2002 Toyota Tacoma

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2018· UNKNOWN OR OTHER

  TAKATA RECALL THE CHASSIS OF THE TRUCK IS COMPLETELY RUSTED. DOES NOT LOOK SAFE TO DRIVE.

• 12/28/2009· SUSPENSION,PARKING BRAKE,FUEL SYSTEM, GASOLINE,POWER TRAIN,STRUCTURE

  GAS TANK SHIELD SEVERELY RUSTED. UNDER SIDE OF GASTANK IS PROTECTED BY A SHIELD/SKID PLATE. IT IS RUSTED SO BADLY THAT WHEN HIT WITH A HAMMER THE HAMMER GOES RIGHT THROUGH. PRESUMABLY THIS SHIELD IS TO PROTECT THE GAS TANK FROM DEBRIS AND STONES ESPECIALLY IF THE TRUCK IS USED OFF ROAD. I DISCOVERED THIS AS I WAS INSPECTING THE UNDERSIDE OF THE TRUCK BEFORE DROPPING THE TRUCK OFF AT THE DEALER TO HAVE THE FRAME REPLACED. IN ADDITION TO THIS, IT IS APPARENT THAT THE DRIVE AXLE AND DIFFERENTIAL HOUSING ALSO HAVE SEVERE RUST. IF TAPPED WITH A HAMMER THE RUST COMES OF IN SHEETS. THE PARKING BRAKES ACTUATING LEVERS HAVE RUSTED IN PLACE AND CAN NO LONGER BE USED. THERE APPEARS TO BE MORE TO THIS RUST THAN SIMPLE FRAME RUST. THE RUST IS PERVASIVE THROUGH OUT THE UNDERSIDE OF THE TRUCK. *TR

• 12/27/2021· SUSPENSION,ELECTRICAL SYSTEM,WHEELS

  DRIVING IN A HIGHWAY STATE 81 TOWARDS HARRISONBURG VIRGINIA WHEN MY 2002 TOYOTA TACOMA , PARTS OR EQUIPMENT UNDERNEATH THE TRUCK COLLAPSE CAUSE OF OUT OF CONTROL OF THE TRUCK , THE WHOLE SHOCK AND THE BALL JOINT IN THE FRONT ALL THE WAY TO THE BACK, THE PASSENGER SIDE AND DRIVER SIDE FALL TO THE GROUND, WHILE DRIVING DID NOT HIT ANY ONE BUT IT WILL CAUSE MY LIFE AT RISK . I DONT KNOW WHAT HAPPEND IF I CAN CALL SOME AS A RECALL , SINCE THE BEGINNING OF 2002 WHEN I BOUGHT THE TRUCK BRAND NEW AT STEVEN TOYOTA HARRISONBURG , VIRGINIA , NOT EVEN A YEAR YET NOTICE THAT UNDERNEATH FROM PIPE TO THE SHKICJ THE WHOLE UNDERRNEATH START TO RUSTY BAD BUT NO ONE EVER TOLD ME HOW BAD IT IS. I LOVE MY 2002 TOYOTA TACOMA .I KEPT THE TRUCK FOR ALMOST 20 YEARS NOW I BELIEVE IM ONLY THE ONE IN PAGE COUNTY TOWN OF STANLEY VIRGINIA DRIVING A TOYOTA TACOMA . I TOOK CARE OF MY TRUCK NOTHING BUT ONLY 135,000 MILES ON IT., MOSTY EVERYDAY I HAVE BEEN ASK OR MANY PEOPLE LIKE TO BUY MY TRUCK . IM NOT VERY RICH PERSON IM NOT RETIRED YET BUT I GOT DISABLE FOR A YEAR AND MY INCOME NOT ENOUGH BUT WITH THE HELP OF SOME FAMILY I MANAGE TO PAY THE TOWING CAMPONY . NOW THE TRUCK SET IN TO MY MECHANIC TOLD THEM TO FIX AND WHAT EVER IT TASKES OF COURSE WILL COST ME MORE MONEY. I WILL LOST MY TRUCK IF I DONT HAVE MONEY TO FIX IT AND MY INSURANCE WILL NOT PAY ANYTHING . THIS THE FIRST THING IM GOING TP WORK ON IT AFTER ALL HOLIDAYS . LOTS IOFTHEY TOWED IT , CHARGE ME THEN PAY SHOP N MECHANIC TOW IT ,WILL START ON IT ,COST LOTS OF MONEY TO FIX IT TOLD THEM TO FIX IT , HOLIDAYS HAVE NOT START YET , I MIGHT NOT BE ABLE TO PAY .! I NEED MY TYRUCK OR SUE/ SO PROUD ON IT .WHY HAPPENED WHY FELL OFF . LEFT THE TRUCK AT THE HIGHWA POLICE SPOTED SAY I ABANDON THE TRUCK , BUT NO CHARGES , NO , JUST DONE STATE INSPECTION , NO WARNING SIGN, BY NOW ILL BE DEAD AT RISK , DEALER IGNORANT, RUDE TOYOTA DEALER. WHERE I BOUGHT THE TRUCK BRAND NEW , SO IGNORANT CARRYING TOYOTAS NAME , SHOULD NOT WORK AT TOYOTA THA

