2005 Volvo XC90

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2012· FUEL SYSTEM, GASOLINE

  TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT HE TOOK THE VEHICLE TO A MECHANIC FOR INSPECTION WHERE THEY ADVISED THAT THE FUEL PUMP MODULE NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE DEALER THREE TIMES BUT THEY DID NOT COMPLETE THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 9/4/13 *CN

• 12/29/2015· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2005 VOLVO XC90. DURING AN INSPECTION, THE TECHNICIAN DIAGNOSED THAT THE VEHICLE HAD A STRONG ODOR OF FUEL NEAR THE ENGINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT BELIEVED THAT THE VEHICLE MAY BE INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE VIN WAS EXCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 131,792.

• 12/29/2009· POWER TRAIN,EQUIPMENT

  WE OWN A 2005 VOLVO XC90 AND IT HAS 54K MILES ON IT. WE HEARD A WHINING SOUND FROM THE REAR AND TOOK IT TO THE DEALER AND THEY SAID THE REAR HUB BEARINGS NEED TO BE CHANGED. WE WERE NOT CONVINCED AND TOOK IT TO OUR AUTO MECHANIC WHO WORKS ON OUR AVALON, HE LOOKED AT IT AND AFTER SPENDING 5HRS ON IT CAME TO THE CONCLUSION THAT IT WAS THE REAR DIFFERENTIAL. WE WENT BACK TO THE VOLVO DEALER AND ASKED HIM TO CHECK AGAIN AND SAID IT MAY BE THE TRANSMISSION. THEY CAME BACK AND SAID YES IT IS THE REAR DIFFERENTIAL AND IT NEEDS TO BE REPLACED. THE PRICE TAG WAS FOR $5200. THIS SEEMS TO BE THE PROBLEM WITH ALL THE XC90'S. WE ARE AFRAID TO DRIVE THIS CAR ON THE HIGHWAY NEVER KNOWING WHEN OUR TRANSMISSION WILL GIVE WAY. *TR

• 12/28/2009· ELECTRICAL SYSTEM

  I AM WRITING THIS LETTER TO NOTIFY THE NHTSA OF A TOTAL SYSTEM FAILURE OF MY 2005 VOLVO XC90 THAT I BELIEVE WAS DUE TO A MANUFACTURER DEFECT WHICH SHOULD BE PART OF A RECALL. AFTER DRIVING ON THE INTERSTATE (IN EXTREME RAINY CONDITIONS) FOR APPROX 2 HRS, THE CAR DISPLAYED A WARNING MESSAGE THAT READ ?ANTI-SKID DISABLED? AND THEN ?BRAKE SYSTEM FAILURE? AT WHICH POINT WE EXPERIENCED TOTAL BRAKE FAILURE. W/IN A MINUTE OF THIS HAPPENING, THE ENTIRE CONTROL PANEL ILLUMINATED THEN WENT BLANK AND ALL THE ELECTRONIC COMPONENTS IN THE CAR TURNED OFF, INCLUDING THE WINDSHIELD WIPERS. FORTUNATELY WE WERE ABLE TO MANEUVER THE CAR SAFELY TO SIDE OF THE ROAD (AFTER THE BRAKES REENGAGED)T. THE CAR WAS TOWED TO FREEDOM VOLVO IN VA BEACH, VA FOR INSPECTION AND REPAIR. UPON EXPLAINING THE INCIDENT TO THE SERVICE MGR, WE WERE INFORMED THAT THEY WERE WELL AWARE OF THE PROBLEM WE WERE DESCRIBING AS THEY HAD SEEN ?A RASH? OF THIS EXACT ISSUE A FEW YEARS BACK. I SUSPECT THAT MY CAR, WITH RELATIVELY LOW MILEAGE FOR A 2005 (32,000), WAS JUST CATCHING UP WITH THE OTHER 2005 XC90?S THAT HAD ALREADY EXPERIENCED THE PROBLEM. THE CAR WAS REPAIRED WITHOUT DELAY AND READY FOR PICK-UP WITHIN TWO DAYS. WE WERE TOLD THE PROBLEM STEMMED FROM WATER LEAKING IN ?OVER TIME? THROUGH THE ENGINE BAY HARNESS WHICH IN EFFECT CAUSED THE CENTRAL ELECTRONIC MODULE (CEM) TO SHORT OUT. AFTER ASKING THE SERVICE TECHNICIAN WHY THIS PROBLEM WAS NOT IDENTIFIED DURING THE RECOMMENDED MAINTENANCE CHECK-UPS (WHICH WAS COMPLETED ON OUR CAR JUST A FEW MONTHS PRIOR TO THIS INCIDENT), WE WERE INFORMED THAT THIS IS NOT SOMETHING THAT IS INSPECTED. HE DID GO ON TO STATE THAT HE HAS NOT SEEN ANY REPEAT PROBLEMS FOR THE VEHICLES THAT HE HAD COMPLETED THIS EXACT REPAIR. HE ALSO NOTED THAT THE ENGINE BAY HARNESS FOR THE XC90 WAS REDESIGNED AFTER '06. I REQUEST THAT THIS PROBLEM WITH THE ENGINE BAY HARNESS ON OLDER MODEL VOLVO XC90 BE INVESTIGATED. *TR

• 12/27/2011· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING AT VARIOUS SPEEDS. THE FIRST OCCURRENCE OCCURRED WHILE DRIVING APPROXIMATELY 55 MPH. THE CONTACT WAS ABLE TO SUCCESSFULLY RESTART THE VEHICLE AFTER THE FAILURES OCCURRED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

• 12/26/2014· ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  2005 XC90 V8 STALLED IN TRAFFIC. WOULD NOT RESTART, BUT STARTER WOULD CRANK. FUEL PUMP CONTROLLER WAS FOUND TO BE INTERNALLY CORRODED AND FILLED WITH DRIED SALT. THIS CONTROLLER IS MOUNTED FORWARD OF THE RIGHT REAR WHEEL WELL. MANY INSTANCES OF THIS CONTROLLER FAILING DUE TO SALT / MOISTURE INGRESS HAVE BEEN REPORTED BY OTHER OWNERS. THE CONTROLLER WAS RELOCATED TO THE INSIDE OF THE VEHICLE SOME MODEL YEARS LATER. *TR

• 12/19/2010· ELECTRICAL SYSTEM

  I WAS DRIVING WITH MY DAUGHTER ON A VERY LONG BRIDGE AT NIGHT IN MY 2005 VOLVO XC90. THE CHECK ENGINE LIGHT CAME ON AND WHILE THE CAR STAYED ON, IT APPEARED TO HAVE LOST POWER. I HAVE HAD OTHER ELECTRICAL PROBLEMS WITH THE CAR AND HAVE HAD IT TO THE DEALER 3 TIMES BUT THEY SAY THEY CAN'T FIND ANYTHING WRONG WITH IT. THIS WAS BY FAR THE MOST DANGEROUS INCIDENT! AFTER DOING SOME INTERNET RESEARCH, I HAVE READ HUNDREDS OF REPORTS SIMILAR TO MINE. THERE IS A DEFINITE ISSUE WITH THIS CAR AND IT SHOULD BE RECALLED. *TR

• 12/18/2016· ENGINE

  PLEASE REVIEW MY WRITE UP ABOUT THE COMPLAINT IN THE ATTACHED PDF DOCUMENT.

