2000 Volkswagen NEW Beetle

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2010· ELECTRICAL SYSTEMFire

  FIRE IN ENGINE COMPARTMENT. *TR

• 12/31/2007· ELECTRICAL SYSTEMFire

  MY 2000 VW PASSAT CAUGHT ON FIRE DEC 28, 2007. I HAD IT TOWED TO A NEARBY DEALER FOR SERVICE AND WAS INFORMED THAT THE FIRE WAS CAUSED BY A FAULTY IGNITION COIL. THE FINAL COST TO REPAIR (IF IT CAN BE REPAIRED) IS STILL BEING INVESTIGATED. I FIND IT VERY PERTURBING TO FIND OUT THAT VW KNEW OF THESE (COIL) DEFECTS YET DID NOTHING TO INFORM OWNERS. I HAD TWO SMALL CHILDREN AGES 2 AND 4 IN THE VEHICLE AT THE TIME OF THE FIRE. FORTUNATELY, MY QUICK INSTINCTS PUT THE FIRE OUT WITH LIMITED ENGINE DAMAGE AND WITHOUT CASUALTIES. *TR

• 12/30/2011· EQUIPMENT

  I WAS USING THE VEHICLE JACK TO RAISE THE LEFT REAR WHEEL OFF THE GROUND TO CHANGE THE TIRE. THE CAR WAS ON A FLAT CONCRETE GARAGE FLOOR. THE JACK FAILED AND THE REAR OF THE VEHICLE SWUNG TOWARD ME. THE JACK SHOULD NOT HAVE FAILED. I CAN SEE THAT THE JACK IS NOT MADE VERY WELL. THE VEHICLE COULD HAVE EASILY FALLEN ON TOP OF ME AND SERIOUSLY INJURED OR KILLED ME. I CHECKED TO SEE IF THERE IS A SAFETY RECALL ON THESE VEHICLE JACKS; BUT, I COULD NOT FIND ONE. THESE JACKS POSE A SERIOUS SAFETY RISK. I WOULD LIKE FOR VW TO REPLACE MY JACK WITH ONE THAT IS SAFE AND WILL NOT FAIL LIKE THIS ONE DID. I HAVE THE JACK AVAILABLE FOR INSPECTION. *KB

• 12/29/2009· AIR BAGS

  FOR THE FIFTH TIME IN 10 YEARS, THE AIRBAG WARNING LIGHT HAS COME ON IN MY 2000 VOLKSWAGEN NEW BEETLE (LESS THAN 50,000 MILES AND NEVER IN A CRASH). ACCORDING TO MANUFACTURER WHEN THE AIRBAG WARNING LIGHT IS ON THE AIRBAGS ARE DEACTIVATED PROVIDING NO PROTECTION IN THE EVENT OF A CRASH. DEALER HAS TWICE PREVIOUSLY REPLACED DRIVER SIDE AIRBAG HARNESS AND RECOMMENDS DOING SO AGAIN. *TR

• 12/29/2006· ELECTRICAL SYSTEM

  2000 VW NEW BEETLE- DIESEL: HAS HAD RECURRING PROBLEM WITH THE GLOW-PLUG SYSTEM. COMPONENTS HAVE BEEN REPEATEDLY REPLACED STARTING 11/2004. SERVICE DATES INCLUDE, BUT NOT LIMITED TO 5/2005, 8/2006, 12/2006, NOT INCLUDING SEPARATE DIAGNOSTICS. TOTAL CHARGES TO DATE IN EXCESS OF $1200.00 OF THIS SINGLE SYSTEM. NO HELP FROM MANUFACTURER OR ACKNOWLEDGEMET THAT A PROBLEM EVEN EXISTS. VEHICLE IS LOCATED IN AREA (SE TEXAS) THAT WOULD NECESSITATE THE USE OF GLOW PLUG ONLY A FEW DAYS A YEAR. THE SYSTEM IS SUPPOSED TO BE DESIGNED TO ACTIVATE ONLY BELOW A CENTIAN LOW TEMPERATURE. IT IS OTHERWISE A 'STATIC' SYSTEM WITH NO MOVING PARTS THAT SHOULD NOT BE SUBJECT TO WEAR AND TEAR. YET, COMPONENTS OF THIS SYSTEM HAVE REGULARLY FAILED, CAUSING DASHBOARD WARNING LIGHT. HAVE TOTALLY LOST CONFIDENCE IN THE VEHICLE, OR VW'S AUTHORIZED SERVICE PROVIDERS TO ROCOGNIZE THAT THERE IS A PROBLEM, AND PROVIDE A SOLUTION FROM THE MANUFACTURER'S SIDE THAT IS A PERMANENT FIX, RATHER THAN JUST REPLACING THE SAME PARTS REPEATEDLY.

• 12/27/2001· ELECTRICAL SYSTEMFire

  CAR BEGAN TO HESITATE BUT DID NOT STALL. ALL PANEL LIGHTS BEGAN TO FLASH, ALSO A ''CLICKING'' SOUND. THERE ALSO WAS A SMELL OF BURNING WIRES. THE CAR BECAME FULLY ENGULFED IN FLAME IN LESS THAN 10 MINUTES. THE FIRE BEGAN ON DRIVERS SIDE. *AK

• 12/26/2000· FUEL SYSTEM, DIESEL

  VEHICLE USES DIESEL FUEL. THEREFORE WATER IN FUEL FREEZES IN FUEL FILTER LINE, CAUSING VEHICLE TO STOP. *AK

• 12/25/2007· VISIBILITY

  HEATER SWITCH PROBLEMS. FIRST IT WON'T TURN OFF THE FAN, THEN IT WON'T TURN ON THE FAN, AND IT SMELLED OF COOKED WIRES INSIDE DASHBOARD. *TR

• 12/23/2015· ELECTRICAL SYSTEM,ELECTRONIC STABILITY CONTROL (ESC)

  FUSE BOX ON TOP OF BATTERY MELTED.

