2005 Chevrolet Suburban

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2010· ELECTRICAL SYSTEM

  MY 2005 CHEVROLET SUBURBAN HAS 79,985 MILES AND THIS WEEK WHILE DRIVING ROUTE 95 (70 MPH HIGHWAY IN THE SOUTH) FROM NEW JERSEY TO SOUTH CAROLINA MY SPEEDOMETER STARTED SHOWING A MUCH HIGHER SPEED THEN I WAS TRAVELING. I WAS USING MY GPS AT THE TIME AND IT SAID I WAS DOING 69 MPH WHILE MY GAUGE SHOWED A CONSTANT CLIMB TILL IT REACHED 120 MPH AND FLAT LINED BEYOND THAT POINT. THIS WAS A 1600 MILE ROUND TRIP AND IF I HAD NOT HAD MY GPS WITH ME I WOULD NOT KNOW HOW FAST OR SLOW I WAS GOING. I WAS WAITING FOR SOMETHING ELSE TO GO WRONG. WHILE IN SOUTH CAROLINA I WENT TO RECALLS ON THE INTERNET WITH 2005 GM SUV'S AND FOUND A WHOLE BUNCH OF SIMILAR COMPLAINTS, YET GM (CHEVROLET) HAS NOT DONE ANYTHING THAT I COULD FIND. I RETURNED HOME TODAY AND CALLED MY LOCAL CHEVROLET DEALER AND EXPLAINED TO THE SERVICE DEPARTMENT WHAT HAD HAPPENED AND THEY SAID THEY NEVER HEARD OF THIS AND GAVE ME AN APPOINTMENT FOR NEXT MONDAY 1/3/2011 TO BRING IN THE SUV. SINCE THIS CAR IS OUT OF SERVICE I AM HOLDING MY BREATH AS TO WHAT THE BILL COULD BE. THIS IS A VERY DANGEROUS THING, I COULD BE NOT LOOKING AT THE GAUGE AND BE RUNNING RIGHT INTO A HIGH SPEED ERROR AND PUTTING MY FAMILY IN HARMS WAY. CAN ANYONE HELP? *TR

• 12/30/2010· ELECTRICAL SYSTEM

  SPEEDOMETER STOPPED WORKING ON OUR 2005 CHEVY SUBURBAN. STARTED OUT GOING FROM 20 TO 100 AND NOT REGISTERING THE PROPER SPEED. NOW IS STUCK AT 120 MPH. COST RANGES FROM 300 TO 1000 DOLLARS TO FIX. HAVING TO USE GPS FOR SPEED WHICH IS A DISTRACTION AND SAFETY CONCERN. *TR

• 12/30/2010· FUEL SYSTEM, GASOLINE

  TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHEN SHE WALKED AROUND THE VEHICLE HE SMELLED GASOLINE AND COULDN'T TELL WHERE IT WAS COMING FROM, BUT NOTICED THAT THERE WAS A LEAK UNDERNEATH THE VEHICLE. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT THE ODOR CAME FROM A FRACTURE IN THE FUEL LINES. THE MECHANIC ADVISED THE CONTACT TO LEAVE HIS VEHICLE BECAUSE DRIVING THE VEHICLE WAS CAUSING THE FUEL LINES TO RUB TOGETHER. THE FUEL LINES WERE REPAIRED FROM THE FRONT AND REAR OF THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. UPDATED 5/2/11 *CN UPDATED 05/16/11

• 12/30/2007· ELECTRICAL SYSTEM

  THE SPEEDOMETER ON MY 2005 CHEVY TAHOE HAS BEEN ACTING ERRATICALLY. SOMETIMES IT WILL WORK NORMALLY. OTHER TIMES, IT WILL NOT REGISTER AT ALL. ADDITIONALLY TIME IT WILL READ ERRONEOUSLY WHEN DRIVING TRAFFIC SPEEDS. THE SELECTION PROCESS DID NOT ALLOW ME TO REGISTER A TAHOE, ONLY A SUBURBAN, WHICH IS WHY THE VEHICLE INFORMATION LOOKS AS IT DOES. *TR

• 12/28/2010· ELECTRICAL SYSTEM

  AT 99K MILES THE SPEEDOMETER STARTED ACTING ERRATIC. THERE ARE TIMES IT IS CORRECT AND TIMES WHEN IT READS 5 TO 25 MILES MORE THAN MY TRAVELING SPEED. IT IS DEFINITELY HIT OR MISS AS TO WHEN THIS WILL OCCUR. NOW THE OIL PRESSURE GAUGE AND THE RPM GAUGE ARE ACTING FAULTY AS WELL. I HAVE NOT TAKEN ANY MEASURES TO CORRECT THE SPEEDOMETER BUT IT WILL RESET ITSELF AFTER SEVERAL TIMES OF TURNING THE CAR ON AN OFF. THIS IS DEFINITELY A SAFETY HAZARD WHEN THE SPEEDOMETER READS ERRANTLY WHILE DRIVING ON THE INTERSTATE. *TR

• 12/27/2013· SERVICE BRAKES

  CATASTROPHIC BRAKE FAILURE, WITHOUT ANY WARNING , CAUSED BY COMPLETE CORROSION OF ENTIRE BRAKE LINE! RAN CAR OFF ROAD TO AVOID CARS AT STOP. EMERGENCY BRAKE ALSO FAILED DUE TO CORROSION. *TR

• 12/26/2008· ENGINE AND ENGINE COOLING

  MY 2005 K1500 SUBURBAN SUSTAINED A CRACKED HEAD WITH 73,000 ON THE ENGINE. THE SERVICE DEPARTMENT AT MY DEALERSHIP HAS NO INFORMATION THAT A MANUFACTURING PROBLEM EXISTS. THE REPAIR COST OVER $2,000. THIS IS NOT A NORMAL OCCURRENCE OR EXPECTED VEHICLE WEAR. *TR

