2004 Subaru Forester

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2017· FUEL/PROPULSION SYSTEM

  GAS SMELL COLD WEATHER CAR IDOLING

• 12/29/2004· ENGINE AND ENGINE COOLINGCrash

  CAR PRODUCING NOXIOUS ODOR INSIDE. WHEN PARKING CAR IN GARAGE, ACCIDENTALLY STEPPED ON ACCELERATOR RATHER THAN BRAKE. HIT AND DESTROYED BACK WALL. COSMETIC DAMAGE TO CAR. DEALER CLAIMS LEAVES WERE SUCKED INTO THE ENGINE COMPARTMENT THROUGH TURBOCHARGE INTAKE. BUT, ODOR WAS OF BURNT RUBBER OR PLASTIC, NOT LEAVES. AND, THE CAR IS ALWAYS PARKED IN THE GARAGE. FINALLY, MOST LEAVES WERE DOWN SEVERAL WEEKS EARLIER THIS YEAR, I.E., BY END OF NOVEMBER. *NM

• 12/28/2016· FUEL/PROPULSION SYSTEM

  THERE IS A TERRIBLE GAS SMELL DURING COLD WEATHER FROM SOME LEAK IN THE FUEL LINE. OTHER SUBARU MODELS HAVE BEEN RECALLED FOR THIS SAME PROBLEM, BUT NOT THE FORESTER. THE SMELL IS SO BAD THAT IT HAS GIVEN ME HEADACHES AND NAUSEA. THE SMELL IS PARTICULARLY AWFUL WHEN THE HEAT IS TURNED ON, WHICH IS PROBLEMATIC SINCE ONE WANTS THE HEAT ON WHEN IT'S THAT COLD OUT. SMELL PERSISTS AROUND THE CAR EVEN WHEN IT ISN'T RUNNING AND IS SO BAD I CAN'T PARK IT INSIDE MY ATTACHED GARAGE BECAUSE IT COMES INTO THE HOUSE. SUBARU REALLY NEEDS TO ADDRESS THIS. I HAVE MENTIONED IT TO MY MECHANIC SEVERAL TIMES AND THEY HAVE TRIED TO CORRECT IT BY TIGHTENING FUEL LINE CONNECTIONS, WHICH HAS NOT SOLVED THE ISSUE. THEY TOLD ME ABOUT THE OTHER MODELS BEING RECALLED, AND WHEN I RESEARCHED IT MYSELF I DISCOVERED THAT THERE ARE HUNDREDS (AT LEAST) OF SUBARU FORESTER OWNERS WHO HAVE COMPLAINED ABOUT THE SAME PROBLEM. THIS IS A HEALTH HAZARD. I DON'T THINK ANYONE SHOULD BE BREATHING THESE CONCENTRATED FUMES. SUBARU NEEDS TO DO A RECALL AND REPLACE THESE FAULTY LINES. THIS PROBLEM HAS BEEN ONGOING FOR AT LEAST THE PAST 2 YEARS/WINTERS. MY MOST RECENT VISIT TO THE MECHANIC (TO ADDRESS THE FUEL SMELL AGAIN) WAS DECEMBER 23, 2016.

• 12/28/2010· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT STATED THAT AS HE STARTED THE VEHICLE, THE VEHICLE ABNORMALLY ACCELERATED. THE CONTACT TURNED THE IGNITION OFF AND TURNED IT BACK ON AND THE VEHICLE INDEPENDENTLY ACCELERATED A SECOND TIME. THE THIRD TIME THE CONTACT TURNED THE IGNITION OFF AND WHEN RESTARTING, THE FAILURE DID NOT RECUR. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 38,530.

• 12/28/2010· FUEL SYSTEM, GASOLINE

  STRONG GAS ODOR WHEN CAR IS STARTED IN COLD TEMPERATURES. *TR

• 12/26/2011· FUEL SYSTEM, GASOLINE

  STRONG RAW FUEL SMELL IN CABIN OF CAR DURING COLD START/COLD WEATHER. IT APPEARS THAT THE FUEL LINES SHRINK IN COLD WEATHER AND PULL AWAY FROM THE METAL FUEL LINES CAUSING VAPOR LEAK AS WELL AS FUEL LEAKS. THE PROBLEM IS THAT THE FUEL LINES ARE LOCATED UNDER THE INTAKE MANIFOLD AND ARE IMPOSSIBLE TO TIGHTEN UNLESS THE MANIFOLD IS REMOVED. THIS IS A HUGE SAFETY HAZARD. *TR

• 12/26/2005· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  WHEN OUTSIDE TEMPERATURE FALLS BELOW 10 DEGREES F., CAR WILL NOT START OR STARTS ONLY WITH GREATEST DIFFICULTY. LAST YEAR(2004), SAME SORT OF STARTING PROBLEM WAS ATTRIBUTED TO A CRACKED IGNITION COIL. THIS YEAR DEALERS SERVICE DEPARTMENT CAN NOT FIND A PROBLEM, ALSO CAN'T EXPLAIN THE PROBLEM. *JB

