2002 Hyundai Elantra

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2003· SERVICE BRAKES, HYDRAULICCrash

  PRIOR TO RECEIVING THE BRAKE HOSE RECALL 03V257000 THE VEHICLE EXPERIENCED BRAKE FAILURE WHILE DRIVING 25 MPH AND REAR ENDED ANOTHER MOTORIST. *NM

• 12/29/2008· AIR BAGS

  TL*THE CONTACT OWNS A 2002 HYUNDAI ELANTRA. WHEN THE IGNITION WAS ACTIVATED THE AIR BAG WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE WARNING INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER FOR THE MALFUNCTION SINCE NHTSA CAMPAIGN ID NUMBER 08V53300 (AIR BAG FRONTAL SENSOR/CONTROL MODULE) RECALL WAS PREVIOUSLY REPAIRED. THE AIR BAG WARNING LIGHT CONTINUED TO REMAIN ILLUMINATED WHEN THE ENGINE WAS ON. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 50,000.

• 12/28/2017· SUSPENSION

  REAR SUSPENSION CROSS MEMBER ROTTED OUT

• 12/28/2012· STEERING,SUSPENSION

  THE FRONT LOWER CONTROL ARM ON MY VEHICLE IS RUSTED OUT, AND IS CRACKED ON BOTH SIDES. LOCAL MECHANIC SAYS IT DOESN'T HAVE LONG BEFORE IT WILL FAIL. RESEARCHED PRICE ON INTERNET AND FOUND THERE WAS A RECALL FOR THAT PART. DEALER SAYS THAT MY VIN ISN'T INCLUDED IN THE RECALL, EVEN THOUGH MY CAR WAS SOLD AND DRIVEN IN THE "SNOW BELT" STATES THAT ARE LISTED, AND KENTUCKY ALSO SALTS THE ROADS DURING WINTER. MY VEHICLE IS OBVIOUSLY AFFECTED, BUT THE DEALER TELLS ME TO CALL HYUNDAI, AND HYUNDAI TELLS ME TO GO TO THE DEALER. THERE ARE SEVERAL OTHER COMPLAINTS ABOUT SIMILAR TREATMENT, AND THERE IS LITTLE RECOURSE OFFERED. I WAS TOLD THAT THE NHTSA DECIDED THE DETAILS OF THE RECALL, BUT IT WAS INSUFFICIENT. THIS IS A PRIORITY, MY CAR COULD HAVE A CATASTROPHIC FAILURE ANY DAY (AND THOUSANDS OF OTHER PEOPLE TOO). THE RECALL IS CAMPAIGN 091 FRONT LOWER CONTROL ARM CORROSION. *TR

• 12/28/2007· FUEL SYSTEM, GASOLINE

  TL*THE CONTACT OWNS A 2002 HYUNDAI ELANTRA. THE FUEL RAIL IS LEAKING GAS ONTO THE ENGINE AND THE CHECK ENGINE LIGHT REMAINS ILLUMINATED. THE DEALER STATED THAT THIS WAS A COMMON FAILURE AND WAS CAUSED BY A MANUFACTURER DEFECT. THE DEALER PERFORMED A DIAGNOSTIC, WHICH SHOWED THAT TWO SENSORS FAILED. THE DEALER STATED THAT THIS WAS A VERY SERIOUS ISSUE THAT COULD RESULT IN A FIRE. THE CONTACT WAS NOT ALLOWED TO TAKE HER VEHICLE HOME DUE TO THE RISK OF FIRE AND THE SEVERITY OF THE GAS LEAK. HYUNDAI STATED THAT NOTHING MORE COULD BE DONE BECAUSE THE PART WAS OUT OF WARRANTY. THE CONTACT STATED THAT THEY WERE NOT EVEN INTERESTED IN LOOKING AT THE PART. THE VEHICLE HAS A 100,000 MILE POWERTRAIN WARRANTY; HOWEVER, THE MANUFACTURER STATED THAT THIS PARTICULAR INCIDENT WAS NOT COVERED FOR THAT WARRANTY. AS A RESULT, OTHER COMPONENTS, SUCH AS THE GASKET, HAVE BLOWN. THE MANUFACTURER STATED THAT THERE WAS NO RECALL FOR THIS PARTICULAR DEFECT; HOWEVER, THERE WERE RECALLS LISTED FOR SIMILAR FUEL DEFECTS OF THE SAME PRESENCE OF FUEL LEAKAGE. THOSE NHTSA CAMPAIGN ID NUMBERS ARE 04V369000 AND 04V178000. THE FAILURE AND CURRENT MILEAGES WERE 86,000.

• 12/27/2005· SERVICE BRAKES, HYDRAULIC,POWER TRAINCrash

  DT: THE CONTACT'S VEHICLE WAS IN AN ACCIDENT ON MARCH 3, 2005, THE VEHICLE RECEIVED DAMAGE TO THE RIGHT FRONT WHEEL. AFTERWARDS, THE CONTACT RECEIVED NHTSA RECALL CAMPAIGN 03V496000 ON AUGUST 10, 2005. SINCE THE VEHICLE WAS IN AN ACCIDENT THE INSURANCE COMPANY ADVISED THE BODY SHOP TO INSTALL AN AFTER MARKET AXLE TO CORRECT THE PROBLEM. THERE HAVE BEEN NO RECALL REPAIRS MADE DUE TO THE AFTER-MARKET PARTS BEING INSTALLED, AND THE SENSORS WERE INSTALLED WRONGLY. THE MANUFACTURER HAS BEEN CONTACTED, AND THEY DID NOT PROVIDE ASSISTANCE. *AK

• 12/24/2003· SERVICE BRAKES, HYDRAULICCrash

  BRAKES FAILED TO STOP VEHICLE WHILE DRIVING AT AN UNDETERMINED SPEED. AS A RESULT, CONSUMER'S VEHICLE HIT ANOTHER VEHICLE HEAD ON. THE DRIVER BECAME COMATOSE. ATTORNEY FELT THAT THE BRAKE FAILURE COULD BE RELATED TO A BRAKE FLUID LEAK AS STATED IN RECALL 03V257000. *AK

