2000 Chevrolet Malibu

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2008· EXTERIOR LIGHTING

  TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE TURN SIGNALS IN THE VEHICLE WORKED INTERMITTENLY. WHILE MAKING A TURN AT ANY SPEED, THE FLASHING SIGNALS USUALLY FAIL TO WORK WHEN THE TURN SIGNAL LEVER IS ACTIVATED. THE FAILURE OCCURRED FOR AN ENTIRE DAY. THE VEHICLE HAS NOT YET BEEN INSPECTED BY ANY MECHANICS OR DEALERS. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V327000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH). THE CONTACT BELIEVES THAT A RECALL SHOULD BE ISSUED BECAUSE THE FAILURES ARE IDENTICAL. THE CURRENT AND FAILURE MILEAGES WERE 109,669. UPDATED 03/05/09 *CN UPDATED 03/10/09. *JB

• 12/31/2001· ENGINE AND ENGINE COOLING

  VEHICLE STALLED WHILE DRIVING 60-70 MPH, THEN AGAIN 3 DAYS LATER. VEHICLE TAKEN TO DEALER BOTH TIMES, COULD NOT FIND CAUSE.

• 12/30/2019· FUEL/PROPULSION SYSTEM

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT SMELLED FUEL WHEN THE VEHICLE WAS PARKED IN THE GARAGE. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 137,000.

• 12/30/2014· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY RELEASED FROM THE IGNITION INDEPENDENTLY. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TOWED TO THE DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) BUT THE PART NEEDED FOR THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT FELT THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE FAILURE MILEAGE WAS 156,000.

• 12/29/2014· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY FAILED TO TURN IN ORDER TO SHUT OFF THE VEHICLE. THE CONTACT MENTIONED THAT THE KEY WAS STUCK IN THE ACCESSORY POSITION. APPROXIMATELY TWENTY MINUTES LATER, THE KEY WAS ABLE TO TURN IN ORDER TO SHUT OFF THE VEHICLE. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM), BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 101,514.

• 12/29/2009· EXTERIOR LIGHTING

  I OWN A 2000 CHEVY MALIBU AND I OWNED IT SINCE 2007 JULY...SINCE THEN I HAVE HAD PROBLEMS WITH MY HAZARD LIGHTS AND SIGNAL LIGHTS...WHEN I WOULD BE DRIVING MY CAR I WOULD USE MY SIGNAL TO TURN LEFT OR RIGHT AND IT WOULD MAKE A CRACKLE SOUND AND STOP WORKING COMPLETLEY I WOULD THEN TRY TO USE MY HAZARD THEY WOULD DO THE SAME THING MAKE A CRACKLE SOUND AND NOT WORK..ALSO WITH MY HEADLIGHTS MY PROBLEM WITH THEM IS THEY WORK WHEN THEY WANT TO AND WHEN THEY DO WORK THEY STAY ON EVEN WHEN MY CAR IS COMPLETELY OFF AM TALKING KEYS OUT OF THE ENGINE AND EVERYTHING I WOULD HAVE TO POP MY HOOD AND MOVE AROUND THE FUSES TILL THE CAR LIGHTS FINALLY TURN OFF..I HAVE TAKEN MY CAR INTO THE DEALERSHIP WERE I BOUGHT MY CAR AND ALL THEY DID WAS GIVE ME A HARDTIME TOLD ME THERE WAS NOTHING WRONG WITH MY CAR AND THAT MY VIN# IS NOT ON THE RECALL LIST...BUT THERE IS A RECALL ON 2000 CHEVY MALIBU ABOUT THERE HAZARDLIGHTS SIGNAL LIGHTS AND HEADLIGHTS NOT ONLY THAT THE NHTSA DOSE NOT SAY ANYTHING ABOUT SPECIFIC VIN# FOR THE RECALLS IT JUS SAYS THAT THIS IS RECALLS ON 2000 CHEVY MALIBU. *TR

• 12/29/2003· SERVICE BRAKES, HYDRAULIC,EQUIPMENT

  FRONT BRAKES (ROTORS) REPLACE AT 22,000MILES THE BRAKE PADS OUT LASTED THE ROTORS - THAT CAN'T HAPPEN ??? IT SEEMS THEY(GM) HAVE SOME TYPE OF DESIGN PROBLEM. *AK

• 12/28/2010· EXTERIOR LIGHTING,VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT WAS DRIVING APPROXIMATELY 30 WHEN MPH SHE ENGAGED THE LEFT SIGNAL AND THE VEHICLE BEGAN TO EXHIBIT AN ABNORMAL NOISE. THE TURN SIGNAL WOULD NOT ACTIVATE. IN ADDITION, THE CONTACT STATED THAT THE HAZARD LIGHTS HAD ALSO FAILED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP, YET THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 03V327000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH) . SHE CONTACTED THE MANUFACTURER WHO ADVISED HER THAT HER VEHICLE WAS NOT INCLUDED IN THE RECALL. ALSO, THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, THE VEHICLE WOULD BECOME SLOW TO RESPOND TO THE CONTACT'S ATTEMPTS TO ACCELERATE. THE VEHICLE WAS TAKEN BACK TO THE SAME LOCAL MECHANIC WHERE THEY WERE UNABLE TO DUPLICATE THE ACCELERATION FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 84,649.

