2005 Hyundai Sonata

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/27/2010· EXTERIOR LIGHTING

  TL*THE CONTACT OWNS A 2005 HYUNDAI SONATA. BOTH FRONT HEADLIGHTS AND FOG LIGHTS TURNED OFF INTERMITTENTLY. THE BULBS WERE CONSTANTLY CHANGED BUT THE FAILURE CONTINUED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 10,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 57,000.

• 12/23/2010· SEAT BELTS

  TL*THE CONTACT OWNS A 2005 HYUNDAI SONATA. WHILE DRIVING 65 MPH A CHILD OCCUPANT WAS SEATED IN THE REAR OF THE VEHICLE WHEN THE SEAT BELT WRAPPED AROUND HIS NECK SEVERAL TIMES. THE SEAT BELT HAD TO BE CUT FROM AROUND HIS NECK. HE WAS SUSTAINED LACERATIONS ON HIS NECK AND WAS TAKEN TO THE DOCTOR. NEITHER THE DEALER NOR THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 135,237.

• 12/22/2005· ENGINE AND ENGINE COOLING,POWER TRAIN,VISIBILITY,ELECTRICAL SYSTEM

  BOUGHT 2005 HYUANDI ON 12/8/04. EXPERIENCED VIBRATION ON 12/9/05 TOOK CAR BACK TO DEALERSHIP IN CLEVELAND TENNESSEE, THEY SAID NOTHING WAS WRONG, BUT THEY THOUGHT THAT THE BOLTS THAT HOLD THE MOTOR IN CAR NEEDED TO BE TIGHTENED. TOOK CAR BACK 3 DAYS LATER FOR THE SAME PROBLEM VIBRATION, THEY SAID THAT THE BOLTS NEEDED TO BE TIGHTENED AGAIN. TOOK THE CAR BACK ON THREE OTHER OCCASIONS AND THEY CONTINUED TO TIGHTEN THE BOLTS THAT HOLD THE ENGINE IN THE CAR. FINALLY A REPRESENTATIVE WAS CALLED IN TO LOOK AT THE CAR HE HAD ME TO DRIVE THE CAR AND TOLD ME THAT IT WAS NORMAL FOR THE CAR TO HAVE A VIBRATION WHEN SITTING STILL AND THAT NOTHING WAS WRONG WITH THE CAR. ALSO, HE SAID THAT THE BOLTS NEEDED TO BE TIGHTENED THAT HOLD THE ENGINE IN. *NM

• 12/20/2012· ENGINE AND ENGINE COOLING

  I WAS DRIVING HOME JUST LIKE EVERYDAY FROM WORK. ALL OF A SUDDEN WHEN I GOT OFF THE HIGH WAY IT FELT LIKE MY CAR WAS AN AIRPLANE TRYING TO TAKE OFF.. WELL IT TURNS OUT I HAVE A BAD MOTOR. THERE WERE NO SIGNS NO NOTHING. I COULD HAVE BEEN IN A WORST PLACE. I DO NOT HAVE ANY WHERE NEAR THE MILEAGE THAT I SHOULD FOR MY MOTOR TO JUST GO. *TR

• 12/19/2023· SUSPENSION,ENGINE

  My car's engine cradle, cross member or subframe is rusted out and the OEM replacement for my VIN number won't fit it correctly I'm getting really upset because this could be dangerous for me and my two young kids. I've already paid the mechanic $600 for the replacement part when it really only costs $450 at the most and the two he has ordered before have both been either too big and it says that it is the correct replacement part. What is going on?!!! If something isn't fixed soon and something happens to me or my kids there is going to be a lawsuit.

• 12/14/2017· STRUCTURE

  TL* THE CONTACT OWNS A 2005 HYUNDAI SONATA. WHILE THE VEHICLE WAS BEING REPAIRED BY AN INDEPENDENT MECHANIC, THE TECHNICIAN NOTICED THAT THE SUBFRAME WAS RUSTED. THE CONTACT CALLED LESTER GLENN HYUNDAI AT 732-451-3016 AND WAS INFORMED OF THE COST FOR A DIAGNOSTIC TEST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT ABOUT A RECALL, BUT IT WAS NOT ON HIS SPECIFIC YEAR. THE APPROXIMATE FAILURE MILEAGE WAS 85,000. *TT UPDATED 8/22/18*JB

• 12/13/2011· FUEL SYSTEM, GASOLINE

  TL* THE CONTACT OWNS A 2005 HYUNDAI SONATA. THE CONTACT STATED THAT THE RUBBER SEAL AROUND THE FUEL TANK FAILED, CAUSING FUEL TO LEAK. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE FUEL TANK. THE MANUFACTURER WAS CONTACTED WHO STATED THAT THEY WOULD TAKE THE LIABILITY FOR THE COST OF THE REPLACEMENT PARTS BUT THE CONTACT WOULD BE RESPONSIBLE FOR THE LABOR COSTS. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 78,000.

