2000 Plymouth Voyager

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/28/2008· ENGINE AND ENGINE COOLING

  I HAVE A 2000 CHRYSLER MINI VAN AND MY SERPENTINE BELT KEEPS COMING OFF WHEN IT RAINS. THIS HAS HAPPENED 4 TIMES IN ONE YEAR. THEY HAVE REPLACED THE BELT AND FIXED THE TENSIONER ITS IN THE SHOP RIGHT NOW AND WAITING FOR A BELT KIT TO FIX THE PROBLEM (GATES SYSTEM KIT). WHY ISN'T THERE A RECALL ON THIS PROBLEM? *TR

• 12/20/2000· ELECTRICAL SYSTEM

  ENGINE SHUT DOWN WHILE ON HIGHWAY AT 55MPH. I WAS ABLE TO ROLL IN TO A PARKING LOT SAFELY. CAR RESTARTED 10 MINUTES LATER ONLY TO SHUT DOWN AS SOON AS I MOVED. TOWED TO NEAREST DEALER, THEY REPLACED AN ELECTRONIC CONTROLLER IN ENGINE COMPARTMENT. I DON'T KNOW IF THIS IS COMMON IN THESE VEHICALS, BUT THIS COULD BE DANGEROUS ON TODAYS HIGHWAYS. *AK

• 12/08/2004· SERVICE BRAKES, HYDRAULIC,EXTERIOR LIGHTING,VEHICLE SPEED CONTROL

  THE TRANSMISSION GOES INTO GEAR WITHOUT DEPRESSING THE BRAKE. THE GUIDE PLATES HAD DAMAGING SPOTS. *TC THE BRAKES HAD EXCESSIVE CLEARANCE AND DAMAGED THE TRAILING EDGE. THE VEHICLE WOULD BE IN OPERATION AT A STOP ON A SLIGHT INCLINE, THE GEAR WAS IN DRIVE, WITH THE FOOT REMOVED FROM THE BRAKE AND THE VEHICLE WOULD ROLL BACKWARDS; (THE SAME FOR REVERSE), THE LENS COVERS ON THE VEHICLE HAVE YELLOWED AND OR HAD BECOME OPAQUE. IN RE: 2000 CHRYSLER VOYAGER AND A 1998 PLYMOUTH GRAND VOYAGER *SC *JB

• 12/04/2001· VEHICLE SPEED CONTROL

  WHEN VEHICLE HEATS UP IT WILL ACELLERATE WITHOUT PRIOR NOTICE. CONSUMER WILL PUT FOOT ON BRAKE PEDAL, BUT VEHICLE WILL STILL GO. DEALERSHIP WAS AWARE OF PROBLEM.*AK

• 12/03/2003· POWER TRAIN

  I PURCHASED A NEW 2000 PLYMOUTH VOYAGER MINIVAN IN NOVEMBER OF 1999. IN JANUARY 2002, AT 38,000 MILES, THE TRANSMISSION FAILED, STRANDING ME ON THE SIDE OF THE ROAD. A LOCAL CHRYSLER DEALER DIAGNOSED THE CAUSE AS A FAILED TORQUE CONVERTER. THE TORQUE CONVERTER, AS WELL AS SEVERAL OTHER TRANSMISSION COMPONENTS, WERE REPLACED. IN JANUARY 2003, AT 55,000 MILES, A TRANSMISSION FLUID LEAK WAS NOTICED. THE SAME DEALER REPAIRED TRANSMISSION FLUID LINES AND SEALS, AND CHANGED THE TRANSMISSION FLUID AND FILTER. IN NOVEMBER 2003, AT 75,000 MILES, THE TRANSMISSION FAILED AGAIN, LEAVING MY CHILDREN AND I STRANDED ON THE ROADSIDE AT NIGHT. ANOTHER CHRYSLER DEALER DIAGNOSED THE PROBLEM AS A SECOND FAILED TORQUE CONVERTER. *NLM

• 11/27/2001· ENGINE AND ENGINE COOLING

  WHILE DRIVING 5 MPH HIT A BUMP IN THE ROAD WHICH CAUSED ENGINE TO COMPLETELY SHUTDOWN WITHOUT WARNING. CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK

• 11/25/2014· AIR BAGSCrash

  TL* THE CONTACT OWNED A 2000 PLYMOUTH VOYAGER. WHILE DRIVING 30 MPH, THE DRIVER CRASHED INTO A WALL AND THE AIR BAGS FAILED TO DEPLOY. THE DRIVER WAS FATALLY INJURED. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

• 11/25/2002· STEERING

  CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE SERPENTINE BELT KEEPS ON BRAKING. DEALER WAS CONTACTED AND STATED THAT THEY DON'T KNOW WHY IT KEEPS ON BRAKING. TS

• 11/21/2000· TIRES

  PE00.046; CONSUMER WAS TRAVELING ABOUT 70MPH ON HIGHWAY AND HEARD A HUGE BANGING NOISE. SHE WAS IN FAST LANE, AND POLICE DIRECTED TRAFFIC, SO SHE COULD PULL OVER. THERE WERE NO INJURIES. GOODYEAR TIRE.*AK

• 11/19/2003· VISIBILITY

  FRONT PASSENGER SIDE WINDOW GLASS SLID DOWN INTO THE DOOR. THIS WAS CAUSED BY A FAILURE IN THE ELECTRIC WINDOW MOTOR. THE PART COULD NOT BE REPLACED DUE TO A 1800 PART BACK ORDER, PER DEALERSHIP.*AK

• 11/18/2004· AIR BAGSCrash

  VEHICLE HIT A DEER AT 30 MPH. UPON IMPACT, AIR BAGS DID NOT DEPLOY. AIR BAG LIGHT TURNED ON, AND RECALLS HAVE BEEN ISSUED ON THIS VEHICLE.*AK

• 11/17/2009· ENGINE AND ENGINE COOLING

  DURING A VERY HEAVY RAIN, I HIT A BIG PUDDLE WHICH CAUSED THE SERPENTINE BELT TO COME OFF THE PULLEYS. MY MECHANIC SAID IT IS A COMMON PROBLEM WITH THIS VEHICLE. THE RESULT IS NO POWER STEERING, NO ALTERNATOR TO CHARGE THE BATTERY AND NO WATER PUMP TO COOL THE ENGINE. I DROVE IT UNTIL THE TEMP GAUGE SHOWED HOT AND THEN SHUT IT DOWN. NO MAJOR DAMAGE RESULTED. MECHANIC PUT BELT BACK ON FOR $15.00. 135K MILES ON VEHICLE AND IS VERY DEPENDABLE. *TR

• 11/15/2004· STEERING

  THE IGNITION LOCKED ONCE CONSUMER MOVED THE STEERING WHEEL TO THE LEFT. VEHICLEWAS SERVICED FOR THE PROBLEM, AND THE CONSUMER HAD TO PAY OUT OF POCKET. HOWEVER, A RECALL FOR CLOCK SPRING WAS RECEIVED. *AK

• 11/15/2000· POWER TRAIN

  I HAVE A TWO YEAR OLD THAT PUT THIS CAR INTO DRIVE WHILE I WAS PUTTING MY FOUR YR OLD IN HIS CAR SEAT. I WOULD HAVE NEVER BOUGHT THIS VEHICLE HAD I KNOWN THAT THIS VEHICLE COULD GO INTO GEAR WITHOUT HAVING YOUR FOOT ON THE BRAKE. I NOW ASK EVERYONE WHO DRIVES ONE OF THESE VANS IF THEY KNEW THAT THEY COULD DO THAT - THEY ARE AS AMAZED AS I AM THAT THIS IS ALLOWED. THIS IS AN ACCIDENT WAITING TO HAPPEN. I AM ENRAGED AT THEIR NONCHALANT ATTITUDE CONCERNING THIS - THERE SHOULD BE WARNINGS ON THE VEHICLE. I EVEN CALLED THE DEALER TO SEE IF IT WAS SUPPOSED TO BE LIKE THAT. HIS RESPONSE WAS WELL YOU JUST HAVE TO MAKE SURE THE EMERGENCY BRAKE IS ON AT ALL TIMES - THANKS FOR NOT TELLING ME THAT WHEN I PURCHASED THE CAR.*AK

