2004 Porsche Cayenne

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2017· FUEL/PROPULSION SYSTEM

  THERE IS AN OPEN RECALL (NHTSA RECALL NUMBER 17V-576) FOR THE FUEL FLANGE ON MY VEHICLE. I PREVIOUSLY PAID OUT OF POCKET FOR THIS REPAIR AND CONTACTED BOTH MY LOCAL DEALERSHIP AND THE CORPORATE CUSTOMER SERVICE FOR INFORMATION ABOUT BEING REIMBURSED AND WAS TOLD THEY NOTIFY ME ABOUT REIMBURSEMENT. I PAID $1995 AND NO ONE WANTS TO DISCUSS REPAYMENT WITH ME. HOW DO I RECOUP MY OUT OF POCKET EXPENSE FOR THIS MANUFACTURERS DEFECT? I HAVE ALL RECEIPTS FOR THIS REPAIR.

• 12/29/2004· VEHICLE SPEED CONTROL

  I OWN A 2004 PORSCHE CAYENNE S AND FROM THE VERY FIRST DAY OF OWNERSHIP THE CAR HAS A SERIOUS HESITATION PROBLEM WHEN ACCELERATING. I HAVE HAD THE CAR SERVICED AT THE PORSCHE DEALERSHIP (MCKENNA IN NORWALK, CA) AND THEY TELL ME THAT THEY ARE VERY AWARE OF THE PROBLEM AND THERE IS NO WAY TO FIX IT. MANY, MANY CAYENNE OWNERS ARE HAVING THE SAME PROBLEM AND PORSCHE REFUSES TO FIX THE PROBLEM. I HAVE HAD SEVERAL NEAR-MISS COLLISIONS BECAUSE OF THE CARS HESITATION WHEN ACCELERATING. PLEASE HELP AND LET ME KNOW THE STATUS OF THIS DANGEROUS ISSUE. THANKS, DEREK DEAN. *NM

• 12/27/2018· STEERING,WHEELS,SERVICE BRAKES

  I HEARD SOME KNOCKING FROM THE AREA OF THE FRONT LEFT WHEEL WHILE DRIVING ON A CITY STREET ABOUT 30 MILES PER HOUR. I STOPPED AND INSPECTED UNDER THE CAR AND SAW NOTHING. SO I DECODED TO BRING IT TO MY SERVICE PROVIDER. I DROVE ABOUT 3 MILES AT SLOW SPEEDS TO GET TO THE SERVICE PROVIDER. AFTER ABOUT AN HOUR THEY FOUND THE PROBLEM. ONE OF THE BOLTS THAT HOLDS THE KNUCKLE TO THE WHEEL HAD BACKED OUT AND WAS BANGING AROUND THE BREAK SYSTEM. THEY SAID I COULD NOT DRIVE THE CAR UNTIL IT WAS FIXED.

• 12/24/2003· SERVICE BRAKES, HYDRAULIC,ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES

  THIS VEHICLE IS A PORSCHE CAYENNE WHICH IS NOT ON YOUR LIST OF VEHICLE MAKE. THIS VEHICLE WAS DELIVERED WITH DEFECTIVE BRAKES AND WIRING PROBLEMS. FACTORY AUTHORIZED DEALER AND SERVICE CO, THOROUGHBRED MOTORCARS, AND DISTRIBUTOR, PORSCHE CARS OF NORTH AMERICA HAVE FAILED TO ADDRESS OR CORRECT DEFECTS IN VEHICLE THAT EXISTED AT THE TIME OF DELIVERY OF THE VEHICLE. *AK THE REAR HATCH DID NOT OPEN FULLY UPON RELEASE OF THE LATCH, BRAKES PULLED TO THE RIGHT AND WOULD GET WORSE WHEN HOT OR WET, PARKING LIGHTS DID NOT FUNCTION PROPERLY, BRAKES GRABBED WITH LITTLE PRESSURE, WARNING ON HIGH BEAM, WARNING ON DIP BEAM, DIP BEAMS FLICKERED THEN WOULD SHUT OFF AND THE TRAILER LIGHTS DID NOT FUNCTION. *SC *JB

• 12/15/2022· STEERING

  The contact owns a 2004 Porsche Cayenne. The contact stated that while the vehicle was taken to the dealer for a recall repair appointment, he noticed that the steering wheel had a quarter inch of play. The U-Joint connection was severely corroded. The dealer diagnosed that the steering column and steering shaft needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 266,969.

• 12/07/2017· FUEL/PROPULSION SYSTEMFire

  TL* THE CONTACT OWNED A 2004 PORSCHE CAYENNE. WHILE PARKED AT HOME, THE VEHICLE CAUGHT FIRE. THE FIRE DEPARTMENT WAS CONTACTED AND THE FIRE WAS EXTINGUISHED. A POLICE REPORT WAS FILED. THE CONTACT'S HOUSE SUSTAINED FIRE DAMAGE. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE VEHICLE WAS PREVIOUSLY TAKEN TO PORSCHE OF NORTH OLMSTED LOCATED 28400 LORAUIN RD, NORTH OLMSTEAD, OH WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V576000 (FUEL SYSTEM, GASOLINE) AFTER THE FAILURE OCCURRED. THE VEHICLE WAS DEEMED DESTROYED. THERE WERE NO INJURIES. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

• 12/03/2010· VEHICLE SPEED CONTROL

  TL*THE CONTACT OWNS A 2004 PORSCHE CAYENNE. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT HEARD A TICKING NOISE FOLLOWED BY A LOUD, THUMPING NOISE WHICH CAUSED THE VEHICLE TO ACCELERATE. THE LOCAL AUTHORIZED DEALER STATED THAT THE BEARING AND DRIVE TRAIN NEEDED TO BE REPLACED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VEHICLE WAS BEING REPAIRED BY THE DEALER. THE VIN WAS UNAVAILABLE. THE CURRENT MILEAGE WAS APPROXIMATELY 93,000. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.

