2006 Dodge Charger

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2019· ENGINE,FUEL/PROPULSION SYSTEM

  CAR STALLS AFTER FILL UP. PULL INTO TRAFFIC AND YOU LOSE STEERING BREAKS ECT. NEED TO PUT IN PARK TO RESTART. WILL CONTINUE AND MISS AND STALL FOR ABOUT 5 MILES. ONCE YOU RUN SOME FUEL OUT OF THE CAR IT RUNS EXCEPTIONAL UNTIL THE NEXT FILL UP.

• 12/31/2013· STEERING,FUEL SYSTEM, GASOLINE,ENGINE

  THIS IS NOT THE FIRST TIME THIS HAS HAPPENED AND THIS IS FLAT OUT DANGEROUS! AFTER DRIVING ALL DAY I WAS ALMOST OUT OF GAS SO I STOPPED AT ONE OF MY REGULARLY USED GAS STATIONS. AS LIKE I ALWAYS DO WHEN I GET GAS I GOT A FULL TANK AND I DO NOT OVERFILL, ONCE THE HANDLE POPS I'M DONE PUMPING. VEHICLE STARTED FINE AND I DROVE OFF THE GAS STATION WITH NO PROBLEMS. ONCE ON THE MAIN ROAD I APPROACHED MY FIRST TURN AND IN MID TURN GOING ABOUT 20MPH MY VEHICLE JUST STALLED,NO WARNING OR NOTHING IT JUST RANDOMLY STALLED. ONCE THE CAR ROLLED OFF THE MAIN STREET I PUT IT IN PARK AND TRIED TO START IT UP AGAIN. NO LUCK, THE VEHICLE WOULDN'T START. IT TOOK A FEW TRIES BUT MANAGED TO GET IT RUNNING AGAIN. TO MY SURPRISE I DIDN'T HAVE A CHECK ENGINE LIGHT SO I SAT THERE FOR A WHILE REVVING THE ENGINE AND EVEN SHUT IT OFF AND RESTARTED IT, EVERYTHING SEEMED FINE SO I WENT ON MY WAY. SHORTLY AFTER I DROVE OFF IT HAPPENED AGAIN AND THIS TIME I WAS JUST DRIVING STRAIGHT. FROM THE GAS STATION TO MY HOME IS ABOUT 10MIN AND IN THAT SHORT TIME FRAME THE VEHICLE RANDOMLY STALLED 4 TIMES! THIS WENT ON FOR A FEW DAYS UNTIL MY FUEL LVL WAS ABOUT 3/4 FULL? AFTER RESEARCHING ONLINE ON DODGE FORUMS I WAS ABLE TO FIND OUT WHAT MAY AND MOST LIKELY BE THE ISSUE WITH MY VEHICLE. SOME SAY ITS A COLLAPSED GAS TANK WHICH AFFECTS A CHECK VALVE IN THE GAS TANK THAT IS FOR THE EVAP SYSTEM. WHEN YOU HAVE A FULL TANK AND THE SYSTEM OPENS UP TO RELEASE GAS VAPORS BACK INTO THE ENGINE IT'S ACTUALLY SENDING RAW FUEL BACK INTO THE ENGINE WHICH IN TURN FLOODS THE VEHICLE AND CAUSES THE STALL. OF COURSE THIS PART CAN'T BE REPLACED OR FIXED SINCE THE TANK AND THOSE PARTS ARE SOLD AS ONE PIECE WHICH IS BIG $$$! MY ONLY FIX FOR THIS UNTIL THIS IS RECALLED IS I DON'T GET A FULL TANK ANYMORE. THIS IS A SERIOUS AND DANGEROUS ISSUE WHICH SHOULD BE RECALLED IMMEDIATELY BEFORE SOMEONE GETS INTO A SERIOUS ACCIDENT. *TR

• 12/31/2013· ENGINE

  MY CAR FROM WORK LIKE ANY NORMAL NIGHT WHEN ALL OF SUDDEN MY CAR SHUT OFF AND WOULD NOT START BACK UP. EVENTUALLY I CALLED MY INSURANCE TO HAVE IT TOWED HOME SINCE AFTER 11PM. THE NEXT MORNING I HAVE MY CAR TOWED TO DODGE TO BE INFORMED THAT ENGINE HAD BLOWN. MY CAR GAVE ME NO INDICATION OR SIGNS AT ALL BEFORE THIS HAPPEN. THE DEALERSHIP INFORMED ME THAT THE ENGINE WAS BLOWN DUE OIL SLUDGE. I VERY ANGRY ESPECIALLY SINCE DODGE ONLY CHANGED MY OIL AND WAS NOT TOLD ABOUT THIS EARLIER. MY COUSIN HAS DODGE CHARGER AS WELL AND ENGINE BLOWN 8 MONTHS BEFORE MINE FOR THE SAME REASON. WHEN I TOLD THIS TO THE DEALERSHIP THEY TOLD ME I SHOULDN'T BELIEVE EVERYTHING I HEAR. I WILL NEVER BUY A CAR FROM DODGE AGAIN. *TR

