR HESITATION IN RESPONSE TO ACCELERATOR INPUT IS FREQUENTLY THERE, BUT IS SOMEWHAT UNPREDICTABLE, MAKING STOP-AND-GO TRAFFIC PERFORMANCE DANGEROUS. POOR PERFORMANCE OF THE CRUISE CONTROL FUNCTION IS PROBABLY RELATED TO THIS DEFECT. THE CAR WAS RETURNED TO THE DEALER FOR SERVICE AT 1500 MILES. THE DEALER DID A THOROUGH CHECK OF THE EQUIPMENT AND FOUND NO DEFECTIVE PARTS. DEALER STATES THAT THERE ARE NO SERVICE BULLETINS FOR THIS PROBLEM, IN SPITE OF THE FACT THAT TOYOTA HAS ACKNOWLEDGED THIS PROBLEM AND PROMISED TO FIX IT SINCE DECEMBER 2004. THIS IS A SERIOUS PROBLEM. HAD THE PAVEMENT BEEN WET, I COULD HAVE LOST CONTROL OF THE VEHICLE. FORTUNATELY, IN THE INCIDENT DESCRIBED, THE OTHER DRIVER WAS ABLE TO AVOID A COLLISION. NEXT TIME, I MIGHT NOT BE SO LUCKY. *TR

• 10/24/2014· POWER TRAIN

  DRIVING ON THE HIGHWAY, CAR BROKE DOWN AND STOPPED FUNCTIONING. TOOK THE VEHICLE TO THE DEALERSHIP AND WAS CHARGED $4259.81 TO REPLACE TRANSFER CASE. AFTER SOME INVESTIGATING, I DISCOVERED THAT TOYOTA HAD ISSUED A TSB (TC008-07) TO REPLACE THE RIGHT-HAND BEARING SEAL THAT WOULD HAVE PREVENTED THIS. MY CAR WAS IN SERVICE AT THE DEALERSHIP MULTIPLE TIMES PRIOR WHILE UNDER WARRANTY, AND THEY COULD HAVE PREVENTED THIS BY REPLACING THE SEAL. *TR

• 10/24/2012· AIR BAGS

  TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE SITTING IN THE FRONT PASSENGER SEAT, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE COMPUTER HAD DETERMINED THAT THE VEHICLE WAS INVOLVED IN A CRASH. THE DEALER RESET THE AIR BAG AND THE WARNING LIGHT WAS NO LONGER ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES LATER. THE DEALER REPLACED THE ELECTRONIC CONTROL UNIT BUT TO NO AVAIL. THE DEALER ALSO STATED THAT THERE WAS WEIGHT LIMIT ON THE SEAT THAT CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND CONFIRMED THAT THE VEHICLE WAS PERFORMING AS DESIGNED. THE FAILURE MILEAGE WAS 70,000.

