2006 Chevrolet Silverado

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2012· AIR BAGS

  THE MODULE ON THE FRONT BUMPER HAS BECOME DEFECTED AND THEREFORE THE AIR BAGS WILL NOT GO OFF DURING A COLLISION. *TR

• 12/31/2011· SERVICE BRAKES, HYDRAULIC

  BRAKE LINES THROUGH OUT TRUCK ARE ROTTING. *KB

• 12/30/2009· POWER TRAIN

  2006 CHEVY SILVERADO 2500HD HAS DEVELOPED A TRANSMISSION COOLER LINE LEAK AT THE METALLIC COUPLER. VEHICLE ONLY HAS LESS THAN 50K MILES UNDER LIGHT LOAD CONDITIONS. NEVER TOWED ANYTHING OVER 3KLBS. I UNDERSTAND THIS IS A VERY HIGH FAIL ITEM AND EVEN THEIR IMPROVED LINES ARE LEAKING AS WELL. THIS SHOULD BE A RECALL ITEM AND REPLACED AT NO COST TO THE CUSTOMER. *TR

• 12/30/2008· VISIBILITY

  AT FIRST #5 ON HEATER QUIT WORKING. SOME TIMES IT WORKED OTHER TIMES IT WOULD NOT. I NOTICED A GLOW UNDER THE DASH AND SMELLED BURNT PLASTIC. I CHECKED THINGS OUT THE CONNECTOR HAD MELTED AND GLOWED WHEN THE HEATER WAS ON. IT THREW SPARKS WHEN I SWITCHED TO THE 5 POSITION. THE BLOWER STILL WORKED EVEN THOUGH IT WAS ABOUT TO CATCH FIRE, WHY DOESN'T IT BLOW A FUSE? THIS IS NOT SAFE. LUCKY I KEEP MY TRUCK CLEAN AND DON'T HAVE CARPET, IT WOULD HAVE PROBABLY CAUGHT FIRE. *TR

• 12/29/2010· ELECTRICAL SYSTEM

  TL*THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE PARKED, THE CONTACT NOTICED THAT ALL THE LIGHTS ON THE INSTRUMENT PANEL WERE NOT WORKING. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 42,000.

• 12/29/2009· SUSPENSION,SERVICE BRAKES, HYDRAULIC

  TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING 50 MPH HE HEARD A GRINDING SOUND FROM THE FRONT-END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND HE WAS ADVISED THAT THE HUB AND BEARING ASSEMBLY FAILED. THE VEHICLE WAS REPAIRED AT AN EXPENSE OF $432.41. THE FAILURE MILEAGE WAS 48985. THE CURRENT MILEAGE WAS 49000. UPDATED 01/29/10.*LJ THE CONSUMER STATED WHEN THE GRINDING STARTED, THE VEHICLE PULLED TO THE RIGHT. ALSO, THE ABS ACTIVATED UNDER NORMAL DRIVING CONDITIONS. UPDATED 01/29/10.*JB

• 12/28/2015· AIR BAGS,SEATS

  TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. AS SOON AS THE VEHICLE WAS STARTED, THE DRIVER'S SEAT HEATED UP AUTOMATICALLY. WHEN THE VEHICLE WAS TURNED OFF, THE SEAT HEATER ACTIVATED ON HIGH. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED AND REMAINED ON FOR THE PAST TWO WEEKS. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 105,647.

• 12/27/2015· SERVICE BRAKES

  BRAKE LINE FAILURE DUE TO EXCESSIVE CORROSION AS THE LINES LAY ON THE FRAME. LUCKILY, THE BREAK WAS AT HOME AND I WAS ABLE TO GET IT INTO THE SHOP FOR REPAIR. LESS THAN A MONTH LATER, ANOTHER LINE BROKE AS I WAS PULLING INTO MY DRIVE.