• 12/30/2016· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  2006 DODGE CHARGES WITH 5.7 HEMI V8 - EXPERIENCING RANDOM STALLING. HAPPENS AT ANY SPEED. EVERYTHING SHUTS OFF INCLUDING THE POWER STEERING AND ABS. FIRST HAPPENED WHILE MERGING ONTO FREEWAY AND I HAD TO DRIVE OFF THE ROAD TO AVOID A SEMI-TRUCK. THIS HAPPENED WITH MY YOUNG CHILD IN THE VEHICLE. I HAD THE GAS TANK, FUEL CANISTER, AND PURGE VALVE REPLACED. THE PROBLEM STILL OCCURS REGARDLESS OF THE AMOUNT OF GAS IN THE VEHICLE AND REGARDLESS OF WHEN IT WAS REFUELED. EVEN THOUGH THIS APPEARS TO BE A COMMON PROBLEM THE DEALERSHIP HAS BEEN NO HELP AND EVEN TRIED CHARGING ME FOR UNNECESSARY DIAGNOSTICS. CAR DOES NOT FLASH A CODE SO AFTER REPLACING WHAT WAS SUPPOSED TO FIX THE ISSUE, DRIVING THE VEHICLE IS THE ONLY WAY TO FIND OUT IF IT IS FIXED. THIS HAS LEAD TO A FEW DANGEROUS CLOSE CALLS. PLEASE LOOK INTO THIS ISSUE BEFORE PEOPLE GET HURT BECAUSE THIS IS A SERIOUS PROBLEM. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/30/2016· ENGINE,FUEL/PROPULSION SYSTEM

  AFTER FILLING UP AT A GAS STATION, THE CAR WILL STALL OUT RANDOMLY AT ALL SPEEDS OF TRAVEL. THIS IS A HUGE SAFETY ISSUE THAT HAS SHT DOWN THE CAR WHILE MERGING ONTO FREEWAY IN FRONT OF SEMI-TRUCKS ONLY TO HAVE POWER STEERING AND PROPULSION STOP. LUCKILY TRUCK WAS PAYING ATTENTION AND HONKED AND SWERVED AROUND, WHILE I RODE OFF ONTO THE SHOULDER. THEN IT RESTARTED, RAN FOR ANOTHER MINUTE AND STALLED AGAIN WHILE TRYING TO GET BACK OFF THE SHOULDER. I ENDED UP LETTING IT IDLE FOR 5 MIN BEFORE BEING ABLE TO MERGE SUCCESSFULLY AND GET HOME. ONLINE I HAVE SEEN MANY PEOPLE SAYING THEY HAVE SAME OR SIMILAR ISSUES WITH THEIR 2006 DODGE VEHICLES AS WELL. PLEASE HELP TO GET THIS RESOLVED AS THIS COULD HAVE VERY WELL KILLED SOMEONE.

• 12/30/2014· ENGINE,FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2006 DODGE CHARGER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED AFTER THE FUEL TANK WAS REFUELED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN INFORMED THAT THE VEHICLE WAS FUNCTIONING AS DESIGNED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 88,000.

• 12/30/2013· FUEL SYSTEM, GASOLINE,ENGINE

  TL* THE CONTACT OWNS A 2006 DODGE CHARGER. THE CONTACT STATED THAT THE VEHICLE WOULD STALL AFTER REFUELING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT WAS ADVISED THAT THE FUEL TANK VALVE WAS DAMAGED AND THE FUEL TANK WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 84,000. UPDATED 02/06/14*LJ

• 12/29/2016· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ELECTRONIC STABILITY CONTROL (ESC)

  WHEN DRIVING ON THE INTERSTATE AT 70 MILES PER HOUR THE CAR STALLED LIKE IT WAS LOOSING POWER AND THE STARTED BACK LIKE EVERYTHING WAS FINE THE CAR STARTED DOING THIS MANY TIMES WHILE DRIVING ALSO WHEN AT A STOP SIGN OR STOP LIGHTS IT WILL JUST DIE MOST THE TIME IT WILL START RIGHT BACK UP OR MAY TAKE A FEW MIN AND WHEN SITTING IN PARK THE OIL LIGHT COME ON AND JUST BEEPS NON STOP THE INTERIOR LIGHTS ALSO WILL FLICKER ON AND OFF WHILE DRIVING. *TR

• 12/29/2015· AIR BAGS

  TL* TAKATA RECALL. THE CONTACT OWNS A 2006 DODGE CHARGER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V313000 (AIR BAGS) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

• 12/29/2011· STEERING,SUSPENSION

  AT CERTAIN SPEEDS MY VEHICLE WILL VIBRATE. GOING OVER SPEED BUMPS OR INTO EVEN THE SLIGHTEST POT HOLE THE VEHICLE WILL VIBRATE. WHEN SLOWING DOWN OR COMING TO A STOP THE FRONT END WILL VIBRATE. TOOK THE VEHICLE TO THE DEALERSHIP AND THEY ADVISED MY FRONT TIRES NEEDED TO BE CHANGED AND/OR ROTATED TO THE BACK DUE TO AN UNUSUAL WEARING ON THE TIRES. THE WEAR WAS ON THE OUTISDE OF THE TIRES. WHEN TOOK THE VEHICLE BACK INTO CHRYSLER DODGE JEEP DEALER SERVICE DEPARTMENT THEY ADVISED I WILL PROBABLY SOON BE NEEDING NEW TIRE ROD ENDS AND THIS IS WHAT MAY HAVE CAUSED MY FRONT TIRES TO WEAR SO EASILY. ESPECIALLY PURCHASING THE CAR USED IN JULY 2010 WITH ALL BRAND NEW TIRES AND NOW NEEDING TO REPLACE ALL FOUR AND ITS ONLY DECEMBER 2011. SERVICE DEPARTMENT MANAGER ADVISED THIS WAS A BIG ISSUE WITH THE EARLY MODEL CHARGERS BUT CHRYSLER STILL HAS YET TO ISSUE A RECALL. I PROLONGED TAKING THE VEHICLE IN TO PURCHASE NEW TIRE RODS. I WENT IN RECENTLY FOR AN OIL CHANGE AND THE SERVICE MANAGER ADVISED ME I NO LONGER NEED TO BE DRIVING MY VEHICLE WITH THE RODS I HAVE ON. IT WAS A RECOMMENDATION EARLIER BUT NOW HE IS HIGHLY ADVISING ME NOT TO DRIVE. WITHIN 3 OIL CHANGES THE RODS HAVE DIMINISHED GREATLY. SOMETHING NEEDS TO BE DONE CHRYSLER IS LETTING THE PURCHASERS TAKE THE BUTT-END OF THIS ISSUE.

