2005 Toyota Tacoma

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2015· ELECTRICAL SYSTEM

  MY STEREO CHANGES STATIONS ON ITS OWN I DON'T KNOW IF IT'S IN THE BUTTONS IN THE STEERING WHEEL OR THE ACTUAL STEREO ITSELF.

• 12/31/2015· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  SHORT IN THE BUTTON TO TURN THE CRUSE CONTROL ON SOMETIMES IT WORKS BUT I HAVE TO PUSH IT AT LEAST 200 TIMES. THE SECOND THING IS A SHORT IN THE OVER HEAD COMPAS/TEMPERATURE GAUGE IT JUST DOES NOT WORK ANY MORE.

• 12/31/2014· SUSPENSION

  TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 3/3/15*CN UPDATED 03/17/15. *JB

• 12/31/2007· VEHICLE SPEED CONTROL

  MY 2005 TOYOTA TACOMA HAS A PROBLEM WITH LURCHING IN STOP AND GO TRAFFIC. I END UP RIDING THE BRAKES ALL THE TIME. NUMEROUS TIMES HAS IT LURCHED AT STOP LIGHTS. *TR

• 12/30/2013· STRUCTURE

  2005 TACOMA FAILED INSPECTION DUE TO A HOLE IN THE FRAME FROM RUST. VEHICLE INSPECTED BY THE DEALER FROM WHICH IT WAS PURCHASED. HAD PURCHASED VEHICLE JUST LESS THAN ONE YEAR EARLIER, SECOND OWNER. NO ACCIDENTS AND WELL CARED FOR. IRONICALLY ENOUGH, WE BOUGHT THIS TACOMA TO REPLACE THE 1998 TACOMA WE LOST DUE TO A FRAME RUST PROBLEM IN THE TOYOTA BUYBACK PROGRAM. DEALER DID FIX AT NO COST UNDER USED CAR WARRANTY. REPORTED ISSUE TO THE TOYOTA USED CAR SALESMAN WHO SOLD US THE TRUCK AND HE STATED HE WAS NOT AWARE OF ANY FRAME RUST ISSUES ON 2005 TACOMAS. AFTER A CURSORY INVESTIGATION I FIND THIS HARD TO BELIEVE. APPARENTLY TOYOTA HAS NOT THOROUGHLY ADDRESSED FRAME RUST ISSUES THAT PLAGUED EARLIER MODELS. A COMPLAINT WILL BE FILED WITH TOYOTA CUSTOMER RELATIONS. VERY CONCERNED ABOUT RECURRING RUST PROBLEM IN FUTURE WHICH WOULD LIKELY LEAVE US WITH A WORTHLESS VEHICLE BASED ON TOYOTA'S UNWILLINGNESS TO ACKNOWLEDGE ON-GOING FRAME RUST PROBLEMS. HOPEFULLY THE LOCAL TOYOTA DEALER WILL STEP UP. *TR

• 12/30/2013· VEHICLE SPEED CONTROLCrash

  PULLED INTO MY DRIVEWAY TO PARK MY 2005 TACOMA AND ALL OF A SUDDEN MY TACOMA ACCELERATES FORWARD AND PLUNGES INTO THE REAR END OF MY 2000 CORVETTE WHICH WAS PARKED IN MY GARAGE, AND DOES $1321.22 IN DAMAGE. THE FORCE FROM THE TACOMA KNOCKED MY CORVETTE ABOUT 3 FEET FORWARD INTO A FREEZER IN THE GARAGE. I WAS APPROXIMATELY 6 FEET BEHIND THE CORVETTE, AND THE CORVETTE WAS IN GEAR AND THE EMERGENCY BRAKE WAS APPLIED, WHEN THE TACOMA SUDDENLY ACCELERATED FORWARD. I HAVE BEEN PARKING IN SAME LOCATION OR 9 YEARS AND THIS HAS NEVER OCCURRED BEFORE. I HAVE HAD ALL RECALLS DONE CONCERNING THE SUDDEN ACCELERATION PROBLEM WITH THE TACOMA. THIS WAS NOT A PEDAL PROBLEM, IT IS A TOYOTA PROBLEM. IF HIS HAD HAPPENED AT A INTERSECTION WHO KNOWS WHAT MAY HAVE HAPPENED. SOMEONE NEEDS TO "FIX" THIS PROBLEM. *TR

• 12/30/2008· POWER TRAIN

  TL*THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 15 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE LUNGED FORWARD WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT HEARD A LOUD SQUEALING NOISE COMING FROM THE WHEELS. THE GEAR SHIFTER WAS PLACED INTO PARK IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE FAILURE RECURRED AND WAS TAKEN TO THE DEALER ON THREE OCCASIONS, BUT THERE WERE NO RESOLUTIONS. THE VEHICLE IS CURRENTLY OPERATING PROPERLY. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS UNAVAILABLE AND CURRENT MILEAGE WAS 45,000. SEE ALSO 10254167. DSY

