2005 Saturn ION

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2014· STEERING

  I TOOK MY CAR IN FOR A RECALL ON THE STEERING AND THE SAID THEY REPLACED THE ELECTRIC STEERING MOTOR. IT STILL HAD NO STEERING . THE GM DEALER SAID IT WAS 58.00 TO TELL ME WHAT WAS WRONG, THE DEALER CAME BACK AND SAID THAT IT WAS THE STEERING MODULE WAS BAD. GM CUSTOMER SERVICE SAYS THE MODULE IS COVERED BUT THE GM DEALER WONT REPLACE IT BECAUSE THEY SAY THAT THE MODULE IS PART OF THE STEERING COLUMN AND ITS ON COVERED FOR THE STEERING COLUMN. I HAVE BEEN GOING ROUND AND ROUND FOR 30 DAYS AND NO AVAIL. I NEED SOME HELP. I AM SENDING THIS FOR MY STEP-DAUGHTER [XXX] WHO IS THE OWNER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *JS

• 12/28/2010· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHEN TRYING TO START THE VEHICLE, THE LOCK OUT WARNING LIGHT WOULD ILLUMINATE AND THE VEHICLE FAILED TO START. THE CONTACT STATED THAT THE FAILURE WOULD ONLY OCCUR ON AN INTERMITTENT BASIS WHEN THE TEMPERATURE WAS 35 DEGREES AND BELOW. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT THEY WOULD NEED TO REPLACE THE STARTER. THE STARTER FOR THE VEHICLE WAS REPLACED YET THE FAILURE PERSISTED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 20,000.

• 12/28/2009· ELECTRICAL SYSTEM

  KEY WILL NOT RELEASE FROM MY IGNITION. IT APPEARS THAT THE IGNITION DOES NOT READ THAT THE STICK SHIFT IS ENGAGED IN PARK AND DOES NOT RELEASE THE KEY FROM THE IGNITION. THIS BEGAN HAPPENING JUST AS MY CAR REACHED 60,000 MILES (MY CAR IS CURRENTLY AT 84,000). THERE DOES NOT SEEM TO BE ANY PATTERN TO THE PROBLEM, JUST RANDOM AND IN ANY WEATHER CONDITION. SOMETIMES I JUST HAVE TO LEAVE THE KEY IN THE IGNITION AND LEAVE THE VEHICLE. THE KEY IS STILL IN ACCESSORY MODE AND DOES DRAIN THE BATTERY. I BROUGHT IT TO THE DEALER AT MY FIRST INCIDENCE AND THE IGNITION WAS REPLACED. IT WAS COVERED UNDER THE WARRANTY AT THE TIME, BUT THE WARRANTY EXPIRED JUST AFTER.*TR

• 12/27/2022· STEERING,ELECTRICAL SYSTEM

  Power steering intermittently fails at random and steering wheel suddenly becomes immovable nearly causing serious accidents and endangerment to myself, my family, and others drivers on the roads.

• 12/26/2011· STEERING

  WHILE DRIVING DOWN THE ROAD AT NORMAL SPEED 55 MPH WE GET A DING DING DING WITH A PWR STEER LIGHT TO COME ON AND THEN WE HAVE NO POWER STEERING. LUCKILY MY HUSBAND WAS DRIVING. AFTER CALLING THE SATURN DEALERSHIP IT APPEARS TO BE THE POWER STEERING ASSIST MODULE. THIS IS DANGEROUS DUE TO YOU NOT GETTING MUCH OF A WARNING. *TR

• 12/26/2007· ELECTRICAL SYSTEM

  OUR SATURN ION 3 WOULD NOT TURN OFF. APPARENTLY THERE IS A SERIOUS PROBLEM WITH THE IGNITION IN THESE CARS. WHY HASN'T SATURN/GENERAL MOTORS RECALLED THIS PART. SOMEONE COULD GET KILLED. WE HAVE HAD IT REPAIRED ONLY TO HAVE IT HAPPEN A SECOND TIME. *TR