• 12/28/2023· ELECTRICAL SYSTEM

  My car has been stalling intermittently. But lately it's becoming more frequent. I've taken it to 3 different repair shops. Diagnostics shows P0700 and U1000 codes. The last shop charged me 150 dollars just to tell me that they don't know what's causing my car to stall. So I'm kind of lost here. Please help me.

• 12/28/2018· ELECTRONIC STABILITY CONTROL (ESC),ENGINE,FUEL/PROPULSION SYSTEM

  CAR WILL SHUT OFF GOING 45 MPH, AT A STOP LIGHT (0 MPH) OR WHEN CROSSING TRAFFIC INTERSECTIONS FOR EXAMPLES (AT MOST GOING 10 OR 15 MPH). I WILL ATTEMPT TO RESTART AND THE CAR WILL START UP, STALL UP AND THEN SHUT OFF AGAIN - WHEN THIS HAPPENS, I LOSE POWER STEERING. I HAVE TO SWITCH GEARS FROM DRIVE TO PARK AND THEN TURN THE CAR OFF AND THEN ON AGAIN IN HOPES IT WILL START. AS YOU'RE DRIVING, YOU CAN FEEL WHEN THE CAR IS ABOUT TO CUT OFF, IT THROTTLES AHEAD A BIT AND REVS, THEN THE CAR BEEPS AND TURNS OFF, WHILE THE GEAR IS IN DRIVE AND TURNING MY WHEEL DOES NOTHING. I NOTICE THAT THIS ISSUE WOULD USUALLY HAPPEN AFTER A FILL UP MY GAS TANK, SO I STARTED ONLY FILLING UP HALFWAY ,BUT THE ISSUE STILL PERSISTS. THIS ISSUE BECAME HEAVILY FREQUENT YESTERDAY WHERE THE CAR STALLED AND CUT OFF AT LEAST 4 DIFFERENT TIMES WHILE MAKING A 7 MILE DRIVE BACK HOME. THIS WAS VERY VERY SCARY IN MY EYES, ESPECIALLY WITH A PASSENGER IN MY SEAT. THIS IS A HUGE SAFETY CONCERN BECAUSE THE VEHICLE IS SHUTTING OFF WHILE IN MOTION AND POWERING STEERING IS LOST. IF THIS HAPPENS ON THE HIGHWAY GOING 60+ MILES PER HOUR, OR TURNING INTO ONCOMING TRAFFIC, THERE IS A GUARANTEED ACCIDENT, POSSIBLY RESULTING IN SERIOUS INJURY OR DEATH. I BELIEVE THERE IS AN ISSUE WITH THE GAS TANK AND THE EVAP CANISTER THAT CAUSES THE SENSORS TO THINK THAT GAS IS OVERFILLING THE ENGINE, WHICH SHUTS OFF THE CAR. THIS WAS FILED UNDER NHTSA PE13-016 (WHICH APPEARS TO BE CLOSED OR INACCESSIBLE- HTTPS://WWW-ODI.NHTSA.DOT.GOV/ACMS/CS/DOCUMENTLIST.XHTML?DOCID=PE13016&DOCTYPE=INV). THIS SAFETY CONCERN REALLY NEEDS TO BE LOOKED INTO.

• 12/28/2011· SUSPENSION

  TL* THE CONTACT OWNS A 2006 DODGE CHARGER. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE WOULD RATTLE WHILE DRIVING OVER BUMPY ROAD SURFACES AT ANY SPEED OVER 5 MPH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT ALL VEHICLES OF A SIMILAR YEAR, MAKE, AND MODEL EXHIBITED THE SAME FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 80,000.

• 12/28/2011· STEERING

  AT 18,500 WE HAD TO REPLACE THE LEFT FRONT OUTER TIE ROD END. NOW AT 33,000 WE ARE BEING TOLD THE SAME THING. I HAVE ON LINE AND SEE THAT THERE ARE QUITE A FEW OTHERS WITH THIS SAME PROBLEM. THIS IS A SERIOUS ISSUE AND WOULD LIKE SOMETHING DONE AS FAR AS A REVIEW OR SOMETHING. ONE GENTLEMAN WAS GOING 55 MPH WHEN HIS BROKE AND THEY CRASHED. I DON'T WANT THIS TO BE ME NOR DO WE HAVE OVER $400 TO PUT TOWARDS THIS CAR EVERY 15K MILES. *TR

• 12/28/2007· POWER TRAIN

  MY 2006 DODGE CHARGER STARTED LEAKING TRANSMISSION FLUID. I TOOK IT TO THE DEALERSHIP, WHERE THEY TOLD ME THE PROBLEM WAS SOME PLUG THAT GOES INTO THE TRANSMISSION PAN. THE SERVICE ADVISOR DIAGNOSED THE PROBLEM WITHOUT EVEN LOOKING UNDER THE CAR, BECAUSE HE SAID THERE HAD OTHER VEHICLES IN FOR REPAIR FOR THE SAME PROBLEM. I DROPPED THE CAR OFF THE FOLLOWING MONDAY FOR REPAIR. THE RECEIPT STATES THAT THEY REPLACED AN O-RING AND BUSHINGS. IT COST ME A LITTLE OVER $153, NOT OVERLY EXPENSIVE FOR WHAT COULD HAVE BEEN A MAJOR PROBLEM HAD THE LEAK NOT BEEN DETECTED AND MORE FLUID LOST. I CHECKED IN ON A FORUM OVER THE WEB AND NOTICED OTHER OWNERS OF THE SAME VEHICLE HAVING THE SAME PROBLEM. I WANTED TO KNOW WHY NO RECALL HAS BEEN FILED FOR THIS. HAVE THERE NOT BEEN ANY OTHER COMPLAINTS CONCERNING THIS? *TR

