2000 Chevrolet Cavalier

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/28/2015· STEERING,SEAT BELTS,FUEL/PROPULSION SYSTEM

  UNNECESSARY GAS ODORS. SEAT BELTS KEEP UNLOCKING. STEERING

• 12/26/2004· FUEL SYSTEM, OTHER

  I WAS DRIVING TO WORKING ON NOVEMBER 19 2004 AT APPROXIMATELY 8:30AM WHEN MY CAR STALLED AT A STOP LIGHT ON A MAJOR STREET. I TRIED TO GIVE IT GAS BUT IT WOULD NOT ACCERATE. I TRIED TO START IT A COUPLE OF TIMES BUT IT WOULD NOT START. THE CAR WAS ON A 1/4 OF GAS WHEN THIS HAPPENED SO I THOUGHT IT WASN'T THE FUEL. I HAD TO CALL MY BOSS, WHO CAME OUT TO TRY TO HELP BUT HAD NO LUCK IN GETTING IT TO START OR FIGURING OUT WHAT THE PROBLEM WAS SO WE HAD TO CALL AAA AND HAVE THEM TOW MY CAR TO AN AUTOMOTIVE SHOP. AFTER 2 DAYS OF HAVING MY CAR IN THE SHOP, I WAS TOLD BY MY MECHANIC THAT MY FUEL PUMP WAS COMPLETELY SHOT DUE TO MY FUEL GUAGE READINGS NOT READING CORRECTLY. WHEN MY FUEL READING WAS AT 1/4 IT WAS ACTUALLY OF EMPTY. MY MECHANIC THEN INFORMED ME THAT THIS HAS BEEN A KNOWN DEFECT FOR MY YEAR, MAKE AND MODEL CAR. I WAS THEN INFORMED BY MY MECHANIC THAT IT WOULD COST $675.00 WHICH INCLUDED PARTS AND LABOR TO FIX THIS PROBLEM. AT THAT TIME, I CALLED THE GM DEALER BECAUSE I THOUGHT THAT SINCE THIS WAS A KNOWN DEFECT THAT THEY SHOULD HAVE IT COVERED UNDER SOME KIND OF WARRANTY. I SPOKE WITH THE SERVICE MANAGER OF THE SANTA CLARITA, CALIFORNIA DEALER, WHO INFORMED ME THAT IT HAS BEEN A KNOWN PROBLEM, BUT THAT ITS NOT UNDER ANY KIND OF EXTENDED WARRANTY. WHEN I HEARD THAT, I WAS VERY ANGRY BECAUSE I FELT THAT IF THIS IS A KNOWN COMPLAINT/DEFECT THAT THESE CERTAIN CARS MAY HAVE, WHY SHOULD I, THE CUSTOMER OF CHEVROLET, HAVE TO PAY FOR THEIR DEFECTIVE PARTS? SINCE I AM IN NEED OF MY "RELIABLE" TRANSPORTATION, I PAID FOR A NEW FUEL PUMP (ALL $675.00 WORTH OF IT).*AK

• 12/25/2014· WHEELS

  WHILE PUMPING MY TIRES WITH AIR I NOTICED MY TWO BACK TIRES (A DIFFERENT BRAND FROM THE TWO FRONT TIRES) HAD CRACKING IN BETWEEN THE TREADS ALL THE WAY AROUND THE TIRES. THIS MUST BE A MANUFACTURERS DEFECT AND AN OBVIOUS SAFETY CONCERN. HERE IS TIRE INFORMATION (AND DESIGNATIONS) AS DESIGNATED ON THE SIDEWALL: REAR DRIVERSIDE TIRE: ACHILES PLATINUM MADE IN INDONESIA (5N1) MANUFACTURED BY MULTI STRADA ARAHSARANA TUBELESS STEEL BELTED RADIAL 195/70 R1491H MOLD NO. 03-02 E4 (ENCIRCLED) 0228041 DOT 5KJN HP 3606 THREAD: 1 POLYESTER, 2 STEEL, 2 NYLON; SIDEWALL 1 POLYESTER THREADWEAR 280 TRACTION A TEMPERATURE A ODDLY ENOUGH, THE REAR PASSENGER TIRE SEEMS TO MATCH THE ABOVE INFORMATION WITH TWO EXCEPTIONS: THREADWEAR 420 TRACTION AA TEMPERATURE A MOLD NO. 03-03 WE BOUGHT TIRES FROM FIGUEROA TIRES IN LOS BANOS. WE DON'T HAVE A RECEIPT TO CONFIRM THIS. THESE TIRES MUST HAVE BEEN PURCHASED BEFORE 04/29/10 SINCE WE DID FIND A SERVICE ORDER RECEIPT FROM WALMART TIRE & LUBE EXPRESS DATED 04/29/10 THAT STATES IN THE TPMS AND TIRE DISCLAIMER RECEIPT: ACTIONS: REPLACE ONE OR MORE OF THE TIRES ON THE VEHICLE...REASONS: VISIBLE TIRE CUT, PUNCTURE, BALD SPOT, OR OTHER IRREGULARITY. *TR

