2006 Dodge Grand Caravan

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2011· POWER TRAINCrash

  TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN SE. THE CONTACT WAS DRIVING 20 MPH WHEN THE ENGINE STALLED WHILE ATTEMPTING A LEFT TURN. THE VEHICLE ALSO JERKED AND THE BRAKES LOCKED CAUSING THE VEHICLE TO CRASH INTO ANOTHER VEHICLE. THE CHECK ENGINE AND TRANSMISSION WARNING LIGHTS ILLUMINATED INTERMITTENTLY PRIOR TO THE FAILURE. THERE WERE NO INJURIES AS A RESULT OF THE CRASH BUT THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGES WERE 44,000.

• 12/30/2010· STEERING

  POWER STEERING COMPLAINT FOR 2006 DODGE GRAND CARAVAN. THERE IS A LOUD WHINING NOISE COMING FROM POWER STEERING. POWER STEERING FLUID LEAKS AND IS CONSTANTLY REPLACED. PREVIOUS REPAIRS HAVE INCLUDED A REPLACEMENT OF POWER STEERING FLUID, REPLACEMENT OF POWER STEERING FLUID RESERVOIR, AND REPLACEMENT OF FILTER. THE PROBLEM IS FIXED FOR AN INTERMITTENT TIME AFTER EACH REPAIR AND THEN RETURNS. A SEARCH OF COMMON AUTOMOBILE FORUMS FOR "2006 DODGE GRAND CARAVAN POWER STEERING DEFECT" REVEALS NUMEROUS COMPLAINTS ABOUT SAME PROBLEM. IT IS NOTED THAT THE NORMAL RESPONSE FROM THE MANUFACTURER IS TO REPLACE THE ENTIRE RACK AND PINION SET. THIS IS HAPPENING ON VERY LOW MILEAGE VEHICLES. MOST ORIGINAL COMPLAINTS APPEAR TO OCCUR ON VEHICLES BETWEEN 40,000 AND 60,000 MILES. *TR

• 12/27/2016· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,SERVICE BRAKES

  TAKATA RECALL 1. THE KEY FOB, AUTOMATICALLY CONTROLLED REAR DOOR HATCH DOES NOT STAY OPEN WHEN USING THE KEY FOB OR MANUALLY OPENING THE HATCH DOOR. IT HAS CLOSED NEARLY UPON MYSELF - THE OWNER, AND OTHERS - WITHOUT WARNING WHEN STOPPED, MOTOR OFF AND LOADING OR UNLOADING ITEMS. THERE IS NO WAY TO ASSESS WHAT CAUSED THIS AS IT GETS BELOW NORMAL WEAR. SINGLE PARTY USE, NO KIDS. THIS INCIDENCE STARTED 12/12/2016 2. THE FRONT BRAKES MAKE A SCRAPING NOISE AND WOBBLING OF STEERING WHEEL UPON COMING TO A STOP. THIS WAS MENTIONED TO THE DEALER EARLIER THIS YEAR AND BRAKES, PADS AND ROTORS WERE CHECKED AT DEALER, AND IT WAS STATED THAT NOTHING WAS WRONG. NEW BRAKE PADS WERE INSTALLED IN 2013. THE CAR MILEAGE IS 85241 MILES. THE WHEELS HAVE BEEN ROTATED, ALIGNED. THE CAR HAS REGULAR, ROUTINE MAINTAINANCE, THE BRAKES STILL SCRAPES AND WOBBLES THE STEERING WHEEL. THIS HAS BEEN A RECURRING INCIDENCE.

• 12/27/2007· VISIBILITY

  MY HUSBAND WAS DRIVING OUR 2006 DODGE GRAND CARAVAN ON THE HIGHWAY WHEN THE DRIVER'S-SIDE, REAR WINDOW BLEW INTO THE CAR. IT CONCERNS US BECAUSE, AS A PARENT, ONE OF MY CHILDREN COULD HAVE BEEN SITTING IN THE THIRD ROW AND WOULD HAVE BEEN SERIOUSLY INJURED. THANKFULLY IT DID NOT CAUSE AN ACCIDENT TO WHICH THE ACTUAL CAUSE (OF A "BROKEN WINDOW") WOULD HAVE NEVER BEEN REALIZED. I AM NOT SURE WHETHER THIS IS A SAFETY DEFECT OR AN ANOMALY, BUT I WOULD LIKE MY COMPLAINT TO BE RECORDED BASED UPON THESE CONCERNS. THE WINDOW WAS REPLACED, AND IS NOT AVAILABLE AS THE WINDOW SHATTERED. *TR

• 12/22/2015· EXTERIOR LIGHTING

  I AM HAVING A INTERMITTENT ISSUE WITH MY HEADLIGHTS, THEY ARE SHUTING OFF WHILE DRIVING AND ALTHOUGH CRYSLER HAS A LIFETIME WARRANTY ON THE HEAD LIGHT SWITHCH FOR THIS EXACT ISSUE MY VEHICLE VIN IS NOT INCLUDED IN THIS WARRANTY. THIS IS DANGEROUS AND SHOULD BE A RECALL AS PEOPLE COULD BE IN DANGER OF CRASHING IF THIS HAPPENS AND THEY ARE UNABLE TO SEE.

