2003 KIA Sedona

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2015· AIR BAGSCrash

  TL* THE CONTACT OWNS A 2003 KIA SEDONA. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE CRASHED INTO A DEER AND CAUSED SIGNIFICANT DAMAGE TO THE FRONT END. DURING THE CRASH, THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 80,000.

• 12/30/2003· FUEL SYSTEM, GASOLINE

  WHILE DRIVING THE CONSUMER BEGAN TO SMELL FUEL. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM

• 12/29/2016· STRUCTURE

  TL* THE CONTACT OWNS A 2003 KIA SEDONA. THE CONTACT NOTICED THAT THE SUBFRAME WAS RUSTED WHEN IT WAS WET. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.

• 12/29/2009· SUSPENSION,SERVICE BRAKES, HYDRAULIC

  TL* THE CONTACT OWNS A 2003 KIA SEDONA. WHILE DRIVING APPROXIMATELY 20 MPH THE LEFT REAR WHEEL SEPARATED FROM THE VEHICLE. HE WAS ABLE TO PULL OVER ON THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE GARAGE. THE MANUFACTURER DID NOT TAKE A REPORT. THE ESTIMATED COST FOR THE REPAIR WAS $400.00. THE WHEEL BEARING SEALS, BREAK DRUM, AND MOUNTAIN PLATE MIGHT NEED TO BE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 130,000.

• 12/29/2008· WHEELS

  05V232000 - THIS MORNING MY LEFT REAR WHEEL CAME OFF MY 2003 KIA SEDONA AT THE HUB -- NOT THE LUGS AT THE HUB - FORTUNATELY I WASN'T DRIVING AT A HIGH RATE OF SPEED AND DUE TO THE NOISE IT WAS MAKING REALIZED THAT I HAD A PROBLEM. PER KIA - THE ABOVE MENTIONED RECALL DID NOT PERTAIN TO MY VEHICLE. *TR

• 12/29/2007· EXTERIOR LIGHTING

  I HAVE A KIA SEDONA VAN WITH APPROXIMATELY 65,000 MILES. IT HAS HAD NUMEROUS HEADLIGHTS BULBS THAT HAVE HAD TO BE REPLACED. IN AN ATTEMPT TO PREVENT THIS, THE DEALERSHIP HAS EVEN REPLACED THE ENTIRE HEADLIGHT. THE LAST TIME A BULB BURNED OUT THE DEALERSHIP REPLACED BOTH BULBS EVEN THOUGH ONLY ONE BULB BURNED OUT. THE RATIONAL FOR REPLACING BOTH BULBS WAS THAT ALL OF THE CURRENT WAS DIVERTED TO THE HEADLIGHT THAT WASN'T BURNED OUT, HENCE IT SHORTENED THE LIFE OF THE BULB THAT WAS WORKING. HOWEVER, SIX WEEKS LATER A NEW BULB WAS ALREADY BURNED OUT. AS I UNDERSTAND FROM TALKING WITH REPRESENTATIVES AT MY DEALERSHIP, THIS IS A COMMON OCCURANCE WITH THE KIA VAN. I HAVE HAD THIS PROBLEM TWICE WHEN TRAVELLING OUT OF STATE -- ONCE WHEN IT WAS FOGGY AND BOTH TIMES AT NIGHT. IT IS VERY DANGEROUS TO HAVE A CAR LOSE A HEADLIGHT OUT-OF-THE BLUE AT NIGHT WHEN TRAVELING ON UNFAMILIAR ROADS. PLUS, THIS IS BECOMING EXPENSIVE! *TR

• 12/29/2007· ENGINE AND ENGINE COOLING

  AT APPROXIMATELY 55,000 MILES MY KIA SEDONA VAN HAD A BROKEN ENGINE MOUNT. NOW, AT APPROXIMATELY 65,000 THE VAN HAS AN ADDITIONAL TWO BROKEN ENGINE MOUNTS -- THAT IS A TOTAL OF THREE BROKEN ENGINE MOUNTS IN ONLY 65,000 MILE'S!! THIS IS INCREDIBLY DANGEROUS -- AND THIS SHOULDN'T HAPPEN WITH THIS FREQUENCY, IF AT ALL!! *TR

• 12/28/2011· ELECTRICAL SYSTEMFire

  ON 12/26/2011 WE WENT OUT TO THE VAN (2003 KIA SEDONA) AND THE CAR WOULDN'T START. THE WHOLE VAN SMELLED LIKE MELTED PLASTIC. I LOOKED AT THE FUSE BOX AND THE ENTIRE THING WAS MELTED ALONG WITH THE TRIM AND CARPET. I HAVE PICTURES AND A MOVIE TO SHOW THE EXTENT OF THE DAMAGE. KIA OF PUTNAM CONNECTICUT REFUSED RESPONSIBILITY. THIS IS A SERIOUS SAFETY ISSUE. WE WERE NOT EVEN DRIVING THE CAR WHEN IT HAPPENED THE ISSUE HAPPENED OVERNIGHT. IF PICTURES ARE REQUESTED PLEASE EMAIL ME AT [XXX] THANK YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/24/2003· FUEL SYSTEM, GASOLINE

  ONLY 260 MILES ON VEHICLE AND CHECK ENGINE LIGHT CAME ON. DEALER STATED CHECK GAS CAP. STATED IT NEEDS TO "CLICK" 3 TIMES TO TIGHTEN AND SEAL. HAVE PERFORMED TASK REPEATEDLY WITH NO CHANGE. WHILE STANDING OUTSIDE OF VEHICLE, WITH VEHICLE RUNNING, CAN HEAR AIR SUCKING IN THROUGH GAS FILL AREA. NEVER HAD THAT HAPPEN ON ANY OTHER VEHICLE OWNED. NOTICED FLAPPER VALVE AT TOP OF GAS FILL AREA IS CREASED AND DOES NOT SEAL LIKE OTHER MANUFACTURERS VEHICLES. WORRIED THAT THIS AIR PROBLEM WILL CAUSE FUTURE ENGINE PROBLEMS. *AK

