2004 Mercury Mountaineer

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2013· AIR BAGS

  TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE DRIVER AND PASSENGER'S SIDE CURTAIN AIR BAGS DEPLOYED ERRONEOUSLY. THE CONTACT SUSTAINED INJURIES TO THE BACK AS A RESULT. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE AIR BAGS NEEDED TO BE REPLACED AND RESET. IN ADDITION, THE LINER AROUND THE WINDOWS AND THE SAFETY CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE WAS 107,000. ...UPDATED 03/07/14 *BF

• 12/29/2005· POWER TRAIN

  I HAVE HAD REPEATED PROBLEMS WITH THE TRANSMISSION I.E. A NOTICEABLE CLUNK WHEN THE TRANSMISSION SHIFTS FROM OVERDRIVE TO LOW UPON APPROACHING A STOP SIGN. ADDITIONALLY, WHEN BACKING AND SHIFTING TO FORWARD THE TRANSMISSION HESITATES AND SLIPS BEFORE GOING INTO FORWARD DRIVE. THIS CAUSES SOME ANXIETY WHEN YOU HAVE TO BACK FROM A COMMERCIAL BUSINESS INTO A BUSY TRAFFIC WAY AND THE TRANSMISSION SLIPS LEAVING YOU NOT KNOWING IF YOUR GOING TO BE ABLE TO AVOID APPROACHING TRAFFIC FROM THE REAR. I HAVE REPORTED THE PROBLEM TO COLORADO RIVER FORD IN ON AT LEAST TWO DIFFERENT OCCASIONS AND HAVE HAD THE TRANSMISSION FLUID REPLACED IN ACCORDANCE WITH MERCURY'S RECALL. HOWEVER, THE PROBLEM CONTINUES. SUBSEQUENTLY,I HAVE CHANGED TO BRADLY FORD FOR REPAIRS. ON ONE OCCASION IMMEDIATELY AFTER A RAIN STORM AND WHILE TRAVERSING A HIGHWAY WASH, I SLOWED THE VEHICLE AND STRADDLED THE CENTER LINE (NO TRAFFIC) TO AVOID ANY STANDING WATER. ADMITTEDLY, THERE WAS MUD RESIDUE ON THE FAR SIDE OF THE WASH. REGARDLESS, AS I EXITED THE WASH AND ACCELERATED THE TRANSMISSION SHIFTED FROM OVERDRIVE TO LOW GEAR CAUSING THE REAR WHEELS TO SPIN AND I WENT INTO A BROAD SIDE SKID TO THE RIGHT AND BACK TO THE LEFT AND TO THE RIGHT AGAIN, ALL OF WHICH WAS AS CLOSE TO A NEAR ACCIDENT AS I WANT TO EXPERIENCE. AS A RETIRED ARIZONA HIGHWAY PATROLMAN I WILL ADMIT THAT MY SPEED WAS TOO FAST FOR THE CONDITIONS (ESTIMATED SPEED 30 TO 40 MPH). HOWEVER, I AM ALSO OF THE OPINION THAT THE SHIFTING PATTERN OF THE VEHICLE ADDED TO THE MOMENTARY LOSS OF CONTROL. REGARDLESS, AT THIS POINT THE VEHICLE REGISTERS 35,500 MILES AND BRADLY FORD IN LAKE HAVASU CITY IS GOING TO ATTEMPT TO RECTIFY THE PROBLEM. THEY WILL BE TEARING DOWN THE TRANSMISSION FOR EXAMINATION. THIS IS AFTER THEY HAVE ALREADY REPLACED A PRESSURE SOLENOID AND THE PROBLEM STILL CONTINUES. I DO NOT BELIEVE THE REPAIR WILL RELIEVE THE PROBLEM AND WILL RESULT IN MY TAKING A FINANCIAL LOSS WHEN I TRADE THE VEHICLE IN. *NM

• 12/28/2014· STRUCTURE

  EVERY TIME IT RAINS, EVEN JUST A SPRINKLE, WATER COMES IN FROM TOP OF DRIVER'S SIDE DOOR/ROOF. IT ALSO COMES IN THROUGH THE DOME LIGHT AND VISOR. MY FLOORBOARD IS FLOODED WITH WATER. I HAVE TRIED TO USE A CAR COVER AND IT DOES NOT WORK. I CAN NOT AFFORD AT THIS TIME TO BRING INTO A DEALERSHIP. THIS PROBLEM IS GOING TO DESTROY THIS VEHICLE. *TR

• 12/28/2010· POWER TRAIN

  HAVE A LITTLE OVER 67,000 MILES ON VEHICLE. DRIVING AT HIGHWAY SPEED TRANSMISSION INDICATOR CAME ON, O/D INDICATOR FLASHES AND SERVICE ENGINE INDICATOR CAME ON. TRANSMISSION SHIFTS ROUGHLY FROM 1ST GEAR TO 2ND, AND DOES NOT HAVE OVERDRIVE. SERVICE STATION RAN DIAGNOSTIC WHICH RESULTED IN 4 SERVICE CODES: PO732, PO735, PO775, AND PO1744. THESE CODES WERE ALSO CONFIRMED BY AAMCO TRANSMISSION. THE RESULT APPEARS TO BE TRANSMISSION SOLENOID PACK, ALONG WITH REBUILD OF THE TRANSMISSION. *TR

• 12/27/2005· POWER TRAIN

  MY 2004 MERCURY MOUNTAINEER SHIFTS ROUGH, LUNGING FORWARD WITH A HARD SHIFT, AND SOMETIMES DRAGGING. ALSO, WHEN SHIFTING FROM PARK TO REVERSE EXPERIENCE A VERY HARD CLUNK FOLLOWED BY A THRUST BACKWARDS. *NM