• 12/22/2014· STEERING,ELECTRICAL SYSTEM,AIR BAGS

  OUR AIR BAG LIGHT COMES ON AFTER REPEATED, EXACT TURNS OF THE STEERING WHEEL. HAS TO DO WITH THE STEERING WHEEL CLOCK SPRING. IT ONLY ILLUMINATES IN TEMPS OVER 70 DEGREES OR SO. WE LIVE IN THE DESERT OF ARIZONA AND HAVE BEEN EXCLUDED IN PREVIOUS RECALLS. WE ARE AFRAID THE AIR BAGS WILL NOT WORK PROPERLY IN THE EVENT OF A CRASH. *TR

• 12/22/2010· STRUCTURE

  2006 DODGE GRAND CARAVAN SXT. SLIDING DOORS ARE INCONSISTENT WITH OPERATION AND CREATE CONCERN FOR A QUICK EXIT IN AN EMERGENCY SITUATION. THE SLIDING PASSENGER DOORS EITHER WILL NOT OPEN WITH THE REMOTE KEY SET OR WILL NOT OPEN ENTIRELY WITH ANY OF THE DOOR RELEASE BUTTONS ON THE INTERIOR OF THE VEHICLE. THIS HAS IMPACTED BOTH THE DRIVER SIDE AND PASSENGER SIDE SLIDING DOORS. INABILITY TO OPEN THESE DOORS WITHOUT SUPPORT OF AN ADULT HAS CREATED CONCERN FOR A QUICK EXIT IN AN EMERGENCY SITUATION FOR ALL PASSENGERS. TO OPEN THESE DOORS WITHOUT SUPPORT OF THE AUTOMATIC DOOR OPENING SYSTEM IS ALSO VERY HARD. THE DOORS ARE HEAVY AND OFTEN TAKE SEVERAL ATTEMPTS TO HOLD THE (BLACK) RELEASE BUTTON DOWN TO OPEN THE DOOR(S). MY CHILDREN DO NOT HAVE THE STRENGTH TO DO THIS ON THEIR OWN DUE TO THIS MECHANICAL FAILURE. THE BUTTON WHICH YOU SHOULD BE ALLOWED TO PUSH AND AUTOMATICALLY OPEN THE DOORS (FROM EITHER THE FRONT DRIVER SEAT OR THE BACK TWO REAR PASSENGER BUTTONS ARE NOT FUNCTIONAL). FROM MY RESEARCH, OF THE DODGE MINI-VANS, I'M FINDING THIS IS A VERY COMMON PROBLEM. I WOULD LIKE TO HAVE THIS RESEARCHED TO DETERMINE THE NEED FOR SAFETY RECALL ACTION. IF A 9 YEAR OLD CHILD AND CHILDREN IN THEIR EARLY TEENS CANNOT OPEN THESE DOORS ON THEIR OWN, THIS PRESENTS A MAJOR SAFETY CONCERN. WE PURCHASED THIS CAR NEW IN 2006 AND 3 YEARS LATER, THE PROBLEM STARTED IMPACTING BOTH DOORS. I WILL ATTEMPT TO BRING THE MINIVAN INTO DODGE TO INSPECT BUT THE INFORMATION I'VE GATHERED HAS PROVEN INCONSISTENT OUTCOMES WITH DEALER REPAIRS AND EVEN MORE CONCERNING, AN INABILITY TO FIX THIS ISSUE ON A PERMANENT BASIS. *TR

• 12/22/2009· SERVICE BRAKES, HYDRAULIC

  NEAR FAILURE IN THE BRAKES ON MY 2006 DODGE GRAND CARAVAN. WENT IN TO HAVE TIRES ROTATED AND TOLD THAT THE FRONT BREAKS AND ROTORS WERE DANGEROUSLY WORN AND NEAR FAILURE. REARS WERE 80% WORN. BRAKES WERE JUST DONE LESS THAN 20K MILES AGO. *TR

• 12/21/2015· ELECTRICAL SYSTEM,AIR BAGS

  TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM) EXCEEDED A REASONABLE TIME FOR REPAIR. THE CONTACT RECEIVED A RECALL NOTIFICATION IN JUNE OF 2015; HOWEVER, THE DEALER PLACED THE CONTACT ON A WAITING LIST AND STATED THAT THE PART WAS NOT AVAILABLE FOR REPAIR. THE DEALER DID NOT KNOW WHEN THE PART WOULD BE AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

• 12/20/2014· FUEL/PROPULSION SYSTEM

  I WAS PICKING UP A MACHINE IN GEORGIA, AND I HAD TO STOP AND GET GAS. I FILLED UP WITH GAS DROVE ONTO THE TURNPIKE AND THE CAR STALLED AND A TRUCK ALMOST HIT MY CAR AS MY CAR WAS COASTING TO GET IT OFF THE HIGHWAY. HE HIT HIS BRAKES AND SQUEALED UP TO MY VEHICLE. THIS SITUATION COULD KILL SOMEONE AND I READ HUNDREDS OF COMPLAINTS FROM PEOPLE ONLINE. THIS HAPPENS ON EVERY FILL UP SINCE. *DT

• 12/19/2018· FUEL/PROPULSION SYSTEM

  UNABLE TO FILL WITH GAS AT SERVICE STATION (EVAPORATIVE SISTEM). THE NOZZLE KEPT SHUTTING OFF EVEN THOUGH THE TANK WAS NEARLY EMPTY.