• 12/16/2008· SEAT BELTS

  TL*THE CONTACT OWNS A 2003 KIA SEDONA. THE CONTACT NOTICED THAT HER CHILD SAFETY SEAT WOULD INAPPROPRIATELY MOVE WITHIN THE DRIVER'S SIDE MIDDLE ROW SEAT WHEN IT WAS RESTRAINED BY THE SAFETY BELT. THE SEAT BELT WOULD NOT RETRACT PROPERLY, WHICH LEFT THE CHILD VULNERABLE TO SERIOUS INJURY IN THE EVENT OF A CRASH. SHE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT SHE WOULD HAVE TO REPLACE THE ENTIRE SEAT BELT UNIT. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 61,000 AND CURRENT MILEAGE WAS 64,000.

• 12/15/2003· ELECTRICAL SYSTEM,VISIBILITY

  POWER LOCKS FAILED WITHOUT WARNING. DEALER STATES AN ELECTRICAL SHORT OCCURRED. *AK

• 12/10/2022· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEMFire

  My Sedona keeps catching on fire not sure why but now if I get it up to temperature it automatically catches on fire I'm going into my second fire extinguishe

• 12/09/2018· WHEELS,SERVICE BRAKES

  THE BREAKS WERE CHANGED DUE TO GRINDING COM TO FIND OUT THERE WAS 1BOLT ON THE BREAK CALIBERS PUT THEM ON AND IT STILL GRINDS AND CAN NOT STOP

• 12/06/2011· STRUCTURE

  TL* THE CONTACT OWNS A 2003 KIA SEDONA. THE CONTACT STATED THAT THE REAR DOOR WAS UNABLE TO BE OPENED FROM THE INTERIOR OR EXTERIOR OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 120,000.

• 12/06/2008· ENGINE AND ENGINE COOLINGFire

  I WAS DRIVING MY KIA SEDONA 2003 EX ONE DAY AND SOMEONE YELLED AT ME THAT IT WAS ON FIRE. I IMMEDIATELY STOPPED AND THE FIRE CAME UP THROUGH THE WINDSHIELD, ALSO THE BOTTOM OF THE VEHICLE WHERE THE PANEL IS. I PROCEEDED TO INFORM THE DEALER, BECAUSE I HAD PURCHASED IT USED ON OCTOBER 19, 2007 AND THIS HAPPENED ON MARCH 10, 2008. THE ONLY REASON WHY THE DEALER PRETENDED TO DEAL WITH IT WAS BECAUSE I HAD INFORMED THE DEALER WITHIN LESS THAN A MONTH OF PURCHASING IT OF SOME DETAILS THAT NEEDED ATTENTION, BUT THEY HAD KEPT PUTTING IT OFF. THE DEALER PICKED UP THE KIA AFTER 2 WEEKS FROM THE INCIDENT AND THEY FIXED SOME HOLES THAT WERE BURNED, BUT ONLY THE ONES I COULD SEE. I WENT VARIOUS TIMES BECAUSE I KEPT HAVING PROBLEMS, THEY FIXED THE GEARS BUT, I KEPT HAVING PROBLEMS, EVERYTIME I WENT THEY PRETENDED TO FIX SOMETHING BUT DID NOTHING. I FOUND MYSELF IN A NO WIN SITUATION, ALL I COULD DO WAS TO TRY FIXING THINGS SLOWLY. I HAD TO PUT IN THE WIRE COVERINGS MYSELF, WHICH WERE BURNED, ALSO HAD TO PUT IN A NEW POWER STEERING HOLES, IT IS NOW ONE YEAR LATER AND THE CONSEQUENCES HAVE GOTTEN WORST, THE DEALER OWNER WILL NOT TALK TO ME. TO MY DISMAY RUBBER PARTS BURNT KEEP GIVING IN; EX: THE SEALER FOR THE VALVE COVER, THE TWO FAN BELTS (I DO HAVE MOST OLD PARTS THAT WERE REPLACED). WHEN THE SEAL COVER WAS REPLACED I REALIZED THAT THE DEALER DID NOT REPLACE THE MOST IMPORTANT PARTS; THAT BEING THE OXYGEN SENSOR WITH THE PLUGS WHICH ARE TOTALLY BURNT AND THE TPS(SENSOR). THE DEALER OWNER WILL NOT TAKE MY CALLS AND I CAN NOT AFFORD TO GET THIS FIXED, THEREFORE, I AM HAVING PROBLEMS WITH THE EXHAUST SYSTEM AND A LIGHT TURNED ON, I HAD IT SCANNED AND IT READS THE FOLLOWING: P0102 : LOW INPUT CIRCUIT MAF OR VAF. PLS ADVISE I HAVE SPOKEN TO DACO AND A LAWYER BUT RIGHT NOW EVERYTHING IS ON HOLD FOR ME. AND I CAN'T BELIEVE HOW THE OWNER OF THE DEALER IS NOT CONCERNED WHEN THIS VEHICLE IS A FAMILY VEHICLE AND I AM DISABLED. *TR

