2004 Volkswagen Jetta

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/28/2012· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,ELECTRONIC STABILITY CONTROL (ESC)

  HEADLIGHTS DIMMING- TO POINT WHERE YOU CAN NOT TELL THEY ARE ON. ENGINE LIGHT COMES ON DESPITE ALL DIAGNOSTICS STATING ALL IS OK WITH CAR. PERIODICALLY FAILS TO START-DESPITE DIAGNOSTICS THAT STATE STARTER, BATTERY, DRAIN ALTENATOR ALL GOOD AND FUNCTIONING PROPERLY. CAR JUMPS EASILY WITH "BOOST". *TR

• 12/28/2007· SEATS

  SEAT WARMER ON DRIVER'S SEAT IN 2004 VW JETTA WAGON OVERHEATED UNTIL IT FELT LIKE IT WAS GOING TO CATCH ON FIRE. VELOUR SEATS SHOW IMPRESSION OF HEATING ELEMENT. I NOTICED FOR ABOUT A MONTH THAT IT WAS VERY HOT AND THE LAST TIME I USED IT I NOTICED A SMELL. I TURNED IT OFF IMMEDIATELY AND HAD IT DISCONNECTED BY A MECHANIC TO PREVENT A FIRE. *TR

• 12/27/2007· POWER TRAIN

  CAR LOST POWER AS DRIVING ON HIGHWAY, TOWED TO GARAGE AND FOUND OUT COIL PACKS NEED TO BE REPLACED AT THE COST OF $900.00. I HAD TO PAY THIS BUT THIS SHOULD NOT BE ON A 3 YEAR OLD CAR WITH 55,000 MILES, WELL MAINTAINED AND CAN BE PROVEN. *TR

• 12/27/2006· POWER TRAIN

  ABOUT 2 YEARS AGO I PURCHASED A 2004 VOLKSWAGEN JETTA 1.8T WITH THE MANUAL TRANSMISSION (4 YEARS/48,000 MILE WARRANTY). A COUPLE OF WEEKS AGO, I NOTICED THAT I HAD LESS AND LESS POWER TO DRIVE THE CAR WHEN IT WAS IN GEAR. ON DECEMBER 7, I BROUGHT THE CAR TO THE ORIGINAL DEALERSHIP WHERE I PURCHASED THE VEHICLE. I WAS TOLD THAT THE CLUTCH HAD WORN OUT AND WAS NOT COVERED UNDER WARRANTY. THUS, THE COST OF THE REPAIR ON THE VEHICLE WAS GOING TO BE $1,800! MY CAR HAS 30,700 MILES ON IT, I AM 34 YEARS OLD AND THERE ARE CERTAIN DAYS WHEN I DRIVE IT LESS THAN 5 MILES A DAY! OF COURSE, I WAS TOLD BY MY CAR-SALESMAN, THE SERVICE MANAGER, THE TELEPHONE OPERATORS AT VOLKSWAGEN AND THE GENERAL MANGER AT THE PLACE WHERE I PURCHASED THE VEHICLE THAT I (THROUGH POOR DRIVING HABITS AND LITTLE EXPERIENCE DRIVING A CLUTCH) WORE IT OUT. I REQUESTED TO PERSONALLY SPEAK TO THE AREA SERVICE REPRESENTATIVE FROM VOLKSWAGEN YET, I WAS NEVER GIVEN HIS/HER CONTACT INFORMATION. IN ADDITION, I GAVE MY CONTACT INFORMATION TO THE DEALERSHIP TO HAVE THEM REACH THE VOLKSWAGEN SERVICE REPRESENTATIVE TO HAVE THEM CONTACT ME. OVERALL, I WAS NEVER ABLE TO SPEAK TO THIS INDIVIDUAL. I HAD 6 YEARS OF DRIVING EXPERIENCE ON A FORD WITH NO CLUTCH PROBLEMS. I ALSO DID SOME RESEARCH AND FOUND AN INTERESTING WEB SITE HTTP://WWW.MYVWLEMON.COM/UBB/FORUM1/HTML/000155.HTML IT WAS INTERESTING TO READ OTHER INDIVIDUALS WITH THE SAME PROBLEM AS MINE (SOME DIFFERENT YEAR DATES THAN MY CAR)! *NM

• 12/21/2005· AIR BAGSCrash

  THE CONSUMER SUSPECT A DEFECT OF THE VEHICLE BECAUSE THE FRONT AIRBAG DID NOT DEPLOY DESPITE THE HIGHEST IMPACT (1 OUT OF 14 SCALE) DAMAGE ON THE FRONT. THE CONSUMER CONTACTED THE MANUFACTURER AND REQUESTED FOR AN INSPECTION; THE MANUFACTURER EXPLAINED WHY THE AIRBAGS DID NOT DEPLOY BUT IT WAS NO MORE THAN A DESCRIPTION IN THE OWNER'S MANUAL. THE MANUFACTURER IS NOT WILLING TO SEND A TECHNICIAN TO INSPECT THE VEHICLE. THE CONSUMER REQUESTS FOR A THIRD-PARTY EXPERTS INSPECTION. 1) ACCIDENT NARRATIVE (BASED ON CITY OF WHEELING, WV, POLICE REPORT): THE VEHICLE (VOLKSWAGEN JETTA 2004) WAS ON THE FIRST LANE OF I-70 W. THE VEHICLE SUDDENLY LOST A CONTROL AND WENT ONTO THE SECOND LANE AND WENT BACK ONTO THE FIRST LANE. THE VEHICLE HIT THE GUARD RAIL WITH THE FRONT LEAVING 25 FEET OF THE GUARD RAIL DAMAGED; THE VEHICLE BOUNCED OFF AND STRUCK A TRUCK TRAILER WITH THE RIGHT REAR END. 2) DESPITE THE SEVERE DAMAGE ON THE FRONT (THE CONSUMER HAS PHOTOS; THE FRONT IS ALMOST GONE), NONE OF THE FRONT AIRBAGS DEPLOYED EXCEPT FOR THE PASSENGER SIDE CURTAIN. THE MANUFACTURER IS NOT WILLING TO SEND A TECHNICIAN TO INSPECT THE VEHICLE. THE CONSUMER REQUESTS FOR A THIRD-PARTY EXPERTS INSPECTION. THE CONSUMER IS WILLING TO PROVIDE THE PHOTOS OF THE DAMAGED VEHICLE TO NHTSA FOR AN ANALYSIS. *NM