• 12/24/2016· AIR BAGS

  ONE MORNING CAME OUT TO START MY 2005 SUBURBAN AND THE SERVICE AIRBAG MESSAGE POPPED ON ALONG WITH THE AIRBAG LIGHT. TOOK IT TO MY SERVICE CENTER AND WAS TOLD IT WAS A FRONT IMPACT SENSOR. WAS ALSO TOLD THIS IS A COMMON PROBLEM ON THESE VEHICLES. AFTER DOING SOME RESEARCH ONLINE I HAVE FOUND THIS TO BE A VERY COMMON PROBLEM RENDERING THE AIRBAG SYSTEM INOP. I BELIEVE GM NEEDS TO STEP UP AND FIX THE ISSUE WITH THE SENSORS AS NOT EVERYONE HAS $400 TO FIX A FAULTY SENSOR. THE ODOMETER ON MY SUBURBAN IS 127,000 MILES, SO BY NO MEANS DRIVEN HARD.

• 12/24/2005· TIRES

  WHILE DRIVING OUR 2005 SUBURBAN ON THE INTERSTATE, THE CHECK TIRE PRESSURE INDICATOR CAME ON AND IMMEDIATELY THE BACK END BECAME SQUIRRELLY. PULLING TO THE SIDE OF THE ROAD, THE PASSENGER SIDE REAR TIRE WAS COMPLETELY BLOWN AT THE SIDEWALL. THE TREAD CAUGHT ONTO THE WHEEL WELL FLARE, CAUSING ABOUT $500 IN DAMAGE TO THE VEHICLE. THE TIRE WAS ORIGINAL EQUIPMENT ON THE SUBURBAN, A P265/70R16 FIRESTONE WILDERNESS RADIAL. THE VIN NUMBER ON THE SUBURBAN IS [XXX]. THE TIRES HAD ABOUT 12,000 MILES OF USAGE WHEN THE BLOWOUT HAPPENED. I CONTACTED GM (SERVICE REQUEST CLAIM #[XXX]) AND HAD THE SERVICE MANAGER AT JOHN SERETTI CHEVROLET IN MOON, PA INSPECT THE TIRE. HE COULD FIND NO PUNCTURES, FOREIGN OBJECTS OR OTHER EVIDENCE OF EXTERNAL DAMAGE TO THE TIRE. GM REVIEWED THIS AND INFORMED ME THAT THEY DID NOT HAVE ENOUGH INFORMATION TO DECLARE A DEFECT, SO THEY REFERRED ME TO THE TIRES MANUFACTURER, FIRESTONE. THE FIRESTONE SHOP IN MOON, PA ALSO COULD NOT FIND ANY PUNCTURE OR EXTERNAL DAMAGE. THE MANAGER THERE SAID THE BLOWOUT COULD HAVE HAPPENED FOR ANY NUMBER OF REASONS OTHER THAN A DEFECT AND TRIED TO SUGGEST THAT IT HAD BEEN DRIVEN WITH TOO LITTLE TIRE PRESSURE. THAT CANNOT BE THE CASE. THE TIRES HAD BEEN ROTATED AND THE AIR PRESSURE CHECKED BY THE DEALERSHIP WITHIN THE PREVIOUS MONTH AND THE VEHICLE IS EQUIPPED WITH AN AIR PRESSURE SENSOR THAT WARNS OF DROPS. THAT SENSOR WENT OFF AT THE SAME TIME THE TIRE BLEW. FIRESTONE SOLD US A REPLACEMENT TIRE AT A PRORATED COST BASED ON THE USAGE FROM THE ORIGINAL. *JB UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/22/2004· POWER TRAIN,VISIBILITY

  THE DRIVER AND PASSENGER'S SIDE MIRRORS FAILED. THE OBJECTS APPEARED FAR AWAY THAN NORMAL. THIS CAUSED POOR VISIBILITY. THE VEHICLE HAD A TOW MIRROR PACKAGE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION, AND THE MECHANIC DETERMINED THAT THIS WAS A DESIGN FLAW FROM THE MANUFACTURER. THE MECHANIC INFORMED THE CONSUMER THAT THE MIRROR COULD BE REPLACED, BUT THE DRIVER HAD TO PAY FOR IT. *AK THE FOUR WHEEL DRIVE LIGHT HAD COME ON. *SC

• 12/19/2007· ELECTRICAL SYSTEM

  SPEEDOMETER OPERATES ERRATICALLY, STICKS WHEN CHANGING SPEEDS, OR READS ERRONEOUSLY (E.G. 5 MPH ON THE FREEWAY DOING 70 OR 100 MPH WHEN PARKED). *TR

• 12/14/2010· ELECTRICAL SYSTEM

  SPEEDOMETER ON OUR 2005 SURBURBAN HAS BEEN MALFUNCTIONING LIKE ALL OTHERS REPORTED ON THIS SITE - OURS FOR WELL OVER TWO YEARS: SOMETIMES READS ZERO WHEN DRIVING AT HIGHWAY SPEEDS, OTHER TIMES IS TACKED AT OVER 120 MPH. WE CAN BE AT A STOP AND IT READS 90. AFRAID TO USE CRUISE CONTROL - WHO KNOWS WHAT WILL HAPPEN! WAITING FOR NHTSA TO DEMAND A RECALL THESE VEHICLES: WHAT WILL IT TAKE? SOMEONE DYING BECAUSE THEY HYDROPLANE, OR ROLL, OR REAR END SOMEONE BECAUSE THEY HAVE NO CLUE HOW FAST THEY ARE GOING? *TR

