2001 Volvo S80

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/29/2011· FUEL SYSTEM, GASOLINE

  TL* THE CONTACT OWNS A 2001 VOLVO S80. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 09V483000 (FUEL SYSTEM; GASOLINE; DELIVERY; FUEL PUMP) AND WAS TOLD THAT THE VEHICLE COULD NOT BE REPAIRED UNDER THE RECALL BECAUSE IT HAD BEEN TEN YEARS SINCE THE VEHICLE WAS MANUFACTURED. THE RECALL WAS ISSUED DECEMBER 7, 2009. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE CURRENT MILEAGE WAS 65,000.

• 12/20/2006· ENGINE AND ENGINE COOLING

  2001 VOLVO S80 T6. VEHICLE STALLS WITHOUT WARNING WHEN ACCELERATOR IS RELEASED AND VEHICLE RETURNS TO IDLE. PROBLEM WAS FIXED ONCE BUT HAS RETURNED. DEALER & VOLVO N.A. SAY THAT SINCE THERE IS NO COMPUTER CODE FOR THE STALL AND THEY CAN'T DUPLICATE IT THERE IS NO CURE. VEHICLE HAS STALLED ON NUMEROUS OCCASIONS DURING THE LAST 5 MONTHS INCLUDING 12/17/2006 IN HEAVY TRAFFIC THE HOV LANE ON THE LONG ISLAND EXPRESSWAY. HAS ALSO STALLED IN HIGH SPEED TRAFFIC ON I95 IN STAMFORD, CT AND WHILE MAKING TURNS AND GOING THROUGH INTERSECTIONS. *JB

• 12/15/2012· SUSPENSION,SEAT BELTS,VEHICLE SPEED CONTROL

  I PURCHASED VEHICLE 8 MONTHS AGO I NOW HAVE PROBLEMS WITH THE FRONT AND BACK SUSPENSION. THE AIR TURNS ON ITS OWN, THE AXLE HAS BROKEN, THE SUNROOF OPENS WHEN IT WANTS TO OPEN, CHECK ENGINE LIGHT HAS TURNED ON ALONG WITH MAINTENANCE LIGHT, MY DOORS WILL UNLOCK THEMSELVES WHEN I LOCK THEM AND THE ALARM WILL ENGAGE, THE LEFT WINDOW DOES NOT WORK , SOMETIMES I CANT UNLOCK THE DOORS HAVE TO UNLOCK WITH MY HAND. MY CRUISE CONTROL DOES NOT WORK, THE BATTERY STOPS WORKING OFTEN, THE INSIDE LIGHTS WORK SOMETIMES. IT IS RUNNING TERRIBLE , IDLE UP AND DOWN I KNOW ALL HAS SOMETHING TO DO WITH RECALL PLEASE HELP! *TR

• 12/12/2006· ELECTRICAL SYSTEMCrash

  I PURCHASED MY VOLVO S80 NOT EVEN 1 YEAR AGO AND I AM EXPERIENCING PROBLEMS WITH MY CAR LOSING ACCELERATION IN TRAFFIC AND IDLING WILDLY. THE PROBLEM HAS BECOME SO SEVERE THAT AT ONE POINT AT A COMPLETE STOP, MY CAR SURGED FORWARD AND HIT THE CAR IN FRONT OF ME! THANK GOODNESS THERE WAS NO DAMAGE OR INJURIES TO MYSELF OR TO THE CAR INVOLVED. I TOOK THE VEHICLE TO THE DEALERSHIP AND WAS INFORMED THE PROBLEM LIES WITH THE THROTTLE. HOWEVER, VOLVO REFUSES TO ISSUE A RECALL AND HIDES BEHIND THE "WARRANTY" SONG AND DANCE EVEN THOUGH THEY AGREE THERE IS A PROBLEM WITH THE THROTTLES IN THEIR VEHICLES. I DID MUCH RESEARCH (OR SO I THOUGHT) BEFORE PURCHASING MY VEHICLE. I CHOSE VOLVO BECAUSE THEY ADVERTISE THE FACT THAT THEY MANUFACTURE ONE OF THE SAFEST CARS ON THE MARKET. MY WIFE OWNS A VOLVO S60 AND HAS HAD SIMILAR PROBLEMS. I FEAR FOR THE SAFETY OF MY WIFE AND 6 YEAR OLD SON. I PLAN TO GET RID OF THIS DANGEROUS VEHICLE FIRST CHANCE I GET. *NM

• 12/09/2004· ELECTRICAL SYSTEM

  MANUFACTURING DEFECT, POOR TO ZERO RECEPTION ON AM RADIO. THE PROBLEM EXISTED SINCE THE BEGINNING PURCHASED CAR NEW FROM DEALER. THE DEALER REFUSED TO REPAIR AT NO COST. *BF *SC

• 12/06/2005· VEHICLE SPEED CONTROL,EQUIPMENT

  MY 2001 VOLVO S-80 SUDDENLY LOST ALL POWER AND CAME TO A STOP AND WOULD NOT RESTART. THIS OCCURRED IN SEPT. 2003. THE DEALERSHIP, BEACH VOLVO IN MYRTLE BEACH, SC, WANTED OVER $600 TO REPAIR THE AUTO SINCE IT WAS BEYOND THE 50,000 MILE WARRANTY. IT HAD 60,000 MILES AT THE TIME. AFTER A LENGTHY DISCUSSION WITH VOLVO AMERICA, THEY AGREED TO SPLIT THE COST BETWEEN MYSELF, THE DEALERSHIP AND VOLVO AMERICA. THE ELECTRONIC THROTTLE BODY WAS REPLACED. ON 12/05/05 THE SAME THING HAPPENED. THE CAR NOW HAS 82,700 MILES. IT IS BEING LOOKED AT BY BEACH VOLVO AT THIS MOMENT. *NM

