2002 Mercury Mountaineer

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2009· SUSPENSION,VISIBILITY,STRUCTURE

  ON COLD MORNINGS, THE FRONT WINDSHIELD FOGS/FROSTS UP. TURNING HEAT ON AND SELECTING DEFROST PROVIDES LITTLE TO NO AIR TO WINDSHIELD. DEALERSHIP IDENTIFIED IT AS A BROKEN VENT SELECT DOOR, REQUIRING DASHBOARD TO BE REMOVED AND PART REPLACED, $1100 FIX. IN DOING RESEARCH ON THE VENT SELECT DOOR - CARS ARE DESIGNED THAT IF THE SELECTOR BREAKS THAT THE AIR SHOULD DEFAULT TO THE FRONT DEFROST SO THAT WINDSHIELD WOULD NOT FOG/FROST AND CAUSE A LIFE THREATENING SITUATION. MULTIPLE TIMES THIS HAS OCCURRED WHILE DRIVING, ALL ALONG BELIEVING THAT THE FOGGING UP WAS DUE TO SNOW BUILD UP ON OUTSIDE VENTS. THE FACT THAT THE VENT BROKE AND DID NOT PUSH AIR TO THE WINDSHIELD IS WHY I'M LOGGING THIS COMPLAINT AS IT COULD HAVE RESULTED IN A LIFE THREATENING SITUATION. IN READING THE OTHER ENTRIES, NOTING THAT I'VE HAD TO HAVE THE REAR COIL SPRINGS REPLACED AND HAD BACK LIFTGATE REPLACED AFTER CRACKING. *TR

• 12/30/2004· TIRES

  I LEFT MY AUTOMOBILE, 2002 MERCURY SABLE, AT THE DEALERSHIP FOR ITS 25,000 MILE MAINTENANCE AND ASKED THEM TO LOOK AT THE FRONT END AS IT WAS SHIMMERING OVER 40 MPH. I WAS TOLD THAT ALL FOUR TIRE WALLS WERE CRACKING AND THAT THE TIRES HAD TO BE REPLACED AT MY COST LESS ALLOWANCE. I WAS FURIOUS AND CALLED SEVERAL PEOPLE AT THE DEALERSHIP AND THE TIRE COMPANY TO COMPLAIN. THE TIRE COMPANY TOLD ME THAT CRACKED SIDEWALLS WERE COVERED IN THE WARRANTY AND IF IT WAS NOT THE TIRES SHOULD BE REPLACED AT NO COST TO ME. THE DEALERSHIP TOLD ME THIS WAS NOT COVERED YET AFTER I CALLED THE TIRE COMPANY THE SAID THAT SOME OF THE MANAGEMENT PEOPLE AT THE DEALERSHIP LEARNED OF MY PROBLEM AND GAVE THE SERVICE DEPARTMENT ORDERS TO REPLACE THE TIRES AT NO COST WITHOUT CALLING THE TIRE COMPANY. THEY ALSO SPECIFIED THAT THE TIRES WOULD HAVE TO BE SHIPPED BACK TO FORD MOTOR COMPANY. THE WHOLE THING SMELLS OF A COVER-UP BECAUSE OF THE IMMEDIATE TURN AROUND AT THE DEALERSHIP WHEN I MENTIONED A LAWSUIT. ALL FOUR OF THESE TIRES COULD HAVE BLOWN ONE AT A TIME OR TOGETHER CAUSING INJURY AND I DO NOT FEEL GOOD ABOUT THIS. *AK

• 12/29/2014· ELECTRICAL SYSTEM,STRUCTURE

  THE CAR WOULD HAVE A WARNING DISPLAY THAT A DOOR WAS AJAR AND WE WOULD CHECK ALL THE DOORS AND RE-CLOSE THEM ALL AND THE WARNING WOULD STILL APPEAR. THEN WE WOULD CHECK THE LIFT GATE WINDOW ON THE BACK AND RE-CLOSE IT AND THE DISPLAY WOULD GO AWAY, BUT THE LIFT GATE WAS CLOSED THE WHOLE TIME BEFORE. IT CONSTANTLY DOES THIS AND NOW THE LIFT GATE HAS A CRACK IN IT. *TR

• 12/29/2008· POWER TRAIN

  ON DEC. 19, 2008, THE O/D LIGHT BEGAN TO FLASH AND THEN ON DEC.26TH THE SERVICE ENGINE SOON LIGHT CAME ON. AS I WAS DRIVING THE CAR BEGAN TO REV UP WHEN I WAS NOT MASHING THE GAS. I HAVE NOT DRIVEN IT SINCE. I CALLED THE FORD DEALERSHIP AND WAS TOLD TO DO A DIAGNOSTIC TEST ON IT, IT WOULD COST $98 PER ISSUE. I SEARCHED THE ISSUE ONLINE AND FOUND THAT MANY PEOPLE HAVE COMPLAINED ABOUT THIS AND HAVE PAID THOUSANDS OF DOLLARS TO HAVE IT FIXED. I WOULD LIKE TO KNOW IF THIS IS A RECALLABLE ISSUE DUE TO THE ABOUT OF COMPLAINTS? I JUST SPENT $300 HAVING THE DOOR AJAR SENSOR FIXED, SOMETHING THAT OTHERS HAVE ALSO COMPLAINED ABOUT. *TR

