2003 Chrysler PT Cruiser

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2015· ENGINE

  TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. AFTER PLACING THE VEHICLE INTO DRIVE, THE ENGINE STALLED AND WAS UNABLE TO RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

• 12/30/2009· POWER TRAIN

  WITH 59,000 FREEWAY MILES, AT 65 MPH VEHICLE DOWNSHIFTED ABRUPTLY AND UNEXPECTEDLY. VEHICLE WOULD ONLY LURCH ALONG AT A SLOW SPEED AND UNABLE TO GO INTO REVERSE. IT HAD TO BE TOWED. TRANSMISSION OVERHAUL REQUIRED COSTING OVER $2,000 TO REPAIR. *TR

• 12/29/2009· WHEELS

  OEM 17" CHROME WHEELS ON 2003 CHRYSLER PT CRUISER GT CORRODE, FLAKE OFF, AND TIRES LOSE PRESSURE OVERNIGHT. LOW TIRE PRESSURE CAN CAUSE THE VEHICLE TO GO OUT OF CONTROL OR SKID. THE CONSUMER IS FORCED TO CHECK TIRE PRESSURE TWICE A DAY. FORGETTING TO DO THIS, EVEN ONCE, CAN LEAD TO AN UNSAFE DRIVING CONDITION. *TR

• 12/23/2003· TIRES

  GOODYEAR EAGLE LS TIRE (P205/55R16) WITH UNDER 15,000 MILES MOUNTED ON A PT CRUISER AND DRIVEN ON AN INTERSTATE BLEW OUT THROUGH THE SIDEWALL. DRIVER HEARD A POP AND IMMEDIATELY PULLED TO THE SIDE OF THE INTERSTATE AND DISCOVERED THE BLOWN TIRE.

• 12/22/2004· VEHICLE SPEED CONTROLCrash

  I WAS DRIVING 40 MILES AN HOUR AND TRIED TO SWERVE TO MISS AN ANIMAL, LOST CONTROL OF THE CAR AND PRESSED ON THE BRAKE PEDAL AND THE CAR CONTINUED ACCELERATING. *JB

• 12/21/2005· EXTERIOR LIGHTING

  BRAKE LIGHT MECHANISM FELL OUT FROM POSITION UNDER DASHBOARD WHICH MADE THE BRAKE LIGHTS STAY ON CONSTANTLY, RESULTING IN A DEAD BATTERY AND A DANGEROUS SITUATION WITH THE BRAKE LIGHTS BEING CONSTANTLY ON. *JB

• 12/18/2013· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  I'VE HAD THIS VEHICLE APPROX. 2 YEARS. AT AN EARLIER TIME I HAD USED THE FOG LIGHTS TWICE WITH NO INCIDENT. LATER AND PRIOR TO 12/17/13 THE FOG LIGHT INDICATOR APPEARED ON THE INSTRUMENT PANEL, THE FOG LIGHT SWITCH WASN'T EVEN TURNED ON BUT THE LIGHT CAME ON BY THEMSELVES. I JIGGLED THE SWITCH AND THE LIGHTS AND INDICATOR WENT OUT, AFTER THAT THE FOG LIGHTS WOULDN'T WORK AT ALL. ON 12/17/13 I WENT OUT TO MY GARAGE TO FIND THE FOG LAMPS ON. THE HEADLIGHTS WERE OFF, THE CAR NOT RUNNING, THE KEYS WEREN'T EVEN IN THE IGNITION. THE LIGHTS JUST CAME ON BY THEMSELVES. I MANAGED TO TURN THEM OFF (FOR THE NIGHT) ONLY TO FIND WHEN I GOT TO WORK THE NEXT MORNING I COULDN'T SHUT THEM OFF. I DROVE THE CAR HOME, FINALLY PULLED THE FUSE FOR THE FOG LAMPS AND RETURNED TO WORK. I'VE ALSO HAD INCIDENCES WHERE THE HEADLIGHTS WILL DIM SLIGHTLY AND THEN ILLUMINATE FULLY. ACCORDING TO SOME OF THE FORUMS I'VE READ, THERE ARE A LOT OF PEOPLE HAVING THIS PROBLEM. SOME PEOPLE ALSO REPORT BURNING WIRES AND DEAD BATTERIES. I WISH THEY WOULD FILE A COMPLAINT. THANK YOU. *TR

• 12/18/2009· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THIRTY SECONDS AFTER STARTING THE IGNITION, THE ENGINE STALLED WITHOUT WARNING. THE "CHECK ENGINE" WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. HE WAS ABLE TO RESTART THE ENGINE AND RESUME NORMAL OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON THREE SEPARATE OCCASIONS. THE TECHNICIAN WAS UNABLE TO LOCATE CAUSE OF THE FAILURE. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER ON SIX SEPARATE OCCASIONS FOR THE IDENTICAL FAILURES. THE ENGINE CONTROL MODULE (ECM), FOUR FUEL INJECTERS , SPARK PLUGS, AND BOTH OXYGEN SENSORS. WERE REPLACED. NONE OF THE REPAIRS HAVE REMEDIED THE FAILURE. THE FAILURE MILEAGE WAS 112,000. THE CURRENT MILEAGE WAS 113,000.