• 12/25/2007· SERVICE BRAKES, HYDRAULIC,POWER TRAINCrash

  PASSENGER FRONT WHEEL OF A 2005 SATURN ION 3, STILL UNDER FACTORY WARRANTY WITH 27,000 MILES, LOCKED UP ON DEC 22, 2007 CAUSING A SINGLE CAR COLLISION. AN ASE CERTIFIED MECHANIC LOOKED THE CAR OVER AFTER HAVING IT TOWED TO MY RESIDENCE AND SAW THAT THE SPINDLE WAS BROKEN, BUT THERE WAS NO SIGN OF OTHER DAMAGE TO THE VEHICLE THAT WOULD CAUSE ENOUGH FORCE TO BREAK THE SPINDLE. HIS OPINION IS THAT THE SPINDLE (CAST ALUMINUM) WAS OVER-TIGHTENED AT THE DEALERSHIP AND HAD A DEFECT/HAIRLINE CRACK THAT FINALLY FAILED. THE FAILURE HAPPENED AT 60 MILES PER HOUR, CAUSING THE VEHICLE TO SLAM INTO THE GUARDRAIL, THEN SPIN INTO A DITCH. WHEN THE SPINDLE FAILED AND THE VEHICLE PULLED SHARPLY TO THE RIGHT, I ATTEMPTED TO HIT THE BRAKES WHICH WENT TO THE FLOOR AND DID NOTHING. INSURANCE HAS REFUSED TO COVER THE DAMAGE, AND DECLARED THE DAMAGE A MANUFACTURER DEFECT. *TR

• 12/24/2009· ELECTRICAL SYSTEM

  CAR WILL NOT START WHEN IT IS VERY COLD OUT! KEY WILL TURN, RADIO ETC. WILL WORK, BUT ANTI-THEFT SYSTEM CUTS OFF FUEL. MANY, MANY PEOPLE HAVE SAME PROBLEM, ON SATURN ION 2, NUMEROUS YEARS! THE OIL/GREASE USED IN IGNITION FREEZES! SATURN KNOWS OF THIS PROBLEM, BUT IS TURNING A BLIND EYE! *TR

• 12/24/2008· ELECTRICAL SYSTEM

  TWO DAYS AFTER MOVING TO NJ FROM FL AS I WAS PULLING INTO MY DRIVEWAY THE POWER STEERING LIGHT CAME ON AND THE STEERING LOCKED UP. I FOUND THAT IF I TURN THE CAR OFF AND ON AGAIN THE STEERING IS GOOD FOR MAYBE 20 MINUTES. I HAVE CHECKED THE FUSE AND TOOK IT TO A SHOP. THE MECHANIC SUGGESTED I DO SOME RESEARCH BECAUSE A CAR THIS YOUNG SHOULD NOT HAVE THESE KINDS OF PROBLEMS. I HAVE SEEN SIMILAR COMPLAINTS ON THE INTERNET ABOUT THE SAME MODEL. MY CAR IS A SATURN, ION 2005. *TR

• 12/22/2015· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHILE IN PARK, THE CONTACT NOTICED FUEL LEAKING FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL LINES WERE LEAKING AND HAD CORRODED. THE MECHANIC STATED THAT THE FUEL LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000.

• 12/22/2005· ENGINE AND ENGINE COOLING

  DT: THE CONTACT STATED VEHICLE STALLED SEVERAL TIMES AT HIGHWAY SPEEDS. THERE HAS BEEN NO WARNING PRIOR TO EACH INCIDENT. THIS WAS THE FOURTH TIME SHE TOOK VEHICLE TO A DEALER. EACH TIME THE DEALERSHIP TOLD HER THE PROBLEMS WAS FIXED. SHE DID NOT KNOW WHAT REPAIRS THE DEALERSHIP HAD DONE PREVIOUSLY. SHE DID NOT HAVE ANY OTHER PROBLEM WITH THE VEHICLE. THE VEHICLE IS AT THE DEALERSHIP NOW AND HAS NOT BEEN REPAIRED. *AK UPDATED 01/25/06. *JB

