2001 Ford Mustang

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/30/2007· FUEL SYSTEM, GASOLINE

  FUEL NECK BEGAN TO LEAK, WITHIN 2 WEEKS IT WAS LOOSING ALMOST A GALLON OF FUEL ON A $20.00 FILL. I CONTACTED FORD TWICE, I WAS TOLD TO TAKE IT TO A FORD DEALERSHIP, I GOT AN ATTITUDE FROM THE DEALERSHIP SO I SPENT THE $110.00 ON A FORD PART AND $180.00 ON THE LABOR AT ANOTHER SERVICE STATION. ADVISED FORD OF THE SAFETY HAZARD, APPARENTLY DIDN'T CONCERN THEM ENOUGH TO CONTACT ME AND MAKE GOOD ON THE REPAIRS. *TR

• 12/30/2002· PARKING BRAKE

  THE CONSUMER STATED THAT THE EMERGENCY BRAKE WILL STAY UP WILL NOT GO DOWN. PLEASE FILL IN ADDITIONAL INFORMATION DEARLER IS AWARE OF THE PROBLEM.

• 12/28/2007· VISIBILITY

  I AM HAVING THE EXACT PROBLEM DESCRIBED IN EA0515. THE DEALERSHIP HAS SAID IT HAS SEEN THE PROBLEM BEFORE. MY LEAK HAS RUINED THE GEM MODULE ACCORDING TO THE DEALERSHIP. THE TOTAL DAMAGE $980.00. MY INSURANCE COMPANY HAS THE BELIEF THIS IS A MANUFACTURES DEFECT AND IS NOT RESPONSIBLE EITHER. *TR

• 12/27/2004· ELECTRICAL SYSTEM

  I PURCHASED MY 2001 FORD FOCUS IN OCTOBER OF 2002, IT ONLY HAD 113 MILES ON IT FROM BEING TEST DRIVEN SO ESSENTIALLY IT WAS BRAND NEW WHEN PURCHASED THAT DAY. THIS IS MY ***3RD*** TIME OF HAVING TO HAVE IT SERVICED BY FORD BECAUSE THE IGNITION LOCKED UP AND MY KEY WOULD NOT TURN. I HAVE BEEN TOLD THAT FORD WAS AWARE THAT THERE WERE A COUPLE MAKE/MODELS OF THE FOCUS THAT HAVE THIS ISSUE. IT HAS SOMETHING TO DO WITH THE SENSORS IN THE INGITION AND THE KEYS BEING WORN DOWN SO MUCH THAT IT WON'T RECOGNIZE THE KEY/SENSOR TO START THE CAR. VERY FRUSTRATING. NOW I AM DEALING WITH IT AGAIN, FORD HAS UNFORTUNATLY NOT PUT A RECALL OUT ON THIS SPECIFIC ISSUE. I AM GETTING CLOSE TO THE END OF MY EXTENDED WARRANTY AND STILL I HAVE TO PAY A 50.00 DEDUCTIBLE EVERYTIME TO GET THIS PROBLEM FIXED AND IT'S FAULTY EQUIPMENT THAT FORD KNOWS ABOUT IT. I HOPE THERE ARE ENOUGH COMPLAINTS THAT FORD ACKNOWLEDGES THIS PROBLEM AND AT THE VERY LEAST, REPLACES THIS CERTAIN IGNITION WITH ANOTHER YEAR SO US CUSTOMERS DON'T HAVE TO PAY FOR THEIR ENGINEERING MISTAKES. I AM A SINGLE MOM WITH 7 WK OLD TWINS AND THIS IS NOT IN MY BUDGET, LET ALONE ONCE I AM OUT OF MY EXTENDED WARRANTY PERIOD, IT WILL BE AROUND 300.00 A POP TO GET THIS PROBLEM FIXED. PLEASE HELP!!!*AK

