2003 Mini Cooper

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2023· STEERING,ELECTRICAL SYSTEM,VISIBILITY/WIPER

  No air or blower or heat to defog windshield. Water in driver-side foot well. Power steering intermittent fault. Engine continues running and panel gauge lights remain on with ignition off and key removed.

• 12/31/2015· POWER TRAIN

  THE CAR WOULD NOT EASILY SHIFT GEARS. WHEN I BROUGHT IT TO THE MINI COOPER DEALERSHIP, I WAS TOLD THAT ALL OF THE TRANSMISSION FLUID LEAKED OUT OF THE TRANSMISSION. THE TRANSMISSION IS "SEALED", SO THE TRANSMISSION FLUID CANNOT BE CHECKED OR CHANGED. I WAS TOLD THAT I NEEDED TO REPLACE THE TRANSMISSION AND CLUTCH. THE CAR SHOULD NOT HAVE A SEALED TRANSMISSION IF IT CAN DEVELOP A LEAK SO EASILY.

• 12/31/2015· STEERINGFire

  LOST POWER STEERING WITH BURNING SMELL AND LOTS OF SMOKE. AS EVIDENCED ON THE ATTACHED DOCUMENT, THE ENGINE WIRING HARNESS WAS BURNT. THE CAR COULD HAVE LOST ALL POWER. THE REPAIR BILL WAS $4097.91. I WAS WITHOUT A CAR FOR WEEKS WITH NO LOANER CAR OFFERED. NATIONAL MINI COOPER DENIED THAT THIS WAS AN ISSUE. THERE IS NOW A PENDING RECALL. THE NEW PARTS MIGHT ALSO NEED TO BE REPLACED. I WAS DRIVING ON THE HIGHWAY WHEN THIS OCCURRED.

• 12/31/2003· VISIBILITY

  WINDSHIELD CRACKED THREE DAYS AFTER PURCHASE. I DON'T REMEMBER ANY STONE DAMAGE BEING DONE. WHEN I WASHED MY CAR (HOT DAY), A CRACK DEVELOPED IN THE MID-RIGHT BOTTOM BORDER OF MY WINDSHIELD. I BROUGHT IT IN TO THE SERVICE DEPARTMENT, AND THEY TOLD ME IT WAS STONE DAMAGE.

• 12/29/2011· STEERING

  2003 MINI COOPER, POWER STEERING PUMP JUST QUIT MAKING THE CAR UNSAFE TOO DRIVE. WAS TOLD THIS IS A COMMON THING WITH THE MINI COOPER AND AFTER CHECKING ON LINE I SEE THERE IS A LOT OF PEOPLE HAVING THE SAME PROBLEM! I THINK BMW NEEDS TO STEP UP TO THE PLATE AND TAKE CARE OF THIS!!! AFTER ALL 800 DOLLARS FOR A NEW ONE IS A BIT MUCH!!! *KB

• 12/29/2008· POWER TRAIN

  MY AUTOMATIC TRANSMISSION (CVT) BROKE WHILE PULLING AWAY FROM A STOP SIGN. CAR WAS WELL MAINTAINED, DEALER SERVICE ONLY. MILEAGE WAS ONLY 54K. *TR

• 12/28/2018· STEERING

  DRIVING NORMALLY ON CITY PAVED ROAD STARTED TO MAKE TURN ON SIDE STREET AND LOST TOTAL STEERING CONTROL AND WENT UP ON CURB JUST MISSING A PEDESTRIAN ON SIDEWALK.THIS VEHICLE HAS 79300 MILES.THE ELECTRIC HYDRAULIC PUMP COMPLETELY FAILED.MINI USA SAID THIS VIN IS NOT PART OF THE RECALL YET JUST ABOUT EVERY MINI INPORTED TO USA HAS COMPLETE STEERING LOSE 2002-2003-2004-2005 AND I BELIEVE THEY ARE HIDING THIS FROM YOU AND THE PUBLIC WHO ARE STILL BUYING THESE USED CARS AND NOT KNOWING THE DANGEROUS PROBLEM THE MINI HAS AND FLAWED POWER STEERING PUMP DESIGN.THANK YOU.

• 12/27/2011· STEERINGFire

  ON THE DATE OF INCIDENT I PARKED MY CAR IN A WELLS FARGO BANK PARKING LOT AFTER GOING TO THE GYM. UPON RETURNING TO MY CAR AN INDIVIDUAL WHO HAD PARKED NEXT TO ME INFORMED ME THAT "YOUR CAR IS SMOKING" I LOOKED AND WHITE SMOKE WAS COMING FROM UNDER THE HOOD. I OPENED THE HOOD TO INSPECT IT AND SAW WHITE SMOKE WHICH SMELLED ELECTRICAL. THE INDIVIDUAL WHO NOTICED SMOKE CAME OUT OF HER SUV TO HELP. SHE AND I LOOKED AND SHE INFORMED ME THAT SHE SAW A SMALL FLAME COMING FROM UNDER THE ENGINE. I SAW IT AND EXTINGUISHED IT WITH A BOTTLE OF WATER I HAD. I THEN HEARD AN ELECTRICAL SPINNING/HUMMING AS IF SOMETHING WAS STILL ELECTRICALLY CHARGED. THE SMOKE THEN BEGAN TO INTENSIFY AND GOT SO OUT OF CONTROL I WAS TEMPTED TO CALL 911 BUT THEN I THOUGHT TO DISCONNECT ANY POWER TO THE CAR BY DISCONNECTING THE BATTERY. THIS ACTION CUT ALL POWER TO THE CAR AND STOPPED THE SMOKE AND ELECTRICAL SPINNING/HUMMING. I CALLED AAA AND HAD MY CAR TOWED TO MY MECHANIC. ON THE EVENING OF 12/23/2011 MY MECHANIC CALLED ME AND INFORMED ME THAT MY POWER STEERING PUMP HAD FAILED AND ESTIMATED THE REPAIRS AT $1,046. ON 12/26/2011 MY CAR WAS RETURNED TO ME BY MY MECHANIC WHO SHOWED ME THE FAILED POWER STEERING PUMP WHICH MELTED OTHER WIRES AND COMPONENTS OF THE POWER STEERING MECHANISM. TOTAL OUT-OF-POCKET EXPENSES WAS $1,053. *TR