• 12/23/2003· STRUCTURE

  THE DRIVER SIDE DOOR LEAKED WHEN IT RAINED. THE VEHICLE HAS BEEN TO THE DEALER FOUR TIMES FOR THIS SAME PROBLEM, BUT THE WATER STILL LEAKS INTO THE VEHICLE. THE MANUFACTURER IS NOT AWARE OF THE PROBLEM. *NLM

• 12/22/2003· AIR BAGSCrash

  WHILE TRAVELING AT 35 TO 40 MPH DRIVER LOST CONTROL OF VEHICLE AND SLAMMED HEAD ON INTO A STREET POLE. UPON IMPACT, NONE OF THE AIRBAGS DEPLOYED. THEN, AIR BAG LIGHT ILLUMINATED SHORTLY AFTER. THE VEHICLE WAS TOWED TO DEALER. *AK

• 12/21/2014· POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  VERY DANGEROUS: THE VEHICLES SHUTSDOWN WHILE DRIVING WITHOUT ANY WARNING. DASHBOARD BLINKS AND ENGINE SHUTS DOWN CAUSING LOST OF STEERING AND POWER, SLOWING CAR IN HEAVY TRAFFIC WITH VEHICLES BEHIND. THIS HAS HAPPENED SEVERAL TIMES. MECHANICS CAN'T SOLVE ISSUES. ON THE INTERNET, SIMILAR INCIDENTS HAVE BEEN REPORTED BY OTHER HYUNDAI DRIVERS . THE CRANKSHAFT POSITION SENSOR, IDLE CONTROL VALVES, AND IN/OUT OUTPUT SENSOR TRANSMISSION ARE REPORTED AS POSSIBLE PROBLEMS. IN ANY EVENT IS A VERY DANGEROUS CONDITION. PROBLEM SHOULD BE STUDIED AND REPORTED. IT HAPPENS NOT ONLY TO THIS MODEL, BUT ON OTHER HYUNDAI VEHICLES. *TR

• 12/21/2008· SUSPENSION

  I STOPPED AT A RED LIGHT AND SOMETHING UNDER MY CAR SNAPPED AND THE CAR SWERVED TO THE RIGHT. I HAD THE CAR TOWED TO A MECHANIC WHO DETERMINED THE LOWER RIGHT CONTROL ARM HAD RUSTED THROUGH AND BROKE. *TR

• 12/20/2015· AIR BAGS

  RANDOM ILLUMINATION OF AIR BAG LIGHT ON DASH WITHOUT EXPLANATION.

• 12/17/2010· AIR BAGS

  SRS LIGHT IN INSTRUMENT CLUSTER WOULD COME ON AND OFF THEN, STAYED OFF. I TOOK VEHICLE TO DEALER AND WAS ADVISED THE WIRING HARNESS UNDER THE PASSENGER FRONT SEAT NEEDED TO BE REPLACED. I DECLINED TO REPLACE AS THE COST WAS VERY HIGH. I LATER CHECKED THE NHTSA DATA BASE AND FOUND THIS PROBLEM LISTED FOR THE 2002 HYUNDAI ELANTRA; NHTSA CAMPAIGN ID NUMBER: 08V533000. I CALLED THE DEALER IN REGARDS TO THE RECALL AND WAS INFORMED MY CAR WAS NOT INCLUDED AND THE STATED RECALL, WAS A DIFFERENT PROBLEM. I LATER CALLED HYUNDAI USA AND THEY ADVISED ME MY CAR WAS NOT INCLUDED IN THE RECALL AS IT WAS MANUFACTURED 6 MONTHS LATER THEN THE RECALL GROUP. MY VEHICLE HAS THE SAME PROBLEM AS THAT LISTED IN THE ABOVE RECALL. IF THERE IS A SIDE IMPACT THE SIDE AIR BAGS WILL NOT DEPLOY, A DEFINITE SAFETY ISSUE! I THINK HYUNDIA SHOULD MAKE AND PAY FOR THE REPAIR!

• 12/15/2008· ENGINE AND ENGINE COOLING

  ALREADY A RECALL ON 2002 HYUNDAI ELANTRA, BUT THE 2002 ELANTRA THAT I HAVE IS PAST THE RECALL DATE OF JAN. 31, 2002. MY CAR, # WAS BUILT IN MARCH 2002 SO NOT COVERED ON RECALL CAMPAIGN #05-01-001-1. CRACK BETWEEN PORT #3 AND #4 ON THE MANIFOLD. THE PART HAS BEEN INSTALLED ON THE CAR SO I EXPECT TO BE REIMBURSED COST OF PART AND LABOR TO INSTALL. *TR

• 12/12/2003· SERVICE BRAKES, HYDRAULIC

  PROBLEMS WITH 2002 HYUNDAI ELANTRA REAR BRAKE TUBES.*MR HYUNDAI ISSUED A RECALL AND UPON THE RECALL THE CONSUMER NEEDED A CAR FOR WORK PURPOSES SINCE IT WAS POSSIBLE THE DEALER MIGHT HAVE KEPT THE VEHICLE OVER NIGHT. HYUNDAI TOLD HIM THAT THEY WOULD NOT PAY FOR A RENTAL CAR. THE CONSUMER WAS VERY DISSATISFIED WITH HYUNDAI CUSTOMER SERVICE. *CB *JB