• 12/26/2004· SERVICE BRAKES, HYDRAULIC,PARKING BRAKE

  2 DAYS EARLIER HAD CAR AT MECHANIC AND HE SAID MY PADS WERE A LITTLE LOW SO THEY SHOOULD BE CHANGED. THE DAY I HAD THE APPOINTMNET TO REPLACE THE PADS THE REAR CALIPER FROZEN OPEN AND EMERGENCY BRAKE WOULD NOT WORK EITHER. WHILE IN MY DRIVEWAY WITH FOOT ON BRAKE PEDAL, CAR STARTED ROLLING FORWARD. HIT POST IN DRIVEWAY AND TORE OFF DRIVER MIRROR AND DENTED DOOR. BROUGHT CAR BACK TO MECHANIC THEN TOWED CAR TO DEALER AS I HAD EXTENDED WARRANTY AND DIDN'T WANT TO PAY MECHANIC FOR PARTS OR LABOR AS MECHANIC STATED CALIPER FROZEN. DEALER WOULD NOT FIX DAMAGE TO DOOR/MIRROR. THE PADS STILL HAD SOMETHING LEFT OTHERWISE ROTORS WOULD BE SCRATCHED UP WITH METAL DIGGING IN. THERE IS NO EVIDENCE OF METAL AGAINST METAL WHAT SO EVER. DEALER ALSO STATED MASTER CYLINDER NEEDED REPLACING AS IT HAD LEAKED ALL FLUID OUT OF SYSTEM. NEEDED TO BLEED SYSTEM AND REPLACE CALIPER. DEALER SAID NOBODY WOULD DO ANYTHING ABOUT DAMAGE AND IT WAS MY PROBLEM. I HAD THE DEALER PUT THE NEW PADS ON THAT MY MECHANIC HAD PURCHASED FOR DOING MY BRAKES. DEALER WANTED TO CHARGE ME $195.00 TO DO THIS. I KNEW SOMEONE THERE AND THEY WAIVED THE FEE BUT I HAD TO PAY $100.00 DEDUCTABLE FOR EXTENDED WARRANTY COVERAGE. DO NOT BUY A FORD!!!!!*AK

• 12/24/2003· SERVICE BRAKES, HYDRAULICCrash

  2001, MUSTANG, HYDROPLANED AT 50 MPH IN HEAVY RAIN, SPUN 360 DEGREES, AND SLID DOWN AN EMBANKMENT. HAD FLAT ON RIGHT FRONT, AND REQUIRED A TOW TRUCK. WHILE TOWING THE VEHICLE THE TOW TRUCK OPERATOR NOTICED THAT THE CAR WAS PULLING HARD. WHEN HE EXAMINED THE VEHICLE BOTH REAR BRAKE CALIPERS WERE GLOWING RED HOT. I WAS INFORMED BY MY INSURANCE ADJUSTER AND THE MECHANIC THAT THE CALIPERS WERE CORRODED. THIS REQUIRED REPLACING THE CALIPERS ON BOTH REAR WHEELS. I DRIVE THE VEHICLE EVERY DAY FOR 125 MILE ROUND TRIP TO WORK AND HAVE FOR THE LAST 12 MONTHS. THERE WAS NO WARNING WHEN THIS OCCURRED AND FIND IT HARD TO BELEIVE THAT THE CALIPERS WERE LOCKED UP FOR ANY LENGTH OF TIME.*AK

• 12/24/2001· VEHICLE SPEED CONTROL

  THROTTLE STUCK WIDE OPEN. BRAKES FAILED TO STOP. TURNED OFF KEY. ENGINE NOW SURGES ABOVE 4,000 RPM. RENTAL CAR: BUDGET BURBANK, CAR # BURAA67 82883. TOWED TO RENTAL AGENCY AND EXCHANGED. CAR # 854726. BUDGET TO TOW TO FORD DEALER FOR REPAIRS.

• 12/20/2003· ENGINE AND ENGINE COOLING

  I GAVE MY CAR A TUNE UP AT A FAMILY FRIENDS SHOP SPARK PLUG BROKE SO REPLACED IT WITH A BOSH PLATINUM 4 WHICH WAS ALL THE LOCAL AUTO PART HAD 6 MONTHS LATTER MY CAR BLOWS A PLUG OUT OF THE OPPOSITE SIDE OF THE ENGINE WHICH HAD THE ORIGINAL PLUG AND I TOW IT BACK TO THE DEALERSHIP THE WARRANTY REFUSES TO FIX IT BECAUSE AFTER MARKET PLUG ON THE OTHER SIDE AND FORD KNOWS THEY HAVE DEFECTIVE HEAD AND 4.6LT ENGINES BUILT FR:01-03 BUT REFUSE TO FIX IT OR EVEN TEST IT TO SEE IF IT WAS DEFECTIVE SINCE THE AFTER MARKET PLAG WAS ON THE OTHER SIDE AND THE ENGINE FAILED DUE TO UNKNOWN REASONS ON THE SIDE WITH THE ORIGINAL PLUGS THIS APPLIES TO ALL VEHICLE FROM FORD WITH 4.6LT 2V ENGINES MORE INFO FOUND HERE HTTP://WWW.BLUEOVALNEWS.COM/2003/POWERTRAIN/4.6L.ENGINETICK.T31604.HTM *LA (PER CONSUMER CALL (NO SMOKE OR FLAMES); CHANGED FIRE FROM YES TO NO - C. ROSE 11/16/05