• 12/06/2006· SERVICE BRAKES, HYDRAULIC

  DT*: THE CONTACT STATED WHILE TRAVELING VARIOUS SPEEDS, THE STEERING WHEEL SHOOK WHEN THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO CLEANED THE BRAKES WITH A HARDWARE KIT. THE PROBLEM RECURRED, AND THE BRAKES WERE CLEANED TWO MORE TIMES. A COUPLE WEEKS LATER, THE PROBLEM RECURRED AGAIN. THE VEHICLE WAS BACK TO THE DEALER, WHO SUGGESTED THE ROTORS BE CUT. THE PROBLEM RECURRED A FIFTH TIME, AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHO REPLACED THE FRONT ROTORS AND SHOES. THE PROBLEM RECURRED 3-4 MONTHS LATER, AND THE FRONT SHOES WERE SHOT. THE INDEPENDENT REPAIR SHOP DETERMINED THAT THE FRONT BRAKES WORE QUICKLY BECAUSE THE REAR BRAKES WERE DEFECTIVE. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO PERFORMED A DIAGNOSTICS, AND DETERMINED THAT THE DRUMS WERE OUT OF ROUND AND THE REAR BRAKES NEEDED TO BE REPLACED BECAUSE THE INDEPENDENT REPAIR SHOP TIGHTENED THEM IMPROPERLY. THERE WERE NO FURTHER REPAIRS MADE BECAUSE THE SERVICE DEALER REFUSED TO PERFORM WORK ON THE VEHICLE.

• 12/01/2010· TIRES

  TL*THE CONTACT OWNS A 2003 KIA SEDONA EQUIPPED WITH BRIDGESTONE FIRESTONE FR380 TIRES, TIRE SIZE P215/70/R15. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH, AND THE FRONT END OF THE VEHICLE AND STEERING WHEEL BEGAN TO SHAKE. THE VEHICLE WAS TAKEN TO A TIRE CENTER WHERE THE FRONT DRIVER SIDE TIRE AND BOTH REAR TIRES WERE REPLACED. THE TECHNICIAN STATED THAT THE TIRE TREAD EXHIBITED PREMATURE WEAR. THE SIMILAR FAILURE RECURRED ONE YEAR AND NINE MONTHS AFTER THE REPLACEMENT OF THE THREE TIRES. THE CONTACT PLANNED TO NOTIFY THE TIRE CENTER FOR THE VEHICLE TO BE INSPECTED AND TO DETERMINE WHICH TIRE WAS DEFECTIVE. THE FAILURE MILEAGE WAS APPROXIMATELY 43,000. THE DOT NUMBER WAS UNKNOWN.

• 11/30/2012· ELECTRICAL SYSTEMFire

  TL* THE CONTACT OWNS A 2003 KIA SEDONA. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE CAUGHT ON FIRE FROM UNDER THE DRIVER'S SIDE DASHBOARD AREA. PRIOR TO THE FIRE, THE HORN ACTIVATED INDEPENDENTLY. THE VEHICLE WAS DESTROYED AND WAS NOT INSPECTED FOR THE CAUSE OF THE FIRE. THE FAILURE AND THE CURRENT MILEAGES WERE 115,000.

• 11/30/2006· FUEL SYSTEM, GASOLINE

  DT*: THE CONTACT STATED THE GAS STORAGE TANK RUSTED OUT CAUSING THE FUEL FILTER TO CLOG. THE SERVICE DEALER DETERMINED THE VEHICLE NEEDED A NEW STORAGE TANK AND FILTER TO CORRECT THE ISSUE. UPDATED 02/06/07. *JB

• 11/23/2003· EQUIPMENT

  IN EARLY SEPTEMBER, THE AIR CONDITIONING ON OUR NEW 2003 KIA SEDONA EX WENT OUT. WE TOOK IT INTO THE DEALERSHIP AND THEY SAID A ROCK HAD HIT THE CONDENSER UNIT AND DRAINED THE FREON. THIS UNIT SITS UNPROTECTED IN FRONT OF THE AIR INTAKE. THE SERVICE MANAGER CLAIMED THIS WAS A COMMON PROBLEM THAT MANY HAD EXPERIENCED. HE SAID IT WOULD COST $850 TO REPAIR AND THAT WE SHOULD PLACE A PROTECTIVE SCREEN AROUND THE UNIT SO IT DIDN'T HAPPEN AGAIN! I SENT A LETTER ON SEPT. 16TH TO MR. GEOFF BEDINE, THE PRESIDENT OF THE DEALERSHIP, BUT RECEIVED NO RESPONSE. ON OCTOBER 8TH, I STOPPED BY THE DEALERSHIP, BUT HE WAS NOT IN. THE SALES ASSOCIATE, MICHELLE WILSON, SUGGESTED I FAX A COPY OF THE LETTER TO HER AND SHE WOULD GIVE IT TO HIM. I WENT HOME AND DID JUST THAT, AND CALLED TO MAKE SURE SHE RECEIVED IT. SHE DID. HOWEVER, STILL NO RESPONSE AS OF NOV. 22ND! ON NOV. 13TH, I WENT TO THE KIA WEBSITE AND FILED CASE#242983 WITH THEIR CONSUMER ASSISTANCE DIVISION. I RECEIVED A CALL FROM MS. BEA UNDERWOOD ON NOV. 20TH, BUT SHE SAID A REGIONAL DIRECTOR CLAIMED THIS WAS AN INSURANCE ISSUE AND NOT A WARRANTY CLAIM, SO THEY WOULD NOT DO ANYTHING FOR ME. I CONSIDER THIS AN ENGINEERING DESIGN DEFECT AND FEEL IT IS KIA'S RESPONSIBILITY. HOWEVER, WHAT CAN I DO NOW? THANKS FOR YOUR HELP ON THIS! *LA

