2003 Chevrolet Malibu

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2004· AIR BAGSCrash

  I WAS INVOLVED IN AN ACCIDENT IN MY 2003 CHEVROLET, MALIBU ON DEC.26, 2004 AND MY FRONT AIRBAGS DID NOT GO OFF.*AK

• 12/30/2016· UNKNOWN OR OTHER

  WENT TO DEALER WHO MENTIONED THE ONLY REMEDY FOR MY CAR IS A SMALL PIECE ON THE CAR KEY (NOTHING DONE TO THE CAR) AND SINCE I HAD A COPIED KEY, THEY WOULD BE UNABLE TO HELP UNLESS I HAD A GM KEY AVAILABLE.

• 12/30/2014· SUSPENSION

  CONTANCT DEALER COMPANY WILL NOT RETURN CALLS ASK FOR ASSISTANCE IN RESOLVING ISSUES CAR NEEDS BRAKE ALL THE WAY AROUND ROTORS DAMAGEDED NEEDS TYROD END HAS WHITE SMOKE COMING FROM EXAUST DEALER WILL NOT CHECK CAR THEY HAVE THEIR OWN MECHANIC TELL YOU TO CONTACT AND YOU GET NO RESPONSE VEHICLE SOLD TO 76 YEAR OLD LADY AND IS UNSAFE I ASKE IF THEY WOULD TRADE UP IT IS HALF PAID FOR I WAS TOLD NO IT HAS TO BE COMPLETELY PAID OFF. *JS

• 12/29/2016· UNKNOWN OR OTHER

  THEFT SYSTEM LIGHT, LEAVES ME STRANDED, CAR WON'T START UNLESS OPEN DOOR WITH KEY IN IGNITION FOR EXACTLY 10 MINUTES THEN CAR WILL START. I AM A WOMAN THAT IS LEFT STRANDED SEVERAL TIMES A WEEK, AT NIGHT AND ONLY WAY CAR WILL START IS TO HAVE DRIVERS DOOR WIDE OPEN WITH KEY IN IGNITION AND OTHER DOORS WILL NOT LOCK, LEAVES ME IN A DANGEROUS SITUATION. BEGAN A COUPLE OF YEARS AGO, APPROX. 50,000 MILES, JUST GETTING WORSE AND MORE FREQUENT.

• 12/29/2016· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  BOTH HEADLIGHTS SUDDENLY WON'T WORK, BULBS FINE, CHECKED RELAYS TOO, FUSES FINE.

• 12/27/2007· STRUCTURE

  I PURCHASED A 2003 CHEVROLET TAHOE LT AND THE BACK GLASS HINGE HAS CAME UNGLUED FROM THE GLASS AND FALLEN ON ONE SIDE. I HAVE BEEN TOLD BY FOUR GLASS COMPANY'S THAT THEY HAVE HAD TO REPLACE MANY OF 2003 TAHOES AND SURBURBANS WITH THE SAME PROBLEM WITH THE BACK GLASS AND THAT IT IS A DEFECT. I CALLED THE CHEVROLET COMPANY AND WAS TOLD THAT THERE WAS NOTHING THEY COULD DO BECAUSE IT WAS OVER 100,000 MILES BUT ITS THERE PROBLEM THEY ARE THE ONES THAT GLUED THE HINGES TO THE GLASS AND WHY SHOULD I HAVE TO PAY 900.00 DOLLARS TO REPLACE THE GLASS ESPECIALLY WHEN I DON'T HAVE IT. PLEASE DO SOMETHING ABOUT THIS PROBLEM I KNOW THAT I AM NOT THE ONLY ONE WITH THIS PROBLEM. PLEASE MAKE THE CHEVROLET COMPANY FIX THIS PROBLEM. IT HAS CAUSED THE BACK GLASS TO STICK UP OVER THE BACK ABOUT A INCH AND YOU CAN NOT EVEN OPEN IT BECAUSE THE HINGE ON THE GLASS HAS COME COMPLETELY UNGLUED IT FALLS DOWN WHEN YOU OPEN IT AND IS VERY VERY HARD TO CLOSE ONCE YOU OPEN IT. BECAUSE YOU HAVE TO PICK UP ON THE GLASS AND TRY TO CLOSE IT AT THE SAME TIME BELIEVE ME MY FINGERS HAS GOTTEN SMASHED MANY TIMES SO I STOPPED EVEN OPENING IT. BUT BEFORE THIS HAPPENED I REALLY USED IT ALOT TO PUT STUFF IN THE BACK WHEN THE 3RD ROW SEAT WAS BEING USED IF YOU OPENED THE WHOLE DOOR THEN YOUR STUFF FALLS OUT BECAUSE THERE'S NOT MUCH ROOM TO PUT YOUR STUFF BACK THERE. *TR

• 12/27/2004· VEHICLE SPEED CONTROLCrash

  WHILE APPLYING THE ACCELERATOR PEDAL IT STUCK TO THE FLOOR. CONSUMER WAS UNABLE TO MAINTAIN CONTROL OF VEHICLE, AND CRASHED INTO A GUARD RAIL. NO INJURIES REPORTED. VEHICLE WAS TOWED, AND TOTALED BY THE INSURANCE COMPANY. *AK

