1997 Ford Ranger

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/31/2012· FUEL/PROPULSION SYSTEM

  PLASTIC FUEL LINE SPLIT AT THE INPUT OF THE FUEL FILTER THAT IS LOCATED BEHIND THE ENGINE ATTACHED TO THE VEHICLE FRAME. WHEN THE IGNITION IS TURNED ON GASOLINE SPRAYS FROM THIS CRACK PIECE OF PLASTIC LINE. THIS IS DUE TO THE FACT THAT THE FUEL PUMP IS ELECTRIC AND ENERGIZES ANYTIME THE IGNITION IS ON THE PUMP IS LOCATED IN THE GAS TANK AT THE REAR OF THE TRUCK . THIS IS POTENTIALLY VERY DANGEROUS AS THE SPRAYING GASOLINE COULD EASILY HIT THE CATALYTIC CONVERTER OR EXHAUST SYSTEM WHEN THE VEHICLE IS IN MOTION. FORTUNATELY I NOTICED THE LEAK UNDER THE VEHICLE WHEN I WAS WARMING UP THE CAR ON AS COOL MORNING. AS A RESULT NO REAL DAMAGE WAS DONE. WILL COST ABOUT $350 TO REPAIR. *TR

• 12/30/2010· SEATS

  I WAS LEAVING THE PARKING LOT OF THE GROCERY STORE I HAD BEEN SHOPPING AT, AND THE DRIVERS SIDE RECLINING SEAT LATCH ASSEMBLY THAT CONTROLS THE ANGLE OF, AND LOCKS THE BACK OF THE SEAT INTO POSITION, GAVE WAY AND THE BACK OF THE SEAT COLLAPSED BACKWARDS CAUSING ME TO GO BACKWARDS AS WELL. FORTUNATELY I WAS ABLE TO STOP MY VEHICLE WITHOUT CAUSING A COLLISION OR INJURY. THE VEHICLE IS NOW AT HOME, AND WITH INTERNET RESEARCH IT SEEMS THAT THE RECLINING SEAT LATCH ASSEMBLY HAS BEEN A WEAK POINT WITH FORD RANGER TRUCKS AND FORD EXPLORER SUV VEHICLES FOR YEARS. THE FORD DEALER/SERVICE CENTER THAT I DO BUSINESS WITH, NOW TELLS ME THAT THE REPLACEMENT PART IS OBSOLETE AND THEY WILL HAVE TO CONTACT VARIOUS DEALERS STILL LISTING IT IN THEIR INVENTORY TO SEE IF THEY CAN GET THE PART, AS THE PARTS SUPPLIER FOR FORD THAT MADE THE REPLACEMENT LATCHES WENT OUT OF BUSINESS DURING THE BAD ECONOMY. I'M AMAZED THAT A RECALL HAS NOT BEEN ISSUED, GIVEN THE POTENTIAL FOR GREAT HARM AND POSSIBLE INJURY OR DEATH FROM THE FAILURE OF THIS COMPONENT.

• 12/30/2000· POWER TRAIN,EXTERIOR LIGHTING,VISIBILITY,INTERIOR LIGHTING

  DOME LIGHT STAYS ON AFTER STARTED AND DOOR CLOSED AND DOES NOT GO OFF. PROBLEM SEEING AT NIGHT... NO WAY TO TURN OFF WITHOUT REMOVING THE BULBS. WINDSHIELD WIPERS DO NOT START WHEN TURNED ON THE DO NOT GO OFF WHEN SWITCHED OFF. HAVE TO TURN THE WIPERS ON THEN OFF AGAIN. SHIFT KNOB COMES OFF WHEN PULLING SHIFT LEVER FROM 1ST TO 2ND AND 3RD TO 4TH. MAKES SHIFTING DIFFICULT WHILE STARTING UP A HILL AND MERGING ON THE FREEWAY BECAUSE THE KNOB SLIPS OFF COMPLETELY AND THE SHIFTER ENDS UP IN THE NEUTRAL POSITION. *AK

