2003 Pontiac Sunfire

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/25/2004· STEERING,ENGINE AND ENGINE COOLING

  CREAKING NOISE IN THE STEERING WHEEL. INTERMEDIATE SHAFT WAS REPLACED. ALSO, BURNING SMELL COMING FROM UNDER THE HOOD. GASKETS REPLACED ON THE INTAKE MANIFOLD AND ALSO THE THROTTLE GASKET REPLACED.*AK

• 12/23/2007· ENGINE AND ENGINE COOLING,EQUIPMENT

  I BOUGHT MY GRAND PRIX FROM CHIP BANKS IN DUQUOIN, IL. IN AUGUST OF 2006 AND IT HAD ONLY 39,500 AFTER OWNING IT FOR 4 MONTHS THE HEAD STARTED TO MISFIRE. I HAD SOMEONE LOOK AT IT AND THEY SAID IT HAD BEEN HEALY COILED TO JUST TEMPORARILY FIX THE PROBLEM. I CONTACTED THE DEALER I BOUGHT THE CAR FROM AND THEY SAID THEY WOULD FIX MY CAR BUT I HAD TO PAY FOR IT. I DID NOT BUY THE EXTENDED WARRANTY FOR MY CAR BECAUSE I COULD NOT AFFORD IT AND IT DID NOT HAVE VERY MANY MILES ON IT SO I THOUGHT IT WOULD BE OKAY. I HAD IT HEALY COILED TO REPAIR IT AND IT HELD FOR 8 MONTHS AND NOW ALL THE OTHER ROCKER ARMS ARE NEEDING HEALY COILED IN BECAUSE THEY ARE WORN OUT AND THEY ARE DROPPING THE PUSH ROD INTO MY HEAD. I BOUGHT A NEW HEAD FOR MY CAR AND HAD IT INSTALLED AND NOW THE OTHER HEAD IS DOING THE SAME THING. PLEASE HELP ME. I AM THE MOTHER OF FOUR AND I AM LOW INCOME I CALLED CHIP BANKS AND THEY WILL NOT HELP ME AND I HAVE NO WAY TO GET MY KIDS AROUND. ONE THING ABOUT MY CAR IS ADVANCED AUTO WHERE I GOT MY HEAD FROM HAD TO SPECIAL ORDER IT BECAUSE IT HAD A 8 MM BOLT PATTERN SO I DON'T KNOW IF THAT HELPS ANSWER ANY QUESTIONS YOU MAY HAVE OR NOT. I GAVE $13,000.00 FOR THIS CAR AND I CANNOT AFFORD ANOTHER CAR AND I DON'T WANT ANOTHER CAR I LOVE MY GRAND PRIX I JUST NEED TO KNOW IF THE HEADS HAVE BEEN RECALLED OR SOMETHING. I TRIED TO GO ON CAR FAX.COM AND IT SAID MY CAR HAD ELEVEN REPORTS ON IT BUT I DO NOT OWN A CREDIT CARD SO I CANNOT PURCHASE IT TO FIND OUT WHAT HAS HAPPENED TO MY CAR. THE DEALERSHIP DID NOT TELL ME IF THE CAR HAD EVER BEEN WRECKED OR THE ENGINE MESSED UP OR ANYTHING. THANK YOU. *TR

• 12/21/2004· STEERING,FUEL SYSTEM, GASOLINE,STRUCTURE

  CONTINUAL EXPENSIVE REPAIR OF MY 2003 PONTIAC MONTANA. IN JAN. 2003.. DOOR HANDLES HAD TO BE REPAIRED BECAUSE THEY SNAPPED. (UNDER WARRANTY). IN OCTOBER 2004... GAS TANK HAD TO BE REPLACED BECAUSE THE NOZZLE CAME LOOSE FROM THE TANK, $900 REPAIR TODAY.. 12/21/04 VAN DID NOT PASS INSPECTION DUE TO RIGHT TIE ROD LOOSE AND ALIGNMENT $300 (CAR HAS 48,000 MILES ON IT. *AK

• 12/17/2003· SERVICE BRAKES, HYDRAULIC

  FRONT ROTORS ON THE CAR ARE DEFECTIVE. MY CAR WAS BROUGHT IN AT 6000 MILES WITH A COMPLAINT OF WARPED ROTORS CAUSING A VIBRATION UPON BRAKEING. AT THAT TIME I WAS TOLD THE ROTORS "WERE WITHIN SPECS". I BROUGHT THE CAR IN AT 14000 MILES WITH THE SAME COMPLAINT AND THE ROTORS WERE "RESURFACED AND THE PADS WERE BUFFED". I DID NOT RECEIVE THE CAR WITH RESURFACED ROTORS AND BUFFED PADS. THIS HAS BEEN A COMPLAINT SINCE I BOUGHT THE CAR IN FEBRUARY 2003. I FEEL SINCE THE CAR CAME WITH A DEFECTIVE PART, THE ROTORS AND THE BRAKE PADS SHOULD BE REPLACED WITH NEW ONES. THIS COULD BE A LIFE THREATING PROBLEM IF THE BRAKES FAIL DUE TO DEFECTIVE ROTORS.*AK

• 12/08/2009· ENGINE AND ENGINE COOLING

  I PURCHASED THE CAR IN 2006 WITH EVERYTHING ON IT STOCK. IN 2009 THE COIL PACK STARTED MISFIRING CAUSING THE CATALYTIC CONVERTER TO GO BAD AND ALSO CAUSING THE RODS BEARINGS TO SPIN. *TR

• 12/08/2003· EXTERIOR LIGHTING

  CONSUMER REPLACED DIRECTIONAL SIGNAL BULBS FOUR TIMES. CONSUMER BELIEVED THAT THIS WAS A SAFETY HAZARD BECAUSE WHEN PREPARING TO MAKE A TURN, AND LOOKING IN THE REAR VIEW MIRROR A VEHICLE WAS RIGHT NEXT TO HER. *AK

