2002 Toyota RAV4 EV

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2013· POWER TRAIN,ELECTRICAL SYSTEM

  WE BOUGHT THIS CAR OFF MY MOM (WHO WAS THE ORIGINAL OWNER AND HAS TAKEN IMMACULATE CARE OF IT!) JUST TWO MONTHS AGO! OUT OF NOWHERE THE CAR STARTED TO EXPERIENCE "HARD SHIFTING". BECAUSE IT COULDN'T SHIFT LIKE IT SHOULD, IT WAS A ROAD HAZARD/SAFETY ISSUE! WE TOOK IT INTO THE TOYOTA DEALERSHIP THAT VERY DAY. THEY TOLD US IT WAS THE ECM AND MAYBE EVEN THE TRANSMISSION! THE APPROX. COST WOULD BE $1,100 TO REPLACE THE ECM, AND THOUSANDS MORE IF IT WAS THE TRANSMISSION. THEY SAID THEY WOULD HAVE IT DONE BY TUESDAY (CHRISTMAS EVE.) I STARTED RESEARCHING THE PROBLEM BECAUSE IT DIDN'T MAKE SENSE THAT THIS CAR THAT HAD SUCH LOW MILES WOULD HAVE THIS PROBLEM. WELL, I FOUND OUT THIS IS A WIDESPREAD PROBLEM WITH THE RAV4. TOYOTA KNOWS ABOUT IT AND HAS NOT RECALLED THIS PART! THERE WAS EVEN A LAWSUIT AGAINST THEM, BUT THAT ONLY LED TO AN EXTENSION OF THE WARRANTY TO 10 YEARS OR 150,000 MILES, WHICHEVER COMES FIRST! OUR CAR ONLY HAS 88,900 MILES BUT BECAUSE IT IS 11 YEARS OLD, IT WON'T BE COVERED BY A WARRANTY! WE ARE OUT $1,180 RIGHT AT CHRISTMAS TIME! AND THEY DID NOT GET THE CAR FIXED UNTIL DEC. 27TH! (KIND OF PUTS A DAMPER ON CHRISTMAS PLANS WHEN YOU DON'T HAVE YOUR CAR!):( I CALLED TOYOTA IN HOPES THAT THEY WOULD HELP US BECAUSE THEY KNOW THIS PART IS FAULTY, BUT I WAS MET WITH AN UNSYMPATHETIC RESPONSE! BASICALLY, "ITS OUT OF WARRANTY SO IT WON'T BE COVERED!" TOYOTA NEEDS TO RECALL THIS PART, AND REIMBURSE THOSE WHO HAVE ALREADY HAD TO FIX IT, NOT ONLY BECAUSE IT IS THEIR MORAL OBLIGATION TO DO SO, BUT ALSO BECAUSE SOMEONE COULD BE KILLED IF THEY DON'T! PLEASE RECALL THIS PART, BE DECENT HUMAN BEINGS, INSTEAD OF BEING WORRIED ABOUT YOUR BOTTOM LINE! THERE ARE MORE IMPORTANT THINGS THAN MONEY, TOYOTA! AS MAD AS I AM ABOUT BEING OUT THE MONEY TO FIX THIS PROBLEM (THAT TOYOTA KNEW ABOUT) I AM GLAD THAT I AM ONLY OUT THE MONEY, RATHER THAN MOURNING THE LOSS OF A LOVED ONE. *TR

• 12/30/2010· ENGINE AND ENGINE COOLING

  I HAVE TAKEN MY 2002 RAV4 TO TOYOTA ON A FEW OCCASIONS. EVERY TIME IT HAS BEEN AN OXYGEN SENSOR OR FUEL SENSOR. WE HAD THESE REPLACED AND NOW TOYOTA IS TELLING US WE NEED TO REPLACE THE ENTIRE CATALYTIC CONVERTER ($1000). THE TRANSMISSION, ACCORDING TO THEM, IS NOT FULLY FUNCTIONAL. *TR

• 12/30/2009· POWER TRAIN

  TRANSMISSION HAS FAILED ON MY 2002 RAV4. 2 MECHANICS AND 1 TRANSMISSION SPECIALIST STATE THAT IT NEEDS TO BE COMPLETELY OVERHAULED AND ECM IS BAD ALSO. CAR WILL NOT SHIFT OUT OF 2ND GEAR AND HESITATES. *TR

• 12/28/2009· POWER TRAIN

  ON THE EVENING OF DECEMBER 21, 2009, I WAS DRIVING OUR 2002 TOYOTA RAV4, EXITING A MAJOR SHOPPING CENTER, IN A LONG LINE OF VEHICLES AT A SLOW SPEED. SUDDENLY THE ENGINE STALLED (SOMETHING THAT NEVER HAPPENED BEFORE). I RESTARTED THE ENGINE AND MOVED A FEW CAR LENGTHS, STILL IN A LONG LINE OF SLOW MOVING VEHICLES AND THE ENGINE STALLED AGAIN. I RESTARTED THE ENGINE AND WAS ABLE TO PROCEED HOME (ABOUT 10 MILES) WITHOUT FURTHER DIFFICULTY. THE NEXT DAY, DECEMBER 22, 2009, MY WIFE USED THE VEHICLE TO DO SOME SHOPPING. DURING HER TRIP SHE MADE 4 UNEVENTFUL STOPS AND RESTARTS. AT HER 5TH STOP, AT A TRAFFIC LIGHT AT AN INTERSECTION (ON A VERY BUSY HIGHWAY) SHE STOPPED FOR A RED LIGHT. SHE THEN PROCEEDED FROM THE RED LIGHT - BUT THE ENGINE STALLED AGAIN. MY WIFE WAS ABLE TO RESTART THE ENGINE, BUT AS SOON AS THE GEAR SHIFT WAS PUT INTO DRIVE, THE ENGINE STALLED AGAIN. REPEATED ATTEMPTS TO RESTART THE ENGINE AND MOVE THE CAR WERE UNSUCCESSFUL. MY WIFE WAS STUCK IN THE MIDDLE OF AN INTERSECTION WITH TRUCKS AND CARS PASSING AROUND HER WITH HORNS BLOWING. A PASSING MOTORIST ULTIMATELY CAME TO HER ASSISTANCE AND PUSHED THE VEHICLE OUT OF THE INTERSECTION TO THE SHOULDER OF THE HIGHWAY OUT OF POTENTIAL DANGER. WHEN I ARRIVED AT THE LOCATION, I ALSO COULD NOT DRIVE THE VEHICLE. THE ENGINE WOULD START, BUT ENGAGING ANY DRIVE POSITION (D, 2, 1, R) WOULD CAUSE THE ENGINE TO SHUT DOWN. THE VEHICLE(WITH 88,000 MILES) WAS TOWED TO MY REPAIR SHOP. THE SHOP DIAGNOSED AN ECM/TRANSMISSION PROBLEM - AND THEN TRANSFERRED THE VEHICLE TO A TRANSMISSION SHOP FOR FURTHER DIAGNOSIS AND REPAIR ON DECEMBER 23, 2009. *TR