• 12/26/2013· POWER TRAIN

  MINI COOPER WITH A CVT AUTO TRANSMISSION: I NOTICED THAT THE ENGINE WOULD "REV." UP WHEN I STEP ON THE GAS PEDAL, AND THE CAR WOULD NOT ACCELERATE. I PULLED OVER AND SHUT OF THE ENGINE, THAN RESTARTED THE ENGINE AND MOVED AHEAD. LATER THE "SLIPPING" HAPPENED AGAIN AND AGAIN; AT ALL SPEEDS AND WITH A COLD OR HOT ENGINE. IN ADDITION, THIS PROBLEM HAS OCCURRED WHILE TRAVELING AT HIGHWAY SPEEDS 55+MPH, AND THIS REQUIRES COASTING OVER TO A BREAKDOWN LANE TO AVOID A COLLISION. THE CONDITION STILL EXISTS AND I AM TRYING TO LOCATE AN INDEPENDENT REPAIR SHOP TO DIAGNOSE THE PROBLEM AND HOPEFULLY RECTIFY THE PROBLEM AT A REASONABLE COST. MINI COOPER DEALERS ARE ASKING BETWEEN $5000 TO $9000.00 TO REPAIR/REPLACE THE TRANSMISSION. I HAVE REASON TO BELIEVE THAT MINI KNEW ABOUT THIS PROBLEM AS EARLY AS 2005. ASIDE FROM DOING WARRANTY REPAIRS NO ATTEMPT HAS BEEN MADE BY MINI TO NOTIFY OWNERS AND/OR OFFER TO REPAIR/REPLACE THESE FAULTY TRANSMISSIONS. *TR

• 12/21/2019· STEERING

  WE KNOW OF TWICE THAT OUR CAR'S POWER STEERING PUMP FAILED WHILE IN MOTION. AFTER BMW WAS FINALLY FORCED INTO A RECALL FOR THE POWER STEERING PUMP FAILURE AND WE RECEIVED A NOTIFICATION, WE TOOK OUR CAR TO CENTURY BMW IN GREENVILLE, SC. THE SERVICE DEPARTMENT CHECKED OUR WORK REGARDING REPLACEMENT PUMP, FAN, ETC. AND DEEMED IT 100% SATISFACTORY. WE SUBMITTED THE PAPERWORK AND INVOICE FOR THE REPAIR AND WAITED (REQUESTED . AFTER 16 WEEKS AND NO REIMBURSEMENT OR NOTIFICATION, WE CALLED AND WAS INFORMED BY THE SERVICE DEPARTMENT MANAGER THAT BMW WOULDN'T PAY US ANYTHING BECAUSE WE DIDN'T USE OEM PARTS. WHY WOULD WE KEEP REPLACING THE PUMP (THIS WAS THE 3RD PUMP THAT WE KNOW OF) WITH A DEFECTIVE ONE (BY ZF) THAT KEPT QUITTING? WE REPLACED IT WITH DORMAN (WELL-KNOWN MANUFACTURER OF QUALITY PARTS) WHICH HAD A LIFE-TIME WARRANTY (LIFE-TIME!) AND WAS MUCH CHEAPER. THE SD MANAGER EVEN SAID THAT SINCE HE'D SEEN SO MANY REPAIRS USING THAT BRAND OF POWER STEERING PUMP HE HAD RESEARCHED THEM AND FOUND NOTHING WRONG WITH THEM. BUT BMW DECIDED THEY WOULDN'T PAY FOR THIS. THERE WAS NOTHING IN THE RECALL LETTER THAT SAID OEM HAD TO BE USED OR THEY WOULDN'T REIMBURSE FOR REPAIRS. I BELIEVE BMW SAW SO MANY DORMAN PUMPS USED THEY KNEW THEY COULD SAVE A LOT OF MONEY BY REFUSING TO PAY. WE FILED A COMPLAINT WITH THE SC DEPT. OF CONSUMER AFFAIRS BUT BMW WOULDN'T ANSWER THEM SO THEY JUST DROPPED IT, LETTING BMW GET BY WITH THIS. WE WERE ONLY REQUESTING $721.04 WHICH IS LESS THAN HALF OF WHAT A REPAIR SHOP WOULD HAVE CHARGED. CAN YOU DO ANYTHING ABOUT THIS? WE FILED THE COMPLAINT WITH SC CONSUMER AFFAIRS IN DECEMBER OF 2017, TOOK THE CAR TO BMW IN MAY OF 2017 SO THIS HAS BEEN GOING ON FOR A WHILE. HAVE OTHER OWNERS HAD THIS PROBLEM? HAS A LAWSUIT BEEN STARTED AGAINST BMW?

• 12/21/2012· STEERING

  POWERSTEERING UNIT FAILS AND STEERING BECOMES UNREPONSIVE. *TR

• 12/20/2006· ELECTRICAL SYSTEM

  WHILE DRIVING AT A THREE WAY INTERSECTION MY MINI SUDDENLY CUT OUT AND BLOCKED TRAFFIC IN ALL DIRECTIONS; SO MUCH SO THAT PEOPLE HAD TO STOP TRAFFIC AND CARS NEEDED TO BE BACKED UP TO GET MY CAR IN A SECURE PLACE. THIS WAS DUE TO A DEFECTIVE WIRING HARNESS. INITIAL ESTIMATE FOR REPAIR WAS $1200 PARTS AND LABOR, BUT UPON MY COMPLAINT JUST LABOR WAS CHARGED ME - I FEEL NEITHER IS APPROPRIATE AS THIS IS A PRODUCT ISSUE, IN MY CASE A SAFETY ISSUE, AND I SHOULD BE REINSTATED TO MY PRE-HARNESS INCIDENCE AT THE PRODUCT OWNER'S EXPENSE. I FURTHER NOTICE THAT THERE IS A T.O. FOR THIS ITEM AND PART OF IT STATES ONLY REPLACE AT OWNER'S COMPLAINT - IN MY CASE THIS WAS ALMOST TOO LATE AS I WAS IN A VERY BUSY AREA WHEN MY CAR DIED AND SHUT DOWN THREE LANES OF TRAFFIC. *JB