• 12/20/2000· SUSPENSIONCrash

  CAR ROLLED-OVER VERY EASILY AFTER GOING OFF ROAD WHEN DRIVE LOST CONTROL ON ICY SURFACE. MY CONCERN IS BASED ON THE CAR ROLLING OVER TOO EASILY. DO NOT BELIEVE THE GRADE THAT CAUSE THE ROLL OVER WOULD HAVE CAUSED ANY OTHER VEHICLE TO ROLL. THIS INDICATES TO ME THAT THE VW BEETLE MAY NOT BE DESIGNED CORRECTLY.

• 12/19/2014· POWER TRAIN,AIR BAGS

  I'VE HAD MY BEETLE SINCE 2005, AND THE AIRBAG LIGHTS CONTINUOUSLY COME ON AS WELL AS ISSUES WITH THE TRANSMISSION. I'VE TAKEN IT TO VW ONCE FOR REPAIR, AND THEY COME BACK ON MONTHS LATER. I'VE READ SIMILAR COMPLAINTS FROM OTHER VW OWNERS CONCERNING THE AIRBAG AND TRANSMISSION. I CAN'T UNDERSTAND WHY THIS ISN'T A RECALL ISSUE PARTICULARLY SINCE THERE WAS A DEATH IN 2007 WITH ANOTHER OWNER. THE AIRBAG WILL NOT DEPLOY WHEN THE LIGHT IS ON. THE WEB PAGE BELOW VOICES THE FRUSTRATIONS OF MANY OWNERS, AND I DO NOT UNDERSTAND WHY THESE COMPLAINTS AREN'T BEING TAKEN SERIOUSLY. THE REPAIRS COST OVER $1600. HOW IS THIS FAIR WHEN HAVING TO GET IT REPAIRED EVERY YEAR? ARE YOU PROTECTING VW? TRYING TO FIND SOMEONE TO CLEAR THE CODES IS DIFFICULT BECAUSE THEY HAVE TO GO UNDER THE SEAT TO ADJUST WIRES AND USING THE COMPUTER TO CLEAR THEM, BUT THEY COME BACK ON A DAY OR TWO LATER. HTTP://WWW.ARFC.ORG/COMPLAINTS/2000/VOLKSWAGEN/BEETLE/AIR_BAGS/PROBLEM.ASPX. *TR

• 12/14/2010· AIR BAGS

  1. 2000 VW BEETLE WORKED FINE. 2. ONE DAY I STARTED THE CAR UP AND THE AIRBAG LIGHT CAME ON. IT DIDN'T COME ON THE NEXT TIME I STARTED IT, BUT IT DID THE TIME AFTER THAT AND IT COMES ON AND STAYS ON NOW EVERY TIME I START THE CAR. 3. TRIED TO HAVE A MECHANIC CHECK IT OUT BUT THEY WERE UNABLE TO READ THE CODE. I WENT ONLINE AND FOUND OUT THAT MANY, MANY PEOPLE HAVE THIS SAME PROBLEM WITH THE AIRBAG LIGHT. (ACCORDING TO MY RESEARCH, ALMOST ALL THE BEETLES HAVE THIS PROBLEM, AS THE WIRING HARNESS UNDER THE SEATS THAT CONNECTS THE SIDE AIRBAGS TO THE BUCKLES ON THE SEAT BELT WAS MADE ABOUT 3" TOO SHORT AND GETS PULLED FORWARD OR OUT COMPLETELY WHEN THE SEATS ARE BROUGHT FORWARD TO GAIN ACCESS TO THE BACK.) THIS OBVIOUSLY SHOULD BE A RECALL. *TR

• 12/14/2001· ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  WHILE COMING TO AN INTERSECTION AND DOWNSHIFTING, INSTEAD OF THE CAR SLOWING DOWN, THE CRUISE CONTROL TURNED ITSELF ON AND PROCEEDED TO ACCELERATE. BY PRESSING THE BRAKE PEDAL, THE CRUISE CONTROL TURNED OFF. THE CRUISE CONTROL SWITCH HAS ALREADY BEEN REPLACED ONE TIME. MY CAR HAS NOW BEEN IN THE SHOP 8 TIMES FOR NUMEROUS ELECTRICAL PROBLEMS AND VW OF AMERICA DOESN'T SEEM TOO INTERESTED ON SOLVING THE PROBLEMS.