• 12/27/2009· ENGINE AND ENGINE COOLING,ELECTRONIC STABILITY CONTROL (ESC)

  I HAVE A 2002 TOYOTA RAV 4 WITH 82K MILES ON IT. AT THE BEGINNING OF NOVEMBER, 2009, I WAS DRIVING MY VEHICLE AND IT BEGAN TO JERK VIOLENTLY WHEN I ACCELERATED BETWEEN 1ST AND 2ND GEARS. I HAD DIFFICULTY MAINTAINING CONTROL AND AVOIDED AN ACCIDENT. SUBSEQUENTLY, I TOOK THE CAR TO THE DEALER AND LEARNED THAT I HAD A COMMON PROBLEM FOR 2002 RAV 4'S -- A FAULTY ENGINE CONTROL MODULE. I RESEARCHED THE PROBLEM AND LEARNED THAT MANY PEOPLE HAVE ALSO HAD THIS PROBLEM IN 2001 AND 2002 RAV 4'S. TOYOTA IS NOT TAKING RESPONSIBILITY FOR THIS PROBLEM. THIS SHOULD BE A RECALL ITEM. *TR

• 12/27/2009· POWER TRAIN

  DETECTED TRANSMISSION PROBLEMS WITH A 2002 RAV 4. WAS TOLD BY MECHANIC THAT THE VEHICLE NEEDS A NEW TRANSMISSION. I UNDERSTAND THAT THERE IS A PROBLEM WITH THE ECM SYSTEM BUT TOYOTA SO FAR REFUSES TO ADDRESS THE PROBLEM. *TR

• 12/27/2007· POWER TRAIN

  AUTOMATIC TRANSMISSION DAMAGED BECAUSE THE ECM TOYOTA INSTALLED IN 2002 RAV 4 HAD PROGRAMMING LOGIC ISSUES. *TR

• 12/26/2010· POWER TRAIN

  EITHER THE ECU OR THE TRANSMISSION IS NOT WORKING RIGHT. THE AUTOMATIC TRANSMISSION CAN USUALLY CHANGE BETWEEN 1ST AND 2ND GEAR BUT IT USUALLY CANNOT CHANGE BETWEEN 2ND AND 3RD. THE ENGINE USUALLY REVS AS THE TRANSMISSION SLIPS. IF WE EASE UP ON THE ACCELERATOR OR SOMETIMES WE TO PUMP IT A LITTLE, THEN THE TRANSMISSION CHANGES GEARS. THERE HAVE BEEN A FEW OCCASIONS WHERE THE ENGINE REVS AND THE TRANSMISSION CATCHES ON ITS OWN BUT THIS IS CAUSES THE CAR TO ACCELERATE WHEN WE DO NOT EXPECT IT TO. THIS JUST STARTED HAPPENING RECENTLY. WE HAD NOTICED FOR THE PAST FEW MONTHS THAT THE TRANSMISSION WOULD CHANGE A LITTLE HARDER THAN NORMAL, BUT NOT THE CAR IS NOT DRIVABLE DUE TO SAFETY REASON. *TR

• 12/26/2003· TIRES

  PURCHASED TOYOTA MR2 SPYDER IN AUGUST OF 2002. CAR NOW HAS 18,300 MILES AND BOTH FRONT TIRES (YOKOHAMA ADVAN A043 185/50R15) ARE WORN BEYOND RECOMMENDED TREAD DEPTH AND BLISTERED ON INSIDE(BECAUSE OF FRONT-END MISALIGNMENT ACCORDING TO DEALERSHIP). *AK

• 12/23/2015· AIR BAGS,SEAT BELTSCrashFire

  TAKATA RECALL: I WAS INVOLVED IN A HEAD-0N COLLISION AND MY AIR BAGS DID NOT DEFLATE LIKE THEY WERE SUPPOSED TO. THE OTHER VEHICLE THAT HIT ME, THEIR AIRBAGS DEFLATED. I WAS GOING APPROXIMATELY 45 MPH AND THE IMPACT PUSHED EVERYTHING BACK FROM THE FRONT END OF MY VEHICLE, WHICH BLOCKED THE DOORS SO THAT WE COULD NOT GET OUT OF THE VEHICLE. THE ACCIDENT WAS THE OTHER PARTIES FAULT AND SHE WAS CITED FOR THE ACCIDENT. I RECEIVED SEVERAL INJURIES WHICH RESULTED WITH ME BEING IN THE HOSPITAL FOR SEVERAL DAYS. THE POLICE OFFICERS, THE AMBULANCE PEOPLE AND THE FIRE DEPARTMENT PEOPLE ALL WONDERED WHY MY AIRBAGS DID NOT DEPLOY WHEN THE ACCIDENT HAPPENED. ALL OF THE PROFESSIONAL PEOPLE ON THE ACCIDENT SCENE SAID THAT MY AIRBAGS WERE PROBABLY MADE BY TAKATA AND WERE DEFECTIVE. AS THE RESULT OF MY AIRBAGS NOT DEPLOYING CAUSED ME TO HAVE EXTENSIVE INJURIES AND I AM HAVING TO HAVE PHYSICAL THERAPY ON MY LEFT ARM AND HAND. I WOULD LIKE FOR THE NHTSA TO PERFORM A CHECK ON THE TOYOTA RAV4 2002 SUV'S TO SEE IF THEY ALSO SHOULD HAVE BEEN INCLUDED IN THE RECALL. AS THE RESULT OF THE ACCIDENT, MY SUV WAS TOTALED AND IT ONLY HAD 33,000 MILES ON IT.