• 12/05/2005· VEHICLE SPEED CONTROL

  I OWN A 2001 VOLVO S80, 4 DR. SEDAN WHICH I AM IN THE PROCESS OF TRADING IN BECAUSE ON 3 DIFFERENT OCCASIONS THIS YEAR (2005) THE CAR STALLED, THE LAST TIME I NEEDED TO HAVE IT TOWED. AFTER DOING SOME RESEARCH I NOTED THAT VOLVO HAD REACHED AN AGREEMENT REGARDING COMPLAINTS FILED IN CALIFORNIA ABOUT THE ETM MODULE. I BELIEVE THAT WAS THE CAUSE OF MY STALLING. I DID HAVE THE PART REPLACED, AT MY EXPENSE AND THE MECHANIC SHOWED ME THE PART THAT WOULD NOT STAY CLOSED CONSEQUENTLY CAUSING THE CAR TO STALL. AT NO TIME WAS THERE AN INDICATION THAT THERE WAS A PROBLEM - NO WARNING LIGHT. WHILE I LOVE THE CAR, I DON'T FEEL I CAN TRUST IT EVEN THOUGH A NEW PART WAS PUT IN. ACCORDING TO THE VOLVO DEALER, PART WOULD NOT BE REPLACED UNLESS WARNING INDICATOR CAME ON. THE LAST TIME THE CAR STALLED WAS THANKSGIVING NIGHT. *NM

• 12/05/2004· POWER TRAIN

  THIS CAR WAS STUCK IN PARK. WE COULD NOT SHIFT THE CAR OUT OF PARK INTO DRIVE. WE WERE STUCK IN A LINE OF TRAFFIC AND IT WAS A DANGEROUS INCIDENT. WE REPEATEDLY CORRECTLY DEPRESSED THE BUTTON ON THE GEAR SELECTOR KNOB AND AND AT THE SAME TIME DEPRESSSED THE BRAKE PEDAL ( WE HAVE DONE THIS THOUSANDS OF TIMES ON THIS VEHICLE FROM 2001 TO PRESENT WITHOUT ANY PROBLEMS) . IT TOOK OVER 15 MINUTES OF TURNING OFF THE ENIGINE AND RESTARTING IT, TURNING THE STEERING BACK AND FORTH TO FINALLY GET IT OUT OF PARK INTO DRIVE. WE ARE FULLY AWARE OF THE BRAKE SHIFT INTERLOCK SAFETY FEATURE. THIS INCIDENT WAS THE RESULT OF EQUIPMENT MALFUNCTION AND NOT OPERATOR ERROR. MY WIFE AND I EACH STRUGGLED TO FINALLY GET IT FROM PARK TO DRIVE. THIS IS A REAL EQUIPMENT PROBLEM THAT NEEDS TO BE INVESTIGATED AND CORRECTED. MY WIFE AND I BOTH DRIVE VOLVOS AND ARE EXPERIENCED VOLVO DRIVERS. ANY SUGGESTION OF OPERATOR ERROR IS FRIVOLOUS DEFENSE.*AK

• 12/02/2017· AIR BAGS,STRUCTURE,UNKNOWN OR OTHERCrash

  ON NOVEMBER 9TH MY WIFE WAS DRIVING OUR 2001 VOLVO S80 TO CHURCH. SHE PARKED THE CAR BUT IT BEGAN TO MOVE. IT ACCELERATED AND SHE WOUND UP DRIVING INTO A TREE TO AVOID HITTING OTHER CARS. SHE WAS ALSO WORRIED THAT CHILDREN FROM THE SCHOOL MIGHT BE AROUND. THE CAR WAS IN PARK. THE ENGINE WAS OFF. THE EMERGENCY BREAK WAS ON. THE STEERING WHEEL WAS TIGHT, MAKING IT DIFFICULT TO STEER SINCE THE ENGINE WAS OFF. THE CHURCH SECRETARY OBSERVED THE INCIDENT. SHE SAW SMOKE COMING OUT OF THE BACK OF THE CAR WHICH WOULD INDICATE THE EMERGENCY BREAK WAS ON. WHEN SHE FIRST REACHED THE CAR WITH MY WIFE IN IT SHE NOTED THAT THE CAR WAS IN PARK.

• 12/02/2010· VISIBILITY

  BOTH FRONT POWER WINDOW REGULATORS FAILING. *TR

• 12/02/2005· VEHICLE SPEED CONTROL

  DT: THE CONTACT STATED THE VEHICLE STALLED WHILE DRIVING. THERE WERE NO WARNING LIGHTS ON WHEN THIS HAPPENED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP ,AND THEY REPLACED THE THROTTLE CONTROL MODULE AT THE CONTACT'S EXPENSE. SHE RECEIVED AN EXTENDED WARRANTY FROM VOLVO, AND IT STATED SHE NEEDED TO CONTACT THE MANUFACTURER FOR REIMBURSEMENT. *AK

• 12/02/2005· VEHICLE SPEED CONTROL

  DT: THE CONTACT STATES WAS DRIVING ON THE HIGHWAY WHEN THE CAR COMPLETELY STALLED, RESULTING IN LOSS OF POWER. THE WARNING LIGHTS CAME ON PRIOR TO THE CAR STOPPING. SHE REPORTED HAVING NO PROBLEMS PRIOR TO THIS INCIDENT. THE VEHICLE WAS TOWED TO THE DEALERSHIP, AND THEY STATED TO CONTACT THE NHTSA HOT LINE SERVICES AND FILE A COMPLAINT. THE CAUSE HAS NOT BEEN DETERMINED.*AK

• 12/02/2002· EXTERIOR LIGHTING

  THE 2001 VOLVO S80 HEADLIGHT & DAYTIME RUNNING LIGHT SYSTEM. THE 2001 VOLVO S80 HEADLIGHT & DAYTIME RUNNING LIGHT SYSTEM. THE DASHBOARD LIGHTS AND DAYTIME RUNNING LIGHTS ARE ON AT START UP. DURING DARKNESS THERE IS NO INDICATION THAT THE NIGHT TIME HEADLAMPS ARE IN THE OFF POSITION (BECAUSE THE DASHBOARD LIGHTS ARE ON AND DAYTIME LAMPS ILLUMINATE THE ROAD TO SOME EXTENT). THE UNSAFE CONSEQUENCE IS THAT BY NOT TURNING ON THE NIGHT TIME HEADLAMPS IN DARKNESS, THE 2001 VOLVO S80 OPERATES VOID OF TAIL LAMP ILLUMINATION.MY WIFE IS THE PRIMARY DRIVER OF OUR VOLVO. SHE COMBATS THE PROBLEM BY LEAVING THE NIGHT TIME HEADLAMPS ON AT ALL TIMES. WHEN I DRIVE THE VOLVO, I HAVE A HABIT OF TURNING THE LIGHTS OFF AFTER USE. MANY TIMES, MY WIFE HAS FORGOTTEN TO TURN THE NIGHT TIME HEADLAMPS BACK ON IN DARKNESS AND HAS BEEN IN HARMS WAY AS SHE DRIVES VOID OF TAIL LAMP ILLUMINATION IN DARKNESS! THIS IS A SAFETY ISSUE. THIS TAIL LAMP PROBLEM WHICH APPEARS TO BE A CARELESS OVERSIGHT BY THE DESIGN TEAM. THIS IS A PROBLEM WHICH SHOULD BE ADDRESSED AND RETROFITTED TO THE CURRENT VEHICLES AFFECTED IMMEDIATELY. DT