• 12/22/2005· TIRES

  2000 CHEVY CAVALIER TIRE CAME OFF VEHICLE. *TS *JB

• 12/22/2005· ELECTRICAL SYSTEM

  2000 CHEVROLET CAVALIER BATTERY ACID LEAKED. *TS THE ACID DAMAGED OTHER COMPONENTS ON THE VEHICLE. THE SECOND INCIDENT OCCURRED ON OCT 6, 2005 *JB THE ACID LEAK DAMAGED THE BATTERY TRAY, TRANSMISSION COOLANT LINES, INNER FENDER AND FRAME (DELCO BATTERY). *NM

• 12/22/2003· FUEL SYSTEM, OTHER

  FUEL GAUGE IS NOT READING THE CORRECT AMOUNT OF FUEL IN THE TANK, CAUSING THE VEHICLE TO SHUT DOWN WHILE DRIVING ON THE HIGHWAY. *AK

• 12/18/2006· WHEELS

  3 MONTHS PRIOR TO NOVEMBER 19TH, 2006, I HAD MY DRIVER SIDE FRONT WHEEL BREAK AWAY FROM THE CAR. WHEN THE CAR FINALLY HAD STOPPED FROM 45 MPH, I WAS SURPRISED TO SEE THAT THE CENTER OF THE WHEEL WAS STILL ATTACHED TO THE CAR WITH THE LUG NUTS STILL TIGHT. THE CENTER OF THE WHEEL HAD BUSTED OUT. THE FRONT END OF THE CAR WAS SLIDING ON THE CONTROL ARM AND THE FENDER, DOOR AND FRONT BUMPER COVER HAD BEEN DAMAGED. I ALSO HAD TO REPLACE THE BRAKE ROTOR, BRAKE PADS AND LOWER BALL JOINT JUST TO GET THE CAR MOBILE TO DRIVE. THE CAR HAS DRIVEN THE SAME SINCE THIS HAD HAPPENED, SO I AM SURE THAT A LOT MORE DAMAGE HAS OCCURRED IN THE FRONT DRIVETRAIN, BUT CAN NOT AFFORD TO FIX AT THIS TIME. I CONTACTED FAIRWAY CHEVROLET IN LAS VEGAS, NEVADA AND WAS TOLD THAT THE WHEEL MUST HAVE BEEN DAMAGED BY A POT HOLE OR SOMETHING. BEING THE WHEEL WAS DAMAGED WHEN IT HAD BROKE OFF THE CAR, I ASSUMED THAT MAYBE THAT IS CORRECT INFORMATION UNTIL NOVEMBER 19TH, 2006. I WAS DRIVING AND FELT THE SAME VIBRATION FROM 3 MONTHS EARLIER. I CAREFULLY CAME TO A STOP AND INSPECTED THE CAR. NOW, MY PASSENGER FRONT WHEEL WAS ONLY SECONDS FROM BUSTING OFF THE CAR. THIS TIME THE WHEEL IS PERFECT CONDITION, MEANING NO SIGNS OF POT HOLE DAMAGE. AMERICAN TIRE IN LAS VEGAS, NEVADA REPLACED THE WHEEL AND INFORMED ME THAT THEY HAD NEVER SEEN A WHEEL BUST APART LIKE THIS, AND AM VERY LUCKY THAT THIS DID NOT RESULT IN A CRASH OR WORSE DEATH. THE SAME DEALER BRUSHED ME AWAY AGAIN, AND NOW I HAVE A DAMAGED CAR BOTH BODY AND DRIVEABILITY. PLEASE HELP. *NM