• 12/23/2013· POWER TRAIN

  WHEN I WAS DRIVING ABOUT 40MPH THE CAR WOULD LURCH, NOT ALL THE TIME, BUT EVERY SO OFTEN. WHEN I WAS BACKING UP THE CAR WOULD MAKE A CLUNKING NOISE. I TOOK MY CAR TO HAVE THE TRANSMISSION REPAIRED WITH MY MECHANIC, IT WAS REPAIRED BUT THE LOCAL BUT HE SAID THAT IF THE COMPUTER PART OF THE TRANSMISSION ISN'T DEALT WITH, IT WOULD HAPPEN AGAIN. I WENT TO THE TOYOTA DEALERSHIP WITH THE RECALL PAPERWORK THAT MY MECHANIC PRINTED OUT FOR ME AND THEY SAID THAT 10 YEARS HAVE PASSED AND THEY WOULDN'T HONOR THE RECALL. *TR

• 12/23/2009· POWER TRAIN

  ONE DAY, OUT OF THE BLUE, MY 2002 TOYOTA RAV4 STARTED HAVING TROUBLE GETTING FULL POWER IN 1ST GEAR, AND OFTEN SLIPPED WHEN GOING FROM 1ST TO 2ND, AND 2ND TO 3RD. SINCE THIS WAS SO SUDDEN, I OFTEN HAD TROUBLE GETTING UP TO SPEED WHEN PULLING INTO TRAFFIC. THERE WERE NO ACCIDENTS, BUT A FEW CLOSE CALLS. I HAD THE ECM (ENGINE CONTROL MODULE) REPLACED THE NEXT DAY BECAUSE MY MECHANIC SAID THAT THIS WAS A FAIRLY COMMON FAILURE FOR THE RAV4, AND TOYOTA HAD PUT OUT A TSB FOR THIS PROBLEM. UNFORTUNATELY, I WAS WELL PAST THE MILEAGE NEEDED TO GET THIS DONE UNDER WARRANTY. *TR

• 12/22/2017· POWER TRAIN

  I NEVER RECEIVED A NOTICE OR LETTER FROM TOYOTA ABOUT EXTENDING THE WARRANTY TO THE TRANSMISSION FOR THE RAV4 SENT TO OWNERS. I EVEN WENT TO THE TOYOTA DEALER IN RAPID CITY FOR CAR MAINTENANCE AND THEY NEVER TOLD ME ABOUT THIS ISSUE. I DONATED THE CAR TO MY DAUGHTER WHO LIVES IN SEATTLE AND SHE IS HAVING PROBLEM WITH THE CAR TRANSMISSION. THE TOYOTA DEALER IN SEATTLE WANTS TO CHARGE $4500 FOR FIXING IT. WHAT DO I OR MY DAUGHTER DO? I WAS NEVER INFORMED ABOUT THIS EXTENDED WARRANTY. PLEASE LET ME KNOW. THANK YOU

• 12/21/2009· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2002 TOYOTA RAV4. WHILE SHIFTING THE VEHICLE IN DRIVE THE VEHICLE WOULD NOT ACCELERATE PAST 4 MPH. THEN WITHOUT WARNING THE VEHICLE BEGAN TO RAPIDLY ACCELERATE. EVENTUALLY HE WAS ABLE TO GAIN CONTROL OF THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO THE TOYOTA DEALER AND THE TECHNICIAN STATED THAT THE COMPUTER WAS OVERRIDING THE TRANSMISSION. A NEW COMPUTER WAS INSTALLED IN THE VEHICLE. ALL THE REPAIRS HAVE BEEN DONE UNDER THE OWNERS EXPENSE. THE FAILURE HAS BEEN REPORTED TO THE OFFICE OF CONSUMERS AFFAIRS AND TO TOYOTA. THE FAILURE MILEAGE WAS 111000. THE CURRENT MILEAGE WAS 111400. UPDATED 02/18/10. *LJ UPDATED 03/04/10. *LJ

• 12/21/2004· SERVICE BRAKES, HYDRAULIC

  2002 TOYOTA SEQUOIA BRAKES VIBRATE SEVERELY. VSC SYSTEM WARNING LIGHT FREQUENTLY COMES ON. PROBLEM HAS EXISTED SINCE CAR HAD 10,000 MILES, NOW HAS 36,000 AND DEALER AND TOYOTA CLAIM IT IS OUT OF WARRANTY. TOYOTA CLAIMS THAT CAR HAS NO BRAKE PROBLEMS, NO SAFETY PROBLEMS AT ALL, AND THAT ORIGINAL BRAKES ARE NOT DEFECTIVE IN DESIGN. I AM INFORMED THAT TOYOTA ISSUED A TECHNICAL SERVICE BULLETIN, ALTHOUGH TOYOTA DENIED THIS THE DEALER ADMITTED THAT IT EXISTED, BUT I HAD TO SPECIFICALLY COMPLAIN ABOUT THE SPECIFIC BRAKE PROBLEM, OR THEY WOULD NOT AND DID NOT ADVISE ME OF THE REMEDY. THESE BRAKE ISSUES ARE A SERIOUS SAFETY PROBLEM.*AK

• 12/20/2010· POWER TRAIN

  2002 TOYOTA RAV4. THE TRANSMISSION SLIPS FROM 1ST TO 2ND GEAR UNCONTROLLABLY AND CAUSES A SUDDEN SURGE IN THE VEHICLE THAT MAKES DRIVING IT NOT ONLY DANGEROUS BUT A LIABILITY TO ME. TOYOTA SHOULD BE CONCERNED WITH THIS, CONSIDERING THEIR RECENT PROBLEMS WITH SUDDEN ACCELERATION AND BRAKING. THE CAR WAS BOUGHT THROUGH A TOYOTA DEALERSHIP, WHICH MAKES IT ALL THE WORSE BECAUSE OF THE FACT THAT THEY KNOWINGLY PASSED THIS CAR THROUGH THEIR INSPECTION PROCESS AND DID NOT DO A [XXX] THING. TELL TOYOTA TO FIX THIS PROBLEM FOR THE SAFETY OF MILLIONS OF PEOPLE ON THE ROAD. *TR INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/20/2008· LATCHES/LOCKS/LINKAGES

  DRIVER SIDE FRONT DOOR POWER LOCK FAILS TO LOCK OR UNLOCK WITH AUTO LOCK BUTTON. HAS TO BE LOCKED OR UNLOCKED BY HAND. PASSENGER SIDE FRONT DOOR LOCK ALSO STARTING TO FAIL. *TR