• 12/18/2012· POWER TRAIN,UNKNOWN OR OTHER,ENGINE

  VOLVO KNOWS THE V8 ENGINE ON THE 2005 XC90 IS FAULTY. SPECIFICALLY, THE COUNTERBALANCE SHAFT BEARING FAILING DUE TO WATER INTRUSION. FORTUNATELY MINE FAILED WHILE AT IDLE. UNFORTUNATELY THE ENTIRE ENGINE IS NOW SEIZED UP AND MY OTHERWISE CLEAN CAR IS A LARGE AND USELESS PAPERWEIGHT. IF THIS WERE TO HAPPEN WHILE THE CAR IS MOVING AT SPEED, IT COULD CAUSE A HORRIBLE ACCIDENT. UNLESS VOLVO ACTIVELY FINDS THE REMAINING ENGINES IN SERVICE AND FIXES THIS PROBLEM, IT REMAINS A RISK REGARDLESS OF THE MILEAGE. APPROPRIATELY, THEY SHOULD ALSO REIMBURSE ANYONE WHO WAS AFFECTED BY THIS PROBLEM SINCE THEY LEARNED OF IT BACK IN 2005. *TR

• 12/18/2007· ENGINE AND ENGINE COOLING

  THE HEATER PIPES THAT GO THROUGH THE FIREWALL HAVE CORRODED IN LESS THAN 2 YEARS AND NORTH POINT VOLVO WANTS A $1,000.00 TO TAKE OF THE DASH AND REPLACE THIS PART ON THE HEATER WHICH IN AND OF ITSELF IS ONLY A $40.00 PART. THIS PIPE SHOULD NOT BE DEFECTIVE ON A CAR THAT'S LESS THAN TWO YEARS OLD. POOR QUALITY!!!!!!!!!! *TR

• 12/13/2011· ENGINE AND ENGINE COOLING

  COUNTER BALANCE SHAFT FAILURE LEADING TO COMPLETE ENGINE FAILURE. DEFECTIVE DESIGN. *TR

• 12/09/2009· POWER TRAIN

  YESTERDAY, OUR 2005 VOLVO XC90 STALLED COMPLETELY AT AROUND 84,000 MILES AND WAS TOWED FOR SERVICE. A DIAGNOSIS DETERMINED THAT THE RADIATOR LEAKED INTO THE TRANSMISSION CAUSING A MECHANICAL FAILURE. THIS WILL LIKELY REQUIRE THE REPLACEMENT OF THE TRANSMISSION AND POSSIBLY THE RADIATOR. OUR EXTENDED WARRANTY WILL COVER THE COST OF MAJOR COMPONENTS SUCH AS THE TRANSMISSION AND RADIATOR BUT WILL NOT COVER THE NEW HOSES AND OTHER REQUIRED ACCESSORIES. THE NHTSA NEEDS TO ACT ON THIS SOON. AS A BRIEF SEARCH OF THE INTERNET WILL SHOW, THESE PROBLEMS ARE FAR TOO COMMON TO BE CONSIDERED "NORMAL WEAR AND TEAR." MOST FAILURES ARE OCCURRING AT AROUND 4 YEARS OF AGE AND BETWEEN 50,000-88,000 MILES. THE FREQUENCY OF FAILURES IN THIS MAKE AND MODEL AT THE SAME AGE/MILEAGE ARE CLEARLY A RESULT OF A DESIGN AND/OR MANUFACTURING DEFECT. A MANDATORY SAFETY RECALL SEEMS TO BE THE ONLY LOGICAL RESOLUTION TO THIS DEFECT AND WOULD PROTECT THE SAFETY OF TENS OF THOUSANDS OF US DRIVERS WHO HAVE YET TO EXPERIENCE A TRANSMISSION FAILURE IN THIS MAKE AND MODEL. *TR

• 12/09/2009· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE BEARINGS THAT WERE INSTALLED ARE STEEL. THE BEARINGS HAVE DETERIORATED BECAUSE THEY ARE NOT GREASED.. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. HE WAS ADVISED THAT THE ENGINE NEEDED TO BE REPLACED AT AN EXPENSE OF $16,000. THE MANUFACTURER HAS NOT BEEN CONTACTED. THE FAILURE MILEAGE WAS 67,000.

• 12/08/2015· ENGINE,FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, A FUEL ODOR EMITTED FROM THE REAR OF THE VEHICLE AS THE VEHICLE LOST POWER AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO MENTIONED THAT FUEL WAS LEAKING FROM THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT AFTER THE VEHICLE WAS RESTARTED, THE FUEL ODOR RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL LINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 113,000.

• 12/06/2011· POWER TRAIN

  TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE STOPPED AT A TRAFFIC STOP, THE VEHICLE BEGAN TO SHAKE BACK AND FORTH UNCONTROLLABLY. THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL IN ORDER FOR THE VEHICLE TO STOP SHAKING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE FOUR WHEEL DRIVE MOTOR WAS NOT ENGAGING AND WOULD HAVE TO BE REPLACED. THE FOUR WHEEL DRIVE WARNING LIGHT WAS NOT INDICATING THAT THERE WAS A FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 39,000.