• 12/06/2007· ENGINE AND ENGINE COOLING

  CAR STALLED ON ME WHILE ON A BUSY ROAD. ENDED UP BEING RELATED TO THE CARS PASSLOCK SYSTEM. COST $500 FOR TOWING AND REPAIRS. PROBLEM APPEARS TO BE HAPPENING AGAIN AS CAR STALLED ON ME WHILE ON THE ROAD AGAIN ON 12/11/2007 AND WOULD NOT START UP AGAIN. APPARENTLY THIS IS A WIDESPREAD PROBLEM ON LATE 90'S EARLY 2000'S GM VEHICLES. IF THIS WERE TO HAPPEN TO SOMEONE ON THE INTERSTATE, I WOULD HATE TO IMAGINE WHAT WOULD HAPPEN AS EVERYTHING SHUTS DOWN ON THE CAR (I.E. POWER STEERING). VERY DANGEROUS!!! *TR

• 12/05/2007· ENGINE AND ENGINE COOLING

  3.1L INTAKE MANIFOLD GASKET LEAK. *TR

• 12/01/2004· ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM,EXTERIOR LIGHTING,AIR BAGS,STRUCTURE

  NUMEROUS OF FAILURES;AIR BAG LIGHT CAME ON AND STAYED ON, CLUTCH STICKS TO FLOOR, CAR DOESN'T WANT TO START. *BF THE TURN SIGNALS AND LIGHTS HAD GONE OUT, IT WOULD TAKE A COUPLE OF ATTEMPTS TO START THE VEHICLE, THERE WERE TIMES WHERE THE VEHICLE WOULD START ON IT'S OWN WITHOUT THE TURN OF THE KEY, THE VEHICLE USED AN EXTREME AMOUNT OF GAS, THE DASH WOULD RATTLE, THE ENGINE WOULD GROWL, THE DASH MADE A SOUND LIKE THE SPEAKER WAS BLOWN, THERE WAS A BURNING SMELL IN THE STEREO AND THERE WAS A THUMPING NOISE WHEN TURNING THE VEHICLE. (2003 PONTIAC SUNFIRE) *SC

• 11/23/2004· SERVICE BRAKES, HYDRAULIC

  WHEN EVER THE BRAKES WERE APPLIED, THEY WOULD CAUSE EXCESSIVE VIBRATIONS IN THE VEHICLE. ALSO, THE VEHICLE WAS NOT STOPPING PROPERLY AS IT SHOULD. THE CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP AND WAS INFORMED BY THE MECHANIC THAT THE FRONT BRAKE ROTORS NEEDED TO BE REPLACED. *JB *NM

• 11/18/2003· ENGINE AND ENGINE COOLING

  WHILE DRIVING AT ANY SPEED VEHICLE STALLED WITHOUT WARNING. VEHICLE HAD BEEN REPAIRED THREE TIMES. *AK

• 11/05/2004· FUEL SYSTEM, GASOLINE

  FUEL PRESSURE REGULATOR LEAKED. *BF *TC *JB

• 10/20/2005· SERVICE BRAKES, HYDRAULIC

  DT: THE CONTACT STATED THAT WHILE DRIVING THE BRAKES GRABBED AND LET GO, LIKE A PULSATION. TOOK THE VEHICLE TO THE DEALER THREE TIMES FOR THIS PROBLEM. THE FIRST TIME THE VEHICLE WAS AT THE DEALER THEY TURNED THE ROTORS. THE SECOND TIME THE DEALER CLEANED THE ROTORS. THE THIRD TIME THEY TURNED THE ROTORS FOR THE SECOND TIME. THE BRAKES WORKED, BUT THE CONTACT WAS CONCERNED ABOUT THE MULTIPLICITY OF TIMES THAT THE ROTORS WERE SERVICED. TWO DIFFERENT DEALERS TOLD THE CONTACT THEY HAVE SEEN THIS PROBLEM A LOT. MANUFACTURER SAID THEY WILL NOT FIX IT UNDER THE WARRANTY AND OFFERED NO HELP AT THEIR EXPENSE. *AK UPDATED 11/15/2005. *NM

• 09/30/2003· EXTERIOR LIGHTING

  LEFT BLINKER AND BRAKE LIGHTS NOT FUNCTIONING - PURCHASED VEHICLE 5/03 - MILEAGE 2300 MILES.

• 09/29/2004· EXTERIOR LIGHTING

  WHILE APPLYING THE BRAKES CONSUMER HAD ANOTHER DRIVER STAND BEHIND THE VEHICLE AND WATCH FOR THE BRAKE LIGHTS TO COME ON. CONSUMER HAD NO BRAKE LIGHTS. HE DROVE THE VEHICLE TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE BULBS NEEDED TO BE REPLACED. THIS CAUSED MOISTURE TO BECOME TRAPPED INSIDE. *AK REAR BRAKELIGHTS KEEP FAILING. THE VEHICLE HAS BEEN IN THE SHOP SIX TIMES.

