2003 Volvo S60

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/28/2006· SEATSFire

  THE VEHICLE IS A 2003 VOLVO MODEL S-60 T-5, PURCHASED MAY 6, 2006. AT THE TIME OF PURCHASE, THE VEHICLE WAS UNDER THE WARRANTY OF 50,000 MILES AND WAS SERVICED FOR WARRANTY ITEMS BY RICKENBAUGH VOLVO. THE VEHICLE CURRENTLY HAS 60,500 MILES. UPON USING THE SEAT WARMERS FOR THE FIRST TIME DECEMBER 27, 2006, A SMALL HOLE BURNED IN THE DRIVER'S SEAT FROM THE SEAT HEATING ELEMENT. SMOKE WAS COMING OUT OF THE HOLE WHEN I DISCOVERED THE ISSUE AND I IMMEDIATELY TURNED OFF THE SEAT WARMER. I TOOK THE VEHICLE IMMEDIATELY (DECEMBER 27, 2006) TO VOLVO PARTS, INC. FOR INSPECTION. THERE IS A SHORT IN THE HEATING ELEMENT THAT MAKES THIS VEHICLE UNSAFE TO DRIVE. I CALLED THE VOLVO CORPORATION CUSTOMER SERVICE THAT SAME DAY AND WAS TOLD THAT THE VEHICLE WOULD NOT BE REPAIRED BY THE VOLVO CORPORATION BECAUSE IT WAS NO LONGER UNDER WARRANTY. I PHONED RICKENBAUGH VOLVO THAT SAME DAY AND WAS TOLD THE HEATING ELEMENT AND PAD WOULD NEED TO BE REPLACED AT A COST OF APPROXIMATELY $630.00. I AM CONCERNED THAT THE HEATING ELEMENT WAS IMPROPERLY INSTALLED CAUSING A SHORT, OR THE ELEMENT IS DEFECTIVE. IN ANY CASE, THE PRODUCT WAS DEFECTIVE WHEN IT WAS STILL UNDER A WARRANTY OR IMPROPERLY INSTALLED AT THE TIME OF MANUFACTURE, BUT INSTEAD OF ADDRESSING THE SAFETY ISSUE, THE VOLVO CORPORATION IS FOLLOWING ITS STANDARD PROCEDURE OF HIDING BEHIND ITS WARRANTY TERMS. THIS IS WHAT CONCERNS ME THE MOST. THERE WAS NO INJURY TO A PERSON, HOWEVER, THE LEATHER SEAT NOW HAS A HOLE FROM THE SMALL FIRE CAUSED BY THE HEATING ELEMENT. I HAVE NOT REPAIRED THE DEFECTIVE ELEMENT BECAUSE OF COST. PLEASE ADVISE ME AS TO WHAT DANGER THIS MAY PRESENT, OR WHAT OTHER OPTIONS I HAVE IN THIS COMPLAINT PROCESS. I WELCOME A DOT ASSIGNED ENGINEER TO INSPECT THIS VEHICLE FOR THE CAUSE OF THE FIRE. VOLVO PARTS, INC., ONLY INDICATES THAT THEY CHECKED CONNECTIONS AND FUSES AND THAT THEY ARE "OK". I WAS CHARGED $75.00 IN LABOR. *JB

• 12/21/2007· POWER TRAIN

  ANGLE GEAR REPLACEMENT ON A 2003 VOLVO XC90 AWD. *TR

• 12/11/2014· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,AIR BAGS

  DRIVING CAR LIGHTS ON DASH BOARD WENT COMPLETELY OFF. TOOK IT TO SHOP THEY TAP IT AND DASH CAME ON AGAIN, CHANGE FUSE . LIGHTS WENT OFF AGAIN AND STAYED OFF. *TR

• 12/08/2003· POWER TRAIN

  FOR BOTH OUR 2001 VOLVO S60 2.4T AND OUR 2003 VOLVO XC90 2.5T AWD THERE HAVE BEEN UNSUCCESSFUL ATTEMPTS TO REPAIR A TRANSMISSION DEFECT (ESSENTIALLY SAME TRANSMISSION IN BOTH VEHICLES PER VOLVO TECH SUPPORT). BETWEEN 2ND AND 3RD THERE IS . INTERMITTENT/UNPREDICTABLE FAILURE TO ENGAGE 3RD IN TIMELY FASHION WITH RESULTANT LOSS OF ACCELERATION AS VEHICLE IS FUNCTIONALLY IN NEUTRAL WITH ENGINE RACING FOR 0.5 TO 2.5 SECONDS. THIS IS EXTREMELY DANGEROUS ESPECIALLY WHEN PULLING ON TO A HIGHWAY. WE HAVE EXPERIENCED 2 NEAR COLLISIONS (ALMOST BEING STRUCK FROM BEHIND). VOLVO TECH SUPPORT ACKNOWLEDGES A FLAW IN DESIGN CAUSING SERVO FLUID AIR LOCK IN THE 2001. A NEW TRANSMISSION IS SCHEDULED TO BE REPLACED FOR OUR S60, BUT IF THE PROBLEM IS STILL OCCURING IN OUR 2003, WILL THIS CORRECT THE PROBLEM? THE 2003 XC90 THEY SAY CAN BE REPAIRED WITH "UPGRADED SOFTWARE" (WHICH IS SCHEDULED FOR THAT VEHICLE) BUT THIS REMEDY FAILED WHEN PERFORMED ON OUR 2001 S60. WE HAVE LET THE DEALER KNOW WE FEEL BOTH VEHICLES ARE UNSAFE WITH THIS PROBLEM AND WE ARE NOW STUCK WITH THEM TRYING TO REMEDY BOTH GLARING SAFETY DEFECTS. WE ARE NOT AWARE OF A FEDERALLY MANDATED RECALL TO REPAIR THIS ACKNOWLEDGED (SAFETY) DEFECT.*AK

