2006 Chevrolet Aveo

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2014· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  S101 SPLICER PACK OVERHEATS AND BURNT WIRING UNDER THE HOOD CAUSING TAIL LIGHT TO NOT WORK. *JS

• 12/30/2014· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  DASH LIGHTS DID NOT TURN ON WHEN THE HEADLIGHTS WERE TURNED ON. ALSO, RUNNING LIGHTS DID NOT TURN ON AFTER MY HEADLIGHTS WERE TURNED ON (FRONT AND REAR RIGHT). LEFT REAR TURN SIGNAL DOES NOT WORK. I WAS TOLD BY A MECHANIC THIS WAS DUE TO THE SPLICE PACK MELTING. HE ALSO INFORMED ME THIS WAS A KNOWN ISSUE WITH CHEVROLET AVEO'S. THIS SHOULD BE A MANUFACTURERS ISSUE AND NOT THE OWNERS IF IT IS A KNOWN HAZARDOUS ISSUE. *JS

• 12/29/2012· STRUCTURE,LATCHES/LOCKS/LINKAGES

  WENT TO LOCK DRIVER SIDE DOOR AND INSIDE LOCK WOULD NOT PUSH DOWN AND FOUND OUTSIDE LOCK HAD FALLEN INSIDE THE DOOR PANEL. ONLINE RESEARCH INDICATES THIS IS A VERY COMMON PROBLEM ON AVEOS DUE TO DEFECTIVE PLASTIC PARTS AND DEALERSHIPS SEEM TO BE CHARGING VERY HIGH AMOUNT TO REPAIR. SEEMS THERE SHOULD BE A RECALL PROVIDED BY GMC TO FIX THIS PROBLEM AS PREVENTS BEING ABLE TO SECURE THE VEHICLE AND BELONGINGS AND OCCUPANTS OF THE VEHICLE. *TR

• 12/28/2006· AIR BAGS

  MY 2006 CHEVY AVEO FRONTAL AIR BAG DOES NOT WORK 90% OF THE TIME. IT HAS BEEN TO THE DEALERSHIP AT LEAST 5 TIMES. I HAVE CALLED THE CHEVY NUMBER IN THE BACK OF THEIR BOOK, AND THE MANUFACTURER HAS NOT DEALT WITH THE ISSUE. THEY HAVE NOT HAD THE PROBLEM FIXED. THEY HAVE MADE APPOINTMENTS FOR MY VEHICLE BUT THE AIR BAG IS STILL NOT WORKING. I AM 5 9 AND 120 LBS AND MY HUSBAND AND I CAN NOT USE MY VEHICLE BECAUSE I DON'T HAVE A WORKING AIR BAG. IN THIS SMALL OF A CAR I WOULD DIE IN A HIGHWAY ACCIDENT WITH OUT AN AIR BAG. MY HUSBAND GETS UPSET THAT WE CAN NOT USE A NEW CAR WITH FUEL ECONOMY FOR TRIPS TOGETHER BECAUSE I'M NOT PROTECTED. THIS CAR IS NEW!! THE CHEVY AVEO IS VERY DANGEROUS AND SHOULD NOT BE PURCHASED. YOUR FAMILY AND FRIENDS WILL NOT BE SAFE, AND YOU WILL BE STUCK WITH A NEW AND UNUSABLE CAR. THE PASSENGER AIR BAG DOES NOT EVEN ACTIVATE WHILE DRIVING IN TOWN. THIS CAR NEEDS TO BE RECALLED. IT HAS TAKEN ME 3 MONTHS TO FIND A PLACE THAT WOULD TAKE MY COMPLAINTS. IT IS ALMOST IMPOSSIBLE TO GET ANY ONE TO DEAL WITH THIS SERIOUS PROBLEM. WHAT GOOD IS A CAR WITH OUT A FONT AIR BAG. PLEASE SOMEONE TAKE THIS SAFETY HAZARD SERIOUS. MY AIR BAG WORKS 1 OUT OF 10 DAYS. *NM

• 12/28/2006· AIR BAGS

  TL*- THE CONTACT STATED THAT PASSENGER 'SSIDE AIR BAG SENSOR DIDN'T PROPERLY WORK. THE CONTACT STATED THAT ANYONE UNDER 150 POUNDS WILL NOT ACTIVATE THE PASSENGER SIDE AIR BAG SENSOR. THE CONTACT TOOK THE CAR TO THE DEALER )FOUR OR FIVE TIMES FOR THIS FAILURE, ANDTHEY TOLD HER THAT SHE DID NOT HAVE A PROBLEM. SHE TOOK THE CAR TO CITY MOTORS ,AND THEY CHANGED THE PASSENGER SIDE AIR BAG SENSOR, BUT THE RECURRED. *AK