• 12/21/2004· SERVICE BRAKES, HYDRAULIC

  WHILE APPLYING THE BRAKE PEDAL, THE VEHICLE VIBRATED UNCONTROLLABLY. THE CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND PULLED OVER. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE FRONT ROTORS NEED TO BE REPLACED. *JB *NM

• 12/20/2010· SEATS

  HEATED SEAT BURNED. ELECTRICAL BURNING SMELL AND EXTREME HOT SPOT ON UPPER RIGHT THIGH. *TR

• 12/18/2016· ELECTRICAL SYSTEM

  ON 12/18/2016 I WAS DRIVING THIS CAR BACK FROM THE MOVIES AT 2:30 A.M. ONCE THE MOVIE HAD ENDED IT WAS STORMING AND SLEETING. I STARTED TO NOTICE SYSTEMS SHUTTING DOWN AS INDICATED BY VARIOUS DASH LIGHTS SUCH AS ABS, AIRBAG, AMONG OTHERS. EVENTUALLY THE RADIO, INTERIOR LIGHTS SHUT OFF. THE WINDSHIELD WIPERS SLOWED AND THE HEADLIGHTS DIMMED, AND EVENTUALLY THE CAR DIED GOING 50 MILES AN HOUR IN SLEETING CONDITIONS LEAVING ME WITH NO ABS, NO AIRBAG SYSTEM (AT LEAST PER WHAT THE DASH LIGHTS INDICATED) AND, OF COURSE, NO POWER STEERING. I INSPECTED THE VEHICLE THIS MORNING AND FOUND THE ALTERNATOR WIRE COMING INTO THE HIGH AMPERAGE FUSE BOX THAT SITS ON TOP OF THE BATTERY HAD MELTED AND DISCONNECTED THE CIRCUIT, DISABLING THE ALTERNATOR FROM CHARGING THE BATTERY, AND LETTING THE BATTERY DIE. THE INCIDENT DID NOT CAUSE A CRASH, BUT IT COULD HAVE IF THERE WAS ANYONE ELSE AROUND ME AS I HAD TO CUT ACROSS A COUPLE LANES WITH NO ENGINE POWER AND NO POWER STEERING TO GET TO THE SHOULDER. *TR

• 12/17/2008· SEATSFire

  I SMELLED A BURNING OR FOUL-SMELLING CHEMICAL ODOR AFTER DRIVING FOR 01 MINUTE AND NOTICED THAT MY SEAT WAS SO HOT THAT IT BURNED MY HAND WHEN I TOUCHED IT. I THEN SMELLED SMOKE AND I IMMEDIATELY SWITCHED OFF THE DRIVER SIDE SEAT HEATER. AFTER STOPPING, I NOTICED THAT THE SEAT APPEARED BURNED IN A ROUGHLY CIRCULAR PATCH THAT LOOKED SIMILAR TO A CIGARETTE BURN. THE FOUL ODOR HAS PERSISTED EVEN WITH THE SEAT HEATER OFF AFTER THE INCIDENT. THE INCIDENT HAPPENED ON 16 DEC 2008. THIS IS THE FIRST TIME THE INCIDENT HAS OCCURRED. *TR

• 12/17/2007· VISIBILITY

  ON DECEMBER 17, 2007, I OPENED THE HATCH OF MY 2004 VOLKSWAGEN JETTA TDI AND THE WINDOW SHATTERED. MY WIFE AND I FIRST HEARD A POP SOUND AND THEN THE WINDOW EXPLODED OVER OUR HEADS. IT WAS A COLD, DRY MORNING IN NE OHIO (AROUND 25 DEGREES). *TR

• 12/16/2005· ENGINE AND ENGINE COOLING

  CAR IS LOOSING COOLANT WITH NO EXTERNAL LEAKAGE. MANY PEOPLE ARE REPORTING EGR COOLER FAILURES. VW NEEDS TO HAVE A RECALL AND ADDRESS THIS ISSUE. *NM

• 12/13/2010· ENGINE AND ENGINE COOLING

  TL*THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE OVERHEATED BECAUSE THE WATER PUMP FAILED. THE CONTACT STATED TAH THE RIM ON THE WATER PUMP MADE OF PLASTIC BROKE IN TWO PIECES. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 56,000. UPDATED 02/10/11 *BF UPDATED 10/12/11

• 12/08/2009· ELECTRICAL SYSTEMFire

  ELECTRICAL FIRE IN IGNITION HARNESS MELTED HARNESS (INCLUDING COILS) WHICH RESULTED IN STALL-OUT. IGNITION FUSE TO COMPUTER WAS DISABLED PREVENTING RE-START OF AUTOMOBILE. *TR

• 12/07/2005· AIR BAGS

  2004 VW JETTA GLI INVOLVED IN FRONTAL OFFSET COLLISION. CAR DECLARED TOTALED BY INSURANCE COMPANY. NONE OF THE SIX AIR BAGS DEPLOYED. VW HAS STATED THAT THE IMPACT DID NOT ENTER THE 60 DEGREE FIELD OF THE AIR BAG SENSOR. I WAS SIDESWIPED SENDING MY CAR INTO THE BACK OF A ROW OF PARKED CARS. I RECEIVED NECK, BACK AND WRIST INJURIES. THE CAR SHOULD STILL BE AVAILABLE AS I HAVE NOT RELEASED IT YET. I AM CONCERNED THAT THE AIR BAGS FAILED TO DEPLOY EVEN WITH THE FRONT OF THE CAR DESTROYED AND THE PASSENGER COMPARTMENT ROOF AND FLOOR BUCKLED. AT THE VERY LEAST, MY NECK INJURIES WOULD HAVE BEEN MINIMIZED IF EVEN JUST THE STEERING WHEEL AIR BAG HAD DEPLOYED. *NM

• 12/05/2006· AIR BAGS,SEAT BELTS

  DT*: THE CONTACT STATED WHILE TRAVELING 35 MPH, THE DRIVER SIDE CURTAIN AIRBAG AND THE REAR LEFT PASSENGER SIDE CURTAIN AIR BAG DEPLOYED WITHOUT WARNING, PUSHING THE CONTACT TO THE RIGHT SIDE OF THE VEHICLE, AND DAMAGING THE SEAT BELT. A POLICE REPORT AND PHOTOS WERE TAKEN OF THE VEHICLE. THE CONTACT SUSTAINED A WELT ON THE LEFT HIP FROM THE AIRBAG. THE VEHICLE WAS DRIVEN TO A RESIDENCE. THE SERVICE DEALER WAS NOTIFIED AND THE VEHICLE WAS TAKEN TO THE DEALER THE NEXT MORNING. THE MANUFACTURER WAS NOTIFIED.