• 11/22/2005· VEHICLE SPEED CONTROL

  THE CRUISE CONTROL WILL NOT WORK AT CERTAIN TIMES AND THIS HAS BEEN GOING ON FOR AT LEAST 6 OR 7 MONTHS AND IS STILL HAPPENING. DEALER REPLACED CRUISE SWITCH BUT THAT DID NOT WORK, IT STILL IS DOING THE SAME THING. WENT BACK TO DEALER AND THEY SAID THEY COULD NOT DOING ANYTHING ABOUT IT UNTIL THEY SEE IT HAPPENING. THIS IS A PROBLEM BECAUSE IT DOES IT WHEN IT FEELS LIKE DOING IT AND I CANNOT GET IT TO THE DEALER WHEN IT IS HAPPENING. *JB

• 11/20/2012· ELECTRICAL SYSTEM,STRUCTURE,WHEELS,ENGINE

  1)HAPPENED TWICE: CAR STOPPED SUDDENLY AFTER A BEEPING NOISE AND ENGINE LIGHT WENT ON BRIEFLY. THERMOSTAT, THERMOSTAT GASKET HAD TO REPLACED TWICE IN 7 MONTHS (REPAIRS DONE ON 5/11/10 AND 12/13/2010). NOTE: ENGINE FLUSH 11/24/09; COOLING SYSTEM PRESSURE TESTED 2/22/10, RADIATOR FLUSHES 6/8/09 AND 7/30/10 IN ADDITION TO LOF EVERY 3,000 MILES) COOLING SYSTEM /CORROSION ISSUES/COOLING SYSTEM CORROSION CONTROL KIT INSTALLED: 12/30/05 & 4/8/08, 2) CAR CAREENING AND TIPPING WHEN STEERING HARD TO RIGHT: FRONT HUB AND WHEEL BEARING, SEAL HAD TO BE REPLACED AS WELL - 3 TIMES (1/2/09; 12/13/10, 8/1/2011). 3) CAR LOST POWER ON FREEWAY DUE TO BAD ALTERNATOR WHICH DISCHARGED BATTERY 6/23/06. *TR

• 11/19/2014· AIR BAGS,EQUIPMENT ADAPTIVE/MOBILITY

  MY AIRBAG LITE HAS BEEN TURNING OFF AND ON AT DIFFERENT TIMES..EG. LITE TURNS ON AND IS ON FOR ABOUT 15 TO 20 SECONDS THEN TURNS OFF. NOW, 11/17/2014 WHEN I STARTED TO DRIVE IT, THE LIGHT WENT ON AND HAS STAYED ON EVER SINCE WHEN THE IGNITION IS ON. I WANTED TO TAKE IT TO THE DEALERSHIP WHERE I PURCHASED THE CAR NEW BUT THEY ARE OUT OF BUSINESS. TODAY ON FOX NEWS I HEAD WHERE THEY ARE HAVING SOME TROUBLE WITH SEAT BELTS ON DIFFERENT CARS. WOULD LIKE TO KNOW WHAT I SHOULD DO. I LOVE THE CAR AND WANT TO KEEP IT. I HAVEN'T HAD ANY PROBLEM WITH IT. IT HAS BEEN GREAT!! PLEASE ADVISE ME WHAT I SHOULD DO. THANK YOU. RESPECTFULLY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 11/17/2006· AIR BAGSCrash

  DT*: THE CONTACT STATED WHILE DRIVING 30 MPH, THE VEHICLE WAS INVOLVED IN A HEAD ON COLLISION WITH ANOTHER VEHICLE. NEITHER FRONTAL AIR BAG DEPLOYED. THERE WAS A POLICE REPORT TAKEN AT THE SCENE. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS TOWED TO A PRIVATE REPAIR SHOP, WHERE THE MECHANIC WAS UNABLE TO DETERMINE THE PROBLEM. A SERVICE DEALER WAS CONTACTED, AND THE MANUFACTURER WAS ALSO NOTIFIED. UPDATED 12/04/06. *JB

• 11/17/2004· ELECTRICAL SYSTEM

  I HAVE BEEN EXPERIENCING ONGOING ELECTRICAL PROBLEMS WITH THE DASHBOARD LIGHTS GOING OUT. IT IS VERY DANGEROUS AT NIGHT BECAUSE YOU CANT SEE THE SPEEDOMETER AND THE CAR IS VERY DARK ON THE INSIDE. I HAVE TAKEN MY VEHICLE IN OVER 5 TIMES FOR REPAIR AND IT'S STILL NOT WORKING. THIS HAS BEEN AN ON-GOING PROBLEM WITH THE ELECTRICAL SYSTEM (DASH BOARD LIGHTS). TWICE THEY SAID IT WAS THE FUSE WHICH THEY REPLACED BOTH TIMES. WITHIN THREE DAYS OF REPAIR THE LIGHTS WERE OUT AGAIN ON BOTH INSTANCES. THE THIRD TIME THEY SAID THE ELECTRICAL WIRING WAS LOOSE. THEY FIXED THE WIRING BUT APPROXIMATELY TWO WEEKS LATER THE LIGHTS WENT OUT AGAIN. I TOOK IT BACK FOR REPAIR AND THEY SAID THE WIRING WAS LOOSE AGAIN AND THEY FIXED IT. AGAIN, THE LIGHTS WENT OUT. I TOOK THE VEHICLE BACK TO THE DEALERSHIP WHERE I PURCHASED IT AND THEY STATED THAT THE IGNITION SWITCH WAS BAD SO THEY REPLACED IT. THIS TIME THE LIGHTS STAYED ON ABOUT A MONTH AND NOW IT'S OUT AGAIN.*AK

• 11/17/2003· ENGINE AND ENGINE COOLINGFire

  WHILE DRIVING AT 30 MPH SMOKE WAS COMING FROM UNDER THE HOOD. THE CONSUMER PULLED OVER, POPPED THE HOOD, AND NOTICED FIRE ON TOP OF THE ENGINE. *AK *SCC *JB

