2002 Dodge Durango

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2014· POWER TRAIN

  TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY SHIFTED OUT OF PARK. IN ADDITION, THE VEHICLE FAILED TO SHIFT OUT OF PARK INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V555000 (POWER TRAIN). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 138,500.

• 12/29/2004· SUSPENSION

  NHTSA CAMPAIGN 04V596000; DAIMLER CHRYSLER ISSUED A UPPER BALL JOINT RECALL. THIS VEHICLE IS NOT INCLUDED IN THE RECALL, HOWEVER THE CONSUMER HEARD A CLICKING NOISE AND EXPERIENCED SHAKING FROM THE UPPER BALL JOINT. THE VIN IS OUTSIDE THE REMEDY SCOPE. *JB THE CONSUMER WAS DISAPPOINTED IN THE RESPONSE HE RECEIVED FROM NHTSA. THE CONSUMER REPLACED BOTH UPPER CONTROL ARM ASSEMBLIES BECAUSE THEY WERE DANGEROUSLY WORN OUT. *TC

• 12/28/2004· SUSPENSION,TIRES

  WHILE DRIVING 65 MPH, THE FRONT OF THE VEHICLE BECAME UNSTABLE. THE CONSUMER GOT OUT OF THE VEHICLE AND DISCOVERED THAT THE OUTSIDE WALL OF THE PASSENGER SIDE FRONT TIRE WAS NOTICEABLY WARNED. THE OWNER CONTACTED THE MANUFACTURER WHO INSTRUCTED THE OWNER TO HAVE THE VEHICLE TOWED TO THE NEAREST DODGE DEALER. THE DEALER REFUSED TO TOW THE VEHICLE TO THE DEALERSHIP AND WOULD NOT RENDER ANY FURTHER ASSISTANCE. PROVIDE FURTHER DETAILS. *JB

• 12/26/2006· AIR BAGS

  AIR BAGS DID NOT DEPLOY. *NM

• 12/24/2011· ENGINE AND ENGINE COOLINGFire

  WHILE DRIVING A BURNING ODOR COULD BE DETECTED FROM INSIDE THE CABIN. SO I PULLED OVER TO CHECK THE ENGINE AND NO IMMEDIATE PROBLEM COULD BE SEEN. AFTER DRIVING FOR TWO BLOCKS I NOTICE THAT THE ODOR WAS GETTING STRONGER AND SMOKE WAS COMING FROM THE ENGINE. I PULLED OVER ONCE MORE OPEN THE HOOD. UPON FURTHER INSPECTION I NOTICE FLAME AT THE FIRE WALL WITHIN SECONDS THE WHOLE ENGINE COVERED IN FLAMES. *TR

• 12/24/2003· SERVICE BRAKES, HYDRAULIC,POWER TRAIN

  I HAVE 30,000 MILES ON MY 2002 DURANGO SLT PLUS. I HAVE HAD THE REAR REPLACED TWICE AND IT STILL MAKES NOISE. MY ENTIRE FAMILY JUST MISSED A ACCIDENT ( 3 CHILDREN) BECAUSE THE ANTILOCK BRAKES DO NOT FUNCTION PROPERLY UNDER AWD MODE. THE TRANSMISSION IS CLUNKING EVERYTIME WE STOP. THE BALL JOINTS ARE WEARING OUT! JUST FOUND OUT SEAT BELTS ARE UNSAFE! I AM SCARED TO DEATH FOR MY FAMILY ! *AK

• 12/21/2004· SUSPENSION

  WHILE DRIVING 25 MPH VEHICLE JERKED AND VIBRATED UNCONTROLLABLY. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT BOTH FRONT UPPER BALL JOINTS NEEDED TO BE REPLACED. *AK *NM