• 11/14/2003· AIR BAGS,ELECTRICAL SYSTEM

  AIR BAG LIGHT ILLUMINATED AND THE HORN STOPPED OPERATING. CONSUMER CONTACTED THE DEALER, WHO INFORMED THE CONSUMER OF A RECALL FOR THE AIR BAG CLOCKSPRING, BUT THE RECALL WAS NOT FOR THAT MODEL YEAR. *AK

• 11/11/2003· POWER TRAINCrash

  VEHICLE SHIFTED INTO REVERSE BY IT SELF AFTER IDLING IN PARK FOR ABOUT 30 SECONDS, IT ROLLED BACK CAUSING THE DRIVER'S DOOR (WHICH WAS OPEN) TO HIT THE BUMPER OF A PARKED CAR THUS DAMAGING THE DOOR AND THE LEFT FRONT FENDER.*AK I PERSONALLY SAW AND HEARD THE MOMENT THE VEHICLE SHIFTED INTO REVERSE, I WAS ABOUT 20 FEET AWAY FROM THE VEHICLE WHEN I SAW THE BACK UP LIGHTS COME ON AND THE VEHICLE START TO ROLL BACK.

• 11/10/2008· TIRES

  MY MOTHER, BROTHER, AND I WERE ON AN EMERGENCY TRIP TO ARKANSAS IN THE MIDDLE OF THE NIGHT ON 09/01/08. WE HAD JUST GONE THROUGH KANSAS CITY, MO WHEN MY BROTHER (WHO WAS DRIVING AT THE TIME) LOST CONTROL OF MY 2000 PLYMOUTH VOYAGER VAN AND WAS ABLE TO GET THE VAN OFF TO THE SIDE OF THE INTERSTATE. LUCKILY, THERE WAS NOT A CRASH INVOLVED. THE FRONT DRIVER'S SIDE TIRE WAS SHREDDED DOWN TO NOTHING. HE PUT ON THE SPARE TIRE AND WE STAYED OVER NIGHT AT AN IHOP RESTAURANT. IN THE MORNING, WE WENT TO WALMART AND HAD THE TIRE REPLACED FOR $84.74, AND WE WERE ABLE TO CONTINUE OUR TRIP. WHEN WE RETURNED HOME TO OMAHA, NE, I WENT TO SEARS WHERE THE TIRES WERE ORIGINALLY PURCHASED IN MAY 2005. THE MANAGER OF THE GARAGE AT SEARS WENT OUT TO LOOK AT THE TIRE THE SHREDDED AND ALSO INSPECTED THE OTHER TIRES. HE WAS SURPRISED BY THE LOOK OF THE SHREDDED TIRE (WHICH I KEPT AS EVIDENCE OF THE DAMAGE) AND HE ALSO NOTICED THAT BOTH PASSENGER SIDE TIRES WERE SPLITTING ON THE SIDEWALLS THE SAME WAY THAT THE BLOWN TIRE DID. THE MANAGER ORDERED THREE NEW TIRES, AND THEY WERE MOUNTED ON 09/28/08. I HAVE "ROAD HAZARD PLUS SERVICE AGREEMENT" WITH SEARS, BUT IT STILL COST ME $317.96 TO REPLACE THE 3 TIRES. SEARS ADJUSTED THE BILL BY $35.11 AND $26.33 (TREAD ADJUSTMENT) FOR THE 2 TIRES THAT HAD SPLITS ON THE SIDEWALLS, BUT I HAD TO PAY THE TOTAL COST OF THE TIRE THAT SHREDDED. I WAS VERY UPSET BY THE WHOLE SITUATION. THE TIRES WERE ONLY 3 YEARS OLD AND HAD ABOUT 33,500 MILES ON THEM (75,000 MILE WARRANTY). THE MANAGER GAVE ME THE FOLLOWING NUMBER: PJKCWKHR1005, BUT I DON'T RECALL WHAT IT WAS FOR. IN THE END, IT COST ME $402.70 ($84.74 + $317.96) TO REPLACE THE TIRES (I KEPT THE WALMART TIRE AS A SPARE). I BELIEVE THAT THESE TIRES WERE A DEFECTIVE, BAD BATCH OF TIRES, AND THAT I SHOULD BE REIMBURSED BY EITHER GOODYEAR OR SEARS. I WOULD LIKE TO KNOW IF THERE HAVE BEEN ANY OTHER COMPLAINTS ABOUT THESE PARTICULAR TIRES. THE TIRES ARE GOODYEAR P205/75S14 WEATHERHANDLER LS. *TR