• 11/28/2016· ELECTRICAL SYSTEM,AIR BAGS,ENGINE

  DASH CLUSTER LIGHTS AND GAUGES AND TURN SIGNAL INDICATOR SHUT DOWN AND BACK ON INTERMITTENTLY, MOTOR SEEMS TO LOSE POWER WHEN DRIVING, AND ROUGH IDLE. THE DASH CLUSTER PROBLEM HAPPENS WHILE DRIVING AND IN THE PARK POSITION. *TR

• 11/28/2012· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE INSTRUMENT PANEL FAILED AND THE GAUGES STOPPED FUNCTIONING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,000 AND THE CURRENT MILEAGE WAS 82,300.

• 11/26/2004· POWER TRAIN

  VEHICLE CONTINUED TO ROW WHEN CONSUMER REMOVED FOOT FROM THE ACCELERATOR PEDAL WHEN DRIVING UP AN INCLINE. DEALER WAS NOTIFIED, AND THEY INFORMED THE CONSUMER THAT WAS THE NORMAL CHARACTERISTIC OF THAT VEHICLE. *AK

• 11/24/2006· VEHICLE SPEED CONTROL

  WHILE DRIVING ON I-290 THE ENGINE OF MY 2003 VOLVO S60 SUDDENLY LOST ALL POWER. I NARROWLY ESCAPED SEVERAL SERIOUS ACCIDENTS ON A BUSY CHICAGO HIGHWAY. WHEN THE CAR LOSES POWER THERE IS ABSOLUTELY NOTHING THE OPERATOR CAN DO TO MOVE OVER TO THE SIDE. I WAS DRIVING APPROX. 60 MPH WHEN THIS HAPPENED. THE VEHICLE COMPLETELY STALLED, AND I WAS ABLE TO RESTART THE VEHICLE AFTER APPROX. 30-60 SECONDS. THE PROBLEMS EXHIBITED BY THE CAR ARE EXACTLY THE SAME AS THE RECENT RECALL THAT VOLVO HAS ANNOUNCED FOR VOLVO VEHICLES. MY CAR IS NOT INCLUDED IN THIS RECALL. THE CAR IS NOW STALLING RANDOMLY AT LOWER SPEEDS. *NM

• 11/19/2012· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2003 VOLVO S60. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY TO APPROXIMATELY 5 MPH. THE CONTACT STOPPED THE VEHICLE ON THE SHOULDER AND SHUT THE ENGINE OFF. AFTER RESTARTING, THE CONTACT WAS ABLE TO DRIVE NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE THIRD TIME THE VEHICLE WAS TAKEN TO THE DEALER, THE TECHNICIAN REPLACED THE ECM. THE FAILURE CONTINUED AFTER THE REPAIR. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE TURBO WAS REPLACED BUT TO NO AVAIL. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.

• 11/16/2010· ELECTRICAL SYSTEM

  I HAVE A 2003 S600 AND THE INSTRUMENT PANEL GOES DARK AND ALL THE INSTRUMENTS STOP WORKING (SPEEDOMETER, RPM, FUEL, TEMP -- ALL GO TO ZERO) . THIS OCCURS INTERMITTENTLY, WHILE DRIVING, THE ENGINE WAS RUNNING FINE AND NO WARNING LIGHTS CAME ON. I AM ALSO EXPERIENCING PROBLEMS WITH INDICATOR LIGHTS ON THE DASHBOARD. AS AN EXAMPLE, THE BLINKER LIGHTS ON THE DASHBOARD ONLY WORK ABOUT 20% OF THE TIME. THE ACTUAL DIRECTIONALS ON THE EXTERIOR OF THE CAR ARE STILL WORKING ALL OF THE TIME. THE CONDITION SEEMS TO BE GETTING PROGRESSIVELY WORSE. IN ADDITION VARIOUS MESSAGES HAVE APPEARED -- SUCH AS SRS AIRBAG SERVICE URGENT, BRAKE FAILURE - STOP SAFELY. BROUGHT IT TO MY MECHANIC AND HE HAD TO REPLACE THE DRIVER INFORMATION MODULE (DIM) $1,300. HE STATED THAT HE HAS REPLACED 4 DIM'S WITHIN THE PAST MONTH. APPEARS TO BE A COMMON FAILURE WITH 2003 S60 MODEL. MY MECHANIC ALSO COMMENTED THAT IN THE PAST VOLVO DEALER WOULD ONLY HAVE 1 DIM IN STOCK -- THEY NOW HAVE 6 TO 8 IN STOCK. I THINK THIS SHOULD BE A MANUFACTURER EXPENSE -- NO MATTER WHAT THE MILEAGE IS ON THE CAR. *TR UPDATED 08/04/11 *BF

• 11/14/2011· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT STATED WITH HIS FOOT ON THE BRAKE PEDAL, THE VEHICLE WOULD INTERMITTENTLY SURGE FORWARD. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD INTERMITTENTLY HESITATE TO ACCELERATE FROM A STOPPED POSITION. THE VEHICLE WAS NOT TAKEN TO A DEALER TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 20,000. UPDATED 01/04/12 *BF UPDATED 01/09/12

• 11/12/2015· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2003 VOLVO S60. AFTER THE VEHICLE WAS PARKED, A FUEL ODOR EMITTED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 180,000.