• 12/28/2009· ELECTRICAL SYSTEM

  "PASSLOCK SYSTEM" 2000 CHEVROLET MALIBU WILL NOT LET CAR START, AND SOMETIMES CAUSES ENGINE TO GO DEAD WHILE DRIVING, WHICH LEAVES DRIVER UNABLE TO STEER CAR (POWER STEERING). PASSLOCK SENSOR WAS CHANGED A YEAR AGO AT CHEVROLET DEALERSHIP ($750) NOW ITS DOING SAME THING AGAIN.*TR

• 12/28/2008· ENGINE AND ENGINE COOLING

  AFTER REPLENISHING RADIATOR FLUID IN MY 2000 CHEVY MALIBU WITH THE APPROVED FLUID, HAVOLINE DEX-COOL RADIATOR FLUID, MY CAR STARTED TO CONSTANTLY LEAK ANTI-FREEZE AND NOW I HAVE A LEAK AND MY RADIATOR "IDIOT" LIGHT IS CONSTANTLY ON. THE CAR WAS PERFECTLY FINE PRIOR TO THE APPLICATION OF THE DEX-COOL BUT DAYS AFTERWARD MY TROUBLES BEGAN. THERE WAS NEVER A PROBLEM BEFORE AND AS USUAL 4-6 WEEKS I WOULD HAVE TO REPLENISH 1/2 GALLON OF FLUID. THIS IS NOTED ON EVERY DISCUSSION BOARD REGARDING THIS MODEL BETWEEN 1997-2003. IT'S TOO CIRCUMSTATIAL THAT IMMEDIATELY AFTER THE APPLICATION OF THE DEX-COOL THAT MY TROUBLES BEGAN THEN FINDING THE SETTLEMENT OF GM REGARDING THIS MATTER AND IMPROPER GASKETS FOR THEIR MANIFOLDS AND WATER PUMPS (NYLON/SOLICONE BASED) THAT THE COURTS FOUND THAT THE COOLANT DOES INDEED CORRODE THESE GASKETS. NOW THAT MY CAR IS 8 YRS OLD, MY ABILITY TO RECOUP ANY MONEY ON USING THE PROPER/RECOMMENDED PRODUCT AS STATED BY GM IS MORE THAN LIKELY IMPROBABLE. *TR

• 12/27/2004· ENGINE AND ENGINE COOLING

  (1) THE FAILURE OCCURRED UNDER NORMAL DRIVING CONDITIONS. (2) THE INTAKE MANIFOLD LEAKS RADIATOR FLUID DUE TO FAULTY GASKETS. FORTUNATELY, THE PROBLEM WAS OBSERVED BEFORE THE ENGINE OVERHEATED OR CAUGHT FIRE, BUT THERE IS EVIDENCE OF COOLANT CONTAMINATING THE ENGINE OIL: FURTHER CONSEQUENCES WILL LIKELY OCCUR IN THE FUTURE. (3) THE FAILURE HAS NOT YET BEEN CORRECTED. A FIRESTONE SERVICE CENTER DIAGNOSED THE PROBLEM BUT REPAIRS HAVE NOT YET BEEN CONTRACTED. A CHEVROLET DEALERSHIP/SERVICE CENTER (BILL HEARD) GAVE AN ESTIMATE OF $1000 FOR THE REPAIR. PLEASE NOTE THAT THIS IS A COMMON FAULT IN CHEVY MALIBUS AND OTHER GM CARS WITH THIS ENGINE TYPE. THE SERVICE REP AT FIRESTONE STATED THAT THIS WAS THE MOST COMMON PROBLEM SEEN IN THIS CAR, AND THE SERVICE REP AT THE CHEVROLET DEALERSHIP STATED THAT IN MALIBUS, THE INTAKE MANIFOLD GASKETS FAIL "MORE OFTEN THAN NOT." *AK

• 12/23/2014· ELECTRICAL SYSTEM

  2000 CHEVROLET MALIBU. CONSUMER IS DISSATISFIED WITH THE SERVICES RECEIVED. *TA AFTER WAITING FOR 45 MINUTES AT THE DEALER, THE CONSUMER WAS INFORMED THE PART WAS NOT AVAILABLE TO PERFORM THE RECALL. *JB