• 12/26/2014· ELECTRICAL SYSTEM

  2006 CHEVROLET AVEO, HAVE HAD RECALL NOTICE FOR SEVERAL MONTHS. HAVE HEARD NOTHING NEW, DRL FAIL REGULARLY AS WELL AS PASSENGER SIDE RUNNING LIGHTS AND DASHBOARD LIGHTS. HAS BEEN GOING ON FOR YEARS, SEVERAL MECHANICS HAVE BEEN ABLE TO MAKE SLIGHT MODIFICATIONS THAT FIX IT TEMPORARILY. AVEO OWNERS NEED A PERMANENT FIX IMMEDIATELY. *TR

• 12/23/2014· STEERING,AIR BAGS

  2005 AND 2006 CHEVROLET AVEO THE STEERING AREA WAS HEATING UP.*MW THE CONSUMER WAS INFORMED THE PARTS WERE NOT AVAILABLE. *JB

• 12/23/2014· EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 14V261000 (EXTERIOR LIGHTING) AND STATED THAT THE PART WAS NOT AVAILABLE FOR SEVERAL MONTHS. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE DELAY. THE CONTACT DID NOT EXPERIENCE A FAILURE. UPDATED 02/04/15*LJ UPDATED 9/11/2017*CN

• 12/22/2014· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT STATED THAT WHEN THE KEY WAS INSERTED INTO THE IGNITION SWITCH, THE KEY WAS EXTREMELY HOT AND WAS NOT ABLE TO BE REMOVED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 130,000.

• 12/20/2005· ENGINE AND ENGINE COOLING,POWER TRAIN

  DT: THE CONTACT STATED HIS VEHICLE SHUT DOWN WHILE DRIVING. PRIOR TO THE CAR SHUTTING DOWN THE ENGINE RPM DROPPED AND THEN INCREASED SUDDENLY. AT THE SAME TIME THE CHECK ENGINE LIGHT CAME ON. THE VEHICLE HAS BEEN INTERMITTENTLY LOSING POWER SINCE THE CONTACT PURCHASED IT. THIS IS THE THIRD TIME THE VEHICLE HAS BEEN IN THE SHOP FOR THE SAME PROBLEM. THE DEALER THINKS THE PROBLEM LIES WITH THE PCM, BUT THEY WERE UNABLE TO OBTAIN A REPLACEMENT PART FROM ANOTHER VEHICLE. *AK

• 12/19/2014· EXTERIOR LIGHTING

  RECEIVED LETTER STATING VEHICLE WAS BEING INCLUDED IN A SAFETY RECALL FOR THE DAYTIME RUNNING LIGHTS. LETTER STATED THAT PARTS WERE NOT CURRENTLY AVAILABLE AND ANOTHER LETTER WOULD BE SENT OUT WHEN THEY DID BECOME AVAILABLE. HAVE NOT HEARD ANYTHING ABOUT PARTS BECOMING AVAILABLE OR ANY OTHER NEWS AT ALL. SO FAR I HAVE HAD NO ISSUES BUT AM CONCERNED THAT NOTHING IS BEING DONE TO FIX THIS PROBLEM. *TR

• 12/18/2007· VISIBILITY,AIR BAGS

  THE AIRBAG LIGHT WOULD NOT TURN OFF, STILL AT THE DEALER WAITING FOR A PART TO COME IN, IT WAS A FAULTY FUSE IN THE STEERING WHEEL IF IN A ACCIDENT AIRBAGS WOULD NOT DEPLOY. 2.THE HEAT STARTED WORKING LESS AND LESS, WHEN I WOULD COME TO A STOP THE AIR WOULD COME OUT COLD, IT FELT LIKE I HAD THE AIR CONDITIONING ON. IF IT SAT FOR TOO LONG THE TEMPERATURE WOULD START TO RISE AND IT WOULD START TO OVERHEAT. *TR

• 12/17/2014· STEERING,SUSPENSION,AIR BAGS,ENGINECrash

  I FELL ASLEEP AT THE WHEEL WENT THROUGH THE MEDIAN WHILE DRIVING DOWN THE INTERSTATE WHERE THE SPEED LIMIT IS 80 OUTSIDE DOUGLAS WYOMING. AS I WOKE WHEN THE CAR WAS IN THE MIDDLE OF THE MEDIAN MY CAR IMPACTED A CONCRETE CULVERT AND WENT THROUGH THE GUARD RAIL ONTO THE OTHER SIDE OF THE INTERSTATE WHERE IT FINALLY CAN TO A STOP ACROSS THE OTHER TWO LANES OF ON COMING TRAFFIC ALL WITH NO AIR BAG DEPLOYMENT. *TR