• 12/22/2005· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROLCrash

  DT: THE CONTACT STATED INTERMITTENTLY THE VEHICLE WILL ACCELERATE WITH THE CONTACT'S FOOT ON THE BRAKE. THE VEHICLE HAS BEEN TO THE DEALERSHIP, AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM, AND NO CODES WERE FOUND. THIS CAUSED THE CONSUMER'S VEHICLE TO REAR END ANOTHER VEHICLE. THERE WAS PROPERTY DAMAGE. THE HOOD BUCKLED AND THE GRILL WAS DAMAGED. THERE HAVE BEEN NO REPAIRS DONE. *AK THE CONSUMER EXPERIENCED ELECTRICAL PROBLEMS SUCH AS THE RIGHT FRONT TURN SIGNAL, WHICH TURNED OUT TO BE A LOOSE CONNECTION. THE VEHICLE WOULD NOT START UNTIL 10 MINUTES AFTER THE INITIAL START. IT WAS DETERMINED THE VEHICLE NEEDED A NEW MODULE. UPDATED 01/25/06. *JB

• 12/21/2022· EXTERIOR LIGHTING

  Headlights are to deem even on high beems.cant see anything coming or the on coming traffic can't see me coming.

• 12/21/2011· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT VEHICLE COULD NOT BE STARTED DURING COLDER WEATHER DUE TO THE ANTI-THEFT SENSOR. THE CONTACT STATED THAT THE VEHICLE WOULD HAVE TO SIT AT LEAST TWENTY MINUTES AFTER STARTING IN ORDER FOR THE VEHICLE TO RESET. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE DEALER ADVISED THE CONTACT TO HAVE THE VEHICLE TOWED WHEN THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED WHO STATED THAT THE DEALER COULD NOT REPAIR THE VEHICLE UNTIL PROPERLY DIAGNOSED. THE FAILURE MILEAGE WAS 83,000.

• 12/19/2014· UNKNOWN OR OTHER

  THERE WAS NOT AN ACCIDENT . THE KEY WILL NOT COME OUT OF THE IGNITION WHEN YOU TURN THE KEY BACK, YOU HAVE TO WAIT FOR A WHILE THEN IT WILL FINALLY COME OUT. THIS IS AFTER THE RECALL THAT FIXES THE IGNITION SWITCH. *TR

• 12/19/2010· EXTERIOR LIGHTING

  2005 SATURN ION TURN SIGNAL LIGHTS STOPPED BLINKING, BUT LAMPS NOT BURNED OUT. GM DEALER RECOMMENDS REPLACEMENT OF THE BODY CONTROL MODULE AND EXTENSIVE AND COSTLY REPAIR! CAN'T FIND PARTS. CANNOT PROPERLY OPERATE VEHICLE WITH EXPIRED INSPECTION STICKER REQUIRED IN LA. *TR

• 12/19/2006· POWER TRAIN

  TL* - THE CONTACT HAS BEEN HEARING A NOISE IN THE CAR SINCE THE ODOMETER REACHED 500 MILES. AFTER ONE AND A HALF YEARS A NEW TRANSMISSION HAS BEEN PUT ON THE CAR. THE NOISE STILL EXIST. THE CAR IS CURRENTLY 2 YEARS OLD AND HAS 20,000 MILES ON IT. CONTACT BELIEVES THE PROBLEM WITH THE CAR IS BAD WHEEL BEARINGS EVEN THOUGH HE HAS BEEN TOLD IT IS THE TRANSMISSION. THE CONTACT ALSO SAID THAT HE HAD A WARPED LEFT FRONT WHEEL AND THAT THE CAR HAS A BOUNCE. THE CONTACT BELIEVES THE TRUE ISSUE HAS NOT BEEN ADDRESSED.

• 12/18/2014· POWER TRAIN

  TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME DIFFICULT TO REMOVE FROM THE IGNITION. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V17000 (FUEL SYSTEM, GASOLINE) AND THE CONTACT STATED THAT AFTER THE REPAIRS THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SHIFTER AND THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