• 11/09/2010· STRUCTURE

  2003 VOLVO S60 PASSENGER FRONT DOOR HANDLE DOES NOT OPEN FROM INSIDE. OPENS FROM OUTSIDE FINE. *TR

• 11/06/2008· SEAT BELTS

  THE SEAT BELT CAN NOT BE PULLED OUT AND THEREFORE DOES NOT WORK. *TR

• 11/01/2012· ELECTRICAL SYSTEM,AIR BAGS,SERVICE BRAKES

  THE DASH INFORMATION SYTEM WILL RANDOMLY GO BLANK AND DISPLAY SRS AND BRAKE FAILURE, ALONG WITH ALL INFORMATION LIGHTS BLINKING ON AND OFF. ALSO THE ANALOG GAUGES LIKE THE SPEEDOMETER AND FUEL GAUGE WILL GO TO "0" AND EMPTY OR JUST MOVE ERATICALLY TO ANY NUMBER OR POSITION WHILE DRIVING. AT NIGHT SOMETIMES THE ENTIRE DASH OR INFORMATION CENTER WILL GO BLACK (NO LIGHTS AT ALL) AND ON ODD OCCASIONS ONE HEADLIGHT MAY GO OUT AND COME BACK ON. *TR

• 10/31/2003· FUEL SYSTEM, OTHER

  MANUFACTURER DEFECT FOR FUEL TANK VAPOR LEAK ON 2003 VOLVO S60 T5. DEALER STATED A SEPERATED PLASTIC WELD SEAM ON TANK WAS REALEASING STRONG FUEL VAPORS. POTENTIAL RISK FOR VAPORS TO IGNITE? *LA

• 10/26/2010· STRUCTURE

  THE INSIDE DOOR HANDLES ON MY VEHICLE BROKE. I WAS ABLE TO GET A NEW HANDLE ASSEMBLY FOR THE PASSENGER SIDE, BUT THE MANUFACTURER HAS NOT BEEN ABLE TO PROVIDE A NEW HANDLE ASSEMBLY FOR THE DRIVER'S SIDE DOOR. THE DOOR CANNOT BE OPENED FROM INSIDE THE VEHICLE. I'VE WAITED TWO MONTHS, BUT APPARENTLY THE NEW PART IS NOT AVAILABLE. *TR

• 10/23/2010· ELECTRICAL SYSTEM,AIR BAGS

  MY 2003 VOLVO S60 HAS A SEATBELT WARNING MESSAGE. THE DEALER DIAGNOSED THE PROBLEM AS A FAULTY DRIVER INFORMATION MODULE WHICH WOULD COST 1400 PLUS TAX TO REPAIR. THE CAR IS VALUED AT APPROXIMATELY 4000 AS A TRADE. THERE ARE MANY COMPLAINTS OF FAILURE OF THIS PART EVEN IN MUCH NEWER VOLVOS. *TR

• 10/22/2015· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE

  TRANSMISSION SHIFTING PROBLEMS OIL LEAKS.

• 10/18/2004· CHILD SEAT

  CONSUMER RECEIVED A RECALL NOTICE(04C002000) REGARDING THE THE HARNESS STRAP, THERE WERE NO PARTS AVAILABLE!!!!!!!!!!*JB

• 10/16/2006· ENGINE AND ENGINE COOLING

  I HAVE A 2003 VOLVO S 60 THAT HAS BEGUN STALLING OUT WHILE DRIVING. I BELIEVE THAT THIS IS SIMILAR TO OTHER CAR PROBLEMS THAT HAVE BEEN REPORTED RECENTLY. THE CAR DIES AFTER IT HAS REACHED OPERATING TEMPERATURES. IT JUST STOPS ON THE INTERSTATE OR AT A STOP LIGHT, IN INTERSECTIONS, ETC. IT TAKES BETWEEN 10 AND 30 SECONDS BEFORE IT CAN BE RESTARTED. MY CONCERN IS THAT THIS COULD BE AN RECURRING UNREPORTED PROBLEM WITH THIS VEHICLE. *NM

• 10/13/2008· EXTERIOR LIGHTING

  THE TURN SIGNAL LEVER BROKE WITHOUT MUCH FORCE BEING PLACED ON IT. THE PLASTIC USED TO CONSTRUCT IT MAY NOT HAVE BEEN OF GOOD QUALITY. THE PART ITSELF IS COSTING ME $100 FOR THE LEVER AND ANOTHER $100 FOR LABOR. THIS SHOULD NOT BE AN ISSUE WITH CARS. I'VE NEVER HAD ANYTHING LIKE THAT HAPPEN TO ME BEFORE. THE TURN SIGNAL LEVER HAS A STEEL REINFORCEMENT BAR GOING UP PART OF IT. WHERE THE BAR STOPS IS WHERE THE PIECE BROKE OFF. IT DIDN'T EVEN SNAP. THE PLASTIC JUST SORT OF PEELED AWAY. NOT WHAT I EXPECT OUT OF ANY CAR, ESPECIALLY A VOLVO. *TR

• 10/10/2014· ELECTRICAL SYSTEM

  THE ENTIRE GAUGE CLUSTER TURNS OFF AND ON WHEN THE VEHICLE IS TRAVELING DOWN THE ROAD. THIS IS A WIDE SPREAD PROBLEM THATS WELL DOCUMENTED BY THE VOLVO COMMUNITY. THE ISSUE IS A POORLY SOLDERED CIRCUIT BOARD ON THE DIM. *TR