• 12/16/2014· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  THE FRONT SIGNAL LIGHT ON THE DRIVER'S SIDE STOPPED WORKING, SO I PURCHASED A BULB AND WHEN MY SON WENT TO REPLACE IT, IT WAS WORKING. ABOUT TWO WEEKS LATER, I WENT TO START THE CAR AND THE BATTERY WAS DEAD. THE BATTERY WAS CHARGED AND IT WORKED THE NEXT DAY. THE WINDSHIELD WIPER FLUID MOTOR DID NOT WORK FOR ABOUT TWO YEARS, BUT RECENTLY, IT STARTED WORKING AGAIN. THIS SOUNDS LIKE AN ELECTRICAL PROBLEM. I HAVE RECEIVED A RECALL NOTICE FOR THE DRL, BUT THEY DO NOT HAVE THE PART. *TR

• 12/15/2010· POWER TRAIN

  PARKED THE CAR IN A PARKING SPOT AT A STORE, WENT INSIDE FOR A LITTLE WHILE, CAME BACK OUT TO HAVE THE SHIFTER NOT SHIFT FROM PARK AFTER BRAKE PEDAL WAS DEPRESSED. I'VE ALREADY TRIED REPLACING THE BRAKE SWITCH NEAR THE BRAKE PEDAL AND REPLACED THE BRAKE TRANSAXLE SOLENOID. NEITHER OPTION HAS WORKED. TOOK TO THE DEALERSHIP TO HAVE THEM LOOK AT IT. $80 LATER, THEY WANT OVER 400 TO FIX THE SHIFTER BY REPLACING THE ENTIRE SHIFT ASSEMBLY. FROM WHAT I HAVE RESEARCHED ONLINE, THIS IS NOT THE ISSUE. THIS SHOULD BE AUTOMATICALLY TAKEN CARE OF BY THE DEALERSHIP AT NO COST TO US. IT STILL IS NOT FIXED BECAUSE WE CANNOT AFFORD TO SPEND ANOTHER 400 DOLLARS TO FIX SOMETHING THAT FAILED RIGHT AFTER THE 36,000 MARK. *TR

• 12/13/2007· LATCHES/LOCKS/LINKAGES

  TL*THE CONTACT OWNS A 2006 CHEVROLET AVEO. AFTER LOCKING THE VEHICLE FROM THE OUTSIDE WITH THE KEY, THE CONTACT COULD NOT UNLOCK THE VEHICLE ANY LONGER FROM THE DRIVER SIDE. THE DEALER STATED THAT A NEW DOOR LATCH WAS NEEDED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 50,849.

• 12/08/2014· UNKNOWN OR OTHER

  TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT RECEIVED A NOTIFICATION FOR AN UNKNOWN RECALL AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

• 12/07/2011· ENGINE AND ENGINE COOLING

  THE THERMOSTAT CASING AND THERMOSTAT BLEW WHEN I WAS ON THE FREEWAY. WHEN I TOOK IT TO THE REPAIR PERSON, HE SAID THE PARTS ARE REALLY CHEAP. IT'S A DESIGN FLAW AND CHEVY SHOULD DO A RECALL. *TR

• 12/02/2013· EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT STATED THAT THE DAYTIME RUNNING LAMPS FAILED. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 83,000. UPDATED 02/11/14*LJ UPDATED 02/11/14

• 12/01/2013· ENGINE

  THE FAN SHROUD RUBBED AGAINST THE RADIATOR AND CAUSED A RADIATOR LEAK. *TR

• 12/01/2006· AIR BAGS

  THE AIR BAG SENSOR LIGHT STAYS ON WHILE SOMEONE IS RIDING IN THE PASSENGER SEAT. ACCORDING TO THE DEALER IF YOU WEIGHT BETWEEN 80 AND 120 LB. THIS MAY OCCUR. HOWEVER, IT HAPPENS WHEN MY DAUGHTER WHO WEIGHTS 140 LBS RIDES IN THE SEAT AS WELL. THIS IS A DEFINITELY SAFETY HAZARD AND NEEDS TO HAVE A RECALL DONE. I HAVE COMPLAINED TO THE DEALER SINCE I PURCHASED THE CAR IN JAN 2006. IN JULY THEY REPLACED THE SENSOR, THEY REPLACED THE SEAT BOTTOM (THE PATTERN DID NOT MATCH MY INTERIOR) AND IT WORKED CORRECTLY. AFTER ORDERING THE CORRECT PATTERN AND INSTALLING IN MY CAR THE PROBLEM CONTINUES TO PERSIST. IT IS AN INCONSISTENT PROBLEM. I CAN RIDE IN THE PASSENGER SEAT TO THE STORE AND THE LIGHT WILL GO OFF, ON THE TRIP BACK IT STAYS ON. DURING ONE TRIP TO THE STORE WHILE MY DAUGHTER WAS IN THE PASSENGER SEAT THE LIGHT STAYED ON SO I DROVE TO THE DEALER, BOTH THE GENERAL MANAGER AND THE SERVICE MANAGER SAW HER IN THE SEAT WITH THE LIGHT ON. THEY RAN DIAGNOSTICS ON THE CAR AND IT SHOWS NO MALFUNCTIONS. THEY STATED THERE WAS NOTHING THEY COULD DO SINCE THE DIAGNOSTICS DIDN'T SHOW ANY ERROR CODES. HOW SAFE IS THIS!!! IT IS IMPERATIVE THE GENERAL MOTORS BE FORCED TO FIX THIS PROBLEM. THEY ARE AWARE OF THE PROBLEM AS I HAVE WRITTEN THE PRESIDENT AND YET THE 2007 STILL HAS THE SAME AIR BAG SYSTEM. I CAN NOT COUNT THE NUMBER OF TIMES THIS HAS HAPPENED. I WOULD APPRECIATE CONTRACT AND RESOLUTION TO THIS ISSUE. *NM