• 12/12/2008· ELECTRICAL SYSTEM

  I HAVE A COMPLAINT ABOUT THERE NOT BEING A RECALL ON MY 2005 CHEVY SUBURBAN ON THE INSTRUMENT PANEL AND ELECTRICAL COMPONENTS. SOMETIME EARLIER THIS YEAR MY SPEEDOMETER STARTED JUMPING TO HIGHER SPEEDS AS I WAS DRIVING AND THEN GOT TO THE POINT IT WAS GOING ALL THE WAY PAST 120MPH. SOMETIMES IT WOULD RESET TO 0 AFTER THE VEHICLE WAS TURNED OFF. MOST RECENTLY IT HAS GONE PAST 120 AND WILL NOT RETURN TO THE NORMAL FUNCTIONS IT SHOULD HAVE. IT IS VERY DANGEROUS NOT TO KNOW HOW FAST YOU ARE GOING, HOWEVER, LIKE EVERYONE ELSE I CANNOT AFFORD THE $400-$600 TO PAY FOR SOMETHING THAT IS A MANUFACTURES DEFECT OBVIOUSLY! WITH SO MANY COMPLAINTS LISTED EXACTLY THE SAME ON THIS SITE, IT HAS TO BE A MANUFACTURES DEFECT. BESIDES THE SPEEDOMETER NOT WORKING PROPERLY, ALL THE INSTRUMENT LIGHTS ARE STARTING TO GO OUT OR NOT WORK. SUCH AS THE RADIO ON/OFF SWITCH NO LONGER LIGHTS UP. SOME OF THE OTHER RADIO LIGHTS DO NOT LIGHT UP. ON THE STEERING WHEEL, SOME OF THE CONTROLS DO NOT LIGHT UP. I CANNOT BELIEVE THAT I HAVE RECEIVED A LETTER LETTING ME KNOW OTHERS ARE ALSO EXPERIENCING PROBLEMS WITH THEIR CHEVY VEHICLES AND THEY HAVE STARTED A LAW SUITE. MY VEHICLE IS A 2005 MODEL, BUT SINCE I BOUGHT IT IN MARCH 2005, SO IT MUST HAVE BEEN MANUFACTURED BEFORE JAN 2005. THE LETTER SAYS IT COVERS UP TO 2004 MODELS AND MAY LATER INCLUDE THE 2005 MODELS. AS I SEE IT MINE IS DOING EXACTLY THE SAME AS EVERYONE ELSE AND NOTHING IS BEING DONE. COULD SOMEONE EXPLAIN WHAT HAPPENS NEXT? AND WHEN WILL CHEVY BE RESPONSIBLE FOR ALL THESE COMPLAINTS? *TR

• 12/07/2005· POWER TRAIN

  WHILE DRIVING INTO WORK THE REAR END HOUSING EXPLODED AND THE DRIVE SHAFT DROPPED TO PIECES BOTH FLEW ALL OVER THE HIGHWAY SOME COMING OUT RED HOT. *JB

• 12/05/2007· STEERING

  THE EVENTS LEADING UP TO THE FAILURE WAS NORMAL VEHICLE OPERATION FOR APPROXIMATELY ONE YEAR. THE FAILURE TO THE VEHICLE WAS A VIBRATION IN THE STEERING SHAFT. CONSEQUENCES COULD HAVE RESULTED IN A LOSS OF STEERING. CHEVROLET SERVICE LUBED THE STEERING SHAFT PER A GM SERVICE BULLETIN. THIS REPAIR WAS COVERED UNDER WARRANTY. APPROXIMATELY ONE YEAR LATER, THE SAME FAILURE OCCURRED. CHEVROLET SERVICE STATED THAT GM HAS DEVELOPED A NEW STEERING SHAFT TO ELIMINATE THIS PROBLEM. I WILL BE TAKING MY VEHICLE IN FOR REPAIR 3 DAYS FROM THIS WRITING. CHEVROLET SUGGESTED THIS COMPLAINT AS A METHOD OF OBTAINING A RECALL AND SUBSEQUENTLY A REIMBURSEMENT FOR THE REPAIR. *TR

• 12/03/2012· ELECTRICAL SYSTEM

  ON AUGUST 3RD, 2012 MY 2005 CHEVROLET SUBURBAN 1500 FIRST SHOWED SIGNS OF THE INSTRUMENT PANEL CLUSTER FAILING. THE TACHOMETER SHOWED A READING OF 5,000 RPMS WITH THE ENGINE IDLING. THIS CONTINUED FOR A FEW DAYS AND THEN SEEMED TO GO BACK TO NORMAL. ABOUT A WEEK LATER THE SPEEDOMETER BEGAN TO INDICATE INCORRECT READINGS. BY SEPTEMBER 6TH, 2012 I HAD NOTICED IT WOULD SOMETIMES SHOW A SPEED OF 120 MPH WHILE GOING AN ACTUAL SPEED 50 MPH OR SOMETIMES SHOW 29 MPH WHILE GOING 50 MPH. FOR A WHILE IT WAS MOVING THE NEEDLE BELOW 0MPH. I CAN NO LONGER RELY ON THE GAUGES OF THIS VEHICLE WITH ONLY 65,000 MILES ON IT. *TR

• 12/03/2011· ELECTRICAL SYSTEM

  I HAVE A CHEVY SUBURBAN 2005 MY SPEEDOMETER HAS STOPPED WORKING. I ALSO HAVE A 2005 DURAMAX THAT THIS HAS HAPPENED TO. I WOULD LIKE TO SEE A FULL BLOWN RECALL PLACED ON ALL GMC/CHEVY VEHICLES. APPARENTLY THESE ARE HUNDREDS OF THOUSANDS PEOPLE WITH THIS ISSUE ACROSS THE U.S./ WORLD ACCORDING TO FORUMS I HAVE BEEN ON. WHILE THERE IS A CLASS ACTION LAWSUIT OUT THERE FOR A VERY LIMITED GROUP OF GMC VEHICLES, MAKING LAWYERS RICH. INSTEAD OF TAKING CARE OF THE PEOPLE WHOM MAKE THIS WORLD ACTUALLY RUN. THIS ISSUE NEEDS TO SERIOUSLY LOOKED INTO. MY NEXT STEP IS TO GET THE MEDIA INVOLVED SHOWING HOW AGAIN THE AVERAGE CONSUMER CAN GET SCREWED BY THE BIG COMPANIES. I AM NOT KEEPING MY MOUTH SHUT ABOUT THIS. THANK YOU *TR

