2002 Nissan Frontier

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/27/2007· FUEL SYSTEM, GASOLINE

  GAS FUMES ARE SMELLED AFTER FILLING UP AT THE GAS STATION. THEY ARE NOT SMELLED INSIDE THE VEHICLE, ONLY OUTSIDE THE VEHICLE BY THE GAS TANK. NO LIQUID GAS DRIPPINGS ARE NOTICED. DASHBOARD CODE LIGHT COMES ON. THE CODE DESCRIPTION SAYS SMALL LEAK DETECTED. SECOND CODE SAYS VERY SMALL LEAK DETECTED. GAS CAP IS TIGHT AND WAS INSPECTED FOR LEAKS. ALSO NEW CAP WAS INSTALLED. NO EFFECT TO CHANGE. *TR

• 12/23/2004· EXTERIOR LIGHTING,EQUIPMENT

  THE HEADLIGHT ASSEMBLY PARTS ON THIS ALTIMA ARE DEFECTIVE AND HAD TO BE REPLACED ON BOTH THE LEFT AND RIGHT SIDE OF THE CAR. PRIOR TO REPLACEMENT THE LIGHTS WERE REPLACED SEVERAL TIMES. BUT THE ACTUAL DEFECT CAUSED BY THE LIGHTS BEING TOO HOT AND THEN MELTING THE PLASTIC WAS NOT BROUGHT TO MY ATTENTION UNTIL EXPENSES HAD BEEN INCURRED ON REPLACEMENT OF THE LIGHTS SEVERAL TIMES. WHENTHE LEFT SIDE WAS PROPERLY DIAGNOSED FINALLY, THE CAR WAS STILL UNDER WARRANTY BUT THE DEALER DENIED REPLACEMENT AND REFUSED TO ATTEMPT ANY SOLUTION. DUE TO THE EXPENSE OF REPLACING THE LIGHTS AND THE LEFT HEAD LIGHT ASSEMBLY PART, I HAD TO WAIT TO REPLACE THE RIGHT SIDE. THE PARTS COMPONENTS FOLKS SHOULD BE RESPONSIBLE. MORE IMPORTANTLY NISSAN SHOULD TAKE RESPONSIBILITY. SEVERAL MECHANICS INCLUDING ONE SERVICE PERSON AT THE NISSAN DEALER TOLD ME THEY HAD SEEN SEVERAL ALTIMAS WITH THIS PROBLEM BUT UNTIL THERE WAS A RECALL THERE WAS NOTHING HE COULD DO.*AK

• 12/20/2002· SERVICE BRAKES, HYDRAULIC,EQUIPMENT

  DEALER IS DENYING RESPONSIBILITY FOR THE PROBLEMS I AM HAVING. I BROUGHT THE TRUCK 4 TIMES FOR ABS, 3 FOR A/C NOT WORKING & ENGINE LIGHT REMAINS ON. I JUST FINISHED ARBITRATION AND BBB AUTO LINE DECIDED THAT ABS IS NOT A SAFETY ISSUE DESPITE THE FACT THAT THE NISSAN MANUAL SHOWS THE IMPORTANCE OF IT IN BRAKING. I THINK THE ARBITRATOR IS NOT FAIR AND INFLUENCE DIRECTLY BY THE DEALERSHIP. *JB ***DIMSSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS***770777

• 12/20/2002· SERVICE BRAKES, HYDRAULIC

  WHILE TRAVELING ON THE HIGHWAY WITHOUT PRIOR WARNING. THE ABS BRAKING LIGHT WILL APPEAR ON THE DASHBOARD. AND WILL STAY ON UNTIL THE VEHICLE IS TURN OFF. PLEASE PROVIDE ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM. TS

• 12/18/2024· ELECTRICAL SYSTEM,ENGINE,FORWARD COLLISION AVOIDANCE

  The main issue on the Nissan Frontier that I just bought a few months ago that I need to report that I think should be recalled item is the passenger side exhaust manifold is cracked and it makes ticking noises the exhaust is loud and I am definitely getting exhaust fumes drawn into the cab especially when I turn the heater on now that it's winter time and it's getting CO2 carbon and exhaust fumes inside cab which is very toxic also the rear window defogger does not work and the cruise control does not work at all so anyway you're asking for what date this first occurred well it was like that when I bought it and I bought it on approximately in July of the summer 2024 it was all these issues were already broke when I got it I looked online and I see that the exhaust manifold is a very common problem and it is also a health hazard and toxic and could cause injury or death to passengers so I believe it should be and maybe is recalled I see online where some dealerships a few years ago already started fixing the issue for free before it was even recalled so I did a recall check and it says that there's no unfixed recalls on my vehicle but that exhaust manifold needs to be recalled and warranted because it's happening on a majority of those that means it's a bad design and it is also health hazard safety hazard health risk of injury or death because of it

• 12/15/2014· STEERING

  TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 75 MPH, THE STEERING WHEEL WAS DIFFICULT TO TURN. THE CONTACT WAS CONCERNED THAT THE FAILURE WOULD RESULT IN A CRASH. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 10V554000 (STEERING) IN FEBRUARY OF 2013, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 225,000.