• 12/24/2007· VEHICLE SPEED CONTROLCrash

  VEHICLE ABRUPTLY ACCELERATED WHILE STOPPED WITH FOOT ON BRAKE IN A RESIDENTIAL NEIGHBORHOOD. VEHICLE JUMPED A CURB AND CLIPPED A TREE AT HIGH SPEED CUTTING ACROSS TWO HOME LAWNS. DRIVER HAD NO CONTROL OF CAR AND BRAKES DID NOT WORK. VEHICLE FINALLY CAME TO A REST AFTER BRAKE PEDAL HAD BEEN PUSHED ALL THE WAY TO THE FLOOR. SIGNIFICANT DAMAGE TO VEHICLE WHERE IT MADE CONTACT WITH THE TREE. THANKFULLY NO ONE WAS OUTSIDE AT THE TIME (3:00 PM) BECAUSE SOMEONE COULD HAVE EASILY BEEN KILLED BY THE OUT OF CONTROL VEHICLE ALSO HAD IT NOT BEEN FOR CLIPPING THE TREE, THE VEHICLE WOULD HAVE LIKELY GONE FORWARD INTO A HOME. *TR

• 12/22/2010· FUEL SYSTEM, GASOLINE

  RAW FUEL SMELL IN CABIN DURING COLD START. TOOK TO MECHANIC AND HE SEES FUEL LEAKING FROM THE FUEL LINE UNDER PASSENGER INTAKE MANIFOLD. TO RESOLVE ISSUE HE WILL HAVE TO PULL THE INTAKE, REPLACE FUEL LINES AND USE BETTER CLAMPS. THE CLAMPS AND HOSE USED BY SUBARU IS FAULTY AS I SEE A TON OF COMPLAINTS ONLINE ABOUT THE SAME ISSUE. THEY EVEN DID A RECALL ON THE WRX WHICH HAS THE SAME MOTOR AS THE FORESTER.

• 12/22/2010· ENGINE AND ENGINE COOLING

  CONSUMER WRITES REGARDING AUTOMOBILE MANUFACTURER DESIGN FLAW EXCLUSIVE DEALERSHIPS REPAIRS *TGW THE CONSUMER STATED HE EXPERIENCED A CATASTROPHIC FAILURE WITH HIS ENGINE DUE TO A BLOWN TURBO. THE LOCAL DEALERSHIP REFUSED TO SELL THE REPLACEMENT PART TO HIS LOCAL MECHANIC DUE TO THE CAUSE OF THE FAILURE AND THE INSTALLATION PROCESS. SUBARU LATER RESPONDED IN WRITING DENYING ALL CLAIMS EVEN WHEN THE CONSUMER SUPPLIED THEM WITH VALID REASONS. THE CONSUMER LEARNED SUBARU WAS AWARE OF THE PROBLEM DATING BACK TO 2005 AND A TSB WAS ISSUED. THE TSB STATED THAT OIL STARVATION TO THE TURBO WAS THE MAIN CAUSE FOR THE TURBO FAILURE. THE OIL STARVATION HAPPENED WHEN THE OIL FEED FILTER BANGO BECAME CLOGGED. SUBARU REALIZED THE DESIGN FLAW IN THE TURBO SYSTEM AND LATER REDESIGNED THE TURBO TO ADDRESS THE PROBLEM. *JB

• 12/21/2004· ENGINE AND ENGINE COOLINGFire

  ENGINE COMPARTMENT FIRE, RESULTING FROM OIL LEAKING IN ENGINE COMPARTMENT. THERE WERE NO INJURIES AND BECAUSE OF PROXIMITY OF FIRE DEPARTMENT FIRE WAS EXTINGUISHED WITHIN 4-5 MINUTES. SUBARU OF AMERICA (SOA) MAINTAINS THAT OIL LEAKED FROM OIL FILTER AND THAT THIS IS NO FAULT OF THEIRS. GIVEN THE HISTORY OF RECALLS OF THIS TYPE OF VEHICLE IN JAPAN FOR LEAKING OIL AND FIRES I AM NOT SURE THAT THIS POINT HAS BEEN DEMONSTRATED. SOA REFUSED TO FIX DAMAGE AND TOLD ME TO FILE AN INSURANCE CLAIM... WHICH I HAVE DONE. DAMAGE IS ESTIMATED TO BE $6-10K. MATTER WILL BE SUBROGATED TO INSURANCE COMPANY FOR SETTLEMENT.*AK

• 12/20/2012· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT STATED THAT HE COULD SMELL GASOLINE INSIDE THE CABIN OF THE VEHICLE WHEN DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 107,000.