• 10/24/2007· STEERING,POWER TRAIN

  LAST SUNDAY, OCTOBER 14, 2007, I WAS DRIVING MY 2006 HIGHLANDER HYBRID AT HORMIGUEROS, PR (ZIP CODE 00660), WHEN SUDDENLY THE VEHICLE'S STEERING GOT REALLY STIFF. IT ALL HAPPENED AT A CRUISING SPEED OF 40-45 MILES PER HOUR WHEN SUDDENLY THE VEHICLE'S TURNING WHEEL GOT HARD AND IT GOT REALLY DIFFICULT TO CONTROL. I SURELY GOT THE SCARE OF MY LIFE. I EXPERIENCED SOME DIFFICULTIES WHILE TRYING TO STOP THE VEHICLE AND PARK IT IN A SAFE PLACE. THE VEHICLE'S CONTROL PANEL INDICATED THE FOLLOWING MESSAGE: VERIFY THE HYBRID SYSTEM. WE TOOK IT THE SAME DAY TO THE NEAREST DEALER (THE ONE THAT I ALSO BOUGHT THE VEHICLE) TOYOTA DEL OESTE, LOCATED AT HORMIGUEROS, PR (00660). MY VEHICLE HAS RECEIVED EVERY SERVICE RECOMENDED BY TOYOTA SINCE I BOUGHT IT. IN OCTOBER 19, 2007 TOYOTA DEL OESTE GAVE ME A QUOTE (NUMBER PQ2105) FOR $5,957.45 FOR THE REPAIRING COSTS OF MY VEHICLE. THE QUOTE SPECIFIED A TRANSAXLE ASSY FOR $4867.71, PLUS $700 FOR 14 LABOR HOURS AND A LOCAL TAX OF $389.74. THE DEALER INDICATED THAT ONCE THE TRANSAXLE WAS REPLACED IT WILL HAVE ONE YEAR ONLY WARRANTY. THEY ALSO INDICATED THAT THE TRANSAXLE ASSY WAS NOT PART OF THE HYBRID SYSTEM SO THE WARRANTY CAN NOT COVER THE REPAIR COSTS (MY VEHICLE HAD APROX. 66,000 MILES. ACCORDING TO TOYOTA, WARRANTY FOR HYBRID COMPONENTS IS 8 YEARS / 80,000 MILES). MY CONCERNS: 1) HOW I, AS A CONSUMER, MAKE SURE THAT TOYOTA IS NOT MAKING ME PAY FOR A DEFECT THAT MY VEHICLE MAY HAVE FROM THE FACTORY? 2) HOW I AM GOING TO BE SURE THAT IF THEY REPLACE THE TRANSAXLE ASSY I WILL NOT BE EXPOSED AGAIN TO AN UNSAFE SITUATION RELATED WITH A SIMILAR PROBLEM (REMEMBER THAT A LARGE PERCENTAGE OF ROADS ACROSS THE ISLAND OF PUERTO RICO ARE BUILT OVER MOUNTAINS). 3) HOW DO I REALLY MAKE SURE THAT THE DEALER IS TRULY MAKING ME PAY FOR A COMPONENT THAT IS NOT PART OF THE HYBRID SYSTEM AND CAN NOT BE COVERED BY THE WARRANTY (REMEMBER THAT, ALTHOUGH OTHER MANUFACTURERS MAYBE AVAILABLE, HYBRID TECHNOLOGY IN PUERTO RICO IS DOMINATED BY TOYOTA. *TR

• 10/23/2014· AIR BAGS

  WE HEARD ON THE NEWS THAT THERE IS A RECALL ON AIR BAGS ON DIFFERENT MAKE CARS, AND TOYOTA WAS ON THE LIST. THIS WAS ON NEWS OCTOBER 22,2014. THE AIR BAG WAS CALLED TAECOTA, OR TAYCOTA. *TR

• 10/23/2008· POWER TRAIN,TIRES

  I HAVE A 2006 TOYOTA HIGHLANDER HYBRID. IT HAS THE FOUR WHEEL DRIVE "I"SYSTEM. ANY TIME THE VEHICLE SENSES SLIPPING IN THE TIRES IT CUTS POWER TO ALL WHEELS. I HAVE BEEN STUCK IN VERY MANAGEABLE CONDITIONS. NOT ONLY DO YOU NOT GET 4 WHEEL DRIVE TO HELP OUT OF ADVERSE CONDITIONS, YOU GET NO DRIVE TO ANY WHEELS AND ARE LEFT STUCK. I SPOKE WITH TOYOTA AND THEY SAID THAT THE VEHICLE IS DESIGNED TO DO THIS TO PREVENT DAMAGE TO THE HYBRID SYSTEM. THERE IS NO INFORMATION IN ANY OF THE LITERATURE PROVIDED WHEN PURCHASING A VEHICLE. THIS VEHICLE SHOULD NOT BE SOLD TO ANYONE WHO DRIVES IN SNOW OR ON ANY THING OTHER THAN AN IMPROVED ROAD. TOYOTA ACKNOWLEDGED THAT THEY HAVE RECEIVED OTHER COMPLAINTS REGARDING THIS ISSUE BUT WILL NOT CORRECT IT, NOR INFORM BUYERS ABOUT IT'S DESIGN. THIS WILL UNDOUBTEDLY STRAND DRIVERS IN ADVERSE CONDITIONS THEY DEEM MANAGEABLE. *TR

