2004 KIA Sedona

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2008· STEERING

  MY 2004 KIA SEDONA WITH 85,000 MILES LOST STEERING. I WAS LUCKY I WAS NOT KILLED. REPAIR SHOP STATES THAT THE SHAFT BROKE, RACK AND PINION WENT AND THE CLOCK SPRING WENT. IT APPEARS TO BE A DEFECT. *TR

• 12/30/2014· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHILE OPENING THE FRONT DRIVER SIDE EXTERIOR DOOR HANDLE, ALL FOUR DOORS ON THE VEHICLE LOCKED INDEPENDENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000. UPDATED 6/11/15*CN UPDATED 06/16/15*JB

• 12/29/2010· ENGINE AND ENGINE COOLING

  I HAVE A 2004 KIA SEDONA THE REAR COOLANT LINES HAVE FAILED AND NOW I AM LEAKING COOLANT AND IT WILL COST $1000 TO FIX. IT HAPPENED ALL OF A SUDDEN. NOW I CAN'T DRIVE MY CAR SAFELY. *TR

• 12/28/2005· SERVICE BRAKES, HYDRAULIC,PARKING BRAKE,ENGINE AND ENGINE COOLING

  NONE. *NM

• 12/26/2014· STEERING,ELECTRICAL SYSTEM

  WHILE DRIVING IN WET CONDITIONS THE BRAKE AND BATTERY LIGHT WILL COME ON INSTRUMENT PANEL AND THERE IS A LOSS OF POWER OF STEERING. WHEN TAKEN TO KIA DEALERSHIP TO FIX PROBLEM THEY TOLD US IT IS A COMMON COMPLAINT AMONG KIA CARS. THEY CHECKED ALL BELTS, BATTERY AND ALTERNATOR ALL TESTS CAME BACK NORMAL. WHILE DRIVING IT IS DANGEROUS TO LOSE POWER OF STEERING ESPECIALLY IN WET CONDITIONS. *TR

• 12/24/2009· VISIBILITY,STRUCTURE

  THE FRONT WINDSHIELD FIRST STARTED MAKING CREAKING AND POPPING NOISES. THEN A LEAK BEGAN IN THE SAME AREA OF THE NOISES. WATER LEAKS ONTO THE FLOOR NEAR THE BRAKE PEDAL AND CAUSES A SLIPPERY SURFACE UNDER MY FEET. NOW I HAVE BEEN TOLD THAT THE ENTIRE WINDOW FRAME OF THE FRONT WINDSHIELD IS MOVING WHEN THE CAR MOVES AND COULD POP OUT OF PLACE OR SHATTER WHILE DRIVING. *TR

• 12/22/2009· ENGINE AND ENGINE COOLING

  I AM WRITING TO BAND TOGETHER EVERYONE WHO IS READY TO BRING ON A CLASS ACTION LAW SUIT AGAINST KIA FOR THE LIES, BREECH OF WARRANTY, AND DEFECTIVE ENGINES THAT THEY ARE RESPONSIBLE FOR. I HAVE THE EXACT SAME STORY AS EVERYONE HERE......MY ENGINE BLEW, KIA WOULDN'T HONOR THEIR WARRANTY, SAID IT WAS MY FAULT DUE TO OVERHEATING, AND THE COOLANT RESERVOIR HAD A CRACK IN IT.....SOUND FAMILIAR? I WAS OUT OVER $8000....I NEED TO RECLAIM MY LOSSES. WHO'S WITH ME? PLEASE CONTACT ME . STACI MINNICK *TR

• 12/22/2006· SERVICE BRAKES, HYDRAULIC

  TL* - THE CONTACT STATES SINCE PURCHASING OF 2004 KIA SEDONA HE HAS HAD TO TAKE THE VEHICLE TO DEALER FOR ROTOR REPAIRS FIVE TIMES . THE DEALERSHIP REPLACED THE ROTORS THREE TIMES. THE CONTACT STATED THAT ON FIRST REPAIR HE WAS TOLD THAT THE ROTORS HAD HOT SPOTS ON THEM. WHILE DRIVING AT 40 MPH AND TRYING TO COME TO A STOP THE VEHICLE VIBRATED. THE CONTACT TOOK THE VEHICLE T O DEALER ON OTHER OCCASIONS FOR THE SAME PROBLEM, AND THEY HAVE DONE ALL OF THE REPAIRS. THE LAST TIME A REPAIR WAS DONE THE DEALERSHIP DID REPAIRS ON THE REAR BRAKES AND DRUMS, BUT THE PROBLEM RECURRED. THE CONTACT TOOK THE VEHICLE TO DEALER TWO WEEKS AGO FOR THE SAME PROBLEMS, WITH THE VEHICLE VIBRATING. THE CONTACT WAS TOLD BY DEALERSHIP THAT THEY WILL NOT DO THESE REPAIRS FOR FREE. THE CONTACT STATED THAT THE VEHICLE SAT AT THE DEALERSHIP FOR OVER A WEEK, AND HE HAD TO GO AND PICK UP THE VEHICLE AND DRIVE IT BACK HOME WITHOUT ANY REPAIRS BEING DONE. THE VEHICLE WAS STILL UNDER WARRANTY, AND THEY HAVE ALWAYS TAKEN CARE OF THE REPAIRS IN THE PAST. HE CONTACTED THE CHRYSLER CORPORATION, AND WAS TOLD THERE WAS NOTHING THEY COULD DO, BUT TAKE DOWN THE INFORMATION. THE CONTACT WAS GIVE A REFERENCE # 15798865 FROM THE CHRYSLER CORPORATION FOR HIS COMPLAINT.*AK UPDATED 02/22/07. *JB UPDATED