• 09/28/2007· FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VISIBILITY,AIR BAGS

  I PURCHASED THE CAR IN OCTOBER 2003 AND THE CAR WAS GREAT. IN MARCH 2006 I STARTED HAVING PROBLEMS WHERE THE CAR WHEN ATTEMPTED TO START WOULD TAKE A FEW SECONDS EXTRA AND THEN START, THEN 6 MONTHS LATER I WAS DRIVING DOWN THE STREET AND THE CAR JUST CUT OFF IN THE MIDDLE OF AN INTERSECTION. THE CAR RESTARTED ABOUT 10 MINUTES LATER. THEN IN NOVEMBER THIS STARTED HAPPENING MORE AN MORE FREQUENTLY. ONE NIGHT IN DECEMBER THE CAR CUT OFF AND WOULD NOT RESTART AT ALL. I WAS ABLE TO PULL OF THE ROAD. I WAITED AN HOUR AND STILL THE CAR WOULD NOT START. I CAME BACK THE NEXT DAY AND THE CAR WOULD NOT START. I GOT THE CAR TOWED TO A MECHANIC WHO SAID THAT HE THOUGHT IT WAS THE FUEL PUMP SO I REPLACED THAT AND THE CAR WORKED FOR 2 DAYS AND THEN THE SAME PROBLEM AGAIN. HE THEN TESTED THE CAR AND SAW THERE WAS NO POWER GOING TO THE FUEL PUMP. I HAD HIM DO A TEMPORARY FIX AND RUN A LINE FROM THE BATTERY TO THE FUEL PUMP SO THE CAR WOULD STILL START. THEN EVERYTHING ELSE SLOWLY STARTED TO FAIL. THE AIR BAG LIGHT WOULD COME ON INTERMITTENTLY AND NOW STAYS ON. ONE LOW BEAM HEADLIGHT WENT OUT AND THEN THE OTHER FOLLOWED BY MY HIGH BEAM TOTALLY. MY FRONT LEFT TURN SIGNAL WENT THEN THE REAR RIGHT FOLLOWED BY THE FRONT RIGHT. MY HORN NO LONGER WORKS. I DON'T KNOW IF MY AIRBAGS WOULD DEPLOY IF I WAS IN AN ACCIDENT. THE WINDSHIELD WIPER RECENTLY STOPPED WORKING AS WELL. *JB

• 09/13/2004· SERVICE BRAKES, HYDRAULIC

  WHILE APPLYING THE BRAKES PEDAL WENT TO THE FLOOR AND HESITATED. ABS BRAKING LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. THIS CAUSED THE BRAKING SYSTEM TO ACTIVATE AND VEHICLE SKIDDED WHILE APPLYING THE BRAKES. CONSUMER DROVE IT TO THE DEALER FOR INSPECTION, BUT MECHANIC COULD NOT DUPLICATE THE PROBLEM.*AK

• 09/07/2009· POWER TRAIN

  1. HIGH USE OF TRANSMISSION SHIFT CABLE LEADS TO SEPARATION AT THE TRANSMISSION END LINK. 2. ONCE THE SHIFT CABLE LINK WEARS OUT IT FALLS DOWN AND THE TRANSMISSION CAN NO LONGER BE SHIFTED THROUGH GEAR POSITIONS FROM WITHIN THE VEHICLE. A VEHICLE CAN BE LEFT STRANDED IN ANY GEAR, DRIVE, REVERSE, NEUTRAL, OR ANY OTHER POSITION. 3. A TEMPORARY FIX IS POSSIBLE WITH A ZIP TIE, BUT IS ONLY TEMPORARY DUE TO HEAT AND WEAR ON THE ZIP TIE. AN OE REPLACEMENT FOR THE SHIFT CABLE NEEDS TO BE INSTALLED. THIS IS A HIGH FAILURE ITEM LEADING TO STRANDED VEHICLES IN MANY DANGEROUS LOCATIONS AND NEEDS TO BE UPGRADED WITH A FAIL SAFE CONNECTION AT THE TRANSMISSION END. *TR

• 09/05/2008· ELECTRICAL SYSTEM,STRUCTURE

  THE 2003 PONTIAC SUNFIRE IS AN INFERIOR CAR. MINE CURRENTLY HAS APPROX 57,000 MILES ON THE ODOMETER. THE DAY AFTER I PURCHASED IT BRAND NEW, IT WOULD NOT START. THE DEALER CAME OUT AND REPLACED THE BATTERY. THE CAR HAD WHITE PAINT OVERSPRAY ON IT. THE DEALER REPAINTED IT. THE SUNROOF MALFUNCTIONED AND THE DEALER FIXED IT. THE TURN SIGNALS KEPT GOING OUT & IT WAS FIXED DUE TO THE RECALL. THE DASH HAD TO BE TAKEN OUT DUE TO THE FACT THAT THE AIR WAS NOT COMING OUT OF THE VENTS PROPERLY. THE POWER WINDOW DRIVER'S SIDE FAILED COMPLETELY AROUND 38,000 MILES & PASSENGER INTERMITTENTLY WOULD NOT WORK. THIS WAS FIXED AT MY EXPENSE. THE CAR HAS BEEN IN THE SHOP FOR BRAKE PROBLEMS NUMEROUS TIMES. I HAD THE DEALER CHECK THEM SEVERAL TIMES WHILE STILL UNDER WARRANTY AND THEY FINALLY REPLACED THEM AT THEIR COST BECAUSE THEY SAID IT SHOULD NOT BE NECESSARY GIVEN THE MILEAGE ON THE CAR. I'VE HAD BRAKES REPLACED TWO OTHER TIMES AT MY EXPENSE AND THEY ARE STILL SQUEAKING AND CREAKING VERY LOUDLY AND I'M TOLD THE BRAKE PADS ARE "CRACKED" BUT THAT IT WON'T HURT ANYTHING. NOW, THE NEW PROBLEM IS, THE RADIO QUIT PLAYING FOR 15 MINUTES AFTER THE CAR IS TURNED OFF AND YOU'RE IN IT. WHEN I COME TO A COMPLETE STOP, MY DOME LIGHT AND MAP LIGHTS COME ON AND STAY ON UNTIL I LET OFF THE BRAKE AND ACCELERATE. ALSO, THE HORN NO LONGER HONKS WHEN I LOCK THE CAR WITH THE REMOTE. I'VE HAD IT UP TO HERE WITH THIS CAR BUT CANNOT AFFORD TO GET RID OF IT SINCE I JUST PAID IT OFF IN JULY 2008. I WILL NEVER BUY ANOTHER PONTIAC! *TR