• 12/10/2012· SUSPENSION

  I RECENTLY BOUGHT A USED 2002 HYUNDAI ELANTRA AND DISCOVERED AN ABNORMAL AMOUNT OF RUST ON THE FRONT CONTROL ARMS. IN SOME PLACES, HOLES HAD RUSTED THROUGH THE CONTROL ARMS. HYUNDAI DID A RECALL FOR OVER 150,000 OF MY EXACT MODEL INCLUDING THOSE IN THE STATE WHICH I LIVE BACK IN 2009. THE RECALL WAS FOR THIS EXACT PROBLEM. WHEN I TOOK THE CAR TO THE DEALER, THEY INSPECTED THE VEHICLE AND SAW THAT MY CARS PROBLEM EXACTLY MATCHED ALL THOSE OTHERS RECALLED. HOWEVER, THEY INFORMED ME THAT MY PARTICULAR CAR WAS NOT UNDER THIS RECALL DESPITE HAVING THIS IDENTICAL PROBLEM. THEY GAVE ME AN ESTIMATE OF $585 TO REPLACE THE ARMS THAT WERE A MANUFACTURER'S DEFECT. THE ARMS HAVE NOT BROKEN YET BUT THEY VERY EASILY COULD BREAK IN THE NEAR FUTURE, POTENTIALLY CAUSING A FATAL ACCIDENT. THE RECALL SENT OUT IN 2009 NEEDS TO BE EXPANDED SINCE IT DID NOT INCLUDE ALL THE CARS HAVING THIS PROBLEM. *TR

• 12/10/2002· FUEL SYSTEM, GASOLINE

  WHILE TRAVELING ON THE HIGHWAY WITHOUT PRIOR WARNING. THERE WAS A OIL SMELLL COMING INSIDE OF THE VENTS PLEASE PROVIDE ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM. TS

• 12/09/2002· ENGINE AND ENGINE COOLING

  WHILE DRIVING AT 70 MPH THE VEHCILE WILL STALL OUT WITHOUT WARNING. CONSUMER HAD VEHICLE SERVICED BY THE DEALERSHIP 3 TIMES FOR THIS PROBLEM. THE DEALERSHIP REPLACED SEVERAL PARTS, BUT THE VEHICLE STILL STALLS OUT. CAUSE STILL UNKNOWN. TS

• 12/08/2004· VEHICLE SPEED CONTROL

  WHILE COMING TO A STOP THE RPMS TEMPORALLY RACED AT A HIGH RATE. CONSUMER CONTINUED TO DRIVE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM.*AK *TC

• 12/08/2004· SERVICE BRAKES, HYDRAULIC

  WHEN PRESSING ON THE BRAKE PEDAL IT WAS SO CLOSE TO THE ACCELERATOR THAT CONSUMER PRESSED BOTH AT THE SAME TIME. THE CONSUMER STATED THAT HE WAS ALMOST INVOLVED IN AN ACCIDENT. *AK THE ENGINE WOULD EXCEED THE BRAKING POWER AND THE VEHICLE WOULD SPEED UP INSTEAD OF SLOWING DOWN. THE CONSUMER WOULD HAVE TO STEP ON THE BRAKES HARDER WITH THE VEHICLE SPEEDING UP EVEN MORE. *SC THE BRAKE PEDAL AND GAS PEDAL WERE TOO CLOSE TOGETHER. *JB

• 12/07/2009· STEERING,SERVICE BRAKES, HYDRAULIC

  MY HUSBAND AND I ARE THE OWNERS OF A 2002 HYUNDAI ELANTRA GT, AND ARE THE ONLY OWNERS OF RECORD AND HAVE MAINTAINED THE VEHICLE IN A REASONABLE MANNER. ON FRIDAY, DECEMBER 4 2009, I WAS DRIVING THE VEHICLE AT APPROXIMATELY 30 MPH APPROACHING A LEFT TURN LIGHT, WHEN I NEEDED TO STOP SUDDENLY TO AVOID HITTING A CAR THAT STOPPED ABRUPTLY IN FRONT OF ME. WHEN I APPLIED THE BRAKES, I HEARD A LOUD NOISE AND THE CAR BEGAN TO PULL TO THE LEFT, PLACING MY VEHICLE INTO THE ON-COMING TRAFFIC LANE. FORTUNATELY, MY VEHICLE DID NOT HIT ANY OTHER VEHICLES OR ROADSIDE OBSTACLES. AFTER COMING TO A FULL STOP, I MANAGED TO NEGOTIATE THE LEFT TURN, IN ORDER TO MOVE THE VEHICLE OUT OF A 5-POINT INTERSECTION AND INTO A SAFER AREA. ONCE THE VEHICLE WAS ENGAGED IN THE TURN, I HEARD METAL GRINDING AGAINST METAL. I PULLED THE CAR OFF OF THE ROAD IMMEDIATELY INTO THE FIRST AVAILABLE TURN OFF, WHICH HAPPENED TO BE A CHURCH PARKING LOT. UPON INSPECTION OF THE VEHICLE, IT BECAME APPARENT THAT THE VEHICLE WAS NO LONGER IN A SERVICEABLE CONDITION AND WOULD NEED TO BE TOWED. THE LOWER CONTROL ARM ON THE PASSENGER SIDE OF THE CAR WAS SIGNIFICANTLY TORN BETWEEN THE SHOCK MOUNT AND THE BALL JOINT. THE CORROSION DAMAGE IS SIGNIFICANT ON THE INTERIOR OF THE ARM. IT LOOKS AS IF IT BLEW UP. THERE IS STILL A SMALL PORTION THAT IS STILL ATTACHED BUT IT IS COMPLETELY IMMOBILE. THE TIRE IS PUSHED UP AGAINST THE WHEEL WELL. WE ARE VERY CONCERNED ABOUT THE LACK OF COOPERATION THAT WE HAVE RECEIVED FROM HYUNDAI CORPORATE OFFICE RECALL DIVISION. THEY HAVE NOT AGREED TO FIX ANY DAMAGE TO THE CAR AS A RESULT OR REIMBURSE EXPENSES INCURRED DUE TO THE INCIDENT. TO MAKE MATTERS WORSE, THEY CLAIM THE REASON WE DIDN'T GET A NOTICE ABOUT THE RECALL IS BECAUSE THEY DIDN'T WANT EVERYONE TO COME IN AT THE SAME TIME SO THEY ARE SPACING IT OUT! IT'S COMPLETELY IRRESPONSIBLE OF THEM TO NOT NOTIFY THE CONSUMER OF THIS DEFECTIVE PRODUCT! I AM 6 MONTHS PREGNANT AND OFTEN DRIVE MY 2 YR OLD! *TR