• 12/01/2015· ELECTRICAL SYSTEM

  THIS VEHICLE ALLOWS YOU TO BE LOCKED INSIDE. AFTER DRIVING IF THE DRIVER AND PASSENGER OPEN THEIR DOORS THEN THE LOCK BUTTON IS HIT ON THE KEY (WHILE THE DOORS ARE STILL OPEN), THEN THE DOORS ARE CLOSED ANYONE INSIDE IN UNABLE TO UNLOCK ANY DOORS, EVEN WHEN HITTING THE UNLOCK BUTTON INSIDE THE VEHICLE LOCATED ON THE DOOR. THIS IS A HUGE SAFETY CONCERN.

• 12/01/2005· AIR BAGS

  CIRCLE IMPORTS LONG BEACH, CA A PORSCHE DEALER INSTALLED A NEW STEERING WHEEL ON OUR 04 PORSCHE CAYENNE. IN ONE WEEK TIME ON OCT. 15, 2005 THE AIR BAG IN THE CENTER OF THE WHEEL STARTED COMING LOOSE AND WAS FALLING OFF THE WHEEL. THE REPAIR TO THIS PROBLEM OCCURRED IN JUST A FEW DAYS HOWEVER, WHEN I QUESTIONED WHY THERE WERE NO SENSORS GIVING ME A WARNING, I WAS TOLD THAT NO SENSORS EXIST. WHEN I ASKED THE DEALER TO CONTACT PORSCHE CORPORATE TO PRESENT THIS PROBLEM, I WAS TOLD THERE WAS NOTHING THEY COULD DO. SHORTLY AFTER THAT I EMAILED TO PORSCHE CORPORATE HOWEVER, NO ONE BOTHER TO REPLY. DURING THAT TIME I CALLED THEIR PORSCHE SURVEY CENTER BECAUSE OF A POST CARD I RECEIVED REGARDING THE QUALITY OF SERVICE, AGAIN NO ONE REPLIED TO ME. I HAVE COLOR PHOTOS OF THE DEFECTIVE AIR BAG/STEERING WHEEL AND SERVICE PAPERS SHOWING THAT SERVICE TOOK PLACE ON DATE MENTIONED ABOVE. I WOULD BE GLAD TO SHARE THE PICTURES WITH YOU AND I HOPE SOMEONE CAN GET PORSCHE TO RETROFIT A SENSOR TO THIS PROBLEM. I AM CERTAIN THAT IF WE HAD BEEN INVOLVED IN AN ACCIDENT THE AIR BAG WOULD NOT HAVE WORKED PROPERLY. ONCE YOU SEE THE PICTURES I THINK YOU'LL AGREE WITH MY FINDINGS. IF NEED TO I CAN ALSO PROVIDE 2 WITNESSES THAT DAY THAT SAW FIRST HAND THE DEFECTIVE AIRBAG. BEYOND THIS THE DEALER HAD PUT ON 40 MILES TO MY CAR DURING SERVICE WITHOUT AUTHORIZATION. THIS PORTION I WILL TAKE UP WITH THE BETTER BUSINESS BUREAU UNLESS THIS FALLS IN YOUR JURISDICTION AS WELL AS THE ABOVE SAFETY ISSUE? BEST REGARDS, CHUCK YANG CELL 714-928-2788. *NM

• 11/28/2005· POWER TRAIN

  WHEN MERGING ONTO A FREEWAY OR SIMILAR HIGHWAY, THE VEHICLE WILL SOMETIMES JUST DIE IN RESPONSE WHEN YOU HIT THE GAS PEDAL TO INCREASE SPEED TO MATCH OTHER TRAFFIC. THIS CAUSES OTHER TO TAKE AVOIDANCE ACTION AT HIGHWAY SPEEDS AND ON ONE OCCASION A SEMI NEARLY REAR ENDED ME. *NM

• 11/27/2017· AIR BAGS

  TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE. WHILE THE CONTACT'S BROTHER WAS DRIVING APPROXIMATELY 65 MPH, THE FRONT DRIVER'S SIDE AIR BAG INADVERTENTLY DEPLOYED WITHOUT WARNING OR IMPACT. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOTIFIED AND A CASE WAS OPENED. THE CONTACT WAS ADVISED TO CALL A DEALER FOR A LOANER VEHICLE. THE CONTACT CALLED PORSCHE OF SILVER SPRING AT (888) 462-9925 (3141 AUTOMOBILE BLVD, SILVER SPRING, MD 20904) WHERE IT WAS CONFIRMED THAT NO LOANER VEHICLES WERE AVAILABLE. THE CONTACT THEN CALLED PORSCHE OF ROCKVILLE AT (855) 683-3144 (1125 ROCKVILLE PIKE, ROCKVILLE, MD 20852) AND PORSCHE OF ANNAPOLIS AT (443) 221-6940 (20 HUDSON ST, ANNAPOLIS, MD 21401) WHERE HE WAS ALSO INFORMED THAT NO LOANER VEHICLES WERE AVAILABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 166,000.