• 12/23/2009· POWER TRAIN

  HERE IS THE E-MAIL I SENT TO FORD REGARDING WHAT IS GOING ON. : MY NAME IS LEANNE FREEMAN I OWN A 2004 MERCURY MOUNTAINEER,I HAVE BEEN HAVING TRANSMISSION TROUBLE WITH THE CAR SINCE I BOUGHT IT. I AM CONCERNED THAT I AM NOT THE ONLY PERSON HAVING THIS TROUBLE I LOOKED ON THE INTERNET AND WAS ABLE TO FIND 25,000 PAGES OF PEOPLE HAVING THE SAME TROUBLE MANY OF WHICH HAVE MADE CONTACT WITH FORD. I AM CONCERNED THAT FORD KNOWS THERE IS A PROBLEM AND HAS DONE NOTHING TO FIX IT. WHY HAVE THEY NOT DONE SOME KIND OF RECALL I COULD SEE IF THIS PROBLEM HAD ONLY HAPPENED TO A HAND FULL OF PEOPLE BUT THERE IS OVER 25,000 PAGES WITH EACH PAGE HAVING OVER 50 POST PER PAGE OF OWNERS HAVING THIS SAME PROBLEM ???? I HAVE SAVED ALL THE INFO FROM ALL THE PEOPLE HAVING THIS PROBLEM IF YOU WOULD LIKE ME TO FORWARD IT TO YOU I WILL BE HAPPY TO THANK YOU FOR YOUR TIME LEANNE FREEMAN HTTP://WWW.CARCOMPLAINTS.COM/MERCURY/MOUNTAINEER/2002/TRANSMISSION/OD_LIGHT_CAME_ON.SHTML HTTP://WIKI.ANSWERS.COM/Q/WHY_WOULD_THE_TRANSMISSION_ON_A_MERCURY_MOUNTAINEER_KEEP_SHIFTING_HARD HTTP://WWW.FORD-PROBLEMS.COM/EXPLORER-TRANSMISSION-PROBLEMS.HTM HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F1C1B35 HTTP://WWW.GOOGLE.COM/SEARCH?HL=EN&EI=JSUKS6K0ENS0TGEIG4JJBW&SA=X&OI=SPELL&RESNUM=1&CT=RESULT&CD=1&VED=0CDYQBSGA&Q=TRANSMISSION+PROBLEMS+ON+MERCURY+MOUNTAINEER&SPELL=1 HTTP://WWW.CARSURVEY.ORG/REVIEWS/MERCURY/MOUNTAINEER/R65436/COMMENTS/PAGE-2/ HTTP://WWW.CARCOMPLAINTS.COM/MERCURY/MOUNTAINEER/2002/TRANSMISSION/TRANSMISSION_FAILURE.SHTML HTTP://WWW.CARSURVEY.ORG/REVIEWS/MERCURY/MOUNTAINEER/R65436/COMMENTS/ HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F0FF573. *TR

• 12/22/2014· AIR BAGS

  DRIVING AT APPRX 50 MPH WHEN SUDDENLY BOTH THE DRIVER SIDE AND PASSENGER SIDE AIR CURTAINS DEPLOYED!! THERE WAS NO ACCIDENT. NO IMPACT FROM OBJECTS. NO POT HOLES OR ROAD HAZARDS. NO WARNINGS JUST A LOUD BANG AND THE NEXT THING I KNEW I WAS HIT IN THE HEAD BY AN AIRBAG!! I HAD NO IDEA WHAT HAPPENED. I THOUGHT I WAS STRUCK OR SHOT AT FIRST! I WAS FORTUNATE TO KEEP THE CAR UNDER MY CONTROL AS I WAS ON A TWO LANE SURFACE STREET IN MORNING TRAFFIC. I AM CURRENTLY IN CONTACT WITH FORD TO ATTEMPT RESOLUTION FOR THE DEFECT. IN RESEARCHING ONLINE I HAVE FOUND THAT THIS HAS HAPPENED MULTIPLE TIMES WITH THE SAME MODEL AND YEAR VEHICLE. THIS SOUNDS LIKE A SAFETY RECALL SHOULD BE CONSIDERED. I WILL ATTEMPT TO UPDATE MY COMPLAINT AS I CONTINUE MY TALK TO TRY AND GAIN RESOLUTION WITH FORD. *TR

• 12/18/2010· POWER TRAIN,EQUIPMENT

  2004 MERCURY MOUNTAINEER V8, 47,000 MILES. TRANSMISSION IS SHOT. IT SLIPPED IN AND OUT OR REVERSE (CREATING A VERY DANGEROUS SITUATION SINCE I COULD NOT CONTROL THE VEHICLE WHEN IT WAS IN REVERSE) AND IT STRUGGLED TO SHIFT GEARS IN DRIVE. NO WARNING LIGHT BEFORE THE PROBLEMS BEGAN. THE VEHICLE AGED OUT OF WARRANTY IN JULY 2010. FORD WILL NOT PAY FOR ANYTHING (ALTHOUGH THE DEALER IS CUTTING ME A BREAK ON THE SERVICE COSTS). *TR

• 12/18/2009· STRUCTURE

  I OWN A 2004 MERCURY MOUNTAINEER. RECENTLY, I FOUND THE BACK PANEL TO THE LIFTGATE NEAR THE EMBLEM IS COMPLETELY CRACKED. THIS IS CAUSING A SAFETY CONCERN FOR ME ON THE ROAD AS IT COULD BE DANGEROUS TO MYSELF AND OTHERS WHILE DRIVING. I CONTACTED FORD AND THEY REFUSE TO RECALL THIS PRODUCT. HUNDREDS OF SIMILAR COMPLAINTS CAN BE FOUND ONLINE AND BY SERVICE MECHANICS. *TR