• 11/10/2003· SUSPENSION,ELECTRICAL SYSTEM

  THE KEY WILL NOT TURN IN THE IGNITION. ALSO, VEHICLE IS HAVING A PROBLEM WITH THE WHEEL BEARINGS.*AK

• 11/09/2005· EXTERIOR LIGHTING

  YEAR 2000 PLYMOUTH VOYAGER MINIVAN. EXTREMELY DIM/POOR HEADLIGHTS. DANGEROUS TO DRIVE AT NIGHT. NO REMEDY TO SITUATION. *NM

• 11/09/2000· TIRES

  TREAD COME OFF 2 FRONT TIRES (TIRESIZE: 15)( DOT NUMBER: TIRE SIZE: 15 )

• 11/06/2006· SUSPENSION,STRUCTURE

  DT*: THE CONTACT STATED WHEN THE VEHICLE WAS TAKEN IN FOR A STATE INSPECTION; THE MECHANIC NOTICED THE DRIVER SIDE STRUT TOWER WAS BADLY CORRODED. THE MECHANIC EXPRESSED THAT THE VEHICLE WOULD PROBABLY NOT PASS INSPECTION THE NEXT TIME. THE VEHICLE WAS TAKEN TO THE DEALER, WHO CONTACTED THE MANUFACTURER TO CHECK FOR RECALLS. THE VEHICLE WAS NOT INVOLVED IN ANY RECALLS. THE SERVICE DEALER ALSO SUGGESTED THAT THE CONTACT SHOULD FILE A COMPLAINT WITH THE MANUFACTURER. THE CONTACT PLANNED TO NOTIFY THE MANUFACTURER AFTER FILING A COMPLAINT WITH THE NHTSA. UPDATED 01/10/06. *JB

• 11/05/2004· POWER TRAIN

  TRANSMISSION FAILURE, 2000 VOYAGER TRANSMISSION SEIZED WHILE BEING DRIVEN ON MAIN ST., AT 40,000 MILES. REPLACED AT COST OVER $3000. *BF THE CONSUMER IS SEEKING RESTITUTION FOR THESE REPAIR COSTS. *SC

• 11/03/2008· WHEELS

  MY SON WAS DRIVING OUR MINIVAN 2000 VOYAGER AND THE FACTORY WHEEL OR RIM CRACKED INTO TWO HALVES DAMAGING THE TIRE BY CUTTING THE SIDE WALL. I AM NOT SURE THE OTHER THREE RIMS ARE SAFE. *TR

• 11/03/2003· POWER TRAIN

  THERE WAS A DELAY IN ENGAGING GEARS. VEHICLE JUMPED FORWARD OR BACKWARD UNEXPECTEDLY. TOOK VEHICLE TO DEALER, DEALER STATED TRANSMISSION NEEDED REPLACING. *AK

• 11/01/2007· ENGINE AND ENGINE COOLING

  TL*THE CONTACT OWNS A 2000 CHRYSLER VOYAGER. WHILE DRIVING 15 MPH, THE FAN BELT DISENGAGED WHEN DRIVING THROUGH A PUDDLE OF WATER. THE VEHICLE LOST POWER. THE DEALER REPLACED THE FAN BELT. THE FAILURE OCCURRED ON TWO OCCASIONS. THE DEALER STATED THAT THE WATER WOULD CAUSE THE FAN BELT TO HYDROPLANE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 30,000 AND CURRENT MILEAGE WAS 119,000.