• 12/20/2002· POWER TRAIN

  THIS NOTE IS TO ACCOMPANY THE MOTOR VEHICLE DEFECT NOTIFICATION FOR MY 2002 DURANGO, VIN 1B8HR48N42F188761. THIS IS THE SECOND DEFECTIVE DURANGO I HAVE PURCHASED IN THE LAST FIVE MONTHS AND IT PRESENTS A SAFETY ISSUE. THE FIRST DURANGO WAS ONLY GOOD FOR FOUR DAYS AND LESS THAN 400 MILES. WE EXPERIENCED MULTIPLE PROBLEMS WITH IT TO INCLUDE TRANSMISSION SHIFTING, ENGINE VIBRATIONS, AND POOR HANDLING PROBLEMS. IT WAS DETERMINED BY THE DEALER THAT MULTIPLE COMPUTERS WERE BAD AND IT WOULD TAKE A CONSIDERABLE AMOUNT OF TIME TO REPAIR THE VEHICLE. AS A SOLUTION, THE DEALER PROVIDED US ANOTHER VEHICLE. THE CURRENT DURANGO IS ONLY FIVE MONTHS OLD AND HAS LESS THAN 5000 MILES. IT HAS BEEN IN THE SHOP EVERY WEEKEND FOR THE LAST THREE WEEKS FOR THE SAME PROBLEM. AS THE VEHICLE IS MOVING, IT DROPS TO FIRST GEAR COMING TO AN ALMOST COMPLETE STOP, LAUNCHING THE OCCUPANTS FORWARD DUE TO THE SUDDEN SPEED REDUCTION. THIS IN ITSELF IS A SAFETY ISSUE SINCE OCCUPANTS COULD GET HURT, NOT TO MENTION LOSS OF CONTROL BY THE DRIVER, POSSIBLY CAUSING AN ACCIDENT, OR THE VEHICLE BEEN HIT FROM BEHIND. IN ADDITION TO COMING TO AN ALMOST COMPLETE STOP, THE VEHICLE CHECK ENGINE LIGHT COMES ON AND THE VEHICLE LOCKS THE TRANSMISSION ON FIRST GEAR (IF IT MOVES AT ALL SINCE THE SECOND TIME IT MALFUNCTIONED, IT WOULD ONLY GO IN REVERSE AND HAD TO BE TOWED TO THE DEALER). PROBLEMS CONTINUE WITH THE VEHICLE. THE DEALER HAS INDICATED THAT THERE IS A SOFTWARE PROBLEM WITH THE TRANSMISSION MODULE BUT THEY DO NOT HAVE A FIX FOR IT YET!!!!! TS

• 12/18/2017· SEAT BELTS,SEATS

  DRIVER AND FRONT PASSENGER SEATS SLIDE BACK AND FORTH IN AN UNCONTROLLABLE MANNER WITH ACCELERATION, BRAKE AND TURNS. SEAT BELTS DO NOT ENGAGE TO LIMIT FORWARD/SIDE MOVEMENT OF HUMAN BODY. SEAT SLIDING/MOVEMENT HAS ENOUGH FORCE TO CAUSE INTERRUPTION OF CONTACT WITH VEHICLE'S GAS/BRAKE PEDALS. FORCEFUL FORWARD MOTION OF SLIDING SEAT HAS ENOUGH MOMENTUM ON DRIVER'S SIDE TO CAUSE HUMAN IMPACT ON THE STEERING WHEEL WHEN A HARD STOP/BRAKE ENGAGED. PASSENGER SIDE SEAT SLIDES WITH ENOUGH FORCE TO CAUSE HEAD TO IMPACT WINDSHIELD ON SUDDEN/HARD STOP. SEAT BELTS DO NOT ENGAGE TO STOP FORWARD OR SIDE MOTION OF HUMAN BODY WHEN EITHER SEAT SLIDES BACK/FORTH. 02/2015 CHRYSLER JEEP DODGE RAM REPAIRED SEAT FRAME WITH A NEW SWITCH (TECH NOTES 545 AND 579) AT MILEAGE: 116,616. 2017 CURRENT MILEAGE: 124,674. DRIVERS/PASSENGERS AT OR BELOW AGE/GENDER APPROPRIATE BMI.

• 12/16/2016· AIR BAGSCrash

  I WAS INVOLVED IN AN ACCIDENT WHERE I HIT THE VEHICLE IN FRONT OF ME TRAVWLLING APPX 45-50 MILES AN HOUR. AIR BAGS DID NOT DEPLOY.

• 12/15/2004· POWER TRAIN,TIRES

  2003 DARANGO HAS BEEN TAKEN TO JIM'S DODGE TO HAVE A PROBLEM FIXED WHEN YOU DRIVE. THEY TELL US THAT THERE IS NOTHING WRONG WITH IT. WHILE YOU DRIVE THE DARANGO IF YOU HIT A DUMP IT JUMPS TO ONE SIDE OR THE OTHER IT DOES NOT STAY CENTER. THE TRANSMISSION FEELS LIKE IT SLIPS, OR WHEN IT IS STARTED IT LIKE THE VEHICLE JUST DOES NOT WANT TO GO. JIM'[S DODGE HAS TOLD US THAT THERE IS NOTHING WRONG WITH THE VEHICLE, BUT THAT SEEMS TO ALL WE HAVE HAD WITH THIS VEHICLE. ONE MORE THING JIM'S DODGE IS NOT A VERY CLEAN PLACE TO TAKE YOUR VEHICLE TO HAVE IT WORKED ON WE HAVE GOT THE VEHICLE BACK WITH OIL ON THE IN SIDE ON THE VEHICLE, ON THE PAINT, SCRATCHS IN THE PAINT AND ON THE BUMPER. THE VEHICLE HAS COME BACK WITH A VERY BAD SMELL IN IT. IT TOOK US A LONG TIME TO GET THE SMELL OUT. WE CALLED JIM'S DODGE AND TOLD THEM ABOUT THE SMELL AND THEY TOLD US THAT THERE WAS NOTHING THA THEY COULD DO ABOUT IT. THE DATE MIGHT NOT BE EXACT BE CLOSE.*AK