• 12/20/2004· ELECTRONIC STABILITY CONTROL,SERVICE BRAKES, HYDRAULIC

  DYNAMIC STABILTY CONTROL, ABS AND FLAT TIRE WARNING LIGHTS ILLUMINATED INTERMITENTLY WHEN STARTING VEHICLE AND DO NOT GO AWAY UNLESS VEHICLE IS RESTARTED. DYNAMIC STABILITY CONTROL MODULE FAULT. *AK

• 12/20/2004· ELECTRONIC STABILITY CONTROL,SERVICE BRAKES, HYDRAULIC

  DYNAMIC STABILTY CONTROL, FLAT TIRE AND ABS LIGHTS COME ON WHILE DRIVING. DEALER HAS REPLACED DYNAMIC STABILTY CONTROL MODULE, PART 34 51 6 765 289. ALSO FOUND LEFT FRONT WHEEL SPEED SENSOR CRUSHED BETWEEN SUBFRAME AND CAR. REPLACED PART 34 52 6 756 384. *AK

• 12/20/2004· VISIBILITY

  DRIVER SIDE POWER WINDOW WILL LOCK UP AND NOT MOVE, MOTOR AND REGULATOR REPLACED AGAIN. *AK

• 12/20/2004· ENGINE AND ENGINE COOLING

  VEHICLE WILL SOMETIMES STALL WITHOUT WARNING. VEHICLE HAS THE LATEST VERSION OF ENGINE CONTROLLER SOFTWARE THAT HAS CORRECTIONS FOR STALLING. DEALER CANNOT DETERMINE THE PROBLEM. *AK

• 12/20/2004· AIR BAGS

  AIR BAG LIGHTS COME ON WHILE DRIVING.*AK

• 12/17/2011· STEERING

  THE POWER STEERING PUMP FAILED WHILE DRIVING AND PROCEEDED TO FAIL INTERMITTENTLY FOR SEVERAL MONTHS WITH NO WARNING, SOMETIMES AT HIGH RATES OF SPEED AND IN TURNS. THE POWER STEERING PUMP QUIT FOR GOOD APPROXIMATELY SIX MONTHS LATER. I COULD HAVE BEEN SEVERELY INJURED OR KILLED - OR WORSE, HURT SOMEONE ELSE. THE MINI COOPER IS VERY HARD TO STEER WITHOUT POWER STEERING. I'M A STRONG WOMAN BUT IT TAKES SOME SERIOUS UPPER ARM STRENGTH AND CORE STRENGTH TO CONTROL THE VEHICLE MANUALLY. THE MOST DISTURBING PART IS THE LACK OF WARNING. THERE IS NO CLUE THAT YOU ARE ABOUT TO LOSE POWER. THESE PARTS ARE PROHIBITIVELY EXPENSIVE AND THERE IS A SHORTAGE OF MECHANICS WILLING TO WORK ON THESE CARS IN OUR AREA. I DON'T KNOW IF THE POWER STEERING FAN WAS AFFECTED, AS WELL, BUT I SUSPECT IT BROKE SOMEWHERE IN THAT TIME, TOO. I KNOW THERE ARE INCIDENTS OF THESE CARS CATCHING FIRE, AND THANKFULLY, WE HAVE NOT EXPERIENCED THAT. PLEASE HELP. THIS IS SO DANGEROUS. *TR

• 12/17/2003· VEHICLE SPEED CONTROL

  MY 2003 MINI COOPER S, UPON ACCELERATION, EXPERIENCES AN EXCESSIVE LOSS OF POWER THAT HAS PUT ME IN THE POSITION OF NEARLY BEING HIT BY ONCOMING TRAFFIC WHEN PULLING INTO TRAFFIC FLOW. I HAVE HAD THE VEHICLE IN TO THE DEALER IN CINCINNATI 5 TIMES, AND THOUGH THEY CLAIM THE VEHICLE IS REPAIRED, AND DRIVES 'NORMALLY' IT STILL NEARLY STALLS WHEN ACCELERATING FROM A STANDSTILL. *AK

• 12/16/2010· STEERING

  HI THERE IS A PROBLEM WITH MY MINI COOPER LOSING POWER STEERING , I HAVE LOST THE POWER STEERING FEW TIMES THIS WEEK AND WHEN I TOOK IT TO THE BMW NEAR MY AREA THEY TOLD ME ITS A KNOWN PROBLEM WITH MINI CARS FROM 2001 TO 2005 AS THE PSP ( POWER STEERING PUMP ) ON THE MODELS HAVE A FAULT AND YOU MAY LOSE THE STEERING POWER AT ANY TIME . I ALMOST HAD 2 ACCIDENTS BECAUSE OF THIS WEEK AND THEY ARE ASKING MY TO PAY 550 FOR A NEW PUMP . IF THEY HAVE A FAULTY PUMP AND THEY NOW IT CAN RISK LIVES THEY SHOULD RECALL IT OR OFFER TO FIX THIS FOR PEOPLE WHO ARE AFFECTED . *TR

• 12/15/2015· STEERING

  TL* THE CONTACT OWNS A 2003 MINI COOPER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V6600000 (STEERING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. WHILE DRIVING 5 MPH WHEN ATTEMPTING TO TURN THE VEHICLE, THE STEERING WHEEL MALFUNCTIONED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THE VEHICLE, BUT THE RESULTS WERE UNKNOWN. THE VEHICLE WAS REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

• 12/15/2008· SUSPENSION

  MY CAR'S RIGHT REAR CONTROL ARM HAD BROKEN IN HALF. THIS ARM PREVENTS THE TIRE FROM SWINGING SIDEWAYS. LUCKY FOR ME, I WAS GOING SLOWLY AT THE TIME. THE CONTROL ARM CONSISTS OF TWO 1/4" PIECES OF METAL WITH HOLES IN THEM AT EVENLY SPACED POINTS. BOTH OF THE METAL ARMS WERE BROKEN IN LINE WITH THE HOLES THAT WERE PART OF THE MANUFACTURED DESIGN. I PAID $1900 FOR AN EXTENDED WARRANTY THROUGH UNIVERSAL UNDERWRITERS(NOW CALLED ZURICH) AT MINI OF CONCORD, CALIFORNIA. CONTROL ARM REPLACEMENT IS LISTED AS COVERED. THEIR REASON FOR NOT COVERING IT IS BECAUSE IT HAS A SLIGHT BEND IN IT (I DON'T SEE IT) AND IT IS BECAUSE OF THAT IT EVENTUALLY BROKE. THE METAL THAT MAKES UP THIS ARM IS NO MORE THAN 1/4" THICK: POORLY MADE, ESPECIALLY WHEN COUPLED WITH THESE HOLES THAT ARE IN IT. THIS PART SHOULD BE MADE TO WITHSTAND IMPACT. TO ME IT IS OBVIOUS THIS IS A MANUFACTURING DEFECT AND I AM APPALLED THAT NEITHER THE DEALER OR THE INSURANCE COMPANY THAT I BOUGHT MY EXTENDED WARRANTY FROM WILL PAY FOR IT. I COULD HAVE BEEN KILLED HAD I BEEN ON THE FREEWAY WHEN THIS HAPPENED. I HAVE GONE FROM A MINI LOVER TO ONE WHO WILL SELL IT AFTER I'M ABLE TO AFFORD TO REPAIR IT. I AM CURRENTLY PRICE COMPARING IN PRIVATE REPAIR SHOPS. *TR