• 12/18/2003· LATCHES/LOCKS/LINKAGES

  2000 CHEVROLET CAVALIER Z-24 - DRIVER'S SIDE DOOR FREEZES SHUT ON MOST REASONABLY COLD DAYS. PASSENGER SIDE DOOR OPENS FINE. MY 94 SATURN PARKS RIGHT NEXT TO IT AND NEVER HAS A PROBLEM UNLESS IT IS EXTREMELY COLD WITH ICE AND SNOW, WHICH IS UNDERSTANDABLE. COULD THE DOOR/WINDOW SEAL BE BAD ON THE CAVALIER?*AK

• 12/18/2001· STEERING,ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM

  WHEN TURNING STEERING WHEEL SHARPLY THERE WAS A POPPING SOUND AT ALL TIMES. DEALER REPLACED POWER STEERING SHAFT.*AK CONSUMER STATES ENGINE LIGHT COMES ON WHILE DRIVING, SQUEALING NOISE FROM PASSENGERS SIDE OF ENGINE ESPECIALLY ON COLD STARTS, AND ENGINE IS SLOW TO CRANK UP-INTERMITTENT, BATTERY WAS REPLACED, ALSO VEHICLE WOULD NOT START, DEALER FOUND FUEL PUMP WAS INOPERATIVE AND REPLACED FUEL PUMP. *YD

• 12/17/2001· UNKNOWN OR OTHER

  ON SUNNY DAYS THERE IS A GLARE THAT COMES FROM THE DASHBOARD TO WINDSHIELD, OBSTRUCTING DRIVERS VIEW. DEALER HAS BEEN NOTIFIED.*AK CONSUMER STATED DASHBOARD SHOULD BE DARK TO REDUCE REFLECTION. *YD

• 12/16/2003· STEERING

  WHEN TURNING, THERE WAS A CLUCKING NOISE WITHIN THE STEERING COLUMN. THE CAUSE OF THE NOISE HAD NOT BEEN DETERMINED. THE VEHICLE IS CURRENTLY AT THE DEALERSHIP. PLEASE PROVIDE MORE DETAILS. *JB

• 12/13/2002· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  LIGHT COMES ON, ON DASH CONSUMER HAS TAKEN VEHICLE TO THE DEALER, AND THEY TOLD HIM THAT IT WAS NOTHING WRONG WITH VEHICLE.WHEN HE WAS ON VACATION,RADIATOR HOSE BUSTED. WHEN HE RETURNED HOME , HE WENT TO THE DEALER, AND WAS REIMBURSED SOME OF HIS MONEY BACK BY THE DEALER. ALSO, WAS TOLD BY DEALER WHEN DASH LIGHT INDICATOR THAT SOMETHING WAS WRONG WITH BATTERY. *AK

• 12/07/2004· SERVICE BRAKES, HYDRAULIC

  THE 2000 CHEVROLET CAVALIER WAS PURCHASED IN JULY 2003 WITH APPROXIMATELY 32,000 MILEAGE. ON DECEMBER 25, 2003 WITH 34,016 MILEAGE THE BRAKE DASH LIGHT CAME ON, INDICATING A PROBLEM. THE FLUID WAS BARELY VISIBLE WHEN CHECKED. THE MECHANIC LATER DETERMINED THE PROPORTIONING VALUE WAS LOSING A DROP OF BRAKE FLUID WITH THE APPLICATION OF THE BRAKE PEDAL. THE PART WAS ORDERED AND RECEIVED FROM THE LOCAL DEALER. THE REPAIRED CAR WAS COMPLETED ON JANUARY 2, 2004. HE DIFFERENCE WAS REMARKABLE. IT WASN'T UNTIL IT WAS REPAIRED THAT I REALIZE HOW MUCH IT HAD LOST IT BRAKING ABILITY. TODAY I WAS TOLD IT WAS NOT A SAFETY ISSUE, SINCE I DIDN'T HAVE IT REPAIRED BY THEIR AUTHORIZED DEALER ONLY THE DEALER COULD MAKE THE DETERMINATION OF DEFECTIVE PARTS. *AK

• 12/02/2001· VISIBILITY

  THE PLASTIC STRIP NEAR FRONT WINDOW ON DASH BOARD IS CRACKED IN TWO DIFFERENT PLACES. THERE WAS NO DAMAGE DONE TO THE VEHICLE TO CAUSE THIS TYPE OF DAMAGE. THE PLASTIC PIECE CRACKED ALL THE WAY UP TO THE WINDSHIELD.