• 09/05/2003· SERVICE BRAKES, HYDRAULIC

  BRAKE ROTORS WARPED AFTER LESS THAN 11,000 MILES OF TRAVEL; 2003 PONTIAC-SUNFIRE PURCHASED ON APRIL 29, 2003. I BELIEVE THAT THIS IS A BAD BATCH OF BRAKE PARTS OR THE COMPONENT IS EITHER UNDER DESIGNED OR IMPROPERLY SPECIFIED TO WITHSTAND DAY-TO-DAY CITY DRIVING CONDITIONS. A 2001 CHEVROLET-CAVALIER THAT I PREVIOUSLY OWNED EXHIBITED THE SAME INSUFFICIENCY IN IT'S BRAKE ROTORS THAT REQUIRED SERVICING THREE TIMES IN 60,000 MILES OF DRIVING. BOTH OF THESE CARS ARE ESSENTIALLY THE SAME WITH THE EXCEPTION OF TRIMS AND GM DIVISION NAME. THE COST TO RESURFACE SALVAGABLE ROTORS IS APPROXIMATELY $140 AT THE DEALER. IF THEY CAN'T BE RESURFACED THEN THEY HAVE TO BE REPLACED ENTIRELY. LOOK FORWARD TO YOUR RESPONSE.*AK

• 09/03/2014· ELECTRICAL SYSTEM,AIR BAGS,ENGINE

  EVERY TIME I LET MY CAR SIT FOR 2 HOURS OR MORE, I START IT UP AND THE BELT ON THE TENSIONER SQUEAK FOR 15 SECONDS. ALSO THE BATTERY LIGHT COMES ON AND THE RIM FLUCTUATE BETWEEN 1,000 AND 2,000. WHEN I DRIVE IT THE BATTERY LIGHT WILL CONTINUE TO STAY ON BUT EVERY TIME THE AIR BAG LIGHT TURNS ON AND I'M ACCELERATING THE ENGINE WILL NOT SHIFT, THE RPMS WILL REV UP TO RED LINE IF PUSHED THAT FAR, EVENTUALLY THE LIGHT FOR AIRBAG AND BATTERY WILL SHUT OFF AND IT WILL SHIFT. SOMETIMES WHEN I HIT THE GAS PEDAL WHILE THIS IS DOING THIS AT NIGHT, MY DASHBOARD AS WELL AS RADIO LIGHTS WILL SHUT OFF UNTIL RPMS GO DOWN TO 2,000. *TR

• 08/26/2003· POWER TRAIN

  WHILE APPLYING THE GEAR TO SHIFT AND WITHOUT PRIOR WARNING VEHICLE STARTED VIBRATING, AND THE TRANSMISSION LOCKED UP.*AK

• 08/20/2003· FUEL SYSTEM, OTHER,EXTERIOR LIGHTING

  VEHICLE HAS SEVERAL PROBLEMS; FUEL GAUGE IS NOT READING PROPERLY, CAUSING VEHICLE TO SHUT OFF WHEN THE GAUGE READS 1/4 FULL. ALSO, LEFT TURN SIGNAL LIGHT DOES NOT OPERATE ALL THE TIME. *AK

• 08/19/2014· ENGINE

  TL* THE CONTACT OWNS A 2003 PONTIAC SUNFIRE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A RATTLING NOISE FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TIMING CHAIN SEPARATED AND CAUSED THE TENSIONER AND VALVE TO FAIL. THE TIMING CHAIN VALVE AND TENSIONER WERE REPLACED, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 98,000.

• 08/14/2004· SERVICE BRAKES, AIR

  THE BRAKES ON MY 2003 SUNFIRE HAVE BEEN SERVICED 4 TIMES. THE FIRST TIME THEY WERE GRINDING AND I WAS TOL DNOTHING WAS WRONG. THEN 3,000 MILES LATER I WAS BACK IN THE SHOP AND THE BREAKS WERE GROUND. THAT WORKED FOR A LITTLE WHILE BUT NO SOONER WAS I BACK IN THE SHOP AND THE BREAKS WERE COMPLETELY CHANGED. WELL ITS BEEN LESS THEN 4,000 MILES SINCE THAT WAS DONE AND THE BREAKS ARE STARTING TO GRIND AGAIN.*AK

• 08/12/2005· EQUIPMENT

  PONTIAC SUNFIRE DEVELOPED A START UP PROBLEM.*MR THE VEHICLE WAS TAKEN TO THE DEALER WHO CLAIMED THAT THE CAUSE WAS A DEVICE BELIEVED TO BE INSTALLED DURING THE ANTI-THEFT SYSTEM RECALL. THEY SAID IT'S A POSSIBLE ASSOCIATION BETWEEN THE RECALL WORK AND A WIRE LEFT LOOSELY ATTACHED TO THE DEVICE, THAT WHEN CONTACT IS BROKEN, PREVENT THE VEHICLE FROM STARTING. THE CONSUMER PAID TO HAVE THE PART REMOVED. THE MANUFACTURER REFUSED TO HONOR THE VEHICLE WARRANTY CLAIMING THAT THE DEVICE WAS A NON-PONTIAC PART. THE CONSUMER IS ADAMANT THAT THE VEHICLE HAS HAD NO ADJUSTMENTS OTHER THAN REGULAR MAINTENANCE. *NM

• 08/09/2007· SUSPENSION

  THIS IS MY MOTHER'S CAR, NOT MINE, SHE'S 54 YEARS OLD AND SHE DOES NOT DRIVE CRAZY. LAST WEEK HER FRONT SPRING SUSPENSION BROKE FOR NO REASON. I'M A MECHANIC, AND I'VE NEVER EVEN HEARD OF THAT KIND OF FAILURE, IT HAD TO BE A MANUFACTURER DEFECT. WHEN SHE WENT AT THE DEALER (WHICH WASN'T WHERE SHE BOUGHT THE CAR) THEY SAID THAT HER CAR WASN'T UNDER WARRANTY, SO IT WOULD COST A $120 PLUS LABOR TO REPAIR THE CAR. SO SHE BOUGHT A USED PART AND HAD IT REPLACED. PERSONALLY, I THINK THE DEALER SHOULD HAVE TOLD HER, THAT THEY NEVER SEEN THAT TYPE OF PROBLEM BEFORE AND THEY SHOULD INFORMED THE MANUFACTURER OF THIS DEFECT. *TR