• 12/29/1999· SEATS

  I ENTERED THE VEHICLE AND SAT IN THE DRIVERS SEAT. AS I WAS ABOUT TO DRIVE, THE SEATBACK COLLAPSED INTO THE REAR, AND WOULD NOT RELATCHED I HAVE AN EXTENDED CAP SO THE SEAT FELL ALL THE WAY BACK TO THE REAR FLOOR AND WOULD NOT STAY UPRIGHT. I TOOK IT TO THE DEALER AND THEY STATED THE FRAME OF THE SEAT BROKE AND THAT I NEED A NEW SEAT. I AM WAITING FOR AN ESTIMATED COST FROM THEM. THEY ALSO STATE THIS IS NOT COVERED BY THE EXTNDED WARRANTY. I AM UNABLE TO DRIVE THE VEHICLE UNTIL THIS IS FIXED. I ONLY WEIGHT 170 LBS SO I DONT GIVE THE SEAT ANY UNUSUAL AMOUNT OF STRESS. *AK

• 12/29/1998· POWER TRAIN,ELECTRICAL SYSTEM

  VEHICLE EXPERIENCED ELECTRICAL PROBLEMS WHICH WILL SHORT CIRCUIT. WHILE THE VEHICLE WAS AT THE DEALER, THE TRANSMISSION FELL OUT. PLEASE PROVIDE FURTHER INFORMATION. *AK

• 12/28/2012· SEAT BELTS

  UNDER HARD BRAKING TO AVOID AN ACCIDENT THE SEAT BELT DISENGAGED FROM THE BUCKLE. I HAVE BEEN DEALING WITH THE SEAT BELT BUCKLE NOT "BUCKLING" WITH THE SEAT BELT FOR YEARS. LOOKING ONLINE I SEE NUMEROUS PEOPLE COMPLAINING OF THE SAME PROBLEM. COMPLAINTS OF A SPRING IS MISSING OR BROKEN, COINS ARE STUCK DOWN INSIDE THE MECHANISM, ETC. THIS IS A DEFECTIVE DESIGN! I CAN ONLY WONDER HOW MANY INJURIES OR DEATHS HAVE OCCURRED FROM SEAT BELT BUCKLE FAILURE. EVERY DAY I GET IN MY TRUCK I HAVE TO WIGGLE THE BELT BACK AND FORTH TO GET IT TO ENGAGE. SOMETIMES I JUST CHECK AFTER IT HAS ALREADY ENGAGED AND IT COMES LOOSE. THE DEALER SOLUTION IS TO PAY THEM FOR A "REPLACEMENT" ITEM, THE COST OF WHICH IS AROUND $250-300... I'LL BE PURCHASING A REPLACEMENT. THE ONLY PROBLEM IS THAT THE REPLACEMENT IS OF THE SAME DESIGN. I'M ASKING FOR HELP TO REMEDY A LIFE THREATENING SITUATION. *TR

• 12/27/2001· SERVICE BRAKES, HYDRAULIC,POWER TRAIN,VISIBILITY,UNKNOWN OR OTHER

  REAR BRAKES PULLED, SERVICED, REPORTED UNVERIFIABLE, BEGAN LOCKING UP IN SHORT BURSTS WHEN STOPPING, REPORTED, FOUND FAULTY , REPLACED COMPLETE REAR ASSEMBLY. WINDSHIELD CRACKED ACROSS CENTER WHILE DRIVING FREEWAY AT 65 MPH, STARTED AT TOP STRIP PASSENGER SIDE SPREADING ACROSS TO DRIVERS SIDE IN JUST MINUTES. DOOR AJAR SWITCHES FAILED CAUSING DOME LIGHT TO REMAIN ON MAKING NIGHT TIME VISIBILITY IMPOSIBLE. TRANSMISSION BEGAN SHIFTING ROUGH IN SECOND GEAR HARD TO DOWNSHIFT, VERIFIED, REPAIRED BEARINGS IN SHIFTER. REOCCURED A FEW MONTHS LATER, SERVICE CLAIMED UNVERIFIABLE, WORSENED STUCK IN FOURTH GEAR IN TRAFFIC, HAD TO BE PUSHED TO SHOULDER , AND DISENGAGED. FOUND TO BE FAULTY, AND TRANSMISSION WAS REBUILT ,NO NOTICABLE CORRECTION , RETURNED TO SERVICE, CLAIMED UNVERIFIABLE, CONTACTED FORD MOTOR COMPANY CORPORAT OFFICE, ADVISED TO GO TO DIFERENT DEALERSHIP , WHILE INVESTIGATED INTERNALLY. DID SO, DEALER REPORTS UNVERIFIABLE, DROVE WITH SUPERVISOR OF SERVICE DEPT, WAS THEN VERIFIED, AND ORDERED REBUILT FOR 2ND TIME.EPAIR, SAME TIME AS EXTENDED WARRANTY TOOK EFFECT, REPAIRS DONE, NO NOTICABLE DIFFERENCE, IN FACT NOW WORSE, ALL GEARS NOW EFFECTED.AND AT TIMES, DIFFICULT TO SHIFT. CONTACTED FORD MOTOR CORPORATION ONCE MORE, IN EFFORT TO GET HELP WITH EXTENSIVE RENTAL CAR COSTS WHILE VEHICLE BEING SERVICED, WAS TOLD NOW THAT TWO INCIDENCES WERE IN NO WAY RELATED NOW THAT EXTENDED WARRANTY WAS IN EFFECT TOO MUCH TIME PASSED, THOUGH EVEN ONLY LESS VTHAN 1000 MILES, IS STILL UNREPAIRED TODAY. *AK