• 12/01/2013· ELECTRICAL SYSTEM

  ALTERNATOR WIRING HARNESS OVERHEATED MY BATTERY FUSE BOX AND MELTED IT. THE VEHICLE BATTERY LIGHT CAME ON SO I PULLED OVER, TURNED THE VEHICLE OFF, AND INSPECTED THE BATTERY, NOTICING THE DAMAGE (MELTED PLASTIC, SMOKE). *TR

• 11/29/2006· FUEL SYSTEM, DIESEL

  2004 JETTA DIESEL - FUEL PUMP/GASKET LEAKING -FALLS W/IN VIN RECALL #'S. FOR THIS VERY PROBLEM. DEALER/MANUFACTURE STATES RECALL NOT FOR MY VIN#. HAS THE VERY PROBLEM THE RECALL FOR FUEL PUMP/GASKET LEAKING THERE FOR REPLACEMENT DESCRIBES. DEALER STATES NEED TO REPLACE PUMP/GASKET. RECALL STATES REPLACEMENT OF PUMP/GASKET. VW OF AMERICA CAN NOT TELL ME THE PARAMETERS OF THE RECALL, JUST THAT MY CAR DOES NOT QUALIFY. SOMETHING IS NOT RIGHT WITH THIS SITUATION. PLEASE HELP IF YOU CAN.

• 11/20/2006· ENGINE AND ENGINE COOLING

  CAR BEGAN MAKING LOUD POPPING NOISE. TOOK CAR TO DEALERSHIP. AFTER THREE DAYS OF EVALUATION, THE DEALER HAD TO CONTACT VW TECHNICIAN FOR ASSISTANCE. THE VW TECHNICIAN INFORMED THE DEALER TO CHECK THE CAMSHAFT AS THEY HAVE BEEN NOTICING PROBLEMS IN THE FIELD IN VEHICLES WITH 80,000 - 150,000 MILES. THEY STATED THAT THERE WAS A PROBLEM WITH THE METAL BEING TOO THIN AND WEARING TOO QUICKLY. *JB

• 11/18/2008· ENGINE AND ENGINE COOLING,EQUIPMENT

  VWOA HAD A RECALL CAMPAIGN FOR THE EGR COOLER SYSTEM ON 2004 AND 2005 VW TDI'S. SUBSEQUENT TO THE RECALL CAMPAIGN, THE LOWER EGR FLEX PIPE IS KNOWN TO CRACK ON NUMEROUS VEHICLES IN WHICH THE RECALL CAMPAIGN WAS PERFORMED. WHEN THE EGR PIPE CRACKS, DIESEL EXHAUST IS SUCKED INTO THE CABIN WHEN THE HEATER FAN IS OPERATED CAUSING DISCOMFORT AND LIGHT HEADED FOR THE DRIVER AND OCCUPANTS. VWOA HAS REFUSED TO ADDRESS THE PROBLEM AND OFFERS NO SOLUTION TO THE VEHICLE OWNER OR A FIX. NOT ONLY IS IT AN EXPENSIVE REPAIR, BUT IT CAN ALSO BE CAUSING MEDICAL PROBLEMS FOR THE DRIVER AND OCCUPANTS. MY EGR PIPE WAS CRACKED FOR 2-4 MONTHS BEFORE I REALIZED WHAT WAS HAPPENING. IT MAY HAVE BEEN CRACKED LONGER WITH OUT MY KNOWLEDGE. *TR

• 11/17/2017· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  HEATED SEAT MODULE MELTED A HOLE THROUGH MY LEATHER.

• 11/16/2017· FUEL/PROPULSION SYSTEM

  THE CAR RANDOMLY STALLS WHILE DRIVING WHETHER AT HIGHWAY SPEEDS OR IN TOWN. THIS CAUSES A LOSS OF POWER STEERING AND POWER BRAKES WHICH IS INHERENTLY DANGEROUS IN CERTAIN SITUATIONS. IT HAS BEEN DOING THIS REGULARLY WITH THE PREVIOUS OWNER FOR THE LAST 3 OR 4 YEARS AND HAS DONE IT 4 TIMES WHILE UNDER MY OWNERSHIP SINCE SEPTEMBER 2017 IT USUALLY HAPPENS WHILE THERE IS LESS THAN 1/4 TANK OF FUEL. WHEN IT HAPPENS THERE IS NO CHECK ENGINE LIGHT NOR DOES THE ECU STORE ANY CODES FROM THE PROBLEM. PREVIOUS OWNER MADE SEVERAL REPAIRS INCLUDING A FUEL PUMP AND FILTER, ENGINE SPEED SENSOR AND ALTERNATOR WIRING HARNESS IN AN ATTEMPT TO FIX THE ISSUES WITH NO SUCCESS. THIS ISSUES ALSO COMES UP REGULARLY ON SEVERAL VW FORUMS AND NO ONE SEEMS TO HAVE AN ANSWER. THIS IS A KNOWN AND REGULAR ISSUE WITH NO CONSISTENT REPAIR AND NEEDS TO BE REMEDIED.