• 12/17/2015· STEERING

  ABSOLUTELY ABYSMAL CUSTOMER SERVICE EXPERIENCE WITH ORANGE BUICK GMC ORLANDO. I HAD THEM DO TWO RECALLS ON MY '05 SATURN: THE IGNITION SWITCH (WHICH WAS GIVING ME PROBLEMS DUE TO THE PASSLOCK SYSTEM), AND THE ELECTRIC STEERING ASSIST (WHICH I'D HAD _ZERO_ PROBLEMS WITH PRIOR, IT WAS DONE AS A PRECAUTION). AFTER THE STEERING MOTOR WAS REPLACED, I STARTED HAVING INTERMITTENT POWER STEERING CODES ON STARTUP WITH NO ASSIST (TURNING THE CAR OFF THEN ON CLEARS IT). THEY REPLACED THE MOTOR AGAIN. PROBLEM STILL OCCURS. NOW THEY'RE SAYING THE STEERING COLUMN IS SUSPECT, IT'S NOT COVERED UNDER THE RECALL, AND THEY WON'T DO ANYTHING ABOUT IT. HOW FUNNY THAT THE COLUMN WOULD HAVE BEEN TOUCHED BY THEIR TECHS FOR BOTH THE MOTOR AND IGNITION REPLACEMENTS.

• 12/17/2011· STEERING

  POWER STEERING KEEPS FAILING ON AND OFF DURING TURNS AT ALL SPEEDS. *TR

• 12/16/2008· ELECTRICAL SYSTEM

  I HAVE A 2005 SATURN ION AND IT HAS A HABIT OF NOT STARTING AT TIMES. THIS HAS HAPPENED SEVERAL TIMES SINCE MY HUSBAND AND I HAVE OWNED IT. WE TURN THE KEY IN THE IGNITION AND THE CAR WILL NOT START. WE HAVE TO WAIT ANYWHERE FROM 10-45 MINUTES FOR THE CAR TO START AND IT SOMETIMES CAUSE MY HUSBAND TO BE LATE TO WORK. THIS IS AN EVEN BIGGER CONCERN SINCE WE HAVE A FOUR MONTH OLD SON. WE HAVE NOT HAD THE MONEY OR TIME DURING THE WEEK TO GO THE SATURN DEALERSHIP BUT I HAVE CALLED THE COMPANY WHO HANDLES MY EXTENDED WARRANTY AND HE SAID THAT THIS IS A COMMON ISSUE. FROM THE DISCUSSION BOARDS I GATHER THAT THIS IS A VERY COMMON ISSUE AND THERE SHOULD BE A RECALL. *TR

• 12/13/2006· ELECTRICAL SYSTEM

  I OWN A 2005 SATURN ION 1. I BOUGHT IT BRAND NEW IN LATE 2004, AND HAVE NOT HAD ANY PROBLEMS WITH IT AT ALL UNTIL THIS WINTER (2006). MY PROBLEM HAS BEEN THAT WHEN IT IS COLD OUTSIDE, THE CAR REFUSES TO CRANK AT ALL. I TOOK IT TO A SATURN DEALER AND THEY SAID IT WAS THE BATTERY. I PAID OVER $100 TO HAVE A NEW BATTERY PUT IN, AND WAS REASSURED THAT IT FIXED THE STARTING PROBLEM. I THOUGHT IT HAD UNTIL ABOUT A WEEK LATER. THE CAR HAS STARTED TO HAVE PROBLEMS STARTING AGAIN, SO I PAID FOR A BRAND NEW CAR BATTERY THAT I DIDN'T NEED IN THE FIRST PLACE. I ORIGINALLY WAS GOING TO TAKE IT BACK TO SATURN TO GET THEM TO LOOK AT THE CAR AGAIN, BUT I STARTED DOING RESEARCH ONLINE. I FOUND THAT SATURNS NOT STARTING IN COLD WEATHER IS A WIDESPREAD PROBLEM, AND SATURN REFUSES TO DO ANYTHING ABOUT IT. I AM NOT GOING TO GO PAY TO HAVE A NEW IGNITION SWITCH PUT IT, WHEN THAT DOESN'T SOLVE THE PROBLEM AT ALL. IT'S RIDICULOUS THAT SATURN ISN'T OWNING UP TO THE PROBLEMS SO MANY PEOPLE ARE HAVING WITH THE VEHICLES THEY OWN. SO MUCH MONEY IS BEING WASTED BY THE CONSUMER, TRYING TO GET A PROBLEM FIXED, THAT ISN'T FIXABLE UNLESS GM RECALLS THIS FAULTY IGNITION SWITCH. *NM

• 12/12/2014· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2005 SATURN ION. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MENTIONED THAT THE KEY BECAME STUCK IN THE IGNITION. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED SEVERAL TIMES. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

• 12/12/2013· STEERING

  TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE POWER STEERING ASSIST MALFUNCTIONED. THE VEHICLE WAS DIAGNOSED AND THE POWER STEERING ASSIST MOTOR WAS REPLACED BUT THE DEFECT WAS NOT REMEDIED. THE CONTACT WAS INFORMED THAT THE POWER STEERING ASSIST CONTROL MODULE NEEDED TO BE REPLACED ALSO IN ORDER TO REMEDY THE DEFECT. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 105,000.