• 12/13/2010· AIR BAGS

  AIRBAG SENSOR LIGHT HAS TURNED ON FOR NO APPARENT REASON. *TR

• 12/09/2019· STRUCTURE

  TL* THE CONTACT OWNS A 2005 HYUNDAI SONATA. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS NOTIFIED THAT THE SUBFRAME WAS COMPLETELY RUSTED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 09V124000 (SUSPENSION). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 147,000. *LN*JB

• 12/07/2019· SUSPENSION

  RUST HOLES THROUGH ENGINE CRADLE OR SUB FRAME. THIS CAR HAS ONLY 39,900 MILES ON IT AND WAS WELL MAINTAINED. WHILE GETTING OIL CHANGED THE MECHANIC SHOWED ME THE PROBLEM AND TOLD ME TO CONTACT THE HYUNDAI DEALER AND TELL THEM ABOUT IT. I CALLED AND THEY TOLD ME THERE WAS NOTHING THEY WOULD DO, I HAD TO PAY FOR THE REPAIRS.

• 12/02/2016· SUSPENSION,POWER TRAIN

  BROUGHT TO GET OIL CHANGED, MECHANIC SHOWED ME THE ENGINE CARRIER WAS ABOUT TO FAIL. IT IS ALMOST RUSTED THRU 2004 HA RECALL BUT NOT 2005 ALSO WHEN IN PARK CAR ROLLS

• 12/01/2007· ELECTRICAL SYSTEM

  THE CHECK ENGINE LIGHT KEEPS COMING ON. THE DEALER HAS TRIED TO FIX IT THREE TIMES. THE FIRST TIME THE ENGINE LIGHT CAME ON THE CAR ONLY HAD ABOUT 12 THOUSAND MILES. THE LIGHT DID NOT COME BACK ON FOR OVER 10 MONTHS. THE CAR NOW HAS ABOUT 22 THOUSAND MILES AND THE DEALER HAS TRIED TO GET THE LIGHT TO GO OFF TWICE IN THE LAST MONTH. THE LAST TIME WAS ABOUT TWO WEEKS AGO AND THE LIGHT STAYED OFF FOR TWO WEEKS AND NOW ITS BACK ON. THE DEALER KEPT THE CAR FOR A WEEK AND THE LIGHT ONLY STAYED OFF FOR TWO WEEKS! THE TRANSMISSION SEEMS TO DRAG WHEN THE CHECK ENGINE LIGHT COMES ON. *TR

• 11/30/2012· STRUCTURE

  TL*THE CONTACT OWNS A 2005 HYUNDAI SONATA. THE CONTACT STATED THAT THE CHROME TRIM ON THE INTERIOR DOOR HANDLES STARTED TO SEPARATE, LEAVING SHARP EDGES AND LACERATIONS TO WHOMEVER OPENED THE DOOR. THE CONTACT STATED THAT HE RECEIVED SMALL LACERATIONS TO HIS LEFT HAND AS A RESULT OF OPENING THE DOOR. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000. THE CURRENT MILEAGE WAS APPROXIMATELY 155,000. THE VIN WAS UNAVAILABLE.

• 11/29/2007· SEATSCrash

  TL*THE CONTACT OWNS A 2005 HYUNDAI SONATA. WHILE IDLING AT A STOP SIGN, THE CONTACT WAS REAR ENDED AND THE FRONT DRIVER SEAT RECLINED BACKWARDS TO ITS FINAL POSITION. THE DEALER WAS NOTIFIED. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE CURRENT MILEAGE WAS 30,000 AND FAILURE MILEAGE WAS 28,000.