• 11/27/2010· ENGINE AND ENGINE COOLING

  THE PORSCHE CAYENNE (AND OTHER PORSCHE MODELS) HAVE A COOLANT LEAK PROBLEM. MY VEHICLE'S "LOW COOLANT LEVEL" LIGHT CAME ON. I CHECKED THE COOLANT LEVEL AND FOUND IT TO BE SEVERELY LOW. THE PORSCHE DEALER SERVICE (AND ON-LINE FORUMS) REPORT THAT PORSCHE CAYENNE ENGINES ARE ENCOUNTERING A COOLANT LEAK PROBLEM THAT APPEARS TO AFFECT ALL CAYENNE S, CAYENNE TURBO AND CAYENNE TURBO S ENGINES BUILT FROM 2003 TO 2006 (MY VEHICLE IS A 2004 MODEL). THE COOLANT LEAK PROBLEM IS LOCATED IN THE PLASTIC COOLANT PIPES LOCATED UNDER THE INTAKE MANIFOLD OF THE ENGINE. ACCORDING TO THE PORSCHE DEALER, THIS IS A COMMON PROBLEM DUE TO THE PLASTIC MATERIAL USED BY PORSCHE (WHICH HAS SINCE BEEN CHANGED TO A METAL MATERIAL) AND THE PLASTIC FITTINGS. THE LACK OF COOLANT CAN CAUSE THE ENGINE TO OVERHEAT, OR EVEN BLOW AN ENGINE, WHICH CAN BE EXTREMELY DANGEROUS IF THIS OCCURS WHILE DRIVING. IN ORDER TO CORRECT THE PROBLEM, PORSCHE SERVICE SAYS THAT THE COOLANT PIPES MUST BE REPLACED, WHICH IS A VERY LABOR AND PARTS INTENSIVE SERVICE COSTING WELL OVER $1,000. *TR

• 11/23/2005· ENGINE AND ENGINE COOLING

  PORSCHE-04 CAYENNE ON OCCASIONS STALLS ON TURNING AND TOUCHING BRAKE AND TWICE ON THE FREEWAY GOING STRAIGHT BUT BRAKING AND PUSHING ON THROTTLE NO POWER FOR A FEW SECONDS. *JB

• 11/22/2004· TIRES

  THE CONSUMER NOTICED THE DRIVER AND PASSENGER SIDE TIRES HAD WIRES COMING OUT FROM THEM. THE CONSUMER HAD THE TRUCK TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT ALL FOUR TIRES NEEDED REPLACEMENT DUE TO TREAD SEPARATION AND WARE AND TEAR. THE PIRELLI PO ROZOSSO 275/45CR191084N0/DOT NUMBER XNR3D631D103. PLEASE FILL IN ADDITIONAL INFORMATION. *JB

• 11/20/2019· POWER TRAINCrash

  2004 PORSCHE CAYENNE. CONSUMER WRITES IN REGARDS TO TRANSMISSION SHIFT LEVER SAFETY RECALL. *LD THE CONSUMER STATED THE VEHICLE WAS PARKED AND ROLLED INTO ANOTHER VEHICLE WHICH, THEN CRASHED INTO A VEHICLE. THE TRANSMISSION SHIFT LEVER FAILED AND WAS REPLACED. THE CONSUMER REQUESTED TO BE REIMBURSED FOR THE REPAIRS TO THE VEHICLES. *JS *JS - (RECALL RELATED INCIDENT) TS

• 11/18/2013· ENGINE

  OWNER OPERATES A 2004 PORSCHE CAYENNE TURBO, 4.5L V8 ENGINE. THIS VEHICLE, WITH JUST OVER 61,000 MILES BEGAN TO OVERHEAT FOUR DAYS PRIOR TO THE INCIDENT (DETECTED BY FLUCTUATING TEMPERATURE GAUGE). THE ENGINE COOLANT WAS FOUND TO BE LOW IN THE SERVICE BOTTLE BY APPX. 2 QUARTS WHEN CHECKED AND WAS REFILLED. THE EVENING BEFORE THE INCIDENT OWNER'S SPOUSE REPORTED A LOW COOLANT ALARM MESSAGE HAD DISPLAYED ON THE INSTRUMENT PANEL, COOLANT WAS ABOUT 2 QUARTS LOW IN THE SERVICE BOTTLE AND WAS REFILLED. THE NEXT DAY THE VEHICLE WAS BEING RUN AT 1500 RPM (FAST IDLE) IN A PARKED POSITION IN THE OWNER'S DRIVEWAY FOR A TEST WHEN A FLOOD OF ENGINE COOLANT WAS OBSERVED COMING FROM THE UNDERSIDE OF THE VEHICLE. VEHICLE ENGINE WAS IMMEDIATELY SECURED TO AVOID DAMAGE. AT THIS POINT THE VEHICLE WOULD NOT BE CONSIDERED DRIVABLE AND WOULD NEED TO BE TOWED TO A SERVICE FACILITY. AN INVESTIGATIVE TEARDOWN REVEALED A RUPTURED PLASTIC COOLING PIPE INSIDE THE VALLEY OF THE ENGINE, THIS FAILURE REQUIRED REMOVAL OF THE INTAKE MANIFOLD TO DIAGNOSE AND IS NOT A ROADSIDE-REPAIRABLE EVENT. THE EVENT CAUSED LOSS OF MORE THEN 50% OF TOTAL COOLANT VOLUME AS ONLY APPX. 1 GALLON WAS RECOVERED FROM THE VEHICLE PRIOR TO TEARDOWN. A PRESCRIBED REPAIR KIT FOR THIS FAILURE (REPLACEMENT COOLING PIPES KIT) WAS OBTAINED FROM SONNEN PORSCHE, SAN FRANCISCO CA AND INSTALLED BY VEHICLE OWNER. AFTER FILLING OF COOLANT AND TEST DRIVING, NO FURTHER PROBLEM WAS NOTED. *TR

