2000 Dodge Grand Caravan

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2002· POWER TRAIN

  TRANSMISSION FAILURE OCCURRED AT 58,822 MILES ON THE 2000 DODGE GRAND CARAVAN I OWN. THE PROBLEM WITH MY TRANSMISSION WAS THAT THE SPLINES OF THE FRONT PLANETARY STRIPPED BECAUSE THEY WERE MADE WITH A SOFTER METAL THAN THE UNDERDRIVE CLUTCH HUB. I FEEL THIS IS A DESIGN FLAW THAT DAIMLER CHRYSLER SHOULD ADDRESS. WHEN I CONTACTED DAIMLER CHRYSLER, I WAS TOLD THE PROBLEM WAS MY FAULT, BECAUSE I HAD NOT CHANGED THE TRANSMISSION FLUID AT THE RECOMMENDED SERVICE INTERVAL, AND I WAS 22,000 MILES OUTSIDE OF WARRANTY. HOWEVER, THERE IS NOT A TRANSMISSION FLUID I AM AWARE OF THAT WILL MAKE THOSE SPLINES STRONGER. TS

• 12/30/2003· POWER TRAIN

  WHILE DRIVING THE GEAR SHIFTER SHIFTED INTO NEUTRAL AND AS A RESULT THE VEHICLE WOULD NOT ACCELERATE. THIS ALSO HAPPENED WHILE STOPPED IN TRAFFIC. THE CONSUMER HAS SEVERAL WITNESSES TO THE PROBLEM BUT THE DEALER MECHANIC COULD NOT DUPLICATE OR DETERMINE THE CAUSE OF THE PROBLEM. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM

• 12/30/2002· SERVICE BRAKES, AIRCrash

  MY 7 YEAR-OLD SON WAS KILLED ON 12/21/02 BECAUSE MY 2000 DODGE GRAND CARAVAN WENT INTO GEAR WITH OUT STEPPING ON THE BREAK. THE VAN ROLLED DOWN A DRIVEWAY AND MY SON HAD HIS HEAD OUT THE WINDOW AND HE HIT A TREE AND WAS KILLED. GRANTED I AM PARTIALLY AT FAULT FOR LEAVING CHILDREN UNATTENDED FOR LESS THAN 2 MINUTES BUT THE VAN SHOULD HAVE NEVER BEEN ABLE TO GO OUT OF GEAR WITH OUT STEPPING ON THE BREAK. THIS IS NOT A FAMILY SAFE VEHICLE. I KNOW FOR A FACT I AM NOT THE ONLY PERSON THAT HAS RAN INSIDE BECAUSE THEY FORGOT SOMETHING AND THE CHILDREN WERE LEFT IN THE VEHICLE. I JUST WANT DODGE TO BE MADE TO PUT THE SAFETY DEVICE ON THEIR VEHICLES SO NO OTHER CHILDREN ARE NOT HURT OR KILLED. THE 2003 DODGE NEON ARE ALSO THE SAME WAY. INSERT THE KEY ONLY AND THE CAR WILL SHIFT THRU ALL THE GEARS THANKS JILL

• 12/30/2001· POWER TRAIN

  2 FRIENDS HAVE HAD SAME PROBLEM WITH TRANSMISSION LEAKING FLUID.*AK

• 12/29/2003· SERVICE BRAKES, HYDRAULIC

  DRIVER'S SIDE BRAKE PADS WORE OUT PREMATURELY. VEHICLE WAS TAKEN TO THE DEALER THREE TIMES, WHERE THE MECHANIC REPLACED THE MASTER CYLINDER AND THE PADS. *AK

• 12/29/2003· POWER TRAIN

  TRANSAXLE PIN SLIPPED OUT OF POSITION AND RIPPED TRANSMISSION CASE OPEN. TRANSMISION WAS DESTROYED. FLUID DRAINED OUT IN LOCAL DRIVEWAY. EALERSHIP SAYS WILL COST $3,100 TO $3,400 TO REPLACE TRANSMISION WITH, NOT A NEW ONE, BUT A CHRYSLER REBUILT TRANSMISION.*AK ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ 3 YEARS OLD ... 71,000 MILES ... WHEN TRANNY BUSTED. DEALERSHIP PREFORMED $150.00 POWERFLUSH TO TRANSMISION 1 1/2 YEARS AGO WITH SUPERIOR FLUID THAT WAS AVERT ANY PROBLEMS DUE TO ORIGINAL EQUIPMENT FLUID NOT RECOMENDED BECAUSE OF NOT BEING GOOD ENOUGH. ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ AMY WHITFORD STOPPED VAN IN THE MIDDLE OF THE ROAD WHEN SHE THOUGHT SHE HIT SOMETHING (THE NOISE OF THE TRANSMISION PIN BREAKING THROUGH THE CASE) AND GOT OUT IN TRAFFIC WALKING AROUND VEHICLE WITH 3 YOUNG CHILDREN INSIDE. SHE NOTICED FLUID ON GROUND AND PULLED INTO NEAREST DRIVEWAY, WHERE REMAINDER OF FLUID RAN OUT. ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ I AM OUTRAGE TO FIND THAT THOUSANDS OF THESE EXACT FALURES HAPPEN WITH THESE CHRYSLER AUTOMATIC TRANSMISIONS AND CONTINUE. THE CONSUMER PAYS THE $3,300 PRICE FOR THESE KNOWN DEFECTS AFTER THEY TEAR THE TRANSMISION APART. THESE FAILURES ARE DANGEROUS AND ONLY IGNORED BECAUSE IT WILL COST THE MANUFACTURER INSTEAD OF ME. ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ CHRYSLER HAS MADE A BLUNDER HERE AND WANTS ME TO PAY FOR IT. ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ CAMERON R. WHITFORD ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ WHITFORDCR@BLUEFROG.COM PLEASE EMAIL WITH ANY ASSISTANCE. ~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~~ HOW DO I GET CHRYSLER TO OWN UP TO THIS CUSTOMER NIGHTMARE. I WILL DO ANYTHING!