• 12/20/2012· ENGINE,FUEL/PROPULSION SYSTEM

  STRONG FUEL ODOR INSIDE CABIN DEVELOPED WHEN OPERATING ON COLD MORNINGS; FUEL ODOR TYPICALLY WENT AWAY WITHIN 15 MINUTES OF STARTING THE CAR. INSPECTION OF FUEL LINES, FILTER, ETC. REVEALED NO OBVIOUS LEAKS ABOVE THE INTAKE MANIFOLD. DEALER QUOTED APPROXIMATELY $800 TO REMOVE INTAKE MANIFOLD AND INSPECT. I HAVE HAD TWO INDEPENDENT SHOPS ATTEMPT TO FIX THIS ISSUE OVER THE PAST 3 YEARS WITH VARYING DEGREES OF SUCCESS; THE MOST RECENT (2011) REMOVED THE INTAKE MANIFOLD AND REPLACED ALL RUBBER FUEL LINES UNDER THE MANIFOLD, BUT THE PROBLEM HAS RECURRED THIS FALL AND WINTER AND AT INCREASINGLY WARM TEMPERATURES. NOW, THERE IS A VISIBLE AND OBVIOUS LEAK FROM A FUEL LINE JUST AS IT GOES UNDER THE MANIFOLD--INACCESSIBLE WITHOUT REMOVING THE MANIFOLD. CLEARLY, THE PROBLEM IS WITH THE DESIGN OF THE METAL FUEL RAIL TO RUBBER LINE INTERFACE, SINCE THIS IS A COMMON PROBLEM IN FORESTER XTS ACROSS SEVERAL MODEL YEARS. SUBARU OF AMERICA ISSUED A RECALL FOR THIS PROBLEM ON THE WRX, BUT SO FAR HAS NOT ACKNOWLEDGED THE PROBLEM FOR THE FORESTER OR FORESTER XT. THIS IS A COSTLY REPAIR AND A HUGE SAFETY ISSUE: THE LEAKING FUEL DRIPS DIRECTLY ONTO THE ENGINE CYLINDER HEADS AND IN SOME CASES (ON PASSENGER-SIDE FUEL LINE LEAKS) IS IN CLOSE PROXIMITY TO THE TURBOCHARGER--REPRESENTING A SIGNIFICANT RISK OF ENGINE FIRE. THE FUEL FUMES IN THE CABIN ARE ALSO A HEALTH AND SAFETY RISK WHICH SHOULD BE DEALT WITH BY SUBARU. *TR

• 12/19/2016· UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

  IN VERY COLD WEATHER, THERE IS A STRONG GASOLINE SMELL INSIDE THE CAR THAT REMAINS AS THE CAR WARMS UP. THIS ONLY OCCURS WHEN TEMPERATURES ARE WELL BELOW FREEZING.

• 12/19/2016· FUEL/PROPULSION SYSTEM

  CAR LEAKS FUEL PROFUSELY FROM FUEL LINE NEAR ENGINE BLOCK WHEN RUNNING DURING COLD WEATHER TEMPERATURES BELOW 20 DEGREES FAHRENHEIT.

• 12/17/2018· FUEL/PROPULSION SYSTEM

  THE RUBBER INJECTOR LINES RUNNING BELOW THE INTAKE MANIFOLD ON THE TURBOCHARGED (XT) MODEL, INCLUDING MY VEHICLE, ARE WELL KNOWN TO DEVELOP A DANGEROUS LEAK. EITHER THE RUBBER DRIES OUT OR THE FACTORY CLAMPS LOOSEN UP OVER TIME, LEAKING GASOLINE ONTO THE ENGINE BLOCK. THIS IS A VERY DANGEROUS DESIGN FLAW THAT HAS BEEN RECOGNIZED AS AN ISSUE ON THE IMPREZA BUT YOU FORGOT ABOUT FOERESTER OWNERS, SUBARU! SHAME ON YOU.

• 12/17/2009· VEHICLE SPEED CONTROL

  OWNER WAS PULLING INTO A PARKING SPACE AT A GROCERY STORE PARKING LOT WHEN VEHICLE SUDDENLY ACCELERATED FORWARD BUMPING THE CONCRETE PARKING POST. WHEN PUT IN REVERSE, IT AGAIN SUDDENLY ACCELERATED BRUISING A PEDESTRIAN. SIMILAR BEHAVIOR WHILE PARKING OCCURRED IN THE SAME LOT A MONTH EARLIER BUT ONLY CAUSING DAMAGE TO THE LICENSE PLATE COVER. WE BELIEVE THE DRIVERS SIDE FLOOR MATT SLIPPED AND HAVE REMOVED IT. WE DID TAKE IT TO THE DEALER TO HAVE THE THROTTLE COMPUTER BOARD CLEANED AT THE PIN CONNECTOR AND MAP SENSORS, AS HAD BEEN SUGGESTED IN AN EARLIER NHTSA REPORT FOR THIS CAR YEAR AND MODEL. HOWEVER, THE MECHANIC SAID THEY WERE NOT DIRTY. *TR

• 12/16/2016· FUEL/PROPULSION SYSTEM

  FORESTERS HAVE A COMMON PROBLEM OF A VERY COMMON PROBLEM OF THE FUEL LINE LEAKING. THE COLD CAUSES SHRINK TO THE FUEL LINES CAUSING A LEAK INTO THE ENGINE AND FUEL VAPORS TO ENTER THE CABIN. THIS ISSUE OCCURS WHETHER IT'S STATIONARY OR IN MOTION AS WELL AS ALL OTHER CONCEIVABLE STATES THAT THE VEHICLE CAN BE IN. A RECALL WAS ISSUED FOR THE WRX, THE SAME SHOULD OCCUR WITH THE FORESTER. THIS ISSUE OCCURS EVERY WINTER WHEN THE TEMP DROPS BELOW 20 DEGREES.