• 12/28/2011· AIR BAGS

  2005 TOYOTA TACOMA SR5 DBL CAB, 6 CYL, 4.0 ENG. 50K MILES, 4 WHEEL DRIVE, MANUAL TRANSMISSION: DRIVER SIDE AIRBAG LIGHT TURNED ON AND STAYS ON. I HAVE SEARCHED THE INTERNET FOR INFO. ON IT AND HAVE FOUND A LOT OF PEOPLE HAVE BEEN HAVING THIS PROBLEM. GOING BY THE INFO. FOUND ON LINE, FROM GOOGLE TO NEWSGROUPS IT SEEMS THAT THE SPIRAL CABLE IN THE STEERING COLUMN IS FAILING AT A ALARMING RATE. THE TOYOTA DEALERS ARE JUST CHARGING FOR DIAGNOSTICS AND NOT ADMITTING A PRODUCT DEFECT. I AM TAKING MINE TO THE DEALER AND IS $117.00 JUST TO DIAGNOSE IT.. AND I KNOW THIS TAKES THEM 10 MIN OR LESS TO HOOK IT UP TO THE COMPUTER AND GET THE ERROR CODES PRINTED. THIS DEALERS ARE CHARGING $90 TO $120 JUST FOR THE DIAGNOSTIC.. AND IT SEEMS THE REPAIRS CAN GO FROM $300 UP TO $800.00. SRS (AIR BAG) ISSUES SHOULD BE COVERED FOR THE LIFE OF A VEHICLE OR SRS (AIR BAGS) SHOULD BE OPTIONAL! IF IT IS A REQUIRED PART LIKE A SEAT BELT TOYOTA SHOULD COVER THE PART FREE. PLEASE TAKE TIME TO REVIEW MY COMPLIANT AND THOSE OF OTHERS. *TR

• 12/28/2008· STRUCTURE

  2005 TOYOTA TACOMA HAS CRACKED FRAME. 05 IS A NEW BODY/FRAME STYLE B/C OF THE 99-04 TACOMA DEFECTIVE FRAMES. AFTER TAKING IT TO THE SHOP B/C MY FAN MOTOR WAS ABOUT TO FALL OFF, THAT'S WHEN THE DISCOVERY WAS MADE. MECHANIC STATED THIS VEHICLE WAS NOT SAFE TO DRIVE. IT HAS BEEN REPORTED TO TOYOTA HQ. MY LOCAL TOYOTA DEALER HAS ALSO CONTACTED TOYOTA. THERE ARE NO RECALLS FOR 2005. MECHANIC/BODY SHOP OWNER STATES IT CANNOT BE REPAIRED. FRAME MUST BE REPLACED, AND HE STATED MOST PEOPLE ARE NOT QUALIFIED TO REPLACE A FRAME, WHICH MAY PRESENT FURTHER SAFETY ISSUES. *TR

• 12/27/2016· STRUCTURE

  I PURCHASED MY 2005 TOYOTA TACOMA USED WITH 108,000 MILES ON IT ON 12/8/2016. IT FAILED VIRGINIA INSPECTION ON 12/20/2016 DUE TO RUST IN THE FRAME. THE TRUCK IS NOT SAFE OR LEGAL TO DRIVE. TOYOTA WILL NOT COVER THE DAMAGE UNDER LSC E0D, WHICH EXPIRED IN MARCH 2016, DESPITE THAT THE VEHICLE WAS IN A TOYOTA DEALER TWICE DURING THE SERVICE CAMPAIGN.

• 12/27/2005· SERVICE BRAKES, HYDRAULICCrash

  ON TWO OCCASIONS THE BRAKES HAVE FAILED IN WET CONDITIONS. THE FIRST OCCURRED WHEN GOING THROUGH STANDING WATER OF ABOUT 5" UNDER NORMAL TEMPERATURE. THE SECOND OCCURRED AFTER GOING THROUGH A CAR WASH IN TEMPERATURE OF 39 DEGREES. AFTER GOING THROUGH THE CAR WAS I WAS TRAVELING ABOUT 5 MPH THROUGH A PARKING LOT TO PARK IN FRONT OF A CONVENIENCE STORE, THE TRUCK STUCK THE CURB, AND NEARLY STRUCK PROPANE TANKS STORED IN FRONT OF STORE. AFTER DRYING THE VEHICLE AND WAITING ABOUT 15 MINUTES I PROCEEDED TO THE INTERSECTION IN FRONT OF BUSINESS AND BRAKES FAILED AGAIN. *NM

• 12/25/2020· STRUCTURE

  TRUCK WAS TAKEN IN FOR COOLANT LEAK. TECHNICIAN FOUND THE FRAME TO BE RUSTED THROUGH AND WAS ADVISED TRUCK WAS NO LONGER SAFE TO OPERATE. TRUCK WAS STATIONARY IN DEALERS REPAIR BAY.

• 12/25/2005· SUSPENSION

  OVER NORMAL USE OF THE VEHICLE, IT HAS SUSTAINED SEVERAL PAINT CHIPS. THE PAINT HAS BEEN CHIPPED ON THE FRONT SIDE OF THE BED, FROM DEBRIS BEING THROWN UP BY THE FRONT TIRES, AND ON THE ROCKER PANELS. TOYOTA OBVIOUSLY THOUGHT OF THE ISSUE BY PLACING A THICKER COAT ALONG THE BOTTOM OF THE VEHICLE. IT DID NOT WORK. THE REAR SPRINGS ARE ALSO SQUEAKING ALREADY. USUALLY NOT AN ISSUE AS THE BUSHINGS WEAR OUT, BUT A LITTLE CONCERNED AFTER ONLY 4600 MILES HAVE BEEN PUT ON THE VEHICLE. *NM