• 12/28/2007· SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING

  CAR JUST SHUT DOWN ON INTERSTATE WHILE I WAS DRIVING 65 MPH. AFTER BEING TOWED TO AUTO REPAIR SHOP. THE CAR STARTED BACK UP WITH NO PROBLEM FOR AWHILE, NOW THE CAR IS MAKING NOISE. FOR YEARS PRIOR TO THIS THE CAR DOES NOT STOP OCCASIONALLY WHEN BRAKES ARE APPLIED. *TR

• 12/28/2007· ENGINE AND ENGINE COOLING

  THIS HAS HAPPENED 2 TIMES IN THE LAST YEAR. HIT A SMALL PUDDLE OF WATER WHILE MAKING A RIGHT HAND TURN. WATER SPRAYED UP ON THE SERPENTINE BELT WHICH THREW THE BELT OFF OF THE IDLER PULLEY AND TENSIONER PULLEY. BOTH TIMES WE WERE MAKING A RIGHT HAND TURN... WHICH MADE IT VERY DANGEROUS BECAUSE WE LOSS THE POWER STEERING. THE FIRST TIME WAS WITH MY WIFE DRIVING...WHICH WOULD BE VERY HARD TO CONTROL FOR A LADY... THE SECOND TIME I WAS DRIVING, WHICH WAS BETTER... BUT STILL VERY DANGEROUS. I AM PLANNING ON PURCHASING THE GOODYEAR REPLACEMENT KIT THAT HAS BEEN MENTIONED ON SEVERAL WEBSITES AND THIS WEBSITE. DAIMLERCHRYSLER SHOULD BE RECALLING ALL THESE VANS AND REPLACING ALL THE PULLEYS WITH THESE SAFER KITS. *TR

• 12/28/2004· ENGINE AND ENGINE COOLING

  THE CROSSOVER PIPE HAS HOLES IN IT AND NEEDS REPLACING. I WAS TOLD BY MY MECHANIC THAT FUMES CAN GET INTO THE CAR AND ALSO THAT IF IT FAILS MUCH MORE, THE WIRES UNDER THE HOOD CAN BE BURNED. ALL THE DEALER WAS WILLING TO DO WAS REPLACE THE PIPE. THE PROBLEM WITH THAT IS SINCE SEPTEMBER 2004, THE PIPE IS BACK ORDERED. *JB

• 12/27/2004· SUSPENSION,ELECTRICAL SYSTEM,VISIBILITY,LATCHES/LOCKS/LINKAGES,EQUIPMENT

  I HAVE TAKEN MY 2000 DODGE DURANGO TO FOREST LAKE DODGE DEALER FOR A CLUNKING NOISE IN MY FRONT END OVER YEAR AGO. I HAD A NUMBER OF COMPLAINTS. THEY SAID AT THAT TIME THERE WAS NOTHING WRONG. THEY COULDN'T HEAR ANYTHING. AGAIN WITHIN A COUPLE MONTHS I RETURNED WITH THE SAME PROBLEM ALONG WITH MY PASSENGER WINDOW NOT GOING UP OR DOWN CORRECTLY. ONCE AGAIN THEY SAID OH YOU NEED SHOCKS AND YOU NEED YOUR SERVICE OF WARRENTY PROFORMED OR YOUR WARRENTLY WONT BE ANY GOOD, SO I SAID YES DO WHAT IS UNDER WARRENTY NOTHING ELSE UNLESS I SAY IT OK, WILL MORE WORK WAS PROFORMED AND I ENDED UP PAYING HUNDRED PLUS DOLLARS OUT OF POCKET. AGAIN THEY SAID THERE WAS NO CLUCKING NOISE NOTED AND THAT THE PASSENGER WINDOW ACCORDING TO THE COMPUTER SAID IT FUNCTIONS CORRECTLY. WILL TO THIS DAY OVER A YEAR LATER, THE CLUCK IS THERE AND SHOCKS AND OTHER MAINTENCE WAS COMPLETED, THE PASSENGER WINDOW MOVES SO SLOW THAT WE DONT USE IT AS IT HAS AND STILL DOES QUIT WORKING. INSIDE WHERE THE 4 WHEEL DRIVE COMPOTENT ALSO COMES LOOSE FROM THE MAIN FLOOR. I WAS TOLD THAT I WOULD HAVE TO PURCHASE A NEW MANTO WHICH SCREWS TO THE FRAME OF THE DURANGO. I HAD SIDE STEPS PUT ON AFTER PURCHASE BY CHRY. DODGE IN FORREST LAKE AND DRIVERS SIDE WITHIN IN ONE AND HALF YEARS FELL LOOSE AND THEY SAID I JUST NEEDED TO HAVE SOMEONE PUT IN NEW SCREWS THAT IT WASN;T COVERED. YET WHEN I PURCHASED THEM THEY SAID THAT IF THEY DID IT, ANYTHING THAT MAY HAPPEN WOULD BE COVERED BUT IF SOMEONE ELSE DID IT THEY WOULDNT COVER ANYTHING THAT HAPPENED.*AK