• 12/27/2017· ELECTRICAL SYSTEM,WHEELS,SERVICE BRAKES

  TL* THE CONTACT OWNS A 2006 DODGE CHARGER. THE CONTACT STATED THAT THERE WERE SEVERAL FAILURES THAT PROGRESSED WITHIN MONTHS OF OWNING THE VEHICLE. THE VEHICLE STALLED SEVERAL TIMES AND THE INSTRUMENT PANEL WARNING INDICATORS AND GAUGES FLICKERED. WHEN THERE WAS A LOSS OF POWER, THE DOORS WOULD AUTOMATICALLY LOCK AND WERE UNABLE TO OPEN. IN ADDITION ,THE BRAKES FAILED TO FUNCTION PROPERLY WHEN APPLIED. AN UNKNOWN DEALER REPLACED THE BRAKES AND THE PINION PINS TWICE DUE TO THE WHEELS ON THE DRIVER'S SIDE BEING AFFECTED DUE TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND THE CONTACT WAS WAITING TO DETERMINE IF THERE WAS AN OPTION TO TRADE IN OR BUY BACK THE VEHICLE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

• 12/26/2018· ENGINE

  I WAS DRIVING HOME FROM WORK, GOING ABOUT 40 MPH ON THE FREEWAY ALL OF THE SUDDEN ENGINE STARTS RUNNING ROUGH. PULLED OVER, TURNED OFF CAR AND WAS NEVER ABLE TO TURN IT ON AGAIN. TOOK IT TO THE MECHANIC.. HE SAID I HAD A BROKEN SEAT VALVE, EVERYTHING DAMAGED...NEED TO REPLACE ENGINE. AFTER LOOKING UP ONLINE IT SEEMS IT IS A KNOWN DEFECT WITH THE HEMI ENGINE FROM 2005-2006.

• 12/26/2013· FUEL SYSTEM, GASOLINE

  WHEN GAS TANK IS FILLED, CAR WILL STALL A FEW BLOCKS LATER. DODGE SAYS THE SENSOR IN THE GAS TANK IS FAULTY AND CAUSES THE SYSTEM TO SUCK GAS BACKWARDS THROUGH THE VAPOR RECOVERY LINES AND DEPOSIT IT INTO THE ENGINE, FLOODING THE CAR. ALL POWER IS LOST TO POWER STEERING, BRAKES, AND DRIVE TRAIN. IF YOU ARE TURNING WHEN THIS HAPPENS, IT IS VERY DANGEROUS AND WILL CAUSE A CRASH. TOTAL LOSS OF CONTROL OVER THE VEHICLE. DEALERSHIP AND DODGE/CHRYSLER ACKNOWLEDGE THE DANGER (I HAVE THE EMAILS TO PROVE IT). THEY SAY IT HAPPENS ALL THE TIME AND THEY WILL ONLY HELP WITH FIXING THE PROBLEM IF YOU (NHTSA) ASKS THEM TO RECALL THE CARS. NOTE THAT THE SENSOR INSIDE THE GAS TANK IS THE PROBLEM. THE PART CAN BE REPLACED, BUT DODGE ONLY SELLS THE ENTIRE GAS TANK AS AN ASSEMBLY, CAUSING INCREASED COST ON THOSE OF US THAT EXPERIENCE THIS PROBLEM. WE ALL ASKING YOU (THE GOVERNMENT) TO HELP KEEP US AND OUR FAMILIES SAFE BY REQUESTING DODGE RECALL VEHICLES AND REPLACE THIS DEFECTIVE DESIGN. THERE IS NO WAY A SIMPLE VAPOR RECOVERY SENSOR INSIDE THE GAS TANK SHOULD CAUSE THE GASOLINE TO FLOW THE WRONG DIRECTION, RESULTING IN A STALL THAT PRODUCES COMPLETE LOSS OF CONTROL OVER THE VEHICLE. IT IS WORSE WHEN PERFORMING TURNS (U-TURNS) OR AT TURNS. THIS IS A DANGER TO PEDESTRIANS, AS THE DRIVER DOES NOT EXPECT SUDDEN LOSS OF ALL POWER STEERING AND BRAKES. THE GAS STATION'S FUEL PUMP CUT OFF AFTER ACCURATELY FILLING THE TANK AND STOPPED WHEN FULL. THE TANK IS NOT OVER-FULL. IT'S A DEFECTIVE DESIGN (ADMITTED BY DODGE) THAT CAUSES GASOLINE TO BE SUCKED UP IN THE WRONG DIRECTION, FLOODING THE ENGINE COMPARTMENT WITH EXCESS FUEL. PLEASE ASSIST THE TAXPAYERS BY KEEPING US SAFE AND RECALLING THE VEHICLES WITH THIS DESIGN TO GET THE PARTS REPLACED WITH ONES THAT WILL NEVER FAULT OUT IN THE SAME MANNER. *TR

• 12/26/2013· VEHICLE SPEED CONTROL,ENGINE

  CAR STALLS AND DIES WHEN ATTEMPTING TO ACCELERATE. HAS OCCURRED MULTIPLE TIMES, AND EACH INCIDENT HAPPENS RIGHT AFTER FILLING THE TANK WITH GASOLINE. *TR