• 12/24/2014· STRUCTURE

  TOYOTA SENT ME A RECALL NOTICE (THAT WAS NOT LISTED ON YOUR SITE) FOR RUST ON THE FRAME. I HAD THE DEALERSHIP INSPECT IT AND THEY SAID THAT IT IS BAD AND TOYOTA WILL REPLACE THE FRAME. THE DEALERSHIP IS TELLING ME THAT SPECIFIC PARTS (THE POWER STEERING RACK AND LINES) THAT ARE RUSTY WILL NOT BE ABLE TO BE PUT BACK WHEN THE FRAME IS REPLACED (AND THE TRUCK ASSEMBLED AGAIN) BUT I HAVE TO PAY THE COST. I HAD THOSE SPECIFIC PARTS LOOKED AT BY MY MECHANIC AND ALTHOUGH A PORTION (THE LINES ARE BAD AND I AM HAVING REPLACED) THE PS RACK IS NOT IN BAD CONDITION. I CONTACTED TOYOTA TO SEE WHAT THEY WILL COVER AND WAS TOLD THEY WILL NOT COVER PARTS THAT ARE NOT THE FRAME. MY TRUCK IS 10 YEARS OLD. IT IS IN GREAT CONDITION AND RUNS GREAT AND I PLANNED TO KEEP IT FOR A LONG TIME. MY CONCERN IS THAT WHEN YOU TRY TO DISASSEMBLE A WHOLE VEHICLE (WHICH IS 10 YEARS OLD) SOME OF THE PARTS THAT ARE IN GOOD WORKING CONDITION, ONCE BANGED AROUND TRYING TO REMOVE THEM, WILL BREAK. I AM CONCERNED THAT I HAVE TO PAY FOR THESE PARTS. IF TOYOTA IS REPLACING THE FRAME DUE TO SAFETY ISSUES, ISN'T IT THEIR RESPONSIBILITY TO REPLACE OTHER PARTS THAT WERE FINE PRIOR TO MAKING THE RECALL FIX? *TR

• 12/23/2015· SUSPENSION,STRUCTURE

  2005 TOYOTA TACOMA. CONSUMER WRITES IN REGARDS TO VEHICLE FRAME RUST. *SMD THE CONSUMER STATED HE TOOK THE VEHICLE TO THE DEALER SEVERAL TIMES, ONLY TO BE TOLD THERE WAS NOTHING WRONG WITH THE VEHICLE. IN 2014, THE DEALER WAS AMAZED AT HOW BAD THE RUST WAS. *JB

• 12/22/2018· STEERING

  STARTED TRUCK AND WHEN PULLING OUT OF DRIVEWAY STEERING BECOME EXTREMELY STIFF. NO UNUSUAL SOUNDS. STIFFNESS IS NOT ALWAYS THERE, IT PULSATES. FLUID LEVEL AND COLOR ALL WITHIN SPECS. BELT WITHIN SPECS. I PLAN ON PUTTING IT ON A LIFT WHEN I RETURN HOME AND PREFORM AN INSPECTION. SUSPECT U JOINT FAILURE.

• 12/21/2010· VEHICLE SPEED CONTROL

  2005 TOYOTA TACOMA. CONSUMER IS EXPRESSING DISCONTENT WITH THE SERVICE RECEIVED FOR THE FLOOR MAT INTERFERENCE RECALL. *KB THE CONSUMER STATED ACCORDING TO THE INVOICE, THE ACCELERATOR PEDAL WAS MODIFIED. THE CONSUMER STATED WHEN HE QUESTIONED THE SERVICE TECH ABOUT REPLACING THE ALL WEATHER FLOOR MATS, SHE WAS UNAWARE OF THAT PORTION OF THE RECALL. THE CONSUMER SHOWED HER A COPY OF THE RECALL NOTICE. THE SERVICE TECH THEN ASKED SOMEONE ELSE AND THE RESPONSE WAS; NO ALL WEATHER FLOOR MATS HAVE BEEN RECEIVED FOR THE RECALL. THE CONSUMER ASKED IF HE COULD BE PLACED ON A LIST, HE WAS INFORMED HE WOULD HAVE TO CALL IN ABOUT TWO MONTHS TO SEE IF ANY WERE AVAILABLE. ON TWO SEPARATE OCCASIONS, THE CONSUMER EXPERIENCED SUDDEN ACCELERATION. *JB

• 12/20/2014· STEERING

  WHEN TURNING THE STEERING WHEEL IN EITHER DIRECTION I HAVE EXTREMELY STIFF STEERING. IT SEEMS TO STICK AND IS NOT FLUID WHEN TURNING. I AM CONCERNED THAT THIS CAN CAUSE AN ACCIDENT WHILE DRIVING. I HAVE CHECKED THE STEERING POWER FLUID LEVEL AND IT IS AT THE CORRECT LEVEL.

• 12/19/2012· SUSPENSION,STRUCTURE

  VEHICLE WAS AT DEALER SHOP FOR BRAKE JOB AND TECHNICIAN REPORTED RUSTED-THROUGH FAILURE OF FRAME WHICH RENDERS THE VEHICLE UNSAFE TO DRIVE. THIS IS A SECOND GENERATION TACOMA, 2005 MODEL YEAR. *TR