• 12/26/2008· FUEL SYSTEM, GASOLINE

  TL*THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT BOTH THE INNER AND OUTER HOSES CRACKED AND CAUSED A SIGNIFICANT AMOUNT OF FUEL TO SPILL OUT FROM THE TOP OF THE FUEL TANK WHEN IT IS FILLED. THE DEALER WAS NOTIFIED AND THEY STATED THAT IT WOULD COST $600 TO REPAIR. THE MANUFACTURER STATED THAT THEY COULD NOT ASSIST WITH THE REPAIRS BECAUSE THE VEHICLE WAS NOT UNDER WARRANTY. THE FAILURE MILEAGE WAS 139,609 AND CURRENT MILEAGE WAS 139,839. UPDATED 2/9/09 *CN THE DEALER REPLACED THE FULE FILTER. UPDATED 02/13/09. *JB UPDATED 07/20/09 *BF UPDATED ADDRESS. 07/21/09. *JB

• 12/26/2004· POWER TRAIN

  THIS TRUCK ACCERLERATES BY ITSELF, IT USED TO ONLY BE BETWEEN 2ND AND 3RD GEARS BUT NOW I CAN BE ON THE FREEWAY AND IN 4TH GEAR WHEN I CAN FEEL THE PEDAL GO DOWN TO THE FLOOR, I'M FORCED TO PUT IT IN NUETRAL UNTIL THE RPMS GO DOWN, TRYING TO GET IT INTO ANOTHER GEAR ONLY GRINDS BECAUSE ITS RUNNING TOO HIGH. THIS IS A SAFETY ISSUE, IF IT HAPPENS AT THE WRONG TIME SOMEONE COULD GET HURT OR THE ENGINE WILL JUST BLOW UP! *AK

• 12/26/2003· SUSPENSION,ELECTRICAL SYSTEM,INTERIOR LIGHTING,EQUIPMENT

  A FEW THINGS HERE, ENGINE LIGHT COMES ON AND GOES OFF AT RANDOM. HAD IT CHECKED A FEW TIMES. NO PROBLEMS FOUND. DOME LIGHT/DOOR CHIME WILL NOT GO OFF WHEN DOOR IS SHUT AND/OR CAR IS TURNED ON. LEFT HAND BLINKER WENT NUTS A FEW TIME, BASICLY IT WAS BLINKING AT A VERY HIGH RATE OF SPEED. A FEW SECOND 'POWER LOSS' HAPPEND A FEW TIMES WHILE DRIVING, LOST POWER TO RAIDO, AND LIGHTS. THE REAR END BOUNCES WAY TOO MUCH WHEN I HIT A BUMP, CAN CAUSE LOSS OF CONTROL AT HIGHWAY SPEEDS. *AK

• 12/18/2006· FUEL SYSTEM, GASOLINE

  TL*- THE FUEL LEAKS WHEN THE VEHICLE IS COMPLETELY REFUELED. THE PROBLEM STEMS FROM THE FUEL FILLER ASSEMBLY. THE DEALER SAID THAT THE PARTS FOR THE VEHICLE WERE NOT AVAILABLE. THE CONTACT WAS TOLD HE NEEDED TO BRING THE VEHICLE IN TO BE LOOKED AT, AND WOULD BE CHARGED AN $80 FEE. THE CONTACT FEELS THAT THIS A SAFETY ISSUE AND THAT THE $80 FEE IS APPROPRIATE.