• 12/03/2010· ELECTRICAL SYSTEM

  WE OWN A 2005 CHEVY SUBURBAN, AND THE SPEEDOMETER BEGAN TO JUMP AROUND AND ACT ERRATICALLY. IT NOW SHOWS ABOUT 60 MPH, EVEN THOUGH THE VEHICLE IS AT A STOP. GOES UP ABOVE 120 MPH WHILE DRIVING THROUGH TOWN. WE CALLED THE DEALERSHIP, AND JUST LIKE OTHERS REPORTED, WAS TOLD WE WERE GOING TO BE TAKEN FOR OVER $600 FOR A REPAIR THAT IS OCCURRING IN VIRTUALLY EVERY 2005 GM TRUCK (ALONG WITH OTHER YEARS). WE CAN NO LONGER TELL WHAT SPEED WE ARE DRIVING, WHICH IS A SERIOUS SAFETY HAZARD, ESPECIALLY FOR MY TEENAGE DRIVERS THAT DRIVE THIS VEHICLE. *TR

• 12/03/2010· ELECTRICAL SYSTEM

  WHILE DRIVING THE SPEEDOMETER JUMPED TO 20 MPH AND NEVER DROPPED BACK DOWN. *TR

• 12/02/2009· ELECTRICAL SYSTEM

  SPEEDOMETER DOES NOT WORK ON MY 2005 CHEVROLET SUBURBAN 1500. STOPPED WORKING AT ABOUT 60,000 MILES - THERE SHOULD BE A RECALL AS THIS IS A COMMON PROBLEM ON THIS VEHICLE AND IT COSTS APPROX. $500 TO FIX AND IT IS A SAFETY HAZARD. *TR

• 12/01/2015· SERVICE BRAKES

  AS I WAS ABOUT TO EXIT A PARKING LOT ONTO A FOUR LANE ROADWAY, THE BRAKES ON MY 2005 CHEVROLET SUBURBAN FAILED. I LIVED APPROXIMATELY 1/2 MILE FROM THIS LOCATION AND PROCEEDED TO DRIVE HOME. IT WAS A LITTLE SCAREY WITHOUT ANY STOPPING POWER, EVEN THE EMERGENCY BAKE WOULD NOT HOLD. WHEN I GOT HOME, I USED A FLASHLIGHT TO TRY TO FIND THE SOURCE OF THE PROBLEM. FOUND A PATTERN OF BRAKE FLUID LEAKING. REMOVED THE SPARE TIRE TO GET A BETTER LOOK AND FOUND A BRAKE LINE BETWEEN THE ABS AND REAR OF THE VEHICLE HAD RUSTED OUT. FROM THE LOOKS OF THE LINE CONDITION, THEY NEED TO BE ALL REPLACED. NEVER IN MY 70 YEARS HAVE I SEEN BRAKE LINES ON A TEN YEAR OLD VEHICLE LOOK LIKE THEY DID, REALLY IN BAD SHAPE. LOOKED AT OTHER LINES, FUEL, TRANSMISSION, THEY ALL LOOKED LIKE THEY SHOULD BE REPLACED.

• 11/28/2012· ELECTRICAL SYSTEM

  SPEEDOMETER VERY ERRATIC, SHOWS EXCESSIVE SPEEDS (120MPH) OR DOESN'T REGISTER CORRECT SPEED AT ALL. CALLED DEALER NUMEROUS TIMES ABOUT PROBLEM AND NEVER TOLD ABOUT THE TSB ONLY THAT IT WOULD BE OVER $600 TO FIX. DID RESEARCH ONLINE AND FOUND TSB AND CALLED AGAIN. THIS IS A HUGE SAFETY HAZARD AND ONE THAT CHEVROLET SHOULD ADDRESS ACROSS THE BOARD WITH THE VEHICLES AFFECTED BY THIS. THEN WAS TOLD CAN'T FIX IT BECAUSE OF MILEAGE UNLESS I PAY OUT OF POCKET. NOW NEEDLE IS STUCK AT ZERO AND UNFORTUNATELY BEING MILITARY WE DON'T GET PAID ENOUGH TO JUST SHELL OUT $600+ ON A WHIM. SOMEONE NEEDS TO MAKE CHEVROLET TAKE CARE OF THEIR FAULTY PRODUCTS, IF YOU PAY FOR A PREMIUM PRODUCT YOU SHOULD GET ONE. *TR

• 11/26/2007· POWER TRAIN

  TRANSMISSION HOT LIGHT CAME ON AS TRAVELING THE INTERSTATE. PULLED OVER UNTIL LIGHT WENT OUT. LEFT THE INTERSTATE, LIGHT CAME ON AGAIN. AS TRYING TO PULL OFF ROAD, TRUCK STOPPED (ENGINE ON, BUT WOULD NOT ADVANCE FORWARD). HAD TO REPLACE WITH ANOTHER TRANSMISSION. *TR

• 11/24/2008· ELECTRICAL SYSTEM

  THE SPEEDOMETER IN MY 2005 CHEVROLET SUBURBAN HAS DEVELOPED A TICKING NOISE IN THE PAST FEW DAYS. THE VEHICLE HAS 83, 300 MILES. IT STARTED AS A LOW CLICKING NOISE AND HAS CONTINUED TO BECOME LOUDER. I HAVE CONTACTED THE LOCAL CHEVROLET DEALERSHIP, WHICH GAVE ME NO SATISFACTION FOR REPAIRS. *TR

• 11/21/2013· WHEELS

  TL* THE CONTACT OWNS A 2005 CHEVROLET K1500 SUBURBAN. THE CONTACT STATED THAT THE SPARE TIRE CARRIER ON THE VEHICLE WOULD NOT LATCH OR DETACH PROPERLY. THE VEHICLE WAS NOT INSPECTED, DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 91,175.