• 12/12/2010· STEERING

  2005 SATURN ION POWER STEERING GOES OUT RANDOMLY WHILE DRIVING AT ANY SPEED. VERY DANGEROUS AND POTENTIALLY DEADLY. *TR

• 12/11/2009· STEERING,ELECTRICAL SYSTEM

  I OWN A 2005 SATURN ION WITH ABOUT 46,000 MILES ON IT. I LOVE MY LITTLE CAR AND HAD HOPES OF OWNING IT FOR YEARS TO COME. HOWEVER, MY HOPES OF BEING A HAPPY SATURN OWNER IS QUICKLY FADING AS I CONTINUALLY HAVE PROBLEMS WITH MY STEERING COLUMN. FIRST IT WAS THE IGNITION, WHICH I HAVE REPLACED TWICE, AND NOW THE POWER STEERING IS TURNING OFF WHILE I'M DRIVING. OBVIOUSLY THIS IS VERY DANGEROUS AND IT ALSO NOT UNCOMMON AS I'VE FOUND OUT BY SEARCHING THE INTERNET ON THIS VERY PROBLEM. *TR

• 12/11/2008· ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)

  SATURN ION 2005 PROBLEM STARTING-EVERY THREE OR FOUR STARTS, THE LOCK SYMBOL SHOWS UP AND CAR WILL NOT START, PANEL, HEADLAMPS, ACCESSORIES ARE OPERATING, BUT STARTER SEEMS LOCKED OUT. AFTER 10-20 MINUTE WAIT, IT USUALLY STARTS. *TR

• 12/09/2014· SEAT BELTS,VEHICLE SPEED CONTROL

  MY SEAT BELTS WILL NO LONGER BUCKLE. MY SHIFT GETS STUCK IN PARK AND JUMPS INTO OTHER GEARS(NEUTRAL) AND THE CAR REVS ON IT'S OWN WITHOUT PUTTING FOOT ON GAS. MY SHIFT IS DOING THE EXACT SAME THING AS THE RECALL FOR THE AURA AND THE DEALER WANTS TO CHARGE ME $700.00 IN REPAIRS AND THE PARTS ARE ON BACK ORDER FOR 6 MONTHS. I DO NOT HAVE MY VIN# AT THIS TIME. PLEASE CHECK WITH HERB CHAMBERS SATURN -WARWICK, RI. *TR

• 12/09/2011· STEERING

  TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE STEERING WHEEL SEIZED AND BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR A DIAGNOSTIC TEST AND THE TECHNICIAN STATED THAT THE POWER STEERING MOTOR WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THERE WAS AN OPEN INVESTIGATION UNDER NHTSA ACTION NUMBER: EA11014 (STEERING:ELECTRIC POWER ASSIST SYSTEM), THAT MAY BE RELATED TO THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 48,000.

• 12/09/2008· ELECTRICAL SYSTEM

  2003 SATURN ION WON'T START WHEN IT'S COLD. *TR

• 12/08/2014· STEERING

  TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING) AND STATED THAT THE PARTS NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE DEALER PROVIDED AN UNREASONABLE TIMEFRAME TO SCHEDULE THE RECALL REPAIR. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE A REASONABLE TIMEFRAME FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIRS. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

• 12/08/2012· UNKNOWN OR OTHER

  THE POWER STEERING WENT OUT. *TR

• 12/08/2009· STEERING

  POWER STEERING WENT OUT. AT THE REPAIR SHOP NOW. THE WHOLE COMPONENT NEEDS REPLACED (YOU CAN'T ORDER SEPARATE PARTS) I WILL HAVE THE REPAIR SHOP SAVE THE OLD PART. IT WILL COST CLOSE TO 900.00 TO HAVE IT FIXED. THE DEALERSHIP WAS THE SAME PRICE. THE CAR IS ONLY 4 YEARS OLD WITH 26,000 MILES ON IT. *TR