• 12/29/2004· UNKNOWN OR OTHER

  I RECENTLY HAD MY BACK HALFWAY HATCH ON MY 2002 MERCURY MOUNTAINEER TO FALL ON ITS ON FROM NO APPARENT REASON. I TOOK MY CAR TO THE DEALERSHIP, UPON TALKING WITH THE CUSTOMER SERVICE SPECIALIST'S WAS SAID IT WOULD HAVE TO BE AN OUT OF POCKET REPAIR. HOWEVER THIS HAD HAPPEN AT NO FAULT TO ME. I BELIEVE THAT IT IS A WARRANTY ISSUE AND SHOULD BE REPLACED WITH NO CHARGE TO ME. THE CSS ALSO SAID IT WOULD PROBABLY COST ME RIGHT AT 5 TO 6 HUNDRED DOLLARS. I EVEN HAD PURCHASED AN EXTENDED WARRANTY BUT IT SEEMS TO BE A LITTLE USELESS. PLEASE HELP. THANKS. P.S. I AM NOT CERTAIN ABOUT THE EXACT DAY OF THE BREAKAGE BUT IT WAS NEAR THE FOLLOWING DAY. *NM

• 12/29/2003· SUSPENSION

  WHILE DRIVING 55 MPH HEARD A KNOCKING NOISE COMING FROM THE REAR. CONSUMER TOOK VEHICLE TO DEALER FOR ANALYSIS, AND MECHANIC COULD NOT RESOLVE THE PROBLEM. *AK

• 12/28/2005· POWER TRAIN

  2002 MERCURY MOUNTAINEER - MARCH 2005 - 46,000 MILES SOLENOID WAS REPLACED COST $600 - DECEMBER 2005 - 60,000 MILES - TRANSMISSION LIGHT ON - IN SHOP NOW TO REPLACE TRANSMISSION OR PARTS - COST OF $2,300. I HAVE FOUR PERSONAL FRIENDS WHO HAVE ALSO HAD TROUBLE WITH THE FORD ENGINE. WE HAD RECEIVED NUMEROUS FORMS FOR EXTENDED WARRANTY. SEEMS THAT A 3 YEAR OLD CAR BOUGHT NEW AND STILL NOT PAID FOR SHOULD HAVE A GOOD WORKING TRANSMISSION. THIS IS A DEFECT IN MERCURY WHICH SHOULD BE FIXED AND CONSUMERS SHOULD NOT BE FORCED TO PAY FOR THIS REPAIR OR FOR AN EXTENDED WARRANTY. WHY IS MERCURY SO INSISTENT ON AN EXTENDED WARRANTY? MERCURY MUST KNOW THAT SOMETHING IS WRONG WITH THE TRANSMISSION IN THE CAR. *JB

• 12/28/2004· VISIBILITY

  AFTER HAVING THE RECALL FOR THE LIFTGATE REPAIRED, THE PLASTIC IS BEGINNING TO CRACK. THE CONSUMER STATES THAT THE VEHICLE WAS NOT HAVING ANY PROBLEMS PRIOR. *JB.........*AK

• 12/28/2004· STRUCTURE

  NHTSA CAMPAIGN 01I010000; FORD ISSUED A LIFTGATE GLASS RECALL. THIS VEHICLE IS INCLUDED IN THE RECALL, BUT THE DEALER STILL DOES NOT HAVE THE PARTS AVAILABLE IN ORDER TO REPAIR THE VEHICLE. *JB.....*AK

• 12/27/2023· STEERING

  Aftermarket rack and pinion system re-manufactured by Detroit Axel began leaking fluid and caused a loss of power steering within 3 months of purchase. A second unit was installed and after about a year had the exact same failure as the first unit. Also resulting in the loss of power steering. It is my contention that Detroit Axel is not capable of re-manufacturing to a satisfactory safety standard. I believe they should be investigated and perhaps subject to a product recall. I pray nobody has yet been killed by their ineptitude!

• 12/26/2006· STRUCTURE

  TL* - THE CONTACT STATED WHILE VEHICLE WAS PARKED AND WHEN SHE WAS CLOSING HER LIFTGATE CYLINDER DETACHED. WEATHER CONDITION AT THE TIME OF THE INCIDENT WAS A RAINY DAY AND TEMPERATURE AROUND 50 DEGREES. *AK

• 12/23/2004· EQUIPMENT

  SUDDEN FLOW OF VERY HOT AIR FORM THE AIR VENTS. *BF THE PROBLEM HAPPENED WHEN THE AIR CONDITION WAS OFF AND THE AIR BLOWER OR FAN WAS TURNED ON. HOWEVER THE PROBLEM NOW HAPPENS WHEN THE AIR CONDITION IS ON. *JB

• 12/21/2007· POWER TRAIN

  ON MY 2002 MERCURY MOUNTAINEER, THE TRANSMISSION FAILED AND HAS TO BE REBUILT AT 70,000 MILES. AFTER READING SEVERAL WEBSITES, IT IS APPARENT THAT THIS HAS BEEN A VERY COMMON AND ONGOING PROBLEM THAT SHOULD QUALIFY IT FOR A RECALL. *TR

• 12/21/2004· VISIBILITY

  THE WINDSHIELD WIPERS WORK VERY SLOW AND THE WASHER SPRAYS ALL OVER THE WINDSHIELD AND WILL NOT STOP. THE CONSUMER TOOK THE VEHICLE TO THE DEALER WHO REPLACED, THE MULTI FUNCTION SWITCH, AND THE PROBLEM CONTINUES. *NM THE PROBLEM RECURRED. THE CONSUMER WAS TOLD ON TWO OCCASIONS THAT THE PROBLEM WAS UNABLE TO BE DUPLICATED. THE CONSUMER WAS ALSO INFORMED THAT THE MICRO PROCESSOR ASSEMBLY NEEDED TO BE REPLACED. CURRENTLY THE PROBLEM COULD NOT BE DUPLICATED. *SC *JB