• 12/23/2010· FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM

  I HAVE A 2000 CHEVY MALIBU. IT HAS SOMETHING CALLED THE PASSLOCK SYSTEM OR THEFT SYSTEM AND IT PREVENTS THE CAR FROM STARTING. IT PREVENTS THE CAR FROM STARTING ALL THE TIME. THIS ISN'T THE FIRST TIME YOU HAVE RECEIVED THIS COMPLAINT I BET. I HAVE PUT AN EXTRA $2000 INTO THE CAR AFTER I BROUGHT IT HOPING IT WOULD FIX IT BUT I STILL HAVE THE PROBLEM. I HAVE READ ON-LINE AND EVERYONE WHO OWNS A 96 AND UP GM CAR HAS THIS PROBLEM. EVERYONE SAYS GM DOESN'T CARE ABOUT THIS PROBLEM AND THEY WON'T FIX IT. THEY SAY THIS IS THE ONLY WAY TO GET THEM TO FIX IT. IF WE COMPLAIN ON HERE. PLEASE MAKE THEM FIX THIS PROBLEM WITH THEIR CARS BECAUSE YOU WOULD SAVE OVER 1,000,000 PEOPLE TIME AND FRUSTRATION. NO JOKE, LITERALLY 1,000,000 PEOPLE HAVE THIS PROBLEM. THIS IS WHY THEY WENT BANKRUPT. GM SUCKS. THIS IS WHY AMERICA SUCKS AS A NATION. WE HAVE TO COMPLAIN ON HERE TO FIX OUR PROBLEMS. NO OFFENSE TO YOU. I DON'T HAVE ENOUGH MONEY TO BY ANOTHER CAR, AS MOST PEOPLE WITH THIS PROBLEM. PLEASE DO THE RIGHT THING AND MAKE GM FIX IT. I KNOW IT IS NOT THE AMERICAN WAY TO GIVE THE PEOPLE WHAT THEY WANT BUT MAYBE THIS TIME WE CAN MAKE AN EXCEPTION. PLEASE HELP ALL OF US WHO WOULD LOVE TO BUY A DIFFERENT CAR BUT DON'T HAVE THE MONEY. THANK YOU. *LN

• 12/23/1999· FUEL SYSTEM, GASOLINE

  WHILE DRIVING 65 MPH ON THE HIGHWAY ENGINE COMPLETELY SHIUT DOWN WITHOUT WARNING DUE TO A DEFECTIVE FUEL PUMP. PLEASE GIVE ANY FURTHER DETAILS. *AK

• 12/22/2014· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE STALLED. THE FAILURE OCCURRED AFTER THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 134,000. UPDATED 02/18/15*LJ UPDATED 9/11/2017*CN

• 12/22/2003· SERVICE BRAKES, HYDRAULIC

  I BELIEVE THERE IS AN ENGINEERING DEFECT IN THE DESIGN OF THE BRAKES THAT CAUSES PREMATURE WEAR OF THE ROTORS, WHICH COULD LEAD TO BRAKE SYSTEM FAILURE. THIS PROBLEM IS WELL DOCUMENTED BY CUSTOMERS, SERVICE FACILITIES AND GM DEALERS. GM GOES OUT OF ITS WAY TO DISCOURAGE RELEVANT DISCUSSION OF THIS PROBLEM, CHOOSING INSTEAD TO IGNORE IT. IN THREE YEARS, I HAVE HAD TO REPLACE MY ROTORS 5 TIMES WITH 87,000 MILES ON THE CAR. IT IS EXPENSIVE AND HIGHLY UNUSUAL FOR ROTORS TO WEAR OUT SO QUICKLY. EVERY MECHANIC/TECHNICIAN I HAVE SPOKEN WITH SAYS THE EXACT SAME THING: THE ROTORS ARE ENGINEERED EXTREMELY THIN DUE TO THE CALIPER DESIGN. IN ORDER TO FIT THE ROTOR IN PLACE - IT MUST BE SO THIN DUE TO THE DESIGN OF THE BRAKE SYSTEM THAT TO BEGIN WITH IT IS BARELY WITHIN SAFETY SPECIFICATIONS. IF NOT EXTREMELY VIGILIANT, ROTORS CAN WARP QUICKLY - CAUSING A CASCADING EFFECT THAT IS ALSO WELL DOCUMENTED. I STRONGLY BELIEVE THIS SITUATION NEEDS CAREFUL SCRUTINY. GM NEEDS TO ACKNOWLEDGE AND DEVELOP A REMEDY FOR THIS SITUATION. *AK

• 12/21/2004· EXTERIOR LIGHTING

  THE CONSUMER STATED THAT THE TURN SIGNAL INTERMITTENTLY FAILED. A RECALL WAS ISSUED. HOWEVER, THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. *AK THE PROBLEM WOULD ALSO OCCUR WHILE IN MOTION MAKING A LEFT OR RIGHT HAND TURN. *SC *JB