• 11/19/2010· ELECTRICAL SYSTEM

  2005 CHEVY SUBURBAN THE SPEEDOMETER JUST WENT OUT @ 42,600K MILES. *TR

• 11/18/2013· TIRES

  TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN EQUIPPED WITH FEDERAL COURGIA M/T 33 TIRES (N/A), SIZE:12.50/R20. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE TREAD BECAME SEPARATED FROM THE REAR DRIVER'S SIDE TIRE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO A TIRE SHOP WHERE THE TECHNICIAN REPLACED ALL FOUR TIRES. THE CONTACT EMAILED THE MANUFACTURER BUT HAD NOT RECEIVED A RESPONSE. THE FAILURE MILEAGE OF THE TIRE WAS 7,800. THE VEHICLE FAILURE MILEAGE WAS 139,000. THE DOT NUMBER WAS NOT AVAILABLE.

• 11/16/2010· LATCHES/LOCKS/LINKAGES

  TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THERE WAS NO KEY SLOT FOR THE REAR HATCH AND NOW THE SWITCH, WHICH WAS ON THE DRIVERS SIDE WILL NOT OPEN THE VEHICLE. THE CONTACT WAS UNABLE TO OPEN THE WINDOW ON THE REAR HATCH AS WELL. THE DEALER STATED IT WAS NOT UNDER WARRANTY, BUT THE MODULE THAT CONTROLS THE REAR HATCH AND WINDOW HAD FAILED. THE FAILURE MILEAGE WAS 60000 AND THE CURRENT MILEAGE WAS 61000.

• 11/15/2010· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. THE CONTACT STATED HE NOTICED WHILE DRIVING 30 TO 40 MPH THAT THE SPEEDOMETER READ 120 MPH, AND WHEN DRIVING 70MPH THE SPEEDOMETER READ 0 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED. THE DEALER ADVISED THE CONTACT THAT THE INSTRUMENTAL CLUSTER PANEL FAILED. THE MANUFACTURER ADVISED THAT BECAUSE THE VEHICLE WAS OVER THE EXTENDED WARRANTY COVERAGE, THEY WOULD NOT ASSIST WITH THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE WAS 69,000.

• 11/13/2013· AIR BAGS

  TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THE AIR BAG SENSOR WAS REPLACED HOWEVER, THE FAILURE LATER RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED AND MANUFACTURER WAS NOT MADE AWARD OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 75000.

• 11/13/2007· TIRES

  TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE VEHICLE HAS TWO COOPER TEMPRA TRAIL CUTTERS, SIZE LT26570R17 TIRES (NA). WHILE DRIVING 70 MPH, THE CONTACT FELT A STRONG VIBRATION COMING FROM THE TIRES. THE REAR PASSENGER SIDE TIRE TREAD SEPARATED, CAUSING THE TIRE TO EXPLODE. THE FAILURE DAMAGED THE REAR FENDER, BUMPER, AND TAILPIPE. TRIPLE A ARRIVED AND REPLACED THE TIRE. THE VEHICLE IS CURRENTLY AT THE BODY SHOP AND ALL FOUR TIRES WILL BE REPLACED BECAUSE THE REAR DRIVER SIDE TIRE ALSO SHOWS TREAD SEPARATION AND BLISTERS. THE DOT NUMBER AND DEALER INFORMATION WERE UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 85,000. UPDATED 12/12/2007 *BF UPDATED 12/12/07 *TR

• 11/11/2014· SERVICE BRAKES

  WE BOUGHT OUR CHEVY SUBURBAN IN MAY OF 2014, 73,000 MILES, GARAGE KEPT VEHICLE. THE SUBURBAN IS IN BEAUTIFUL SHAPE, ENGINE COMPARTMENT SHOWS VERY LITTLE SIGNS OF RUST OR CORROSION, SAME GOES FOR THE UNDERSIDE OF THE VEHICLE, VERY CLEAN. THIS PAST WEEKEND WHILE TRAVELING DOWN A LARGE HILL, MY WIFE HAD OUR TWO BOYS WITH HER IN THE VEHICLE AGES 5 AND 7 WHEN ALL OF A SUDDEN THE BRAKES GAVE OUT COMPLETELY, NO BRAKING POWER AT ALL. IF IT WASN'T FOR THE EMERGENCY BRAKE THEY WOULD HAVE BEEN SERIOUSLY HURT OR WORSE. UPON INSPECTION OF THE VEHICLE WE FOUND THAT THE BRAKE LINES ARE COMPLETELY ROTTED, THE ONLY PART ON THE VEHICLE THAT LOOKS LIKE THIS. WE KNOW WHO OWNED THE VEHICLE BEFORE US, ONE OWNER, AND SHE DID NOT DRIVE THIS VEHICLE VERY OFTEN IN WINTER WEATHER. SHE WORKS FOR A SCHOOL DISTRICT AND HAS OFF WHEN IT SNOWS. SHE ALSO HAD AN OLDER CAR THAT SHE DROVE WHEN THE WEATHER AND ROADS WERE BAD. THESE BRAKE LINES ARE FAULTY. THERE IS NO WAY THESE BRAKE LINES SHOULD LOOK LIKE THIS AFTER 9 YEARS ON THE ROAD. MY NEIGHBOR HAS A 2005 YUKON AND HAS THE SAME PROBLEM. MY FRIEND [XXX] HAS A 2003 GMC PICKUP, SAME PROBLEM, HE ALMOST CRASHED INTO A LAKE WHEN HIS BRAKE LINES FAILED. SOMETHING NEEDS TO BE DONE ABOUT THIS AND FAST AS PEOPLE ARE GOING TO GET KILLED. I HAVE PICTURES I CAN SHARE WITH ANYONE WHO WANTS TO SEE THEM. YOU CAN ALSO CONTACT ME AT ANY TIME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 11/10/2014· STEERING,POWER TRAIN