• 12/22/2006· ENGINE AND ENGINE COOLING

  HAD TO GET MY CAR SERVICED BECAUSE ANTIFREEZE WAS POURING OUT OF MY CAR. AFTER THEY LOOKED AT MY CAR I WAS NOTIFIED THAT KIA DOES NOT HAVE THE PART TO FIX MY CAR BUT INSISTS THAT I CAN STILL DRIVE IT. MEANWHILE I NEED TO FILL UP THE TANK AFTER MY ERRANDS FOR THE DAY, THAT'S AN ESTIMATE OF $20 A DAY!THEY TOLD ME IT WOULD TAKE UP TO 2-3 WEEKS UNTIL THIS PART CAME IN. I FOUND IT DISTURBING HOW THEY TOLD ME I CAN DRIVE THIS CAR WHILE IT POURS OUT ANTIFREEZE (ANTIFREEZE IS POISON TO ANIMALS). ALSO TO GET IT SERVICED I CALLED THE PLACE WHERE I BOUGHT IT AND THEY COULDN'T EVEN LOOK AT MY CAR TILL ANOTHER 3 WEEKS OR SO. MY CAR IS NOW AN HOUR AWAY AND KIA WILL NOT PROVIDE ME WITH A RENTAL. ITS A SHAME HOW THEY SCAM PEOPLE INTO BUYING THE CAR FOR THE WARRANTY BECAUSE ONCE THEY HAVE YOUR MONEY THEY DON'T CARE AFTER THAT. *NM

• 12/15/2009· STEERING

  TL* THE CONTACT OWNS A 2004 KIA SEDONA. WHEN MAKING TURNS SHE CAN HEAR A CLINGING NOISE IN THE STEERING COLUMN. ALSO SHE EXPERIENCED DIFFICULTLY STEERING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. SHE WAS ADVISED THAT THE INTERMEDIATE SHAFT BINDING NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 50000.

• 12/14/2006· ELECTRICAL SYSTEMFire

  I WAS DRIVING ON THE FREEWAY FOR ABOUT 15 MINUTES WHEN MY 04 KIA SEDONA LX STARTED SMOKING. AT FIRST I THOUGHT THERE WAS A FIRE IN THE LOCAL AREA. AFTER A FEW MINUTES IT OCCURRED TO ME THAT IT COULD BE MY VAN AND PULLED OVER AND POPPED THE HOOD. FLAMES JUMPED UP IN THE ENGINE AND BURNED UNTIL THEY WERE EXTINGUISHED WITH A FIRE EXTINGUISHER. THE KIA SERVICE MANAGER SAID THAT HE BELIEVED IT WAS A TOTAL LOSS. MY INSURANCE COMPANY IS NOW VERIFYING THAT. *NM

• 12/13/2009· SUSPENSION,WHEELS

  WHILE DRIVING AT 10 MPH ,MY DAUGHTER AND I HEARD A CLUNK IN THE REAR OF OUR 2004 KIA SEDONA LX. I WAS HEADING FOR A REPAIR SHOP AS A RESULT AND HEARD A SECOND CLUNK AND PULLED OFF ON A SIDE STREET AND DROVE 200 FEET WHEN THE WHEEL BEARING ASSEMBLY CAME APART AND THE WHOLE WHEEL FLEW OFF THE VAN. *TR

• 12/13/2006· ENGINE AND ENGINE COOLING

  DT*: THE CONTACT STATED THE ENGINE DIED WITHOUT WARNING. THE SERVICE DEALER DETERMINED THE ENGINE SHORT BLOCK NEEDED TO BE REPLACED TO FIX THE ISSUE.

• 12/09/2014· ENGINE

  ENGINE SEIZED WITHOUT ANY WARNING. THERE WASN'T MUCH TRAFFIC ON THE ROAD AND HELPED TO STEER THE VEHICLE TO THE SHOULDER. IN BAD WEATHER AND/OR TRAFFIC CONDITIONS, THIS COULD HAVE RESULTED IN A SERIOUS ACCIDENT. I STRONGLY BELIEVE THAT THERE ARE SOME SAFETY ISSUES WITH THE ENGINE OF THIS VEHICLE MAKE/MODEL AND WOULD LIKE TO REGISTER THIS INCIDENT. *TR

• 12/07/2005· EXTERIOR LIGHTING

  ON MULTI OCCASIONS REAR BRAKE OR DIRECTIONAL LIGHTS FAIL. THIS STARTED WITH 3000 MILES AND STILL IS ORRURRING WITH LESS THAN 10, 000 MILES ON THE CAR. *NM

• 12/04/2007· SERVICE BRAKES, HYDRAULIC,FUEL SYSTEM, GASOLINE

  TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHEN THE BRAKES ARE APPLIED, THE CONTACT HEARS A GRINDING, SQUEALING, AND SQUEAKING SOUND. THE FAILURE IS HEARD WHEN TWO OR MORE PEOPLE ARE IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER A DOZEN TIMES CONCERNING THIS AND, ON SIX OF THOSE OCCASIONS, THE SOUNDS COULD NOT BE DUPLICATED. THE BRAKING SYSTEM HAS BEEN REPLACED TWICE; ONCE AT THE CONTACT'S EXPENSE AND ONCE AT THE DEALER'S EXPENSE. THE SOUNDS CEASED FOR APPROXIMATELY ONE WEEK AND THEN RESUMED. THE CURRENT MILEAGE WAS 53,891 AND FAILURE MILEAGE WAS 30,000. UPDATED 12/31/07 *BF THE FUEL TANK PRESSURE SENSOR WAS REPLACED DUE TO THE CHECK ENGINE LIGHT ILLUMINATING. DIFFERENT PARTS WITHIN THE BRAKE SYSTEM WAS REPLACED; SUCH AS THE DRUMS AND REAR BRAKE SHOES UPDATED