• 12/17/2002· EQUIPMENT

  FILED COMPLAINT BEFORE, YOU ALL SAID IT WASN'T SAFTY RELATED.IT SURE IS WHEN FORD MAKES PARTS OUT OF THIN PLASTIC/OR PUT IN WRONG PLEUM CHAMBER.THE BLEND DOOR WON'T OPERATE AND BREAKS ON SO MANY EXPLORER/RANGER.YOU CAN'T EVEN DEFROST YOUR WINDOWS IN THE RAIN OR IN THE MORNING.DO THEY HAVE TO WAIT FOR SOMEONE TO GET HURT/KILLED FOR SOMEONE TO CARE.

• 12/17/2001· AIR BAGSCrash

  WHILE TRAVELING APPROXIMATELY 55 TO 60 MPH VEHICLE WAS STRUCK ON THE SIDE BY ANOTHER VEHICLE CHANGING LANES AND TRAVELING IN SAME DIRECTION. THIS IMPACT CAUSED DRIVER'S SIDE AIR BAG TO DEPLOY. DRIVER RECEIVED SEVERE FACIAL INJURIES AND BURNS. NO DETERMINATION HAS BEEN MADE AS TO WHY THE DRIVER'S AIR BAG DEPLOYED DURING A NON-FRONTAL CRASH. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION.*AK

• 12/16/2003· FUEL SYSTEM, OTHER,ELECTRICAL SYSTEM,EQUIPMENT

  THE LOCATION AND CONNECTION OF THE FACTORY ALARM SYSTEM CAUSED THE RELAY SWITCH UNDER THE DASH TO OVERHEAT AND THE BATTERY DRAINED EVEN WHEN THE VEHICLE WAS TURNED OFF.*JB ELECTRICAL SYSTEM ON 1997 FORD RANGER IS MALFUNCTIONING. ABS SYSTEM LIGHTS ILLUMINATES WHEN THE EMERGENCY BRAKE IS ENGAGED. THE FUEL GAUGE IS INOPERATIVE, RELAYS UNDER THE DASHBOARD STARTED HEATING UP. CONSUMER CONCERED THAT AIR BAGS MAY FAIL IF VEHICLE IS INVOLVED IN AN ACCIDENT.*MR

• 12/14/2009· FUEL SYSTEM, GASOLINE

  FUEL FILLER HOSE CRACKS PREMATURELY AT THE CONNECTION TO THE TOP OF THE FUEL TANK RESULTING IN SIGNIFICANT FUEL SPILLAGE DURING REFUELING AS WELL AS PROBABLY SPLASHING OUT DURING DRIVING. FUEL VAPORS SURELY ESCAPE ALL THE TIME AS WELL. BOTH SITUATIONS LEAD TO A SERIOUS FIRE HAZARD. SEEMS TO BE A WIDESPREAD SAFETY ISSUE BASED ON THE AMOUNT OF FORD RANGERS WITH SAFETY COMPLAINTS LISTED ON THIS SITE AS WELL AS DISCUSSIONS ON VARIOUS FORD RANGER FORUMS. THE OEM FORD PART LISTS FOR ~$400. *TR

• 12/12/2007· TIRES

  TL*THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT PURCHASED NEW GOODYEAR MOHAVE R/S (NA), SIZE P215/70R/14 TIRES IN OCTOBER OF 2005. WHEN THE VEHICLE WAS TAKEN TO THE SHOP FOR MAINTENANCE IN MAY OF 2007, THE MECHANIC STATED THAT THE TREAD WAS SEPARATING AND THE TIRES NEEDED TO BE REPLACED. THE CONTACT RECEIVED A NOTICE THAT OFFERED HER REPLACEMENT TIRES, IF THEY QUALIFIED. SHE CALLED THE MANUFACTURER AND THEY STATED THAT THEY WOULD CALL HER BACK. THE VEHICLE WAS RARELY DRIVEN AND THE CONTACT FELT THAT THE TIRES SHOULD NOT HAVE FAILED. THE FAILURE MILEAGE AND DOT NUMBER WERE UNKNOWN. THE CURRENT MILEAGE WAS 93,697.