• 12/08/2008· ELECTRICAL SYSTEM

  AT ABOUT 38,000 MILES, THE IGNITION SWITCH LOCKED UP WITH THE ENGINE RUNNING. I HAD TO DISCONNECT THE BATTERY TO SHUT OFF THE ENGINE. I PURCHASED A REPLACEMENT SWITCH WITH KEY FROM THE SATURN DEALER FOR ABOUT $140.00 AND INSTALLED IT MYSELF (THANK GOD I'M A MECHANIC) OR THE COST WOULD HAVE BEEN ABOUT TRIPLE. SATURN DOES NOT CLAIM ANY DESIGN RESPONSIBILITY FOR THE THOUSANDS OF KEY SWITCH FAILURES, BUT GM IS CERTAINLY WILLING TO TAKE OUR MONEY TO REPAIR A KNOWN DESIGN FLAW. NEXT VEHICLE I PURCHASE WILL BE MADE BY CHRYSLER-2005 CARAVAN SXT IS MECHANICALLY PERFECT WITH VERY GOOD FUEL ECONOMY. NO MORE GM PRODUCTS FOR THIS FAMILY! *TR

• 12/07/2020· EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT UPON ACTIVATION OF THE HEADLIGHTS, THE HEADLIGHTS WERE DIM CAUSING POOR FORWARD VISIBILITY WHILE DRIVING AT NIGHT OR IN LOW LIGHT CONDITIONS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 09E012000 (EXTERIOR LIGHTING) HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

• 12/07/2010· ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES

  PASSLOCK MALFUNCTION DUE TO FAULTY IGNITION SWITCH CAUSES NO CRANK AND ACTIVATION OF 10 MINUTE RELEARN SEQUENCE. ONLY HAPPENS WHEN TEMPERATURES ARE BELOW 40 DEGREES. HAS ALWAYS HAPPENED EVER SINCE I BOUGHT THE CAR JANUARY 3RD, 2009. FREQUENCY OF OCCURRENCE HAS INCREASED, AND I'M SCARED THAT IT WILL CAUSE A CRASH IF I HAPPEN TO STALL IN TRAFFIC. THE REMEDY TO THIS SITUATION HAS BEEN DISCUSSED IN NUMEROUS TECHNICAL FORUMS ON THE INTERNET - ALL OF WHICH POINT TO REPLACEMENT OF THE IGNITION SWITCH. THE CAUSE IS THOUGHT TO BE EXCESSIVE GREASE APPLIED TO THE INTERNALS OF THE SWITCH. I THINK GM SHOULD RECALL THE AFFECTED UNITS EXHIBITING THIS PROBLEM AND PROVIDE NO COST REPLACEMENT OF THE IGNITION SWITCH. THIS IS NOT A NEW PROBLEM. THOUSANDS OF OWNERS HAVE BEEN EXPERIENCING THIS AGGRAVATING AND SOMETIMES DANGEROUS TECHNICAL FAULT. GM IS IGNORING THE ISSUE AND OFFERING SATURN OWNERS ABSOLUTELY NO ASSISTANCE TO CORRECT THIS SERIOUS PROBLEM. IF GM DOES NOT ACT, THE LAW OF AVERAGES SAYS THAT EVENTUALLY SOMEONE MAY BE INJURED OR KILLED AS A RESULT OF THIS MALFUNCTION. PLEASE HELP US. THIS ISN'T FAIR AT ALL. *TR

• 12/06/2009· STEERING

  THE POWER STEERING IN MY 2005 ION SATURN QUITS WORKING. I'VE RESEARCHED THE WEB AND IT IS HAPPENING TO NUMEROUS PEOPLE. I PULL OVER SHUT THE CAR OFF AND BACK ON AND IT WORKS AGAIN. IT WAS HAPPENING ABOUT ONCE A MONTH NOW IT HAPPENS EVERY TIME I DRIVE MY CAR. NOW I CAN'T EVEN PULL OUT OF THE DRIVEWAY. *TR