• 12/16/2009· FUEL SYSTEM, GASOLINE

  IN COLD WEATHER (BELOW 0F) VEHICLE LEAKS FUEL IN THE ENGINE COMPARTMENT. VEHICLE WAS PARKED OUTSIDE STARTING AT 6:30 AM, WITH AN OUTDOOR AIR TEMPERATURE OF APPROXIMATELY -11F AFTER A 6 MILE DRIVE. WHEN VEHICLE WAS RESTARTED AT 11:30AM, WITH AN OUTDOOR AIR TEMPERATURE OF APPROXIMATELY 3F, FUEL SMELL WAS NOTICED WITHIN ONE MILE. FUEL LEAK IS FROM HIGH PRESSURE HOSE ON PASSENGER SIDE OF VEHICLE, JUST FORWARD AND BELOW THE MANIFOLD. CAR WAS TOWED TO SHOP AND SHOP REPLACED HIGH PRESSURE FUEL HOSE AND CLAMPS. PHOTOS OF EXACT LOCATION OF LEAK, COMPONENTS REPLACED, REPAIR BILL AND NATIONAL WEATHER SERVICE TEMPERATURE DATA AVAILABLE IN PDF FORMAT. *TR

• 12/15/2013· FUEL SYSTEM, GASOLINE

  STRONG SMELL OF FUEL WHEN OPERATING THE VEHICLE IN COLD WEATHER (AROUND 35 DEGREES OR COLDER). THE FUMES ARE SOMETIMES SO INTENSE THAT THEY CAUSE A HEADACHE AND CERTAINLY POSE A SIGNIFICANT FIRE RISK. *TR

• 12/15/2010· FUEL SYSTEM, GASOLINE

  TL*THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT STATED THAT AS THE TEMPERATURE STARTED TO DROP HE NOTICED FLUID LEAKING FROM THE ENGINE. HE INSPECTED THE VEHICLE AND REALIZED THAT THE HARD FUEL LINE WAS LOOSE. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 104,000.

• 12/13/2013· FUEL/PROPULSION SYSTEM

  I'VE OWNED MY 2004 SUBARU FOR 5 YEARS WITHOUT INCIDENT, BUT AS OF DECEMBER 2013, I'VE EXPERIENCED A STRONG FUEL SMELL BOTH INSIDE AND OUTSIDE OF THE CAR. THE SMELL IS OVERPOWERING WHILE CAR IS PARKED, BUT LESSENS WHILE MOVING. IT BEGAN AFTER THE FIRST BIG DROP IN TEMPERATURE (40 DEGREES TO 10 DEGREES), AND HAS PERSISTED FOR OVER A WEEK NOW. *TR

• 12/12/2017· FUEL/PROPULSION SYSTEM

  JUST LIKE 60 OR SO OTHER 03-05 FORESTER XT OWNERS, I'M EXPERIENCING THE FUEL LEAK FROM THE RUBBER FUEL LINE WHERE IT CLAMPS ON TO THE METAL LINE TO THE FRONT DRIVERS SIDE INJECTOR. JUST LIKE EVERYONE ELSE, THE ISSUE ONLY OCCURRED WHEN TEMPERATURES DROPPED BELOW ABOUT 20F - UNCOINCIDENTALLY, IN MY OPINION, THIS WAS THE FIRST NEW ENGLAND WINTER THIS CAR HAD EVER SEEN. SUBARU HAS ISSUED A RECALL FOR WRX WITH THE SAME EXACT ISSUE INVOLVING THE SAME EXACT HARDWARE. GET ON IT SUBARU, THIS IS COMPLETELY UNACCEPTABLE AND AN EXTREMELY DANGEROUS DESIGN FLAW. YOU'VE ALREADY FESSED UP TO THE ISSUE WITH OTHER VEHICLES USING THE EJ255 NOW DON'T FORGET ABOUT US FOZZY OWNERS.

• 12/12/2009· FUEL SYSTEM, GASOLINE

  EXTREMELY STRONG FUEL ODOR IN THE INTERIOR OF AN 04 SUBARU FORESTER. *TR

• 12/11/2007· VISIBILITY

  SUBARU REFUSES TO MAKE WINTER BLADES FOR THE REAR WIPER BLADE ON 2004-2008 SUBARU FORESTERS. THIS RESULTS IN REAR WIPER BLADES THAT ICE UP AND CANNOT EFFECTIVELY WIPE THE REAR WINDOW IN ICE OR SNOW. REAR VISION IS BLOCKED. THIS SUMMER BLADE FAILURE HAS OCCURRED MORE TIMES THAN I CAN COUNT. STOPPING ALONG SIDE A HIGHWAY TO CLEAN THEM OFF CAN BE A SAFETY HAZARD. I HAVE CONTACTED SUBARU SEVERAL TIMES ON THIS SINCE 2004. ALL THEY SAY IS THAT THEY WILL TALK ABOUT IT. CAN YOU MAKE THEM MANUFACTURE A WINTER BLADE? *TR

• 12/10/2013· FUEL SYSTEM, GASOLINE

  I FIRST NOTICED A STRONG GAS SMELL IN THE VEHICLE ON THE COLDEST DAY OF THE YEAR, WHEN THE TEMPERATURE WAS BELOW 20 DEGREES. THE GAS SMELL ENTERS THE VEHICLE THROUGH THE VENTS WHEN THE HEATER IS TURNED ON AND THE CAR IS IDLING. WHILE THE VEHICLE IS TRAVELING AT A SPEED OF 10+ MPH, THE GAS SMELL IS NOT NOTICEABLE. WHEN THE HEATER IS TURNED OFF, THE GAS SMELL DOES NOT ENTER THE VEHICLE. WHEN I EXIT THE VEHICLE, I CAN SMELL GAS OUTSIDE OF THE VEHICLE ALSO. THE SMELL IS SO OVERWHELMING THAT I CANNOT RUN THE HEATER IN THE EXTREME COLD TEMPERATURES WHILE THE VEHICLE IS IDLING. I RAN THE VEHICLE THROUGHOUT THE SUMMER MONTHS AND THERE IS NO PROBLEM WITH THE GAS SMELL WHATSOEVER. I DO NOT TAKE MY CHILD IN THE VEHICLE WITH ME DURING THE WINTER MONTHS DUE TO THE STRONG GAS FUMES. I FEAR THAT I MAY BECOME STRANDED IN MY VEHICLE AND I WILL NOT BE ABLE TO IDLE MY CAR FOR HEAT. *TR