• 12/27/2006· POWER TRAIN

  THE VEHICLE MAKES A HIGH PITCH NOISE WHILE LIGHTLY ACCELERATING. IT STRONGLY APPEARS TO BE COMING FROM THE TRANSMISSION. THE DEALERS TO DATE HAS REFUSED TO ACKNOWLEDGE THIS PROBLEM WITH MY VEHICLE. I HAVE HAD THIS COMPLAINT SINCE THE FIRST WEEK OF PURCHASING THE VEHICLE. I PRESENTLY HAVE 2200 MILES. *JB

• 12/26/2020· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,SERVICE BRAKES

  THE INTERIOR LIGHTS ON THE GAUGES ALL TURN OFF MAKING IT HARD TO SEE THE SPEED LIMITS. BRAKES SOUND AS IF GRINDING BUT CANT TELL IF ITS BRAKES OR DIFFERENTIAL AND U JOINTS. NOISE GETS LOUDER IN THE CABIN OF THE TRUCK AS I DRIVE ON THE ROAD. 3. SIGNAL LIGHTS TURN ON BRIGHT WHILE ON LEFT HAND TURN SIGNAL. AND CIGARETTE LIGHTER AND OTHER COMPONENTS WONT WORK

• 12/26/2013· SERVICE BRAKES

  TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED WHILE DRIVING 20 MPH, HE DEPRESSED THE BRAKE PEDAL BUT THE VEHICLE DID NOT STOP IMMEDIATELY. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 52,000. THE VIN WAS UNAVAILABLE.

• 12/24/2010· POWER TRAIN

  2006 CHEVY SILVERADO HD DIESEL WITH ALLISON TRANS-- TRANSMISSION COOLER LINES LEAKING, DEALER SAID THERE HAS BEEN NO KNOWN PROBLEM. I SEARCHED ONLINE AND FOUND HUNDREDS OF SIMILAR COMPLAINTS. SO I WAS FORCED TO PAY $700 TO HAVE THE LINES REPLACED, WHICH WILL PROBABLY END UP LEAKING AGAIN. THIS IS OBVIOUSLY A DEFECT, AS I HAVE 3 OTHER CHEVY TRUCKS, NONE OF WHICH HAVE EVER LEAKED FROM THE TRANS LINES, AND SOME ARE OVER 10YRS OLD. *TR

• 12/22/2024· POWER TRAIN,FUEL/PROPULSION SYSTEM

  The auxiliary transmission fuel pump system is prone to failure. This makes it so the start/stop feature will not work, as the vehicle will stall when stopped (causing an unsafe situation), and it cannot pass state inspection. The part is entirely unavailable from Chevy, and results in the vehicle being scrapped. There is no way to permanently bypass this system.

• 12/22/2013· SERVICE BRAKES

  BRAKE FAILURE WHEN STEPPING ON BRAKES ON HIGHWAY. STEEL BRAKE LINE FROM FRONT TO REAR BRAKES RUPTURED AND PEDAL WENT TO FLOOR WITH NO WARNING. FROM READING ON WEB THIS IS A COMMEND PROBLEM WITH CORROSION ON BRAKE LINES DUE TO POOR QUALITY MATERIALS USED IN MANUFACTURING. *TR

• 12/22/2008· FUEL SYSTEM, OTHER

  TL*THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 3500. WHILE DRIVING 60 MPH, THE VEHICLE GOES INTO SAFETY MODE. THE VEHICLE DROPS TO 20 MPH WITHOUT WARNING AND CANNOT GO ANY FASTER. THE VEHICLE WAS TOWED TO THE DEALER OVER SIXTEEN TIMES AND THEY STATED THAT THE FUEL FILTER WAS THE CAUSE OF THE FAILURE, IN ADDITION TO THE TYPE OF FUEL THAT WAS BEING USED. THE CONTACT STATED THAT HE HAS BEEN USING THE SAME GAS AND GRADE SINCE HE PURCHASED THE VEHICLE. HE ALSO PLACED DIFFERENT ADDITIVES INTO THE TANK TO STOP THE FAILURE, BUT IT STILL PERSISTS. THE FAILURE MILEAGE WAS 42,700.

• 12/22/2005· ELECTRICAL SYSTEM

  DT: THE CONTACT STATED THE INSTRUMENT CLUSTER DID NOT WORK AT ALL. THE MANUFACTURER WAS CONTACTED, AND ADVISED THE CONTACT TO BRING THE VEHICLE TO A GM DEALERSHIP FOR SERVICE. THE CAUSE OF THE PROBLEM WAS UNDETERMINED.