• 12/07/2003· SERVICE BRAKES, HYDRAULIC,AIR BAGS,SEAT BELTS,STRUCTURE

  FROM DAY OF PURCHASE, I NOTICED A VIBRATION IN THE STEERING, STARTING ABOUT 42 MPH. TOOK THE VEHICLE TO DEALER, WHO ROTATED AND BALANCED TIRES. VIBRATION THEN STARTED ABOUT 50 MPH, BACK TO THE DEALER ROTATED AND BALANCED TIRES AGAIN ALONG WITH ALIGNMENT. VIBRATION ABOUT 58 MPH BACK TO DEALER AGAIN, ROTATION, FORCED BALANCING, ROTOR TURNED DOWN, STILL HAD VIBRATION. FILED UNDER LEMON LAW, FINAL ATTEMPT BY SERVICE DEPARTMENT INVOLVED HMA REGIONAL CHIEF MECHANIC TROUBLE SHOOTER. HE CLAIMED THEY LOOSENED MOTOR MOUNTS AND LET ENGINE CENTER ITSELF, CHANGED TIRES, BALANCED AND ALIGNED AGAIN. AFTER A WEEK I PICKED UP CAR WHICH HE SAID WAS FINE. VIBRATION STILL NOTICEABLE. GAVE UP ON HMA AND DROVE CAR ABOUT 20,000 MORE MILES TILL VIBRATION GOT SO BAD I HAD TO GO TO A BRAKE SHOP BECAUSE IT WAS ALMOST IMPOSSIBLE TO STOP. THEY CHANGED PADS, ADJUSTED BRAKES AND REBUILT RIGHT FRONT CALIPER. NO MORE VIBRATION. HYUNDAI WON'T PAY FOR THE REPAIR, SO FOLLOWING THRU WITH LEMON LAW AND HOPING TO GET OUT OF THIS DEATH TRAP. AIR BAG LIGHT COMES ON SOME DAYS, AND STAYS ON ALL DAY, SOME DAYS IT'S NOT ON. DO THE AIR BAGS WORK. ALSO HAVING PROBLEMS WITH PAINT FINISH, DOOR SEALS AND SEAT BELT RETRACTORS. REAL PIECE OF JUNK AND I WOULD NEVER RECOMMEND THIS CAR TO ANY ONE. ALSO HAD TO HAVE BRAKE DUST REMOVED FROM REAR BRAKES AT ABOUT 7000 MILES AND THE DEALER CHARGED ME 60.00$ EXCESSIVE DUST ACCUMULATION IS A DESIGN DEFECT AND AT THE LEAST SHOULD HAVE BEEN COVERED BY HYUNDAI. *LA ABL.PCO

• 12/07/2001· POWER TRAIN

  WHILE DRIVING, VEHICLE OFTEN GETS STUCK IN FIRST GEAR AND REVS EXCESSIVELY AS IF GEARS ARE NOT PROPERLY SHIFTING OUT OF 1ST GEAR. DEALER HAS SEEN VEHICLE TWICE. THIRD TIME DEALER INDICATED THAT A PROGRAM HAD TO BE ESTABLISHED IN ORDER TO FIX VEHICLE. *AK *JB

• 12/06/2003· AIR BAGS,SEAT BELTSCrash

  ON BOARD COMPUTER FAILED TO DEPLOY AIRBAG AND SEAT BELT DID NOT HOLD DURING AN ACCIDENT WHICH RESULTED IN INJURY TO MY NECK AND BACK. *LA

• 12/04/2014· SUSPENSION

  THERE IS A RUST HOLE IN MY RIGHT LOWER FRONT SUSPENSION CONTROL ARM, RELATED TO HYUNDAI RECALL# 091. I CONTACTED HYUNDAI CUSTOMER ASSISTANCE CASE# [XXX]. I WAS TOLD I WOULD HAVE TO PAY FOR THE REPAIRS AND THEN ATTEMPT TO SEEK REIMBURSEMENT BUT WAS TOLD THERE IS NO PROMISE OF A REFUND. I SAID THEIR RECALL CLEARLY STATES VEHICLES BEING RECALLED ARE IN THE SALT BELT STATES OR CARS THAT ARE REGISTERED IN THESE STATES. MY CAR CAME FROM VIRGINIA BUT HAS BEEN REGISTERED AND DRIVEN HERE IN MICHIGAN FOR TWO YEARS AND SHOULD BE INCLUDED IN THIS RECALL. MY REQUEST FOR ASSISTANCE WAS DENIED. ALL THESE VEHICLES WERE BUILT WITH POOR QUALITY METAL COMPONENTS, THERE ARE NO VIN. BREAK POINTS AND SHOULD NOT MATTER WHERE VEHICLE IS LOCATED AS VEHICLES MOVE FROM STATE TO STATE. I SHOULD NOT AND WILL NOT WAIT FOR AN INCIDENT TO OCCUR. I WILL PAY FOR THIS REPAIR TO ASSURE MY FAMILIES SAFETY. I CONTACTED MY LOCAL DEALER ANN ARBOR AUTOMOTIVE AND TALKED TO BETHANY PATTERSON IN SERVICE AND EMAILED HERE PICTURES OF THE DEFECTIVE COMPONENT(WE HAVE THE EMAIL CONFIRMATION). SHE STATED THE SERVICE MANAGER WOULD REVIEW AND GET BACK TO ME. THREE WEEKS LATER AND NO CONTACT. I ALSO TOOK THE CAR TO THEM AT ANN ARBOR AUTOMOTIVE WHICH IS MY CLOSEST HYUNDAI DEALER IN ANN ARBOR MICHIGAN JUST TO SHOW THEM THE FAILURE WHICH IS VISIBLE WITH THE STEERING TURNED WITHOUT PUTTING ON A LIFT. THE SERVICE MANAGER WOULD NOT COME OUT TO LOOK AT, THEY ASKED ME IF I HAD AN APPOINTMENT AND THEN TOLD ME I WOULD HAVE TO LEAVE THE CAR FOR AT LEAST 3-5 DAYS JUST TO LOOK AND CONTACT HYUNDAI WITH NO ASSURANCE OF ANYTHING BEING DONE. WHAT A JOKE. I HAVE TRIED TO CONTACT YOU BUY PHONE BUT THE CALLS WILL NOT GO THROUGH, DO YOU STILL HAVE A PHONE? THERE ARE MORE PROCEDURES THAT HAVE TO BE DONE RELATED TO THIS RECALL BUT RIGHT NOW I HAVE TO REPLACE THIS ONE PART TO MAKE THE CAR SAFE FOR MY FAMILY. PLEASE HELP EVERYONE WITH THIS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 12/04/2007· SERVICE BRAKES, HYDRAULIC