• 12/27/2003· ENGINE AND ENGINE COOLING

  SERPENTINE BELT KEEPS SLIPPING OFF THE MAIN DRIVE.. HAVE HAD INTO THE SHOP 4TIMES FOR SAME PROBLEM. DEALER SAID IT IS A MOISTURE/SNOW HITTING THE BELT OFF.*AK

• 12/27/2002· POWER TRAIN

  THE AUTOMATIC TRANSMISSION PAN WAS LEAKING. CONSUMER HAD VEHICLE CHECKED BY A MECHANIC, WHO INDICATED THAT THIS WAS A RESULT OF THE TRANSMISSION PAN BEING MADE WITH SILICONE. THE MECHANIC ALSO STATED THAT THIS IS A COMMON PROBLEM WITH THESE MAKE/MODEL VEHICLE. PLEASE PROVIDE MORE DETAILS.

• 12/27/2000· STEERING

  THERE IS A POPPING NOISE IN THE STEERING COLUMN, VEHICLE HAS BEEN TO DEALER THREE TIMES FOR THIS PROBLEM. NLM

• 12/23/2002· AIR BAGS

  CONSUMER WAS INVOLVED IN AN ACCIDENT IN WHICH THE AIR BAGS FAILED TO DEPLOY. *JB

• 12/22/2004· ENGINE AND ENGINE COOLING

  I PRESSED THE ACCELERATOR TO PASS SOMEONE AND THE CAR DIDN'T SOUND QUITE RIGHT AFTERWARDS. IT WAS DUE TO HAVE THE OIL CHANGED AND DID SO REGULARLY FROM THE BEGINNING OF THE CAR WHEN I BOUGHT IT BRAND NEW IN 2000. THE TECHNICIAN SAID THAT WHEN HE CHANGED THE OIL THERE WAS SLUDGE BUILD UP. SO I PUT A OIL TREATMENT IN TO SEE IF IT WOULD HELP. I RAN MY CAR FOR LESS THAN A WEEK AFTER THAT AND AS I WAS DRIVING TO INTO WORK MY CAR STARTING KNOCKING VERY LOUD. RIGHT NOW I AM LOOKING AT A POSSIBLE $500 TO $4800 FIX. MY CAR HAS ALMOST 100,000 MILES ON IT AND ALMOST PAID OFF. MY ENGINE IS THE 2.7 DODGE INTREPID. AS I FOUND OUT THAT MY ENGINE ONE OF THE WORST ON THE MARKET. THERE AREN'T VERY MANY OF THE ENGINES LEFT IN THE JUNK YARDS EVEN. MY MECHANIC SAID HE IS PUTTING IN THE SECOND ENGINE IN A COUPLES CAR FROM LAST YEAR. THE 2.7 IS JUNK. *JB

• 12/22/2003· POWER TRAIN

  TRANSMISSION FLUID LEAKING FROM TRANSMISSION PAN SEAL AT 24000 MILES.*AK

• 12/21/2004· ENGINE AND ENGINE COOLING

  THE CROSS OVER PIPE/EXHAUST MANIFOLD FAILED UPON TURNING THE HEAT ON. SOME VERY HEAVY EXHAUST FUMES FILLED THE VEHICLE WHEN DRIVING. CONSUMER CONTACTED THE DEALER, BUT PROBLEM RECURRED. *AK EXHAUST FILLS THE VEHICLE WHEN THE HEAT OR AIR IS TURNED ON USUALLY WHEN VEHICLE IS AT A STAND STILL. *TC