• 11/30/2005· ELECTRICAL SYSTEMFire

  A FIRE IN MY 2000 CHEVROLET CAVALIER BEGAN IN THE CENTER CONSOLE APPARENTLY THE RESULT OF ELECTRICAL PROBLEMS WITH THE POWER WINDOW CONTROL WIRINGS. NO ONE WAS IN THE PARKED AND LOCKED CAR AT THE TIME OF OCCURRENCE. THE DAMAGE RESULTED IN MY INSURANCE COMPANY TOTALING THE VEHICLE. *JB

• 11/29/2004· ELECTRICAL SYSTEM

  THE IGNITION BECAME INOPERABLE. KEY WOULD NOT TURN, THE KEY CYLINDER AND SWITCH HAD TO BE REPLACED FOR THE SECOND TIME. THE FIRST TIME WAS OCTOBER OF LAST YEAR 2003. IN BOTH OCCURANCES THE VEHICLE HAD TO BE TOWED.*AK

• 11/29/1999· POWER TRAIN,UNKNOWN OR OTHER

  THE CLUTCH WILL RETURN TO THE UP POSITION BECAUSE OF THE POSITIONING OF THE FLOOR MAT. DEALER HAS BEEN NOTIFIED. *AK

• 11/27/2000· FUEL SYSTEM, GASOLINE

  THE GAS CYLINDER IS BEING CORRODED BY THE SULFUR IN THE GASOLINE, THE GAS GAUGE WILL READ THAT THERE IS GAS AND THEN THE VEHICLE WILL JUST STOP WITHOUT ANY WARNING. *SLC

• 11/26/2001· ENGINE AND ENGINE COOLING,UNKNOWN OR OTHER

  WHILE DRIVING ENGINE CHECK LIGHT CAME ON. TOOK TO DEALER, AND THEY REPLACED OXYGEN SENSOR. IN MARCH OF 2001, PROBLEM REOCCURRED, AND DEALER REPLACED OXYGEN SENSOR AGAIN. ON SEPTEMBER 11, 2001, PROBLEM OCCURRED AGAIN, AND DEALER DID NOT HAVE A SOLUTION FOR PROBLEM. ON OCTOBER 22, 2001 PROBLEM REOCCURRED. A DEALER TOLD CONSUMER IT WAS OKAY TO DRIVE WITH ENGINE LIGHT ON. FINALLY, ON NOVEMBER 14, 200 ENGINE LIGHT CAME BACK ON. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK

• 11/22/2002· SERVICE BRAKES, AIR

  WHEN BRAKE APPLIED THEIRS A SHIMMY IN THE FRONT END OF THE VEHICLE. THE DEALERSHIP INDICATED THAT THIS IS A RESULT OF THE BRAKE ROTOR BEING OUT OF ROUND. CONSUMER HAD ROTOR REPLACED PROBLEM STILL OCCURS. PLEASE PROVIDE MORE DETAILS. TS

• 11/18/2002· VEHICLE SPEED CONTROL

  SPEEDOMETER STAYS AT BETWEEN 15 AND 20 MPH WHEN VEHICLE IS NOT IN MOTION. WHEN DRIVING AT ABOUT 25 MPH, GAUGE SAYS SPEED IS 75MPH. OTHER TIMES, GAUGE STAYS AT 0 AND VEHICLE IS IN MOTION. DT

• 11/15/2014· ELECTRICAL SYSTEM,ENGINE

  AFTER ACCELERATING OVER 35MPH VEHICLE CONTINUES TO ACCELERATE. VEHICLE ABLE TO STOP BUT YOU CAN STILL HEAR AND FEEL THE MOTOR TO CONTINUE TO ACCELERATE AND THE VEHICLE STARTS TO JERK AROUND. ITS VERY UNSAFE AND NO ONE AT THE CAR SHOP ABLE TO TELL ME EXACTLY WHAT IS WRONG. I'VE HAD SEVERAL THINGS FIXED AND STILL HAVING THE SAME PROBLEM. THE VEHICLE SOMETIMES AFTER STARTING UP WILL ACCELERATE ON IT OWN. *TR