• 12/01/2003· SERVICE BRAKES, HYDRAULIC

  CONSUMER STATED THAT 6 MONTHS AGO HE REPLACED REAR BRAKES AND CALIPERS AT 15,000 MILES. CURRENTLY, CONSUMER TOOK VEHICLE TO DEALER FOR REGULAR MAINTENANCE, AND WAS TOLD THAT HE NEEDED TO REPLACE FRONT BRAKES AND ROTORS. *AK

• 11/30/2005· FUEL SYSTEM, GASOLINE

  I OWN A 2001 VOLVO S-80. THERE IS A DANGEROUS PROBLEM WITH THIS CAR . IT INVOLVES THE ELECTRONIC THROTTLE MODULE (ETM). THE CAR AT TIMES WILL NOT MOVE EVEN THOUGH THE ENGINE IS RUNNING AND THE CAR IS IN GEAR. IT JUST WILL NOT MOVE. PARTICULARLY WHEN TRYING TO MOVE INTO TRAFFIC. I AM AWARE THROUGH MY READING OF THE FACT THAT THERE ARE HUNDREDS OF THOUSANDS OF VEHICLES WITH THE SAME PROBLEM. VOLVO KNOWS ABOUT THIS BUT TO DATE HAS DONE NOTHING TO CORRECT IT. I ALSO KNOW THAT NHTSA IS INVESTIGATIONS THE PROBLEM AND I WANTED TO LIST MY NAME WITH YOU FOR A COMPLAINT ON THIS. *JB

• 11/25/2003· POWER TRAIN

  SINCE BUYING MY 2001 VOLVO S80 2.9, I HAVE HAD TO HAVE THE TRANSMISSION REPLACED TWO TIMES WITHIN A 16 MONTH PERIOD. THE FIRST TIME WAS JUNE 2002 AND THE SECOND TIME WAS NOVEMBER 2003. *LA

• 11/23/2005· POWER TRAIN,VEHICLE SPEED CONTROL

  2001 VOLVO S80 T6 1. FAILURE VEHICLE SPEED CONTROL/ELECTRONIC THROTTLE CONTROL MODULE 2. TRANSMISSION FAILURE - GM TRANSMISSION. *JB

• 11/21/2005· VEHICLE SPEED CONTROL

  VEHICLE REPEATEDLY STALLS AT LOW RPMS, DECELERATING, OR COMING TO STOP AT TRAFFIC LIGHTS, OFF-RAMPS, TOLL BOOTHS ETC. PROBLEM IS INTERMITTANT, AND DOESN NOT YIELD DIAGNOTICS ON CONSISTANT BASIS. DEALERS REFUSE TO FOLLOW-UP ON PROBLEM AS DIAGNOSTICS ARE INCONSISTANT. ONE INJURY AVOIDING ONCOMING VEHICLE UPON EXITING STALLED VEHICLE. INJURY MINOR, AND TREATED LOCALLY. *NM

• 11/18/2005· VEHICLE SPEED CONTROL

  X REF 10131066, 2 ETMS, SMCH. 8-26-5 E-MAIL THAT IS THE UNIT THAT HAS CAUSED THE CAR TO TO BE TOWED TWICE. ONCE WHILE DRIVING, AND ONCE WHILE STARTING IN A PARKING LOT. THE ELECTRICAL THROTTLE MODULE (ETM) FAILED. *AK

• 11/18/2005· VEHICLE SPEED CONTROL

  DT: 2001 VOLVO S80. VEHICLE STALLED/DIED AND LOST POWER DUE TO THROTTLE BODY FAILURE. *AK. THE THROTTLE BODY AND GASKET HAVE BEEN REPLACED THREE TIMES TO ALLEVIATE THE STALLING PROBLEM. *NM X-REF 10132057, SECOND ETM, SMCH. *AK

• 11/18/2005· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  THE CONTACT OWNS 2000 VOLVO S80. PURCHASED IT UNDER AN EXTENDED WARRANTY CERTIFIED USED CAR PROGRAM FROM CLAYTON VOLVO IN KNOXVILLE TENNESSEE IN APRIL 2001. SEVERAL MONTHS LATER, WHILE THE CAR WAS STILL UNDER WARRANTY, THE CAR DIED IN THE MIDDLE OF AN INTERSECTION. AFTER TOWING IT TO THE DEALER IT WAS DISCOVERED THE ELECTRONIC THROTTLE MODULE WASFILLED WITH CARBON. THAT UNIT WAS REPLACED UNDER WARRANTY. A COUPLE YEARS LATER, THE CAR AGAIN DIED. THIS TIME IT HAPPENED IN A PARKING LOT. THANKFULLY, IN BOTH CASES IT HAPPENED IN A SAFE SITUATION. AGAIN, THE ETM WAS DETERMINED TO BE THE PROBLEM. BUT, THE WARRANTY HAD EXPIRED. THE DEALER AND THE MANUFACTURER REFUSED TO RECOGNIZE THAT THE PROBLEM WAS AN ONGOING ISSUE. THIS TIME THE CONTACT WAS FORCED TO PAY NEARLY $1000 FOR REPAIRS. IT WAS THE CONTACT'S UNDERSTANDING THAT INFORMATION WAS BEING COLLECTED ON THIS PROBLEM, SO HE FELT COMPELLED TO ADD THIS COMPLAINT. ALTHOUGH HAD SPECIFIC DATES AVAILABLE , THE CONTACT COULD CHECK MY RECORDS AND PROVIDE THEM IF NECESSARY. *NM. X-REF 10131424, 2 ETMS INSTALLED, SMCH. *AK THE THROTTLE BODY WAS CLEANED TWICE AND THE MASS AIR FLOW SENSOR WAS REPLACED. UPDATED 12/07/05. *JB