• 12/13/2004· ELECTRICAL SYSTEMFire

  WHILE DRIVING BETWEEN 20-40 MPH, SUDDENLY THE VENTILATION PANEL BECAME HOT. WHEN THE DRIVER ATTEMPTED TO TURN THE VENTILATION SYSTEM ON THE KNOB MELTED. THIS WAS FOLLOWED BY SMOKE COMING OUT THE AIR VENT. VEHICLE WAS ENGULFED IN FLAMES WITHIN MINUTES OF THE CONSUMER EXITING THE VEHICLE, AND CALLING THE FIRE DEPARTMENT. THE INSURANCE COMPANY AND A FACTORY REPRESENTATIVE INSPECTED THE VEHICLE. THE CAUSE OF THE FIRE WAS REPORTEDLY DUE TO INTERIOR ELECTRICAL SYSTEM. THE VEHICLE WAS TOTALED.*AK

• 12/12/2005· POWER TRAIN

  DT: THE CONTACT STATES THE GEAR SHIFT WILL NOT MOVE FROM THE PARK POSITION. DUE TO THE DESIGN THE BRAKING SYSTEM IS NOT EQUIPPED WITH ANY OVERRIDE FEATURE THAT WOULD ALLOW THE DISENGAGEMENT OF THE SHIFT POSITION. THE DEALER IS WILLING TO OFFER A FREE REMEDY HOWEVER, THEY WILL NOT PROVIDE THE TOWING SERVICE. THEREFORE, NO REPAIRS HAVE BEEN MADE.*AK

• 12/11/2011· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  ODBI CAME ON WAS TESTED INDICATING CYLINDER MISFIRE TOOK IT FOR REPAIR WAS INFORMED TWO WIRES WERE BROKEN AND SPARK PLUG WAS SEVERELY FOULED NOW THERE'S A COMPRESSION PROBLEM WHICH REQUIRES THE ENGINE TO BE TORN APART. COST OF REPAIRS EXCEEDS AMOUNT VEHICLE'S VALUE AND PURCHASE PRICE I HAVE HAD THIS VEHICLE FOR FIVE MONTHS WHEN VEHICLE WAS PURCHASED IT HAD A LITTLE OVER 51000 MILES ON THE ODOMETER RAN GREAT AND THE VEHICLE BODY IS IN EXCELLENT SHAPE. *TR

• 12/09/2009· VISIBILITY

  TURNING ON HEATER IN WINDOW MODE WILL CAUSE WINDOWS TO FOG UP IN ANY WEATHER ANY OUTSIDE TEMPERATURE. A SEARCH OF THE INTERNET SHOWS I AM NOT THE ONLY 1 WITH MY TYPE OF VEHICLE HAVING THIS ISSUE. A SMELL COMES INTO THE CAR THAT CAN'T BE GOOD FOR YOUR HEALTH. *TR

• 12/09/2004· EXTERIOR LIGHTING

  03V265000/EXTERIOR BRAKE LIGHT SWITCH. THE CONSUMER TOOK THE VEHICLE INTO THE DEALER TO HAVE THE RECALL SERVICE WORK DONE. THE CONSUMER WAS NOT HAVING ANY PROBLEMS WITH THE BRAKES OR THE BRAKE LIGHT. NOW, CONSUMER HAS DIFFICULTY CHANGING GEARS WHEN PRESSING ON THE BRAKE PEDAL. THE CONSUMER EXPERIENCED PROBLEMS GOING FROM PARK TO DRIVE OR FROM PARK TO REVERSE. THE VEHICLE LEFT THE CONSUMER STRANDED. THE EPC LIGHT ILLUMINATED AND AFTER SEVERAL MOMENTS, THE VEHICLE BEGAN TO OPERATE NORMALLY. THE CONSUMER TOOK THE VEHICLE BACK TO THE DEALER WHO INFORMED THE HIM THAT THE PROBLEM WITH THE VEHICLE WAS THE BRAKE LIGHT SWITCH. BECAUSE THE BRAKE LIGHT SWITCH WAS PREVIOUSLY REPLACED DURING THE RECALL, THE VEHICLE WAS 27 DAYS PAST THE 12 MONTH 12,000 MILES REPLACEMENT PARTS WARRANTY. PROVIDE FURTHER DETAILS. *JB

• 12/07/2006· AIR BAGS

  DT*: THE CONTACT STATED THE AIR BAG LIGHT ON THE DASHBOARD ILLUMINATED. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO DETERMINED THAT THE AIR BAG DRIVER INFLATOR MODULE FAILED.

• 12/07/2004· ENGINE AND ENGINE COOLING

  RADIATOR FAILURE. CRACKED RADIATOR ON PASSENGER SIDE BOTTOM. RADIATOR FAN FAILURE. BEARINGS IN MOTOR SQUEALING. *AK

• 12/05/2002· VISIBILITY

  MY HUSBAND WAS INSTALLING THE BABY SEAT INTO THE BACK SEAT OF OUR CAR IN PREPARATION FOR BRINGING OUR NEWBORN SON FROM THE HOSPITAL ON A COLD RAINY EVENING. WHEN HE TURNED THE REAR-WINDOW DEFOGGER ON. THE REAR WINDOW OF THE CAR EXPLODED INTO SMALL FRAGMENTS OF FLYING SHRAPNEL WHICH SPATTERED ALL OVER THE BACK SEAT AND BABY SEAT. MY HUSBAND SUSTAINED MINOR CUTS ON HIS HANDS AND HEAD. IF THIS HAD HAPPENED THE NEXT DAY, WHEN WE WERE TO BRING MY SON HOME. HE MIGHT HAVE BEEN BLINDED AND BADLY LACERATED OR MUCH WORSE. THE ENTIRE BACK OF THE CAR WAS SOAKED DUE TO THE DRIVING RAIN. BEFORE MY HUSBAND GOT THE CAR INTO A GARAGE, SIGNIFICANT WATER DAMAGE WAS DONE TO THE ENTIRE BACK PASSENGER COMPARTMENT. I CONTACTED VW TO PAY FOR OUR DEDUCTIBLE AND REIMBURSE US FOR THE WATER DAMAGE, AND THEIR ONLY ANSWER WAS THAT THE VEHICLE IS OUT OF WARRANTEE AND THAT THEY WILL NOT HELP US. I MENTIONED THE SERIOUSNESS OF THE INJURIES WHICH COULD HAVE HAPPENED HAD MY SON BEEN IN HIS REAR FACING BABY SEAT WHEN THE GLASS SHATTERED. THEY WEREN'T EVEN INTERESTED IN TAKING THE INFORMATION DOWN. THE CUSTOMER SERVICE AGENT, A MR. BRANDON CURTIS, SEEMED WILLING TO HELP, BUT IT SEEMS HIS SUPERVISOR OVERRULED HIM. I HOPE WE CAN FIND A WAY TO GET VW TO PAY FOR OUR EXPENSES, BUT EVEN MORE IMPORTANTLY, IT IS VITAL TO MAKE SURE THIS NEVER HAPPENS TO ANYONE WHILE THERE IS A CHILD OR INFANT ON THAT BACK SEAT. DT