  HAD SERVICED THE TRANSFER CASE AND HAD TAKEN IT BACK TWICE NOW BESIDES A NOISE LIKE THAT OF A POWER STEERING PUMP GOING BAD ( WHINING ) , HAD A TURNING CLUNK NOISE COMING AND AT A STOP LIGHT I SAW SMOKE COMING FROM PASSENGER SIDE, GOT TO PARK IT AND SMELLED LIKE SOMETHING IS BURNING .BRING IT BACK TO SEE IF THE MECHANIC WILL WORK ON IT SINCE IT HASN'T BEEN 30 DAYS. PLEASE NOTIFY ME OF ANYTHING DO TO THE TRANSFER CASE. *TR

• 11/08/2010· SERVICE BRAKES, HYDRAULIC

  TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH WHEN THE BRAKES LOCKED AND THE VEHICLE WOULD ONLY ACCELERATE AT A VERY LOW SPEED. THE CONTACT CONTINUED TO DRIVE AT A LOW SPEED UNTIL SHE HEARD A LOUD BANG AND THE VEHICLE SUDDENLY BEGAN TO PICK UP SPEED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT REPAIRED NOR WAS THE VEHICLE INSPECTED FOR THE FAILURE. ON A LATER DATE WHILE DRIVING 45 MPH, SHE APPLIED PRESSURE TO THE BRAKE PEDAL AND THE PEDAL ABNORMALLY DEPRESSED INTO THE FLOORBOARD. THE BRAKES DID NOT RESPOND AND THE CONTACT SHIFTED THE VEHICLE INTO NEUTRAL AND COASTED TO A STOP. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE BRAKE DISCS HAD FAILED. THE VEHICLE WAS REPAIRED. SHE ALSO STATED THAT THE SPEEDOMETER WAS INOPERABLE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS UNKNOWN.

• 11/07/2008· POWER TRAIN

  TRANSMISSION FAILURE. AS I BEGAN ACCELERATING FROM A STOP, IN ORDER TO MAKE A LEFT TURN ACROSS OPPOSING TRAFFIC LANES, I HAD A COMPLETE FAILURE OF FORWARD MOMENTUM. THE VEHICLE BEHIND ME NARROWLY MISSED A REAR END ACCIDENT AND OPPOSING TRAFFIC WAS FORCED TO QUICKLY STOP AS I WAS LEFT BLOCKING THEIR TRAFFIC LANE. VEHICLE STILL UNDER WARRANTY WITH 25,122 MILES. DEALER REPAIRED TRANSMISSION AND IDENTIFIED "SPRAG GEAR FOUND DAMAGED ... CLUTCHES ALSO BURNT REPLACED AS NEEDED...". POSSIBLE TSBS 08-07-30-027. *TR

• 11/03/2008· TIRESCrash

  ROLLOVER ACCIDENT OF 2005 CHEVY SUBURBAN. RIGHT REAR TIRE SEPARATED TREAD AT HIGHWAY SPEED. TIRES WERE BIG O PATHMAX LT245/75R16. TIRES HAD 10,465 MILES OF USE AT TIME OF ACCIDENT. THE TREAD ON REMAINING INFLATED TIRES SHOWED BELTS BETWEEN TREAD EVEN THOUGH THE TREAD ITSELF LOOKED OK. DRIVER WAS INJURED, VEHICLE WAS TOTALED. *TR

• 11/01/2010· SERVICE BRAKES, HYDRAULIC

  ONE WEEK AGO I WAS DRIVING TO MY BACK ABOUT 6 TO 7 MILES AND MY BRAKES WENT OUT. I WAS SO SCARED I ALMOST DIED IT WAS A HEAVY TRAFFIC AREA. THIS TIME IT WAS MY FRONT ROTOR CRACKED RIGHT IN HALF. I SEE A BIG PROBLEM WITH THIS ESPECIALLY WHEN THE CAR IS ONLY 5 YEARS OLD. I HAVE ASKED AROUND AND NOBODY HAS EVER SEEN OR HEARD OF SUCH A THING. THIS IS CRAZY AND I TAKE MY KIDS IN THIS CAR. *TR

• 10/27/2014· SERVICE BRAKES

  MY 2005 CHEVROLET SUBURBAN HAS RUSTED BRAKES LINES THAT WILL COST ME $2,000 TO REPAIR. INTERESTINGLY I SEE MANY NATIONAL ARTICLES ABOUT THE PROBLEM AND A SIGNIFICANT NUMBER OF COMPLAINTS FILED. GM HAS REFUSED TO ISSUE A RECALL TO COVER THIS DANGEROUS PROBLEM; OTHER AUTOMAKERS HAVE DONE SO. THE NHTSA HAS BEEN INVESTIGATING THIS FOR WELL OVER 3 YEARS AND DONE NOTHING ABOUT IT TO DATE. I DON'T HAVE $2,000 TO HAVE THE WORK DONE, HOWEVER I ALSO CAN'T RISK THE LIVES OF MY FAMILY AND THOSE OF OTHER DRIVERS AND PEDESTRIANS. THIS PROBLEM NEEDS IMMEDIATE ACTION AND GM SHOULD TAKE FULL RESPONSIBILITY FOR THE REPAIR. PRIOR TO THIS I WOULD CONSIDER BUYING ANOTHER SUBURBAN, HOWEVER, NO MORE GM FOR ME! ITS A DISGRACE THE GM DOES NOT VALUE ITS CUSTOMERS AND THEIR SAFETY AND THAT THE NHTSA HAS NOT STEPPED UP TO FORCE A RECALL. JUST HOW MANY PEOPLE HAVE TO BE SERIOUSLY INJURED OR DIE FOR ACTION TO OCCUR? *TR

• 10/27/2006· SEAT BELTS

  DT*: THE CONTACT STATED WHILE DRIVING 35 MPH, THE SEAT BELT ON THE PASSENGER AND CENTER SECOND ROW SEATS CAME UNLATCHED ON THREE OCCASIONS. THE VEHICLE WAS DRIVEN TO THE DEALER EACH TIME WHERE THE BUCKLE ASSEMBLY WAS REPLACED TWICE, HOWEVER THE PROBLEM RECURRED. UPDATED 12/1/2006 - *NM

• 10/25/2022· ELECTRICAL SYSTEM

  This defect pertains to gear indicator on the instrument panel. During the daylight hours the light indicating the gear the car is in (park, neutral, drive, etc.) is impossible to read. At night you can just barely read the gear indicators. The dimness of the lights behind this gear indicator gauge is a safety hazard because you cannot tell what gear you are in during the day. It is an expensive repair because the instrument panel needs to be removed to fix the problem.

