2004 Ford Ranger

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2013· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  THE TURN SIGNAL LIGHT STOPS FLASHING WHEN TURNED ON DURING NORMAL DRIVING CONDITIONS. WHEN THE SIGNAL IS SWITCH IS TURNED ON TO ACTIVATE THE LEFT OR RIGHT SIGNALS, THE LIGHTS DO NOT FLASH AS THEY NORMALLY WOULD BOTH INSIDE THE CAB OR OUTSIDE ON THE SIGNAL LIGHTS. IN REVIEW OF PREVIOUS RECALLS FOR SIMILAR VEHICLES ON THE WWW.RECALL.GOV WEBSITE, NHTSA CAMPAIGN NUMBER: 11V352000, AND FORD RECALL NUMBER 11C18 SEEM TO COINCIDE WITH THE ISSUE I AM HAVING ALTHOUGH MY PARTICULAR VEHICLE WAS NOT RECALLED VIA ITS VIN NUMBER. THE RECALL DETAILS: "THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE." I WOULD LIKE TO KNOW IF THE RECALL CAN BE EXTENDED TO INCLUDE MY VEHICLE. *TR

• 12/31/2010· STRUCTURE

  FRAME HAS ISSUES WITH SEVERE SURFACE RUST PROBLEMS AND POSSIBLE MORE DEEPER RUSTING UNDERNEATH. WORRIED BRACKETS, HANGERS AND OTHER PARTS IN TIME WILL CORRODE TO THE POINT OF FAILURE. *TR

• 12/31/2010· SUSPENSION

  AT 45,000 MILES MY 2004 FORD RANGER 4X4 HAD A FAILURE OF THE FRONT WHEEL BEARINGS HUB CAUSING TIRE TO LOCK UP. NEEDED TO BE REPLACED. WAS TOLD BY THE REPAIR SHOP THERE WAS VERY LITTLE GREASE IN THE UNIT. *TR

• 12/29/2016· SERVICE BRAKESCrash

  MY VEHICLE IS A 2004 FORD RANGER XLT PICKUP TRUCK WITH 4 WHEEL DRIVE. THE VEHICLE IS IN EXCELLENT MECHANICAL CONDITION. THE BRAKE SYSTEM MALFUNCTIONED, ALLOWING THE BRAKE PEDAL TO HIT THE FLOOR. THIS INCIDENT OCCURRED WHILE I WAS PULLING INTO A PARKING SPOT ON A SNOW COVERED PARKING LOT. THE AIR TEMPERATURE WAS VERY COLD (0 DEG. F) AT THE TIME, AND THE 4X4 SYSTEM ON THE VEHICLE WAS ENGAGED. WHEN I APPLIED THE BRAKES AS I WAS PULLING INTO THE PARKING SPOT, THE BRAKE PEDAL HIT THE FLOOR SO THE VEHICLE DID NOT SLOW DOWN AND THERE WAS NO PULSING SENSATION FROM ABS. AS A RESULT, MY VEHICLE COLLIDED WITH A PARKED VEHICLE IMMEDIATELY IN FRONT OF MY VEHICLE. MY VEHICLE AND THE OTHER VEHICLE WERE BOTH DAMAGED AS A RESULT OF THIS BRAKE SYSTEM FAILURE. I HAVE TRIED TO REPRODUCE THE PROBLEM MANY TIMES AND HAVE BEEN UNABLE TO DO SO. THE FORD DEALER IN MY TOWN WAS UNABLE TO REPRODUCE THE FAILURE AND DID NOT FIND ANY MECHANICAL PROBLEM WITH THE BRAKING SYSTEM. ALSO THE DEALER STATED THAT THE ABS CONTROLLER ON MY VEHICLE CANNOT BE UPGRADED WITH NEW FIRMWARE. THE DEALER INVOICE FOR THE BRAKE INSPECTION IS ATTACHED. I HAVE FOUND OTHER REPORTS ON FORD AUTO ENTHUSIAST FORUMS OF THIS SAME PROBLEM OCCURRING TO OTHER FORD RANGER AND EXPLORER VEHICLES WHEN THE DRIVER WAS MAKING A TIGHT TURN AT VERY SLOW SPEEDS. SO IT SEEMS THERE IS A DESIGN DEFECT WITH THIS PARTICULAR FORD BRAKING SYSTEM.