• 12/11/2010· STEERING

  NHTSA CAMPAIGN ID NUMBER : 10V554000 THIS RECALL CAMPAIGN DESCRIBES EXACTLY WHAT HAPPENED LAST SATURDAY TO MY 2002 NISSAN FRONTIER....MY STEERING COLUMN BROKE OFF WHILE I WAS DRIVING AND I HAD ABSOLUTELY NO STEERING. I ALMOST CRASHED TWICE AND BUT MANAGED TO LAND THE TRUCK SAFELY ON A FRIEND'S MOTHER'S FRONT LAWN. AN EXPERIENCED MECHANIC ON SCENE SAID HE HAD NEVER SEEN A STEERING COLUMN BREAK OFF LIKE THIS ONE DID. IT WAS TOWED BY A FLATBED FROM THERE AND IS CURRENTLY AT THE LOCAL NISSAN DEALER, BUT THERE ARE NO PARTS AVAILABLE ANYWHERE TO FIX IT. I HAD NO CHOICE BUT TO BUY ANOTHER VEHICLE THIS WEEK, AND I DID BUY ANOTHER NISSAN, A 2009 FRONTIER. *TR

• 12/10/2003· ELECTRICAL SYSTEM

  THE VEHICLE EXPERIENCED AN ELECTRICAL FAILURE WHILE DRIVING AT ANY SPEED. THE TURN SIGNAL/ HAZARD LIGHTS AND INSTRUMENTAL PANEL LIGHTS WERE WORKING ABNORMALLY. THE DEALER INSPECTED THE TRUCK AND COULDN'T FIND ANYTHING WRONG. *AK THE DEALER REPLACED THE IGNITION SWITCH AND THE SUB HARNESS IN AN ATTEMPT TO LOCATE THE PROBLEM. *SCC *JB

• 12/07/2011· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE WARNING INDICATOR CONTINUOUSLY ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. ON A SEPARATE OCCASION THE VEHICLE JERKED VIOLENTLY WITH A REDUCTION IN THE ENGINE POWER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE KNOCK SENSOR, MASS AIR FLOW SENSOR AND FOUR OXYGEN SENSORS WERE REPLACED. THE FAILURE CONTINUED TO OCCUR AFTER THE REPAIR WAS PERFORMED. THE VEHICLE WAS TAKEN BACK TO THE INDEPENDENT MECHANIC FOR THE SECOND TIME AND THE WIRING HARNESS WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM AND THEY INFORMED THE CONTACT THAT THE WIRING HARNESS CONNECTORS EXHIBITED CORROSION AS A RESULT OF NOT BEING WEATHERPROOF DURING PRODUCTION. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 04/10/12*LJ THE CONSUMER STATED HE SPENT CLOSE TO $2000 REPAIRING THE VEHICLE. THE CHECK ENGINE LIGHT CONTINUED TO ILLUMINATE, AFTER REPLACING THE O2 SENSORS FOUR TIMES. ALSO, THE WIRING HARNESS HAD TO BE REPLACED BECAUSE WHEN THE VEHICLE WAS MANUFACTURED IT WAS NOT WEATHER PROOF WHICH CAUSED CORROSION IN THE WIRES, WHICH SENT INCORRECT SIGNALS TO THE VEHICLE'S COMPUTER. THE CONSUMER NO LONGER OWNS THE VEHICLE. UPDATED 05/31/12

• 12/05/2011· FUEL SYSTEM, GASOLINE

  TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE VIN DID NOT QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 04V230000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 139,893.

• 12/04/2003· SERVICE BRAKES, HYDRAULIC

  PULSATING IN STEERING WHEEL DUE TO APPARENT WARPED FRONT BRAKE ROTORS. *NLM

• 12/02/2015· FUEL/PROPULSION SYSTEM

  IN JUST UNDER 14 YEARS OF OWNING THIS VEHICLE, I NOW HAVE HAD TO REPLACE THE GAS TANK A THIRD TIME DUE TO LEAKAGE. I DO NOT FEEL THAT THIS SHOULD BE THE RESPONSIBILITY OF THE OWNER, DUE TO THE FREQUENCY OF THIS HAPPENING. I BELIEVE THESE TANKS ARE A BAD DESIGN AND WITH POOR MATERIAL TO RUST OUT AND LEAK IN SUCH SHORT PERIODS OF TIME. I JUST CAN;T BELIEVE THERE HAVE NOT BEEN NUMEROUS INJURIES OR ANY DEATHS DUE TO THESE GAS TANKS. I HAVE ATTACHED PICTURES OF THE SECOND GAS TANK THAT WAS REPLACES ABOUT 6-7 YEARS AGO. AND YOU CAN DEFINITELY SEE THAT IT HAS BEEN LEAKING. BY THE WAY. MY TRUCK HAS ALWAYS BEEN GARAGE KEPT AND I HAVE YET TO FIND SOMEONE THAT BELIEVES MY TRUCK IS THAT OLD DUE TO HOW NICE THAT IT STILL LOOKS INSIDE AND OUT.