• 12/19/2018· ELECTRICAL SYSTEM

  THE REAR POWER LIFT GATE ON MY 2006 DODGE GRAND CARAVAN DOES NOT STAY OPEN WHEN LOADING OR UNLOADING ITEMS BUT KEEPS CONTINUALLY CLOSING HARD AUTOMATICALLY WHEN NEEDING TO HAVE IT STAY OPEN TO ALLOW FOR LOADING OR UNLOADING. THIS HAPPEN WHETHER ONE TRIES TO OPEN THE DOOR USING THE HANDLE MANUALLY OR AUTOMATICALLY WITH THE KEY FOB. THIS HAS HAPPENED OVER THE LAST 3 OR 4 YEARS ESPECIALLY DURING WINTER BUT NOT CONFINED TO WINTER ONLY. MY GRANDSON AND MYSELF ALMOST GOT CAUGHT MORE THAN ONCE AND INJURED IN ITS UNEXPECTED DOWNWARD FREE-FALL. THIS IS VERY DANGEROUS TO ANYONE TRYING TO ACCESS THE BACK PORTION OF THE VAN AS THE HEAVY LIFT GATES CLOSES ON THEM TRAPPING THEM AND CAUSING POTENTIAL SERIOUS INJURY. THIS HAPPENS WHEN VEHICLE IS STATIONARY AND IN THE GARAGE OR STATIONARY IN A SHOPPING PARKING LOT WHEN LOADING GROCERIES OR OTHER PURCHASES. OR WHEN PUTTING THE REAR SEATS UP OR DOWN TO UTILIZE BACK PORTION OF VAN. SOMEONE CANNOT HOLD THE LIFT GATE OPEN WHEN ANOTHER IS TRYING TO ACCESS THE BACK OF THE VAN AS THE LIFT GATE FALLS HARD AND CANNOT BE STOPPED. THERE ARE CURRENTLY 93,360 MILES DRIVEN.

• 12/17/2013· AIR BAGS

  TO WHOM THIS MAY CONCERN: I SPOKE WITH A DODGE CUSTOMER SERVICE AGENT RECENTLY REGARDING AN ISSUE WITH MY 2006 DODGE GRAND CARAVAN, WHICH I FEEL SHOULD BE COVERED UNDER CHRYSLER RECALL CAMPAIGN J38 BUT, ACCORDING TO THEM, IS NOT. THE ISSUE WITH MY VEHICLE INVOLVES A CRACKED AIRBAG SENSOR, WHICH CURRENTLY ILLUMINATES THE AIRBAG LIGHT AND I SUSPECT MAY NOT OPERATE PROPERLY IN A FRONTAL CRASH. MY LOCAL MECHANIC COPIED THE RECALL NOTIFICATION FOR ME AND MARKED THE INFORMATION PERTINENT TO MY PARTICULAR VEHICLE. HE FEELS AS THOUGH THE NECESSARY REPAIRS TO THE AIRBAG SENSOR SHOULD BE COVERED UNDER THIS RECALL CAMPAIGN. ACCORDING TO THE RECALL NOTIFICATION, ?2005-2006 DODGE GRAND CARAVANS BUILT FROM JANUARY 19, 2005 THROUGH APRIL 5, 2006? AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CERTAIN STATES (TO INCLUDE PENNSYLVANIA) ARE INVOLVED IN THIS RECALL. THE AIRBAG LIGHT INITIALLY CAME ON AFTER DRIVING THROUGH STANDING WATER, BUT WOULD GO OFF AFTER A PERIOD OF TIME. THE LIGHT IS NOW ON CONSTANTLY. SINCE MY VEHICLE IS CURRENTLY REGISTERED IN PENNSYLVANIA, ONE OF THE STATES LISTED ON THE RECALL NOTIFICATION, AND WAS BUILT IN DECEMBER 2005, I BELIEVE THE REPAIRS SHOULD BE COVERED UNDER THIS RECALL. SINCE I PURCHASED MY VEHICLE USED WITH 13,000 MILES ON IT, I DO NOT KNOW WHERE IT WAS ORIGINALLY SOLD OR REGISTERED. PLEASE CONTACT ME WHEN YOU HAVE REVIEWED THIS INFORMATION AND CAN GIVE ME YOUR INFORMED DECISION ABOUT THE REPAIRS TO MY VEHICLE AND ANY CONCERN YOU HAVE ABOUT THE SAFETY OF MY VEHICLE. I APPRECIATE YOUR TIME AND EFFORT. *TR

• 12/17/2013· VISIBILITY/WIPER

  WE CANT GET THE WINDSHIELD WASHER FLUID WORKING. IT WORKED FINE WHEN WE FIRST BOUGHT IT AT 64K MILES. *TR

• 12/14/2006· AIR BAGSCrash

  12-13-06 FRONT CAR COLLUSION WITH NO AIR BAG DEPLOYMENT. APPROXIMATE SPEED OF VEHICLE LESS THAN 40 MPH. APPROXIMATELY 24 INCH INTRUSION INTO MIDDLE OF THE FRONT OF THE CAR BY PASSENGER SIDE FENDER AREA OF CAR THAT CAUSED COLLUSION. DAMAGE TO CAR WILL REQUIRE COMPLETE REPLACEMENT OF EXISTING AIR BAG SENSORS. *JB