• 11/16/2007· ELECTRICAL SYSTEM

  HEATER WIRING HARNESS OVER HEATED BURNED OUT FAN SWITCH HAPPENED TWICE CANNOT GET FAN TO COME ON NOW. *TR

• 11/12/2014· ELECTRICAL SYSTEMFire

  FUSE PANEL CAUGHT FIRE AND BURNT WHILE VEHICLE WAS PARKED AND NOT IN USE. VEHICLE IS NO LONGER FUNCTIONAL. *TR

• 11/12/2003· ENGINE AND ENGINE COOLING

  WHILE DRIVING , THE ENGINE LIGHT ILLUMINATED AND THE BRAKE PEDAL WENT TO THE FLOOR. THE CONSUMER TOOK THE VEHICLE TO THE DEALER WHO STATED THAT THE ENGINE COILS BURNED OUT. *AK ENGINE PROBLEMS WITH O-RING LEAKING GAS INTO THE AIR VENTS. *LA *JB

• 11/11/2003· SEATS

  THE CENTER SEATS IN THE KIA SEDONA ARE THE RECLINING TYPE AND WHEN YOU TRY TO PUT IT UP-RIGHT THE BACK OF THE SEAT SLAMS UP AND THE WHOLE SEAT SHOOTS FORWARD AS HAPPEN TO MY DAUGHTER (9 YRS OLD). I POINTED THIS OUT TO THE DEALER AND WAS TOLD BY HIM SITTING IN THE SEAT THAT HE HAD NO PROBLEM, THEN AGAIN HE IS A GROWN MEN WITH A BIT WEIGHT AND NOT A 9 YR OLD WHOSE FEET TO DO NOT TOUCH THE FLOOR WHEN SITTING IN THAT SEAT. WE WERE LUCKY THAT THE VEHICLE WAS AT STAND STILL WHEN THIS OCCURRED. ALL I ASKED HER TO DO WAS PUT THE SEAT UP-RIGHT WHICH SHE HAD RECLINED TO READ. END RESULT WAS THE SEAT SLAMMED HER INTO THE (MY) SEAT AND HAD HER TRAPPED, HAD WE BEEN MOVING, WHAT THEN ????????*AK

• 11/05/2004· ELECTRICAL SYSTEMFire

  ON SEPTEMBER 30, 2004 AT APPROXIMATELY 6:00 P.M. MY HUSBAND AND SON WERE SCHEDULED TO ATTEND A MEETING. AS THEY APPROACHED OUR VEHICLE PARKED IN THE DRIVEWAY, MY HUSBAND NOTICED THAT THE AUTOMATIC KEY DID NOT OPEN THE VEHICLE. HE TRIED SEVERAL TIMES AND FINALLY MANUALLY UNLOCKED THE DOOR. WHEN HE OPENED THE DOOR HE NOTICED THAT THE STEERING COLUMN, DASH BOARD AND DRIVER'S DOOR WERE DAMAGED BY FIRE AND MELTED PLASTIC DAMAGED THE CARPET. THE WINDOWS AND INTERIOR WERE COVERED IN RESIDUE FROM THE SMOKE. WE IMMEDIATELY CONTACTED THE KIA DEALERSHIP AND REPORTED THE INCIDENT AND HAD THE VEHICLE TOWED TO SOUTHPOINT KIA WHERE WE PURCHASED THE VEHICLE. WE RECEIVED A SLOW RESPONSE FOR GETTING A REPLACEMENT VEHICLE AND WAS TOLD SEVERAL DAYS LATER THAT WE WOULD NEED TO COVER THE RENTAL VEHICLE UNTIL THEY DETERMINED THE CAUSE OF THE FIRE. I WAS TOLD TO REPORT THE CLAIM TO MY INSURANCE COMPANY STATE FARM. STATE FARM DETERMINED THAT THE DAMAGE WAS CAUSED BY A "RIGHT SEAT SWITCH - ELECTRICAL PROBLEM." AS OF TODAY, WE HAVE NOT RECEIVED THE STATUS OF THIS CLAIM OR THE CAUSE OF THE DAMAGE FROM KIA ENGINEERS. IT APPEARS THAT THEY ARE NOT HONORING THEIR 10 YEAR 100,000 MILE WARRANTY. OUR VEHICLE WAS PURCHASED SEPTEMBER, 2003. *AK

• 11/05/2004· SERVICE BRAKES, HYDRAULIC

  THE VEHICLE'S BRAKES DID NOT FUNCTION PROPERLY. *NM THE CONSUMER HAD TO PRESS THE BRAKE ALL THE WAY TO THE FLOOR IN ORDER TO STOP THE VEHICLE. THE BRAKES MADE A DEEP DRUM LIKE NOISE THAT LASTED FOR A FEW MINUTES UNTIL THE BRAKES STARTED TO REACT NORMALLY. *TC *JB

• 11/03/2004· SERVICE BRAKES, HYDRAULIC

  WHEN APPLYING THE BRAKES FROM LOW SPEEDS, THE PEDAL INTERMITTENTLY WENT TO THE FLOOR. AS A RESULT EXTENDED STOPPING DISTANCE OCCURRED. *JB KIA REPLACED THE BRAKES AND THE CONSUMER HAD NOT EXPERIENCED A BRAKE PROBLEM SINCE. *SC