• 12/24/2019· ENGINE

  THE FIRST TIME MY MOTOR FAILED I WAS DRIVING ON THE FREEWAY 70MPH AND SOMEONE CUT ME OFF I HIT THE BRAKES GOOD ENOUGH TO BARELY AVOID THEM CRASHING INTO ME , WHEN I TRIED TO PUSH THE THROTTLE IMMEDIATELY AFTER THE MOTOR STARTED JUMPING BACK AND FORTH LIKE IT WANTED TO JUMP OUT OF THE ENGINE BAY , TOOK IT TO DODGE AND THEY SAID TWO OF MY CYLINDERS WERE ONLY RUNNING AT HALF THE COMPRESSION MEANING I HAD A VALVE ISSUE LIKE THESE CARS ARE WELL KNOWN TO HAVE NOW. WELL $5,000 LATER I GOT MY CAR BACK FROM DODGE WITH ONE HEAD REPLACED , JUST ABOUT 60K MILES LATER THE OTHER HEAD FAILED ON ME AND TRAVELED INTO MY OTHER HEAD DESTROYING THAT ONE AND MY PISTONS , JUST SPENT $9,000 TO HAVE THE MOTOR REPLACED AND NOT EVEN A 1,000 MILES LATER I'M HAVING THE SAME ISSUE . THIS IS UNACCEPTABLE I STILL OWE MONEY ON THE CAR AND I'VE SPENT UPWARDS OF $14,000 TO KEEP THIS CAR RUNNING . IT'S LEFT ME WITH NO WAY TO GET ME TO WORK IT'S LEFT ME STRANDED I'VE LOST A JOB BECAUSE I COULDN'T BE THERE I'VE MISSED OUT ON OPPORTUNITIES IN LIFE BECAUSE OF THIS CAR I'M 23 YEARS OLD AND THIS HAS BEEN GOING ON 4 YEARS NOW . I MAKE MINIMUM WAGE WORK 50HRS A WEEK THIS CAR HAS TAKEN A YEARS WORTH OF SALARY FROM ME AND MADE MY LIFE SO STRESSFUL I CAN NOT STRESS THIS ENOUGH , THIS HAS MADE MY LIFE VERY DIFFICULT IN THESE PAST 4 YEARS ... THE CAR IS CURRENTLY DOWN BECAUSE CYLINDER #2 ONLY HAS ABOUT 90PSI AND I DON'T KNOW WHY TO DO ANYMORE ... I HAVE NO CAR I WALK OR TAKE THE BUS TO WORK EVERYDAY I CAN NOT DO THIS MUCH LONGER ..

• 12/23/2017· FUEL/PROPULSION SYSTEM

  CAR STALL 3-4 TIMES AFTER REFUELING THEN RUNS FINE UNTIL NEXT REFUELING

• 12/23/2013· FUEL SYSTEM, GASOLINE

  ON 12-14-2013, I FILLED UP THE GAS TANK. I PULLED OUT OF THE GAS STATION AND INTO TRAFFIC AND STOPPED AT A RED LIGHT. WHILE AT THE RED LIGHT, VEHICLE STALLED AND OIL LIGHT CAME ON. TURNED THE CORNER AT THE RED LIGHT AND GOT INTO MY PARENTS SUBDIVISION AND VEHICLE STALLED AGAIN. GOT THE VEHICLE STARTED AND PULLED INTO THE DRIVEWAY. ON 12-15-2013, VEHICLE STALLED CLOSE TO PARENTS DRIVEWAY. ATTEMPTED TO RESTART. VEHICLE WOULD NOT START ON FIRST ATTEMPT AND ON THE SECOND ATTEMPT, I HAD TO PRESS THE ACCELERATOR TO START THE VEHICLE. GOT IT STARTED AND PUT THE VEHICLE IN THE DRIVEWAY. NOTIFIED THE DEALERSHIP THE NEXT DAY AND HAD THE VEHICLE TOWED. DEALERSHIP COULD NOT FIND PROBLEM RIGHT AWAY AND I ASKED THEM TO LOOK AT THE ROLLOVER (VENT) VALVE IN THE GAS TANK. THEY CHECKED THE ROLLOVER (VENT) VALVE AND FOUND THAT IT WAS THE PROBLEM. GOT IT REPAIRED AND THE FINAL COST WAS $1446.47. *TR

• 12/22/2019· FUEL/PROPULSION SYSTEM

  BOUGHT THE 2006 DODGE CHARGER. WE FILLED WITH GAS A COUPLE MILES FROM THE DEALER. WHEN LEAVING THE GAS STATION THE CAR STALLED IN FRONT OF ONCOMING TRAFFIC. THANKFULLY, THE OTHER DRIVERS AVOIDED HITTING US UNTIL WE GOT IT RESTARTED. THEN AT HIGHWAY SPEED THE CAR AGAIN STARTED BUCKING AND CHOKING. RESEARCH ONLINE SHOWS THIS TO BE A COMMON ISSUE WITH THIS VEHICLE. THIS IS A DANGEROUS PROBLEM THAT CONCERNS ME GREATLY!

• 12/22/2015· FUEL/PROPULSION SYSTEM

  AFTER FILLING UP WITH GAS, THE CAR STALLS/DIES 2-4 TIMES. RESTARTS RIGHT UP BUT THIS IS A SAFETY ISSUE BECAUSE IT HAS DIED IN HEAVY TRAFFIC, TURNING ONTO OTHER STREETS IN TRAFFIC AND PULLING OUT OF PARKING LOTS INTO TRAFFIC. SEVERE SAFETY ISSUE!

• 12/22/2015· ENGINE

  MY CAR KEEPS STALLING EVEN WHILE DRIVING ABOVE 20 MPH, ESPECIALLY WHILING PULLING OUT INTO TRAFFIC. MY CAR HAS BEEN AT THE DEALERSHIP FOR A MONTH WITH NO RESOLUTION. MY CAR IS NOT SAFE.