• 12/25/2003· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  HEADLIGHTS, DASHLIGHTS, GO DIM, FLICKER WHEN STEP ON BRAKES. ALSO HEATER FAN SLOWS DOWN WHEN STEP ON BRAKES. *LA

• 12/24/2014· ELECTRICAL SYSTEM

  2003 CHEVROLET MALIBU. FIRST IGNITION SWITCH FAULTY, HAD WORK DONE AT NON GM DEALERSHIP, CONSUMER WANTS REIMBURSEMENT. *TA THE IGNITION LOCK CYLINDER WAS REPLACED. *JB

• 12/24/2014· ELECTRICAL SYSTEM

  2003 CHEVROLET MALIBU. CONSUMER HAD TO HAVE THE ANTI-THEFT SYSTEM RESET DUE TO RECALL, AND WOULD LIKE TO BE REIMBURSED.

• 12/21/2007· ELECTRICAL SYSTEM

  I HAVE A 2003 TAHOE AND HAVE HAD THE SPEEDOMETER STICK A NUMBER OF TIMES. I HAVE TAKEN IT IN FOR REPAIR SEVERAL TIMES HOWEVER THE SERVICE TECH COULD NOT DUPLICATE THE CONDITION SO THEY TOLD ME NOT TO REPAIR THE ISSUE BECAUSE OF THE COST. GM IS NOW OFFERING A "SPECIAL COVERAGE" THAT EXTENDS THE WARRANTY OF THE INSTRUMENT PANEL, HOWEVER ONLY IF THE TAHOE HAS LESS THAN 70,000 MILES OR YOU HAVE OWNED THE VEHICLE UNDER 7 YEARS WHICHEVER OCCURS FIRST. I FEEL THAT GM HAS KNOWN ABOUT THIS ISSUE AND SHOULD ISSUE A FULL RECALL TO CORRECT THIS ISSUE. THIS IS A VERY DANGEROUS ISSUE THAT NEEDS TO BE ADDRESSED. *TR

• 12/20/2011· ELECTRICAL SYSTEM

  I BOUGHT A CHEVY MALIBU NEW IN 2003. I NEVER KNEW IT HAD ANY ANTI THEFT DEVICE. THREE WEEKS AGO THE ANTI THEFT LIGHT CAME ON. I IGNORED IT. AFTER A FEW DAYS THE CAR WOULD NOT START. THE ENGINE STARTED TO RUN BUT SPUTTERED OUT. I LOOKED IN THE INSTRUCTION MANUAL THAT CAME WITH THE CAR. IT SAYS IF THE ANTI THEFT LIGHT COMES ON (FOR NO REASON) TURN IGNITION TO ON POSITION WAIT TEN MINUTES TURN CAR OFF AND THE CAR WILL START. I FOLLOWED INSTRUCTIONS AND CAR STARTED. SAME THING HAPPENED AGAIN YESTERDAY. I FOLLOWED INSTRUCTIONS AND CAR RUNS AGAIN. PROBLEM I HAVE IS WHY WOULD THE ANTI THEFT SYSTEM BE ACTIVATED FOR NO REASON? CHEVY KNEW THIS HAPPENS AND THIS IS WHY THEY HAVE IT WRITTEN UP IN THE INSTRUCTION MANUAL. IF THE ANTI THEFT SYSTEM IS FAULTY IE COMES ON FOR NO REASON AND PROHIBITS THE CAR FROM STARTING, CHEVY SHOULD NOT HAVE INSTALLED IT IN THE FIRST PLACE. *TR

• 12/20/2007· ELECTRICAL SYSTEM

  ANTI-THEFT LIGHT FLASHING ON MY 2003 CHEVY MALIBU. *TR

• 12/19/2007· ENGINE AND ENGINE COOLING

  MY 2003 CHEVY MALIBU HAD DIED ON ME 3 TIMES WHILE I WAS DRIVING IT AND WOULD NOT RESTART. TWICE I HAD IT TOWED TO THE DEALERSHIP (JBA IN GLEN BURNIE, MD) AND THEY CANNOT FIND A PROBLEM WITH IT. I CAN'T DRIVE IT, BECAUSE I HAVE A 45 MINUTE COMMUTE TO WORK AND CANNOT AFFORD TO KEEP HAVING IT TOWED. *TR

• 12/19/2003· AIR BAGS

  AIR BAG DEPLOYED AFTER IGNITION SWITCH WAS TURNED ON. VEHICLE WAS PARKED IN DRIVEWAY AND WAS NOT MOVING.*AK

• 12/15/2015· ENGINE

  TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO START INTERMITTENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