• 12/20/2012· STEERING,SUSPENSION,STRUCTURE

  STRUT TOWERS ROTTED OUT AT 90000 MILES, REPLACEMENT CAPS WERE PURCHASED FROM DODGE DEALER AND INSTALLED AS PER FACTORY TSB .... STRUT TOWERS ARE ROTTED BELOW REPAIR CAPS AGAIN.... APPROX. 150000 MILES NOW ON VAN, STRUTS ARE ALSO IN NEED OF REPLACEMENT HOWEVER THIS CAN NOT BE DONE DUE TO SEVERITY OF RUST DAMAGE....THIS IS OBVIOUSLY A FACTORY DEFECT... RESULTING IN AN UNSAFE CONDITION... CHRYSLER IS WELL AWARE OF THIS ISSUE AND SHOULD BE HELD RESPONSIBLE ... THIS IS A SERIOUS SAFETY ISSUE AFFECTING TENS OF THOUSANDS OF VEHICLES...NOT JUST A FEW HERE OR THERE - THE QUESTION SHOULD BE HOW MANY ARE NOT AFFECTED??? I'M ACTUALLY CONSIDERING SEARCHING FOR A LAWYER TO START A CLASS ACTION LAWSUIT AGAINST CHRYSLER ...SOMETHING NEEDS TO BE DONE! *TR

• 12/19/2005· STRUCTURE

  I HAD AN OIL CHANGE DONE AT A CHRYSLER DEALER THE SERVICE ADVISOR NOTED ON THE REPAIR ORDER AND TOLD MY WIFE THAT THE FRONT STRUT TOWERS WERE RUSTING OUT AND THAT THE STRUT COULD BREAK THOUGH THE TOWER CAUSING A LOSS OF CONTROL OF THE VAN. *JB

• 12/18/2017· SUSPENSIONCrash

  STRUT TOWERS ON MY 2000 DODGE GRAND CARAVAN HAVE RUSTED THROUGH. VISIBLE, SIGNIFICANT RUST HAS BEEN PRESENT FOR AT LEAST 7 YEARS, HOWEVER, IT IS NOW NOT DRIVEABLE. I DID NOT REALIZE THIS IS SUCH A BROADSCALE, SIGNIFICANT PROBLEM TO MOST OWNERS OF 1996-2000 VANS. PLEASE RECALL THIS MESS! STRUT TOWERS ARE NOT COSMETIC!

• 12/18/2010· STRUCTURE

  I PURCHASED A USED 2000 DODGE GRAND CARAVAN IN 2005. AT TIME OF PURCHASE THE LEFT FRONT STRUT TOWER HAD NO VISIBLE SIGNS OF DECAY. AS TIME WENT ON, THE STRUT TOWER HAS BEGAN TO RUST COMPLETELY THROUGH WHILE THE RIGHT TOWER IS PERFECTLY FINE. I HAVE FOUND THIS IS A COMMON PROBLEM WITH DODGE CARAVANS OF THIS MODEL YEAR AND IF THE TOWER FAILS, THE STRUT CAN PUNCH THROUGH CAUSING CATASTROPHIC LOSS OF CONTROL. I HAVE A FAMILY OF 5 AND I AM VERY CONCERNED FOR THEIR WELL-BEING. THERE IS NOTHING WRONG THIS VEHICLE OTHER THAN THE DESCRIBED ISSUE I HAVE MENTIONED HERE. FOR ME PERSONALLY, THIS A HUGE LAWSUIT IN THE MAKING, ESPECIALLY IF ANY MEMBER OF MY FAMILY IS ENDANGERED. I AM THE SECOND OWNER OF THIS VEHICLE. REGARDLESS, IF SOMETHING HAPPENS TO ANY MEMBER OF MY FAMILY DUE TO THIS KNOWN DEFECT WHICH I JUST FOUND OUT ABOUT, I CAN GUARANTEE YOU WITH 100% PERCENT CERTAINTY THAT I WILL FIGHT THIS IN COURT. I WOULD LIKE TO BE CONTACTED REGARDING THIS ISSUE AS SOON AS POSSIBLE. I AM VERY CONCERNED OVER THIS, AND MY DECISION TO TAKE LEGAL ACTION AND WHETHER OR NOT I EVER PURCHASE ANOTHER DODGE PRODUCT AGAIN HINGES ON ANY ASSISTANCE THAT I MAY OR MAY NOT RECEIVE. I WILL PROVIDE VIN # AND ANY OTHER INFORMATION NEEDED ONCE I AM CONTACTED. *TR

