2005 KIA Sorento

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2011· SUSPENSION

  BRACKETS THAT HOLD THE REAR END UPPER CONTROL ARMS ARE COMPLETELY RUSTED INTO TWO USELESS PIECES. ONLY THE LOWER CONTROL ARMS AND SIDE LINK OR CANARD IS HOLDING THE REAR END IN PLACE, ANY TORQUE APPLIED COULD POTENTIALLY TWIST THE REAR CAUSING CATASTROPHIC DAMAGE, OBVIOUSLY THE METAL IS BAD AND WITH NO WEEP HOLES SALT, WATER, ETC. HOLD IN BRACKET. I THOUGHT THE HANDLING FELT BAD, AND HEARD SLIGHT, EVER SO SLIGHT CLUNKING, WOULD NEVER HAVE SUSPECTED THIS UNTIL TOO LATE EXCEPT I WAS CHECKING BRAKE PADS AND NOTICED THE DISCONNECTED SUSPENSION, NOW MUST GRIND OFF OLD BRACKETS, FABRICATE NEW ONES AND WELD ON AFTER FREEING UP UPPER CONTROL ARM BOLTS, NOT YOUR NORMAL MECHANIC WORK ON A 6 YEAR OLD CAR,,[XXX],,I FEAR WHAT COULD HAPPEN TO THE UNSUSPECTING NORMAL PERSON,,STAY WELL CLEAR OF ANY SORENTO'S YOU SEE ON THE ROAD, AND BY ALL MEANS INFORM ANY OWNERS OF THESE TO CHECK THEIR UPPER CONTROL ARMS BRACKETS. THIS SHOULD BE A FACTORY RECALL. WHY SHOULD WE (I) HAVE TO REPAIR OR JUNK AN OTHERWISE GOOD CAR. P.S. ANY AND ALL GARAGES THAT INSPECT THIS CAR SHOULD BE FAILING THEM AND IF THERE NOT THEY AREN'T LOOKING AT THE SUSPENSION WELL ENOUGH, EVERY ONE I CHECKED, THREE SO FAR ARE IN VARIOUSLY ILL SHAPE, NOT COMPLETE FAILURE BUT SO CLOSE, TO CALL THEM UNSAFE AGAIN [XXX] METAL BRACKETS, OTHER PIECES OF METAL CLOSE BY LOOK BRAND NEW, THANKS, I FEEL BETTER NOW, TIME TO RECALL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR *KB UPDATED 06/13/13*LJ

• 12/27/2016· SUSPENSION,STRUCTURE

  TL* THE CONTACT OWNS A 2005 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 50 MPH, THE CONTACT HEARD A LOUD NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRACKETS ON THE REAR END OF THE VEHICLE WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. THE VIN WAS NOT AVAILABLE.

• 12/27/2011· ELECTRICAL SYSTEM

  MY CAR HAS BROKEN DOWN 3 TIMES IN THE LAST MONTH. I HAVE A 2005 KIA SORENTO WITH 115,000 MILES ON IT. EVER SINCE I BOUGHT MY CAR, IT HAS CONTINUALLY HAD ELECTRICAL ISSUES SUCH AS REPLACEMENT OF THE HEADLIGHTS EVERY FEW MONTHS. I HAVE JUST DEALT WITH IT AND LEARNED HOW TO REPLACE THEM MYSELF. ONE MONTH AGO THOUGH, MY CAR BROKE DOWN AND I HAD IT TOWED TO MY LOCAL MECHANIC. HE SAID IT WAS THE ALTERNATOR AND WENT AHEAD AND REPLACED IT. EVERYTHING WAS RUNNING SMOOTH WHEN I DROVE IT AWAY BUT THEN 2 WEEKS LATER, I BROKE DOWN AGAIN (SAME SYMPTOMS OCCURRED FROM WHEN I BROKE DOWN THE FIRST TIME - BRAKE & BATTERY LIGHT BLINKS AND THEN THE AIRBAG LIGHT COMES ON AND BOOM, NO POWER). BROUGHT IT TO THE SAME MECHANIC AND THIS TIME IT WAS THE BATTERY THAT NEEDED REPLACED SO HE WENT AHEAD AND REPLACED IT. JUST YESTERDAY, 2 WEEKS AFTER THE BATTERY ISSUE, MY CAR BROKE DOWN AGAIN WITH THE SAME SYMPTOMS OCCURRING. I'M STILL WAITING ON IT TO BE DIAGNOSED BUT THERE IS NO OTHER EXPLANATION THAN FOR IT TO BE AN ELECTRICAL ISSUE. SUGGESTIONS? *TR

• 12/26/2008· EXTERIOR LIGHTING

  I OWN A 2005 AND A 2006 KIA SORENTO EX. IN BOTH VEHICLES I MUST REPLACE LIGHTBULBS CONTINUALLY. ON AVERAGE, I REPLACE HEADLIGHTS APPROXIMATELY ONCE EVERY 60 TO 90 DAYS. BRAKE LIGHT BULB REPLACEMENT IS LESS FREQUENT, BUT DOES OCCUR OFTEN WITHIN THE YEAR. THERE IS OBVIOUSLY A PROBLEM WITH THE ELECTRICAL SYSTEM IN THESE VEHICLES BUT KIA WILL NOT ACKNOWLEDGE ANY PROBLEMS. *TR

• 12/21/2010· EXTERIOR LIGHTING,INTERIOR LIGHTING

  LIGHTING (BULBS) VERY SHORT LIFE, BULBS LAST 1/5 TO 1/10TH OF THE LIFE IN OTHER VEHICLES. MOST RECENT BOTH LOW BEAM BULBS FAILED WITHIN 5 MINUTES LEAVING US WITH NO LIGHTING WHILE DRIVING AT HIGHWAY SPEED ON UNLIT DIVIDED HIGHWAY. WE HAVE BEEN REPLACING BULBS EVERY 2-3 MONTHS. WE ALWAYS REPLACE BOTH HEADLIGHTS WHEN ONE BURNS OUT. MY OTHER VEHICLES LAST MANY YEARS, THIS VEHICLE IS THE ONLY ONE I HAVE EVER HAD THAT HEADLIGHTS ONLY LAST MONTHS. THE VEHICLE IS ONLY DRIVEN 4 DAYS PER WEEK AND THE HEADLIGHT LIFE IS ACTUALLY LESS THAN 50 HOURS USE. WE HAVE TRIED SYLVANIA (STANDARD, SILVERSTAR AND SILVERSTAR ULTRAS, GE, HELLA AND RECENTLY PHILLIPS BULBS ALL WITH THE SAME LIFESPAN (WITHIN DAYS) SOMETHING IS WRONG. THERE IS A TSB BUT NO RECALL. *TR