• 12/10/2013· FUEL/PROPULSION SYSTEM

  DURING THE COLD WEATHER THERE IS AN VERY STRONG GAS SMELL IN THE CAR. I STARTED THE CAR AND LOOKED UNDER THE HOOD AND CAN SEE WHERE GAS IS LEAKING FROM THE FUEL SYSTEM. I BELIEVE IT LEAKS IN THE SAME SPOT THAT MANY OTHER PEOPLE HAVE REPORTED. *TR

• 12/08/2018· FUEL/PROPULSION SYSTEM

  DURING COLD WEATHER, WHILE AT A STOP AND IN MOTION, THERE IS A STRONG FUEL SMELL INSIDE THE CABIN. THE SOURCE WAS DETERMINED TO BE THE FUELS LINES AND SPECIFICALLY THE FITTINGS ON THE LINES. DURING COLD WEATHER, EITHER THE FITTINGS OR THE HOSES CONTRACT, CAUSING FUEL TO LEAK IN THE ENGINE BAY, NEAR THE HOT HEADERS AND HOT TURBO.

• 12/08/2016· FUEL/PROPULSION SYSTEM

  STRONG FUEL ODOR HAS BEEN ENTERING THE CABIN DURING STARTUP ON COLD MORNINGS. THIS IS CAUSED BY A FUEL LINE LEAKING ONTO THE ENGINE. THE LEAK CAN BE SEEN BUT IS INACCESSIBLE WITHOUT REMOVING THE INTAKE MANIFOLD. ONCE THE VEHICLE HEATS UP AND THE LINE EXPANDS THE LEAK STOPS. I AM VERY CONCERNED ABOUT THE POTENTIAL FOR A VEHICLE FIRE AND THE DANGER OF INHALING GASOLINE FLAMES. *TR

• 12/08/2010· FUEL SYSTEM, GASOLINE

  I OWN AND DAILY DRIVE A 2004 FORESTER XT. IT HAS RECENTLY DEVELOPED WHAT I CONSIDER TO BE A SEVERE SAFETY RELATED ISSUE. LAST NIGHT, AFTER DRIVING APPROXIMATELY 30 MINUTES, THERE WAS AN OVERWHELMING SMELL OF RAW FUEL IN THE CABIN. THIS SITUATION HAPPENED AGAIN THIS MORNING WHILE SITTING IN TRAFFIC, AT A RED LIGHT. THE SMELL OF GASOLINE WAS SO STRONG, I FELT LIGHT HEADED AND HAD TO ROLL DOWN THE WINDOWS WHEN THE TEMPERATURE OUTSIDE WAS 24 FAHRENHEIT. I FOUND THAT SUBARU OF AMERICA (SOA) ISSUED A RECALL FOR THE SAME PROBLEM ON WRX MODELS WHICH PRODUCED THIS SYMPTOM. UPON INSPECTION OF MY ENGINE, I CAN BOTH SEE AND SMELL RAW FUEL SEEPING FROM ONE OR MORE OF THE FUEL LINES. I CONTINUED MY RESEARCH AND FOUND THAT THERE ARE MANY REPORTS OF THIS ISSUE COVERING MANY YEAR MODELS OF THE FORESTER AND THE LEGACY MODELS. DUE TO THE VOLATILITY OF GASOLINE AND THE INHERENT DANGERS TO HUMANS IN VAPOR FORM, I FEEL THIS IS A CRITICAL SAFETY ISSUE. I HAVE READ MANY REPORTS AND NOTICED THE APPARENT LARGE POPULATION OF AFFECTED VEHICLES. THIS IS VERY DISCONCERTING. I AM CONTACTING SOA TO REPORT THIS PROBLEM AND TO REQUEST THEY COVER THE FAILURE UNDER GOODWILL. *TR

• 12/08/2008· FUEL SYSTEM, GASOLINE

  MODEL IS A 2004 SUBARU FORESTER XT. UPON STARTUP IN COLD WEATHER, THERE IS AN EXTREME SMELL OF RAW FUEL (GASOLINE) BOTH INSIDE THE VEHICLE AND OUTSIDE AS WELL. I AM AFRAID TO DRIVE THIS CAR IN COLD WEATHER. *TR

• 12/07/2016· ENGINE,FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. WHEN THE VEHICLE WAS STARTED, A VERY STRONG FUEL ODOR EMERGED FROM THE ENGINE COMPARTMENT. THE FUEL TANK LEAKED FUEL ONTO THE MANIFOLD. THE FAILURE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC AS A FUEL TANK LEAK. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 149,966.