• 11/15/2002· ENGINE AND ENGINE COOLING

  CAR STALLED NUMEROUS TIMES AT ANY SPEED, DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORAMATION. TS

• 11/14/2003· ENGINE AND ENGINE COOLING

  ENGINE HEAD GASKET FAILED PREMATURELY. DEALER REPAIRED, AND 8 MONTHS LATER THE PART FAILED AGAIN. *AK

• 11/13/2002· FUEL SYSTEM, OTHER

  CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE BOLTS THAT HOLD THE MOTOR MOUNTING FELT OUT WICH CAUSED THE BRACKET TO SHIFT AND CAUSE A WHOLE ON THE OIL PAN WICH CAUSE THE OIL TO COME OUT OF THE OIL PAN. DEALER WAS NOT CONTACTED TBUT THE VEHICLE WAS TAKING TO A PRIVATE MECHANIC. MR

• 11/13/2002· FUEL SYSTEM, OTHER,VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

  CAR WAS BEING DRIVEN ON HIGHWAY, ACCELERATED BEYOND DRIVER'S CONTROL, WITH BRAKES APPLIED DRIVER PUT CAR IN NEUTRAL, GUIDED CAR OFF ROAD AND SHUT OFF ENGINE. MECHANIC WHERE CAR WAS TOWED EXPLAINED THAT THE AIR FILTER COVER HAD BROKEN AND A PIECE FROM AIR FILTER COVER WAS SUCKED INTO AIR DUCT TO THROTTLE BODY CAUSING THROTTLE TO BE STUCK OPEN. CAR IS BIFUEL CNG. IS THIS IS A FACTOR IN AIR FILTER COVER CRACKING? IS THERE PARTS TRACKING FOR REPLACEMENT OF AIR FILTER COVERS AND IS IT KNOWN HOW MANY OF THOSE WENT TO BIFUEL CARS. WHY IS AIR FILTER COVER CRACKING? OR IS THERE A FIX TO PREVENT PIECES FROM LODGING IN THROTTLE? DT

• 11/12/2011· FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM

  THIS CAR WILL NOT START. AND WHEN IT DOES START IT BACK FIRES. I HAVE REPLACED THE STARTER, THE FLEX PLATE THE SENSORS, AND THE MUFFLER, AND NOTHING SEEMS TO WORK AND NO MECHANIC CAN TELL ME WHAT'S WRONG WITH. I EVEN WENT OUT AND BOUGHT A CAR CODE READER AND IT SAYS EMISSIONS BUT STILL NO LUCK. *TR

• 11/12/2010· AIR BAGSCrash

  MY DAUGHTER WAS DRIVING THE 2000 CAVALEIR FROM CHURCH TO HER COLLEGE WHEN SHE STOPPED AT A STOP SIGN AND LOOKED LEFT AND THEN RIGHT AND PROCEEDED THROUGH THE INTERSECTION AND FAILED TO SEE A CHRYSLER MINIVAN COMING FROM HER LEFT.. SHE BRAKED AND THE MINIVAN T-BONED HER CAR ON THE LEFT SIDE AND HER CAR PROCEEDED TO TURN 90 DEGREES TO THE RIGHT FOR 20 FEET AND STOPPED. THE MOST DAMAGE OCCURED ON THE PASSENGER DOOR, TO THE FRONT TIRE WAS PUSHED IN...THE WHOLE STEERING WHEEL ASSEMBLY WAS PUSHED FORWARD. THE FRONT PASSENGER WAS SEVERELY INJURED WITH SEVERE HEAD TRAUMA AND SKULL FRACTURE.SHE IS PRESENTLY IN A COMA. THE DRIVER OF THE VEHICLE HAD A CONCUSSION,SEVERE LACERATIONS ON THE BACK OF HER HEAD , AND BRUISING ON HER ARMS AND LEGS. THE THIRD PASSENGER IN THE REAR DRIVERS SIDE HAD MINOR INJURIES.