• 12/13/2019· STRUCTURE

  TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE SPARE TIRE HOLDER WAS CORRODED, WHICH CAUSED THE SPARE TIRE TO DETACH FROM THE HOLDER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 92,000.

• 12/13/2004· SUSPENSION

  THE UPPER BALL JOINT IS MAKING A CLICKING NOISE, CAUSING THE VEHICLE TO HAVE DIFFICULT CONTROL ESPECIALLY WHEN MAKING TURNS. CONSUMER WILL TAKE VEHICLE TO DEALER FOR REPAIRS FOR THE SECOND TIME.*AK

• 12/13/2004· STEERING

  THERE WAS A KNOCKING NOISE AND GRINDING SOUND IN THE DRIVERS SIDE FRONT WHEEL. AFTER LOOKING AT IT FURTHER, THE TIE-ROD THAT CONNECTS TO THE RACK AND PINION STRIPPED THE THREAD AND FELL OFF. THE ABILITY TO STEER THE VEHICLE PROPERLY WAS LOST AND CONTROL OF THE VEHICLE WAS SEVERLY IMPACTED.*AK

• 12/12/2011· ELECTRICAL SYSTEM,VISIBILITY

  WHILE STOPPED AT AN INTERSECTION, THE AIR CONDITIONER/HEATER BLOWER MOTOR CEASED TO OPERATE IN ALL RANGES EVEN THOUGH THE A/C WAS ON AND THE COMPRESSOR CLUTCH WAS ENGAGED. ON INSPECTION, IT WAS OBSERVED THAT THE FIRST TWO PINS OF THE RESISTOR BLOCK WERE MELTED AS WAS THEIR CORRESPONDING SOCKETS IN THE PLUG. FURTHER, THE WIRING AT THE PLUG WAS SEVERELY OXIDIZED AND THE INSULATION WAS MELTED BACK. I REPLACED THE PLUG ASSEMBLY AND RESISTOR BLOCK. THE RESISTOR BLOCK HAD BEEN REPLACED THREE YEARS PRIOR WHEN THE LOWEST BLOWER SETTING CEASED TO OPERATE. INTERNET ACCOUNTS OCCUR FREQUENTLY ON THIS ISSUE. THIS CREATES A COLD WEATHER HAZARD AS THE DEFROSTER WILL CEASE TO OPERATE CREATING A DANGEROUS OPERATING CONDITION. TOTAL COST OF REPAIR MATERIALS WAS APPROXIMATELY $125.00. *TR

• 12/12/2004· ENGINE AND ENGINE COOLING

  ENGINE JUST STOPPED. CAR WAS TAKEN TO CHRYSLER DEALERSHIP. THEY SAID THERE IS SLUDGE IN THE ENGINE. SO FAR NOTHING HAS BEEN DONE TO CORRECT THE PROBLEM. *JB

• 12/11/2004· LATCHES/LOCKS/LINKAGES

  DOOR LOCKS INTERMITTENTLY UNLOCKING AND LOCKING WHILE DRIVING IN THE RAIN. *JB

• 12/11/2004· SUSPENSION

  BOTH BALL JOINTS ON MY 2002 DURANGO VIN [XXX] MILES 47000 [APPROX]. *JB SEPTEMBER 04 MARIETTA DODGE SCOOT THE SERVICE MANAGER SAID THEY SHOULD NOT BE BAD ON A 2 YEAR OLD VEHICLE WITH AVERAGE MILES. BUT I AM TOLD THAT MY VEHICLE IS NOT COVERED UNDER THE RECALL. IT IS EXTRMELY CLEAR IT SHOULD BE. UPDATED 07/24/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 12/11/2003· SUSPENSION

  MY 2002 DODGE DURANGO LEFT AND RIGHT UPPER BALL JOINTS WORE OUT PREMATURELY. THEY COULD NOT BE FIXED AND HAD TO BE REPLACED AT $625.82 AT A DODGE DEALERSHIP. I UNDERSTAND THIS IS UNDER INVESTIGATION FOR DEFECTIVE EQUIPMENT. *AK