• 12/19/2007· STRUCTURE

  MOTOR MOUNT FAILURE / FRAME FALIURE. *TR

• 12/18/2014· SUSPENSION

  I WAS DRIVING MY TRUCK WHEN SUDDENLY I HEARD A CLUNK AND MY TRUCK JERKED LIKE MY RIGHT REAR WHEEL LOCKED UP THEN MY TRUCK BOUNCED. I PULLED OVER BUT I WASN'T SURE WHAT TO LOOK FOR. I TOOK MY TRUCK IN TO LITHIA TOYOTA AND WAS TOLD THEY SAW NOTHING WRONG BUT I TOLD THEM I THINK SOMETHING BROKE. I WAS TOLD MY SHOCKS MIGHT HAVE GONE BAD. I LATER HAD MY SHOCKS REPLACED BECAUSE THEY SAID THE SHOCKS WILL HELP MY RIDE. LATER I FOUND OUT BY RESEARCHING THAT IT IN FACT WAS NOT A SHOCK ISSUE, AND THAT OTHERS HAVE LEAF SPRING ISSUES SO I TOOK TO A LOCAL MECHANIC AND THEY SAID THEY WERE SHOT. WHEN I MENTIONED THIS TO LITHIA TOYOTA THEY SAID I COULD REPLACE THEM BUT IT WOULD BE OUT OF MY POCKET COSTS. I TOLD THEM I THINK IT BROKE OFF AND THAT I HAD SPOKEN WITH THEM BEFORE BUT NOTHING WAS DONE. 6 MONTHS HAVE PASSED AS MY TRUCK EVERYDAY RIDE WAS BOUNCY, BOTTOMED OUT SO I COULD NOT TRAVEL LONG DISTANCES DUE TO THIS ISSUE. I FINALLY RECEIVED A LETTER FROM TOYOTA STATING THEY HAVE A RECALL FOR LEAF SPRINGS FOR MY TRUCK.I TOLD THEM THAT I WASN'T SURPRISED. I WAS TREATED BY TOYOTA LIKE I WAS MAKING IT UP AND THAT I WAS JUST TRYING TO GET SOMETHING FOR FREE WHEN IN FACT IT WAS A SAFETY ISSUE WHICH COULD HAVE BEEN TAKEN CARE OF WHEN I FIRST REPORTED MY PROBLEM. PLUS I DON'T THINK I NEEDED TO REPLACE MY SHOCKS AND NOW AM OUT THAT MONEY. *TR

• 12/18/2007· POWER TRAIN,STRUCTURE

  THE EVENTS LEADING UP TO THE INCIDENT WAS DRIVING MY VEHICLE ON VACATION. THE MOTOR MOUNT ON THE VEHICLE BROKE, AND THE ENGINE WAS LEANING TO THE DRIVER SIDE. TOYOTA REFUSED COVERAGE FOR A NUMBER OF REASONS, INCLUDING SAYING IT WASN'T COVERED UNDER WARRANTY, MY AFTERMARKET SHOCKS CAUSED THE MOTOR MOUNT TO BREAK, MY HEAVY FRONT BUMPER CAUSED THE PROBLEM, AND THEY SAID I DROVE THE TRUCK TO HARD. UNDER THE MAGNUSSON-MOSS ACT, I ASKED THEM TO PROVE THAT MY AFTERMARKET PRODUCTS CAUSED THE FAILURE. THEY EXPLAINED THAT THEY COULDN'T DO THAT AND OFFERED ME ARBITRATION. BECAUSE OF THE COST OF RENTING A CAR WHILE WAITING FOR ARBITRATION, I DECIDED TO FIX THE TRUCK OUT OF MY OWN POCKET AND TAKE TOYOTA TO SMALL CLAIMS COURT. I WON MY CASE, AND TOYOTA WAS ORDERED TO PAY ME $2,900.00. SINCE MY COURT CASE, I HAVE JOINED AN INTERNET FORUM IN WHICH THERE HAS BEEN AT LEAST 5 OTHER 2005 TACOMAS WITH THE SAME EXACT ISSUE; MOST RECENTLY LAST WEEK. TOYOTA NEEDS TO RECOGNIZE THIS IS A PROBLEM BEFORE SOMEONE DIES BEHIND THE WHEEL AS A RESULT OF ENGINE MOUNT FAILURE. *TR

• 12/17/2019· STRUCTURE

  TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT TOOK THE VEHICLE TO HALTERMAN'S TOYOTA (1741 PARADISE TRAIL, EAST STROUDSBURG, PA 18301, (570) 273-9454) TO HAVE THE BRAKES SERVICED. THE MECHANIC POINTED OUT THAT THERE WERE MULTIPLE HOLES FOUND WITHIN THE FRAME OF THE VEHICLE. THE CONTACT WAS INFORMED THAT THERE WAS AN UNKNOWN MANUFACTURER RECALL ON THE VEHICLE AND THAT IT NEEDED TO BE SERVICED. THE CONTACT WAS PROVIDED A RENTAL VEHICLE AND, AFTER SIX WEEKS, THE CONTACT WAS INFORMED THAT THEY DID NOT HAVE THE PART TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 167,000.

• 12/16/2008· STRUCTURE

  AT HIGHWAY SPEEDS I GET A WHISTLING/WHINE IN THE FIREWALL AREA. SOMETIMES IT SEEMS TO BE THE RIGHT SIDE AND OTHERS THE LEFT, DEPENDING ON THE WIND DIRECTION. I HAVE SEARCHED AND HAD A DEALER SEARCH FOR THE CAUSE TO NO AVAIL. SURELY MY VEHICLE IS NOT THE ONLY 05 TACOMA EXPERIENCING THIS PROBLEM. ANY ASSISTANCE WILL BE GREATLY APPRECIATED. *TR