• 10/08/2012· ELECTRICAL SYSTEM

  DASHBOARD INSTRUMENT CLUSTER GOING ON AND OFF-HAD IT TESTED SEVERAL TIMES-STAYS OFF--NO GAUGES OR LIGHTING-THIS IS A COMMON PROBLEM WITH ALL VOLVOS AND I AM THINKING IT IS A SAFETY ISSUE-AND WHY HAD IT NOT BEEN RECALLED YET?? THIS IS A REPAIR THAT I HAVE TO FIX-AS IT IS ALMOST 1500 DOLLARS---VOLVO FORUMS HAS SEVERAL HUNDRED PEOPLE COMPLAINING OF THIS--BEFORE I GET REPAIR I AM WONDERING IF VOLVO SHOULD CONTRIBUTE--- *TR

• 10/04/2007· POWER TRAIN

  1. THERE IS A WHOOPING CRANE SOUND WHEN I STEP ON THE FOOT FEED AND THEN RELEASE. THE DEALER SAID IT WAS REPAIRED AND THEN WHEN I DROVE IT HOME IT WAS STILL MAKING THE NOISE. AFTER NO RESPONSE FROM MY COMPLAINT TO THEM I STOPPED THE PAYMENT VIA AE AND HAVE STILL HEARD NOTHING. I THINK I PUT THE WRONG YEAR OF MY VEHICLE IN THE BEGINNING AND IF I TRY TO GO BACK I LOOSE EVERYTHING. IT IS A 2003 XC90 PURCHASED IN 12/02. THANK YOU FOR ANY HELP YOU CAN GIVE. IF YOU CAN'T HELP, PLEASE AT LEAST SEND ME AN EMAIL AND TELL ME SO. THANKS. 2. ANOTHER PROBLEM THAT STARTED IN JULY 2006 IS A KNOCKING NOISE COMING FROM UNDERNEATH THE VEHICLE. AFTER NUMEROUS TRIPS TO THE DEALER I WAS TOLD A NEW BOX FOR THAT PARTICULAR ITEM AND IT WOULD COST $2800.00 TO REPAIR. BUT THEY COULD NOT GUARANTEE THAT WOULD FIX THE PROBLEM. MY XC90 HAD A 4 YR OR 50,000 WARRANTY. THIS PROBLEM STARTED IN JULY 2006 WITH 41800 MILES. I TOOK POSSESSION OF THE CAR IN 12/02 SO MY MATH SAYS THE WARRANTY EXPIRED 12/06 AND THAT MEANS IT WAS STILL UNDER WARRANTY WHEN THIS WAS FIRST NOTICED. I HAVE HAD THE VEHICLE IN AT LEAST EVERY 4 MONTHS FOR SERVICE AND EACH TIME COMPLAINED ABOUT IT. ALSO I HAD IT IN AT LEAST 5 TIMES FROM JUNE THRU JULY 2007 WITH NO SATISFACTION. NOW THEY DON'T EVEN ANSWER MY EMAILS OR RETURN MY PHONE CALLS. I HAVE CONTACTED THE CONSUMER COMPLAINT DEPARTMENT OF VOLVO AND THEY HAVE NEVER ANSWERED ME. I AM AT A LOSS AS TO WHAT TO DO. THIS CAR WAS PURCHASED AT POWER VOLVO OF CERRITOS (THEN IT WAS CALLED VOLVO OF CERRITOS) PLEASE HELP ME! *TR

• 09/25/2010· ENGINE AND ENGINE COOLING

  I HAD A SIMILAR ISSUE ABOUT TWO YEARS AGO AND REPLACED THE CATALYTIC CONVERTER. JUST TODAY (9/25/10), MY 2003 VOLVO S60 BEGAN TO IRREGULARLY STALL WHILE DRIVING. WHILE I'M SLOWING DOWN, IT DOWNSHIFTS BY IT SELF, AND JUST DIES, AND WHILE I'M SLOWING DOWN, THE WARNING INDICATORS ON THE DASH ARE NOT LIT, AS IF NOTHING IS WRONG, BUT WHEN COME TO A COMPLETE STOP ALL THE LIGHTS ON THE DASH ARE LIT. THE CHECK ENGINE LIGHT THEN COMES ON, IT WASN'T ON BEFORE THIS HAPPENED. THIS CAN BE VERY DANGEROUS WHEN YOU ARE SLOWING DOWN TO TURN AT AN INTERSECTION. THE CAR STALL, YOU HAVE NO POWER STEERING AND YOU ARE DEAD IN THE MIDDLE OF TRAFFIC. THIS HAPPENED NO LESS THAN 10 TIME WHILE I WAS DRIVING TODAY. *TR

• 09/24/2018· FUEL/PROPULSION SYSTEM

  VECHILE LEAKING GAS AND HAD STRONG GAS SMELL.

• 09/18/2018· ELECTRICAL SYSTEM

  THE DASHBOARD INSTRUMENT PANEL AND LIGHTS GO OFF AND COME BACK ON WHENEVER. I HAVE HAD THE CAR FOR OVER A YEAR. IT WAS A GIFT. I JUST FOUND OUT TONITE FROM AN OFFICER THAT WHEN THE INSTRUMENT PANEL AND LIGHTS ARE OFF I HAVE NO TAIL LIGHTS. I WAS WONDERING IF THERE HAS EVER BEEN A RECALL. THIS IS VERY DANGEROUS THE DATE BELOW IS IT AN APPROXIMATE. I REALLY DO NOT REMEMBER THE EXACT DATE.