• 12/05/2007· EXTERIOR LIGHTING

  SIMILAR TO THE 04 SATURN IONS, MY 2005 ION HAS THE SAME FRONT TURN SIGNAL PROBLEM. THE BULB QUITS FLASHING, BUT IS NOT BURNED OUT, IT IS LOSING CONTACT IN THE SOCKET. I CALLED SATURN, BUT THEY DO NOT HAVE A RECALL FOR MY VIN, BIT IT IS THE EXACT SAME PROBLEM AS WITH THE 04. *TR

• 12/04/2014· ELECTRICAL SYSTEM

  2005 SATURN ION CONSUMER IS COMPLAINING THAT THE DEALER HAS NOT RECEIVED THE PART TO FIX CAR PER RECALL *CN

• 12/04/2011· STEERING,ELECTRICAL SYSTEM

  THE FIRST TIME IT WENT OFF WAS WHEN WE WERE ENTERING A HIGHWAY. THE ELECTRIC ALARM WENT OFF AND THEN I FOUND THE STEERING WAS NOT WORKING. IT WAS DANGEROUS AND VERY HARD TO PULL OVER WHEN CARS BEHIND ARE ACCELERATING TO GET INTO THE HIGHWAY TRAFFIC. AFTER A RESTART, EVERYTHING SEEMED OKAY. THEN ON OUR WAY BACK HOME THE SAME THING HAPPENED FOR 4 OR 5 TIMES. WE HAD TO DRIVE IN THE RIGHT LANE AT A LOW SPEED TO GIVE OURSELVES ENOUGH SPACE FOR SAFTY. *TR

• 12/04/2009· ELECTRICAL SYSTEM

  TL*THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT WAS UNABLE TO START THE VEHICLE; HOWEVER, ALL OF THE ELECTRICAL COMPONENTS WERE OPERATING NORMALLY. THE DEALER INFORMED THE CONTACT THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE CONTACT STATED THAT OCCASIONALLY THE KEY WOULD NOT RELEASE FROM THE IGNITION. THE VEHICLE WAS SERVICED BUT THE FAILURE HAS CONTINUED TO OCCUR. THE CURRENT AND FAILURE MILEAGES WERE 59000. UPDATED 01/12/10. *LJ THE CONSUMER STATED EVERY WINTER THE DOESN'T START. UPDATED 01/13/10.*JB

• 12/03/2014· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEED, FUEL FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THERE WAS A LEAK IN THE FUEL LINE PIPE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL LINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

• 12/03/2011· ELECTRICAL SYSTEM

  MY 2005 SATURN ION WILL NOT START WHEN IT'S COLD, I REPLACED THE STARTER, I REPLACED THE NEUTRAL SAFETY SWITCH, I REPLACED THE IGNITION SWITCH, I WAS EXTREMELY FRUSTRATED. I CUT THE WHITE WIRE AFTER ROLL STARTING AS MY CAR IS A MANUAL AND TAPED OFF WIRES, CAR NOW STARTS ANYTIME I NEED IT TO, GM / SATURN NEED TO RECALL THIS ISSUE AND QUIT BEING CHEAP AND FIX THERE MISTAKES. *TR

• 11/30/2010· STEERING

  TL*THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT THE POWER STEERING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY THE DEALER WHO STATED THAT THE STEERING COLUMN NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.

• 11/29/2011· STEERING

  THE POWER STEERING ON THIS CAR REPEATEDLY FAILS. AS SOON AS YOU START THE CAR THE POWER STEERING LIGHT COMES ON MAKING IT EXTREMELY DIFFICULT TO MANEUVER THE CAR. *KB

• 11/29/2005· ELECTRICAL SYSTEM

  THE ALMOST CRASH: 1. DRIVING ALONG THE ROAD; 2. PASSLOCK ANTI-THEFT DETERENT LIGHT CAME ON; 3. CAR STOPPED IN THE ROAD CAUSING DRIVERS TO TAKE EVASIVE ACTION AROUND MY CAR. *NM

• 11/25/2013· EXTERIOR LIGHTING

  MY RIGHT TURN SIGNAL FLASHES FAST AND WILL NOT WORK. I CHANGED THE BULB THE SAME PROBLEM NOBODY SEEM TO KNOW WHAT TO DO ABOUT THIS , FROM THE AMOUNT OF COMPLAINTS I THINK G M NEED TO FIX THIS PROBLEM. *TR

