2006 Hyundai Sonata

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2023· SUSPENSION

  Rear lower control arm snapped

• 12/31/2009· SEAT BELTS

  TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. AFTER STARTING THE IGNITION THE "AIR BAG" WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE FRONT DRIVER-SIDE SEAT BELT WAS REPLACED FOR THE MALFUNCTION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON TWO SEPARATE OCCASIONS FOR IDENTICAL FAILURES, AND THE FRONT PASSENGER SEAT BELT ASSEMBLY WAS REPLACED. NONE OF THE REPAIRS HAVE REMEDIED THE FAILURE. THE FAILURE MILEAGE WAS 79,000.

• 12/30/2017· SUSPENSION

  TAKATA RECALL

• 12/30/2015· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  THE PARKING LIGHTS WILL AUTOMATICALLY COME ON BY ITSELF WHEN THE CAR IS OFF AND THERE'S NO KEY IN THE IGNITION. I HAVE RETURNED TO MY CAR FROM WORK AND THE LIGHTS WOULD BE ON DRAINING THE BATTERY. IN ADDITION, WHILE DRIVING THE PARKING LIGHTS WILL COME ON AND GO OFF AS WELL AS IN THE DASH WHEN THE SWITCH IS IN THE OFF POSITION. I HAVE VIDEO BUT IT'S NOT DOWNLOADING. *JS

• 12/30/2014· AIR BAGS

  MY 2006 HYUNDAI SONATA AIR BAG LIGHT ILLUMINATED ON MY DASH. I TOOK MY CAR INTO THE DEALER ON 12/9/15 AND AFTER A $120 DIAGNOSIS FEE WAS TOLD THAT I NEEDED TO REPLACE THE SEAT BELT BUCKLE AND THAT THE COST WOULD BE NEAR $500. UNFORTUNATELY, I DO NOT HAVE THE MONEY TO REPLACE THE PART AND WAS TOLD THAT MY AIR BAGS WILL NOT WORK. I HAVE SEEN MANY MORE COMPLAINTS ABOUT THIS SAME PROBLEM. THIS IS A SAFETY ISSUE AND THERE SHOULD BE A RECALL FOR THIS ISSUE! *JS

• 12/30/2012· STRUCTURE,VEHICLE SPEED CONTROLCrash

  ON DECEMBER 30TH 2012 TIME:11.52 AM WHILE MAKING A SLOW TURN INTO A PARKING AREA OF SIKH TEMPLE, 16000 STIRLING ROAD,SOUTHWEST RANCHES,FL33331 TEL: 954 680 0221,MY 2006 HYUNDAI SONATA SUDDENLY ACCELERATED UNCONTROLLABLY FOR NO REASON,AN ACCIDENT RESULTED WITH MINOR DAMAGED TO OTHER PROPERTY AND MINOR DAMAGE TO THE FRONT OF THE 2006 SONATA. IS THERE ANYTHING WRONG WITH THE VEHICLE'S SPEED CONTROL? *TR

• 12/30/2012· AIR BAGS

  PASSENGER RIGHT SIDE AIRBAG WARNING LIGHT IS INTERMITTENTLY ON. DIAGNOSIS WAS "PASSENGER SIDE PRE TENSIONER" SINCE THIS TIME THE PROBLEM HAS NOT BEEN SOLVED. THE SEAT ITSELF WAS REPLACED, BUT THE PROBLEM STILL REMAINS IN DECEMBER 2012. SERVICE SAYS THAT THE OCCUPANT WEIGHT LESS THAN 110 MAY CAUSE THE WARNING, BUT THE DECEMBER 2012 DIAGNOSIS USED 3 DIFFERENT PEOPLE (100,120, AND 170 POUNDS) AND FOUND NO PROBLEM. WHEN THE LIGHT IS ON, THERE IS NO ASSURANCE THAT THE AIRBAG WILL FUNCTION IN A CRASH.AFTER THE DECEMBER 28 CHECK THE WARNING LIGHT HAS NOT COME ON BUT ONLY ONE SHORT DRIVE FROM DEALER. *TR

• 12/29/2016· POWER TRAIN

  TAKATA RECALL ON CHRISTMAS NIGHT MY CAR WOULDN'T GO IN REVERSE.IT HAS TRANSMISSION FLUID IN THERE.I DROVE AROUND TO THE STORE AND IT WON'T GO OVER 60MPH.

• 12/29/2015· AIR BAGS

  TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. WHILE DRIVING AT A LOW SPEED, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CONNECTOR IN THE FRONT PASSENGER SEAT NEEDED TO BE TIGHTENED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 79,411. UPDATED 04/08/16*LJ

• 12/29/2010· AIR BAGS

  PASSENGER SIDE "AIR BAG" LIGHT HAS COME ON. PASSENGER AIR BAG "ON/OFF" LIGHT FLASHES BACK AND FORTH WHEN THE SEAT IS OCCUPIED. HAVE SEEN MANY REPORTS OF SAME ON THE INTERNET - SAME YEAR, MAKE AND MODEL OF AUTOMOBILE. IT IS REPORTED TO BE VERY EXPENSIVE TO REPAIR BUT SOUNDS LIKE A RECALL IS IN ORDER AS MANY VEHICLES HAVE BEEN FOUND TO SHARE THE PROBLEM NOT ASSOCIATED WITH NORMAL WEAR AND TEAR. *TR