• 12/14/2014· SUSPENSION,ELECTRICAL SYSTEM

  THIS MINI COOPER A 2003 W/130K MILES DRIVEN BY A YOUNG FEMALE. SHE HAD NO IDEA HER WHEEL WAS GOING TO FALL OFF THE DRIVER SIDE FRONT. SHE HAD CALLED FOR A CHECK ENGINE LIGHT ON AND INTERMITTENT BATTERY FAILURE. IT WAS ASK THAT I DRIVE THE CAR AND LISTEN TO A POP COMING FROM THE WHEEL SECTION. THE POP WAS THE ENTIRE WHEEL ASSEMBLY MOVING FORWARDS AND BACK BUMPING THE WHEEL WELLS AS THE CAR WENT FORWARD. NEEDLESS TO SAY I DIDN'T DRIVE FAR NOR DID I ACCELERATE FASTER THAN 10 MPH. I TOLD THE PARENT OF THE DRIVER THAT THE CAR WAS NOT DRIVABLE UNDER ANY CONDITION AND THAT IT NEEDED IMMEDIATE ATTENTION. THE LOWER CONTROL ARM BUSHING RUBBER WAS COMPLETELY GONE. I DO NOT KNOW IF THIS IS A DEFECT. THIS PART IS A MOUNT AND IT'S HOLDING MANY COMPONENTS OF THIS CAR TOGETHER. IT IS NOTHING LIKE I HAVE SEEN BEFORE USED AS A MOUNT. I HAVE SEEN THE RUBBER WORN FROM THIS TYPE PART BUT THEY WERE NOT BEING USED AS A MOUNT. WHEN THE RUBBER ON THIS PART DETERIORATES IT CAUSES THE MOUNT TO BE UNSTABLE RESULTING IN THE WHOLE WHEEL ASSEMBLY MOVING LIKE A SWING FORWARDS AND BACKWARDS WHILE DRIVING. IN A TRAFFIC SITUATION THIS COULD BE DEVASTATING TO MORE THAN JUST THE DRIVER OF THIS CAR BUT ALSO TO THE CARS DRIVING NEAR IF THE WHEEL WERE TO COME OFF IN THEIR TRAFFIC. NEEDLESS TO SAY THE MINI COOPER WOULD IMMEDIATELY FAIL IN TRAFFIC WITH THE BRAKE CYLINDERS HITTING THE ROAD CAUSING FLYING SPARKS, IF REAR ENDED IT WOULD MORE THAN LIKELY FLIP. THIS IS A DANGEROUS SCENARIO. THIS CAR WAS PURCHASED SECOND HAND AS ARE A LOT OF CARS. THIS IS NOT A PART ON ANYONE'S CHECK LIST AND NOT ONE YOU CONSIDER TO BE ONE OF THIS TYPE OF FAILURE. I AM FILING THIS COMPLAINT BUT I AM NOT THE OWNER OF THIS CAR. I AM MERELY CONCERNED AT THE IMPLICATIONS OF THE DETERIORATION OF THE RUBBER AND WHAT THOSE IMPLICATIONS MEAN TO THE OTHER PURPOSE THIS PART IS SUPPOSE TO PERFORM AND CAN'T WHEN THE RUBBER IS GONE. *TR

• 12/14/2011· STEERING

  TL* THE CONTACT OWNS A 2003 MINI COOPER S. WHILE DRIVING AT APPROXIMATELY 25 MPH THE STEERING WHEEL BECAME STIFF AND DIFFICULT TO MANEUVER. THE CONTACT RESTARTED THE VEHICLE AND REGAINED POWER STEERING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC. THE MECHANIC STATED THE ELECTRIC POWER STEERING PUMP WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.

• 12/14/2010· STEERINGFire

  TL* THE CONTACT OWNS A 2003 MINI COOPER S. THE VEHICLE WAS PARKED AND SHUT OFF FOR APPROXIMATELY 30 MINUTES WHEN THE CONTACT WAS ADVISED THAT THE VEHICLE WAS ON FIRE. THE CONTACT STATED THAT FIRE WAS COMING FROM UNDER THE HOOD. THE FIRE EXTINGUISHED INDEPENDENTLY AND THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR FACILITY. THE CONTACT WAS INFORMED THAT THE POWER STEERING REMAINED ON WHILE THE VEHICLE WAS SHUT OFF AND CAUSED THE FIRE. THE POWER STEERING PUMP, WIRING HARNESS AND BATTERY WERE ALL REPLACED. THE FAILURE DID NOT RECUR. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 92,000.