• 12/20/2004· POWER TRAIN

  TRANSMISSION: UPON PARKING THE VEHICLE CONSUMER HEARD A NOISE. VEHICLE VIBRATED, UPON TRYING TO USE THE VEHICLE AGAIN THE GEARS WOULD NOT GO INTO REVERSE OR DRIVE. *AK

• 12/19/2009· STRUCTURE

  REAR TAILGATE LATCH BRAKES ACROSS THIS IS A KNOW ISSUE WITH ALL FORD EXPLORERS AND MERCURY MOUNTAINEERS. IT'S OBVIOUSLY A BAD DESIGN FROM FORD MOTOR CO. FORD NEEDS TO RECALL THIS AND IT'S THEIR DESIGN AND IT ALSO CAN REPRESENT AN INJURY TO SOMEONE IF A PIECE WAS TO FALL OFF AND HIT ANOTHER CAR. *TR

• 12/19/2006· LATCHES/LOCKS/LINKAGES

  MERCURY MOUTAINEER 2003, THE HATCH OF THE CAR JUST CAME DOWN AND HIT HER, SHE JUMPED BACK AND THE DOOR CONTINUED TO CLOSE AND THE WINDOW SHATTERED. CONTACT LEARNED THAT THE CAR DOOR HAS A SAFETY RECALL AND TOOK IT TO THE DEALERSHIP FOR REPAIR. CONTACT WAS TOLD THAT THE SAFETY RECALL HAD ALREADY BEEN REPAIRED ON HER CAR AND THAT SHE WOULD HAVE TO PAY TO HAVE IT REPAIRED AGAIN. CONTACT WANTS TO KNOW WHAT SHE CAN DO NOW. DOESN'T FEEL SHE IS RESPONSIBLE BECAUSE IT IS A SAFETY RECALL.

• 12/18/2002· VISIBILITY

  CONSUMER LEFT HER REAR BACK HATCH OPEN, AND CLOSED THE GARAGE DOOR. THE HATCH GLASS EXPLODED UPON IMPACT OF THE GARAGE DOOR. CONSUMER FEELS THAT "THE GLASS IN UNSAFE , CAUSE IF THE GLASS HAD IMPLODE IN AN ACCIDENT, IT COULD OF CAUSE SERIOUS INJURIES TO THE OCCUPANT. PLEASE PROVIDE MORE DETAILS. TS ORIG PART OF LIFTGATE INVEST, BUT LATER DET. TO BE NOT RELATED TO INVESTIGATION_PCO

• 12/17/2007· SUSPENSION

  NOTICED SLIGHT ROARING NOISE IN REAR SUSPENSION. FIGURED IT WAS A WHEEL BEARING THAT WAS WORN, WHICH IS WHAT IT WAS, BUT IN LOOKING AT THAT ISSUE SAW THAT REAR PASSENGER COIL SPRING WAS BROKEN. VEHICLE STANCE DID NOT INDICATE A BROKEN SPRING. CHECKED THE DRIVER SIDE TO BE SAFE AND NOTED THAT REAR SPRING WAS BROKEN IN TWO PLACES AND LOOKED AS IF IT WAS TO COME OFF THE BOTTOM SPRING/STRUT CUSHION. AS A RESULT OF THIS MECHANIC INDICATED BROKEN SPRINGS HAD CREATED PREMATURE WEAR OF REAR TOE LINKS. I AM CURRENTLY LOOKING FOR REPLACEMENT PARTS. THIS VEHICLE HAS SEEN NO OFF-ROAD USE OR BEEN USED TO CARRY HEAVY CARGO LOADS. LADY DRIVEN ONLY. *TR

• 12/16/2003· SERVICE BRAKES, HYDRAULIC

  THE ANTI-LOCK BRAKE SYSTEM FAILED. IT WAS SERVICED BUT THE SERVICE TECHNICIAN STATED IT NEEDED A NEW PART TO MAKE THE BRAKES EFFECTIVE. PROVIDE FURTHER DETAILS............................................ *JB