• 12/03/2013· POWER TRAINCrash

  THE VAN WAS IN DRIVE TO MOVE FORWARD WHEN THE GAS WAS PRESSED INSTEAD OF GOING FORWARD IT WENT IN REVERSE & WHEN THE BRAKE WAS PRESSED TO STOP IT DIDN'T WORK. THE ONLY WAY TO STOP THE VAN BEFORE GOING INTO THE CEMENT WALL OF A COMMUNITY CENTER WAS TO OPEN THE DRIVER DOOR WHICH CAUSED 3 OTHER VEHICLES TO BE DAMAGED. THANK GOD THE DRIVER IS SAFE BUT THE VAN HAS DEEMED A TOTAL LOSS BY THE INSURANCE COMPANY. *TR

• 12/01/2012· VEHICLE SPEED CONTROL,SERVICE BRAKES

  THIS HAS HAPPENED 3 TIMES, THE LATEST IN NOVEMBER WHILE ON THE INTERSTATE, DURING RUSH HOUR, GOING 60 MILES PER HOUR. MY VAN KEEPS DYING WHILE I'M DRIVING WHETHER IT WAS A SENSOR OR OUT OF GAS, WHATEVER THE REASON, WHEN POWER GOES OUT, THE BRAKE LOCKS UP AND I HAVE NO CONTROL TO SLOW DOWN OR STOP THE VAN. IT HAS TO COAST UNTIL IT STOPS ON ITS OWN. THE LAST TIME TOOK ME A MILE AND HALF TO FINALLY STOP. THIS IS VERY DANGEROUS AND COULD CAUSE INJURY/AND OR DEATH IF THERE ARE OTHER VEHICLES IN FRONT OF ME. *TR

• 11/30/2004· FUEL SYSTEM, OTHER

  GAS MILEAGE FAR BELOW PROMISED. THE 2004 KIA SEDONA LX WAS POSTED AS 16-22 MPG. WE ARE AVERAGING 11 MPG HWY/CITY. IT HAS BEEN TO THE DEALER TWICE, THE SECOND TIME THERE WERE PARTS REPLACED LIKE AIRFLOW SENSORS. THIS DID NOT CORRECT THE PROBLEM. OUR DEALER HAS WORKED WITH US WELL, BUT WITH GAS PRICES THE WAY THEY ARE, THE COST TO OPERATE THE VEHICLE IS MUCH MORE THAN ADVERTISED. I HAVE TALKED TO OTHERS WHO OWN THE SEDONA AS WELL, SOME ARE AVERAGING OVER THE 20MPG, WHILE OTHERS ARE LIKE MYSELF, 10-11 MPG.*AK

• 11/27/2006· ELECTRICAL SYSTEM

  I HAVE A 2004 KIA SORENTO 4X4 (THAT CAR OPTION NOT INCLUDED IN COMPLAINT FORM) ONE MORNING CAR STARTED UP ROUGH AND WOULDN'T STOP. ENGINE LIGHT CAME ON. DROPPED OFF AT DEALERSHIP WHERE THEY SAID IT WAS MY FUEL INJECTORS. THEY REPLACED THEM, BUT SAID THEY WANTED TO KEEP CAR OVERNIGHT TO MAKE SURE PROBLEM DID NOT REPEAT. IT STARTED ROUGH AGAIN WITH THEM AND ENGINE LIGHT CAME ON AGAIN. THEY KEPT THE CAR NEXT DAY TO DIG DEEPER TO FIND PROBLEM. THEY DISCOVERED THE WIRE HARNESS SUFFERED A SHORT AND WAS BURNT IN 3 DIFFERENT AREAS. SINCE HARNESS IS CONNECTED FROM COMPUTER TO SPARK PLUGS, FUEL INJECTOR AND OTHER ENGINE COMPONENTS THEY HAD TO REPLACE EVERYTHING...BUT THE COMPUTER. I GOT CAR BACK AFTER 5 DAYS. 2 DAYS LATER CAR STARTED ROUGH IDLING AND STARTED MISFIRING AND CHECK ENGINE LIGHT CAME ON. I ONCE AGAIN DROPPED CAR OFF AT DEALERSHIP. SAID IT FEELS LIKE THE SAME PROBLEM, OR COULD BE RELATED TO WORK DONE. THEY SAID RANDOM MISFIRES ARE COMMON AND CLEARED COMPUTER LOG AND I GOT CAR BACK. NEXT MORNING CAR RAN ROUGH AGAIN AND WAS MISFIRING AGAIN. I CALLED KIA SERVICE AND SAID THAT THIS CAR NEVER MISFIRED BEFORE OR RAN ROUGH AND HOW CAN A RANDOM MISFIRE HAPPEN SO FREQUENTLY AND ISN'T IT COINCIDENTAL THAT IT ONLY STARTED HAPPENING AFTER MY WIRE HARNESS SUFFERED FROM A SHORT THAT WAS DIRECTLY ATTACHED TO THE SPARK PLUGS. SERVICE MANAGER MENTION THAT TECHNICIAN WORKING ON CAR THOUGHT THAT COMPUTER WAS MALFUNCTIONING BUT NEGLECTED TO TELL ME. I ASKED IF THEY KNEW IT WAS MALFUNCTIONING, WHY DID THEY EVER GIVE THE CAR BACK TILL EVERYTHING WAS FIXED. HE SAID THEY NEED PROOF AND NOT JUST MAYBE'S. I TOLD THEM THAT THE CONSTANT MISFIRING WAS PROOF ENOUGH. THEY TOOK THE CAR BACK AND REPLACED THE COMPUTER. THEY SENT THE COMPUTER TO KIA HEADQUARTERS TO INVESTIGATE WHY THE COMPUTER MALFUNCTIONED. I WAS TOLD THAT THEY WERE WORRIED THAT THIS MAY NOT BE A ISOLATED CASE. *JB