• 12/13/2005· SEAT BELTS

  I PURCHASED A PRE-OWNED 2003 CAVALIER LS EARLIER THIS YEAR. ON A REGULAR BASIS, THE DRIVERS SEAT BELT SLIPS OUT OF THE LOOP ON THE TOP OF THE SEAT THAT IS SUPPOSED TO HOLD IT, WHILE I AM BUCKLING UP, AND SMACKS ME IN THE NECK. SOMETIMES I DRIVE WITH IT THIS WAY, BUT WAS SINCE TOLD BY MY MECHANIC THAT I SHOULDN'T BECAUSE THE SEAT BELT IS NOT DOING ITS JOB EFFECTIVELY THAT WAY. THE LATEST TIME BEING TODAY, BUT THIS HAS HAPPENED EVER SINCE I PURCHASED THE VEHICLE. THE NUMBER OF FAILURES I HAVE BELOW IS 15, BUT THIS IS JUST AN ESTIMATE. *JB

• 12/12/2014· SUSPENSION,FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,SERVICE BRAKES

  I TELL DEALER CHECK ENGINE LIGHT ON "HE SAYS NOT TO BE CONCERNED THERE IS WHITE SMOKE COMING FROM TAILPIPE IGNITION CAN TAKE UP TO 5 MIN TO GET ON CODE SAYS CAR NEEDS EGR VALVE CAR NEEDED BRAKES AND ROTORS ALL THE WAY AROUND AND TYROD DEALER WILL NOT RESPOND TO CALLS CAR WAS RECALLED FOR IGNITION SWITCH NEVER REPAIRED I NEED TO KNOW IF I CAN TAKE IT IN TO CHEVY DEALER ONY HAD 1 MONTH VEHICLE IS NOT SAFE AND I AM 76 THERE IS A WARANTY ON ENGINE AND TRANSMISSION. *TR

• 12/10/2015· ELECTRICAL SYSTEM

  WHILE DRIVING ON A BUSY ROAD DURING RUSH HOUR, VEHICLE THEFT SYSTEM LIGHT BEGAN FLASHING, DISABLING THE ENGINE WHILE VEHICLE WAS MOVING. DEALER WAS CONTACTED FOR ADVICE, TOLD THAT MOST LIKELY SOLUTION IS REPLACEMENT OF THE BODY CONTROL MODULE, FOR A COST OF $700. $700 FOR A KNOWN AND POTENTIALLY VERY DANGEROUS SAFETY ISSUE IS UNBELIEVABLE.

• 12/10/2003· POWER TRAIN

  WHEN DRIVING AT AN UNDETERMINED SPEED THE VEHICLE WOULD NOT ACCELERATE WHEN PASSING OTHER VEHICLES. THIS CAUSED THE DRIVER TO SLOW DOWN TRAFFIC. *AK THE PASSING GEAR WAS SLOW TO ACTUATE: WHEN PASSING A HIGHWAY SPEED WHEN PULLING OUT STEPPING ON THE GAS, THE ENGINE WOULD REV-UP BUT THE GEAR CHANGE WAS DELAYED. *SCC *JB

• 12/10/2003· SERVICE BRAKES, HYDRAULIC

  WHEN DEPRESSING THE BRAKE PEDAL CONSUMER HEARD A GRINDING NOISE WHICH CAUSED EXTENDED STOPPING DISTANCE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER TO BE INSPECTED. THE MECHANIC INFORMED THE CONSUMER THAT THE FRONT ROTORS WORE OUT. *AK

• 12/08/2011· STEERING

  THE POWER STEERING HAS FAILED 5 TIMES WHILE DRIVING THE VEHICLE. EACH TIME,MY DAUGHTER HAS PULLED OVER, TURNED OFF AND RESTARTED THE ENGINE, AND THE POWER STEERING OPERATED CORRECTLY AGAIN. I HAVE HAD THE POWER STEERING SYSTEM CHECKED BY CERTIFIED GM MECHANICS AT THE LOCAL GM DEALERSHIP; THEY WERE AWARE OF THIS COMMON PROBLEM BUT THEY DID KNOW OF A REMEDY. THE DEALERSHIP CHECKED THE STEERING SYSTEM EACH TIME, AND DID NOT FIND ANY PROBLEMS. I AM SELLING THIS VEHICLE...IT IS NOT SAFE ENOUGH FOR MY DAUGHTER TO DRIVE. *TR

• 12/07/2006· AIR BAGS

  MY HORN WENT OUT ON MY 2003 CHEVY MALIBU DUE TO A DEFECT IN THE AIRBAG MODULE...I DON'T HAVE A HORN AND MY CAR FAILED THE SAFETY INSPECTION, I DO NOT HAVE THE 1100.00 TO FIX IT, THE DEALER TOLD ME TO CONTACT GM TO SEE WHAT THEY WILL DO ABOUT IT. *JB

• 12/07/2006· ENGINE AND ENGINE COOLING

  DT*: THE CONTACT STATED THE VEHICLE ENGINE HESITATED AND LOST ALL POWER AT VARIOUS SPEEDS UNDER NORMAL ROAD CONDITIONS. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO COULD NOT IDENTIFY THE PROBLEM.