• 12/15/2004· POWER TRAIN

  2004 MERCURY MOUNTAINEER, V6, AUTOMATIC, 2WD. VIN 4M2ZU66K8UJ13274. PURCHASED MARCH 2004. CURRENTLY MILEAGE 9821. STARTING APPROXIMATELY 12/1/04, WHEN REVERSE GEAR DOES NOT ENGAGE FOR 2 OR 3 SECONDS, THEN ENGAGES WITH A VERY HARD JOLT THAT SHAKES THE WHOLE VEHICLE. THIS OCCURS WHEN FIRST STARTING THE VECHICLE AND ALSO MID-DAY WHEN BACKING INTO A PARKING SPACE. ALSO THE AUTOMATIC TRANSMISSION ROUGH SHIFTS IN FREEWAY SLOW TRAFFIC BETWEEN 20 AND 30 MPH. FORD MOTOR CO. CONSUMER HOTLINE SAID ON 12/15/04 THAT MY VEHICLE VIN NUMBER HAS NO RECALLS. FROM PRESS RELEASES, I KNOW OF FORD'S 11/22/04 ANNOUNCEMENT OF 740,000 EXPLORERS AND MOUNTAINEERS WITH THIS SAME TRANSMISSION PROBLEM.*AK

• 12/13/2008· POWER TRAIN

  TRANSMISSION IS SLIPPING. I NOTICED WHEN PUTTING VEHICLE IN REVERSE IT JERKS REAL HARD INTO GEAR. ALSO COMING TO A STOP AND WHEN TAKING OFF FROM A STOP THE TRUCK WILL JERK. *TR

• 12/13/2004· POWER TRAIN

  THE REVERSE GEAR TENDS TO POP AND SWITCH TO ANOTHER GEAR, MAKING THE VEHICLE JUMP. TAKEN TO DEALER, BUT THE CAUSE WAS UNDETERMINED.*AK

• 12/12/2016· AIR BAGSCrash

  MY SON WAS DRIVING TO WORK ON AUGUST 6, 2015. SOMETHING HAPPENED, AND HE RAN OFF THE ROAD AND HIT A TREE. AT THAT POINT THE AIRBAG COVER FLEW TOTALLY OFF, INSTEAD AND FALLING DOWN AS IT IS SUPPOSED TO. THE COVER ITSELF GASHED MY SONS FOREHEAD FROM LEFT TO RIGHT, AND HE LOST HIS RIGHT EYE. THIS IS A TERRIBLE ACCIDENT. THE AIRBAGS CAME OUT SO FAST THAT THEY HAD BURN MARKS ON THEM. THESE AIRBAGS WERE SUPPOSED TO SAVE PEOPLES LIVES INSTEAD OF MANGLING THEIR FACES. SOMEONE NEEDS TO BE RESPONSIBLE FOR THIS HORRIFIC ACT....01/04/17 *BF *TR *CN

• 12/11/2017· ELECTRICAL SYSTEM,STRUCTURE,WHEELS

  1. PAINT COMING OFF OF ROOF AND DRIVER'S DOOR. 2. REAR PASSENGER SIDE AND DRIVER SIDE POWER WINDOWS NOT WORKING. 3. CRACKS IN PLASTIC AREA OF REAR LIFT GATE AROUND WIPER ARM. 4. ALMOST LOST CONTROL AND POTENTIAL ACCIDENT ON INTERSTATE WHEN RIGHT REAR WHEEL CAME LOOSE.

• 12/11/2009· STRUCTURE

  STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS - THE LEFT HINGE ON THE LIFTGATE ON MY 2004 MERCURY MOUNTAINEER FRACTURED, CAUSING THE GLASS LIFTGATE TO SWING OUT. THE RIGHT HINGE HELD BUT SHOWS CORROSION. THIS APPEARS TO BE THE SAME ISSUE IN NHTSA CAMPAIGN 04V442000 FOR MODEL YEARS 2002 - 2003. THE LIFTGATE IS NO LONGER OPERATIONAL. I HAVE NOT YET REPLACE THE PARTS. *TR

• 12/07/2004· POWER TRAIN,VEHICLE SPEED CONTROL

  WHEN APPLYING THE ACCELERATOR PEDAL FROM A STOP POSITION IT CAUSED A MOMENTARY PULSE BEFORE THE VEHICLE WENT INTO MOTION. VEHICLE HAD BEEN TO THE DEALER ON NUMEROUS OCCASIONS, AND THEY WERE UNABLE TO LOCATE THE PROBLEM. *AK THE CONSUMER STATED THAT THE PAUSE WAS SO SEVERE THAT IT JERKS ALL PASSENGERS HEADS . THE VEHICLE ALSO HAD TRANSMISSION PROBLEMS. THE TRANSMISSION HAD A HARSH SHIFT AND CLUNK WHEN GOING INTO REVERSE OR DRIVE. THE TRANSMISSION HAS BEEN REPAIRED. *TC