• 12/29/2008· STRUCTURE

  I OWN AN 06 HYUNDAI SONATA AND WAS HEARING A GROWLING NOISE WHICH BECAME LOUDER WITH INCREASED SPEED. AFTER GOING TO THE DEALER ON THREE SEPARATE OCCASIONS WITH THE HOPE OF IDENTIFYING THE PROBLEM, I WAS INFORMED THAT I NEEDED TO REPLACE THE TWO FRONT WHEEL BEARINGS (TO A TUNE OF $1100.00). I AM SHOCKED BY THIS CONSIDERING THIS IS A FARELY NEW VEHICLE. I READ COMPLAINT AND DEFECT REPORTS ON THE NHTSA WEBSITE WHICH SITED FRAME CORROSION ISSUES IN MODELS UP TO 2002. MY CONCERN IS THAT THIS IS THE SAME TYPE OF ISSUE BUT MY CAR IS NOT ACKNOWLEDGED OR INCLUDED BECAUSE IT IS A 2006 MODEL. I KNOW THAT HYUNDAI CLAIMS TO HAVE IMPROVED THE ENGINEERING OF THEIR NEWER MODELS; HOWEVER, IT JUST SEEMS IRONIC THAT I AM NEEDING TO REPLACE THE WHEEL BEARING (WHICH IS INCLUDED IN THE FRAME) AT SUCH AN EARLY AGE IN THE LIFE OF THE VEHICLE. THERE HAS BEEN NO ACCIDENTS OR INJURIES AS OF THIS DATE, BUT I WAS INFORMED THAT IF I DIDN'T REPLACE THESE BEARINGS THAT I AM IN JEOPARDY OF THE WHEELS FALLING OFF...WHICH COULD BE DETRIMENTAL AND VERY DANGEROUS. *TR

• 12/28/2021· VEHICLE SPEED CONTROL

  The contact owns a 2006 Hyundai Sonata. The contact stated while driving approximately 65 MPH, the accelerator pedal became stuck and was unable to reduce speed while depressing the brake pedal or shifting into neutral. The contact was able to pull over to the shoulder and place the vehicle into the park. The contact stated no warning light was illuminated. The vehicle was towed to the residence where it was awaiting diagnostic testing. The manufacturer was not informed of the failure. The failure mileage was approximately 230,000. Consumer stated vehicle was inspected by contractor investigator.

• 12/28/2011· AIR BAGS

  TL- THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WHEN THE AIR BAG WARNING INDICATOR ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TEN TIMES FOR THE DEFECT. IN ADDITION, THE FRONT PASSENGER AND DRIVER SIDE SEAT BUCKLES WERE REPLACED ON A SEPARATE OCCASION DUE TO THE SEAT BELTS NOT PROPERLY OPERATING BUT THE FAILURE CONTINUED AFTER THE REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 19,313. KMJ

• 12/28/2010· VISIBILITY

  BOTH SUN VISORS HAVE CRACKED IN THE AREA THAT HOLDS THEM STABLE THEY WILL NOT STAY UP ON THEIR OWN. 2006 HYUNDAI SONATA. *TR

• 12/27/2014· AIR BAGS,SEAT BELTS

  DEAR SIR OR MADAM, MY 2006 SONATA HAS BEING ILLUMINATED THE AIR BAG LAMP. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SEAT BELT BUCKLE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT THE VEHICLE WAS NOT REPAIRED. PLEASE INVESTIGATE IF WILL DETERMINE IF 2006 HYUNDAI SONATA CAR SHOULD BE RECALLED. THANKS, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/27/2013· SUSPENSION

  TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THERE WAS AN ABNORMAL VIBRATION IN THE VEHICLE WHEN DRIVING VARIOUS SPEEDS. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 13V354000 (SUSPENSION) BUT TO NO AVAIL. IN ADDITION, THE AIR BAG WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE PROBLEM. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

• 12/27/2012· AIR BAGS,SEAT BELTS

  MY AIRBAG LIGHT HAS BEEN ON FOR APPROXIMATELY 8 MONTHS. I HAD IT TO THE DEALER AND THEY SAID IT WAS A LOOSE CONNECTION. THEY "RE-CONNECTED" AND THE LIGHT WENT OFF. NOW IT HAS BEEN BACK ON FOR ABOUT 2 MONTHS. ALSO I HAVE A HARD TIME CONNECTING MY DRIVER SEAT BELT, ONE TIME I HAD TO DRIVE WITHOUT IT AT ALL SINCE I COULD NOT GET IT TO SNAP IN AT ALL. ALSO THE PASSENGER SEAT BELT DISPLAY LIGHT FLASHES EVEN WHEN THERE IS NO ONE SITTING IN THE SEAT. I CALLED AND APPARENTLY I AM NOT A PART OF THE RECALL FOR THE AIRBAG. MY SISTER HAS THE SAME CAR, SAME YEAR AND HAS THE SAME ISSUES. I FIND THIS HARD TO BELIEVE THAT THIS IS AN ISOLATED PROBLEM. *TR

• 12/27/2010· AIR BAGS

  AIR BAGS. *TR

• 12/26/2012· SUSPENSION,STRUCTURE,ELECTRONIC STABILITY CONTROL (ESC)

  DRIVING ON HIGHWAY FROM A FAMILY EVENT DOING 65 MILES AN HOUR. EXPERIENCED EXTREME INSTABILITY. ESC LIGHT CAME ON DASHBOARD MAKING US THINK PROBLEM WAS ELECTRONIC. CONTINUING AT A REDUCED SPEED, THE CAR CONTINUED TO DART TO LEFT. ON A HIGHWAY OFF RAMP, THE CAR DARTED TOWARD THE LEFT HAND GUARDRAIL, WITH REAR TIRE SQUEALING. WE WERE STILL 50 MILES FROM HOME. LIMPED THE CAR HOME TO BRING TO OUR MECHANIC. WE TOOK IT TO FIRESTONE IN CT. THE MECHANIC PUT IT ON THE LIFT AND INSPECTED IT. FOUND IT TO HAVE EXTENSIVE CORROSION ON THE SUBFRAME IN THE BACK END. WE COULD OF BEEN KILLED. HE TOLD ME NOT TO DRIVE THE CAR UNTIL THE PROBLEM WAS FIXED. *TR