• 11/28/2011· STRUCTURE

  TL* THE CONTACT OWNS A 2005 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE PASSENGER SIDE REAR MOLDING TO THE WINDOW FRACTURED AND DETACHED FROM THE VEHICLE. THE DEALER WAS CONTACTED AND THEY ADVISED HIM THAT THERE WAS ONLY A ONE YEAR WARRANTY ON THE MOLDING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE APPROXIMATELY 36,500. ....UPDATED 12/03/12 *BF THE CONSUMER STATED THE CHROME ON TOP OF THE MOLDING, ABOVE THE RIGHT REAR DOOR, BECAME DETACHED AND FLEW OFF. UPDATED 01/10/12

• 11/18/2014· ELECTRICAL SYSTEM,AIR BAGS

  THIS IS THE FIRST DATE THAT I REPORTED TO THE DEALER THAT THE AIR BAG LIGHT WAS ON. SINCE THAT TIME, THE LIGHT HAS GONE OFF AND COME BACK ON A MANY TIMES. IT WAS CHECKED AGAIN BY THE DEALER AND ALSO BY A LOCAL, CERTIFIED MECHANIC. IT USUALLY STAYS OFF FOR ABOUT 6 MONTHS, BUT COMES BACK ON. IT IS NOW ON AGAIN. IN ADDITION, I'VE HAD TO REPLACE THE DOOR JAM SWITCH IN JAN. 2014. THE DOOR CHIMES (SEATBELT SOUND) GOES OFF RANDOMLY. NOW, THIS SOUND IS BACK. THE CAR RANDOMLY LOCKS ITSELF AND THE RADIO RANDOMLY GOES ON AS WELL. I FEEL THAT THE CAR HAS ELECTRICAL PROBLEMS THAT MAY MAKE IT UNSAFE. I AM ESPECIALLY CONCERNED ABOUT THE AIR BAG ISSUE. THE CAR HAS APPROXIMATELY 57,000 MILES ON IT. I FIND IT HARD TO BELIEVE THAT THIS VEHICLE HASN'T BEEN RECALLED FOR ANY NUMBER OF REASONS. *TR

• 11/11/2012· AIR BAGS

  I BOUGHT THE HYUNDAI SONATA 2005 GLE FROM COLONIAL HYUNDAI OF DOWNIGTWON PA. IT WAS A USED CAR WITH POWER TRAIN WARRANTY GIVEN BY THE DEALER. THE CAR HAD APPROXIMATELY 73,000 MILES AT THE TIME OF PURCHASE. SOON AFTER I PURCHASED THE CAR THE AIRBAGS LIGHTS STARTED SHOWING UP. I WENT TO THE DEALERSHIP AND GOT IT FIXED, THEY CHARGED ME LABOR AND SCANNING FEES DESPITE IT NOT BEING MY FAULT AS THE CAR HAD NO IMPACT TO ANY OBJECT OR ACCIDENTS. WITHIN 6 MONTHS OF GETTING IT FIXED THE AIRBAGS LIGHTS STARTED FLASHING AGAIN, THE DEALERSHIP FIXED IT AGAIN. THE AIRBAGS LIGHT AGAIN CAME BACK AGAIN FOR THE THIRD TIME, I REPORTED IT TO HYUNDAI GLOBAL CUSTOMER SERVICE - THEIR RESPONSE WAS TO TAKE IT BACK AGAIN TO THE SAME DEALERSHIP AND ASK THEM TO FIX IT. I DID NOT TAKE IT BACK TO THE SAME DEALERSHIP BECASUE I LACKED CONFIDENCE IN THEIR WORK HENCE I TOOK IT OUTSIDE CAR SERVICE CENTER WHERE THEY RAN THE SCAN BUT COULD NOT FIND ANY ISSUES WITH THE AIRBAGS BUT SAID ONLY HYUNDAI DEALERSHIP CAN RESET THE LIGHTS. I NOW MOVED TO NJ HENCE THE HYUNDAI DEALERSHIP NOW WANTS 90$ TO DO THE DIAGNOSIS AFTER WHICH THEY WILL GIVE ME AN ESTIMATE. I FEEL ITS UNNECESSARY WASTE OF TIME AND MONEY AND I HAVE ALREADY SPENT ENOUGH ON THIS ISSUE. I FEEL IT'S UNSAFE TO DRIVE THE CAR WITH THE AIRBAGS ISSUE. REQUESTING HELP IN THIS REGARD. *TR

• 11/10/2014· AIR BAGS

  ARE MY AIRBAGS A PROBLEM? WERE THEY MANUFACTURED BY TAKATA? THE AIR BAG LIGHT HAS REMAINED ON SINCE I BOUGHT THE CAR USED. SHOULD I GET THEM REPLACED? AM I IN DANGER FROM AIRBAGS? *TR

• 11/06/2015· AIR BAGSCrash

  INVOLVED IN A FOUR CAR CRASH EARLY THIS MORNING. I WAS THE LAST IN LINE AND REAR ENDED A TRUCK. THE SONATA IS TOTALED. THE PASSENGER AIRBAG DEPLOYED, BUT NOT THE DRIVER'S ONE. I HIT THE STEERING WHEEL AND GLASSES FLEW OFF ON THE DASHBOARD. IT WAS A HARD IMPACT, THE FRONT END IS DESTROYED.