• 12/05/2011· ENGINE AND ENGINE COOLING

  THE BALANCER BEARING AND SHAFT ON THE 2005 VOLVO XC90 SUV IS DEFECTIVE IN THE FIRST 6000 VEHICLES MANUFACTURED FOR THAT MODEL YEAR. THE BALANCER SHAFT BEARING CAN GO BAD AT ANY TIME WITHOUT WARNING, CAUSING CATASTROPHIC ENGINE DAMAGE. IF THIS HAPPENS ON A HIGHWAY WHILE TRAVELING AT A HIGH RATE OF SPEED, THE RESULTS COULD BE DEADLY. VOLVO NORTH AMERICA IS AWARE OF THIS AND DOES NOTHING TO ADDRESS THIS SERIOUS, POTENTIALLY DEADLY SITUATION. WE HAVE BEEN WORKING TO GET VOLVO OF NORTH AMERICA TO RECOGNIZE THIS ISSUE AND THEY HAVE DOING NOTHING TO DATE EXCEPT POINT TO MAINTENANCE, WHICH HAS NO IMPACT ON THE PROBLEM. THERE IS NO MAINTENANCE PROCEDURE TO INSURE THIS DOES NOT HAPPEN AND VOLVO WILL NOT PAY FOR DAMAGES. THE REMEDY IN MOST CASES IS AN ENGINE REPLACEMENT WHICH COSTS ABOUT $15,000 , AND AS MENTIONED, VOLVO WILL NOT PAY FOR IT. VOLVO MUST BE FORCED TO RECALL THESE VEHICLES AND FIX THE PROBLEM AND COMPENSATE OWNERS WHO HAVE BEEN IMPACTED. THESE VEHICLES MUST BE RECALLED AND THE PROBLEM MUST BE FIXED BEFORE COUNTLESS LIVES ARE PUT AT RISK BY THIS TICKING TIME BOMB THAT WILL GO OFF. AT 70 MILES AN HOUR , A FAILED ENGINE COULD LEAD TO DEATH. THERE ARE 6000 VOLVO XC90'S WITH THIS PROBLEM. *TR THE DEALER DIAGNOSED THE PROBLEM AS A COMPLETE ENGINE FAILURE DUE TO THE BALANCER BECOMING DAMAGED AND CAUSING CATASTROPHIC ENGINE FAILURE. THE CONSUMER WAS INFORMED IT WOULD COST $ 14,700 TO REPLACE THE ENGINE. UPDATED IVOQ 03/09/12

• 12/04/2009· POWER TRAIN

  URGENT SERVICE TRANSMISSION LIGHT CAME ON 2005 VOLVO XC90 T6 WITH 80,000 KM. FLUSH AND NEW SOFTWARE TRIED TO FIX PROBLEM. IT DIDN'T SOLVE ANYTHING. ONE MONTH OR TWO LATER THE GEARS STARTING SLIPPING FROM STOPPED POSITION AND WHILE DRIVING. LIGHT CAME ON AGAIN. A LARGE AMOUNT OF SLUDGE AND FILING WERE FOUND IN THE PAN. HAD TO HAVE TO A COMPLETE REBUILD OF THE TRANSMISSION. *TR

• 11/29/2016· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT THERE WAS A FUEL ODOR EMANATING FROM THE VEHICLE WHILE DRIVING AT VARIOUS SPEEDS. THE ODOR CAUSED THE CONTACT TO SUSTAIN OCCASIONAL HEADACHES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 137,000.

• 11/29/2010· EXTERIOR LIGHTING

  TL*THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER SIDE HEADLIGHT WOULD SHUT OFF INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY A DEALER WHERE THE CONTACT WAS INFORMED THAT THEY WOULD HAVE TO REPLACE THE CEM UNIT. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

• 11/26/2006· TIRES

  I BROUGHT MY 2005 XC90 IN FOR ROUTINE MAINTENANCE AT 25,500 MILES. AT THAT TIME, IT WAS DETERMINED THREE OF THE FOUR TIRES WERE WORN ON THE OUTER EDGES AND SHOULD BE REPLACED. THIS IS UNACCEPTABLE FOR A VEHICLE TO HAVE THREE OF ITS TIRES REPLACED WITHIN THE FIRST 25K MILES OF SERVICE. SOMETHING IS OBVIOUSLY WRONG WITH EITHER THE TIRES OR THE VEHICLE DYNAMICS. *JB

• 11/22/2014· ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  DRIVING AT APPROXIMATELY 40 MPH, THE CHECK ENGINE AND OIL WARNING LIGHTS APPEARED. THE CAR COMPLETELY DIED WHILE I WAS ON THE ROAD. THE STEERING WHEEL AND BRAKES FROZE UP AND THE SPEED DECREASED TO BARELY NOTHING. I COULD GET THE CAR TO JUST MAKE IT OFF THE ROAD SAFELY BECAUSE I COULD NOT TURN THE WHEEL OR USE THE BRAKES WELL. THOUGHT IT WAS MY OIL SO I WAS ABLE TO GET SOMEONE TO ADD OIL TO IT WHILE ON SIDE OF BUSY ROAD. STARTED CAR UP FINE AND DROVE FOR 5 MORE DAYS UNTIL IT HAPPENED AGAIN. GOT IT TOWED TO MECHANIC WHO CHANGED THE FUEL PUMP. OTHER ELECTRICAL PROBLEMS AROUSE WHILE MECHANIC HAD IT SO BROUGHT TO VOLVO WHO SAYS I NEED A NEW CONTROL ELECTRIC MODULE IN MY CAR. *TR

• 11/19/2009· POWER TRAIN

  I AM THE OWNER OF A 2005 XC90 VOLVO. THIS CAR ONLY HAS 69,000 MILES ON IT AND THE TRANSMISSION HAS FAILED AND NEEDS TO BE REPLACED. MY CAR BROKE DOWN ON A SHORT ROAD TRIP IN THE MIDDLE OF NO WHERE ON TOP OF A SNOWY MOUNTAIN. DUE TO THE POOR QUALITY OF TRANSMISSION COUPLED WITH THE POWERFUL ENGINE THE TRANSMISSION SHREDDED METAL THAT REACHED THE RADIATOR AND OTHER COOLANT DEPARTMENTS THAT ALSO NOW NEED TO BE REPLACED. THE TOTAL COST OF REPAIRING THE DAMAGE CAUSED IS $6,700.00. I BOUGHT THIS CAR IN HOPES TO HAVE A SECURE VEHICLE TO DRIVE MY KIDS AROUND WHILE MY HUSBAND IS DEPLOYED AND EXPECTED TO IT LAST AT LEAST TO 100,000 MILES. THE CAR IS ONLY 4 YEARS OLD AND SHOULD NOT BE NEEDING SUCH EXTENSIVE REPAIRS. I CONTACTED VOLVO AND IT IS TAKING THEM A LONG TIME TO GET BACK TO ME. MY CAR IS SITTING AT A REPAIR SHOP WHILE I WAIT FOR A PHONE CALL TO SEE IF THEY WILL HELP COVER THE COSTS OR NOT. A VOLVO TECHNICAL SUPPORT REPRESENTATIVE ADMITTED TO ME THAT THEY ARE AWARE THAT THIS IS A COMMON PROBLEM WITH THIS YEAR AND MAKE BUT WERE NOT SAYING THAT THEY WOULD COVER THE EXPENSES, RATHER SHE SAID THAT THEY WOULD SEE IF THEY COULD ASSIST ME IN SOME WAY. I AM DISSATISFIED WITH THEIR LACK OF RESPONSE AND UNWILLINGNESS TO HELP CORRECT THEIR MISTAKE. AFTER DOING SOME RESEARCH IT IS OBVIOUS THAT MANY VOLVO OWNERS OF THE CX90 2005 ARE HAVING THE SAME PROBLEM AND THIS NEEDS TO BE ADDRESSED AND VOLVO NEEDS TO BE HELP ACCOUNTABLE FOR THEIR FAULTY PRODUCT, THEY NEED TO SELL CARS THAT ARE SAFE FOR FAMILIES TO DRIVE. *TR