• 11/17/2005· ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

  WELL, WELL - LET'S SEE, I BOUGHT A 2001 VOLVO S-80, T-6 IN FEBRUARY 2005 TO REPLACE MY 1996 740 IL BMW - I THOUGHT I WOULD GET A MORE ECONOMICAL AND SAFE CAR. BOY WAS I WRONG! TO MY DISGUST I PAID ALMOST $20,000 FOR THIS USED CAR AND WITHIN WEEKS IT STARTED ACTING UP. IT TURNED OUT TO BE THE MASS AIRFLOW SENSOR AND THE THROTTLE BODY. I FINALLY - 9 MONTHS AFTER PURCHASING THE CAR - HAVE HAD TO GET IT FIXED - OVER $1200.00. I, LIKE ANOTHER PERSON WHO FILED A COMPLAINT, WAS MAKING A LEFT HAND TURN ON A VERY BUSY ROAD, AND THE CAR DIED WHILE IN THE MIDDLE OF MY TURN. LUCKILY I WAS ABLE TO PUT IT IN NEUTRAL QUICK ENOUGH AND RESTART IT BEFORE I GOT HIT. THE CAR ALSO SURGES DANGEROUSLY AT STOPS. IF YOU DON'T HAVE YOUR FOOT ON THE BRAKE 110%, THE CAR WOULD LURCH FORWARD AND HIT THE CAR IN FRONT OF IT. I'M SO DISAPPOINTED IN THIS CAR I WILL NEVER BUY ANOTHER VOLVO. SO MUCH FOR LOOKING FORWARD TO "ONE DAY PURCHASING THIS SAFE CAR". NOW THAT I HAVE DUMPED LOTS OF MONEY INTO THIS CAR, TAKEN VACATION TIME TO PICK IT UP AND DROP IT OFF, IT WORKS OKAY. THE THROTTLE BODY WAS REPLACED ABOUT 2 WEEKS AGO, BUT THE CAR STILL FEELS LIKE ITS NOT GIVING ME 100% - BUT AT LEAST IT ISN'T STALLING OR SURGING. I STILL HAVE MY BMW - THANK GOODNESS. I'LL BE GETTING RID OF THIS VOLVO. FORD BOUGHT VOLVO AND THEY ARE RESPONSIBLE FOR MAKING THIS UNRELIABLE CAR. I ALSO UNDERSTAND THAT THERE A CLASS ACTION LAWSUIT AGAINST VOLVO (FORD) - IT'S TIME THEY DO THE RIGHT THING AND REIMBURSE CUSTOMERS WHO HAVE BEEN SUBJECTED TO THIS DANGEROUS AND POORLY DESIGNED FUEL SYSTEM. *JB

• 11/15/2005· VEHICLE SPEED CONTROL

  WHILE DRIVING ON AN INTERSTATE HIGHWAY AT 65-70 MPH, 2001 VOLVO S80 T6 DISPLAYED A MESSAGE INDICATING REDUCED POWER. WAS ABLE TO STEER THE CAR, BUT PUSHING THE ACCELERATOR PEDAL IT HAD NO EFFECT. THE CONTACT WAS FORCED TO MANEUVER TO THE SHOULDER, AND HAD THE CAR TOWED TO LOCAL DEALER. THE CAR WOULD START AND CONTINUED TO RUN, BUT THE CAR WOULD NOT GO. IT WAS AS IF THE ACCELERATOR PEDAL HAD BEEN DISCONNECTED. THIS HAPPENED AT ALL SPEEDS. THE MECHANIC DETERMINED THAT THE ELECTRICAL THROTTLE MODULE (ETM) MALFUNCTIONED. *AK

• 11/15/2005· VEHICLE SPEED CONTROL

  ETM BAD/ ELECTRONIC THROTTLE MODULE THIS HAS BEEN A NIGHTMARE AND IT'S NOT RESOLVED YET! I BOUGHT MY USED VOLVO S-80 T6 OCTOBER 20 TH WITH 76,000 MILES. WITHIN THE DAY OF OWNERSHIP THE SERVICE ENGINE REQUIRED LIGHT CAME ON, AND I FAILED MASS INSPECTION. I TRIED TO GET MY MONEY BACK, BUT I BOUGHT OUT OF STATE, AND THEY REFUSE TO RETURN CALLS. I RESEARCHED THE PROBLEM AND FOUND IT WAS THE ETM. ON WEDNESDAY NOV 10TH 2005, I CALLED MY LOCAL DEALER PIONEER VOLVO IN SOUTH DEERFIELD MASS 1 800 680 2140, AND WAS INFORMED THAT THE ETM WARRANTY EXPIRED AT 70,000 MILES, AT 76,000 MILE, THERE WAS NO WARRANTY. I ASKED HIM ABOUT KNOWN PROBLEMS WITH THE ETM, AND DENIED THAT HE WAS AWARE OF ANY! I ASKED HIM FOR AN APPOINTMENT, EXPLAINED THAT HE IS THE CLOSEST DEALER AT 47 MINUTES AWAY, AND THAT I NEEDED HELP ASAP DUE TO FAILED EMISSIONS. HE TOLD ME "BRING IT IN...AT 9 30 AM AND MAYBE I'LL LOOK AT IT....WHEN I ASKED HIM FOR A GUARANTEED TIME....HE SAID ..."MAYBE IN 2 WEEKS" I DECIDED TO FIX THE PROBLEM MYSELF BY CLEANING THE ETM, WHICH I UNDERSTAND HELPS TEMPORARILY. I HAD NO CHOICE BEING I AM EXTREMELY BUSY IN AN UNFLEXIBLE JOB AND FINANCIALLY STRAPPED. HOWEVER, WHEN REINSTALLING THE ETM, THE BOLTS ARE DESIGNED TO SHEER. THE BOLT SNAPPED AND I HAVE BEEN UNDER MY CAR FOR 3 DAYS....STILL CAN'T EXTRACT IT. I NEED MY CAR! I NEED IT TO PASS INSPECTION! WHY WON'T VOLVO COVER THIS? *NM