• 12/29/2010· VISIBILITYCrash

  THE PROBLEM THE WINDSHIELD IS LOWER THAN NORMAL ON THE 2004 FORD RANGER CAUSING THE DRIVER VIEW HARD TO SEE THE STREET LIGHT. *TR

• 12/28/2016· AIR BAGS

  TAKATA RECALL. I AM STILL WAITING ON FORD TO FIX THE DRIVER'S SIDE AIRBAG. I NEED TO BE ABLE TO SELL THIS VEHICLE AND CAN NOT WITHOUT THE AIR BAG BEING FIXED. YOU CAN'T SEE A CAR THAT YOU'RE TOLD TO NOT DRIVE BECAUSE IT COULD KILL YOU. AT THIS POINT I BELIEVE FORD SHOULD PURCHASE THE VEHICLE AS IF I WAS SELLING TO A PRIVATE PARTY, NOT A DEALER AS THAT IS THE ONLY WAY I CAN GET ANY MONEY FOR THE VEHICLE. IT'S IN GREAT SHAPE BUT UN-SELLABLE SPECIFICALLY BECAUSE FORD HASN'T REPLACED THE AIRBAG. I BELIEVE WE'VE BEEN WAITING A YEAR?

• 12/28/2004· VEHICLE SPEED CONTROLCrash

  WHILE DRIVING 50 MPH, THE ACCELERATOR PEDAL BECAME STUCK AND THE VEHICLE ACCELERATED TO 70 MPH. THE CONSUMER HIT A WALL. THE VEHICLE WAS TOWED. *JB

• 12/24/2016· AIR BAGS

  WHEN WILL FORD REMEDY THE RECALL ON THE AIR BAGS? IT HAS BEEN NEARLY A YEAR FOR THE COMPANY TO MAKE THE CORRECTION. HOW LONG WILL OWNERS HAVE TO FACE THE POSSIBILITY OF AN ACCIDENT?

• 12/24/2008· POWER TRAIN

  I TOOK MY VEHICLE TO HAVE THE DIAGNOSTICS CHECKED ON IT , BECAUSE MY ENGINE LIGHT KEPT COMING ON , AFTER HAVING THE PLUGS CHANGED. THE DIAGNOSTICS SAID IT WAS A FIX IT PROBLEM, WITH THE VALVES, I THEN CALLED THE DEALERSHIP, IT SEEMS THE WARRANTY HAS EXPIRED BECAUSE OF THE MI. BEING 66,000 MY WIFE AND I WERE PLANNING TO GO OUT OF TOWN TO VISIT OUR GRANDCHILDREN, BUT CANNOT NOW. THE DEALERSHIP SAYS THEY ARE AWARE OF THE PROBLEM BUT SAYS THERE ARE NOT ENOUGH COMPLAINTS TO MAKE A RECALL. I WILL BE CONTACTING EVERYONE ABOUT THIS PROBLEM, PLEASE HELP US BY TELLING EVERYONE YOU KNOW!! MERRY CHRISTMAS ! WHO STOLE OUR CHRISTMAS FORD ! CALL YOUR GOV, OFFICIALS HELP MAKE THIS A RECALL NOT A FAIR WARRANTY 3YRS OR 36000 MI. BUY A FOREIGN CAR FROM NOW ON. *TR

• 12/23/2016· STEERING,VISIBILITY/WIPER

  THE PROLBEM WITH THIS TRUCK SEATING AT THE LIGHT THE SEAT SEEMS LITTLE BE HIGH CAN NOT SEE THE STREET TRAFFIC LIGHT IF YOU THE FIRST ONE, SECONDLY THE TURNING RADIUS IT IS TERRIBLE WHEN YOU TURN TO THE LEFT ONLY GOES 3/4 OF THE WAY WHILE OTHER TRUCKS CAN TURN 180 DEGREES ONE WAY IT IS FINE TO THE LEFT BUT TO THE RIGHT NOT GOOD. THIS PROBLEM SINCE WE OWN THE TRUCK.