• 11/18/2014· ELECTRICAL SYSTEM

  AFTER PARKING AT RESTAURANT, WE WALKED TO OUR PARKED VOLVO AND WHEN I TURNED THE KEY, IT WOULD ONLY GO FROM 0 TO THE 1 POSITION ( I.E.LIGHTS, RADIO WOULD COME ON) BUT IT WOULD NOT TURN ANY FURTHER TO THE START POSITION HAD TO HAVE IT TOWED TO THE DEALER AND WAS TOLD THIS HAS HAPPENED BEFORE TO THIS MODEL AND IT IS AN IGNITION LOCK FAILURE. THEY NEED TO ORDER THE PART FROM SWEDEN AND HAVE IT MATCH OUR KEYS. $850 !!. THIS IS A SAFETY ISSUE IN MY MIND HAS WE COULD HAVE BEEN STRANDED ANYWHERE AND IF THIS IS NOT THE FIRST TIME THIS HAS HAPPENED, WHY ARE THEY NOT RECALLING THIS PART? *TR

• 11/14/2016· POWER TRAIN,ENGINE

  TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING 40 MPH, THE VEHICLE STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND IT WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

• 11/14/2006· AIR BAGS

  DT*: THE CONTACT STATED THE PASSENGER FRONT AIRBAG LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO COULD NOT DUPLICATE THE PROBLEM. THE GENERAL MANAGER SUGGESTED THAT THE CONTACT TAKE THE VEHICLE TO ANOTHER DEALERSHIP FOR SERVICE BECAUSE THE DEALER WAS NOT WILLING TO SERVICE OR FURTHER EXAMINE THE VEHICLE.

• 11/08/2017· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  2005 VOLVO XC90 HAS MANY PROBLEMS. TRANSMISSION JUMPS AND JERKS WHEN SWITCHING TO HIGHER GEARS. ALMOST THROWS THE CAR OFF THE ROAD AT TIMES. ALSO, VEHICLE HAS MANY ELECTRICAL PROBLEMS DUE TO CAR NOT BEING SEALED PROPERLY. THIS LEADS TO ELECTRICAL ISSUES INCLUDING FAULTY AIR BAG CODES, BRAKE LIGHTS AND REAR TURN SIGNALS GOING OUT. CAR HAS NO BRAKE LIGHTS NOR REAR TURN SIGNALS AT ALL. DEALERSHIP CAN NOT FIND PROBLEM SAYS IT IS DUE TO THE 2005 VOLVO XC90 NOT HAVING RELAYS AT ALL. AND ALSO FROM WATER BEING INTRODUCED TO ELECTRICAL PARTS.

• 11/08/2006· VISIBILITY

  WINDSHIELD WIPERS LEAVE A STREAK ACROSS WINDSHIELD, SIGNIFICANTLY IMPAIRING VISION AND MAKING DRIVING IN RAIN HAZARDOUS. BOTH WIPER BLADES AND WINDSHIELD WIPER ARMS WERE REPLACED BY DEALER - PROBLEM PERSISTS. THIS HAS BEEN AN ONGOING ISSUE SINCE THE CAR WAS PURCHASED; DEALER ACKNOWLEDGE THE PROBLEM BUT HAS NOT ADEQUATELY REPAIRED THE CAR. *JB

• 11/07/2012· EXTERIOR LIGHTING

  THE LEFT HEADLIGHT WILL SUDDENLY GO OUT, SOMETIMES WHILE DRIVING AND OTHER TIMES THE HEADLIGHT WILL NOT LIGHT WHEN THE VEHICLE IS STARTED. AT TIMES IT REMAINED OFF FOR ONLY A FEW MINUTES AND OTHER TIMES IT WILL BE FOR DAYS. I'D TAKEN THE VEHICLE IN FOR SERVICE, BUT EACH TIME I DID, THE LEFT HEADLAMP WAS AGAIN WORKING. I'D ALSO REPLACED THE HEADLAMP IN QUESTION, BUT STILL THE HEADLAMP WORKED ONLY INTERMITTENTLY. I JUST RETURNED FROM MY 4TH VISIT TO THE DEALER, AT WHICH TIME THEY REPLACED THE LEFT FRONT LIGHT BALLAST ($440.00). THE HEADLAMP IS CURRENTLY WORKING. MY WIFE HAS BEEN RELUCTANT TO DRIVE THE VEHICLE AT NIGHT, FOR FEAR THAT BOTH HEADLAMPS WOULD GO OUT. IN RESEARCHING ONLINE, I'M FINDING THAT THIS HAS BEEN A RECURRENT PROBLEM WITH 2004 AND 2005 VOLVO XC-90'S. I UNDERSTAND THAT THE NHTSA HAS BEEN INVESTIGATING THIS PROBLEM WITH THE VOLVO XC-90 AND A RECALL IS BEING CONSIDERED. WE PURCHASED THE VEHICLE PRIMARILY DUE TO IT'S 5-STAR SAFETY RATING, BUT WE ARE NOT CONVINCED THAT VOLVO HAS ADEQUATELY ADDRESSED A KNOWN PROBLEM. *TR

• 11/05/2015· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,VISIBILITY/WIPER

  MY VOLVO XC90 ALSO HAS BEEN DIAGNOSED WITH CEM PROBLEMS AFTER VARIOUS SYMPTOMS BEGAN TO ARISE. AFTER GOING THROUGH A CAR WASH, THE DISPLAY BEGAN SHOWING VARIOUS MESSAGES. THE BIGGEST PROBLEM IS THE THE WINDSHIELD WIPERS STOPPED WORKING. I HAVE ORDERED A NEW CEM AND INTEND TO REPLACE IT . I AM AN ATTORNEY. IF THIS VEHICLE CONTINUES TO FAIL AFTER THE CEM IS REPLACED, I INTEND TO TAKE FURTHER LEGAL ACTION, ESPECIALLY IN LIGHT OF THE REPORTS AND COMPLAINTS I HAVE READ ON THIS WEBSITE. I INTEND TO CALL THE LOCAL DEALER TOMORROW TO PUT THEM ON NOTICE OF THE PROBLEMS WITH MY VEHICLE. I CANNOT BELIEVE A REPUTABLE COMPANY LIKE VOLVO DOES NOT TAKE CARE OF THE CUSTOMERS WHO HAVE PURCHASED THEIR VEHICLES. I AM FORMALLY REQUESTING THAT THE INVESTIGATION INTO THESE PROBLEMS BE REOPENED AS THE PROBLEMS CAUSED BY THE CEM DESIGN FLAWS CAUSE DANGEROUS PROBLEMS THAT CAN THREATEN THE SAFETY AND EVEN THE LIVES OF THOSE WHO DRIVE AND RIDE IN THE VOLVO XC90