• 12/26/2003· TIRES

  PURCHASED TOYOTA MR2 SPYDER IN AUGUST OF 2002. CAR NOW HAS 18,300 MILES AND BOTH FRONT TIRES (YOKOHAMA ADVAN A043 185/50R15) ARE WORN BEYOND RECOMMENDED TREAD DEPTH AND BLISTERED ON INSIDE(BECAUSE OF FRONT-END MISALIGNMENT ACCORDING TO DEALERSHIP). *AK

• 12/25/2014· STRUCTURE

  I PURCHASED THIS VEHICLE FROM MOTORCARS OF LANSING ON 12/5. THE ONLY DISCLOSURE WAS RUST ON BUMPER. EVERYTHING ELSE APPEARED OK UNTIL I HAD IT CHECKED FOR RUST. WHEN HIT WITH A HAMMER THE FRAME FELL APART. I CALLED THE DEALER & THEY SAID "SORRY THE RECALL EXPIRED IN 2011". I CONTACTED TOYOTA DIRECTLY WHO TOLD ME THE SAME THING. BASICALLY I'M STUCK WITH A VEHICLE I CAN'T DRIVE BECAUSE IT'S NOT SAFE. WHAT I DON'T UNDERSTAND IS THIS VEHICLE HAD BEEN SERVICED AT SEVERAL TOYOTA DEALERS DURING THE RECALL TIME & NO ONE REPAIRED THE FRAME. THIS VEHICLES IS NOT DRIVABLE, IT'S NOT SAFE & NO ONE WILL HELP ME GET IT FIXED. HOW CAN A TOYOTA DEALER SEND A VEHICLE TO AUCTION KNOWING THERE WAS A RECALL ON THE FRAME THAT WAS NEVER REPAIRED? *TR

• 12/24/2018· STRUCTURE

  FRAME IS RUSTING REAL BAD AND FALLING APART.CALLED TOYOTA AND DEALER AND THEY SAID THERE IS NOTHING THEY CAN DO. THERE IS A SUBSTANTIAL CRACKING AND BREAKING APART ON THE FRAME I READ ONLINE THIS IS A KNOWN ISSUE AND THERE IS PROBLEMS WITH A LOT OF TACOMA'S AND LIKE TRUCKS. BUT NO ONE WANTS TO TAKE OWNERSHIP OF THE PROBLEM. EVERYWHERE ELSE ON THE FRAME IS LITTLE RUSTY GIVEN THE AGE OF THE TRUCK BUT IN ONE SPOT IT IS ABSOLUTELY HORRIBLE AND SCARY. I DON'T KNOW WHAT ELSE TO DO OR WHERE ELSE TO TURN.

• 12/24/2010· SUSPENSIONCrash

  THE BALL JOINTS AND SUSPENSION ON MY 2002 TOY TACOMA FELL APART WHILE MAKING A ROUTINE TURN ONTO MY STREET! THE BALLJOINTS SEPARATED AND THE FRONT AXLE DUG INTO THE STREET, THE ONLY THING HOLDING THE WHEEL TO THE VEHICLE WAS THE BRAKE LINE! HAD THIS HAPPENED 5 MINUTES EARLIER IT WOULD HAVE BEEN ON THE FREEWAY DOING 65 MPH INSTEAD OF IN A RESIDENTIAL TRACT DOING 20 MPH! *TR