• 11/10/2010· ENGINE AND ENGINE COOLINGFire

  TL*THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT HAD TO REPLACE THE IGNITION COILS AND THE CYLINDERS IN THE ENGINE. THE COILS WERE REPLACED SEVERAL TIMES AND FAILED AGAIN AFTER ONE MONTH. THE MECHANIC STATED THAT THIS WAS A MAJOR PROBLEM WITH THIS MAKE AND MODEL VEHICLE. THE FIRST FAILURE OCCURRED IN FEBRUARY 2010 WHEN THE VEHICLE CAUGHT FIRE. THE VEHICLE WAS REPAIRED SIX TIMES WITHIN A YEAR. ALL OF THE COILS DO NOT FAIL AT THE SAME TIME, BUT THE ALL FOUR COILS HAVE BEEN REPLACED MORE THAN ONE TIME. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 101000 AND THE CURRENT MILEAGE WAS 135000.

• 11/10/2008· FUEL SYSTEM, GASOLINE

  CAR WAS SMELLING OF GAS. LOOKED UNDER CAR AND FOUND GAS LEAKING FROM UNDERNEATH CAR. TOOK IT TO CAR DEALERSHIP AND THEY SAID THE FUEL PUMP HAD TWO SMALL PIN HOLES IN IT. REPLACED IT AT NO COST. *TR

• 11/10/2008· SEAT BELTS

  DRIVER'S SIDE SEATBELT LATCH BROKEN. TRIED TO BUCKLE SEAT BELT AND A PART IN SEATBELT LATCH MECHANISM BROKE OFF INSIDE. SEATBELT WILL NOT LATCH. *TR

• 11/09/2004· SEATS

  WHILE DRIVING MY 2003 1.8T VOLKSWAGEN JETTA, THE SEAT HEATER ON THE DRIVER SIDE MALFUNCTIONED. I FELT A VERY SMALL POINT OF PAIN IN MY LEG, BUT DIDN'T REALLY NOTICE IT UNTIL I STARTED TO SMELL SMOKE. I IMMEDIATELY SHUT OFF THE SEAT HEATER (WHICH WAS ON A SETTING OF 3 OUT OF 5 INITIALLY), PULLED THE CAR OVER TO A PARKING LOT, GOT OUT, AND FORTUNATELY NOTHING CAUGHT FIRE. I BROUGHT THE CAR IN TO MY DEALER (TREND MOTORS IN ROCKAWAY, NJ), WHO PROMPTLY FIXED THE PROBLEM, AND HAVE ORDERED A NEW SEAT COVER TO REPLACE THE ONE DAMAGED BY THE MALFUNCTION. THE CAR WAS COVERED UNDER WARRANTY AT THE TIME OF THE PROBLEM, WHICH OCCURED ON NOVEMBER 4, 2004.*AK

• 11/07/2007· POWER TRAIN

  THE WRONG TRANSMISSION WAS PLACED IN MY CAR FROM THE FACTORY. *TR

• 11/03/2005· POWER TRAIN,ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES,SEATS

  OUR 2004 VW JETTA 1.8T HAS HAD NUMEROUS PROBLEMS FROM A CLICKING/POPPING NOISE IN THE FRONT END AT APPROXMIATELY 10,000 MILES, TO THE TRANSMISSION LOCKING UP WHILE OPERATING VEHICLE. THE CLUTCH/DISC WENT COMPLETELY OUT AT 15,000 MILES. ALL THE INTERIOR AND EXTERIOR LIGHTS WENT OUT AS MY WIFE WAS DRIVING IN THE DARK ON A NON LIT BACK ROAD TO WORK, TRANSMISSION LOCKED UP BETWEEN 3RD AND 4TH GEARS, TRANSMISSION STILL SLIPPING, BACK DOOR LOCKS DO NOT UN-LOCK WHEN REMOTE IS ACTIVATED, SERVICE DEPARTMENT HAS RE-TORQUED EVERYTHING ON VEHICLE BUT THIS HAS NOT MADE PROBLEMS GO AWAY. SINCE MAY 2005, THE SERVICE DEPARTMENT AT LOCAL VW DEALERSHIP HAS HAD MY CAR FORA TOTAL OF 62 DAYS FOR SERVICE AND IT IS STILL NOT FIXED. PROBLEMS CONTINUE TO MOUNT AND THE DEALERSHIP FOR THE MOST PART STATES "THAT THEY CANNOT REPLICATE THE PROBLEM." THE DEALERSHIP REPLACED ALL THE WHEEL BEARINGS IN THE FRONT OF THE VEHICLE AND THIS DID NOT STOP THE CLICKING/POPPING NOISE, THEY REPLACED THE CLUTCH DISC THIS DID NOT CLEAR UP THE PROBLEM, THE ELECTRICAL PROBLEM COULD NOT BE REPLICATED PER DEALERSHIP, THE ENGINE CONTINUES TO HAVE A WHISTLING NOISE, TRANSMISSION CONTINUES TO SLIP. THE DRIVER'S SIDE LEATHER SEAT HAS THE SEAMS POOPING LOOSE AND A PART OF THE FRAME IS PUSHING THROUGH THE LEATHER. TRUNK LATCH HAS BEEN REPLACED 2 TIMES. DEALERSHIP STATES CAR IS SAFE TO OPERATE, I BEG TO DIFFER!

• 10/27/2007· STRUCTURE

  LEAKING SUNROOF ALLOWS WATER TO ENTER AREA AROUND CURTAIN AIRBAGS. *TR

• 10/24/2011· AIR BAGSCrash

  WE WERE STOPPED IN THE TRAFFIC AND ALL OF A SUDDEN THIS TRUCK [2001 CHEVY] REAR ENDED US AT THE SPEED OF 45 MILES PER HOUR AND OUR CAR GOT PUSHED INTO THE CAR IN FRONT OF US. IN OUR CAR, PASSENGER SIDE AIR BAG COVER CAME OUT BUT AIRBAG DID NOT DEPLOY. WE BOUGHT THIS CAR BECAUSE WE HAD GREAT TRUST IN VW [GERMAN CARS] IN MAKING STRONG AND RELIABLE CARS WHICH CAN SAVE LIVES WHICH COULD NOT BE PROVED IN THE ACCIDENT WE GOTTEN INTO. HAD THE IMPACT BEEN LITTLE HIGHER WE COULD HAVE DIED IN THE ACCIDENT. I'M SAD TO SAY THAT OUR TRUST IN VW HAS BEEN SHATTERED AFTER THE ACCIDENT. *TR