• 12/14/2010· STEERING

  POWER STEERING PUMP FAILED, CAUSING HARD TO CONTROL CONDITIONS IN VEHICLE. *TR

• 12/13/2013· STEERING

  BACK IN MAY OF 2013 THE POWER STEERING PUMP STARTING BEING VERY LOUD AND MAKING NOISES. THE STEERING WHEEL IS ALSO QUITE HARD TO TURN SINCE THEN. THIS COULD END UP BADLY WHEN COMPLETELY FAILS WHEN I'M MID-TURN OR SOMETHING. THIS NEEDS TO BE FIXED ASAP. *TR

• 12/12/2012· STEERING,ELECTRICAL SYSTEMFire

  I PARKED MY CAR IN A PARKING GARAGE AFTER DRIVING APPROXIMATELY 20 MILES. I WALKED TO A DENTIST DOWN THE STREET FOR AN APPOINTMENT. WHILE AT THE DENTIST I GET A CALL THAT WENT TO MY VOICEMAIL THAT MY CAR (WHILE PARKED WITH THE ENGINE OFF) WAS ON FIRE AND WAS FILLING THE PARKING GARAGE WITH SMOKE. UPON RECEIVING THE MESSAGE I RUSHED HOME TO FIND THAT THE FIRE WAS ALREADY OUT, BUT THE SMELL OF SMOKE WAS STILL VERY STRONG. I NOTICED THAT THE INSIDE INDICATING LIGHTS OF THE CAR WERE ON AS IF THE KEY WAS IN THE IGNITION OF THE CAR. I IMMEDIATELY DISCONNECTED THE BATTERY AND INSPECTED THE CAR TO FIND THE SOURCE OF THE FIRE. UPON INSPECTION I FOUND THAT THE FLAMES HAD COME FROM BEHIND AND SLIGHTLY BELOW THE MOTOR. THERE WAS A METAL SHIELD THAT WAS BLACKENED BY THE FLAMES THAT I COULD NOT SEE AROUND SO I JACKED UP THE CAR AND REMOVED THE DRIVER SIDE WHEEL TO FURTHER INSPECT THE SOURCE OF THE FIRE. AFTER DOING SO I COULD THEN CLEARLY SEE THAT THE SOURCE OF THE FIRE WAS THE POWER STEERING PUMP DUE TO THE SURROUNDING BURN MARKS. THE TOTAL AMOUNT OF DAMAGE HAS YET TO BE ASSESSED BY MY INSURANCE COMPANY. THEY TOWED THE CAR AND ARE INSPECTING THE CAR ON DEC 13, 2012. *TR

• 12/12/2008· SUSPENSIONCrash

  CONSUMER WANTS TO KNOW IF THERE ARE ANY RECALLS FOR 2003 MINI COOPER S. CONSUMER STATES THAT HER SON WAS KILLED WHILE DRIVING HIS MINI COOPER S BACK IN JULY 2008. *NJ THE CONSUMER WAS TOLD HER SON LOST CONTROL OF THE VEHICLE. THE CONSUMER DISCOVERED RECALL 03V086000 AND WANTED TO KNOW COULD THE RECALL HAVE BEEN A CONTRIBUTING FACTORY. *JB

• 12/12/2008· POWER TRAIN

  I OWN A 2003 MINI COOPER WITH A CVT AUTOMATIC TRANSMISSION. THE CAR HAS 80000 MILES ON IT AND THE CVT FAILED COMPLETELY. THERE IS NO ALTERNATIVE BUT TO GET A NEW REPLACEMENT WITH AN "UPDATED" 2005 MODEL WHICH I HAVE BEEN QUOTED FROM 2 PLACES $8000 FOR PARTS AND LABOR. THIS IS MY COMPLAINT. IF THEY KNOW THERE IS A PROBLEM WITH THE CVT WHY HAVE THEY NOT CONTACTED ME? PLEASE CONTACT IF YOU NEED FURTHER DETAILS. *TR

• 12/10/2014· STEERING

  WHILE ADJUSTING THE TILT CONTROL ON MY MINI COOPER, I DISCOVERED THAT THE ENTIRE STEERING COLUMN HAD BECOME LOOSE. UPON INSPECTION, I DISCOVERED THAT TWO METAL BRACKETS USED TO SUPPORT THE STEERING COLUMN AND ATTENDANT ASSEMBLY HAD SHEERED OFF, APPARENTLY UNDER NORMAL USE. *TR

• 12/10/2012· STEERING

  ONE NIGHT I'M DRIVING JUST NORMALLY ON THE HIGHWAY, EVERYTHING WAS FINE, NO SIGNS OF ANY OTHER PARTS INCLUDED AND OUT OF NOWHERE MY POWER STEERING GOES OUT. I ALMOST GOT INTO AN ACCIDENT. *TR

• 12/10/2010· STEERING

  I PURCHASED A 2003 MINI COOPER S USED IN NOVEMBER 2007. IT HAD 30,000 MILES. SHORTLY AFTER PURCHASE THE POWER STEERING PUMP WENT OUT. THE DEALERSHIP REPLACED IT PROMPTLY, DEC. 2007. I AM NOW EXPERIENCING INTERMITTENT POWER STEERING FAILURE AGAIN, AT 79,000 MILES, 49,000 MILES ON A NEW PUMP. IT COMES AND GOES WHILE DRIVING. VERY DANGEROUS WHILE TAKING CURVES. *TR

• 12/10/2003· VISIBILITY

  2003 MINI COOPER S PURCHASED NEW; AT APPROX 4500 MILES 6-INCH CRACK APPEARED OVERNIGHT IN LOWER RIGHT CORNER OF WINDSHIELD. VEHICLE WAS PARKED AT THE TIME AND THERE WAS NO VISIBLE DAMAGE ANYWHERE ON WINDSHIELD. SINCE THEN, CRACK HAS PROGRESSED NEARLY TO CENTER OF WINDSHIELD. TOOK VEHICLE TO DEALER AND WAS TOLD THAT THE CRACK WAS THE RESULT OF A STONE HITTING THE WINDSHIELD. SERVICE MANAGER "PROVED" THIS BY TRACING CRACK WITH A BALLPOINT PEN UNTIL IT ENCOUNTERED A MICROSCOPIC, NEARLY INVISIBLE "PIT" ALONG THE CRACK. DEALER DECLINED TO REPLACE UNDER WARRANTY. PERSONAL OPINION, SUPPORTED BY EXPERIENCE OF OTHER MINI OWNERS: STRESS CRACK PROBABLY CAUSED BY INCORRECT INSTALLATION OR UNDERDESIGNED WINDSHIELD. IN ANY CASE, MINI HAS BEEN INCONSISTENT IN SOLUTION, REPLACING SOME CUSTOMERS' WINDSHIELDS UNDER WARRANTY AND REFUSING TO REPLACE OTHERS, LIKE MINE.