• 12/15/2014· SERVICE BRAKES, HYDRAULIC,STRUCTURE

  2005 TOYOTA TACOMA. CONSUMER STATED ISSUES WITH FRAME OF VEHICLE AND BRAKE LINES LEAKING. THE DEALER INFORMED THE CONSUMER THE FRAME HAD RUSTED THROUGH AND NEEDED TO BE REPLACED. HE WAS INFORMED, IT WOULD BE TWO MONTHS, BEFORE THE PARTS WERE AVAILABLE TO FIX THE FRAME. THE CONSUMER STATED THE BRAKES WERE FINE, WHEN ARRIVED AT THE REPAIR SHOP. THE CONSUMER BELIEVED THE REPAIR SHOP DAMAGED THE BRAKE LINES, WHEN THEY CHECKING THE FRAME. AFTER TWO MONTHS PASSED, THE CONSUMER CALLED THE REPAIR SHOP AND WAS INFORMED THE PARTS HAD ARRIVED. HOWEVER, THEY DID NOT HAVE THE KITS. *JB

• 12/14/2013· ENGINE AND ENGINE COOLING

  FRAME AT PASSENGER SIDE MOTOR MOUNT IS CRACKED AND FAILED. BECAUSE IT'S VERY UNUSUAL FOR A TRUCK FRAME TO CRACK, NOTIFIED TOYOTA (HILO, HAWAII) OF THE PROBLEM AND ASKED IF THERE IS A RECALL TO ADDRESS IT. TOYOTA SAID IT'S NORMAL WEAR AND TEAR AND THERE IS NO RECALL. *TR

• 12/14/2012· STRUCTURE

  TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE SPARE TIRE FELL AND DETACHED FROM THE VEHICLE. THE SPARE TIRE WAS LOCATED UNDER THE VEHICLE AND THE CONTACT STATED THAT THE ENTIRE CROSS MEMBER ON THE REAR OF THE VEHICLE BECAME RUSTED. THE CONTACT STATED THAT HALF OF THE REAR CROSS MEMBER ALSO FRACTURED AND DETACHED FROM THE VEHICLE. THE CONTACT ALSO STATED THAT THE CROSS MEMBER THAT WAS LOCATED IN THE CENTER OF THE VEHICLE WAS ALSO COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 145,000.

• 12/14/2008· STRUCTURE

  2005 TOYOTA TACOMA FRONT MUD FLAP BROKEN AND RUBBED THROUGH THE PAINT PRIOR TO ME KNOWING THE FLAP WAS BROKEN. HAPPENED AT ABOUT 40,000 MILES. NEVER OFFROAD OR ANYTHING LIKE THAT. ALL CITY/HIGHWAY MILES. *TR

• 12/13/2005· LATCHES/LOCKS/LINKAGES

  2005 TACOMA PASSENGER DOOR WOULD NOT LATCH CLOSED, WHEN DOOR WAS CLOSED. HAD TO HOLD DOOR CLOSED UNTIL TRUCK WAS DRIVEN HOME. THERE WERE TWO PEOPLE IN TRUCK, ONE TO DRIVE THE OTHER TO HOLD DOOR SHUT. NEXT BUSINESS DAY TOOK TRUCK TO DEALER FOR REPAIRS. NO REPAIR FOR FAULTY PART, PART WAS PUT ON ORDER, A TEMP FIX WAS DONE SO DOOR WOULD REMAIN CLOSED. WAS ADVISED NOT TO USE DOOR UNTIL NEW PART WAS INSTALLED. *NM

• 12/12/2023· SUSPENSION,STRUCTURE

  Frame failure due to rust. Suspension is detached with springs hitting frame. NOTE: fuel tank partially detached previously due to rusted brackets 3-4 years ago and all components were replaced. Filed NHTSA report at that time however had technical issues completing… Still have photos.

• 12/12/2017· SUSPENSION

  I RECEIVED SEVERAL RECALL NOTICES FROM TOYOTA AND TOOK MY VEHICLE TO THE DEALER MULTIPLE TIMES, BUT THE REPAIR DEPT KEPT INFORMING ME THAT A FIX HASN'T BEEN FINALIZED YET. CONTRADICTING TO TO RECALL NOTICE, THEY TOLD ME THIS ISSUE WAS NOT A "BIG DEAL." ACCORDING TO THE RECALL, THERE IS A POSSIBILITY THAT A LEAF COULD FRACTURE DUE TO STRESS AND CORROSION. AND, IF THIS OCCURS AND THE VEHICLE CONTINUES TO BE OPERATED, THE BROKEN LEAF COULD MOVE OUT OF POSITION AND CONTACT SURROUNDING COMPONENTS, INCLUDING THE FUEL TANK. IF THE BROKEN LEAF CONTACTS THE FUEL TANK REPEATEDLY, IT COULD PUNCTURE THE TANK AND CAUSE A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, THIS COULD RESULT IN A FIRE. TOYOTA CLAIMED THEY WOULD REPLACE THE LEAF SPRINGS WITH NEWLY DESIGNED ONES, BIT THIS HAS YET TO HAPPEN.

• 12/11/2014· SUSPENSION

  TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHILE THE VEHICLE WAS BEING INSPECTED, THE MECHANIC DISCOVERED THAT THE REAR LEAF SPRINGS FRACTURED. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). AFTER THE RECALL REPAIR WAS PERFORMED, THE REAR OF THE VEHICLE BEGAN TO LOWER TOWARDS THE GROUND. IN ADDITION, THE VEHICLE WAS DIFFICULT TO VEER AND SWERVED WHEN DRIVING. THE CONTACT MENTIONED THAT THE RECALL PART INSTALLED WAS THE INCORRECT SIZE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 174,764.