• 12/18/2003· AIR BAGSCrash

  AIR BAGS DID NOT DEPLOY WHEN VEHICLE WAS HIT IN A 3 CAR COLLISION. THIS VEHICLE WAS IN THE CENTER OF THIS COLLISION.*AK

• 12/13/2007· STEERING,SUSPENSION,ENGINE AND ENGINE COOLING,POWER TRAIN

  2003 CHRYSLER PT CRUISER WITH DEFECTED CONTROL ARM BUSHINGS. CONSUMER STATED THAT THE BUSHINGS ARE WEARING PREMATURELY. *KB THE CONSUMER STATED HE HAS HAD PROBLEMS WITH THE TRANSMISSION, STEERING COLUMN, FRONT BEARING AND WATER PUMP. *JB

• 12/12/2015· ENGINE

  ENGINE RUNS ROUGH AT IDLE AND SHUTS OFF WHILE DRIVING. CANNOT RESTART. REPLACED CAM SENSOR, AIR INTAKE, PLUGS, ETC. HAS HAPPENED 8-10 TIMES IN THE 3 MONTHS WE HAVE OWNED THE CAR.

• 12/10/2004· WHEELS

  I HAVE A 2003 CHRYSLER PT CRUISER WITH CHROME PLATED WHEELS. I HAD A FLAT TIRE AND BROUGHT THE VEHICLE TO A TIRE STORE FOR REPAIR. THEY SAID THERE WAS NOTHING WRONG WITH THE TIRE BUT THE WHEELS WERE CORRODED TO THE POINT THAT THE AIR LEAKED OUT AROUND THE VALVE STEM. I TOOK THE VEHICLE TO THE LOCAL CHRYSLER DEALER AND THEY ORDERED NEW WHEELS AND SAID THEY WOULD BE REPLACED UNDER WARRANTY. WHEN THE WHEELS CAME IN THEY CALLED ME AND I SETUP AN APPOINTMENT TO HAVE THEM INSTALLED. I TOOK THE CAR THERE AND THEY SAID THEY WOULD CALL ME WHEN IT WAS DONE. THEY CALLED THREE HOURS LATER AND SAID THEY COULD NOT REPLACE THE WHEELS UNDER WARRANTY BECAUSE CHRYSLER RECENTLY CHANGED THEIR POLICY. THEY SAID THE CORROSION WAS DUE TO ENVIORNMENTAL REASONS DUE TO THE AREA I LIVE. SOUTHWESTERN NEW YORK. THE CAR HAS ONLY BEEN THROUGH ONE WINTER AND PART OF ANOTHER. THESE WHEELS WERE STANDARD EQUIPMENT ON THE MODEL I PURCHASED. I FEEL THIS IS A TREMENDOUS SAFETY HAZZARD AS YOU CAN NOT TELL THE AIR HAS LEAKED OUT UNLESS YOU LOOK AT THE TIRE. IT HAS BEEN DOWN TO FIVE LBS. OF AIR AND YOU CAN'T TELL WHILE DRIVING DOWN THE ROAD. I WOULD THINK THE TIRE COULD COME OFF THE WHEEL AND CAUSE LOSS OF CONTROL AND SERIOUS INJURY.*AK

• 12/06/2005· AIR BAGS

  DT: CONTACT STATED THE AIR BAG WARNING LIGHT CAME ON INTERMITTENTLY. ALSO, IT MADE NOISE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP ON NUMEROUS OCCASIONS. THEY WERE UNABLE TO DUPLICATE THE PROBLEM. *AK THE AIR BAG MODULE WAS REPLACED. UPDATED 01/11/06. *JB

• 12/04/2008· SUSPENSION,STRUCTURECrash

  I JUST FOUND A RECALL ON MY PT CRUISER ON THE WEB AND I HAVEN'T GOTTEN A NOTICE TO DATE. I TOOK MY CAR BACK TO THE DEALER MANY TIMES TO COMPLAIN ABOUT THE PROBLEM AND I THINK THEY KNEW ABOUT THE RECALLS. MY PROBLEMS WITH MY CAR ARE PROBLEMS RELATED TO THE RECALL ISSUES. *TR

• 12/02/2006· POWER TRAIN

  I HAVE A 2003 PT CRUISER WITH 82000 MILES ON IT. IN MARCH OF 2005 WITH 47765 MILES ON IT, I TOOK THE VEHICLE TO A CHRYSLER DEALER TO REPAIR A VIBRATION WHILE BRAKING. THE CHRYSLER DEALER NOTED THERE WAS A GRINDING NOISE COMING FROM THE TRANSMISSION AND STATED THE COMPRESSOR WAS RUBBING AGAINST THE FRONT FRAME DUE TO SOME KIND OF COLLISION AND STATED THERE WAS A BROKEN MOTOR MOUNT. WE TOOK THE VEHICLE TO THE DEALER WHERE WE PURCHASED THE VEHICLE TO ADDRESS THIS DIAGNOSIS SINCE THIS WAS A NEW VEHICLE WHEN WE PURCHASED IT. THE DEALER CLAIMS THEY FOUND NO BROKEN MOTOR MOUNTS, NO SIGNS OF ACCIDENT AND DID NOT EVEN ADDRESS THE TRANSMISSION NOISE. ON 11/17/2006 I WAS TRAVELING ON A TWO LANE HIGHWAY WITH MY 3 YEAR OLD DAUGHTER AT NIGHT, AND WITHOUT WARNING,NOISE, HESITATION, OR LACK OF POWER, MY TRANSMISSION WENT OUT. I WAS NOT ABLE TO MOVE IN ANY GEAR. THE VEHICLE WAS TOWED TO THE DEALERSHIP WHERE I PURCHASED IT AND THEY TOLD ME IT HAS MAJOR TRANSMISSION DAMAGE AND THE TRANSMISSION NEEDS TO BE REPLACED. THE COST OF THE TRANSMISSION REPLACEMENT IS $2715.00 AND THE DEALER WILL NOT COVER ANY OF THE COST. *JB