• 11/02/2010· AIR BAGSCrash

  TL* THE CONTACT OWNS A 2005 HYUNDAI SONATA. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE VEHICLE WAS INVOLVED IN A CRASH IN WHICH THE AIR BAGS DID NOT DEPLOY. THERE WERE NO REPORTED INJURIES. THE SAME FAILURE OCCURRED ON TWO PRIOR OCCASIONS IN WHICH THE VEHICLE WAS INVOLVED IN A CRASH AND THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS NEVER TAKEN TO HAVE THE FAILURE DIAGNOSED BUT IT WAS TAKEN TO AN INDEPENDENT REPAIR SHOP TO HAVE THE BODY DAMAGES REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 175,000.

• 10/30/2023· STRUCTURE

  I took my car to the mechanic for a “once over” before driving from New Jersey to North Carolina. This car has only 41,000 original miles on it as we bought it new in 2005. Upon inspection, the mechanic came back with certain repairs that are needed due to age; but he was extremely concerned about a severe safety issue that the subframe had rotted out and needed to be replaced. This is a known corrosion issue with other years of manufacture for this model. There was a class action suit for this specific issue for 1999 to 2004 Sonatas. The subframe threatens to collapse from rust at any time and is an extreme hazard to the driver, passengers, and others on the road. There was absolutely no warning of this issue prior to this inspection, making it even more dangerous as it affects many drivers who are unaware of the issue.

• 10/27/2010· FUEL SYSTEM, GASOLINE

  CUT VALVE IN GAS TANK NECK FAILED. WHEN FUELING VEHICLE GAS WOULD SHUT OFF WITHIN 2 SECONDS, ATTEMPTING TO FUEL AGAIN GAS WOULD SHOOT OUT SPLASHING GAS ON YOU. QUICKLY MOVING OUT OF THE WAY I BROKE OFF THE COVER PLATE TO FUEL CAP. *TR

• 10/25/2018· AIR BAGS

  AIRBAG LIGHT STAYS ON. I HAVE TAKEN IT BACK TO DEALER SEVERAL TIMES AND HAS NOT BEEN FIX CAR IS OUT OF WARRANTY.

• 10/23/2021· SUSPENSION

  My mechanic just took a picture of the subframe of the car which is almost completely rusted through. He said that this is extremely dangerous and that if it was to break while driving the car, I would loose control. I have seen numerous complaints about this on the 2005 Hyundai Sonata on the internet which makes me think this is a common issue.

• 10/23/2009· STRUCTURE

  THE DRIVERS DOOR HANDLE HAS A CHROME COVER ON IT, THAT AT ONE POINT WAS GLUED TIGHT TO THE HANDLE, BUT NOW DUE TO WEAR AND TEAR, THE EDGE OF THE PLASTIC CHROME PIECE IS EXPOSED AND IT YOUR NOT PAYING ATTENTION AND SLIDE YOUR HAND ACROSS IT WHEN OPENING THE DOOR, IT CAN RESULT IN A CUT.GASH IN SOMEONE'S HAND. (INJURY) I HAVE GOTTEN A FEW CUTS, NOTHING SERIOUS, BUT IF SOMEONE REALLY WAS IN A RUSH, IT COULD BE QUITE A DEEP CUT/GASH IN YOUR HAND. *TR

• 10/14/2016· AIR BAGSCrash

  TL* TAKATA RECALL. THE CONTACT OWNED A 2005 HYUNDAI SONATA. THE CONTACT WAS INVOLVED IN A FENDER BENDER WHILE DRIVING APPROXIMATELY 10 MPH. THE AIR BAGS DEPLOYED AND RELEASED A LOT OF TINY METAL CRYSTALS. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A NEARBY DEALER AND DEEMED DESTROYED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

• 10/13/2021· SUSPENSION,STRUCTURE

  Upon inspecting the undercarriage of my vehicle found the right side of Front Subframe Cradle Suspension rotted almost completely through. When researching for issues pertaining to this model found a TSA was issued , after a lawsuit in California, for the years prior and after my vehicle. The damage is concurrent with the TSA bulletin but excluded. How does a manufacturer whom obviously is aware of an ongoing issue allow so many people, families and children, drive and risk their lives on our public roadways. Is their a subclass recall that will aid those like myself take corrective action.