• 12/07/2004· SERVICE BRAKES, HYDRAULIC

  FRONT END ROTORS ARE VERY THIN, HEATING UP, AND WARPING. ROTORS HAS BEEN CHANGED TWO TIMES SINCE MARCH OF 2003. *AK THE CONSUMER STATED THAT THE VEHICLE PULSATED WHEN BRAKES ARE APPLIED. *TC

• 12/07/2004· AIR BAGS,VEHICLE SPEED CONTROLCrash

  WHILE DRIVING CONSUMER WAS ENTERING A PARKING SPACE AND VEHICLE ACCELERATED AT A VERY HIGH SPEED, LEAVING SKID MARKS IN THE PARKING SPACE WHERE SHE WAS TRYING TO PARK. THEN, VEHICLE JUMPED THE CURB AND HIT A TREE. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE CONSUMER WAS INJURED. *AK *TC

• 12/06/2014· ELECTRICAL SYSTEM

  VEHICLE WON'T START AND SECURITY LIGHT IS ON. I HAVE TO WAIT 10 MINUTES WITH KEY IN THE ON POSITION TO RESTART ANTI-THEFT SYSTEM AND THEN ENGINE WILL START. THE CAR AS WELL DIED AND SECURITY LIGHT CAME ON WHILE DRIVING ON THE HIGHWAY AT SPEEDS OF 60 MPH AND HAD TO COAST OVER 2 LANES AND WAS LUCKILY NOT HIT OR INJURED. AFTER THIS I TOOK IT TO MY NORMAL MECHANIC TO LOOK AT IT. HE FIXED IGNITION SWITCH ON 3/3/2009 WHICH I HAVE DOCUMENTATION OF PROBLEM I WAS HAVING AND HIM FIXING IT. THIS DID NOT FIX THE PROBLEM AND THE CAR STILL DOES NOT START. I HAVEN'T HAD IT STOP WHILE DRIVING SINCE THEN BUT IN THE BACK OF MY HEAD I'M TELLING MYSELF I NEED TO GET RID OF THIS CAR BEFORE SOMETHING TERRIBLE HAPPENS. SOMETIMES THE CAR IS FINE FOR MONTHS AND THEN IT WON'T START TWICE IN ONE WEEK. THIS IS ESPECIALLY A PAIN WHEN IT IS FREEZING COLD AND I HAVE NO WHERE ELSE TO WAIT 10 MINUTES BUT IN MY CAR. SEEMS TO BE VERY INTERMITTENT. BUT ONE THING IS FOR SURE THAT IF I TRY TO REMOTE START THE CAR WITH THE KEY FAB IT WILL MOST LIKELY ENDS IN TRIPPING THE ANTI-THEFT SYSTEM AND THE CAR WILL NOT START. I'VE SEEN SO MANY COMPLAINTS ON-LINE ABOUT THIS ISSUE. AND I ASK WHY HAS IT NOT BEEN RECALLED ESPECIALLY IF THE CAR CAN STOP RUNNING WHILE DRIVING. THIS HAS MADE ME LOSE CONFIDENCE IN GM, AND IF I BUY ANOTHER CAR I WILL THINK TWICE ABOUT BUYING ANOTHER CHEVY EVEN THOUGH I LIKE EVERYTHING ELSE ABOUT MY CAR. I AM NOT ABOUT TO TAKE IT IN AND SPEND HUNDREDS OF DOLLARS GETTING IT FIXED WHEN I CAN SAVE MY MONEY AND BUY SOMETHING MORE DEPENDABLE BESIDES A GM CAR. IN THE NEXT COUPLE OF YEARS I WILL BE ABLE TO BUY A NEW CAR AND I WILL BE GLAD WHEN I DON'T HAVE TO DEAL WITH THIS PROBLEM AGAIN. *TR