  DRIVING 25 MPH - APPROACHED STOP SIGN - BRAKES FAILED COMPLETELY, NO PEDAL, PUMPED BRAKES, NO PETAL AND NO STOPPING - NO WARNING, NO BRAKE LIGHT ON DASH - RAN THROUGH A STOP SIGN UNABLE TO STOP - NO ONE WAS COMING FORTUNATELY - PULLED OVER TO SIDE OF ROAD - HAS VEHICLE TOWED TO DEALERSHIP. WAS ADVISED MY VEHICLE WAS 3 MONTHS OUT OF WARRANTY AND REPAIRS WOULD COST $1400.00 TO REPLACE A LEAKING ABS ANTI LOCK BRAKE MODULE. I QUESTIONED WHY ALL BRAKES FAILED AT ONCE WITHOUT WARNING SINCE THIS IS A DUAL MASTER CYLINDER SYSTEM WHICH SHOULD SEGREGATE BRAKING FRONT FROM REAR. I ALSO QUESTIONED WHY SUCH A SERIOUS DEFECT WOULD NOT BE COVERED SINCE THIS CAR ONLY HAS 40,000 MILES, IS 3 MONTHS BEYOND THE 5 YEAR APPLIED WARRANTY, AND REPORTEDLY HAS A 10 YEAR, 100,000 WARRANTY. I AM CONCERNED BECAUSE WE HAVE ANOTHER EXACT SAME YEAR AND MODEL CAR IN OUR FAMILY. I CALLED THE HYUNDAI 800 LINE FOR CUSTOMER SUPPORT. THEY ADVISED ME THEY WOULD LOOK AT IT AND GET BACK TO ME WITHIN 2 BUSINESS DAYS. *TR

• 12/04/2002· VEHICLE SPEED CONTROL

  WHEN AT A STAND STILL AND FOOT ON THE BRAKE THE VEHICLE AUTOMATICALLY SURGED FORWARD. TS

• 12/02/2009· STEERING,SUSPENSION

  COLLAPSE OF CONTROL ARM AND LOSS OF STEERING WHILE DRIVING, NEVER RECEIVED RECALL NOTICE. THEY NEED TO GET THE RECALL OUT BEFORE SOMEONE IS HURT BADLY. *TR

• 12/01/2010· POWER TRAIN

  2002 HYUNDAI ELANTRA GT MANUAL TRANSMISSION - REPLACED CLUTCH ON 10/13/09 AFTER CLUTCH WENT. REPLACED MASTER CYLINDER A COUPLE OF MONTHS AGO AFTER NO GRAB ON CLUTCH AGAIN!! ON WAY TO JOB INTERVIEW LAST NIGHT AND CLUTCH PEDAL STUCK, FLUID LEAKING FROM UNDER CAR, LOST ALL CONTROL OF VEHICLE & HAD TO HAVE SOMEONE PICK ME UP!!!! I SEE I AM NOT ONLY ONE WITH THIS PROBLEM AS YOUR WEBSITE IT RIDDLED WITH SIMILAR COMPLAINTS!! SOMEONE HAS TO DO SOMETHING SOON BEFORE SOMEONE IS SERIOUSLY INJURED AND/OR KILLED IF NOT ALREADY!!!!!!! HYUNDAI NEEDS TO MAKE THIS SERIOUS SITUATION RIGHT!!!!! *TR

• 11/30/2012· FUEL/PROPULSION SYSTEM

  MY FUEL TANK ASSEMBLY VALVE. IT TAKES ME A VERY LONG TIME TO PUMP GAS BECAUSE THE CAR SHUTS THE PUMP OFF LIKE MY TANK IS ALREADY FULL. I EVEN HAD GAS SPILL OUT WHILE I WAS STILL PUMPING. I STARTED TO BECOME VERY CONCERNED WHEN I DID A LITTLE RESEARCH ON THIS PARTICULAR INCIDENT. WHAT REALLY GOT ME CONCERNED IS WHEN IT SAID IF THIS PROBLEM IS NOT TAKEN CARE OF, IF I WERE TO GET INTO AN ACCIDENT AND MY CAR OVERTURNED, IT COULD POTENTIALLY CATCH A FIRE! I HAVE TWO CHILDREN, AND GOD FORBID SOMETHING LIKE THIS HAPPEN WHEN IM IN MY CAR WITH MY CHILDREN. *TR

• 11/26/2015· UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM

  ENGINE STOPS SUDDENLY ALMOST CREATING ACCIDENT. CAUSE ?

• 11/25/2011· SUSPENSION

  TL* THE CONTACT OWNS A 2002 HYUNDAI ELANTRA. THE CONTACT WAS TRAVELING 65 MPH WHEN SHE HEARD WHAT SOUNDED LIKE A TIRE BLOWOUT. THE CONTACT WAS ABLE TO MANEUVER THE VEHICLE TO THE SHOULDER AND NOTICED THAT THE FRONT DRIVER'S WHEEL WAS TURNED OUTWARD. THE CONTACTS INSURANCE COMPANY INSPECTED THE VEHICLE AND DETERMINED THAT THE FRONT DRIVERS SIDE CONTROL ARM WAS RUSTED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS PREVIOUSLY REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09V125000 (SUSPENSION; FRONT CONTROL ARM) ON 7/17/2009. THE CONTACT FELT THAT THIS WAS STILL A SAFETY ISSUE AND THE MANUFACTURER DID NOT HAVE AN ADEQUATE REPAIR. THE FAILURE AND CURRENT MILEAGES WERE 67,000. UPDATED 01/03/12*LJ UPDATED 01/12/12

• 11/23/2015· SUSPENSION

  TL* THE CONTACT OWNS A 2002 HYUNDAI ELANTRA. WHILE AT AN INDEPENDENT MECHANIC FOR ROUTINE REPAIR. THE MECHANIC STATED THAT THE FRONT LOWER CONTROL ARM BUSHINGS WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 153,248.