• 11/21/2006· SERVICE BRAKES, HYDRAULIC

  WE ARE WRITING TO REPORT A POTENTIALLY DANGEROUS SITUATION WITH THE 2004 *(AND POSSIBLY OTHER YEARS) KIA SEDONA. WE PURCHASE OUR VEHICLE NEW IN DAYTONA BEACH FLORIDA AND DID NOT HAVE A PROBLEM UNTIL WE RELOCATED TO THE MOUNTAINS OF WESTERN NORTH CAROLINA. SINCE FEBRUARY OF 2005 WE HAVE BEEN ATTEMPTING TO SAFELY RECTIFY A PROBLEM WITH OUR CAR WHICH NOW HAS APPROX 38,000. MILES ON IT. OUR CAR FYI HAS NEVER BEEN IN AN ACCIDENT AND WE ARE THE ONLY DRIVERS AND OWNERS. WE NOTICED IN APPROX JAN OF 2005 A SEVERE CAVITATION IN THE VEHICLE WHEN BRAKING ON A HILL AT A NORMAL RATE OF SPEED. MY HUSBAND IMMEDIATELY WENT TO THE LOCAL DEALER,PARAMOUNT KIA TO HAVE THE VEHICLE EXAMINED AND REPAIRED. HE WAS TOLD THAT KIA WAS AWARE OF A PROBLEM WITH THE BRAKING SYSTEM AND WAS UNABLE TO OFFER ANY ASSISTANCE AS THE PROBLEM WAS NOT UNDER WARRANTY. IN ADDITION, THE SERVICE MANAGER AT THE DEALERSHIP TOLD US THAT MANY KIA SEDONA OWNERS WERE COMPLAINING OF THE SAME PROBLEM AND THAT THE PROBLEM WAS SINGULAR TO THE WESTERN NORTH CAROLINA AREA DUE TO UNUSUAL WHETHER CONDITIONS. AT THAT TIME THE DEALERSHIP COULD NOT TELL US WHETHER THE CAR WAS SAFE TO DRIVE AND WAS UNABLE TO OFFER ANY ASSISTANCE IN REPAIRING THE PROBLEM, AS WE WERE TOLD THAT THE REPLACEMENT PARTS WERE THE SAME PARTS THAT WERE SUPPOSEDLY CAUSING THE PROBLEM. MY HUSBAND, UNSATISFIED BY THE POOR ANSWERS (EVASIVE IN NATURE) WENT TO ANOTHER REPUTABLE MECHANIC AND HAD ON SEVERAL OCCASIONS DIFFERENT PARTS OF THE BRAKING SYSTEM CHECKED AND THEN REPLACED AS NECESSARY. DURING THE ALMOST YEAR THAT WE HAVE BEEN HAVING THE PROBLEM WE HAVE BEEN TOLD REPEATEDLY THAT KIA IS AWARE OF A BRAKING SYSTEM PROBLEM, BUT NO RECALL HAS BEEN INITIATED, NO INFORMATION LETTER HAS BEEN SENT OUT TO LET KIA SEDONA OWNERS KNOW THAT THERE IS A POTENTIAL PROBLEM WITH THE BRAKING SYSTEM. *NM

• 11/17/2010· WHEELS

  TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A LOUD CRACKING NOISE. A FEW MOMENTS LATER, HE HEARD A LOUD EXPLOSION. THE CONTACT PULLED OVER AND NOTICED THAT THERE WAS A HOLE IN THE REAR PASSENGER SIDE HUB AND THE BEARING WAS MISSING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN RECALL 05V232000 (WHEELS). THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 97,000.

• 11/15/2005· SERVICE BRAKES, HYDRAULIC,WHEELS,SEATS

  KIA SEDONA REAR OUTER BEARINGS AND/OR HUB ASSEMBLY NEEDING REPLACED. *TS WHEN THE CONSUMER ARRIVED AT THE DEALERSHIP, SHE INFORMED THE REPRESENTATIVE THE LEFT REAR SEAT WOULD NOT COME OUT AND THE AIR BAG LIGHT WAS ON. WHEN THE CONSUMER WENT TO PICK UP THE VAN AND AFTER GOING OVER THE PAPERWORK, SHE NOTICED ONLY THE AIR BAG LIGHT WAS FIXED AND EVERYTHING ELSE THE PARTS WERE ON ORDER. AFTER GETTING ANOTHER APPOINTMENT, THE CONSUMER THEN TOLD THE DEALER SHE WAS EXPERIENCING A PULSATION WHEN IN THE BRAKES. THE DEALER TOLD THE CONSUMER THE BRAKES WERE NOT A PART OF THE WARRANTY, HOWEVER THEY WOULD TAKE THE RESPONSIBILITY FOR THE ROTORS, BUT THE CONSUMER WOULD HAVE TO PAY FOR THE BRAKE PADS. THE CONSUMER STATED THE PULSATION PROBLEM HAD NEVER BEEN FIXED. THE CONSUMER WAS TOLD NOW THE REAR BRAKES WERE PULSATING. *JB

• 11/12/2009· STEERING

  I HAVE A 2004 KIA SEDONA MINI-VAN. ON THE EVENING OF NOVEMBER 6, 2009 THE STEERING COLUMN ESSENTIALLY SEIZED ON ME. THE VAN BECAME EXTREMELY DIFFICULT TO CONTROL ALMOST TO THE POINT WHERE IT WAS UNDRIVEABLE. THERE WAS NO WARNING OR PREVIOUS INDICATIONS. I WAS BARELY ABLE TO GET THE VAN TO A SHOP ON SATURDAY, NOVEMBER 7, 2009 WHERE THE MECHANIC FOUND THAT KIA HAD ISSUED A TECHNICAL SERVICE BULLETIN FOR STEERING DIFFICULTIES DUE TO MALFUNCTIONING INTERMEDIATE STEERING COLUMN. GIVEN THE SEVERE SAFETY IMPLICATIONS OF THIS SITUATION, I BELIEVE THAT KIA SHOULD HAVE ISSUED A RECALL NOTICE AND SHOULD REIMBURSE OWNERS THAT HAVE HAD THE PART REPLACED. *TR

• 11/04/2015· STEERING

  MY STEERING IN MY 2004 KIA SEDONA LX IS TENDING TO BIND AND NEARLY LOCK UP AROUND TURNS. THIS PROBLEM COMES AND GOES.