• 12/11/2014· STEERING,STRUCTURE

  TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE SPARE TIRE COULD NOT BE REMOVED FROM THE VEHICLE DUE TO RUST UNDER THE VEHICLE. ADDITIONALLY, THERE WAS RUST ON THE STEERING COLUMN THAT REQUIRED FREQUENT LUBRICATION. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE SPARE TIRE WAS RUSTED TO THE FRAME OF THE VEHICLE AND THERE WAS NO REMEDY AVAILABLE AT THE TIME. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

• 12/11/2006· VEHICLE SPEED CONTROL

  WHILE USING THE CRUISE CONTROL AT FREEWAY SPEED, DRIVING UP AN INCLINE. THE TRANSMISSION DOWNSHIFTED VIOLENTLY TWO GEARS FROM 5TH TO 3RD. ACTUAL SPEED ACCELERATION HAPPENED ENOUGH TO NEARLY CAUSE A REAR END COLLISION. I HAD TO MANUALLY CANCEL CRUISE CONTROL TO REGAIN SAFE CONTROL....*JB

• 12/10/2014· STRUCTURE

  I TOOK MY TACOMA TO THE LOCAL DEALERSHIP FOR LEAF SPRINGS AND A CHECK OF CORROSION OF FRAME ON DECEMBER 7, 2014 AND FOUND OUT I HAD TWO HOLES IN THE FRAME. THE WOULDN'T LET ME TAKE MY TRUCK, BECAUSE OF SAFETY ISSUES. THE DEALER GAVE ME A RENTAL CARE FOR NOW AT TOYOTA'S EXPENSE. THEY SAID TOYOTA WANTS TO JUST REPLACE THE FRAME? THEN MY TRUCK WILL HAVE A SALVADGED TITLE IN PA. I NEED TO HELP, I WANT THE SAME DEAL OTHER TACOMA OWNERS GOT THE LAST TIME FOR THE SAME PROBLEM. *TR

• 12/10/2010· SUSPENSION

  I PURCHASED A BRAND NEW TACOMA 2005 TRD 4X4 4 DOOR FROM THE DEALER IN 2004. IN 2009 THE TRUCK STARTED MAKING POPPING, CRACKING, AND SQUEAKING NOISES FROM THE SUSPENSION AND FROM THE ENGINE. NOW, THE TRUCK MAKES SQUEAKING AND CRACKING NOISES JUST GETTING IN AND OUT OF THE TRUCK AND EVEN JUST OPENING AND CLOSING THE DOOR. I TOOK THE TRUCK INTO SEVERAL SHOPS COULD NOT DETERMINE THE CAUSE. I STARTED RESEARCHING ONLINE, FOUND NUMEROUS 2005 TACOMAS'S WITH THE SAME PROBLEM. THIS IS WHEN I FOUND OUT THAT SEVERAL RECALLS WERE MADE ON TACOMA, BUT WE WERE NEVER NOTIFIED. ON 12/9/2010, I CALLED THE DEALER, I WAS TOLD THAT TOYOTA ACKNOWLEDGE POPPING NOISE FROM THE ENGINE ON 6/28/2005 AND ACKNOWLEDGE REAR SUSPENSION SQUEAKING NOISES ON 8/13/2009, BUT THE DEALER CLAIMED THAT THE TRUCK HAS TO BE UNDER 3 YEARS OLD OR 36,000 MILES TO COVER UNDER WARRANTY. THIS IS MANUFACTURE DEFECTS, TOYOTA SHOULD BE RESPONSIBLE FOR CORRECTING THIS PROBLEM, THEY DID NOT NOTIFIED THE OWNER WITHIN WARRANTY PERIOD. *TR

• 12/09/2009· VEHICLE SPEED CONTROL

  I HAVE A TOYOTA TACOMA 2005. ON DECEMBER 6, 2009 AT APPROXIMATELY 3PM I WAS HEADING SOUTH ON I-190 IN NIAGARA FALLS NY. CRUISE WAS ON,BUT HAD TO TAP BREAKS BECAUSE OF SLOWER MOVING VEHICLE. THIS DID DISENGAGE THE CRUISE & MY TRUCK BEGAN TO SLOW DOWN. WHEN THE CAR MOVED OVER I DEPRESSED THE ACCELERATOR AND AT THAT TIME THE TRUCK WENT INTO OVERDRIVE/PASSING GEAR. THE MOTOR WAS ROARING AND I HAD NO BREAKS . THEY WERE LIKE A ROCK.IT ACCELERATED TO OVER 94MPH.IT THEN DISENGAGED ON IT'S OWN& THE SPEED DECREASED. I THEN TURNED OFF THE CRUISE CONTROL NOT SURE HOW LONG THIS WENT ON BUT IT SEEMED LIKE AN HOUR. AND YES I PANICKED. THIS IS NOT A MAT PROBLEM / THIS TRUCK IS A DEATH TRAP. I WAS TOLD IT COULD NOT BE REPAIRED UNTIL APRIL OF 2010 (5MONTHS). *TR

• 12/08/2011· POWER TRAIN,STRUCTURE

  MY 2005 TOYOTA TACOMA QUAD CAB SR5 HAS AN ISSUE WITH THE TRANSMISSION. AT A COMPLETE STOP WITH MY FOOT FIRMLY ON THE BRAKE MY TRUCK LUNGES FORWARD IN A VERY DANGEROUS ABRUPT MANNER AS THOUGH SOMEONE REAR ENDED ME. THIS HAPPENS OFTEN AT STOP LIGHTS A FEW SECONDS AFTER I COME TO A COMPLETE STOP. A SECOND ISSUE IS THAT MY PAINT IS CRACKING AND PEELING ON MY ROOF AND MY CLEAR COAT IS NOTICEABLY BAD ON THE EDGES OF MY HOOD AND DOORS. MY TRUCK IS NOT OF APPROPRIATE AGE OR WEATHER CONDITIONS TO HAVE THESE TYPES OF PAINT PROBLEMS. TOYOTA REFUSES TO INVESTIGATE OR PAY FOR MY ISSUES AND JUST RECOMMENDS THAT I GO PAY A DEALER TO FIX IT OUT OF MY POCKET. I SEE SEVERAL OTHERS WITH THE EXACT SAME PROBLEMS ON MANY BLOGS, CLASS ACTION ANYONE? *TR

