1990 Toyota 4RUNNER

These are unverified consumer reports filed with NHTSA, shown as submitted.

• 12/20/2000· ENGINE AND ENGINE COOLING

  WATER IS BEING SUCKED INTO ENGINE, AND HEAD GASKET PROBLEM. THERE IS A DEFECT IN HEAD ENGINE GASKET. TOYOTA IS AWARE OF PROBLEM. *AK

• 12/16/1997· SERVICE BRAKES, HYDRAULIC,POWER TRAIN

  TRANSMISSION/OVERDRIVE CYCLES ON AND OFF DURING HIGHWAY DRIVING, RESULTING IN LOSS OF GAS MILEAGE. ALSO ABS BRAKES LOCK UP, CAUSING VEHICLE TO SLIDE.

• 12/15/1999· ENGINE AND ENGINE COOLING

  THIS IS THE 4TH TIME THE GASKET HAS FAILED. GASKET WAS INSTALLED BY A CERTIFIED TOYOTA MECHANIC IN 1996. 3/97 WHITE SMOKE POURED OUT OF THE EXHAUST. TOYOTA REPLACED THE TOP OF THE ENGINE. 11/97 ENGINE FAILED - 600MILES FROM HOME, AFTER 3 MONTHS AT THE DEALERSHIP ON 2/98 THE BOTTOM & TOP OF THE ENGINE WAS REPLACED. NOW 12/99 SAME PROBLEM - GASKET NEEDS TO BE REPLACED -OIL BLEW ALL OVER THE ENGINE, THE REAM MAIN SEAL IS GONE. TOYOTA SAYS ITS OUR PROBLEM NOW. *AK

• 12/11/1998· ENGINE AND ENGINE COOLINGFire

  THE CONSUMER WAS DRIVING TRUCK, AND SHE NOTICED THAT THERE WAS NO PRESSURE WHEN SHE HIT THE GAS PEDAL AND SHE SMELLED FUEL. ALSO SHE HAD A NEW ENGINE PUT IN JULY, THE MILEAGE WAS 75000 ON THE TRUCK. THE SHORT BLOCK WAS REPLACED . THEN THE TRUCK BURST INTO FLAMES. THE CAR WA STOWED TO THE DEALER FOR FURTHER INVESTIGATION. *AK

• 12/07/2001· ENGINE AND ENGINE COOLING

  ENGINE BLEW AT 13000 MILES AND VEHICLE STARTED HESITATING AND CUTTING OFF WITHOUT PRIOR WARNING. DEALERSHIP WAS AWARE OF PROBLEM.*AK

• 12/06/2000· ENGINE AND ENGINE COOLING

  THIS PARTICULAR TYPE OF HEAD GASKET FAILURE (COOLANT LEAKAGE INTO THE CYLINDER) IS A KNOWN PROBLEM ON THE 3VZ-E ENGINE, TOYOTA INITIATED A SPECIAL SERVICE CAMPAIGN (V06) TO REPAIR MOST, HOWEVER THE CONSUMER'S VEHICLE DOES NOT QUALIFY DUE TO THE VIN # RANGE. *MJS

• 12/04/2006· STRUCTURE

  DT*: THE CONTACT STATED THERE WAS A PROBLEM WITH THE REAR END OF THE VEHICLE. THE WELDS ON THE REAR SUBFRAME OF THE VEHICLE POPPED AND FRACTURED WHICH CAUSED THE READ END TO FALL OFF. THE WELD DID NOT FRACTURE, BUT INSTEAD POPPED AWAY FROM THE REAR END WHICH HELD THE REAR SWAY BAR ONTO THE AXLE. THE WELDS POPPED ON BOTH SIDES. THE TRUCK HAD NEVER HAD A HITCH OR CARRIED A HEAVY LOAD ON THE VEHICLE.