• 11/23/2005· AIR BAGSCrash

  AIRBAGS ON MY 2002 HYUNDAI ELANTRA GT DID NOT GO OFF WHEN I HAD A HEAD ON COLLISION WITH A GUARDRAIL AT HIGH SPEED. NO INJURIES EXCEPT WHIPLASH, LUCKILY! *JB

• 11/20/2008· AIR BAGS

  TL*THE CONTACT OWNS A 2002 HYUNDAI ELANTRA. WHEN THE CONTACT STARTED THE IGNITION, THE AIR BAG WARNING INDICATOR IMMEDIATELY ILLUMINATED ON THE INSTRUMENT PANEL. THE WARNING INDICATOR REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A DIAGNOSTIC AND THEY STATED THAT THE FAILURE WAS RELATED TO THE AIR BAG MODULE. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 08V533000 (AIR BAGS, FRONTAL:SENSOR/CONTROL MODULE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE FAILURE MILEAGE WAS 70,000 AND CURRENT MILEAGE WAS 104,000. UPDATED 12/10/08 *CN UPDATED 12/16/08. *JB

• 11/20/2005· SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROLCrash

  ON 11/03/05 I HAD AN ACCIDENT WHERE I REAR ENDED ANOTHER VEHICLE. I DID NOT REALIZE EXACTLY WHAT HAPPENED AT THE TIME OF THE ACCIDENT, BUT DID TELL THE POLICE SOMETHING WAS WRONG WITH EITHER THE BRAKES OR THE TIRES. I JUST HAD A VERY UNCOMFORTABLE FEELING WHEN ATTEMPTING TO STOP! I FELT AS THOUGH THE VEHICLE WAS COASTING. THE DAMAGE TO MY VEHICLE WAS $1,385.00 AND I HAVE NO IDEA OF THE DAMAGE TO THE OTHER VEHICLE. I SUBSEQUENTLY DISCOVERED, AFTER DUPLICATING THE INCIDENT, MY FOOT WAS ON BOTH THE BRAKE AND ACCELERATOR. THE BRAKE PEDAL, ON THE HYUNDAI ELANTRA, IS 2.25 INCHES FROM THE ACCELERATOR. A SIMILAR INCIDENT RESULTED IN A 424,000 VEHICLE RECALL AND CORRECTION BY FORD MOTOR CO. IN THEIR CASE THE RELATIONSHIP WAS 1.95 INCHES THIS DISTANCE TO THE ACCELERATOR, ON THE ELANTRA, WAS NOT THE MAJOR ISSUE, THE BRAKE PEDAL IS ONLY ONE INCH ABOVE THE ACCELERATOR AND WHEN FULLY BRAKING THE BRAKE IS ONE INCH BELOW THE ACCELERATOR. WHEN YOU COMBINE THE TWO THE END RESULT MAY BE DEVASTATING. I HAVE A SECOND VEHICLE, A HYUNDAI SONATA, IN THIS ONE THE BRAKE IS 3.25 INCHES FROM THE ACCELERATOR AND ALSO IS 2.25 INCHES ABOVE THE ACCELERATOR. UPON BRAKING THE BRAKE PEDAL REMAINS .50 INCHES ABOVE THE ACCELERATOR. NO PROBLEM! *NM

• 11/20/2001· AIR BAGSCrash

  VEHICLE WAS INVOLVED IN A FRONTAL COLLISION AT 70MPH. UPON IMPACT, AIR BAGS DID NOT DEPLOY. VEHICLE WAS TOTALLED. PLEASE PROVIDE ADDITIONAL INFORMATION. *AK

• 11/20/2001· SERVICE BRAKES, HYDRAULICCrash

  WHEN BRAKES WERE APPLIED IN A PANIC STOP PEDAL WENT TO THE FLOOR, CAUSING EXTENDED STOPPING DISTANCE, AND RESULTING IN A COLLISION. PLEASE PROVIDE ADDITIIONAL INFORMATION. *AK

• 11/18/2005· WHEELS

  DT: THE CONTACT STATED AT 60-65 MPH NOTICED VIBRATION IN VEHICLE. HE TOOK THE VEHICLE TO THE DEALERSHIP, AND THEY FOUND THREE RIMS WERE BENT. THE VEHICLE IS CURRENTLY BEING REPAIRED WITH NEW RIMS. *AK

• 11/17/2003· SERVICE BRAKES, HYDRAULICCrash

  CONSUMER'S VEHICLE EXPERIENCED BRAKE FLUID LEAKAGE PRIOR TO BEING NOTIFIED OF BRAKE HOSE RECALL 03V257000. AS A RESULT, VEHICLE WAS INVOLVED IN AN ACCIDENT ON TWO SEPARATE OCCASIONS. *AK