• 12/07/2009· STRUCTURE

  ENGINE MOTOR MOUNT TO FRAME SUPPORT BRACKET WAS WELDED USING TOO HIGH OF A CURRENT SETTING ON ROBOT WELDER AND WELD IS UNDERCUT INTO BASE METAL ON FRAME. THIS HAS THE POTENTIAL TO CRACK OR RUST THROUGH OVER TIME AND CAN CAUSE THE ENGINE TO BREAK LOOSE FROM THE FRAME. ON 2005 AND 2006 TOYOTA TACOMA'S . TOYOTA HAS MADE A CORRECTION TO THE 2007 MODELS BY ADDING A REINFORCEMENT PLATE OVER THE FRAME IN THIS AREA BEFORE WELDING IN THE MOTOR MOUNT SUPPORT PROVING THEY HAVE REALIZED THAT THIS IS A DEFECT THAT NEEDS TO BE CORRECTED TO EARLIER MODELS. PICTURES SHOWING THIS CAN BE SEEM AT (WWW.TACOMAWORLD.COM ) SHOWING FAILED MOTOR MOUNTS AND HOW CONSUMERS ARE REPAIRING THE FAILED FRAME AND HAVE PICTURES OF THE CORRECTIONS MADE AT THE PRODUCTION FACILITY THE MANUFACTURES THE TACOMA FRAMES FOR TOYOTA. I WOULD APPRECIATE IT IF YOU WOULD CONSIDER INVESTIGATING THIS BEFORE IT CAUSES ANY PERSONAL INJURY TO SOMEONE.. THANK YOU FOR YOUR HELP. *TR

• 12/05/2017· ENGINE

  DRIVING DOWN THE ROAD AND HEAD GASKET APPARENTLY BLOWN AFTER OWNING FOR THREE MONTHS. NO WARNING JUST BLEW. 30 MILES AWAY FROM HIGHWAY AND NO CELL SERVICE.

• 12/05/2014· SUSPENSION,POWER TRAIN,STRUCTURE

  THE FRAME IS RUSTING. THERE ARE HOLE STARTING TO FORM. *TR

• 12/05/2014· ENGINE AND ENGINE COOLING,STRUCTURE

  THE CATALYTIC CONVERTER SHIELD ON MY 2005 TACOMA FELL OFF WHILE DRIVING AND ALMOST CAUSED AN ACCIDENT. AFTER PICKING UP THE LARGE METAL PARTS AND INSPECTING UNDER THE VEHICLE, I NOTICED THAT NEAR TO WHERE THE CATALYTIC CONVERTER SITS, THAT THERE WAS EXTENSIVE CORROSION ON THE TRUCK'S FRAME AND EVEN A LARGE HOLE. I AM EXTREMELY WORRIED ABOUT THE SAFETY OF THE VEHICLE AND AM AFRAID THAT THE FRAME MAY CRUMPLE WHILE DRIVING CAUSING AN ACCIDENT OR DEATH. TOYOTA IS AWARE OF THE ISSUE. I CONTACTED THE CORPORATE OFFICES, BUT WAS TOLD THAT TOYOTA IS ONLY REPLACING THE FRAME ON VEHICLES REGISTERED IN WHAT THEY HAVE DESIGNATED AS A "SNOW STATE". I PURCHASED MY TOYOTA AT A DEALERSHIP IN ILLINOIS (A "SNOW STATE") AND HAVE DONE A LOT OF TRAVELING WITHIN THE "SNOW STATES", YET BECAUSE I LIVE 25 MILES AWAY ON THE MISSOURI SIDE, TOYOTA IS REFUSING TO COVER THE REPAIR. THE WOMAN FROM TOYOTA CORPORATE DID NOT SEEM TO CARE WHEN I TOLD HER THAT I WAS WORRIED ABOUT THE SAFETY OF THE VEHICLE AND THAT IT COULD RESULT IN AN ACCIDENT OR DEATH. I OFFERED TO EMAIL THE PHOTOS OF THE FRAME CORROSION, BUT WAS REJECTED. TOYOTA NEEDS TO COVER THIS REPAIR ON ALL VEHICLES WITH FRAME CORROSION REGARDLESS OF THE STATE THEY LIVE IN. *TR

• 12/04/2015· SUSPENSION

  TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THE VEHICLE WAS MAKING AN ABNORMAL NOISE, WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE LEAF SPRINGS NEEDED TO BE REPLACED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 196,219. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