• 12/03/2001· ENGINE AND ENGINE COOLINGFire

  VEHICLE WAS IN FOR OIL CHANGE 4 WEEKS PRIOR TO INCIDENT. ENGINE BEGAN TO MAKE A LOUD BANGING NOISE. STOPPED AT A JIFFYLUBE, AND FOUND OIL VERY LOW. FILLED WITH OIL AND WAS TOLD THAT IT SOUNDS LIKE I THREW A ROD, BUT IT SHOULD BE OKAY TO GET ME WHERE I WAS GOING (ABOUT 5 MILES UP THE ROAD). APPROXIMATELY 2 MILES LATER, WHITE SMOKE BEGAN COMING OUT THE BACK OF THE VEHICLE, AND THE BANGING STOPPED. THE SMOKE BECAME VERY BAD, AND I WAS ABOUT TO PULL INTO A GAS STATION WHEN SOMEONE PULLING OUT YELLED TO ME THAT IT WAS ON FIRE (IN THE ENGINE COMPARTMENT). I GOT ME AND MY 2 SMALL BOYS OUT, AND CAME HOME THAT SAME NIGHT TO THE HEAD GASKET RECALL NOTICE IN THE MAIL. I IMMEDIATELY CALLED TOYOTA, WHO SENT SOMEONE OUT TO INVESTIGATE, BUT THEY SAID THAT THE INVESTIGATION CONCLUDED THAT THE CAUSE WAS NOT KNOWN, AND IT WAS NOT THEIR RESPONSIBILITY. I WAS READING MORE HORROR STORIES ABOUT THIS ON YOUR SITE. WHAT CAN BE DONE? MY VEHICLE WAS PAID FOR AND MY INSURANCE DID NOT COVER FIRE. WHY DID IT TAKE THEM SO LONG TO GET THE HEAD GASKET RECALL NOTICE TO ME? IT APPEARS THAT THIS WAS AN ISSUE FOR SEVERAL YEARS. I BASICALLY DROPPED THE ISSUE FOR SEVERAL YEARS FIGURING I WAS FIGHTING A LOSING BATTLE, UNTIL I DISCOVERED THIS SITE. THANKS.*AK

• 11/29/2000· ENGINE AND ENGINE COOLING

  STARTED AND LOW SPEED STRANGE NOISE AND ANTIFREZE SPEWING, HEAD GASKET BLOWN (REPLACED IN 1998) ONLY 42 K MILES INTO NEW GASKET. *AK

• 11/24/1999· ENGINE AND ENGINE COOLING

  NO SUMMARY.

• 11/21/2005· POWER TRAIN

  CLUTCH PEDAL BRACKET FAILURE NO EVENTS WERE PRESENT LEADING UP TO THE FAILURE OF MY CLUTCH PEDAL BRACKET ASSEMBLY. WHILE APPROACHING A STOPLIGHT IN TRAFFIC I DEPRESSED MY CLUTCH PEDAL IN ORDER TO GEAR DOWN FOR THE STOP. WHILE DEPRESSING THE PEDAL I HEARD A LOUD SNAP - THE SOUND OF THE CLUTCH PEDAL BRACKET BREAKING. WITH THE BRACKET BROKEN THERE WAS NO ACCEPTABLE WAY TO DISENGAGE THE CLUTCH AND GET THE VEHICLE OUT OF GEAR TO STOP FOR THE STOP LIGHT. I SLAMMED ON THE BRAKES AND BROUGHT THE VEHICLE TO A STOP (WHICH STALLED THE VEHICLE) BEFORE REAR ENDING THE CAR IN FRONT OF ME. ONCE THE LIGHT TURNED GREEN I HAD TO USE THE STARTER WITH THE VEHICLE IN GEAR TO CLEAR THE INTERSECTION. THE VEHICLE HAS BEEN TOWED TO MY RESIDENCE SO I CAN DECIDE HOW TO FIX THIS. IT SEEMS TOYOTA KNOWS OF THE PROBLEM AND OFFERS AN "UPGRADED" BRACKET AT A PREMIUM PRICE ALONG WITH A PREMIUM INSTALLATION FEE. AFTER BROWSING THE INTERNET IT SEEMS AS IF THIS PROBLEM IS VERY COMMON AMONG TOYOTA TRUCK, 4-RUNNER AND T-100 OWNERS ALIKE. THIS TYPE OF PROBLEM COULD BE LIFE THREATENING! *NM