• 11/01/2004· POWER TRAIN

  THE TRANSMISSION HAS A FILTER THAT IS HOUSED AT THE BOTTOM OF THE TRANSMISSION. THE PLASTIC DEVICE THAT HOLDS THE FILTER BREAKS, AND WHILE DRIVING IT FALLS OFF, MAKING THE TRANSMISSION DEFECTIVE. THE O RING AND FILTER WERE REPLACED. IT FELL INTO THE PAN. *AK *SC

• 10/31/2002· EXTERIOR LIGHTING

  CONSUMER STATES THAT WHILE DRIVING AND TURNING THE HEADLIGHT FROM HIGH TO LOW BEAM IT WILL FLICK OFF CAUSING A DISTRACTION TO THE CONSUMER VIEW. DEALER NOTIFIED TS

• 10/30/2008· SUSPENSION

  JUST INFORMED FROM MECHANIC THAT MY FRONT STRUT TOWERS ARE RUSTED THROUGH. DRIVER SIDE IS COMPLETED ROTTED AWAY AND PASSENGER SIDE SHOULD HAPPEN AFTER THIS WINTER. MY 2000 PLYMOUTH VOYAGER HAS UNDER 60,000MILE AND HAS ONLY 2 OWNERS. I HAVE RESEARCHED THAT THIS IS WAY TOO FREQUENT IN VOYAGERS FROM 1996 TO AT LEAST 2000 FOR THEIR NOT BE A MANDATE RECALL ON THIS. THE REPAIR COST CAN COST UP TO $3000 WHICH MOST PEOPLE CANNOT AFFORD. THROUGH MY INTERNET RESEARCH, I AM AWARE THAT CHRYSLER ISSUED SOME SORT OF SUGGESTED FIX FOR THE PROBLEM IN 1992 BUT NOT A RECALL. THIS IS A SERIOUS PROBLEM AND I KNOW IF AT LEAST 6 PEOPLE PERSONALLY THAT ARE HAVING THE SAME PROBLEM. SOMETHING NEEDS TO BE DONE! *TR

• 10/30/2002· SEAT BELTS

  CONSUMER STATED THE SEAT BELT IN THE REAR MIDDLE SEAT, WON'T STAY BUCKLED. CAUSE UNKNOWN. TS *TT

• 10/29/2000· STRUCTURE

  WHEN EITHER SLIDING DOOR IS CLOSING, MY CHILDREN HAVE BEEN CAUGHT BY THE ACTION OF THE DOOR CLOSING SHUT. I SUGGEST HAVING THIS VERY DANGEROUS SITUATION CORRECTED BEFORE SOMEONE GETS SERIOUSLY INJURED. ALSO, NOT ONLY SHOULD THE DOOR HAVE A SENSITIVITY SENSOR BUT KIDS COULD GET THEIR FINGERS CAUGHT IN THE BOTTOM ROLLER SECTION AND GET THEIR TOES OR FINGERS SEVERED OFF. ALSO THE REMOTE TO OPEN THE DOORS IS TO SENSITIVE. WHEN TOSSING YOUR KEYS INTO A PURSE OR ON THE FLOOR,IT WILL TRIGGER THE DOORS CLOSED WHEN YOU LEAST EXPECT IT.

• 10/26/2009· ENGINE AND ENGINE COOLING

  TL*THE CONTACT OWNS A 2000 CHRYSLER VOYAGER. WHILE DRIVING IN EXCESSIVE RAINY CONDITIONS, HE NOTICED THAT THE BATTERY LIGHT APPEARED ON THE DASHBOARD AND THE VEHICLE NO LONGER HAD POWER STEERING. THERE WERE NO PRIOR WARNINGS AND THE CURRENT AND FAILURE MILEAGES WERE 89000. UPDATED 12/07/09 *BF THE SERPENTINE BELT WAS REPLACED. UPDATED 12/09/09

• 10/26/2009· STRUCTURE

  THE STRUT TOWERS OF 2000 CHRYSLER VOYAGER ARE COMPLETELY RUSTED OUT. IF THEY BREAK APART IT WILL LIKELY BREAK THROUGH THE HOOD OR WINDSHIELD CAUSING SERIOUS ACCIDENT AND OR INJURIES WE WERE TOLD BY BLOOMINGTON CHRYSLER (THE DEALERSHIP WHERE WE PURCHASED THE VEHICLE) IT WOULD BE $1000.00 TO REPAIR. THEY TOLD ME THEY HAVE REPAIRED OVER 30 SIMILAR VEHICLES JUST THIS SUMMER 2009 WITH SAME PROBLEM. *TR