• 12/21/2010· SERVICE BRAKES, HYDRAULIC,EQUIPMENT

  ABS BRAKES ACTIVATE AT A VERY LOW SPEED ALMOST WHEN SLOWING TO A STOP. I'M AFRAID IM GOING TO REAR END SOMEONE. DEALER CANT FIND ANY PROBLEMS. WHEN WILL THIS BE A RECALL???? *TR

• 12/20/2015· SERVICE BRAKES

  LOST BRAKES WHILE DRIVING IN RESIDENTIAL NEIGHBORHOOD DUE TO RUSTED BRAKE LINE. HAD IT TOWED TO MY MECHANIC WHO DID AN INSPECTION AND SAID ALL THE BRAKE LINES WERE RUSTED AT THE BRACKETS HOLDING THE LINES. MY MECHANIC IS IN THE PROCESS OF REPLACING THE BRAKE LINES. I TALKED TO SEVERAL OTHER PEOPLE WITH THE SAME YEAR TRUCK AND BOTH HAD ALSO EXPERIENCED BRAKE LINE FAILURE FROM RUST. TRUCK HAS ONLY 20K MILES AND HAS ONLY BEEN IN THE SALT TWICE AS I HAD AN OLDER VEHICLE I USED WHEN IT SNOWED. GM NEEDS TO CORRECT THIS SAFETY DEFECT.

• 12/19/2019· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  RANDOMLY MY TRUCK WILL GO IN ENGINE POWER REDUCED AND TOP SPEED IS 35 MPH. IT HAPPENED A COUPLE OF TIME ON THE INTERSTATE. THE CODE THAT POPS UP IS P2135 AND I LOOKED IT UP ON LINE. THE INTERNET IS FULL OF FORMS AND VIDEOS ABOUT THIS PROBLEM. EVERYTHING ON THE INTERNET POINTS TO THE THROTTLE POSITION SENSOR. I'VE REPLACED IT TWICE AND REPLACED THE THROTTLE BODY TWICE AND WIRING TWICE. I PUT TRUCK IN THE SHOP THREE TIMES. SPENT A GOOD $1500 TRYING TO FIX THE PROBLEM AND IT STILL POPS UP EVERY COUPLE OF MONTHS.

• 12/19/2013· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE DRIVING 25 MPH AFTER REFUELING, HE NOTICED FUEL LEAKING FROM THE FRONT FUEL TANK. THE CONTACT MENTIONED THAT HE COULD HEAR THE REAR PUMP RUNNING AND WHILE ATTEMPTING TO INSPECT THE FUEL CAB, IT SPEW DIESEL ALL OVER HIM. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 52,621.

• 12/18/2008· FUEL SYSTEM, DIESEL

  MY CHEVY DIESEL PICK-UP TRUCK DIES FOR 2-3 SECONDS WHEN DRIVING AT MEDIUM SPEEDS (50MPH) AND I FLOOR THE THROTTLE. 2 DEALERS HAVE TOLD ME THIS IS NORMAL, IT IS A LAG DUE TO THE TURBO. EVERYONE ELSE I TALK TO THAT HAS THIS TRUCK TELLS ME THEY HAVE THE SAME PROBLEM. HOWEVER, FORD AND DODGE DIESEL TRUCKS WITH TURBOS DO NOT HAVE THIS PROBLEM UNLESS THE TURBO IS DEFECTIVE. ALSO I HAVE BEEN TOLD BY SOME PEOPLE WHO ADD A CHIP AND ADJUSTED SUCH THINGS AS SHIFT POINTS ETC. THIS PROBLEM GOES ALWAYS IN 45 YEARS OF DRIVING MANY VEHICLES I HAVE NEVER ENCOUNTERED SUCH A SAFETY ISSUE. THIS NEEDS TO BE CORRECTED. *TR

• 12/18/2006· FUEL SYSTEM, GASOLINE

  TL*- THE CONTACT STATED THE VEHICLE WAS IDLING LOW. THE VEHICLE HAS BEEN TAKEN TO A REPAIR SHOP TO BE ADJUSTED ONCE. SINCE THE ADJUSTMENT THE GAS MILEAGE HAS GOTTEN WORST. HE SAID THE VEHICLE IS RUNNING AT ABOUT 1000 RPM TO WARM UP.