• 12/06/2011· STRUCTURE

  CAME OUT ONE MORNING TO DISCOVER THE REAR HATCH HAD A CRACK AROUND THE EMBLEM OF MY 2004 MERCURY MOUNTAINEER. CAR WAS PARKED IN DRIVEWAY AND WAS NOT HIT OR INVOLVED IN AN ACCIDENT. STARTED NOTICING THAT EVERY MERCURY MOUNTAINEER OF THE SAME BODY TYPE HAD SIMILAR CRACKS IN THE SAME LOCATION. CONTACTED FORD BUT DID NOT HAVE VIN #. EVENTUALLY CONTACTED FORD AGAIN WITH VIN # AND WAS TOLD THERE WAS NO RECALL AND THAT FORD WAS NOT ACCEPTING ANY RESPONSIBILITY . I TOLD FORD THAT IT IS AN OBVIOUS DEFECT TO NO AVAIL. I WILL NEVER BUY ANOTHER FORD PRODUCT IF THIS IS HOW THEY TREAT THEIR CUSTOMERS. THIS SHOULD BE A RECALL AND FORD SHOULD REPAIR THIS DEFECT. THE VALUE OF MY CAR HAS DECREASED BECAUSE OF THIS. I GOT A $500.00 ESTIMATE TO REPAIR IT BUT WAS TOLD IT WOULD PROBABLY HAPPEN AGAIN. *TR

• 12/06/2010· STRUCTURE

  I OWN A 2004 MERCURY MOUNTAINEER. ABOUT A WEEK AGO I NOTICED A CRACK IN THE REAR LIFTGATE PANEL OF MY VEHICLE. THE CRACK CURVES AROUND THE MERCURY LOGO LOCATED ON THE REAR PANEL. I CONTACTED THE DEALER AND HE SAID FORD IS VERY AWARE OF THIS PROBLEM AND HE REPAIRS MANY CRACKED LIFTGATES ON FORD/MERCURY SUV'S, ESPECIALLY IN THE WINTER DUE TO EXPANDING AND CONTRACTING OF PLASTIC. IT IS ALMOST HALFWAY DOWN THE BACK AND AM AFRAID THAT THE WINDOW WILL POP OUT WHILE DRIVING AND CAUSE AN ACCIDENT OR INJURE SOMEONE. IT IS A SAFETY HAZARD. FORD NEEDS TO RECALL THESE VEHICLES AND FIX THIS PROBLEM. IT SHOULD NOT BE THE RESPONSIBILITY OF THE CONSUMER, SINCE IT IS A DEFECT OF THE SUV. *TR

• 12/05/2007· STRUCTURE

  WE PURCHASED OUR MERCURY IN FEBRUARY OF 2007. AT THE TIME OF PURCHASE IT HAD AROUND 36,000 MILES. IT CURRENTLY HAS AROUND 46,000 MILES. I HAVE A CONCERN ON THE VEHICLE THAT I BELIEVE IS A DEFECT IN MATERIAL WORKMANSHIP OR A FLAW IN THE DESIGN OF THE VEHICLE. THE REAR OF THE VEHICLE HAS A CRACK ON THE REAR LIFTGATE TRIM. THE CRACK STARTS RIGHT BELOW THE REAR WIPER AND CRACKS ALONG WHAT APPEARS TO BE THE WEAK POINTS OF THE REAR BODY TRIM. I HAVE NOTICED SEVERAL VEHICLES WITH THE SAME PROBLEM THAT ARE MERCURY MOUNTAINEERS AND FORD EXPLORERS WITH THE SAME BODY STYLE AND APPROXIMATE TIME OF MANUFACTURE. THERE IS NO REASON FOR THE PLASTIC TRIM TO CRACK IN SUCH A PLACE. IT IS LIKE A STRESS FRACTURE IN THE HATCH. I BELIEVE THIS TO BE A FACTORY DEFECT IN THE DESIGN AND WORKMANSHIP OF THE VEHICLE, AND I DO NOT BELIEVE THAT A VEHICLE WHICH IS 3 YEARS OLD AND HAS LOW MILEAGE SHOULD HAVE SUCH A STRESS FRACTURE. I BELIEVE THAT FORD MOTOR COMPANY SHOULD LOOK INTO THIS MATTER AND CORRECT THIS PROBLEM. IT IS MY UNDERSTANDING THAT FORD IS AWARE OF THIS PROBLEM AND IS AVOIDING TAKING RESPONSIBILITY TO REPAIR THIS ISSUE. *TR