• 11/17/2009· SUSPENSION

  TL*THE CONTACT OWNS A 2004 PORSCHE CAYENNE TURBO. THE AIR SUSPENSION COLLAPSED WHILE DRIVING 70 MPH. THE AIR SUSPENSION BAG ALSO EXPLODED WHICH CAUSED THE VEHICLE TO MOVE UNCONTROLLABLY FROM THE RIGHT TO THE LEFT LANE. THE VEHICLE ALMOST ROLLED OVER DUE TO THE FAILURE. THE CONTACT WAS ABLE TO DRIVE TO THE DEALER WHO STATED THAT IT WAS A MANUFACTURERS DEFECT. THE DEALER ALSO CONFIRMED THAT THE COLLAR WHICH IS METAL SPLIT AND PUNCTURED THE SUSPENSION BAG. THE VEHICLE WILL BE REPAIRED; HOWEVER, THE SUSPENSION WAS NOT COVERED BY THE WARRANTY. THE FAILURE MILEAGE WAS 43,000. UPDATED 2/17/10 *CN UPON INSPECTION, IT WAS DISCOVERED THAT THE COLLAR ON THE AIR SUSPENSION BELLOW ON THE RIGHT FRONT HAD SHEARED AND PUNCTURED THE AIR SUSPENSION BAG THAT CAUSED THE SUSPENSION TO DROP SUDDENLY. UPDATED 02/22/10.

• 11/13/2008· ELECTRICAL SYSTEM

  HORN DOSE NOT WORK, NAVIGATION SYSTEM NOT FUNCTIONING PROPERLY, RADIO NO LONGER WORKS. REFERENCE CAMPAIGN ID 04V069000. *TR

• 11/11/2022· FUEL/PROPULSION SYSTEM

  There is a significant smell of gasoline inside the cabin of the vehicle. There was a recall on the same make, model, and year for fuel pump filter flange leaks, which are indicative of a strong smell of gas inside the car. This can potentially cause the car to start on fire. The dealer stated due to the VIN, the vehicle was not covered under the existing recall.

• 11/09/2009· SUSPENSION

  DRIVING ON A HIGHWAY AT AROUND 64 MILES PER HOUR WHEN THE ENTIRE FRONT TRANSMISSION DROPPED AND WE NEARLY ROLLED OVER ON OUR VEHICLE WITH A 4 YEAR OLD CHILD IN THE CAR ON THE HIGHWAY. FORTUNATELY WE WERE IN THE LEFT LANE WHEN THIS HAPPENED. *TR

• 11/02/2022· FUEL SYSTEM, GASOLINE,POWER TRAIN,EXTERIOR LIGHTING

  The contact owns a 2004 Porsche Cayenne. The contact received notification of NHTSA Campaign Numbers: 22V656000 (Exterior Lighting), 19V446000 (Power Train), and 17V576000 (Fuel System, Gasoline) however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the fuel gauge failed to read accurately. The headlamp wiring had been deteriorating causing the headlights to malfunction. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 170,000. Parts distributions disconnect.

• 11/02/2015· UNKNOWN OR OTHER,ENGINE

  PORSCHE LURCHES,JERKS,THUDS,INTERMITTENT POWER LOSS WHEN ACCELERATING TO PASS ANOTHER CAR. ENGINE,TRANSMISSION/TURBO SYSTEM FAULTY AND HAZARDOUS AS POWER LOSS OCCURS WHEN QUICK SPEED-UP WHEN PASSING POWER IS CRITICALLY NEEDED. THIS POWER FAILURE PROBLEM HAS OCCURRED SINCE CAR WAS BOUGHT NEW IVY ME IN 2004.

• 11/02/2012· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE S. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR AN UNRELATED REPAIR. THE TECHNICIAN SMELLED AN ODOR OF FUEL OUTSIDE OF THE VEHICLE AND DETECTED THAT A SUBSTANTIAL AMOUNT OF FUEL LEAKED ONTO THE GROUND CONTINUOUSLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 91,000.

• 11/01/2004· VEHICLE SPEED CONTROL

  WHILE TURNING ACROSS TRAFFIC FROM E 2ND AVE ONTO JOSEPHINE ST. THE ACCELERATOR PEDAL WAS DEPRESSED TO THE JUST ABOVE THE FLOOR AND NO DISCERNABLE ACCELERATION RESPONSE WAS NOTICEABLE FOR A SECOND OR TWO. WHEN THERE WAS AN ACCELERATION RESPONSE IT WAS AN EXPLOSIVE, 'OFF TO THE RACES' ONE. THIS INCIDENT TOOK PLACE AFTER THE DEALER ADVISED THAT: UNOFFICIAL FIXES (DME UPDATE AND TRANSMISSION ADAPTATION) ISSUE HAD BEEN IN PLACE SINCE THE DELIVERY OF THE VEHICLE; VEHICLE HAD BEEN INTO THE DEALER TO EVALUATE/ADDRESS THIS ISSUE THREE TIMES; ON THE THIRD VISIT THE TRANSMISSION CONTROL MODULE WAS REPLACED/UPDATED/ADAPTED AND DME CONTROL UNIT WAS REMAPPED.*AK