• 10/13/2020· SUSPENSION,STRUCTURE

  BOTH THE REAR AND FRONT SUBFRAME HAVE HOLES FROM RUST WHICH HAS STARTED TO CAUSE NUMEROUS OTHER ISSUES SUCH HAS BALL JOINTS TIE ROD ENDS

• 10/12/2018· STRUCTURE,UNKNOWN OR OTHERCrash

  RUST UNDERNEATH ENGINE PART OF BODY FRONT PASSENGER SIDE I THINK THIS METAL SUPPORT BREAK ANYTIME WHILE DRIVING IN RAIN

• 10/12/2011· AIR BAGS

  AIR BAG LAMP RANDOMLY TURNS ON AND OFF. PAID TO HAVE IT FIXED ONCE BUT AFTER SEVERAL DAYS SAME TROUBLE RETURNED. AS I UNDERSTAND, IF THE AIR BAG LAMP IS LIT THE AIR BAGS WILL NOT DEPLOY. THIS WOULD SEEM LIKE A MANDATORY RECALL FOR A VERY UNSAFE CONDITION. *KB

• 10/11/2020· AIR BAGS

  THE AIR BAG LIGHT IS ON AND IT WON'T GO OFF. THIS IS ALL THE TIME WHEN THE CAR IS STATIONARY, OR MOVING. WHEN YOU TURN THE CAR ON AND OFF, IT'S STILL ON.

• 10/11/2018· STEERING,UNKNOWN OR OTHER

  "TAKATA RECALL" I THOUGHT I NEEDED A NEW INNER TIE ROD ON MY 2005 HYUNDAI SONATA. WHEN I WENT TO THE SHOP THE MECHANIC TOLD ME YOU HAVE BIGGER PROBLEMS. " YOUR SUB-FRAME ON THIS CAR IS RUSTED OUT AND THE CAR IS UNSAFE TO DRIVE." WITH THAT INFORMATION, I CALLED THE HYUNDAI SUPPORT NUMBER, THEY GAVE ME A REFERENCE NUMBER, I THEN WENT TO THE HYUNDAI DEALERSHIP TO GET AN ESTIMATE FOR REPAIRS AND TO SEE IF HYUNDAI WOULD REPAIR THE SUBFRAME. THE DEALERSHIP TOLD ME THAT HYUNDAI CORPORATION REFUSED TO PAY ANY GOODWILL MONEY TO FIX THE CAR BUT THEY DID TELL ME, " OUR ADVICE: " IS TO NOT DRIVE THE CAR, IT IS UNSAFE." THIS IS NOT A MECHANICAL ISSUE THIS IS A SAFETY ISSUE, AND EVEN THOUGH I DID NOT FIND ANY RECALLS FOR 2005 SUBFRAME, IT WAS OBVIOUS THAT HYUNDAI KNEW THEY DID HAVE A SLEW OF SONATAS THAT HAD A SERIOUS SUBFRAME CORROSION PROBLEM. IN MY BIT OF RESEARCH, THERE HAS BEEN A DEFINITE PROBLEM WITH THE SONATAS AND THE SUBFRAME ROTTING OUT, ALL DIFFERENT YEARS AND MILEAGE AND AGE THAT HYUNDAI DID REPAIR THE CARS THAT I FOUND ON EDMONDS.COM AND ON THE INTERNET.

• 10/08/2014· AIR BAGS

  AIR BAG LIGHT ILLUMINATES. CHECKED BY AUTO ELECTRICAL SERVICE SHOP, RESET LIGHT, BUT ILLUMINATES AGAIN SHORTLY AFTER. CONSTANT PROBLEM. TOLD AIR BAGS WILL NOT OPERATE IF LIGHTS IS ON. DANGEROUS. *TR

• 10/07/2015· SUSPENSION

  I NOTICE THAT THERE IS A RECALL ON HYUNDAI SONATA'S FROM 2006 -2010 IN REGARDS TO RUST CONCERNS WITH REAR SUSPENSION. THIS WAS JUST DETECTED BY MY MECHANIC THAT THE ATTACHING POINT FOR THE CONTROL ARM HAS RUSTED AND BECAME SEPARATED FROM THE CROSSMEMBER. THE RESULT AND MY IMMEDIATE CONCERN WAS THE SUDDEN CHANGE IN VEHICLE HANDLING, A LOUD NOISE COMING FROM THE REAR TIRE WHEN I HIT A SMALL BUMP. I WAS WONDERING WHY THE 2005 SONATA ISN'T COVERED IN THIS RECALL?