• 12/01/2008· STRUCTURE

  THE FAILURE IS FOR A 2004 MERCURY MOUNTAINEER AND THE FAILURE IS A CRACK IN THE LIFT GATE THAT OCCURS RIGHT ALONGSIDE THE MERCURY EMBLEM OR LOGO ON THE BACK OF THE TAILGATE OR LIFT GATE. THIS CRACK HAS BEEN REPORTED NUMEROUS TIMES ON ONLINE FORUMS AND TO ME SEEMS LIKE A DEFICIENCY IN THE MATERIAL THAT MAKES UP THE LIFT GATE OR TAILGATE. (I.E. - THE LOGO IS SO BIG AND THE MATERIAL AROUND THE LOGO EMBLEM SO THIN THAT IT CRACKS UNDER PRESSURE AND CHANGE IN TEMPERATURE) I WOULD ALSO LIKE TO ADD THAT I HAVE BEEN TOLD THAT THE FORD EXPLORER HAS A RECALL FOR THIS EXACT TYPE OF PROBLEM, YET MERCURY HAS YET TO ISSUE A RECALL FOR THE MOUNTAINEER. THE VEHICLES THAT HAVE INCURRED THIS TYPE OF PROBLEM HAVE BEEN AROUND THE SAME YEARS (2004-2006 MODELS - OR AT LEAST THE VEHICLES THAT I HAVE SEEN THIS PROBLEM OCCUR IN.) 1. THE EVENTS THAT HAVE LED UP TO THIS FAILURE INCLUDES: MERCURY AND FORD ARE SOLELY TO BLAME FOR PRODUCING A FAULTY TAILGATE OR LIFT GATE ON THESE VEHICLES AND SHOULD RECALL THEM. THE CHANGE IN TEMPERATURE ALONG WITH AVERAGE USAGE OF SHUTTING OR CLOSING THE TAILGATE WOULD CAUSE A VIBRATION TO PROMOTE THE TAILGATE TO CRACK. I NOTICED MY FAILURE OR CRACK IN MID-AUGUST OF 2008, I'VE OWNED MY VEHICLE SINCE 2004 BUT IT HAS BEEN GARAGED ALL OF THOSE YEARS EXCEPT FOR LAST YEAR, WHICH COULD EXPLAIN WHY IT HAPPENED LAST YEAR (CHANGE IN TEMPERATURE MORE SEVERE). 2. I HAVE NOTED HOW THE FAILURE OCCURS, ITS CONSEQUENCES INCLUDE A CRACK IN THE LIFT GATE OF THE VEHICLE, WHICH IS AESTHETICALLY NON-APPEALING, AND THIS COULD LEAD TO A LARGER CRACK IN THE LIFT GATE THAT COULD EVENTUALLY CAUSE MAJOR PROBLEMS FOR THE VEHICLE. THIS CRACK (WHICH IS NOT MINOR, 3 - 5 INCHES USUALLY) COULD ALSO REDUCE OR LEAD TO COMPROMISING THE VEHICLES STRUCTURAL INTEGRITY AND REDUCE CRASH TEST RATINGS. THIS IS A BIG CONCERN FOR YOUR SAFETY. 3. I PERSONALLY SPENT OVER $400 TO REPLACE THE ENTIRE LIFT GATE. I SHOULD BE REIMBURSED AND MERCURY SHOULD RECALL THIS PROBLEM. *TR

• 11/29/2010· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  JUST PURCHASED A 2004 MERCURY MOUNTAINEER TODAY. DRIVING HOME, USING CRUISE/SPEED CONTROL AT AROUND 30MPH AND DRIVING ON A SLIGHT DECLINE, THE VEHICLE SHUT DOWN. ALL INDICATOR LIGHTS WENT ON, AND I HAD TO COAST TO THE SIDE OF THE ROAD. I PUT VEHICLE IN PARK AND RESTARTED IT WITHOUT PROBLEM. THERE WERE NO INDICATOR LIGHTS (CHECK-ENGINE, ETC.) LIT UP. IMMEDIATELY WENT TO LOCAL FORD DEALERSHIP AND THEY HAD NO CLUE, ESPECIALLY SINCE THE COMPUTER DID NOT HAVE ANY CODES INDICATING A PROBLEM.. I'M CANCELING THE CHECK AND RETURNING THE VEHICLE TOMORROW. *TR

• 11/27/2011· POWER TRAIN,STRUCTURE

  BEING HAVING PROBLEMS WITH REAR LIFT GATE [ NOT STAYING CLOSE, OPENS ANYTIME, IT WANTS TO BY ITSELF. MY TRANSMISSION PROBLEMS ERRATIC SHIFTING, HARD SHIFTING UP AND DOWN SHIFTING AND IN AND OUT SHIFTING ON REVERSE FROM PARK TO REVERSE PULLS VERY HARD. WHEN I BOUGHT THE CAR I TOLD THEM THEY LOOKED AT LIKE I DIDN'T KNOW WHAT I WAS SAYING THEY MADE AN APPOINTMENT FOR MECHANIC TO CHECK IT AND SAID IT WAS GOOD BUT IT WASN'T. I HAVE 84,000 MILES ON IT NEVER PULL A TRAILER WITH IT I'VE MADE 38 PAYMENTS ON IT. WHY DOES FORD PUTS A PRODUCT LIKE THAT AND ASKS ALOT OF MONEY FOR THE CAR THAT CAN'T EVEN MAKE TO 100,000 MILES THEY SHOULD BE OUT OF ACT. HOPE FORD WILL TAKE CARE OF THIS CARS. *TR

• 11/24/2014· POWER TRAIN

  TL* THE CONTACT OWNS A 2006 MERCURY MOUNTAINEER. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE LOST POWER WITHOUT WARNING. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD WHERE IT WAS RESTARTED. HOWEVER, THE VEHICLE FAILED TO ACCELERATE PAST 35 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE POWER TRAIN NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 99,000. THE VIN WAS NOT AVAILABLE.

• 11/24/2009· ELECTRICAL SYSTEM

  WHILE DRIVING 40-45 MPH AND USING THE CRUISE CONTROL, CAR SUDDENLY SHUT DOWN. CHECK ENGINE LIGHT AND BATTERY LIGHT CAME ON. LOSS OF POWER STEERING, POWER BRAKES, ACCELERATION. WAS ABLE TO STEER SUV TO OFF THE ROAD BUT WAS VERY DIFFICULT TO DO SO. NEARLY RAN OFF A 10 TO 12 FOOT DROP OFF INTO A DRAINAGE DITCH. THIS HAS HAPPENED SEVERAL TIMES BEFORE. CAR MAX (WHERE WE BOUGHT SUV COULD NOT DUPLICATE THE ISSUE SO THEY SENT IT TO METRO FORD IN INDEPENDENCE, MO AND ON THE FIRST TIME IT HAPPENED REPLACE THE THROTTLE POSITION SENSOR BUT THAT DID NOT FIX THE PROBLEM). THE WRENCH AND FAIL SAFE MODE CAME ON THIS LAST TIME BUT THE PERSONS REPAIRING IT INDICATED THEY FOUND NO CODES FOR IT AND WERE UNABLE TO RE-CREATE TO DIAGNOSE. FROM RESEARCH I KNOW THIS IS A PROBLEM WITH OTHER VEHICLES OF THIS TYPE (BOTH THE LOSS OF ELECTRICAL POWER AND THE NO CODE FOUND SITUATION) BUT WE CAME VERY CLOSE TO AN INJURY RELATED ACCIDENT BECAUSE OF THIS. *TR