• 12/15/2005· POWER TRAIN

  COPY OF EMAIL SENT TO MERCURY DIVISION OF FORD MOTOR COMPANY: ON 12/9 I HAD TO TAKE MY 2002 MOUNTAINEER, WITH ONLY 46,000 MILES ON IT, TO FINNIN FORD IN DUBUQUE. I WAS TOLD I NEEDED A "NEW" TRANSMISSION!! I CALLED FORD TO EXPLAIN THE PROBLEM AND THIS PAST MONDAY (12/12) I GOT A CALL BACK THAT FORD WAS ONLY GOING TO PICK UP $1200.00 OF A $3000.00 REPAIR BILL. LAST NIGHT I PICKED UP MY VEHICLE FROM THE DEALERSHIP, BUT ONLY AFTER PAYING $1800.00!! THE REPLY FROM THE FORD CUSTOMER REP WAS THAT BECAUSE I DID NOT PAY FOR THE EXTENDED WARRANTY, I WAS STUCK FOR THE MAJOR PORTION OF THIS BILL. THIS IS NOT ACCEPTABLE!! BEFORE I SEEK LEGAL COUNSEL, I WOULD LIKE TO OFFER FORD/MERCURY ONE LAST CHANCE TO DO WHAT SHOULD OF BEEN DONE IN THE FIRST PLACE FOR A VERY LOYAL CUSTOMER (2 EXPLORERS & 2 MOUNTAINEERS). FORD/MERCURY SHOULD HAVE REPLACED THIS TRANSMISSION AT NO CHARGE. A TRANSMISSION FAILURE AT 46,000 MILES ON A 2002 SUV SHOULD NOT HAVE HAPPENED AND BECAUSE IT DID, THE MANUFACTURE SHOULD BE FIXING THE PROBLEM AT NO CHARGE TO THE CUSTOMER. OH, AND DID I MENTION THAT ACCORDING TO THE DEALERSHIP, THIS WAS THE SECOND SUCH PROBLEM THIS WEEK. IF FORD MOTOR CO. HAS A TRANSMISSION PROBLEM, THEY SHOULD OWN UP TO IT AND FIX THE PROBLEM. I AM ALSO A LONG STANDING MEMBER OF CONSUMER REPORT, AND I WILL BE ADVISING THEM OF THIS ISSUE AS WELL AS THE NATIONAL SAFETY COUNSEL. PLEASE RESPOND TO THIS EMAIL BY 12/20/2005. THANK YOU, DAVE GRALL. *NM

• 12/14/2010· STRUCTURE,EQUIPMENT

  HIT THE REMOTE CONTROL BUTTON TO OPEN THE REAR HATCH FOR THE 2002 MERCURY MOUNTAINEER. THE REAR HATCH OPENED ONLY HALFWAY AUTOMATICALLY, AS IT IS SUPPOSE TO OPEN FURTHER I PUSHED IT UP, WITHOUT UNUSUAL FORCE AND THE ENTIRE REAR WINDOW SHATTERED, AND THE ENCASEMENT THAT HELD IT HIT ME IN THE HEAD RATHER HARD. IT IS NOW WITHOUT A WINDOW. THIS IS THE SECOND WINDOW REPLACEMENT. THE FIRST REAR WINDOW WAS REPLACED IN 2004 WHEN, DURING A COLD SNAP HERE IN NY IT SPIDERED INTO A CRACK BUT DID NOT SHATTER. WHEN MY HUSBAND TOOK IT TO THE DEALER AS IT WAS STILL UNDER WARRANTY THEY ARGUED AT FIRST, BUT THEN THE PHONE STARTED TO RING AND THEY DECIDED IT WAS AN ONGOING PROBLEM AND DESIGN "FLAW". *TR

• 12/10/2007· POWER TRAIN

  AFTER READING OTHER COMPLAINTS REGARDING 2002 MOUNTAINEERS AND EXPLORERS, I CAN HARDLY TYPE I AM SO FRUSTRATED. THE NUMBER OF POWER TRAIN COMPLAINTS FOR THIS YEAR, MAKE AND MODEL ARE ASTOUNDING. THE TRANSMISSION IN MY 2002 MOUNTAINEER (AKA MONEY SUCKER) NEEDS TO BE REPLACED. THE CAR IS CURRENTLY BEING FIXED AT THE FORD DEALER FOR $3500. THE CAR HAS ALWAYS HAD A FUNNY SHUTTER WHEN SHIFTING FROM 2ND TO 3RD AS WELL AS HESITATION WHEN DROPPING INTO REVERSE AND DRIVE. WHILE DRIVING IN ICY CONDITIONS YESTERDAY MY WIFE THOUGHT HER TIRES WERE SPINNING WHEN SHE WAS TRYING TO PROCEED AT A STOP LIGHT. SHE THANKFULLY AVOIDED BEING REAR ENDED BY A SEMI THAT WAS ABLE TO SWERVE ONTO THE APRON AND AVOID CONTACT WITH HER. SHE WAS ABLE TO LIMP THE CAR TO THE SIDE OF THE ROAD WHERE SHE THEN CALLED ME. AFTER I ARRIVED, I ATTEMPTED TO GET THE CAR TO THE FORD DEALERSHIP WHERE IT COULD BE DIAGNOSED. HOWEVER, THE CAR WOULD ONLY REACH 30MPH AND THE RPMS WERE AT 4,000 TO 5,000 AT THAT SPEED. THE OVERDRIVE LIGHT FLASHED AND THE CHECK ENGINE LIGHT CAME ON. I PARKED IT AND REMOVED THE BATTERY CABLES FOR 10 MINUTES TO SEE IF THE COMPUTER WOULD RESET ITSELF ? THIS DID NOT HELP. IN FACT, THE CAR WOULD NOT EVEN MOVE IN DRIVE OR REVERSE. HAD THE DEALER PICK IT UP TO GET IT FIXED. THIS CAR HAS 108,000 MILES ON IT ? NOT EXACTLY KNEW THIS IS TRUE, BUT IT SOUNDS LIKE I WAS ONE OF THE LUCKY ONES TO GET THAT MANY MILES OUT OF IT ? FROM THE REPORTS I'VE READ ON THE INTERNET. HAVE ALSO EXPERIENCED AND REPLACED FRONT LEFT BEARINGS, REAR LEFT BEARING AND HAVE THE PROBLEM WITH THE STEERING THAT MANY HAVE REPORTED ON THIS VEHICLE (BINDING, TENSION, CAN'T MAKE FULL TURNS, POPPING SOUNDS). *TR