• 12/09/2014· STEERING,POWER TRAIN

  TRANSMISSION. *TR

• 12/08/2004· FUEL SYSTEM, GASOLINEFire

  DRIVING HOME THE CAR STALLED AND CAUGHT FIRE. *BF MINI USA EXPERTS WERE UNABLE TO DIAGNOSE THE ROOT OF THE FIRE. *SC THE CONSUMER SPOKE TO 2 OTHER DIFFERENT CAR EXPERTS WHO WERE POSITIVE THAT THE PROBLEM WAS A DEFECTIVE FUEL LINE THAT CONTINUED TO PUMP FUEL ALL OVER THE ENGINE PARTS. *JB

• 12/07/2009· STEERINGFire

  MY 2003 MINI COOPER S SPONTANEOUSLY CAUGHT FIRE WHILE PARALLEL PARKING IN LOS ANGELES, CA. THE POWER STEERING PUMP FAILED, A FIRE SHORTLY FOLLOWED. THE LOS ANGELES FIRE DEPT. WAS PHONED. CAR NEEDED TO BE TOWED. *TR

• 12/06/2011· STEERINGFire

  THE INCIDENT OCCURRED BACK IN JUNE 27, 2007. I PARKED MY CAR AND THEN NOTICED THERE WAS SMOKE COMING FROM THE FRONT OF THE CAR. OPENED THE BONNET AND THERE WERE FLAMES COMING FROM THE UNDERSIDE OF THE ENGINE. THE FIRST ATTEMPT AT USING A FIRE EXTINGUISHER TEMPORARILY PUT OUT THE FIRE, BUT IT RE-IGNITED AND AT THIS POINT CALLED THE FIRE DEPARTMENT TO PUT IT OUT SAFELY. THE BMW DEALER KEPT SAYING THERE WAS NEVER A FIRE, JUST SMOLDERING. THE "SMOLDERING" WAS THE CAUSE OF A STEERING PUMP FAILURE WHICH OVERHEATS, WHICH IN TURN DAMAGED THE LOOM (HARNESS, OR MAIN WIRING FOR THE VEHICLE), WHICH ALSO RUINED THE BATTERY. THE COST WAS OVER $1000 TO REPAIR THE "SMOLDERING" DAMAGES. PRIOR TO THE STEERING PUMP FAILURE, THERE WAS NO INDICATION THAT THERE WERE STEERING PROBLEMS, NOR ANY POSSIBLE ELECTRICAL PROBLEMS. CAR MILEAGE WAS AT 65,525 AT THE TIME OF THE INCIDENT. *TR

• 12/06/2007· STEERING,POWER TRAIN,VISIBILITY

  I WILL BE INSTALLING WHAT WILL BE THE THIRD MANUAL 5-SPEED TRANSMISSION IN MY MINI. SAME PROBLEM, SEEMS TO BE THE FINAL DRIVE BEARING IS FAILING LIKELY DUE TO LACK OF LUBRICATION. I HAVE RECORDS OF ALL SERVICE AND CHECK IT REGULARLY AND IT HAS NEVER BEEN LOW. THE BEARING IS APPARENTLY NOT GETTING A PROPER SUPPLY OF FLUID. PROBLEM NUMBER TWO, MY POWER STEERING PUMP FAILED ON ME ONCE. IT EXPLODED WHILE I WAS DRIVING. THE HOSES BASICALLY GOT TOO HOT AND BLEW UP. I FORTUNATELY WAS ABLE TO LIMP IT TO A SHOP WITHOUT ANY FIRE. ON ANOTHER OCCASION THE POWER STEERING FAN CONTINUED TO RUN EVEN WHEN THE IGNITION WAS SHUT OFF, NEEDED TO REPLACE THE ENTIRE PUMP THIS TIME WHICH COST ME $500 INSTALLED WITH A REMANUFACTURED PUMP. THIRD, I HAVE HAD TO PUT THREE WINDSHIELDS IN THE CAR. NONE OF THESE REPAIRS WERE WARRANTED! MINI NEEDS TO SUCK IT UP AND CLAIM RESPONSIBILITY FOR THESE SHODDILY MADE CARS, THEY HAVE MADE THEIR MONEY AND DON'T CARE TO HELP WITH ANYTHING. I AM A LOYAL BMW CUSTOMER BUT I THINK I WILL STICK WITH THE OLDER MODELS NOW AS THEY AREN'T IMPOSSIBLE TO WORK ON AND FIND PARTS FOR. GOD KNOWS I WILL NOT PAY 23 GRAND FOR THIS NIGHTMARE AGAIN. *TR

• 12/02/2009· STEERINGFire

  TL*THE CONTACT OWNS A 2003 MINI COOPER S PURCHASED NEW. HE STATED WHILE TRAVELING AT SPEEDS OF LESS THAN 65 MPH, THE VEHICLE BEGAN PULLING TO THE RIGHT. SHORTLY AFTER THAT THE BATTERY CHARGING WARNING LIGHT ILLUMINATED AND THE CONTACT IMMEDIATLEY SMELLED A BURNING ODOR. HE PULLED OVER AND FOUND THERE WAS A FIRE COMING FROM UNDER THE HOOD. THE FIRE DEPARTMENT ARRIVED SHORTLY AFTER HOWEVER HE HAD ALREADY EXTINGUISHED THE FIRE. THE INSURANCE COMPANY AND MECHANIC DETERMINED THE FIRE WAS A RESULT OF A FAULTY POWER STEERING PUMP COOLING FAN. THE VEHICLE WAS REPAIRED UNDER HIS INSURANCE COMPANY. THE FAILURE AND CURRENT MILEAGES WERE UNDER 88,000.THE VIN WAS NOT AVAILABLE.

• 12/02/2008· STRUCTURE

  SEVEN MONTHS PREGNANT AND LOCKED INSIDE OF MY 2003 MINI COOPER S BECAUSE THE CABLES INSIDE THE DOOR FROZE. HUSBAND HAD TO PULL ME OUT OF THE CAR VIA THE DRIVER'S WINDOW BECAUSE THERE WAS NO OTHER WAY OUT. ABLE TO INITIALLY GET IN AND OUT OF CAR BUT WITHIN A FEW MINUTES, THE DOORS FROZE AND I WAS STUCK. TALKED TO MINI USA AND DEALERSHIP AND BOTH SAID NEVER HEARD OF IT EVEN THOUGH NUMEROUS BLOGS AND COMPLAINTS EXIST FOR MINI COOPER S MADE BEFORE 04/2004. VERY WORRIED IN CASE OF EMERGENCY AND ME AND MY UNBORN CHILD NEED TO GET OUT. ALSO HAVE HAD MY TWO AND FOUR YEAR OLD GIRLS IN THE CAR WITH ME. FORTUNATELY DIDN'T HAPPEN WHEN THEY WERE PRESENT. *TR