• 07/30/2004· ENGINE AND ENGINE COOLING

  VEHICLE INTERMITTENTLY STALL ON THE HIGHWAY WITHOUT WARNING. THE VEHICLE HAS BEEN TO THE DEALER EIGHT TIMES AND STILL HASN'T FOUND THE PROBLEM. *LA SINCE THE LAST CORRESPONDENCE THE CONSUMER WAS INVOLVED IN AN ACCIDENT WHEN HER VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A DIFFERENT DEALER WHO INFORMED THE CONSUMER THAT A SERVICE BULLETIN HAD BEEN ISSUED IN NOVEMBER 2003 REGARDING THIS PROBLEM. THE CONSUMER WAS NEVER NOTIFIED OF A RECALL FROM THE OTHER DEALER. *NM

• 07/23/2008· ELECTRICAL SYSTEM

  2005 HEADLIGHTS WENT OUT WHEN DRIVING AT NIGHT - PONTIAC DEALER WRAPPED HARNESS WITH ELECTRICAL TAPE. STATED IT WAS FROM WASHER FLUID LEAKING. APPROX 12 MONTHS LATER INCIDENT OCCUR AGAIN. TAKEN TO ANOTHER DEALER ON REQUEST OF PONTIAC. RE-WRAP HARNESS DIFFERENT AREA. SERVICE LIGHT ON 2 WEEKS AGO. DEALER WRAPPED ENTIRE HARNESS. PONTIAC SERVICE NOTIFIED SEVERAL TIMES COMPLAINT NUMBERS OBTAINED. SAFETY ISSUE AS LIGHTS GO OUT. WIRING HARNESS DETERIORATED. BANDAIDED 3X. CONCERN RE: LIGHTS GOING OUT AGAIN AT NIGHT. FEEL THIS IS A DANGEROUS SITUATION. *TR

• 07/22/2004· VISIBILITY

  OUTSIDE MIRROR VIBRATION AT INTERSTATE HIGHWAY SPEEDS, WHICH MAKES IT IMPOSSIBLE TO SEE VEHICLES ON THE SIDE AND REAR OF CAR. DEALER AND GENERAL MOTORS REFUSES TO CORRECT THE PROBLEM. WAS TOLD THAT THIS IS A "NORMAL OPERATING CHARACTERISTIC OF THIS MODEL." VEHICLE CAN NOT BE DRIVEN SAFELY AT HIGHER SPEEDS. *JB

• 07/14/2005· AIR BAGSCrash

  WHILE DRIVING 45 MPH MY AIRBAGS DEPLOYED FOR NO REASON WHICH CAUSED ME TO HIT A POLE. MY SEATBELTS UNLACHED DURING IMPACT.

• 07/13/2005· AIR BAGS,SEAT BELTSCrash

  DT: WHILE DRIVING ABOUT 45 MPH, THE AIRBAGS DEPLOYED INADVERTENTLY DEPLOYED WHICH CAUSED THE CONSUMER TO STRIKE A UTILITY POLE. THE SEAT BELT ALSO FAILED, IT UNLATCHED DURING THIS INCIDENT. THE VEHICLE WAS TOTALED AS A RESULT. THE CONSUMER HAD BEEN DRIVING FOR ABOUT 20 MINUTES WHEN THIS OCCURRED. NO REPAIRS HAVE BEEN MADE TO VEHICLE. *JB

• 07/13/2005· SERVICE BRAKES, AIR

  I HAVE A 2003 PONTIAC GRAND AM V6 AND AM ON MY 5TH SET OF LIFETIME WARRENTY BREAKS AND MY 2ND SET OF ROTORS. I HAVE ALSO HAD TO TAKE IT IN FOR THE GAS HAND MALFUNCTIONING AND THE MOTOR ON THE DRIVERS SIDE WINDOW IS NOT WORKING.

• 07/12/2007· VISIBILITY,EQUIPMENT

  DRIVER'S SIDE WINDOW BEGAN LOSING ABILITY TO LIFT/LOWER AFTER BEING LOWERED ONE DAY WHILE WINDOW HAD MOISTURE ON IT. TOOK IT TO GM DEALER AFTER WINDOW BECAME TOTALLY STUCK DOWN AND WAS TOLD IT WAS MOTOR. A MONTH LATER IT HAPPENED AGAIN. WAS TOLD IT WAS REGULATOR. THREE MONTHS LATER HAPPENED AGAIN, ONLY THIS TIME TO PASSENGER SIDE WINDOW. HAVE YET TO TAKE IT IN AGAIN BECAUSE CAR IS NO LONGER UNDER WARRANTY. IT IS MY UNDERSTANDING THAT WINDOW MOTOR REGULATOR SHOULD LAST AROUND 5 YEARS. IT ALSO MAKES ME WONDER WHY THIS ONLY HAPPENED AFTER THE WINDOWS WERE OPENED/SHUT WITH MOISTURE ON THEM (DEW FROM AM. THIS DOES POSE A SAFETY HAZARD IN MY OPINION AS WE HAVE TROUBLE MAKERS IN THE NEIGHBORHOOD WHO DELIGHT IN SHOOTING PAINT BALLS AT CARS AT NIGHT, AND I DON'T LIKE HAVING AN OPEN WINDOW IN WHICH IT CAN GO FLYING THROUGH AND HIT ME IN THE EYE/HEAD), AS WELL AS A GENERAL INCONVENIENCE. I WOULD LIKE AN INVESTIGATION DONE ON WHETHER OR NOT THE MOISTURE HAS ANYTHING TO DO WITH THESE FAILING WINDOWS. PLEASE UPDATE ON WHAT IS FOUND OUT. THANK YOU. AND I CHECKED PROPERTY DAMAGE BECAUSE OF THE MOISTURE DAMAGE THAT RESULTED TO MY VEHICLE (AND EVERYTHING IN IT) BECAUSE OF A STORM WE HAD WHILE THE WINDOW WAS STUCK DOWN. SO TO ME THAT IS PROPERTY DAMAGE. *AK