• 12/05/2001· EXTERIOR LIGHTING

  FAILED HEADLIGHT CANNOT BE REPLACED BY OWNER BECAUSE OF THE DIFFICULTY OF REMOVING FRONT CAR PANEL. THE ONLY DEALER WITHIN 30 MINUTE DRIVE CANNOT WORK ON THE CAR WITHIN THE NEXT 5 DAYS, RESULTING IN CAR HAVING TO BE DRIVEN WITHOUT HEADLIGHT. SUGGEST DEALERS MAKE EXCEPTIONS FOR WORKING ON CARS IN NEED OF A HEADLIGHT, SINCE IT'S A CORE PIECE OF SAFETY EQUIPMENT AND THAT CONSUMERS BE MADE AWARE OF THE DESIGN PROBLEM BEFORE BUYING THIS CAR BECAUSE OF BOTH THE TIME AND EXPENSE INVOLVED IN A PIECE OF EQUIPMENT THAT IS SUBJECT TO FAILURE AT ANY TIME. *AK

• 12/04/1999· SERVICE BRAKES, HYDRAULIC

  ABS CONTROL UNIT AND PUMP WERE REPLACED DURING AN EXTENDED STAY (OVER 30 DAYS) AT THE DEALER. BRAKES ARE CURRENTLY NOT OPERATING PROPERLY. CAR TO BE RETURNED TO DEALER FOR REPAIR(S).

• 12/02/2018· ELECTRONIC STABILITY CONTROL (ESC),ENGINE

  I BOUGHT A BEETLE (136K M) FROM AN ACQUAINTANCE FOR $1600 CASH THERE WERE SOME ISSUES I.E. THE FAULTY TRUNK RELEASE DIDNT WORK, THE DRIVER SIDE DOOR HAD NO POWER, (TURNS OUT THE DOOR MOTOR IS A COMMON ISSUE BEETLE HAS) SUNROOF WAS STUCK PART OPEN, AND THE KEY FOB TO THE BEETLE HAD BEEN WORN/BROKEN. (FUN FACT: WITHOUT THE KEY FOB, ACCESS TO THE TRUNK, AND NO POWER TO THE DRIVER SIDE DOOR. THE STOCK ALARM IS VERY DIFFICULT TO DISABLE.) WE DROVE THE BEETLE FOR ABOUT A WEEK WHEN THE CLUTCH WENT OUT. A TRANSMISSION SPECIALIST QUOTED US $400 FOR THE HYDRAULIC LINE, AFTER FURTHER EXAMINATION THE ENTIRE CLUTCH WAS OUT (HE CHARGED ME $1100) THE VERY NEXT DAY THE OIL LIGHT WAS BLINKING, WE CHECKED THE OIL LEVEL AND IT WAS FULL. WE CONTINUED ON OUR BUSINESS THE CAR STARTED LOSING POWER, STALLING AND MAKING A HORRIBLE TAPPING/KNOCKING SOUND. THE ENGINE LIGHT STARTED BLINKING. WE WERENT ABLE TO PULL CODES BECAUSE THE ODB WAS DISCONNECTED DURING THE EXPENSIVE CLUTCH REPAIR. AT THIS POINT WE HAVE INVESTED A GREAT DEAL OF MONEY INTO THIS USED VEHICLE, WE ARE HESITANT TO TO TAKE IT TO THE CRUSHER. WE BOUGHT A HAYNES REPAIR MANUAL AND AFTER SOME LUCK, COMMON SENSE, AND TROUBLE SHOOTING WE WERE ABLE TO DIAGNOSE THE CAR WITH A FAULTY CAMSHAFT TIMING CHAIN TENSION GUIDE. THE REPAIR SEEMED EASY ENOUGH SO WE ENLISTED A OUR FAMILY MECHANIC TO PERFORM THE REPAIR. AFTER ANOTHER $575 WE DISCOVERED THAT THE TENSION GUIDE WAS IN FACT THE PROBLEM. WE WERE ABLE TO GET THE VEHICLE ALL PUT BACK TOGETHER WITH SEVERAL NEW VITAL PARTS. IT WILL NOT TURN OVER. THE MANUAL INDICATES IT MAY STILL BE OUT OF TIME OR WE MAY HAVE A BLOWN FUSE. AFTER I REPLACE THE FUSES AND REATTEMPT INSTALLING THE TIMING CHAIN, I WILL HAVE PUT 3 X AS MUCH MONEY INTO THIS CAR THAN ITS WORTH. I FEEL LIKE VOLKWAGEN IS PRODUCING LEMONS AND RIPPING OFF AMERICANS!!!