• 10/06/2006· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  DT*: THE CONTACT STATED WHILE TRAVELING AT HIGH SPEEDS OR COMING TO A STOP, THE VEHICLE STALLED WITHOUT WARNING. EACH TIME THE VEHICLE WAS RESTARTED, IT STALLED AGAIN AFTER IT WAS SLOWED DOWN TO 10 MPH. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHO PERFORMED DIAGNOSTIC TESTING WHICH IDENTIFIED CAUSE CODE #15 AND REPLACED THE IGNITION COIL ASSEMBLY, WIRE REPAIR TIME (MAJOR), COIL ASSEMBLY, IGNITION COIL ADD SCAN TOOL OPERATIONS. A YEAR LATER, THE VEHICLE WAS TAKEN TO ANOTHER SERVICE DEALER WHO COULD NOT DETERMINE THE CAUSE OF THE PROBLEM. THE MANUFACTURER WAS NOT NOTIFIED. UPDATED 10/25/2006 - *NM

• 10/05/2005· AIR BAGS,TIRESCrash

  I WAS DRIVING DOWN A ROAD AT 30-35 MPH WHEN I HAD A SIDEWALL BLOW OUT IN MY RIGHT FRONT TIRE, THE BLOW OUT CAUSED MY AIRBAGS TO DEPLOY WHICH HAD KNOCKED ME UNCONSCIOUS FOR A FEW MOMENTS. AFTER CONTACTING HYUNDAI, THEY ADMITTED THEY HAVE HEARD OF THIS HAPPENING BEFORE ON THEIR 2005 SONATAS, THEY HAVE NOT HOWEVER ISSUED A RECALL OR A NOTICE TO CONSUMERS WARNING THEM OF THE POSSIBLE AIRBAG DEPLOYMENT. AFTER BEING UNCONSCIOUS, I HIT 3 PARKED CARS AND PROCEEDED TO ROLL MY CAR UPSIDE DOWN. *NM

• 10/02/2012· SERVICE BRAKES

  WITH FAMILY IN CAR A TRAFFIC SITUATION OCCURRED THAT REQUIRED AGGRESSIVE BRAKING. WITHOUT WARNING THE CAR NOSE-DIVED, & SWUNG STRONGLY TO THE LEFT. THE SITUATION WAS VERY SCARY & I REGAINED CONTROL. FORTUNATELY NO CAR WAS IN THE NEARBY LANE. TOOK THE CAR INTO FIRESTONE WHERE AMONG OTHER THINGS THEIR CERTIFIED MASTER MECHANIC DID A FULL BRAKE INSPECTION, CHECKED THE TIRES FOR SIZE AND PRESSURE & DID A BRAKE FLUID FLUSH. THEY ADVISED THAT THERE WAS AN ABS PROBLEM & I SHOULD IMMEDIATELY TAKE THE CAR INTO THE DEALER AS THIS IS A MAJOR SAFETY PROBLEM! I TOOK THE CAR TO THE HYUNDAI DEALER IN DENTON, TX WHO RAN EXTENSIVE DIAGNOSTIC'S AND SAID THE ABS CONTROL MODULE (589203C500) SYSTEM HAD MALFUNCTIONED, WAS DEFECTIVE FINDING ONLY FLUID FLOW TO THE LEFT FRONT BRAKE CA. THE DEALER QUOTED APPROX. $2500 FOR MATERIALS, TAX AND LABOR SAYING THERE WAS NO WARRANT COVERAGE. WE WERE SHOCKED BY BOTH THE COST TO FIX AND THAT AN APPARENT MANUFACTURING DEFECT WOULD NOT BE COVERED BY THE MANUFACTURER. AT THE DEALER 10/01/2012, I CALLED HYUNDAI MOTORS USA & FILED CASE #5034644. AFTER QUITE SOME TIME ON THE PHONE THE CASE MANAGER SAID THERE WAS NO WARRANTY COVERAGE, THEY FELT NO RESPONSIBILITY FOR THE DEFECT AND ESSENTIALLY THAT IT WAS ALL ON ME TO FIX IT. EVEN AFTER ADDITIONALLY SHARING MY LACK OF EMPLOYMENT & TOUGH FAMILY FINANCIAL SITUATION IT WAS, "SORRY WE CAN DO NOTHING AS YOUR VEHICLE IS OUT OF WARRANTY. WE NOW HAVE NO CHOICE BUT TO FIGURE OUT HOW TO PAY FOR THE REPAIR OUT OF POCKET AS THE CAR IS CRUCIAL TO OUR NEEDS. *TR