• 11/21/2014· SUSPENSION,WHEELS

  THIS WILL NOW BE THE 5TH TIME WE HAVE REPLACED A BALL BEARING IN THIS [XXX] TRUCK ... THE FRONT DRIVER TWICE THE FRONT PASSENGER ONCE AND NOW THIS IS THE SECOND TIME FOR THE BACK DRIVER! THIS IS HORRIBLE! THERE HAS TO BE MORE OF AN ISSUE THEN JUST THAT IF IT KEEPS HAPPENING! I WILL BE CONTACTING MERCURY AND I PRAY SOMETHING GETS DONE! THIS IS NOT A CHEAP FIX EITHER! AND WHEN IT HAPPENS IT IS LIKE THE TIRE IS ABOUT TO FALL OFF IT WOULD IF THERE WEREN'T LUG NUTS ON IT! BY FAR THE WORST SUV I HAVE HAD! 1000S OF DOLLARS TO FIX IT AND IT JUST KEEPS HAPPENING WHY AND WHY HASN'T THERE BEEN A RECALL ON THIS?? *TR

• 11/21/2009· STRUCTURE

  THE GLASS IN THE LIFT REAR GATE FELL OUT INTO MY SON'S HAND. THANK GOD, HE DID NOT SUFFER ANY INJURIES. I HAD TO TAKE IT IN AND HAVE THE HINGES REPLACED. THIS REPAIR COST ME $100 BECAUSE I HAD A WARRANTY. PREVIOUS INCIDENTS SIMILAR TO MINE HAVE BEEN REPORTED. THE CAR MANUFACTURES NEED TO COME UP WITH A BETTER DESIGN. *TR

• 11/21/2008· STRUCTURE

  CRACK APPEARED IN BODY OF VEHICLE IN THE BACK ABOVE AND AROUND THE MERCURY EMBLEM. IT CONTRACTS AND EXPANDS DEPENDING ON THE TEMPERATURE. THERE WAS NO CRASH, IMPACT OR ANYTHING THAT CAUSED THIS FAILURE. IT IS A DEFECT IN THE BODY. THE CONSEQUENCES OF THIS ARE THE INABILITY TO USE THE HATCH, THE REPAIR BILL AND THE DEPRECIATION OF THE VEHICLE. *TR

• 11/18/2013· STEERING,POWER TRAIN,VISIBILITY

  TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT WHILE ATTEMPTING TO CHANGE THE WHEEL DRIVE, THE VEHICLE FAILED TO UTILIZE THE FORWARD WHEEL DRIVE. IN ADDITION, THE VEHICLE BEGAN EXHIBITING SEVERAL FAILURES SIMULTANEOUSLY. THE POWER STEERING ASSIST FAILED, THE GEAR SHIFTER FAILED, AND THE TRANSMISSION WAS CAUSING THE VEHICLE TO JERK ABNORMALLY. ALSO, THE POWER WINDOWS HAD BECOME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE CONTACT WAS INFORMED THAT THE TRANSFER CASE AND TRANSMISSION NEEDED TO BE REPLACED. THE ADDITIONAL FAILURES WERE NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

• 11/14/2014· POWER TRAIN,ELECTRICAL SYSTEM,STRUCTURE

  TRANSMISSION SOLENOIDS THREE TIMES, PAINT COMING OFF, PASSENGER SEAT TRIM CAME OFF, CRACKED REAR LIFT GATE, PASSENGER FRONT AND REAR DOOR WINDOWS, AND DRIVER SIDE REAR DOOR WINDOW DO NOT WORK. *TR

• 11/13/2007· STRUCTURE

  VEHICLE PURCHASED USED 6/3/07. ABOUT 2 MONTHS LATER, NOTICED A POPPING NOISE FROM REAR HATCH AREA WHEN TURNING ON SLIGHT INCLINES (EG. PARKING LOTS. AROUND OCT 21, 2007, ON OPENING REAR HATCH, LEFT HINGE BOLT CAME OUT- GLASS DROPPED AND WAS CAUGHT. DEALER SAID HATCH RECALL DOES NOT INCLUDE THIS VIN #. PAID OUT OF POCKET FOR REPAIR. *TR

• 11/12/2011· POWER TRAIN

  TRANSMISSION FAILED AT 58,000 AND WAS REBUILT ( NOT REPLACED) UNDER WARRANTY. NOW LESS THAN 24,000 MILES AND 27 MONTHS LATER AT 84,000 MILES, TRANSMISSION HAS FAILED AGAIN. THE REBUILT TRANSMISSION HAS NOT EVEN HIT THE 30,000 MILES MAJOR TRANSMISSION SERVICE TIME. *TR