• 11/30/2001· FUEL SYSTEM, GASOLINE

  FUEL TANK IS SPILLING/LEAKING GAS.*AK

• 11/27/2007· ENGINE AND ENGINE COOLING,EXTERIOR LIGHTING

  MY NEW CAR WAS PERFORMING AS IT WAS SUPPOSED TO AND MAINTENANCE WAS BEING COMPLETED ON A REGULAR SCHEDULE. MY VEHICLE STARTED TO CUT OFF DURING OPERATION IN 2004/5. IT WOULD HAPPEN IN THE DRIVEWAY, EXPRESSWAYS, ETC. IT DIDN'T MATTER. I TOOK IT TO THE NISSAN DEALER AND THEY CLAIMED TO FIX THE PROBLEM. NEXT MY HEADLIGHT BEGAN TO BLOW A BULB EVERY 2,0000-3,000 MILES. I TOOK IT TO THE DEALER AND THEY REPLACED IT. THIS OCCURRED IN 2005. MID- JULY TO LATE NOVEMBER 2006 MY CAR BEGAN TO STALL IN COLD/WARM WEATHER. I TOOK IT TO THE NISSAN DEALER AND THEY STATED THAT NO PROBLEM WAS FOUND. MY CAR STARTED TO CONSUME OIL AT AN ALARMING RATE IN APRIL 2007. IT WAS TAKEN TO THE DEALER YET AGAIN AND I WAS TOLD IT HAD INTERNAL ENGINE DAMAGE AND THEY COULD NOT FIND A PROBLEM WITH THE EXTERNAL COMPONENTS. I WAS QUOTED $4,000-$4,200 FOR A REPLACEMENT ENGINE. I HAVE ALWAYS GOTTEN MY REPAIR WORK AND OIL CHANGES AT NISSAN DEALERS AND NOW WHEN MY EXTENDED WARRANTY IS GONE I AM TOLD I NEED TO BUY AN ENGINE. THIS IS UNFAIR AND COSTLY. I CANNOT USE THE CAR FOR WORK COMMUTES OR TO GET TO SCHOOL. NISSAN HAS BEEN TOLD MANY TIMES ABOUT THEIR PRODUCT FAILURE AND THE MECHANICS BASICALLY ONLY CARE THAT YOU BUY/NOT BUY A MOTOR. I SHOULD NOT BE PAYING FOR THIS CAR WHEN IT IS CLEARLY A MECHANICAL DESIGN DEFECT THAT HAS CAUSED ME SO MUCH TIME, MONEY AND PAIN. I LEFT IT AT MY SISTER'S APARTMENT FOR 3 MONTHS BECAUSE IT WOULD START AND CUT OFF, IF AT ALL. I DROVE THE CAR THE OTHER DAY AFTER TRYING TO GET IT STARTED FOR 2 DAYS. IT DROVE LIKE A DREAM. NOW I CAN'T GET IT STARTED TO EVEN GET TO AND FROM ANYWHERE. I HAVE NUMEROUS REASONS FOR THINKING NISSAN SHOULD BE LIABLE. WHATEVER THEY ARE CURRENTLY DOING TO FIX THE PROBLEM IS OKAY BUT THERE ARE LOTS AND LOTS OF ENGINES DAMAGED DUE TO THESE RECALL ITEMS THAT WERE NOT HANDLED BY THE DEALERS AND NISSAN PROPERLY. *TR

• 11/25/2009· SUSPENSION

  NO FOLLOW UP FROM DEALER ABOUT NHTSA CAMPAIGN NUMBER 02V299000. I CALLED NISSAN TO GET MORE INFORMATION BECAUSE MY ABS SENSOR LIGHTS TEND TO TURN ON DURING RAINY DAYS. RESEARCHED ONLINE AND FOUND THIS RECALL, ASKED TO SCHEDULE MY TRUCK FOR SERVICING WITH NO RESULTS, NOT EVEN A CALL BACK. *TR

• 11/18/2015· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. WHILE DRIVING AT AN UNKNOWN SPEED, THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL TANK WAS COMPLETELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED SEVEN YEARS LATER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000.

• 11/18/2004· SERVICE BRAKES, HYDRAULIC,AIR BAGSCrash

  I WAS IN A CAR ACCIDENT TODAY AND THE BRAKES NOT WORKING HAD A LOT TO DO WITH IT. AS I NOTICED A CAR IN FRONT OF ME, I APPLIED MY BRAKES ONLY TO FIND THAT IT DIDN'T DO ANYTHING AND WENT TO THE FLOOR SO I TRIED AGAIN (STILL ABOUT TO HIT ANOTHER CAR) AND THEY WORKED FINE. I AM WAITING TO HEAR IF THERE WAS A FAILURE WITH THEM, BUT THE FACT THAT THEY WORKED THE SECOND TIME LEADS ME TO BELIEVE THAT THEY WILL FIND NOTHING WRONG.....I KNOW THERE ARE OTHER BRAKE COMPLAINTS WITH NISSANS, SO I HOPE THIS WARNING HELPS. ALSO, I WAS GOING AT A SPEED OF ABOUT 50MPH AND WHEN I HIT THE CAR AHEAD, THE AIR BAGS DID NOT DEPLOY. IT WAS A FRONTAL HIT, MORE TO THE RIGHT SIDE, AND NEITHER AIR BAG WORKED. NO INJURIES BUT MY NECK AND BACK HURT. I HAVE JUST REPAIRED SO MUCH ON MY SENTRA, AND I AM NOT HAPPY WITH THE PROBLEMS I HAVE INCURRED WITH NISSAN, WE'LL SEE IF I EVER BUY ANOTHER.*AK