• 12/02/2003· ENGINE AND ENGINE COOLING

  WHEN SITTING AT A TRAFFIC LIGHT, THE VEHICLE HAD THE TENDENCY TO SHUT DOWN COMPLETELY. THE DRIVER MUST WAIT SEVERAL MINUTES BEFORE ATTEMPTING TO START THE VEHICLE AGAIN. THE VEHICLE HAD BEEN TO THE DEALERSHIP 3 TIMES. EACH TIME, THE DEALERSHIP CLAIMED TO HAVE REPAIRED THE VEHICLE, BUT THE SAME PROBLEM RECURRED. *AK *SCC *JB

• 12/01/2008· ELECTRICAL SYSTEM

  BATTERY FAILURE. BATTERY HAS FAILED FOR THE THIRD TIME SINCE CAR BRAND NEW IN FEB, 2003. ON EACH OCCASION THE VEHICLE WOULD NOT START AFTER HAVING GIVEN NO WARNING. THE FIRST FAILURE WAS IN 2005 AT 26,000 MI., THE SECOND IN 2007 AT 51,000 MI., THE THIRD IN 2008 AT 68,000 MI. EACH FAILED BATTERY WAS A MANUFACTURER'S BRAND (MINI). *TR

• 12/01/2003· ENGINE AND ENGINE COOLING

  BELOW IS A QUOTE OF ANOTHER PERSON,I AM EXPERIENCING SIMILAR PROBLEMS EXCEPT FOR "TOTAL LOSS OF POWER" WHICH HAS NOT HAPPENED TO ME. ALSO, THE STUDDERING PROBLEM IN FIRST GEAR IS GREATLY REDUCED WHEN THE "ACTIVE SKID CONTROL" IS DISABLED.*AK MY MINI COOPER S WAS PURCHASED IN MAY 2003. "NEW MINI COOPER S AUTOMOBILE (PURCHASED IN JUNE OF 2003) EXPERIENCES A NOTICEABLE AND SIGNIFICANT STUMBLE WHEN ENGAGING FIRST GEAR AND ACCELERATING FROM A STOPPED POSITION. THE STUMBLE IS SIGNIFICANT ENOUGH TO CAUSE A STALL CONDITION AND RESULTS IN UNRELIABLE THROTTLE RESPONSE. THE PROBLEM IS WORSE AT HIGHER RPM ENGAGEMENTS, IN HOTTER WEATHER, AND WITH THE AC ENGAGED. THE STUMBLE FEELS LIKE A MOMENTARY LOSS OF POWER AND THEN SHORTLY THEREAFTER, POWER IS RETURNED TO THE WHEELS. THE PROBLEM OCCURS ON VIRTUALLY EVERY ENGAGEMENT BUT IS CONSIDERABLY WORSE ON THE FIRST ENGAGEMENT AFTER THE CAR HAS SAT FOR SEVERAL HOURS WITH THE ENGINE OFF. THE PROBLEM IS LESS SEVERE WHEN TURNING THE CAR LEFT OR RIGHT WHILE ENGAGING FIRST GEAR. THIS ISSUE RENDERS THE THROTTLE RESPONSE UNRELIABLE AND CAN STALL THE AUTOMOBILE AT UNEXPECTED TIMES. NO CRASHES HAVE OCCURRED AT THIS TIME BUT THE POTENTIAL FOR A REAR-END COLLISION DUE TO A STALL OR A SIDE IMPACT COLLISION DUE TO STALLING WHEN CROSSING AN INTERSECTION IS PRESENT. ADDITIONAL ISSUES RELATED TO ENGINE MANAGEMENT AND THROTTLE RESPONSE OCCUR IN THE SAME AUTOMOBILE HAVE OCCURRED BUT THESE ADDITIONAL PROBLEMS HAVE BEEN INTERMITTENT AND DIFFICULT TO REPRODUCE. IN GENERAL, THE ADDITIONAL PROBLEMS SEEM TO OCCUR IN ON TEMPERATURE DAYS WITH AC ENGAGED AND INCLUDE A FULL LOSS OF POWER FOR AN EXTENDED PERIOD OF TIME WHILE ENGAGING FIRST GEAR AND A NOTICEABLE SURGING DURING ACCELERATION AS IS THE DRIVER WAS PRESSING AND RELEASING THE GAS. *JB"

• 11/29/2009· STEERING,POWER TRAIN

  FAILURE OF 2003 MINI COOPER MANUAL TRANSMISSION. MY CAR HAS BEEN UNDER REGULAR MAINTENANCE. I FIRST NOTICED THE CAR LOSING POWER GOING UPHILL, THEN IT BECAME DIFFICULT TO PUT THE CAR IN GEAR. NEXT MORNING I WAS UNABLE TO GET INTO REVERSE, WAS EXTREMELY DIFFICULT TO SHIFT AND SOME GEARS COULD NOT BE ENGAGED. AT A STOP LIGHT I BEGAN HEARING A VERY LOUD GRINDING NOISE, LIKE METAL IN A BLENDER, THE CAR WOULD NOT ENGAGE IN GEAR, I HAD TO BE PUSHED OUT OF THE INTERSECTION. THE DEALER OFFERED NOTHING. MY PRIVATE MECHANIC FOUND METAL SHREDS THROUGHOUT THE TRANSMISSION. SAID A BEARING HAD COME LOOSE AND DESTROYED THE INTERIOR OF THE TRANSMISSION, ALL AT 65K MILES. HE ALSO SAID THE ENGINE COULD HAVE FAILED WHILE ON THE FREEWAY AT HIGH SPEEDS AND THIS COULD HAVE BEEN LIFE ENDANGERING. ALSO THE POWER STEERING PUMP WENT AT 30K MILES. BOTH VERY COSTLY REPAIRS AND THE TRANSMISSION LOCKING UP A VERY SERIOUS LIFE THREAT. THE REPLACEMENT COSTS FOR THE TRANSMISSION WERE $3K AND THAT WAS FROM A PRIVATE MECHANIC. ONLINE RESEARCH SHOWS A PLETHORA OF CONSUMER COMPLAINTS AND INFORMATION THAT MINI COOPER KNOWS ABOUT THIS. NEITHER THE LOCAL DEALER NOR CORPORATE OFFICE WOULD OFFER ANY HELP IN REPLACEMENT COSTS. *TR