• 11/02/2004· SERVICE BRAKES, HYDRAULIC,AIR BAGSCrash

  WHILE DRIVING 45 MPH, THE CONSUMER APPLIED THE BRAKE PEDAL, BUT THE BRAKES FAILED. THIS CAUSED THE CONSUMER TO COLLIDED WITH THE VEHICLE IN FRONT OF HIS. THE OCCUPANTS IN ALL THREE VEHICLES SUSTAINED MINOR INJURIES AND WERE TRANSPORTED TO THE HOSPITAL. BOTH FRONTAL AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS TOWED TO A GARAGE FOR INSPECTION. PLEASE PROVIDE FURTHER DETAILS. *JB

• 11/01/2007· EXTERIOR LIGHTING

  TL*THE CONTACT OWNS A 2003 KIA SEDONA. WHEN THE LEFT TURN SIGNAL WAS ACTIVATED, THE SIGNAL SWITCH REMAINED ENGAGED UNTIL IT WAS MANUALLY DISENGAGED. THE RIGHT TURN SIGNAL OPERATED NORMALLY. THE CONTACT BELIEVED THAT THE LEFT TURN SIGNAL FAILED BECAUSE IT DOES NOT OPERATE THE SAME AS THE RIGHT SIGNAL. THE DEALER STATED THAT THE FAILURE WAS ACTUALLY A STANDARD FEATURE OF THE VEHICLE. THE POWERTRAIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 51,000 AND CURRENT MILEAGE WAS 53,000.

• 10/31/2007· LATCHES/LOCKS/LINKAGES

  TL*THE CONTACT OWNS A 2003 KIA SEDONA. THE CONTACT WAS UNABLE TO ENTER AND EXIT THE DRIVER SIDE DOOR WITH HER KEY OR REMOTE. THE DEALER INFORMED HER THAT THEY WOULD HAVE TO BREAK THE DOOR TO REPAIR THE VEHICLE; HOWEVER, THEY SMASHED THE WINDOW INSTEAD. THE DOOR LOCK ACTUATOR WAS REPLACED ON THE DRIVER SIDE DOOR. THE REMAINING LOCKS ON THE VEHICLE HAVE NOT FAILED. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED. THE FUEL SYSTEM WAS UNKNOWN. THE APPROXIMATE CURRENT AND FAILURE MILEAGES WERE 120,000.

• 10/29/2004· VEHICLE SPEED CONTROL

  THE SPEEDOMETER WOULD READ THE WRONG SPEED INTERMITTENTLY. PLEASE PROVIDE MORE INFORMATION. *JB

• 10/27/2009· WHEELSFire

  TL* THE CONTACT OWNS A 2003 KIA SEDONA. WHILE DRIVING APPROXIMATELY 45 MPH ON NORMAL ROAD CONDITIONS; THERE WAS A BURNING ODOR INSIDE AND OUTSIDE OF THE VEHICLE. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD. UPON VEHICLE INSPECTION HE OBSERVED THAT THE FRONT DRIVER AND PASSENGER WHEELS HAD EXCESSIVE HEAT BUILD-UP. HIS VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL CAMPAIGN ID NUMBER 05V232000 (WHEELS). THE VEHICLE HAS NOT BEEN REPAIRED FOR THE MALFUNCTION. THE FAILURE AND CURRENT MILEAGES WERE 103,000.

• 10/27/2008· SERVICE BRAKES, HYDRAULIC,ELECTRICAL SYSTEM

  I HAVE A 2003 KIA SEDONA AND I HAVE HAD NOTHING BUT ISSUES. ANYWHERE FROM HAVING TO REPLACE THE ALTERNATOR, WHICH I WILL SAY WAS A PAIN IN THE BUTT...TO MAJOR ISSUES WITH THE BRAKES. FROM READING MANY DIFFERENT SITES THIS IS NOT AN UNCOMMON ISSUE!!!!!!!!!!!! IT IS JUST SO FRUSTRATING THAT YOU PURCHASE A VAN BECAUSE THEY SAY IT IS GREAT THEN YOU GET THIS PIECE OF JUNK. THE SAD THING IS MOST PEOPLE WHO OWN THESE ARE YOUNG COUPLES WITH CHILDREN AND CAN NOT AFFORD THE REPAIRS BUT HAVE TO PAY FOR THEM AND WE ARE STUCK WITH THESES TRASH BOXES BECAUSE WE HAVE CHILDREN AND CAN NOT AFFORD TO GO OUT AND TRADE IT IN, LOSE OUR BUTTS BECAUSE THEY ARE NOT WORTH THE MONEY WE OWE ON THEM. I CAN NOT AFFORD TO KEEP FIXING THIS HEAP OF JUNK BUT I AM STUCK WITH IT. I HOPE THAT SOMETHING GETS DONE WITH THESE...THEY ARE WORTHLESS AND MY CHILDREN ARE PAYING FOR IT!!!!!!!!!!!!!!!!!!!!!!!!!!!! I HAVE NOT HAD A VEHICLE SO BAD IN MY LIFE...I AM TIRED OF REPLACING THE BRAKES, ROUTERS, AND NOW THE CALIPERS!!!!!!!!!!!!!*TR

• 10/27/2004· SERVICE BRAKES, HYDRAULICCrash

  BRAKES FAILED IN AN ACCIDENT AND THE AIR BAG DID NOT DEPLOY. *BF WHEN THE CONSUMER ATTEMPTED TO APPLY THE BRAKES BECAUSE THE VEHICLE IN FRONT OF HIM WAS A T A STOP, THE BRAKES LOCKED UP AND THE VEHICLE WENT INTO A SKID. THE CONSUMER RECEIVED THE VEHICLE BACK AND WAS TOLD THERE WAS NOTHING WRONG WITH THE BRAKES, HOWEVER OVER THE NEXT FEW MONTHS HE CONTINUED TO EXPERIENCE BRAKE PROBLEMS EVERY SO OFTEN. THE DEALER KEPT THE VEHICLE FOR A FEW DAYS AND THEY REPLACED THE WHEEL CYLINDER AND THE ROTORS WHICH WERE WARPED. THE CONSUMER THEN RECEIVED A RECALL NOTICE REGARDING THE BRAKES AND TOOK THE VEHICLE BACK TO THE DEALER WHO STATED IT WOULD TAKE A FEW HOURS TO FIX. SINCE THE RECALL REPAIR WAS COMPLETE THE CONSUMER HAS NOT EXPERIENCED ANYMORE BRAKE PROBLEMS. *JB