• 12/19/2001· VEHICLE SPEED CONTROL

  ACCELERATOR STUCK AFTER ACCELERATING FROM 0 TO 60. COULDN'T SLOW DOWN. *AK

• 12/18/2001· VEHICLE SPEED CONTROLCrash

  VEHICLE "LUNGED" OR ACCELERATED UPON FINAL PARKING (NEAR STOP) WITH FOOT OFF ACCELERATOR AND ON BRAKE. CAR JUMPED OVER "PARKING BUMP" CURB AND HIT SHRUBS, SMALL TREE APPROX 40 FT. DRIVER HAD NO CONTROL. DEALER INVESTGATED SAID FORD IS AWARE OF PROBLEM AND THERE IS "NO FIX'. STATED ENGINE CAN INCREASE SIGNIFICANTLY DURING WARMUP. DEFROSTER WAS ON. DRIVER SUFFERED INJURED RT ARM AND NECK. NO FRONT IMPACT. UNDERACARRIAGE HAS MINOR DAMAGE ONLY. NO FATALITIES OR OTHER INJURIES. *AK

• 12/14/2006· AIR BAGS

  I WAS DRIVING THROUGH AN ALLEY GOING ABOUT 5-10 MPH WHEN I WENT OVER A SMALL POTHOLE AND MY SUSPENSION BOTTOMED OUT AND MY AIRBAGS DEPLOYED. THE AIRBAGS DID NOT FULLY DEPLOY AND IF THIS WAS AN EVENT OF A REAL ACCIDENT THE AIRBAGS WOULD HAVE NOT DID ANYTHING FOR SAFETY. THERE IS NO DAMAGE TO THE VEHICLE AT ALL. *JB

• 12/13/2002· AIR BAGS

  THE AIR BAGS IN MY 2001 FORD MUSTANG GT, DEPLOYED WITHOUT CAUSE. THERE WAS NO IMPACT OR SUDDEN STOP. THERE WAS NO REASON FOR THEM TO DEPLOY. FORD SAYS IT THAT THEY DEPLOYED FROM AN IMPACT, YET THERE IS NO DAMAGE TO THE VEHICLE. THEY WOULD NOT COVER IT UNDER WARRANTY AND I HAD TO GO THRU MY INSURANCE COMPANY TO GET THEM REPLACED.

• 12/10/2007· ENGINE AND ENGINE COOLING

  UPPER INTAKE GASKET MANIFOLD. *TR

• 12/09/2014· FUEL/PROPULSION SYSTEM

  I SMELLED STRONG GASOLINE ODORS WHILE DRIVING FROM WORK. THE CAR HAD BEEN FILLED WITH FUEL RECENTLY. THE FUEL TANK IS LEAKING NEAR THE FILL TUBE. FURTHER RESEARCH INTO THIS ISSUE HAS SHOWN THAT IT IS A COMMON OCCURRENCE WITH THIS MODEL. THE CAR CANNOT BE FILLED ABOVE HALF FULL OR GASOLINE LEAKS ALL OVER THE BACK OF THE CAR AND ON THE GROUND ONCE PARKED. THIS LEAK IS TOO NEAR THE EXHAUST PIPE FOR SAFETY. FORD DOES NOT REPAIR THIS SAFETY ISSUE UNDER ANY RECALL. IT IS A CHEAP PART BUT LABOR IS VERY EXPENSIVE SINCE THE FUEL TANK MUST BE REMOVED TO REPLACE THE LEAK. THIS IS A MANUFACTURING ISSUE AND FORD SHOULD BE REQUIRED TO REPAIR IT FREE OF CHARGE. *TR

• 12/09/2002· AIR BAGSCrash

  CONSUMER WAS REAR-ENDED BY ANOTHER CAR TRAVELING APPROXIMATELY 40-45 MPH, WHICH CAUSED CONSUMER'S VEHICLE TO HIT ANOTHER MOTORIST. DRIVER AND PASSENGER AIR BAGS FAILED TO DEPLOY. TS. CONSUMER AND OCCUPANT SUFFERED NECK, BACK, SHOULDER AND KNEE INJURIES.*JB