• 11/03/2015· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,STRUCTURE

  TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHEN IT RAINED, WATER ENTERED THE VEHICLE THROUGH THE PASSENGER SIDE AND ONTO THE DASHBOARD, CAUSING THE INSTRUMENT PANEL LIGHTS TO DIM. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING AND THE RADIO NO LONGER WORKED. ADDITIONALLY, THE HEADLIGHTS TURNED ON AND OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 162,189.

• 11/03/2014· ENGINE

  I WAS JUST DRIVING ALONG AT 30 MPH OR LESS WHEN I HEARD A PRETTY LOAD NOISE AND THEN FELT A VIBRATION ON THE FLOOR BOARD. I WAS JUST A BLOCK AWAY FROM MY DESTINATION AND WHEN I GOT THERE THE NOISE CONTINUED. I ORIGINALLY THOUGHT THE NOISE WAS COMING FROM UNDER THE CAR BUT AFTER FURTHER INVESTIGATION LATER IN THE DAY AFTER LETTING THE CAR SIT FOR AWHILE I REALIZED THE NOISE WAS COMING FROM THE ENGINE. I HAD THE CAR ORIGINALLY TOWED TO MY MECHANIC WHO INFORMED ME THAT THE ENGINE WAS BLOWN. I COULD NOT BELIEVE THIS I HAD THE CAR A LITTLE UNDER ONE YEAR AND THE PREVIOUS OWNER ALWAYS HAD THE CAR SERVICED THROUGH A VOLVO DEALERSHIP FROM DAY ONE TO 60,200. I TOOK OVER THE CAR AND AT THE TIME OF THE INCIDENT MY CAR HAD A LITTLE OVER 85,000 MILES. ENGINES ARE NOT SUPPOSE TO FAIL AT UNDER 100,000 MILES. THERE IS SOMETHING SERIOUSLY WRONG WITH THESE ENGINES. THE INTERNET IS FULL OF THESE STORIES JUST LIKE MINE AND VOLVO IS DOING NOTHING ABOUT IT! THEY DO NOT CARE, THEY DO NOT STAND BEHIND THEIR CARS. SOMETHING HAS TO BE DONE ABOUT THIS A LOT OF INNOCENT PEOPLE ARE BEING HURT FINANCIALLY BY VOLVO. A RECALL ON THESE CAR SHOULD BE ISSUED...VOLVO NEEDS TO BE HELD ACCOUNTABLE FOR THIS! VOLVO MADE THE DETERMINATION NOT TO HELP ME...WITHOUT EVEN SEEING THE CAR AND THE SERVICE RECORDS. ACTION NEEDS TO HAPPEN AND THEY NEED TO BE FORCED TO HELP ME AND THE HUNDREDS IF NOT THOUSANDS OF PEOPLE THAT HAVE BEEN AFFECTED BY THIS. *TR

• 11/03/2011· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT HEARD A LOUD NOISE EMITTING FROM THE FRONT END OF THE VEHICLE. IMMEDIATELY THERE WAS A SLIGHT LOSS OF ENGINE POWER DURING ACCELERATION. THE MALFUNCTION PROGRESSED AND THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO STATED THE ENGINE WOULD NEED TO BE REPLACED AS A RESULT TO THE ENGINE BALANCE SHAFT FRACTURING. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

• 11/03/2010· ENGINE AND ENGINE COOLING

  OCTOBER 10, 2010 PURCHASED CASH 2005 XC90 V8. WENT THROUGH SAFETY AND EMISSION SERVICE FOR REGISTRATION-- OKAY. OCTOBER 22 HEARD A STRANGE NOISE FROM ENGINE, CALLED VOLVO DEALERSHIP TO REQUEST SERVICE. DIDN'T DRIVE ON OCTOBER 23, 2010. ON SUNDAY, OCTOBER 24, WENT OUT TO MOVE THE CAR FOR OPPOSITE SIDE PARKING AND TO GAS UP FOR DRIVE TO SERVICE CENTER. CAR STOPPED AT SERVICE STATION, AND HAD TO BE TOWED TO DEALERSHIP. DEALERSHIP DIAGNOSTICS OCTOBER 25, 2010 CONFIRMED: NOISE IS FROM EITHER BROKEN CONNECTING ROD OR BALANCE SHAFT....ADVICE TO CUSTOMER "NEEDS ENGINE" AT A COST OF $14,000+. THE CAR DID NOT COME WITH A WARRANTY AND EVEN NOW THE DEALER IS BECOMING INCREASINGLY EVASIVE--AS HE SAYS HE WAS THE OWNER/DEALER AT THE TIME OF SALE, AND AS INDIVIDUAL SELLER REGISTERED IN ANOTHER STATE AND NOT NEW YORK, SO DOES NOT HAVE TO HONOR WARRANTY OR ASSUME RESPONSIBILITY. CALL VOLVO NORTH AMERICA ON OCTOBER 26, 2010 WITH NO KNOWLEDGE OF OUR OWNERSHIP, (STILL HAVEN'T RECEIVED TITLE TO CAR). RESPONSE WAS --NO WARRANTY NO ASSISTANCE WITH THIS COUNTER BALANCE OR ANY OTHER ISSUE BEYOND 4 YEAR/50,000 MILES. CONCERN: BEFORE PURCHASE WHEN ASKING THE DEALER NO MENTION NOR WHEN RESEARCHED NO REVELATION OF THE COUNTERBALANCE SHAFT BEING AN ONGOING ISSUE FOR THE 2005 XC90 V8. HOWEVER, FURTHER EVIDENCE CLEARLY SHOWS DESIGN FLAWS IN THE ORIGINAL YAMAHA ENGINES, AND A SLIGHT COVERT ATTEMPT BY VOLVO TO FIX IT VIA ITS LIMITED EDITION TECHNICAL SERVICE BULLETIN(TSB) TO DRILL THE HOLE IN THE SHAFT TO LET BUILD UP MOISTURE ESCAPE. ADDITIONALLY, VOLVO'S SECOND ATTEMPT TO SLIGHTLY ADDRESS THE COUNTER BALANCE ISSUE IS EVIDENCED VIA ITS LIMITED AND PAY-TO-GET TSB INFORMING DEALERSHIPS NOT CONSUMERS 'OF NOT WASHING THE ENGINE,' WHICH MAY LEAD TO MOISTURE BUILD UP AND TOTAL ENGINE FAILURE. OUR ATTEMPTS ARE NOW BEING MADE FOR VOLVO TO MAINTAIN ITS SLOGAN OF "SAFETY FOR LIFE." WE WANT THE SAFETY ATTRIBUTE TO BE EFFECTIVE AND USEFUL WHEN THE CAR IS OPERABLE, AND NOT WHEN THE CAR IS INOPERABLE. *TR