• 10/26/2006· AIR BAGS

  DT*: THE CONTACT STATED THE AIR BAG WARNING LIGHT ILLUMINATED CONSTANTLY WHILE THE ENGINE WAS RUNNING. THE VEHICLE WAS TAKEN TO A PRIVATE REPAIR SHOP, WHERE THE MECHANIC WAS UNABLE TO DETERMINE THE PROBLEM.

• 10/24/2003· TIRES

  MY TIRE RIPPED OFF THE RIM WHEN WE DRIVING ABOUT 60 MPH LIKE THE ONES DID FOR FIRESTONE AND IT DID DAMAGE TO MY VAN THE COMPANY DID NOT WANT TO FIX ANYTHING WELL WE LUCKY NO ONE GOT HURT. SO I TOOK IT TO THE DEALER AND THEY SAID THEY NEVER SEEN THIS HAPPEN I THINK YOU SHOULD LOOK AT THESE TIRES. *LA

• 10/23/2007· FUEL SYSTEM, OTHER,STRUCTURE,EQUIPMENT

  THE HYDRAULICS THAT KEEP THE HOOD AND THE BACK OF THE VAN OPEN ARE NOT WORKING. SO YOU ARE STUCK HOLDING THEM OPEN (AND THEY ARE VERY HEAVY) TO PUT IN GROCERIES, ETC. MY DAUGHTER HAS HURT HER HEAD A COUPLE OF TIMES TRYING TO HELP ME KEEP IT OPEN TO GET THE GROCERIES OUT. IT IS VERY DANGEROUS TO BE DOING THIS. THE ELECTRICAL SYSTEM ON THE INSIDE SOMETIMES WORKS, SOMETIMES NO. THE BACK AIR ADAPTER FOR THE A/C KEEPS FALLING OUT OF THE CEILING. THE A/C ITSELF SOMETIMES WORKS AND SOMETIMES DOESN'T. THE SEATS IN THE BACK KEEP COMING UNDONE. THE VAN EATS THE TREAD OF THE TIRES EVEN WITH CONSTANT REPLACEMENT AND ROTATIONS AND BALANCES. THE SLIDING DOORS STICK ALL THE TIME AND MY DAUGHTERS HAVE ALL HURT THEM SELVES TRYING TO GET IN OR OUT FROM THE SLIDING DOORS. I AM AFRAID OF CUTTING OFF FINGERS HAVING TO FORCE IT OPEN OR CLOSED. THE DRIVER SIDE DOOR HANDLE HAS A LATCH THAT BROKE SO THE HANDLE IS HALF ON HALF OFF. NOW WHEN I FILL UP ON GAS MY VAN WILL JERK WHEN I DRIVE IT OUT OF THE GAS STATION FOR A GOOD 20 MINS. MY GAS GAGE MOVES!! I CAN SEE IT DECREASE WHEN I DRIVE. THE GAS MILEAGE WAS APROX. 18 MPG NOW IT IS DOWN TO 12!!! THIS CAR IS A DANGER!! *TR

• 10/20/2003· SERVICE BRAKES, AIR

  WHEN BRAKING AT SPEEDS OVER 45 MPH THE VEHICLE SHUTTERS AND VIBRATES. FELT LIKE THE ROTOR IS WARPED, BUT THE VEHICLE ONLY HAS 12,000 MILES. *LA

• 10/19/2006· ELECTRICAL SYSTEMFire

  ON TUES. THE 3RD OF OCT. 2006 I WENT TO START MY 2003 KIA SEDONA AND IT WOULD NOT START SO AAA WAS CALLED, THEY CAME AND JUMPED THE BATTERY AND IT WAS ALL SET TO GO. THURSDAY THE 5TH I NOTICED CONSOLE NEAR RADIO WAS HOT TO THE TOUCH. FRIDAY OCT. 6TH 2006 I WENT TO GET INTO MY CAR AND I COULD NOT GET THE DOOR OPEN. I NOTICED THE WINDSHIELD WAS CRACKED AND BLACK. WHEN I FINALLY GOT INTO THE CAR THE DRIVERS SIDE WAS COMPLETELY MELTED BY A FIRE THAT OCCURRED SOMETIME IN THE MIDDLE OF THE NIGHT. THE CAR WAS TOTALED BY MY INSURANCE COMPANY, THEY ARE GIVING ME CASH VALUE FOR IT AND NOW I AM STUCK WITH OWING MONEY ON A CAR I DON'T HAVE. THEY ARE CURRENTLY INVESTIGATING THE EXACT CAUSE OF THE FIRE. THERE MUST HAVE BEEN SOME KIND OF MANUFACTURING DEFECT. IT WAS A 2003 AND I PURCHASED IT ONLY 6 MONTHS AGO. NO ONE WAS HURT BUT EVERYTHING WAS DAMAGED AND I AM AT A LOSS AND DON'T KNOW WHAT I CAN DO. *NM