• 12/17/2010· SERVICE BRAKES, HYDRAULICCrash

  2006 CHEVY SILVERADO [ONLY 20K MILES] 16K ABS ACTIVATION AT LOW SPEED - DEALER REPLACED ROTORS, PADS, SENSORS 18K LOW SPEED ACCIDENT - SUSPECT ABS PROBLEMS 20K ABS ACTIVATION AT LOW SPEED - GRINDING NOISE SEVERAL OCCASIONS OF POOR STOPPING RESPONSE DURING OWNERSHIP. *TR

• 12/17/2009· TRACTION CONTROL SYSTEM

  TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE TRACTION CONTROL SYSTEM ACTIVATES WITHOUT WARRANT. WHEN THE FAILURE OCCURS THE VEHICLE WILL NOT ACCELERATE. HE WAS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER FOR INSPECTION. THE FAILURE MILEAGE WAS 41,810. UPDATED 01/1410 *BF UPDATED 01/20/10*JB

• 12/17/2009· SERVICE BRAKES, HYDRAULIC

  TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. DURING BRAKE APPLICATION THE ABS SYSTEM ENGAGED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE FRONT ABS SENSOR WERE CLEANED AND THEN REPLACED AT AN EXPENSE OF $270.00. THE FAILURE MILEAGE WAS 43,642.

• 12/17/2009· SERVICE BRAKES, HYDRAULIC

  TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE DRIVING 25 MPH THE ABS WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, AND THEN THERE WAS A LOUD NOISE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE TECHNICIAN STATED THAT THE WHEEL SPEED SENSOR WOULD HAVE TO BE CLEANED. SINCE THE REPAIR, THE SENSORS WERE CLEANED FOUR TIMES. THE REPAIRS HAVE NOT REMEDIED THE FAILURE. THE FAILURE MILEAGE WAS 22,300.

• 12/15/2009· SERVICE BRAKES, HYDRAULIC

  REF: 2006 SILVERADO Z71. THE ABS SYSTEM ON MY VEHICLE ROUTINELY ENGAGES (RELEASES BRAKE PRESSURE) DURING SLOWDOWN IN THE 3-8 MPH SPEED RANGE. THIS ENGAGEMENT REQUIRES LONGER STOPPING DISTANCES AND CAN LEAD TO DANGEROUS SITUATIONS IN THE LAST PORTION OF A STOP. THIS SAFETY ISSUE WITH MY 2006 VEHICLE IS IDENTICAL TO THE ONE NHTSA IDENTIFIED FOR THESE SAME TYPE VEHICLES 2005 AND PRIOR. ALTHOUGH MAINTENANCE HAS NOT BEEN ACCOMPLISHED ON MY VEHICLE YET, I BELIEVE IT IS THE SAME SAFETY ISSUE AS EARLIER MODELS. *TR

• 12/14/2016· SERVICE BRAKES

  BRAKE LINES ROTTED/RUSTED OUT ,FRONT TO BACK. FLUID LEAKED OUT EVERYWHERE. HAD TO DRIVE TEN MILES PER HOUR ,BUT MADE IT HOME FROM WORK SAFELY! ($950 REPAIR BILL). THANK YOU GENERAL MOTORS. MY NEXT TRUCK WILL BE A FORD. *TR

• 12/14/2007· STEERING,SERVICE BRAKES, HYDRAULIC

  VEHICLE SAT AT THE AIRPORT FOR 72HRS. WHEN I LEFT THE AIRPORT, THE BRAKES FELT SPONGY, BUT WERE ABLE TO STOP THE VEHICLE. ON THE FREEWAY AS I WAS BRAKING, THE BRAKES BEGAN TO FEEL MORE SPONGY, REQUIRING INCREASED STOPPING DISTANCE. WHEN I ARRIVED AT MY RESIDENCE APPROXIMATELY 45 MILES FROM THE AIRPORT, I TRIED TO TURN INTO MY DRIVEWAY, ONLY TO FIND I HAD LOST ALL POWER STEERING ASSIST AND BRAKING ASSIST. I WAS ABLE TO FINALLY TURN IN, BUT HAD TO USE MY EMERGENCY BRAKE TO COME TO A FULL STOP. ONCE, STOPPED, I FOUND I COULD NOT TURN THE STEERING WHEEL AND THERE WERE NO BRAKES. I OPENED THE POWER STEERING RESERVOIR CAP, WHICH IMMEDIATELY SPEWED A FEW OUNCES OF P/S FLUID OVER THE ENGINE COMPARTMENT, FORTUNATELY NOT ON THE HOT EXHAUST. DEALER HAD THE VEHICLE TOWED 2 MILES TO THEIR DEALERSHIP WHERE THEY CLAIMED THEY COULD NOT DUPLICATE THE PROBLEM. HOWEVER, THEY DID KEEP IT OVER NIGHT AND DECIDE TO CHANGE A P/S PRESSURE RELIEF VALVE EVEN THOUGH THEY COULD NOT DUPLICATE ANYTHING. I FILED A COMPLAINT TO GM WITHOUT ANYONE TAKING THIS SERIOUS SAFETY ISSUE AS A REAL PROBLEM. THIS SAFETY ISSUED MUST BE ADDRESSED AND THE ROOT CAUSE MUST BE FOUND BEFORE SERIOUS INJURY/DEATH OCCURS DUE TO THIS PROBLEM. *TR