• 11/09/2005· VEHICLE SPEED CONTROL

  ELECTRONIC THROTTLE MODULE (ETM )REPLACED SECOND TIME, 50 MPH, STALLED X REF 10131141, SMCH. *AK UPDATED 1/4/2006 - *NM

• 11/02/2005· VEHICLE SPEED CONTROL

  I WAS DRIVING DOWN A US HIGHWAY WHEN I NOTICED MY CAR WAS 'LURCHING' FORWARD THEN WOULD LOOSE SPEED ALL TOGETHER KIND OF LIKE IT WANTED TO STALL. I WOULD PUSH ON THE ACCELERATOR AND NOTHING WOULD HAPPEN, THEN ALL OF A SUDDEN THE CAR WOULD DRIVE NORMALLY. I WAS ABOUT A MILE FROM MY WORK, SO I DIDN'T PULL OVER IMMEDIATELY. THE NEXT TWO STOP LIGHTS I ALMOST STALLED, BUT DIDN'T. AT THE THIRD TRAFFIC LIGHT ON ANOTHER US HIGHWAY, I WASN'T SO LUCKY - MY CAR STALLED AND WOULD NOT RE-START. I HAD TO CALL FOR A TOW TRUCK. MY SERVICE REPORT STATES THAT THE CODE ECM-130A WAS DETECTED. I FIGURED FOR SURE THIS WOULD BE COVERED UNDER MY EXTENDED WARRANTY. VOLVO SAID NO AS IT WAS 'JUST A DIRTY THROTTLE UNIT'. THEY SUPPOSEDLY TOOK IT APART, CLEANED IT, REPLACED A GASKET, UPGRADED THE ECM PET, AND PUT IT ALL BACK TOGETHER AND TOLD ME TO BE SURE TO USE PREMIUM GASOLINE BY ONLY A REPUTABLE GAS STATION, AND ONCE EVERY FEW MONTHS USE A FUEL SYSTEM CLEANER AND I SHOULDN'T HAVE ANY MORE PROBLEMS. *NM

• 10/31/2008· ENGINE AND ENGINE COOLING

  HESITATION, SURGING, LOSS OF POWER, ETC. THIS CAR RUNS SO ERRATICALLY THAT I AM EVEN AFRAID TO CHANGE LANES IN TRAFFIC BECAUSE I AM JUST AFRAID THAT IT IS GOING TO STOP RIGHT IN THE MIDDLE AND I AM GOING TO BE HIT BY THE CAR BEHIND ME. I AM AFRAID TO STOP AT TRAFFIC LIGHTS BECAUSE THE CAR WONT ACCELERATE AND RUN NORMALLY THEREFORE ILL HAVE UPSET DRIVERS IN BACK OF ME WAITING UNTIL THE CAR DECIDES TO MOVE FORWARD. THIS IS VERY DANGEROUS ESPECIALLY WHEN YOU ARE DRIVING WITH A LOT OF TRAFFIC AROUND YOU. I HAVE TAKEN IT TO THE DEALER BUT THEY JUST SAY THAT IF THERE ARE NO MESSAGES OR CODES THEY CANNOT DO ANYTHING ABOUT IT BECAUSE VOLVO WONT REIMBURSE THEM FOR THE EXPENSE. THIS ERRATIC BEHAVIOR HAS BEEN HAPPENING MORE AND MORE OFTEN AND I DON'T BELIEVE IT HAS BEEN A DAY THAT HAS NOT HAPPENED SINCE IT FIRST STARTED. I HAVE HAD AN UPGRADE, A CLEANING BUT NO REPLACEMENT IN SIGHT. *TR

• 10/29/2005· VEHICLE SPEED CONTROL

  FOR THE PAST YEAR (10/04-10/05), MY 2001 VOLVO S80 SEDAN HAS HAD REPEATED PROBLEMS WITH STALLING AND LOSS OF POWER STEERING. IT HAS OCCURRED AT SLOW SPEEDS AND UP TO 40 MPH IN TRAFFIC. I HAVE TAKEN THE CAR TO THE DEALER TWICE. THEY CAN NOT FIND ANY FAULT CODES DURING THE COMPUTER TROUBLESHOOTING, SO MY WARRANTY WILL NOT COVER ANY REPAIR. THEY SUGGESTED IT MIGHT BE "BAD GAS" AND HAVE SENT ME HOME TWICE HAVING DONE NOTHING. THE STALLING PROBLEM HAS OCCURRED FIVE TIMES IN THE LAST MONTH. THE CAR HAS 66,500 MILES ON IT. *JB

• 10/26/2005· VEHICLE SPEED CONTROL

  NO ACCELERATION AT TIMES. FROM TIME TO TIME WHEN MERGING ON FREEWAYS OR TRAFFIC CAR WOULD NOT ACCELERATE. SOMETIMES IT WOULD SERGE. HAD A FEW CLOSE CALLS. FIRST HAD THROTTLE BODY (ETM) CLEANED WHICH DIDN'T WORK THEN HAD THROTTLE BODY REPLACED TWO DAYS LATER AT COST OF $1,177.16. *JB