• 11/01/2004· VEHICLE SPEED CONTROL

  WHILE MERGING FROM HIGHWAY 141 ONTO I-70 THE ACCELERATOR PEDAL WAS DEPRESSED TO ACCELERATE FROM HIGHWAY SPEED TO MERGE INTO INTERSTATE TRAFFIC AND NO NOTICEABLE ACCELERATION WAS APPARENT. THE EXTREMELY CONCERNING ABOUT THIS INCIDENT WAS THAT THIS MERGE WAS BEING EXECUTED BETWEEN TWO 18-WHEELERS. WHILE THERE WAS AMPLE SPACE TO MERGE IF THE VEHICLE HAD RESPONDED WITHOUT HESITATION TO ACCELERATOR PEDAL INPUTS, THE EXPERIENCED HESITATION MADE THE MERGE DICEY.*AK

• 11/01/2004· VEHICLE SPEED CONTROL

  WHILE PULLING OUT FROM A PARKING LOT INTO MAJOR CITY STREET THE VEHICLE HESITATED TO RESPOND TO ACCELERATOR INPUT WITH APPROACHING TRAFFIC.*AK THE VEHICLE MOVED OFF FROM A STOP AND INTO THE CLOSEST LANE FINE BUT WOULD NOT ACCELERATE AS MORE ACCELERATOR PEDAL WAS APPLIED. THERE WAS NOTICEABLE DELAY/HESITATION, AS TRAFFIC BORE DOWN ON ME, BEFORE THE CAYENNE DECIDED TO ACCELERATE. CONTACTED DEALER WHO NOTED THAT THERE WAS AN UNOFFICIAL FIX THAT MAY ADDRESS THE ISSUE.

• 10/20/2005· ENGINE AND ENGINE COOLING,AIR BAGS

  DT: THE AIR BAG AND THE CHECK LIGHTS CAME ON. THE CONSUMER CONTACTED THE DEALER AND THEY SAID THEY COULD NOT SERVICE THE CAR UNTIL 10/17/2005. CALLED PORSCHE CUSTOMER SERVICE, AND THEY SAID THEY COULD HELP. THE CONSUMER BELIEVED THIS WAS A SAFETY HAZARD, AND HE DID NOT WANT TO DRIVE THE CAR.*AK *JB

• 10/19/2018· POWER TRAIN

  TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE. WHILE DRIVING AND ACCELERATING, THE DRIVESHAFT MALFUNCTIONED, WHICH CAUSED THE VEHICLE TO WOBBLE AND SHAKE. THE CONTACT CALLED MOMENTUM PORSCHE (10155 SOUTHWEST FWY, HOUSTON, TX 77074, (844) 894-5470) AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 180,000.

• 10/14/2014· ENGINE

  ENGINE COOLANT HOSES ARE LEAKING ANTIFREEZE. EVERYTIME I POUR ANTIFREEZE INTO THE CAR IT COMES OUT, IM AFRAID IT MIGHT DAMAGE SOMETHING ELSE, LIKE THE ENGINE ETC. THEY HAVE PLASTIC HOSES ON THEM. *TR

• 10/12/2005· POWER TRAIN

  DT: THE CONTACT OWNS A 2004 PORSCHE CAYENNE S. WHILE DRIVING UP A HILL AT SLOW SPEEDS THE VEHICLE WILL FEEL AS IF THE TRANSMISSION IS GOING IN AND OUT OF GEAR. THIS CAUSES THE VEHICLE TO JERK, AND MAKES IT DIFFICULT TO CONTROL THE VEHICLE. THIS HAPPENS INTERMITTENTLY WHETHER IT IS WARMER OR COLDER TEMPERATURES. THE SERVICE DEALER REPROGRAMMED THE ELECTRONIC CONTROL MODULE, , BUT THIS DID NOT REMEDY THE PROBLEM. THE SERVICE DEALER ATTEMPTED TO REPAIR THE PROBLEM NUMEROUS TIMES. THE ATTEMPTS TO REPAIR THE PROBLEM INCLUDED, UPDATING AND THE REPLACEMENT OF THE TRANSMISSION CONTROL UNIT. THIS STILL DID NOT REMEDY THE PROBLEM. THE DEALER REPORTED THE PROBLEM TO THE MANUFACTURER, AND THEY SENT A TECHNICIAN TO DETERMINE THE PROBLEM. THE TECHNICIAN REPRODUCED THE PROBLEM, AND SAID THAT IT WAS A CONDITION OF HILL HOLDER FUNCTION WHICH HOLDS THE VEHICLE IN PLACE TO APPROXIMATELY 800-1100 RPMS, AT WHICH IT WILL START TO ENGAGE THE TRANSMISSION. THE MANUFACTURER STATED THAT THIS WAS A NORMAL OPERATING PROCEDURE FOR THIS TYPE OF VEHICLE WHEN THE VEHICLE WA SCOLD. THE CONTACT REQUESTED FOR THE MANUFACTURER TO SUBMIT THE REASON WHY THIS WAS NORMAL OPERATING PROCEDURES FOR THE VEHICLE. THE REMEDY FROM THE MANUFACTURER WAS FOR THE CONTACT TO ACCELERATE MORE WHEN GOING UP A HILL. THE SECOND EXPLANATION THE MANUFACTURER OFFERED WAS THAT THE JERKING OF THE VEHICLE WAS CAUSED BY OUTSIDE TEMPERATURES. THE CALIFORNIA NEW MOTOR VEHICLE BOARD REQUESTED THAT THE SECOND EXPLANATION BE PUT INTO WRITING, BUT THE MANUFACTURER REFUSED. ANOTHER SAFETY CONCERN BOTHERING THE CONTACT WAS THAT WHILE DRIVING AND UPON ACCELERATION THE VEHICLE WILL STALL. WHEN ACCELERATING NOTHING WILL HAPPEN, THE ENGINE WILL COMPLETELY LOSE POWER. THE SERVICE DEALER STATED THIS WAS TRANSMISSION CONTROL., BUT THE REPAIRS DID NOT SOLVE THE PROBLEM. *AK