• 12/20/2002· TIRES,EQUIPMENT

  DEFECTIVE TIRES, VEHICLE JACK EQUIPMENT. WHILE DRIVING ONE OF THE VEHICLE'S TIRE EXPLODED WHEN IT RAN OVER AN ORANGE IN THE ROAD. THE CONSUMER REQUEST REIMBURSEMENT FOR THE REPLACEMENT TIRE AND WOULD LIKE THE REMAINING 4 TIRES REPLACED. THE CONSUMER RETAINED THE TIRE FOR INSPECTION. WHILE ATTEMPTING TO CHANGE THE BLOWN TIRE THE CONSUMER REALIZED THAT THE JACK WAS NOT DESIGNED PROPERLY TO REPLACE THE BLOWN TIRE. WITH THE JACK PROPERLY PLACED AND FULLY EXTENDED THERE WAS INSUFFICIENT CLEARANCE TO REPLACE THE BLOWN TIRE. THE CONSUMER REQUEST THAT THE JACK BE REPLACED. *NM

• 12/19/2008· POWER TRAIN

  HARSH SHIFTING/SLIPPING IN AUTOMATIC TRANSAXLE. NO SPECIAL EVENTS LEADING UP TO FAILURE; JUST STARTED IN ABOUT 123,000 MILES. PROBLEM NOW OCCURS EVERY TIME I DRIVE THE VEHICLE. ONLY AN OBD II SCAN HAS BEEN PERFORMED ON THE VEHICLE. *TR

• 12/18/2009· POWER TRAIN,ELECTRICAL SYSTEM

  NO PROBLEMS WERE APPARENT UNTIL OVERNIGHT THE TRANSMISSION APPEARED TO BE SLIPPING. INDEPENDENT MECHANIC CITED FAILING TRANSMISSION AS PROBABLE ISSUE. TOYOTA DEALERSHIP STATED THE ECM/ECU WAS FAILING. TURNS OUT ECM WAS DEFECTIVE IN THE MODEL YEAR OF THIS VEHICLE. TOYOTA' RESPONSE WAS TO "REPROGRAM/REFLASH" DEFECTIVE ECM. THIS ONLY POSTPONEDTHE FAILURE OF THE ECM. THE DEFECTIVE ECM WOULD SEND INCORRECT CODES TO THE TRANSMISSION STUTTERING OR HALTING SHIFTS THUS LEAVING THE VEHICLE EFFECTIVELY IN NEUTRAL. THIS STUTTERING/SLIPPING QUICKLY DESTROYS THE TRANSMISSION. THE FAILURE OF THE ECM WOULD NOT ALLOW THE TRANSMISSION TO SHIFT WHICH PUT US IN DANGER OF BEING IN A REAR END COLLISION WHILE TRYING TO GET ONTO BUSY HIGHWAYS OR STALLING IN AN INTERSECTION. THIS OCCURRED MULTIPLE TIMES IN THE TRIP TO THE DEALERSHIP ALONE (THE VEHICLE WENT IN THE NEXT OPEN BUSINESS DAY AFTER THE FIRST OCCURRENCE). THE FAILURE OCCURRED IN THE FIRST THREE GEARS. THIS IS A VERY SERIOUS SAFETY ISSUE WHICH WAS GIVEN AN INEFFECTIVE SOLUTION. THE DEALERSHIP REPLACED THE ECM AT A SIGNIFICANT COST TO THE CONSUMER. WHEN ASKED ABOUT THE DEFECTIVE ECM, THE SERVICE DEPARTMENT STATED THE REPLACEMENT OF THE ECM, ALTHOUGH AGREED TO BE DEFECTIVE, WAS THE RESPONSIBILITY OF THE CONSUMER AND NOT TOYOTA. *TR

• 12/17/2008· POWER TRAIN

  STARTED CAR 2 WEEKS AGO (DECEMBER 8TH) DROVE FOR 10 MINUTES AT SLOW SPEED UNDER 30 MPH. CAR STARTED BUCKING AND HAVING TROUBLE SHIFTING. WAS ALMOST RARE ENDED DUE TO LACK OF ACCELERATION. RPM WOULD INCREASE BUT CAR WOULD STRUGGLE SHIFTING AND ACCELERATING. BROUGHT TO TRANSMISSION SPECIALIST. THEY THOROUGHLY CHECKED TRANSMISSION AND COULDN'T FIND A PROBLEM. DRAINED FLUID AND REPLACED FILTER. COST $170. THREE DAYS LATER STARTED BUCKING AGAIN. TROUBLE SHIFTING. BROUGHT TO DIFFERENT MECHANIC WHO STATES NEEDS NEW TRANSMISSION. REQUESTING REBUILT FROM TOYOTA. COST OVER $2000, CAR ONLY HAS 94,000 MILES ON ENGINE. TOYOTA SAYS THAT IF IT IS OVER 60,000 MILES IT IS NOT UNDER WARRANTY. *TR

• 12/16/2008· POWER TRAIN

  DRIVING DOWN THE HIGHWAY GOING 65 MILES PER HOUR AND THE ENGINE JUST STOPPED, COMPLETELY SHUT DOWN. 2002 TOYOTA RAV 4. *TR

• 12/15/2007· ENGINE AND ENGINE COOLING

  MY 2002 RAV4 HAS BEEN DIAGNOSED AS HAVING ENGINE OIL SLUDGE AND NEEDS TOTAL REPLACEMENT. OIL CHANGES HAVE BEEN PERFORMED BETWEEN 3,000 - 4,000 MILES. *TR

• 12/14/2015· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2002 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE ACCELERATED INDEPENDENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

• 12/14/2004· LATCHES/LOCKS/LINKAGES

  PLASTIC DOOR HANDLES ON TOYOTA SEQUOIAS EASILY BREAK OFF, VERY FLIMSY. THIS COULD LEAD TO SOMEONE GETTING TRAPPED IN THEIR CAR, ESPECIALLY IF YOU ARE INVOLVED IN AN ACCIDENT AND NEED TO OPEN THE DOOR QUICKLY OR AGGRESSIVELY. MY NEIGHBOR HAPPENS TO HAVE THE SAME VEHICLE EVEN THE SAME COLOR AND I ASKED HIM HOW HE LIKES IT AND HE SAID FANTASTIC, EXCEPT WE HAVE BROKEN OFF 2 DOOR HANDLES. WHEN I TOOK IT TO THE DEALER THE SERVICE WRITER CASUALLY MENTIONED, "OH, WE GET THESE IN ALL THE TIME". I CONTACTED THE DEALER AND THE TOYOTA ZONE OFFICE AND THEY WILL NOT PAY FOR THE $175 REPAIR. THIS IS A SERIOUS SAFTEY HAZARD AND A DEFECTIVE PRODUCT.*AK