• 12/21/2018· STRUCTURE,UNKNOWN OR OTHER

  TOOK TRUCK FOR STATE INSPECTION AND GARAGE CALLED 2 DAYS LATER,SAID THEY CAN'T INSPECT IT DUE TO FRAME BEING CRACKED IN 2 PLACES AND FRAME IS ROTTED AWAY. TRUCK ONLY HAS 66930 MILES ON IT AND LOOKS IN VERY GOOD SHAPE. I WAS SHOCKED WHEN THEY POINTED OUT THE PROBLEMS. I CALLED FORD MOTOR CO AND THEY WON'T DO ANYTHING ABOUT IT. TRUCK HAS BEEN DRIVEN UP TO THAT POINT.

• 12/21/2004· POWER TRAINCrash

  WHILE DRIVING IT FELT AS IF THE GEARS WERE GOING TO JUMP. CONSUMER WENT OUT TO START THE VEHICLE, AND WENT BACK INTO THE HOUSE, AND GEARS JUMPED FROM PARK INTO REVERSE, CAUSING A COLLISION. CONSUMER TOOK VEHICLE TO DEALER SEVERAL TIMES FOR THIS PROBLEM, AND WAS TOLD THERE WAS NOTHING WRONG WITH THE VEHICLE. *AK *NM

• 12/19/2013· ENGINE,FUEL/PROPULSION SYSTEM

  THIS COMPLAINT IS REGARDING THE VERY COMMON PROBLEM WITH THE 3.0 V6 MOTORS THAT FORD PRODUCED KNOWN AS THE "VALVE RECESSION" FORD RELEASED OVER 200,000 VEHICLES WITH THESE FAULTY CYLINDER HEADS. FORD IS AWARE OF THIS PROBLEM AS THEY SENT OUT A TSB (SERVICE BULLETIN) REGARDING THIS ISSUE BUT YET THEY WONT RECALL THIS PROBLEM. *TR

• 12/19/2007· POWER TRAINCrash

  TL*THE CONTACT OWNS A 2004 FORD RANGER. THE VEHICLE BEGAN TO ROLL BACKWARDS. THE CONTACT TURNED OFF THE ENGINE AND PLACED THE VEHICLE IN PARK. THE VEHICLE DROVE OVER A WOOD SPLINTER, WHICH DAMAGED THE TIRE, ALUMINUM WHEEL, BUMPER, AND TAILGATE. THE REPAIR SHOP STATED THAT THERE WAS A VACUUM LEAK IN THE 4 WHEEL DRIVE THAT CAUSED THE GEAR TO SHIFT INTO NEUTRAL. THE FAILURE MILEAGE WAS 26,000 AND CURRENT MILEAGE IS 36,000. UPDATED 01/08/08 *BF

• 12/18/2017· AIR BAGSCrash

  TL* THE CONTACT OWNS A 2004 FORD RANGER. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT'S VEHICLE WAS STRUCK ON THE DRIVER'S SIDE BY ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUFFERED NECK AND BACK PAIN, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED. THERE WERE NO OPEN RECALLS ASSOCIATED WITH THE VEHICLE AT THE TIME OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

• 12/15/2006· SERVICE BRAKES, HYDRAULIC

  ANTI-LOCK BRAKE FAILURE CAUSED EXCESSIVE WEAR TO FRONT BRAKES OF THE VEHICLE. DEALER AND MANUFACTURER ARE REFUSING RESPONSIBILITY FOR REPAIR. *JB

• 12/14/2016· AIR BAGS

  TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBERS: 15V322000 (AIR BAGS) AND 16V036000 (AIR BAGS). THE CONTACT STATED THAT THE PARTS NEEDED WERE NOT AVAILABLE TO PERFORM THE RECALL REPAIRS. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

• 12/13/2004· STRUCTURE

  PAST SAFETY RECALLS OTIFICATION DATE COMPONENT DESCRIPTION NHTSA CAMPAIGN NUMBER /3/2004 STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS 04V331000 . *AK I BROUGHT MY 2004 FORD RANGER TO THE DEALER THIS DAY 12-13-2004 AND WHEN I MENTIONED THIS RECALL TO INSPECT FOR THIS POSSIBLE FRAME PROBLEM THE SERVICE WRITER AT THE "WORLD FORD" DEALER IN MIAMI, FL. TOLD ME THERE IS NO RECALL. WHAT DO I DO NOW?