• 12/20/2010· EXTERIOR LIGHTING

  I HAVE REPLACED MY TAIL LIGHT BULBS NUMEROUS TIMES AS WELL NOW THE ENTIRE BULB PANEL ONCE ON EACH SIDE. THE DESIGN AND THE SEAL ALLOWS FOR WATER TO ENTER AND HOLD WATER IN THE COVERING/REFLECTORS WHICH IN TURN CAUSE RUSTING AND BLOWN BULBS. AT THIS POINT I NOW NEED A WHOLE NEW WIRING HARNESS DUE TO THE WATER DAMAGE ON THE PASSENGER SIDE AS WELL AS ANOTHER NEW BULB PANEL. I HAVE MANY FRIENDS WHOM ALSO HAVE THE SAME CARS WHO CAN NOT KEEP TAIL LIGHTS WORKING EITHER. I NOTICE AS I DRIVE AROUND MANY, MANY OTHERS ON THE ROAD HAVE NO VISIBLE LIGHTS I WOULD HAVE TO GUESS FOR THE SAME REASON. I AM PULLED OVER BY THE POLICE FREQUENTLY FOR THIS AS WELL. I HAVE NOT BEEN ISSUED A CITATION YET AS I HAVE A SPOILER , REAR WINDOW, AND BOTH BREAK LIGHTS THAT ARE WORKING. THIS IS DEFINITELY A DESIGN PROBLEM AND HAVE BEEN TOLD THIS BY MANY MECHANICS OVER THE YEARS. THIS SHOULD BE CORRECTED TO POTENTIALLY REDUCE ACCIDENTS DUE TO LACK OF REAR LIGHTS AND OWNERS NOT KNOWING THEY HAVE GONE OUT OR BEING UNABLE TO REPAIR. THE SEALS ARE POOR AND HOLD BOWLS OF WATER CONSTANTLY IN THE COVERS. I OFTEN SEE THE PROBLEM IN THE PASSENGER SIDE AS WELL AS MINE. UNSURE IF THIS IN COMMON OR JUST MY OBSERVATION. *TR

• 12/20/2006· ENGINE AND ENGINE COOLING

  WHILE DRIVING MY CAR ALONG THE FREEWAY AND WITHOUT ANY NOTICE THE CAR WENT FROM HAVING A NORMAL TEMP TO RED LINING ON THE TEMPERATURE. I IMMEDIATELY SLOWED THE VEHICLE DOWN AND TURNED ON THE HEAT. AT THIS POINT NO HEAT CAME OUT AND SOON AFTERWARDS THE VEHICLE OVERHEATED AND DIED. I CRUISED IT OFF THE FREEWAY AND ONTO A SIDE ROAD. I WAS IN THE MIDDLE OF NOWHERE AND A PASSERBY WAS NICE ENOUGH TO STOP. I ENDED UP REFILLING THE COOLANT AND WAS ABLE TO DRIVE TO WHERE I NEED TO GO AND RETURN HOME. I HAD REFILL THE FLUID LEVEL MULTIPLE TIMES. I TOOK IT TO A RADIATOR SHOP THAT STATED THAT THE SEALS ON MY ENGINE WERE LEAKING EXHAUST INTO THE FLUIDS WHICH CAUSED THE VEHICLE TO OVERHEAT. THEY STATED THAT CHEVY WAS HAVING TROUBLE WITH THE DEXACOOL COOLANT IN THE VEHICLES AND THAT IT WAS EATING AWAY THE SEAL IN THE ENGINE. *JB

• 12/20/2001· STEERING,SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,LATCHES/LOCKS/LINKAGES,EQUIPMENT

  VEHICLE WOULD JUMP WHEN TRYING TO STOP. ROTORS WERE WARPED. CONSUMER HAD TO PUT ON 5 SETS OF ROTORS SINCE JAN 2001. CONTACTED DEALER WHO WANTED CONSUMER TO EXTEND WARRANTY.*AK THE CONSUMER STATED THAT THE FRONT ROTORS ARE WARPED CAUSING BRAKE PULSATION. THE A/C DOES NOT FLOW OUT OF THE CORRECT VENTS DUE TO A/C CONTROL FAILURE, THE A/C CONTROL HEAD ALSO SHORTED OUT. THE DOOR WAS HARD TO OPEN AND CLOSE DUE TO THE LOCK BEING MISALIGNED. ENGINE MAKES A CLUNK NOISE. WHILE DRIVING THE VEHICLE SURGES. LEFT REAR SPEAKER SHORTED OUT. THERE IS A CLICKING NOISE COMING FROM THE FRONT WHEN TURNING, CONSUMER LATER STATED THAT THERE WAS A CHIRPING NOISE COMING FROM THE STEERING COLUMN. *YH

• 12/18/2012· EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE TURN SIGNALS BECAME INOPERABLE. THE CONTACT WOULD HAVE TO ABRUPTLY STRIKE THE HAZARD AND TURN SIGNAL LIGHTS IN ORDER FOR THEM TO OPERATE. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 68,000.

• 12/18/2008· ENGINE AND ENGINE COOLING,AIR BAGS

  TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE AIR BAG LIGHT HAS BEEN ILLUMINATED SINCE THE VEHICLE WAS PURCHASED. THE COOLANT IS ALSO LEAKING FROM THE VEHICLE. HE WAS ADVISED THAT THE THERMOSTAT WAS NOT WORKING PROPERLY. THE DEALER REFUSED TO REPAIR THE VEHICLE. THE FAILURE MILEAGE WAS 93,600.