• 11/15/2011· FUEL SYSTEM, GASOLINE

  A VERY STRONG AND VERY OVERPOWERING GAS SMELL CAME INSIDE THE VEHICLE WHILE I WAS DRIVING IT AT NIGHT. I HAD MY 5-YEAR OLD STRAPPED IN HIS CAR SEAT IN THE BACK. I WAS STUCK IN TRAFFIC ON I-95 AND DIDN'T HAVE MANY OPTIONS BUT TO CONTINUE TO DRIVE HOME. THE "SERVICE ENGINE SOON" LIGHT CAME ON AS WELL. THE NEXT DAY, I TOOK THE VEHICLE IN FOR SERVICING AT MY NISSAN DEALERSHIP MECHANIC, AND I HAVE SPECIFIC TEXT FROM THE WORK INVOICE THAT STATES THE FOLLOWING WORD-FOR-WORD: "CANNISTER COMING APART. RIGHT VALVE STUCK INSIDE - REPLACED - GAS LEAKING DOWN SIDE. REPLACED GAS TANK - RUSTED." THE WORK INVOICE ALSO DETAILS THAT THE DEALERSHIP MECHANIC REPLACED THE FOLLOWING COMPONENTS: (1) CANISTER ASSY E (2) VALVE ASSY - CO (3) FUEL TANK (4) RING-O FUEL GAG. THIS VEHICLE HAS NEVER BEEN IN ANY ACCIDENTS AND I FULLY MAINTAIN IT ACCORDING TO THE MANUFACTURER'S SCHEDULE. I HAVE BEEN A RESPONSIBLE AND GENTLE OWNER. I FEEL THIS WAS EXTREMELY UNSAFE -- TO HAVE GASOLINE LEAKING OUT DUE TO A RUSTED GAS TANK IS [IN MY OPINION] AN UNACCEPTABLE DEFECT -- THE GAS TANK SHOULD HAVE BEEN MADE [IN MY OPINION] OUT OF A NON-RUSTING MATERIAL. I HAVE COMPLAINED TO NISSAN USA AND THEY OFFERED ME (ON THE PHONE THE REPRESENTATIVE SAID IT WAS AS "GOODWILL") A $250 NISSAN DEBIT CARD FOR FUTURE REPAIRS ON THIS VEHICLE. BUT THE TOTAL COST THAT I HAD TO PAY FOR THIS LEAKING GASOLINE ISSUE WAS $1,254.83. I AM WILLING TO PROVIDE NHTSA WITH MY RECEIPT THAT SHOWS THE TEXT INDICATING THE DETAILS OF THIS DEFECT AND THAT I HAD TO PAY $1,254.83 TO RECTIFY IT. *TR

• 11/14/2003· ELECTRICAL SYSTEM

  TACH, ODOMETER, SPEEDOMETER, FUEL AND TEMPERATURE GAUGES DID NOT ACTIVATE ON START. DRIVING ENGAGED SPEED LIMITER ONCE TRANSMISSION ENTERED 3RD GEAR (AUTOMATIC). AFTER DRIVING 3-4 MILES, GAUGES CAME TO LIFE. THIS HAPPENED ON A PREVIOUS EXPERIENCE BUT WAS RECTIFIED BY TURNING OFF AND RESTARTING VEHICLE. A WEB SEARCH RESULTED IN FINDING OTHER NISSAN OWNERS WITH SIMILAR PROBLEMS WITH DIFFERENT MODELS. TWO DEALERS SAID THEY COULDN'T DETERMINE THE PROBLEM UNLESS THEY COULD SEE IT HAPPENING. *LA

• 11/13/2009· FUEL SYSTEM, GASOLINE

  2002 NISSAN FRONTIER FUEL TANK EVAP LEAKS AND FUEL LEAK DUE TO RUST DAMAGE ON TANK. SHOP IS UNABLE TO OBTAIN A REPLACEMENT TANK AND STATES TANK IS NOT THE NORMAL TANK FOR THIS TRUCK IS UNABLE TO IDENTIFY IT. THEY INFORMED ME NISSAN HAS A PROBLEM WITH FAULTY TANKS FOR THE FRONTIER THIS YEAR. *TR

• 11/13/2008· ENGINE AND ENGINE COOLING

  NISSAN ALTIMA - CHECK ENGINE LIGHT CAME ON NOVEMBER 2006. NISSAN DEALERSHIP STATED THAT THE CATALYTIC CONVERTER SENSOR COULD BE BAD AND NOT NECESSARILY THE PART. THEY SHUT THE LIGHT OFF AND SENT ME ON MY WAY. THE LIGHT CONTINUED TO GO OFF AND ON OVER THE COURSE OF THE NEXT YEAR YET PASSED A STATE EMISSIONS TEST. NO OTHER ENGINE PROBLEMS OCCURRED. NOVEMBER, 2008 VEHICLE FAILED STATE EMISSIONS TEST - TOLD IT WAS THE CATALYTIC CONVERTER. NISSAN DEALERSHIP STATES THE WARRANTY RAN OUT AT 80K MILES - THE CAR HAS 83K MILES. HAVE NOT HAD THE CAR LOOKED AT BY DEALERSHIP MECHANIC YET FOR FEAR THE ESTIMATED $1000 REPAIR COULD TURN INTO AN ENGINE REPLACEMENT AT A MUCH HIGHER COST. *TR

• 11/13/2004· SERVICE BRAKES, HYDRAULIC

  BRAKES : UPON BRAKING, NOTICED SIGNIFICANT VIBRATION IN STEERING WHEEL. DIAGNOSED/ AS WARPED ROTORS: REPAIRED VIA GRINDING ON 5/15/03 BY NISSAN MILEAGE 20,834 . ON NOVEMBER 10, 2004 AT APPROX 30,700 MILES ,AGAIN NOTICED SIGNIFICANT VIBRATION WHEN BRAKING AT 50 MPH. NISSAN SERVICE SAID ROTORS HAD HEATED AND WARPED AGAIN! ROTORS WARPED AFTER LESS THEN 10,000 MILES!! MILES AFTER THE FIRST REPAIR. REPAIRED AGAIN AT 30,830 MILES. NORMAL DRIVING HAS RESULTED IN THE 17" WHEELS TO WARP ROTORS TWICE WITHIN A 10,000 MILE SPAN. *JB

• 11/10/2015· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL TANK WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 133,000. THE VIN WAS NOT AVAILABLE.