• 11/12/2011· POWER TRAIN

  THE TRANSMISSION FAILED ON MY 2004 MOUNTAINEER THE FIRST TIME IN JULY 2009 WITH ONLY APPROX 58,000 MILES. IT WAS UNDER WARRANTY. I WAS TOLD BY THE MERCURY DEALERSHIP THAT MY TRANSMISSION WOULD HAVE TO BE REBUILT FOR THE TRANSMISSION WAS ON NATIONAL BACK ORDER FOR A BRAND NEW TRANSMISSION. I MADE AN INQUIRY AS TO WHY A TRANSMISSION WOULD BE ON NATIONAL BACK ORDER??. NOW AT APPROX 84,000 MILES THE WARRANTY REBUILT TRANSMISSION HAS FAILED AGAIN . THAT IS ONLY 24,000 MILES PUT ON THE REBUILT TRANSMISSION. MY REBUILT TRANSMISSION HAS NOT EVEN HIT THE 30,000 MILES MAJOR TRANSMISSION SERVICE TIME. MY WARRANTY EXPIRED AT 75,0000 MILES . MY DEALERSHIP HAS INFORMED ME I HAVE NO WARRANTY ON A TRANSMISSION THAT WAS REBUILT UNDER WARRANTY PAST 75,0000 MILES. *TR

• 11/11/2014· VISIBILITY,STRUCTURE

  I TOOK MY CHILDREN TO DAYCARE CAME HOME AND PARKED IN THE DRIVEWAY. I CAME BACK OUT TWO MINUTES LATER AND THERE IS GLASS ALL OVER. THE BACK HATCH WINDOW EXPLODED, IT LOOKS LIKE IT GOT REALLY HOT AS SOME OF THE PLASTIC TRIM IS MELTED. *TR

• 11/10/2008· STRUCTURE

  CRACK ON REAR HATCH FROM TOP OF HATCH DOWN AND AROUND THE EMBLEM (UNDER THE REAR WINDOW). VEHICLE IS A 2004 MERCURY MOUNTAINEER WITH 75K MILES. *TR

• 11/10/2008· POWER TRAIN,LATCHES/LOCKS/LINKAGES

  TRANSMISSION SLIPPING AND RECENTLY WITHIN THIS MONTH NOTICED A CRACK IN THE LIFTGATE AND THE LIFTGATE WILL NOT RISE FULLY. *TR

• 11/10/2008· STRUCTURE,LATCHES/LOCKS/LINKAGES

  2004 MERCURY MOUNTAINEER REAR WINDOW PANEL CRACKED AND HINGES WILL NOT STAY TIGHT. FORD DEALER SAID THIS IS A COMMON PROBLEM BUT FORD WILL NOT REPAIR IF VEHICLE IS NOT UNDER WARRANTY. VEHICLE HAS 53,000 MILES BUT I HAD DEALER CHECK VEHICLE WHILE IT WAS UNDER WARRANTY AND THEY SAID ALL IT NEEDED WAS ADJUSTING. *TR

• 11/09/2009· STRUCTURE

  MY LIFT GATE GLASS HINGES HAVE STARTED TO FAIL, THE PIN HOLDING THE TOP AND BOTTOM PART OF THE HINGES TOGETHER HAVE COME OUT ON ONE SIDE OF BOTH HINGES CAUSING THEM TO TURN AND START LETTING THE OTHER SIDE COME OUT. EVENTUALLY WITHIN THE NEXT COUPLE OF MONTHS THE GLASS WILL FALL OUT ALL TOGETHER. BECAUSE OF THIS THE LATCH DOES NOT LINE UP RIGHT AND HAS CAUSE THE EXTERIOR TRIM MOLDING TO COMPLETELY CRACK FROM TOP TO BOTTOM. I HAVE ORDERED THE HINGES TO BE REPLACED AND I WILL HAVE TO PAY FOR THIS REPAIR MYSELF BEFORE SOMETHING BAD HAPPENS, EVEN THOUGH THERE IS A RECALL FOR THIS ON THE PREVIOUS YEARS OF MY VEHICLE. *TR

• 11/08/2012· STRUCTURE

  TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. THE CONTACT STATED THAT SHE WAS OPENING THE REAR DOOR WHEN THE REAR LIFT GATE WINDOW FRACTURED AND DROPPED ON THE CONTACT'S HEAD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE HINGES FROM THE LIFT GATE NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 25,000 AND THE CURRENT MILEAGE WAS 120,000. UPDATED 05/08/13*LJ THE CONSUMER STATED ONLY THE LIFT GATE HINGES WERE REPAIRED. THE HYDRAULIC LIFT WOULD NOT RAISE FULLY. THE CRACK AROUND THE MERCURY MEDALLION WAS NOT REPAIRED. *JS

• 11/03/2004· ENGINE AND ENGINE COOLING

  THE VEHICLE STALLS INTERMITTENTLY. THE CONSUMER HAS TAKEN THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE PROBLEM DID NOT DUPLICATE ITSELF. *JB *SC

• 10/24/2014· STRUCTURE

  REAR HATCH HINGE BROKE WHILE CLOSING BACK GLASS OF HATCH. *TR

• 10/22/2013· POWER TRAIN,STRUCTURE

  I ACTUALLY MISSED TWO RECALL ON MY VEHICLE THAT I PURCHASED IN 2004. MY DEALER WHICH IS JOHNSON BROTHERS FORD/MERCURY ON IH 35 TEMPLE, TEXAS 76501. MY WIFE WAS UNLOADING TRUCK AND THE LIFTGATE PLUNGED DOWN ON HER WITHOUT ANY NOTICE. SHE SUFFERED MINOR INJURIES FROM INCIDENT. THE YEAR BEFORE OUR TAILGATE STARTED CRACKING IN 2006 . THE DEALER JOHNSON BROTHERS NEVER NOTIFIED ME OF THE TAILGATE RECALL OR THE RECALL #RQ8003 FOR THE LIFTGATE ISSUE IN 2008. THIS DEALER HAS BEEN THE WORST IVE SEEN SINCE BUYING MY FIRST NEW OR USED VEHICLE IN AMERICA. I ,[XXX], HAVE ONLY RECEIVED HELP CONCERNING OIL CHANGES , AND TIRE CHECKS SINCE 2004. POOR SERVICE CENTER FOR CUSTOMERS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)*TR THE CONSUMER STATED THE TRANSMISSION OIL PAN WAS NEVER CHANGED AND THE DEALER CONTINUED TO TELL THE CONSUMER, ALL THE FLUIDS WERE FINE. HOWEVER, THE VEHICLE WOULD STALL WHILE IN DRIVE MODE.