• 07/07/2014· STEERING,ELECTRICAL SYSTEM

  I WAS DRIVING HOME FROM VERNON DOWN'S CASINO AND WAS MAKING A RIGHT AND WAS ABOUT TO SWITCH INTO THIRD GEAR THE RPM'S WHERE 3000 AND THE ENGINE JUST DIED ........ MAUGERI''S AUTO ON ALBANY AND BLEEKER ST. TOWED MY CAR TO HIS SHOP FIXED THE STEERING COLUMN AS A RESULT OF THE ENGINE DIEING THE WINDOW'S WONT ROLL UP AND THE INTERIOR JUST GOT SOAKED IN WET IN THE RAIN AFTER ON THE DATE OF 7/714 PAID ALMOST A GRAND FOR TOWING AND STEERING COLUMN IN THE VEHICLE . I AM A RECIPIENT OF THE TRAUMATIC BRAIN INJURY PROGRAM AND USE THE VEHICLE TO AND FROM MY STRUCTURED DAY AS WELL AS MY NEUROLOGIST AS WELL AS MY HEMATOLOGIST WHO'S OFFICES ARE 57 MILES AWAY FROM MY HOUSE IT IS GOING TO BE VERY UNCOMFORTABLE TO DRIVE TO MY DR. APPT. IN THE MORNING... I AM ON SOCIAL SECURITY DISABILITY AND A FIXED INCOME RECEIVER LESS THEN 700 DOLLARS A MONTH... *TR UPDATED 2/6/2015 *JS

• 07/06/2010· TIRES

  TL*THE CONTACT OWNS A 2003 PONTIAC SUNFIRE, WITH COOPER, TREND SETTER SE, SIZE P195/15/R15 REPLACEMENT TIRES. WHILE DRIVING APPROXIMATELY 65 MPH THE PASSENGER FRONT TIRE SEPARATED AND THE TREAD SEPARATED FROM THE STEEL BELT. THE CONTACT WAS ABLE TO DRIVE SAFELY ONTO THE EMERGENCY LANE. THE CONTACT SATED THE TIRE DID NOT DEFLATE; HOWEVER, THE WHEEL WELL AND THE REAR TIRE WERE DAMAGED. THE TIRE WAS REPLACED AT A LOCAL REPAIR SHOP. THE LOCAL MECHANIC STATED THAT THE FRONT DRIVER SIDE TIRE WAS ALSO CRACKED. A POLICE REPORT WAS FILED. THE FAILURE AND CURRENT MILEAGE WERE 90,000. UPDATED 12/30/10

• 07/03/2003· ELECTRICAL SYSTEM

  THE VEHICLE EXPERIENCED PROBLEM WITH THE TURN SIGNAL ON SIX OCCASIONS. THE TURN SIGNALS AND BRAKE LIGHTS WERE INOPERATIVE. *AK *CB *NLM

• 06/16/2013· AIR BAGS,SEAT BELTSCrash

  I WAS DRIVING ON THE HIGHWAY AROUND 5:00PM, PERFECT ROAD CONDITIONS. I STARTED CHOKING & SWERVED INTO ANOTHER LANE, OTHER DRIVER BLASTED HIS HORN & SCARED ME. I OVER COMPENSATED & LOST CONTROL OF MY CAR & ENDED UP HITTING THE MEDIAN. MY AIRBAGS DEPLOYED, THE PASSENGER SIDE WAS FINE, BUT THE DRIVERS SIDE DIDN'T DEPLOY CORRECTLY. THE AIR BAG CAME OUT OF THE SIDE & NOT DIRECTLY IN FRONT OF ME. THE AIRBAG BLEW MY REAR VIEW MIRROR OFF OF THE WIND SHIELD & ENDED UP BREAKING MY RIGHT HAND IN MULTIPLE PLACES. MY SEAT BELT ALSO CAME UNDONE. I AM ONLY 5 FEET TALL & IF THE AIRBAG HAD GONE OFF LIKE IT SHOULD'VE, I KNOW I WOULD HAVE HAD NUMEROUS INJURIES TO MY FACE & CHEST. THE REASON I AM MAKING A COMPLAINT IS DUE TO THE FACT THAT HAD I HIT THIS WALL HEAD ON, I MOST LIKELY WOULD'VE BEEN KILLED. AT THIS TIME I DO NOT KNOW THE VIN OR CORRECT MILES, MY CAR AS TOTALED & IT'S STILL WITH THE TOW COMPANY. I BELIEVE THIS, ALONG WITH THE SEAT BELT UNLOCKING ON IT'S OWN AFTER A SERIOUS ACCIDENT, TO BE TREMENDOUSLY DANGEROUS. *TR

• 06/16/2008· ELECTRICAL SYSTEM

  THE SPEEDOMETER IN THE VEHICLE BECOMES ERRATIC AFTER WARMING UP. ON A HOT DAY IT MAY NOT RESPOND AT ALL OR MAY RESET TO A NEGATIVE VALUE AND NOT RESPOND DURING MOVEMENT. IT ALSO LOCKS UP WHEN GOING DOWN THE HIGHWAY AT WHATEVER THE SUSTAINED SPEED HAS BEEN, GRADUALLY FALLING TO ZERO AS THE CAR ACCELERATES AND DECELERATES. *TR