• 11/09/2004· SERVICE BRAKES, HYDRAULIC

  I HAVE HAD REOCCURING BRAKING PROBLEMS WITH MY 02 NISSAN XTERRA FOR THE PAST YEAR. THE BRAKES DO NOT ADEQUATELY STOP THE VEHICLE AND GRAB/RELEASE WHEN COMING TO A STOP MAKING CONTROL OF THE VEHICLE DIFFICULT AT TIMES. I HAVE TAKEN THE VEHICLE TO THE NISSAN DEALER THREE SEPARATE TIMES FOR SERVICE AND THE PROBLEM HAS STILL NOT BEEN REMEDIED. I WAS RECENTLY TOLD BY THE SERVICE DEPARTMENT AT THE NISSAN DEALERSHIP THAT THIS IS A COMMON PROBLEM WITH THE VEHICLE AND THE MANUFACTURER HAS NOT COME UP WITH A SOLUTION.*AK

• 11/09/2004· SERVICE BRAKES, HYDRAULIC

  I OWN A 2002 NISSAN ALTIMA THAT HAS JUST 37000 MILES ON IT. IN THE PAST 2-3 WEEKS I NOTICED BRAKE NOISE THAT SOUNDED LIKE METAL ON METAL GRIDING. I OF COURSE TOOK IT TO MY DEALER FOR INSPECTION AND WAS TOLD THAT ALL FOUR SETS OF BRAKES NEEDED TO BE REPLACED. IN SHORT, EVERYTHING WAS GONE. AFTER LESS THAN 2.5 YEAR. THIS SEEMS LIKE EXCESSIVE AND PREMATURE BRAKE FAILURE. I HAVE VISTITED SEVERAL OWNER WEBSITES AND HAVE SEEN A MULTITUDE OF STORIES REGARDING EARLY BRAKE WEAR ON THE 2002 ALTIMA. THIS VEJICLE HAS ALSO HAD 5 SAFETY RECALL IN THE LAST 2 YEARS. NISSAN CLAIMS THAT THIS IS "NORMAL" BRAKE WEAR. I THINK IT'S A POTENTIAL SAFTEY HAZARD. THE VEHICLE HAS BEEN REPAIRED AT A COST OF $900. I AM NOT A "HARD" DRIVER AND ALL VEHICLES I HAVE OWNED IN THE PAST HAVE NOT NEEDED BRAKES TILL 50-60000 MILES. THIS SEEMS LIKE EITHER A DESIGN FLAW OR FAULTY PARTS OR BOTH. *AK

• 11/07/2007· EXTERIOR LIGHTING,STRUCTURE

  WATER GETS IN THE SEAL OF THE UPPER REAR TAIL LIGHT/CARGO LIGHT. THE WATER LEAKS THROUGH DAMAGING THE HEADLINER AND CARPET. ALSO BLEW MY FUSE AND NONE OF THE LIGHTS WORK IN IT, AS WELL AS BLOWING OUT THE FUSE EVERY TIME I REPLACE IT. THERE IS STILL NO UPDATED VERSION OR RECALL FOR IT ALL YOU CAN DO IS GET A NEW ONE AND HOPE IT LASTS A LITTLE LONGER. *TR

• 11/06/2001· CHILD SEAT

  I AM CONCERNED ABOUT THE SAFETY OF MY CHILD OR MYSELF SITTING IN THE JUMPER SEATS OF THIS TRUCK. I WAS TOLD BY DOT THAT A 3 PT. SEAT BEAT WAS SAFEST. IT IS RECOMMENDED THAT CHILDREN SIT IN THE BACK OF VEHICLES, BUT SINCE THERE IS ONLY A LAP BELT, HOW SAFE IS IT FOR A 6 YEAR OLD TO SIT IN THE JUMPER SEAT? DOES CRASH TESTS SHOW THAT THE LAP BELT IS SUFFICIENT FOR ADULTS SITTING IN THE JUMPER SEAT?*AK

• 11/05/2018· STRUCTURE

  TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC TO BE SERVICED AND WAS INFORMED THAT THE FRAME OF THE VEHICLE WAS CORRODED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

• 11/04/2002· UNKNOWN OR OTHERCrash

  NO SUMMARY. DT

• 11/03/2004· SERVICE BRAKES, HYDRAULIC

  AT APPROX. 36,400 MILES ABS WARNING LIGHT WENT ON. II TOOK THE CAR TO A LOCAL DEALER FOR INSPECTION AND THEY SAID IT WAS THE FRONT LEFT ABS SENSOR, $290.00 TO REPAIR, FRONT BRAKE PADS DOWN TO 10% AND ROTORS NEED TO BE RESURFACED. I INQUIRED ABOUT WARRANTY COVERAGE OF THE SENSOR AND THEY SAID NO. I CONTACTED NISSAN EXPLAINED THE SITUATION, THEY CONTACTED THE DEALER AND NISSAN REFUSED TO COVER THE REPAIR SAYING THE CAUSE WAS DUE TO BRAKES BEING WORN DOWN. THIS WAS MY 3RD NISSAN VEHICLE AND WILL BE MY LAST ONE.*AK