• 12/08/2001· ENGINE AND ENGINE COOLING

  A TICKING, RATTLING NOISE IN THE MOTOR WHICH BEGINS AT 3,000 RPMS AND STOPS WHEN CAR SHIFTS INTO 2ND GEAR. WHEN IN 2ND GEAR, THE TICKING WILL BEGIN AT 3,000 RPMS. IT STARTED DOING THIS WHEN THE WEATHER DROPPED BELOW 55 DEGREES. IT WILL DO IT IN THE MORNING FOR ABOUT 5 MINS. ONCE CAR WARMS UP, TICKING NOISE VANISHES. IT IS VERY LOUD. I WAS READING ARTICLES ON BULLITTCLUB.COM AND MANY 2001 MUSTANG OWNERS ARE REPORTING THE EXACT SAME PROBLEM. A MAN HAD HIS CAR IN THE DEALERSHIP FOR OVER A MONTH. HIS CAR STILL TICKS WHEN COLD AND HE WAS TOLD THAT HE WAS PLACED ON THE LIST OF FORD'S "UNFIXABLES" I HAVE NOT TAKEN MY CAR TO THE DEALER BECAUSE I AM WAITING TO SEE WHAT THE FIX IS. I DIDNT HEAR THIS NOISE WHEN THE VEHICLE WAS DRIVEN OFF THE LOT IN JANUARY. THIS IS THE SAME FOR EVERYONE ELSE WHO IS HAVING THIS PROBLEM. BULLITCLUB.COM AND CLICK ON MECHANICAL ISSUES, THEN CLICK ON "VERY SCARY SOUND"....IT IS ALMOST 10 PAGES LONG OF PEOPLE WHO HAVE THIS PROBLEM. THIS NOISE CANNOT BE NORMAL AND I WANT FORD TO DO SOMETHING ABOUT IT, OTHER THAN PUT YOU ON THE "UNFIXABLES" LIST.*AK

• 12/06/2011· ENGINE AND ENGINE COOLING

  WHILE DRIVING AT 30 MPH, THE VEHICLE SPARK PLUG EXPLODED OUT OF THE ENGINE. *TR

• 11/30/2005· AIR BAGSCrash

  HAD AN ACCIDENT ON 19 NOV 05 IN DALLAS,TX AT 9.50 PM, I WAS CHANGING LANE WHEN THE OTHER CAR IN THE LANE I WAS CHANGING INTO LOWED DOWN, HE WAS DRIVING A JAGUAR WE BOTH WENT HEAD ON INTO THE CONCRETE DIVING WALL AT ABOUT 60-63 MPH MY AIR BAGS DID NOT DEPLOY; I HAVE $12000.00 IN DAMAGE TO MY 2001 MUSTANG COBRA. *JB

• 11/28/2007· ENGINE AND ENGINE COOLING

  TL*THE CONTACT OWNS A 2001 FORD MUSTANG CONVERTIBLE. WHILE DRIVING BETWEEN 10-30 MPH, THE VEHICLE STALLED, BUT THE RADIO REMAINED ACTIVATED. THE CONTACT WAITED FOR APPROXIMATELY FIVE MINUTES BEFORE THE VEHICLE RESTARTED AUTOMATICALLY. THE VEHICLE WAS TOWED TO A DEALER, BUT THEY COULD NOT FIND ANY FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 50,200. UPDATED 12/12/2007 *BF

• 11/28/2006· EXTERIOR LIGHTING

  DT*: THE CONTACT STATED WHILE DRIVING AT NIGHT THE HEADLIGHTS WERE NOT BRIGHT ENOUGH. THE VEHICLE WAS DRIVEN TO THE DEALER WHO DETERMINED THE HEADLIGHTS NEEDED TO BE REPLACED.

• 11/28/2006· ENGINE AND ENGINE COOLING

  I DON'T KNOW MUCH ABOUT THE MECHANICS OF CARS, BUT A SPARK PLUG BLEW OUT OF MY 2001 MUSTANG GT CAUSING A LOUD REPETITIVE NOISE AND A NOTABLE LOSS OF POWER. IT WAS STILL UNDER THE 30 DAY/3000 MILES USED VEHICLE WARRANTY AND IT WAS FIXED AT NO CHARGE TO MYSELF. THE SAME THING HAPPENED AGAIN A WEEK LATER AND I WAS TOLD (IN THE BEST WORDS THAT I CAN DESCRIBE IT) THE THREADING IN THE HOLE OF THE PART OF THE ENGINE THAT THE SPARK PLUG SCREWS INTO, WOULD NO LONGER HOLD THE SPARK PLUG AND THAT THE ENGINE NEEDED TO BE SENT TO A MACHINE SHOP TO BORE THE HOLE IN DEEPER COSTING A AROUND $3000.00. *NM