• 10/24/2005· FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL

  SURGING IDLE SPEED. CAR LURCHES FORWARD AT TIMES WHEN ACCELERATING FROM A STOP. CAR ALMOST STALLS WHEN IDLING IN BUMPER TO BUMPER TRAFFIC, REQUIRING YOU TO PRESS ON THE GAS TO KEEP IT FROM STALLING, BUT THIS MAKES THE CAR LURCH FORWARD EVEN MORE. SEVERAL TIMES I HAVE ALMOST HIT THE CAR IN FRONT OF ME. THIS PROBLEM IS DUE TO A FAULTY ETM (ELECTRONIC THROTTLE MODULE) THAT IS DESCRIBED IN THE NHTSA DEFECT INVESTIGATION SHOWN BELOW. THE ETM IN MY CAR WAS REPLACED TWO YEARS AGO AT 46K MILES BUT THE SAME SYMPTOMS ARE RECURRING. NHTSA ACTION NUMBER : PE05041 NHTSA RECALL CAMPAIGN NUMBER : N/A MAKE : VOLVO MODEL: S80 MANUFACTURER : VOLVO CARS OF N.A. LLC. YEAR : 2001 COMPONENT : VEHICLE SPEED CONTROL DATE INVESTIGATION OPENED : JULY 26, 2005 DATE INVESTIGATION CLOSED : OPEN SUMMARY: THE OFFICE OF DEFECTS INVESTIGATION (ODI) HAS RECEIVED ONE HUNDRED AND THIRTY-ONE (131) CONSUMER COMPLAINTS ALLEGING A VARIETY OF CONCERNS RESULTING FROM FAILURE OF THE ELECTRONIC THROTTLE CONTROL MODULE (ETM) IN THE SUBJECT VEHICLES, INCLUDING A SUDDEN LOSS OF SPEED AND STEERING ASSIST WHEN DRIVING IN HIGHWAY TRAFFIC AND SUDDEN AND COMPLETE STALL WITHOUT WARNING. IN SOME INSTANCES, IT HAS BEEN REPORTED THAT THE VEHICLES WOULD RESTART, AND IN SOME CASES THE VEHICLES WERE TOWED. SOME CONSUMERS ALLEGE THAT AFTER HAVING THE ETM REPLACED THE NEW COMPONENT FAILED IN A SIMILAR MANNER. A PRELIMINARY EVALUATION HAS BEEN OPENED TO DETERMINE THE SCOPE, FREQUENCY, AND POTENTIAL SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT. *JB

• 10/19/2017· ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  TAKATA RECALL" FRIST I CALLED VOLVO TO INQUIRE ABOUT RECALLS REFERENING TO THE COOLING SYSTEM AND THE FUEL PUMP THE FIRST LADY I SPOKE WITH INFORMED ME THIS PROBLEM WAS UNDER RECALLS AND TO TAKE MY CAR TO GET IT SERVICED AT THE NEAREST DEALER AFTER TAKING MY CAR TO THE DEALER AT 7:15AM 4HOURS LATER AFTER I CALLED THEM FIRST THEY NOW ARE SAYING THAT THERE ISN'T ANYTHING THEY CAN DO WITH MY CAR AND THEY DO NOT KNOW WHO TOLD ME THAT FALSE INFORMATION. ON TOP OF ALL OF THIS MY CAR ACCELERATES BY ITSELF LUCKY WHEN IT HAPPENS I HURRY AND PUSH THE BRAKES AND THE CAR DOSENT START UP ONCE TURNING THE KEY EVEN THE GUY SAY THAT'S ALWAYS BEEN A PROBLEM. BASED ON HOW EXPENSIVE THIS CAR IS IT SEEM THERE WOULDN'T BE MANY PROBLEMS WITH IT OR IT SEEM THAT THEY WOULD AT LEAST TRY TODO SOMETHING ABOUT THE FALSE INFORMATION OVER ALL I WILL NEVER BUY ANOTHER VOLVO AGAIN!

• 10/19/2005· ELECTRICAL SYSTEM

  NHTSA ACTION NUMBER : PE05041 WHILE DRIVING THROUGH A BUSY INTERSECTION OF A LOCAL HIGHWAY THE CAR DIED. I PUSHED THE CAR OFF INTO A LOCAL OIL CHANGE/ LUBE GARAGE. THEY MANAGE TO GET IT STARTED ALTHOUGH IT WAS IDLING ROUGHLY. I BROUGHT IT TO VOLVO OF FORT WASHINGTON TO HAVE THE ETM REPLACED AT A CHARGE OF OVER $600. VOLVO OF NORTH AMERICA SAID THAT THEY DON'T BELIEVE THEY ARE RESPONSIBLE ALTHOUGH MANY HAVE HAD THE SAME ISSUE. *JB

• 10/18/2005· VEHICLE SPEED CONTROL

  PURCHASED 2001 VOLVO S80 ABOUT A MONTH AND A HALF AGO. IN THE PAST TWO WEEKS THE VEHICLE HAS DEVELOPED AN ENGINE SURGE AND ON TWO OCCASIONS HAS SIMPLY LOST POWER WHILE TRAVELING AT 55 MILES PER HOUR. BOTH TIMES A MESSAGE WAS DISPLAYED STATING REDUCED PERFORMANCE BUT THE VEHICLE HAD NO POWER AT ALL. AFTER PULLING ON TO THE SHOULDER I WAS ABLE TO GET IT STARTED AGAIN. THE PROBLEM HAS SUBSEQUENTLY BEEN DIAGNOSED AS THE ETM. THE CAR IS NOW PARKED WHILE I TRY TO RAISE THE MONEY TO HAVE IT FIXED. AS A RETIRED STATE TROOPER I CAN ONLY SAY THAT THIS IS A VERY DANGEROUS SITUATION AND I HOPE THE NHTSA AND VOLVO WILL NOT WAIT UNTIL THERE ARE INJURIES OR FATALITIES TO CORRECT THE PROBLEM. *NM

• 10/18/2005· FUEL SYSTEM, GASOLINE

  WEEK OF 10/10/05 AS TRAVELING UPHILL, MY CAR SPUTTERED AND LOSS POWER. AFTER NEARLY BEING REAR ENDED ON THE BUSY ROAD, I WAS ABLE TO LIMB MY CAR INTO A PARKING LOT AND TURN OFF THE ENGINE. AFTER A FEW MINUTES, I WAS ABLE TO RESTART MY CAR AND CONTINUE DRIVING. TODAY, 10/18/05, AS I WAS ENTERING I-85, MY CAR ONCE AGAIN SPUTTERED AND STALLED. THE ENTRANCE RAMP WAS DOWNHILL, SO I WAS ABLE TO COAST INTO THE EMERGENCY LANE AS TRACTOR TRAILERS AND CARS WHIZZED BY ME. I RESTARTED THE CAR AFTER A FEW MINUTES OF BEING TURNED OFF. I WENT TO A MECHANIC FRIEND AND HE TOLD ME THAT IT WAS PROBABLY THE ETM AND IF IT WAS NOT, IT WOULD BE THE NEXT TIME THE CAR BREAKS DOWN. HE COULD NOT REPAIR IT. HE ESTIMATED THE DEALERSHIP WOULD CHARGE ME $1200.00. HE REPORTED THAT HE SEES THIS AT LEAST ONCE A MONTH IN VOLVOS. I TOOK THE CAR TO THE DEALER. AN HOUR AND A HALF LATER, I WAS INFORMED MY ETM NEEDED TO BE REPLACED AND THE COST WOULD BE $1150.00. I RELUNCTANTLY AGREED TO THE REPAIR. I HAVE RESEARCHED THE ETM PROBLEM OVER THE INTERNET AND HAVE LEARNED THAT VOLVO KNEW OF THIS PROBLEM YEARS BEFORE THEY SOLD THE CAR TO ME. AT A PERSONAL LEVEL, I HAD TO PAY FOR A DEFECTIVE PART THAT VOLVO HAS KNOWN IT HAS A 94%-100% FAILURE RATE! AT A MUCH HIGHER LEVEL, VOLVO IS RISKING PEOPLE LIVES BY NOT INFORMING OR VOLUNTARILY RECALLING THIS DEFECTIVE PART. CARS STALL UNEXPECTIVELY. I WAS FORTUNATE THAT I WAS NOT ON THE INTERSTATE YET. OTHERWISE, THE OUTCOME COULD HAVE BEEN DEADLY.