• 11/30/2005· TIRES

  THE BRAND NEW HANKOOK TIRES ON MY 2006 CHEVY AVEO ARE DEFECTIVE. I HIT A POT HOLE AND THE FIRST ONE WAS RUINED JUST 26 DAYS AFTER I DROVE THE CAR OFF THE DEALER LOT. THE REPLACEMENT TIRE I JUST BOUGHT FOR $265.55 POPPED TONIGHT 3 DAYS AFTER I DROVE OFF THE REPAIR SHOP LOT. *JB

• 11/29/2013· POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT STATED THAT AFTER PARKING, THE VEHICLE ROLLED AWAY IN REVERSE. THE CONTACT ENGAGED THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE SHIFTER CABLE TAB FRACTURED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 78,000. ..UPDATED 12-30-13 *BF UPDATED 1/17/2014 *JS

• 11/27/2012· ELECTRICAL SYSTEM

  I HAVE BEEN READING ALL THE COMPLAINTS ON THE SAME PROBLEM WITH THE LIGHT GOING OUT ON THE DASHBOARD AND THE SHIFT GEAR LIGHT AS WELL AT THE SAME TIME ALL THE FUSES HAVE BEEN CHECKED THERE ALL GOOD SO WITH ALL THE COMPLAINTS I HAVE READ THERE SHOULD BE A RECALL ON THIS SOME PEOPLE DASH EVEN STARTED A FIRE COME ON CHEVY PEOPLE DO A RECALL. *TR

• 11/25/2014· EXTERIOR LIGHTINGFire

  TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT STATED THAT THE DRL LIGHTS FAILED TO ACTIVATE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT PARTS OF THE LIGHTS WERE MELTED. THE CONTACT WAS PLACED ON A WAITING LIST FOR NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING). THE CONTACT MENTIONED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE DEALER STATED THAT THE PARTS WERE ON BACK ORDER AND NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DELAY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 130,000.

• 11/24/2013· AIR BAGS,STRUCTURECrash

  HIT FROM BEHIND WITH A CAR PUSHED MY CAR INTO A VEHICLE IN FRONT OF ME. DRIVERS FRONT AIR BAG DEPLOYED. IT COMPLETELY BLEW UP; BURNING MY HAND AND ARM. THERE WAS MOSTLY SECOND DEGREE BURNS. THERE WAS SOME PARTS ON THE ARM LATER SHOWING THIRD DEGREE BURNS. THE CAR I WAS DRIVING WAS DETERMINED TO BE TOTALED. *TR

• 11/23/2020· STEERING

  POWER STEERING FLUID IS LEAKING OUT, RELEASE VALVE GETS STUCK.

• 11/20/2008· VEHICLE SPEED CONTROLCrash

  TL*THE CONTACT OWNS A 2006 CHEVROLET AVEO. WHILE ATTEMPTING TO PARK AT APPROXIMATELY 5 MPH WITH THE BRAKE PEDAL DEPRESSED, THE ENGINE BEGAN TO REV. THE VEHICLE JUMPED A CURB AND SCRAPED A BUILDING WITH THE DRIVER'S SIDE FENDER BEFORE IDLING NORMALLY AGAIN. THERE WERE NO INJURIES, BUT A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 27,000. UPDATED 12-15-08 *BF UPDATED 12/17/08. *JB

• 11/18/2010· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,INTERIOR LIGHTING

  INSTRUMENT CLUSTER LIGHTS (SPEEDOMETER, GAS GAUGE, ETC.) LIGHTS ON SHIFTER, AND RIGHT REAR TAILLIGHTS ALL WENT OUT AT THE SAME TIME. FUSES WERE ALL STILL GOOD, LIGHT BULBS STILL GOOD. EVENTUALLY TRACKED IT DOWN TO A BURNT OUT WIRING SPLICE, WHICH HAD TO BE REPLACED. THE LOSS OF INTERIOR LIGHTS AND BRAKE LIGHTS IS A SERIOUS HAZARD - ESPECIALLY WHEN THE FIX REQUIRES HUNTING DOWN BAD FACTORY WIRING. *TR

• 11/13/2014· EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DAYTIME RUNNING LIGHTS ACTIVATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT DAYTIME RUNNING LIGHT MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (LIGHTING, ELECTRICAL) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