• 12/22/2014· ENGINE,FUEL/PROPULSION SYSTEM

  ENGINE STALLS AFTER REFUELING. USUALLY AT IDLE BUT HAS STALLED WHILE MOVING RENDERING POWER STEERING INOPERATIVE. COMMON TO PE 13-016 NHTSA. *TR

• 12/22/2013· FUEL SYSTEM, GASOLINE

  I OWN A 2006 DODGE CHARGER SRT8 WITH ABOUT 31,000 MILES ON IT. I JUST GOT THE VEHICLE ON OCTOBER 25, 2013 AND HAVE ONLY HAD IT FOR A MONTH. A COUPLE WEEKS AFTER I HAD THE CAR, I NOTICED A BIG PROBLEM. MY ENGINE WOULD JUST SHUT OF WHEN I WAS IDLING. USUALLY THIS WOULD HAPPEN WHEN I WAS STUCK IN TRAFFIC, OR AT A RED LIGHT, OR AT A STOP SIGN AT AN INTERSECTION. THE ENTIRE CAR WOULD JUST SHUT DOWN IMMEDIATELY AND I WOULD HAVE NO CONTROL OVER THE VEHICLE. THERE WAS NO WAY OF BEING ABLE TO TELL WHEN THIS PROBLEM WOULD OCCUR BECAUSE THERE WERE NO EARLY WARNING SIGNS SUCH AS CHUGGING OR NOISES COMING FROM THE ENGINE. IT STARTED GETTING REALLY BAD TO THE POINT WHERE I NEED TO GET IT FIXED. I WAS RESEARCHING ONLINE AND READING FORUMS AND FOUND THAT THIS IS A KNOWN PROBLEM WITH CHRYSLER ENGINES OF THIS MODEL. HUNDREDS IF NOT THOUSANDS OF PEOPLE LIKE MYSELF HAVE THE SAME PROBLEM. APPARENTLY, IT IS A FAULTY FUEL VAPOR VALVE ON THE TOP OF THE FUEL TANK. THE ONLY WAY TO REPAIR IT IS TO REPLACE THE ENTIRE FUEL TANK WHICH IS GOING TO COST ME WELL OVER $1000. I WANT TO KNOW WHY THIS ISN'T A SAFETY RECALL AND WHY IT HASN'T BEEN. *TR

• 12/21/2015· AIR BAGS

  TL* TAKATA RECALL. THE CONTACT OWNS A 2006 DODGE CHARGER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V313000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

• 12/21/2014· FUEL/PROPULSION SYSTEM

  AFTER FILLING UP THE GAS TANK VEHICLE WAS RUNNING, SITTING IN TRAFFIC. ENGINE STALLED. VEHICLE TOOK A FEW MINUTES TO RESTART AS IT SAT IN RUSH HOUR TRAFFIC. RESEARCH INDICATES THIS DANGEROUS PROBLEM IS COMMON ON THIS VEHICLE. *TR

• 12/21/2014· FUEL/PROPULSION SYSTEM

  PLEASE REFER TO PE13-016 REGARDING SIMILAR COMPLAINTS. AFTER FILLING CAR WITH GAS LEFT GAS STATION AND CAR STALLED IN TRAFFIC. AFTER A FEW MINUTES CAR STARTED BUT I HAD TO SIT BLOCKING TRAFFIC UNTIL IT STARTED AGAIN. *TR

• 12/21/2010· ELECTRICAL SYSTEM

  SINCE I PURCHASED MY CAR IN 2007 (2ND OWNER) WHILE DRIVING DOWN THE ROAD MY INSTRUMENT PANEL GOES DEAD. I HAVE BROUGHT THIS TO THE DEALERSHIP ON 6 OCCASIONS ONLY FOR THEM TO TELL ME THEY CAN'T DUPLICATE THE PROBLEM. IT IS NOW GOING TO BE 2011 AND THE ELECTRICAL SYSTEM PANEL STILL SHUTS DOWN UNEXPECTEDLY. *TR

• 12/20/2020· POWER TRAIN,ELECTRICAL SYSTEM

  VEHICLE ORIGINAL KEYS WILL ENABLE/DISABLE ALARM, UNLOCK THE DOORS BUT WILL NOT START ENGINE DUE TO A MALFUNCTION IN THE (SKREEM) SENTRY KEY REMOTE ENTRY MODULE INTERNAL AND SKIM. WHEN THE WEATHER BECOMES COLD, THE SKIM MALFUNCTIONS WORST MAKING THE VEHICLE INOPERABLE. B1A28 ECM MISMATCH WITH SKIM B1A35 UNIDENTIFIED KEY COMMUNICATION ERROR B2224 (SKREEM) SENTRY KEY REMOTE ENTRY MODULE INTERNAL P0513 INVALID SKIM KEY

• 12/20/2011· POWER TRAIN

  WHEN ENGAGED IN PARK, WILL NOT DISENGAGE, EVEN WITH USE OF EMERGENCY RELEASE DETENT. WILL ONLY RELEASE WITH USE OF HIDDEN RELEASE AT FRONT OF SHIFTER, AND IF REENGAGED INTO PARK, WILL REOCCUR. *TR

• 12/19/2018· ENGINE,FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2006 DODGE CHARGER. AFTER FILLING THE VEHICLE WITH FUEL, IT STALLED IN TRAFFIC. SOMETIMES THE VEHICLE WOULD RESTART, BUT OTHER TIMES THE CONTACT WOULD HAVE TO CRANK THE VEHICLE SEVERAL TIMES TO RESTART IT WHILE IN TRAFFIC. THE DEALER (STERLING CHRYSLER JEEP DODGE RAM, 5504 I-49 FRONTAGE RD, OPELOUSAS, LA 70570, (337) 942-1241) AND THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE REMAINED PARKED AT THE CONTACT'S HOUSE WITH NO REPAIRS COMPLETED. THE FAILURE MILEAGE WAS 170,000.

• 12/19/2017· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  TWO YEARS AGO I HAD TO REPLACE THE ENGINE WHILE DRIVING THE CAR ALL THE LIGHTS CAME ON AND IT LOST POWER WHILE DRIVING AT APPROXIMATELY 40 MPH. YESTERDAY WHILE ON THE HIGHWAY GOING 65 MPH THE CAR LOST POWER. THIS IS VERY UNSAFE ESPECIALLY ON THE HIGHWAY.