• 12/16/2004· POWER TRAIN

  TRANSMISSION FAILURE AT 42,000 MILES. PROBLEMS WITH TRANSMISSION SHUDDER, TSB 18-05-94. I HAD BROUGHT THE TRANSMISSION SHUDDER TO THE DEALERS ATTENTION STARTING AT AROUND 32,000 MILES. DEALER SAID THEY COULD NOT FIND ANYTHING WRONG. THEY RE-FLASHED THE COMPUTER, ETC. VAN WAS BROUGHT BACK TO DEALER TWICE BEFORE 36,000 MILE WARRANTY EXPIRED. BROUGHT THE VAN BACK AT 37,000 MILES TO COMPLAIN AGAIN AND DEALER PROCEEDED TO TELL US THAT THEY HAVE NO RECORDS OF ANY PRIOR COMPLAINT REGARDING THE TRANSMISSION, THEREFORE THEY WOULD HAVE TO CHARGE US TO RE-FLASH THE TRANSMISSION. (I WILL NEVER LOSE OR THROW AWAY ANY WARRANTY RELATED RECEIPTS AGAIN). AFTER GOING BACK AND FORTH AND GETTING NOWHERE WE PAID THE RE-FLASH FEE AND ONCE AGAIN THE THEY TOLD US THERE WAS NOTHING WRONG. THEN AT ABOUT 42,000 MILES THE TRANSMISSION BLEW. THIS AFTER THE DEALER TOLD US ON A MINIMUM OF 4 OCCASIONS THE TRANSMISSION WAS FINE. AFTER SOME "POLITE" NEGOTIATION I GOT THE DEALER TO COVER HALF OF THE $1300.00 REPAIR COST TO REPLACE THE TRANSMISSION PUMP. OF COURSE THEY DIDN'T COVER THE FLATBED & RENTAL CAR EXPENSES. I HAVE NEVER OWNED A CAR THAT I HAVE HAD TO REPAIR OR REPLACE A TRANSMISSION AND I HAD DRIVEN MOST OF THEM WELL OVER 100,000 MILES. I DO NOT UNDERSTAND HOW CHRYSLER CAN GET AWAY WITH THIS. WITH ALL OF THE DISGRUNTLED CHRYSLER CUSTOMERS ON THE INTERNET I CAN'T BELEIVE THE NHTSA ISN'T INVESTIGATING THEIR TRANSMISSIONS. WHO IS PAYING OFF WHO?*AK

• 12/16/2001· SUSPENSION

  FIRST NOTICED BUMPING NOISE UNDER FRONT END WHEN I WAS MAKING A RIGHT TURN AND GOING OVER A DIP OR BUMP IN THE ROAD. EVENTUALLY, THE NOISE HAPPENED TURNING LEFT OR RIGHT OR GOING OVER ANY BUMPS OR DIPS IN THE ROAD (EX. RAILROAD TRACKS, SPEED BUMPS ) THE FRONT END OF VAN SOUNDED LIKE IT WAS ACTUALLY HITTING THE PAVEMENT. THE DEALERSHIP REPLACED THE SWAY BAR BUSHINGS THE FIRST FIVE TIMES, THEN THE SIXTH TIME WE TOOK IT IN, THEY REPLACED THE STRUTS AND THE SWAY BAR LINK AS WELL. THAT WAS JULY 2001. AS OF 2 WEEKS AGO (DEC. 2001) THE BUMPING NOISE UNDER THE VAN HAS STARTED AGAIN.

• 12/14/2004· VISIBILITY,LATCHES/LOCKS/LINKAGES

  WINDING SOUND WHEN YOU LOCK OR UNLOCK THE DOORS. DRIVERS DOOR WON'T LOCK, PASSENGER FRONT DOOR DOSN'T UNLOCK, PASSENGER LEFT-REAR ALSO DOSN'T UNLOCK , PASSENGER RIGHT-REAR IS THE ONLY ONE THAT WORKS WITH THE KEY LESS ENTRY.*AK ALSO BOTH REAR WINDOWS DO NOT WORK. I MYSELF INSPECTED THE OPERATION OF THE LEFT REAR DOOR AND FOUND THAT THE ACTUATOR WAS BAD. I CRACKED OPEN ACTUATOR AND FOUND THAT THE GEAR WAS STRIPPED. THIS CAUSING THE WINDING SOUND AND FAILURE TO LOCK OR UNLOCK THE DOORS. THE GEAR IS MADE OF SOME KIND OF SOFT PLASTIC MATERIAL FOR THIS TO HAPPEN. ABOUT THE REAR WINDOW, I CHECKED AND FOUND POWER GOING TO THE MOTORS. BUT WITH ONE OF THE WINDOW MOTORS I TAPPED IT AND GOT IT TO WORK FOR ACOUPLE OF DAYS. WITH MY EXPERINCE AS AN AUTO/TRUCK/BUS TECHNICIAN THE MOTORS ARE DEFECTED ALONG WITH THE DOOR ACTUATORS. I HOPE THESE ISSUES CAN GET RESOLVED, BECAUSE OVERALL MY VEHICLE IS GOOD AT 60,000 MILES.

• 12/14/2002· POWER TRAIN

  I HAVE A CHECK ENGINE LIGHT ON MY DASH BOARD. I TOOK THE CAR INTO THE DEALERSHIP AND THEY RAN A DIAGNOSTIC TEST ON THE CAR AND IT INDICATE THAT THE " DIAGNOSTIC TEST DTL FOR THE TORQUE CONVERTOR CLUTCH CIRCUIT FAILURE INTFRMAL, RECOMMEND O/H TRANSMISSION." I WAS ADVISED OF THE PROBLEM. MY ISSUE IS THAT THE CAR IS A 2000 MODEL AND HAS 44,500 MILES ON IT AND THE CAR HAS A TRANSMISSION PROBLEM ALREADY. THERE IS NO NOISE OR FEELING OF THE ACCELERATION OR CHANGE OF GEAR PROBLEMS. WHY HAVE TRANSMISSION PROBLEMS THIS EARLY IN THE CAR LIFE.