• 11/13/2010· ELECTRICAL SYSTEM

  I HAVE A 2006 AVEO. IN THE LAST 12 MONTHS, THE CAR HAS BEEN IN THE SHOP FOR LOSS OF POWER TWICE, THROTTLE SENSOR REPLACED. BATTERY REPLACED, HEADLIGHTS BLOW OUT WITHIN MONTHS OF BEING REPLACED. IGNITION GETS EXTREMELY HOT. RADIO BLEW OUT, A/C NO LONGER WORKS, PASSENGER SIDE AIRBAG LIGHT HAS NOW BURNED OUT, INSTRUMENT PANEL/SHIFTER LIGHTS GOING OUT. AND THE CAR IS NOW BACK IN THE SHOP WITH A BAD ALTERNATOR. THE COST OF REPAIRING THIS VEHICLE IN THE LAST 12 MONTHS IS RIDICULOUS...NOT TO MENTION THE TOWING, THE STRANDEDNESS AND STRESS. I ALSO HAVE A 2000 TOYOTA COROLLA THAT HAS NEVER BEEN IN THE SHOP SINCE I PURCHASED IT OTHER THAN ROUTINE REPAIRS.....THE AVEO IS NOT WORTH THE MONEY, EVEN WHEN PURCHASED USED. *TR

• 11/12/2009· AIR BAGS

  I OWN A 2006 CHEVROLET AVEO AND IT HAS SEVERAL OCCURRENCES OF THE AIR BAG NOT ON LIGHT. I HAVE TAKEN IT TO MY LOCAL CHEVY DEALER FOR REPAIRS THE FIRST 4 TIMES UNDER WARRANTY AND THE LAST VISIT LIGHTENED MY WALLET BY ALMOST $500.00 AND GUESS WHAT IT'S BACK ON AGAIN. I HAVE PEOPLE NOW THAT RIDE WITH ME THAT REFUSE TO RIDE IN THE PASSENGER SEAT BECAUSE THEY DO NOT BELIEVE THE BAGS WILL OPERATE PROPERLY IN A CRASH. LIKE I SAID THIS VEHICLE WAS PURCHASED NEW AND THIS HAS HAPPENED 5 TIMES NOW IN LESS THAN 3 YEARS. THEY HAVE REPLACED SENSORS, CONNECTORS, WIRE BUNDLES AND 1 TIME COULD NOT GET IT TO DUPLICATE AFTER THEY RESET IT. SO MY QUESTION IS TO YOU, WHO DOES MY ATTORNEY NEED TO CONTACT WHEN THE LAWSUIT IS FILED AFTER SOMEONE RIDING IN MY VEHICLE DIES FROM LACK OF AIRBAG DEPLOYMENT? WILL CHEVROLET STEP UP AND TAKE RESPONSIBILITY OR DO THEY SHIFT BLAME TO YOU FOR LACK OF PURSUIT IN THIS MATTER? LET ME KNOW SO THE VICTIMS RELATIVES CAN LIGHTEN YOUR OR CHEVROLETS WALLETS FOR LACK OF ACTION ON A VERY VITAL SAFETY ITEM IN THESE VEHICLES. *TR

• 11/11/2015· ELECTRICAL SYSTEM,AIR BAGS,SEAT BELTS

  THE SAME TIME THE RECALL FOR DAYTIME RUNNING LIGHTS MODULE CAME MY DAYTIME RUNNING LIGHTS INDICATOR STARTED FLASHING AND MY AIRBAG LIGHT CAME ON. I TOOK IT TO DEALER TO FIX DAYTIME RUNNING LIGHTS MODULE, I ALSO HAD AIRBAG LIGHT CHECK AND THEY SAID THE WIRING HARNESS MELTED AND IT COST ME OVER $300.00 TO FIX. IS THIS CONNECTED TO DAYTIME RUNNING LIGHT MODULE PROBLEM? IF SO I WOULD LIKE MY MONEY BACK! LET ME KNOW PLEASE.

• 11/11/2008· AIR BAGS

  CONSUMER COMPLAINT: ODI CASE NUMBER: 10244499 COMPONENT: AIR BAGS:FRONTAL DETAILS: PASSENGER AIR BAG OFF -- INDICATOR IS LIT. WILL NOT ENGAGE PASSENGER SAFETY AIR BAG WHEN WIFE, WEIGHING 105 POUNDS IS IN SEAT. CHEVROLET DEALER CANNOT FIX. *TR