• 12/19/2014· AIR BAGS

  ALTHOUGH THE RECALL HAS BEEN ISSUED, CHRYSLER HAS NOT RELEASED THE REPLACEMENT PARTS TO ANY DEALER IN MY AREA (CENTRAL FLORIDA). FURTHER, THE DEALERSHIPS HAVE NO DATE BY WHICH THEY EXPECT TO RECEIVE THE PARTS. *TR

• 12/19/2013· STEERING,FUEL/PROPULSION SYSTEM

  PROBLEM OCCURRED AND CONTINUES TO OCCUR AFTER FILLING UP THE GAS TANK. FIRST INSTANCE WAS IN NOVEMBER 2010 AND MOST RECENTLY DECEMBER 2013. CAR WILL STALL NUMEROUS TIMES UNTIL SOME AMOUNT OF GAS IS BURNED OFF AFTER DRIVING. FIRST INSTANCE OCCURRED MAKING A TURN IN FRONT OF A RAILROAD TRACK. OTHER INSTANCES HAVE BEEN ON A FREEWAY IN HEAVY TRAFFIC CAUSING ME TO HAVE TO PULL OVER. CAR CAN RESTART ON THE FIRST RE-ATTEMPT OR TAKE UP TO 4 ATTEMPTS. CAR WILL USUALLY STALL AGAIN SECONDS LATER. A WORKAROUND IS NOT TO FILL UP THE TANK ALL THE WAY (TO THE AUTO SHUTOFF OF THE GAS PUMP) BUT THIS DOESN'T ALWAYS WORK. THIS IS WITH A 2006 DODGE CHARGER WITH A 5.7 LITER HEMI. CHRYSLER DENIED THE ISSUE BACK IN 2010 ALTHOUGH THE PROBLEM WAS STARTING TO BE DOCUMENTED ON THE INTERNET AT THAT TIME. *TR

• 12/19/2013· FUEL SYSTEM, GASOLINE,ENGINE

  AFTER FILLING UP GAS TANK, WITHOUT OVER FILLING BY ROUNDING OFF, THE CAR WILL STALL OUT WITHIN 1/4 MILE OF RUNNING. IT TAKES TIME CRANKING ENGINE TO START, THEN WILL BUCK AND STALL OCCASIONALLY UNTIL IT IS DRIVEN AT LEAST 2-3 MILES. ALL POWER STEERING AND BRAKES ARE LOST AT THIS TIME AS WELL. *TR

• 12/19/2011· POWER TRAIN

  VEHICLE WILL NOT COME OUT OF PARK DUE TO FAILED SHIFT INTERLOCK MECHANISM. SHIFT INTERLOCK FAILS DUE TO A 1/8 INCH TAB BREAKING OFF AND RELEASING THE SPRING NOT ALLOWING THE DRIVER TO TAKE THE VEHICLE OUT OF PARK. THE VEHICLE STILL STARTS BUT WILL NOT MOVE. THIS PROBLEM WILL MAKE IT APPEAR THIS SOMETHING WRONG WITH THE VEHICLES TRANSMISSION. THIS HAS HAPPENED WITH SEVERAL DODGE CHARGER(S) AND CHRYSLER 300 VEHICLES. EXAMPLES CAN BE FOUND ON WWW.YOUTUBE.COM. RECOMMEND FAILED MECHANISM BE REPLACED BY PART : DORMAN 924-706. MAN PEOPLE HAVE COMPLAINED ABOUT REPAIRS FOR THIS ITEM, WHICH SHOULD BE COVERED UNDER A MANUFACTURES RECALL. THANK YOU. HAPPY HOLIDAYS *TR

• 12/18/2013· FUEL SYSTEM, GASOLINE

  CONTINUES TO STALL AFTER GAS FILL-UP IN TRAFFIC CAUSING OTHER CARS TO DODGE TO RIGHT OF LEFT TO AVOID COLLUSION. MAKES FOR DANGEROUS DRIVING AFTER FILL-UP. APPARENTLY MANY OTHER CHARGER OWNERS ARE HAVING THE PROBLEM AT AN INCREASING RATE. THIS IS SOMETHING CHRYSLER SHOULD LOOK INTO BEFORE PEOPLE GET INJURED OR WORSE! THIS IS WELL DOCUMENTED ON THE INTERNET. *TR

• 12/18/2013· STEERING,ENGINE

  VEHICLE STALLED MULTIPLE TIMES WHILE COMING TO A STOP. HARD TO START AFTER STALLING. JUST FILLED THE GAS TANK, AND CAR STALLED TWO OR THREE TIMES GETTING FROM THE GAS STATION TO HOME. CAR STALLED THE NEXT MORNING THREE TIMES, AGAIN HARD TO START. *TR

• 12/18/2012· ENGINE

  TL* THE CONTACT OWNS A 2006 DODGE CHARGER. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, A LOUD CLICKING NOISE COULD BE HEARD AS THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE ENGINE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 88,000.

• 12/17/2018· ELECTRICAL SYSTEM,ENGINEFire

  MY SON'S CAR CAUGHT FIRE AFTER HE HAD PARKED IT FOR THE NIGHT. AFTER 10 MINUTES HE WAS CALLED AT HIS APARTMENT BY A FRIEND WHO TOLD HIM HIS CAR WAS ON FIRE. THERE WERE NO WARNING SIGNS WHATSOEVER. NO WARNING LIGHTS, UNUSUAL SMELLS, OR HINTS OF IMPENDING DOOM FOR HIS CAR.

• 12/17/2014· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2006 DODGE CHARGER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS REFUELED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL TANK SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 81,000.