• 10/22/2010· ENGINE AND ENGINE COOLING

  TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. THE CONTACT STATED THAT SINCE THE VEHICLE WAS PURCHASED IT HAS STALLED WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE DIAGNOSTIC TEST DID NOT DETERMINE WHAT CAUSED THE FAILURE TO OCCUR; HOWEVER, THE COOLING PUMP WAS REPLACED. THE REPAIR DID NOT CORRECT THE FAILURE. ON OCTOBER 14, 2010, WHILE DRIVING 65 MPH THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE INVERTER COOLING SYSTEM FAILED. THE DEALER STATED THAT THE WARRANTY HAD EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER FILED REPORT 1010191147 AND ADVISED THE CONTACT THAT THEY WOULD CALL HER. THE FAILURE MILEAGE WAS 59,000 AND THE CURRENT MILEAGE WAS 108,000.

• 10/21/2010· ENGINE AND ENGINE COOLING

  I WENT THROUGH A TOLL BOOTH, CAR BEGAN TO LURCH, LIGHTS ALL WENT UP, AND THE CAR STALLED, HIGHLY DANGEROUS, BUT MANAGED TO GET TO SIDE OF ROAD, APPARENTLY THE INVERTER IN MY 2006 TOYOTA HIGHLANDER, 102,000 MILES ON IT, WAS DEFECTIVE, IT WAS REPLACED FREE, BUT HAD TO PAY LABOR AND FOR RENTAL.. BUT I REALLY COULD HAVE BEEN INJURED SEVERELY. *TR

• 10/20/2010· SERVICE BRAKES, HYDRAULIC

  S10 DIRECT REPLY - COURTESY COPY SENT TO THE SECRETARY SENT FROM RE THE PROBLEMS EXPERIENCED WITH HIS 2006 TOYOTA HIGHLANDER. *KB THE CONSUMER STATED AFTER HE HIT A BUMP OR JUST TO SLOW DOWN, IT FELT AS THOUGH THE BRAKES WERE NO LONGER WORKING. IN ADDITION, HE EXPERIENCED AN EXTRAORDINARY NOISE FROM THE FRONT BRAKES WHENEVER THE BRAKE PEDAL WAS DEPRESSED. THE CONSUMER WAS TOLD IT WAS A TYPICAL SOUND FROM THE BRAKES FOR HIS MODEL/YEAR VEHICLE. *JB UPDATED 11/12/10.*JB

• 10/19/2023· SERVICE BRAKES

  Over 2 year ago our 2006 Highlander Hybrid began making a series of noises when depressing the brake pedal when in park and in motion. Dashboard screen are showing Check ABS, Check VSC System, Check Brake System and Brake Malfunction, and Errors. The noise would get louder and last longer and took longer distance to slow or stop. The shop asked for over $3000 that I don't have to fix so I drive it less and less. Please help if possible.

• 10/17/2012· VISIBILITY

  THE SUN VISOR ON THE PASSENGER SIDE WILL NOT STAY UP. IT JUST KEEPS COMING DOWN AND THIS CAN BE DANGEROUS WHILE DRIVING. I'VE HAD 5 DIFFERENT TOYOTAS AND NEVER HAD THIS PROBLEM BEFORE. *TR

• 10/17/2012· EXTERIOR LIGHTING

  OVERHEATING OF DRL/HIGH BEAM HEADLAMP BULBS, CAUSING MELTING/ DISTORTION OF CLEAR HEADLAMP HOUSINGS AND OPAQUE WHITE AREAS TO FORM IN HOUSINGS DIRECTLY IN FRONT OF INBOARD BULBS. THE INVOLVED BULBS ARE ALSO OBSERVED TO BE DEFORMED AND BULGING. FIRST NOTED AT 65K MILES. THIS ISSUE IS SEEN TO BE COMMONLY REPORTED FOR HIGHLANDER 2001-2007, AND THUS REPRESENTS A CONSISTENT DESIGN DEFECT AND POSSIBLE FIRE HAZARD. TOYOTA DEALERSHIP IS NOW DETERMINING WHETHER TOYOTA WILL COVER REPAIR OF THIS DESIGN DEFECT UNDER OUR COMPREHENSIVE EXTENDED WARRANTY. *TR