• 11/01/2010· POWER TRAIN

  60,000 MILES ON A 1995 VOLVO XC90 AND THE TRANSMISSION JUST FAILED FOR THE FOURTH TIME. THE TRANSMISSION WAS ALREADY REPLACED THREE TIMES. FAILURE RESULTS IN CAR STOPPING WITHOUT WARNING. ANYTIME, ANYPLACE, IT JUST LOSES POWER. *TR

• 10/29/2010· POWER TRAIN,ELECTRICAL SYSTEM

  I HAVE A 2005 VOLVO XC90 T6. BOUGHT THIS CAR BRAND NEW. HAD SO MANY PROBLEMS INCLUDING TRANSMISSION OUT; THE BLINKERS DO NOT WORK. THE QUALITY AND SAFETY OF THIS VEHICLE IS MISLEADING AND THIS IS A HORRIBLE SAFETY ISSUE SINCE BLINKER DON'T WORK. LOOKING INTO IT, SEEMS LIKE THIS IS AN ONGOING ISSUE WITH MANY OWNER OF VOLVO XC90 2005. THEY REALLY NEED TO RECALL THIS BEFORE IT'S TOO LATE AND CAUSE FATALITIES. *TR

• 10/29/2007· ELECTRICAL SYSTEM

  TL*THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT NOTICED A BURNING SMELL INSIDE THE PASSENGER COMPARTMENT. THE VEHICLE WOULD NOT START AND WAS TOWED TO THE REPAIR SHOP. THE MECHANIC STATED THAT THE JACK CRANK HANDLE CAUSED THE FAILURE. THE CONTACT WAS UNSURE IF THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V221000 (ELECTRICAL SYSTEM:BATTERY:CABLES). THE CURRENT AND FAILURE MILEAGES WERE 25,000.

• 10/28/2018· FUEL/PROPULSION SYSTEM

  GASTANK WAS LEAKING WHEN I WAS FILLING UP IN FULL TANK NOT VERY MUCH BUT I SMELL WHENEVER I WAS PARKING

• 10/25/2018· STRUCTURE

  PASSENGER DOOR INTERMITTENTLY SWINGS OPEN WHILE DRIVING, EVEN WHILE LOCKED. FAULTY LATCH.

• 10/25/2013· ENGINE

  THE COUNTERBALANCE SHAFT BROKE RESULTING IN ENGINE FAILURE. VOLVO ESTIMATES REPAIR AT $5,0000. RIDICULOUS. WHY DOESN'T VOLVO FIX THIS WELL KNOWN ISSUE FOR LOYAL CUSTOMERS. I HAVE HAD 5 VOLVOS IN MY LIFE STARTING BACK IN THE 1980'S AND LOVE THE CARS BUT THIS LACK OF CARE FOR CUSTOMER WELFARE IS JUST WRONG. IT MAY BE MY LAST VOLVO IF THIS IS HOW THEY TREAT CUSTOMERS NOW DAYS. *TR

• 10/24/2014· POWER TRAIN,ENGINE

  THIS IS A 2005 VOLVO THAT HAS A HISTORY OF TRANSMISSION FAILURE IN ALL CARS OF THIS MODEL AND YEAR. IF ONE GOOGLES THE MODEL AND MAKE OF THIS CAR ONE WILL FIND FORUM AFTER FORUM OF PEOPLE WHO HAVE HAD TO REPLACE THESE FAILED TRANSMISSIONS BEFORE OR SHORTLY AFTER WARRANTY IS UP. THE DEALERS AND SERVICES HAVE LARGELY PUT THIS ITEM WHICH SHOULD HAVE BEEN A RECALL ISSUE ON TO THE CUSTOMER. MY TRANSMISSION FAILED WHEN TRYING TO ACCELERATE ON TO A FREEWAY. I WAS NEARLY IN A LIKELY FATAL COLLISION DUE TO THE TRANSMISSION FAILING TO GO OUT OF 2ND GEAR. THERE WAS A CLASS ACTION SUIT SURROUNDING THIS ISSUE IN THIS MODEL , BUT FEW VOLVO OWNERS WERE NOTIFIED OF IT. PLEASE HELP US AND DEMAND THAT VOLVO RECALL THESE CARS, REPAY FOR FAILED TRANSMISSIONS AND LOST VALUE OF THE CARS......ONE CANNOT EVEN GIVE THEM AWAY NO AND THESE WERE 45K$ CARS!!!!!!!!!!FURIOUS. *TR

• 10/24/2014· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VEHICLE SPEED CONTROL

  WHILE DRIVING VEHICLE AT 55-60 MPH ALL DASHBOARD LIGHTS CAME ON AND CAR LOST POWER. THIS CAUSED A FRIGHTENING AND EXTREMELY DANGEROUS SITUATION. WITHOUT HEADLIGHTS OR TAIL LIGHTS I COULD NOT BE SEEN BY OTHER DRIVERS. I TRIED TO CROSS 2 LANES AND GET ONTO THE SHOULDER WITH NO POWER STEERING OR ENGINE POWER. WHILE I WAS VERY FORTUNATE I WAS NOT IN OR DID NOT CAUSE A SERIOUS ACCIDENT I HAD AN EXTREMELY CLOSE CALLS. I CHANGED LANES AND ALMOST COLLIDED WITH ANOTHER VEHICLE TRAVELING AT 55. ONCE IN THE LANE ANOTHER DRIVER WHO WAS UNABLE TO SEE MY VEHICLE (NO LIGHTS) CAME UP BEHIND ME AT A HIGH RATE OF SPEED. ONLY A LAST MINUTE SWERVE AVOIDED A REAR END COLLISION THAT NO DOUBT WOULD HAVE CAUSED A TERRIBLE ACCIDENT WITH VERY SERIOUS IF NOT TRAGIC RESULTS. ADDITIONALLY OTHER DRIVERS HAD TO SWERVE TO AVOID THE VEHICLE-CAUSING A VERY DANGEROUS, CHAOTIC SITUATION. THE LOSS OF POWER AND LOSS OF LIGHTS CAME CLOSE TO CAUSING A MAJOR MULTI-VEHICLE ACCIDENT. MANY ARE AWARE OF THIS PROBLEM. PLEASE DO NOT WAIT UNTIL PEOPLE ARE KILLED TO REOPEN THE INVESTIGATION AND RE-CONSIDER A SAFETY RECALL. *TR