• 12/23/2014· STRUCTURE

  I TOOK MY TRUCK T A TOYOTA ANY A DEALER TO FIX SOME EMISSION ISSUES, THEY ASKED IF I WANTED THE FRAME INSPECTED, THEY INFORMED ME ABOUT THE FRAME RUST/PERFORATION ISSUES THAT HAVE PLAGUED TACOMA'S FOR YEARS FROM THE MID 90'S TO 2010 TACOMA,S. THE FRAMES RUST FROM THE INSIDE OUT CREATING HOLES THAT CAUSE A FRAMED TO FALL APART AND RENDER THE VEHICLE WORTHLESS!! A SOME POINT ON 2001-04 TACOMA'S THEY SENT OUT A TSB OFFERING A VOLUNTARY CUSTOMER INSPECTION ON THE FRAMES THIS PROGRAM ENDED 6/11. THEN SOME TYPE OF FRAME REPLACEMENT PROGRAM WAS OFFERED TO PEOPLE THAT DID THE VOLUNTARY INSPECTION UNTIL 7/14. SO IF YOU CHOOSE NOT TO DO OR NEVER RECEIVED A NOTICE YOUR VEHICLE WILL FALL APART AND TOYOTA DOESN'T CARE. MY TRUCK RUN AND ON THE SURFACE LOOKS NEW DRIVES LIKE NEW HOWEVER I CAN'T DRIVE IT BECAUSE IT IS UNSAFE. IT HAS BEEN REDUCED TO A LAWN ORNAMENT. I BOUGHT THE TRUCK FROM THE ORIGINAL OWNER AN HE HAS LIVED AT THE SAME ADDRESS FOR OVER 40 YEARS HE NEVER! RECEIVED ANY NOTICE..TOYOTA .REPLACE MY FRAME BECAUSE YOU KNOW IT'S A SAFETY HAZARD. *TR

• 12/21/2012· STRUCTURE

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THE ENTIRE FRAME WAS COVERED WITH RUST. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE A RUST UNDER COATING WAS APPLIED TO THE FRAME. TWO YEARS LATER, THE FRAME EXHIBITED SEVERE RUST AND CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 53,871. UPDATED 01/18/13*LJ UPDATED 01/24/13

• 12/21/2004· SERVICE BRAKES, HYDRAULIC

  2002 TOYOTA SEQUOIA BRAKES VIBRATE SEVERELY. VSC SYSTEM WARNING LIGHT FREQUENTLY COMES ON. PROBLEM HAS EXISTED SINCE CAR HAD 10,000 MILES, NOW HAS 36,000 AND DEALER AND TOYOTA CLAIM IT IS OUT OF WARRANTY. TOYOTA CLAIMS THAT CAR HAS NO BRAKE PROBLEMS, NO SAFETY PROBLEMS AT ALL, AND THAT ORIGINAL BRAKES ARE NOT DEFECTIVE IN DESIGN. I AM INFORMED THAT TOYOTA ISSUED A TECHNICAL SERVICE BULLETIN, ALTHOUGH TOYOTA DENIED THIS THE DEALER ADMITTED THAT IT EXISTED, BUT I HAD TO SPECIFICALLY COMPLAIN ABOUT THE SPECIFIC BRAKE PROBLEM, OR THEY WOULD NOT AND DID NOT ADVISE ME OF THE REMEDY. THESE BRAKE ISSUES ARE A SERIOUS SAFETY PROBLEM.*AK

• 12/20/2010· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  WAS DRIVING ON THE HIGHWAY WHEN THE TRUCK ENGINE BEGAN TO THUMP. TOWED TRUCK TO TOYOTA DEALERSHIP WHERE THE FIRST DAY THEY SAID INTERNAL ENGINE FAILURE, THE NEXT DAY THEY SAID ENGINE OIL PUMP FAILURE. THE OIL LIGHT INDICATOR NEVER CAME ON BEFORE AND AFTER THE INCIDENT. I HAD AN OIL CHANGE FROM ANOTHER TOYOTA DEALERSHIP ON NOVEMBER 30TH. *TR

• 12/18/2002· SUSPENSION,POWER TRAIN

  BROUGHT TRUCK TO TOYOTA SERVICE FOR 5000 MILE SERVICE REPORTED AUTO TRANS JUMP IN GEAR SHIFT FROM 1ST TO SECOND (MECHANIC SAID NEEDED NEW TRANSMISSION, AFTER LEAVING SERVICE STATION NOTICED TRUCK WASN'T DRIVING PROPERLY BROUGHT TRUCK BACK MECHANIC SAID NEEDS NEW FRONT SHOCK AND REAR SHOCK. NOW IT DID NOT NEED NEW TRANSMISSION EVEN THOUGH IT STILL JUMPS FROM GEAR TO GEAR.

• 12/17/2002· SUSPENSION,EQUIPMENT

  TRANSMISSION JUMPS FROM FIRST TO SECOND AND SECOND TO THIRD TRANSMISSION SLIPS BACKWARD ON HILL IN DRIVE

• 12/14/2010· SUSPENSION

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH AND ATTEMPTING A RIGHT TURN WHEN THE FRAME FRACTURED FROM THE VEHICLE, LEAVING THE WHEEL CONNECTED BY THE BRAKE LINE ONLY. THE VEHICLE WAS TOWED TO THE CONTACTS PLACE OF RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY CONFIRMED THAT THERE WAS A RECALL FOR THAT YEAR, MAKE AND MODEL (NHTSA CAMPAIGN ID NUMBER: 05V225000-SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT) BUT THE RECALL DID NOT INCLUDE HIS VIN. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