• 10/15/2021· AIR BAGS

  Takata recall. The contact owns a 2001 Volvo S80. The contact received a notification for NHTSA Campaign Number: 21V766000 (Air Bags). The dealer had been notified about the recall; however, the contact was informed that the part was not yet available. The manufacturer was then notified and informed him that they were unaware of when the parts may have become available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnection.

• 10/14/2005· VEHICLE SPEED CONTROL,EQUIPMENT

  WHILE DRIVING LOST STEERING POWER AND ENGINE COMPLETELY SHUT DOWN, UNSAFE ON THE TURNPIKE, I SCARED. TOOK CAR TO DEALERSHIP WHILE UNDER WARRANTY REPLACED THROTTLE UNIT. CAR SHUT DOWN AND LUNGES FORWARD AT A LIGHT/TOOK TO DEALER AND FIXED RESET VALVE STICKING AND GASKET HAPPENED AGAIN REPLACED BOX AND PIPE REMOVED TRAP BOX IN PIPE, SHUT DOWN AGAIN REPLACED DID TOTAL CAN UP GRADE FAILED AGAIN. UNTIL TODAY CAR STILL SHUTS DOWN VERY DANGEROUS THIS CAR IS A DEATH TRAP AND MY WARRANTY IS OVER AND THEY WANT TO PAY 3,000.00 DOLLARS TO FIX, I FEEL THEY ARE RESPONSIBLE THEY SOLD ME A LEMON AND A VERY DANGEROUS CAR. AND THE CUSTOMER SERVICE OF VOLVO CLAIM THEY CARE ABOUT CUSTOMER SERVICE VERY UNTRUE THEY GOT YOUR MONEY AND THE DON'T CARE MY PROBLEMS STILL EXIST AND I GET SCARED JUST GETTING INTO THIS CAR. *NM

• 10/12/2005· VEHICLE SPEED CONTROL

  I WAS DRIVING A 2001 VOLVO S80 T6 ON THE HIGHWAY PREPARING TO PASS A VEHICLE IN ORDER TO MAKE MY EXIT. AT THIS TIME THE CAR LOST POWER AND I RECEIVED A MESSAGE "PERFORMANCE REDUCTION". AFTER DODGING A COUPLE OF CARS I WAS ABLE TO MAKE IT TO THE SIDE OF THE ROAD. AT THAT TIME THE CAR WOULD NOT START BACK UP, I DECIDED TO LET THE CAR SIT AND COOL DOWN FOR ABOUT 15 MINUTES. THE CAR WOULD STILL NOT START. I HAD THE VEHICLE TOWED TO THE DEALERSHIP AND THEY INFORMED ME THAT THE ETM HAD FAILED AND THE OXYGEN SENSOR WHICH COST ME ABOUT $1300.00 TO REPAIR. *NM

• 10/08/2006· VEHICLE SPEED CONTROL

  MY 2001 VOLVO S80 ETM (ELECTRONIC THROTTLE CONTROL) FAILED, THIS CAUSED A SUDDEN LOSS OF ENGINE, STEERING, BREAKING AND HEADLIGHT SYSTEMS. *NM

• 10/08/2002· POWER TRAIN

  WHILE PARKED ON A HILL OR UPWARD SLOPE, OR STANDING STILL ON THESE HILLS OR SLOPES, THE VEHICLE ROLLS BACK VERY FAST. THIS HAPPENS BETWEEN THE TIME IT TAKES TO RELEASE THE BRAKE PEDAL AND PRESS THE ACCELERATOR. THIS HAS CAUSED SEVERAL NEAR MISSES. CONSUMER WOULD LIKE NHTSA TO REVIEW THIS SAFETY DEFECT AND FOR VOLVO DEALERS TO ALERT CURRENT AND POTENTIAL VOLVO OWNERS OF THIS DEFECT. *JG

• 10/06/2005· VEHICLE SPEED CONTROL

  DT: THE CONSUMER STATED THAT THE VEHICLE STALLED / DIED AND LOST POWER. THE ENGINE WAS MISSING, AND WHEN THE GAS PEDAL WAS PRESSED THE CAR WOULDN'T ACCERLATE. THE CAR WOULD ONLY GET UP TO ABOUT 20-40 MPH. CONSUMER WAS GOING ABOUT 70 AND THE CAR LOST POWER. THE DRIVER WAS ABLE TO DRIVE THE CAR TO THE DEALERSHIP, THEY SAID THE ELECTRONIC THROTTLE BODY FAILED. THE DEALERSHIP REPLACED IT AND CHARGED THE CONSUMER $883.00 FOR THE PARTS AND LABOR. *AK *NM

• 10/06/2005· VEHICLE SPEED CONTROL

  DT: THE CONTACT OWNS A 2001 VOLVO S80. THE VEHICLE WILL BEGIN TO BUCK AT HIGHWAY SPEEDS. THE CRUISE CONTROL WILL DROP OFF AT RANDOM AND STOP WORKING BEFORE THE BUCKING STARTS. SOMETIMES AT START UP IT WILL IDLE REALLY ROUGH. THE CONTACT PURCHASED THE VEHICLE ON JULY 16, 2005 AND THIS PROBLEM HAS BEEN OCCURRING EVER SINCE HE PURCHASED THE VEHICLE. THE VEHICLE WILL COMPLETELY STALL AS WELL AS RUN AT LOW SPEEDS. THE VEHICLE FAILED AT LEAST 50 TIMES SINCE HE PURCHASED THE VEHICLE. THE CONSUMER WAS NOT THE ORIGINAL OWNER. THE PROBLEM HAS BEEN DIAGNOSED AS THE ELECTRONIC THROTTLE MODULE, BUT HAS NOT BEEN FIXED AT THIS POINT. *AK *JB