• 12/01/2004· ENGINE AND ENGINE COOLING

  THE CONSUMER STATED THE SPARK PLUGS CONTINUED TO BURN OUT. IT WAS ALWAYS SPARK PLUG #1. THE CONSUMER HAS TAKEN THE VEHICLE BACK TO THE DEALER ON 4 SEPARATE OCCASIONS FOR THIS DEFECT. THE OWNER ALSO STATED THAT THE SPARK PLUGS HAVE BEEN RE-WIRED AND THE FUEL INJECTOR WAS REPLACED IN MARCH 2004, THIS HAPPENED AFTER THE SECOND VISIT TO THE DEALER. *JB THE VEHICLE ACTED AS THOUGH IT WASN'T GETTING ANY GAS. THE VEHICLE WOULD BUCK AT RED LIGHTS AND OR STOP SIGNS WITH A DIFFICULT TIME CONTINUING TO DRIVE. THE CHECK ENGINE LIGHT HAD COME ON AND THE VEHICLE EXPERIENCED ROUGH IDLE. *SC

• 11/30/2004· STEERING,SERVICE BRAKES, HYDRAULIC

  THE POWER STEERING HOSE AND BRAKES FAILED. THE CONSUMER RECEIVED A RECALL FOR THE HOSE BUT THE DEALER WOULD NOT FIX UNDER WARRANTY. *BF RECALL# 04V268000. *SC *JB

• 11/29/2016· VEHICLE SPEED CONTROL,ENGINE

  TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. WHILE DRIVING VARIOUS SPEEDS AND DEPRESSING THE ACCELERATOR PEDAL, THE THROTTLE MECHANISM SEEMED TO HAVE BECOME STUCK SEVERAL TIMES AT A HIGH THROTTLE SETTING. THE VEHICLE WAS NOT TOWED TO A DEALER OR INDEPENDENT MECHANIC AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

• 11/28/2006· WHEELS

  DT*: THE CONTACT STATED A DEFLATED TIRE WAS NOTICED ON THE VEHICLE. AFTER INFLATING THE TIRE, IT WAS DRIVEN TO THE DEALER WHO DETERMINED OXIDATION ON THE RIMS CAUSED SLOW LEAKS IN ALL FOUR TIRES AND SUGGESTED REPLACING THE RIMS.

• 11/26/2004· AIR BAGSCrashFire

  CONSUMER'S VEHICLE T-BONED ANOTHER VEHICLE AT 40 MPH, AND NEITHER FRONTAL AIR BAG DEPLOYED. CONSUMER REPORTED NO INJURIES. MANUFACTURER WAS NOTIFIED.*AK

• 11/24/2009· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  1. I GENERALLY DRIVE OUR 2003 CHRYSLER PT CRUISER WITH THE FOG LIGHTS ON DURING THE DAY, AND THE HEADLIGHTS AT NIGHT. THIS MEANS I WAS TURNING THE FOG LIGHT SWITCH ON THE TURN SIGNAL UNIT SEVERAL TIMES A DAY. 2. BEGINNING EARLY IN 2009 I EXPERIENCED TIMES WHEN THE FOG LIGHTS WOULD NOT TURN OFF WITH THE SWITCH WITHOUT A LOT OF CYCLING, OR THE FOG LIGHTS WOULD TURN THEMSELVES ON WHEN THE DOOR CLOSED. THE VIBRATION OF THE VEHICLE MADE THAT HAPPEN. THEN, WHEN TRYING TO GET THE FOG LIGHTS TO TURN OFF, THE SWITCH BEGAN TO SMOKE. TURNING OFF THE CAR CLEARED THAT, SO I STOPPED USING THE FOG LIGHTS. THE TURN SIGNALS AND HEADLIGHT PORTION OF THE SWITCH WORKED FINE. 3. I CONTACTED THE CHRYSLER DEALERSHIP AND WAS TOLD THEY WERE OUT OF THE SWITCH. I THEN CONTACTED A LOCAL AUTO MAINTENANCE COMPANY I HAVE USED IN THE PAST AND TRUST. THEY QUOTED ME A BETTER SERVICE PRICE, AND THAT THE SWITCH WAS BACKORDERED. THERE WERE OVER 5000 SWITCHES ON BACKORDER AND IT WAS SIX MONTHS AFTER THE ORDER WAS PLACED BEFORE WE RECEIVED THE SWITCH AND HAD IT INSTALLED. MY CONCERN IS TWO FOLD: 1. THE 5000 MAY WELL HAVE BEEN THE TIP OF THE ICEBERG IN TERMS OF FAILURES, AND 2. IF I HAD NOT BEEN SITTING THERE, WOULD THE LIGHTS, AFTER COMING ON BY THEMSELVES HAVE CAUSE THE SWITCH TO ACTUALLY CATCH THE VEHICLE ON FIRE? I THOUGHT THAT THE BRIEF TIME I WAS SMOKE SHOULD HAVE BEEN ENOUGH TO BLOW THE FUSE, BUT IT DIDN'T. *TR