• 09/16/2004· TIRES

  MY WIFE, JANELLE, AND I HAVE A 2003 VOLVO S60 WHICH WE PURCHASED NEW IN APRIL, 2003, AND WHICH HAD FOUR ORIGINAL EQUIPMENT MICHELIN TIRES (MXV-4, I BELIEVE). WE USE IT FOR NORMAL HIGHWAY AND SUBURBAN TRAVEL IN THE BOSTON AREA. WHEN THE CAR HAD GONE ONLY 8000 MILES, ONE OF THE LEFT TIRES GAVE OUT ON US. THE SIDE WALL OF THE TIRE UNRAVELED, AND THE TIRE COULD NOT BE REPAIRED. NO SPECIFIC CAUSE COULD BE DETERMINED. FORTUNATELY, THIS HAPPENED IN A QUIET CAPE COD TOWN AND WE WERE NOT IN ANY DANGER (BUT I WAS OUT ABOUT $150). WE HAD NO FURTHER PROBLEMS UNTIL SEPTEMBER 13, WHEN THE RIGHT FRONT TIRE GAVE OUT FROM THE SIDE IN THE SAME MANNER AS THE PREVIOUS TIRE ON ROUTE 128 IN WAKEFIELD, MA (AT 23000 MILES), WHILE I WAS TRAVELING MORE THAN 60 MILES AN HOUR IN HEAVY TRAFFIC. WE WERE LUCKY NOT TO HAVE BEEN KILLED OR INJURED. AGAIN, THE TIRE WAS RUINED. AGAIN, IT COST ME OVER $150 FOR A REPLACEMENT TIRE. BOTH TIRE DEALERS WHO SOLD US REPLACEMENT MICHELIN MATCHING TIRES ADVISED US THAT PERHAPS THE PROBLEM HAD TO DO WITH THE "LOW PROFILE" OF THE VOLVO S60 AND BUMPING INTO CURBS. YET THE FIRST TIRE WHICH UNRAVELED WAS ON THE LEFT SIDE OF THE VEHICLE AND THE SECOND TIRE WHICH UNRAVELED HAD ABSOLUTELY NO CONTACT WITH A CURB FOR ABOUT 100 MILES PRIOR TO THE INCIDENT. I DO NOT BELIEVE THAT THIS SHOULD HAVE HAPPENED. I BELIEVE THAT THE ORIGINAL TIRES WERE DEFECTIVE, AND WE ARE NOW AFRAID TO DRIVE THE CAR AT ALL, EVEN THOUGH WE ARE PLANNING LONG TRIPS IN THE NEXT FEW WEEKS. I WANT THE REMAINING TIRES REPLACED BY MICHELIN ASAP, AND I WANT TO BE REIMBURSED FOR THE $300 I HAVE ALREADY SPENT ON THE FIRST 2 REPLACEMENT TIRES. HAVE THERE BEEN OTHER COMPLAINTS? WHAT SHOULD I DO? COULD YOU CONTACT MICHELIN FOR ME? VOLVO REFUSES TO DO ANYTHING. MY OFFICE PHONE NUMBER IS 781/431-9788, AND MY HOME PHONE NUMBER IS 781/641-0668. MY CELL PHONE NO. IS 617/645-4345. THANK YOU IN ADVANCE FOR YOUR PROMPT ASSISTANCE. *JB

• 09/15/2008· EQUIPMENT

  THE OEM JACK THAT CAME WITH MY VOLVO FAILED MISERABLY WHEN I HAD A FLAT TIRE. THE JACK WAS NEVER USED BEFORE THIS INCIDENT. WHILE THE JACK WAS PLACED ON A LEVEL SURFACE AND WAS COMPLETELY VERTICAL, THE FORCE NECESSARY TO SPIN THE JACK HANDLE CAUSED THE JACK TO VERY SLOWLY SLIDE SIDEWAYS IN AN INCREASINGLY PRECARIOUS POSITION. I STOPPED AND STARTED OVER SEVERAL TIMES ONLY TO RENDER THE SAME RESULT. AFTER SEVERAL ATTEMPTS, I WAS ABLE RAISE THE CAR HIGH ENOUGH TO ATTEMPT REMOVAL OF THE FLAT TIRE. THE JACK HOWEVER WAS VERY UNSTABLE. WHILE ATTEMPTING TO REMOVE THE TIRE, THE JACK FAILED AND THE CAR FELL TO THE GROUND. LUCKILY, THE FLAT TIRE WAS STILL ON THE CAR. SINCE I WAS IN MY PAVED DRIVEWAY, I WAS ABLE TO USE ANOTHER JACK. SINCE IT WASN'T A VOLVO JACK, I WAS ABLE TO USE WOODEN BLOCKS TO CRIB OR SECURE THE CAR BY STACKING WOOD UNDER THE CAR AS THE JACK RAISED THE CAR SO IT WOULDN'T FALL OFF THE JACK. THE VOLVO JACK IS BENT AND UNSAFE TO USE AGAIN, EVEN THOUGH IT WASN'T SAFE TO USE THE FIRST TIME. I AM REPORTING IT AS I HAVE FOUND MANY OTHER VOLVO OWNERS ON THE WEB WHO HAD THE SAME EXPERIENCE WITH THEIR VOLVOS. *TR