• 12/10/2001· STRUCTURE

  I FIXED THIS ONCE WITH GLUE AND REPLACED. THE ACTUATOR BROKE THE DOOR AGAIN. THIS CAN BE A SERIOUS SAFETY PROBLEM CONSIDERING IF WILL MAKE WINDOW DEFROSTER NON FUNCTIONAL. *AK

• 12/06/2000· TIRES

  THESE WERE ORIGINAL EQUIPMENT TIRES AND, AFTER ABOUT 30000 MILES, I NOTICED THE TRUCK LURCHED UPON TAKE-OFF FROM EITHER A STOP OR SLOW SPEED, AS WELL AS A WORMING MOTION GOING AROUND CORNERS. THE DEALERSHIP ASSURED ME THIS ALL WAS NORMAL. I GOT A FLAT (THE FRONT LEFT) WHILE HUNTING AND, UPON TAKING IT TO LES SCHWAB FOR PROPER REPAIR, WAS TOLD THE TREAD HAD SEPARATED. THE PLUG WAS STATED TO HAVE BEEN THE CAUSE OF THE SEPARATION. I THEN PURCHASED FOUR NEW TIRES. SINCE THESE TIRES HAVE BEEN ON MY TRUCK, THE "NORMAL" LURCH IS GONE. I HAVE BEEN TOLD BY OTHERS THAT TREAD SEPARATION CAN CAUSE A LURCH THE SAME AS WHAT I WAS EXPERIENCING. THESE WILDERNESS AT TIRES WERE NOT PART OF THE RECALL. I DO NOT HAVE THE DOT NUMBERS OF THE TIRES, THOUGH I AM SURE THE DEALERSHIP OR FORD WOULD HAVE THEM ON RECORD. I DO NOT KNOW IF LES SCHWAB WOULD STILL HAVE THE TIRES THAT I HAD REPLACED.*AK( DOT NUMBER: TIRE SIZE: P265/75R15 )

• 12/04/2002· SERVICE BRAKES, HYDRAULICCrash

  CONSUMER STATED THAT WHEN APPLYING THE BRAKE THE BRACKET SNAP CAUSING A VEHICLE ACCIDENT. DEALER NOTIFIED. TS

• 12/04/1997· SUSPENSION

  WHENEVER DRIVING OVER A BUMP, SUCH AS REPAIRED POTHOLE OR BEFORE A BRIDGE, REAR SUSPENSION JUMPS JUMPS TO THE SIDE AND GETS OUT OF CONTROL. *AK

• 11/29/2006· SEAT BELTS

  DT*: THE CONTACT STATED THE DRIVER'S SEAT BELT BUCKLE BECAME DISENGAGED ON A FREQUENT BASIS. THE CONTACT CHECKED FOR DEBRIS AND DIRT IN THE BUCKLE AND STATED THERE WAS NONE. THE SERVICE DEALER DETERMINED THE CONTACT WOULD NEED TO BUY A NEW SEAT BELT, WHICH WERE NOT AVAILABLE FOR PURCHASE. THE CONSUMER STATED THE PRESSURE SPRING ASSEMBLT BECOMES WEAK OVER A PERIOD OF TIME. UPDATED 12/28/06. *JB

• 11/27/1999· VISIBILITY

  WIPER OPERATION ERRATIC. OPERATE BY THEMSELVES, OR WILL NOT OPERATED WHEN TURNED ON.

• 11/27/1999· SERVICE BRAKES, HYDRAULIC

  BRAKES GRAB AFTER TRUCK HAS SET DURING MOIST CONDIATIONS

• 11/26/2009· VEHICLE SPEED CONTROL

  I AM WRITING TO COMPLAIN ABOUT NOT HAVING MY VEHICLE SERVICE, AND I RECEIVED A RECALL LETTER. I WENT TO THE LEONARDTOWN DEALERSHIP ON WEDNESDAY, NOVEMBER 23, 2009, WITH MY LETTER FOR RECALL, AND WAS GIVEN INSTRUCTIONS ON HOW TO DISCONNECT THE SPEED DEACTIVATION SWITCH. I EXPLAINED TO THE SERVICE ADVISOR MR. JOHN JARBOE THAT MY VEHICLE HAS BEEN LEAKING BRAKE FLUID, BRAKE LIGHTS HAVE BEEN COMING ON AND I WANTED TO KNOW IF THIS DEFECTIVE SWITCH HAD ANYTHING TO DO WITH IT. HE SHOWED ME A DIAGRAM OF THE SWITCH, WHERE IT IS LOCATED NEAR THE MASTER CYLINDER AND TOLD ME THAT I CAN DISCONNECT IT MYSELF, AND IF I WANTED TO HAVE THE VEHICLE TOWED IN THEY WOULD LOOK AT THE OTHER PROBLEM. I THOUGHT FORD IS RESPONSIBLE FOR DOING THIS REPAIR NOT ME. I CAN'T DRIVE THE VEHICLE BECAUSE IT IS LEAKING BRAKE FLUID. I WAS TOLD THAT I CAN HAVE IT TOWED IN AND THEY WOULD LOOK AT THE PROBLEM. I AM NO SURE IF THIS SWITCH IS THE PROBLEM, BUT EVEN IF IT ISN'T ARE THEY SUPPOSED TO DEACTIVATE THE SWITCH NOT ME. I AM NOT A MECHANIC. *TR