• 12/14/2004· LATCHES/LOCKS/LINKAGES

  PLASTIC DOOR HANDLES ON TOYOTA SEQUOIAS EASILY BREAK OFF, VERY FLIMSY. THIS COULD LEAD TO SOMEONE GETTING TRAPPED IN THEIR CAR, ESPECIALLY IF YOU ARE INVOLVED IN AN ACCIDENT AND NEED TO OPEN THE DOOR QUICKLY OR AGGRESSIVELY. MY NEIGHBOR HAPPENS TO HAVE THE SAME VEHICLE EVEN THE SAME COLOR AND I ASKED HIM HOW HE LIKES IT AND HE SAID FANTASTIC, EXCEPT WE HAVE BROKEN OFF 2 DOOR HANDLES. WHEN I TOOK IT TO THE DEALER THE SERVICE WRITER CASUALLY MENTIONED, "OH, WE GET THESE IN ALL THE TIME". I CONTACTED THE DEALER AND THE TOYOTA ZONE OFFICE AND THEY WILL NOT PAY FOR THE $175 REPAIR. THIS IS A SERIOUS SAFTEY HAZARD AND A DEFECTIVE PRODUCT.*AK

• 12/13/2015· STRUCTURE

  IS THERE A RECALL ON THE FRAME OF MY TRUCK? IF NOT THEY SHOULD BE BECAUSE RIGHT BEHIND THE THE CAB OF MY TRUCK THE FRAME IS BROKE.

• 12/12/2017· STRUCTURE

  MY TRUCKS FRAME RUSTED TO WHERE THE CAB IS IN GRAVE DANGER OF SEPARATING FROM THE BED OF THE TRUCK. WE DIDN'T GET A RECALL ON THE FRAME AND HAD NO IDEA THIS WAS HAPPENING. THE TRUCK WAS BOUGHT NEW AND WE DO LIVE WHERE THEY PUT SALT ON THE ROADS. NOW, TOYOTA SAID THEY WILL NOT HELP REMEDY THIS AT ALL BECAUSE THE TRUCK WASN'T TAKEN INTO A TOYOTA DEALERSHIP IN APPROX. 6 MTHS OR HOWEVER LONG THEY HAD KNOWN ABOUT THIS. HOW WERE WE TO KNOW IT SHOULD HAVE BEEN TAKEN IN? WE HAD NO PRIOR NOTICE UNTIL WE SAW IT OURSELVES AND A MECHANIC NOTICED IT AND WOULDN'T JACK THE TRUCK UP TO REPAIR A BRAKE LINE. HE SAID IT WOULD SEPARATE THE TRUCK FROM THE CAB PART.

• 12/11/2014· TIRES

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.

• 12/11/2013· STRUCTURE

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR UNRELATED REPAIRS WHEN HE WAS ADVISED THAT THE SUB-FRAME WAS SEVERELY CORRODED. AS A RESULT, THE TECHNICIAN ADVISED THE CONTACT THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 110,000.

• 12/09/2001· TIRES

  TREAD COMPLETELY SEPARATED. *AK (DOT NUMBER: W2UL AWN TIRESIZE: P205/75R15)

• 12/07/2022· UNKNOWN OR OTHER

  chassis recall

• 12/07/2004· EQUIPMENT

  I PURCHASED A 2002 TOYOTA SAQUOIA IN THE YEAR OF 2002,IN THE YEAR 2003 MY AIR CONDITIONING SYSTEM WENT OUT IN MY NEW VEHICAL UPON TAKING IT TO THE LOCAL TOYOTA DEALER I WAS TOLD THAT MY COMPLETE AIR CONDITIONING SYSTEM NEEDED TO BE REPLACED,I HAVE WENT A COMPLETE YEAR WITH OUT AN AIR CONDITION SYSTEM MIND YOU I LIVE IN AUGUSTA GEORGIA,THIS CAUSES SEVERAL THINGS TO NOT FUNCTION PROPERLY SUCH AS GAS GAGE NOT PROPERLT WORKING,WHEN YOU DRIVE THE CAR 60 MPH OR OVER THE TRUCK BEGAN TO BURN,THE AIR COMES ON AUTOMATICLLY AND THE TRUCK BEGAN TO JUMP VERY BADLY LIKE THE CAR IS GOING TO BLOW UP,THE HEAT ONLY WORKS WHEN YOU SET IT AT 80 DEGREES OR HIGHER SO YOU CAN ONLY LEAVE IT ON FOR SO LONG THEN YOU MUST TURN IT OFF AND WHEN IT GETS COLD AGAIN YOU HALF TO TURN IT ON AGAIN THIS GOES ON ALL DAY LONG.I CAN'T SEM TO GET ANY ONE FROM TOYOTA TO HELP ME WITH THERE DEFAULT, MY WIFE WON'T EVEN DRIVE THE CAR.SO WHEN I TOOK IT TO A NOTHER DEALER TO SEE IF THIS WAS REALLY THE PROBLEM HE TOLD ME THAT THE SYSTEM WAS REALLY BLOWEN.SIRS I WORK VERY HARD FOR MY MONEY AND I DON'T HAVE A LOT OF IT TO GIVE AWAY,IREALLY DON'T APPRICIATE A PRESTEGIOUS COMPANY SUCH AS TOYOTA TO PRAY ON ON IT'S CONSUMER. WHEN THE VEHICAL WAS CHECKED TO SEE IF THERE WAS A RECALL AT MY REQUEST THERE WAS WHAT YOU CALL A BULLITEN ON THIS PROBLEM,I THEN ASKED IF YOU KNOW THAT THIS PROBLEM ENOUGH WHY ISN'T THERE A RECALL I REALLY DON THINK THAT I THE CONSUMER SHOULD HALF TO FOOT A $2000 BILLL ON SOMETHING THAT WAS NOT MY FAULT I AM VERY SORRY THAT I PICKED A TOYOTA SEQUOIA THIS IS NOT A CHEAP VEHICAL IF YOU CAN HELP ME AND MY FAMILY PLEASE DO SO.THANK YOU IN ADVANCE. *AK