• 09/13/2005· VEHICLE SPEED CONTROL

  HAD PROBLEMS WITH CAR STALLING AT SLOW SPEEDS, BUT ALL OF A SUDDEN WHILE DRIVING ON A MAJOR HIGHWAY AT 65 MPH AND CAR LOST POWER. WE WERE ABLE TO GLIDE TO SHOULDER WHERE CAR STALLED. IT RESTARTED IMMEDIATELY, BUT ABOUT EVERY 5 MI. THE CAR WOULD STALL AGAIN. THE SERVICE DEPT. AT STAMFORD VOLVO TOLD ME I HAD BAD GAS AND THEY REPLACE A SENOR IN THE FUEL SYSTEM. AS SOON AS I LEFT THE DEALERSHIP AND GOT ON THE HIGHWAY THE CAR STALLED AGAIN. I BROUGHT IT BACK TO THE DEALER. THEY SERVICED THE CAR AGAIN AND TOLD ME THE WATER IN THE GAS RUSTED SOME SCREEN IN THE FUEL SYSTEM. THEY REPLACED IT AND THUS FAR THE CAR HASN'T' STALLED BUT THERE IS STILL SOME HESITATION WHILE DRIVING AT HIGH SPEEDS. *NM

• 09/12/2005· VEHICLE SPEED CONTROL

  RECENTLY WHILE DRIVING AT SPEEDS AROUND 40 MPH MY CAR EXPERIENCED A LOSS OF SPEED AND THEN STALLED. EACH EXPERIENCE HAS BEEN PRECEDED BY A BRIEF LOSS AND THEN BY A MORE PROLONGED LOSS AND FINALLY A COMPLETE ENGINE FAILURE WHICH LOCKS UP STEERING. IN EACH INSTANCE THE CAR HAS RESTARTED. THE MECHANIC SAID IT WAS MOST LIKELY A FAILURE OF THE ELECTRONIC THROTTLE CONTROL MODULE (ETM). STEPS ARE CURRENTLY BEING TAKEN TO REPLACE THE ETM. *NM

• 09/09/2005· VEHICLE SPEED CONTROL

  DT: 2003 VOLVO S60. VEHICLE STALLED/LOST POWER DUE TO THROTTLE BODY FAILURE. *AK THE VEHICLE STALLED A TOTAL OF SIX TIMES WHILE THE CONSUMER WAS ON A ROAD TRIP. THE VEHICLE WAS TAKEN TO A REPAIR FACILITY BUT THEY DIDN'T HAVE THE PART TO REPAIR THE PROBLEM. *NM

• 09/05/2015· ENGINE,FUEL/PROPULSION SYSTEM

  FUEL LEAK COMING FROM UNDERCARRIAGE PASSANGER RIGHT REAR SEATS, NEAR FUEL FILTER, OFF THE TOP OF THE GAS TANK. NOTICABLE SMELL AND HUGE HAZARD FOR SAFETY. WHAT MAKES IT PRESENCE DETECTED IS SMELL INSIDE CABIN AFTER FILLING GAS TANK AT FUELING STATIONS.

• 09/03/2003· WHEELS

  WHILE PULLING OUT OF A GAS STATION FRONT RIGHT WHEEL UNSCREWED AND COME COMPLETELY OFF. THE CAUSE OF THE FAILURE WAS UNDETERMINED.*AK

• 09/02/2018· FUEL/PROPULSION SYSTEM

  FUEL LEAKING FROM TANK (MOST LIKELY TOP OF TANK), WHEN FUEL PUMP IS OPERATING. UPON SOME SEARCH, I FOUND THAT THERE WAS A RECALL FOR THIS PROBLEM FOR THE S60 FROM 2001 TO 2009. BUT FOR SOME REASON MY VIN IS NOT COVERED. SEEMS LIKE THERE'S SOME LOOPHOLE THAT THEY MANAGED TO USE, WHY NOT ALL VINS SHOULD BE COVERED. ITS CLEARLY A VERY DANGEROUS FAILURE.

• 08/31/2015· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  I AM SURPRISED THERE HAS NOT BEEN A RECALL ISSUED FOR CERTAIN MODEL YEAR VOLVOS RELATIVE TO THE CENTER DASH MODULE LOSING ALL COMMUNICATION APPARENTLY DUE TO FAILED SOLDER CONNECTIONS (BASED ON CHAT-ROOMS, VOLVO SPECIFIC). I UNDERSTAND COMPONENTS CAN FAIL, BUT THE SHEER NUMBER OF FAILURES AND THE FAILURE MODE IS BEYOND TYPICAL OR EXPECTED FAILURES. THE FAILURE MODE CAUSES MOST OR ALL DASH GAUGES, INDICATORS AND LIGHTS TO FAIL, INCLUDING THE SPEEDOMETER. THESE FAILURES APPARENTLY OCCUR RANDOMLY, AND AT ANY AGE/MILEAGE.

• 08/29/2005· POWER TRAIN

  DT: 2003 VOLVO S60. VEHICLE STALLED AT LEAST 6 OR 7 TIMES AT VARIOUS SPEEDS. TRANSMISSION WAS REPLACED DUE TO STALLING. *AK

• 08/29/2005· VEHICLE SPEED CONTROL

  DT: THE CONTACT S BROUGHT CAR TO DEALER 3 TIMES BECAUSE IT WILL NOT START AFTER SITTING FOR AWHILE. . SHE OWNS A 2003 VOLVO MODEL S60 2.4T. THE FIRST TIME IT HAPPENED WAS ON 8-12-05. THE LAST TIME IT HAPPENED ON 8-27-05. ONCE IT TOOK OVER AN HOUR FOR IT TO START UP. EVERY TIME SHE FIXED IT, THE PROBLEM RECURRED. IT WILL INTERMITTENTLY NOT START. SHE WAS THE ORIGINAL OWNER. SHE DID NOT THINK SHE HAD THE ELECTRONIC THROTTLE MODULE (ETM) REPLACED. VEHICLE HAS NOT STALLED WHILE SHE WAS DRIVING, BUT AT TIMES IT SURGED FORWARD. *AK

