1997 BMW 328I

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/22/1997· POWER TRAIN

  VEHICLE LURCHES FORWARD IN DRIVE GEAR AS WELL AS REVERSE FOR UNKNOWN REASONS.

• 12/19/2008· VEHICLE SPEED CONTROLCrash

  1997 BMW 328I LESS THAN 80,000 MILES. DRIVING 40MPH WITH CRUISE CONTROL ON. SNOWING BUT STRAIGHT LEVEL CONCRETE ROAD. APPROACHING ASPHALT CURVE ENTERING SMALL MOUNTAIN VILLAGE, I TAPPED BRAKE TO DISENGAGE CRUISE. IT DIDN'T DISENGAGE SO HIT IT HARDER. CRUISE STARTED TO ACCELERATE AND THREW CAR INTO A SKID. TRIED STEERING COLUMN LEVER, NO EFFECT. CRUISE NOW ACCELERATED STRONGLY, SPUN CAR 180, CAR SLID INTO DITCH AT UNDER 30MPH AND FLIPPED OVER. CAR DRIVEN BACK 600 MILES TO HOME BUT TOTAL LOSS FROM CRUSHED IN ROOF. BMW HAS POSSESSION OF THE CAR PENDING PRODUCT SPECIALIST REVIEW. CRUISE HAD STARTED ACTING ERRATIC ON 4-5 OCCASIONS EARLIER THAT WEEK BEING RELUCTANT TO DISENGAGE WITH TWO DIFFERENT DRIVERS. AFTER ACCIDENT 3 WITNESSED THAT BRAKE LIGHTS FAILED TO LIGHT WITHOUT EXCESSIVE PETAL PRESSURE. MANY BMW OWNER REPORTS OF SAME PROBLEM ON INTERNET FROM BRITAIN. BMW SERVICE ADVISOR STATED IT WAS PROBABLY THE SWITCH STARTING TO FAIL. BMW DEALER NOW HAS CAR AND BMW CORPORATE APPEARS TO HAVE ISSUED GAG ORDER TO DEALER EMPLOYEES. *TR

• 12/18/2000· AIR BAGS

  AIRBAG LIGHT STAYS ILLUMINATED WHILE VEHICLE IS IN MOTION. DEALER WILL BE NOTIFIED. *AK

• 11/26/2015· AIR BAGS

  IT SHOWS SEATBELT SIGN AND AIRBAG SIGN

• 11/23/2001· STRUCTURE,ELECTRICAL SYSTEM,BACK OVER PREVENTION

  WHILE DRIVER WAS SITTING IN VEHICLE, SOMETHING UNEXPECTEDLY ACTIVATED THE ALARM SYSTEM, DOORS WOULD NOT UNLOCK FROM THE INSIDE OR THE OUTSIDE, HORN ALSO BECAME INOPERABLE. *JB

• 10/24/2008· POWER TRAIN,EQUIPMENT

  1997 BMW 328 CI WITH 114K MILES. DRIVING AND AT STOP LIGHT READY TO GO INTO 1ST GEAR TO DRIVE OFF AND CAR MOVING VERY SLOWLY. TRANSMISSION PROBLEM I'VE BEEN TOLD AND WILL COST $5K-$7.5 TO FIX DEPENDING ON IF I GO TO DEALER OR MAACO SHOP. NO PRIOR NOTICE OF PROBLEM; IT JUST HAPPENED. *TR

• 10/02/2000· TIRES

  TIRE TREAD CAME OFF DURING HIGHWAY DRIVING CAUSING DAMAGE TO THE REAR BUMPER. THE TIRE DID NOT DEFLATE. CONTINENTAL DENIED CLAIM BECAUSE THE TIRE WAS PREVIOUSLY REPAIRED FOR A PUNCTURE. THE PUNCTURE REPAIR REMAINED INTACT AND AS FAR AS I COULD SEE HAD NOTHING TO DO WITH THE LOSS OF THE TREAD. CONTINENTAL TOLD ME THAT THE TIRE WAS LIKELY TO FAIL (TREAD COME OFF) SOONER OR LATER BECAUSE OF THE PUNCTURE REPAIR. I FIND THIS STATEMENT TO BE INCREDULOUS AS I WAS NEVER NOTIFIED IN ANY OF THEIR SERVICE MANUALS THAT REPAIRING A PUNCTURE WOULD RENDER THE TIRE UNUSEABLE. IF I HAD KNOW THAT I WOULD HAVE HAD THE TIRE REPLACED (SILLY AS THAT SEEMS). AT THE VERY LEAST CONTNENTAL SHOULD BE FORCED TO NOTIFY ALL OF THE USERS OF ITS TIRES THAT ANY SORT OF PUNCTURE - EVEN IF IT IS PROPERLY REPAIRED - MAKES THE TIRE UNFIT FOR THE SAFE OPERATION OF THE VEHICLE. WE WERE NOT INJURED IN THE INCIDENT BUT WE WERE ALMOST KILLED AS I TEMPORARILY LOST CONTROL OF THE VEHICLE. (DOT NUMBER: ACTM2Y7136 TIRESIZE: 205/60R15)