• 06/15/2014· STEERING,SERVICE BRAKESCrash

  BOUGHT A 2003 PONTIAC SUNFIRE FROM A DEALERSHIP 5 MONTHS AGO. I TOLD THE OWNER/SALESMAN I WANTED A SAFE 1ST CAR FOR MY KID. MY KID AND SOME FRIENDS WERE DRIVING,IT WAS RAINING AND THE BACK TIRES STARTED TO SLIDE,MY KID REGAINED CONTROL OF THE CAR BRIEFLY AND SAID AFTER A FEW MINUTES THE STEERING LOCKED UP AND THEY ENDED UP IN A SPIN. THE CAR HIT AN OBJECT ON THE PASSENGER SIDE,SPUN AROUND AND HIT ANOTHER ON THE DRIVERS SIDE,THEN BOUNCED OFF THAT AND LANDED ACROSS A DEEP DITCH WHERE IT WAS HIT AGAIN IN THE REAR WHEN STOPPING. NO STEERING. NO BRAKES. THE ENGINE WAS STILL GOING EVEN THOUGH THE FRONT END OF THE CAR WAS WEDGED INTO THE EDGE OF THE PAVEMENT AND THE EMBANKMENT OF THE DITCH. BY THE GRACE OF GOD NO ONE WAS PHYSICALLY INJURED. WE HAD THE CAR TOWED TO OUR HOME. MY KID SAID THAT BEFORE THE ACCIDENT THE STEERING WHEEL FELT " WIGGLEY". WE LOOKED AT THAT AREA 1ST. THE STEERING COLUMN WAS LOOSE. THE PIVOT PIN FOR THE COLUMN WAS GONE. I SAW THERE WAS A RECALL IN OCTOBER OF 2008. I CALLED GM TO REQUEST THE RECORDS TO FIND OUT IF THE REPAIR WAS EVER DONE. THE GM REP REFUSED TO GIVE ME THE INFORMATION IN THE DATA BASE. HE SAID I COULD GET IT FROM A "CERTIFIED" GM DEALER! HE ALSO SAID THERE WAS NO RECALL ON THE STEERING, BUT THERE WAS OTHERS. I ASKED WHAT THEY WERE AND AGAIN HE SAID HE COULDN'T GIVE ME THAT INFORMATION. I ALSO OWN A PONTIAC G5 THAT'S BEEN WAITING FOR PARTS ON THE IGNITION RECALL. I HAVE BEEN ON A LIST AT MY DEALERSHIP. I AM MAD AS HELL! ALL MY KID HAS NOW IS THE COMFORT OF KNOWING THE FRIENDS WEREN'T HURT OR KILLED. SOME 1ST CAR, HUH? SPENT 5000.00 OF 401K MONEY FOR A DEATH TRAP THAT GM REFUSES TO GIVE ME THE DATABASE HISTORY ON. CAN'T DRIVE IT, CAN'T SELL IT, AND WITH NO HISTORY, CAN'T FIX IT. LIABILITY AND COMP, THAT'S ALL WE COULD AFFORD, INSURANCE IS TOO EXPENSIVE FOR YOUNG DRIVERS. THERE IS NO MIDDLE CLASS AND THIS KIND OF THING IS WHY. *JS

• 06/11/2005· FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM

  WAS DRIVING ON THE FREEWAY, TRAVELING AT 70 MPH AND ALL OF THE LIGHTS BOTH DASH AND EXTERIOR WENT OUT AND THE ENGINE STOPPED. PULLED TO THE SIDE OF THE HIGHWAY AND TRIED TO RESTART THE CAR, NO LUCK. WAITED FOR 30 MINUTES AND TRIED TO RESTART IT AND IT STARTED UP, BUT WHEN I GOT UP TO 40MPH, IT REPEATED WHAT IT DID BEFORE, PULLED TO THE SIDE OF THE ROAD AND WAITED ANOTHER 15 MINUTES AND IT STARTED AGAIN, AND IT DID IT AGAIN. AGAIN I PULLED TO THE SIDE OF THE ROAD AND WAITED, THEN IT STARTED, AND I FINALLY GOT IT TO AN EXIT OFF OF THE HIGHWAY. IT WOULD ONLY RUN AT 25MPH, ANYTHING ABOVE THAT IT WOULD REPEAT THE SAME SYMPTOMS AS ABOVE. THE NEXT DAY AFTER LEAVING THE CAR SIT OVERNIGHT, IT STARTED JUST FINE, RAN JUST FINE, EXCEPT THE ENGINE LIGHT CAME ON. TOOK IT TO THE DEALERSHIP, AND THEY RESET THE COMPUTER, THE CODE READ THAT IT WAS RUNNING TO LEAN, THEY CHECKED, BUT COULD NOT FIND ANY PROBLEMS. THE CAR WILL NOT RUN ABOVE 70MPH, THIS HAS HAPPENED THREE TIMES SINCE THE FIRST INCIDENT. THE ONLY REPAIRS THAT WERE DONE, WERE THE RECALLS ALREADY ON FILE FOR THIS VEHICLE.

• 06/10/2004· SERVICE BRAKES, HYDRAULIC,EXTERIOR LIGHTING

  WHILE DRIVING AT NIGHT, THE HEADLIGHTS FAILED. THIS CAUSED POOR VISIBILITY TO THE DRIVER. THE BRAKES BECAME INOPERATIVE. WHILE DRIVING AT ANY SPEED THE VEHICLE VIBRATES. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE ROTORS NEEDED TO BE REPLACED. *AK

• 06/08/2004· EXTERIOR LIGHTING

  REAR TAIL LIGHTS AND TURN SIGNALS-- BULBS BURNING OUT ON A WEEKLY BASIS, ONE BULB WAS MELTED IN THE SOCKET, BULBS HAVE BEEN REPLACED. I PLAN ON TAKING IT INTO THE DEALERSHIP NEXT WEEK.*AK

• 06/07/2005· EQUIPMENT

  THE ACCELERATOR STICKS OR "FLUTTERS".