• 10/25/2001· SERVICE BRAKES, HYDRAULIC

  RIGHT FRONT BRAKES DISENTEGRATED AT 11500 MILES, NOW EVERY 2000-3000 MILES, THE RIGHT FRONT BRAKES DISSOLVE, CONSUMER STATES THAT THE FRONT RIGHT ROTORS AND BRAKES NEED TO BE REPLACED, CONSUMER DOES NOT FEEL SAFE DRIVING VEHICLE. *SLC

• 10/24/2003· ENGINE AND ENGINE COOLING

  WHILE DRIVING AT 45 MPH, THE STEERING WHEEL BEGAN TO GET STIFF. THE VEHICLE HAD TO BE TOWED. *AK TSB#090600. DURING HEAVY RAIN, THE CONSUMER LOST THE ABILITY TO STEER AND APPLIED THE BRAKES TO AVOID A COLLISION. WHEN THE CONSUMER CHECKED UNDER THE HOOD, HE SAW THAT THE SERPENTINE BELT HAD COME COMPLETELY OFF. THE DEALER TOLD THE CONSUMER THAT THIS WAS A COMMON PROBLEM DUE TO THE MANUFACTURER REMOVING THE SHIELD THAT WOULD HAVE PREVENTED THE INCIDENT. *SCC *JB

• 10/17/2000· POWER TRAINCrash

  VEHICLE WAS IN PARK POSITION WITH ENGINE RUNNING WHEN IT ROLLED BACKWARDS, HITTING A VEHICLE, WHEN THIS HAPPENED THE KEY COULD NOT BE REMOVED . THIS OCCURRED 3 TIMES. VEHICLE WAS NOT REGISTERING PARK GEAR.*AK

• 10/12/2004· AIR BAGSCrash

  I WAS REAR-ENDED ON 10/8/04 AND THE IMPACT WAS HARD ENOUGH TO BREAK THE DRIVER SIDE SEAT. HOWEVER, THE AIRBAGS DID NOT DEPLOY. *NM

• 10/12/2003· AIR BAGS

  CONSUMER TOOK VEHICLE INTO THE DEALER FOR AIRBAG LIGHT PROBLEM. DEALER STATED IT WAS THE CLOCKSPRING. IT COST $275.14 TO REPLACE THE CLOCKSPRING. THE FAULTY CLOCKSPRING ALSO AFFECTED THE HORN AND CRUISE CONTROL. *AK *TS *NLM

• 10/11/2000· TIRES

  PRONOUNCED TIRE BOUNCE BETWEEN 45-50 MPH. TOOK TO DEALER ON FRIDAY, 5 OCTOBER. THEY DIAGNOSED 3 TIRES OUT OF ROUND. TOOK VEHICLE TO GOODYEAR AUTO SERVICE CENTER (37 E. NINE MILE RD., PENSACOLA, FL. 32514, PH. 850-479-2007) ON MONDAY, OCT 9, GOODYEAR DIAGNOSED 1 TIRE (RF) OUT OF ROUND AND 3 ALUMINUM RIMS (LF, LR, & RR) AS BEING WARPED. GOODYEAR ORDERED 3 TIRES AND CHRYSLER DEALER ORDERED 3 NEW RIMS FROM ATLANTA. CALLED BOTH THE MORNING OF OCTOBER 11 AND THEY HAD RIMS AND TIRES. PICKED UP THE RIMS AT CHRYSLER PLYMOUTH DEALER AND TOOK THEM OVER TO GOODYEAR FOR INSTALLATION. GOODYEAR MOUNTED THEIR THREE NEW TIRES ON THE THREE NEW RIMS SUPPLIED BY THE CHRYSLER DEALER AND REPLACE THEM ON THE LF, RR, AND LR. STILL HAVE A THE SAME NOTICABLE BOUNCE. MY MAJOR CONCERN IS THE FACT THAT I STARTED VACATION ON MONDAY, OCTOBER 9TH AND OUR PLAN WAS TO HEAD FOR A VISIT TO MICHIGAN. IT SNOWED LAST WEEKEND IN MICHIGAN, AND ALTHOUGH I AM ORIGINALLY FROM MICHIGAN AND DROVE ON THEIR WINTER ROADS FOR 33 YEARS, I AM CONCERNED ABOUT THE LOSS OF CONTROL ON SLIPPERY ROADS DUE TO THE WHEEL BOUNCE. THE ORIGINAL TIRES, SER #'S B276272GCW79MMSC, B276261GCW79MMSC, AND B301163GCW79MMSC ARE AT THE GOODYEAR STORE, AND THE ORIGINAL RIMS WERE RETURNED TO THE CHRYSLEY/PLYMOUTH DEALER. I DO NOT KNOW WHICH DEALER OR IF THE RIMS OR WHEELS ARE AT FAULT. I DID NOT KNOW WHERE ELSE TO TURN. WILL CALL CHRYSLER IN DETROIT TOMORROW TO SEE IF I CAN MEET WITH THE FACTORY REP THE NEXT TIME HE IS IN TOWN. HOPE THIS INFO MAY HELP OTHERS. (TIRESIZE: P215/65R15)( DOT NUMBER: TIRE SIZE: P215/65R15 )