• 12/26/2011· AIR BAGS

  ONE MORNING THAT I STARTED THE CAR, MY AIRBAG LIGHT WOULDN'T GO OFF AFTER THE START-UP. IT HAS BEEN 5 MONTHS SINCE THIS LIGHT CAME ON, AND I BROUGHT IT TO A HYUNDAI DEALER'S SERVICE CENTER. AFTER THEIR DIAGNOSTIC, THEY SAID IT'S A SENSOR IN THE DRIVER'S SEAT BELT HAD SHORTEN OUT AND IT'S CAUSING AIRBAG SIGN TO COME ON. THE MECHANIC ALSO TOLD ME THAT THIS MEANS THAT IN CASE OF ACCIDENT THAT MY DRIVER-SIDE AIRBAG WOULDN'T INFLATE. THIS SEEMS LIKE A COMMON PROBLEM AFTER READING SEVERAL WEBSITES ABOUT THIS PARTICULAR MODEL AND YEAR'S AIRBAG LIGHT PROBLEM, BUT HYUNDAI IS KEEP DENYING THEIR RESPONSIBILITY. ANOTHER THING THAT IT'S SHOCKING TO ME IS THAT IN CASE A PERSON IS DRIVING WITHOUT A SEATBELT, AIRBAG WOULDN'T INFLATE, JUST AS AN ELECTRICAL FAILURE IN SEATBELT BUCKLE CAN CAUSE MALFUNCTION IN DEPLOYMENT OF THE AIRBAG SYSTEM. THIS DOESN'T MAKE ANY SENSE TO ME..WHY WOULD A CAR MAKER WOULD EVER DESIGN A SYSTEM LIKE THIS? TO PUNISH PEOPLE WHO ARE DRIVING WITHOUT A SEATBELT? WHEN I ASKED THIS QUESTION, THE HYUNDAI DEALER REPRESENTATIVE SAID THAT HE DOESN'T MAKE A CAR BUT THERE TO SELL IT! *TR

• 12/26/2006· AIR BAGS

  TL* - THE CONTACT STATED THAT AIR BAG LIGHT DIDN'T ALWAYS TURN ON WHEN SOMEONE SAT ON THE PASSENGER'S SIDE OF THE VEHICLE. THE MOST COMMON PASSENGER WEIGHED 120 LBS, AND THE FAILURE OCCURRED ABOUT 50% OF THE TIME. IF THIS LIGHT WAS ON AT THE BEGINNING OF A TRIP IT USUALLY STAYED ON FOR THE DURATION OF THE TRIP. THE CONTACT SAID THAT HE NOTICED THIS PROBLEM ON 11/1/2006 ,AND HE TOOK VEHICLE TO THE DEALERSHIP ON DECEMBER 1, 2006. THE SERVICE DEPARTMENT INFORMED HIM THAT THEY HAD TO ORDER A SEAT SENSOR FOR VEHICLE. THE DEALERSHIP GAVE HIM A LOANER VEHICLE, 2006 OR 2007 HYUNDAI SANTA FE, AND HE NOTICED THAT THE SENSOR LIGHT HAD THE SAME FAILURE AS HIS SONATA. THE CONTACT DID TAKE THE SANTA FE BACK TO THE DEALERSHIP, WHO GAVE HIM ANOTHER VEHICLE. THE SECOND LOANER VEHICLE WAS A 2007 SONATA, AND HE NOTICED THE SAME FAILURE. THE CONTACT STATED THAT THE DEALERSHIPHAD OTHER COMPLAINTS ABOUT THIS SAME FAILURE. THE DEALERSHIP CALLED HIM ON 12/26/06 TO INFORM HIM THAT ORDERED PART WAS IN, AND THE VEHICLE COULD BE BROUGHT IN FOR REPAIR. *AK

• 12/26/2006· ELECTRICAL SYSTEM,AIR BAGS

  AIR BAG OFF LIGHT ILLUMINATES INTERMITTENTLY WHEN PASSENGER (130+ LBS) IS SEATED PROPERLY IN FRONT PASSENGER SEAT, INDICATING THE AIR BAG WOULD NOT GO OFF. HAVE HAD THIS PROBLEM REPEATEDLY AND RANDOMLY SINCE PURCHASING THE VEHICLE 9/05, AND HAVE REQUESTED ACTION AT EACH WARRANTY SERVICING. (22,500 MI CURRENTLY) EACH TIME THE DEALER SERVICE DEPARTMENT CLAIMS THE DIAGNOSTICS DO NOT FIND A PROBLEM AND THE AIR BAG SENSOR IS WORKING PROPERLY. THEY SAY THERE ARE NO SERVICE BULLETINS OR RECALLS FROM HYUNDAI ON THIS PROBLEM. HOWEVER THERE ARE AT LEAST 15 COMPLAINTS ON THIS WEBSITE ABOUT THIS PROBLEM AS OF 12/06. I AM VERY UPSET BY THIS APPARENT LACK OF CARING ON HYUNDAI'S PART ABOUT THE SAFETY OF THEIR PASSENGERS. JUST BECAUSE THE INTERMITTENT PROBLEM CAN'T BE REPRODUCED AT THE DEALER'S DOES NOT MEAN THAT THE PASSENGERS ARE NOT EXPERIENCING THE PROBLEM. THERE HAS GOT TO BE A WAY TO ISOLATE THE PROBLEM EVEN IF IT CAN'T BE OBSERVED IN THE MOMENT, EVEN IF IT MEANS REPLACING THE PARTS IN THE SEQUENCE TILL THE PROBLEM GOES AWAY. *NM