• 12/13/2011· EXTERIOR LIGHTING

  WHEN I GOT TO WORK AND WENT TO TURN THE HEADLIGHTS OFF. THE LIGHTS SHUT OFF BUT IT KEPT DINGING LIKE THEY WERE STILL ON. I TURNED THE SWITCH ON THEN OFF AGAIN AND IT STILL KEPT DINGING AND THE SMALLER HEADLIGHTS CAME ON AND DIDN'T SHUT OFF AFTER I HAD SHUT OFF LIGHTS. I HAD TO GO BACK AND DO THE SAME THING WITH THE LIGHT SWITCH AND THEN THEY FINALLY SHUT OFF. THIS HAS HAPPENED ON SEVERAL OTHER OCCASIONS. *TR

• 12/08/2009· VISIBILITY

  TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING IN SEVERE RAINY CONDITIONS, THE WINDSHIELD WIPERS WOULD OPERATE INTERMITTENTLY UNTIL FINALLY THEY FAILED COMPLETELY. THE DRIVER WAS ABLE TO REACH HIS DESTINATION WITHOUT A CRASH. SHE CONTACTED THE MANUFACTURER. SHE WAS ADVISED THAT HER VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL CAMPAIGN ID NUMBER 06V067000 (VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR). NO REPAIRS WERE MADE. THE CURRENT AND FAILURE MILEAGES WERE UNDER 45,000. UPDATED 1/11/09 *CN UPDATED 01/13/10.*JB

• 12/06/2011· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,STRUCTURE

  THE SLIDING PASSENGER DOOR LOCKS NO LONGER LOCK AUTOMATICALLY LOCK WHILE DRIVING. THEY HAVE TO BE LOCKED MANUALLY. THIS IS A SAFETY ISSUE. WITH CHILDREN IN THE BACK SEAT, THEY CAN NOW OPEN THE DOORS WHILE THE CAR IS MOVING IF AN ADULT FORGETS TO LOCK THEM. THE LIFT GATE IN THE BACK NO LONGER CHIMES WHEN OPENING. THIS IS A SAFETY ISSUE. SOMEONE CAN GET WHACKED WITH THE DOOR, NOT KNOWING THAT IT IS ABOUT TO OPEN. THE PARKING LIGHTS STAY ON OR COME ON SPONTANEOUSLY AFTER THE HEADLIGHTS HAVE BEEN TURNED OFF. THIS IS A PROBLEM. VERY EASY FOR THE OWNER TO COME OUT IN THE MORNING TO A DEAD BATTERY AND A CAR THAT WON'T START. SOME OWNERS HAVE REPORTED THE HEADLIGHTS CUTTING OUT WHILE DRIVING, A SERIOUS SAFETY ISSUE. *TR

• 12/04/2012· EXTERIOR LIGHTING

  WE WERE DRIVING ALONG AND THE HEADLAMPS RANDOMLY TURNED OFF FOR NO APPARENT REASON. WE JIGGLED THE SWITCH AND THEY CAME BACK ON. THIS NOW HAPPENS FREQUENTLY. *TR

• 12/02/2013· STEERING

  TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE PARKED, SHE NOTICED A LEAK FROM UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE POWER STEERING FLUID WAS LEAKING AND THE STEERING RACK WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED AT AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

• 12/01/2009· STEERING

  STEERING SYSTEM MAKES A LOUD HUMMING NOISE ALL OF THE TIME. VEHICLE HAS 51000 MILES ON IT, AND MY MECHANIC TOLD ME THE RACK AND PINION HAS TO BE REPLACED. I ASKED HOW HE COULD TELL WITHOUT LOOKING, AND HE TOLD ME THAT THIS IS WELL KNOWN PROBLEM, WITH THESE VEHICLES. *TR

• 11/28/2025· ENGINE AND ENGINE COOLING

  The contact owns a 2006 Dodge Grand Caravan. The contact stated that when the vehicle was purchased in 2010, the vehicle was missing the EGR (Exhaust Gas Recirculation) valve. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle idled roughly, jerked and stalled while driving. The check engine warning light was illuminated. The vehicle was taken to Auto Zone, where it was diagnosed with power train failure. The vehicle was taken to the dealer, where the contact was informed that the vehicle was missing the Exhaust Gas Recirculation (EGR) valve. The contact was provided DTCs: P0403 and P0404. The vehicle was not repaired. In 2019, the vehicle was taken to a tire business and the EGR valve was installed on the vehicle. The failure was progressively worsened, and the vehicle was no longer being driven. Upon further investigation, the contact found information on various auto websites indicating that the vehicle was manufactured in Canada and imported to the United States. The contact was the second owner. The contact found information on other auto websites that stated that the EGR valve was removed from the vehicle, and it was removed in stages. The manufacturer was notified of the failure. The contact was informed that the VIN was not under recall. The failure mileage was approximately 122,000.