• 10/10/2007· AIR BAGS

  TL*THE CONTACT OWNS A 2000 CHRYSLER VOYAGER. WHILE DRIVING 25 MPH, THE FRONT AIR BAGS DEPLOYED WITHOUT WARNING OR AN IMPACT. A POLICE REPORT WAS FILED. THE DRIVER WAS RUSHED TO THE EMERGENCY ROOM BECAUSE HIS EYES WERE BURNING AND HIS VISION WAS LIMITED. THE VEHICLE WAS TOWED TO HIS RESIDENCE. THE CURRENT AND FAILURE MILEAGES WERE 110,000.

• 10/05/2004· AIR BAGS,VEHICLE SPEED CONTROL,ELECTRICAL SYSTEM

  EA 01 007/AIR BAG CLOC SPRING: AFTER ADJUSTING THE STEERING WHEEL, THE HORN AND THE CRUISE CONTROL BECAME INOPERATIVE. DEALER WAS NOT CONTACTED.

• 10/04/2011· STEERING,SUSPENSION,STRUCTURE

  DRIVER'S SIDE UPPER STRUT TOWER SHEET METAL RUSTED THROUGH - PASSENGER SIDE STRUT TOWER, LIKE NEW(NO RUST AT ALL) MANY OTHER LIKE VEHICLE COMPLAINTS FOUND ON INTERNET SEARCH. *TR

• 09/30/2003· SUSPENSION

  BALL JOINTS FACTORY INSTALLED WITH NO GREASE FITTINGS DRIED OUT WITH NO WAY TO LUBRICATE. CAUSING POPPING, KNOCKING NOISE UNDER FRONT END OF PLYMOUTH VOYAGER. THIS WAS FOUND AFTER AN ACCIDENT WHERE THE FRONT END OF VEHICLE WAS OFF IN A DITCH. MECHANIC HAD OVERLOOKED THIS ISSUE EARLIER AND THE JOINT BROKE ON THAT CUSTOMER. THIS WAS NOT THE CAUSE OF MY ACCIDENT BUT MECHANIC HAD SEEN IT BEFORE AND SPOTTED IT IMMEDIATELY. I COULD NOT LOCATE ANYTHING ON THE WEB SITE REGARDING THIS ISSUE. I DO NOT FEEL LIKE I SHOULD HAVE TO PAY FOR THIS REPAIR. CHRYSLER SHOULD KNOW BETTER.

• 09/28/2004· SERVICE BRAKES, HYDRAULIC

  FRONT AND REAR BRAKES ARE WEARING OUT TOO SOON ON MINIVAN. GOT BRAKE WORK DONE ON 10/5/02, 11/5/03, 3/26/04, 8/3/04 AND 9/4/04.*AK *TC