• 12/13/2005· STRUCTURE

  THE BOLTS IN THE ROOF RACK FALL OUT. WE HAVE NEVER USED THE ROOF RACK. OVER THE PAST 3 YEARS, WE HAVE LOST 4 BOLTS. FORTUNATELY, THE LOSS OF THE BOLT CAUSES RATTLING. OTHERWISE, OVER TIME, IT COULD HAVE FALLEN OFF! *NM

• 12/11/2009· POWER TRAIN

  TRANSMISSION FAILURE. *TR

• 12/09/2016· AIR BAGSCrashFire

  TAKATA RECALL: ME AND MY WIFE WERE INVOLVED IN A CAR ACCIDENT IN JUNE, 2015. A LADY TALKING ON HER CELL PHONE LOST CONTROL OF HER SUV AND HIT MY TOYOTA RAV4 SUV HEAD-ON. NONE OF THE AIRBAGS IN MY VEHICLE DEPLOYED. AS A RESULT, I SUSTAINED SEVERAL INJURIES TO MY HEAD, NECK, RIGHT KNEE AND LEFT ARM AND HAND. THE IMPACT WAS SO HARD THAT THE FRONT OF MY VEHICLE WAS PUSHED BACKWARD WHICH BLOCKED THE TWO FRONT DOORS FROM OPENING. MY VEHICLE WAS ON FIRE AND SOMEONE CALLED THE POLICE, THE FIRED DEPARTMENT, AND AN AMBULANCE. THE FIRE DEPARTMENT PUT THE FIRE OUT IN MY VEHICLE AND HAD TO PRY THE TWO FRONT DOORS OPEN TO GET ME AND MY WIFE OUT OF MY VEHICLE. EVERYONE THAT CAME TO MY RESCUE, THE FIRE DEPARTMENT, THE POLICE, AND THE AMBULANCE PERSONNEL ALL ASKED THE SAME QUESTION, WHY DID YOUR AIRBAGS WORK. I TOLD THEM THAT I DID NOT KNOW. EVERY ONE OF THE RESCUE PEOPLE SAID THAT I PROBABLY HAD TAKATA AIRBAGS WHICH HAD FAILED TO DEPLOY BECAUSE DUE TO THE TEMPERATURE CHANGES IN WEST VIRGINIA ARE EITHER VERY HOT OR VERY COLD. IF THE AIRBAGS WOULD HAVE WORKED IN MY TOYOTA RAV4 SUV. THEN MY WIFE AND I WOULD NOT HAVE BEEN INJURED. AS THE RESULT OF THE WRECK, MY TOYOTA RAV4 SUB WAS TOTALED. THE AIRBAGS IN THE OTHER SUV THAT HIT US HEAD ON DEPLOYED LIKE THEY WERE SUPPOSED TO AND PROTECTED THE LADY DRIVING HER SUV. I WOULD LIKE FOR YOUR AGENCY TO FIND OUT WHY MY TAKATA AIRBAGS DID NOT DEPLOY. I AM VERY CERTAIN THAT THERE A LOT OF OTHER TOYOTA RAV4 SUVS ON THE ROAD THAT HAVE DEFECTIVE TAKATA AIRBAGS. I WAS DRIVING ON A CITY STREET, GOING THE SPEED LIMIT OF 40 MPH AND THE LADY WHO HIT US HEAD ON WAS DRIVING MUCH FASTER. THE IMPACT WAS LIKE HITTING A STONE WALL. PLEASE ADVISE. THANK YOU. *TR

• 12/09/2011· POWER TRAIN

  VERY UNSAFE TRANSMISSION TOYOTA 2002 RAV 4 SHAKES DOESN'T GO INTO GEAR.CALLED TOYOTA WILL PAY ONLY IF ONE OF THREE CODES COME UP ON DEALER ONLY TEST CHARGED 140 RIP OFF. DEALER SAYS TRANSMISSION BAD BUT NO CODE. TOYOTA WILL NOT COVER . DEALER AND TOYOTA ACT LIKE THEY NEVER HEARD OF THIS UNTIL YOU LET THEM KNOW YOU READ ABOUT IT. PROBLEM SHIFTING OUT OF THE BLUE. *TR

• 12/09/2009· POWER TRAIN

  CHECK ENGINE LIGHT CAME ALL OF SUDDEN WHILE DRIVING VEHICLE REGULAR TO WORK, WHEN CHECKED, THE TRANSMISSION SENSOR BAD ERROR CAME UP, THEN DROVE VEHICLE BACK HOME.WHILE DRIVING BACK GEAR STARTED SLIPPING, COULD NOT ABLE TO PICK UP SPEED. LATER CHECK ENGINE LIGHT GONE AND VEHICLE STARTED WORKING FINE. NEXT DAY CHECK ENGINE LIGHT WAS AGAIN ON. WHEN TOOK THE VEHICLE TO MECHANIC, TRANSMISSION BAD DIAGNOSTIC CAME. COSTING MORE THAN 3500. IT WAS HAZARDOUS DRIVE WHILE COMING BACK HOME AT A SUCH LOW MILES. *TR

• 12/08/2009· POWER TRAIN

  I HAVE A 2002 TOYOTA RAV4 WITH 110,000 MILES ON IT. THE TRANSMISSION HAS JUST FAILED. WHAT A DANGEROUS SITUATION, DOESN'T WANT TO GO, SO YOU TAKE OFF FROM A STOP SIGN & YOU'RE IN THE MIDDLE OF TRAFFIC & THERE YOU SIT TRYING TO GET THE CAR TO MOVE. TO CORRECT THE PROBLEM THE TRANSMISSION NEEDS TO BE REPLACED & I DON'T HAVE $5000 TO REPAIR THIS. IT IS MY UNDERSTANDING THAT TOYOTA WAS AWARE OF THIS PROBLEM AND HAS DONE NOTHING ABOUT IT. NICE *TR

• 12/08/2008· POWER TRAIN,ELECTRICAL SYSTEM

  I BROUGHT MY RAV BRAND NEW IN 200. HAVE HAD NO PROBLEM WITH IT UP UNTIL A FEW DAYS AGO. IT WAS RUNNING JUST FINE BUT THE NEXT DAY I NOTICED THAT IT WOULD JERK WHEN I SHIFTED IN/OUT OF REVERSE. NOT ONLY THAT BUT IT HAD TROUBLE ACCELERATING AND WOULD JERK FROM 1ST TO 2ND GEAR. READ MULTIPLE COMPLAINTS ON THIS ISSUE VIA WWW.CARCOMPLAINTS.COM/TOYOTA/RAV4/2002/TRANSMISSION/PROBLEMS_SHIFTING.SHTML AND FOUND THAT I AM NOT ALONE IN THIS PROBLEM....THIS IS UNACCEPTABLE.. I HAVE A FOUR YEAR OLD AND I AM SCARED OF DRIVING ANYWHERE BECAUSE IM SCARED OF PULLING OUT IN TRAFFIC FOR THE FEAR THAT THE CAR WONT MOVE AND I MAY GET HIT.....THIS NEED TO BE ADDRESSED....*TR

• 12/07/2015· ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  THE ECM WHICH CONTROLS THE TRANSMISSION FAILED.