• 10/05/2005· ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL

  VOLVO S80 ELECTRONIC THROTTLE MODULE (ETM) PRODUCTION DEFECT NOT COVERED UNDER WARRANTY AS THE DEFECT OCCURRED JUST OUTSIDE OF WARRANTY. DEALER COST TO CORRECT IS OUTRAGEOUS GIVEN THIS IS CLEARLY A MANUFACTURER ENGINEERING DEFECT WITHIN THE THROTTLE BODY MECHANISM ITSELF. *JB

• 09/30/2010· POWER TRAIN

  2001 VOLVO S 80 T6 EX TRANSMISSION FAILURE. BASED ON PERSONAL RESEARCH IT APPEARS THAT THE 2001 VOLVOS HAVE A WIDESPREAD PROBLEM WITH TRANSMISSION FAILURE. TRANSMISSIONS WERE BUILT BY GM FOR VOLVO AND TRANSMISSION PROBLEMS ACROSS THE ENTIRE LINE FOR THAT YEAR ARE EXTREMELY HIGH. IS THERE OR CAN THERE BE AN INVESTIGATION OF THIS PROBLEM. IT APPEARS TO ENCOMPASS THE ENTIRE LINE FOR THAT YEAR. *TR

• 09/30/2005· VEHICLE SPEED CONTROL

  I HAVE EXPERIENCED REPEATED PROBLEMS WITH THE ELECTRONIC THROTTLE MODULE ON MY 2000 S80 VOLVO. FOR THE LAST COUPLE YEARS I HAVE TAKEN MY VEHICLE TO THE VOLVO SERVICE DEALER FOR REPEATED PROBLEMS WITH THE CAR ENGINE SURGING WHEN COMING TO A STOP. THE VOLVO DEALER SERVICE WORKED ON THE ISSUE MULTIPLE THROUGHOUT THE WARRANTY PERIOD, STATING THEY KNEW OF A PROBLEM WITH THE ETM AND TO WATCH IT. NOW MY VEHICLE IS OUT OF WARRANTY AND THE PROBLEM WAS DEFINITELY DIAGNOSED AND I HAD TO PAY OVER $900.00 TO GET IT FIXED. *JB

• 09/29/2005· VEHICLE SPEED CONTROL

  DT: 2001 VOLVO S80. VEHICLE STALLED/DIED AND LOST POWER DUE TO THROTTLE BODY FAILURE. *AK THE THROTTLE BODY AND GASKET HAVE BEEN REPLACED THREE TIMES TO ALLEVIATE THE STALLING PROBLEM. *NM

• 09/29/2005· VEHICLE SPEED CONTROL

  DT: ON SEPTEMBER 12, 2005 THE CONSUMER'S HUSBAND HAD HIS FOOT ON THE BRAKE AND THE VEHICLE SURGED FORWARD. THE ELECTRONIC THROTTLE MODULE FAILED AND WAS REPLACED. *AK *JB

• 09/27/2005· VEHICLE SPEED CONTROL

  DT: THE CALLER SAID THAT WHILE DRIVING VEHICLE SPUTTERED AND STALLED. THE CALLER SAID THAT WHEN THE PROBLEM STARTED IT WOULD HAPPEN ABOUT ONCE A WEEK, AND IT GOT PROGRESSIVELY WORSE. IT WOULD STALL APPLYING THE BRAKES. HE SAID THIS PROBLEM MADE IT VERY HARD TO DRIVE IN DAILY TRAFFIC. THE CALLER WAS ABLE TO GET VEHICLE OFF THE ROAD. THEN, IT STARTED BACK UP. HE HAD THE ELECTRONIC THROTTLE MODULE REPLACED. DEALER SAID THE PROBLEM WAS COMMON IN THIS VEHICLE, AND THEY FIXED IT. MANUFACTURER SAID TO CALL DEALER. THE CALLER HAD THE PROBLEM FIXED ABOUT SIX MONTHS AGO. HE JUST WANTED TO LET NHTSA KNOW ABOUT THIS PROBLEM.*AK

• 09/27/2005· ELECTRICAL SYSTEM

  CAR WAS RACING AND STALLING ON HIGHWAY AND WHILE IDLING. TOOK IT IN AND DIAGNOSTIC CODES IDENTIFIED A FAULTY MASS AIR FLOW SENSOR AND ELECTRONIC THROTTLE MODULE/RELOAD AND THROTTLE BODY. CAR HAS 48,800 MILES ON IT. THESE REPAIRS COST OVER $1400. PLEASE HAVE VOLVO LOOK INTO THIS AND A RECALL IS JUSTIFIED. *JB

• 09/26/2005· FUEL SYSTEM, GASOLINE

  I OWN A 2001 VOLVO S 80. IT DIED ON THE HIGHWAY IN THE MIDDLE OF BUSY RUSH HOUR TRAFFIC. HAD IT TOWED TO VOLVO AND REPAIRED. NEED A NEW THROTTLE BODY AND MASS AIR FLOW SENSOR. VERY EXPENSIVE REPAIR AND WAS TOLD OFF THE RECORD THAT THIS PART FAILURE HAS BEEN MUCH MORE COMMON THAN IT SHOULD BE. I AM NOTIFYING YOU SO THAT YOU WILL LOOK INTO MANNER. SEEMS THIS SHOULD BE A RECALL ITEM. THANK YOU. *NM

• 09/23/2005· VEHICLE SPEED CONTROL

  CAR STALLED IN TRAFFIC AND THEN FAILED TO ACCELERATE AT AN INTERSECTION. PAID $900 FOR A NEW ELECTRONIC THROTTLE MODULE AND THE LEARNED VOLVO IS WELL AWARE OF PROBLEM WITH THE PART AND THAT MANY, MANY VEHICLES HAVE THE PROBLEM. *NM