• 11/27/2010· STRUCTURE,LATCHES/LOCKS/LINKAGES

  MY 2006 GRAND CARAVAN DOES NOT CONSISTENTLY ALLOW THE SLIDING POWER DOOR ON BOTH SIDES CLOSE MORE THAN 1/2 OR 3/4 OF THE WAY. ADDITIONALLY, IF IT DOES CLOSE IT WILL INTERMITTENTLY WILL NOT CYCLE FULLY TO FULLY SECURE THE DOOR. AS A RESULT THE POWER MECHANISM WHICH SEALS THE DOOR WILL CYCLE OVER AND OVER UNTIL SOMEONE MANUALLY OPENS THE DOOR AND THEN PULLS IT SHUT. *TR

• 11/23/2009· STEERING

  WE BOUGHT ALMOST THREE YEARS AGO 2006 DODGE GRAND CARAVAN. RIGHT NOW IT ONLY HAS 47000 MILES. RECENTLY WE NOTICED A LEAK AND WE TOOK THE CAR FOR SERVICE & WE FOUND OUT THE POWER STEERING RACK IS BROKEN AND LEAKING OIL. WE THOUGHT IT WAS COVERED BY THE WARRANTY. BUT THE DEALER TOLD US IT WASN'T COVERED BY THE WARRANTY. THEY ESTIMATED THE COST AROUND $1300. WE CALLED CHRYSLER AND THEY FAILED TO HELP US. AFTER WE DID SOME SEARCH WE FOUND OUT SO MANY DODGE GRAND CARAVANS GETTING END UP BREAKING THE POWER STEERING RACK AT EARLY AGE. WE BELIEVE CHRYSLER NEED TO RECALL THIS AND FIX THE ISSUE. IT IS NOT FAIR FOR US WHEN OUR CAR HAS ONLY 47,000 MILES . *TR

• 11/21/2014· STEERING,ENGINE,FUEL/PROPULSION SYSTEM

  OVER THE LAST SEVERAL WEEKS MY 2006 DODGE GRAND CARAVAN WITH A 3.8 LITER ENGINE WILL STALL OUT SEVERAL TIMES AFTER REFUELING. IT WILL RESTART & STALL SEVERAL TIMES BEFORE THE PROBLEM SEEMS TO RECTIFY ITSELF. ALL POWER ASSISTED STEERING IS LOST AND THE VEHICLE BECOMES DIFFICULT TO STEER SAFELY. POWER BRAKING IS ALSO AFFECTED. THERE HAVE BEEN A COUPLE OF OCCASIONS WHERE I HAVE BEEN TURNING INTO TRAFFIC AND HAD THE VEHICLE STALL. ONE TIME I WAS UNABLE TO COMPLETE THE TURN AND STAY IN MY LANE. ON ONE OCCASION I BREACHED THE LANE TO MY LEFT. WHILE TRAFFIC WAS TRAVELING IN THE SAME DIRECTION I WAS, ANOTHER MOTORIST HAD TO SLAM ON THE BRAKES TO AVOID HITTING ME. *TR

• 11/19/2008· POWER TRAIN

  BRAKES APPEARED TO BE GOING OUT IN VEHICLE. HAD SERVICE TECHNICIAN CHECK AND BELIEVE TRANSMISSION IS GOING OUT. FOUND OUT SEVERAL PEOPLE WITH THIS VEHICLE HAVE HAD PROBLEMS WITH TRANSMISSIONS BETWEEN 60,000 AND 80,000 MILES. *TR

• 11/17/2009· STEERING

  MY 2006 DODGE GRAND CARAVAN HAS DEVELOPED A LOUD WHINING SOUND FROM UNDER THE HOOD AT A COLD START AND CONTINUING FOR SEVERAL MINUTES. THE NOISE IS PRESENT WHEN SITTING STILL WITH THE WHEELS STRAIGHT BUT GETS WORSE WHEN THE WHEEL IS TURNED. *TR

• 11/17/2008· SERVICE BRAKES, HYDRAULIC

  TL*THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD A HUMMING SOUND WHEN THE BRAKE PEDAL WAS DEPRESSED. AFTER THE FIRST INCIDENT, THE HUMMING SOUND OCCURRED EVERYTIME THE BRAKES WERE APPLIED. THE VEHICLE WAS DRIVEN TO A LOCAL REPAIR SHOP AND THE MECHANIC STATED THAT THE BRAKE ROTORS WERE WEARING BEFORE THE BRAKE PADS. THE DEALER STATED THAT THE ROTORS WERE WARPED AND NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER INFORMED HIM TO HAVE THE VEHICLE SERVICED AT AN AUTHORIZED DEALER. THE CURRENT MILEAGE WAS 31,800 AND FAILURE MILEAGE WAS 30,200. UPDATED 12/22/08. *LJ UPDATED 12/23/08. *JB