• 10/22/2004· AIR BAGS

  WHILE DRIVING. 70-75 MPH AIR BAG DEPLOYED WITH NO WARNING. THERE WAS NO ACCIDENT. TOOK VEHICLE TO VOLKSWAGEN. WAS TOLD THAT IT WAS THE CONSUMER'S FAULT. *AK

• 10/21/2008· TIRES

  A RIP APPEARED IN THE SIDEWALL OF MY FRONT TIRE OVER THE COURSE OF SEVERAL DAYS. THE TIRE APPEARS TO BE SEPARATING. I NOTICED IT AFTER HEARING A CLICKING SOUND WHILE DRIVING SLOWLY IN A PARKING LOT. THIS WAS NOT PROCEEDED BY ANY IMPACT TO THE TIRE. THE RIP IS GETTING LARGER. ONLINE RESEARCH INTO THIS TIRE SHOWS THAT NUMEROUS OTHERS HAVE HAD SIMILAR TIRE FAILURE INCIDENTS, OFTEN RESULTING IN COSTLY REPAIRS AND MEDICAL BILLS. I BELIEVE THAT THIS TIRE MODEL IS DEFECTIVE AND SHOULD BE RECALLED. *TR

• 10/20/2007· STEERING

  CLICKING/POPPING NOISE COMING FROM THE FRONT OF THE VEHICLE WHEN MAKING TURNS. TAKEN TO DEALERSHIP TWO TIME AND THEY STATE THEY CANNOT DUPLICATE THE SOUND. DROVE TECH AROUND AND DUPLICATED SOUND FOR HIM. DEALERSHIP STILL STATED THEY COULD NOT MAKE ANY REPAIRS BECAUSE THEY COULDN'T DUPLICATE THE PROBLEM. SERVICE ALSO STATED THAT THE PROBLEM WOULD HAVE TO GET WORSE BEFORE THEY COULD DO ANYTHING. *TR

• 10/18/2009· FUEL SYSTEM, GASOLINE,EQUIPMENT

  I AM THE OWNER OF A 2004 VOLKSWAGEN JETTA GLI, WHICH I GARAGE AT MY CONDOMINIUM. IN MARCH 2006, THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION ISSUED A RECALL OF VOLKSWAGEN AND AUDI 2003 CARS WITH 1.8L TURBO ENGINES DUE TO ELECTRICAL FAILURE OF THE FUEL PUMPS. I RAISE THE POSSIBILITY OF MY CAR BEING INVOLVED IN THE MANUFACTURING MALFUNCTION, BUT NOT INCLUDED IN THE RECALL. 07/17/2009: CAR TOWED TO VOLKSWAGEN AUTOBARN OF EVANSTON. COSTS: $74.15. 07/25/2009: INFORMED THAT THE CAR REQUIRED A NEW BATTERY AND FUEL PUMP. PARTS & LABOR COSTS: $905.85. AFTER PAYING FOR THE REPAIRS AND WAITING FOR DELIVERY, THE CAR WOULD NOT START. 07/27/2009: RETRIEVED THE CAR AFTER VW AUTOBARN SERVICE INSTALLS A SECOND FUEL PUMP, DUE TO A DEFECT IN THE PREVIOUS PART. I DROVE THE CAR HOME AND PARKED UNDERGROUND. 07/28/2009: I DROVE TO THE FAA REGIONAL OFFICE IN DES PLAINES, IL. AT APPROXIMATELY 18:30, I ATTEMPTED TO LEAVE HOWEVER, THE CAR DID NOT START IN THE SAME FASHION THAT LED TO THE INITIAL REPAIR. THE CAR IS TOWED BACK TO VOLKSWAGEN. 08/17/2009: INFORMED BY THE VW AUTOBARN SERVICE MANAGER THAT THEY HAVE GONE TO EXTRAORDINARY EFFORTS TO REPAIR THE CAR: DRIVEN THE CAR ON MULTIPLE OCCASIONS INCLUDING TAKING IT HOME OVERNIGHT; COMMUNICATED WITH THE GERMAN SERVICE OFFICE TO PURSUE OTHER POSSIBLE CAUSES FOR FUEL PUMP FAILURES. COSTS FOR TOWING, FUSES, RELAY SWITCHES, LEADS, CONNECTORS AND TECHNICIAN LABOR: $574.11. AFTER PAYING FOR THE ABOVE REPAIRS, AGAIN, THE CAR WOULD NOT START. 08/28/2009: INFORMED THE FUEL IN THE CAR CONTAINED 40% ALCOHOL AND IS THE CAUSE OF FAILURE OF THE THREE PREVIOUS FUEL PUMPS. MOREOVER, I WAS RESPONSIBLE FOR VOIDING THE WARRANTY OF THE PREVIOUS FUEL PUMPS AND NOW FINANCIALLY RESPONSIBLE FOR $1400 IN NEW CHARGES, INCLUDING THE COST OF A FOURTH FUEL PUMP. I LAST PURCHASED 12.63 GALLONS PREMIUM FUEL ON JUNE 26 WITHOUT ISSUE UNTIL JULY 17. *TR