• 11/27/2004· VEHICLE SPEED CONTROL

  THE GAS PEDAL ON MY FORD 2001 ESCAPE KEEPS GETTING STUCK WHEN WE ARE DRIVING IT. I'M AFRAID IT MAY GET STUCK AND NOT RELEASE. WHICH COULD CAUSE A VERY BAD ACCIDENT. IS THERE ANYTHING WE CAN DO ABOUT THIS?*AK

• 11/21/2007· ENGINE AND ENGINE COOLING

  EMISSIONS LIGHT WENT ON AND OFF AND THE CAR SEEMED TO MISFIRE. DID NOT DRIVE SMOOTH. I WAS GLAD I WAS CLOSE TO HOME. I FELT THE CAR WOULD CONK OUT WHILE I WAS DRIVING. *TR

• 11/21/2002· AIR BAGSCrash

  CONSUMER WAS INVOLVED IN ACCIDENT YET THE AIR BAGS DID NOT DEPLOY, THE DRIVER AND A PASSENGER SUSTAINED SERIOUS INJURIES FROM THIS ACCIDENT, THE VEHICLE WAS TOTALED. NLM

• 11/16/2005· SEAT BELTS

  DT: THE CONTACT STATES THE PASSENGER'S SIDE SEAT BELT DOES NOT WORK PROPERLY. THE VEHICLE HAS NOT BEEN TO A DEALERSHIP FOR REPAIRS. *AK

• 11/16/2004· EXTERIOR LIGHTING,EQUIPMENT

  DETERIORATION OF MATERIALS OF HEADLIGHT LENSES. DETERIORATION CAUSED BY THE HEAT PRODUCED BY THE LIGHT ITSELF. DIMS THE HEADLIGHTS AND REDUCES VISIBILITY THEREBY CAUSING UNSAFE AND ILLEGAL DRIVING CONDITIONS.L *AK

• 11/16/2001· SUSPENSION

  LOWER CONTROL ARM CAME OFF WHILE PULLING OUT OF THE DRIVEWAY. VEHICLE WAS TOWED TO DEALER, AND REPAIRS WERE MADE. *AK CONSUMER STATES THAT THE NUT WAS NOT TIGHTENED SUFFICIENTLY AND THE SAFETY PIN WAS MISSING. *JB

• 11/14/2001· SEATSCrash

  VEHICLE WAS REARENDED AND FRONT DRIVER'S SIDE SEAT BROKE AND FELL BACKWARDS. BRACKET THAT HOLDS SEAT BROKE. WHEN SEAT FELL BACKWARD IT INJURED A CHILD IN BACK SEAT. DAMAGE WAS ON RIGHT REAR SIDE OF VEHICLE. HAD NOT CONTACTED DEALER. *AK

• 11/14/2001· AIR BAGSCrash

  VEHICLE WAS REARENDED AND AIR BAG DID NOT DEPLOY. VEHICLE WAS HIT ON RIGHT REAR SIDE. *AK

• 11/08/2008· SEAT BELTS

  DRIVER'S SIDE SEATBELT KEEPS TANGLING WITHIN THE TRIM PANELS PREVENTING PROPER DEPLOYMENT OR RETRACTION OF THE BELT. I HAD TO REMOVE THE TRIM PANELS AND MANUALLY TWIST THE BELT THROUGH THE B POST GUIDE TO STRAIGHTEN, AS WELL UNDOING AND REDOING THE ANCHOR BOLTS ON THE B POST AND DRIVER LOWER DOOR SILL SEVERAL TIMES OVER THE LAST FEW YEARS. *TR

• 11/07/2003· SEATSCrash

  AUTOMOBILE COLLISION FRONT SEAT FAILURE LEAVING DRIVER UNABLE TO CONTROL THE VEHICLE. VEHICLE INVOLVED 2001, FORD, MUSTANG. *AK

• 11/06/2006· SERVICE BRAKES, HYDRAULIC

  DT*: THE CONTACT STATED WHILE DRIVING 35 MPH, SMOKE BEGAN TO ESCAPE FROM UNDER THE HOOD. THE VEHICLE WAS NOT TAKEN TO A SERVICE DEALER. UPON INSPECTION, AN INDEPENDENT MECHANIC DETERMINED THAT THE ABS ELECTRONIC CONTROL MODULE FAILED.