• 11/16/2009· STRUCTURE,LATCHES/LOCKS/LINKAGES

  I OWN A 2006 DODGE GRAND CARAVAN WITH APPROX 40K, I HAVE NEVER HAD DAYTIME RUNNING LIGHTS WHICH SEEMS ODD BUT MY MAIN COMPLAINT IS ONE OF MY POWER SLIDING DOORS WONT OPEN WHEN I PRESS THE BUTTON ON MY KEY OR THE BUTTON ON THE DASH, IT SEEMS TO NOT BE UNLOCKING. IF YOU MANUALLY UNLOCK THE DOOR FROM THE INSIDE AND THEN PRESS THE BUTTON THEN THE DOOR OPENS FINE. I SEE NUMEROUS OTHER PEOPLE ON LINE WITH THE SAME EXACT PROBLEM WHICH MAKES ME WONDER WHY DODGE HAS DONE NOTHING. *TR

• 11/14/2019· ENGINE

  TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING 45 MPH, THE OIL PRESSURE AND AN UNKNOWN WARNING INDICATOR ILLUMINATED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. ON NOVEMBER 9, 2019, WHILE DRIVING 55 MPH, WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS LOSING SPEED, BUT WAS ABLE TO BE PULLED OVER TO THE SIDE OF THE ROAD. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE CONTACT CALLED THE POLICE DUE TO HER DISABLED HUSBAND BEING IN THE COLD FOR OVER TWO HOURS. A POLICE REPORT WAS FILED. HE WAS TRANSPORTED TO THE HOSPITAL, BUT THERE WERE NO INJURIES OR MEDICAL ATTENTION NEEDED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TOWED TO AN INDEPENDENT MECHANIC. THE CONTACT WAS INFORMED THAT THERE WAS AN OIL LEAK IN THE ENGINE AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

• 11/10/2019· UNKNOWN OR OTHER

  SLIDING DOOR LOCK ACTUATOR FROZE UP.THIS RENDERSTHE SLIDING DOOR COMPLETELY INOPERABLE.IF THAT DOOR WAS NEEDED FOREGRESS,IT WOULDNT BE AVAILABLE!!

• 11/08/2013· EXTERIOR LIGHTING

  THE HEADLIGHTS FUNCTION INTERMITTENTLY WITH THE SWITCH AND ALSO TURN OFF INTERMITTENTLY WHILE DRIVING EVEN THOUGH THE HEADLIGHT SWITCH REMAINS ON. TURNING THE SWITCH ON AND OFF MULTIPLE TIMES SOMETIMES WILL CAUSE THE HEADLIGHTS TO TURN BACK ON BUT NOT ALWAYS. SOMETIMES THE HEADLIGHTS WILL TURN BACK ON BY THEMSELVES. *TR

• 11/05/2010· SEATS

  ON THE 2006 DODGE GRAND CARAVAN WITH REAR STOW N GO SEATING, A PASSENGER WAS SITTING IN A CHILD BOOSTER SEAT ON ONE OF THE BACK STOW N GO SEATS. THE SEAT APPEARED TO BE LOCKED INTO POSITION. HOWEVER, IN TRANSIT THE SEAT EXPLODED BACKWARDS WITH THE CHILD. THE CHILD HIT THEIR HEAD ON THE BACK DOOR. THE ENDING POSITION WAS THE TAILGATING POSITION WITH THE CHILD'S HEAD CAUGHT ON THE REAR DOOR. THIS WAS THE FIRST TIME THE FAILURE OCCURRED. WE ARE NOT SURE WHAT CAUSED THE FAILURE. *TR

• 11/05/2009· LATCHES/LOCKS/LINKAGES

  I HAVE A 2006 DODGE GRAND CARAVAN AND THE SLIDING DOORS ARE NOT WORKING PROPERLY, THE SLIDING DOOR ON THE DRIVERS SIDE DOES NOT WORK AT ALL WITH THE CONTROL BUTTON OR THE REMOTE, YOU HAVE TO MANUALLY OPEN AND CLOSE IT BUT THE PASSENGER SLIDING DOOR WILL OPEN WITH THE BUTTON SOMETIMES, BUT WILL NOT STOP ONCE OPENED, IT WILL CLOSE RIGHT BACK (A COUPLE OF TIMES IT ALMOST CLOSED ON MY KIDS GETTING IN AND OUT OF THE CAR). I BOUGHT THE CAR FOR THE EASE OF THE SLIDING DOORS, BUT NOW I CAN'T EVEN USE THEM. I'M WORRIED THAT ONE OF MY CHILDREN CAN GET CAUGHT IN THE DOOR AND GET SERIOUSLY INJURED AS THE DOOR DOES NOT STOP ONCE IN MOTION. *TR

• 10/31/2010· EXTERIOR LIGHTING

  APPROXIMATELY 10 TIMES OVER THE LAST 3 YRS. THE HEADLIGHTS ON MY VAN HAVE MALFUNCTIONED. ABOUT 6 OF THOSE 10 TIMES THE PROBLEM WAS THAT I COULDN'T GET THE LIGHT TO TURN ON. THE OTHER TIMES, I COULDN'T GET THEM TO TURN OFF. WHEN THE LIGHTS WERE NOT WORKING THE ONLY WAY TO SEE WAS TO MANUALLY HOLD THE LEVER TO TURN THE BRIGHTS ON AND DRIVE WITH ONE HAND ON THE WHEEL AND THE OTHER ON THE LEVER. AS FAR AS THE LIGHTS NOT TURNING OFF, I HAD TO MANIPULATE THE SWITCH BY TURNING IT OFF AND ON AND PULLING IT OUT TO THE FOG LIGHT POSITION AS WELL AS BANG ON THE DASH TO GET THE LIGHTS TO TURN OFF. *TR