• 10/18/2006· POWER TRAIN

  VOLKSWAGEN JETTA TDI. WAS RUNNING FINE AND I WAS VERY HAPPY WITH THE VEHICLE. DURING A ROUTINE STOP AT A STOP SIGN I PUSHED IN THE CLUTCH, A LARGE CLUNKING NOISE OCCURRED AND THE CLUTCH PRESSED ALL THE WAY TO THE FLOOR AND WOULD NOT RETURN TO NORMAL POSITION. VEHICLE HAD 62,000 MILES ON IT, THUS MANUFACTURERS WARRANTY EXPIRED. EXTENDED SERVICE WARRANTY (OBTAINED WHEN VEHICLE WAS PURCHASED NEW) COVERED TOWING AND INITIALLY INVESTIGATION UNTIL THEY DISCOVERED THE DAMAGE WAS DUE TO THE CLUTCH -- A 'WEARABLE' ITEM. APPARENTLY THE CLUTCH PLATE HAD BEEN RUBBING AGAINST THE TRANSMISSION, UNSEEABLE UNTIL THE TRANSMISSION WAS TAKEN OUT OF THE VEHICLE. I TOOK THE VEHICLE IN FOR ALL SCHEDULED MAINTENANCES WITH A VOLKSWAGEN SERVICE CENTER AND THEY NEVER INSPECTED THE CLUTCH, NOR IS DAMAGE CAUSED BY THE CLUTCH OR THE CLUTCH ASSEMBLY COVERED IN EITHER THE ORIGINAL MANUFACTURERS WARRANTY OR THE EXTENDED WARRANTY. I BELIEVE IF IT IS A 'WEARABLE' ITEM IT SHOULD BE PART OF THE STANDARD SERVICE PROGRAM (WHICH IS QUITE EXPENSIVE FOR VOLKSWAGEN VEHICLES) OR IT SHOULD BE COVERED UNDER WARRANTY. *NM

• 10/18/2005· ENGINE AND ENGINE COOLING

  2004 VOLKSWAGEN JETTA TDI. ENGINE WILL STALL AT TIMES DUE TO COOLANT LEAKING INTERNALLY INTO INTAKE MANIFOLD THROUGH FAULTY EGR COOLER. CAUSING VEHICLE TO LOSE STEERING AND BRAKE ASSIST. *JB

• 10/15/2018· ENGINE,FUEL/PROPULSION SYSTEM

  VEHICLE UNDER MULTIPLE OCCASIONS HAS STALLED OUT AT VARIOUS SPEEDS, LOCATIONS, AND DRIVING STYLES/ROADS AT OR UNDER A QUARTER OF A TANK

• 10/14/2008· POWER TRAIN

  I HAVE HAD THIS CAR INTO THE AUTOMOTIVE SHOP AT THE LOCAL VW DEALERSHIP SEVERAL TIMES SINCE DATE OF PURCHASE IN LATE 2007 FOR THE SAME INCIDENT. THE VEHICLE WILL DO A HARD JOLTING ACTION WHILE SHIFTING (AUTOMATIC TRANSMISSION) BETWEEN GEARS, AS IF THERE IS A BROKEN MOTOR MOUNT OR A TRANSMISSION PROBLEM. I HAVE GOTTEN NO SATISFACTION FROM THE DEALERSHIP. THEY HAVE REPEATEDLY TOLD ME THAT THE CAR SHIFTS PROPERLY ACCORDING TO VW STANDARDS. NOW THAT MY WARRANTY HAS EXPIRED, I AM AFRAID THAT IT WILL CONTINUE AND LEAD TO MORE COSTLY REPAIRS DOWN THE LINE. HAVING THIS MATTER RESOLVED WOULD BE GREATLY APPRECIATED. *TR

• 10/14/2007· SUSPENSION,SERVICE BRAKES, HYDRAULIC,TIRES

  I WAS DRIVING HOME 50-55 MPH CLEAR NIGHT SMOOTH ROAD I HAD NOT NOTICED ANY SIGNS OF MY TIRE BEING LOW I HAVE VALVE CAPS THAT SHOW WHEN TIRE AIR PRESSURE IS LOW AND THEY ALL WERE GREEN THAN I HEARD A LOUD NOISE AND MY CAR PULLED TO THE LEFT I PULLED OVER AND NOTICED MY TIRE HAD COMPLETELY SEPARATED AT THE SIDEWALL LEAVING ABOUT 2-3 INCHES OF TIRE ON THE RIM AND THE REST WAS IN ONE PIECE BARLEY SITTING ON THE RIM THE TIRE WAS MADE BY NANKANG TOURSPORT 611 DOT 109N OTHER NUMBERS I FOUND ON THE TIRE WERE 517 2306 Z2C, N-2570-3L XR611 RADIAL 195/65 R15 9IH M+S TUBELESS WHEN THE TIRE BLEW OUT AND THE TIRE SEPARATED IT TORE MY ABS SENSOR WIRE AND IM NOT SURE WHAT OTHER DAMAGE MY ALIGNMENT IS NOW OFF AS WELL. *TR

• 10/12/2012· STRUCTURE

  THE INTERIOR OF MY 2004 VW JETTA EMITS A VERY STRONG "CRAYON LIKE" ODOR. BREATHING THIS ODOR FOR A LONG PERIOD OF TIME MAKES MY THROAT HURT AND CAUSES DISCOMFORT WHEN I INHALE. I WORRY THAT REPEATEDLY INHALING WHATEVER CHEMICAL CAUSES THIS WILL CAUSE PERMANENT RESPIRATORY DAMAGE. *TR

• 10/07/2005· SERVICE BRAKES, HYDRAULIC

  I RECENTLY PURCHASED A 2004 VOLKSWAGEN JETTA GLI WITH 9200 MILES. APPROXIMATELY ONE WEEK AFTER OWNING THE VEHICLE, A CLUNKING SOUND WAS COMING FROM THE REAR OF THE CAR. THE CLUNKING NOISE HAS INCREASED IN SOUND LEVEL AND SENSITIVITY TO ROAD SURFACES SINCE THEN. I TOOK THE VEHICLE IN TO BE SERVICED BY FLETCHER JONES CHICAGO VW AND WAS TOLD THAT THE BRAKE PAD IS LOOSENING IN THE CALIPER AND IS CAUSING THE CLUNKING SOUND. I WAS ALSO TOLD THAT THIS WOULD NOT BE COVERED BY MY WARRANTY AS THEY SUGGESTED THE CAR WAS STILL DRIVABLE AND THE PROBLEM WAS LIKELY DUE TO WEAR ON THE PAD. AT THE TIME OF THE SERVICE DIAGNOSIS BY FLETCHER JONES, THE CAR HAD 10,173 MILES ON THE ODOMETER. PRIOR TO PURCHASING THIS VEHICLE, IT WAS FULLY INSPECTED BY A SERVICE TECHNICIAN THAT HAS BEEN IN THE INDUSTRY FOR OVER TEN YEARS, AND WHOM I KNOW PERSONALLY. I WAS TOLD THIS VEHICLE DID NOT HAVE ANY ISSUES WITH THE BRAKES. FURTHERMORE, THE VEHICLE WAS NOT MAKING A CLUNKING SOUND WHEN I PURCHASED IT. RATHER, THE SOUND DEVELOPED OVER A WEEK AFTER I PURCHASED THE VEHICLE. \I AM CONCERNED THAT THE PART WILL FAIL AND THAT VW IS NOT GOING TO FIX IT UNDER MY WARRANTY THAT IS STATED TO COVER SUCH THINGS FOR 4 YEARS/50,000 MILES, OR WHICH EVER ONE COMES FIRST. *JB