• 12/20/2013· EXTERIOR LIGHTING

  HELP!! I AM CONSTANTLY REPLACING HEAD LIGHTS, TAIL LIGHTS, BRAKE LIGHTS, FOG LIGHTS. EVERY SINGLE MONTH IT'S ONE LIGHT OR ANOTHER IN A CONTINUOUS CYCLE. I SEE MANY COMPLAINTS FOR THIS SAME ISSUE. I LOVE MY KIA SORRENTO OTHER THAN THIS PROBLEM. I FEEL THAT THIS IS A SAFETY ISSUE AS MUCH AS IT IS A NUISANCE NOT TO MENTION AN EXPENSE!!! KIA, DO THE RIGHT THING!! PLEASE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/19/2015· FUEL/PROPULSION SYSTEM

  BOUGHT THE CAR USED DROVE HOME .... CAR SAT FOR A WHILE CAME OUT TO THE SMELL OF GAS SO STRONG THE GAS TANK IS LEAKING AT THE SEAMS... TANK IS DAMP FROM GAS SOAKING IN..... BOUGHT A USED TANK FIXED IT AND THE LEAK IT 100X WORSE!!!! YOU CAN'T SEE THE HOLES IT'S AS IF IT'S NOT SEALING I HAVE READ THIS IS A COMMOM PROBLEM IN THIS CAR. AND NOT A CHEEP FIX!!! NO RECALLS?????

• 12/19/2010· ENGINE AND ENGINE COOLING

  DECEMBER 18, 2010 KIA MOTORS AMERICA, INC. DEAR KIA THIS LETTER IS TO COMPLAIN ABOUT AN INTERNET POSTED AND KNOWN DEFECT IN YOUR 2005 KIA SORENTO. I RECENTLY BROKE DOWN BECAUSE 'THE CRANKSHAFT BOLT BROKE OFF INSIDE THE ENGINE'. IT COST ME $85.00 TO GET IT TOWED AND NOW WILL RUN AN ADDITIONAL $1,200+/- TO REPAIR IT. FROM WHAT I'M READING ON THE INTERNET WHEN THE PROBLEM IS FIXED THERE IS NO WAY OF GUARANTEEING IT WON'T HAPPEN REPEATEDLY. THROUGH NO FAULT OF SORENTO OWNERS AS TOLD BY YOUR SERVICE MECHANIC (SCOTT) OF KIA OF DUTCHESS COUNTY (NY). 'JUST A BAD PART'. APPARENTLY, THIS BOLT SHEARS OFF AND FALLS INSIDE THE ENGINE CAUSING ADDITIONAL DAMAGE. YOUR FIX SUPPOSEDLY, IS TO TORQUE THE BOLT PROPERLY, WELL THAT BOLT IS FACTORY TORQUED! I HAVE NO COMPLAINTS WITH SCOTT AS HE IS COURTEOUS AND TRYING TO FIX IT. THE ISSUE IS THAT THIS VERY COSTLY FACTORY DEFECT IN EITHER THE BOLT OR THE ENGINEERING OF THE BOLT SPECIFICATIONS IS AND SHOULD BE THE RESPONSIBILITY OF KIA MOTORS.' AS AN OWNER, I AM DISAPPOINTED THAT YOU HAVE TURNED AWAY FROM YOUR RESPONSIBILITY TO ADDRESS THE FACTORY PROBLEMS AS THEY ARE NOTED THROUGH USE OF YOUR VEHICLES. ADDITIONALLY, WHEN THE BOLT BREAKS, AND I HAVE FIRSTHAND KNOWLEDGE, THE BRAKE AND BATTERY LIGHTS APPEAR ON THE DASHBOARD AND LOSS OF POWER STEERING OCCURS. THE SUDDEN LOSS OF POWER STEERING ALMOST CAUSED ME TO VEER INTO A CURB ON THE SIDE OF THE ROAD BUT COULD HAVE BEEN A LOT WORSE. I HAVE ADDED (BELOW) SOME OF THE MANY INTERNET POSTED COMPLAINTS OF PEOPLE WITH THE SAME NIGHTMARE. AND EVEN AFTER IT'S FIXED THERE IS NO GUARANTEE IT WON'T CONTINUE TO HAPPEN. HOW ABOUT SOME GOOD OLD FASHIONED OWNING UP TO THE RESPONSIBILITY OF PROVIDING SAFE AND RELIABLE CARS FOR PEOPLE WHO PAY THOUSANDS OF DOLLARS TO PURCHASE ONE OF THE MOST EXPENSIVE THINGS WE WILL EVER OWN!!! NEEDLESS TO SAY, I AM QUITE FRUSTRATED AND WHEN I PICK UP THE CAR TOTALLY OUT OF MONEY. *TR

• 12/16/2015· STEERING,ENGINE,FUEL/PROPULSION SYSTEM

  I WAS DRIVING DOWN THE HIGHWAY AND ALL THE SUDDEN MY CAR GAVE A BIG SOUND AND DIED. THE STEERING WAS REALLY HARD TO STEER, LUCKLY I WAS IN THE SLOW LANE AND COASTED OFF THE EDGE OF THE ROAD. HAD IT TOWED TO MECHANIC THE STARTED WAS BAD, ALONG WITH THE FUEL LINE AND FUEL PUMP. AFTER GOT IT RUNNING ONCE AGAIN RAN FINE HOUR LATER THE CRANK SHAFT SENSOR WENT OUT. I HAVE READ MANY MANY COMPLAINTS ABOUT THE SAME ISSUES, ALSO WAS TOLD THAT MY FUEL TANK AND BOTTOM WAS RUSTING OUT. AND MY SWAY BAR IS BAD. MY CAR SHAKES, I HAVE HAD NEW TIRES AND BRAKES PUT ON AND A NEW MUFFLER PUT ON. I HAVE HAD ALL MY OIL CHANGES AND TUNE UPS. THEY SAY THERE IS NO RECALLS, HOW COULD THERE NOT BE RECALLS HERE IN THE USA. THEY HAD A CLASS ACTION LAW SUIT IN CANADA AND KIA WAS MADE TO FIX THESE SAME ISSUES.