• 12/06/2015· SUSPENSION

  HAVING RECENTLY BOUGHT MY 2004 SUBARU FORESTER XT, IT RAN GREAT FOR THE FIRST FEW MONTHS. THEN, WHILE ON THE HIGHWAY, IT WOULD SHAKE UNCONTROLLABLY, ALMOST LIKE AN EARTHQUAKE. HAVING TAKEN IT TO SUBARU A MONTH BEFORE, I MENTIONED THAT IT WAS DOING THIS A LITTLE, BUT NOT TO THE EXTENT THAT IT DID ON THE HIGHWAY. HE SAID IT WOULD BE $150 TO LOOK AT IT. TAKING IT IN TO A DIFFERENT MECHANIC, THEY HAD TO REPLACE THE LOWER CONTROL ARM. LOOKING TODAY ONLINE FOR RECALLS ON ANOTHER ISSUE I'M EXPERIENCING, I SEE THAT THERE WAS A RECALL ON THIS EXACT ISSUE, BUT ONLY FOR CARS SOLD IN CERTAIN STATES. THIS IS THE EXACT ISSUE THAT WAS WRONG WITH MY SUBARU, AND I BELIEVE THAT OWNERS IN OTHER STATES ARE EXPERIENCING THIS ISSUE AS WELL. HOPEFULLY YOU WILL LOOK AT THIS BEFORE THIS HAPPENS TO SOMEONE ON THE INTERSTATE AND THEY LOSE CONTROL OF THEIR VEHICLE.

• 12/06/2015· FUEL/PROPULSION SYSTEM

  DANGEROUS!! I AM THE RECENT PROUD OWNER OF A 2004 SUBARU FORESTER XT. A COUPLE OF DAYS AGO WE GOT OUR FIRST FREEZE. I WALK OUT TO START MY CAR AND IT'S NOT TURNING OVER AND A STRONG FUEL SMELL IS FILLING THE CABIN. I KEEP TRYING THINKING THAT IT MAY TURN OVER. WITH NO LUCK, AND FEARING SOMETHING IS WRONG (OR MAY POSSIBLY BLOW UP), I STOP AND GET OUT. TAKING A CLOSER LOOK HAVING PARKED IT SOME DIRT, I SEE THAT IT IS VISIBLY MOIST UNDER MY CAR. THE GROUND IS SATURATED WITH GAS. LUCKILY IT DIDN'T CONTACT ANY SPARK IN THE ENGINE OR I WASN'T SMOKING, BECAUSE I WOULDN'T BE HERE TODAY TO TELL THIS STORY. IT WAS A TON OF GAS. PLEASE FIX THIS BEFORE SOMEONE DIES OR GETS SERIOUSLY INJURED.

• 12/06/2013· FUEL SYSTEM, GASOLINE

  START VEHICLE IN THE MORNING AND CAN SMELL GAS FUMES OUTSIDE AND INSIDE EVEN WHEN DRIVING. THIS CAUSES BURNING OF NOSE AND THROAT. *TR

• 12/06/2010· STRUCTURE

  TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. THE CONTACT RECEIVED NOTIFICATION OF A MANUFACTURERS RECALL PERTAINING TO THE SUN-ROOF REPLACEMENT IN OCTOBER, 2010. THE DEALER WAS CONTACTED AND ADVISED THAT THE RECALL COULD NOT BE PERFORMED BECAUSE THE PART WAS NOT YET AVAILABLE. THE DEALER WAS UNABLE TO CONFIRM WHEN THE PART WOULD BECOME AVAILABLE. THE CONTACT FEELS THE RECALL EXCEEDED A REASONABLE TIME FOR REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 45,102.

• 12/05/2008· FUEL SYSTEM, GASOLINE

  THIS PROBLEM HAPPENED WHEN TEMPERATURE DROPPED BELOW ABOUT 15 DEGREES F. THERE WAS A VERY STRONG GAS SMELL INSIDE CAR WITH HEATER ON. THERE WAS ALSO A STRONG GAS SMELL UNDER HOOD. I DROVE CAR THE NEXT DAY AT 35 DEG F AND NO SMELL. *TR

• 12/01/2010· FUEL SYSTEM, GASOLINE

  TL*THE CONTACT OWNS A 2004 SUBARU FORESTER XT. THE CONTACT STATED THAT DURING COLD WEATHER HE WOULD SMELL GASOLINE FUMES INSIDE OF THE VEHICLE. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED STATED THAT HE HAD A LEAK IN HIS FUEL LINE FROM THE HOSE ON THE FUEL RAIL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 108,000. THE VIN WAS UNAVAILABLE. UPDATED 02/02/11 *CN