• 12/06/2007· FUEL SYSTEM, OTHER,ELECTRICAL SYSTEM

  I RECEIVED A LETTER FROM CHEVROLET STATING "THIS LETTER IS INTENDED TO MAKE YOU AWARE THAT YOUR VEHICLE COULD DEVELOP A CONDITION WHERE ONE OR MORE OF THE INSTRUMENT PANEL GAUGE NEEDLES MAY STICK, FLUTTER, OR BECOME INOPERATIVE. THIS MAY CAUSE INACCURATE READINGS, INCLUDING THE SPEEDOMETER AND THE FUEL GAUGE" THE LETTER CONTINUES TO STATE THAT "GENERAL MOTORS IS PROVIDING SPECIAL COVERAGE THAT EXTENDS THE WARRANTY" IF "YOUR 2003 CHEVROLET MODEL YEAR CHEVROLET TAHOE WITHIN 7 YEARS OF THE DATE" OR "70,000 MILES". MY CHEVROLET TAHOE HAS BOTH THESE ISSUES. THEY STARTED ABOUT TWO WEEKS BEFORE I RECEIVED THE LETTER. WHAT I DON'T UNDERSTAND AND WOULD LIKE A RESPONSE FROM GENERAL MOTORS IS WHY MY SAFETY IS NOT AN CONCERN TO THEM BECAUSE I HAVE DRIVEN MORE THAN 70,000 MILES IN MY TAHOE? I TRAVEL THROUGH A LOT OF RURAL AREAS TO WORK AND I FEEL IT IS VERY IMPORTANT TO NOT RUN OUT OF GAS. I FEEL IT EQUALLY IMPORTANT TO KNOW HOW FAST I AM GOING. THE SPEEDOMETER REGISTERS THAT I AM GOING 60 OR 70 MILES PER HOUR WHEN I AM SITTING AT A RED LIGHT. WHEN I AM GOING DOWN THE ROAD IT REGISTERS THAT I AM GOING OVER 120 MILES PER HOUR. THIS IS ANOTHER SAFETY ISSUE BECAUSE I DON'T KNOW HOW FAST I AM GOING. NOT TO MENTION THE POTENTIAL FOR SPEEDING TICKETS. I WOULD LIKE TO THINK THAT GENERAL MOTORS CARES ABOUT THEIR CUSTOMERS SAFETY REGARDLESS OF HOW MANY MILES THEY HAVE DRIVEN. THESE GAUGES ARE VERY EXPENSIVE TO HAVE REPLACED AND THEY ARE A SAFETY HAZARD. NOT BEING ABLE TO MONITOR YOUR RATE OF SPEED OR BE AWARE IF YOU HAVE ENOUGH GAS TO GET HOME ARE SAFETY ISSUES TO ME FOR MY HEALTH AS WELL AS MY PEACE OF MIND AND I WOULD LIKE TO KNOW WHY GENERAL MOTORS DOESN'T FEEL RESPONSIBLE FOR CORRECTING THIS DEFAULT THEY ARE AWARE FOR ALL THEIR TAHOE OWNERS. I HAVE A COMPLAINT WITH THE GENERAL MOTORS ANSWER CALL CENTER BUT HAVE NOT RECEIVED A RESPONSE. *TR

• 12/05/2015· STEERING,VEHICLE SPEED CONTROL,ENGINE

  MY SON WAS DRIVING THE 2003 CHEVROLET MALIBU ON THE HIGHWAY WHEN THE THEFT PROTECTION SYSTEM SUDDENLY KICKED IN AN SHUT OFF THE ENGINE CAUSING HIM TO LOSE SPEED AND POWER STEERING AND FORCING HIM TO STOP ON THE HIGHWAY. THEN HE HAD TO SIT THERE 10 MINUTES WITH THE KEY TURNED ON TO RESET THE THEFT SYSTEM BEFORE HE COULD START THE CAR AGAIN AND GET OUT OF A DANGEROUS SITUATION. THE IGNITION AND KEY WAS ALREADY READY REPLACED UNDER THE RECALL TOO.

• 12/04/2004· TIRES

  FIRESTONE TIRES FR680, 215/70R15. REPLACED THE TIRES ON THE FRONT OF MY VEHICLE AT 25,000 MILES DUE TO SEVERE FLAT SPOTTING & STEEL CHORDS SHOWING. THE REAR TIRES ARE PERFECT. CHEVY DEALER AND TIRE STORE BOTH CONFIRMED NO ALIGNMENT ISSUES ARE PRESENT. THE TIRES ARE REALLY DEFFECTIVE. I HAD THE REAR TIRES MOVED TO THE FRONT AND BOUGHT NEW TIRES FOR THE REAR. THE SAME WEARING OCCURRED, SO BOUGHT A NEW SET OF FOUR. THERE HAS NOT BE ANY PROBLEM SINCE.*AK

• 12/01/2014· ELECTRICAL SYSTEM

  I. WAS HAVING TROUBLE WITH THE IGNITION COULDN'T GET THE KEY TO WORK. IT WOULDN'T TURN AND COULDN'T GET THE KEY OUT. I HAD THE IGNITION REPLACED AT MY COST. THEN I HEARD THERE WAS A RECALL FOR THE IGNITION. I CALLED GM THEY SAID THEY WONT COVER THE COST OF MY REPAIRS. *JS

• 11/30/2018· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THERE WAS NO FAILURE WITH THE TWO VEHICLE KEYS UNTIL THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) BY AUTONATION CHEVROLET LAUREL (500 WASHINGTON BLVD, SUITE A, LAUREL, MD 20707, 301-725-2700). THE DEALER WAS INFORMED NUMEROUS TIMES THAT THE REPLACEMENT KEYS FROM THE RECALL FAILED TO REMEDY THE DEFECT. THE VEHICLE FAILED TO START AND WAS UNABLE TO BE RESTARTED NUMEROUS TIMES. FOR OVER FOUR YEARS, THE CONTACT STATED THAT THE ORIGINAL OEM KEYS FUNCTIONED PROPERLY. IN ADDITION, THE ANTI-THEFT FUNCTION FAILED TO OPERATE PROPERLY. THE CONTACT REFERENCED THE OWNER'S MANUAL TO REPROGRAM THE FUNCTION AND TURNED THE VEHICLE ON AND OFF. THE CONTACT STATED THAT THE ANTI-THEFT FEATURE DID NOT WORK FOR THIS YEAR, MAKE, AND MODEL VEHICLE, THE ANTI-THEFT WARNING INDICATOR ILLUMINATED, AND THE VEHICLE WOULD NOT START WHEN THE KEY WAS INSERTED IN THE IGNITION. THE DEALER KEPT THE TWO OEM KEYS AND STATED THAT THE PLASTIC INSERT PIECE THAT WAS TO BE PROVIDED AS A KEY INSERT FAILED AS A REMEDY FOR THE RECALL. THE TWO KEYS DID NOT WORK FOR THE CONTACT'S MODEL VEHICLE. THE DEALER REPORTED TO THE MANUFACTURER THAT THE PLASTIC COVER AND THE KEY MODIFICATION FAILED TO FUNCTION MANUALLY AND ELECTRONICALLY. THE VEHICLE HAD TO BE TOWED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