• 10/17/2006· ENGINE AND ENGINE COOLING

  THE VEHICLE WAS BOUGHT BACK IN 10/31/04. WITHIN WEEKS OF HAVING THE VEHICLE, WE NOTICED LOST OF POWER AND PERFORMANCES IF THE VEHICLE. WE CALLED THE DEALER ABOUT IT AND SAID THAT IT MIGHT JUST BE DUE TO THE GAS CAP. AS IT TURNED OUT THEY HAD TO REPLACE A SOLENOID WHICH PART OF THE STARTER OR SOME TYPE OF FIRING MECHANISM FOR THE ENGINE. AFTER THAT PROBLEM WAS FIXED, WE HAD TO CONTINUALLY BRING THE VEHICLE BACK TO THE DEALER FOR THE CHECK ENGINE CONSTANTLY COMING ON. THIS WENT ON FOR NUMEROUS TIMES UNTIL THEY FOUND A RELAY PROBLEM. LAST FRIDAY MY WIFE, WHO PRIMARILY DRIVES THE CAR, COMPLAINED ABOUT THE PERFORMANCE AND LOST OF POWER ISSUE. I TEST DROVE THE VEHICLE AND CONFIRMED HER WORRIES ABOUT THE VEHICLE. THE VEHICLE DOES NOT ACCELERATE PROPERLY AND A SUDDEN JERK OR RISE OF RPM WHEN IT HITS ITS MARK. ALSO AROUND 60 MPH AND 70 MPH YOU CAN HEAR OBVIOUS NOISE FROM THE ENGINE. AT IDLE FOR ABOUT A MINUTE YOU CAN SMELL SOMETHING BURNING IN THE ENGINE COMPARTMENT. THE VEHICLE WILL BE TAKEN TO DEALER ON 10/17/06. *NM

• 10/16/2012· ENGINE

  SUNDAY MORNING (10.14.12) CAR MAKING A HORRIBLE NOISE FROM ENGINE BLOCK. SOUNDS LIKE LOOSE BOLTS RATTLING AROUND INSIDE ENGINE BLOCK. CHECKED TRUSTED VOLVO FORUMS ON WEB. I HAVE HAD FOUR VOLVOS BETWEEN MYSELF AND MY WIFE: 2000 S40 (WIFE), 2001 S80 AND NOW 2005 S40 (WIFE) AND MY XC90 - USED THESE FORUMS TO STAY UP ON LATEST ISSUES/MAINTENANCE. THERE WERE SEVERAL POSTS WITH IDENTICAL ISSUE WITH THIS MODEL, YEAR AND V8 ENGINE. APPARENTLY, ONGOING ISSUE WITH COUNTER BALANCE SHAFT BEARING. DESIGN FLAW ALLOWS RUST TO OCCUR AT BEARING AND THEN THEN CB-SHAFT FAILS. WILL CAUSE INCREDIBLE DAMAGE TO ENGINE - MAYBE EVEN DEATH IF OCCURS AT HIGH SPEEDS. CALLED DEALER THIS MORNING, THEY ARE FAMILIAR WITH ISSUE, WANTED ME TO DRIVE IN OR TOW. COST IS PROHIBITIVE AND BASED ON LEGIONS OF SIMILAR CONSUMER REPORTS, AM ALREADY CERTAIN OF DIAGNOSIS. VOLVO NA EVEN DISTRIBUTED TECHNICAL BULLETIN TO SERVICE DEPTS TO DRILL MOISTURE RELIEF HOLE IN BEARING AREA AS FIX FOR THOSE UNDER WARRANTY!!! THAT'S INSANE!!! LINKS TO POSTS ABOUT ISSUE (ONE OWNER EVEN POSTED VIDEO OF HIS ENGINE NOISE): HTTP://FORUMS.SWEDESPEED.COM/SHOWTHREAD.PHP?123707-INTERMITTENT-CLATTERING-NOISE-FORM-HEAD-OF-BLOCK-WITH-ROUGH-RUNNING ALSO HTTP://S298.PHOTOBUCKET.COM/ALBUMS/MM262/DLRNORDIC/VEHICLE20PICTURES202010/ACTION=VIEW&CURRENT=IMG_0385.MP4 AND HTTP://WWWODI.NHTSA.DOT.GOV/COMPLAINTS/RESULTS.CFMODI_IDS=10313311&SEARCHTYPE=QUICKSEARCH&SUMMARY=TRUE&REFURL=EMAIL NEED VOLVO NA TO STEP UP AND HELP, HELP, HELP! HARDWORKING FAMILY MAN WITHOUT ESTIMATED 10-15K TO FIX THIS!!! ALSO, ISSUE WITH INTERNAL RAIN LEAKS ON 2005 S40 BUT NEVER RAISED FUSS. LOVE OUR VOLVOS BUT IN A REAL SPOT HERE. COME ON VOLVO NA, DO THE RIGHT THING!! WILL ACKNOWLEDGE VOLVO'S COMMITTMENT TO CONSUMER ALL ACROSS WEB!!! *TR

• 10/14/2010· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  VEHICLE HAS DRIVER'S SIDE HEADLIGHT FAILURE. REPLACED BULB WITH CERTIFIED VOLVO REPLACEMENT AND STILL DID NOT WORK. CERTIFIED VOLVO MECHANIC TRACED FUSES AND ALL ELECTRICAL COMPONENTS (5 HOURS PAID SERVICE) AND FOUND THAT A PLASTIC PART DESIGNED TO KEEP WATER OUT OF THE INTERIOR (VIA WINDSHIELD) WAS DEFECTIVE, THEREFORE, CAUSING WATER LEAKAGE TO DAMAGE THE CENTRAL ELECTRICAL MODULE . *TR

• 10/14/2005· STEERING

  AT TIME OF PURCHASE, A VIBRATION FROM THE FRONT OF VEHICLE OCCURS UPON TURNING, MANUFACTURER REPLACED ENTIRE STEERING ASSEMBLY AFTER 5K MILES. OTHER VOLVO XC90 OWNERS HAVE HAD SIMILAR PROBLEMS AND REPAIRS OF STEERING ASSEMBLY AT THIS TIME I WOULD LIKE TO BRING THE ISSUE TO NSTB AS IT MAY REFLECT POTENTIAL SAFETY ISSUES IF NOT REPAIRED.