• 12/17/2013· ENGINE

  THE CAR STALLED A NUMBER OF TIMES IN TRAFFIC. I HAD JUST FILLED THE TANK. *TR

• 12/17/2013· ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE

  MY CAR STALLS AFTER EVERY FILL UP FOR FUEL. I LATER DISCOVERED THIS WAS A COMMON COMPLAINT CAUSING RANDOM FIRES AS WELL AS REAR END COLLISIONS FROM STALLING ONTO FREEWAYS . I PAID $40K FOR THIS VEHICLE. MANUFACTURER NOR EXTENDED WARRANTY COVERS THIS COSTLY AND DANGEROUS DEFECT. I WOULD LIKE FOR THIS PROBLEM TO BE RECTIFIED BY A MANUFACTURES' RECALL OR CONSUMER REIMBURSEMENT. PLEASE CONTACT ME AT [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/17/2013· FUEL/PROPULSION SYSTEM

  AFTER FUELING MY VEHICLE, I WAS TRAVELING AT APPROXIMATELY 20 MPH AROUND A CORNER AND THE VEHICLE STALLED AND DIED. ONCE THE ENGINE DIED, I WAS UNABLE TO STEER AND HAD TO HARD BREAK TO AVOID GOING INTO THE OTHER LANE OF TRAFFIC AND NARROWLY AVOIDED MISSING THE ONCOMING VEHICLE IN THE OTHER LANE. ONCE I WAS STOPPED I ATTEMPTED TO RESTART THE VEHICLE, IT CONTINUED TO STALL THREE MORE TIMES WHEN I ATTEMPTED TO PUT THE VEHICLE IN DRIVE. I WAS STUCK IN THE MIDDLE OF THE ROAD, ON A CORNER WITH LITTLE VISIBILITY. I WAS FINALLY ABLE TO RESTART THE VEHICLE ON THE FOURTH ATTEMPT. I WAS ABLE TO DRIVE A COUPLE MILES TILL I STOPPED AT A TRAFFIC LIGHT. THE VEHICLE STALLED AND DIED AGAIN RIGHT AS THE LIGHT TURNED GREEN. I AGAIN HAD TO RESTART THE VEHICLE THREE TIMES BEFORE IT WOULD STAY RUNNING. THERE WERE MULTIPLE VEHICLES BEHIND ME AT THE LIGHT, THANKFULLY THEY HAD COME TO A STOP BEFORE I STALLED. THIS HAS HAPPENED IN THE PAST, BUT IT IS GETTING WORSE AND I NO LONGER FEEL IT IS SAFE TO DRIVE. I HAVE TAKEN IT TO THE DEALER AND WAS INFORMED THAT THERE IS A KNOWN ISSUE WITH THE FUEL SYSTEM. THE COST FOR THIS REPAIR IS OVER $2,000 AND THERE IS NO MANUFACTURERS RECALL AT THIS POINT. IT IS MY OPINION THAT THIS IS NOT A WEAR ITEM, IT IS A MANUFACTURING DEFECT. THIS IS MY FAMILY CAR, AND I DO NOT FEEL SAFE DRIVING WITH MY CHILDREN AS THERE IS A GREAT RISK TO THEIR SAFETY. *TR

• 12/17/2012· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2006 DODGE CHARGER. THE CONTACT STATED THAT AFTER REFUELING, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED IMMEDIATELY AND WAS TAKEN TO A MECHANIC WHERE THE CONTACT WAS ADVISED THAT THE FUEL TANK MAY HAVE BEEN THE CAUSE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED SEVERAL TIMES AFTER THE INITIAL REPAIR. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000 AND THE CURRENT MILEAGE WAS 65,807. THE VIN WAS NOT AVAILABLE.

• 12/17/2010· TIRES

  ON MY 2006 DODGE CHARGER R/T I HAD A LOW TIRE PRESSURE LIGHT. I TRIED TO REMOVE THE TIRES VALVE STEM COVER AND THE VALVE STEM WHICH IS AN INTEGRAL PART OF THE TIRE PRESSURE SENSOR BROKE IN HALF WHICH DEFLATED MY TIRE COMPLETELY WITHIN 10 SECONDS. 3 OUT OF 4 VALVE STEMS DID THIS. AFTER CONTACTING MY LOCAL DEALER THEY TOLD ME THAT THIS IS A REALLY BIG PROBLEM NOT ONLY WITH THE CHARGER MODEL BUT ALL OF THE MODELS. IF THIS VALVE STEM BROKE OFF DURING DRIVING YOU WOULD HAVE NO WARNING AND AN IMMEDIATE AND COMPLETE LOSS OF TIRE PRESSURE COULD OCCUR. WHICH COULD LEAD TO A LOSS OF CONTROL, ESPECIALLY IF IT WAS IN THE FRONT DURING THE WINTER LIKE IT IS NOW. LUCKILY MINE BROKE WHILE IN THE GARAGE. *TR

• 12/17/2010· STEERING

  THE VEHICLE DESCRIBED IN THIS FORM HAS HAD THE RIGHT TIE ROD ENDS REPLACED TWICE WITHIN A YEAR BY A CERTIFIED DODGE DEALERSHIP USING MOPAR PARTS. 4/15/2010 THE RIGHT TIE ROD END WAS REPLACED WITH TIE ROD END PART NUMBER 52013468-AC AND HEX NUT PART NUMBER 6505623-AA WITH ONLY 29,458 MILES ON THE VEHICLE. 12/16/2010 THE RIGHT TIE ROD END WAS REPLACED WITH TIE ROD END PART NUMBER 52013468-AD AND HEX NUT PART NUMBER 6505623-AA WITH ONLY 38,954 MILES ON THE VEHICLE. THE DEFECTIVE RIGHT TIE ROD ENDS WERE FOUND DURING ROUTINE MAINTENANCE PERFORMED PRIOR TO A FRONT END ALIGNMENT.