• 10/06/2010· ENGINE AND ENGINE COOLING,POWER TRAIN

  CATASTROPHIC DRIVE TRAIN FAILURE OF A VW JETTA TDI 5-SPEED. WHILE TRAVELING AT 65-70 MPH ON RELATIVELY FLAT TERRAIN ON A CLEAR ROADWAY IN 5TH GEAR WITH NO INPUT TO THE CLUTCH OR THE TRANSMISSION, OCCUPANTS FELT & HEARD A SINGLE, MUFFLED 'THUMP'. ORIGINATING DRIVE TRAIN FAILURE EVENT OCCURRED SPONTANEOUSLY AND COMPLETELY UNEXPECTEDLY. AFTER THE ANOMALY, A LOW METALLIC RATTLE WAS HEARD. ONCE CLEAR OF SURROUNDING TRAFFIC, IN TROUBLESHOOTING ATTEMPT THE DRIVER ENGAGED CLUTCH AND SHIFTED INTO NEUTRAL; IMMEDIATELY THE RATTLING BECAME MORE PRONOUNCED. FIFTH GEAR IMMEDIATELY REENGAGED AND NOISE ABATED. DRIVER NAVIGATED VEHICLE UNDER POWER TO RIGHT LANE & SUBSEQUENTLY EXITED EXPRESSWAY. UPON APPROACH TO SIDE STREET TRAFFIC LIGHT, THE CLUTCH WAS REENGAGED RESULTING IN A RENEWED RATTLING; TRANSMISSION SHIFTED INTO NEUTRAL. WHEN CLUTCH WAS LET OUT, THE CONSTANT RATTLING NOISE CONTINUED AS ENGINE IDLED. WITH SIGNAL CHANGE, CLUTCH REENGAGED & TRANSMISSION SHIFTED TO 1ST GEAR. CLUTCH SLOWLY, CAREFULLY RELEASED: NOTICEABLE NOISE INCREASE FOLLOWED BY SHORT SERIES OF LOUD, SHARP NOISES. VEHICLE LURCHED AND STALLED. TWO ATTEMPTS TO RESTART ENGINE FAILED; NO ENGINE RESPONSE. POLICE NOTIFIED & VEHICLE TOWED TO DEALER. SIGNIFICANT FLUID LEAKAGE NOTICED. SUBSEQUENTLY NOTIFIED BY VW DEALER THAT MAIN SHAFT OF TRANSMISSION CATASTROPHICALLY FAILED PRESSING FLYWHEEL INTO MOTOR DAMAGING CASING, BEARINGS & CRANKSHAFT LOBS RESULTING IN IMMEDIATE SEIZING OF THE DIESEL POWER PLANT. TOTAL REPLACEMENT OF TRANSMISSION AND ENGINE ASSEMBLY REQUIRED (EST ~$11K). THIS VEHICLE HAD ALL MAINTENANCE SERVICE PERFORMED REGULARLY AT 5K INTERVALS BY VW DEALER (DOCUMENTED) AND HAD RECENTLY HAD FULL 100K SERVICE INCLUDING TIMING BELT REPLACEMENT. NO NOTIFICATION/CONCERN FOR ADDITIONAL TRANSMISSION INSPECTION/SERVICE. CLUTCH RECENTLY SEEMED TO BE ENGAGING A WEE BIT FURTHER BUT NO BOTTOMING OF PEDAL OR CLUTCH SLIPPAGE. OWNER EXPECTED TO SCHEDULE CLUTCH INSPECTION/WORK DURING NEXT 5K SERVICE VISIT. *TR

• 10/05/2006· EXTERIOR LIGHTING,VISIBILITY

  DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT VARIOUS SPEEDS, THE REAR BRAKE LIGHT AND TURN SIGNALS FAILED TO ILLUMINATE WITHOUT WARNING. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED THE BRAKE LIGHT SWITCH MALFUNCTIONED AND NEEDED TO BE REPLACED. THERE WAS A NHTSA RECALL, # 06V183000, REGARDING THE EXTERIOR LIGHTING. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. ADDITIONALLY, THE DRIVER SIDE WINDOW GLASS STUCK WITHIN THE WINDOW RETAINER, AND WOULD NOT ROLL UP. THE DEALER DETERMINED THE WINDOW GLASS NEEDED RETAINER CLIPS INSTALLED. AFTERWARDS, THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOTIFIED.

• 10/03/2006· AIR BAGSCrashFire

  I WAS TRAVELING 0 MPH AND WAS HIT HEAD ON AT 60 MPH. I WAS DRIVING A 2004 VOLKSWAGEN JETTA AND THE AIRBAGS DID NOT DEPLOY. *JB

• 10/02/2004· POWER TRAIN

  I BOUGHT A 2004 VW JETTA GLS ON MARCH 15, 2004 AND IT HAS NOW BEEN TO THE SHOP, OH, ABOUT 4 OR 5 TIMES! THE FIRST TIME, THE CLUTCH WAS CHATTERING - SO, THEY HAD TO REPLACE THE WHOLE CLUTCH KIT, THEN THE CLUTCH CABLE HAD TO BE ADJUSTED BECAUSE IT WASN'T SHIFTING RIGHT, THEN THE SECONDARY AIR PUMP HAD TO BE REPLACED, NOW THE BRAKE PEDAL MAKES A POPPING SOUND EVERYTIME I PRESS AND DEPRESS IT... THEN TO TOP IT ALL OFF - - I WENT TO GOTO WORK THE OTHER DAY, AND IT WOULDN'T START!!! - FINALLY GOT IT STARTED AFTER THINKING IT WAS THE BATTERY (BUT, BATTERY WASN'T DEAD), AND TWO DAYS LATER, IT BARELY STARTS AND IS RELEASING A HORRIBLE SMELL - THE INSIDE SMELLED LIKE ROTTEN EGGS.. IF THERE'S SOMETHING WRONG WITH THE EMISSIONS, I DON'T KNOW WHAT I'M GOING TO DO! I REALLY THING VW SHOULD REPLACE MY CAR WITH A NEW ONE AND COVER IT FOR LIFE!*AK