• 11/24/2003· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  PURCHASED 2003 PT CRUISER IN OCT 02. MARCH 03- CHECK ENGINE LIGHT CAME ON AND ENGINE IDLED VERY ROUGH. BROUGHT IT IN AND THEY SAID IT HAD A CRACKED SPARK PLUG. FIXED? NO... JUNE 03 CHECK ENGINE LIGHT CAME ON AND IT IDLED VERY ROUGH. BROUGHT IT IN AND THEY SAID IT NEEDED A NEW ALTERNATOR. FIXED? NO. SAME THING IS HAPPENING AGAIN. CHECK ENGINE LIGHT IS ON AND IT IS IDLING VERY ROUGH. *LA

• 11/23/2003· EXTERIOR LIGHTING

  THE GASKET ON THE THIRD BREAK LIGHT DOES NOT FIT UP TO THE REAR WINDSHIELD. THERE IS ABOUT A 1/4 INCH GAP. A NEW ONE WAS INSTALLED BUT IT HAS THE SAME PROBLEM. IT MUST BE A DESIGN FLAW. *LA

• 11/22/2002· SEAT BELTS

  LOCKING MECHANISM BROKE DURING THE INSTILLATION OF A CHILD SEAT. IF THIS CAN BREAK THIS PART I FEEL THAT IT WOULD NOT HOLD UP IN AN ACCIDENT. DT

• 11/20/2013· VEHICLE SPEED CONTROL,SERVICE BRAKES

  SET CRUISE CONTROL AND THE CAR ACCELERATED RATHER THAN SET AT SPEED. CAR CONTINUED TO ACCELERATE DESPITE APPLICATION OF BRAKES, INCLUDING EMERGENCY BRAKE WHICH ONLY GOT IT DOWN TO 40 MPH. CAR HAD TO BE POPPED INTO NEUTRAL IN ORDER TO BE ABLE TO KEEP FROM CRASHING AND STOP THE CAR. *TR

• 11/17/2004· POWER TRAIN

  THE TRANSMISSION FAILED. A PIECE OF THE CLUTCH BROKE OFF IN THE HOUSING. PER THE DEALER. *JB THE CONSUMER HAS NOT HEARD ANYTHING FROM CHRYSLER AND WOULD LIKE TO KNOW THE NEXT STEP HE NEEDS TO TAKE. *TC

• 11/17/2004· AIR BAGSCrash

  CONSUMER WAS DRIVING ON THE FREEWAY AT 50 TO 55 MPH AND REAR ENDED A TRUCK. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY.*AK

• 11/16/2010· AIR BAGSCrashFire

  TL*THE CONTACT OWNED A 2003 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 60-65 MPH, HE REMEMBERED CHANGING LANES AND THERE WAS SHAKING IN THE STEERING WHEEL. THE VEHICLE ACCELERATED OFF OF THE GROUND PER A WITNESS SINCE THE CONTACT DOESN'T RECALL THE DETAILS OF WHAT OCCURRED. HE DOES REMEMBER THAT THE ENGINE WAS SMOKING AND THAT THE AIR BAGS NEVER DEPLOYED. ONE PASSENGER SUSTAINED HEAD AND HIP INJURES. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 61,000. UPDATED 02/02/11 *CN

• 11/16/2003· LATCHES/LOCKS/LINKAGES

  AUTOMATIC DOOR LOCKS ENGAGE AND DISENGAGE RANDOMLY BOTH WHILE DRIVING AND WHEN THE VEHICLE IS SHUT OFF AND PARKED. *LA

• 11/14/2019· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,ENGINE

  I REPLACED MY VEHICLES BATTERY 2 DAYS AGO(NOV 12, 2019)(VERY OLD BATTERY AND WITH THE COLD IN MASSACHUSETTS IT NEEDED TO BE CHANGED). NOW WITH A PROPERLY FUNCTIONING BATTERY THE VOLTAGE REGULATOR IN PCM (NOT ALTERNATOR) IS SIGNALING ALTERNATOR TO RAISE CHARGING VOLTAGE INTERMITTENTLY TO AS HIGH AS 17.1VOLTS, BUT HAS BEEN FREQUENTLY BOUNCING BETWEEN 14.1V -16.7VOLTS. THIS INCREASE OF VOLTAGE TO A UNSAFE LEVEL CAUSES ALL ELECTRICAL ACCESSORIES THAT ARE IN CONNECTED TO THE CHARGING SYSTEM AND ARE OPERATIONAL TO FLASH/ FLICKER. EXTREMELY DISTRACTING AT NIGHT WITH HEADLIGHTS AND DASHBOARD FLASHING/ FLICKERING. AFTER A LOT OF RESEARCH I FOUND OUT THE PCM NEEDS TO BE REPROGRAMMED WITH THE PROPER UPDATED FIRMWARE IN ORDER TO FIX THE FACTORY WEAK PARAMETERS. I SPOKE WITH A SERVICE MANAGER TODAY(NOV 14,2019) AT MY LOCAL CHRYSLER DEALERSHIP (CENTRAL JEEP CHRYSLER DODGE RAM FIAT @ 56 BOSTON PROVIDENCE TPKE, NORWOOD, MA 02062) ABOUT THE PROBLEM AND ASKED TO HAVE MY PCM REPROGRAMMED SINCE ONLY THAT SPECIFIC MODEL CAR MANUFACTURES SERVICE SHOP WILL HAVE THE CAPABILITY AND PCM FIRMWARE TO REPAIR IT. THE MANAGER REFUSED TO DO ANY WORK ON MY CAR SINCE HE SAID, "I WONT TOUCH CARS OLDER THAN 10YEARS AND CLOSE TO 100,000MILES". THEN ASKED IF I WAS EVEN A CUSTOMER AT THAT SPECIFIC LOCATION, SAYING NO AGAIN AFTER I SAID I WASN'T. THERE IS NO OTHER OPTION THAN THE FACTORY DEALERSHIP TO FIX A FACTORY FLAWED PCM, WHICH MAKES THE RISK OF MY BATTERY EXPLODING DUE TO THE INCREASED REGULATED VOLTAGE VERY LIKELY. THIS PROBLEM ISN'T NEW TO CHRYSLER SINCE THEY HAVE ISSUED SEVERAL TSB(S) IN MY SPECIFIC VEHICLE AND THIS EXACT PROBLEM: 18-112-16 18-026-03 REV.A 18-016-03 18-020-04