• 11/03/2004· POWER TRAIN

  MY CONCERNS ARE ALSO REFLECTED IN 2 OTHER COMPLAINTS LISTED ON YOUR WEBSITE. MY 2002 NISSAN ALITMA 3.5L SE, STARTED GIVING ME PROBLEMS AT 57,000 MILES. IT STARTED WITH VERY HARD SHIFTING GOING FROM 1ST TO 2ND GEAR. SOMETIMES IT WOULD WORK FINE (ESPECIALLY IF THE VEHICLE WAS WARM) IF THE VEH HAS BEEN SETTING OVER NIGHT, AND YOU PUT IT INTO "DRIVE" IF WOULD SHIFT VERY HARD. IF I REVVED THE ENGINE UP BEFORE PUTTING IT INTO GEAR IT USUALLY DID NOT SHIFT HARD. UPON ENTERING THE VEHICLE ONE EVENING TO DRIVE HOME FROM WORK, THE VEHICLE WENT INTO DRIVE FINE, HOWEVER WOULD NOT SHIFT OUT OF FIRST GEAR. AS I PULLED TO THE SIDE OF THE ROAD AND HAD THE VEH TOWED TO THE NEAREST NISSAN DEALERSHIP, I WAS ADVISED THE THROTTLE CHAMBER WAS THE ISSUE AND THE TRANSMISSION NEEDED TO BE REPLACED. THIS HAS COST ME A TOTAL OF $4600.00 TO REPLACE THE TRANSMISSION, A $150.00 TOWING BILL AND THEN HAD TO RENT A RENTAL CAR UNTIL THIS WAS REPLACED. AM SEEING MANY VEHICLE COMPLAINTS WITH THIS ISSUE, INCLUDING 2 ON YOUR WEBSITE. *AK

• 11/01/2011· STRUCTURE

  2002 NISSAN FRONTIER PICK UP. CONSUMER WRITES IN REGARDS TO A SERIOUS CORROSION PROBLEM IN THE UNDER BODY; ESPECIALLY THE DRIVE SHAFT. *TGW AN INSPECTION REVEALED MAJOR RUST IN THE UNDER BODY. THE CONSUMER STATED TWO YEARS AFTER PURCHASING THE VEHICLE, A METAL GUARD COVERING THE CATALYTIC CONVERTER RUSTED OFF. *JB

• 11/01/2006· SUSPENSION

  DT*: THE CONTACT STATED SINCE THE VEHICLE WAS PURCHASED THERE WAS A KNOCKING SOUND UNDER THE REAR OF THE VEHICLE WHEN THE BRAKE PEDAL WAS DEPRESSED OR WHEN REVERSING AT 3 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT SERVICE DEALER WHO REPLACED THE REAR SHOCKS, BUT THE NOISE CONTINUED. THE SERVICE DEALER INSPECTED THE VEHICLE 5 TIMES AND COULD NOT IDENTIFY THE PROBLEM. THE MANUFACTURER WAS NOT NOTIFIED.

• 10/30/2005· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  2002 NISSAN FRONTIER. ELECTRICAL COMPONENT; ALTERNATOR/GENERATOR/REGULATOR. EXPERIENCING EXACT SAME PROBLEM AS DESCRIBED IN THE NHTSA CAMPAIGN ID #05V319000. 1) NORMAL OPERATION LEADING TO FAILURE. 2) CONSEQUENCE; BATTERY AND BRAKE WARNING LAMPS COME ON AND BATTERY BEGINS TO DISCHARGE. ENGINE GOES INTO FAIL SAFE MODE, ENGINE WILL STOP AND COULD RESULT IN CRASH. 3) DEALER WILL NOT CORRECT THE PROBLEM WITHOUT PAYMENT BECAUSE THE FRONTIER DOES NOT HAVE THIS PARTICULAR RECALL AND THE DEALER STATES THE VEHICLE HAS EXCEEDED THE 3YR WARRANTY LIMIT EVEN THOUGH THE VEHICLE WAS PURCHASED NEW 26 MONTHS AGO. *NM

• 10/29/2008· FUEL SYSTEM, GASOLINE

  I PURCHASED 2002 NISSAN FRONTIER XE AND HAVE HAD TO DO MAJOR REPAIR ON IT. CARFAX REPORTS THREE RECALLS;ONLY TWO OF WHICH I CAN CONFIRM ATTENDED TO. THE ISSUES ARE SUSPENSION AN DFUEL: THROTTLE LINKAGES AND CONTROL AND FUEL SYSTEM, GASOLINE DELIVERY:FUEL PUMP. DESPITE THE WORK I HAVE ALSO HAD DONE ON THESE ISSUES THE TRUCK STILL HAS PROBLEMS: FAILS TO ACCELERATE AT TIMES AND STEERING WHEEL SHAKES BETWEEN 60K AND 100K AND MAKES STEERING DIFFICULT. I AM TRYING TO WORK THIS OUT WITH DEALERSHIP BUT THEY ARE BEATING AROUND THE BUSH. I FEEL VERY MUCH THAT FIXING THIS VEHICLE IS LIKE CHASING GHOSTS AND THAT IT IS A LEMON. THE INCIDENT DATE IS MY DATE OF PURCHASE. *TR

• 10/28/2016· SERVICE BRAKESCrash

  BRAKES FAILED ON PUBLIC ROADWAY, COULD NOT STOP VEHICLE, CRASHED INTO WALL TO STOP VEHICLE, CAUSING SERIOUS BODILY INJURIES.