• 09/30/2016· SEATSFire

  MY CLOTHE SEATS CAUGHT ON FIRE TODAY WHILE DRIVING IT FOR ONLY 25 MINUTES THE SEAT WARMER WAS ONLY SET ON NUMBER 2. I WAS SO RETRIED AND PANICKED BUT MANAGED TO PULL OVER TO THE SIDE OF THE ROAD AND HIT IT WITH MY HAND UNTIL IT WENT OUT. IT DID BURN MY HAND. MY VEHICLE WAS IN MOTION THEN I STOPPED. IT WAS IN A CITY STREET FILLED WITH CARS AND CONSTRUCTION WORKERS.

• 09/28/2024· ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE

  Unknown, very complex. Multiple issues. Have been addressed as well as parts been replaced however other issues arised that are definitely safety concerns between electrical issues engine motor etc

• 09/28/2010· ENGINE AND ENGINE COOLING

  BOTH RADIATOR FANS FAILED SIMULTANEOUSLY, CAUSING CAR TO OVERHEAT AND STOP ALMOST INSTANTANEOUSLY IN HOT WEATHER. CAR ONLY HAS 55K MILES ON IT AND HAS BEEN PROPERLY MAINTAINED. BOTH RADIATOR FANS WERE REPLACED. *TR

• 09/28/2006· AIR BAGS

  WHILE DRIVING TO WORK, MY LEFT FRONT TIRE WENT FLAT THEN MY RIGHT SIDE CURTAIN AND RIGHT SIDE SEAT AIR BAG DEPLOYED THUS CAUSING THE VEHICLE TO STALL OUT AND WOULD NOT START ON A BUSY HIGHWAY. I WAS ABLE TO SAFELY PULL OFF TO THE SIDE WITHOUT GETTING HIT AND NOTIFIED POLICE. WHEN THE AIRBAGS DEPLOYED, I THOUGHT I WAS SHOT AT. OTHER THAN A FLAT TIRE AND A SCRATCH ON MY RIM, THERE WAS NO UNDERCARRIAGE OR BODY DAMAGE. I TOOK IT TO MY DEALER IN PLEASANTVILLE, NY THINKING IT WOULD BE COVERED UNDER WARRANTY, SINCE IT IS A 2004 VW JETTA WITH APPROXIMATELY 34,000 MILES. THEY DID ABSOLUTELY NOTHING TO HELP ME WITH MY PROBLEM. AFTER 2 1/2 WEEKS AT THE DEALER, I WAS TOLD THAT VW WAS NOT AT FAULT AND THEY WERE NOT GOING TO REPAIR THE CAR UNDER WARRANTY. THEY SAID THEY FOUND CRASH DATA WHICH OF COURSE THEY ARE GOING TO FIND SINCE THE AIRBAGS DEPLOYED. THEY SHOULD HAVE CHECKED THE SENSORS INSTEAD. THE REGIONAL COORDINATOR OF VW AMERICA CALLED ME TO LET ME KNOW THAT SINCE NOBODY WAS SITTING IN THE PASSENGER SEAT, THAT'S WHAT CAUSED THE AIRBAG DEPLOYMENT. I GUESS WE SHOULD ALL HAVE CRASH TEST DUMMIES SITTING IN OUR PASSENGER SEAT SO THAT THIS DOESN'T HAPPEN TO US. THE AMOUNT WOULD BE APPROXIMATELY $4,000 TO FIX. RIGHT NOW I HAVE IT AT AN AUTO BODY SHOP TO BE REPAIRED AND WILL SAVE THE PARTS. THIS IS A VERY EXPENSIVE FLAT AND I REALLY THINK I SHOULD BE REIMBURSED BY VW. THIS IS ALSO A SAFETY ISSUE AND THEY NEED TO RECALL THE CARS. AFTER RESEARCHING ON THE INTERNET (VWVORTEX.COM), THERE ARE MANY OTHER PEOPLE IN MY SIMILAR SITUATION - SOME GETTING REIMBURSED AND OTHERS NOT. *JB

• 09/26/2015· ELECTRICAL SYSTEM

  I HAVE REPLACED MY BATTERY TWICE AND MY ALTERNATOR ONCE. MY CAR COMPLETELY SHUTS DOWN WHEN I PART IT. I HAVE ALSO TURNED ON MY CAR AND THEN COMPLETELY SHUTS DOWN BY ITSELF, YET IF I JUMP START IT WILL TURN ON. I'M NOT ABLE TO TURN MY CAR BACK ON, AS THOUGH SOMETHING IS DRAINING MY BATTERY. THIS HAS BEEN OCCURRING FOR OVER ONE YEAR NOW AND I'M GETTING STRANDED AT MY LAST DESTINATION AND HAVE HAD TO GET TOWED TO THE MECHANIC SHOW. IT'S GETTING VERY EXPENSIVE AND RIDICULOUS. THE MECHANIC HAS DONE HIS DUE DILIGENCE BUT PROBLEM IS STILL OCCURRING. I'M AFRAID TO DRIVE ON THE HIGHWAY IN FEAR MY CAR WILL SHUT DOWN! *TR

• 09/24/2014· ENGINE

  TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE JERKED, THE EPC WARNING INDICATOR ILLUMINATED, AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE MASS AIR FLOW SYSTEM FAILED. THE DEALER PREVIOUSLY REPLACED THE MASS AIR FLOW SYSTEM DUE TO THE CHECK ENGINE INDICATOR ILLUMINATING, BUT THE FAILURE PERSISTED. THE TECHNICIAN STATED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.