• 09/21/2018· ENGINE

  2004 PORSCHE CAYENNE S. CONSUMER WRITES IN REGARDS TO REIMBURSEMENT FOR VEHICLE FIRE DAMAGES. *AS *JS

• 09/21/2005· STEERING,TIRES

  DT: THERE WAS VIBRATION THAT AFFECTED THE STEERING COLUMN, AND IT WAS FELT THROUGH OUT THE STEERING WHEEL. ONE COULD FEEL VIBRATION WHEN THE VEHICLE ONLY HAD FORTY-TWO MILES ON IT. ONE COULD HEAR A NOISE WHEN MAKING A RIGHT OR LEFT HAND TURNS. THIS VEHICLE WAS PURCHASED ON AUGUST 28, 2004, AND WAS AT THE DEALERSHIP ON AUGUST 31, 2004. THE DEALER BALANCED THE TIRES. ON SEPTEMBER 27, 2004 IT WAS BACK AT THE DEALER FOR VIBRATION, AND THE DEALER SAID THE TIRES WERE WORN OUT. THEY ATTEMPTED TO FIX THE VEHICLE SIX DIFFERENT TIMES. THEY REMOVED AND REPLACED THE STEERING COLUMN, AND PUT ON NEW TIRES AND WHEELS. BUT STILL WAS HAVING THIS PROBLEM. CONSUMER IS A PRIVATE INVESTIGATOR FOR THE STATE OF CALIFORNIA, AND HE WANTED TO ADD THAT DURING AN ARBITRATION HEARING PORSCHE WAS UPSET WITH THE MENTIONING OF NHTSA. *AK

• 09/17/2009· ELECTRICAL SYSTEM

  THE REAR BRAKE LIGHTS (LEFT, RIGHT AND HIGH MOUNTED) REMAIN LIT AT ALL TIMES, AS DOES THE REAR RIGHT AND LEFT FOG LIGHTS. TURNING LIGHTS ON OR OFF HAS NO EFFECT. DEPRESSING THE BRAKE PEDAL HAS NO EFFECT. THIS PROBLEM HAS OCCURRED RANDOMLY AND INCONSISTENTLY AND WHEN THE CAR HAS BEEN UNOCCUPIED AND UNATTENDED AS WELL AS WHILE DRIVING. WHILE UNATTENDED, THE LIGHTS COMING ON DRAINS THE BATTERY AND CAN STRAND THE DRIVER. IF PROBLEM OCCURS AND THE BATTERY IS NOT DRAINED, THE DRIVER MAY BE WHOLLY UNAWARE OF THE PROBLEM AND MAY DRIVE WITH THE BRAKE AND REAR FOG LIGHTS LIT. THIS PROBLEM ALSO CREATES A MAJOR SAFETY HAZARD AS THE BRAKE LIGHT REMAIN ON AT ALL TIMES. FOLLOWING DRIVERS HAVE NO WAY OF KNOWING THAT THE DRIVER MAY BE BRAKING AND COULD RESULT IN A SERIOUS AND POTENTIALLY FATAL REAR END COLLISION. THE DRIVER OF THE CAYENNE, IS NOT AWARE OF THE PROBLEM. NO WARNING LIGHTS ARE ILLUMINATED TO MAKE THE DRIVER AWARE. IF PROBLEM IS NOTICED, REMOVING THE FUSES FOR THE FOG LIGHTS AND THE BRAKE LIGHTS CORRECTS THE ISSUE, BUT MUST BE REINSERTED, ALLOWING FOR THE PROBLEM TO REOCCUR. VEHICLE BUILD DATE WAS 12/03 AND OUTSIDE OF THE PORSCHE WIRING HARNESS RECALL, BUT THIS MAY BE THE RESULT OF A FAULTY WIRING HARNESS FEEDING THE REAR OF THE VEHICLE. *TR

• 09/10/2007· POWER TRAIN

  CAR WAS DRIVING NORMAL. PARKED IN GARAGE AND 2 HOURS LATER TOOK BACK OUT FOR SHORT DRIVE. REACHING 25 MPH, CAR BEGIN SHAKING VIOLENTLY AND THAN AS ACCELERATED FURTHER STOPPED SHAKING. PULLED OVER, THAN ACCELERATED AGAIN SLOWLY, CAR BEGIN SHAKING AT APPROX 50 MPH. SLOWED AGAIN. AND CAR CONTINUED TO SHAKE VIOLENTLY AT VARIOUS SPEEDS. TOOK TO INDEPENDENT PORSCHE SHOP, AND WAS DIAGNOSED AS "FAILED DRIVE SHAFT CENTER BEARING". *TR

• 09/06/2019· POWER TRAIN

  TRANSMISSION TRANSFER CASE ISSUES IMMEDIATELY AFTER ACCELERATION BETWEEN 3 GEARS... CAR TRANSMISSIONS "STUMBLES" (TRANSMISSION LOCKING). WELL KNOWN ISSUE IN THE PORSCHE COMMUNITY AND PORSCHE SOLUTION IS DOES NOT FIX THE ISSUE. NO ENGINE ERROR CODES ISSUED AS WELL. PORSCHE SAYS CANNOT DUPLICATE PROBLEM. THIS HAS BEEN HAPPENING FOR QUITE A WHILE UNTIL I RESEARCHED THE ISSUES ONLINE. PREVIOUSE RECALL # 03V351000 - PORSCHE WILL NOT CURRENTLY HONOR THIS RECALL.