• 11/10/2014· EXTERIOR LIGHTING

  I PURCHASED MY '06 CHEVY AVEO NEW FROM FRIENDLY CHEVROLET IN FRIDLEY MN AND AFTER APPROXIMATELY TWO YEARS I REALIZED THAT I WAS NEEDING TO CHANGE HEADLIGHTS FAR TOO FREQUENTLY FOR ANY CAR. I ASKED THE DEALERSHIP ABOUT IT AT THE TIME AND WAS TOLD THEY KNEW NOTHING ABOUT ANY PROBLEMS. SEVERAL OTHER MECHANICS ALSO LOOKED AT IT AND I WAS TOLD THERE IS A SHORT SOMEWHERE BUT COULD NOT SPECIFY WHERE WITHOUT DIGGING INTO IT. EVERY OTHER MONTH (APPROXIMATELY) FOR OVER THREE YEARS, ONE HEADLAMP OR THE OTHER WOULD GO OUT. I RECEIVED THE LECTURE ABOUT NOT TOUCHING THE BULB WHEN INSTALLING, THOUGH I KNEW THIS ALREADY, AND IT WAS NOT THE PROBLEM. BOTH HEADLAMP PLUGS ARE NOW CHARRED AND APPROXIMATELY ONE MONTH AFTER I GOT THE ORIGINAL RECALL LETTER, BOTH HEADLAMPS WENT DIM, SO DIM THAT THE PARKING LIGHTS SHED MORE LIGHT, MAKING THE VEHICLE UNSAFE FOR DRIVING OTHER THAN DAYTIME. I WAS INITIALLY TOLD THAT I NEED TO WAIT UNTIL I CAN MAKE AN APPOINTMENT TO REPAIR IT, SO WAITED ANOTHER MONTH OR TWO AND MADE AN APPOINTMENT, ONLY TO BE TOLD WHEN I ARRIVED, THAT THERE WAS NOT A FIX FOR THE PROBLEM YET. I HAVE HAD ONGOING PROBLEMS WITH THE FRIENDLY CHEV STAFF, NOT BEING ABLE TO CONTACT THE SERVICE MANAGER [XXX] , AND THE ONE OCCASION I WAS ABLE TO LEAVE MESSAGE FOR HIM, HE STILL HAS NOT CALLED BACK. I HAVE NOW LEFT MESSAGE FOR THE GENERAL MANAGER, WHOSE NAME WAS INAUDIBLE ON HIS OUTGOING MESSAGE. I NEED TO KNOW WHAT CAN BE DONE; WILL GM FIX IT? DO I DRIVE IT (DAYTIME ONLY) UNTIL IT BURNS? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 11/09/2012· SUSPENSION

  2006 CHEVY AVEO - ISSUE REAR AXLE BEAM BUSHINGS FAILED AT 65,000 MILES. THE FAILURE ALLOWS THE REAR AXLE TO HAVE UP TO AN INCH OF TRAVEL LEFT TO RIGHT. AS YOU GO DOWN THE ROAD YOU CAN FEEL THE BACK OF THE CAR SHIFTING AS YOU HIT BUMPS IN THE ROAD OR SIMPLY BY TAKING AN EXIT RAMP. I TOOK IT BACK TO THE DEALER AND THEY REPLACED THE AXEL AT HALF PRICE. NOW 2 YEARS LATER I AM HAVING THE SAME ISSUE AND HAVE BEEN TOLD I HAVE TO REPLACE THE AXLE FOR THE SECOND TIME. I AM WORKING WITH GM CUSTOMER SERVICE.. I READ ON LINE THIS IS A PROBLEM FOR MOST AVEO OWNERS. THESE ARE NOT OLD CARS AND THIS SAFETY ISSUE FAILURE SHOULD BE ADDRESSED BY GM. *TR

• 11/07/2009· SUSPENSION

  2006 CHEVY AVEO - ISSUE REAR AXLE BEAM BUSHINGS FAILED AT 45,000 MILES. THE FAILURE ALLOWS THE REAR AXLE TO HAVE UP TO AN INCH OF TRAVEL LEFT TO RIGHT. AS YOU GO DOWN THE ROAD YOU CAN FEEL THE BACK OF THE CAR SHIFTING AS YOU HIT BUMPS IN THE ROAD OR SIMPLY BY TAKING AN EXIT RAMP. AS THE AXLE WAS SHIFTED TO ON SIDE WHEN YOU HIT A HARD BUMP IT WOULD BR METAL TO METAL AND WOULD CAUSE SPARKS UNDER THE CAR. BY 49,000 MILES IT BECAME UNDRIVEABLE AS THE SMALLEST BUMP OR TURN WOULD SHIFT THE AXLE. GM WOULD NOT PROVIDE ANY ASSISTANCE WITH THIS PROBLEM. I EXPLAINED THIS IS A SAFETY ISSUE AND IT FELL ON DEAF EARS. I HAVE REPLACED THE AXLE BEAM AT A COST OF $461.00 FOR THE BEAM IT SELF FORM GM AS THE GM OEM PART IS THE ONLY PART AVAILABLE, I PUT IT MYSELF - 6 HOURS OF LABOR. WILL THIS FAIL AGAIN IN ANOTHER 40K MILES. I READ ON LINE THIS IS A PROBLEM FOR MOST AVEO OWNERS. THESE ARE NOT OLD CARS AND THIS SAFETY ISSUE FAILURE SHOULD BE ADDRESSED BY GM. *TR