• 09/30/2015· AIR BAGSCrash

  TL* THE CONTACT OWNED A 1997 BMW 328I. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT'S VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

• 09/28/2001· ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,SEATS

  THERMOSTAT MALFUNCTIONED, CAUSING VEHICLE TO OVERHEAT, AND RADIATOR TO BLOW. *AK THE BATTERY LIGHT ILLUMINATED AND TRIM UNDER THE REAR OF THE DRIVER SEAT WAS LOOSE. *ET

• 09/22/1998· WHEELS

  2 ALUMINUM WHEELS ARE BENT, CAUSING THE VEHICLE TO SHAKE. *AK

• 09/18/2002· AIR BAGS

  TURNED ENGINE OFF, AND WENT INTO STORE, AND HEARD AN EXPLOSION. CONSUMER STATED DRIVER'S SIDE AIRBAG DEPLOYED FOR NO REASON. *AK THE DEALER SAID THAT THE WIRING HARNESS MELTED AND CAUSED A SHORT CIRCUIT IN TURN DEPLOYING THE AIR BAG. *JG

• 08/14/2015· ENGINE

  WHEN I WAS AT A STOP LIGHT, MY ENGINE BEGAN TO ACCELERATE WITH MY FOOT ON THE BRAKE. WHEN THE LIGHT TURNED GREEN THE ENGINE CONTINUED TO REVVE HIGHER. IT DID NOT TAMPER DOWN UNTIL I PUT THE CAR IN NEUTRAL. THE ENGINE CONTINUED TO REVVE WHEN I BEGAN TO DRIVE AGAIN UNTIL I CAME TO MY DESTINATION AND PLACED THE CAR IN PARK AND SHUT THE ENGINE OFF. IT DROVE FINE WITHOUT FURTHER INCIDENT THAT DAY. BEFORE THE INCIDENT I HAD TURNED ON THE A/C. ON TUESDAY (2 DAYS LATER) IT UNINTENTIONALLY ACCELERATED AGAIN AT HIGHER REVOLUTIONS AT THE SAME STOP LIGHT. I REPEATED WHAT I DID BUT THIS INCIDENT, THE CAR DID NOT THROTTLE DOWN. IT WAS AS IF IT WAS IN MANUAL MODE WITH THROTTLE FULLY OPENED. I HAD TO PUT THE CAR IN NEUTRAL THEN PARK. MY DESTINATION AT BOTH TIMES WAS 10 MIN AWAY. IT DROVE FINE EVER SINCE. I HAD THE CAR ABOUT A WEEK. I DID TEST DRIVE THE CAR AND IT DID NOT HAVE ANY HISTORY OF THIS.

• 08/01/2000· TIRES

  TIRE FAILED ON FREEWAY ON HOT DAY. PERMETER AND 2/3 OF SIDEWALL SEPARATED FROM BEADS. NO EVIDENCE OF PUNCTURE IN TIRE FRAGMENTS. TIRES HAVE UTQGS OF 400, TRACT. A, TEMP. A, BUT THERE IS NO RECORD OF OF ANY TIRE OF THIS MAKE HAVING EVER BEEN TESTED AT NHTSA FACILITIES. *AK

• 07/22/2003· AIR BAGSCrash

  WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING ANOTHER VEHICLE HIT ON THE RIGHT SIDE, AND DRIVER'S SIDE AIR BAG DIDN'T DEPLOY. *AK

• 07/19/2005· ENGINE AND ENGINE COOLING

  PLASTIC RADIATOR BROKE AT UPPER HOSE CONNECTION, CAUSING SUDDEN TOTAL LOSS OF COOLANT AND ENGINE STOPPING IN HEAVY FREEWAY TRAFFIC. THIS LED TO A VERY DANGEROUS RESCUE BY CALTRANS TRUCK AFTER AN HOUR OF EXPOSURE TO HIGH-SPEED TRAFFIC.