• 08/25/2010· STRUCTURE,LATCHES/LOCKS/LINKAGES

  FRONT PASSENGER SIDE DOOR, WILL NOT OPEN FROM THE INSIDE AND WINDOW WILL NOT ROLL DOWN. WINDOW LOCKED IN PLACE AND THE MOTOR STRUGGLES IN ITS ATTEMPT TO ROLL IT DOWN. ALONG WITH THIS A WEEK LATER MY SUN ROOF DECIDED NOT TO OPEN, IN AN ATTEMPT TO OPEN THE SUN ROOF- ALL YOU HEAR IS A LOUD CLICKING SOUND. EVEN THEN IT BARELY CRACKS OPEN. *TR

• 08/25/2010· ENGINE AND ENGINE COOLING

  I HAVE A 2003 S60 VOLVO. WHILE DRIVING 55 MPH THE CAR WOULD GO INTO LIMP MODE AND THE SPEED WOULD QUICKLY DROP TO 10 MPH AND THE MESSAGE REDUCED ENGINE PERFORMANCE WOULD BE DISPLAYED. THE CAR WILL NOT ACCELERATE PAST THAT SPEED. THIS IS VERY SERIOUS SAFETY CONCERN BECAUSE THE QUICK DROP IN SPEED MAY LEAD TO AN ACCIDENT. I TOOK THE CAR TO A VOLVO DEALERSHIP AND WAS INFORMED THE CAR NEEDS THE ELECTRONIC THROTTLE SYSTEM REPLACED. THIS WAS A COMMON PROBLEM WITH OLDER MODELS AND A RECALL WAS ISSUED AFTER A CLASS ACTION LAWSUIT. MY MODEL IS NOT INCLUDED IN THIS RECALL, HOWEVER; IT IS EXHIBITING THE EXACT SAME PROBLEM THAT USUALLY OCCURS WHEN THE CAR REACHES 100,000 MILES. *TR

• 08/25/2009· FUEL SYSTEM, GASOLINE

  WE TO HAVE A 2003 S60 WITH A VERY BAD FUEL SMELL. WE BOUGHT IT USED IN 2006 FROM A VOLVO DEALER IN CARY, NC. OF COURSE, WHEN I CALLED VOLVO AND GAVE THEM THE VIN #, THEY SAID THAT WE WERE NOT COVERED. OUR CERTIFIED PRE OWNED STATUS EXPIRED IN FEB. OF THIS YEAR. I REALLY DON'T WANT TO SPEND $700+ TO GET SOMETHING FIXED THAT HAS BEEN A RECURRING PROBLEM FOR VOLVO. *TR

• 08/21/2007· FUEL SYSTEM, OTHER

  TL*THE CONTACT OWNS A 2003 VOLVO S60. WHILE DRIVING 35 MPH, THE ENTIRE VEHICLE BEGAN TO SHAKE, THE SERVICE ENGINE LIGHT ILLUMINATED, AND THE VEHICLE SHUT OFF. THE WEATHER CONDITIONS WERE RAINY AT THE TIME OF FAILURE. THE FAILURE OCCURRED IN THE MIDDLE OF THE ROAD. THE CONTACT PULLED OFF THE HIGHWAY AND THE VEHICLE RESTARTED AFTER 2-3 MINUTES. THE DEALER REPLACED THE FUEL PRESSURE SENSOR, BUT THE FAILURE PERSISTS. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 63,000.

• 08/19/2005· UNKNOWN OR OTHER

  DT: THE CONSUMER STATES THAT 2003 VOLVO S60 HAS AN INABILITY TO STOP IN REVERSE . THE BRAKES FAILED AND THE CAR ACCELERATED IN REVERSE. THIS OCCURRED AFTER THE CAR STARTED AND SPUTTERED. THE CONSUMER TOOK THE CAR TO THE DEALER, AND THEY SAID IT WAS A SOFTWARE PROBLEM, THE SOFTWARE WAS UPDATED. BUT THE CAR WAS STILL DOING THIS. THE CONSUMER HAS NOT CALLED THE MANUFACTURER. THE SOFTWARE WAS THE ONLY THING MENTIONED AS BEING THE PROBLEM WITH THE CAR. THE CAR HAS BEEN DOING THIS FOR ABOUT 2 YEARS. LATELY, THE CAR HAS BEEN DOING THIS MORE FREQUENTLY. *AK

• 08/17/2010· ELECTRICAL SYSTEM,EQUIPMENT

  2003 VOLVO S60 EXPERIENCED "DEATH" OF DRIVER INFORMATION MODULE (DIM), WHICH MONITORS ALL GAUGES ON THE VEHICLE. DEALERSHIP IS ABLE TO REPLACE THE PART FOR $1500! IT NOT AVAILABLE "AFTER MARKET" BY ANOTHER MANUFACTURER. RESEARCH ONLINE SHOWS THIS IS A VERY COMMON PROBLEM AMONG 2001-2003 MODELS. THIS MAJOR SAFETY CONCERN SHOULD BE INVESTIGATED, AS NUMEROUS PEOPLE ARE DRIVING WITHOUT DASH PANEL INFORMATION DUE TO THE EXORBITANT COST. THE PROBLEM BEGAN APPROXIMATELY TWO WEEKS AGO AND CANNOT BE REMEDIED WITHOUT BUYING THE DIM. *TR

• 08/17/2010· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT WAS DRIVING 55 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY REPLACED THE ELECTRONIC THROTTLE ASSEMBLY AT THE CONTACTS EXPENSE. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 64,000.