• 11/10/2005· POWER TRAIN,ELECTRICAL SYSTEM,AIR BAGS,EQUIPMENT

  MY 2003 CHRYSLER PT CRUISER, GT MODEL, HAS HAD PROBLEMS SINCE I HAVE HAD IT. FIRST, THE ENGINE LIGHT CAME ON AND THEY REPLACED A HOSE, THEN IT CAME ON AGAIN, AND THEY SAID THEY DIDN'T KNOW WHAT WAS WRONG WITH, AND THEY WOULD HAVE TO WAIT UNTIL IT WENT COMPLETELY OUT. IT DID, AT 28,000 MILES, IT WAS THE TURBO CHARGER. SECONDLY, THE AIRBAG MALFUNCTIONED, THEY HAD TO REPLACE THE SEAT, TOOK THREE TIMES TO GET THE RIGHT SEAT. THIRD, NOW, I WOULD PUT THE CAR IN DRIVE OR REVERSE, AND IT JUST SIT THERE, THEN JERKS INTO GEAR. SOMETIMES IF YOU GIVE IT GAS IT WOULD JUST REV UP. THEY SAID IT WAS THE PUMP IN THE TRANSMISSION, THEY TOOK 4 PLUS DAYS TO REPLACE IT. WHEN I PICKED IT UP I HEARD A NOISE AND SMELL SOMETHING BURNING. WHEN I TOOK IT OUT THERE THEY DIDN'T HEAR OR SMELL ANYTHING SO I WAS SENT ON MY WAY. THEN IT STARTED DOING THE SAME THING IT DID WHEN YOU PUT IT IN REVERSE OR DRIVE. I TOOK IT IN, HE SAID IT NEEDED A BATTERY. I PUT A DIEHARD BATTERY IN IT, BUT SEARS SAID THAT WAS NOT THE PROBLEM. THEN THE CHECK THE ENGINE LIGHT CAME ON, THEY SAID IT WAS THE EVAC PUMP. THEY FIXED THAT. THEY CLAIMED THAT WAS NOT COVERED UNDER THE WARRANTY I HAD WHEN I BROUGHT IT IN TWO WEEKS BEFORE. NOW, I HEAR A GRINDING WHEN I START THE CAR UP, SOMEONE SAID IT SOUNDS LIKE THE FLYWHEEL AND THEY DIDN'T ASSEMBLE THE TRANSMISSION CORRECTLY, AND THAT WAS PROBABLY WHERE THE BURNING SMELL WAS COMING FROM. I AM TAKING IT IN TO THE SHOP TODAY FOR THIS. *NM

• 11/09/2002· SUSPENSION

  THE COMPLAINT INVOLVES A MISSING PART, THE REAL STABILIZER BAR. THIS MODEL STATES ON THE WINDOW STICKER THAT A REAR STABILIZER BAR IS INCLUDED. THIS CAR DOES NOT HAVE A REAL STABILIZER BAR. THE DEALER SAID THAT HE COULD INSTALL ONE FOR $520. CHRYSLER WOULD NOT REIMBURSE THE DEALER BECAUSE THEY CLAIM THAT THEY BEEFED UP THE REAL AXLE AND THAT IS THEIR STABILIZER BAR. I CONTEND THAT THIS IS MISLEADING THE PUBLIC, PARTICULARLY AN INFORMED PUBLIC THAT KNOWS WHAT A STABILIZER BAR IS. THEY CONTINUE TO PRODUCE THIS MODEL WITH THIS MISLEADING INFORMATION ON THE WINDOW STICKERS. I ASK WHY DO THEY SHOW A REAR STABILIZER BAR IN THEIR PARTS COMPUTER THAT THE DEALER LOCATED AND OFFERED TO INSTALL FOR $520 IF WHAT THEY CLAIM IS TRUE. THE SERVICE MANAGER AGREED THAT THIS WAS MISLEADING BUT REFUSED TO ABSORB THE COSTS. OTHER OWNERS WITH SAME MODEL REPORT THAT THEIR CARS ARE MISSING THIS PART AS WELL. I HOPE THAT YOU CAN CORRECT THIS SITUATION BY REQUIRING CHRYSLER TO INSTALL THE PART AT NO COST TO THE OWNERS. DT