• 12/04/2007· PARKING BRAKE

  PARKING BRAKE SYSTEM CONTINUALLY FREEZES UP DUE TO POOR CABLE AND SPRING ROUTING. PROBLEM APPEARS TO BE WELL KNOWN TO AREA MECHANICS. *TR

• 12/03/2020· SUSPENSION,STRUCTURE

  MY FRAME IN MY 2002 TACOMA IS ALMOST FULLY RUSTED . I CONTACTED TOYOTA AND THEY ARE NOT WILLING TO HELP EVEN THOUGH THEY KNOW THAT THEIR TRUCKS ARE RUSTING AND THAT THERE WAS A PREVIOUS RECALL SET TO REPLACE THE FRAME. SINCE I JUST GOT THIS TRUCK FORM SOMEONE, I HAD NO IDEA OF THE RECALL AND OF THE RUST . THE CAR IS NO LONGER SAFE TO DRIVE AT THIS POINT SINCE IT IS ABOUT TO BREAK IN HALF .

• 12/03/2013· STRUCTURE

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR SERVICE UNDER NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES). THE CONTACT WAS ADVISED THAT THE VEHICLE COULD NOT BE SERVICE UNDER THE RECALL BECAUSE OF EXCESSIVE CORROSION. THE CONTACT STATED THAT HE WAS NEVER ADVISED OF CORROSION WHEN THE VEHICLE WAS INSPECTED IN 2010 FOR A MANUFACTURER'S WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

• 12/02/2013· STRUCTURE

  2002 TOYOTA TACOMA. CONSUMER WRITES IN REGARDS TO VEHICLE SEVERE FRAME RUST ISSUE AND NO WARNING OF RECALLS. *SMD TOYOTA USA INFORMED THE CONSUMER, A RECALL WAS NOT ISSUED, BUT A CUSTOMER SERVICE PROGRAM WAS OFFERED, BUT IT EXPIRED AT THE END OF 2011. THE CONSUMER WAS INFORMED SIX LETTERS WERE MAILED INFORMING HER OF THE ISSUE. HOWEVER, THE CONSUMER STATED SHE NEVER RECEIVED ANY LETTERS.

• 12/02/2007· STRUCTURE

  2002 TOYOTA TACOMA HAS PREMATURE FRAME DETERIORATION ON FRAME SIDE RAILS AND REAR. REAR FRAME IS SO BAD THAT THE RUST IS CAUSING THE BUMBERTO LIFT UP IN THE MIDDLE BY ABOUT 1-2INCHES. OWNER KEEPS TRUCK WASHED AND WAXED EVEN THROUGH WINTER MONTHS. HAVE NOT YET LOOKED TO GET REAR PROBLEM REPAIRED. *TR

• 11/30/2016· STRUCTURE

  I OWN A 2002 TOYOTA TACOMA. THE VEHICLE WAS TAKEN TO A TIRE SHOP AND THE TECHNICIAN NOTICED THAT THE FRAME OF THE VEHICLE HAD A CONSIDERABLE AMOUNT OF RUST. THE DEALER DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED DUE TO THE RUST AND THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE NEEDS TO REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 150,000.