• 12/13/2020· AIR BAGS

  PASSENGER AIR BAG SEAT MATT FAULTY. PASSENGER AIRBAG DOES NOT COME ON.

• 12/10/2012· STRUCTURE,LATCHES/LOCKS/LINKAGES,VEHICLE SPEED CONTROL,EQUIPMENT

  TL* THE CONTACT OWNS A 2005 KIA SORENTO. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT DEPRESSED THE ACCELERATOR PEDAL BUT THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT STOPPED THE VEHICLE ON THE SHOULDER. THE CONTACT WAS ABLE TO DRIVE WITHOUT FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING HOWEVER, THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 1,500. ..UPDATED 01/16/2013 *BF UPDATED 129/2013 JS

• 12/09/2011· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2005 KIA SORENTO. THE CONTACT STATED THAT ALL OF THE INSTRUMENT PANEL LIGHT ILLUMINATED AS THE VEHICLE STALLED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE CRANKSHAFT POSITION SENSOR FAILED AND NEEDED TO BE REPLACED. THE FAILURE AND THE CURRENT MILEAGE WAS 110,522. UPDATED 1/29/13 *CN UPDATED 2/6/2013*JS

• 12/08/2010· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,SEATS

  OWN A 2005 KIA SORENTO. WE HAVE A CONTINUOUS PROBLEM WITH THE LIGHTS BURNING OUT. THIS INCLUDES THE HEADLIGHTS, BRAKE LIGHTS, PARK LIGHTS, AND FOG LIGHTS. THESE LIGHTS BURN OUT ABOUT EVERY 3 TO 4 MONTHS. NOW THE POWER SEAT HAS STOPPED MOVING FORWARD OR BACK. THE DRIVER'S SIDE POWER SEAT WILL NOT MOVE FORWARD OR BACKWARD. A SHORTER PERSON THAT MY WIFE MOVED HER CAR AND SHE ADJUSTED THE SEATS. WHEN MY WIFE GOT INTO THE CAR SHE WAS UNABLE TO PUT THE SEAT IN THE ORIGINAL POSITION. I HAVE TRIED TO JOCKEY THE SWITCH BACK AND FORTH AND UP AND DOWN AND THE SEAT WILL NOT MOVE. *TR

• 12/07/2010· STEERING,POWER TRAIN

  TL*THE CONTACT OWNS A 2005 KIA SORRENTO. THE CONTACT WAS ATTEMPTING A TURN WHILE DRIVING APPROXIMATELY 2 MPH WHEN THE STEERING WHEEL ABNORMALLY LOCKED. THE CONTACT WAS UNABLE TO TURN THE WHEEL AND THE VEHICLE WAS IMMEDIATELY SHUT OFF. THE VEHICLE WAS THEN TOWED TO AN INDEPENDENT REPAIR FACILITY WHERE SHE WAS INFORMED THAT A BOLT WITHIN THE DRIVESHAFT HAD FRACTURED AND CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 64,000.

• 12/05/2009· AIR BAGSCrash

  WHILE HEADING EAST DURING A SNOW STORM, COLLIDED WITH A SNOW PLOW. THE KIA SORENTO WAS TOTALED BEYOND REPAIR. IMPACT WAS AT DRIVERS SIDE DOOR. DESTROYED FRONT OF VEHICLE, REAR DOOR AND RIPPER PART OF ROOF OPEN, DRIVER HIT FACE ON SIDE WINDOW CAUSING BLEEDING ON BRAIN. WAS HOSPATIZED FOR 3 DAYS. NOT ONE AIR BAG WAS DEPLOYED. NOT FRONT NOR SIDE AIR BAGS. NOTIFIED KIA CORP. SENT PICTURES AND REPORT. SAID THEY DIDNT THINK IT WAS THE FAULT OF KIA. *TR

• 12/02/2008· VEHICLE SPEED CONTROL

  IDLER AIR CONTROL VALVE- BAD ON 2005 KIA SORENTO, 75, 000 MILES REPAIR COST STEVEN KIA WICHITA KS, $570.00 DEALER SAID THE VALVE WOULD NEED REPLACED, AND PINS CLEANED.. SYMPTOMS, VEHICLE DIES WHEN SLOWING DOWN WONT STAY RUNNING, CAR ONE TIME IDLED UP ON IT OWN AT A VERY HIGH ACCELERATION, SCARED ME, I HAD TO TAP THE GAS PEDAL IT DIDN'T WORK, THEN TURN OFF IGNITION SWITCH TO STOP CAR. *TR

• 12/01/2013· STRUCTURE,LATCHES/LOCKS/LINKAGES

  FRONT PASSENGER DOOR WILL NOT (OPEN) FROM INSIDE OF VEHICLE.. IT LOCKS AND UNLOCKS BUT DOOR OPENING CONNECTION LINK IS NOT OPENING. THIS PRESENTS A CRASH AND FIRE HAZARD AS PASSENGERS MUST EITHER OPEN THE WINDOW AND REACH OUT TO OPEN OR HAVE SOMEONE OUTSIDE OPEN THE DOOR! HAD IT REPAIRED AND IT BROKE AGAIN SHORTLY AFTER REPAIR. *TR

• 11/29/2011· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  I CONSTANTLY HAVE TO CHANGE TAIL LIGHTS AND HEAD LIGHTS ON MY VEHICLE. EVERY 4/5 MONTHS THEY ARE GOING OUT. ALSO THE INTERIOR LIGHT ABOVE IN THE BACK SEATING AREA DOES NOT COME ON WHEN THE DOORS ARE OPEN, ONLY IF MANUALLY PRESSED ON AND OFF. THE LIGHT BEHIND THE PANEL CONTROLLING THE HEAT/AIR TEMPERATURES IS NO LONGER FUNCTIONAL. NO ONE ELSE SEEMS TO CHANGE THEIR LIGHTS AS FREQUENTLY AS I DO, IF AT ALL SINCE THEY'VE HAD THEIR CARS. IT SEEMS TO BE AN ISSUE WITH THE ELECTRICAL SYSTEM. *KB

• 11/24/2021· UNKNOWN OR OTHER

  My 2005 Kia Sorento’s headlights keep going out. I get new bulbs and even replaced the whole headlight thing and checked the wiring hoping to fix the problem and nothing. Works great for one day and then the next one or both are out. It is very dangerous to myself and my children who are under the age of 5. This is my only vehicle as I am a single mother and cannot afford the constant repairs let alone a new vehicle. This is ridiculous. I can’t go no where after 5 in the winter time since my lights go out and I have errands to run, school and work. I’ve heard this happens too often. This is a problem that not only should be addressed but is extremely dangerous for all drivers !