• 09/30/2010· AIR BAGS

  AIR BAG LIGHT 2005 HYUNDAI SONATA IS ALWAYS ON. I HAD IT RESET 1X. I CANNOT GET MY CAR TO PASS INSPECTION AND FROM WHAT I'M READING ONLINE THIS COULD COST UP TO 1600$..I CANNOT AFFORD THAT KIND OF FIX AND MY EXTENDED WARRANTY DOESN'T COVER IT. THIS VEHICLE SHOULD BE RECALLED BECAUSE THIS IS A VERY COMMON PROBLEM WITH THE 05/06 SONATA. THIS IS A SAFETY ISSUE AND SHOULD NOT BE IGNORED. *TR

• 09/29/2016· STRUCTURE

  I HAVE A HYUNDAI SONATA 2005 AND THE MECHANIC FROM HYUNDAI DEALERSHIP NOTIFIED ME THE SUBFRAME CORROSION ISSUE. THE SYMPTOM OF MY CAR EXACTLY SAME AS THE CASE FROM NICHOLAS CIRULLI AND ROBERT D'ELIA V. HYUNDAI MOTOR COMPANY AND HYUNDAI MOTOR AMERICA, WHICH EVENTUALLY RECALLED 2000 - 2004 HYUNDAI SONATA DUE TO THE SUBFRAME CORROSION ISSUE. I AM WONDERING WHETHER 2005 HYUNDAI SONATA OWNERS EXPERIENCE A SIMILAR ISSUE AND THIS VEHICLE SHOULD BE INCLUDED ON THE RECALL AS WELL. I WOULD APPRECIATE IF NHTSA WOULD REVIEW THIS CASE. THANKS.

• 09/29/2010· POWER TRAIN

  CHECK ENGINE LIGHT COME ON WHEN IT RAINS 2005 SONATA AND TRANSMISSION WON'T SHIFT TILL THE LIGHT GOES OUT. *TR

• 09/26/2016· SUSPENSION,UNKNOWN OR OTHER

  I OWN A 2005 HYUNDAI SONATA GLS. WHILE DRIVING DOWN THE FREEWAY AT 70 MPH THE CAR SUDDENLY BECAME HARD TO CONTROL, AS IN IT STARTED PULLING EXTREMELY HARD TO THE RIGHT. I HAD TO DRIVE HOME WITH THE STEERING WHEEL COCKED TO THE LEFT IN ORDER TO GO STRAIGHT. I BROUGHT IT INTO THE SHOP THINKING IT NEEDED AN ALIGNMENT - BOTH FRONT TIRES WERE TILTED IN AT THE TOP - WHAT I FOUND OUT WAS THAT THE SUBFRAME WAS RUSTED IN HALF. IT SEEMS VERY SHADY TO ME THAT THERE IS A RECALL FOR THIS EXACT PROBLEM FOR PRETTY MUCH EVERY YEAR EXCEPT 2005. THIS IS THE SAME MODEL AS THE 2004 AND IT WAS MANUFACTURED THAT YEAR AS WELL. *ALSO, THE TRIM ON THE CAR, WHICH IS WHAT MAKES IT MORE EXPENSIVE, IS CONSTANTLY COMING OFF WHILE I'M DRIVING. THE SILVER TRIM AROUND THE PASSENGER WINDOW FLEW OFF ON THE TOLLWAY. THE DRIVER'S WINDOW TRIM CAME OFF DUE TO ICE - IT WAS REPLACED BY A BODY SHOP, BUT LATER FLEW OFF ON THE TOLLWAY AS WELL. THE TRIM ON ALL FOUR DOORS IS NOW BOLTED ON AS THAT KEPT FALLING OFF TOO. *ALSO, THERE IS SIGNIFICANT RUST RIGHT ABOVE THE TOP OF THE WINDSHIELD TO THE POINT THAT IT WILL SOON BE RAINING IN MY CAR.

• 09/26/2014· AIR BAGS

  AT ABOUT 110,000 MILES THE AIRBAG LIGHT CAME ON IN MY2005 SONATA. I TOOK IT TO THE DEALER AND THEY SCANNED IT. THEY SAID IT WAS EITHER A BAD MODULE OR A BREAK IN A WIRE. I TOOK IT TO A VERY GOOD LOCAL MECHANIC AND THEY INSPECTED THE WIRING AND MODULE IN THE CENTER CONSOLE AND FOUND NOTHING OBVIOUSLY WRONG. THEY PUT IT BACK TOGETHER AND THE LIGHT STAYED OFF FOR ABOUT 6 MONTHS. I TOOK IT BACK AGAIN, THE DID THE SAME THING AND IT STAYED OFF FOR ABOUT 3 WEEKS. IT HAS BEEN ON SINCE. *TR