• 12/10/2004· TIRES

  I'M DRIVING A 2002 DODGE DURANGO. MY CAR PULLED TO THE RIGHT, I GOT A TIRE ROTATION AND NOW IT'S PULLING TO THE LEFT. I SAW IN THE NEWS THAT THERE IS A PROBLEM WITH THE FRONT UPPER JOINT BALL, SO THAT COULD HAVE SOMETHING TO DO WITH MY PROBLEM. THE TIRES ARE FINE.*AK

• 12/10/2004· SUSPENSION

  THE FRONT LEFT SIDE BALL JOINT WAS MAKING A GRINDING NOISE CAUSING THE WHEEL TO SHAKE AND MAINTAIN CONTROL. CONSUMER TOOK VEHICLE TO DEALER FOR REPAIRS FOR THE SECOND TIME IN A MONTH.*AK

• 12/10/2004· SUSPENSION

  WHILE STEERING TO THE RIGHT CONSUMER HEARD A LOUD KNOCKING NOISE COMING FROM THE FRONT. CONSUMER APPLIED THE BRAKE PEDAL AND VEHICLE VIBRATED UNCONTROLLABLY. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT BOTH FRONTAL UPPER BALL JOINTS NEEDED TO BE REPLACED. *AK

• 12/10/2003· SERVICE BRAKES, HYDRAULIC

  THE BRAKES PULSATED WHEN THEY WERE APPLIED. HOWEVER, THERE WASN'T ANY PROBLEM WITH BRAKING. THE DRIVER TOOK THE VEHICLE TO THE DEALER AND THE MECHANIC NOTICED THAT BOTH FRONT ROTORS WERE WARPED AND NEEDED TO BE RESURFACED *AK AFTER REPLACING 3 SETS OF ROTORS WITHIN SIX MONTHS THE CONSUMER FEELS THAT DODGE AUTO PARTS ARE DEFECTIVE. *CB *JB

• 12/09/2009· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2002 DODGE DURANGO. WHILE DRIVING 15 MPH THE VEHICLE STALLED WITHOUT ANY PRIOR WARNINGS. HE COULD NOT RESTART THE VEHICLE. HE CONTACTED THE MANUFACTURER AND THE DEALERSHIP , BUT WAS NOT PROVIDED WITH ANY ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. THE CURRENT AND FAILURE MILEAGES WERE 141,016.

• 12/09/2007· POWER TRAIN

  ON THE FIRST DAYS OF NOVEMBER, I STOPPED ON A RED LIGHT, WHEN THE LIGHT WAS GREEN I STARTED GOING. WHEN THE TRANSMISSION REACHED THE THIRD GEAR, THE ENGINE REVVED UP TO 3000 + RPM. TOOK IT TO MECHANIC AND USED THE SCANNER TOOL TO FOUND OUT THAT THE TRANSMISSION WAS SLIPPING ON THE THIRD AND FOURTH GEAR. I WAS DRIVING LATE NIGHT SO NOT TOO MANY CARS AROUND. I HAD TO REPLACE THE WHOLE TRANSMISSION. *TR

• 12/09/2002· SERVICE BRAKES, HYDRAULIC

  CONSUMER WAS DRIVING AND APPLIED BRAKES SUDDENLY. BRAKES WERE FUNCTIONING ERRATICALLY AND CAR WOULD NOT STOP, ONLY "BARELY" SLOW DOWN. ABS DID NOT ENGAGE AND CONSUMER HAD TO DRIVE VEHICLE OFF THE ROAD TO EFFECTIVELY SLOW IT DOWN. DEALER COULD NOT DUPLICATE OR DIAGNOSE PROBLEM. TS

• 12/08/2007· POWER TRAIN

  TRANSMISSION WILL NOT STAY ENGAGED IN PARK. PARKING WILL NOT ENGAGE AND THE ONLY WAY TO KEEP VEHICLE FROM ROLLING IS TO APPLY THE PARKING BRAKE. *TR