• 10/27/2004· ELECTRICAL SYSTEM

  MY NISSAN FRONTIER, 2002 MODEL, IS JUST OUT OF WARRANTY, LESS THAN 3 YEARS OLD. WITHOUT ANY WARNING COMPLETELY DIED ON INTERSTATE. I TOWED IN AND PROBLEM WAS SOMETHING ELECTRICAL WITH THE DISTRIBUTOR. I UNDERSTAND THIS VEHICLE HAS NO WARRANTY AFTER 36000 MILES HOWEVER THIS ISSUE SEEMS VERY RARE TO ME AND SHOULD BE INVESTIGATED.*AK

• 10/25/2014· FUEL SYSTEM, GASOLINE

  IN 2014 THE FUEL SENDING UNIT ATTACHED TO THE FUEL TANK HAD A 3-4 INCH GAP. EXCESSIVE FUEL SMELL (HEALTH, ENVIRONMENTAL AND FIRE HAZARD). A SIMILAR REPORT WAS MADE IN: RECEIPT DATE: MAY 24, 2004 > NHTSA CAMPAIGN NUMBER: 04V230000 > COMPONENT(S): FUEL SYSTEM, GASOLINE THESE INCIDENTS MAY BE CONNECTED AND STILL OCCURRING I HAVE PHOTOS AND DOCUMENTATION FROM THE REPAIR MADE BY A NISSAN DEALER AVAILABLE UPON REQUEST. FUEL CAN LEAK FROM THE GAP AND IF IN AN ACCIDENT CAUSE A FIRE, SERIOUS BODILY INJURY OR DEATH. I CONTACTED NISSAN NORTH AMERICA AND CASE # [XXX] WAS GENERATED. NO FURTHER ACTION ON THEIR PART HAS BEEN MADE TO INVESTIGATE THIS INCIDENT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 10/23/2003· EXTERIOR LIGHTING

  INEFFECTIVE HEADLIGHTS/2002 NISSAN FRONTIER. *LA

• 10/21/2003· SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL

  WHILE DRIVING VEHICLE SUDDENLY ACCELERATED. DRIVER APPLIED THE BRAKES, BUT THE BRAKES HAD A DELAY IN RESPONSE. EXTENDED STOPPING DISTANCE WAS NECESSARY BASED ON POOR PERFORMANCE OF BRAKES. *AK

• 10/20/2008· FUEL SYSTEM, GASOLINE

  TL*THE CONTACT OWNS A 2002 NISSAN FRONTIER. WHILE DRIVING APPROXIMATELY 60 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE SHUT OFF WITHOUT WARNING. THE ENGINE WOULD NOT RESTART AFTER SEVERAL ATTEMPTS. ROADSIDE ASSISTANCE WAS CALLED TO THE SCENE AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE FAILURE WAS RELATED TO THE FUEL PUMP. THE VEHICLE WAS REPAIRED. THE CONTACT WAS REIMBURSED BY THE MANUFACTURER FOR A PRIOR REPAIR, WHICH WAS RELATED TO A RECALL. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. RECENTLY, THE FAILURE RECURRED BECAUSE THE PREVIOUS REPAIR WAS INSUFFICIENT. THE VEHICLE HAS NOT BEEN REPAIRED AGAIN. THE FAILURE MILEAGE WAS UNKNOWN.

• 10/12/2015· STEERING,STRUCTURE,FUEL/PROPULSION SYSTEM

  THE FRAME ON THESE VEHICLES ARE UNSAFE DUE TO PERSISTENT CORROSION WHICH ALSO CARRIES THROUGHOUT OTHER PARTS UNDER THE VEHICLE LIKE THEIR STEERING. IN MY CASE, THE RUST IS SETTLING IN AND CAUSING THE FRAME TO DETERIORATE DESPITE IT ONLY HAVE 69K MILES. THE CONCERN IS OBVIOUSLY HAVING THE VEHICLE CRUMBLE DURING USE. HERE ARE JUST A FEW OTHER COMPLAINTS LISTED ON THE INTERNET BY OTHER OWNERS. HTTP://WWW.NISSANFORUMS.COM/PATHFINDER/117181-RUSTED-FRAME.HTML HTTP://NISSANPROBLEM.COM/2002-NISSAN-FRONTIER-STRUCTURE-FRAME-AND-MEMBERS-UNDERBODY-SHIELDS-PROBLEMS-DEFECTS/ HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/NISSAN_FRONTIER.HTML

• 10/11/2007· ELECTRICAL SYSTEM

  2002 NISSAN SENTRA SERVICE ENGINE LIGHT ILLUMINATED. CUSTOMER STATES THE VEHICLE WOULD NOT PASS INSPECTION WITH THE LIGHT ON. OXYGEN SENSOR WAS REPLACED AND CODE STILL REMAINED. CONSUMER FOUND A RECALL FOR THE ECM. *KB THE CONSUMER STATED THAT THE VIN WAS NOT PART OF THE RECALL, HOWEVER THE CONSUMER FEELS THIS IS AN ERROR AND WANTS TO BE REIMBURSED FOR THE REPAIRS SINCE HE EXPERIENCED THE EXACT FAILURE AS STATED IN THE RECALL. *TR

• 10/07/2014· STEERING

  I GOT A RECALL FOR THE STEERING COLUMN. I WAS TOLD THERE WOULD BE NO COST TO ME FOR LABOR AND PARTS. I TOOK MY VEHICLE TO THE DEALER AND THEY WANTED TO CHARGE ME $208 TO REMOVE SOME RUSTED BOLTS THAT HAD TO BE REMOVED TO GET TO RECALLED PART.. I GOT IN TOUCH WITH NISSAN CORP. THEY REVIEWED THE INFORMATION AND SENT ME A LETTER STATING "IT FALLS OUTSIDE THE PARAMETERS OF THE NEW VEHICLE LIMITED WARRANTY". MY COMPLAINT IS, WHY SHOULD I HAVE TO PAY ANYTHING FOR A RECALLED PART. IF THE PART WAS NOT FAULTY I WOULDN'T BE REMOVING THOSE BOLTS ANYWAY. I THINK NISSAN CORP. SHOULD INCUR ANY COST ASSOCIATED WITH REPLACING THE RECALL ON THE "COMPLETE STEERING COLUMN RECALL". *TR