• 07/11/2011· STEERING

  1997 BMW 328IS WITH 179K MILES. AFTER DRIVING FOR MORE THAN 30 MINUTES (HIGHWAY OR CITY), MY STEERING WHEEL WILL BIND OR GET TIGHT IN A TURN. AFTER MUSCLING THROUGH THE TURN SO I DON'T CRASH, THE STEERING WHEEL "POPS" AND RETURNS TO NORMAL OPERATION. THIS HAS BEGAN TO HAPPEN DAILY AND I AM CONCERNED FOR MY SAFETY AS WELL AS ANYONE IN THE CAR WITH ME! *TT

• 07/11/2008· SEAT BELTS

  TL*THE CONTACT OWNS A 1997 BMW 328I CONVERTIBLE. DUE TO HIS BODY STATURE, THE CONTACT WOULD HAVE TO LEAN THE SEAT BACK IN ORDER TO USE THE SEAT BELT EFFECTIVELY. HE CONSULTED THREE DEALERS FOR SEAT BELT EXTENDERS, BUT NONE HAD THEM AVAILABLE OR WERE NOT BEING SOLD. THE MANUFACTURER STATED THAT THEY DID NOT HAVE SEAT BELT EXTENDERS FOR THAT MODEL. THE CURRENT MILEAGE WAS 159,882 AND FAILURE MILEAGE WAS APPROXIMATELY 159,800.

• 06/13/2005· ELECTRICAL SYSTEM

  SUDDEN AND COMPLETE FAILURE OF IGINITION SWITCH. AFTER ROUTINE DRIVE FROM WORK TO THE GYM, I TURNED THE IGNITION SWITCH TO THE OFF POSITION, AND THE ENGINE DID NOT STOP. I WAS ABLE TO REMOVE THE KEY BUT THE ENGINE KEPT RUNNING. THERE WAS NO WAY TO TUN OFF THE ENGINE USING THE KEY. DROVE CAR TO THE DEALERSHIP.

• 05/20/2005· ELECTRICAL SYSTEM

  SUDDEN FAILURE OF IGNITION COIL RESULTING IN A SHAKING/VIBRATING VEHICLE. WHILE ACCELLERTING IN CITY TRAFFIC THE CAR CAN LUNGE AND JERK WHILE ACCELLERATING, RESULTING IN UNPREDICTABLE ACCELLERATION. IN CITY TRAFFIC THIS IS VERY DANGEROUS. I HAVE INVESTIGATED THE IGNITION COILS FOR BMW 3 SERIES CARS AND IT APPEARS THEY FAIL A LOT, YET THERE IS NO RECALL CAMPAIGN! AFTER INVESTIGATING FURTHER IT APPEARS BMW HAS SOME RECALL CAMPAIGNS FOR SOME OF THE NEWER CARS. THEY SUGGEST REPLACING ALL IGNITION COILS WITH A NEW BOSCH MODEL. MY CAR HAS BREMI MODEL COILS (PART NO. F3000-86682) AND THERE IS NO BOSCH SUBSTITUTE ACCORDING TO THE BMW DEALER (PLAZA MOTORS IN ST. LOUIS, MO). I FOUND AN EPA RECALL NUMBER FOR THE BREMI COILS FOR ANOTHER MODEL BMW AT THIS WEB SITE: REFERENCE: HTTP://WWW.EPA.GOV/OTAQ/CERT/RECALL/420B04018.PDF EPA# 2061 IT DESCRIBES AN INTERNAL FAILURE AS FOLLOWS: "BECAUSE OF PRODUCTION PROCESS FAILURES, THE IGNITION COIL OF ONE SUPPLIER (BREMI)MAY HAVE AN INTERNAL INSULATION BREAK-DOWN IN THE PRIMARY ELECTRIC 2121 CIRCUIT, THE SECONDARYELECTRIC CIRCUIT AND/OR A DISRUPTIVE DISCHARGE. REMEDY: BMW HAS DECIDED TO IMPLEMENT A VOLUNTARY EMISSION RECALL CAMPAIGN TO REPLACE ALL IGNITION COILS WITH A NEW IMPROVED VERSION." THE SAME EXACT THING IS HAPPENING TO BMW 3 SERIES CARS. A REVIEW OF BMW FORUMS ON THE INTERNET EXPLAINS THAT THIS PROBLEM IS OCCURRING MORE FREQUENTLY BY THE DAY. I WOULD LIKE THIS TO BE INVESTIGATED AND A RECALL CAMPAIGN INITIATED AS SOON AS POSSIBLE BEFORE SOMEBODY GETS HURT!