• 11/04/2008· ENGINE AND ENGINE COOLINGCrash

  I STARTED MY CAR AND PUT IT IN DRIVE AND BEGAN TO ACCELERATE WHEN THE ENGINE RACED TO 6000 RPMS. PUT MY FOOT ON THE BRAKE AND THE CAR KEPT ACCELERATING. I PULLED MY PARKING BRAKE AND GOT THE SAME RESULT. I THEN PUT MY CAR IN PARK AND AT THAT TIME I WAS DOING ABOUT 60 IN A NEIGHBORHOOD HEADING STRAIGHT FOR A LIGHT POLE. I JUST BARELY MISSED THE POLE BUT STILL HIT THE CURB AND TOTALED MY CAR. AFTER TURNING THE KEY THE ENGINE STOPPED. A MECHANIC AT THE COLLISION CENTER LOOKED AT MY ENGINE AND SAW THAT MY THROTTLE WAS STUCK WIDE OPEN. THE CAR IS STILL SITTING AT THE COLLISION CENTER WAITING FOR A FORD REPRESENTATIVE TO COME AND LOOK AT IT. *TR

• 10/31/2011· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2001 FORD MUSTANG. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD. THE CONTACT STOPPED THE VEHICLE AND NOTICED A HOSE WAS DETACHED FROM THE ENGINE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THAT THE BYPASS HOSE WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED WHILE THE VEHICLE WAS STILL AT THE DEALER. THE TECHNICIAN THEN STATED THAT THE MANIFOLD WAS FRACTURED AND THE HEAD GASKET WOULD HAVE TO BE REPLACED. THE MANIFOLD WAS REPLACED BUT NOT THE HEAD GASKET. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. UPDATED 12/06/11*LJ THE CONSUMER STATED THE REPAIR TECHNICIAN WAS INJURED WHILE REPAIRING THE CRACKE MANIFOLD INTAKE. UPDATED 06/13/2012 *JS

• 10/31/2006· AIR BAGSCrash

  DT*: THE CONTACT STATED WHILE TRAVELING 65 MPH, A TRAILER HIT THE VEHICLE ON THE REAR PASSENGER SIDE. THIS CAUSED THE VEHICLE TO HIT A GUARD RAIL WITH THE FRONT END. THERE WAS BRAKING PRIOR TO THE IMPACT AND THE AIRBAGS DID NOT DEPLOY. THE DRIVER WAS WEARING A SEAT BELT, BUT MINOR INJURIES WERE SUSTAINED. THERE WAS A POLICE REPORT TAKEN AT THE SCENE. THE VEHICLE WAS TOWED TO AN IMPOUND LOT WHERE IT WAS DEEMED TOTALED BY THE INSURANCE COMPANY. THE VEHICLE WAS NOT INSPECTED TO DETERMINE WHY THE AIRBAGS DID NOT DEPLOY.

• 10/29/2008· SUSPENSION

  THE LEFT DRIVER SIDE OF THE CAR CAME COMPLETELY OF AND FELL ON THE RIM AND BROUGHT THE CAR TO AN ALMOST COMPLETE STOP. *TR

• 10/28/2006· STRUCTURE

  REAR SPOILER CRACKING ALONG SEAMS. *NM

• 10/28/2004· STRUCTURE

  STOPPING FOR RED LIGHT AND BRAKES FAILED, BRAKE PAD TO FLOOR NO INJURIES. OUR MECHANIC DIAGNOSED BRAKE LINE WAS SEVERED FROM REAR RIGHT UPPER CONTROL ARM WELD FAILURE CAUSED BRACKET TO BREAK, CUTTING BREAK LINE. TOOK CAR TO DEALERSHIP WHERE PURCHASED 2 MONTHS EARLIER. AFTER DEALERSHIP SAID IT WAS FAULT OF DRIVER (SAID WARRANTY WOULD NOT COVER) WE INVESTIGATED THIS MATTER AND FOUND 2 OTHER REPORTS ON NHTSA, THEN DEALERSHIP AGREED TO FIX PROBLEM. WE ARE VERY DISSATIFIED WITH THE HANDLING OF THIS SERIOUS PROBLEM FROM DEALERSHIP. *AK

• 10/28/2003· ENGINE AND ENGINE COOLING

  VEHICLE STALLED WHILE DRIVING AT A MODERATE SPEED. THE VEHICLE THEN CAME TO AN ABRUPT HALT. DEALER WAS CONTACTED, BUT COULD NOT DUPLICATE THE STALLING PROBLEM. *AK