• 12/25/2014· AIR BAGS

  THE AIRBAG LIGHT ON THE DASHBOARD CAME ON AT APPROX. 101,550 MILES AND HAS REMAINED ON SINCE. MILEAGE NOW AT 102,049. LIGHT REMAINS ON REGARDLESS ON IF THERE IS A PASSENGER SEATED OR NOT. PLEASE ADVISE STATUS ON A RECALL FOR THIS DEFECT WHICH BY ALL THE READINGS COMPLAINTS NOTED ON LINE, IS FOR SURE AN ISSUE. *TR

• 12/24/2010· VISIBILITY,AIR BAGS

  DEC 22 2010 BOTH MY AIRBAG LIGHTS CAME ON DRIVE SIDE STAYS ON THE PASSENGER SIDE FLASHES OFF AND ON AND THE PASSENGER SIDE VISOR DOESN'T NOT STAY UP ALREADY HAD THE DRIVE SIDE VISOR REPLACED BECAUSE OF THE SAME REASON IT WOULDN'T STAY UP. *TR

• 12/23/2011· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  DURING OPERATION OF THE VEHICLE, WHEN VEHICLE ENGINE SPEED DROPS TO APPROXIMATELY 1000 - 1100 RPM, HEADLIGHTS WILL DIM OR BRIEFLY SHUT OFF, RADIO WILL SHUT OFF, AND INTERIOR FAN SPEED WILL DROP. THIS HAPPENS FOR APPROXIMATELY 1 SECOND AND IS INTERMITTENT. FROM SEARCHES OF THE INTERNET, THIS APPEARS TO BE A COMMON PROBLEM REQUIRING REPLACEMENT OF THE POSITIVE BATTERY CABLE ASSEMBLY. I DO NOT UNDERSTAND WHY THIS HAS NOT BEEN HANDLED VIA A RECALL, ESPECIALLY SINCE HEADLIGHTS DIMMING OFF OR SHUTTING OFF DURING NIGHT DRIVING IS EXTREMELY DANGEROUS. THIS HAS HAPPENED ON MULTIPLE OCCASIONS TO THIS CAR. IN ADDITION, PROBABLY DUE TO THIS VOLTAGE DROP PROBLEM, SEVERAL HEADLIGHTS, BRAKE LIGHTS ETC., HAVE HAD TO BE REPLACED. THIS HAS ALREADY COST ME SEVERAL HUNDRED DOLLARS IN TROUBLESHOOTING AND REPAIR, PRIOR TO LEARNING ABOUT THE CABLE ASSEMBLY. *TR

• 12/22/2025· ENGINE AND ENGINE COOLING,ENGINE

  The contact owns a 2006 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of automotive power. No warning light was illuminated. The contact was able to pull over to the shoulder of the roadway and noticed that engine oil was leaking onto the ground and the coolant level was abnormally low. The contact stated that the vehicle failed to restart and was towed to a local independent mechanic, where it was diagnosed with a valve cover leak. The vehicle was repaired at the owner's expense; however, the failure reoccurred. The local dealer was not contacted. In addition, the contact stated that several other unknown repairs were made; however, the failure reoccurred. The contact related the failure to an unknown NHTSA Campaign; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 112,000.

• 12/22/2015· AIR BAGS

  ON NOV. 7, 2013, I NOTIFIED HYUNDAI THAT WE HAD BEEN EXPERIENCING PROBLEMS WITH THE SONATA'S OCCUPANT CLASSIFICATION SYSTEM (OCS). THE SYSTEM DID NOT CONSISTENTLY RECOGNIZE MY WIFE AS AN ADULT PASSENGER, EVEN THOUGH SHE CLEARLY EXCEEDED THE NECESSARY WEIGHT THRESHOLD DESIGNED TO ACTIVATE THE AIRBAG SENSOR. HYUNDAI, AFTER MECHANICAL/ELECTRONIC REVIEW, STATED THE OCS WAS WORKING AS DESIGNED. IT WASN'T. WE RETURNED THE VEHICLE FOR SERVICE ON APRIL 1, 2014, AND AGAIN ON MAY 22, 2014, ONLY TO HAVE HYUNDAI TELL US THE OCS WAS OPERATING "OK". AGAIN, ON JULY 30, 2015, WE RETURNED THE VEHICLE FOR SERVICE, AS THE OCS WAS STILL MALFUNCTIONING. HYUNDAI, AT THAT TIME, PERFORMED A REPROGRAMMING. STILL THE OCS DOES NOT CONSISTENTLY RECOGNIZE MY WIFE AS AN ADULT PASSENGER. I HAVE CONTACTED HYUNDAI AN ALMOST INNUMERABLE NUMBER OF TIMES IN REGARD TO THIS ISSUE. THOUGH HYUNDAI EVEN HAD AN ARBITRATOR DOCUMENT THE DEFECT, TO DATE WE STILL HAVE NO RESOLUTION. IT IS UNSAFE FOR MY WIFE, OR ANY OTHER ADULT PASSENGER, TO RIDE IN THE CAR. AND, AS ONE CAN SEE BY THE HISTORY, IT HAS BEEN THAT WAY FOR QUITE SOME TIME.