• 11/26/1997· SEAT BELTS

  REAR SEAT BELTS FAILED TO RESTRAIN CHILDREN FROM INJURIES . EVERY STOP OR TURN CAUSED CHILDREN TO SLIDE SIDEWAYS, CAUSING THEM TO CRASH AGAINST FRONT PASSENERS SEATS AND THEN BOUNCE OFF AND HIT REAR WINDOW.

• 11/25/2002· SUSPENSION

  CONSUMER STATED THAT WHILE DRIVING AT ANY SPEED AND WITHOUT WARNING THE FUEL PUMP FAILED CAUSING A DISTRACTION TO THE CONSUMER. DEALER NOTIFIED. TS

• 11/24/2009· SERVICE BRAKES, HYDRAULIC,PARKING BRAKE

  SUDDEN BRAKE FAILURE --TWO INSTANCES FIRST IN SEPT 2009 AND TODAY --SEVERE CORROSION ON REAR BRAKE LINES AND LOSE OF BRAKE FLUID AND NO BRAKES ---NEED TO CHECK ALL 1997 FORD RANGERS XLT FOR SIMILAR PROBLEMS AS CAN RESULT IN A CRASH. I HAVE HAD REPAIRS MADE AS AFRAID OF REPEAT ALSO NOTICE CORROSION AT FRONT BRAKE LINES. *TR

• 11/23/2015· VEHICLE SPEED CONTROLFire

  TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT THE SPEED CONTROL SWITCH MELTED. THE CONTACT STATED THAT HE HAD NOT EXPERIENCED A FAILURE PRIOR TO THE VEHICLE BEING REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

• 11/23/2002· POWER TRAIN

  NO SUMMARY. DT

• 11/22/2006· FUEL SYSTEM, GASOLINE

  1997 FORD RANGER. WHENEVER I FILL UP WITH GAS, IT LEAKS OUT THE VENT OR THE FILLER TUBE. NOT EXACTLY SURE YET. IF I PUSH THE FUEL NOZZLE ALL THE WAY IN THE FILLER I CAN GET ALMOST A FULL TANK BEFORE IT LEAKS OUT THE BOTTOM. IF I JUST INSTALL THE FILLER HOSE AND LET IT FILL AUTOMATICALLY IT WILL START LEAKING ALMOST IMMEDIATELY. *NM

• 11/22/2003· TIRES

  AT 50,379 MILES, THE LEFT FRONT TIRE DELAMINATED (IE, THE ENTIRE TREAD CAME OFF THE TIRE IN ONE PIECE) WHILE TRAVELING ON THE FREEWAY. THERE WAS NO ACCIDENT OR INJURIES. IT, AND THE OTHER THREE, ARE OE FIRESTONE WILDERNESS AT P265/75R15 112S M+S TIRES WHICH WERE MOUNTED ON THE TRUCK WHEN PURCHASED NEW IN JULY 1997. *LA

• 11/21/2011· VEHICLE SPEED CONTROL

  TODAY MY ACCELERATOR FAILED. I WAS SITTING AT A RED LIGHT. I WENT TO ACCELERATE BY PUSHING ON THE ACCELERATOR PEDAL WITH MY RIGHT FOOT. THERE WAS NO ACCELERATION. THE ACCELERATOR PEDAL HAD FAILED. FURTHER INVESTIGATION REVEALED THREE SPOT WELDS THAT HELD A PLATE TO THE FIREWALL HAD FAILED. THE ACCELERATOR PEDAL PIVOTS ON THIS PLATE AND ATTACHED BOLT. I WAS ABLE TO DO A TEMPORARY REPAIR TODAY. BUT, THE FAILURE IN TRAFFIC WAS VERY DANGEROUS. *TR