• 11/24/2018· UNKNOWN OR OTHER

  BATTERY AND BRAKE LIGHT CAME ON AND LOST POWER STEERING CONTROL, POWER STEERING BELT CAME OFF AND AC BELT HAD TO GET TOWED HOME. WHEN I WENT UNDER THE HOOD NOTICED THE DAMPER PULLEY WAS WOBBLY THE BOLT IN THE MIDDLE WAS STILL IN PLACE HAD THIS HAPPEN TWICE BEFORE ISSUE WAS FIXED AND IT HAPPENED AGAIN. CAN'T AFFORD TO TAKE TO A PROFESSIONAL MECHANIC BECAUSE I'M A SINGLE MOTHER OF 4 CHILDREN AND I NEED MY CAR RUNNING. I WAS DRIVING INTO A SHOPPING PLAZA PARKING LOT WHEN IT HAPPENED AND AS I TURNED IN THAT'S WHEN THIS HAPPENED.

• 11/24/2015· STEERING,AIR BAGS,SERVICE BRAKES

  I PURCHASED THIS 2005 KIA SORENTO AND ON MY WAY HOME THERE WAS A KNOCK BEFORE I LOST MY STERRING AND BRAKES. LUCKILY I SLOWED DOWN WHEN I HEARD THE SOUND. I GOT THE CAR HOME SAFELYBEING ONLY A HALF A MILE AWAY. CALLED THE DEALER I PURCHASED THE KIA FROM AND HE CAME AND GOT IT TO REPAIR IT. HE BOUGHT THE UPDATED SO CALL BOLT THAT WAS SUPPOSE TO FIX THE ISSUE WITH THE CRANK SHAFT BOLT. THEN I GOT THE CAR BACK AND HAD THE GAS TANK LEAKING FROM THE SEAMS. HE FIX AND REPLACED THAT. JUST THE OTHER NIGHT ON MY WAY TO WORK AND I LOST MY STERRING AND BRAKES AGAIN..I TRAVEL ON MAIN ROADS BUT THERE IS A LOT OF AMISH HERE AND THANK GOD I WASN'T GOING AROUND ANY OF THERE BUGGY AND HURT THOSE PEOPLE OR MYSELF..THERE IS NO FIX WHAT SO EVER FOR THIS ISSUE AND SOMEONE NEEDS TO MAKE KIA STAND UP AND TAKE RESPONSIBILITY FOR THIS FAULTY DEFECT BEFORE A INNOCENT CHILD OR WOMAN OR HUSBAND GETS KILLED.

• 11/24/2014· POWER TRAIN,ENGINE

  TL* THE CONTACT OWNS A 2005 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, AN ABNORMAL NOISE EMITTED FROM UNDER THE HOOD AND THE POWER STEERING SEIZED. THE CONTACT DISCOVERED THAT NONE OF THE BELTS IN THE VEHICLE WERE MOVING. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE CRANK SHAFT DAMPER, HARMONIC BALANCER AND THE GEAR NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000.

• 11/22/2005· AIR BAGSCrash

  DT : THE CONTACT"S WIFE WAS GOING APPROXIMATELY 65 TO 70 MPH WHEN VEHICLE COLLIDED WITH A DEER . THIS WAS A FRONTAL LEFT CORNER AND SIDE IMPACT. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED TO A DEALERSHIP. THE VEHICLE IS STILL UNDER WARRANTY.*AK

• 11/21/2014· AIR BAGS

  THERE IS A PROBLEM WITH THE OCS SYSTEM. AIRBAG LIGHT IS ON. I BELIEVE THE OCS SYSTEM IS BROKEN, HAD A SIMILAR PROBLEM WITH MY 2007 KIA RIO THAT HAD A RECALL FOR THE SAME PART. *TR

• 11/19/2014· FUEL/PROPULSION SYSTEM

  WHILE FILLING THE GAS TANK, GASOLINE SPITS BACK OUT OF THE CAR ONTO GROUND (AND ME)...NOT AN OVERLOW; AN ACTUAL PROJECTILE SPITTING! *TR

• 11/19/2007· PARKING BRAKE

  BRAKE PULSATION. *TR

• 11/18/2010· SUSPENSION,ENGINE AND ENGINE COOLING,POWER TRAIN

  MY 2005 SORENTO, SUV, BEGUN TO SHAKE ON THE FRONT AND LATER STOPPED. I HAD A MECHANIC CHECK IT FOR THE MAIN BELT TO BE OFF AND HE SAID IT WAS MORE MAJOR. THE BOLT HAD BROKEN OFF IN THE MOTOR. SOME CARS FROM KIA HAD ALREADY HAD THAT COMPLAINT. I CALLED THE KIA HEADQUARTERS AND THEY SAID YES, BUT NOT A RECALL FOR THAT MODEL DOING IT. WELL IT IS AND I AM STILL PAYING FOR SOMETHING I CAN'T USE.???? *TR

• 11/18/2010· STEERING

  TL*THE CONTACT OWNS A 2005 KIA SORENTO. THE CONTACT STATED THAT WHEN ENTERING HER VEHICLE SHE HAD A DIFFICULT TIME TRYING TO TURN THE STEERING WHEEL. THE VEHICLE WAS TOWED TO A INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT THE BOLT ON THE CRANK SHAFT HAD FRACTURED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE VIN WAS UNKNOWN. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 82,000.