• 12/18/2003· ENGINE AND ENGINE COOLING

  LEAKING COOLANT FROM AROUND ENGINE BLOCK. DEALER DIAGNOSIS: LOWER INTAKE MANIFOLD GASKET LEAK. MILEAGE 30,000. PREVIOUS REPAIR COMPLETED ON WATER PUMP FOR BAD BEARINGS AT 28,800 MILES. MANUFACTURER SHOULD BE HELD ACCOUNTABLE FOR A DEFECTIVE COMPONENT USED IN THE BUILDING OF THESE MOTORS.*AK

• 12/18/2002· SERVICE BRAKES, HYDRAULIC

  BRAKE PADS AND ROTORS REPLACED IN SEPT, 2002 AND AGAIN IN DEC, 2002. BRAKES STILL SCRUB AND SQUEAL WHEN BRAKING. THIS IS A PROBLEM THAT GENERAL MOTORS I HAVE BEEN TOLD KNOWS ABOUT. WHY HASN'T THERE BEEN A RECALL. THIS MAKES FOR A BAD REPUTATION. I WILL NEVER BUY ANOTHER MALIBU AND MAYBE NOT EVEN A CHEVROLET PRODUCT.

• 12/17/2015· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED. THE FAILURE RECURRED. WHEN THE CONTACT ATTEMPTED TO REMOVE THE KEY FROM THE IGNITION, IT WAS STUCK AND COULD NOT BE REMOVED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 196,600.

• 12/17/2009· EXTERIOR LIGHTING

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE TURN SIGNALS/HAZARD LAMPS ARE INOPERATIVE. HE CONTACTED GM IN REFERENCE TO RECALL #03V327000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH). HE WAS ADVISED THAT SINCE HIS VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM THE RECALL, HE WAS INELIGIBLE FOR A FREE REMEDY. HE WAS IN THE PROCESS OF HAVING THE VEHICLE REPAIRED. THE FAILURE MILEAGE WAS 54,000.

• 12/17/2003· ENGINE AND ENGINE COOLING

  THE ENGINE COOLANT CONSTANLY RUNS LOW OR EMPTY. I HAVE TO REFILL IT ALL THE TIME. NOW I FIND OUT I MIGHT HAVE A LEAK FROM THE COOLANT THAT IS RUNNING IN MY OIL. CAR ALSO HARD TO START SOMETIMES. I HAVE A FRIEND WHO HAS THE SAME PROBLEM WITH HAVING TO FILL UP THE ENGINE COOLANT CONSTANLY. SHE HAS A 2002 MODEL. HAVING TO FILL IT UP THAT OFTEN IS NOT NORMAL. *AK

• 12/17/2002· SERVICE BRAKES, HYDRAULIC

  VEHICLE HAS HAD THE BRAKE ROTORS TURNED TWICE AND REPLACED ONCE DUE TO EXCESSIVE VIBRATION WHILE BRAKING. CONSIDER THE BRAKES SYSTEM UNSAFE. THE AC CONTROL HEAD HAS BEEN REPLACED. THE UPPER STRUT MOUNTS HAVE BEEN REPLACED TO TRY AND CURE FRONT END NOISE. FRONT WHEEL HUB AND BEARING HAVE BEEN REPLACED DUE TO NOISE. ENGINE IS EXCESSIVELY NOISY ON STARTUP WITH CLICKING AND TAPPING THAT THE DEALER CALLS NORMAL. TURN SIGNALS FAILED. POWER WINDOW IS INTERMITTENT. THREE SPARK PLUG WIRES HAVE FAILED. RADIATOR CAP HAS FAILED. INTAKE MANIFOLD GASKET FAILED. CAR RUINS TIRES. CAR IS IN FOR A CHECK ENGINE LIGHT RIGHT NOW (12-17-02) CHEVROLET WILL NOT DO ANYTHING (IE:TAKE THE CAR BACK, REPLACE IT, ETC.) HOW MANY PROBLEMS DO YOU HAVE TO HAVE. TS

• 12/16/2014· ELECTRICAL SYSTEM

  2000 CHEVROLET MALIBU. THE IGNITION SWITCH HAS CONSISTENTLY WORE OUT MANY KEYS OVER THE YEARS. *MW THE CONSUMER STATED PERIODICALLY, SHE WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. THE CONSUMER RECEIVED A RECALL LETTER IN THE MAIL AND MADE AN APPOINTMENT AT THE DEALER. HOWEVER, WHEN SHE ARRIVED, THE DEALER STATED THEY DID NOT HAVE THE PARTS. TWO WEEKS, THE DEALER CALLED HER AND SHE RETURNED TO THE DEALER. SHE WAS INFORMED THEY COULD NOT RETROFIT HER CURRENT KEYS TO THE VEHICLE. SHE WAS INFORMED SHE WOULD HAVE TO BUY A FACTORY MADE KEY AT $15.00 EACH PLUS TAX, TO ALLOW THEM TO DO THE RECALL. THE CONSUMER DID NOT BELIEVE THE ISSUE WAS THE KEY, BUT WITH THE IGNITION SWITCH THAT SHOULD HAVE BEEN REPLACED. *JB