• 11/20/2000· SERVICE BRAKES, HYDRAULICCrash

  REAR BRAKES GRABBED CAUSING A LOSS OF CONTROL ON DAMP ROAD. VEHICAL WAS INSPECTED MAY 2000. GOOD BRAKE LINNING FRONT AND REAR. *AK

• 11/19/2001· SUSPENSION,STRUCTURE

  WHEN DRIVING MY RANGER IF I HIT A SMALL BUMP OR POTHOLE THE TRUCK BECOMES VERY DANGEROUS TO OPERATE. THE VEHICLE WANTS TO JUMP UNCONTROLLABLY FROM LANE TO LANE POSING DANGER TO MYSELF OR OTHER DRIVERS ON THE ROAD. RECENTLY I NOTICED A SMALL HAIRLINE CRACK IN THE ROOF OF THE CAB ABOVE THE DRIVERS SIDE AND THE FRONT PASSENGER PANEL PROTRUDES AWAY FROM THE VEHICLE. THIS TELLS ME SOMETHINGIS SERIOUSLY WRONG AND THE VEHICLE IS UNSAFE TO BE ON THE ROAD.NOT ONLY IS THE TRUCK A HAZARD BECAUSE OF THE UNSTABLENESS OF OPERATION NOW IT HAS A STRESS PROBLEM AS WELL AND IF IN AN ACCIDENT I WONDER IF THE THE STRUCTURE WOULD HOLD UP AS IT WAS DESIGNED TO DO. I HAVE SINCE PURCHASED ANOTHER VEHICLE AND BECAUSE OF THE SAFETY HAZARD AM REFRAINING FROM OPERATING THIS VEHICLE UNTIL A LATER DATE. I HOPE SOMETHING IS DONE BEFORE SOMEONE IS SERIOUSLY INJURED. *AK

• 11/18/1998· STEERINGCrash

  BROTHER WAS DRIVING AT APPROXIMATELY 30 MPH WHEN HE LOST POWER STEERING.- THE STEERING WHEEL WOULD JUST TURN AROUND AND AROUND, CAUSING HIM TO HIT A BANK OF DIRT ON THE SIDE OF THE ROAD. *AK

• 11/18/1997· POWER TRAIN

  WHILE THE KEY IS OUT OF THE IGNITION, THE DEFECTIVE MANUAL TRANSMISSION MALFUNCTIONED, THE VEHICLE ROLLED AWAY WHICH ALMOST CAUSED AN ACCIDENT. *AK

• 11/16/1999· VEHICLE SPEED CONTROL

  WHEN AIR CONDITIONER/HEATER OR DEFROSTER IS ON, AND WHILE DRIVING AT DIFFERENT SPEEDS, IF DRIVER LETS UP THE ACCELERATOR, VEHICLE WILL NOT SLOW DOWN. IT TAKES ABOUT 30-40 SECONDS BEFORE IT ACTUALLY SLOWS DOWN. DLR/ MANUFACTURER CANNOT FIX DEFECT. *AK

• 11/14/2008· STRUCTURE

  RE: 1997 FORD RANGER. THE PEDAL MOUNT BRACKET (MOULDED ALUMINUM) FRACTURED, CAUSING THE COMPLETE FAILURE OF THE CLUTCH AND PARTIAL FAILURE OF THE BRAKE. THIS IS A PART THAT SHOULD NEVER, EVER, EVER FAIL IN NORMAL OPERATION. *TR

• 11/14/2000· VISIBILITY

  THE WINDSHIELD WIPER AND FLUID TURNS ON BY ITSELF. DOES NOT SEEM TO BE ASSOCIATED WITH ANYTHING, JUST COMES ON FREQUENTLY.*AK

• 11/14/1998· POWER TRAIN,VISIBILITY,UNKNOWN OR OTHER

  NO SUMMARY PROVIDED BY THE CONSUMER( DOT NUMBER: TIRE SIZE: P225/75R14 )

• 11/14/1997· AIR BAGSCrash

  VEHICLE COLLIDED WITH DEER, AIR BAG BURNED ARM OF OCCUPANT AND FILLED VEHICLE WITH SMOKE.