• 11/14/2014· STEERING,SERVICE BRAKES,ENGINE

  FIRST INCIDENT-ON AUGUST 16, 2014 WHILE ON VACATION AND DRIVING FROM VIRGINIA TO CHICAGO ILL, THE VEHICLE START MAKING A RATTLING NOISE COMING FROM THE FRONT OF THE VEHICLE AND WARNING LIGHTS CAME ON THE DASH (BATTERY, BRAKE) AND THE POWER STEERING WENT OUT MAKING THE VEHICLE VERY HARD TO MANEUVER, I IMMEDIATELY PULLED OVER INTO A FAST FOOD PARKING LOT TO CHECK THE NOISE AND FOUND THAT THE HARMONIC BALANCER WAS LOOSE AND BELTS WERE NOT TURNING, I HAD THE VEHICLE TOWED TO A MECHANIC AFTER INSPECTION I WAS INFORMED THAT THE CRANK SHAFT GEAR PIN HAD BROKE OFF TO THE HARMONIC BALANCER. I PURCHASE THE PARTS (HARMONIC BALANCER, BOLT AND CRANK SHAFT GEAR) AND HAD THE MECHANIC REPAIR THE VEHICLE AND DROVE BACK TO VIRGINIA. SECOND INCIDENT-OCTOBER 2014 WHILE MY WIFE WAS DRIVING THE VEHICLE, SHE ENCOUNTERED THE SAME PROBLEMS THE WARNING LIGHTS, RATTLING IN THE FRONT OF VEHICLE, POWER STEERING LOCKED UNABLE TO TURN VEHICLE, I INSPECTED THE VEHICLE AND SAW THAT THE HARMONIC BALANCER WAS LOOSE AND BELTS WERE NOT TURNING, THE PIN IN THE CRANK SHAFT GEAR HAS BROKEN AGAIN, I HAD THE VEHICLE TOWED TO THE KIA DEALERSHIP IN RICHMOND, AND THEY STATED THAT I NEEDED A NEW MOTOR. AFTER INVESTIGATING COMPLAINTS ABOUT THIS VEHICLE ON LINE I FOUND OUT THAT THIS PROBLEM IS WELL DOCUMENTED WITH THIS MAKE AND YEAR VEHICLE. IF I OR MY WIFE HAD BEEN ON THE HIGHWAY AT THE TIME OF THIS FAULT IT COULD HAVE BEEN CATASTROPHIC. I ALSO FOUND THAT THEIR IS A CLASS ACTION SUIT AGAINST KIA MOTORS ADDRESSING THE EXACT SAME FAULT.(CIVIL ACTION NO. 13-006 UNITED STATES DISTRICT COURT, DISTRICT OF NEW JERSEY) ESSENTIALLY, PLAINTIFFS CLAIMED THEIR VEHICLES WERE DESIGNED WITH A ?DEFECTIVE CRANKSHAFT PULLEY BOLD AND BALANCER,? WHICH COULD RESULT IN ?BREAKING OFF THE SPRING GUIDE PIN,? CAUSING ?CATASTROPHIC ENGINE FAILURE.? THIS VEHICLE IS UNSAFE, A RECALL IS WARRANTED AND KIA MOTORS NEEDS TO CORRECT THE DEFECT. *TR

• 11/13/2015· SUSPENSION

  I HAVE AN 05 KIA SORENTO LX. WHEN I WAS DRIVING I NOTICED THAT MY CAR KEPT MAKING A GRINDING SOUND WHEN MAKING A LEFT, AND THEN I ALSO NOTICED THAT IT WAS RATTLING A LOT WHEN HITTING BUMPS AND JUST DRIVING DOWN THE ROAD. I TOOK THE VEHICLE INTO MY PERSONAL MECHANIC WHOM I'VE BEEN USING FOR YEARS AND TRUST TO THE HIGHEST, AND HE TOLD ME THAT THE ENTIRE FRAME WAS RUSTED THROUGH, WITH MULTIPLE HOLES AND IT WAS UNSAFE TO DRIVE AND THE COST TO REPAIR IS WAS EXTREMELY HIGH. HE TOLD ME TO TAKE IT TO KIA TO SEE IF THERE WERE ANY RECALLS OR ANYTHING THEY COULD DO BECAUSE A BARELY 10 YEAR OLD CAR SHOULDN'T BE HAVING THIS ISSUE, AND IT'S A SAFETY ISSUE. I TOOK IT TO THE KIA DEALERSHIP, THEY INSPECTED THE CAR, AND UPON THEIR INSPECTION THEY SAID, "FRAME IS RUSTING AND HAS MANY HOLES, IS UNSAFE. ADVISE CUSTOMER TO DRIVE AT OWN RISK SINCE IT COULD BREAK AT ANY TIME. ENTIRE FRAME AND REAR END WOULD NEED TO BE REPLACED. FOUND SEVERAL AREAS WHERE THE FAME HAS ROTTED THROUGH, AND THE REAR AXLE IS BROKEN WHERE THE CONTROL ARM ATTACHES. ADVISE GETTING A NEW CAR". TO ME, THIS IS A HUGE SAFETY CONCERN - AND I'VE SEEN MULTIPLE COMPLAINTS ABOUT THIS SAME ISSUE. KIA ISN'T DOING ANYTHING TO HELP WITH THE SITUATION, AND QUOTED ME WAY MORE THAN THE CAR IS WORTH TO FIX IT. I JUST BOUGHT THIS CAR 2 YEARS AGO USED FROM A DEALERSHIP, AND IF THIS IS AN ISSUE NOW, THEN IT WAS AN ISSUE WHEN THEY SOLD ME THE TIME OF PURCHASE. THEY CLEARLY SAID THAT THE CAR WAS UNSAFE TO DRIVE, AND YET THEY'RE GOING TO LET THEIR CUSTOMERS RISK THEIR LIVES INSTEAD OF TRYING TO HELP THEM.

• 11/13/2013· EXTERIOR LIGHTING

  I WAS ON THE INTERSTATE AND BOTH OF MY TAILLIGHTS STOP WORKING. I WAS NOTIFIED BY ANOTHER DRIVER. I TOOK THE VEHICLE INTO THE KIA DEALERSHIP AND WAS TOLD IT WAS A LIGHT ASSEMBLY PROBLEM. THEY CLAIMED TO HAVE FIXED IT. EVEN AFTER THEIR SO CALLED FIX I HAVE T O REPLACE TAILLIGHT AND HEADLIGHT BULBS ABOUT EVERY THREE MONTHS. THE OUTAGES OCCUR ON OPPOSITE SIDES EVERYTIME AND SWITCH BETWEEN THE TAILLIGHT AND HEADLIGHT. I HAVE TO KEEP EXTRA BULBS AND THE NEEDED TOOLS AVAILABLE IN MY TRUCK AT ALL TIMES. I HAVE BEEN ISSUED A TICKET AS WELL DUE TO MY TAILLIGHT BEING OUT. THIS IS VERY COSTLY AND DANGEROUS TO FAMILY. I HAVE TWO TEENAGE CHILDREN WHO ALSO DRIVE THIS VEHICLE. IT SEEMS TO BE A WIDESPREAD PROBLEM DUE TO THE BLOGS THAT I HAVE SEEN CONCERNING THIS PROBLEM. PLEASE HELP. *TR

• 11/12/2009· EXTERIOR LIGHTING,INTERIOR LIGHTING

  TL* THE CONTACT OWNS 2005 KIA SORENTO. INTERMITTENTLY WHILE DRIVING THE HEAD-LIGHTS FAIL. ALSO THE INTERIOR LIGHT DOES NOT COME ON WHEN THE DOORS ARE OPEN. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE TECHNICIAN COULD NOT IDENTIFY THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 101,000. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE.