• 04/28/2009· STRUCTURE

  I WAS TOLD TODAY THAT MY CAR IS NOT SAFE AS THE FRONT SWAY BAR MOUNTS HAVE RUSTED THROUGH. *TR

• 04/26/2017· ELECTRICAL SYSTEMCrash

  AFTER SEEING YET ANOTHER REAR END COLLISION, I WOULD LIKE TO MAKE A SUGGESTION I HAVE HAD IN MIND FOR A LONG TIME. I BELIEVE WE CAN REDUCE THE INCIDENCE OF SUCH ACCIDENTS, BY FLASHING THE STOP SIGNALS WHENEVER THE BRAKES ARE ON AND THE CAR IS STOPPED ( REQUIRES A SPEED SENSOR, OF COURSE). MANUAL FLASHING ELECTRONICS EXISTS IN EVERY MODERN CAR, BUT IS NOT NORMALLY USED WHEN STOPPED ON THE ROADWAY.

• 04/16/2001· SEAT BELTS

  PASSENGER'S SIDE SEAT BELT BUCKLE HOUSING PORTION DOES NOT HOLD LATCH PLATE IN BUCKLE HOUSING MECHANISM. LATCH PLATE POPS OUT OF BUCKLE. CONSUMER HAS CONTACTED DEALER, DEALER HAS REPLACED BUCKLE. *AK CONSUMER HAD TO PAY TO REPLACE THE FAILED HOUSING. *SLC

• 04/08/1998· STRUCTURE

  WATER LEAKS INTO THE VEHICLE FROM ALL DOORS IN RAINY WEATHER CONDITIONS, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK

• 03/31/2006· SUSPENSION,STRUCTURE

  REAR SUSPENSION FAILURE ON E36 BMW.. I HAVE READ ABOUT THIS ON EVERY BMW FORUM.. THE REAR SUBFRAME MOUNTS TEAR THE FLOOR SHEET METAL AS THEY ARE NOT PROPERLY REINFORCED. I HAVE OWNED 4 SEPARATE CARS WITH THIS SAME PROBLEM AND I KNOW COUNTLESS OTHERS. HTTP://WWW.UNOFFICIALBMW.COM/PHPBB/VIEWTOPIC.PHP?T=10859. *NM

• 03/09/2005· VISIBILITY

  IT IS COMMON KNOWLEDGE THROUGH CAR CLUBS, PARTS SUPPLIERS AND THE MECHANICS PROVIDING REPAIRS THAT THE ELECTRONIC CLIMATE CONTROL UNIT OFTEN FAILS COMPLETELY OR BECOMES INTERMITTENT IN OPERATION. WHEN IT FAILS THERE IS NO CONTROLS OR CHANCE OF CHANGING FUNCTIONS. THIS ALLOWS THE CONDITION TO EXIST THAT THE VEHICLE OPERATOR CAN NOT SELECT THE WINDSHIELD DEFROSTER FUNCTION AND POSSIBLY IMPAIRING THE DRIVERS ABILITY TO VIEW THROUGH THE WINDSHIELD. I HAVE TWO CARS OF THIS BUILD TYPE AND THEY BOTH HAVE THIS PROBLEM. THE MECHANICS REPAIR BILLS OFTEN AMOUNTS TO AN EXCESS OF $400 PER REPAIR. HERE IS A QUOTE FROM A REPUTABLE PARTS SOURCE, WWW.BAVAUTO.COM WEBSITE: THIS IS THE DIGITAL CLIMATE CONTROL COMPUTER. THESE ARE A COMMON FAILURE ITEM ON ALL 1996-1999 3 SERIES. WHEN THESE FAIL, THE LCD SCREEN WILL GO DIM/BLANK (USUALLY IINTERMITTENTLY AND EVENTUALLY PERMANENTLY) AND THE VENTILATION & AIR SYSTEM WILL NOT FUNCTION." PART NUMBER: 64 11 8 379 521 DESCRIPTION: CLIMATE CONTROL COMPUTER MODULE - IN-DASH RICE: 74.95. *AK