• 10/25/2022· VEHICLE SPEED CONTROL

  Speedometer stops working intermittently. This is a safety hazard as the operator cannot tell the speed that the vehicle is operating. It seems to occur randomly.

• 10/25/2005· SERVICE BRAKES, HYDRAULIC

  GENERAL MOTORS RECENTLY ANNOUNCED AN SUV/TRUCK RECALL FOR DEFECTIVE AND UNSAFE ANTI-LOCK BRAKE SYSTEMS. THE RECALL WENT INTO EFFECT IN 14 COLD-WEATHER STATES AND CANADA...BUT IT EXCLUDED WISCONSIN!!!! IT DID SO BECAUSE GM SAID IT DIDN'T HAVE ENOUGH COMPLAINTS FROM WISCONSIN. THAT'S LUDICROUS! MANY HERE HAD THE SAME PROBLEMS AS IN IOWA, MICHIGAN, AND ALL THE REST. I EXPERIENCED THE PROBLEM, TOOK MY 2001 SUBURBAN TO MY GM DEALER FOR REPAIRS, AND WAS TOLD I'D BE REIMBURSED SUBJECT TO THE RECALL. THEN THE WISCONSIN EXCLUSION WAS ANNOUNCED. MANY PEOPLE HERE WILL BE OPERATING UNSAFE VEHICLES...AND THAT'S NOT RIGHT! PLEASE HELP. MARK & SHARON LEIDER. *NM

• 10/23/2007· ELECTRICAL SYSTEM

  THE SPEEDOMETER NEEDLE BEGAN READING HIGHER AND HIGHER SPEEDS EVEN THOUGH THERE WAS NO ACCELERATION. WHEN SITTING STILL, THE SPEEDOMETER READ 70 MPH. THE NEEDLE WILL NOT RETURN TO ZERO, EVEN WHEN THE VEHICLE IS PARKED.I HAVE CONTACTED THE DEALER AND WAS TOLD IT WOULD COST $400.00 TO $500.00 TO REPAIR. I CANNOT DRIVE THE VEHICLE, NOT KNOWING HOW FAST I AM GOING. *JB

• 10/22/2018· ELECTRICAL SYSTEM

  I NOTICED CORRODED AND WHAT I WOULD CALL CHARRED OR BURNT WIRING ON THE WIRING HARNESS FOR THE REAR LIFT GATE OF MY SUBURBAN. I NOTICED IT WHEN I OPENED THE LIFT GATE TO GAIN ACCESS TO THE REAR OF THE SUBURBAN. IT APPEARS THAT THE RUBBER GROMMET MATERIAL PROTECTING THE WIRING HARNESS, WAS BURNT OR MELTED AWAY. THE RUBBER HOSE THAT SUPPLIES WATER TO THE REAR WINDOW WASHER/WIPER HAD A HOLE IN IT, AND MAY HAVE BEEN LEAKING WINDSHIELD WASHER FLUID ONTO THE WIRES FOR A TIME. THE WIRES WERE BARE IN SOME SPOTS, SOME OF THE WIRE INSULATION LOOKED MELTED/BURNT AWAY, AND THEY LOOKED CORRODED/WITH A GREEN COLOR TO THEM. THE CONNECTOR THAT CONNECTS THE HARNESS, TO THE REST OF THE ELECTRICAL SYSTEM, LOOKED LIKE IT HAS SOME BLACK/ POSSIBLY BURNT RESIDUE ON IT. I CAN TAKE A GUESS AT BEST, THAT BECAUSE OF THE HOLE IN THE RUBBER HOSE, WATER MAY HAVE BEEN LEAKING ONTO THE ELECTRICAL WIRING/CONNECTIONS WHEN I USED THIS FEATURE TO CLEAR DIRT FROM THE LIFT GATE WINDOW, BUT I DON'T REALLY KNOW FOR SURE IF THAT IS HOW THE DAMAGE TO THE WIRING HARNESS HAS OCCURED! THANKS!

• 10/20/2008· POWER TRAIN

  TRANSMISSION NEEDED TO BE REPLACED WITH A REBUILT TRANSMISSION @ 51,100 MILES. CHILDREN AND OTHER PASSENGERS WERE STRANDED IN PA @ 12:00 AM. *TR