• 12/22/2014· AIR BAGS

  AT APPROXIMATELY 78,000 MILES THE AIRBAG LIGHT ON THE DASHBOARD CAME ON. I TOOK IT TO THE DEALER WHO FOUND HISTORY CODE B1448 - OCS MAT DEFECTIVE. THE TECH CLEARED THE CODE AND RETESTED CAR AND STATED IT IS WORKING AS DESIGNED. THEN AT 83,000 MILES THE SAME LIGHT CAME ON AGAIN. I TOOK IT BACK TO THE DEALER WHO STATED THIS TIME THAT THERE IS A FAULT CODE SET FOR THE PASSENGERS SIDE SEATBELT LATCH. THE LATCH SIDE OF THE SEATBELT NEEDS TO BE REPLACED AND IT WILL COST $360. THE TECH ALSO STATED THAT THE AIRBAG SYSTEM IS DISABLED. THERE ARE NUMEROUS COMPLAINTS FROM MANY SONATA OWNERS REGARDING THIS SAME PROBLEM. THERE SHOULD BE A RECALL AS THIS IS A MAJOR SAFETY CONCERN. *TR

• 12/22/2010· VISIBILITY

  DRIVER SIDE VISOR CRACKED & DOES NOT STAY UP, BLOCKING VISION. *TR

• 12/21/2013· AIR BAGS,SEAT BELTS

  CAR WAS TAKEN TO HYUNDAI DEALERSHIP FOR OCS RIGHT FRONT PASSENGER SEAT RECALL. A FEW HOURS LATER DEALER CALLED TO ADVISE THAT THERE WAS NO PROBLEM WITH THE OCS AIR BAG. I WAS TOLD THE CODE ASSOCIATED WITH THE LIGHT BEING ON INDICATING "PASSENGER AIR BAG OFF" RELATED TO THE SEAT BELT TENSIONER NOT WORKING, NOT THE OCS. SINCE THE SEAT BELT IS A SAFETY ISSUE, I ASKED THE DEALER TO TAKE CARE OF IT AT NO CHARGE TO ME. THE DEALER (RICK CASE HYUNDAI IN DAVIE, FL) REFUSED TO DO SO SAYING THAT IT WAS NOT COVERED IN THE OCS RECALL AND THE CAR WAS OUT OF WARRANTY. I THEN CALLED HYUNDAI CUSTOMER SERVICE AND REQUESTED THAT HYUNDAI REPAIR THE SEAT BELT TENSIONER AT NO CHARGE TO ME. THEY READ ME A PREPARED STATEMENT STATING THAT THIS WAS NOT COVERED UNDER THE OCS RECALL AND WOULD NOT TAKE CARE OF IT BECAUSE THE CAR WAS OUT OF WARRANTY. AFTER I SPOKE TO A CASE MANAGER AT HYUNDAI, THEY AGREED TO CALL THE DEALERSHIP AND SEE IF THEY COULD WORK SOMETHING OUT WITH THE DEALERSHIP FOR THE SEAT BELT REPAIR. HYUNDAI WAS SUPPOSED TO CALL ME BACK WITHIN A WEEK TO TELL ME WHAT WAS WORKED OUT. THEY DID NOT. WHEN I CALLED BACK A COUPLE OF WEEKS LATER, HYUNDAI AGAIN READ ME THE PREPARED STATEMENT SAYING THIS PROBLEM WAS NOT COVERED UNDER THE RECALL. I REITERATED THAT THE SEAT BELT TENSIONER WAS A SAFETY ISSUE AND I EXPECTED THEM TO REPAIR IT. THEY CONTINUED TO REFUSE TO TAKE RESPONSIBILITY FOR THE REPAIR. I ADVISED I WAS GOING TO REPORT THIS SAFETY ISSUE TO NHTSA. HYUNDAI WAS UNCONCERNED. AS NHTSA SHOULD SEE, SEVERAL HYUNDAI SONATA OWNERS HAVE REPORTED THIS SAME SEAT BELT PROBLEM TO NHTSA. MY PASSENGER SEAT IS RARELY USED, SO THIS SEEMS TO BE A HYUNDAI SAFETY DEFECT FOR WHICH THE DEALERS AND HYUNDAI SHOULD BE REQUIRED TO MAKE A RECALL AND REPAIR AT THEIR EXPENSE.I AM ALSO CONCERNED THAT THE PASSENGER SEAT WAS NOT REMOVED AND SENT TO HYUNDAI FOR ANALYSIS AS NOTED IN THE OCS RECALL. *TR

• 12/21/2010· AIR BAGS

  SEATBELT LIGHT ON FOR 2006 HYUNDAI SONATA. *TR

• 12/20/2015· SUSPENSION,AIR BAGS,ELECTRONIC STABILITY CONTROL (ESC)

  AIR BAG LIGHT IN INSTRUMENT PANEL REMAINS ON AT ALL TIMES. ESC INDICATOR TURNS OFF AT RANDOM TIMES WHILE DRIVING. REAR SUSPENSION KNOCKS WHEN FUEL TANK IS LOW (I.E. NEAR EMPTY).

• 12/19/2013· ELECTRICAL SYSTEM,AIR BAGS

  TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 08V161000 (AIR BAGS). AFTER THE RECALL REPAIR WAS PERFORMED, ALL OF THE INSTRUMENT PANEL WARNING LIGHTS ILLUMINATED AND THE READING OF THE GAUGES FLUCTUATED ERRATICALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS AWAITING DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.