• 12/07/2009· POWER TRAIN

  IN MARCH 2006, TOYOTA SENT DEALERS A TECHNICAL SERVICE BULLETIN 002-06WARNING THEM THAT SOME CONSUMERS MIGHT COMPLAIN ABOUT HARSH SHIFTING. IT SAID IMPROVEMENTS WERE MADE TO THE COMPUTER ?MANUFACTURING PROCESS TO REDUCE THE POSSIBILITY OF THIS CONDITION OCCURRING.? IT THEN TOLD THE DEALERS TO REPLACE THE MODULE AND IF THAT DID NOT WORK TO REPLACE THE TRANSMISSION. BUT CONSUMERS OWNING THE VEHICLES WERE NEVER NOTIFIED ABOUT THE PROBLEM. THIS IS EXACTLY WHAT MY CAR IS DOING, I WAS NEVER INFORMED OF THIS DEFECT WHEN I BOUGHT MY 2002 TOYOTA RAV4 USED IN NOV 2007 FROM TOYOTA OF BUTTE MT. AND OF COURSE IT ISN'T COVERED UNDER ANY WARRANTY OR RECALL NOW - ONLY UP TO 80,000 MILES BEFORE THE ECM STARTS TO MALFUNCTION. I WAS QUOTED THE FIX TO BE AROUND $900.00 AND THAT'S IF IT HASN'T CAUSED DAMAGE TO MY TRANSMISSION BY NOW. I'M A SINGLE WORKING MOM OF 3 KIDS ON A VERY LIMITED INCOME - I CAN'T AFFORD TO HAVE THIS FIXED AND NOW I'M WITHOUT THE ONLY CAR MY FAMILY HAS BECAUSE DRIVING IT IS AN EXTREME SAFETY HAZARD WITH IT'S CURRENT PROBLEMS. AS I PULL OUT INTO TRAFFIC THE CAR DECIDES TO NOT SHIFT (AS IF IT WERE IN NEUTRAL) RIGHT IN THE PATH OF ONCOMING TRAFFIC - NICE JOB TOYOTA. I THINK THAT THIS SHOULD BE A COVERED RECALL ON THESE VEHICLES BEFORE SOMEONE IS KILLED!!!!!!!! *TR

• 12/07/2004· EQUIPMENT

  I PURCHASED A 2002 TOYOTA SAQUOIA IN THE YEAR OF 2002,IN THE YEAR 2003 MY AIR CONDITIONING SYSTEM WENT OUT IN MY NEW VEHICAL UPON TAKING IT TO THE LOCAL TOYOTA DEALER I WAS TOLD THAT MY COMPLETE AIR CONDITIONING SYSTEM NEEDED TO BE REPLACED,I HAVE WENT A COMPLETE YEAR WITH OUT AN AIR CONDITION SYSTEM MIND YOU I LIVE IN AUGUSTA GEORGIA,THIS CAUSES SEVERAL THINGS TO NOT FUNCTION PROPERLY SUCH AS GAS GAGE NOT PROPERLT WORKING,WHEN YOU DRIVE THE CAR 60 MPH OR OVER THE TRUCK BEGAN TO BURN,THE AIR COMES ON AUTOMATICLLY AND THE TRUCK BEGAN TO JUMP VERY BADLY LIKE THE CAR IS GOING TO BLOW UP,THE HEAT ONLY WORKS WHEN YOU SET IT AT 80 DEGREES OR HIGHER SO YOU CAN ONLY LEAVE IT ON FOR SO LONG THEN YOU MUST TURN IT OFF AND WHEN IT GETS COLD AGAIN YOU HALF TO TURN IT ON AGAIN THIS GOES ON ALL DAY LONG.I CAN'T SEM TO GET ANY ONE FROM TOYOTA TO HELP ME WITH THERE DEFAULT, MY WIFE WON'T EVEN DRIVE THE CAR.SO WHEN I TOOK IT TO A NOTHER DEALER TO SEE IF THIS WAS REALLY THE PROBLEM HE TOLD ME THAT THE SYSTEM WAS REALLY BLOWEN.SIRS I WORK VERY HARD FOR MY MONEY AND I DON'T HAVE A LOT OF IT TO GIVE AWAY,IREALLY DON'T APPRICIATE A PRESTEGIOUS COMPANY SUCH AS TOYOTA TO PRAY ON ON IT'S CONSUMER. WHEN THE VEHICAL WAS CHECKED TO SEE IF THERE WAS A RECALL AT MY REQUEST THERE WAS WHAT YOU CALL A BULLITEN ON THIS PROBLEM,I THEN ASKED IF YOU KNOW THAT THIS PROBLEM ENOUGH WHY ISN'T THERE A RECALL I REALLY DON THINK THAT I THE CONSUMER SHOULD HALF TO FOOT A $2000 BILLL ON SOMETHING THAT WAS NOT MY FAULT I AM VERY SORRY THAT I PICKED A TOYOTA SEQUOIA THIS IS NOT A CHEAP VEHICAL IF YOU CAN HELP ME AND MY FAMILY PLEASE DO SO.THANK YOU IN ADVANCE. *AK