• 11/02/2005· PARKING BRAKE

  AN OBJECT STRUCK THE PASSENGER SIDE REAR AXLE BETWEEN THE SPRING AND TIRE CAUSING THE EMERGENCY BRAKE CABLE TO SET THE BRAKE ON THE RIGHT REAR WHEEL WHILE I WAS TRAVELING AT 65 MPH ON AN INTERSTATE HIGHWAY. AN EMERGENCY STOP WAS REQUIRED TO MAINTAIN CONTROL. IN ORDER TO SAFELY DRIVE THE VEHICLE, THE CABLE HAD TO BE FORCED BACK TO ITS ORIGINAL POSITION TO FREE THE BRAKE. *JB

• 10/31/2011· STEERING

  INCREASED STEERING EFFORT NOTED. RESEARCHED AND FOUND NHTSA ACTION # 10027724, AND FOUND IT WAS OPENED AND CLOSED TWICE. THE ACTION APPEARED TO BE RELATED THE INTERMEDIATE STEERING SHAFT AND ASSOCIATED UNIVERSAL JOINT. LUBRICATING THE INTERMEDIATE SHAFT UNIVERSAL JOINT APPEARED TO SLIGHTLY LESSEN STEERING EFFORT. *TR

• 10/31/2011· STEERING

  THE STEERING STARTED TO BECOME DIFFICULT WHILE DRIVING ,INTERMITTENTLY DANGEROUS WHEN YOU NEVER KNEW IT WAS GONNA HAPPEN. EVENTUALLY JUST STOPPED WORKING ALL TOGETHER ,I DID ALOT OF ONLINE RESEARCH AND FOUND OUT THIS IS A VERY COMMON PROBLEM ,WITH THE STEERING KNUCKLE BINDING BECAUSE OF CORROSION . ALL AND ALL THINK THE VEHICLE WAS VERY WELL THOUGHT OUT AND ALOT OF AMENITIES ARE AWESOME IN THIS VEHICLE ,WHY DOESN'T KIA JUST OFFER A RECALL ,SINCE THEY HAVE ALREADY POSTED A BULLETIN FOR THIS? CALL THE DEALERSHIP AND REALIZE THIS PART IS ALWAYS ON BACK ORDER COME ON KIA MAN UP. *TR

• 10/30/2006· AIR BAGSCrash

  MY WIFE HAD A FRONTAL CRASH AT 35-40 MPH. INTO THE SIDE OF A BOX TRUCK. NEITHER PASSENGER NOR DRIVER'S AIRBAG DEPLOYED. THE HOOD HAD ALSO FLEW OFF THE VEHICLE AND LANDED MORE THAN 20 FEET AWAY AFTER BEING DEFLECTED OFF HER WINDSHIELD. THIS VEHICLE SUSTAINED MORE THAN $11,000 IN DAMAGES. *JB

• 10/29/2008· STEERING

  PROBLEM WITH THE STEERING. POPPING AND LOUD TIGHT SOMETIMES. CONCERNED THAT IT COULD BE A SAFETY HAZARD. *TR

• 10/28/2009· ELECTRICAL SYSTEM

  KIA SEDONA 2004-VEHICLE WILL NOT SHUT OFF EVEN WHEN THE KEYS ARE REMOVED FROM THE IGNITION. THE CAR WILL DRIVE HOWEVER NO FUNCTIONS ON THE DASHBOARD WILL WORK, LIGHTS, WIPERS, RADIO, HEADLIGHTS ETC. THIS HAPPENED FOR ABOUT 1 WEEK IN JUNE 2009 AND HERE AND THERE THROUGHOUT THE SUMMER. I DID HAVE IT TOWED BACK TO THE DEALERSHIP BUT AT THE TIME THEY WERE UNABLE TO IDENTIFY THE PROBLEM AS IT HAD CORRECTED ITSELF. IT HAPPENED AGAIN THE WEEK OF OCTOBER 21ST. THE BATTERY HAD TO BE DISCONNECTED TO TURN THE VEHICLE OFF. THEY ARE STILL UNSURE OF WHAT IS CAUSING THE CAR TO REMAIN ON WITHOUT THE KEY IN THE IGNITION. *TR

• 10/24/2005· SUSPENSION

  DT: THE CONTACT STATED THAT WHILE DRIVING THE LEFT REAR PASSENGER WHEEL CAME LOOSE FROM THE VEHICLE WITH THE TIRE AS WELL AS THE LUGS NUTS STILL INTACT. THE CONTACT WAS ABLE TO COAST INTO A GAS STATION BEFORE THE WHEEL CAME COMPLETELY OFF. BEFORE THIS INCIDENT RECALL 05V232000 REPAIRS WERE PERFORMED ON REAR WHEEL BEARINGS FOR WATER BY A LOCAL KIA DEALERSHIP. THE DEALERSHIP INSPECTED THE INSIDE WHEEL BEARINGS . THE VEHICLE WAS TOWED BACK TO THE KIA DEALERSHIP. THE DEALER COULD NOT DETERMINE WHY THIS OCCURRED, AND COULD NOT FIND ANY MOISTURE WITHIN THE BEARINGS. THE VEHICLE IS CURRENTLY AT THE DEALER FOR REPAIRS. *AK

• 10/22/2010· STEERING

  TL*THE CONTACT OWNS A 2004 KIA SEDONA. WHILE TRYING TO MAKE A TURN THE RACK A PINION STEERING MADE A CLANGING NOISE IN STAGES, JERKS BACK AND FORTH AND BECAME VERY HARD TO TURN. THE DEALER WAS CALLED AND INFORMED HIM THAT THE WARRANTY EXPIRED AND HE HAD TO PAY FOR THE REPAIRS. THE MANUFACTURER WAS CALLED AND CONFIRMED THAT THE WARRANTY EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 55,000.