• 09/02/2014· POWER TRAIN,ENGINE

  UPON TAKING THE VEHICLE OUT OF THE DRIVEWAY I STARTED HEARING A TICKING SOUND COMING FROM THE ENGINE, SOMETHING LIKE A LIFTER HITTING THE BLOCK. I PULLED BACK IN TO MY DRIVEWAY AND CALLED A REPAIR SHOP AND SCHEDULED AN APPOINTMENT. WHEN MEETING WITH THE TECHNICIAN I WAS INFORMED THAT THE ENGINE HAD A SCORED CYLINDER AND THAT IT IS A COMMON ISSUE WITH THE MODEL AND YEAR. THE ONLY RECOURSE TO FIX THE ISSUE WOULD BE TO REPLACE THE ENGINE. A REPLACEMENT ENGINE WOULD COST $17 -35,000 - MORE THAN THE VEHICLE IS WORTH. IF I WERE TO REPLACE IT WITH A USED ENGINE, I WOULD BE DESTINED FOR A REPEAT OF THE SAME ISSUE. IF THIS ISSUE IS SUCH A COMMON PROBLEM WHY HAS THERE NOT BEEN A RECALL FOR THESE VEHICLES? I HAVE CONTACTED THE MANUFACTURER AND WAS TOLD THAT I WOULD NEED TO HAVE A AUTHORIZED SERVICE DEALERSHIP MAKE THE DIAGNOSIS I HAVE ALREADY BEEN TOLD, BUT THERE IS NOT A AUTHORIZED DEALERSHIP WITHIN 500 MILES OF MY LOCATION. *TR

• 09/02/2005· SUSPENSION,ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM,VISIBILITY,STRUCTURE,EQUIPMENT

  2004 PORSCHE CAYENNE HAD THE FOLLOWING REPAIRS PERFORMED ON THE VEHICLE: REAR HATCH LID ADJUSTED, DOME LIGHT COVERS REPLACED, AUDIO UNIT REPLACED, ETC...***NO ANSWER REQUIRED***. *MR THE TRANSMISSION JERKS AND BANGED AT SLOW SPEEDS. THE DEALER UPDATED THE TRANSMISSION CONTROL UNIT. THE VEHICLE ALSO EXPERIENCED STALLING PROBLEMS. THE REMOTE ENTRY REMOTE LOST IT'S PROGRAMMING AND HAD A POOR SIGNAL. AT TIME ALL THE DOOR LOCKS WOULD NOT UNLOCK USING THE KEYLESS ENTRY SYSTEM. THE VEHICLE EXPERIENCED SUSPENSION PROBLEMS. THE REAR HATCH LIGHT WOUOLD NOT TURN OFF BECAUSE THE HATCH WAS MISADJUSTED. THE CONSUMER FELT THAT THE HORN WAS NOT LOUD ENOUGH. THE VEHICLE SHIMMIED AT HIGHWAY SPEEDS AND A VIBRATION COULD BE FELT IN THE STEERING WHEEL. THE HEADLAMPS FOGGED UP. THE DRIVER'S SIDE MIRROR OULD NOT FOLD IN AUTOMATICALLY. THE RADIO AND OTHER ACCESORIES WOULD NOT TURN OFF WHENT HE KEY WAS REMOVED FROM THE IGNITION. THE HOOD WAS HAD TO RAISE BECAUSE THE TAILGATE SHOCKS FAILED. THE REAR HATCH WOULD NOT CLOSE BECAUSE IT WAS MISALIGNED. THE REAR ROOF MOLDING WOULD NOT STAY IN PLACE. THE RADIO PRODUCED NO SOUND AT TIME IN THE RADIO OR CD MODE. THE INSTRUMENT CLUSTER HAD TO BE UPDATED. THE SUNROOF WOULD NOT CLOSE FLUSH WITH THE ROOF. THE VEHICLE HAS BEEN OUT OF SERVICE FOR A TOTAL OF 32 DAYS SINCE THE VEHICLE WAS PURCHASED. *NM

• 08/28/2008· FUEL SYSTEM, GASOLINEFire

  PORSCHE CAYENNE TURBO CAUGHT FIRE IN THE ENGINE COMPARTMENT WHILE DRIVING ON THE 101 FREEWAY. EXPERT DETERMINED THAT THE CAUSE WAS THE FUEL HOSE FAILING WHERE IS CONNECTS TO THE ENGINE MOUNTED FUEL SYSTEM. *TR

• 08/24/2023· POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  Strong odor of gasoline traveling through the vents injected into vehicle. Fuel filter has a crack. Underhood electrical problems that may cause a fire

• 08/23/2013· TIRES

  TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE S. THE CONTACT STATED THAT THE TREAD WALL SEPARATED ON ALL FOUR OF THE TIRES. THE TIRES WERE INSPECTED BUT WERE NOT DIAGNOSED. THE TIRES HAD NOT BEEN REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 129,000. THE TIRE FAILURE MILEAGE WAS UNKNOWN. UPDATED 10/17/13*LJ THE CONSUMER PURCHASED THE TIRES FROM A TIRE RETAILER. THE TIRE SEPARATED ON THE SIDE WALL PREMATURELY.