• 12/09/2008· STRUCTURE

  WHEN APPROACHING MY VEHICLE (2002 MERCURY MOUNTAINEER) FROM BEHIND, I NOTICED A CRACK IN THE CENTER OF THE LIFTGATE PANEL, BEGINNING AT THE BOTTOM OF THE WINDOW AND EXTENDING TO THE HANDLE. I RESEARCHED THIS ON THE INTERNET AND FOUND THAT IT IS A PROBLEM WHICH HAS OCCURRED IN FORD-MANUFACTURED SUVS, INCLUDING THE MOUNTAINEER AND EXPLORER. I CALLED THE SERVICE MANAGER OF THE DEALERSHIP WHERE I PURCHASED THE VEHICLE. HE WAS FAMILIAR WITH THE PROBLEM AND STATED THAT THE PANEL WILL NEED TO BE REPLACED. SINCE THERE IS NO RECALL ISSUED, THERE WAS NOTHING HE COULD DO. I THEN CALLED FORD CUSTOMER SERVICE AND SPOKE TO A PERSON WHO TOLD ME THAT FORD COULD NOT PROVIDE ASSISTANCE SINCE MY VEHICLE WAS OUT OF WARRANTY. SINCE THIS IS AN OBVIOUS DEFECT IN THE PRODUCT, I BELIEVE THAT FORD SHOULD ISSUE A RECALL AND COVER THE REPAIR COST. FORD SHOULD STAND BEHIND THE QUALITY OF ITS VEHICLES AND IF THERE IS A PROBLEM, THEN IT SHOULD PROVIDE THE CUSTOMER WITH A SATISFACTORY REMEDY. *TR

• 12/09/2003· STRUCTURE

  WITHOUT WARNING RIGHT SIDE LIFTGATE HINGE SNAPPED, CAUSING THE LIFTGATE TO HIT THE CONSUMER IN THE CHEST.*AK PE04045_PCO

• 12/08/2004· LATCHES/LOCKS/LINKAGES

  FORD WILL NOT PROVIDE ANY INFORMATION AT THEIR 1-866-436-7332 NUMBER REGARDING THE CURRENT STATUS OF WHEN PARTS WILL BE AVAILABLE FOR RECALL # 04S20 - MERCURY MOUNTAINEER REAR LIFTGATE WINDOW. THE LETTER SENT IN EARLY OCTOBER SAID THE PARTS WOULD BE AVAILABLE IN LATE NOVEMBER. TWICE WHEN I ASKED TODAY TO SPEAK TO A SUPERVISOR, I WAS PUT ON HOLD & DISCONNECTED. *JB

• 12/07/2009· POWER TRAIN

  2002 MERCURY MOUNTAINEER V6 AWD 130,000MILES! TRANSMISSION PROBLEMS O/D LIGHT FLASHING ONE DAY CAUSING TRANSMISSION NOT TO SHIFT CORRECTLY. TEN MINUTES LATER START THE VEHICLE AND LIGHT NOT ON AND TRANSMISSION SHIFTS FINE. HAPPENS ON SEVERAL OCCASIONS. SEVERAL WITH SIMILAR VEHICLES HAVE REPORTED SAME PROBLEMS! ALSO HAS WHEEL BEARING ISSUES! *TR

• 12/06/2004· ENGINE AND ENGINE COOLING

  CONSUMER CALLED AND REQUESTS SEVERAL TIMES FOR CERTAIN PARTS. IT HAS BEEN SEVERAL MONTHS AND DEALER HAS NOT RESPONDED. CONSUMER WAS WAITING TO GET VEHICLE SERVICED.*AK

• 12/05/2005· ENGINE AND ENGINE COOLING

  I HAD A SPARK PLUG BLOW OUT OF MY 2002 MERCURY MOUNTAINEER 4.6L ENGINE. THE CAR HAS 86,000 MILES ON IT BUT THIS IS THE SECOND ENGINE. THE ORIGINAL ENGINE WAS REPLACED IN DEC 2003 WHEN IT HAD 49,000 MILES ON IT. THE ORIGINAL ENGINE SEIZED UP AFTER AN OIL PUMP FAILURE. *NM

• 12/04/2006· POWER TRAIN

  2002 MERCURY MOUNTAINEER - TRANSMISSION FAILED SEVERAL TIMES ON WAY TO WORK THIS MORNING WHILE PULLING ONTO HIGHWAYS. CAR TAKEN TO TRANSMISSION SHOP AND WE HAVE BEEN TOLD THAT THE TRANSMISSION IS GONE AND WILL COST $2,400 TO REPAIR. MECHANIC ALSO STATED THAT THIS IS A KNOWN PROBLEM IN MOUNTAINEERS BUT HAS NOT BEEN RECALLED AS IT IS NOT DEEMED A SAFETY HAZARD. APPARENTLY THE CAR MAKER HAS NOT BEEN IN SUCH A CAR WHEN THIS HAPPENS ON A BUSY FREEWAY! WE ALSO HAD NO INDICATIONS OF A PROBLEM PRIOR TO THIS HAPPENING. *NM

• 12/02/2004· EXTERIOR LIGHTING

  CONSUMER NOTICED THAT THE TAIL LIGHTS WERE INOPERATIVE. THE TAIL LIGHTS STAYED ON WHILE THE VEHICLE WAS TURNED OFF. CONSUMER WILL CONTACT THE DEALER IN THE NEAR FUTURE. *AK