• 12/19/2012· AIR BAGS,SEAT BELTS

  UPON STARTING THE VEHICLE, THE DASHBOARD "CHECK AIRBAG" LIGHT WAS CONSTANTLY ILLUMINATED. TOOK VEHICLE TO THE DEALER (23JUL08) WHERE THEY DIAGNOSED CODE B1701 AND REPLACED THE FRONT DRIVERS SEAT BELT BUCKLE ASSEMBLY. AT 43,340 MILES (03FEB09) I NEEDED THE PASSENGER SEAT BELT BUCKLE ASSEMBLY (B1706 CODE) REPLACED. AT 57,106 MILES (06NOV09) I NEEDED THE DRIVERS SEAT BELT BUCKLE REPLACED (CODE NOT DOCUMENTED BY DEALER). NOW (19DEC12) THE "CHECK AIRBAG" LIGHT IS LIT AGAIN (103,121) AND THE CODES B1701 AD B1706 BOTH SHOW UP. MOST LIKELY REPLACE BOTH DRIVER AND PASSENGER SEAT BELT BUCKLE ASSEMBLY. AN UNBELIEVABLE NUMBER OF SEAT BELT BUCKLE REPLACEMENTS IN THE LIFE OF THIS VEHICLE. SINCE SEAT BELT ISSUES LIKE THIS ILLUMINATE THE "CHECK AIRBAG" INDICATOR LIGHT, I HAVE TO BELIEVE THIS IS A SAFETY FACTOR RELATED PROBLEM. *TR

• 12/19/2006· STEERING,SUSPENSION,ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,POWER TRAIN,WHEELS

  THIS COMPLAINT APPLIES TO A 2007 HYUNDAI SONATA LIMITED (NO OPTION FOR 2007 WAS AVAILABLE IN DROP DOWN MENU) (ISSUE 1) AT OR AROUND THE INITIAL FEW DAYS AFTER TAKING DELIVERY I BEGAN TO NOTICE ABRUPT VIBRATION AND SHAKING COMING FROM THE STEERING WHEEL; SUBSTANTIAL ENOUGH TO FEEL IN THE SEAT. VEHICLE WAS TAKEN BACK TO DEALERSHIP ON 3 SEPARATE OCCASIONS TO REMEDY THE PROBLEM BUT THEY REPORTED THAT THEY WERE UNABLE TO DUPLICATE THE PROBLEM AND REPORTED THE VEHICLE TO BE IN MANUFACTURER SPECIFICATION. NONETHELESS, DEALER ATTEMPTED WHEEL BALANCE AND RADIAL FORCE BALANCE AS A "GOOD WILL GESTURE." PROBLEM IS NOW MORE ARTICULATED AND THE ISSUE REMAINS UNRESOLVED. (ISSUE 2) ENGINE EMITS A RATTLE NOISE SIMILAR TO LIFTER CLATTER UPON START AND CONTINUES THROUGHOUT OPERATION; PARTICULARLY IN COLDER WEATHER. TIMING CHAIN TENSIONER WAS REPLACED AND ONE NOISE WAS RESOLVED BUT THE CONTINUAL NATURE OF THE LIFTER CLATTER REMAINS. DEALERSHIP AND HYUNDAI REPRESENTATIVE REPORTED THAT THEY WERE UNABLE TO DUPLICATE THE PROBLEM AND THE ISSUE REMAINS UNRESOLVED. (ISSUE 3) FUEL SLOSHING COMING FROM THE FUEL TANK. MANUFACTURER AND DEALER CLAIMS THIS TO BE NORMAL AND NOT A SAFETY RISK. SOUND IS MORE PRONOUNCED AT OR AROUND 3/4 TANK. BROUGHT THIS TO THE ATTENTION OF THE DEALER AND THE MANUFACTURER DIRECTLY AND REMAINS UNRESOLVED. *NM

• 12/19/2006· AIR BAGS

  TL* - THE CONTACT IS HAVING PROBLEMS WITH THE PASSENGER SIDE AIR BAG LIGHT, IT WOULD NOT TURN OFF. THE CAR WAS TAKEN BACK TO DEALERSHIP TWICE (MEDILD HYUNDAI), AND THE CONTACT WAS TOLD THAT SEAT COVER WAS THE REASON WHY THE LIGHT STILL ON. THE CONTACT SAID THAT SHE TOOK THE SEAT COVER OFF AND THE LIGHT STILL DID NOT GO OFF. CONTACT SAID THAT THE DEALER TOLD HER THAT A PERSON WOULD HAVE TO BE AT LEAST 110 POUNDS FOR THE AIR BAG TO WORK. THE CONTACT DOSE NOT HAVE RECORD OF SERVICE, BECAUSE CAR IS UNDER WARRANTY.

• 12/18/2018· AIR BAGS

  THE AIRBZG LIGHT CAME ON AFTER MY GIRFRIEND SAT IN THE PASSENGER SEAT .AFTER LEAVING THE VEHICLE THE AIRBAG LIGHT IS STAYING ON INDICATING A FAULR IN THE AIRBAG / OCS SYSTEM. I HAD THE CODES PULLED BY INDEPENDANT MECHANIC AND CODE B1448 SHOWED INDICATING THE SEAT MAT SENSOR WAS DEFECTIVE . I WENT TO HYUNDAI DEALER IN NORTH HAMPTON NEW HAMPSHIRE.THE DEALER SAID THEY WOULD HAVE TO DIAGNOSE THE ISSUE FOR $125 AND IT COSTS ABOUT 1400 TO REPLACE THE MAT , MANY PEOPLE ONLINE IN FORUMS HAVE THE SAME ISSUE . THEY WERE ABLE TO HAVE THIS REPAI DONE .ITS CAMPAIGN 083 . I WAS TOLD TO CONTACT HYUNDAI CORPORATE BY SERVICE EMPLOYEE AT THE DEALERSHIP . HYUNDAI CONTINUED TO CLAIM MY VIN IS NOT LISTED .THIS IS NOT A RECALL BUT CAMPAIGN .THE CAMPAIGN AFFECTS 2006 AND NEWER SONATAS .THE HUYNDAI CORPORATE EMPLOYEE SAID I CSN HAVE THE CAR DIAGNOSED AND THEN THEY CAN SUBMIT A "REQUEST" TO HAVE CORPORATE AUTHORIZE THE REPAIR .WHICH WOULD COST SIGNIFICANT MONEY . OTHERS ONLINE HAD NO PROBLEM GETTING THIS REPAIR DONE FREE AS ITS A KNOWN ISSUE WITH THE SONATA . FAILURE OF THE SEAT MAT AND SUBSEQUENT AIRBAG MALFUNCTION LIGHT IS VERY CONCERNING TO ME CAUSE I DO NOT KNOW IF MY AIRBAG WILL FUNCTIIN