• 09/24/2018· EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2005 HYUNDAI SONATA. THE CONTACT STATED THAT THE BRAKE LIGHTS FAILED TO SHUT OFF. AFTER EXITING THE VEHICLE, THE CONTACT NOTICED THAT THE BRAKE LIGHTS WERE ILLUMINATED. THE CONTACT OPENED THE HUB CAP AND SWITCHED THE WIRES IN ORDER TO TURN OFF THE LIGHTS. HUB HYUNDAI OF KATY (877- 773-4656, LOCATED AT 17007 KATY FWY, HOUSTON, TX 77094) WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE EXTERIOR LIGHTING RECALL AND TO CONTACT THE MANUFACTURER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V280000 (EXTERIOR LIGHTING). THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

• 09/24/2007· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  HEAD LAMPS AND FOG LAMPS BURN OUT ALL AT THE SAME TIME, POSSIBLE SHORT IN WIRING. *JB

• 09/24/2007· STEERING

  TL*THE CONTACT OWNS A 2005 HYUNDAI SONATA. WHILE DRIVING 35 MPH, THE STEERING WHEEL BECAME STIFF. THE CONTACT PULLED OVER AND TURNED OFF THE VEHICLE. WHEN THE VEHICLE WAS RESTARTED, THE STEERING OPERATED NORMALLY. THERE WERE NO WARNING INDICATOR LIGHTS PRESENT. THE DEALER WAS UNABLE TO DUPLICATE AND DIAGNOSE THE CAUSE OF FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 56,000.

• 09/23/2013· ELECTRICAL SYSTEM,EQUIPMENT

  2005 HYUNDAI SONATA. CONSUMER WRITES IN REGARDS TO AC COMPRESSOR ELECTRICAL PROBLEMS. *SMD ACCORDING TO THE REPAIR INVOICE, THE AC COMPRESSOR HAD AN ELECTRICAL MELTDOWN. THE AC CLUTCH CAME APART AND THE CLUTCH MELTED ONTO THE COMPRESSOR.

• 09/21/2009· EXTERIOR LIGHTING

  1)NO CHANGES OR EVENTS THAT LEAD TO THIS CONCERN. 2)HEADLIGHTS CONTINUE TO GO OUT. IT USUALLY STARTS WITH THE PASSENGER SIDE AND THEN ONTO THE DRIVERS SIDE. I HAVE TO REPLACE THE HEADLIGHT BULBS EVERY MONTH IF NOT MORE. 3)THESE BULBS ARE PURCHASED BRAND NEW. DEALER STATES NO RECALL. I REPLACED THE BLOWN PASSENGER BULB ON A TUESDAY, IT BLEW OUT TWO DAYS LATER AND THEN THE DRIVERS SIDE BLEW OUT; WE WERE IN THE MIDDLE OF A ROAD TRIP LATE AT NIGHT! NOT THE FIRST TIME THIS HAD HAPPENED. SAFETY ISSUE. I HAVE FRIENDS WHO ARE HAVING THE SAME OCCURRENCES. *TR

• 09/12/2016· AIR BAGS

  I HAVE A 2005 HYUNDAI SONATA AND REPORTED THIS TO THE DEALERSHIP TWICE AS OF TODAY AND THE DEALERSHIP CONTINUES TO STALL. THE AIRBAG LIGHT STAYS ON AND NEVER GOES OFF SO I REPORTED IT AGAIN ABOUT THIS PROBLEM, WHERE ARE SAFETY CONCERNS FOR THE CONSUMERS.

• 09/07/2015· SUSPENSION

  ACCORDING TO MECHANIC THE UPPER CONTROL ARM REAR PASSENGER SIDE IS RUSTED AND DETACHED.

• 09/02/2019· SUSPENSION,STRUCTURE

  WHILE CHANGING MY OIL ON THE WEEKEND, I NOTICED SEVERE CORROSION FAILURES WITH THE FRONT SUBFRAME ON THE RIGHT SIDE OF MY CAR. (SEE ATTACHED PHOTOS). ONE AREA WAS IN FRONT OF THE LOWER CONTROL ARM AND ANOTHER AREA IS BEHIND THE CONTROL ARM. IT LOOKS LIKE THE SUBFRAME WILL FAIL AT ANY MOMENT AND THE CONTROL ARM WOULD BE FREE TO MOVE ANYWHERE. THIS WOULD SIGNIFICANTLY AFFECT CONTROL OF THE VEHICLE AND BE A SERIOUS SAFETY CONCERN. I SEE THIS PART HAS ALREADY HAD A RECALL FOR 2001 TO 2004 HYUNDAI SONATAS WHICH IS THE SAME BODY AND FRAME STYLE AS THE 2005 VEHICLE. RECALL #09V124000.