• 12/10/2016· AIR BAGS

  TAKATA INFLATORS,DRIVERS SIDE WAS REPLACED 3/7/16 AND AT THAT TIME DEALER ORDERED PASSENGER SIDE PARTS WHICH STILL HAVE NOT ARRIVED. IS THEIR A RECALL FOR PASSENGER SIDE AND IF SO WHEN SHOULD I EXPECT TO HAVE THE PARTS AT THE DEALERSHIP ( SHAKER FORD,WATERTOWN,CT)

• 12/09/2016· AIR BAGS

  TAMARA RECALL. NOTHING DONE CONCERNING RECALL. IT'S ALMOST BEEN A YEAR SINCE FIRST NOTICE.

• 12/08/2016· AIR BAGS

  TAKATA RECALL: I THINK I'VE BEEN WAITING FOR WELL OVER A YEAR FOR THE FIX TO THIS RECALL. I DON'T FEEL SAFE KNOWING THE AIRBAGS COULD HARM OR KILL ME AND A PASSENGER. I WOULD FEEL SAFER IF THEY WOULD DEACTIVATE THE DRIVER SIDE AIRBAG UNTIL THE REMEDY IS AVAILABLE.

• 12/07/2018· STRUCTURE

  I WAS DRIVING DOWN THE ROAD WHILE WORKING ONE DAY LAST SUMMER AND THE REAR CROSSMEMBER COMPLETELY ROTTED AWAY AND FELL OFF MY TRUCK TAKING THE EVAP EMISSIONS CANISTER WITH IT WHEN IT WENT I WAS GOING 45 AND LUCKILY I SAW IT AND HEARD IT AND NO ONE WAS BEHIND ME BUT THE FRAME IN THIS VEHICLE HAS COMPLETELY ROTTED AWAY THE CROSSMEMBERS ARE ALL CRACKED OR GONE THE FRAME RAILS ARE SPLIT AND IT WILL NOT PASS INSPECTION THIS YEAR AND I ALSO LOST THE STAIR TIRE MOUNT WHILE DRIVING THE REAR EXHAUST AND THE CATALYTIC CONVERTER HEAT SHIELD ALL WHILE DRIVING SOME ON THE HIGHWAY I AM DISABLED RECENTLY AND CAN'T AFFORD A NEW VEHICLE OR REPAIRS AND THERE'S NO REASON THIS SHOULD HAVE HAPPENED AT ALL I NEED THE VEHICLE TO MAKE MY PHYSICAL THERAPY AND DOCTORS APPOINTMENT WEEKLY PLEASE HELP IF YOU CAN THANK YOU

• 12/06/2016· AIR BAGS

  RECALL ON PASSENGER SIDE AIRBAG ,FORD DEALER HAS FAILED TO GET THE PART NEEDED TO FIX THE PROBLEM. ALTHOUGH THEY DID FIX THE AIRBAG ON THE DRIVERS SIDE. IT'S BEEN MONTHS SINCE I GOT THE RECALL NOTICE ,AND I STILL HAVEN'T HEARD FROM THE FORD DEALER IN CORBIN KY. PEOPLE ARE BEING KILLED BECAUSE OF FAULTY AIRBAGS,HOW MUCH LONGER DO I HAVE TO WAIT FOR FORD TO FIX THIS ?

• 12/05/2016· AIR BAGS

  TAKATA RECALL,I HAVE RECEIVED LETTERS FOR THE PAST THREE YEARS TO REPLACE MY AIR BAGS, BUT THE PARTS ARE NOT IN STOCK. SHOULD I CONTINUE DRIVE MY TRUCK WITH THIS SAFETY ISSUE OR SHOULD THE MANUFACTURE PROVIDE ME WITH VEHICLE.

• 12/05/2011· ELECTRICAL SYSTEMFire

  TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT STATED THAT THERE WAS A HOLE BURNT THROUGH THE WIRING HARNESS. THE CONTACT WAS INFORMED OF THE FAILURE WHILE HAVING A THERMOSTAT REPLACED BY AN INDEPENDENT MECHANIC. THE CONTACT WAS ALSO INFORMED THAT THE FAILURE COULD CAUSE A FIRE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE FAILURE WAS NOT COVERED BY WARRANTY. THE FAILURE AND CURRENT MILEAGES WERE 62,000.

• 12/04/2018· AIR BAGS

  TAKATA RECALL - LOCAL FORD DEALER, BARTOW FORD, HAS FAILED TO REPAIR THE REPAIR AFTER TWO PHONE CALLS.