• 12/18/2013· AIR BAGS

  TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED WHILE THE PASSENGER'S SEAT WAS OCCUPIED. THE VEHICLE WAS DIAGNOSED AND THE CONTACT WAS INFORMED THAT THE SENSOR IN THE SEAT BELT BUCKLE MALFUNCTIONED. THE CONTACT WAS INFORMED THAT THE DEFECT WAS NOT ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 08V161000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 150,000.

• 12/18/2009· VISIBILITY

  MY DRIVER-SIDE SUN VISOR IN MY 2006 HYUNDAI SONATA BEGAN HANGING LOWER AND LOWER UNTIL EVENTUALLY IT WOULD NEITHER STAY UP AGAINST THE ROOF OF THE CAR OR OUT TOWARD THE WINDSHIELD. THE VISOR NOW ONLY HANGS DOWN, WHICH OBSTRUCTS MY VIEW WHEN DRIVING. *TR

• 12/18/2009· FUEL SYSTEM, GASOLINE

  SMELLED A STRONG FUEL SMELL INSIDE THE CAR; ESPECIALLY WHEN COLD STARTING; THIS IS 3.3L V6 ENGINE. TOOK THE CAR TO THE DEALER AND THEY COULD NOT FIND ANY PROBLEM. THIS WAS ON AND BEFORE 22 SEP 2009 WITH ABOUT 48,000 MILES ON THE VEHICLE. GAS SMELL GETTING STRONGER AND PERSONAL MECHANIC FOUND RIGHT FRONT FUEL INJECTOR LEAKING, ESPECIALLY WHEN COLD. ALSO MILEAGE HAS DROPPED ABOUT 10 MPG DURING LONG ROAD TRIP. MECHANIC RECOMMENDS CHANGE OF FUEL INJECTOR O-RING SEAL(S) ON THE LEAKING INJECTOR AND ALL OTHERS (5 MORE). I TOOK THE VEHICLE TO THE DEALER FOR A WARRANTY REPAIR. STILL WAITING TO SEE IF THEY WILL REPAIR THE VEHICLE PROPERLY. THIS COULD BE A SERIOUS SAFETY/FIRE ISSUE WITH RAW FUEL BEING SPRAYED ON THE HOT ENGINE. *TR

• 12/17/2014· AIR BAGS

  I NOTICE THE AIR BAG LIGHT STAYS ON. I TOOK IT TO THE HYUNDAI DEALER WITH IN A WEEK TO HAVE IT FIXED THEY SAID I WOULD HAVE TO PAY TO GET IT FIX. THEY TOLD ME THAT IT WAS SOMETHING IN THE SEAT BELT CONNECTION AND IT WAS ELECTROANAL OR SOME KIND OF SENSOR TO TURN THE LIGHT OFF. SO I ASKED WILL THE AIR BAG STILL WORK IF I WAS IN A ACCIDENT? THEY SAID NO BECAUSE ITS NOT MAKING THE RIGHT CONNECTION TO TURN OFF THE LIGHT AND ACTIVATE THE AIRBAG. SO THAT'S THE ONLY CAR I HAVE TO GO FROM HOME TO WORK AND BACK OR FOR ANYTHING ELSE. SO WHAT AM I TO DO? THANK YOU *TR

• 12/17/2010· EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT THE BRAKE LIGHTS FREQUENTLY BLEW OUT; THEY WERE REPLACED FIFTEEN TIMES. THE DEALER WAS CONTACTED AND THEY INFORMED THE CONTACT THAT THERE WERE NO RECALLS AND ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT TO TAKE THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 88,000. THE FAILURE MILEAGE WAS APPROXIMATELY 37,000.

• 12/16/2015· SUSPENSION,ELECTRICAL SYSTEM,ENGINE

  I OWN A 2006 HYUNDAI SONATA, AT 100,000 (HWY MILES) THE FRONT UPPER CONTROL ARMS BECAME SQUEEKY AND DETATCHED FROM THE RUBBER BUSHINGS, MAKING A HORRIBLE RIDE AND CLUNKING SOUND WHEN I WOULD PUT THE CAR INTO GEAR. THIS PROBLEM MAKES THE CAR BOUNCY AND UNSTABLE. THERE IS ALSO A KNOCKING OR LOUD CLICKING SOUND IN THE ENGINE AT CRUSING SPEEDS, WHEN I BARLEY PUSH THE GAS PEDAL. IT SOUNDS LIKE THE AIR INTAKE CONTROL VALVE. IT GOES AWAY WHEN I ACCELERATE. THE RADIO AND CRUISE CONTROL ELECTORNICS SEEM TO WORK ONLY WHEN THEY WANT TOO!