• 12/12/2007· ENGINE AND ENGINE COOLING

  TL*THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING 70 MPH, THE CONTACT EXPERIENCED A LOSS OF STEERING AND THE INSTRUMENT PANEL LIGHTS ILLUMINATED. HE LOOKED UNDER THE HOOD AND DISCOVERED THAT THE SERPENTINE BELT WAS DETACHED. THE CONTACT RE-ATTACHED THE SERPENTINE BELT. THE DEALER WAS NOTIFIED. THE CURRENT MILEAGE WAS 96,000 AND FAILURE MILEAGE WAS 95,000.

• 12/12/2004· SERVICE BRAKES, HYDRAULIC

  FRONT DISC BRAKE CALIBER, PISTON IS MADE OF A COMPOSITE AND NOT METAL,COMPOSITE CRACKS AND LEAKS. THE PISTON TURNS TO MUSH AND THE BRAKE PAD BECOMES LOOSE. *JB THIS CAUSE THE VEHICLE TO PULSE WHEN APPLYING THE BRAKES. WAS BROUGHT BACK TO DEALER AND FINALLY REPLACED UNDER WARRANTY. TWO YEARS LATER THE SAME THING HAS HAPPENED, BUT THE VEHICLE IS NOT UNDER WARRANTY ANY MORE. 04/23/02 WAS THE FIRST TIME, 12/04/04 FOUND THE SAME PROBLEM AGAIN

• 12/11/2004· SUSPENSION,POWER TRAIN

  MAKE : DODGE MODEL : GRAND CARAVAN YEAR : 2000 MANUFACTURER : DAIMLERCHRYSLER CORPORATION CRASH : NO FIRE : NO NUMBER OF INJURIES: 0 ODI ID NUMBER : 10100418 DATE OF FAILURE: NOVEMBER 20, 2004. *JB VIN : NOT AVAILABLE COMPONENT: CV JOINT.AXLE PROBLEM SUMMARY: I TOOK MY 2000 DODGE GRAND CARAVAN IN ON A FRIDAY TO THE DEALER FOR THE AIR BAG RECALL (CLOCKSPRING- WHICH BY THE WAY THE AIRBAG REALLY STAYS ON NOW, WHERE IT DID NOT BEFORE THE DEALER REPLACED/REPAIRED THE CLOCKSPRING) AND PLUS THE DEALER CALLED ME TO TELL ME THAT HAD FOUND A LEAK IN THE MASTER CYLINDER WHICH THEY WANTED TO FIX. I SAID YES (NOW I SEE THERE ARE SEVERAL COMPLAINTS ABOUT MASTER CYLINDER LEAKS) I PICKED UP MY VAN UP ON FRIDAY EVENING AFTER WORK. SATURDAY MORNING I RAN A COUPLE OF ERRANDS AROUND TOWN AND AT 12:30 P.M. BEGAN TO BACK OUT OF A PARKING SPOT AND HEARD A LOUD NOISE. I PROCEEDED OUT OF THE PARKING STRUCTURE AND ONLY MADE IT AS FAR AS THE STREET BEFORE COMING TO A COMPLETE STOP. I CALLED FOR A TOW. THE TOW TRUCK DRIVER SAID THAT MY WHEEL ON THE FRONT DRIVER'S SIDE DID NOT APPEAR TO BE COMPLETELY ATTACHED TO THE AXLE. HE TOWED IT TO THE DEALER. THE SERVICE DEPARTMENT ON MONDAY INFORMED ME THAT MY CV JOINT/AXLE HAD BROKEN. A BROKEN AXLE ON A 2000 THAT HAS 18,222 MILES ON IT. HOW DOES THIS HAPPEN UNDER NORMAL DRIVING CONDITIONS? MY KIDS AND I WERE LUCKY THAT I WAS NOT GOING FAST OR DRIVING DOWN A FREEWAY. NOW I SEE ON THE NEWS THIS MORNING THAT THERE IS A RECALL FOR DAKOTA TRUCKS AND DURANGOS, BUT NOT CARAVANS. WHAT'S UP WITH THAT? *JB

• 12/11/2004· SUSPENSION

  THE FRONT BALL JOINT IS MAKING NOISES AND BLACK LOOKING SOOT ON TIRE RIMS. *JB

• 12/09/2002· POWER TRAIN

  CONSUMER STATED THAT WHILE DRIVING TRANSMISSION FAILED CAUSING VEHICLE TO STALL. DEALER DIAGNOSED AND REPLACED TRANSMISSION "LINE", "CONVERTER" AND "SOLENOID". PH

• 12/08/2014· AIR BAGS,EQUIPMENT ADAPTIVE/MOBILITY

  TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE HORN FAILED TO OPERATE AND THE AIRBAG LIGHT ILLUMINATED SPORADICALLY. ALSO, THE CRUISE CONTROL FEATURE WAS DISABLED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 162,721.