• 12/04/2016· AIR BAGS

  TAKATA RECALL SINCE JANUARY 22, 2016. UNRESOLVED SAFETY ISSUE

• 12/03/2011· STRUCTURE

  ROT HAS APPEARED IN BED OF TRUCK. ROT HAS COME FROM UNDERSIDE OF BED, SEEMINGLY DUE TO A FABRIC THAT HOLDS MOISTURE AND WATER, THAT IS IN DIRECT CONTACT WITH UNDERSIDE OF BED, CAUSING RUST TO FORM AND EVENTUALLY ROT THROUGH THE BED. IN THE PAST 4 MONTHS, ONE HOLE APPROXIMATELY 5 INCHES IN DIAMETER, ANOTHER 2 INCHES IN DIAMETER AND THIRD HOLE IS FORMING. I AM CONCERNED THAT THERE IS ROT FORMING ON THE FRAME MEMBERS, AND IF THIS WILL LEAD TO AN UNSAFE CONDITION DURING DRIVING OR IN THE EVENT OF AN ACCIDENT. *TR

• 12/03/2004· AIR BAGSCrash

  WHILE DRIVING AT 50 MPH CONSUMER'S VEHICLE COLLIDED WITH ANOTHER VEHICLE HEAD ON. UPON IMPACT, THE AIRBAGS FAILED TO DEPLOY, RESULTING IN MINOR INJURIES.*AK

• 12/02/2004· ENGINE AND ENGINE COOLING

  CONSUMER COMPLAINED ABOUT A STARTING PROBLEM. VEHICLE WAS TAKEN TO DEALER ON SEVERAL OCCASIONS. DEALER REPLACED THE FUEL PUMP, BUT PROBLEM RECURRED.*AK

• 11/29/2010· ENGINE AND ENGINE COOLING

  TL*THE CONTACT OWNS A 2004 FORD RANGER. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE BEGAN MAKING A NOISE. THE VEHICLE THEN LOST ALL POWER AND THE CHECK ENGINE LIGHT FLASHED. THE CONTACT TURNED THE VEHICLE OFF AND RESTARTED IT; THE FAILURE CONTINUED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE MECHANIC REBUILT CYLINDER ONE. 36,000 MILES LATER, THE FAILURE OCCURRED AGAIN. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT CYLINDER ONE FAILED AGAIN. THE VEHICLE HAD NOT BEEN REPAIRED AGAIN. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 126,000.

• 11/29/2008· POWER TRAIN

  MIL ON WITH VARIOUS MISFIRE RELATED DTC'S PO300-PO306 AND PO316 - 3.0L-2V VULCAN ENGINE. *TR

• 11/25/2003· POWER TRAINCrash

  WHILE DRIVING 35 MPH THE REAR END OF THE VEHICLE FISH-TAILED AND CAUSED THE DRIVER TO LOSE CONTROL OF THE VEHICLE. THE VEHICLE CRASHED INTO A DITCH AND FLIPPED ON IT'S LEFT SIDE. THE DRIVER RECEIVED MINOR SCRAPES AND BRUISES. AN INDEPENDENT MECHANIC DETERMINED THE DRIVE SHAFT ON THE REAR END WAS THE CAUSE OF THE CRASH. PLEASE PROVIDE ANY FURTHER DETAILS. *NLM

• 11/24/2011· STRUCTURE

  MY WIFE SAT ON THE TAILGATE OF THE VEHICLE, AND BOTH TAILGATE SUPPORT CABLES SNAPPED AT THE SAME TIME CAUSING HER TO BE DROPPED ONTO THE GROUND, AND INJURING HER KNEE. NEITHER OF THE CABLES HAD SHOWN ANY PHYSICAL DAMAGE, AND THE RUBBER EXTERIOR COATING OF THE CABLES WAS STILL FULLY INTACT. UPON MY INSPECTING THE CABLES AFTER THEY HAD BROKEN, BOTH STEEL CORES WERE IN FACT CORRODED. *TR