• 10/30/2014· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  THE PARKING LIGHTS TURN ON AND OFF RANDOMLY WHEN THE VEHICLE IS OFF. WHEN THE VEHICLE IS RUNNING, THE PARKING LIGHTS DON'T OPERATE PROPERLY USING THE LIGHT SWITCH--E.G. THE PARKING LIGHTS STAY ON WHEN TURNED OFF. CYCLING THE SWITCH SEVERAL TIMES CAN TURN THE PARKING LIGHTS OFF. OUR CAR WAS MANUFACTURED LATE IN DECEMBER 2005 ACCORDING TO DODGE. THIS APPEARS TO BE RELATED TO NHTSA ACTION # EA11010. DODGE HAS REFUSED TO COVER THE HEADLIGHT SWITCH ASSEMBLY (HSA) UNDER WHAT SHOULD BE A LIFETIME WARRANTY. THE HSA HAS BEEN REPLACED AT OWNERS EXPENSE AND THE PROBLEM APPEARS TO BE FIXED. WE SAVED THE DEFECTIVE PART. *TR

• 10/29/2014· AIR BAGS

  TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING VARIOUS SPEEDS, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE AIR BAG SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

• 10/28/2015· UNKNOWN OR OTHER

  SIDE SLIDING DOORS WILL NOT UNLOCK MANUALLY OR ELECTRICALLY. EXTREME SAFETY ISSUE; HAVE ELDERLY PARENTS AND IF ACCIDENT OCCURRED WOULD NOT BE ABLE TO GET THEM OUT! HAVE REPLACED THE ACTUATOR 3 TIMES IN LAST 2 YEARS ON DRIVER SIDE. PASSENGER SIDE HAS BEEN REPLACED TWICE. WHY IS THERE NOT A RECALL ON THESE?

• 10/28/2011· ELECTRICAL SYSTEM,STRUCTURE

  DRIVER SIDE PASSENGER DOOR AUTOMATIC LOCK DOES NOT WORK. *TR

• 10/25/2014· FUEL/PROPULSION SYSTEM

  FILLED FUEL TANK RIGHT OFF I24 IN TN. CAR STALLED ON ENTRANCE RAMP TO HIGHWAY. DRIFTED TO SIDE AND ENGINE RESTARTED QUICKLY. THIS NOW HAPPENS ALMOST EVERY TIME THE TANK IS FILLED. AROUND TOWN I CAN COPE BY NOT FILLING THE TANK, BUT VERY INCONVENIENT AND VERY DANGEROUS ON TRIPS ESPECIALLY ON HIGHWAYS. WE ARE NOT TALKING ABOUT OVERFILLING THE TANK, BUT JUST FILLING TO POINT WHEN PUMP SHUTS OFF. WHEN ENGINE STALLS, NOT ONLY IS THERE AN IMMEDIATE LOSS OF MOMENTUM, THE POWER STEERING SYSTEM QUITS, BUT THE BRAKES BECOME USELESS. EVERY TIME THIS HAPPENS, I JUST WAIT FOR SOMEONE BEHIND ME TO NOT SLOW DOWN IN TIME AND REAR-END ME. LUCKILY, I HAVE NOT BEEN IN THE FAST OR MIDDLE LANE WHEN IT STALLS, BECAUSE OF POSSIBLY NOT BEING ABLE TO GET TO THE SHOULDER TO RESTART IT. I AM ALSO PARANOID THAT IF I TRY TO MESS WITH PUTTING IT INTO NEUTRAL AND FOOLING AROUND WITH THE KEY, I WILL BECOME A VERY DISTRACTED DRIVER. CHRYSLER'S ANSWER IS TO REPLACE FUEL TANK AT A COST OF $1200. IF I COULD AFFORD THAT THEN I WOULDN'T BE DRIVING A 2006 AUTOMOBILE. *TR

• 10/25/2009· LATCHES/LOCKS/LINKAGES

  AUTOMATIC DOOR ON 2006 DODGE GRAND CARAVAN WILL NOT CLOSE. COMES TO WITHIN 6 INCHES OF CLOSING AND STOPS. HAVE DRIVEN OFF SEVERAL TIMES THINKING IT WAS CLOSED BUT THE KIDS STARTED YELLING AT ME AND THEN I HAD TO CLOSE MANUALLY. STILL TRYING TO DIAGNOSE. *TR

• 10/24/2017· AIR BAGS

  THE AIR BAG LIGHT GOES ON AND OFF PERIODICALLY, BOTH WHILE DRIVING AND STOPPED, TYPICALLY AFTER A RAIN STORM.