• 12/14/2006· STEERING

  THE INTERMEDIATE SHAFT ON THE STEERING WHEEL COLUMN IS LOOSE. THE DEALER AND MANUFACTURER HAVE TOLD ME THAT THEY ARE AWARE OF THIS PROBLEM, BUT THERE IS NO FIX FOR IT. THE FRONT END ON THE VEHICLE WILL FEEL LOOSE AND BOUNCE WHILE DRIVING OVER UNEVEN PAVEMENT AND BUMPS AND MORE SO WHILE DRIVING ON FREEWAYS. THE VEHICLE FEELS UNSAFE. ALL THE DO IS PUT MORE LUBE IN THE SHAFT AND TELL ME I HAVE TO DEAL WITH IT. I AM HAVING AN ARBITRATION HEARING. HOPEFULLY SOMETHING GOOD WILL COME OUT OF IT. *JB

• 12/13/2013· SERVICE BRAKES, HYDRAULIC,FUEL/PROPULSION SYSTEM

  BRAKE LINES RUSTED COMPLETELY THROUGH AND BLEW OUT WHILE BRAKING AND LOST ALL PRESSURE. FUEL LINES ARE SEVERELY RUSTED. *TR

• 12/13/2011· SERVICE BRAKES, HYDRAULIC

  ABS SENSOR(S) OPERATE WHEN SLOWING TO A STOP REGARDLESS OF ROAD CONDITIONS. THIS INITIALLY HAPPENED ONLY OCCASIONALLY BUT NOW IS NEARLY CONSTANT AND REPAIR IS NEEDED. GM DEALER INITIALLY HAD NO CLUE OF WHAT WAS HAPPENING BUT ALSO FOUND PLAY IN RIGHT FRONT HUB, INTERNET SEARCH SHOWS MANY DRIVERS WITH SAME PROBLEMS IN SENSORS AND HUBS BUT NO RECALL FROM GM. WHY? *TR

• 12/13/2010· POWER TRAIN

  TRANSMISSION COOLANT LINE LEAKING. *TR

• 12/12/2013· SERVICE BRAKES

  DESCENDING SMALL HILL TO MAKE TURN AND BRAKES FAILED. WAS ABLE TO GET VEHICLE STOPPED, BUT WAS IN-TOWN SITUATION AND VERY DICEY FOR A FEW MOMENTS. INVESTIGATION REVEALED ROTTED BRAKE LINE(S). REPAIRED REAR LINES FOR $500 . . WAS FRI AFTERNOON AND 100 MILES FROM HOME AND COULDN'T GET BRAKES REPAIRED UNTIL TUES. MECHANIC SAID ALL LINES SHOULD BE REPLACED AND I AGREED FRONT LINES STILL NEED DOING. $300-500. I HAVE HAD THE LOW SPEED ABS ISSUE IN THIS VEHICLE AS WELL. THIS IS AN ISSUE THAT IS WAY PREMATURE! THIS IS A SERIOUS SAFETY ISSUE AND GM NEEDS TO STEP UP! IT'S OBVIOUSLY COMMON. PEOPLE WILL BE KILLED OR SERIOUSLY INJURED. BUT THE PERSON KILLED WON'T BE WRITING THIS LETTER, EH? NHTSA--WHERE ARE YOU? *TR

• 12/12/2007· AIR BAGSCrash

  TL*THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE DRIVING BETWEEN 35-40 MPH, THE FRONT AIR BAGS FAILED TO DEPLOY DURING A FRONT END CRASH. GENERAL MOTORS HAS NOT BEEN NOTIFIED. THE CONTACT SUSTAINED BRUISING AND A SPRAINED ANKLE. HER DAUGHTER SUSTAINED A SEVERELY BRUISED HIP AND HER SON IS EXPERIENCING SEVERE MUSCLE ACHES. THE POLICE WAS CALLED TO THE SCENE AND A REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 43,000.