• 11/03/2010· FUEL SYSTEM, GASOLINE

  GAS FUMES INTERIOR OF CAR NO PHYSICAL GAS UNDER VEHICLE. *TR

• 11/02/2006· SUSPENSION

  I WENT TO HAVE MY BRAKES CHECKED AND WAS TOLD MY RIGHT AND LEFT LOWER CONTROL ARM BUSHINGS WERE BROKEN. I TOOK THE CAR TO THE DEALERSHIP (TOWED IN BECAUSE THE TRANSMISSION WENT OUT) AND THE BUSHINGS WERE REPLACED. THE MECHANIC SAID HE HAS VERY SELDOM SEEN BUSHINGS IN THE SUSPENSION BREAK WITH ONLY 60,000 MILES ON THE CAR. MY CAR IS A 2003 CHRYSLER PT CRUISER. I COMPLAINED NUMEROUS TIMES ABOUT THE TRANSMISSION BUT WAS NOT ACKNOWLEDGED UNTIL THE CAR WAS INOPERABLE. I AM QUITE HAPPY THAT THE MECHANIC WHO DOES MY BRAKES NOTICED THE CONTROL ARMS. I ASKED CHRYSLER TO CHECK THEM WHILE MY TRANSMISSION WAS BEING REPAIRED, IF NOT, THEY WOULD NEVER HAVE CHECKED. THE SUSPENSION IS OF COURSE, NOT COVERED BY THE WARRANTY ANY LONGER. REPAIR COSTS WERE NEARLY $600. *NM

• 10/31/2016· EXTERIOR LIGHTING,AIR BAGS,STRUCTURECrash

  TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. WHILE DRIVING 35-40 MPH, THE FRONT AMBER HEAD LAMPS FAILED, WHICH RESULTED IN A FRONT END PASSENGER COLLISION. THE FRONT PASSENGER WHEEL DETACHED FROM THE VEHICLE DURING THE CRASH. THE CONTACT STATED THAT THE GLOVE BOX FRACTURED AND SEPARATED UPON DEPLOYMENT OF THE AIR BAGS, WHICH CAUSED FACIAL INJURIES TO THE FRONT SEAT PASSENGER. THE FRONT SEAT PASSENGER SUSTAINED LACERATIONS TO THE FACE, A FRACTURED EYE SOCKET, AND A FRACTURED NASAL PASSAGE. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 09E012000 (EXTERIOR LIGHTING) AND NHTSA CAMPAIGN NUMBER: 08E033000 (SUSPENSION). THE APPROXIMATE FAILURE MILEAGE WAS 112,450. *JS *JS

• 10/27/2006· AIR BAGS,SEAT BELTS

  9/1/06 AS I WAS PARKING MY CAR MY DRIVERS SIDE AIR BAG DEPLOYED . AFTER SEVERAL PHONE CALLS AND EMAILS TO CHRYSLER'S CUSTOMER SERVICE DIVISION, THERE WAS NO REPLY. ON 9/29/06, MY PASSENGER SIDE AIRBAG DEPLOYED, AS WELL AS MY PASSENGER SIDE SEAT BELT LOCKED UP WHILE I WAS DRIVING 50 MILES AN HOUR. THAT DAY I CALLED CHRYSLER AGAIN AND AN INVESTIGATION WAS CREATED. AFTER THE INVESTIGATION CHRYSLER FOUND NO RESPONSIBILITY ON THEIR PART. I SUBMITTED A CLAIM INTO MY INSURANCE COMPANY, AND THEY FOUND THE DEFECT TO BE A MANUFACTURERS DEFECT, AND WILL NOT COVER THE DEPLOYED AIR BAGS OR LOCKED SEAT BELT. AT THIS TIME THERE HAS BEEN NO REPARATION. *NM

• 10/26/2010· POWER TRAIN

  I SAW A STORY ON ABC NEWS CONCERNING DECELERATION ON BMW VEHICLES AND I HAD A SIMILAR EXPERIENCE IN A CHRYSLER PT CRUISER. I WAS TRAVELING AT INTERSTATE SPEED AND EXPERIENCED A SUDDEN DECELERATION OF MY VEHICLE. IF SOMEONE WAS BEHIND ME I WOULD HAVE BEEN HIT. I HAD THE VEHICLE TOWED TO A CHRYSLER DEALERSHIP AND WAS TOLD IT WAS A SENSOR IN THE TRANSMISSION. *TR

• 10/23/2008· STEERING,SUSPENSION

  TL*THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT CONTINUED TO HEAR A CLUNKING NOISE AND STATED THAT THE VEHICLE WOULD "GET AWAY FROM HER" WHILE DRIVING VARIOUS SPEEDS ON THE HIGHWAY. THE DEALER REPAIRED THE TIRE, BUT AN INDEPENDENT MECHANIC STATED THAT CONTROL ARM BUSHINGS AND TIE ROD END REPAIRS WERE COMMON. THE DEALER OFFERED TO REPAIR THE VEHICLE AT THE COST OF MORE THAN $600. THEY ALSO STATED THAT A FRONT END ALIGNMENT WOULD BE NEEDED FOLLOWING THE REPAIRS. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 65,000. UPDATED 11/17/08 *CN UPDATED 11/24/08. *JB

• 10/21/2015· SEATSFire

  TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 25 MPH, THERE WAS A BURNING ODOR COMING FROM THE FRONT DRIVER SIDE SEAT. THE CONTACT MENTIONED THAT THERE WAS A SEAT CUSHION PLACED ON THE DRIVER SEAT AND, WHEN IT WAS REMOVED, IT WAS DISCOVERED THAT THERE WAS A LARGE BURN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 202,078.