• 12/15/2004· EXTERIOR LIGHTING

  TURN SIGNAL AND FLASHER WOULD INTERMITTENTLY TURN ON, MAKING IT DIFFICULT FOR VEHICLES IN THE REAR TO SEE WHEN DRIVER NEEDED TO TURN. CONSUMER WILL TAKE VEHICLE TO DEALER FOR CHECK UP.*AK

• 12/14/2020· ELECTRICAL SYSTEM,ENGINE

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT SHIFTED THE VEHICLE INTO NEUTRAL, TURN THE SWITCH TO THE OFF POSITION THEN BACK TO THE ON POSITION AND THE VEHICLE STARTED. THE CONTACT ALSO STATED THAT WHILE DRIVING 45 OR 55 MPH, THE VEHICLE LOSS MOTIVE POWER AND STALLED WITHOUT WARNING. THE CONTACT STATED THAT SEVERAL ATTEMPTS WERE NEEDED TO RESTART THE VEHICLE. ADDITIONALLY, THE CONTACT STATED THAT THE VEHICLE WOULD LOSS POWER BEFORE SHE COULD SHIFT OUT OF PARK INTO REVERSE. THE CONTACT STATED THAT SHE HAD RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) AND HAD THE VEHICLE TAKEN TO WEST CHEVROLET, INC., (3450 AIRPORT HWY, ALCOA, TN 37701) WHERE THE VEHICLE WAS REPAIRED UNDER RECALL. THE CONTACT STATED THAT THE IGNITION SWITCH WAS NOT REPAIRED UNDER THE RECALL CAMPAIGN. THE VEHICLE WAS NOT TAKEN BACK TO THE DEALER. THE CONTACT CALLED THE SAME DEALER AND INFORMED THEM OF THE FAILURE AND WAS ADVISED TO SCHEDULE AN APPOINTMENT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 104,000.

• 12/14/2005· ENGINE AND ENGINE COOLING

  INTAKE MANIFOLD LEAK..LOSS OF COOLANT..OVERHEATING ENGINE..HEATER MALFUNCTION SPORADICALLY. THIS PROBLEM CONTINUES BUT ABATED SOMEWHAT AFTER SERVICE AT A RADIATOR REPAIR FACILITY RODDED THE RADIATOR TWICE ,FLUSHED AND REFILLED THE SYSTEM WITH NEW COOLANT AND INSTALLED NEW THERMOSTAT. MILEAGE WAS 39,500. *NM

• 12/12/2016· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU CLASSIC. WHILE DRIVING AT ANY RATE OF SPEED, THE VEHICLE RANDOMLY STALLED SEVERAL TIMES WITHOUT WARNING. IN ADDITION, THE ANTI-THEFT WARNING INDICATOR FLASHED NUMEROUS TIMES. THE CONTACT HAD TO RESTART THE VEHICLE EACH TIME THE FAILURE OCCURRED AND, AT TIMES, THE KEY WAS EXTREMELY DIFFICULT TO TURN OVER TO RESTART THE VEHICLE. THE VEHICLE WAS NOT YET INSPECTED AND DIAGNOSED BY A MECHANIC NOR A DEALER. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 179,000.

• 12/12/2006· ENGINE AND ENGINE COOLING,EQUIPMENT

  2000 MALIBU ENGINE GASKETS HAD TO BE REPLACED. *TS THE AIR CONDITION CONTROL HEAD WAS REPLACED. *JB

• 12/11/2002· AIR BAGS

  INTERMITTENTLY INDICATOR AIR BAG LIGHT BECOME INOPERABLE. DUE TO A FAULTY CLOCK SPRING. DEALER INSPECTED AND NOTANY LONGER UNDER GUARANTEE. PLEASE PROVIDE FURTHER INFORMATION. MR

• 12/11/2000· SERVICE BRAKES, HYDRAULIC

  THE DEALER REPLACED MY ROTORS 3 TIMES AND REPLACED MY PADS ONCE WHICH WAS ON MY LAST BRAKE REPLACEMENT VISIT AROUND 3 MONTHS AGO... NO PROBLEMS SO FAR. I ALSO COMPLAINED TO THE DEALER ABOUT THE VEHICLE JERKING, I GOT A FOLLOW UP CALL FROM A FOREMAN AND THE GUY WHO INSTALLED MY DASHBOARD ASKING ABOUT THE CAR OVERALL, I TOLD HIM ABOUT THE CAR JERKING HE ASKED WHAT KIND OF GASOLINE DO I USE, I TOLD I ONLY HAD 3 FILLUPS SINCE I BOUGHT THE CAR AND I USED BP OIL....HE TOLD ME TO USE SHELL GASOLINE, IT DID HELP THE PROBLEM BUT THE PROBLEM NEVER WENT AWAY..... ALSO IN THE MORNINGS WHEN THE CAR IS COLD , I START MY CAR AND I HEAR ALL KINDS OF CLICKING AND TICKING NOISES FROM THE ENGINE.......THE CAR SURGES AND HAS COMPLETLY CUT OFF ON ME TWICE WITHIN THE PAST YEAR AND IT DO IDLED VERY VERY LOW SOMETIMES..........CHEVROLET ALSO DID A VERY POOR JOB WITH THE PAINT ON MY CAR UNDER THE DOORS AND HOOD THERE IS SOME SPOTS WERE THERE IS NO PAINT AT ALL.....THE DEALER OFFERD TO HAVE THOSE SPOTS TOUCHED UP BUT IT HAS TO GO TO THE BODY SHOP FOR A FEW DAYS........... GENERAL MOTOR NEEDS TO RECALL THE ENGINES ON THOSE CARS BECAUSE SOMETHING IS WRONG. *AK