• 12/11/2012· SERVICE BRAKES

  AT LOW SPEEDS WHEN COMING TO A STOP, THE ABS WILL ACTIVATE FOR NO REASON. APART FROM BEING AN ANNOYANCE, THIS ALSO CAUSES A LONGER STOPPING DISTANCE WHICH POSES A HAZARD IF THERE IS ANOTHER VEHICLE IN FRONT OF YOU. THE RIGHT SENSOR WAS REPLACED IN 3/2011 AND THE LEFT SENSOR WAS REPLACED IN 11/2012. IT SEEMS ODD THAT BOTH WOULD FAIL AND JUDGING BY THE NUMBER OF COMPLAINTS FOR THE SAME ISSUE LISTED ON HERE AND MULTIPLE OTHER WEBSITES, I THINK IT'S TIME FOR GM TO STEP UP AND ADMIT A CONTINUED PROBLEM WITH THIS. THERE WAS A RECALL FOR THIS ISSUE UP TO 2002, I THINK IT'S TIME IT IS EXTENDED. *TR

• 12/10/2011· ENGINE AND ENGINE COOLING

  BOLT HEAD IS SNAPPED OFF ON THE LEFT EXHAUST MANIFOLD ON THE REAR MOST BOLT. I KNOW OF MANY OTHERS WHO HAVE THIS SAME PROBLEM AND I BELIEVE THAT THEIR SHOULD BE A RECALL ON THE DEFECTIVE BOLTS USED IN THESE VEHICLES. *TR

• 12/10/2010· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT AS HE STARTED THE VEHICLE, THE CHECK ENGINE LIGHT WAS ILLUMINATED AND THERE WAS AN UNUSUAL INCREASE IN ENGINE RPMS. THEN, ALL OF THE GAUGES ON THE INSTRUMENT PANEL BEGAN FLUCTUATING ABNORMALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE TECHNICIAN ADVISED THE CONTACT THAT THE INSTRUMENT CLUSTER WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 69,780. UPDATED 02/07/11 *BF UPDATED 02/14/11

• 12/10/2009· POWER TRAIN

  PURCHASED A NEW TRUCK IN 2006. THE TRUCK HAD JUST OVER 42000 ORIGINAL MILES. THE TRUCKS WARRANTY WAS 3 YEARS 36 MILES. AND THE TRANSMISSION IS SHOT WHICH CHEVY IS DOING ABSOLUTELY NOTHING. THE TRANSMISSION SHOP IS TELLING ME THIS IS A REALLY ODD INCIDENT AND THAT I SHOULD FILE A COMPLAINT WITH YOU. *TR

• 12/08/2024· STEERINGFire

  hi the power steering hose failed and caused a fire and total loss

• 12/08/2020· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  THE PASSLOCK LIGHT COMES ON AND THE TRUCK WON'T START. THE INTERIOR LIGHTS GETS BRIGHT THEN DIM. BACK AND FORTH. WHEN THE PASSLOCK COMES ON IT WILL KEEP THE TRUCK FROM STARTING FOR DAYS AT A TIME. I'M AFRAID TO DRIVE THE TRUCK ANYWHERE