• 10/21/2018· ENGINEFire

  MY 2004 KIA SEDONA WAS SITTING STATIONARY IN MY DRIVEWAY ENGINE WAS OFF. WHEN SOMETHING IN THE ENGINE COMPARTMENT CAUGHT FIRE CAUSING EXTENSIVE DAMAGE TO ENGINE PARTS ON THE TOP SIDE OF THE ENGINE. SUCH BE AS FLUID RESERVOIRS WIRING, FUSE BOX, AND MORE.

• 10/20/2004· SUSPENSION,WHEELS

  ON 10/17/04 WHILE DRIVING TO WORK I HEARD A NOISE LIKE I HAD A FLAT, WHEN THE VEHICLE WAS CHECKED THERE WAS NO FLAT. I DROVE THE VEHICLE TO THE NEAREST EXIT. WHEN I ATTEMPTED TO MOVE THE VEHICLE THE WHOLE TIRE FELL OFF THE VEHICLE, THE REAR DRIVERS SIDE . THE VEHICLE WAS TOWED TO THE DEALER WHERE NEW PARTS WERE ORDERED. IN MY OPINION I DONT FEEL SAFE DRIVING THIS VEHICLE BECAUSE IT COULD HAPPEN AGAIN AND NEXT TIME I MIGHT NOT BE LUCKEY. I COULD HAVE KILLED OR MY WHOLE IF THEY WERE WITH ME.

• 10/18/2006· SERVICE BRAKES, HYDRAULIC

  AT 18000 MI. VAN SHOOK WHILE BRAKING. DEALER CUT ROTORS AND REPLACED BRAKE PADS. AT 20000 MI. VAN SHOOK AGAIN BROUGHT VEHICLE BACK TO DEALER, DEALER REPLACED ROTORS AND BRAKE PADS. AT 33000 MI PROBLEM STARTED ALL OVER AGAIN. *NM

• 10/18/2005· SUSPENSION,SERVICE BRAKES, HYDRAULIC

  DT: THE CONTACT OWNS A 2004 KIA SEDONA. WHEN APPLYING THE BRAKES THE WHOLE FRONT END VIBRATED. DID NOT HEAR NOISES WHEN APPLYING THE BRAKES. SHE NOTICED THIS AROUND TWO MONTHS AGO. THE CONSUMER MOTHER-IN -LAW ALSO HAD A 2005 KIA SEDONA AND SHE EXPERIENCED THE SAME PROBLEM. THE CONSUMER TOOK CAR TO A DEALER, AND THEY TOLD HER THAT IT WAS NOT THE BRAKES. THEY WERE NOT SURE WHAT IT WAS. THE CONSUMER SAID THIS HAPPENS AT ANY SPEED.*AK *JB

• 10/12/2005· VEHICLE SPEED CONTROLCrash

  DRIVING VEHICLE AS NORMAL ON RTE 1 NORTH. ATTEMPTED TO SLOW VEHICLE TO STOP AT AMBER COLORED LIGHT BEFORE INTERSECTION WITH E. GRAND AVE,VEHICLE TRAVELING OVER 5 MPH BUT UNDER 10 MPH AT THIS TIME, APPLIED BRAKES, VEHICLE DID NOT SLOW DOWN. PUMPED BRAKES AND PUSHED BRAKE PEDAL TO FLOOR OF VEHICLE TO NO AVAIL, VEHICLE STILL MOVING , MAINTAINING SPEED,AND ABOUT TO TRAVEL THROUGH RED LIGHT AT INTERSECTION, ALSO APPLIED EMERGENCY BRAKE, VEHICLE DID NOT STOP, VEHICLE PROCEEDED THROUGH RED LIGHT AND COLLIDED WITH ANOTHER VEHICLE TRAVELING EAST BOUND ON E.GRAND AVENUE, AFTER COLLISION TURNED OFF VEHICLE, VEHICLE RESTARTED, TESTED BRAKES ON SIDE OF ROAD, BRAKES WERE APPLIED BUT DID NOT FUNCTION NORMALLY, WHEN BRAKES WERE APPLIED THEY HESITATED AND YOU COULD STILL PUSH PEDAL TO FLOOR WITHOUT STOPPING VEHICLE. TURNED OFF CAR AGAIN AND RESTARTED FOR LATER TESTING BY POLICE OFFICER. LATER TESTING SHOWED BRAKES "APPEARED" TO FUNCTION NORMALLY. CAR WAS DRIVEN TO DEALER FOR FURTHER TESTING, OBSERVING BRAKES JERKING AND HESITATING. CAR HAD NOT DEMONSTRATED THIS BEHAVIOR PRIOR TO INCIDENT. MECHANIC CALLED IN SPECIALIST, AS PER MANUFACTURER, TO MAKE ASSESSMENT OF BRAKES. RECALL NOTICE RECEIVED FOR DEFECTIVE THROTTLE, PRODUCING SAME EFFECT AS DEMONSTRATED AT INCIDENT. INFORMED MECHANIC OF RECALL NOTICE UPON RECEIPT,RECALL REPAIRED AS PER DEALER MECHANIC. CAR HAS NOT PRODUCED SAME EFFECT SINCE. *NM

• 10/08/2021· UNKNOWN OR OTHERFire

  Everything appears normal driving down road bout 45 to 50 mph. Slowed down for car n front was turning when I noticed smoke coming from under hood around headlights both sides. Then we pulled into a storage unit place. When even more smoke . I got out popped hood it was all on fire. I turned off van and a friend and I got a couple cups and dipped in water puddle and put fire out , while we were watching to make sure it restarted 2 more times. After half hour goes by and no more smoke . Closed van up found a ride home after contacting insurance company.