• 12/08/2006· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  DODGE DURANGO JUST STOPS RUNNING AT RANDOM TIMES. THIS OCCURS AT SPEEDS OF 10-60 MPH OR EVEN WHEN THE CAR IS BEING STARTED. THE ODOMETER BLINKS AND READS NO BUS. THERE ARE NUMEROUS REPORTS OF THIS ON DODGE INTERNET FORUMS. THE POWERTRAIN CONTROL MODULE AND/OR CRANKSHAFT SENSORS END UP BEING REPLACED, BUT THE PROBLEM IS HARD TO DIAGNOSE AND DANGEROUS BECAUSE IT OCCURS WITHOUT WARNING AND WHILE DRIVING. WITH SO MANY REPORTS ON 1999-2002 DODGE DURANGOS HAVING THIS PROBLEM (SEARCH DURANGO PCM "NO BUS") SOMETHING MUST BE DEFECTIVE. MY DURANGO BEGAN DOING THIS ABOUT A MONTH AGO AND THE DEALER DOESN'T SEE ANYTHING WRONG. I WAS MILDLY INJURED DURING ONE OF THE FAILURES, WHEN MY DURANGO 'SHUT OFF' WHILE I WAS COMING DOWN A HIGHWAY RAMP AND I BUMPED MY HEAD AGAINST THE DRIVER SIDE WINDOW WHILE TRYING TO STABILIZE THE CAR, WHICH SUDDENLY AND WITHOUT WARNING HAD NO POWERTRAIN CONTROL. *JB

• 12/07/2004· AIR BAGSCrash

  WHILE DRIVING AT 25 MPH CONSUMER'S VEHICLE WAS INVOLVED IN A COLLISION, HITTING ANOTHER VEHICLE. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY. VEHICLE WAS TOWED TO A COLLISION CENTER.*AK

• 12/05/2006· ENGINE AND ENGINE COOLING,POWER TRAIN,ELECTRICAL SYSTEM

  2002 DODGE DURANGO. CAR ENGINE "SURGES" WHEN STARTING TO DRIVE, THEN RETURNS TO NORMAL AFTER A FEW HUNDRED YARDS. OCCURS AT SPEEDS OF 10-20 MPH. REPORTED TO DEALER. DEALER UNABLE TO REPRODUCE PROBLEM. OCCURS RANDOMLY, BUT ABOUT 1-2 A MONTH. CAR ALSO STOPS AND WILL NOT RESTART. RECURS RANDOMLY AND WITHOUT WARNING. LOCAL MECHANIC FEELS PROBLEM COULD BE POWERTRAIN CONTROL MODULE RELATED. OCCURS AT SPEEDS OF 0-60 MPH. *JB

• 12/05/2003· SUSPENSION

  AT 27K MILES MY DODGE DURANGO NEEDED BOTH THE UPPER AND LOWER BALL JOINTS REPLACED FOR BOTH THE LEFT AND RIGHT SIDE. *JB

• 12/04/2006· ELECTRICAL SYSTEM

  CENTRAL TIMER MODULE FAILED UNEXPECTEDLY AT NIGHT, CAUSING HEADLIGHTS, TAILLIGHTS, SECURITY INDICATOR AND HORN TO ACTIVATE INTERMITTENTLY WHILE DRIVING. VEHICLE UNSAFE TO OPERATE IN THIS CONDITION. OUT OF WARRANTY, DEALER CHARGES $421.00 TO FIX. THIS FOLLOWS SEVERAL IN-WARRANTY ELECTRICAL REPAIRS - REMOTE LOCKING MECHANISM, REAR AXLE SPEED SENSOR AND POWERTRAIN CONTROL MODULE. DEFECT COULD EASILY CAUSE A WRECK AND POSES A SAFETY HAZARD. *JB

• 12/04/2002· SERVICE BRAKES, HYDRAULIC

  CONSUMER STATES THAT WHEN TRYING TO APPLY THE BRAKES THE BRAKE WILL PULSATE CAUSING THE VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. DEALER NOTIFIED. TS

• 12/03/2010· ELECTRICAL SYSTEM

  I HAVE A 2002 DODGE DURANGO SPORT WITH 123K MILES. I WAS DRIVING 70 MPH ON THE FREEWAY, WHEN MY CAR COMPLETELY SHUT DOWN....I.E. POWER STEERING, POWER BRAKES, EVERYTHING. DUE TO THE FACT THAT I COULD HARDLY TURN OFF THE ROAD I WAS NEARLY REAR ENDED BY AN 18 WHEELER. I HAD 2 SMALL CHILDREN IN THE VEHICLE WITH ME, AND IT WAS ONE OF THE MOST TERRIFYING EXPERIENCES OF MY LIFE. I HAVE READ ONLINE THOUSANDS OF PEOPLE HAVING THE SAME ISSUES, WHICH ARE APPARENTLY THE PCM IS TOO CLOSE THE ENGINE WHICH CAUSES THE VEHICLES INSTRUMENTS TO SHUT DOWN. I FIND THIS A MAJOR REASON TO INVESTIGATE THIS ISSUE. DOES CHRYSLER/DODGE NEED A WHOLE FAMILY TO DIE IN ONE OF THEIR VEHICLES BEFORE THEY DECIDE TO ISSUE A RECALL? THIS IS A VERY SERIOUS ISSUE THAT THE NHTSA NEEDS TO INVESTIGATE BEFORE, IF IT HASN'T HAPPENED YET, SOMEONE GETS KILLED. *TR