• 11/11/2011· ENGINE AND ENGINE COOLING

  STRIPPED CRANK SHAFT. *TR

• 11/10/2017· AIR BAGS,SEATS

  SEAT SENSOR ON MY KIA SORENTO FOR THE AIRBAG LIGHT DOES NOT WORK. WHEN A PASSENGER SETS IN THE FRONT PASSENGER SEAT THE AIRBAG OFF LIGHT STAYS ON. YOU PUT THE VEHICLE IN GEAR, YOU DRIVE AND THE LIGHT STAYS ON. CITY OR HIGHWAY TRAVEL, THE LIGHT STAYS ON ALL THE TIME INDICATING THE PASSENGER AIRBAG IF OFF.

• 11/08/2011· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  WE HAVE A CONSTANT PROBLEM WITH HEADLIGHT BULBS. I HAVE TRIED EVERY AVAILABLE BRAND AT LOCAL AUTOMOTIVE STORES FROM THE LEAST EXPENSIVE TO THE MOST EXPENSIVE WITH THE SAME RESULTS. THEY LAST ABOUT 4 MONTHS AT BEST. THERE IS A DEALER AVAILABLE "FIX" WHICH INCLUDES A NEW WIRING HARNESS. KIA WILL NOT FIX THIS AT NO COST. THERE HAS BEEN 4 TIMES IN THE LAST 3 YEARS THAT THE HEADLIGHT HAS FAILED DURING LATE NIGHT DRIVING. I REPLACED THE BLOWN BULB AND WITHIN HOURS THE OPPOSITE SIDE FAILED. HAD BOTH FAILED AT THE SAME TIME IT WOULD BE A SERIOUS PROBLEM. AT THE DEALERSHIP (THREE) THEY SAID "YEA A LOT OF PEOPLE HAVE THIS ISSUE" MY OTHER VEHICLES BULBS LAST ON AVERAGE 5 TIMES LONGER - OR MORE. *TR

• 11/08/2010· ENGINE AND ENGINE COOLING,STRUCTURE

  CAR POWER STEERING BEGAN TO FAIL. POWER STEERING FLUID WAS CHECKED BUT ADDING FLUID DID NOT SOLVE THE PROBLEM. VEHICLE FAILED TO START, NEEDED TO BE TOWED TO MECHANIC. AFTER INSPECTION BY MECHANIC, IT WAS DETERMINED THAT THE CRANK SHAFT BOLT BROKE OFF FROM THE CAR. CONSEQUENTLY THIS BROKE THE TIMING BELT AND MAY HAVE BENT THE VALVE RODS (MECHANIC IS IN THE PROCESS OF TAKING THE VEHICLE APART AND ASSESSING ANY OTHER SUBSEQUENT DAMAGE CAUSED BY THE BROKEN CRANK SHAFT BOLT). THE VEHICLE NEEDS THOUSANDS OF DOLLARS OF REPAIRS (STILL BEING DETERMINED AS TO THE ENTIRE SCOPE). THE BOLT, TIMING BELT AND MOST LIKELY VALVE RODS WILL NEED TO BE REPLACED, ALONG WITH NUMEROUS HOURS OF LABOR DUE TO THE FACT THE ENGINE NEEDS TO BE TAKEN APART AND PUT BACK TOGETHER. THE OLD CRANK SHAFT BOLT IS AVAILABLE. *TR

• 11/07/2015· FUEL/PROPULSION SYSTEM

  VEHCILE WAS FILLED UP AND DRIVEN TO FRIENDS HOUSE. VEHICLE WAS STATIONARY AT FRIENDS HOUSE FOR FEW HOURS. WHEN LEAVING I SMELLED THE ODOR OF GAS. GOT LIGHT TO OBSERVE PUDDLE OF GAS UNDER VEHICLE. I DROVE HOME BECAUSE IT WAS DARK AND WAITED TO INSPECT IN THE MORNING. WHEN RE-INSPECTED IT WAS VERIFIED GAS WAS LEAKING FROM INSIDE AN INSET ON THE BOTTOM OF THE GAS TANK.

• 11/05/2014· ENGINE

  WHILE LEAVING OUR HOME TO RUN ERRANDS, I LOST POWER STEERING AND SEVERAL DASHBOARD LIGHTS CAME ON. WE PURCHASED THE KIA SORENTO IN 2005 NEW AND HAVE HAD VERY FEW PROBLEMS WITH IT UNTIL NOW. IT HAS LESS THAN 70K MILES AND HAS BEEN SERVICED BY THE DEALER EVERY 3K MILES. I HAD THE VEHICLE TOWED TO THE DEALER, WHO RATHER QUICKLY DIAGNOSED THE PROBLEM AS A BROKEN CRANK BOLT AND ESTIMATED REPAIRS WOULD COST ABOUT $1300. THE DEALER CHECKED WITH KIA ON WHETHER OUR 100K WARRANTY WOULD COVER THE REPAIRS. KIA SAID THIS PROBLEM WAS NOT COVERED. AT THE TIME I DIDN'T REALIZE THIS IS A FAIRLY COMMON PROBLEM WITH THE KIA SORENTO'S. CHECKING THE COMMENTS FROM OTHER SORENTO OWNERS, I HAVE CONCLUDED THIS CERTAINLY APPEARS TO BE A DESIGN DEFECT. OUR CONCERN IS THAT THIS COULD HAVE HAPPENED IN TRAFFIC AT 70 MPH AND THE LOSS OF THE ABILITY TO STEER COULD CERTAINLY BECOME A VERY SERIOUS PROBLEM, WITH POTENTIAL FATAL CONSEQUENCES. I AM ESPECIALLY CONCERNED ABOUT THE NUMBER OF SITUATIONS THAT THE BOLT FAILED A SECOND AND SOMETIMES A THIRD TIME AFTER THE INITIAL REPAIR WAS MADE. REQUEST SERIOUS CONSIDERATION OF KIA ISSUING A RECALL TO REMEDY THIS DESIGN DEFECT. UPDATED 01/14/15