• 10/21/2014· POWER TRAIN

  COLUMN MOUNTED GEARSHIFT SELECTOR BROKE OFF WHEN MOVING IT FROM DRIVE TO PARK. *TR

• 10/21/2010· ENGINE AND ENGINE COOLING

  2004 MERCURY MOUNTAINEER - HARMONIC BALANCER FAILED. IT WAS NOTICED WHEN A SQUEAKY NOISE WAS COMING FROM THE ENGINE. ALTHOUGH IS WAS CAUGHT BEFORE ANY SERIOUS INJURY OCCURRED, THIS FAILURE MAY HAVE LED TO ONE. IF THE BALANCER HAD COMPLETELY FAILED, IT COULD HAVE RESULTED IN LOSS OF STEERING AND AT HIGHWAY SPEEDS WOULD HAVE BEEN CATASTROPHIC. STEERING IS LOST BECAUSE DRIVE BELT WOULD HAVE COME LOSE. UNIT WAS REPLACED AT A COST OF $475. OLD PART WAS SAVED FOR INSPECTION. *TR

• 10/21/2005· POWER TRAIN

  VEHICLE JERKS INTO REVERSE. VEHICLE WAS PLACED IN SHOP TO HAVE ADDITIVE PLACED IN TRANSMISSION FLUID TO CORRECT THE PROBLEM. THE PROBLEM HAS NOT ABATED. THE TRANSMISSION IS ALSO VERY LOOSE. AFTER BEING PLACED IN PARK IT LUNGES 3 TO 4 INCHES IN THE DIRECTION OF THE SLOPE IT IS PARKED ON. *JB

• 10/19/2008· STRUCTURE

  WHILE PARKED OUTSIDE MY OFFICE DOOR THE BACK LIFTGATE WINDOW AND LIFTGATE BLEW OUT FOR NO APPARENT REASON. GLASS INSIDE AND OUTSIDE THE VEHICLE. HAD THE CHILDREN BEEN SEATED IN THE 3RD SEAT THEY WOULD HAVE BEEN SERIOUSLY INJURED. FORD MOTOR CO REFUSED TO ACKNOWLEDGE ANY RESPONSIBILITY, THE INSURANCE COMPANY HANDLES IT AS A COMP CLAIM AND I WAS OUT $250. AND WITHOUT AN ANSWER AS TO WHY IT HAPPENED AND WOULD IT HAPPEN AGAIN!?? *TR

• 10/16/2007· STRUCTURE

  SAME PROBLEM AS DESCRIBED IN "SAFETY RECALL 04S20" CONCERNING LIFTGATE GLASS HINGE. *TR

• 10/13/2010· STRUCTURE

  I OWN A 2004 MERCURY MOUNTAINEER HAS FOUR THOUSAND MILES. THE VEHICLE WAS STORAGE IN GARAGE FOR FOUR AND HALF YEARS. I STARTED TO USE THE VEHICLE ON LAST FALL OF 2009. ON SEPTEMBER I SEE THE TAILGATE DEVELOPED A CRACK AROUND THE EMBLEM AND THE REAR GLASS. THE HEATER IS NOT WORKING ALSO. THIS IS OBVIOUS MANUFACTURE DEFECTS! *TR

• 10/13/2009· AIR BAGS

  TL* THE CONTACT OWNS A 2004 MERCURY MOUNTAINEER. WHILE IDLING AT A STOP LIGHT, THE AIR BAGS DEPLOYED WITHOUT ANY PRIOR WARNINGS. AN INSPECTOR FROM THE INSURANCE AGENCY CONCLUDED THAT THE FAILURE WAS CAUSED BY A MANUFACTURES DEFECT. THE MANUFACTURER WAS NOTIFIED, AND A REPRESENTATIVE REQUESTED THE CONTROL RESTRAINT MODULE FROM THE DEALER TO INVESTIGATE THE FAILURE. NO REPAIRS WERE MADE. SHE WAS AWAITING A RESPONSE FROM THE MANUFACTURER. THE FAILURE MILEAGE WAS 60,000. UPDATED 11/13/09.*LJ THE FRONT AND REAR AIR BAGS DEPLOYED. UPDATED 11/16/09

• 10/11/2011· STRUCTURE

  WIFE WAS CLOSING LIFTGATE AND IT BROKE FROM THE HINGES. THE LEFT SIDE FELL AND HIT HER ON THE HEAD. WAS TRYING TO HOLD LIFT GATE SO GLASS WOULDN'T FALL AND BREAK. CALLED FORD AND THEY SAID IT WAS NOT A RECALL ISSUE. LOOKING ONLINE IT SEEMS THIS HAPPENS A LOT. *KB

• 10/07/2011· STEERING,POWER TRAINCrash

  TRANSFER CASE DEFECT CAUSES STEERING DIFFICULTY ON SLOW TURNS. TRANSMISSION ISSUE REPORTED TO FORD IN 2005 AT 38,000 MILES. AGAIN AT 51,000. I OPTED FOR AN AAMCO TRANSMISSION WHEN FORD REFUSED TO COVER. NOW TRANSFER CASE IS MAKING DRIVING DANGEROUS. TURNING ABILITY GREATLY REDUCED. *TR