• 11/27/2018· SUSPENSION

  MY DAUGHTER (DRIVER) AND A PASSENGER PULLED SLOWLY OUT OF OUR DRIVEWAY IN REVERSE, HEADING OFF TO COLLEGE (100 MILES AWAY) BUT JUST AFTER PULLING OUT IN THE STREET, THE RIGHT FRONT LOWER CONTROL ARM OF HER 2004 SUBARU FORESTER BROKE IN HALF DUE TO RUST/CORROSION. I WAS ABLE TO INCH THE CAR BACK INTO MY GARAGE AND ON JACKS ONLY TO FIND THE RIGHT LOWER CONTROL ARM BROKE IN HALF. I CHECKED THE OTHER LOWER LEFT CONTROL ARM AND IT WAS VERY RUSTED. I HAD THE VEHICLE TOWED TO THE NEAREST SUBARU DEALER. THE SUBARU DEALER NOTIFIED ME THAT SUBARU RECALL WVX-34: FRONT LOWER CONTROL ARM/TRANSVERSE LINK, ISSUED 09/11 HAD BEEN COMPLETED FOR THIS 2004 FORESTER IN 12/11. I WAS TOLD THAT THE LOWER CONTROL ARMS WERE NOT REPLACED IN 2011, BUT THAT THE LOWER CONTROL ARMS WERE TREATED WITH THE RECALL-PRESCRIBED RUST/CORROSION PREVENTION. THIS "FIXED" RECALL LASTED ONLY 7 YEARS! INITIALLY, THE SUBARU DEALERSHIP WOULD NOT COVER THE COST TO REPLACE THE LOWER CONTROL ARMS; HOWEVER, AS I PLACED A CALL WITH SUBARU OF AMERICA (SOA), I RECEIVED ANOTHER PHONE CALL FROM THE DEALERSHIP STATING THAT THEY CONTACTED THEIR "REP" AND AGREED TO PAY 50/50 TOWARDS THE COST OF REPLACING BOTH FRONT LOWER CONTROL ARMS. I DISCUSSED THIS VERY UNSAFE ISSUE WITH TWO DIFFERENT SOA REPRESENTATIVES, ONE OF WHICH WAS A SUPERVISOR. SOA LET ME KNOW THAT I WOULD BE RESPONSIBLE FOR THE COST OF THIS REPAIR BECAUSE IT WAS A 2004. ARE YOU KIDDING ME? MY DAUGHTER WAS GETTING READY TO MAKE A DEADLY 100 MILE TRIP IN THIS VEHICLE CLAIMED TO HAVE BEEN "FIXED" BY SUBARU JUST SEVEN YEARS PREVIOUS. HOW NEGLIGENT IS THIS, COMING FROM A COMPANY CLAIMING TO HAVE MORE CARS ON THE ROAD THAN ANYONE ELSE AND SAFER THAN OTHERS? I HAVE FOUR SUBARUS (04' FORESTER, 05' FORESTER XT, 08 TRIBECA LTD., AND 2010 IMPREZA) AND I'VE LOST MY FAITH IN THIS ORGANIZATION. THIS IS A DEADLY RECALL THAT SOA IS IGNORING.

• 11/24/2017· FUEL SYSTEM, GASOLINE,ENGINE

  TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. WHETHER THE VEHICLE WAS PARKED OR BEING DRIVEN, A FUEL ODOR WAS DETECTED IN AND OUTSIDE THE VEHICLE. THE FUEL ODOR WAS MOST NOTICEABLE WHILE OPERATING THE HEATER. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO MID-HUDSON SUBARU (1715 U.S. 9, WAPPINGERS FALLS, NY 12590 (866) 678-2048) SEVERAL TIMES, BUT NO LEAKS OR FAILURES WERE DETECTED. THE CONTACT STATED THAT THE DEALER FINALLY DETECTED A FUEL ODOR AND DIAGNOSED THE FAILURE AS A MALFUNCTION WITH TUBING OR PIPING WITHIN THE ENGINE. THE PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO THE COST. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THEY WOULD CONTACT THE LOCAL DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. *TT *TR

• 11/24/2014· FUEL/PROPULSION SYSTEM

  FUEL SMELL IN CABIN WITH BLOWER SET ON OUTSIDE AIR. THE CAUSE WAS A FUEL LEAK IN THE ENGINE BAY UNDER THE INTAKE MANIFOLD. *TR

• 11/23/2015· FUEL/PROPULSION SYSTEM

  DURING WINTER MONTHS 2004 FORESTER XT EMITS NOXIOUS FUEL SMELL INTO CABIN. SOURCE IS FROM ENGINE COMPARTMENT IN AREA OF TURBO/EXHAUST MANIFOLD AS DISCOVER FROM PUDDLE ON GARAGE FLOOR DURING WARM UP

• 11/22/2011· FUEL SYSTEM, GASOLINE

  ON THE FIRST GENUINE COLD DAY OF THE YEAR (BELOW 40 DEGREES F) I NOTICED A STRONG FUEL SMELL COMING FROM MY AIR VENTS WHILE DRIVING. AS IT'S NOW MID NOVEMBER AND AVERAGES BELOW 40 DEGREES F I GET A STRONG FUEL SMELL AT EVERY COLD START UNTIL THE CAR WARMS UP TO TOP OPERATING TEMPERATURE. AFTER RESEARCHING THIS SYMPTOM, I DISCOVERED THAT IT'S VERY COMMON FOR THE FUEL CLAMPS UNDERNEATH THE INTAKE MANIFOLD ON THE PASSENGER SIDE TO LEAK WHEN COLD ON 2004 SUBARU FORESTER XTS. UPON FURTHER INVESTIGATION I DISCOVERED THAT THIS IS HAPPENING WITH MY CAR, AND IS POOLING FUEL ON THE ENGINE UNTIL WARM. AVERAGE ESTIMATE FROM DEALER IS $500. *TR

• 11/20/2014· FUEL/PROPULSION SYSTEM

  ON DAYS WITH SUB-FREEZING TEMPERATURES, AFTER STARTING THE VEHICLE, A STRONG SMELL OF GAS IS PRESENT. UPON INSPECTION OF THE ENGINE COMPARTMENT, THERE IS GASOLINE VISIBLY DRIPPING FROM A FUEL LINE BEHIND THE AC COMPRESSOR. THE GASOLINE LANDS ON THE ENGINE BLOCK AND PRODUCES VISIBLE VAPORS AS IT IS SLOWLY BURNED UP BY THE HEAT. UPON DISCUSSING THE PROBLEM WITH A SUBARU REPAIR SHOP, THEY SAID THIS IS QUITE COMMON FOR MY VEHICLE. *TR