• 10/21/2014· ELECTRICAL SYSTEM,AIR BAGSCrash

  STOP AT A RED LIGHT AND WAS HIT FROM BEHIND BY ANOTHER CAR GOING OVER 30 MILES PER HOUR. IT PUSHED US INTO ANOTHER VEHICLE AND THE AIR BAGS DID NOT DEPLOY. MY HUSBAND AND SON GOT WHIP LASH. *TR

• 10/20/2010· EXTERIOR LIGHTING

  THE PLASTIC HEADLIGHT LENSES ON MY 2003 CHRYSLER PT CRUISER HAVE BECOME SO CLOUDY THEY ARE PRACTICALLY USELESS. THIS IS DANGEROUS. I HAVE SEEN OTHER PT CRUISERS AS WELL AS OTHER CHRYSLER PRODUCTS WITH THIS SAME PROBLEM. I AM GOING TO HAVE TO REPLACE THEM AS I AM FEARFUL OF HAVING AN ACCIDENT DUE TO LOW VISIBILITY. I LIVE IN A RURAL AREA WITH ALOT OF DEER AND THIS LOW VISIBILITY CONCERNS ME. *TR

• 10/20/2008· STEERING,ENGINE AND ENGINE COOLING,POWER TRAIN,VEHICLE SPEED CONTROL

  TL*THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT HEARD A LOUD HUMMING NOISE COMING FROM HER VEHICLE. SHE TOOK THE VEHICLE TO A DEALER AND THEY STATED THAT THE POWER STEERING PUMP FAILED. POWER STEERING FLUID LEAKED OUT AND CAUSED THE AIR CONDITIONER TO FAIL. THE UNIT WAS REPLACED AT THE COST OF $1,583. THE TECHNICIAN STATED THAT HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V268000 (STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS); THEREFORE, THEY WOULD NOT ASSUME FINANCIAL RESPONSIBILITY FOR THE REPAIR. SEVERAL WEEKS AFTER THE REPAIR, THE AIR CONDITIONING UNIT FAILED AGAIN. THE CONTACT TOOK THE VEHICLE TO THE DEALER ON NUMEROUS OCCASIONS, IN WHICH SHE HAD TO REPLACE THE WATER PUMP, THE THROTTLE BODY, THE RADIATOR, AND VARIOUS COMPONENTS IN THE POWERTRAIN AND STEERING UNIT. THE REPAIRS COST $4,000. TYPICALLY, THE FAILURES IMMEDIATELY RECUR AFTER THE REPAIRS ARE MADE. THE MANUFACTURER GAVE HER A SMALL REIMBURSEMENT OF $878. THE FAILURE MILEAGE WAS 32,208 AND CURRENT MILEAGE WAS 66,500.

• 10/19/2016· STEERING

  TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS AND TURNING, THE STEERING WHEEL FAILED TO OPERATE AS INTENDED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE POWER STEERING HOSE AND AUTO BELT TRANSMITTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED TWICE FOR POWER STEERING FAILURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V268000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

• 10/15/2003· VEHICLE SPEED CONTROL

  WHEN COMING TO A STOP DRIVER WOULD PRESS ON THE BRAKES AND VEHICLE WOULD ACCELERATE.*AK

• 10/13/2006· SUSPENSION

  PT CRUISER LOWER CONTROL ARM BUSHINGS SHOT WITH ONLY 32000 MILES. THIS IS A COMMON PROBLEM. A DEFECT IN THE BUSHING MATERIAL IS SUSPECT AND FAILURE CAN LEAD TO LOSS OF CONTROL. *NM

• 10/12/2006· ELECTRICAL SYSTEM

  WE RECENTLY PURCHASED A USED 2003 PT CRUISER GT TURBO. WE REALLY LOVE IT. HOWEVER, THERE IS AN ISSUE WE HAVE BEEN TRYING TO FIGURE OUT. THE LIGHTING FLICKERS WHEN YOU START THE CAR. IT IS INTERMITTENT. AFTER RUNNING AWHILE IT DECREASES. USUALLY WHEN FIRST STARTING THE CAR IT IS REALLY BAD. WE DIDN'T NOTICE A DIFFERENCE WHEN WE USED MORE OR LESS POWER IN THE CAR, LIKE TURNING ON THE RADIO AND A/C. THE POWER FLUCTUATION MAKES ALL THE LIGHTS FLICKER INSIDE AND OUTSIDE OF THE CAR, AS WELL AS THE PANEL LIGHTS AND RADIO. *JB

• 10/12/2005· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  CHECK ENGINE LIGHT COMES ON, CAR IDLES AT LOW RPM, AND STALLS AT ANYTHING NEAR 1000 RPM, WHICH IS ITS NORMAL IDLE SPEED, AT LEAST 25 STALLS IN THE PAST 2-3 MONTHS. SO FAR CHRYSLER KNOWS THERE IS A PROBLEM BUT CAN'T FIND IT, SO THEY KEEP GIVING IT BACK TO ME. *JB