• 11/29/2010· SUSPENSION

  TL*THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, HE HEARD A LOUD POP WHILE TURNING RIGHT AND LOST CONTROL OF THE VEHICLE. THE CONTACT PULLED OVER. HE NOTICED THAT THE FRONT PASSENGER SIDE TIRE DISCONNECTED FROM THE LOWER CONTROL ARM AND FOLDED BENEATH THE PASSENGER SIDE FENDER. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE CONTACT WAS INFORMED THAT RECALL 05V225000 (SUSPENSION: FRONT: CONTROL ARM: LOWER BALL JOINT) DID NOT INCLUDE HIS VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000.

• 11/26/2013· STRUCTURE

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT THE REAR FRAME WAS DETERIORATED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT THEY WOULD NOT REPAIR THE PROBLEM. THE CONTACT STATED THAT THE DEALER INFORMED HIM THAT THE VEHICLE WAS INCLUDED IN A MANUFACTURER'S RECALL AND SEVERAL NOTICES HAD BEEN SENT HOWEVER, THE CONTACT FAILED TO HAVE THE VEHICLE SERVICED PER THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 220,000.

• 11/24/2015· AIR BAGS

  AIRBAG LIGHT ON, DRIVING.

• 11/23/2020· SUSPENSION

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, SHE HEARD AN ABNORMALLY LOUD CLUNKING SOUND AS THE VEHICLE BEGAN TO VEER INDEPENDENTLY TO THE RIGHT, WITHOUT WARNING. THE CONTACT THEN PULLED THE VEHICLE OVER AND CALLED HER HUSBAND WHO ARRIVED AT THE SCENE AND DETERMINED THAT THE FAILURE WAS CAUSED BY A DEFECTIVE BALL JOINT. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 05V225000 (SUSPENSION) WHICH SHE LINKED TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED HER THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE FAILURE MILEAGE WAS 109,544.

• 11/22/2016· STRUCTURE

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE VEHICLE WAS TAKEN TO A TIRE SHOP AND THE TECHNICIAN NOTICED THAT THE FRAME OF THE VEHICLE HAD A CONSIDERABLE AMOUNT OF RUST. THE DEALER DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED DUE TO THE RUST AND THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 164,000. ...UPDATED 03/13/17 *BF UPDATED 08/11/2017*JS

• 11/22/2016· STRUCTURE

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT NOTICED RUST ON THE VEHICLE'S FRAME NEAR THE SPRING HANGER ON THE PASSENGER SIDE. THE CONTACT TOOK THE VEHICLE THE DEALER, BUT THE VEHICLE WAS NOT COVERED UNDER WARRANTY DUE TO THE COATING ON THE VEHICLE. THE DEALER DIAGNOSED THAT THE FRAME OF THE VEHICLE WAS RUSTED COMPLETELY THROUGH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000. UPDATED 01/25/2017*CT UPDATED 7/10/18*JB *TR

• 11/21/2011· SUSPENSION

  WHILE DRIVING AWAY FROM MY HOUSE AT 5MPH, AT NIGHT IN THE RAIN, APPROXIMATELY 200 FEET FROM MY DRIVEWAY AND JUST AFTER A SPEED BUMP, I HEARD AND FELT A LOUD NOISE, LIKE DRIVING OVER A CONCRETE BLOCK. I STOPPED THE TRUCK AND USING A FLASHLIGHT SAW THAT THE WHEEL WAS BENT AT AN ANGLE AND THE LOWER BALL JOINT WAS COMPLETELY SHEARED OFF. HAD TO CALL A TOW TRUCK TO GET IT OUT OF THE ROAD AND BACK TO OUR DRIVEWAY. *TR

• 11/21/2008· STRUCTURE

  TL*THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO INSPECT THE MAINFRAME UNDERNEATH THE VEHICLE. THE FRAME WAS RUSTED FROM ONE END TO THE OTHER. A TOYOTA REPRESENTATIVE ADVISED HIM TO HAVE THE METAL PLATES WELDED ON THE FRAME, INCLUDING THE SPRING HANGERS. THE SPRING HANGERS WERE UNSAFE BECAUSE THEY WERE ALSO RUSTED. THE CONTACT STATED THAT IF ANYTHING IS WELDED ON RUST, IT WILL NOT WORK. THE TOYOTA REPRESENTATIVE STATED THAT NOTHING ELSE COULD BE DONE TO REPAIR THE FAILURE. THE FAILURE MILEAGE WAS 96,000.