• 12/08/2016· SERVICE BRAKES

  WAS DRIVING VEHICLE ON US 131 IN HOLLAND MI. I WAS TRAVELING AT APPROX 50MPH WHEN I HAD TO BRAKE FOR STOPPED TRAFFIC AHEAD. VEHICLE BEGAN TO SLOW WHEN SUDDENLY BRAKE PEDAL FELL AND I LOST MUCH OF MY BRAKING. HAD TO VEER OFF TO THE SHOULDER OF THE ROAD TO AVOID POSSIBLE COLLISION WITH STOPPED TRAFFIC. WHEN I PULLED OVER TO INSPECT MY TRUCK, I NOTICED FLUID DRIPPING FROM THE FRAME RAIL NEAR THE FUEL TANK. IT WAS BRAKE FLUID. THE BRAKE LINE THAT GOES FROM THE ABS UNIT TO THE REAR BRAKE HOSE WAS RUSTED THROUGH AND LEAKING. THIS IS A 10YR OLD TRUCK WITH ONLY 122000 MILES ON IT. I DON'T BELIEVE THIS TYPE OF FAILURE IS ACCEPTABLE FOR A VEHICLE OF THIS AGE AND MILEAGE. I WAS ABLE TO CAREFULLY DRIVE THE TRUCK HOME AND PARKED IT. I CONTACTED MY LOCAL DEALER SERVICE MANAGER, WHO COULD ONLY REPAIR IT AT MY EXPENSE. I GOT GENERAL MOTOR CUSTOMER ASSISTANCE # FROM HER AND CONTACTED THEM. THEY OPENED A CASE, #8-2572108769, AND SAID THEY ALSO WOULD DO NOTHING TO ASSIST IN THE REPAIR OF THIS CONDITION. THEY ARE LUCKY NOT TO HAVE A DEATH OR INJURY LAWSUIT ON THEIR HANDS. I'VE SEEN SEVERAL OTHER COMPLAINTS ONLINE FROM OTHER OWNERS OF THIS MODEL. THESE NEED TO BE RECALLED BEFORE SOMEBODY GETS KILLED. *TR

• 12/08/2014· EXTERIOR LIGHTING

  THE REAR TAIL LIGHT ASSEMBLY IS BREAKING OUT OF THESE PICKUP TRUCKS BECAUSE OF A WEAK DESIGN TO SECURE THE LIGHT ASSEMBLY IN PLACE. THE PLASTIC CLIPS ON THE SIDE OF THE LIGHT ASSEMBLY THAT ATTACHES TO THE SMALL METAL CLIP AND SCREW BREAKS OFF ALLOWING THE LIGHT ASSEMBLY TO FALL OUT OF THE TRUCK BED AND HANG BY THE REAR LIGHT WIRING HARNESS. WHILE DRIVING THE TRUCK IT STRIKES A POTHOLE OR ROUGH PLACE IN THE ROAD THE PLASTIC CLIPS BREAK AND THE TAIL LIGHT ASSEMBLY FALLS OUT OF THE TRUCK. I HAVE SEEN SEVERAL TRUCKS WITH THE REAR LIGHT ASSEMBLY TAPED UP TO SECURE THE LIGHTS. THIS IS VERY EXPENSIVE TO REPLACE THIS LIGHT ASSEMBLY. *TR

• 12/08/2009· STEERING,SERVICE BRAKES, HYDRAULIC

  POWER STEERING FAILS AND SINCE THE POWER STEERING PUMP CONTROLS THE HYDOBOOST IT AFFECTS THE POWER BRAKES OF THE VEHICLE. WHEN THE POWER STEERING PUMP FAILS YOU LOOSE POWER BRAKES AND THE VEHICLE MOVES FORWARD AT A BRISK PACE UNTIL YOU FORCEFULLY PUT BOTH FEET ON THE BRAKE PEDAL AND PUSH DOWN WITH ALL THE POWER YOU CAN TO STOP THE TRUCK. SINCE THIS HAS HAPPENED 4 TIMES I REALIZE IMMEDIATLY WHAT THE PROBELEM WAS AND APPLIED ALL THE PEDAL POWER I COULD TO STOP THE TRUCK. THIS CAN BE AN INTERMITTENT PROBLEM AND SINCE THE DEALER CANNOT DUPLICATE THE ISSUE, THEY WILL NOT REPLACE THE POWER STEERING PUMP UNTIL IT FAILS COMPLETELY, WHICH MINE FINALLY DID. 6 MONTHS LATER THE REPLACEMENT PUMP IS DOING THE SAME INTERMITTENT FAILURE AND THE DEALER WILL NOT REPLACE IT UNTIL IT COMPLETELY FAILS AGAIN. *TR