• 03/04/2014· ELECTRICAL SYSTEM

  THE LOCKING DEVICE ON A 1997 BMW 328I INTERMITTENTLY MAKES IT IMPOSSIBLE FOR OCCUPANTS TO EXIT THE VEHICLE IF IT IS LOCKED WHILE OCCUPIED. THIS IS A SAFETY RISK, WHICH CREATES A HIGH DANGER AND SEVERITY OF RISK OF INJURY OR DEATH TO CONSUMERS AND/OR USERS OF THE VEHICLE IF AN OCCUPANT STAYS IN A VEHICLE THAT IS LOCKED. DESPITE KNOWLEDGE OF THIS SAFETY RISK, BMW FAILED TO CORRECT THIS DEFECT AND ADVISE OR WARN PURCHASERS OR POTENTIAL USERS, INCLUDING THE PURCHASERS, OWNERS AND/OR USERS OF THE SUBJECT 1997 BMW 328I, BY PROVIDING ADEQUATE WARNINGS AND/OR NOTICES OF THE SEVERE RISK OF INJURY OR DEATH IF AN OCCUPANT STAYS IN A VEHICLE THAT IS LOCKED. ON OR ABOUT SEPTEMBER 11, 2013, A HOT AND SUNNY DAY, A FEMALE YOUTH WHO WAS AN OCCUPANT OF A 1997 BMW 328I, BECAME TRAPPED IN THE SUBJECT 1997 BMW 328I THAT WAS LOCKED. IT WAS IMPOSSIBLE FOR THE YOUTH TO EXIT THE VEHICLE, AND SHE ULTIMATELY SUCCUMBED TO HEAT STROKE AND DIED WHILE TRAPPED IN THE VEHICLE.

• 02/01/1999· ELECTRICAL SYSTEM

  ALTERNATOR FAILED. *YC

• 02/01/1999· ENGINE AND ENGINE COOLING

  THERMOSTAT STUCK.

• 02/01/1999· ELECTRICAL SYSTEM

  IGNITION SWITCH FAILED ON THREE OCCASIONS. MJS

• 02/01/1999· STRUCTURE

  PLASTIC FACE PLATE ON THE BOTTOM OF DOOR FRAME GOT CAUGHT ON CONSUMER'S SHOE AND BROKE. MJS

• 02/01/1999· ENGINE AND ENGINE COOLING

  EMISSION FAILED. YH

• 01/29/2001· TIRES

  ODI #740028. NO SAFETY DEFECT MENTIONED. *AK (DOT NUMBER: ACTM2Y7166 TIRESIZE: 205/60R15)

• 01/27/2001· TIRES

  IT HAPPENED AT 3:50 PM, PACIFIC STANDARD TIME, JANURAY 26, 2001, FREEWAY 91 HEADING EAST, PASSED FREEYWAY 710, AT THE EXIT OF ATLANTIC. I WAS LUCKY TO PULL OVER AND MY COLLEAGUE WAS FOLLOWED ME AT THE INCIDENT HAPPENED. SHE WITNESSED EVERY THING. THE METRO (MTA) TOW TRUCK PASSED BY 15 MINUTES LATER AND CHANGED THE SPARE TIRE FOR ME. A PIECE OF TIRE WAS FLYING AWAY AND CAUSED THE MUFFLER AND THE LEFT SIDE REAR BUMPER SEVERE DAMAGE. I HAVE TAKEN A ROLL OF PICTURES AFTERWARDS. I WILL SEND YOU A DETAILED TIRE'S SPEC. TOMORROW. *AK( DOT NUMBER: )

• 01/18/1999· ELECTRICAL SYSTEM

  I PARKED THIS CAR FOR 3 DAYS BEFORE I DROVE IT AT SUNDAY MORNING. AFTER I PARKED FOR AN HOUR LATER IT STARTED ON FIRE BY IT SELF. FIRE DEPARTMENT TOLD ME IT WAS ELECTRICAL PROBLEM WHICH IS STARTED FROM ENGINE ROOM BETTERY TERMINAL.

• 01/17/2001· VEHICLE SPEED CONTROL

  WHEN SHIFTING FROM DRIVE TO PARK VEHICLE WOULD SUDDENLY ACCELERATE ON ITS OWN. CAN ONLY BE STOPPED BY TURNING OFF IGNITION. BRAKES WOULD ONLY SLOW IT DOWN, BUT NOT STOP IT. HAS HAPPENED 4 TIMES, AND WAS AN INTERMITTENT PROBLEM. BEEN TO DEALERSHIP, AND MECHANIC COULD NOT DUPLICATE PROBLEM, WILL NOT REPAIR IT. MANUFACTURER AGREED WITH DEALERSHIP, AND POLICY WAS TO RETURN VEHICLE IF NOT REPAIRABLE.*AK