• 11/29/2010· ELECTRICAL SYSTEM

  WHILE DRIVING THE CAR ON FREEWAY IT JUST STALLED. I COASTED TO BERM. IT THEN RESTARTED. I'VE HAD ALL KINDS OF ELECTRICAL PROBLEMS WITH THIS CAR, BUT THIS IS A SAFETY PROBLEM. I'VE READ THAT THIS ENGINE CUTTING OUT IS PROBABLY ASSOCIATED WITH THE PASSLOCK SYSTEM. I'VE HAD PROBLEMS WITH THAT SYSTEM EVER SINCE I'VE HAD THE CAR. *TR

• 11/29/2008· ENGINE AND ENGINE COOLING

  2003 CHEVY MALIBU WITH 88K. DURING ROUTINE OIL CHANGE WAS ADVISED OF OIL IN COOLANT. UPON TAKING TO MECHANIC WAS TOLD I HAD BAD HEAD/INTAKE GASKET AND NEEDED REPLACED , ESTIMATE COST $2400. UPON RESEARCHING FARTHER I FOUND OUT THAT THIS IS COMMON ON SOME GM VEHICLES WITH THE SAME ENGINE AND THAT IN FACT A CLASS ACTION LAWSUIT HAD BEEN SETTLED IN CALIFORNIA EARLIER THIS YEAR. IN ANY CASE, I'M STUCK WITH THE BILL ON A REPAIR THAT WAS CAUSED BY THE COOLANT THAT THE GM USED AND REQUIRED AS APART OF THE WARRANTY. *TR

• 11/28/2003· SUSPENSION,SERVICE BRAKES, HYDRAULIC

  MANUFACTURING SAFETY ISSUE - CHEVROLET MALIBU 2003 FRONT WHEEL ASSEMBLY HUBS ROTORS, AND BRAKES. CONTINUOUS PROBLEMS. DEALER AND GENERAL MOTORS REFUSES TO CORRECT. ROTORS WARPED, CAUSING BRAKE PADS TO WEAR OUT. TURNED TWICE ALREADY. LEFT HUB REPLACED. NOW EXPERIENCING SAME PROBLEMS AGAIN WITH BRAKING. DEALER REFUSES TO REPAIR DURING NOVEMBER 28, 2003 VISIT. *AK

• 11/24/2014· ELECTRICAL SYSTEM

  2003 CHEVROLET MALIBU. THE CONSUMER STATED THE IGNITION LOCK CYLINDER, WAS REPLACED TWO YEARS AGO. *MW THE CONSUMER IS SEEKING REIMBURSEMENT. *JB

• 11/24/2012· AIR BAGS,STRUCTURECrash

  WHILE DRIVING ON THE FREEWAY I WAS REAR ENDED AND PUSHED INTO THE CENTER DIVIDER AND BOUNCED OFF ONLY TO BE STRUCK AGAIN FROM THE REAR. THE FRONT AND REAR QUARTER PANELS WERE DAMAGED THE FRAME WAS COMPROMISED. MY COMPLAINT IS THAT THE AIRBAGS NEVER DEPLOYED. I SUFFERED BACK, ARM, LEG & KNEE INJURIES IN THE COLLISION. THE CAR HAS BEEN TOTALED BY MY INSURANCE COMPANY BUT I AM STILL CURIOUS AS TO WHAT HAPPENED TO THE SAFETY AIR BAGS. *TR

• 11/23/2005· SERVICE BRAKES, HYDRAULIC

  2003 CHEVY MALIBU HAS HAD RECURRING BRAKE PROBLEMS FOR THE LAST 10,000 MILES IT HAS 33,000 MILES . BRAKES WOULD GRAB AND VIBRATE THE FRONT END. FINALLY WAS TOLD THAT IT NEEDED NEW ROTORS AND PADS, IT IS DRIVEN ON A REGULAR BASIS AND FROM ALL THE OTHER BRAKE COMPLAINTS I READ ABOUT THIS NEEDS TO BE INVESTIGATED. *JB

• 11/21/2017· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE VEHICLE DID NOT START AND THE ANTI-THEFT WARNING INDICATOR ILLUMINATED FOR APPROXIMATELY TWO MINUTES. ALL OF THE INDICATORS ILLUMINATED BECAUSE THE KEY WAS IN THE ON POSITION, BUT THE ENGINE DID NOT START. THE VEHICLE WAS TAKEN TO THE DEALER (ART MOEHN CHEVROLET IN JACKSON, MICHIGAN) AND HAD THE IGNITION SWITCH REPLACED IN AUGUST OF 2017. THE VEHICLE WAS NOT REPAIRED THIS TIME. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 136,000.