• 10/15/2005· STEERING,ELECTRONIC STABILITY CONTROL,ENGINE AND ENGINE COOLING

  TOYOTA HIGHLANDER HYBRID-I HAVE LOST ABS BRAKES, STABILITY CONTROL AND POWER STEERING ALONG WITH THE HYBRID ENGINE ON TWO OCCASIONS WITH MY 2 WEEK OLD 2006 HIGHLANDER. I HAVE BROUGHT IT TO THE DEALER TWICE-THE FIRST TIME THEY FOUND "MALFUNCTION CODES" AND "REBOOTED" THE COMPUTER AND TOLD ME IT WAS OPERATING AS "DESIGNED," ONLY TO HAPPEN AGAIN 2 DAYS LATER. CURRENTLY, THEY ARE REPLACING A COMPUTER. DATE OF INCIDENT AND PURCHASE OF VEHICLE IS ACTUALLY 2006 BUT IS NOT AN OPTION BELOW. I AM CONCERNED IT WILL HAPPEN AGAIN AND RESULT IN AN ACCIDENT IN THE FUTURE. *JB

• 10/13/2015· ENGINE

  DRIVING CAR AND IT STALLED THEN MESAGE CAME ON WHICH STATED CHECK HYBRID ENGINE. TOOK IT TO SHOP AND WAS TOLD WOULD COST $9,000 AS IT WAS THE INVERTER. THEY SAID MY VIN WAS NOT ON THE RECALL LIST FOR THE RECALL OF 2006 HIGHLANDER HYBRIDS. HAD THE POWER MODULE REPLACED AS RECALL IN 2012 BUT WHY WASNT MY CAR ON RECALL LIST FOR THE INVERTER?

• 10/13/2006· AIR BAGSCrash

  DT*: THE CONTACT STATED WHILE DRIVING 20 MPH ON RAINY, WET AND SLIPPERY CONDITIONS, AN APPROACHING VEHICLE STRUCK THE CONTACT'S VEHICLE ON THE PASSENGER SIDE. THE CONTACT'S VEHICLE SPUN AND WAS THROWN ONTO THE CURB. THE CONTACT LOST CONSCIOUSNESS FOR A SHORT PERIOD OF TIME. A SEATBELT WAS WORN AND NONE OF THE 6 AIRBAGS DEPLOYED. THERE WAS NO WARNING SIGNALS PRIOR TO THE INCIDENT. THE VEHICLE WAS PARTIALLY WRECKED ON THE PASSENGER SIDE, AND A POLICE REPORT WAS TAKEN. THE MANUFACTURER WAS NOTIFIED AND PROMISED A CALL BACK WITHIN 2 BUSINESS DAYS. THE CONSUMER WAS TOLD BY TOYOTA THAT THE FORCE WAS NOT STRONG ENOUGH FOR THE AIRBAGS TO DEPLOY. UPDATED 10/30/06. *JB

• 10/12/2010· ENGINE AND ENGINE COOLING

  TL*THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID (NA). WHILE THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH ATTEMPTING TO MAKE A LEFT TURN, THERE WAS A COMPLETE LOSS OF THE ENGINE POWER. THE VEHICLE WAS COASTED SAFELY TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A DEALER FOR DIAGNOSIS. THE TECHNICIAN INFORMED THAT THE FAILURE WAS ATTRIBUTED TO THE POWER INVERTER. THE VEHICLE WAS NOT REPAIRED. THE CONTACT EXPRESSED CONCERN OF THE POTENTIAL SAFETY HAZARD. THE FAILURE MILEAGE WAS 101,128.

• 10/09/2018· VEHICLE SPEED CONTROL,SERVICE BRAKESCrash

  TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER. WHILE MAKING A TURN AT 5 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE ACCELERATED AT AN UNKNOWN SPEED. AS A RESULT, THE VEHICLE STRUCK A PEDESTRIAN. A POLICE REPORT WAS FILED. THE PEDESTRIAN SUFFERED INJURIES AND MEDICAL ATTENTION WAS REQUIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN. *JS