• 12/07/2012· STEERING,ENGINE

  THE SERPENTINE BELT ON MY 2000 DODGE GRAND CARAVAN COMES OFF EVERYTIME THAT IT RAINS. I LOSE POWER STEERING WHICH MAKES IT NEARLY IMPOSSIBLE TO DRIVE AND THE TEMP GAUGE JUMPS ALL THE WAY UP. *TR

• 12/07/2010· EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. THE CONTACT WAS REVERSING LESS THAN 5 MPH INTO A RESIDENTIAL DRIVEWAY WHEN THE CONTACT NOTICED THAT THE TAILLIGHTS WERE NOT ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE IT WAS DIAGNOSED THAT THE BACK UP SWITCH HAD FAILED. THE MECHANIC ADVISED THAT THE SWITCH WAS LOCATED WITHIN THE TRANSMISSION AND THE ENTIRE TRANSMISSION WOULD NEED TO BE REMOVED TO PERFORM THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 129.989. UPDATED 02/01/11*LJ THE CONSUMER STATED CHRYSLER PAID FOR 1/2 OF THE REPAIRS. UPDATED 03/23/11

• 12/07/2004· AIR BAGS

  AIR BAG LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE RECALL WAS NOT FOR THIS VEHICLE. *AK *TC

• 12/07/2000· FUEL SYSTEM, GASOLINECrash

  VEHICLE WENT OVER SOME ROAD DEBRIS AND FILLER TUBE GOT KNOCKED OFF. IT WAS EXPOSED UNDER VEHICLE & COULD BREAK LOOSE, OR IF SPARKED IGNITED. DEALER VERY UNCONCERN CONSUMER. ALTHOUGH WARRANTY WAS GOOD ON VEHICLE CONSUMER HAD TO PAY $818 FOR A NEW FUEL TANK. DEALER SAID CONSUMER WAS RESPONSIBLE FOR ROAD HAZARD. *AK

• 12/04/2001· ENGINE AND ENGINE COOLING

  ENGINE DIES IN RIGHT HAND TURNS OF 2 DEGREES OR MORE WITH OR WITHOUT CRUISE ENGAGED. *AK

• 12/04/2001· SEAT BELTS

  DRIVER'S AND PASSENGER'S FRONT SEAT RESTRAINTS WILL SOMETIMES LOCK OR MAY STAY UNLOCKED. A FEW TIMES CONSUMER HAD TO CRAWL OUT OF SEAT BELT BECAUSE IT WOULDN'T UNLOCK. DEALER WILL HAVE TO REPLACE LOCK OR LATCH MECHANISM. OCNSUMER IS BEING CHARGED FOR PART AND LABOR.*AK

• 12/02/2019· STEERING

  TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING 35 MPH, THE CONTACT HEARD AN ABNORMAL NOISE AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. IN ADDITION, THE BATTERY AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO PARK THE VEHICLE IN A NEARBY PARKING LOT. WHEN THE IGNITION WAS STARTED, THE TEMPERATURE GAUGE INCREASED. THE CONTACT TURNED OFF THE IGNITION AND ALLOWED THE VEHICLE TO COOL DOWN FOR AWHILE. AFTERWARDS, THE VEHICLE WAS RESTARTED AND THE CONTACT CONTINUED DRIVING 15 MPH TO HIS RESIDENCE. THE CONTACT NOTICED THAT THE STEERING WHEEL BELT WAS LOOSE. THE CONTACT CALLED LITHIA CHRYSLER JEEP OF RENO (LOCATED AT 1050 E PLUMB LN #100, RENO, NV 89502, (775) 501-8593) AND INFORMED THEM OF THE FAILURE. THE CONTACT SCHEDULED AN APPOINTMENT WITH AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 147,000.

• 12/01/2010· STEERING,ENGINE AND ENGINE COOLING,UNKNOWN OR OTHER

  WHILE DRIVING ON A WET ROAD THE SERPENTINE BELT FLEW OFF THE PULLEYS. THIS MADE THE POWER STEERING PUMP, ALTERNATOR, WATER PUMP AND THE AIR CONDITIONING SYSTEM TO ALL BECOME UNABLE TO WORK IN AN IMMEDIATE FASHION. THIS PROBLEM APPEARS TO HAPPEN OFTEN; MEANING SEVERAL TIMES A YEAR TO MANY CARAVAN OWNERS. MY MECHANIC SAID HIS BEST ADVICE WAS TO NOT DRIVE IN WET OR SNOWY CONDITIONS. THIS IS A MANUFACTURERS DEFECT THAT CHRYSLER SHOULD MAKE RIGHT BY INSTALLING A BELT GUARD TO HOLD THE BELT IN PLACE.