• 12/01/2006· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,AIR BAGS

  AIRBAG SHORT TO GROUND COOLANT SYSTEM SHORT TO GROUND. *JB

• 11/28/2004· EXTERIOR LIGHTING

  WAS WONDERING IF THERE IS A PROBLEM/RECALL WITH THE NEW VW BEATLE. I HAVE A 2000 AND I HAVE HAD TO REPLACE THE HEADLIGHTS 4-5 TIMES WITHIN A YEAR OR SO. ALSO I SEE ALOT OF THEM ON THGE HIGHWAY WITH ONE HEADLIGHT OUT. DO YOU HAVE ANY INFORMATION INREFERENCE TO THIS ISSUE. *AK

• 11/26/2005· EXTERIOR LIGHTING

  RECENTLY I BROUGHT MY NIECE'S VW 2000 NEW BEETLE TO THE VW DEALER TO HAVE THE BRAKE LIGHT SWITCH REPLACED. IT WAS CLEARLY EVIDENT FROM INFORMATION AVAILABLE ON THE WEB AND THE RECALL NOTICE BELOW THAT THE VEHICLE WAS EXPERIENCING THE SAME PROBLEM DESCRIBED IN THE RECALL. HOWEVER THE DEALER INDICATED THE VIN FOR MY NIECE'S VEHICLE WAS NOT INCLUDED IN THE RECALL AND THEREFORE NOT COVERED BY VW. WE HAD IT FIXED ANYWAY AT OUR COST AND IT WAS EXACTLY WHAT IS INDICATED IN THE RECALL. LATER I CONTACTED VW CUSTOMER SERVICE IN THE US AND THEY DISCUSSED THE MATTER WITH THE DEALER AND CONFIRMED THEY WOULD NOT COVER THE SERVICE COST FOR REPLACEMENT OF THE BRAKE SWITCH. SURPRISINGLY THE CUSTOMER SERVICE REP AT VW KNEW VERY LITTLE ABOUT THE RECALL AND COULD NOT ACCESS READILY AVAILABLE INFORMATION ON THE WEB TO UNDERSTAND IT. THE VIN FOR OUR VEHICLE IS [XXX]... VW SHOULD BE FORCED TO EXPAND THE RECALL TO ALL VEHICLES, SINCE IT IS CLEAR THE PROBLEM EXIST WTH MANY OTHER VEHICLES BEYOND THOSE INCLUDED AS PART OF THE ORIGINAL RECALL AND THIS IS A SIGNIFICANT SAFETY HAZARD. * MAKE : VOLKSWAGEN MODEL : NEW BEETLE YEAR : 2000 MANUFACTURER : VOLKSWAGEN OF AMERICA,INC NHTSA CAMPAIGN ID NUMBER : 03V265000 MFG'S REPORT DATE : JUL 25, 2003 COMPONENT: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH POTENTIAL NUMBER OF UNITS AFFECTED : 295136 SUMMARY: ON CERTAIN PASSENGER VEHICLES, THE BRAKE LAMP SWITCH MAY MALFUNCTION. CONSEQUENCE: IF THIS HAPPENS, THE BRAKE LAMPS COULD BECOME INOPERATIVE; OR THE LAMPS COULD COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED. REMEDY: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE BRAKE LAMP SWITCHES. OWNER NOTIFICATION BEGAN SEPTEMBER 26, 2003. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987. NOTES: VW RECALL NO. WT. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATIONS AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236). *NM UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• 11/25/2004· ELECTRICAL SYSTEM

  TWO WIRES ON IGNITION SWITCH MODULE SHORTED. CAUSED FAILURE OF HEADLIGHTS, WIPERS, BRAKE LIGHTS, AIR CONDITIONING, INTERIOR LIGHTING, ETC. IGNITION MODULE WAS REPLACED. PROBLEM REMEDIED.*AK THIS IS A KNOWN PROBLEM. VOLKSWAGEN, AND VOLKSWAGEN OF AMERICA REFUSE TO RECOGNIZE THIS DEFECT, OR INITIATE A RECALL. HERE IS A LINK TO AN ONLINE FORUM WITH OTHER CONSUMERS THAT HAVE HAD THE EXACT SAME SAFETY ISSUE AS I HAVE. HTTP://FORUMS.NEWBEETLE.ORG/SHOWTHREAD.PHP?S=0667E7E7A9388BFAAA8A71DCDD6574F2&POSTID=499275#POST499275 THIS IS A FIRE HAZARD, AND COULD POTENTIALLY HURT SOMEONE. UPDATED 07/24/2012. *TR

• 11/24/2008· AIR BAGS

  PROBLEM: CHRONIC FAILURE OF DRIVER'S AIR BAG CIRCUIT PURCHASED FEBRUARY 2000. SINCE JULY 2004 WE HAVE HAD REPEATED (EIGHT) REPAIRS DONE IN RESPONSE TO THE AIRBAG LIGHT ILLUMINATING CONTINUOUSLY, INDICATING THE AIR BAG CIRCUIT IS FAULTY AND THE AIR BAG WON'T FIRE SHOULD AN ACCIDENT OCCUR. DESPITE REPEATED REPAIRS, TWICE COMPLETELY REPLACING THE WIRING HARNESS, AND ONCE REPLACING THE AIRBAG ITSELF, THE AIRBAG LIGHT HAS ILLUMINATED AGAIN THIS WEEK AND A NINTH REPAIR IS NEEDED. ALL REPAIRS HAVE BEEN DONE AND DOCUMENTED BY OUR VW DEALER. TO DATE REPAIR COSTS EXCEED $1500. THE PROBLEM CONTINUES TO OCCUR. *TR