• 08/14/2020· STEERING,SUSPENSION

  TL* THE CONTACT OWN A 2003 VOLVO S60. THE CONTACT STATED THAT THE FRONT STRUTS WERE COMING THROUGH THE STRUT MOUNTS. THE CONTACT STATED THAT THE VEHICLE SHOOK VIOLENTLY WHILE DRIVING. THE CHECK ENGINE WARNING LIGHT AND ANOTHER UNKNOWN WARNING LIGHT WERE ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO CHERRY HILL VOLVO CARS (1810 W RTE 70, CHERRY HILL, NJ 08002), WHERE THE STRUT MOUNTS WERE REPLACED HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN BACK TO A DEALER OR AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TEST. THE CONTACT STATED THAT WAS HE AFRAID THAT WHILE DRIVING OVER A BUMP THE STRUTS MIGHT DETACH. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 126,000.

• 08/11/2012· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,AIR BAGS

  WHILE DRIVING OUT OF A PARKING LOT AND ACCELERATING TO 35 MPH, ENTIRE DASHBOARD BLACKED OUT. NO SPEEDOMETER, NO ODOMETER, NO GAS GAUGE,NO MESSAGE. RADIO, WINDOWS, AND AIR CONDITIONING CONTINUED TO WORK NORMALLY, AS DID HEADLIGHTS, INTERIOR LIGHTS, AND TURN SIGNALS. I TURNED OFF ENGINE AND THEN RESTARTED CAR. SAME SYMPTOMS. THE THIRD TIME I RESTARTED CAR I RECEIVED MESSAGE ON PANEL, SRS/AIRBAG SERVICE URGENT LIGHT COMES ON AND STAYS ON. I COULD NOT RETRIEVE ANY OTHER INFORMATION REGARDING AVERAGE SPEED, HOW FULL GAS TANK IS, ETC. I JUST WENT OUT TO MY CAR, WHICH HAS BEEN PARKED FOR ABOUT 21/2 HOURS SINCE THE INCIDENT, TO GET THE MILEAGE FOR THIS REPORT AND PANEL LIGHTS HAVE DISAPPEARED AGAIN! I WILL GET CAR TO MECHANIC TOMORROW, BUT I FEEL THIS IS A VERY DANGEROUS SITUATION TO BE IN,AND ESPECIALLY WITH NIGHT TIME OR HIGH SPEED HIGHWAY DRIVING! MY MILEAGE IS APPROXIMATELY 94,000 MILES. I COULD NOT GET A READING FROM MY ODOMETER AS THE PANEL IS BLACKED OUT AGAIN! *TR

• 08/11/2005· VEHICLE SPEED CONTROL

  BETWEEN 12/2004-6/2005 MY 2003 VOLVO S60 LOST POWER/ POWER DECREASES AT VARYING SPEEDS. THE MOST SIGNIFICANT WAS ON THE HWY GOING 65 MPH. I HAD JUST ACCELERATED TO GET ONTO THE HWY IN FRONT OF A SEMI TRUCK. MY CAR REACHED 65-70 MPH AND BEGAN TO DROP SPEEDS - 65 TO 55 TO 50 TO 40 WITH IN SECONDS. THE SEMI ALMOST RAN OVER ME BECAUSE THE SPEEDS DROPPED SO FAST. I CAUSED 2 OTHER CARS ON THE HWY TO GO ONTO THE SIDE RAMP OTHERWISE IT WOULD HAVE BEEN A HORRIBLE CRASH WITH THE SEMI. I HAVE TAKEN THE VEHICLE TO THE DEALER 3 TIMES COMPLAINING OF THE SAME PROBLEM. THE FINAL TIME STATING NOT TO GIVE THE CAR BACK UNTIL IT WAS FIXED. THE DEALER SAID THEY DOWNLOADED NEW SOFTWARE TO THE CAR? IF IT HAPPENS AGAIN THEY CAN INSTALL A BLACK BOX TO RECORD WHAT IS GOING ON. WHAT IF THE NEXT TIME THE SEMI DOES CRASH INTO ME? THE FIRST TIME THEY HAD THE CAR THE LABELED AS PEDAL POSITION SENSOR INSTALL/REPLACE? THE SECOND TIME THE INVOICE READS PRESSURE SENSOR INTAKE AIR REPLACED? ULTIMATELY, I SAW THE REPORT IN THE NEWS AND RECOGNIZED THE ISSUE TO EXACTLY WHAT HAPPENS TO MY CAR. I NOTICED THAT YOU DID NOT INCLUDE 2003 S60'S IN YOUR REPORT. I KNOW THESE SHOULD BE LOOKED AT AS WELL. I LOVE MY VOLVO I JUST DON'T FEEL VERY SAFE IN IT. PLEASE CONTACT ME FOR ANY QUESTIONS. *NM

• 08/09/2012· ELECTRICAL SYSTEM

  THE ENTIRE INSTRUMENT PANEL WENT DEAD, AND WILL NOT COME BACK TO LIFE. THE TACHOMETER, ODOMETER, SPEEDOMETER AND FUEL GAUGE ARE OFF AS THOUGH THE CAR IS OFF. SEVERAL MECHANICS HAVE QUOTED ME $1200+ TO REPLACE THE ENTIRE INSTRUMENT PANEL. THE INSTRUMENTS WENT DEAD WHILE I WAS ON THE INTERSTATE AND LEAVE ME WITHOUT THE INFORMATION I NEED TO SAFELY DRIVE. VOLVO SHOULD RECALL THESE VEHICLES AND REPLACE THE FAULTY PARTS, THERE A QUITE A FEW FORUMS ON THE INTERNET WHERE OTHER VOLVO DRIVERS HAVE THE SAME INSTRUMENT FAILURE. *TR