• 11/20/2019· STRUCTURE

  I HAVE A 2002 TACOMA THAT WAS PART OF THE FRAME PERFORATION RECALL. HOWEVER, I DID NOT GET A FRAME REPLACEMENT. THE "FIX" WAS TO APPLY A GEL OVER THE RUST ON THE FRAME, WHICH, SUBSEQUENTLY, ALL FELL OFF THE FRAME ONTO MY DRIVEWAY. RECENTLY, I TOOK MY TRUCK INTO THE DEALERSHIP FOR A 4WD REPAIR AND WAS TOLD THAT MY "FRAME WAS SHOT" AND THE TRUCK WAS "UNSAFE TO DRIVE", DUE TO THAT. AND IF THEY LIFTED MY TRUCK TO DO THE REPAIR, IT MIGHT "CRUSH MY FRAME". I EXPRESSED MY DISPLEASURE FOR THE RECALL FIX AND HAD THEM DO AN ESTIMATE ON THE 4WD REPAIR. THEY CAME BACK WITH AN OUTRAGEOUS NUMBER, AS IF THEY DID NOT WANT TO DO THE WORK. I HAVE SINCE CONTACTED INDEPENDENT REPAIR SHOPS AND NO ONE WILL TOUCH IT. *SO, I HAVE A TRUCK NO ONE WILL REPAIR, I CAN'T SELL IT, I CAN'T TRADE IT IN...AND I CAN'T DRIVE IT. IT HAS NO WORTH.ONE OF MY LEAF SPRINGS HAS RUSTED AND BROKEN, TOO. THE TRUCK HAS 215K AND IS IN GOOD CONDITION OTHER THAN RUST. THE ENGINE WILL GO 500K. I SEE RECALLS ON THE FRAME AND LEAF SPRING FOR OTHER MODEL YEARS, BUT THE 2002 SEEMS TO NOT FALL INTO ANY OF THEM. I DON'T EXPECT A NEW FRAME, BUT ASSISTANCE IN OBTAINING A SIMILAR TRUCK AT A REASONABLE PRICE OR OTHER FAIR SOLUTION MAY BE A CONSIDERATION.

• 11/20/2016· UNKNOWN OR OTHER

  FRAME RUSTED, UNSAFE TO DRIVE. CALLED TOYOTA AND WAS TOLD RECALL HAD EXPIRED, NEVER RECEIVED ANY RECALL INFORMATION. TRUCK WAS PURCHASED SECOND HAND FROM TOYOTA DEALER.

• 11/20/2015· SUSPENSION,STRUCTURE

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES) HOWEVER, THE CONTACT WAS INFORMED BY THE SERVICE TECHNICIAN THAT THERE WAS EXCESSIVE CORROSION TO THE SUBFRAME OF THE VEHICLE. THE CONTACT STATED THAT THE CORROSION TRAVELED FROM THE FRONT DRIVER SIDE SUSPENSION TO THE REAR DRIVER SIDE SUSPENSION. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE AND COULD NOT BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 169,175.

• 11/20/2010· STRUCTURE,LATCHES/LOCKS/LINKAGES

  2002 TOYOTA SIENNA MINIVAN. WHEN I TRY TO OPEN THE DRIVER SIDE SLIDING DOOR, I CAN HEAR IT UNLATCH BUT REMAINS SHUT. YOU HAVE TO PUSH THE REAR PART OF THE DOOR BACK IN UNTIL YOU HEAR A CLICK, THEN YOU HAVE TO VIOLENTLY PULL THE HANDLE AND THE DOOR WILL OPEN. *TR

• 11/18/2009· STRUCTURE

  I TOOK MY TACOMA FOR ITS 95000 MILE SERVICE, AND THEY DISCOVER MY SUB-FRAME WAS RUSTED OUT AND IT WAS UNSAFE TO DRIVE. MY TRUCK HAS GONE FOR SERVICE EVERY 5000 MILES FOR 7 YEARS AND NO ONE EVER NOTICED THE RUST. MY COMPLAINT IS THAT TOYOTA DOES NOT COVER THE SUBFRAME IN THEIR FRAME RUST PROBLEM. THE DEALER TRIED FOR 2 DAYS TO GET THEM TO INCLUDE THIS IN THEIR 2001-2004 RUST FRAME REPAIR OR BUY BACK PROGRAM. THEY REFUSE. WHY ISN'T THE SUB FRAME PART OF THE WHOLE FRAME. I BELIEVE THE SUB FRAMES SHOULD BE LOOKED AT. *TR

• 11/16/2016· EXTERIOR LIGHTING,STRUCTURE

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT NOTICED THAT THE FRAME UNDERNEATH THE VEHICLE WAS SEVERELY CORRODED. IN ADDITION, THE HEADLIGHTS FAILED TO ILLUMINATE AND THE BULBS HAD TO CONSTANTLY BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 05V225000 (SUSPENSION) AND 06E026000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 149,000.