• 11/13/2009· SUSPENSION

  2002 ELANTRA GT MADE R TURN FROM FULL STOP ONTO CHESTER PIKE. HEARD GRINDING FROM PASSENGER FRONT WHEEL. CAR CAME TO COMPLETE STOP. FRONT WHEEL FELL OFF. FRACTURED SUSPENSION ARM WAS SEEN. AXLE FAILURE WAS FOUND WHEN CARE WAS INSPECTED. RECALL WAS ISSUED 7/10/09. I AM THE ORIGINAL OWNER AND HAVE NOT RECEIVED A RECALL NOTICE. I DO RECEIVE WEEKLY ADS FROM HYUNDAI SUGGESTING TRADE IN, SO THEY KNOW WHERE I AM. I NOW NEED TO JUMP THROUGH HOOPS TO GET HYUNDAI TO PAY, AS I DID NOT FIND OUT ABOUT THE RECALL UNTIL MY CAR WAS TOWED TO AND REPAIRED BY AN INDEPENDENT GARAGE. POLICE WERE ON SCENE WITH LIGHTS FLASHING TO PROTECT DISABLED VEHICLE UNTIL TOW TRUCK ARRIVED. NO REPORT WAS FILLED AS THERE WAS NO ACCIDENT OR INJURY. *TR

• 11/12/2009· SUSPENSION

  TL* THE CONTACT OWNS A 2002 HYUNDAI ELANTRA. WHILE DRIVING 30 MPH THE CONTROL ARM FRACTURED IN HALF, AND THEN KNOCKED THE STABILIZER LINKS OUT. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC, AND HE WAS INFORMED OF THE CONTROL ARM FAILURE. SHE CONTACTED THE DEALER IN REFERENCE TO RECALL #09V125000 (SUSPENSION:FRONT:CONTROL ARM). A TECHNICIAN STATED THAT SHE WOULD HAVE TO MAKE A COMMITMENT TO PAY $1000 IN ORDER FOR HIM TO REPAIR THE VEHICLE ACCORDING TO RECALL. HE THEN ADDED THAT IN ORDER TO PERFORM THE REMEDY REFERENCED IN THE RECALL, HE WOULD HAVE TO TAKE THE MUFFLER DOWN. SHE THEN CONTACTED THE MANUFACTURER, AND A REPRESENTATIVE TOLD HER THAT THE DEALER WAS GOING TO CREATE ANOTHER ESTIMATE FOR THE REPAIR. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 180,000.

• 11/12/2004· UNKNOWN OR OTHER

  THE CONSUMER HAS RECEIVED 2 MAJOR RECALL ON THE VEHICLE. THE FIRST FOR THE ECM (V02) AND THE SECOND FOR THE FUEL VALVE (O66). THE CONSUMER REQUEST REIMBURSEMENT. *NM *SC

• 11/07/2018· SUSPENSION

  I HAVE NOTED A RECALL #09V125000 RELATED TO THIS MAKE/MODEL/YEAR BUT FOR SOME REASON MY CAR WITH THE EXACT PROBLEM IS NOT PART OF THE RECALL. MY RIGHT FRONT CONTROL ARM COLAPSED. IT WAS COMPLETELY RUSTED THROUGH. WITH THAT SIDE FIXED I TRAVELED ABOUT 3 MILES AND MY LEFT SIDE CONTROL ARM BROKE. MY MECHANIC AND I WERE COMPLEXED, BUT AFTER RESEARCH I FOUND THIS PROBLEM EXIST AND RECALLS ISSUED. AFTER CONTACTING HYUNDA THEY SAID THIS VEHICLE VIN# WAS NOT COVERED. I DON'T UNDERSTAND HOW THIS LIFE THREATENING PROBLEM WAS NOT PART OF THE RECALL. SOMETHING IN THE RECORDS OF THIS CAR MUST BE IN ERROR.

• 11/07/2016· STEERING

  ON OCTOBER 28TH, 2016 THE LOWER, DRIVER'S SIDE, FRONT CONTROL ARM DISINTEGRATED WHILE MY WIFE WAS DRIVING HER ELANTRA IN A PARKING LOT. SHE WAS MAKING A RIGHT TURN TO LEAVE THE LOT WHEN SHE LOST CONTROL OF THE CAR AS IT MADE A "TERRIBLE GRINDING NOISE." THE NEXT DAY I REMOVED THE WHEEL AND DISCOVERED THE CONTROL ARM WAS TORN IN TWO SECTIONS AND BADLY CORRODED. I WENT TO TWO HYUNDAI DEALERS TO TRACK DOWN A NEW PART. NEITHER DEALER MENTIONED THE FACT THAT THIS MODEL HYUNDAI HAD BEEN RECALLED FOR PRECISELY THIS PROBLEM. WHEN I LEARNED OF THIS PROBLEM I CONTACTED HYUNDAI MOTORS. THEY INFORMED ME THAT THE RECALL ONLY APPLIED TO VEHICLES PURCHASED OR REGISTERED IN THE SO-CALLED "SALT BELT" STATES. MY WIFE BOUGHT THIS CAR NEW IN COLORADO AND HAS NEVER DRIVEN IT IN THE "SALT BELT." YET IT SUFFERED THE SAME CORROSION AND FAILURE AS DESCRIBED IN THE RECALL BULLETIN. THIS IS A VERY DANGEROUS FAILURE BECAUSE THE CORROSION IS INSIDE THE CONTROL ARM AND CANNOT BE DETECTED BY A NORMAL VISUAL INSPECTION. I SUSPECT THAT THE FAILURE THAT SHOWED UP YEARS AGO IN THE "SALT BELT" CARS IS NOW APPEARING IN OLDER CARS IN OTHER PARTS OF THE COUNTRY. HYUNDAI APPARENTLY DOES NOT GIVE A [XXX]. I SUGGEST THE NHSTA IMPOSE A NATIONWIDE MANDATORY RECALL OF THESE VEHICLES. IF IT OCCURRED AT HIGHWAY SPEEDS THIS FAILURE WOULD RESULT IN IMMEDIATE LOSS OF CONTROL, RESULTING IN SEVERE INJURY OR DEATH FOR PASSENGERS IN THE CAR. THIS VEHICLE IS A ONE OWNER CAR THAT WAS GARAGED ALL ITS LIFE. IT WAS REGULARLY SERVICED BY A HYUNDAI DEALER. IT SHOWS NO SIGNS OF EXCESSIVE CORROSION IN ANY OTHER AREA OR PART. I AM OUTRAGED THAT HYUNDAI CHOSE TO LIMIT THE RECALL OF THESE VEHICLES TO SELECT STATES. THIS INCIDENT CLEARLY DEMONSTRATES THE PROBLEM IS NOT LIMITED TO VEHICLES EXPOSED TO CORROSIVE CHEMICALS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

• 11/06/2006· SEAT BELTS

  DT*: THE CONTACT STATED THE DRIVER'S SIDE FRONT SEAT BELT WOULD NOT RETRACT OR HOLD CORRECTLY. IF THE VEHICLE WERE IN AN ACCIDENT IT WOULD NOT PROTECT THE OCCUPANT PROPERLY. THE SERVICE DEALER STATED THE SPRING WOULD NOT CATCH AND THE SEAT BELT NEEDED TO BE REPLACED.