• 10/11/2012· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT THE INTERIOR OF THE VEHICLE SMELLED OF GASOLINE AND HAD STALLED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSE THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE DEALER NOTIFIED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP). THE FAILURE AND CURRENT MILEAGE WAS 105,000.

• 10/07/2015· FUEL/PROPULSION SYSTEM

  THERE IS A RECALL DATED MARCH 2010 FOR 2003-2005 XC90 FOR FUEL SYSTEM PROBLEMS, I AM HAVING PROBLEMS WITH MY CAR HAVING PROBLEMS RUNNING. ENGINE ANALYSIS SHOWS CODE PO087AND P0089, FUEL PRESSURE REGULATOR. CAR WILL NOT CONTINUE TO RUN WHILE DRIVING WITH LESS THAN 3/4 FULL TANK.

• 10/07/2014· POWER TRAIN

  TRANSMISSION COMPLETELY FAILED. THIS WAS THE 2ND TRANSMISSION, AS THE FIRST ONE FAILED AT 45000 MILES. I HAD TO REPLACE THE TRANSMISSION AT A COST OF $6000. REBUILDING FAILED TRANS WAS SLIGHTLY CHEAPER BUT NOT WORTH IT. I UNDERSTAND THERE IS A CLASS ACTION LAWSUIT, BUT WAS SETTLED BEFORE MY TRANSMISSION FAILED. *TR

• 10/06/2008· POWER TRAIN

  I HAVE HAD MY 2005 T6 XC90 FOR 5 MONTHS AND UNTIL TODAY HAVE ONLY DEALT WITH SMALL ISSUES. TODAY I WAS ON THE FREEWAY AND LOST TRANSMISSION POWER AT 65 MPH AND THE EVENT COULD HAVE BEEN CATASTROPHIC, HOWEVER I WAS LUCKY ENOUGH TO REGAIN TRANSMISSION CONTROL AND COULD GET TO AN EXIT AND PARK MY VEHICLE IN A SAFE PLACE TO AWAIT A TOW. I HAD NO IDEA THAT THE T6 WAS KNOWN FOR THIS TYPE OF FAILURE WITH THE TRANSMISSION OR I WOULD NEVER HAVE BOUGHT IT. I HAVE TWO LITTLE GIRLS AND THEIR SAFETY WAS THE KEY ELEMENT IN MY PURCHASING THIS VEHICLE. ALL THINGS CONSIDERED, TODAY COULD HAVE BEEN MUCH WORSE BUT ACCORDING TO MANY ACCOUNTS THIS ISN'T THE FIRST T6 TO HAVE TRANNY PROBLEMS AND IT WON'T BE THE LAST. UNTIL VOLVO IS MADE TO ACKNOWLEDGE THAT THEIR DESIGN WAS FAULTY OTHER FAMILIES' LIVES ARE AT STAKE. I KNOW MY XC90 WILL NEED A NEW TRANSMISSION, AND THE COST IS GOING TO BE UPWARDS OF $6,000. AND FOR A "VOLVO FOR LIFE" THIS IS UNACCEPTABLE!! *TR

• 10/05/2015· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,ELECTRONIC STABILITY CONTROL (ESC)

  ASIDE FROM NORMAL CARE, I HAVE ONLY REPLACED MY TIRES AND A GAS CAP. I STARTED TO EXPERIENCE SOME WATER SEEPAGE ONTO THE DRIVER-SIDE. I COVERED THE VEHICLE WHEN IT RAINED AND FIGURED I WOULD HAVE A LOOK AT IT WHEN I HAD TIME. JULY 2015, I TOOK MY VOLVO TO SAVANNAH VOLVO, FIXED MY BREAKS ALONG WITH OTHER SAFETY FIXES, AFTER 14 HRS OF HAVING MY VEHICLE AND 2800 LATER, PETE STATED EVERYTHING WAS TAKEN CARE OF AND THE WATER SEEPAGE WAS DUE TO THE DRAINS BEING CLOGGED, BUT, THEY ARE ALL CLEAR NOW, WE DID A WATER TEST AND EVERYTHING IS OK. YOU WILL EXPERIENCE SOME MORE WATER SEEPAGE BUT IT SHOULD DRY UP IN A FEW DAYS. HE ALSO MENTIONED SOME OTHER WORK THAT NEEDED TO BE DONE THOUGH NOT UNTIL NOVEMBER, DECEMBER. I SAID GREAT AND GOT ON MY WAY. THREE DAYS LATER IT DID RAIN, CONFIDENT I DID NOT NEED TO COVER MY VEHICLE AND WAS STILL EXPERIENCING WATER SEEPAGE FROM MY VISIT, I DID NOT THINK ANY THING OF IT. THE NEXT DAY, MY CONTROL PANEL STARTED TO LIGHT UP. I CALLED SAVANNAH, AND HE MENTIONED IT MUST JUST BE BECAUSE YOU PUT A FULL TANK OF GAS....WHAT??? OK. AS THE WEEK WENT ON THE CONTROL PANEL CONTINUED TO LIGHT UP ONE BY ONE. THE DAY BEFORE GOING BACK, MY DRIVER SIDE TURN SIGNAL WAS ON. HOPING I DID NOT HAVE A DEAD BATTERY THE NEXT DAY, I HEADED TO VOLVO. AFTER 4 HRS THEY TELL ME THE ROOF DRAINS WERE CLOGGD AND SEEPED ONTO THE CEM, AND IT IS DAMAGED. I SAID TO PETE, I THOUGHT THE DRAINS WERE CLEAR WHEN I LEFT A WEEK AGO??? YEAH, WELL, WE CAN'T CREATE A PROBLEM WITH YOUR DRAINS. THOUGH, AFTER 10 YRS I LEAVE THERE AND 3 DAYS LATER EXPERIENCE A PROBLEM, AFTER YOU TOLD ME MY DRAINS WERE ALL CLEARED? SEVERAL PHONE CALLS TO THE DEALERSHIP AND VOLVO HEADQUARTERS, NOT ONE PERSON IS TAKING RESPONSIBILITY FOR THIS BAD DESIGN, WHICH COULD HAVE CAUSED MY TRANSMISSION TO LIMP AND A POSSIBLE ACCIDENT! IT NOW SITS IN MY DRIVEWAY, AFTER SPENDING 2800.00 I WILL NEVER PURCHASE ANOTHER VOLVO!