• 11/24/2011· STEERING,ELECTRICAL SYSTEM

  I HAD BEEN DRIVING APPROX. 2 HOURS OF A 11 HOUR TRIP WHEN I SAW A MESSAGE REPLACE THE ODOMETER ABOUT THE POWER STEERING. I LEFT I95 USING EXIT 98 AND PULLED OVER IN A GAS STATION. THE MANUAL STATED THAT THE POWER STEERING WAS ELECTRIC, SO NO STEERING FLUID TO CHECK. I RESTARTED THE CAR AND MAGICALLY THE PROBLEM WAS FIXED AND MY TRIP ODOMETER WAS MAGICALLY SET TO ZERO. I DROVE AROUND THE FRONTAGE ROAD AND EVERYTHING SEEMED FINE SO I CONTINUED ON MY WAY. 22 MILES LATER THE SAME THING HAPPENED. I TOOK THE NEXT EXIT, SHUT THE CAR OFF, RESTARTED IT AND MAGICALLY AGAIN IT WAS FIXED WITH NO RESET OF THE TRIP ODOMETER. AGAIN I CONTINUED ON MY TRIP ONLY TO HAVE IT HAPPEN AGAIN 23 MILES LATER, AT WHICH POINT I REPEATED THE STOPPING/RESTARTING PROCEDURE AND TURNED AROUND HEADED FOR HOME. WHILE DRIVING HOME IT HAPPENED TWO MORE TIMES, THEN ONCE MORE IN THE DRIVEWAY WHEN I WAS BACKING UP. SO A TOTAL OF 6 TIMES WITHIN A 5 HOUR PERIOD AND NO PRIOR HISTORY (SINCE I'VE OWNED IT) OF THIS PROBLEM. I PURCHASED THIS CAR USED FROM A DEALER MAY 28 2011 WITH APPROX. 46500 MILES. THE ONLY OTHER PROBLEM I'VE HAD IS THE KEY NOT WANTING TO COME OUT OF THE IGNITION AFTER I'VE TURNED THE CAR OFF; AFTER I PUT THE GEAR SHIFT INTO REVERSE THEN BACK INTO PARK, THE KEY WILL COME OUT; SOMETIMES I CAN HEAR A CLICKING SOUND WHEN THE IGNITION SWITCH FIXES ITSELF AND THEN THE KEY WILL COME OUT, ALSO. *TR

• 11/24/2006· VEHICLE SPEED CONTROL

  2005 SATURN ION, MULTIPLE PROBLEMS W CRUISE CONTROL DISENGAGING & NOT OPERABLE UNLESS VEHICLE SHUT OFF, UNEXPECTED ACCELERATION, & ACTIVATING ON IT'S OWN. THE DEALERSHIP WOULD NOT BELIEVE ME UNTIL THE SERVICE MANAGER WITNESSED THIS PROBLEM. WHEN SATURN SENT AN ENGINEER TO REVIEW THE ISSUE HE ALSO DOUBTED ME AS HE HAD THE VEHICLE FOR 1 WEEK & WAS UNABLE TO REPRODUCE THE PROBLEM. WHEN I SUBMITTED FOR A NEW VEHICLE UNDER THE STATES LEMON LAW THE SERVICE MANAGER ACCUSED ME OF MAKING THIS UP TO GET A NEW VEHICLE. SATURN REQUIRED ME TO PAY $1800 FOR MILEAGE DEPRECIATION TO REPLACE THE VEHICLE & REFUSED TO HONOR THE EXTENDED WARRANTY WHICH CAME WITH MY ORIGINAL VEHICLE. MY BIG ERROR WAS IN GIVING THE DEALER & SATURN CORP 5 TIME TO TRY & FIX THE PROBLEM. THOSE 2 EXTRA ATTEMPTS CAUSED FURTHER MILEAGE WHICH COST ME IN ADDITIONAL OUT OF POCKET EXPENSES. *NM

• 11/23/2012· ELECTRICAL SYSTEM

  AFTER 50K MILES KEY GETS STUCK IN THE IGNITION AND TAKES 5-10 MINUTES TO COME OUT, REPLACED IGNITION CYLINDER STILL SAME ISSUE, UNABLE TO TURN ENGINE OFF, HAZARD. *TR