• 11/12/2004· ENGINE AND ENGINE COOLING

  CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD AND REMAINED. WHILE DRIVING AT ANY SPEED VEHICLE STALLED. CONSUMER RESTARTED VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION. *AK

• 11/09/2012· ELECTRICAL SYSTEM,EXTERIOR LIGHTING,VEHICLE SPEED CONTROL

  FIRST DRIVER SIDE REAR TURN SIGNAL BLINKED RAPIDLY, THEN BRAKE LIGHT AND TURN LIGHT CEASED TO WORK. WHEN CHECKED, THE LIGHT AND LENS WERE FUSED (MELTED) TOGETHER. AS WELL DRIVER SIDE WINDOW CEASED TO WORK. MECHANIC STATED ITS ELECTRICAL AND ADVISED I CHECK RECALLS.ALSO SOMETIMES GAS PEDAL ACCELERATES WITHOUT PRESSURE FROM ME. NO CRUISE CONTROL ENGAGED, NOT ABLE TO DETERMINE WHEN OR WHY...JUST OCCASIONALLY HAPPENS. *TR

• 11/08/2004· ENGINE AND ENGINE COOLING

  WHILE DRIVING AT ANY SPEED THE VEHICLE STALLS. *AK

• 11/07/2002· FUEL SYSTEM, OTHER

  FUEL SENDING UNIT FAIL WHILE DRIVING CAUSE THE VEHICLE STOP OPERATING DEALER NOTIFIED. TS

• 11/05/2003· SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL

  WHILE DRIVING AT SLOW A SPEED, THE VEHICLE LURCHED FORWARD AND IT FELT LIKE THE VEHICLE WAS REAR ENDED. THE DEALER REFUSED TO FIX THE VEHICLE AND STATED THE VEHICLE WAS SAFE TO DRIVE. *PH THE ABS SENSOR HAD BECOME INOPERATIVE. *SCC *JB

• 11/05/2002· ELECTRICAL SYSTEM

  BATTERY LEAKED ACID FROM POSITIVE POST DOWN INTO BATTERY BOX WHICH DRAINED INTO ENGINE COMPARTMENT AND ON TO THE ELECTRICAL HARNESS JUNCTION WHICH IS ROUTED UNDER THE BATTERY BOX. THERE IS NO DRAIN TUBE TO DRAIN ANY ACID OVERFLOW DOWN UNDER THE CAR. THE ACID BURNED THROUGH THE JUNCTION AND SHORTED OUT THE MAIN HARNESS TO ALL THE LIGHTING ON THE FRONT OF THE CAR. IF THIS HAD BEEN AT NIGHT I WOULD HAVE LOST MY HEADLIGHTS AND TURN SIGNALS. THERE IS MINOR DAMAGE TO TORQUE CONVERTER HOUSING AND MOTOR MOUNT. I'M WAITING NOW TO HEAR FROM THE DEALER AS TO WHEN THE CAR WILL BE RETURNED TO ME AFTER THE REPAIRS ARE DONE, AND SEE IF CHEVROLET WILL TAKE CARE OF THE REPAIRS. IT IS MY BELIEF THEY NEED TO INSTALL A DRAIN TUBE IN THE BATTERY BOX AND REROUTE THIS HARNESS AWAY FROM THIS AREA. I FEAR AS TO WHAT WOULD HAPPEN IF THIS HAD BEEN AT NIGHT AND I WAS DRIVING DOWN THE ROAD AT HIGHWAY SPEEDS. THIS BATTERY WAS THE ONE THAT CAME WITH THE CAR. *****DIMS 11 IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS*****769324. *AK *JB

• 11/03/2004· AIR BAGSCrash

  A DEER RAN IN FRONT OF THE CONSUMER WHILE DRIVING, CONSUMER WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND HIT A TREE. UPON IMPACT, BOTH FRONTAL AIRBAGS DID NOT DEPLOY. NO INJURIES REPORTED. VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY.*AK

• 11/03/2004· VISIBILITY,AIR BAGSCrash

  THE WINDSHIELD EXPLODED WHILE DRIVING. CONSUMER WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE AND CRASHED INTO A TREE. UPON IMPACT, BOTH FRONTAL AIR BAGS DID NOT DEPLOY. DRIVER AND PASSENGER SUSTAINED HEAD AND BACK INJURIES, AND WERE TRANSPORTED BY AMBULANCE TO A HOSPITAL. VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY. *AK