• 10/24/2007· EXTERIOR LIGHTING

  THE TURN SIGNAL SWITCH ON THIS VEHICLE DOES NOT WORK PROPERLY. MANY TIMES, WHEN IT IS SWITCHED ON, THE OPPOSITE TURN SIGNAL TURNS ON (IE. THE SWITCH IS FLIPPED TO MAKE A RIGHT TURN, BUT THE LEFT SIGNAL LIGHTS). SOMETIMES IT WILL COME ON FOR THE PROPER DIRECTION, BUT THEN ALL OF A SUDDEN STARTS FLASHING TO THE OTHER SIDE. SOMETIMES THE SIGNAL TURNS ON PROPERLY BUT THEN JUST STOPS DOING ANYTHING, EVEN THOUGH THE SWITCH IS STILL "ON". AND YET OTHER TIMES, THE TURN SIGNAL DOES NOT TURN ON AT ALL. THIS HAS BEEN HAPPENING OVER THE LAST MONTH OR SO, BUT IS GETTING PROGRESSIVELY WORSE. THE VEHICLE IS LESS THAN 2 YEARS OLD, BUT BECAUSE THE VEHICLE IS 2000 MILES OUT OF WARRANTY, DODGE IS NOT WILLING TO REPAIR THIS WITHOUT A CHARGE. *TR

• 10/19/2015· FUEL/PROPULSION SYSTEM

  POST REFUELING STALLS. WHILE GOING ON LONG TRIPS, AFTER REFUELING IN THE REST AREAS, THE MINIVAN STALLS WHILE ENTERING THE HIGHWAY CAUSING ME TO PANIC WHILE AVOIDING HIGH SPEED TRAFFIC GOING BY. THIS HAPPEN MANY TIME DURING A TRIP TO FLORIDA FROM INDIANA.

• 10/16/2007· SERVICE BRAKES, HYDRAULIC

  OUR BRAKES HAVE FAILED FOR THE SECOND TIME. I TOOK MY VAN BACK TO THE SHOP THAT REPLACED THE PADS AND ROTORS IN MAY. THEY TOLD ME THE CALIPERS WERE DEFECTIVE, AS THEY WERE UNDER WARRANTY I TOOK THE VAN TO THE DEALER. THE DEALER STATED THE NEW ROTORS THAT WERE PUT ON IN MAY WERE DEFECTIVE, THEY REFUSED REPAIRS AND CHARGED ME $50. *JB

• 10/15/2018· ENGINE,FUEL/PROPULSION SYSTEM

  I'VE TAKEN THE VEHICLE TO PEPBOYS TWICE BECAUSE ALTHOUGH THE GAS GAUGE WAS WORKING, THE VEHICLE WOULD CLICK THE GAS NOZZLE OFF AND WOULD NOT ACCEPT FUELING. PEPBOYS REPLACED THE IN-TANK PUMP AS A REMEDY TWICE. DODGE/CHRYSLER SAID IT WAS THE BREATHER TUBE. WHO'S RIGHT?

• 10/15/2012· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THE VEHICLE EXHIBITED SEVERAL ELECTRICAL FAILURES. THE BRAKE LIGHTS, INSTRUMENT PANEL AND THE CLUSTER ABOVE HER HEAD ALL FAILED. THE CONTACT REPLACED SEVERAL LIGHT BULBS BUT ALL OF THE LIGHTS CONTINUED TO FAIL. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE LIGHT IN THE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 165,000. ..UPDATED 12/06/12 *BF

• 10/15/2007· ENGINE AND ENGINE COOLING

  TL*THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING 45 MPH, THE STEERING VIBRATED AND THE VEHICLE FELT OUT OF ALIGNMENT. PRECISION ALIGNMENT INSPECTED THE VEHICLE AND NOTICED THAT THE MOTOR MOUNT WAS WORN AND NEEDED TO BE REPLACED. THE DEALER STATED THAT THEY WOULD PERFORM A DIAGNOSTIC TO DETERMINE IF THE MOTOR MOUNT WAS FAULTY. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 38,000 AND FAILURE MILEAGE WAS 36,000.

• 10/13/2018· STEERING

  WHEN DRIVING IN RAINY CONDITIONS (NOTE: WET ROAD, NOT HIGH WATER), POWER STEERING FAILED AND VAN WAS UNCONTROLABLE. THIS HAS HAPPENED 2X IN THE PAST YEAR. DEALERSHIP SAYS THIS IS A COMMON ISSUE WITH THIS MODEL, AS WATER CAN GET TO THE POWER STEERING BELT. THEY OFFERED NO SOLUTION. I NEARLY RAN INTO A DITCH AS I WAS UNABLE TO STEER. THANKFULLY I WAS ABLE TO STOP THE CAR WITHOUT CAUSING AN ACCIDENT, BUT THIS WAS A DANGEROUS SITUATION. BOTH TIMES THIS HAPPENED I WAS DRIVING ON A CITY STREET IN RAINY CONDITIONS.

• 10/11/2011· WHEELS

  TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE STUDS ON THE WHEELS WERE FRACTURING. THE MECHANIC ADVISED THAT THE STUDS WERE FRACTURED BECAUSE THEY WERE TOO SOFT AND WEAKENED OVER TIME. THE CONTACT CALLED THE MANUFACTURER REGARDING THE STUDS AND THE MANUFACTURER ADVISED THAT THERE WAS NOTHING THEY COULD DO TO ASSIST. THE FAILURE MILEAGE WAS 97,000.