• 12/10/2008· EXTERIOR LIGHTING,EQUIPMENT

  TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE HAZARD LIGHTS AND TURN SIGNALS WOULD FUNCTION INTERMITTENTLY. SHE COULD NEVER PINPOINT WHEN THEY WOULD MALFUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS; HOWEVER, THE LIGHTS FUNCTIONED PROPERLY EACH TIME AND THEY COULD NOT DUPLICATE THE FAILURE. THE CONTACT TOOK THE VEHICLE TO THE DEALER REGARDING NHTSA CAMPAIGN ID NUMBER 03V327000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH) AND THEY INSTALLED A NEW SWITCH. THE REMEDY CORRECTED THE ISSUE; HOWEVER, THE FAILURE RECURRED IN THE LATTER PART OF 2008. THE DEALER STATED THAT THE REPAIR WOULD BE AT THE CONTACT'S EXPENSE AGAIN BECAUSE THE RECALL REPAIR HAD PREVIOUSLY BEEN PERFORMED. IN ADDITION, THE HEATER DID NOT WORK. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS 62,902 AND FAILURE MILEAGE WAS 42,668.

• 12/10/2003· SERVICE BRAKES, HYDRAULIC,TIRES

  WHILE BRAKING THE VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE DUE TO THE FRONT BRAKE ROTORS WEARING. ALSO THERE WAS A VIBRATION WHEN DEPRESSING THE BRAKE PEDAL. THE DEALERSHIP WAS NOTIFIED, BUT THE PROBLEM WAS NOT RESOLVED. *AK THE DEALERSHIP TOLD THE CONSUMER THEY WOULD REPLACE THE ROTORS WHEN THE VEHICLE WAS FIRST PURCHASED, BUT THEY NEVER DID. *CB *JB

• 12/10/2003· FUEL SYSTEM, GASOLINE

  WHILE DRIVING AT ANY SPEED THE VEHICLE WILL SUDDENLY STALL WITHOUT ANY WARNING. IT HAD TAKEN THE VEHICLE A WHILE TO RESTART AND WHEN IT DID RESTART IT NEEDED CONSTANT REFUELING. UPON INSPECTION OF THE VEHICLE BY A LOCAL MECHANIC HE INDICATED THAT THE PROBLEM COULD BE CAUSED BY THE FUEL PUMP. *AK *SCC *JB

• 12/09/2005· AIR BAGS

  MY 2000 MALIBU RECENTLY DEPLOYED THE AIRBAGS WHILE CAR WAS PARKED AND ENGINE OFF. I CONTACTED POLICE THINKING THE CAR HAD BEEN HIT, ALTHOUGH NO DAMAGE WAS VISIBLE. THE POLICE SAID THAT THERE WAS NO EVIDENCE AT ALL THAT THE CAR HAD BEEN INVOLVED IN ANY SUSPICIOUS ACTIVITY. I THEN CONTACTED THE LOCAL DEALER AND THEY SAID THEY WOULD HAVE TO REMOVE BLACK BOX AND THAT I WOULD NOT BE ALLOWED THE USE OF THE CAR FOR SEVERAL DAYS. I WAS TREATED VERY RUDELY WHEN I COMPLAINED TO THE GM NATIONAL OFFICE REGARDING THE EXPENSE I WOULD INCUR FOR RENTAL CAR BECAUSE LOCAL DEALER WOULD NOT PROVIDE LOANER. BASICALLY, THEY SAID THAT IT WAS NOT THEIR PROBLEM. I THEN WAS TALKING TO A MECHANIC AT A DIFFERENT SHOP AND WAS TOLD THAT THERE IS A PROBLEM WITH MALIBU'S AIR BAGS DEPLOYING WITHOUT IMPACT OF ANY KIND. HE TOLD ME ABOUT A RECENT CLASS ACTION LAWSUIT IN OKLAHOMA OVER THIS ISSUE. BEFORE I SPEND THE $100'S OF DOLLARS TO FIX THIS, I WOULD LIKE TO KNOW IF THIS IS A MANUFACTURER'S DEFECT. *JB