• 11/01/2003· STEERING,SUSPENSION,STRUCTURE,INTERIOR LIGHTING

  POPPING SOUND AND FEEL WHEN TURNING STEERING WHEEL HAS BEEN WORKED ON TWO TIMES FOR THIS PROBLEM; INTERIOR LIGHTS DO NOT TURN ON WHEN OPENING DRIVERS DOOR; TOP PORTION OF DASH IS SPLIT IN THE MIDDLE; MAKES LOTS OF CRACKLING NOISE, SOUNDS LIKE SOMETHING IS LOOSE WITH THE SUSPENSION. *LA

• 10/31/2007· ELECTRICAL SYSTEM

  I WAS DRIVEN HOME FROM WORK (100 MILES BOTH WAYS) 65MPH THEN IT STOPPED ACCELERATING PULLED OVER 2 MIN. LATER BACK ON THE ROAD 1 MILE LATER IT HAPPENED AGAIN. FORCED IT TO MAKE IT TO TOWN 1AM. LEFT IT AT A GAS STATION. CAME BACK IN THE MORNING TO TAKE IT BACK TO DEALER (45 MIN DRIVE) IT BROKE DOWN 6 TIMES!!! I'VE HAD IT 9 DAYS!!! DEALER SAID IT WASN'T HIS PROBLEM BUT BECAUSE MY 7 MONTH OLD BABY WAS W/ME HE CHANGED THE FUEL FILTER AND SENT ME AWAY. 45 MIN LATER I WAS BROKEN DOWN ON A HIGHWAY 1 HOUR IT STILL WOULDN'T START. A MAN PULLED UP CALLED THE DEALER AND TOLD HIM TO TOW IT BACK TO THE SHOP. NEXT DAY HE WORKS ON IT END OF DAY SAYS IT MUST BE ELECTRICAL. I GAVE HIM $4800 CASH!!!! I DON'T EVEN WANT THE CAR BACK!!! HE NEEDS TO GIVE ME MY MONEY CAUSE IT IS A LEMON. *TR

• 10/31/2001· UNKNOWN OR OTHER

  ENGINE CHECK LIGHT WOULD STAY UP TO TWO OR THREE DAYS AT A TIME. CONTACTED DEALER, AND DEALER STATED REASON FOR ENGINE CHECK LIGHT BEING ON WAS BECAUSE CONSUMER DID NOT DRIVE VEHICLE LONG ENOUGH.*AK

• 10/30/2003· POWER TRAIN

  NO 3RD AND 4TH GEAR IN 4 SPEED AUTOMATIC TRANSMISSION. 31,000 MILES ON CAR. *LA

• 10/29/2012· STEERING,SUSPENSION,STRUCTURE

  BROKEN K-MEMBER /477-03540. *TR

• 10/29/2008· ELECTRICAL SYSTEM

  TL*THE CONTACT OWNS A 2000 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WHEN THE KEY WAS INSERTED INTO THE IGNITION. SHE TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AND HAD THE STARTER REPLACED. IMMEDIATELY AFTER THE REPAIR, THE FAILURE RECURRED. SHE TOOK THE VEHICLE BACK TO THE REPAIR SHOP AND WAS ADVISED THAT AN ADD ON STARTER RELAY NEEDED TO BE INSTALLED IN HER VEHICLE. THE DEALER STATED THAT HER VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 04V036000 (ELECTRICAL SYSTEM:IGNITION:SWITCH); THEREFORE, THEY WOULD NOT ASSUME RESPONSIBILITY FOR THE REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 172,000.