• 11/04/2019· ENGINE

  THE HARMONIC BALANCER MOUNTING BOLT SHEARED AND STRIPPED THE THREADS IN THE CRANKSHAFT OF MY 2005 KIA SERENTO. THE MECHANIC HAD MY CAR FOR 3 MONTHS TRYING TO FIX THIS PROBLEM. THIS IS EVIDENTLY A DESIGN ISSUE AND SHOULD HAVE A RECALL ISSUED. THIS PROBLEM COST ME A LOT OF MONEY TO FIX. (THE CAR WAS IN MOTION WHEN THE HARMONIC BALANCER FELL OFF) MY WIFE STRUGGLE TO GET THE CAR HOME DUE TO LOST OF BELTS.

• 11/04/2015· STEERING,ELECTRICAL SYSTEM,ENGINE

  I WAS TURNING ONTO A STREET AND HEARD A BIG CLUNK ONLY TO FIND OUT THE BOLT ON THE CRANKSHAFT BROKE OFF AGAIN ON 10/29/15 AS WELL AS 7/30/13. THE POWER STEERING WENT OUT & BATTERY LIGHT CAME ON. LOST POWER AND EVERYTHING AFTER A BIG CLUNK! THIS HAPPENS ALL THE TIME: THERE ARE A MULTITUDE OF THESE SAME COMPLAINTS: THIS ENGINE WAS REPLACED IN MAY 2010 AND THE HARMONIC BALANCER AND PULLEY HAVE BEEN WORKED ON TWICE SINCE 2010. THERE IS A DEFECTIVE BOLT THAT WAS REPLACED WITH A NEW DEFECTIVE BOLT. THIS IS HAPPENING NUMEROUS TIMES TO MANY KIA SORENTO OWNERS AND THEY ARE LEFT STRANDED. KIA KNOWS ABOUT IT AND REFUSES TO DO ANYTHING! MY CAR IS SITTING AT COUNTRY KIA IN CHARLESTON, SC BECAUSE THE EXTENDED- WARRANTY WILL NOT COVER THIS DEFECTIVE BOLT AND I CAN'T PAY $5000.00 ON A CAR THAT IS NOW ONLY WORTH $3000.00. I HAD TO STAY IN CHARLESTON, SC AN EXTRA 2 DAYS AT MY EXPENSE $79.00 /NIGHT, PAY $75.00 FOR THE TOW BILL AND AN ADDITIONAL $55 OR $65 FOR THE KIA DEALERSHIP TO CHECK IT OUT. I HAD TO RENT A CAR TO COME BACK TO FL AS I WAS STRANDED IN CHARLESTON WITHOUT TRANSPORTATION. I CANNOT AFFORD THE $5000.00 FOR REPAIRS AND THE $1500.00 TO PAY IT OFF JUST TO GET THE TITLE TO SEND THIS TO A JUNK YARD. THE MILEAGE JUST TURNED TO 107,000 OR 108,000. THIS IS THE 4TH TIME THAT THERE WAS AN ISSUE ON THIS PART OF THIS CAR HAVING TO DO WITH THE SAME ISSUES RELATED TO THIS DEFECTIVE BOLT, HARMONIC BALANCER AND PULLEY AS A RESULT OF THIS DEFECTIVE BOLT. (THIS IS ONLY ON ONE CAR). YOU WILL SEE HOW MANY TIMES THIS IS OCCURRING TO MANY OTHER OWNERS OF THESE KIA SORENTOS. PLEASE READ THROUGH THE COMPLAINTS ON THE FOLLOWING LINK: HTTP://GOTACLASSACTION.COM/KIA-NAMED-IN-CLASS-ACTION-OVER-FIRST-GENERATION-2002-2009-EQUIPPED-WITH-A-HYUNDAI-MANUFACTURED-3-5L-24-VALVE-DOHC-V6-ENGINE/

• 11/03/2015· SUSPENSION,STRUCTURE

  TL* THE CONTACT OWNS A 2005 KIA SORENTO. WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL RATTLING NOISE AND THE VEHICLE SHOOK. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DISCOVERED THAT THE ENTIRE FRAME HAD EXCESSIVE RUST AND FRACTURES AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.

• 10/31/2015· ENGINE

  HAD A CAR REPAIR IN OCTOBER 2014 DUE TO A BROKEN BOLT NEAR CRANK SHAFT DRIVING DOWN THE HIGHWAY. PAID FOR REPAIR AND GOT CAR BACK AND WITHIN A MONTH THE MOTOR WAS SHOT . I WENT TO GO START THE CAR TO GO TO WORK AND IT WAS MAKING A TERRIBLE NOISE, IT WAS STATIONARY. I STILL HAVE AT 7 MORE CAR PAYMENTS TO MAKE ON THE CAR.

• 10/30/2010· ENGINE AND ENGINE COOLING

  05 KIA SORENTO. THE HARMONIC BALANCER BOLT DOESN'T ADEQUATELY SECURE THE BALANCER OR PULLEY. THRU NORMAL USE, THE BOLT BECOMES LOOSE CAUSING DAMAGE TO THE BALANCER. THE DAMAGED BALANCER CAUSES THE PULLEY TO BECOME DAMAGED, AND ALL OF THE ACCESSORY BELTS RUN BY THE CRANKSHAFT PULLEY ARE DAMAGED. THE "FIX" OFFERED BY KIA DOES NOTHING TO PERMANENTLY FIX THE PROBLEM. I HAVE NOW TAKEN MY VEHICLE TO AN ASE CERTIFIED MECHANIC TWICE IN THE LAST YEAR AND THE PROBLEM STILL EXISTS. COSTS HAVE NOW REACHED OVER $2100 AND COUNTING!!!!! *TR