• 12/02/2002· STEERING

  CONSUMER CALLED COMPLAINING ABOUT HAVING A PROBLEM WITH A STRONG VIBRATION ON THE WHOLE VEHICLE AND ALSO ON THE STEERING WHEEL.DEALER WAS CONTACTED AND THEY FIRST STATED THAT THERE WERE THE TIRES THEN ALSO THE SHOCKS ON THE BACK WERE CAHNGED AND THE VEHICLE STILL HAS THE SAME PROBLEM. PH

• 12/02/2002· ENGINE AND ENGINE COOLING

  THE EXHAUST PIPE HAD SOME WAY BENT WHICH CAUSED THE PIPE TO GET CLOSE TO THE REAR FENDER. THE REAR FENDER WAS MADE OF SOME SORT OF PLASTIC WHICH MELTED FROM THE EXHAUST PIPE. THE OWNER WAS TOLD "THE ONLY WAY THAT THE PIPE COULD HAVE BEEN DISFIGURED IF YOU RAN OVER A SPEED BUMP". THE OWNER DOES NOT RECALL DOING THAT OR OVER LOADING THE TRUCK. TS RECONDITIONED BUMPER, ABSORBER, REFLECTOR HAD TO BE REPLACED. *TT

• 12/01/2008· SUSPENSION,TIRES

  TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE VEHICLE HAS TOYO OPEN COUNTRY AT TIRES, SIZE P22570R15 (NA). THE TIRES WERE PURCHASED BRAND NEW IN MAY OF 2007 FROM JENSEN TIRE COMPANY WHILE DRIVING 15 MPH. AT 36,000 MILES, THE REAR PASSENGER TIRE BLEW OUT IN JUNE OF 2008. THE REPAIR SHOP STATED THAT THE TIRE WAS WORN DOWN TO THE STEEL. THE TIRE COMPANY FROM WHERE THE TIRE WAS PURCHASED IS PROVIDING REIMBURSEMENT FOR THE FAILED TIRE. THE REMAINING TIRES WERE INSPECTED BY OTHER SHOPS AND EACH SHOP RECOMMENDED THAT THE REST OF THE TIRES BE REPLACED. TOYO STATED THAT THE TIRES NEEDED AN ALIGNMENT. THE CONTACT STATED THAT AN ALIGNMENT HAD JUST BEEN PERFORMED; HOWEVER, THE MANUFACTURER ADVISED HER TO HAVE ANOTHER ONE. WHILE THE VEHICLE WAS AT THE SHOP, THE MECHANIC STATED THAT THE BALL JOINTS WERE DEFECTIVE DUE TO THE DAMAGE CAUSED BY THE TIRES AND NEEDED TO BE REPLACED. THE BALL JOINTS HAVE NOT BEEN REPLACED AND THE MANUFACTURER IS REFUSING RESPONSIBILITY FOR THE REPAIRS. THE FAILURE MILEAGE WAS 34,200 AND CURRENT MILEAGE WAS 123,402.

• 11/30/2012· POWER TRAIN

  THE SHIFT LEVER SNAPPED OFF, IN REVERSE, WHILE ATTEMPTING TO PUT INTO PARK. THE LEVER BROKE IN SUCH A WAY THAT THE VEHICLE WAS STUCK IN GEAR WITH NO MEANS TO PUT IN PARK. THE BASE OF THE LEVER THAT OPERATES THE GEAR CHANGE MECHANISM APPEARS TO BE MADE OF POROUS METAL. I WAS FORCED TO LEAVE MY VEHICLE IN REVERSE, WITH THE KEYS STUCK IN THE IGNITION, UNTIL I WAS ABLE TO ARRANGE A TOW. THANKFULLY I WAS NOT IN TRAFFIC, ON A HILL WHEN THIS HAPPENED. I WAS ABLE TO PLACE SOME ITEMS BEHIND THE WHEELS TO PREVENT ROLLING (EMERGENCY BRAKE DOES NOT WORK WELL). THIS APPEARS TO BE A COMMON PROBLEM AS THERE ARE NUMEROUS DOCUMENTED COMPLAINTS (ENOUGH THAT A PARTS MANUFACTURER HAS COME UP WITH A MORE DURABLE REPLACEMENT PART). *TR

• 11/30/2010· ELECTRICAL SYSTEM

  TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE WIRING HARNESS IN THE DOOR WAS EXPOSED. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 170,000. UPDATED 01/26/11*LJ THE CONSUMER STATED THE WINDOWS WOULD NOT GO UP OR DOWN. UPDATED 03/25/11

• 11/30/2010· POWER TRAIN

  TL*THE CONTACT OWNS A 2002 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE GEARS FAILED AND WOULD NOT SHIFT FROM THE PARK POSITION INTERMITTENTLY. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT BELIEVED THE COLUMN SHIFT TO BE THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. THE VIN WAS UNAVAILABLE. UPDATED 01/26/118LJ UPDATED 02/11/11

• 11/30/2005· AIR BAGSCrash

  DT: THE CONTACT'S VEHICLE WAS INVOLVED IN A HEAD ON COLLISION WITH A TREE WHILE DRIVING AT 45 MPH. UPON IMPACT, THE FRONT AIR BAGS DID NOT DEPLOY. THERE WAS ONE INJURY REPORTED. THE INSURANCE COMPANY WAS NOTIFIED AND A REPORT WAS TAKEN. THE MANUFACTURER WAS CONTACTED. THEY REQUESTED THAT THE VEHICLE BE DELIVERED TO THEM FOR ANALYSIS. THE INSURANCE COMPANY HAD ALREADY TAKEN THE VEHICLE. A POLICE REPORT WAS TAKEN. *AK UPDATED 12/19/05. *JB