• 11/24/2006· SERVICE BRAKES, HYDRAULIC

  I RECENTLY HAD TO REPAIR (AT MY COST) TO HAVE MY REAR BRAKES REDONE DUE TO THEM LOCKING UP. UPON REMOVAL OF THE DRUMS IT WAS VERY EVIDENT THAT THE BRAKE SHOES WERE DELAMINATED (SEPARATED) CAUSING MY REAR END OF MY TRUCK TO LOCK UP AND NOT MOVE. THIS BECAUSE THIS IS NOT A WEAR ISSUE. THIS IS A SAFETY ISSUE. TRUCK HAS 46K MILES. I AM LOOKING TO TRADE IT IN ON A TOYOTA, WHICH WILL BE THE FIRST JAPANESE VEHICLE THAT I HAVE EVER CONSIDERED. RUST IS ALSO STARTING TO FORM BETWEEN THE BED AND THE GATE. *NM

• 11/24/2004· SEATS

  I JUST BOUGHT A 2004 FORD RANGER REGULAR CAB IN AUG 2004. ABOUT 2 WEEKS AGO AFTER A HEAVY RAIN THE WHOLE INSIDE OF MY VEHICLE WAS WET. IT WAS WET FROM BOTH THE DRIVER AND THE PASSENGER HEAD RESTS TO THE FLOOR. IT TOOK A LITTLE OVER A WEEK FOR THE VEHICLE TO DRY OUT. I TOOK IT TO THE FORD DEALER THAT I BOUGHT IT FROM AND THEY TOLD ME THAT I HAD A DEFECTIVE WINDOW. THEY DID NOT EVEN HAVE TO LOOK AT THE TRUCK TO TELL ME WHAT THE PROBLEM WAS. THEY HAD TO ORDER A NEW BACK WINDOW FOR ME. THE ASSISTANT SERVICE MANAGER TOLD ME THAT THE PROBLEM THE SEAT BACK PUSHES OUT THE BACK WINDOW AND WATER CAN GET INSIDE. I AM 6'4" AND I HAVE TO HAVE THE SEAT ALL THE WAY BACK TO DRIVE. WHEN THEY REPLACED THE WINDOW I TALK TO THE AUTO GLASS COMPANY THAT THEY SUB THE WORK OUT TO. HE TOLD ME THAT THIS WAS A VERY COMMON PROBLEM IN THE RANGER REGULAR CABS. HE SAID THAT HE HAS HAD A FEW VEHICLES THAT COME IN EVERY 3 MONTHS TO GET A NEW REAR WINDOW. I HAVE ALSO CALLED FORD AND SPOKE WITH THEM ABOUT THE PROBLEM. THEY OFFERED LITTLE HELP. MY NEW TRUCK NOW SMELLS LIKE MOLD AND MILDEW, BUT THEY WILL DO NOTHING TO FIX THAT, EVEN THOUGH IT IS THEIR FAULT, OR THE WINDOW PROBLEM OTHER THAN REPLACE IT IF IT HAPPENS AGAIN. I THINK THAT THE SEAT IS THE MAJOR PROBLEM. NOT ONLY DOES IT PUSH THE GLASS OUT IT ALSO RESTRICTS THE REAR VIEW OF THE TRUCK WHILE DRIVING BECAUSE THE SEATS GO ALL THE WAY TO THE CEILING. WHAT WOULD HAPPEN IN A ACCIDENT IF THE SEAT PUSHES OUT THE BACK WINDOW? *NM

• 11/22/2023· AIR BAGS

  The contact owns a 2004 Ford Ranger. The contact received notification of NHTSA Campaign Number: 21V0810000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

• 11/22/2006· TIRES

  DT*: THE CONTACT STATED THE SPARE TIRE RIM WAS 16 INCHES INSTEAD OF 15 INCHES AND THE TIRE ITSELF WAS 70 SERIES INSTEAD OF 75 SERIES. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO DID NOT FIND ANY PROBLEM. *AK THE CONSUMER IS REQUESTING A PROPER SIZED SPARE TIRE. UPDATED 12/26/06.*JB

• 11/22/2005· FUEL SYSTEM, GASOLINE

  DT: THE CONTACT STATED THIS WAS A COMPANY FLEET VEHICLE AND IT WAS LEAKING FUEL. THE VEHICLE HAS NOT BEEN TO A DEALERSHIP. THE COMPANY HAD ANOTHER VEHICLE WITH THE SAME FUEL LEAKING PROBLEM DUE TO A BROKEN FUEL LINE. THE CONTACT ASSUMED THE SAME PROBLEM EXISTED WITH THIS VEHICLE SINCE THE FUEL WAS LEAKING FROM THE SAME AREA. *AK