• 10/14/2007· ELECTRICAL SYSTEM

  SPEEDOMETER WAS TICKING UP AND DOWN RATHER THAN SMOOTHLY INCREASING AND DECREASING. WE USED CRUISE CONTROL WHEN ON A TRIP AND THEN THE SPEEDOMETER STARTED MALFUNCTIONING. SINCE THIS OCCURRED, THE SPEEDOMETER HAS BEEN STUCK PAST 120 MPH ON MULTIPLE OCCASIONS WHEN WE WERE GOING ABOUT 30. THIS IS CERTAINLY A SAFETY HAZARD FOR WHICH A RECALL SHOULD BE ISSUED. THIS COULD CAUSE AN ACCIDENT IF IT MALFUNCTIONS WHILE YOU ARE DRIVING AND YOU ARE UNABLE TO DETERMINE HOW FAST YOU ARE GOING. YOU WOULD TEND TO DRIVE SLOWER AND YOU COULD BE REAR-ENDED BY SOMEONE ELSE WHO WAS EITHER SPEEDING OR DOING THE CORRECT SPEED LIMIT. I WAS SURPRISED TO SEE THE NUMBER OF COMPLAINTS ABOUT THIS PROBLEM AND CHEVROLET HAS NOT STEPPED UP TO THE PLATE AND ACKNOWLEDGED THAT IT IS A MANUFACTURER DEFECT. I FOUND OUT ACCIDENTALLY THAT WHEN YOU START THE VEHICLE, THE SPEEDOMETER RESETS BY 5MPH. I WOULD HAVE TO START THE VEHICLE REPEATEDLY TO GET IT BACK TO ZERO. ALTHOUGH THIS IS NOT GOOD FOR THE STARTER, THIS WAS MY ONLY OPTION AT THE TIME. I JUST SAW SOMETHING ON THE INTERNET THAT SAID TO PUT THE VEHICLE IN REVERSE AND THEN TRY TO START IT. BY DOING THIS IT WOULD RESET THE SPEEDOMETER BY 5MPH EVERY TIME WITHOUT ENGAGING THE STARTER. THIS DID WORK, BUT WHEN I DROVE THE VEHICLE THE NEXT TIME, THE SPEEDOMETER DID NOT WORK AT ALL. I TRIED RESETTING THE SPEEDOMETER AGAIN BY PUTTING IT IN PARK AND STARTING, BUT TO NO AVAIL. AFTER TRYING MANY MORE TIMES TO RESET BY STARTING THE VEHICLE, THE SPEEDOMETER STARTED TO WORK. THIS IS UNACCEPTABLE AT EVERY LEVEL. THE CONSUMER SHOULD NOT HAVE TO BEG AND PLEAD TO GET A MANUFACTURER DEFECT FIXED. WHAT WILL IT TAKE TO CAUSE CHEVROLET TO FIX THIS DEFECT, ACCIDENTS OR FATALITIES? IF YOU LOOK AT THE WEBSITE HTTP://WWW.TOPIX.COM/FORUM/AUTOS/CHEVROLET-TAHOE/T2BGKBGI55EKNU77C/P3 YOU WILL SEE THIS IS A COMMON OCCURRENCE. *TR

• 10/12/2010· POWER TRAIN

  I WAS DRIVING WITH MY TWO YOUNG CHILDREN IN THE CAR AND MY CAR MADE A CLICKING SOUND AND THEN BEGIN TO SHAKE AND VIBRATE. THEN ALL OF A SUDDEN IT MADE A REALLY LOUD NOISE THAT SOUNDED LIKE THE BOTTOM OF THE CAR FELL ONTO THE ROAD AND WAS BEING DRAGGED ALONG AND THE IT WOULD NOT GO ANYMORE. I TRIED PUTTING IT IN PARK AND IT WOULD NOT STOP, IT ROLLED BACKWARDS UNTIL I PUT THE EMERGENCY BRAKE ON AND TURNED IT OFF. I HAD IT TOWED TO MECHANIC WHO INFORMED ME THE DRIVE SHAFT BROKE IN TWO. IT WAS A VERY SCARY INCIDENT WITH MY TWO SMALL CHILDREN IN THE CAR. THEY WERE CRYING INCONSOLABLY AND SCARED. I WOULD LIKE TO KNOW WHY THIS HAPPENED AND IF THERE IS SOME KIND OF DEFECT IN THE 2005 CHEVY SUBURBAN THAT CAUSED THIS. *TR

• 10/11/2006· ELECTRICAL SYSTEM

  I HAVE HAD NOTHING BUT ELECTRICAL PROBLEMS EVER SINCE I BOUGHT THIS CAR. I DIDN'T EVEN HAVE THE CAR FOR A MONTH AND THE DASH LIGHTS AND HEAD LIGHTS WOULD DIM ON AND OFF BROUGHT THE CAR IN TO WHERE IT WAS PURCHASED FROM AND HAD MY CAR FOR A WEEK AND REPLACED CONTROL MODULE CAR STILL PROCEED TO DO THE SAME THING BROUGHT IT IN TO ANOTHER DEALERSHIP TOLD ME THAT THIS WAS NORMAL BECAUSE CAR HAD PCM AFTER 4 MONTHS OF GOING BACK AND FORTH WITH THESE DEALERSHIPS CAR WAS FINALLY FIXED DUE TO A RECALL IN A SCREW AND WIRE NOT BEING GROUNDED CORRECTLY. NOW MY CAR IS IN THE DEALERSHIP WITH NUMEROUS ELECTRICAL PROBLEMS AND ARE TRYING TO SAY THAT CAR WAS HIT BY LIGHTING CAR WOULD NOT START BURNING SMELL CAME FROM UNDERNEATH HOOD OF CAR. NOW CAR DOES NOT RUN OVER 15 MPH WITH DYING OUT BATTERY ONLY HOLD CHARGE OF 10 VOLTS. *JB

• 10/10/2012· ELECTRICAL SYSTEMFire

  TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 2500. THE CONTACT INSPECTED THE VEHICLE AND DETECTED A SHORTAGE WITHIN THE CIRCUITS UNDER THE DRIVER'S SIDE DASHBOARD, WHICH RESULTED IN THE WIRES BECOMING MELTED. THE MANUFACTURER WAS NOTIFIED AND RECOMMENDED THE VEHICLE BE TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 107,000.

• 10/09/2014· SERVICE BRAKESFire

  FRONT BRAKE LINE FAILURE/BRAKE LINE RUPTURE. 6 MONTHS AGO IT WAS THE REAR BRAKE LINE FAILURE/RUPTURE. BRAKE FLUID CAUSED SMOKE AND SMALL FIRE ON THE EXHAUST HEADERS. *TR