• 12/06/2012· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  THIS PAST SUMMER THE 2002 RAV 4 STARTED GIVING INDICATIONS THAT SOMETHING MIGHT NOT BE RIGHT. THE CAR HAD ALWAYS GOTTEN ITS REQUIRED MILEAGE MAINTENANCE WHICH WAS ALSO DUE AT THE TIME. SO THOSE THINGS WERE DONE. HOWEVER, OVER THE LAST THREE WEEKS THE FOLLOWING STARTED: --THE ENGINE LIGHT CAME ON, THEN OFF; --THERE WAS HESITATION WHEN ACCELERATING/ A HARSH JERK AND SHIFT WHEN CHANGING GEARS --THE VEHICLE WOULD SOMETIMES SLIP BACK INTO NEUTRAL AND STALL WHILE DRIVING THREE INDEPENDENT TOYOTA-CERTIFIED TECHNICIANS DIAGNOSED THAT THERE IS A PROBLEM WITH THE TRANSMISSION, SO WE TOOK IT TO DARCARS TOYOTA WHERE THE CAR WAS PURCHASED. THE TECHNICIAN THERE CONFIRMED THE DIAGNOSIS BUT SAID WE NEEDED TO CONTACT THE WARRANTY ENHANCEMENT DEPARTMENT. AFTER PLACING ME ON HOLD FOR ABOUT 5 MINUTES, SHE TOLD ME THAT THE CAR HAD EXCEEDED THE TIME FOR THE WARRANTY BY ABOUT 3 MONTHS AND THEREFORE NOTHING COULD BE DONE. IS TOYOTA WILLING TO JEOPARDIZE THE LONG-TERM CUSTOMER LOYALTY AND MORE IMPORTANTLY, THE SAFETY OF THEIR CUSTOMERS, JUST BECAUSE THE CAR CHOSE TO DISPLAY ITS PROBLEMS 3 MONTHS LATER? *TR

• 12/04/2002· FUEL SYSTEM, OTHER

  THE DASHBOARD RATTLES WHEN DRIVING. TOOK TO DEALER AND THE DEALER HAS REPLACED THE DASHBOARD ABOUT FOUR TIMES. THE DASH IS STILL RATTLING. PLEASE PROVIDE ANY FURTHER INFORMATION. TS

• 12/03/2009· ELECTRICAL SYSTEM

  2002 TOYOTA, RAV4, MY CHECK ENGINE LIGHT CAME ON, THE CAR ONLY HAS 50,000MILES ON IT, I HAVE JUST RECENTLY HEARING ABOUT THIS SAME PROBLEM WITH MANY OTHER TOYOTA RAV 4 OWNERS. *TR

• 12/03/2008· POWER TRAIN

  MY 2002 RAV4 TRANSMISSION WENT BAD (SHIFTING IMPROPERLY) OVER 100 COMPLAINTS ON LINE ABOUT SAME PROBLEM. THERE ARE NO RECALL OR EXTENDED WARRANTIES FROM TOYOTA. *TR

• 12/02/2009· POWER TRAIN

  CAR JERKS; HESITATES; DOES NOT GO INTO GEAR PROPERLY; REVS LOUDLY BUT STARTS LIKE IT'S BEING MOVED OFF IN THIRD GEAR. TOLD IT'S THE COMPUTER THAT IS BAD BUT IF IT DOES NOT GET FIXED AFTER REPLACEMENT OF THE COMPUTER, IT COULD BE THE TRANSMISSION. I AM ORDERING A REPLACEMENT COMPUTER BUT CANNOT AFFORD TO DO IT VIA THE DEALER BECAUSE THE INITIAL COST IS $1300. PROBLEM IS SIMILAR TO MANY LISTED ON VARIOUS WEBSITES - SPOKE TO TOYOTA 800-NUMBER: THEY CAN ONLY TAKE THE COMPLAINT AND GIVE A REFERENCE NUMBER BUT NOBODY WILL CONTACT ME. NO SUGGESTION OF A RECALL DESPITE HUNDREDS OF COMPLAINTS ABOUT CARS WITH EXACT PROBLEMS. I'M FRUSTRATED BECAUSE THERE IS NO CONSIDERATION OF A DISCOUNT BEING OFFERED, KNOWING THAT SO MANY CARS HAVE HAD THIS EXACT PROBLEM. I FEEL THE CARS SHOULD BE RECALLED AND TOYOTA SHOULD OFFER A GOOD-FAITH DISCOUNT, EVEN IF IT'S NOT THE FULL AMOUNT BEING REFUNDED BECAUSE CARS ARE OVER THE 80,000 MILE THRESHOLD, FOR SUCH SAFETY CONCERNS AS THIS. *TR

• 12/01/2010· ELECTRICAL SYSTEM

  AUTO: 2002 TOYOTA RAV4 ISSUE: ECU OR ECM COMPLAINT: TOYOTA REFUSES TO REPAIR ANY TRANSMISSION DAMAGES ASSOCIATED WITH THE FAULTY COMPUTER PART. DESCRIPTION: WHEN PRESSING THE GAS WHILE ACCELERATING FROM A COMPLETE STOP, THE TRANSMISSION WILL NOT SHIFT PROPERLY. JERKY MOVEMENTS IN THE LOWEST GEARS AND REVERSE; SLUGGISH WHEN PEDAL FULLY PRESSED. CURRENT RESOLVE: TOYOTA WILL REPLACE THE ECM, THOUGH THE PART WILL TAKE 2-3 WEEKS DUE TO HIGH DEMANDS. TOYOTA WILL NOT REPAIR ANY OTHER TRANSMISSION DAMAGES ASSOCIATED WITH THE FAULTY PART. *TR

• 12/01/2009· POWER TRAIN

  TOYOTA 2002 RAV4 PROBLEM WITH AUTOMATIC TRANSMISSION HESITATING AND JERKING IN LOW GEARS. PROBLEM STARTED IN JULY 2009 AND WITHIN ONE WEEK WAS OCCURRING ALL THE TIME. RAV4 WAS WELL PAST ITS WARRANTY OF 50K OR 5 YEARS. OURISMAN CHANTILLY VIRGINIA TOYOTA DEALER SAID IT NEEDED NEW TRANSAXLE FOR $5,500. MILLER TOYOTA OF MANASSAS VIRGINIA REPLACED ECM MODULE WHICH WAS STILL UNDER EMISSIONS WARRANTY OF 80K OR 8 YEARS. THIS HAS CORRECTED THE PROBLEMS SO FAR. *TR

• 11/30/2012· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  ON STARTING, THE CAR THE BATTERY LIGHT CAME ON AND STAYED ON. A MONTH OR SO LATER I NOTICED A CLUNKING IN THE TRANSMISSION AS THE AUTOMATIC WENT TO A HIGHER GEAR. THIS PROBLEM STILL REMAINS. *TR