• 10/04/2005· STEERING,POWER TRAIN,ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  I HAVE TAKEN MY PT CRUISER INTO DEALER 10-12 TIMES FOR PROBLEMS THAT THEY ARE UNABLE TO CORRECT. THERE HAVE BEEN PARTS LOOSE THAT NEEDED TO BE TIGHTENED, SUCH AS BELTS, HOSES, CONNECTIONS AND INTERIOR PARTS THAT HAVE FALLEN OFF THE CAR AND DEALER DOES NOT KNOW HOW TO FIX. I SUBMITTED A COMPLAINT TO MANUFACTURER AND APPLIED FOR LEMON LAW, BUT CHRYSLER REPRESENTATIVE DID NOT LISTEN AND TOOK DEALER SIDE. THEY CLAIM THEY CANNOT DUPLICATE NOISES, BUT I RECENTLY FOUND OUT THE SHOP SUPERVISOR WHO HAS BEEN CHECKING OUT MY CAR FOR THE NOISES HAS A SEVERE HEARING LOSS AND A CLAIM AGAINST INSURANCE COMPANY FOR HEARING PROBLEMS. THERE ARE HIGH PITCH WHINING NOISES, SQUEALS AND LOUD SCREECHING NOISES COMING FROM THE ENGINE COMPARTMENT. THE CAR LOSES POWER AND SEEMS TO HESITATE AT FREEWAY SPEEDS. THERE IS ALSO A NOISE THAT SOUNDS LIKE A TRAIN WHISTLE IN THE DISTANCE. I HAVE HEARD POPPING SOUNDS IN THE FRONT END AND SQUEALING AND SCREECHING SOUNDS FROM THE BRAKES AND UNDER HOOD IS CONSTANT. THERE IS ALSO A NOISE THAT IS HEARD SOMETIMES IN STEERING AND TURNING. THE DEALER TOLD ME THEY WOULD REPLACE THE POWER STEERING UNIT TO SEE IF IT WOULD SOLVE THE PROBLEMS AND ORDERED THE PART. WHEN I TOOK THE CAR IN FOR THE SERVICE, THEY SAID THEY COULD NOT DUPLICATE THE NOISE AGAIN AND DID NOT DO ANYTHING. WHEN I STEP ON THE BRAKES THE NOISE IS SO LOUD IT CAN BE HEARD FOR A LONG DISTANCE. IT SOUNDS LIKE CARS BEING CRUSHED. THE NOISE IS ALSO PRESENT IN TURNING CORNERS AND DRIVING, BUT WORSE IN STEPPING ON BRAKES. THE DEALER ACKNOWLEDGES A BRAKE PROBLEM BUT SAY THEY DO NOT KNOW HOW TO FIX IT. THERE HAVE BEEN OTHER PROBLEMS SUCH AS RADIO/CD PLAYER DID NOT WORK WHEN NEW, SENSOR LIGHT REPLACED, RATTLES UNDER DASH, CHECK ENGINE LIGHT, ETC, BUT THE NOISES AND IN-ABLILITY TO REPAIR HAVE ME WORRIED ABOUT SERIOUS PROBLEMS. THEY HEAR THE NOISE, BUT THEN TELL ME THE MECHANIC CANNOT DUPLICATE AND DO NOTHING TO REPAIR. THIS HAS BEEN AN ONGOING PROBLEM SINCE I GOT THE VEHICLE IN 2003. *JB

• 10/03/2005· WHEELS

  DT: THE WHEELS ARE CAST ALUMINUM WITH A METAL CHROME PLATE PUT ON IT, ALLOWING AIR LEAKAGE AROUND THE RIMS. THERE WAS CORROSION BETWEEN THE WHEELS AND AXLE. A MECHANIC TOLD THE CONSUMER THAT HE HAD SEEN OTHER SIMILAR VEHICLES WITH THE SAME PROBLEM. THERE WAS A HIGH CHANCE THAT THE WHEEL AND AXLE WILL SEPARATE. THE PROBLEM FIRST STARTED ON DECEMBER OF 2004. THERE HAVE BEEN NO ACCIDENTS AS OF YET. *AK UPDATED 12/07/05. *JB

• 10/02/2008· EXTERIOR LIGHTING

  SHORTLY AFTER LEAVING THE HOUSE, THE FOG LIGHT INDICATOR CAME ON EVEN THOUGH THE HEADLIGHTS THEMSELVES WERE OFF. PRESSURE ON THE END OF THE STALK TURNED THE INDICATOR OFF BUT IT CAME BACK ON WHEN PRESSURE WAS RELEASED. AFTER PARKING AND SHUTTING OFF THE ENGINE, THE INDICATOR (AND THE FOG LIGHTS THEMSELVES) REMAINED ON. REMOVING THE KEYS FROM THE IGNITION HAD NO EFFECT. THE ONLY THING THAT TURNED THE FOG LIGHTS OFF WAS SETTING THE TURN INDICATOR IN THE 'LEFT TURN' (DOWN) POSITION. FURTHER TESTING FOUND THAT THE ONLY OTHER WAY TO TURN OFF THE FOG LIGHTS WAS TO REMOVE THE APPROPRIATE FUSE FROM THE INTERIOR FUSE PANEL. RESEARCHING THE PROBLEM ONLINE TURNED UP SEVERAL MESSAGE BOARDS WITH A LARGE NUMBER OF DRIVERS REPORTING THIS EXACT PROBLEM GOING BACK AT LEAST THREE YEARS, WHICH TURNS OUT TO BE CAUSED BY A FAILING MULTIFUNCTION SWITCH. (ONE SUCH FORUM: HTTP://WWW.TOPIX.COM/FORUM/AUTOS/CHRYSLER-PT-CRUISER/TF81KHBDLDVT92AH2/ ). *TR