• 12/04/2006· STRUCTURE

  I WAS LOADING A MOTORCYCLE INTO THE BACK OF MY 2005 TOYOTA TACOMA AND THE TAILGATE COLLAPSED. I HAVE OWNED THIS TRUCK FOR A YEAR AND A HALF AND THIS IS THE FIRST TIME I'VE EVER PUT ANY WEIGHT ON THE TAILGATE OF THE TRUCK. AFTER DOING SOME RESEARCH ON THE INTERNET, IT SOUNDS LIKE THOUSANDS OF PEOPLE ARE EXPERIENCING THE SAME THING. THERE IS NO MENTION FROM TOYOTA IN THE OWNERS MANUAL OR ANY ASSOCIATED DOCUMENTS THAT THE TAILGATE IS INCAPABLE OF HANDLING A LOAD. THE WEIGHT RATING FOR THE CARGO BOX IS LISTED AT 1000 POUNDS BUT THERE IS NOTHING ON THE TAILGATE. I HAVE OWNED A FORD RANGER AND A CHEVY S-10 IN THE PAST AND NEVER HAD ANY PROBLEM LOADING A BIKE IN THE BED. I HAVE PICTURES OF THE COLLAPSED TAILGATE AVAILABLE. FORTUNATELY, NO ONE WAS SERIOUSLY INJURED IN THIS BUT IT COULD HAVE BEEN POTENTIALLY FATAL IN THE BIKE HAD FALLEN ON ONE OF THE MEN LOADING THE BIKE. TOYOTA WON'T ADDRESS THIS PROBLEM AND IS BLAMING THIS ON THE CONSUMERS. *JB

• 12/04/2004· ENGINE AND ENGINE COOLING,POWER TRAIN

  2005 TOYOTA TACOMA 2WD MANUAL WITH 800 MILES DEVELOP A MAJOR OIL LEAK BETWEEN THE TRANSMISSION AND THE CRANK SHAFT. GEAR SHIFT NOT SMOOTH. *AK

• 12/03/2013· STRUCTURE

  TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRONT FRAME WAS CORRODED. THE CONTACT ALSO MENTIONED THAT THERE WAS A HOLE IN THE METAL FRAME WHERE IT BEGAN TO SEPARATE. THE VEHICLE WAS TAKEN TO A DEALER, WHO STATED THAT THE FRONT PORTION OF THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 98,000. ..UPDATED 12-30-13 *BF THE CONSUMER STATED THE REAR FRAME WAS BEGINNING TO CORRODE. UPDATED 1/22/2014 *JS

• 12/02/2015· SUSPENSION

  TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THE VEHICLE WAS MAKING AN ABNORMAL NOISE WHILE DRIVING AT APPROXIMATELY 25 MPH. IN ADDITION, THE VEHICLE JERKED WHEN MAKING A STOP. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. VIN TOOL CONFIRMS PARTS UNAVAILABLE.

• 12/02/2013· STRUCTURE

  LAST MONTH I LOOKED UNDERNEATH MY TRUCK AND DISCOVERED SIGNIFICANT FRAME RUST. THE MOST SIGNIFICANT AREAS ARE BETWEEN STEEL FRAME COMPONENTS THAT ARE RIVETED TOGETHER. RUST HAS FORMED BETWEEN THESE PLATES AND IS PUSHING THEM APART. THERE IS UP TO 3/8" DEFORMATION BETWEEN PLATES. THE PLATES WERE ORIGINALLY IN CONTACT WITH EACH OTHER. THE PLATES ARE STILL IN CONTACT WITH EACH OTHER AT RIVET POINTS. THE CONDITIONS OF THE CONCEALED PORTIONS OF THE RIVETS ARE UNKNOWN. THE RUST IS LOCATED PRIMARILY UNDER THE TRUCK BED, BUT THERE IS SOME UNDER THE PASSENGER CAB. AN INTERNET SEARCH INDICATES THIS IS NOT AN ISOLATED INCIDENT. THE VEHICLE HAS NOT BEEN MISTREATED AND HAS FOLLOWED ALL MANUFACTURER RECOMMENDED MAINTENANCE. I AM ALSO AWARE OF THE 2001-2004 TACOMA FRAME RECALL. I WILL BE CONTACTING TOYOTA IN THE NEAR FUTURE WITH THE HOPE THEY WILL PROPERLY ADDRESS THIS SITUATION. *TR

• 12/02/2008· STRUCTURE

  I HAVE A 2005 TOYOTA TACOMA DOUBLE CAB TRD SPORT. THE MOTOR MOUNTS ON MY VEHICLE HAVE BECOME "RIPPED" OFF THE FRAME OF THE VEHICLE SOMEHOW AS TOYOTA HAS STATED TOWARDS ME AND THIS TO ME SEEM LIKE A SAFETY ISSUE. I HAVE HEARD OF ONE INSTANCE OF A GUY WHO WAS DRIVING DOWN THE FREEWAY WHEN HIS ENTIRE FRAME COLLAPSED DUE TO HIS MOTOR MOUNTS CAVING IN HIS FRAME! THIS SEEMS LIKE A SERIOUS SAFETY ISSUE AND MY TRUCK HAS HAD IT HAPPEN AS WELL JUST NOT CAVE IN MY FRAME AND HAS RIPPED AWAY FROM IT. MAKING MY ENGINE SIT CROOKED AND LEANING FORWARD IN MY ENGINE BAY. IT HAS BEEN QUITE SCARY DRIVING IT RECENTLY AND TOOK IT IN AS SOON AS I REALIZED THE PROBLEM. *TR

• 12/01/2017· VISIBILITY/WIPER

  SUN VISORS WILL NOT STAY UP PART WAY. THEY DROP COMPLETELY AND BLOCK THE DRIVERS VIEW.I HAD THE SAME PROBLEM WITH MY OTHER TOYOTAS: 2006 COROLLA, 2007 COROLLA, AND 2010 COROLLA. THE VISOR WOULD DROP AT ALL TIMES WHEN IN USE.