• 11/13/1997· POWER TRAIN,VEHICLE SPEED CONTROL

  WHILE TRAVLING ON THE HIGHWAY THE VEHICLE SHIFTS GEARS FROM 4TH TO 3RD. CONSUMER ALSO NOTICED THE RMP IDLES HIGH. PLEASE PROVIDE FURTHER DETAILS. *AK

• 11/12/2005· FUEL SYSTEM, GASOLINE

  1997 FORD RANGER REEKS FUEL DURING FILLING AT PUMP. STOPS WHEN FILLING STOPS. CHECKED FUEL FILL LINE AND TANK, FOUND LARGE CRACK IN FILL LINE ABOVE HOSE CLAMP. TANK AND LINE HAVE NEVER BEEN REMOVED BEFORE. THIS TYPE OF HOSE SHOULDN'T BE SPLITTING. CONTACTED SEVERAL AUTO STORES ONLY AVAILABLE AT DEALER. COST $200+ IN MY AREA. *JB

• 11/09/2005· VEHICLE SPEED CONTROL

  DT: THE CONTACT STATED THE ACCELERATOR PEDAL FRAME FELL OFF FROM THE WALL. ONE COULD SEE WHERE THE RIVET HOLES WERE, THEY HAVE SEPARATED FROM THE WALL. IT WAS A CLEAN BREAK, BUT THE RIVETS WERE DEFECTIVE. THERE WAS NO RUST ON THE FRAME. THERE WAS NO PRIOR WARNING. HE CONTACTED THE DEALER;THEY OFFERED NO FREE REMEDY.*AK UPDATED 11/29/2005 - *NM

• 11/09/1999· SERVICE BRAKES, HYDRAULIC

  WHILE DRIVING AND APPLYING THE BRAKES, PEDAL WENT ALL THE WAY TO THE FLOOR, RESULTING IN EXTENDED STOPPING DISTANCE. ALSO, FRONT LEFT BRAKE ROTOR CRACKED, CAUSING BRAKES TO PULSATE. *AK

• 11/08/2006· FUEL SYSTEM, GASOLINE

  DT*: THE CONTACT STATED WHILE PARKED IN THE DRIVEWAY A PUDDLE OF GAS WAS NOTICED UNDER THE VEHICLE AND AN ODOR OF GAS WAS PRESENT INSIDE THE VEHICLE. IT WAS DRIVEN TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THE FILLER PIPE WAS CRACKED AND NEEDED TO BE REPLACED. THE DEALER WAS ALERTED.

• 11/08/2002· VISIBILITY

  NO SUMMARY. DT

• 11/07/2011· SUSPENSION

  DRIVING DOWN ROAD REAR SPRING BROKE ANOTHER TIME SPAR TIRE CAME OF ALMOST CAUSING CRASH ,HAVE REPAIRED BOTH REAR SPRING BRACKETS ,TWO FRONT SUSPENSION , LOST SPARE AND FRAME ABOUT TO BRAKE AWAY . WHAT SHOULD I DO . HAVE LOT OF MONEY INVESTED . *TR

• 11/06/2018· UNKNOWN OR OTHER

  BELT SEPARATION ON 2 TIRES IN ONE MONTH TIME SPAN. FUSION TOURING 195 70R14 91T. THESE TIRES HAVE 8/32 TREAD REMAINING. FAILURES WERE FRONT RIGHT, THEN LEFT READ ONE MONTH LATER. CAUSED DIFFICULTY STEERING AS THE CAR WAS ALL OVER THE ROAD PLUS BUMPY RIDE. THE TIRES ARE VISIBLY BULGING BALOON. I FELT TIRE TEMP WITH MY HAND. UNIFORMLY WARM EXCEPT AT THE BULGE WHERE IT WAS SO HOT AS TO BURN MY HAND. WOULD NTSB LIKE ME TO SAVE A TIRE FOR EVALUATION? THIS SECOND TIRE FAILURE OCCURRED AT 70 MPH ON I-94 IN MICHIGAN WHEN A SUDDEN VIBRATION OCCURRED AND I OBSERVED THE LEFT REAR FENDER BOUNCING UP AND DOWN. I STOPPED TO INVESTIGATE AND FOUND THE BULGE AND HOT SPOT.

• 11/06/2000· TIRES

  THE CONSUMER REPLACED ALL FOUR FIRESTONE P225/70 R14 98R TIRES ON THE VEHICLE DUE TO TREAD SEPARATION, THE TIRES ARE NOT INCLUDED IN THE RECALL (00T-005), HOWEVER CONSUMER IS REQUESTING REIMBURSEMENT. *MJS