• 10/26/2009· STEERING,ENGINE AND ENGINE COOLING,INTERIOR LIGHTINGFire

  WHILE RETURNING FROM OUR VACATION OUR KIA STARTED MAKING AT LOT OF NOISES IN AROUND THE AIRCONDITIONING HEATING SYSTEM, THE AIR COMING FROM THE VENTS DIDN'T SEEM TO BE WARM ENOUGH TO DEFOG THE WINDOWS, THEN THE NEXT DAY WHEN IT WAS WARMER IT STARTED MAKING A RATTLING FAN NOISE WHEN THE AIR WAS TURNED ON. WHEN THE SYSTEM WAS TURNED OFF IT DIDN'T MAKE THE NOISE ANYMORE. WE ARRIVED HOME UNLOADED OUR GEAR AND THEN WENT OUT AGAIN A WHILE LATER. THE FAN NOISE STARTED AGAIN AND THE WARNING LIGHT CAME ON AND THE POWER STEERING DIDN'T WORK, WHEN THE AIR WAS TURNED OFF EVERYTHING RESUMED TO NORMAL. WE ARRIVED AT OUR FRIEND HOUSE AND WENT INSIDE. AFTER SEVERAL MINUTES WE SMELLED SOMETHING BURNING AND WENT OUTSIDE TO SEE SMOKE COMING FROM THE ENGINE AREA. WE LIFTED THE HOOD TO INVESTIGATE WHERE WE SAW FLAMES COMING FROM THE ENGINE. WE IMMEDIATELY EXTINGUISHED THE FIRE AND HAD THE VEHICLE TOWED THE NEXT DAY. COME TO FIND OUT SEVERAL DAYS LATER THAT OUR VEHICLE WAS TOO BADLY BURNED TO REPAIR THE ENGINE. THE ENGINE HAD TO BE REPLACED DUE TO A TIMING BELT FAILURE. IF THIS IS AN ONGOING PROBLEM IT SHOULD BE MANDATORY THAT THEY SHOULD BE REPLACED BY WHOMEVER OWNS THE VEHICLE OR THE DEALER IF THE CAR HAS BEEN TRADED BECAUSE THE NEXT OWNER WOULD NOT KNOW ANY OF THE PREVIOUS REPAIRS SUCH WAS OUR CASE. AS IT STANDS NOW THERE ARE SOME INTERIOR ELECTRICAL PROBLEMS SUCH AS THE LIGHTS AN THE ELECTRONIC SEATS WE ARE HOPING FOR SOME KIND OF RECALL FOR THIS PROBLEM. THERE WAS ALSO A PROBLEM WITH THE FAN RUNNING ON AFTER THE CAR WAS TURNED OFF. THIS WAS STILL HAPPENING EVEN AFTER THE ENGINE HAD BEEN REPLACED AND WE WERE TOLD EARLIER THAT IT WAS A SENSOR PROBLEM WHICH STILL HAPPENED EVEN AFTER THE SENSOR WAS REPLACED. *TR

• 10/24/2016· POWER TRAIN

  TL* THE CONTACT OWNS A 2005 KIA SORENTO. WHILE AT A TRAFFIC LIGHT, THE VEHICLE WOULD NOT ACCELERATE WITHOUT WARNING. THE VEHICLE WAS PUSHED TO THE SIDE OF THE ROAD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE DRIVESHAFT FRACTURED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS OUT WARRANTY. THE FAILURE WAS NOT REMEDIED. THE FAILURE MILEAGE WAS APPROXIMATELY 132,000.

• 10/24/2011· ENGINE AND ENGINE COOLING

  CRANKSHAFT POSITION SENSOR HAS TO BE REPLACED EVERY 2 YEARS WITH NO EXPLANATION AND HEADLIGHTS BEING REPLACED EVERY 3-4 MONTHS AND DOME LIGHT JUST QUIT AND NO EXPLANATION FROM KIA OR DLR. *TR

• 10/23/2018· STRUCTURE,UNKNOWN OR OTHER

  I WAS DRIVING DOWN THE HIGHWAY WITH MY 7 MONTH OLD BABY IN THE BACKSEAT IN HIS CHILD SEAT. I WAS ABOUT 10 MILES INTO MY DRIVE WHEN I HEARD A PUFF AND A SMALL WHISTLE OF AIR. I THOUGHT MY PASSENGER WINDOW HAD COME DOWN SOME OR MAYBE I HAD LEFT THE DOOR OPENED AND IT WAS LETTING AIR IN. WHEN I TRIED TO PUT MY EAR CLOSER TO THE SOUND I HEARD IT COMING FROM THE TOP OF MY CAR. I TURNED TO THE SUNROOF COVER AND SLID IT OPEN SLIGHTLY TO SEE WHAT HAPPENED AND I IMMEDIATELY NOTICED THE WHOLE GLASS WAS CRACKED. AS I KEPT GOING DOWN THE ROAD I COULD HEAR SMALL PIECES OF GLASS FALLING OFF AND INTO THE SLOT WHERE THE SUNROOF SLIDES INTO. IF I WOULD HAVE HAD THAT OPEN THERE COULD HAVE BEEN SHARP PIECES OF GLASS THAT COULD HAVE FALLEN ONTO MY BABY.

• 10/19/2015· VEHICLE SPEED CONTROL,SERVICE BRAKESCrash

  TL* THE CONTACT OWNS A 2005 KIA SORENTO. WHILE REVERSING THE VEHICLE FROM A PARKING SPACE AND PLACING THE GEAR SHIFT INTO THE DRIVE POSITION, THE VEHICLE BEGAN TO ACCELERATE FORWARD. THE CONTACT'S VEHICLE CRASHED INTO A PARKED VEHICLE AT 10 MPH. THE BRAKES FAILED WHILE BEING DEPRESSED. THE PASSENGER SIDE OF THE VEHICLE SUSTAINED MAJOR DAMAGE. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 48,000.

• 10/17/2013· POWER TRAIN,ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2005 KIA SORENTO. THE CONTACT STATED WAS DRIVING UPHILL WHEN THE THROTTLE FAILED TO ENGAGE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE WIRING INTO THE TRANSMISSION WAS OVERHEATING AND CAUSING THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 10,000 AND THE CURRENT MILEAGE WAS 80,000.

• 10/13/2022· ELECTRICAL SYSTEMFire

  Electrical fire under drivers dash. While trying to drive the kia . called fire department and they responded quickly. I know there was recall on 2006 and believe 2005 should have been included Thanks [XXX] [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).