• 10/07/2005· WHEELS

  DT: THERE IS A PROBLEM WITH HEAVY CORROSION ON THE FRONT WHEELS. THE CONTACT NOTICED THE PROBLEM IN AUGUST 2005, BUT IT HAD BEEN GOING ON BEFORE THEN. HE HAD TAKEN IT TO THE DEALER TO HAVE TWO RECALL REPAIRS PERFORMED. THE RECALLS WERE FOR THE REAR WHEELS AND THROTTLE CABLE. THE RECALLS WERE ESC-051 AND SC-049. THE CONTACT ASKED THE DEALERSHIP TO LOOK AT THE FRONT WHEELS ALSO. HE TOLD HIM THAT ANY VEHICLE WOULD HAVE THAT SAME PROBLEM. THE REPAIRS HAVE YET TO BE DONE. *AK UPDATED 11/29/05. *JB

• 10/05/2012· VEHICLE SPEED CONTROL

  DRIVING IN MOUNTAINS IN SOUTHWEST IN OCTOBER USING CRUISE CONTROL AT 60 MPH. THE CRUISE WAS DISENGAGED BY THE DRIVER AS A TURN APPROACHED. VEHICLE SUDDENLY ACCELERATED FULLY. BRAKES DID NOT SLOW IT AND THEY BECAME UNRESPONSIVE. DRIVER PUT VEHICLE IN NEUTRAL AND ENGINE CONTINUED TO REV PAST 6000 RPM'S. IN NEUTRAL, VEHICLE WAS ABLE TO COAST TO A STOP. AFTER A TOW TO A REPAIR SHOP, THE MECHANIC FOUND THE CRUISE CONTROL ASSEMBLY BROKE AND THE CABLE CONNECTED TO THE THROTTLE RECOILED PULLING THE THROTTLE WIDE OPEN. THE MECHANIC DISENGAGED THE CRUISE CONTROL CABLE FROM THE THROTTLE AND THE VEHICLE COULD BE DRIVEN NORMALLY WITHOUT CRUISE. *TR

• 10/05/2009· STEERING

  ABOUT A YEAR AGO MY STEERING ON MY 04 KIA SEDONA WAS GETTING TIGHT AND HARD TO TURN, NOW THERE IS A CLICKING NOISE WHEN TURNING THE STEERING WHEEL MY FRIEND HAS AN 03 SEDONA AND HERS DID THE SAME THING IS THIS A RECALL? *TR

• 10/05/2006· SUSPENSION

  DT*: THE CONTACT STATED THE REAR PASSENGER SIDE TIRE FELL OFF WHILE THE CONTACT WAS JACKING UP THE VEHICLE. THE NON SERVICE DEALER DETERMINED THIS OCCURRED DUE TO THE WHEEL BEARING DISINTEGRATING. THE FRONT DRIVER SIDE WHEEL BEARING ALSO DISINTEGRATED. THE MANUFACTURER HAD A RECALL #05V232000; REGARDING THE WHEELS, BUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.*AK

• 10/04/2011· ENGINE AND ENGINE COOLING,POWER TRAIN

  VAN WAS MAKING A HIGH-PITCHED WHINING SOUND. TOOK IT IN AND FOUND THAT THE WATER PUMP NEEDED REPLACEMENT. THEY TESTED IT AND IT WAS STILL NOT RUNNING PROPERLY SO THEY DUG A LITTLE DEEPER AND FOUND THAT THE COILS AND WIRING NEEDED TO BE REPLACED. GOT THE VAN BACK IN WORKING CONDITION AND LESS THAN TWO DAYS LATER, THE CHECK ENGINE LIGHT COMES ON. TOOK IT BACK AND THEY SAID IT NEEDED A NEW CATALYTIC CONVERTER. THANKS TO LAWS IN THE STATE OF CALIFORNIA, WE CANNOT REPLACE WITH AN AFTERMARKET ($200); INSTEAD WE WERE QUOTED $1K, AND THAT APPARENTLY IS ON THE CHEAP SIDE. THE GOV.'T HAS A WARRANTY PROGRAM TO REPLACE CATALYTIC CONVERTERS ON VEHICLES 80,000 MILES OR LESS. WE WERE JUST OUT OF THAT LIMIT. TOO BAD FOR US. WE'RE TRADING IT IN. *TR

• 10/04/2011· WHEELS

  THE WHEEL BEARINGS DISINTEGRATED AND CAUSED THE WHOLE HUB TO COME OFF. LUCKILY WE WERE RIGHT AROUND THE CORNER FROM OUR DESTINATION AND WEREN'T GOING VERY FAST. *TR