• 11/22/2011· POWER TRAIN,VEHICLE SPEED CONTROL

  I JUST BOUGHT A 2000 VOLKSWAGEN NEW BEETLE, AND MY TRANSMISSION IS SLIPPING I HAVE TAKEN THIS VEHICLE TO MORE THAN ONE LOCATION INCLUDING THE VOLKSWAGEN DEALERSHIP AND EVERYONE IS TELLING ME THE CODE READ GEAR RATIO INCORRECT. MY CAR IS VERY DANGEROUS FOR ME TOO DRIVE THE DEALERSHIP TOLD ME THAT THE TRANSMISSION I NEED IS 5000 AND THERE IS NO WARRANTY THAT THEY COULD OFFER ME. I JUST BOUGHT THIS CAR I DON'T HAVE 5000 FOR A NEW TRANSMISSION AND I HAVE DONE MY RESEARCH ABOUT THIS SITUATION AND EVERYONE IS SAYING THE SAME EXACT THING IM COMPLAINING ABOUT HOW FAST BEETLES TRANSMISSION GO OUT AND HALF OF THEM TOOK THERE BEETLE TO VOLKSWAGEN JUST FOR THEM TO TELL THEM THEY NEED 5000 TO 7000 TRANSMISSION AND LATER FIND OUT THAT WAS JOT EVEN THE PROBLEM AND THE CAR IS STILL DRIVING VERY RECKLESS. I'M PUTTING MY LIFE N DANGER EVERY TIME I DRIVE THE CAR I HAVE TWO JOBS AND I CANT AFFORD TO MISS ONE DAY. SO U TELL ME MISS DAYS FROM WORK BECAUSE I DON'T HAVE SAFE TRANSPORTATION OR DRIVE THE CAR I HAVE N REST MY LIFE EVERYDAY. I NEED SOMEONE TO HEAR ME OUT AND HELP ME WITH THIS SITUATION. I'M SORRY TO SAY I WILL KEEP COMPLAINING INTEL SOMEONE GETS TO BOTTOM OF THIS. *TR

• 11/22/2004· ELECTRICAL SYSTEMFire

  WHILE PARKED VEHICLE CAUGHT ON FIRE. VEHICLE WAS TOTALED. *AK A PEDESTRIAN INFORMED THE FIRE INSPECTOR THAT THE FLAMES WAS NOTICED COMING FROM THE DRIVER'S SIDE OF THE ENGINE. (ELECTRICAL FIRE) *SC

• 11/18/1999· FUEL SYSTEM, GASOLINE

  AFTER DISCOVERING THAT FUEL WAS LEAKING FROM THE BOTTOM OF THE VEHICLE. VEHICLE WAS TOWED TO A DEALERSHIP, WHERE THE FUEL TANK WAS FOUND TO BE BUSTED. THE FUEL TANK WAS REPLACED AT OWNER'S EXPENSE. DRIVER NEVER RAN OVER ANYTHING THAT COULD HAVE DAMAGED THE FUEL TANK. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

• 11/16/2007· ELECTRICAL SYSTEM

  WE HAVE A 2000 VW BEETLE WITH AUTOMATIC TRANSMISSION THAT HAS SOME SORT OF ELECTRICAL PROBLEM THAT DRAINS THE BATTERY IF NO ONE DRIVES THE CAR FOR A FEW DAYS. WE DIDN'T REALLY NOTICE THE PROBLEM UNTIL OUR DAUGHTERS BOTH WENT OFF TO SCHOOL AND NO ONE WAS DRIVING THE CAR ON A REGULAR BASIS. WE ARE AT THE POINT WHERE AAA AND AMOCO MOTOR CLUB WILL NO LONGER JUMP THE CAR. WE HAVE PURCHASED SEVERAL BATTERIES IN THE LAST 3-4 YEARS OR REPLACED THEM UNDER WARRANTY TO THE POINT WHERE SEARS TOLD US TODAY TO NOT COME BACK. THE VW DEALER TOLD US TO GO SOMEPLACE ELSE BECAUSE THEY COULDN'T HELP US AND VW ITSELF HAS NOTHING TO SAY OTHER THAN GO TO THE LOCAL DEALER WHO TOLD US TO CALL VW. THIS CAR HAS BEEN A PROBLEM FROM THE BEGINNING AND WE HAVE DONE EVERYTHING ASKED OF US, EXPENDED FUNDS AND AN INORDINATE AMOUNT OF TIME TO NO AVAIL. TODAY THE VW DEALER DID SAY THAT THERE WAS A PROBLEM WITH VW'S OF THIS VINTAGE BECAUSE THEY HAD PROBLEMS WITH CARS SITTING ON THE LOT AND DYING. WE NOW NEED TO OUR DAUGHTER TO USE IN CHICAGO, BUT WE CAN'T RISK GIVING IT TO HER AND HAVING HER COME OUT TO THE CAR LATE AT NIGHT AFTER WORK AND FIND THAT THE CAR IS DEAD. *TR