• 12/16/2014· AIR BAGS,SEAT BELTS

  I STARTED HAVING ISSUES WITH MY AIR BAG LIGHT COMING ON INTERMITTENTLY TWO YEARS AGO AT ABOUT 55,000 MILES. I BROUGHT IT IN TO THE DEALER FOR A CORROSION RECALL AND SPOKE WITH THEM ABOUT THE AIR BAG LIGHT. THEY TOLD ME IF IT STAYS ON SOLID THEN RETURN AND THEY WILL LOOK INTO IT FOR ME. I PROBABLY COULD HAVE HAD IT REPAIRED AT THAT POINT HAD THEY LOOKED INTO IT FURTHER. SO NOW LIGHT IS ON ALL THE TIME, TOOK IT IN TODAY AND IT IS "SEAT BELT BUCKLES" THAT IS CAUSING ISSUE, REPAIR IS 700 DOLLARS AND NEED MY CAR FOR AT LEAST 4-5 DAYS. I AM GUESSING IT WILL TAKE ANOTHER CLASS ACTION LAW SUIT TO HAVE HYUNDAI STAND BEHIND THEIR PRODUCT AGAIN AND ISSUE RECALLS FOR IT'S CUSTOMERS. I CALLED CORPORATE AND INQUIRED ABOUT INVESTIGATIONS INTO MAKING THIS A RECALL BUT OBVIOUSLY DIDN'T GET ANYWHERE. THE SERVICE DEPARTMENT INFORMED ME THAT THE AIR BAGS DO NOT WORK NOW AT ALL. I SAW MANY OTHER SIMILAR COMPLAINTS ABOUT THIS ISSUE, HYUNDAI OBVIOUSLY DOES NOT HAVE THE SATISFACTION OR THE SAFETY OF THEIR CUSTOMERS AS A PRIORITY. *TR

• 12/16/2014· AIR BAGS,SEAT BELTS

  DRIVING ALONG, AND THE AIRBAG LIGHT ILLUMINATED. DEALER SAYS DRIVERS SIDE SEAT BELT BUCKLE FAILED AND NOW, AIRBAG LIGHT REMAINS ILLUMINATED, POSSIBLE FAILURE OF AIRBAGS. *TR

• 12/16/2008· SERVICE BRAKES, HYDRAULIC

  COMPLETE 4 WHEEL BRAKE PADS AND ROTORS WERE REQUIRED AT ONLY 27,000 MILES AT A COST OF $825. I AM A VERY SLOW AND CAREFUL DRIVER AND NOT HARD ON BRAKES. DEALER SAID ALL 4 WHEELS WERE METAL TO METAL AND HYUNDAI CLAIMS THIS IS A WEAR ITEM AND NOT COVERED BY WARRANTY. THIS IS WAY TOO SOON AND DANGEROUS. *TR

• 12/15/2015· VISIBILITY/WIPER

  BOTH SUN VISORS FAILED DROPPING DOWN INTERFERING FRONT VISIBILITY. ONE WAS REPLACED AT DEALER UNDER WARRANTY BUT REFUSED TO PAY FOR THE OTHER ONE REPAIR.

• 12/15/2014· SERVICE BRAKES, HYDRAULIC

  TL* THE CONTACT OWNS A 2006 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE BRAKES BECAME INOPERABLE AND THE ABS AND ESC WARNING INDICATORS ILLUMINATED CONTINUOUSLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE BRAKE SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 130,000.

• 12/15/2014· AIR BAGS

  AIR BAG LIGHT STAYS ON TOOK TO DEALER SAID DRIVER SEAT SWITCH BAD, POSSIBLE SEAT BELT BUCKLE COULD BE BAD QUOTED OVER 500. DOLLARS TO FIX I CAN NOT AFFORD TO HAVE FIXED SHOULD BE COVERED UNDER WARRANTY. *TR

• 12/15/2009· VISIBILITY

  WHILE DRIVING A 2006 HYUNDAI SONATA WITH 30,000 MILES, THE DRIVER SIDE SUNVISOR JUST FLOPPED DOWN WHILE DRIVING ON THE INTERSTATE HIGHWAY SYSTEM ON I-95 AT 70 MPH. THERE WAS NO WARNING AND THE VISOR BLOCKED THE DRIVERS VISION BECAUSE IT WOULD NOT RETURN TO THE "UP" POSITION. SINCE THE CAR WAS BEING DRIVEN ON A VACATION TRIP THAT HAD BEEN PREVIOUSLY PLANNED AND IN A DIFFERENT LOCATION, IT WAS NOT PRACTICAL TO GO TO A STRANGE DEALERSHIP. TO SOLVE THE PROBLEM ON THE REMAINDER OF THE TRIP, I USED A "WOODEN CLOTHSPIN" CLIPPED TO THE VISOR AND PUT THE SUNVISOR TO THE LEFT SIDE OF THE VEHICLE AND PUT THE CLOTHSPIN BEHIND THE DRIVER SIDE HAND HOLD LOCATED ON THE INSIDE OF THE ROOF OF THE CAR. SINCE THE TRIP WAS GOING TO BE FOR ABOUT A WEEK, I LATER USED A RUBBER BAND TO KEEP THE VISOR HIGH ENOUGH TO ENTER AN EXIT THE DRIVER DOOR. THE VISOR WAS REPLACED AT THE DEALER BACK HOME AND I BECAME AWARE THAT THIS SEEMED TO BE A FREQUENT PROBLEM ON THIS CAR. THIS IS A VERY DANGEROUS CONDITION AND THIS AGENCY SHOULD LOOK INTO THIS SERIOUS OBSTRUCTION OF DRIVER VISIBILITY WHEN THIS CONDITION OCCURS. OF ALL THE VEHICLES I HAVE OWNED IN THE LAST 40 YEARS, THIS IS THE ONLY ONE TO HAVE THIS PROBLEM. *TR