• 12/02/2014· SUSPENSION,SERVICE BRAKES, HYDRAULIC

  TL* THE CONTACT OWNS A 2002 DODGE DURANGO. WHILE DRIVING 75 MPH, THE REAR DRIVER SIDE TIRE VIBRATED, ACCOMPANIED BY A GRINDING NOISE AND LOUD SOUND. THE CONTACT EXITED THE VEHICLE AND DISCOVERED THE WHOLE TIRE WAS MISSING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE REAR AXLE AND DRUM NEEDED TO BE REPLACED. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

• 12/01/2006· SUSPENSION

  REAR LEAF SPRING (DRIVER'S SIDE) BROKE OFF FROM THE SHACKLE CAUSING THE VEHICLE TO WANDER TO THE RIGHT! *JB

• 11/29/2019· SERVICE BRAKES,ENGINE,FUEL/PROPULSION SYSTEM

  WHILE DRIVING, NO MATTER WHAT SPEED THE VEHICLE STARTS TO SPUTTER, LOSES POWER AND WILL STALL. I WAS LOW ON GAS, AND TOOK MY CAR TO A LOCAL GAS STATION FOR FUEL. AFTER PUTTING $10 IN MY CAR WAS RUNNING EXTREMELY ROUGH. I WAS DOING ABOUT 20 MPH, WHEN IT JUST SHUT OFF. BRAKES GOT REAL HARD. AFTER RE STARTING THE VEHICLE ALL SEEMED NORMAL. THEN, I DROVE ABOUT 3 CAR LENGTHS AND IT DID IT AGAIN AT A RED LIGHT. I TRIED PUSHING THE GAS TO SEE IF THAT WOULD DO ANYTHING, IT DIDNT. I DROVE ALL IN , ABOUT 3 MILES, AND THE CAR STALLED 7 TIMES. WHILE IN THE DRIVE THROUGH, IT STALLED 3 ABD AT ONE POINT JERKED SO FAR I THOUGHT I WAS GOING TO HIT THE CAR IN FRONT OF ME. VEHICLE SPEED DOES NOT MATTER , AS IT WILL SLOWLY LOSE POWER AND TURN OFF. I WAS DRIVING LOCALLY ON A CITY STREET. MY BEST GUESS TO THIS PROBLEM WOULD BE SOMETHING RELATED TO THE EVAP SYSTEM, QUITE POSSIBLY THE PURGE VALVE BUT IM NOT 100% SURE BUT THIS SITUATION IS VERY UNSAFE, I HAVE 2 SMALL CHILDREN AND CANNOT DRIVE THIS VEHICLE. DURING MY TRIP THE SPEED WAS BETWEEN 20-45 MPH

• 11/29/2005· SERVICE BRAKES, HYDRAULIC

  BRAKE PROBLEMS WITH MY 2002 DODGE DURANGO XLT PLUS. AT HIGH OR LOW SPEEDS WHEN YOU HAVE TO MAKE A SUDDEN STOP AND HIT THE BRAKES, THEY ATTEMPT TO GRAB BUT THEN LET GO, AND YOUR ONLY HOPE IS TO STOP IN TIME. I HAVE HAD THE BRAKES LOOKED AT BY 2 MECHANICS OTHER THAN THE DODGE DEALERSHIP(TIM PARKER OF HOT SPRINGS) AND BOTH SAY THAT THERE IS A DEFINITE PROBLEM WITH THE BRAKES. HOWEVER, AFTER SPENDING $300 FOR BRAKE PADS AND SEVERAL OTHER VISITS TO TIM PARKERS, THEY KEEP DENYING A PROBLEM AND TELL ME THAT IS JUST HOW THE BRAKES ARE ON THE DODGE. I ASKED THEM IF WHEN THAT 1 SMALL CHILD RUNS OUT IN THE STREET TO CATCH HIS BALL AND I AM THE UNLUCKY PERSON TO BE TRAVELING DOWN THAT STREET AND I APPLY THE BRAKES BUT CAN NOT STOP, IF THEY WOULD BE READY TO ACCEPT THEIR RESPONSIBLILITY. I HAVE COPIES OF ALL REPORTS FROM THEM STATING THERE IS NOTHING WRONG WITH THE BRAKES. I AM AFRAID TO DRIVE IT AT ALL BUT TRAVELEING 64 MILES A DAY IT IS NECESSARY. CAN SOMEONE PLEASE HELP ME? SURELY I AM NOT THE ONLY PERSON COMPLAINING OF THE BRAKES! *NM