• 12/08/2008· SERVICE BRAKES, HYDRAULICCrash

  TL*THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT FILED A COMPLAINT TWO YEARS AGO REGARDING THE ABS LOCKING UP IN RAINY CONDITIONS. ALL FOUR OF HIS TIRES LOCKED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT DROVE THROUGH TWO BUSHES AND STRUCK A LARGE TRAFFIC LIGHT POLE. THE VEHICLE SUSTAINED $7,000 WORTH OF DAMAGES. A POLICE REPORT WAS FILED. THE CONTACT HAS BEEN IN AND OUT OF THE HOSPITAL SINCE THE CRASH. THE MANUFACTURER RECALLED THE VEHICLES IN THE NORTH OF THE UNITED STATES, BUT NOT THE SOUTH. THE CONTACT HAS A LAWYER AND SPOKE WITH THE CHEVROLET MANUFACTURER REGARDING THE BRAKE FAILURE. HE NO LONGER DRIVES THE VEHICLE IN THE RAIN. THE FAILURE MILEAGE WAS 16,000.

• 12/07/2015· POWER TRAIN,AIR BAGSCrash

  TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. WHILE THE TODDLER WAS PLACED IN THE DRIVER SEAT OF THE VEHICLE, SHE TURNED THE KEY TO THE ACCESSORY POSITION. THE VEHICLE ROLLED DOWN THE HILL AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. THE TODDLER DID NOT SUSTAIN ANY INJURIES. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 215,000.

• 12/07/2013· SERVICE BRAKES

  WHILE STOPPING FOR TRAFFIC LIGHT, BRAKES WERE WEAK AND REQUIRED EXCESSIVE PRESSURE TO ACTIVATE ENOUGH TO STOP VEHICLE. PULLED INTO NEAREST PARKING LOT AND FOUND BRAKE FLUID DRIPPING FROM CHASSIS UNDER DRIVER DOOR AREA. CALLED TOW TRUCK TO TAKE VEHICLE TO DEALER. TRIED TO MOVE VEHICLE TO MAKE IT EASIER FOR TOW TRUCK OPERATOR TO HOOK UP AND PEDAL WENT COMPLETELY TO FLOOR WITH NO BRAKING EFFECT. USED PARKING BRAKE TO STOP. DEALER SAID ENTIRE BRAKE SYSTEM NEEDS TO BE REPLACED DUE TO CORROSION. *TR

• 12/07/2010· SERVICE BRAKES, HYDRAULIC

  ABS ACTIVATES AT LOW SPEEDS. DEALER STATES NOTHING CAN BE DONE TO PERMANENTLY RESOLVE THE ISSUE. NOV 2009 (13000 MILES)HAD THE SPEED SENSOR REPLACED. OCT 2010 FRONT BRAKES REPLACES(22000 MILES) NOW DECEMBER 2010 WITH 24000 MILES HAPPENING AGAIN. *TR

• 12/06/2009· TRAILER HITCHES

  2005 CHEVY PICKUP RECEIVER HITCH . AFTER PULLING A 6000 LB TRAILER SEVERAL TIMES MY RECEIVER HITCH HAS WORN THIN AND THE DRAWBAR SLAPS AROUND IN THE 2" HOLE. THE 5/8" HITCH PIN HAS WORN THE 5/8" HOLE ELLIPTICAL. *TR

• 12/06/2008· ENGINE AND ENGINE COOLING

  2006 CHEVROLET 2500 PICK-UP W/8.1 MOTOR. FIRST THERE WAS FAULTY HOSES CAUSING LOW OIL WARNING TO COME ON. NOW ENGINE IS LOW ON OIL WITH 1800 MILES SINCE LAST OIL CHANGE. HAD TO PUT IN 1 1/4 QUART OF OIL. AFTER ENGINE BREAK IN. I SWITCHED TO MOBILE 1 5W30 SYNETHIC. A RECOMMENDED OIL TO USE BY CHEVROLET. DEALERS SERVICE DEPT. SAYS ITS SUPPOSE TO USE A QUART TO 2000MILES. I DON'T BELIEVE THAT WITH THE MODERN TECHNOLOGY OF ENGINES. MAYBE YEARS AGO BUT NOT NOW. IF THAT'S THE CASE THEN CHEVROLET SHOULD HAVE SAID THIS ENGINE USES OIL. I GUARANTEE YOU NOT MANY WOULD HAVE BEEN SOLD. *TR