• 08/22/2018· FUEL SYSTEM, GASOLINE

  2004 PORSCHE CAYENNE. CONSUMER WRITES IN REGARDS TO ISSUES WITH THE FUEL FILTER FLANGE SAFETY RECALL. *LD THE CONSUMER STATED THE FUEL FILTER FLANGE COULD NOT BE REPLACED WITHOUT REPLACING THE FUEL TANK AND THE FUEL LINE. THE CONSUMER REQUESTED THAT MANUFACTURER INCUR THE REPAIR COSTS. *JS

• 08/03/2014· ELECTRICAL SYSTEM,STRUCTURE

  DRIVER SIDE DOOR WILL NOT OPEN FROM INSIDE OR OUTSIDE WITHOUT WARNING LUCKILY IT HAPPENED TO MY YOUNG SON SO HE COULD GET OUT AND GET IN FROM OTHER DOOR TO DRIVE TO DEALER. DEALER HAD TO REPLACE THE NEW DOOR LOCK, ACCORDING TO DEALER SAME THING HAD HAPPENED TO FEW CARS.IN THE PAST. MY CONCERN IS WHAT WOULD HAVE HAPPENED IS IT WAS ME OR MY WIFE , WE ARE NOT FLEXIBLE ENOUGH TO GET OUT FROM OTHER DOORS. WHAT HAPPENS IN CASE OF EMERGENCY WHEN YOU CAN NOT OPEN THE DOOR. IT IS A SAFETY ISSUE AND DOOR LOCKS SHOULD BE RECALLED FOR OLDER MODELS THERE SHOULD ALWAYS BE WAY TO OPEN DRIVERSIDE DOOR MANUALLY IN CASE OF EMERGENCY. *TR

• 07/23/2004· SUSPENSION

  PROBLEMS WITH TIRE EQUIPMENT ON 2004 CAYENNE.*MR THE VEHICLE'S FRONT TIRES WERE WORN AT A LITTLE OVER 10000 MILES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS LATER DETERMINED THAT THERE WAS A RECALL ON THE FRONT END ALIGNMENT THAT POSSIBLY CAUSED THE TIRES TO WEAR PREMATURELY. THE MANUFACTURER AGREED TO SPLIT THE DIFFERENCE OF THE PRO-RATED COST. THE CONSUMER REQUEST REIMBURSEMENT FOR THE TIRES HE HAD TO REPLACE AND WOULD LIKE PORSCHE TO BUT OUT THE REMAINING TIME ON HIS LEASE. *NM

• 07/21/2006· ENGINE AND ENGINE COOLING

  DT*: THE CONTACT STATED THE VEHICLE PERFORMS AS IF IT WILL STALL WHILE ACCELERATING IN TRAFFIC. THE VEHICLE HAS NEVER ACTUALLY STALLED, BUT HESITATES DURING ACCELERATION. THE HESITATION OCCURS MOSTLY WHEN VEHICLE IS MAKING TURNS. THIS IS A RECURRING INCIDENT WHICH OCCURS DAILY.

• 07/19/2011· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE S. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, AN OVERHEATING INDICATOR LIGHT BEGAN TO ILLUMINATE ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN DIRECTLY TO AN INDEPENDENT REPAIR SHOP WHERE ENGINE COOLANT WAS ADDED TO THE VEHICLE. WHILE ADDING THE COOLANT, THE TECHNICIANS NOTICED THAT THE COOLANT WAS LEAKING OUT THROUGH ITS PLASTIC TUBING. THE VEHICLE WAS THEN TOWED TO AN AUTHORIZED DEALER WHERE THE PLASTIC TUBING FOR THE ENGINE COOLANT WAS BEING REPLACED WITH ALUMINUM TUBING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 54,500.

• 07/17/2018· FUEL/PROPULSION SYSTEM

  RECEIVED RECALL NOTICE FOR FILTER FLANGE OF FUEL PUMP. CALLED DEALER WHO SAID DID NOT HAVE REPAIR PARTS AND DOES NOT KNOW WHEN THEY WILL GET THEM. CALLED PORSCHE U.S. AND THEY TOLD ME THE SAME THING. NO DATE FOR RECEIVING PARTS OR REPAIRING MY CAR.

• 07/12/2012· ENGINE

  WHILE DRIVING CHECK ENGINE LIGHT ON AND VEHICLE LACK POWER. DROVE TO INDEPENDENT REPAIR SERVICE, REPLACED 8 IGNITION COILS AND 8 SPARK PLUGS TO CORRECT PROBLEM. ALL IGNITION COILS CRACKED. *TR

• 07/12/2012· ENGINE

  DRIVING VEHICLE, HEARD NOISE AND ENGINE LIGHTS ON. STOP CHECK ENGINE, BELTS OFF. TOW TO SERVICE FACILITY. WATER PUMP PULLEY WAS FOUND TO SPLIT, MADE OF FIBER. REPLACED PULLEY AND MULTI RIB BELT. *TR

• 07/12/2012· STRUCTURE

  REAR LIFT GATE WOULD NOT STAY OPEN. DROVE TO INDEPENDENT REPAIR SERVICE, REPLACED BOTH REAR LIFTGATE SHOCK SUPPORTS. PORSCHE WOULD NOT COVER REPAIRS. *TR

• 07/12/2012· ENGINE

  DRIVING ON INTERSTATE HIGHWAY, CHECK ENGINE AND ADD COOLANT LIGHTS ON. STOPPED ADDED COOLANT, DROVE HOME PARKED IN DRIVEWAY. OUT TO USE CAYENNE AGAIN, NOTICED COOLANT ON DRIVEWAY, STARTED ENGINE COOLANT LEAK ALLOVER DRIVE. CALLED PORSCHE DEALER, NOT COVERED UNDER WARRENTY, ALSO 2 WEEK BACKLOG IN GETTING REPAIR, CALL INDEPENDENT SERVICE AND HAD TOW TO INDEPENDENT GARAGE. REPLACE ALL COOLANT PIPES AND WATER PUMP. AFTER REPAIR "INTERNAL ENGINE NOISE". OK TO DRIVE. *TR