• 10/04/2005· WHEELS

  WE TOOK OR 2004 SEDONDA EX. TO WESTON PONTIAC FOR A RECALL ON THE THROTTLE CABLE, MY WIFE ALSO SHOWED THEM THE LETTER FOR THE RECALL ON THE ALLOY WHEELS ASKED FOR THEM TO CHECK REAR BEARINGS FOR MOISTURE IN FEAR OF A CRASH. AFTER 3 HRS SHE WAS SENT HOME SAID IT WAS GOOD AND THEY WOULD ORDER PARTS. SOMETHING DIDN'T SEEM RIGHT SO I HAD HER TAKE IT TO BE CHECKED BY OTHER TECH. HIS FINDINGS WAS MOISTURE AND WAS CORRODED WITH RUST. LATER WHEN I WAS TALKING TO KIA'S CAC THEY GOT WESTON PONTIAC ON THE PHONE THE SHOP SAID THEY NEVER HAD TIME TO CHECK REAR BEARINGS WE WERE LUCKY THAT NO ONE WAS INJURED OR DEATHS WE HAVE GOTTEN A RUN AROUND FROM THEM LIES AND ONLY FIXING 1/2 THE PROBLEM. SAYING OUR PARTS ARE IN AND THEY DID NOT EVEN HAVE THEM JUST THAT KIA HAS CALLED AND WANTED TO GET THEM OFF THEIR BACKS. WE WERE ALSO TOLD TO KEEP CHECKING FOR MOISTURE IN THE BEARINGS AND JUST BRING IT WHEN WE DO. ITS LIKE SAYING DRIVE WITH YOUR EYES CLOSED YOU NEVER KNOW WHEN YOU MAY CRASH, AS THE RECALL SAYS I DON'T LIKE THAT ODDS WITH MY WIFE & GRANDCHILDREN LIVES AT HAND. KIA( KARRIE) IS WHO I SPOKE TO & GAVE ME THIS # K1016279 TO REFER TO MY COMPLAINT SAID WELL YOUR VAN IS FIXED AND NO ONE GOT HURT I DON'T SEE WHAT YOUR PROBLEM IS. THE LIE TO MY WIFE SAYING OR VAN WAS OK WHEN NEVER CHECK AND WAS NOT THE RISK THEY PUT MY LOVED ONES IN WITH NO CONCERN FOR THEIR LIVES AND THAT THEY NEVER FIXED IT THEY PUT A BANDAID ON IT JUST TO GET US AND THIS RECALL OFF THEM. I KNOW THE RECALL WAS NOT ON THE RENTAL BUT IT WAS NOT SAFE TO BE OUT ON THE ROAD THE TIRES WERE BOLD AND WAS OUT OF ALIGNMENT THAT IT PULLED SO HARD TO THE RIGHT. THE ONLY THING THEY COULD SAY WAS NO ONE TOLD US. SO THEY PUT US FROM ONE DANGER RIGHT INTO ANOTHER. PLEASE SOMETHING NEEDS TO BE DONE TO STOP THEM HOW MANY OTHERS HAVE THEY SENT OFF SAYING THEIR VEHICLE IS OK AND NOT. THANK-YOU FOR YOUR TIME AND CONCERN IN THIS MATER ALBERT SMITH . *JB

• 10/04/2005· SUSPENSION

  DT: THE CALLER RECEIVED RECALL LETTER CONCERNING OUTER REAR WHEEL BEARING IN JUNE AND HAS NOT BEEN ABLE TO GET WORK DONE. THE CALLER HAS NOT EXPERIENCED ANY PROBLEMS YET. DEALER SAID THE PARTS WERE ON BACK ORDER. MANUFACTURER SAID THEY WOULD CALL THE DEALER AND FIND OUT WHY THE CALLER COULD NOT GET PARTS. THEY WERE TOLD THE CALLER WAS ON TOP OF LIST WHEN PARTS COME IN. CALLER WAS CONCERNED ABOUT THE SAFETY ISSUE OF THE WHEEL BEARING WENT OUT. THE CALLER SAID THE RECALL LETTER STATED THAT THE PROBLEM COULD LEAD TO A CRASH IF IT WAS NOT REPAIRED. *AK

• 09/29/2008· SERVICE BRAKES, HYDRAULIC

  TL*THE CONTACT OWNS A 2004 KIA SEDONA. EVER SINCE PURCHASING THE VEHICLE, THE CONTACT HAS HEARD A HUMMING NOISE COMING FROM THE REAR BRAKES WHILE DRIVING 10 MPH. SHE HAS TAKEN THE VEHICLE TO THE DEALER NUMEROUS TIMES, BUT THEY COULD NOT FIND ANY FAILURES. THE CONTACT STATED THAT IT SOUNDS AS IF SOMETHING IS WRONG WITH THE REAR BRAKING SYSTEM AND IS CONCERNED OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 100 AND CURRENT MILEAGE WAS 45,000.

• 09/29/2004· ELECTRICAL SYSTEM

  BLOWN MAIN ENGINE FUSE DUE TO THIS FAILURE IT SHUTS OFF ALL ENGINE AND IT DOES NOT OPERATE AT ALL. WHILE DRIVING, ENGINE SHUTS OFF AND WON'T START. AFTER IT WENT TO THE DEALER FOR SO MANY DAYS WITHOUT CALLING US TO INFORM OF WHAT'S GOING ON, THEY HAVE FIGURED THAT IT HAS A BLOWN FUSE AND THEY ( DEALER MECHANICS ) BLAME ME TO THE FACT THAT I MIGHT BE USING A LOT OF ELECTICAL ACTIVITIES IN THE VAN SUCH AS PLAYING VIDEO GAME WHILE DRIVING AND MIGHT HAVE CAUSED THE ELECTRICAL BLOW OUT. THEN 2 MONTHS LATER... SAME THING HAPPENED I WAS ON MY WAY TO WORK AND IT DID THE SAME THING. NOW THAT THE CAR IS AT THE DEALER, GOD KNOWS WHAT THEY WILL COME UP WITH, TO HAVE SUCH AN EXCUSE. *AK

• 09/28/2009· STEERING

  TL*THE CONTACT OWNS A 2004 KIA SEDONA EX. SHE HAD TO EXERT GREAT FORCE WHILE TURNING THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY FOR INSPECTION AND THE MECHANIC REPLACED THE POWER STEERING PUMP, THE RACK AND PINION, AND THE INTERMEDIATE SHAFT. THE MANUFACTURER STATED THAT THEY WOULD NOT ASSUME RESPONSIBILITY FOR THE FAILURE. THE FAILURE MILEAGE WAS 36,000 AND THE CURRENT MILEAGE WAS 41,000.