• 10/28/2005· SERVICE BRAKES, HYDRAULIC

  DT: THE CONTACT STATED THE BACK PLATE FAILED ON THE REAR BRAKES. THE VEHICLE WAS IN NEUTRAL WITH THE EMERGENCY BRAKE ON AND THE BRAKE FAILED. UPON INSPECTION IT WAS DISCOVERED THE BACKER PLATE RUSTED OUT, RESULTING IN THE BRAKE FAILURE. THE PARKING BRAKE SYSTEM WAS A COMBINATION OF BOTH DISC AND DRUM BRAKES. THERE WAS NO WARNING PRIOR TO THE COMPLETE FAILURE OF THE BACK PLATE. THE BACK PLATE HAS NOT BEEN REPLACED AT THIS TIME. EARLIER THERE WAS A FAILURE OF THE ENTIRE VEHICLE BRAKING SYSTEM. ALL FOUR BRAKE ROTORS RUSTED, RESULTING IN TOTAL BRAKE FAILURE. THE WHEEL CYLINDER SEPARATED FROM THE CALIPERS. THE ONLY WARNING LIGHT CAME AFTER THE COMPLETE FAILURE OF THE LEFT ROTOR. THE ROTORS WERE REPLACED AND THE CALIPERS WERE REBUILT. THE BRAKE PADS HAD LESS THAN 50 % WEAR BUT THEY WERE REPLACED AS WELL. *AK

• 10/28/2004· VISIBILITY

  WINDSHIELD WIPER CAME ON AND OFF INTERMITTENTLY ON ITS OWN. CONSUMER CONTACTED THE DEALER ON MORE THAN ONE OCCASION, AND THE PROBLEM HAD NOT BEEN RESOLVED. *AK

• 10/26/2001· SERVICE BRAKES, HYDRAULIC

  FRONT ROTORS WARP AND CAUSE A GREAT AMOUNT OF VIBRATION AND LOSS OF CONTROL. THIS HAS HAPPENED 5 TIMES IN 21000 MILES. CHEVY CAN NOT FIX.*AK

• 10/25/2001· SUSPENSION,STRUCTURE

  CONSUMER HAS CONTACTED DEALERSHIP FOR VARIOUS SUSPENSION PROBLEMS, BUT WAS TOLD THAT CAVALIER CONVERTIBLE WAS NO LONGER BEING MANUFACTURED BECAUSE IT WILL BUCKLE AND WILL FALL APART.*AK CONSUMER STATED THAT WINDOWS, DOORS AND ROOF ARE MAKING NOISE.*SLC

• 10/23/2003· ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  HIGH BEAMS & DRL'S STOPPED WORKING, CHECKED FUSES, NONE BLOWN. TOOK TO DEALER AND FOUND THAT BATTERY THAT HAD BEEN PREVIOUSLY REPLACED FOR LEAKING, WAS AGAIN LEAKING. THE ACID DAMAGED HEADLIGHT WIRE HARNESS MAKING DRL'S AND HIGH BEAMS NON-FUNCTIONAL. DEALER SAYS BATTERY HAS NO WARRANTY EVEN THOUGH BATTERY STATES 5 YEAR WARRANTY. *LA

• 10/23/2002· STRUCTURE

  WHEN IT RAINED OR IF THE VEHICLE WAS TAKEN TO A CAR WASH, WATER LEAKED INSIDE THE VEHICLE, THE VEHICLE WAS SERVICED FOR THE PROBLEM ON 5 OCCASIONS AND THE PROBLEM WAS UNRESOLVED, CONSUMER PURCHASED A 2001 MODEL AND ALSO EXPERIENCED THE SAME PROBLEM WITH THAT VEHICLE.*JB

• 10/20/2004· VISIBILITY

  WHILE DRIVING IN INCLEMENT WEATHER THE WINDSHIELD WIPER WOULD COME ON AND GO OFF ON THEIR OWN. THE CONSUMER WAS ABLE TO DRIVE TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE WINDSHIELD WIPER MOTOR NEEDED TO BE REPLACED.. PLEASE FILL IN ADDITIONAL INFORMATION. *JB

• 10/18/2004· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM

  LOW TRACK LIGHT CAME ON WHEN THE VEHICLE WAS ACCELERATED OR WHEN THE GEAR WAS PLACED IN REVERSE. *BF IN ORDER FOR THE LIGHT TO GO OUT, THE CONSUMER HAD TO TAKE HIS FOOT OFF THE ACCELERATOR, SOMETIMES THE ENGINE SHUT OFF BY ITSELF. THE CONSUMER STATED THE DEALER FIXED THE PROBLEM IN THE BEGININING, HOWEVER THE PROBLEM RETURNED. THE VALVE COVER GASKET LEAKED.