• 11/14/2011· ELECTRICAL SYSTEM,VISIBILITYFire

  TRAVELING ON THE CROSSTOWN FREEWAY @ THE POSTED SPEED, I STARTED TO ENGAGE THE VEHICLE'S HEATER AND THE POWER CONTROL SWITCH STARTED TO MALFUNCTION. I TURNED THE POWER CONTROL KNOB CLOCKWISE AND NOTICED SLIPPAGE OF THE CONTROL KNOB. I NOTICED SMOKE COMING FROM THE WHOLE HEATER CONTROL ASSEMBLY AND THEN AN ARCH, THEN A SMALLFLAME. *TR

• 11/12/2003· ENGINE AND ENGINE COOLING,VISIBILITY

  2000 VOLKSWAGEN BEETLE LEAKING COOLANT, DEFECTIVE AIRFLOW SENSOR, CHECK ENGINE LIGHT ILLUMINATED AND PROBLEMS WITH WINDOW SWITCH. *MR THE WINDOW HAD TO BE OPERATED A CERTAIN WAY IN ORDER TO OPERATE PROPERLY,THE CHECK ENGINE LIGHT HAD COME ON DUE TO A BAD AIRFLOW SENSOR IN WHICH THE PROBLEM OCCURRED ON TWO OCCASIONS, THE COOLANT LIGHT HAD COME ON DUE TO THE TUBE THAT HAD RUN FROM THE COOLANT CONTAINER TO THE ENGINE HAD CUT IN IT AND LEAKED COOLANT. *SCC *JB

• 11/10/2014· SEAT BELTS

  CABLE HAS COMPLETELY SEVERED ON DRIVER'S SEAT BELT RECEPTOR. THIS IS NOT THE RESULT OF AN ACCIDENT BUT JUST DUE TO USE AS INTENDED. ISSUE WAS DISCOVERED ON EXAMINATION ON 7 NOVEMBER 2014. INFORMED VOLKSWAGEN OF AMERICA WHO DECLINED TO REPAIR THE PROBLEM DESPITE SAFETY IMPLICATIONS. INFORMAL COMMUNICATION WITH DEALER SERVICE DEPARTMENT IS THAT THE ISSUE WAS CAUSED BECAUSE A PLASTIC SLEEVE AROUND THE TWO CABLES AT THE LATCHING MECHANISM HAD SLIPPED DOWN THE CABLE ALLOWING THE CABLE TO BEND BACK AND FORTH, EVENTUALLY CAUSING STRESS FAILURE. *TR

• 11/10/2003· POWER TRAIN

  MY WIFE'S VOLKSWAGEN CLUTCH HAS BROKEN 3 TIMES. ONCE AT 3K, ANOTHER AT 34K AND NOW AT 83K; THIS DESPITE THE FACT SHE DRIVES ABOUT THIRTY FIVE MILES EACH WAY TO WORK ON AN EXPRESSWAY, AND DOES NOT SUE THE CLUTCH THAT MUCH. *AK

• 11/09/2004· ELECTRICAL SYSTEM

  FUSE BLOCK ON TOP OF BATTERY MELTED, FUSES NOT BLOWN. *AK

• 11/09/2001· ELECTRICAL SYSTEM

  WHEN JUMP STARTING OR REPLACING BATTERY VEHICLE WOULD RUN APPROXIMATELY THREE MILES OR LESS BEFORE IT STALLS COMPELETLY OUT. VEHICLE HAD TO BE TOWED TO DEALER SHOP TO RESET ALL OF ELETRICAL COMPONENTS, TO GET THE VEHICLE TO RUN AGAIN. IF THIS OCCURS IN A TOWN OR CITY THAT DOES NOT HAVE A VOLKSWAGEN DEALER SHOP WHAT CAN ONE DO? *AK *JG

• 11/07/2005· AIR BAGS

  AIR BAG FAULT LIGHT ON. *NM

• 11/06/2007· AIR BAGS

  ON THE 2000 BEETLE, YOU CAN TELESCOPE THE DRIVER STEERING COLUMN. WELL, THE AIRBAG SPRING COIL UNCOILED ON MY CAR WHEN I TELESCOPED THE COLUMN AND THE ONLY WAY I KNOW THIS IS BECAUSE THE AIRBAG LIGHT CAME ON. THE DEALER AND OTHER MECHANICS ARE SAYING THE WHOLE AIRBAG NEEDS TO BE REPLACED WHICH WILL COST ANYWHERE FROM $600 TO $800. NOW, I DON?T FEEL AS IF THIS IS A PROBLEM I SHOULD HAVE TO PAY FOR. THE VEHICLE WAS DESIGNED TO HAVE THE STEERING COLUMN TELESCOPE SO WHY WOULD THE COIL UNCOIL WHEN I USE THE FEATURE? ALSO, THEY HAVE TOLD ME THAT THE AIRBAG WILL NOT WORK IF SOMETHING WHERE TO HAPPEN. IS THIS SOMETHING VW SHOULD LOOK INTO AND REPLACE FOR ME FREE OF CHARGE? *TR

• 11/06/2006· AIR BAGS

  AIR BAG DASHBOARD LIGHT LIT AT 24,635 MILES. REPAIR MADE BY DEALER 2/9/05 FOR $308 LABOR AND $44.76 PART (SMALL CABLE UNDER DRIVER'S SEAT). TEXT ON DEALER WORK ORDER: "FOUND THE D/S AIRBAG ASSM. TO HAVE A FAULT IN THE CONNECTOR OF HARNESS. REMOVED SEAT ASSM AND REPLACED HARNESS. SEAT AIRBAG CODES. T/DRIVE TO CONFIRM REPAIR." AT 35,500 AIR BAG DASHBOARD LIGHT HAS LIT AGAIN. *NM