• 11/30/2009· POWER TRAIN

  THIS COMPLAINT IS REGARDING THE 2002 TOYOTA RAV4 ABOUT A YEAR AGO I NOTICED THAT THE VEHICLE WAS STOPPING AND HAVING PROBLEMS CHANGING SHIFTS. I RESEARCHED AND FOUND A LOT OF PEOPLE SAYING THAT IT WAS THE COMPUTER OF THE ENGINE WHICH WAS MESSING UP MY TRANSMISSION. I WENT AHEAD AND PAID AROUND $2000.00 TO HAVE THE COMPUTER CHANGED. THE DEALERSHIP TOLD ME THAT THE OLD COMPUTER WHICH WAS PUT AT THE FACTORY HAD DAMAGED MY TRANSMISSION. IT RAN WELL FOR A WHILE BUT A COUPLE OF WEEKS BACK I WAS TURNING LEFT AND THE VEHICLE UNEXPECTEDLY STOPPED I WAS SCARED OUT OF MY MIND BECAUSE THERE WERE CARS COMING AT A HIGH SPEED I PUSHED THE GAS ABOUT 3 TIMES FOR IT TO JERK INTO GEAR. A LOT OF OTHER INCIDENTS LIKE THAT HAVE HAPPENED WITH THIS VEHICLE WHERE THE ENGINE JUST WONT REACT AND PLACE ME IN DANGEROUS SITUATION. NOW ITS EVEN WORST WHERE IT IS REALLY STAINING ITSELF TO AT LEAST GET TO 40MPH I'M GOING TO ONCE AGAIN HAVE TO TAKE IT TO A SHOP TO GET FIXED OR MAYBE TRADE IT IN ALL TOGETHER, BECAUSE IT'S A DANGER TO ME AND MY FAMILY. *TR

• 11/30/2006· ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEMFire

  NOVEMBER 17, 2006 - AFTER BEING PARKED IN MY DRIVEWAY FOR APPROXIMATELY 30 MINUTES THE ENGINE CAUGHT ON FIRE. THE RAV4 ENGINE COMPARTMENT AND ENTIRE INTERIOR WAS DEMOLISHED, TIRES EXPLODED, GLASS EXPLODED OVER AT LEAST A 20 FOOT RADIUS. TWO ENGINE TRUCKS AND 10 RESPONDERS LATER THE FIRE WAS OUT. 63,000 MILES, NO PRIOR PROBLEMS, 50K MAINTENANCE COMPLETED BY DEALER JAN 2006. VIN HAS ZEROS AND LETTER O WHICH ARE INDISTINGUISHABLE. TRY BOTH. *JB

• 11/26/2008· POWER TRAIN

  2002 TOYOTA RAV4 TRANSMISSION STARTED JERKING AND COULD NOT PICK UP SPEED ON HIGHWAY. ALMOST GOT INTO A MAJOR ACCIDENT WITH MY DAUGHTER (20 MONTH OLD) ON BOARD. I LOOKED ONLINE AND THERE ARE NUMEROUS COMPLAINTS OF THIS MAKE AND MODEL HAVING MAJOR TRANSMISSION PROBLEMS. TOYOTA NEED TO FIX THIS MAJOR SAFETY PROBLEM AND NOT STICK THE CONSUMER WITH THE BILL (AVERAGE FIX $3,000 DOLLARS FIX PER VEHICLE AT BEST WORTH$7,000). *TR

• 11/24/2003· LATCHES/LOCKS/LINKAGES

  THE REAR LUGGAGE COVER DOES NOT STAY UP AND NUMEROUS TIMES IT HAS SLIPPED AND HIT ME OR ONE OF MY FAMILY ON THE HEAD. THIS WEEKEND, IT SLIPPED AGAIN AND CAUSED A CUT ON MY HEAD. I ASKED THE DEALER ABOUT A FIX FOR THIS AND HE STATED NONE NOTED AND THEY HAVE HAD SIMILAR COMPLAINTS BUT NO TSB OR RECALLS ISSUED. THIS LUGGAGE COMPARTMENT COVER IS DANGEROUS AND NEEDS TO BE RE-DESIGNED. *LA

• 11/23/2018· POWER TRAIN,ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2002 TOYOTA RAV4. AFTER STARTING THE ENGINE, THE VEHICLE WOULD NOT PROPERLY ACCELERATE WHEN DEPRESSING THE ACCELERATOR PEDAL. THE VEHICLE WAS TAKEN TO FRED ANDERSON TOYOTA (9101 GLENWOOD AVENUE, RALEIGH, NC) WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC CONTROL MODULE AND TRANSMISSION WERE FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 91,000. *TT CONSUMER STATED TRANSMISSION FAILED WHILE IN TRAFFIC, CAR WAS ABLE TO ACCELERATE PROPERLY AND WAS LONGER SHIFTING GEARS.*JB

• 11/23/2014· POWER TRAIN

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

• 11/23/2010· POWER TRAIN

  MY 2002 RAV 4 CHECK ENGINE LIGHT CAME ON AT 96,000 MILES; WHEN THE CODE WAS CHECKED IT RELATED IT TO THE CATALYST SYSTEM, BUT I CALLED TOYOTA CUSTOMER SERVICE AND THEY INFORMED ME THAT THE ECM HAD TO BE UPDATED AS PART OF A RECALL FOR MY VEHICLE AND I NEEDED TO TAKE IT TO A TOYOTA DEALER; DOING THIS WOULD CAUSE THE FAULTY CHECK ENGINE LIGHT TO BE RESET. THEY PERFORMED THE SERVICE, AND NOW 3 WEEKS LATER THE VEHICLE SPONTANEOUSLY POPS OUT OF 5TH GEAR, CAUSING THE VEHICLE TO DRAMATICALLY DECREASE UNPREDICTABLY AT HIGHWAY SPEEDS. DANGEROUS!!! ALTHOUGH AFTER LOOKING ON THE INTERNET AND DISCOVERING COUNTLESS OTHERS WITH THIS SAME PROBLEM, TOYOTA HAS NOT YET ISSUED A RECALL FOR THE TRANSMISSION PROBLEMS; THEY HAVE DONE NOTHING TO ADDRESS THIS DANGEROUS AND COSTLY-TO-FIX PROBLEM. SUPPOSEDLY IN 2006 TOYOTA REALIZED THERE WAS AN ISSUE WITH THE ECM, (WHICH COULD APPARENTLY DAMAGE THE TRANSMISSION). INSTEAD OF LETTING CONSUMERS KNOW ABOUT THIS ISSUE AS SOON AS THEY REALIZED, THEY SENT A TECHNICAL SERVICE BULLETIN TO DEALERSHIPS AND SERVICE AREAS, BUT FAILED TO LET THEIR OWN CUSTOMERS KNOW. ACCORDING TO INTERNET RESEARCH, THIS PROBLEM GENERALLY STARTS AROUND 90,000 MILES. *TR