• 11/06/2014· AIR BAGS

  I HAVE A 2006 CHEVROLET AVEO LT THAT I PURCHASED NEW, AND IT CURRENTLY HAS LESS THAN 60,000 MILES ON THE ODOMETER. IT FAILED VIRGINIA SAFETY INSPECTION BECAUSE THE AIRBAG WARNING LIGHT WAS ON. I TOOK THE CAR TO THE HUDGINS HOLIDAY CHEVROLET DEALERSHIP IN WILLIAMSBURG, VIRGINIA ON NOVEMBER 5, 2014 TO HAVE IT REPAIRED. AFTER A THROUGH DIAGNOSIS, THEY INFORMED ME THAT THE PROBLEM WAS A FAULTY PASSENGER SEAT OCCUPANCY SENSOR, AND IT WILL COST $1,152.00 TO REPLACE THE SENSOR. I SEARCHED THE WEB AND DISCOVERED THAT THIS APPEARS TO BE A VERY COMMON PROBLEM FOR THE AVEO. I FOUND A CONSIDERABLE NUMBER OF ENTRIES WHERE OTHER AVEO OWNERS HAVE HAD THE SAME PROBLEM. SINCE THIS A SAFETY ISSUE, BECAUSE THE PASSENGER AIRBAG WILL NOT DEPLOY IN A CRASH, AND SINCE IT SEEMS TO EFFECT MANY AVEOS, I FEEL THIS PROBLEM SHOULD BE THE SUBJECT OF A RECALL, OR AS A MINIMUM, GM SHOULD REPLACE THE SENSOR AT NO COST TO THE EFFECTED AVEO OWNERS. *TR

• 11/05/2009· AIR BAGS

  THE CAR IS A 2006 AVEO. THE CAR IS ONLY THREE YEARS OLD AND NOW HAS 100,000 MILES AND IS OVER WARRANTY. OVER THE LIFE OF THE CAR BEGINNING AT AROUND 20,000 MILE THE AIR BAG DISENGAGED LIGHT HAS CONTINUED TO COME ON AND STAY ON. THE CAR HAS BEEN TAKEN TO THE DEALER EACH TIME AND THEY CLAIM THERE EITHER IS NO ISSUE OR IT'S JUST A FUSE. EACH TIME THE CAR, CONTINUES TO HAVE A TROUBLE. THE LIGHT STAYS ON, MEANING THE AIRBAG IS NOT WORKING. I FEAR IN A CRASH THAT THE AIRBAG WOULD NOT DEPLOY. *TR

• 10/28/2009· ELECTRICAL SYSTEM

  2006 & 2007 CHEVY AVEO SVM MODELS. BOTH ALTERNATORS FAILED WITHIN 1 MONTH OF EACH OTHER. DEALER CLAIMS TO HAVE REPLACED 'MANY' ALTERNATORS FOR AVEO MODEL IN JUST THE LAST WEEK. DEALER CLAIMS THAT AVEO HAS THIS PROBLEM WITH ALTERNATORS, BUT THEY ARE NOT COVERED UNDER WARRANTY. ALTERNATOR CAUSES MASSIVE ELECTRICAL PROBLEMS THROUGHOUT CAR. ONE CAR LOST BATTERY, DOME LIGHT, RADIO, WIPERS, THROTTLE SENSOR DUE TO MALFUNCTIONING ALTERNATOR. ALTERNATOR ON AVEO SHOULD BE A RECALL ITEM AS IT IS A PREVALENT ISSUE FOR THE MODEL. IT SHOULD NOT BE A 'DEALER MAKES MONEY' SINCE CAR IS 3 MONTHS OUT OF WARRANTY. *TR

• 10/27/2007· AIR BAGS

  WHEN A PASSENGER 130LBS SITS IN THE FRONT PASSENGER SEAT THE PASSENGER AIRBAG LIGHT IS STILL ON INDICATING THE AIRBAG IS OFF! I HAVE HAD THE WHOLE SEAT REPAIRED AND THIS PROBLEM IS STILL EXISTING. THIS IS A SAFETY ISSUE DUE TO IF THERE IS A ACCIDENT HOW WILL I KNOW THAT THE AIRBAG SYSTEM IS WORKING PROPERLY. THE SERVICE DEPARTMENT SAYS IT WILL MAKE A DIFFERENCE IF YOUR SKINNY BUT IT SHOULD NOT MAKE ANY DIFFERENCE DUE TO I AM PAST THE WEIGHT LIMIT FOR THE SENSOR. *TR