• 11/05/2002· AIR BAGSCrash

  AIR BAGS ACTIVATED CAUSING DRIVER TO LOSE CONTROL OF VISIBILITY AND VEHICLE. *JB ABL.PCO ***DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS*****769299

• 11/04/2004· SUSPENSION

  WENT TO HAVE BRAKES REPAIRED AND WAS TOLD THAT THE RIGHT, FRONT BALL JOINT AND ARM WERE LOOSE. CONSEQUENTLY, BECAUSE OF THE WAY THE CAR WAS UNBALANCED THE TREADS ON THE TWO FRONT TIRES WERE BALD - SO OI HAD TO REPLACE THE TIRES ALSO. I WAS TOLD THAT THE CAR WAS NOT SAFE TO DRIVE AND ONE GOOD POTHOLE COULD HAVE CAUSED THE BALL JOINT AND ARM TO BREAK OFF. THE MOST DISTURBING THING ABOUT THIS WAS THAT I DETECTED NO CHANGE IN THE HANDLING OF THE CAR. NO NEW NOISES. NO INDICATION AT ALL THAT THERE WAS A SERIOUS PROBLEM.*AK

• 11/03/2015· STRUCTURE

  CAR RECALLED FOR "SALT BELT CORROSION" REPAIRS IN 2002. ORIGINAL OWNER SOLD CAR BACK TO HYUNDAI DEALERSHIP. REPAIRS WERE NEVER DONE.WHEN I BOUGHT THIS USED HYUNDAI ELANTRA IN LATE 2002, IT HAD LESS THAN 13K MILES ON ITS ODOMETER. IT WAS SERVICED AT A 2ND HYUNDAI DEALERSHIP UNTIL 2012, WHEN ITS 10 YR/ 100 K MI WARRANTY EXPIRED. TODAY, EVEN THOUGH IT STILL HAS < 100 K ON ITS ODOMETER, THE ENTIRE UNDERSIDE OF THE VEHICLE IS SO BADLY RUSTED THAT I'VE BEEN TOLD BY TWO DIFFERENT SOURCES THAT THE CORROSION ON THE UNDERSIDE IS SO BAD THAT, DURING A 50 MPH OR GREATER ACCIDENT, IT IS LIKELY THE ENTIRE INSIDE OF THE CAR COULD FALL ONTO THE HIGHWAY, WHILE IT KEPT MOVING FORWARD, DECAPITATING EVERYONE INSIDE. JPG IMAGES OF THE EXTENT OF THE CORROSION ON THIS VEHICLE ARE AVAILABLE AT: WWW.HYUNDAIDCM.COM/WEB/ACTIVITYDETAILS.ASPX?ACTIVITYID=7738650-4. MY HYUNDAI IS UNSAFE TO DRIVE BECAUSE HYUNDAI NEVER PERFORMED THE MANDATED NHTSA SERVICE IN 2002. PLEASE TAKE MY CASE ON.. I'VE FILLED OUT THE WHEN DID THIS HAPPEN? BOX BELOW WITH THE DATE WHEN HYUNDAI AMERICA HAD MY ELANTRA INSPECTED BY MANLY HYUNDAI (2702 CORBY AVE, SANTA ROSA, CA 95402). EVER SINCE THIS INSPECTION, HYUNDAI AMERICA HAS OFFERED TO PAY ME $ 1K TO "TAKE MY CAR AWAY". WHEN I ASKED THEM WHY NOT $ 3K (IT'S HIGH KELLY BLUE BOOK VALUE), THEY INFORMED ME IT "WAS A RUST BUCKET".YES, MY ELANTRA IS A "RUST BUCKET", BUT ONLY BECAUSE OF HYUNDAI'S FAILURE TO PERFORM THE REPAIRS REQUIRED IN NHTSA'S 2002 RECALL, THAT NEVER GOT DONE.

• 11/03/2003· SERVICE BRAKES, HYDRAULIC

  KNOCKING NOISE FROM REAR BRAKES. AFTER THE FOLLOWING REPAIRS I AM NOW BEING TOLD IT IS GENERAL MAINTENANCE AND SINCE I LIVE IN MAUI IT IS NOT ABNORMAL TO HAVE DIRT ON THE BRAKE PADS AND FOR IT TO MAKE THE KNOCKING NOISE. THIS GENERAL MAINTENANCE IS AT MY COST AND HAS BEEN HAPPENING FOR MONTHS. COULD END UP A MONTHLY EXPENSE. I DON'T BELIEVE THIS IS THE PROBLEM IF SO WHY ARE MORE CARS HAVING THE SAME PROBLEMS. 3/2003 FRONT PADS GLAZED BEFORE I GOT HOME THE KNOCKING 3/2003 KNOCKING NOISE AND WINDOW PILLAR AROUND WINDOWS 5/2003 FOUND -IMPROPERLY FORMED BRAKE SHOES- REPLACED 5/28-29/2003 SHOE & LINING-IMPROPERLY FORMED BRAKE SHOES 6/5-6/6/2003 BAD SEALS -REAR WHEEL CYLINDERS ORDERED 6/23/2003 REPLACED BAD SEALS -REAR WHEEL CYLINDERS ORDERED 7/14-7/18/2003 PAINTED DOOR FRAMES DUE TO WARPING OF DOOR TRIM 10/13/2003 CLEANED BRAKE PADS 10/14/2003 NOISE IS BACK *LA