• 11/06/2002· AIR BAGS

  AIRBAG INDICATOR LIGHT VOLKSWAGEN AGREED TO PAY FOR REPAIR PAID $73 OUT-OF-POCKET TO GET DIAGNOSTIC AIRBAG INDICATOR LITE ADMISSION OF PROBLEM ONLY PAID FOR REPAIR? LITE OFF WANT $73 REFUNDED. DT

• 11/06/2002· EXTERIOR LIGHTING

  I HAVE HAD TWO BRAKE RELAY SWITCH PROBLEMS WITH THIS CAR IN THREE MONTHS. I THINK ITS A COMMON DEFECT. DT

• 11/04/2013· SERVICE BRAKES

  TL* THE CONTACT OWNS A 2000 VOLKSWAGEN BEETLE. THE CONTACT STATED WHILE DRIVING 25 MPH, THE DRIVER DEPRESSED THE BRAKE PEDAL BUT THE VEHICLE WOULD NOT STOP. THE DRIVER FORCED THE GEAR SHIFT INTO THE PARK POSITION AND THE VEHICLE STOPPED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

• 11/02/2017· AIR BAGS,STRUCTURECrash

  TL* THE CONTACT OWNED A 2000 VOLKSWAGEN BEETLE. WHILE DRIVING APPROXIMATELY 40 MPH, THE DRIVER FELL ASLEEP BEHIND THE WHEEL AND CRASHED INTO A GUARDRAIL. THE AIR BAGS DID NOT DEPLOY. THE DRIVER EXITED THE VEHICLE AND WALKED A FEW YARDS AWAY FROM THE VEHICLE WHEN IT SUDDENLY EXPLODED WITHOUT WARNING. THE DRIVER SUSTAINED A MINOR INJURY THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOTALED AND WAS TOWED TO A TOW YARD. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT NOTHING COULD BE DONE. THE CONTACT WAS PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000. THE VIN WAS NOT PROVIDED.

• 11/02/2007· ENGINE AND ENGINE COOLING

  I RECENTLY PURCHASED A 2000 VW NEW BEETLE ON OCTOBER 10, 2007. MY SIGNIFICANT OTHER DROVE THE CAR TO WORK. WHEN SHE GOT READY TO LEAVE THE CAR WOULD NOT START. SHE CALLED A MECHANIC AND THEY CHECKED THE VEHICLE. THEY DETERMINED THAT THE TIMING BELT HAD BROKEN. THE CAR HAS LESS THAN 90,000 MILES ON IT. I WENT A RESEARCHED AND FOUND OTHER SIMILAR COMPLAINTS ABOUT LOW MILEAGE BEETLES OF THIS YEAR HAVING THE SAME PROBLEM. I AM CONCERNED THAT SUCH AN EXPENSIVE REPAIR IS REQUIRED AT SUCH LOW MILEAGE IN ORDER TO OWN THIS VEHICLE AND HAVE IT OPERATE PROPERLY. I AM NOT THE ORIGINAL OWNER SO I REALIZE THAT THIS REPAIR IS NOT COVERED FOR ME. THERE SHOULD BE SOME FORM OF DISCLAIMER PLACED ON THIS YEAR OF BEETLE SO THAT PERSPECTIVE OWNERS WILL KNOW THAT THEY HAVE AN EXPENSIVE REPAIR COMING UP (TIMING BELT) IF IT HASN'T BEEN CORRECTED ALREADY. *TR

• 11/01/2004· ENGINE AND ENGINE COOLINGFire

  AFTER PARKING THE VEHICLE, WITHIN 15 MINUTE OR LESS THE VEHICLE CAUGHT ON FIRE UNDER THE HOOD. THE LOCAL FIRE DEPARTMENT ARRIVED ON LOCATION TO EXTINGUISH THE FIRE. THE DEALER AND THE MANUFACTURER WERE BOTH NOTIFIED. THE CAUSE OF THE FIRE WAS STILL UNDETERMINED. *JB

• 10/31/2005· ELECTRICAL SYSTEM

  I DROVE AN HOUR AWAY IN THE RAIN, PARKED FOR 15 MINUTES, AND WHEN I RETURNED THE ENGINE WOULD START BUT I HAD NO USE OF WIPERS, HEATER/BLOWER, OR DIRECTIONAL SIGNALS. SINCE I DARED NOT DRIVE IN THE RAIN WITHOUT WIPERS, AND SINCE IT WAS A SUNDAY, I HAD TO GET TOWED HOME. IT WAS THE IGNITION SWITCH -- AND WHEN THEY TRIED TO REPLACE IT, THEY FOUND THAT ITS RECEPTACLE AND NEARBY WIRES WERE ALL MELTED! VW SAYS TOUGH LUCK, IT'S MY PROBLEM. *NM

• 10/26/2001· ENGINE AND ENGINE COOLING

  DURING NORMAL OPERATION OF VEHICLE ENGINE WILL JUMP OR "BUCK", INCREASING THE RISK OF A CRASH IN TRAFFIC. DEALERSHIP HAS EXAMINED VEHICLE AND COULD NOT IDENTIFY CAUSE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / ATTACHMENTS.*AK