• 10/23/2008· ENGINE AND ENGINE COOLING

  THERMOSTAT HOUSING BROKE AT THE SEAL. *TR

• 10/22/2012· ELECTRICAL SYSTEMFire

  MY 2006 CHEVY AVEO HATCHBACK WAS SITTING PARKED IN MY DRIVEWAY AND HAD NOT BEEN TURNED ON IN THE LAST 12 HOURS. MY DOGS STARTED TO BARK, AND THAT IS WHEN I NOTICED MY CAR ALARM WAS GOING OFF, VERY QUIETLY. I WENT OUTSIDE TO SEE WHAT WAS GOING ON AND THAT IS WHEN I NOTICED MY CAR WAS FILLED WITH SMOKE AND THAT IT WAS COMING OUT OF MY AIR VENTS AS WELL. HOWEVER THE ENGINE WAS NOT ON FIRE, NOR WAS IT EFFECTED. I TRIED IMMEDIATELY TO UNLOCK MY CAR, BUT MY LOCKS HAD GONE OUT, SO I HAD TO USE MY KEY AND MANUALLY UNLOCK THE DOORS. IT WAS ONCE THE SMOKED CLEARED I COULD SEE MY DASH WAS COMPLETELY MELTED IN WHERE MY AIR VENTS AND CLOCK ONCE WERE. IT DOES NOT APPEAR THAT IT HURT THE CD PLAYER DIRECTLY BELOW IT HOWEVER. MY WINDOWS ARE RUINED BY THE SMOKE AS WELL AND THEY ARE DARKENED WHERE THE "FIRE" STARTED. PRIOR TO THIS DAY MY BATTERY HAS GONE DEAD TWICE, BUT THERE WAS NOT WARNING SIGNS THAT ANYTHING WAS WRONG. I NEVER RECEIVED A CHECK ENGINE LIGHT OR ANYTHING OF THE SORT. IT NEVER SHOWED ANY PROBLEMS OPERATING OTHER THAN THE TWO DEAD BATTERIES. *TR

• 10/20/2006· ELECTRICAL SYSTEM

  CURRENTLY OWN A 2006 CHEVY AVEO HATCHBACK, WITH JUST OVER 20,000 MILES. PURCHASED NEW. HAVE BEEN NOTICING WITHIN THE LAST MONTH THAT OCCASIONALLY WHEN ATTEMPTING TO START VEHICLE, I GET A BUZZING NOISE, AND ENGINE WILL NOT START. MUST TURN KEY AGAIN TO GET VEHICLE STARTED. SEEMS TO BE A DEFECTIVE STARTER OR IGNITION SWITCH. WILL BE GETTING THIS CHECKED ASAP. ***HAVE ALSO NOTICED THIS PROBLEM ONCE IN MY MOM'S AVEO SEDAN, ALSO PURCHASED NEW IN 2006, CURRENTLY WITH LESS THAN 10,000 MILES. *NM

• 10/18/2011· SUSPENSION,STRUCTURE,WHEELS

  TIRES NEVER LAST VERY LONG, MAY GET 10,000 MILES OUT OF A SET SINCE WE BOUGHT THE CAR. CAR HAS BEEN MAKING ALOT OF NOISE GOING OVER ANY LITTLE BUMP AND WE CHANGED THE SHOCKS AND ONE WAS BAD, STARTED AROUND 90,000. IT IS STILL MAKING SOME NOISE AND THE DEALER SAID THAT THE REAR AXLE BUSHING IS BAD AND WOULD HAVE TO GET A NEW REAR AXLE $$$-$$$$. ALSO THE PAINT ALONG THE BOTTOM OF BOTH DOORS ON THE OUTSIDE ON BOTH SIDES HAD BEEN STARTING TO COME OFF. *TR

• 10/14/2014· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT STATED THAT BURNING ELECTRICAL FUMES WERE PRESENT INSIDE THE VEHICLE AND THE DAYTIME RUNNING LAMPS FLICKERED ON AND OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V261000 (EXTERIOR LIGHTING: HEADLIGHTS); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

• 10/08/2020· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ELECTRONIC STABILITY CONTROL (ESC)

  MY CAR JUST NOT RUNNING RIGHT I JUST BOUGHT IT AND SEEN A RECALL

• 10/08/2013· AIR BAGSCrash

  TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT WAS DRIVING 30 MPH AND CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED A CONCUSSION AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE AIR BAGS DID NOT DEPLOY BECAUSE THEY WERE STUCK. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 37,000.

• 10/06/2009· ELECTRICAL SYSTEM

  TL*THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT STATED THAT HIS HEADLIGHTS BURNED OUT EVERY TWO MONTHS. THE CONTACT STATED THAT THE FAILURE WAS ELECTRICAL. THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED. THE VIN NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 58,000.

• 10/06/2008· AIR BAGS

  PASSENGER AIR BAG OFF -- INDICATOR IS LIT. WILL NOT ENGAGE PASSENGER SAFETY AIR BAG WHEN WIFE, WEIGHING 105 POUNDS IS IN SEAT. CHEVROLET DEALER CANNOT FIX. *TR