• 12/01/2004· ENGINE AND ENGINE COOLING

  SERPENTINE BELT CAME OFF EVERY TIME CONSUMER HIT A PUDDLE. THE BELT CAME OFF FOUR TIMES, AND WAS BEING SERVICED AGAIN.*AK

• 11/28/2018· ENGINE AND ENGINE COOLING

  TL* THE CONTACT OWNS A 2000 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 50 MPH WITH A FULL TANK OF FUEL, THE FUEL GAUGE DISPLAYED AS EMPTY. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND DEPRESSED THE RESET BUTTON SINCE THE VEHICLE HAD JUST BEEN FUELED. THE VEHICLE WAS RESTARTED AND OPERATED NORMALLY, BUT THE FAILURE RECURRED APPROXIMATELY EIGHT OTHER TIMES IN A FOUR MONTH PERIOD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE RADIATOR NEEDED REPLACEMENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

• 11/28/2006· VEHICLE SPEED CONTROL

  DT*: THE CONTACT STATED WHILE DRIVING 55 MPH UNDER NORMAL ROAD CONDITIONS, THE VEHICLE SUDDENLY ACCELERATED TO 95 MPH. AFTER BEING TAKEN TO THE SERVICE DEALER, IT WAS DETERMINED THAT THE CRUISE CONTROL CABLE BENT, AND CAUSED THE SUDDEN ACCELERATION. THE CONSUMER TRIED USING THE BRAKES WITH NO SUCCESS, THE CONSUMER FINALLY TURNED THE IGNITION OFF AND WAS ABLE TO COAST TO THE EMERGENCY LANE. THE CONSUMER USED THE EMERGENCY BRAKE TO STOP THE VEHICLE AND SHIFTING THE TRANSMISSIONS IN TO LOW. UPDATED 12/28/06. *JB

• 11/28/2006· ENGINE AND ENGINE COOLING

  SERPENTINE BELT SLIPS OFF TENSIONER PULLEY IN WET CONDITIONS. TOTAL POWER STEERING FAILURE AND VEHICLE IS EXTREMELY DIFFICULT TO CONTROL. *NM

• 11/28/2005· SUSPENSION

  I BROUGHT MY 2000 GRAND CARAVAN IN FOR ROUTINE OIL CHANGE. SERVICE MGR. I WAS INFORMED THAT MY LEFT STRUT TOWER/STRUT SEATING WAS BEGINNING TO RUST AND THAT IT WOULD COST OVER $700 TO REPAIR. STATED IT SHOULD BE REPAIRED SOON OR COULD CAUSE SERIOUS ACCIDENT IF IT FAILS. THE RIGHT ONE IS PERFECTLY FINE. I PROCEEDED TO DO RESEARCH ON THE INTERNET AND HAVE FOUND OUT THAT THIS IS A VERY COMMON "FAILURE". WHY HAS THIS NOT BEEN ADDRESSED OTHER THAN TSB 2304402? ISN'T THIS A SAFETY ISSUE AND SHOULDN'T THERE BE A RECALL? WHAT RECOURSE DO I HAVE BEFORE I SPEND THIS MONEY THAT I DON'T FEEL IS MY FAULT OR CAUSE? *JB

• 11/27/2006· STRUCTURE

  WATER LEAKS ONTO THE PASSENGER SIDE FLOOR FROM THE HVAC DURING AC USE AND IN HEAVY RAIN. *NM

• 11/27/2001· VEHICLE SPEED CONTROLCrash

  UPON STARTING IGNITION VEHICLE ACCELLARATED INTO REVERSE, CAUSING AN ACCIDENT. PLEASE PROVIDE VEHICLE IDENTIFICATION NUMBER AND ALSO ANY FURTHER INFORMATION.*AK

• 11/27/2000· TIRES

  REPORTING A PROBLEM WITH TIRES CAUSING A 2000 DODGE, GRAND CARAVAN TO SLIP WHILE DRIVING ON WET CONDITION ROAD. GOODYEAR NOTIFIED, AND WOULD REPLACE TIRES WITH SAME BRAND. SEEKING HELP FROM NHTSA IN THIS MATTERS. *AK GOODYEAR CONQUEST TIRE (P215 65 R15) DOT # M6VFAKDR1500. *SLC

• 11/26/2004· ENGINE AND ENGINE COOLING

  CONSUMER STATED EVERYTIME IT RAINED THE OIL SENSOR LIGHT CAME ON AND STAYED ON. DEALER STATED THEY COULD NOT DUPLICATE THE PROBLEM. *AK

• 11/26/2001· ENGINE AND ENGINE COOLINGFire

  WHILE DRIVING, VEHICLE LOST POWER AND ENGINE CAUGHT ON FIRE, CLAIM 46-0158-766. *SLC

• 11/25/2008· SUSPENSION,STRUCTURE

  I OWN A 2000 DODGE GRAND CARAVAN THAT I PURCHASED NEW IN 2000, I RECENTLY HAD NEW STRUTS INSTALLED ON THE FRONT AND WAS TOLD THAT THE LEFT FRONT STRUT TOWER WAS SEVERELY RUSTED AND SHOULD BE FIXED AS SOON AS POSSIBLE. I WAS ALSO TOLD THAT THIS WAS A SERIOUS SAFETY ISSUE THAT CHRYSLER WAS AWARE OF,I DID SOME RESEARCH AND FOUND THAT THIS IS A COMMON PROBLEM WITH 1996 TO 2000 CHRYSLER MINI-VANS DUE TO A DESIGN DEFECT. *TR