• 10/28/2003· AIR BAGSCrash

  WHILE DRIVING 25 MPH CONSUMER TURNED LEFT ON A ROAD UNDER CONSTRUCTION AND VEHICLE ROLLED ACROSS A STRETCH OF GRAVEL, IT LOST CONTROL AND COLLIDED WITH A BEAM PROTRUDING FROM A RETAINER WALL. SEAT BELTS WERE WORN, BUT THE FRONT AIR BAGS DID NOT DEPLOY. CONSUMER SUSTAINED MINOR BACK AND HEAD INJURIES. POLICE DID ARRIVE ON THE SCENE BUT THE CONSUMER WAS NOT CITED. *AK

• 10/27/2020· WHEELS

  TL* THE CONTACT OWNS A 2001 FORD MUSTANG EQUIPPED WITH HANKOOK TIRES, TIRE LINE: VENTUS V2 EVO2, TIRE SIZE: 275/35/R18, DOT NUMBER: 5MRKYBH. THE CONTACT STATED THAT THE TIRES WERE PURCHASED IN MARCH OF 2020 AND INSTALLED IN APRIL OF 2020. AFTER DRIVING THE VEHICLE FOR APPROXIMATELY 3,000 MILES, THE TIRES SHOWED EXCESSIVE UNEVEN TREAD WEAR. THE CONTACT STATED THAT THE VEHICLE FAILED THE STATE INSPECTION DUE TO THE TREAD WEAR FAILURE. THE CONTACT STATED THAT THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE ISSUE. THE MANUFACTURER RECOMMENDED THAT THE TIRES BE INSPECTED BY AN AUTHORIZED HANKOOK DISTRIBUTOR. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE EXCESSIVE TREAD WEAR WAS NOT DUE TO A TIRE MANUFACTURING DEFECT BUT AN ISSUE WITH THE VEHICLE. THE TIRES WERE NOT REPLACED AND REMAINED ON THE VEHICLE. THE VEHICLE FAILURE MILEAGE WAS UNKNOWN.

• 10/25/2020· SEAT BELTS,SERVICE BRAKES,FUEL/PROPULSION SYSTEM

  1. THERE IS A DREADFUL GAS FUME ODOR INSIDE THE CAR EVERY TIME I PUT FUEL IN THE CAR ESPECIALLY WHEN I FILL THE TANK. 2.THE EMERGENCY BRAKE DOES NOT WORK PROPERLY. WHEN ENGAGED MY CAR STILL ROLLS A LITTLE. 3. THE SEAT BELTS DO NOT RETRACT PROPERLY AND TEND TO TWIST AND TANGLE WHEN I TRY TO DO IT MANUALLY.

• 10/24/2004· ELECTRICAL SYSTEM

  MY IGNITION ON MY 2001 FORD FOCUD ZX3 ALSO HAS LOCKED UP AS SO MANY OTHERS. IT HAS DONE THIS MANY TIMES BEFORE AND THIS SATURDAY IT HAS FINALLY GAVE UP, LEAVING ME AND MY GIRL FRIEND STRANDED 25 MILES FROM HOME. I TRIED JIGGLING THE STEERING WHEEL AND KEYS AND SPEND ABOUT 3 HOURS TRYING TO GET THE IGNITION UNLOCKED. THIS IS DEFINENTLY A DESIGN FLAW AND FORD NEEDS TO ADDRESS IT. I WILL DEFINENTLY NOT BE BUYING A FORD AGAIN IF THIS IS HOW THEY TREAT THEIR CUSTOMERS AND DESIGN THEIR SHODDY CARS.*AK

• 10/23/2010· SERVICE BRAKES, HYDRAULIC

  A LOUD FOG HORN SOUND COMING FROM UNDER THE HOOD. RAISED RPM HELPED TO REDUCE OR STOP NOISE. THE ABS LIGHT (AMBER) COMES ON AND DISENGAGES THE TRACTION LOC FOR THE REAR END (DRIVE WHEELS). OVER A PERIOD OF APPROX. 1 MONTH THE ABS LIGHT STAYS ON WITH TRACLOC DISENGAGED. I GOT THE SYSTEM CHECKED AND THEY STATED NO ELECTRIC SIGNAL IS COMING OUT OF THE CONTROL MODULE BUT POWER IS GOING IN. I WAS TOLD FOR A MORE DETAILED ANALYSIS I SHOULD TAKE IT TO FORD BECAUSE THERE ARE 2 ITEMS THAT COULD BE REPLACED AND IT COULD BE $2600.00 OR MORE. *TR