• 11/29/2001· EQUIPMENT

  WARNING IN OWNERS MANUAL STATED DO NOT MODIFY HEADLINER ON VEHICLE WITH SIDE AIR BAGS, ALSO DEALER PUT SUNROOF IN VEHICLE FROM WHICH HEADLINER HAD TO BE TAKEN OUT, THIS VEHICLE WAS MODIFIED WITH NO REGARD FOR WARNING IN OWNERS MANUAL. CONTACTED DEALER, AND NO RESPONSE FROM DEALER OR FORD CUSTOMER SERVICE.*AK *SLC

• 11/28/2004· ENGINE AND ENGINE COOLING

  NOTICED A STRONGE SMELL OF GAS IN OUR GARAGE. WHEN WE BACKED OUT THERE WAS A LARGE SPOT ON THE GARAGE FLOOR. WE THEN GOT OUT OF THE CAR AND SMELLED THE LIQUID. IT WAS GAS WE THEN LOOKED UNDER THE VEHICLE AND THERE WAS A LIQUID DRIPING. AS WE CONTINUED TO INVESTAGATE IT WAS CLEAR THAT GAS WAS LEAKING OUT OF THE TANK. THE SEAL ALONG WITH THE BOTTOM OF THE TANK WERE SATURATED WITH A DARK GASOLINE SMELLING LIQUID. WE THEN CALLED ROADSIDE ASSISTANCE TO HAVE THE VEHICLE TOWED TO A MERCURY DEALER. WE ALSO WERE INSTRUCTED NOT TO DRIVE IT.AFTER THE VEHICLE ARRIVE TO THE DEALERSHIP WE PROCEDED TO FIND A VEHICLE SAME MADE MODLE AND YEAR. AT THAT POINT WE LOOKED UNDER THAT VEHICLE AND NOTICED THAT THE SEAL LOOKED DIFFERNT. IT LOOKED AS IF EVERYTHING WAS CONNECTED UNLIKE OUR VEHICLE WHICH LOOKED LIKE TWO PIECES PUT TOGETHER WITH A YELLOW RING AROUND IT HOLDING THE GAS LINE TO THE GAS TANK. OUR VEHICLE IS NOW SITTING AT THE DEALERSHIP WAITNG FOR SOMEONE TO INVESTIGATE THE SITUATION. WE FEEL THIS VEHICLE IS UNSAFE AND A SAFETY HAZARD WHICH COULD EASILY CAUSE INJURY AND OR DEATH BY THE FACT THAT GASOLINE IS FLAMABLE!!!!!!!!! WE WILL NOT PUT OUR FAMILY IN THIS POSTION AGAIN BY DRIVING THIS UNSAFE VEHICLE!!!!!!*AK

• 11/27/2001· POWER TRAIN

  A VIOLENT JERK IS PRESENT WHEH SHIFTING OUT OF PARK. A NOISE CAN BE HEARD ON AN INTERMITTENT BASIS BEFORE JERK OCCURS. DEALER HAS BEEN CONTACTED. *AK *TT

• 11/27/2001· STEERING,SUSPENSION,ENGINE AND ENGINE COOLING,VISIBILITY,AIR BAGS,STRUCTURE,TIRES,EQUIPMENT

  THREE SETS OF GOODYEAR, EAGLE LS TIRES, SIZE P24570R16 (NO DOT # MENTIONED) WITH LESS THAN ONE HUNDRED MILES HAD TO BE REPLACED BECAUSE KNOTS WERE FOUND ON SIDEWALL AND TREAD. DEALER HAS BEEN CONTACTED. *AK ENGINE LIGHT ILLUMINATED DUE TO FAULTY DPFE SENSOR; AIR BAG LIGHT ON, AIR BAG MODULE REPLACED; LOOSE REAR CENTER CONSOLE; VIBRATION AND POPPING NOISE OVER BUMPS, REPLACED AND BALANCED ALL FOUR TIRES, REPLACED STABILIZER BAR LINKS, RIMS WERE OUT OF ROUND; SCRUNCHING NOISE WHILE TURNING, RACK AND PINION REPLACED; EXPERIENCING WHISTLING NOISE; HARD JERK AND POPPING NOISE WHEN SHIFTING, GEAR SELECTOR SLIPPAGE; A/C VENT SQUEAKING, A/C VENT READJUSTED. *TT

• 11/27/2001· SUSPENSION

  A LOUD POPPING NOISE COULD BE HEARD COMING FROM FRONT END OF VEHICLE. DEALER HAS BEEN CONTACTED FOR PROBLEM, AND REPLACED TIE RODS. CONSUMER STATED THAT THIS DID NOT REMEDY THE PROBLEM. *AK *TT