• 11/20/2019· UNKNOWN OR OTHER

  FRAME IS ROTTING AWAY, LARGE HOLES IN THE REAR HALF OF THE FRAME CAN BE FOUND, YOU CAN PUSH YOUR FINGERS THRU THE FRAME IN SPOTS. THE REAR SHACKLE BRACKETS CAME COMPLETELY OFF WITH THE FRAME. CAN MOUNTS AND BED MOUNTS ARE RUSTING/ FALLING OFF. SPARE TIRE WELL FELL OFF WITH SPARE TIRE WHILE DRIVING. CHARCOAL FILTER FELL OFF DURING DRIVING. FRAME IS CRACKED ON PASSENGER SIDE BETWEEN CAN AND BED. TRUCK ONLY HAS 115770 MILES AND THE REAR HALF OF THE FRAME FROM THE CAB BACK IS LITERALLY FALLING APART.

• 11/19/2025· UNKNOWN OR OTHER

  since 2020 i have owned this ford ranger edge and have replaced drivers side exterior door handle 4 times, interior drivers side door handle 2 times and exterior passenger door handle 2 times. they keep breaking at the clip on the left side. It has been so bad that i actually had drivers side interior and exterior door handles break and could not get in on drivers side. It has caused me to be late for work, terminated from one service job, and a lot of stress. I have ordered handles a total of 5 times. Not any have been of quality to be called "Built Ford Tough"

• 11/19/2025· AIR BAGSCrash

  The contact owns a 2004 Ford Ranger. The contact stated that while driving on the highway in rainy weather at 60 MPH, she lost control of the vehicle and drove off the road. The contact stated that she could not recount what happened moments after she drove off the road; she did recall that she pulled up to a stop sign and her air bags had deployed. The police arrived at the scene and assisted the contact with moving the vehicle out of the road; a police report was not filed. The contact did not seek medical attention but suffered burns to her right arm and chest. The contact also sustained bruising to her face. The vehicle was towed the next day to an independent mechanic, where the vehicle remained in the possession of the mechanic and had yet to be repaired. The manufacturer had yet to be notified of the failure. Upon investigation, the contact discovered that the vehicle was under recall for NHTSA Campaign Number: 23V306000(Air Bags). The failure mileage was approximately 270,000.

• 11/19/2014· AIR BAGS

  NHTSA WEBSITE STATES AIRBAG RECALLS FOR 2004 RANGER ON BOTH DRIVER AND PASSENGER SIDE, AND FORD HOTLINE CONFIRMED RECALL 14BO4 FOR THIS VEHICLE VIN. LOCAL DEALER MADE APT FOR 11/28/14 FOR RECALL BUT ON DRIVER SIDE ONLY, BUT WHY THIS APPOINTMENT BECAUSE FORD HOTLINE SAYS NO PARTS UNTIL 1ST QTR 2015 BUT YOUR WEBSITE VIN CHECK SAYS 0 RECALLS. WHAT GIVES? DOES NHTSA KNOW WHAT IS REALLY GOING ON? *TR

• 11/18/2022· UNKNOWN OR OTHER

  The since weld behind the cab on drivers side frame completely rotted the frame away this was verified as a defect from a reputable welding shop since then I've not driven it as they said it could snap and cause a very bad accident or cause death or multiple deaths

• 11/17/2018· AIR BAGS

  I AM FORCED TO DRIVE A DANGEROUS RECALL OF MY VEHICLE AIRBAGS

• 11/17/2018· STRUCTURE

  WHILE DRIVING ALONG A SECONDARY ROAD NEAR MY HOME THE LEFT REAR FRAME RAIL IN FRONT OF THE REAR SPRING BROKE IN HALF CAUSING THE TRUCK TO SWERVE INTO THE OTHER LANE, NO ONE WAS HURT JUST SHAKEN UP, THE FRAME RAIL IS REALLY RUSTED. ALSO THE RIGHT SIDE FRAME RAIL IS CRACKED AND RUSTED..