• 10/22/2007· ELECTRICAL SYSTEM

  WHENEVER IT RAINS MY 2001 FORD EXPEDITIONS ELECTRICAL GOES CRAZY, I GET A LEAK FROM WHEAT I AM GUESSING IS THE WINDSHIELD, AND THE FLOOR GETS WET, THEN MY AC RUNS WITHOUT THE KEYS IN THE IGNITION AND MY LIGHTS COME ON AND OFF, THE RADIO GOES ON AND OFF AND KEEPS DRAINING THE BATTERY, TOOK IT TO FORD, BUT ALL THEY SAY IS IT NEEDS A NEW GEM MODULE BUT NEVER SAYS ANYTHING ABOUT THE WINDSHIELD. THIS HAS BEEN AN ON GOING PROBLEM FOR ABOUT 6 MONTHS. *JB

• 10/19/2005· POWER TRAIN

  DRIVING ALONG AND THE 4 WHEEL DRIVE JUST CAME ON AND I DIDN'T TOUCH ANYTHING. THE WHEELS FELT LIKE THEY HAD LOCKED UP AND WERE SCREECHING ON THE DRIVEWAY. THERE WERE BLACK MARKS ON THE DRIVEWAY FROM THE TIRES. HAD THE CAR TOWED TO A FORD DEALER, THEY CHECKED IT AND TOLD ME THE SHIFT MOTOR AND GEM MODULE HAD TO BE REPLACED. ALSO TOLD ME THAT THERE WAS A TSB ON THE PROBLEM. I HAD NO IDEA WHAT THAT MEANT. AFTER READING ABOUT THIS I FEEL THAT THIS IS A MANUFACTURERS DEFECT. MY EXTENDED WARRANTY WILL NOT COVER THIS AND THE FORD MOTOR COMPANY WILL NOT COVER THIS PROBLEM. THE FORD MOTOR CO. HAS SAID THAT THEY HAVE KNOWN ABOUT THIS PROBLEM IN THE 99-2001 EXPEDITIONS AND F250 LD AND F-150 AND LINCOLN 99-2001 NAVIGATOR. THEY ALSO HAVE SAID WHAT THE NEW PART NUMBER THAT IT SHOULD BE REPLACED WITH. I WOULD THINK IF I WAS DRIVING 65 MPH AND THE 4X4L COMES ON I COULD GET INTO A MAJOR ACCIDENT, SINCE YOU ARE ONLY SUPPOSED TO GO 30 MPH OR LESS IN 4X4L. I HAVE NOT YET HAD THE CAR REPAIRED. REPAIRS ARE GOING TO COST ME OVER $800. I HAVE PAID FOR DIAGNOSTIC FEES OF $68.00. *NM

• 10/18/2004· AIR BAGSCrash

  WHILE DRIVING, THE CONSUMER HAD AN ACCIDENT. THERE WAS DIRECT FRONTAL IMPACT TRAVELING AT 65 MPH. THE AIR BAGS DID NOT DEPLOY. THE CONSUMER HIT HIS HEAD ON THE WINDSHIELD.

• 10/17/2011· ENGINE AND ENGINE COOLING

  S # 1 SPARKPLUG EJECTED FROM HEAD UPON ENGINE START-UP. *TR

• 10/17/2009· FUEL SYSTEM, GASOLINE

  SINCE IT HAS GOTTEN COLDER, THE CAR START AND YOU HAVE TO SIT WITH YOUR FOOT ON THE GAS PEDAL FOR 5 OR 10 MINS OR THE CAR WILL STALL OUT WHEN YOU TRY TO PUT OUT OF WHERE EVER YOU ARE. DANGEROUS! MECHANIC CAN'T SEEM TO FIND THE PROBLEM, THEY THINK ITS A SENSOR BUT ARE NOT SURE. *TR

• 10/16/2013· SEAT BELTS

  SEAT BELT ON PASSENGER SIDE ALWAYS RETRACTED SLUGGISHLY SINCE NEW, OFTEN JUST HANGING LOOSELY FROM THE UPPER HANGER. THEN IT WOULD RETRACT WITH HELP. FINALLY IT JAMMED AND WILL NOT RELEASE IN ORDER TO CONNECT THE BELT FOR USE. WHEN AN ATTEMPT IS MADE TO USE THE BELT, I HEAR A METALLIC CLUNK AND THE BELT WILL NOT COME OUT FAR ENOUGH TO USE. *TR