• 09/26/2005· ELECTRICAL SYSTEMFire

  PURCHASED 2000 CHRYSLER VOYAGER MINIVAN FROM DAVID STANLEY DODGE IN MIDWEST CITY, OK. ON SEPTEMBER 22, 2005, THE VEHICLE CAUGHT ON FIRE IN THE INSIDE OF THE VEHICLE, IN THE REAR NEAR THE SPEAKER COMPARTMENT. LUCKILY THE FIRE EXTINGUISHED ITSELF AND NO FURTHER DAMAGE TO THE VEHICLE OTHER THAN THE SPEAKER AND MELTING OF WIRES AROUND SPEAKER. NO INJURIES. INVESTIGATED VEHICLE FIRES ON SIMILAR VEHICLES AND FOUND THE 2001 AND 2002 CHRYSLER/DODGE MINIVANS WERE RECALLED FOR FIRE STEMMING FROM A MANUFACTURING DEFECT WHERE THE ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS. (DIRECTLY FROM RECALL NOTICE) THE RECALL NOTICE WAS NHTSA CAMPAIGN ID NUMBER : 04V531000 OBVIOUSLY WHAT OCCURRED WITH MY VAN IS EXACTLY AS DESCRIBED IN THIS RECALL, THE AIR CONDITIONING UNIT WAS RUNNING AND ALSO THE RADIO WAS TURNED ON HOWEVER MY VEHICLE WAS NOT RECALLED DUE TO THIS DEFECT. WHEN I TOOK THE VEHICLE TO DAVID STANLEY DODGE LOCATED AT 7609 SE 29TH STREET, MIDWEST CITY, OK 73110 (405)737-3700 "NICK" WAS MY SERVICE ADVISOR. ALTHOUGH NICK WAS HELPFUL, THEY CONTACTED CHRYSLER AND DENIED ANY CLAIM OR RESPONSIBILITY AND WOULD NOT EVEN LOOK AT THE VEHICLE TO ENSURE ITS SAFETY! I NOW FEEL UNSAFE DRIVING THIS VEHICLE FOR FURTHER PROBLEMS. THANK YOU FOR YOU TIME IN THIS MATTER! *NM

• 09/25/2001· FUEL SYSTEM, GASOLINE

  THE GAS TANK GIVES OF A THUMPING SOUND WHEN I ACCELERATE FROM A STOP POSITION DO YOU HAVE ANY INFORMATION ON THIS. *AK

• 09/22/2003· POWER TRAIN

  TRANSMISSION HAS FAILED 4 TIMES CAUSING VEHICLE TO LOOSE POWER IN DANGEROUS SITUATIONS. *JB

• 09/22/1999· VISIBILITY

  WHEN LOOKING OUT ON EITHER SIDE OF THE WINDSHIELD THERE IS DISTORTION. THE WINDSHIELD HAS BEEN REPLACED TWICE. DISTORTION IS STILL A PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK

• 09/21/2004· POWER TRAINCrash

  GEARS COULD BE SHIFTED WITHOUT PRESSING THE BRAKE PEDAL. *BF THE GEAR SELECTOR WAS BUMPED WHILE THE VEHICLE WAS PARKED AND THE KEY WAS IN THE IGNITION'S AUXILIARY MODE. AS A RESULT THE VEHICLE ROLLED BACKWARD, HIT THE CONSUMER AND ROLLED OVER HER HIP/THIGH. THE EMERGENCY BRAKE WAS NOT ENGAGED AT THE TIME OF THE ACCIDENT. *NM

• 09/20/2005· SEAT BELTS

  REAR SEAT BELTS DO NOT CATCH (STOP LETTING OUT BELT) WHEN BRAKE APPLIED. THIS IS AN ISSUE CAUGHT AS PART OF A MASSACHUSETTS MANDATORY YEARLY INSPECTION WHICH CAUSE THE VEHICLE TO FAIL. CHRYSLER DEALERSHIP HAS INDICATED IT CAN BE FIXED FOR A CHARGE OF AT LEAST $82. *NM

• 09/15/2003· SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,EQUIPMENT

  PROBLEMS WITH VEHICLE'S BATTERY, MASTER CYLINDER, TENSIONER, AIR CONDITIONER AND SERPENTINE BELT.*MR THE MAIN PROBLEM WAS THE AIR CONDITIONER. ALL THE EXPENSES WERE VERY FRUSTRATING, ESPECIALLY WITH LOW MILEAGE. IN ADDITION, CONSUMER FELT THE EXTENDED WARRANTY FOR 2001, 2002, AND 2003 VOYAGERS WITH AIR CONDITIONER PROBLEMS, SHOULD'VE BEEN EXTENDED TO 2000 VOYAGERS. *PH *JB