• 11/19/2019· POWER TRAIN

  FIRST TIME, WOULDN'T SHIFT INTO PARK AND COULDN'T TURN KEY TO OFF AND TAKE OUT OF IGNITION. SECOND TIME, SHIFT IS STUCK IN PARK AND WILL NOT BUDGE. JUST SITTING IN MY DRIVEWAY.

• 11/19/2014· ELECTRICAL SYSTEM

  2003 CHEVROLET MALIBU ENGINE REFUSED TO START DUE TO IGNITION SYSTEM, REPLACED IGNITION AND KEY, RESET COMPUTER.*CW THE CONSUMER STATED THE ANTI-THEFT LIGHT ILLUMINATED ROUGHLY 50 TIMES WITHIN THE LAST TWO YEARS. ON SEVERAL OCCASIONS, THE VEHICLE WOULD NOT START AND THE VEHICLE HAD TO BE TOWED. THE IGNITION WAS REPLACED. THE VEHICLE RAN FINE FOR NINE MONTHS, AND THEN THE PROBLEM RETURNED. *JB

• 11/19/2003· SERVICE BRAKES, HYDRAULIC,EXTERIOR LIGHTING

  2003 CHEVROLET MALIBU HAVE PROBLEMS WITH ROTORS.*MR THE CONSUMER WAS ALSO TOLD THE VEHICLE HAD A DEFECTIVE BRAKE LAMP SWITCH WHICH CAUSED PARTS TO ACTUALLY MELT BECAUSE THE BRAKES STAYED ENGAGED WHILE DRIVING. ONE MONTH LATER THE VEHICLE WAS BACK TO EXPERIENCING THE SAME PROBLEM, THE CONSUMER STATED WHEN HE ATTEMPTED TO MAKE A U-TURN, THE TIRE DID NOT TURN THEY GRABBED THE ROAD AND SAT THERE JUST BENDING THE PRESSURE OF THE TURN AND THE VEHICLE BUCKED. *JB *NM

• 11/18/2011· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT ATTEMPTED TO START THE IGNITION BUT THE ENGINE FAILED TO OPERATE WITH THE ILLUMINATION OF THE ANTI-THEFT SECURITY SYSTEM WARNING INDICATOR. THE ENGINE WAS RESTARTED AFTER TEN TO FIFTEEN MINUTES. IN ADDITION, THE SAME FAILURE WOULD OCCUR WHILE DRIVING AND RESULT IN THE VEHICLE STALLING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO ADVISED THAT THE IGNITION SYSTEM AND COMPUTER MODULE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 36,000. UPDATED 01/03/12*LJ UPDATED 01/04/12

• 11/15/2020· AIR BAGS

  MY DAUGHTER GOT A SAFETY RECALL NOTICE FOR HER 2003 CHEVY MALIBU. SHE TOOK THE CAR TO MAGUIRE CHEVROLET 2073 ROUTE 96 IN TRUMANSBURG, NY 14886 (607)-387-6111 (THIS DEALER WAS PRINTED ON THE RECALL CARD) IN AUGUST TO HAVE THE RECALL REPAIRED. SOMEONE AT THAT DEALERSHIP TOLD HER THAT THERE IS NO SUCH RECALL. I FOUND IT FISHY AT THE TIME. WE HAVE RECEIVED ANOTHER RECALL NOTICE EXACTLY THE SAME AS THE OTHER ONE. SO, I HAVE RESEARCHED IT ONLINE. THERE IS INDEED A RECALL, AND IT CAN BE SERIOUS. IT CLEARLY STATES THAT THERE COULD BE A POSSIBILITY OF THE AIR BAGS NOT DEPLOYING. WHAT IF SOMETHING HAPPENS TO MY DAUGHTER OR MY GRANDSON, IN THE MEANTIME, BECAUSE MAGUIRE CHEVROLET WERE TOO LAZY TO MAKE THE REPAIRS? I DON'T UNDERSTAND HOW THIS IS ACCEPTABLE BEHAVIOR BY A DEALERSHIP? THANK YOU FOR YOUR ATTENTION TO THIS MATTER.