• 11/17/2008· ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE

  TL*THE CONTACT OWNS A 2004 FORD RANGER. WHILE DRIVING LESS THAN 40 MPH, THE CONTACT STATED THAT THERE SEEMED TO BE WATER IN THE FUEL TANK. HE HEARD A RATTLING NOISE AND THE ENGINE FAILED. THE DEALER COULD NOT ASSIST AND THERE WERE NO RECALLS ON THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 62,000. UPDATED 12/11/08 *BF THE VALVE SPRING CAME OUT OF THE PLASTIC VALVE COVER. UPDATED 12/11/08. *JB

• 11/17/2004· VEHICLE SPEED CONTROL

  THE ENGINE CONTROLLER TENDS TO HOLD THE ENGINE SPEED BETWEEN 2000 AND 2500 RPM WHEN MY FOOT IS NOT TOUCHING THE ACCELERATOR PEDAL. THIS BEHAVIOR IS MOST OBVIOUS WHEN THE CLUTCH IS DEPRESSED WHILE CHANGING GEARS. THE ENGINE RPM IS HELD ARTIFICIALLY HIGH (WAY ABOVE NORMAL IDLE) FOR AS LONG AS I DEPRESS THE CLUTCH, UP UNTIL THE POINT THAT THE VEHICLE HAS COASTED ALMOST TO A COMPLETE STOP. I BELIEVE THAT THE COMPUTER ALSO DOES THIS WHEN THE CLUTCH IS ENGAGED. FOR EXAMPLE, IF I REMOVE PRESSURE FROM THE ACCELERATOR PEDAL AND ALLOW THE VEHICLE TO COAST WITH THE CLUTCH ENGAGED WHILE IN THIRD GEAR ON A LEVEL ROAD, THE VEHICLE NEVER SLOWS DOWN BELOW APPROXIMATELY 30 MPH (CORRESPONDING TO APPROXIMATELY 2000 ENGINE RPMS). ALSO, WHILE DESCENDING A HILL IN A LOW (2ND/3RD) GEAR USING ENGINE BRAKING (NOT TOUCHING THE GAS PEDAL), I CAN FEEL THE TRUCK SPONTANEOUSLY ACCELERATE. I FIRST TOOK THE TRUCK TO THE DEALER FOR THIS COMPLAINT ON 10/22/04. THE TECHNICIAN CONFIRMED THE BEHAVIOR, INSPECTED VARIOUS SENSORS, PROBED THE COMPUTER FOR ERROR CODES, AND EVENTUALLY RESORTED TO RESETTING THE COMPUTER IN HOPES THAT THE PROBLEM WOULD MAGICALLY DISAPPEAR. THIS OF COURSE DID NOT FIX THE PROBLEM, SO I RETURNED TO THE DEALERSHIP ON 11/16/04 WITH THE SAME COMPLAINT. THEY RESEARCHED THE ISSUE AND FOUND THAT IT IS A "NORMAL CHARACTERISTIC" OF THE VEHICLE, SUPPOSEDLY ADDED TO THE COMPUTER PROGRAM TO IMPROVE EMISSIONS. ASIDE FROM BEING ANNOYING, I BELIEVE THAT THIS "FEATURE" COULD POSE A SAFETY PROBLEM BECAUSE IT REDUCES THE EFFECTIVENESS AND PREDICTABILITY OF ENGINE BRAKING ON DOWN-HILL GRADES. ENGINE BRAKING IS VERY IMPORTANT IN MY AREA BECAUSE OF THE STEEP, FREQUENTLY SNOW-COVERED ROADS.*AK

• 11/16/2016· AIR BAGS

  TL* THE CONTACT OWNS A 2004 FORD RANGER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V036000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 01/06/17*LJ UPDATED 7/6/18*JB

• 11/16/2004· FUEL SYSTEM, OTHER

  FUEL CUT OFF SWITCH LOCATED UNDER THE DASHBOARD ON PASSENGER'S SIDE WAS ENGAGED ON TWO SEPARATE OCCASIONS WHILE DRIVING AT HIGHWAY SPEED OF 50 MPH OR MORE. THE FUEL CUT OFF SWITCH WAS ENGAGED BY THE PASSENGER'S FOOT. VEHICLE WAS TOWED TO THE DEALER, WHO REPLACED THE FUEL CUT OFF SWITCH. CONSUMER WAS CONCERNED THAT THE FUEL CUT OFF SWITCH DID NOT HAVE A PROTECTIVE COVER TO PREVENT THIS INCIDENT FROM RECURRING.*AK