• 12/08/2008· ELECTRICAL SYSTEM

  RECURRING PROBLEM WITH A "THEFT SYSTEM" ERROR. IN COLD WEATHER, THE THEFT SYSTEM DISABLES THE VEHICLE FOR 10 MINUTES, THEN MAYBE WILL ALLOW CAR TO START. THERE ARE NUMEROUS COMPLAINTS ON AUTO FORUMS REGARDING THIS EXACT ISSUE. EACH YEAR FOR THE LAST 4 WE HAVE ISSUES WITH THE CAR NOT STARTING. THIS IS RELATED TO A "PASS LOCK" SYSTEM IN THIS VEHICLE. THIS VEHICLE DOES NOT HAVE AN ALARM, NOT REMOTE STARTER. *TR

• 12/08/2004· EXTERIOR LIGHTING

  INTERMITTENTLY, THE SIGNALS FAILED TO FUNCTION. HIS FAILURE COULD RESULT IN AN ACCIDENT. THE DEALERSHIP WAS CONTACTED. THE CAUSE OF THE FAILURE WAS UNDETERMINED. *AK *SC

• 12/08/2004· EXTERIOR LIGHTING

  THE HAZARD WARNING SWITCH FAILED INTERMITTENTLY. MANUFACTURER'S RECALL 03043 WAS ISSUED. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK

• 12/07/2002· TIRES

  SIDEWALL BLOWN IN 3 SPOTS WHILE ENTERING DRIVEWAY. DT

• 12/07/2000· SERVICE BRAKES, HYDRAULIC

  BRAKES PULSATE, THE HIGHER THE SPEED THE MORE IT DOES IT. DEALER FOUND THAT ROTORS & PADS WERE THE WRONG SIZE. THEY WERE REPLACED UNDER WARRANTY. BRAKES WORK NORMAL NOW. *AK *SLC

• 12/06/2006· SERVICE BRAKES, HYDRAULIC,ELECTRICAL SYSTEM

  I HAVE A 2000 CHEVY MALIBU. AS MANY MALIBU OWNERS MY CAR HAS THE SAME ISSUES. BLOWER FAN DOESN'T WORK ON SETTING 1 AND 2, REAR SPEAKERS DON'T WORK IN COLD WEATHER, REAR TAIL LIGHTS DON'T ALWAYS WORK, WEIRD BRAKING ISSUES IN THE COLD, AND AIR CIRCULATION BUTTON CHANGES FROM CLOSED TO OPEN AUTOMATICALLY. THESE ARE JUST SOME ELECTRICAL ISSUES WITH THE CAR AND I THINK I FOUND THE ROOT CAUSE. THE WINDSHIELD RUBBER SEAL ON MY CAR WAS UNATTACHED FROM THE WINDOW OUTSIDE AT THE BOTTOM ON THE PASSENGER SIDE. I FOUND OUT BECAUSE AFTER A HEAVY RAIN A LOT OF WATER WAS SHOWING ON THE FLOOR OF THE PASSENGER SIDE. THE WATER DAMAGES HAS BEEN HAPPENING FOR YEARS. I FOUND WATER SITTING IN THE PLASTIC MOLDING RIGHT UNDER THE BLOWER FAN. WATER CORRODING THE ELECTRICAL CABLES ON THE FLOOR. WATER TRACKS OVER THE COMPUTER BOARD LOCATED UNDER THE GLOVE BOX. I'VE INFORMED CHEVROLET AND ASK FOR THEM TO CREATE A TSB BUT THEY DENIED MY REQUEST.*JB

• 12/05/2012· VEHICLE SPEED CONTROL

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE ERRONEOUSLY ACCELERATED. THE CONTACT RESTARTED THE VEHICLE WHILE IT WAS STILL IN MOTION AND IT RESUMED NORMAL FUNCTION. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS106,000. UPDATED 01/15/13*LJ THE CONSUMER STATED THE CURRENT MILEAGE WAS 107,697. THE THROTTLE BODY WAS CLEANED, THROTTLE SENSOR REPLACED, IDLE AIR CONTROL VALVE REPLACED YET, THE FAILURE PERSISTS. OLD PARTS ARE AVAILABLE. UPDATED 1/23/2013 *JS

• 12/04/2015· ELECTRICAL SYSTEM

  TL* THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ANTI-THEFT SYSTEM ACTIVATED CAUSING THE VEHICLE TO BE UNABLE TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

• 12/04/2014· ELECTRICAL SYSTEM

  2000 CHEVROLET MALIBU REMOVE AND REPAIR IGNITION LOCK CYLINDER SWITCH *TA THE CONSUMER IS SEEKING REIMBURSEMENT. *JB

• 12/04/2003· ENGINE AND ENGINE COOLING,EQUIPMENT

  INDEPENDENT SHOP REPLACED THE INTAKE MANIFOLD AT OWNER EXPENSE OF $800. DOLLARS AND HAS HAD PROBLEMS WITH THE AIR CONDITIONER. DEALER NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. *PH