• 06/04/2004· ELECTRICAL SYSTEM

  WHILE DRIVING 55 MPH ALL LIGHTS FROM THE VEHICLE TURNED OFF. THE CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND PULLED OVER. THE CONSUMER TURNED OFF THE VEHICLE AND WAS UNABLE TO START IT UP AGAIN. VEHICLE WAS TAKEN TO THE DEALER THE NEXT DAY FOR INSPECTION AND THE MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK THE PROBLEM RECURRED. *SC *JB

• 06/02/2010· ELECTRICAL SYSTEM

  TL*THE CONTACT OWNS A 2003 PONTIAC SUNFIRE. THE CONTACT STATED THAT ALL OF THE GAUGES ON THE INSTRUMENT PANEL STOPPED FUNCTIONING WHILE SHE WAS DRIVING 50 MPH. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE INSTRUMENT CLUSTER MALFUNCTIONED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 70,000.

• 06/02/2008· FUEL SYSTEM, GASOLINE

  FUEL PUMP WENT OUT ON 2003 GM PONTIAC SUNFIRE. LOST POWER ON HIGHWAY IN THE MIDDLE OF TRAFFIC ONLY 65K MILES ON THE CAR. *TR

• 05/31/2005· ENGINE AND ENGINE COOLING

  DT: BOUGHT VEHICLE BRAND NEW AND IT HAS BEEN IN THE REPAIR SHOP 15 TIMES FOR THE SAME PROBLEM. IT IS DYING AT RANDOM FOR NO REASON AND WILL NOT START BACK. SOMETIMES IT TAKES UP TO 20 MINUTES OR LONGER BEFORE IT WILL RESTART. MECHANIC HAD NO IDEA WHY THIS PROBLEM HAPPENED. THE CAR WAS TAKEN TO DIFFERENT DEALERSHIP, BUT NO ONE COULD FIGURE THIS OUT. TWO WEEKS AGO THE CAR WAS SUBJECTED TO A PRESSURIZED TEST. CONSUMER HAS THE CAR TOWED ON 5-31-2005 BECAUSE IT DIED, AND DID RESTART. THERE HAVE BEEN LOTS OF PROBLEMS TO TRY TO CORRECT, BUT NOTHING WORKED. THE CAR WAS KEPT AT THE DEALER FOR UP TO TWO WEEKS AT A TIME.*AK

• 05/27/2009· EXTERIOR LIGHTING

  TL*THE CONTACT OWNS A 2003 PONTIAC SUNFIRE. WHILE DRIVING APPROXIMATELY 40 MPH AT NIGHT, THE HEADLIGHTS SUDDENLY BECAME EXTREMELY DIM. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND REPAIRED ACCORDING TO A SAFETY RECALL. THE VEHICLE WAS TAKEN BACK TO THE DEALER ON THREE SEPARATE OCCASIONS FOR IDENTICAL FAILURES, BUT THE REPAIRS DID NOT CORRECT THE ISSUE. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 3,000 AND THE CURRENT MILEAGE WAS UNKNOWN.

• 05/16/2008· EXTERIOR LIGHTING

  REFERRING TO THE PASSENGER-SIDE HEADLIGHT: WHILE DRIVING MY CHILDREN HOME AFTER IT WAS ALREADY DARK, I NOTICED THAT THE PASSENGER-SIDE HEADLIGHT SEEMED A LITTLE DIMMER THAN THE DRIVER-SIDE HEADLIGHT. I ALSO HAD ON MY DRIVING LIGHTS THAT ARE BELOW THE HEADLIGHTS. WE WERE ON A PARTICULARLY DARK ROAD WHERE THERE IS A TENDENCY TO BE DEER, SO WHEN IT WAS CLEAR OF OPPOSING TRAFFIC, I PUT THE HIGH-BEAM LIGHTS ON. AFTER PUTTING THE HIGH-BEAMS ON, ALL THE LIGHTS.....HEADLIGHTS, HIGH-BEAMS, AND DRIVING LIGHTS WENT OUT....WHILE I WAS DRIVING. A RED "SERVICE" LIGHT CAME ON THE DASHBOARD. I WAS VERY STARTLED AT THIS AND HAD TO PULL OVER TO THE SIDE OF THE ROAD. I SWITCHED THE LIGHTS OFF AND THEN ON AGAIN AND NOTHING WOULD WORK AND THE "SERVICE" LIGHT REMAINED ON. FORTUNATELY, I WAS NOT IN A HIGH TRAFFIC AREA OR THIS COULD HAVE BEEN A VERY SERIOUS ACCIDENT WAITING TO HAPPEN, ESPECIALLY IF I PANICKED. MY CHILDREN WERE VERY WORRIED THAT WE WERE PULLED OFF IN THE DARK. I DECIDED TO SHUT THE CAR OFF, HOPING TO RESET SOMETHING, AND TURN IT BACK ON. WHEN I DID THIS, THE "SERVICE" LIGHT WAS NOT ON, AND THE HEADLIGHTS AND DRIVING LIGHTS CAME ON. THE PASSENGER-SIDE LIGHT WAS STILL DIM WHEN I LOOKED AT IT, AND I ALSO NOTICED THAT THE HIGH BEAM LIGHTS WERE LIT AND DIM, ALTHOUGH THE HIGH BEAM SWITCH INSIDE THE CAR WAS NOT ON. I BOUGHT A NEW HEADLIGHT AND CHANGED THE BULB, BUT THERE WAS NO CHANGE IN THE BRIGHTNESS OF THE HEADLIGHT, IT WAS STILL DIM. *TR