• 11/28/2003· ENGINE AND ENGINE COOLING

  WHILE DRIVING ON A LOW SPEED, STOP AND GO TRAFFIC IN THE FREEWAY THE CAR SUDDENLY STALLED AND I WAS STOPPED IN THE FIRST LANE OF THE FREEWAY. I TRIED TO RE-START THE ENGINE SEVERAL TIMES WITH NO SUCESS, AFTER WAITING A FEW MINUTES THE ENGINE STARTED. I WAS VERY LUCKY THAT THE SUV DRIVING BEHIND WAS ABLE TO STOP BUT NOT BEFORE HITTING MY BUMPER. THIS IS THE SECOND TIME IT HAPPENED, THE FIRST TIME IT HAPPENED I WAS IN THE MIDDLE OF THE STREET AND HAD THE CAR TOWED BUT THE ENGINE STARTED AS SOON AS I GOT TO THE DEALER AND THEY TOLD ME THAT THEY COULD ONLY CHECK WHEN THE THE CARS IS STALLED. I HAVE 2 LITTLE KIDS AND I AM SCARED TO DRIVE WITH THE CAR.*AK

• 11/27/2010· EXTERIOR LIGHTING

  I AM THE 2ND OWNER OF THIS 03 MINI COOPER S SINCE 5/09. I PURCHASED WITH 12,500 MILES. CURRENTLY, 32K MILES. THE XENON LOW BEAM HEADLIGHT, DRIVERS SIDE, FREQUENTLY DOES NOT IGNITE. THE SELF LEVELING HEAD LIGHT SYSTEM DOES NOT OPERATE PROPERLY. THE AIMING DISTANCE IS VERY POOR, LIGHT SHINES APPROX 20FT IN FRONT OF THE CAR. OTHER TIMES, THE LIGHT SHINES HIGH, BLINDING ON-COMERS. THE 1ST OWNER COMPLAINED ABOUT THIS SAME PROBLEM TO A MINI DEALERSHIP IN 10/03 WITH 1,971 MILES. AGAIN, 5/08 WITH 9,000 MILES WITH CHECKS PERFORMED. THIS ESTABLISHED PROBLEM CONTINUES TO GET WORSE. BALLASTS AND BULBS HAVE BEEN CHANGED. THE PROBLEM CONTINUES. THIS IS A SAFETY HAZARD, MAKING IF DIFFICULT TO NAVIGATE AT NIGHT. AFTER DOING OUR OWN RESEARCH AND SEEING HOW MANY OTHERS ARE HAVING THIS EXACT SAME PROBLEM, IT IS TIME FOR MINI/BMW TO IMMEDIATELY ADDRESS THIS OVERDUE SAFETY HAZARD BY IMPLEMENTING A RECALL, OR A SERVICE BULLETIN TO ALL AFFECTED CONSUMERS WHO HAVE COMPLAINED TO CORRECT THIS PROBLEM. I WILL CONTINUE TO COMPLAIN UNTIL SOMETHING IS DONE. *TR

• 11/26/2014· STEERING,EXTERIOR LIGHTING,VISIBILITY/WIPER

  NIGHT DRIVING IN COLORADO MTNS. LIGHTS BEGAN TO FLICKER AND POWER STEERING FAILED. FOUND SAFE PLACE TO PULL OVER AND TURNED OFF LIGHTS AND ENGINE. RESTARTED AND TURNED LIGHTS BACK ON TO RESUME DRIVING WITHIN A FEW MINUETS LIGHTS FLICKERED AND POWER STEERING FAILED AGAIN. HAD TO CONTINUE FOR SEVERAL MILES UNTIL IT WAS SAFE TO PULL OVER AGAIN. ATTEMPTED TO TURN OFF HEAD LIGHTS AND USE FOG LIGHTS ON COUNTY DIRT ROAD, STILL LIGHTS FLICKERED/DIMMED AND POWER STEERING FAILED. CURRENTLY VEHICLE IS PARKED AND WE ARE ATTEMPTING TO RESEARCH RECALL MATTERS WITH THIS MALFUNCTION. SUPERIOR DRIVING SKILL IS REQUIRED TO OPERATE THIS VEHICLE WITH NONFUNCTIONAL POWER STEERING. AVERAGE OPERATORS WILL HAVE GREAT DIFFICULTY MAINTAINING SAFE OPERATION OF THE AUTOMOBILE. THIS ISSUE WILL LEAD TO LOSS OF LIFE IF NOT ADDRESSED. NEAREST DEALER FOR MINI IS 130 MILES DISTANT. *TR

• 11/24/2015· STEERING

  TL* THE CONTACT OWNS A 2003 MINI COOPER S. WHILE OPERATING THE VEHICLE AT LOW SPEEDS, THE STEERING WHEEL REQUIRED EXCESSIVE FORCE IN ORDER TO TURN. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE POWER STEERING FLUID LEAKED FROM THE POWER STEERING FLUID RESERVOIR. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 136,000.

• 11/23/2010· STEERING,SUSPENSION,ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES,SEATS,UNKNOWN OR OTHER

  MY 2003 MINI COOPER HAS ALMOST CAUGHT ON FIRE SEVERAL TIMES, REPLACED TRANSMISSION, ELECTRICAL HARNESS, POWER STEERING PUMP, A/C HOSES AND A/C SERVICE, WHEEL BEARINGS, INJECTION PLUGS ETC....... I STILL CANNOT FIND THE REAL PROBLEM WHY IS CAUSING A SHORT, IT HAS ALMOST CAUGHT ON FIRE SEVERAL TIMES, THIS CAR HAS BEEN THE MOST DANGEROUS CAR I HAVE EVER OWN, I HAVE NEVER SPEND SO MUCH MONEY ON TRYING TO FIX ANY VEHICLE, RIGHT NOW I'M ABOUT $11,500 IN COSTS OF REPAIRS, THIS IS A CRIME TO THE CONSUMER, I HAVE BEEN READING ABOUT A CLASS ACTION LAWSUIT THAT IS IN PROGRESS, I HOPE AND PRAY THAT WE GET JUSTICE FROM THE MAKER OF MINI. *TR