• 11/29/2004· ELECTRICAL SYSTEM

  IGNITION SWITCH FAILED ON 2002 DURANGO AFTER ONLY 55,000 MILES. STUCK IN LOCK POSITION. NOT COVERED UNDER WARRANTY, DEALER CHARGED $400.00 TO REPLACE.*AK

• 11/28/2007· SUSPENSION

  I PURCHASED A 2002 DODGE DURANGO IN JAUARY OF 2007. I HAVE NOT HAD ANY PROBLEMS WITH IT UNTIL I NOTICED THAT THE TRUCK WAS PULLING TO THE RIGHT. I TOOK THE TRUCK TO A LOCAL SERVICE CENTER AND THEY INFORMED ME THAT THE UPPER AND LOWER BALL JOINTS NEEDED TO BE REPLACED. THEY ALSO INFORMED ME THAT THERE HAD BEEN A RECALL FOR THE UPPER BALL JOINTS FOR CHRYSLER. WHEN I CONTACTED THE LOCAL DEALER THEY TOLD ME THAT THE RECALL HAD BEEN PERFORMED ON MY TRUCK IN 2005. WHEN I INFORMED THE SERVICE CENTER THAT THE RECALL HAD BEEN DONE THEY WERE AMAZED TO FIND THAT THEY BALL JOINTS HAD WORN SO QUICKLY AND THE PROBLEM WITH THE BALL JOINTS "STILL" PRESENTS VERY DANGEROUS SITUATION FOR DODGE DURANGO OWNERS. *TR

• 11/26/2020· ENGINEFire

  WHEN DRIVING TO THE STORE I SHUT VEHICLE OFF AND WENT IN . WHEN I CAME OUT I CRANKED IT OVER AND IT STARTERED AND THEN CAUGHT ON FIRE BY FIREWALL AND WAS INGOLFED IN FLAMES

• 11/25/2003· SUSPENSION,AIR BAGSCrash

  WHILE STOPPED IN TRAFFIC THE CONSUMER'S VEHICLE WAS STRUCK FROM BEHIND BY ANOTHER VEHICLE. THE CONSUMER'S VEHICLE COLLIDED WITH THE VEHICLE IN FRONT OF IT. UPON IMPACT, AIR BAGS DID NOT DEPLOY. CONSUMER WAS WEARING A SEAT BELT BUT STILL SUFFERED INJURIES TO THE RIGHT KNEE. A POLICE OFFICER ARRIVED ON THE SCENE. ALSO, NHTSA PE 03-032, FRONT SUSPENSION UPPER BALL JOINT FAILURE: WHILE VEHICLE WAS GETTING REPAIRED MECHANIC FOUND THAT UPPER BALL JOINTS WERE WEARING OUT AT AN ALARMING RATE. *AK

• 11/25/2003· ELECTRICAL SYSTEMFire

  CONSUMER STATED THAT WHILE DRIVING SHE SMELLED AN ODOR OF BURNING RUBBER BUT DIDN'T KNOW THAT IT WAS HER VEHICLE. AS SOON AS SHE PUT THE TURN SIGNAL ON, ALL THE DASHBOARD LIGHTS STARTED TO BLINK. WHEN THE TURN WAS COMPLETE SHE SAW SMOKE COMING FROM UNDER THE DASHBOARD. THE CONSUMER MANAGED TO PULL OVER INTO A MALL PARKING LOT AND AT THAT POINT THE VEHICLE WENT UP IN FLAMES. *AK *NLM

• 11/24/2008· POWER TRAIN

  TL*THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE WOULD BECOME STUCK IN THE PARK POSITION FOR APPROXIMATELY 2-3 MINUTES. THE DEALER COULD NOT ASSIST BECAUSE THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V555000 (POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT). THE FAILURE AND CURRENT MILEAGES WERE 113,000.