• 11/19/2014· FUEL/PROPULSION SYSTEM

  I PURCHASED A USED SUBARU FORESTER XT. THE CAR HAD APPROXIMATELY 180,000 MILES AND WAS PURCHASED MID-WINTER IN DENVER, COLORADO. ON EXTREMELY COLD DAYS I NOTICED A RAW FUEL SMELL. IT WAS AN ALARMINGLY STRONG SMELL! I WAS ALL TOO FAMILIAR WITH THIS ISSUE SINCE I HAD ALSO OWNED A 2002 SUBARU WRX WITH APPROXIMATELY 155,000 WHICH INCIDENTALLY WAS COVERED UNDER A RECALL FOR THIS "KNOWN" ISSUE. INTERESTINGLY ENOUGH THERE WAS NO ISSUE WITH RAW GAS SMELL ON THE DAYS THAT WERE WARMER WITH EITHER VEHICLE. I MADE AN APPOINTMENT AT A SUBARU DEALERSHIP IN LONGMONT, COLORADO WHERE THEY ADVISED ME THAT THE FUEL HOSES WERE LEAKING UNDERNEATH THE MANIFOLD AND THAT THE REPLACEMENT PART WAS NOT AVAILABLE AT THE TIME BECAUSE IT WAS BACK ORDERED APPROXIMATELY 6-8 WEEKS. I HAD A FACTORY TRAINED SUBARU TECHNICIAN THAT OWNS HIS OWN SHOP REPLACE A CERTAIN NUMBER OF THE FUEL DELIVERY HOSES WITH ORIGINAL SUBARU REPLACEMENT PARTS SINCE SAID PART WAS BACK ORDERED. I ALSO REPLACED THE LONG BLOCK (SUBARU) ALONG WITH A HOST OF OTHER ITEMS AT THE SAME TIME SINCE THE MOTOR WAS OUT. PRIOR TO GOING TO THE DEALERSHIP I WAS ABLE TO TEST THE VEHICLE'S INTERNAL ATMOSPHERE WITH A TOOL THAT DETECTS THE ENVIRONMENTS AIR QUALITY. THE ATMOSPHERE WAS ABLE TO TRIP THE TOOL SHOWING THAT THE ATMOSPHERE WAS IN A LOWER EXPLOSIVE LIMIT. IMAGINE MY SURPRISE THAT IT WAS THAT BAD. I DETERMINED THAT THIS ISSUE WARRANTED AN IMMEDIATE FIX WITH SUBARU FACTORY PARTS. AS OF THIS LAST WEEK, NOVEMBER 2014, WHEN DENVER HAD RECORD BREAKING COLD WEATHER I HAVE THE SAME ISSUE AGAIN WITH RAW FUEL SMELL. NOW, ONE COULD CONCLUDE THAT THE FACTORY TRAINED TECHNICIAN MADE AN ERROR REPLACING SAID PARTS BUT I HAVE BEEN DRIVING MY VEHICLE WITHOUT ISSUE FOR NEARLY 9 WARM MONTHS. COINCIDENCE??? I'M BEGINNING TO WONDER. THIS FIX SHOULD HAVE BEEN FIXED UNDER A RECALL AS WAS MY 2002 SUBARU WRX. I CALLED S.O.A WITH NO HELP. *TR

• 11/17/2015· FUEL/PROPULSION SYSTEM

  THE FUEL LINES UNDER THE MANIFOLD ON THE PASSENGER SIDE ARE LEAKING FUEL WHEN FIRST STARTING AND IT IS COLD OUTSIDE(BELOW 50F). THE FUMES AND FILLING THE CAB OF THE CAR WHEN THE HEATER IT ON.

• 11/16/2016· POWER TRAINFire

  THE TURBOCHARGER BROKE TWICE IN THE 2D QUARTER 2015. SHORTLY AFTER THE SECOND TIME IT WAS FIXED, THE CAR CAUGHT FIRE OVER THE TURBOCHARGER UNIT (WHILE BEING DRIVEN 9/18/15), UNDER THE HOOD. NEW SUBARUS HAVE BEEN RECALLED FOR THIS REASON, BUT I THINK THE REPLACEMENT TURBOCHARGER WAS DEFECTIVE. THE SUBARU TURBO FP # WAS 14411AA5329L.

• 11/15/2015· FUEL/PROPULSION SYSTEM

  FUEL RAIL HOES CLAMPS/RUBBER LINE IS FAULTY, CAUSING POOLING OF GAS ON THE TOP OF THE ENGINE. MAJOR FIRE HAZARD.

• 11/13/2018· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2004 SUBARU FORESTER. WHILE ATTEMPTING TO START THE VEHICLE IN COLD WEATHER, THE CONTACT NOTICED AN ABNORMAL FUEL ODOR UNDER THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND THE MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

• 11/13/2014· ENGINE,FUEL/PROPULSION SYSTEM

  THE SMELL OF FUEL BECAME OBVIOUS AFTER A 10-15 MINUTE DRIVE. UPON EXAMINATION, THERE WAS FUEL DRIPPING FROM A FUEL LINE. THIS OCCURRED AFTER THE FIRST FREEZE OF THE YEAR, FITTING OTHER DESCRIPTIONS OF THIS ISSUE I FOUND FOR THIS MODEL. *TR