• 10/04/2010· SUSPENSION

  TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS TO THE REAR SEALS UNDER NHTSA CAMPAIGN ID NUMBER: 02V299000 (SUSPENSION:REAR) IN 2003. ONE YEAR LATER, THE LEFT REAR SEAL BEGAN LEAKING ON THE AXLE. THEN, IN 2005 THE WHEEL ASSEMBLY FRACTURED FROM THE AXLE BECAUSE THE SEAL FAILED A SECOND TIME. IN TOTAL, THE CONTACT HAS HAD THE SEALS REPLACED SEVEN TIMES AND MOST RECENTLY, THE CONTACT WAS ADVISED BY THE DEALER THAT THE REAR HOUSING WAS DEFECTIVE. THE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 21,000.

• 10/03/2014· STEERING

  TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SEIZED AND MADE A CRACKING SOUND. THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 10V554000 (STEERING), BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE STEERING COLUMN WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

• 09/30/2011· FUEL SYSTEM, GASOLINE

  TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT HE NOTICED THAT THE FUEL TANK WAS LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THERE WAS SEVERE RUSTING AND SMALL PIN HOLES IN THE GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THE COMPONENT WAS NO LONGER WAS BEING MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. THE VIN WAS UNAVAILABLE.

• 09/28/2006· POWER TRAIN

  I TOOK MY TRUCK INTO BROWNS FAIRFAX NISSAN DEALERSHIP REGARDING THE OVERDRIVE INDICATOR LIGHT ON THE DASHBOARD WAS COMING ON/OFF WHILE I WAS DRIVING. I SPOKE WITH A FEW MECHANICS REGARDING THIS ISSUE, THEY INFORMED ME THAT IT COULD BE THE TRANSMISSION AND THAT IT SHOULD BE COVERED UNDER NISSANS WARRANTY, I WAS ADVISED TO CHECK THE INTERNET. AFTER CHECKING THE INTERNET, I LOCATED THE RECALLS AND FOUND MY CAR ON THEIR LISTINGS. I CALLED NISSANS RECALL DEPARTMENT, SPOKE WITH SOLOMON KIRK ABOUT THE ISSUE I WAS HAVING WITH MY TRUCK. MR. KIRK WENT OVER NISSANS WARRANTY COVERAGE (COVERAGE LISTED BELOW) WITH ME, HE TOLD ME TO GO TO ANY DEALERSHIP TO TAKE CARE OF THE PROBLEM AND HE SAID THAT HE WOULD CALL THEM TO LET THEM KNOW THAT I WAS BRINGING MY TRUCK IN REGARDING THE ISSUE WE COVERED. I TOLD MR. KIRK THAT IN THE PAST I HAVE TAKEN MY TRUCK TO BROWS FAIRFAX NISSAN. I TOOK MY TRUCK TO BROWNS FAIRFAX NISSAN ON SEPTEMBER 25, 2006 AND PICKED UP A RENTAL CAR. I RECEIVED A CALL THAT EVENING FROM CHARTER WELLS, THEY COULD NOT FIND OUT WHAT THE PROBLEM WAS AND WOULD HAVE TO KEEP IT OVER NIGHT. ON SEPTEMBER 26 I RECEIVED A CALL FROM CHARTER WELLS, HE SAID THE FUEL SENDING UNIT WAS REPLACED (RECALL ISSUE), I ASK HIM DID THAT TAKE CARE OF THE ISSUE WITH THE OVERDRIVE LIGHT HE SAID NO BUT I WOULD NEED MY TRANSMISSION FLUSHED BECAUSE IT IS DIRTY. AFTER THINKING ABOUT THE FUEL SENDING UNIT BEING REPLACED AND THAT DID NOT TAKE CARE OF THE ISSUE, I THOUGHT TO GO BACK TO MY MECHANIC FOR HIS ADVICE. I DID NOT HAVE THE TRANSMISSION FLUSHED. ON SEPTEMBER 28, 2006 I WENT TO MY MECHANIC AND INFORMED HIM OF THE WORK THAT WAS DONE ON MY TRUCK FROM BROWNS FAIRFAX NISSAN AND THE ISSUE WITH THE OVERDRIVE LIGHT. OIL CHANGED AND TIRES BALANCED/ROTATED ISSUE HE INFORMED ME THAT THE TRANSMISSION WAS GOING BAD AND IT SHOULD HAVE BEEN COVERED UNDER THE NISSANS WARRANTY. HE ALSO CHECKED THE TRANSMISSION FLUID TO SEE IF IT WAS DIRTY AND IT WASN'T. *JB

• 09/26/2002· SUSPENSION

  CONSUMER STATES THAT WHILE DRIVING "PARTS" FELL OUT OF PASSENGER SIDE OF SUSPENSION SYSTEM. VEHICLE WAS REPAIRED BY DLR WHO ALSO STATED THEY PERFORMED A FULL INSPECTION OF SUSPENSION SYSTEM. 1 WEEK LATER "PARTS" FELL OUT OF DRIVER'S SIDE SUSPENSION. *MR

• 09/26/2002· POWER TRAIN

  CONSUMER STATES THAT DRIVE LINE FAILED WHEN VEHICLE HAD APPROX 15K-18K MILES. *MR