• 11/22/2017· ELECTRONIC STABILITY CONTROL (ESC)

  VEHICLE STALLS INTERMITTENTLY WITH OUT WARNING AT ANY SPEED INCLUDING IN PARK AND WHILE IDLING. WHEN THIS OCCURS POWER STEERING IS LOST, GAUGES FREEZE IN LAST POSITION, NO CHECK ENGINE LIGHT. VEHICLE STARTS RIGHT BACK UP WITHOUT HESITATION. DURING MY 7 MINUTE DRIVE TO WORK IT MAY STILL ONCE OR NOT AT ALL UP TO 7 TIMES. VEHICLE IS CURRENTLY SITTING AT A DODGE DEALERSHIP GARAGE WHERE THEY ARE UNABLE TO DIAGNOSE IT DUE TO VEHICLE NOT GIVING AND CODES EVEN WITH IT STALLING FOR THEM MULTIPLE TIMES. I ALREADY REPLACED THE CRANKSHAFT POSITION SENSOR AND IT DIDN'T FIX THE ISSUE. MY OPTIONS ARE TAKE MY CAR BACK STILL STALLING OR REPLACE THE PCM $500-$900 WHICH MAY NOT BE THE PROBLEM THEN I'M OUT THE MONEY. I GUESS FINGERS CROSSED SINCE NO ONE AT THIS GARAGE HAS EVER SEEN A VEHICLE NOT THROW A CODE WITH THEM WITNESSING THE ISSUE

• 11/22/2010· SUSPENSION,POWER TRAIN

  TL*THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING 10-15 MPH, HE HEARD A NOISE. WHEN THE VEHICLE WAS TAKEN TO LOCAL REPAIR SHOP, THE CLUTCH PACK RETAINING CLIP ON THE REAR DIFFERENTIAL WAS REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000. UPDATED 1/21/11 *CN THE CLUTCH PACK RETAINER FAILED AND HAD TO BE REPLACED AS WELL AS THE ENTIRE REAR DIFFERENTIAL POST UNIT. UPDATED 03/23/11

• 11/21/2002· ENGINE AND ENGINE COOLING

  CONSUMER'S VEHICLE LOSES POWER AND SHUTS OFF WHILE IN MOTION.

• 11/20/2003· SUSPENSION

  DURING INSPECTION, MECHANIC NOTICED THE PASSENGER FRONT TIRE WOBBLED. DEALER STATED THE PASSENGER FRONT UPPER BALL JOINT WAS WORN OUT AND HAD TO BE REPLACED. PARTS ARE ON BACK ORDER. *PH

• 11/20/2002· SERVICE BRAKES, HYDRAULIC

  WHEN STOPPING QUICKLY, BUT NOT IN A PANIC. THE ABS BRAKE SYSTEM WILL SOMETIMES BRAKE AND RELEASE. WHEN THE BRAKES ARE NO WHERE NEAR LOCKUP. THIS HAS CAUSED THE ME TO COME CLOSE TO REAR ENDING A VEHICLE IN FRONT OF ME THAT SHOULD HAVE BEEN A SLIGHTLY FASTER STOP THAN NORMAL, BUT NO WHERE CLOSE TO CAUSING AN ACCIDENT. I WOULD PREFER NO ABS SYSTEM IF THIS SYSTEM ON THE DURANGO IS NORMAL. NO ACCIDENTS FOR OVER 30 YEARS, BUT TWO CLOSE CALLS WITH THIS VEHICLE. I KNOW THIS IS NOT NORMAL FOR NORMAL ABS BRAKES. DEALER FOUND NO PROBLEMS WITH THE BRAKES. DT

• 11/19/2008· ELECTRICAL SYSTEM

  2002 DODGE DURANGO THE HEATER BLOWER WIRES STARTED TO MELT, THE HEATER BLOWER RESISTOR FAILED AND THE PLUG BETWEEN THE WIRES AND RESISTOR MELTED TOGETHER. THIS IS THE SECOND TIME THIS HAS HAPPENED. FIRST TIME THE VEHICLE WAS IN WARRANTY AND THE DEALER JUST REPLACED THE RESISTOR. I WOULD HAVE TO LOOK AT MY RECORDS BUT I BELIEVE IT WAS AROUND 58,000 MILES ON THE VEHICLE. NOW THE VEHICLE HAS 80,000 MILES ON IT. AT FIRST IT SMELLED LIKE SOMETHING WAS BURYING WHEN THE BLOWER FAN WAS ON. THE HIGHER THE SETTING THE WORST THE SMELL BECAME. I HAVE REPLACED THE RESISTOR BUT LEFT THE MELTED PLUG AND WIRES BECAUSE THE DEALER WANTS $70.00 JUST FOR THE PARTS. I AM GUESSING I WILL HAVE TO REPLACE THE WIRES AND PLUG THE NEXT TIME THIS HAPPENS. I BELIEVE I HAVE ALREADY THROWN OUT THE PART BUT I WILL CHECK. THE MELTED PLUG IS ON THE VEHICLE. *TR