• 11/15/2010· ELECTRICAL SYSTEM

  THE PASSLOCK ANTI THEFT SYSTEM IS A VERY DANGEROUS SYSTEM. THERE HAVE BEEN THOUSANDS OF COMPLAINTS ABOUT THIS SYSTEM. THOUSANDS OF ANGRY, FRUSTRATED PEOPLE THAT ARE BEING LEFT WITH NO RECOURSE. THE PROBLEM DATES FROM THE 1990S.THROUGH 2010. THE PROBLEM SHOULD HAVE BEEN ADDRESSED BEFORE NOW. I JUST SPENT OVER $5000. FOR A CAR THAT CANNOT BE MOVED OUT OF MY DRIVE WAY I DON'T THINK CONGRESS HEARD THE SCREAMS I'VE HEARD AND READ ABOUT THIS PROBLEM ('I'LL NEVER BUY ANOTHER GM CAR AGAIN', OR 'IF THERE IS EVER A CLASS ACTION SUITE, COUNT ME IN') WE DON'T KNOW HOW MANY PEOPLE HAVE BEEN HURT BECAUSE THEY HAVE BEEN LEFT STRANDED, OR THEIR CARS CAUSED WRECKS BECAUSE THE PASSLOCK SYSTEM KICKED IN AND CUT OFF THE FUEL WHILE THEY WERE GOING DOWN THE HIGHWAY AT 70 MILES AN HOUR. IT IS VERY DIFFICULT TO READ ABOUT SO MANY UNHAPPY PEOPLE. I CAME FROM A GENERATION OF PEOPLE THAT WORKED FOR FIFTY YEARS. WE DID ALL THE THINGS WE WERE SUPPOSED TO. WE WORKED HARD, PAID OUR BILLS AND TRUSTED THAT WE WOULD BE TREATED FAIRLY. TO REALLY FIND OUT ABOUT PASSLOCK, JUST GOOGLE PASSLOCK COMPLAINTS. THESE ARE JUST A FEW OF THE LINKS TO COMPLAINTS. HTTP://WWW.CONSUMERAFFAIRS.COM/SEARCH.HTML?CX=PARTNER-PUB-0200629403145096%3AQT7MBBQYBBG&COF=FORID%3A10&IE=ISO-8859-1&Q=PASSLOCK&SA=SEARCH&SITEURL=WWW.CONSUMERAFFAIRS.COM%2F&SITEURL=WWW.CONSUMERAFFAIRS.COM%2FAUTOMOTIVE%2FGM_CHEV_MALIBU_P2.HTML#906 HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2003/CHEVROLET/MALIBU/ELECTRICAL+SYSTEM HTTP://WWW.CARCOMPLAINTS.COM/CHEVROLET/MALIBU/2002/ELECTRICAL/PASSLOCK_PROBLEM_WONT_START_ANTI-THEFT_LIGHT_IS_ON.SHTML HTTP://WWW.CAR-FORUMS.COM/TALK/SHOWTHREAD.PHP?T=2349 HTTP://WWW.CHEVROLETPROBLEMS.COM/SEARCH/RESULTS.SHTML?CX=PARTNER-PUB-6745124734283845%3A635TFYW220Y&COF=FORID%3A10&IE=ISO-8859-1&Q=PASSLOCK&SA=SEARCH&SITEURL=WWW.CHEVROLETPROBLEMS.COM%252FINVESTIGATIONS%252FMALIBU%252F#931 IS THERE NO HOPE'..EVER? *TR

• 11/14/2014· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING 10 MPH, THE ENGINE STALLED AND ALL OF THE INSTRUMENT PANEL LIGHTS ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE STARTED TO EXHIBIT THE FAILURE IMMEDIATELY AFTER BEING REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 168,000.

• 11/14/2011· ELECTRICAL SYSTEM

  AT LEAST ONCE A WEEK SINCE PURCHASING THE CAR I AM UNABLE TO START IT BECAUSE THE ANTI-THEFT SYSTEM WILL BLOCK THE CAR FROM STARTING. I WILL PUT THE KEY IN THE IGNITION AND THE SENSOR LIGHT WILL FLASH. I HAVE TO WAIT EXACTLY 10 MINUTES WITH THE KEY TURNED TO "ON" BEFORE THE LIGHT STOPS FLASHING AND I CAN TURN THE CAR OFF AND BACK ON AGAIN. ON A FEW OCCASIONS THIS HAS OCCURRED BACK TO BACK RESULTING IN HAVING TO WAIT AT LEAST 20 MINUTES TO START MY CAR. I HAVE SEEN THAT THIS IS A COMMON PROBLEM FOR THIS CAR, WHICH SEEMS TO DEFEAT THE PURPOSE OF A SAFETY FEATURE IF YOU HAVE TO WAIT IN A DARK PARKING LOT ALONE FOR 10 MINUTES BECAUSE OF FAULTY CONSTRUCTION. *TR

• 11/13/2014· ELECTRICAL SYSTEM

  2003 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH REPLACEMENT AND RECALL. *TGW

• 11/12/2015· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH AND ATTEMPTING TO MAKE A RIGHT TURN, THE VEHICLE STALLED WITHOUT WARNING. AFTER A FEW MINUTES, THE VEHICLE WAS ABLE TO BE RESTARTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 68,000.

• 11/12/2014· ELECTRICAL SYSTEM

  THE IGNITION LOCK FAILED RESULTING IN AN INABILITY TO START THE ENGINE. *TR