• 11/16/2007· SERVICE BRAKES, HYDRAULIC,EXTERIOR LIGHTING

  I HAVE A 2002 TOYOTA SEQUOIA WITH 62,000 MI. I HAVE BEEN TO TWO TOYOTA DEALERS TO FIGURE OUT MY PROBLEM. THE VSC TRAC, VSC OFF, ABS AND BRAKE LIGHTS ARE COMING ON. FINALLY AFTER @$700 OF MY MONEY, THEY FIGURED OUT THE PROBLEM TO BE THE ECU. THIS WILL NOW COST ME @1800 FOR PARTS, AND WHO KNOWS YET FOR LABOR. I HAVE READ ONLINE THAT MANY OTHER TOYOTA OWNERS HAVE THE SAME PROBLEM. THIS IS AN EXPENSIVE SITUATION, UNLESS YOU HAVE THE EXT. WARRANTY. I FEEL THAT TOYOTA NEEDS TO DO SOMETHING ABOUT THIS, MAYBE RECALL THIS AND FIX THESE CARS BEFORE THERE IS AN ACCIDENT. I LIVE IN NEW YORK WHERE THERE IS ALOT OF SNOW. MY VSC WILL NOT WORK UNTIL I GET THIS FIXED. I HAVE TWO SMALL CHILDREN AND HAVE TO RELAY ON STANDARD BRAKES IN THE SNOW UNTIL THIS IS FIXED. TOYOTA SHOULD STAND BEHIND THEIR REPUTABLE NAME AND FIX THESE PROBLEMS ASAP..... *TR

• 11/15/2013· STRUCTURE

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR STATE INSPECTION WHEN HE WAS ADVISED THAT THE FRONT AREA OF THE FRAME WAS SEVERELY CORRODED. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE FRAME WAS NOT SAFELY COATED THEREFORE, THEY DENIED ASSISTANCE WITH ANY REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 161,250.

• 11/15/2004· SUSPENSIONCrash

  NO KNOWN EVENTS LEADING TO THE FAILURE. PROGRESSIVE, SUCCESSIVE FAILURE OF BOLTS HOLDING LEFT FRONT WHEEL ASSEMBLY AND SUSPENSION ARM TO THE TRUCK. THIS CAUSED SEPARATION OF MENTIONED MEMBER FROM THE VEHICLE RESULTING IN TOTAL LOSS OF CONTROL AND OVERTURNING OF SAID VEHICLE. THE VEHICLE WAS A TOTAL LOSS AS A RESULT OF THE INCIDENT.*AK

• 11/14/2018· STRUCTURE

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT TOOK THE VEHICLE TO TOYOTA OF PORTLAND (55 NE BROADWAY ST, PORTLAND, OR 97232, (503) 284-1105) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES). THE CONTACT WAS INFORMED THAT THE RECALL REPAIR COULD NOT BE PERFORMED DUE TO EXCESSIVE RUST ON THE VEHICLE'S FRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 212,000.

• 11/13/2020· WHEELS

  WAS DRIVING DOWN 85 S C FROM GREENVILLE- ANDERSON IN PASSING LANE .HEARD SLIGHT NOISE LIKE IN LEFT REAR TIRE AT FIRST.SOUND INCREASED FAST TO EXTREME THUMPING.HAD TO PULL OVER IMMEDIATELY INTO BREAKDOWN LANE.LOOKED AT TIRE-----OUTSIDE WALL WAS COMPLETELY RIPPED OPEN SHOWING TOTAL RIM.IF THIS HAD BEEN EITHER FRONT TIRE I WOULD DEAD NOW.TIRE WAS BOUGHT ABOUT 2 1/2 YRS AGO,TWAS OVER 50%,MILAGE WAS UNDER 20,000 MILES

• 11/10/2015· STRUCTURE

  TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. AN INDEPENDENT MECHANIC STATED THAT THE FRAME NEEDED TO BE REPLACED ON THE VEHICLE DUE TO HOLES AND CORROSION ON EACH SIDE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 230,000. THE VIN WAS NOT AVAILIABLE.

• 11/09/2016· STRUCTURE

  CPSC: 2002 TOYOTA TACOMA: CONSUMER STATED THE VEHICLE HAS A RUSTED BODY FRAME, AND IT IS UNSAFE TO DRIVE. *SS

• 11/07/2005· SUSPENSION

  CONSUMER COMPLAINT REGARDING SAFETY ISSUE WITH BALL JOINTS. *TS *** NO ANSWER REQUIRED*** UPDATED 11/7/2005 - THE CONSUMER HAD PROBLEMS WITH THE TOYOTA DEALER THEREFORE DECIDED TO TAKE HIS VEHICLE TO A NON-TOYOTA DEALER TO HAVE RECALL ON THE LOWER BALL JOINT REPAIRED (RECALL NUMBER 05V225000). THE CONSUMER REQUEST REIMBURSEMENT FORM THE MANUFACTURER SINCE HE HAD TO PAY FOR THE REPLACEMENT. *NM