• 11/23/2004· VISIBILITY

  THE FIRST TIME IT WINDSHIELD WIPERS FAILED WAS IN SEPT. 2004. I WAS DRIVING HOME FROM WORK ( IT WAS RAINING) THE WIPERS WERE WORKING FINE, THEN THEY BEGAN TO MOVE VERY SLOW AND WINDSHIELD WASHER FLUID BEGAN TO SQUIRT OUT. I HAD TO PULL OVER TO THE SIDE OF THE ROAD BECAUSE I COULDN'T SEE OUT OF THE FRONT WINDOW. I WAITED UNTIL THE RAIN SLOWED DOWN AND PRECEDED HOME WITH THE WIPERS MALFUNCTIONING. SINCE THE FIRST INCIDENT THE WIPERS WILL WORK FINE FOR THE FIRST 10,15,20 MINUTES AND START DOING THE SAME THING. THE VEHICLE IS AT REEDMAN MERCURY SERVICE CENTER IN LANGHORNE PA. AS THIS LETTER IS BEING WRITTEN. THEY TELL ME THAT THERE HAS BEEN PROBLEMS WITH THE MULTI FUNCTION SWITCH IN MERCURY PRODUCTS. THEY ARE GOING TO REPLACE THIS SWITCH FOR $220.00 MUCH TO MY DISAPPOVAL. THIS IS A SAFTEY ISSURE THAT SHOULD BE TAKEN CARE OF BY MERCURY. *JB

• 11/21/2016· POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  WHEN GOING 25-30 MPH VEHICLE WILL NOT SHIFT.IT ACTUALLY KICKED THE VEHICLE BACK. OD LIGHT STARTED TO FLASH THEN SERVICE ENGINE SOON LIGHT CAME ON.BEEN DOING THIS SINCE. WENT TO GO GET MOUNTAINEER READ AND OF COARSE..THE TRANSMISSION..SOMETHING NEEDS TO BE DONE OTHERWISE THIS MIGHT EVENTUALLY LEAD TO A LAWSUIT AFTER READING ALL OF THE COMPLAINTS ON THE EXACT SAME THING.

• 11/20/2013· TIRES

  DEXTERO DHT2 TIRE P245/70R16 106T THIS TIRE I PURCHASED AT WALMART MARCH 2013. I HAVE HAD PROBLEMS WITH SLIDING NOT GRIPPING THE PAVEMENT ALSO LOOKS LIKE THE BULGE OUT. I HAVE CALLED WALMART THEY SAID THEY PROBABLY NEED BALANCED OR ROTATED SO THEY DID THIS STILL DOING THE SAME THING. I CALLED THEM THEY SAID THEY NEED THEIR TIRE SPECIALIST TO LOOK IT OVER. ALSO TOLD ME THERE WAS NO RECALL ON THIS TIRE. I COULD NOT EVEN FIND THIS TIRE ON THE RECALL LIST I ASSUME ITS FROM CHINA. THE TIRE SPECIALIST TOOK MEASURMENTS OF TIRE AND HAD TO TALK WITH ANOTHER SPECIALIST ABOUT WHAT TO DO IF ANYTHING THEY SAID. I FEEL UNSAFE DRIVING WITH THESE TIRES AND WANTED TO SEE WHAT I COULD DO FROM HERE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 11/17/2014· POWER TRAIN

  I RECENTLY DECIDED TO BE #TEAMFORD....UNFORTUNATELY I'M DISAPPOINTED. MY TRUCK NOW HAS THE O/D LIGHT FLASHING EXCESSIVELY. THE TRUCK GOES IN TO 3RD GEAR BUT THUMPS & GOES DOWN INTO 2ND & THEN 1ST. I WAS TOLD THE REPAIRS WILL RUN ME ABOUT $1800. I REALLY WISH I WOULD'VE STUCK WITH CHEVROLET. .... I'VE USED GOOGLE TO SEE IS ANYONE ELSE HAVING THIS PROBLEM....& YES THEY ARE. FORD SHOULD REALLY OWN UP TO THIS & FIX THIS PROBLEM OUR DO A RECALL. THIS IS SAD. BOY DO I MISS MY CHEVY..... *TR

• 11/17/2005· ENGINE AND ENGINE COOLING

  SPARK PLUG BLEW OUT OF CYLINDER HEAD AND STRIPPED THREADS. MERCURY MOUNTAINEER 2002. *NM

• 11/16/2004· LATCHES/LOCKS/LINKAGES

  WHEN SHUTTING MY REAR HATCH ON MY 2002 MERCURY MOUNTAINEER MY LIFT CRACKED UNDERNEATH THE WINDOW. WHEN I CONTACTED FORD THEY SAID THAT I WOULD HAVE TO PAY FOR THIS - I COULD NOT AFFORD IT. THEN MY HATCH WAS HARDER AND HARDER TO CLOSE. ONE DAY WHILE TRYING TO SHUT IT THE ENTIRE WINDOW AND HATCH FELL ON MY HEAD THE LATCH CAME UNDONE. NOW I HEAR THE CYLINDER ARE A DEFECT WHAT ABOUT THE ENTIRE HATCH. THIS WHOLE UNIT IS A DEFECT.*AK

• 11/15/2006· POWER TRAIN

  I HAVE A 2002 MERCURY MOUNTAINEER WITH 58,000 MILES. I BOUGHT THIS CAR, SO MY WIFE WOULD HAVE SOMETHING SAFE TO DRIVE. SO FAR, I BELIEVE THAT THIS CAR IS UNSAFE. THE TRANSMISSION DOESN'T SHIFT RIGHT. IF SHE WERE TO TRY TO CROSS A BUSY INTERSECTION OR TO ATTEMPT TO MERGE AND THIS WERE TO OCCUR, IT COULD BE A TRAGEDY. I LOOKED THROUGH YOUR SERVICE BULLETINS. I BELIEVE WHAT I REFER TO IS DOCUMENTED. 10014089. THIS CAR IS ALMOST NEW. FORD SHOULD PAY FOR IT TO BE FIXED. PLEASE FORCE A RECALL! THANKS. *NM