• 10/17/2006· WHEELS

  IN JULY OF 2006, WHILE ON VACATION, WE NOTICED A LUG NUT MISSING FROM THE RIGHT FRONT WHEEL, AND ONE NEXT TO IT WAS FINGER LOOSE. (NEW TIRES WERE PUT ON IN FEBRUARY 2006). I REPLACED THESE AT THE NEXT EXIT. TOOK VAN TO KIA DEALER THE NEXT WEEK, THEY REPLACED WITH OEM LUG NUTS. THE FOLLOWING WEEK, I NOTICED A LUG NUT WAS MISSING AGAIN FROM THE SAME WHEEL. TOOK TO KIA, THEY REPLACED. 2 WEEKS LATER, I NOTICED A LUG NUT MISSING FROM SAME TIRE AGAIN. TOOK TO KIA TO BE REPLACED AND THEY SAID THEY DIDN'T KNOW WHY THEY KEPT FALLING OFF, HAD NOT SEEN THIS BEFORE. 2 MONTHS PASSED, AND I TRIED TO ROTATE MY TIRES IN EARLY OCT. ONE STUD SNAPPED OFF, AND ANOTHER SEIZED UP, IF I TRIED TO GET IT OFF, IT WOULD HAVE SNAPPED OFF ALSO. TOOK IT TO THE DEALER TODAY, THEY REPLACED 2 STUDS AND THE 2 LUG NUTS. AGAIN, NO IDEAS AS TO WHY THIS IS OCCURRING. I'M AFRAID THERE IS SOMETHING WRONG WITH THE WHEEL STUDS / WHEEL ASSEMBLY, WHICH MAY RESULT IN A WHEEL SEPARATION WHILE DRIVING, RESULTING IN SERIOUS INJURY TO PASSENGERS/OTHER PEOPLE, AND SERIOUS DAMAGE TO VEHICLES. I THINK THIS SHOULD BE INVESTIGATED BEFORE SOMEONE GETS INJURED/KILLED. *NM

• 10/14/2003· VEHICLE SPEED CONTROL

  WHILE DRIVING APPROXIMATELY 50 MPH VEHICLE WOULD SUDDENLY ACCELERATE. HAD APPLIED THE BRAKES TO STOP VEHICLE. MANAGED TO PULL TO SIDE OF ROAD AND STOP. RESTARTED VEHCLE, AND TOOK IT TO DEALERSHIP. MECHANIC INDICATED COULD NOT LOCATE CAUSE OF ACCELERATION.*AK

• 10/06/2006· ENGINE AND ENGINE COOLING,POWER TRAIN

  2003 KIA SEDONA WHICH WE BOUGHT BRAND NEW HAS HAD A PROBLEM ALMOST SINCE WE PURCHASED IT, INITIALLY WITH RUNNING ROUGH, THEN TRANSMISSION INTO STALLING, OR LOSS OF POWER AND ALMOST STALLING, WHEN ACCELERATING ONTO A HIGHWAY OR OTHER MAIN THOROUGHFARE WHERE RAPID ACCELERATION IS REQUIRED FOR SAFE ENTRY. WE HAVE BROUGHT THE VEHICLE BACK TO THE DEALERSHIP AT WHICH WE PURCHASED IT NUMEROUS TIMES. EITHER THEY COULD NOT FIND THE PROBLEM, OR THEY MADE REPAIRS WHICH DID NOT CORRECT THE PROBLEM. ON OCTOBER 4, 2006, MY WIFE WAS DRIVING IT ON A BUSY 4 LANE ROAD WHEN IT STALLED AND COULD NOT BE STARTED AGAIN, LEAVING HER STRANDED IN A DANGEROUS SITUATION. THE DEALERSHIP REPLACED THE POWER CONTROL MODULE THIS TIME, AND WE GOT IT BACK TODAY, OCTOBER 6, IN THE LATE AFTERNOON. I DROVE TO A DESTINATION 17 MILES AWAY AND BACK THIS EVENING. IT STALLED SEVERAL TIMES, AND ALMOST STALLED SEVERAL MORE TIMES, WHILE ATTEMPTING TO ACCELERATE ONTO A HIGHWAY OR A MAJOR LOCAL ROAD. I NARROWLY AVOIDED GETTING INTO A SERIOUS ACCIDENT SEVERAL TIMES TONIGHT. THIS VEHICLE IS DEFECTIVE AND DANGEROUS. *JB

• 10/03/2003· TIRES

  WHILE DRIVING 60 TO 65 MPH THE REAR RIGHT PASSENGER TIRE BLEW OUT. THE CONSUMER KNOWS HE DID NOT RUN OVER ANY OBJECT IN THE ROAD. THE MANUFACTURER OF THE TIRE WAS CONTACTED AND ASK THE CONSUMER TO SEND THE TIRE BACK FOR FURTHER CHECK UP. THE MANUFACTURER CALLED HIM BACK TO LET HIM KNOW THAT THE TIRE HAD BEEN CHECK AND INDICATED THAT IT WAS A SIDE IMPACT. CONSUMER DOES NOT AGREE WITH THE FINDINGS. *NLM

• 10/01/2010· WHEELS

  THE BACK RIGHT WHEEL CAME OFF OF OUR 2003 KIA SEDONA VAN. MY WIFE HEARD A LOUD NOISE AS SHE WAS DRIVING DOWN THE ROAD. SHE APPLIED THE BRAKES BUT THE CAR HAD DIFFICULTY STOPPING. SHE MANAGED TO PULL THE VAN OVER TO THE SIDE OF THE ROAD. WHEN THE TOW TRUCK CAME, IT PULLED THE VAN ABOUT A FOOT BEFORE THE ENTIRE RIGHT REAR WHEEL CAME OFF. HAD SHE BEEN TRAVELING ON THE HIGHWAY, SHE AND MY 3 CHILDREN MIGHT NOT HAVE SURVIVED THE INCIDENT. *TR