• 11/21/1995· POWER TRAINCrash

  CONSUMER WAS DRIVING 40 TO 45 MPH THE REAR PASSENGER SIDE REAR AXLE CAME OFF CAUSING THE TRUCK TO ROLLOVER TRUCK WAS TOTOALED . TT

• 11/20/2000· ENGINE AND ENGINE COOLING

  THREW A ROD, RESULTING IN TOTAL ENGINE FAILURE. COMPLETE OIL LOSS BLAMED - CAUSE UNKNOWN. HEAD GASKET REPLACED IN APRIL OF 1996. THIS OCCURRED IN MAY OF 1997.*AK

• 11/19/1997· SUSPENSIONCrash

  WHILE DRIVING ABOUT 50 MPH, SWITCHING LANES THE VEHICLE WOBBLED AND SPUN OUT OF CONTROL, CAUSING THE VEHICLE TO ROLLOVER, INJURING THE DRIVER. *AK

• 11/06/1995· STRUCTURE

  TAILGATE ELECTRIC DOOR FAILED AND CANNOT OPEN GATE. TT

• 11/03/1999· ENGINE AND ENGINE COOLING

  TRUCK BURNS A QUART OF OIL EVERY 15 MILES. CONSUMER RECEIVED A RECALL NOTICE FOR NEW ENGINE HEAD GASKETS. TOOK CAR TO THE DEALER, REPAIRED THE HEAD GASKET . THEN DISCOVERED A PROBLEM WITH THE ENGINE BLOCK. DEALER WOULD HAVE TO SEND THAT PART OUT. EVERY SINCEVEHICLE WAS FIXED, TRUCK HAS JUST BEEN BURNING OIL TOO FAST. CONSUMER FEELD IT IS UNSAFE TO DRIVE TRUCK BECAUSE THE FEAR OF BREAKING DOWN DUE TO LACK OF OIL. *AK

• 11/02/1995· ENGINE AND ENGINE COOLING

  THE ENGINE HEAD IS BAD . TT

• 10/28/2003· SERVICE BRAKES, HYDRAULIC

  TOTAL LOSS OF BRAKING FUNCTION. WIFE AND GRAND DAUGHTER IN CAR. NO ACCIDENT OCCURRED. EMNERGENCY BRAKE STILL FUNCTIONED. ROOT CAUSE WAS DUE TO LONG-TERM WEAR ON LEFT REAR METAL BRAKE LINE BY ANIT-LOCK-BRAKES CONTROL ARM. THIS ACTION RESULTED IN THE METAL BRAKE LINE INTEGRITY FAILURE.*AK

• 10/24/2001· POWER TRAIN,VEHICLE SPEED CONTROLCrash

  VEHICLE WAS PARKED BUT TURNED ON, HAD JUST SHIFTED INTO REVERSE WITH FOOT ON BRAKES WHEN IT SUDDENLY ACCELERATED BACKWARDS. HIT 2 PARKED VEHICLES. NO INJURIES WERE SUSTAINED. HAVE NOT CONTACTED DEALERSHIP.*AK

• 10/17/1994· VISIBILITY

  POWER WINDOW REGULATOR FAILED, PREVENTING WINDOW FROM BEING OPENED. (2ND VEHICLE ON 474932) *AW

• 10/12/2004· ENGINE AND ENGINE COOLING

  WHILE THE VEHICLE WAS PARKED, THE CONSUMER NOTICED FLUID LEAKING FROM UNDERNEATH THE VEHICLE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR AN INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE HEAD GASKET WAS CRACKED AND NEEDED TO BE REPLACED. PLEASE PROVIDE FURTHER DETAILS. *JB

• 10/08/1996· ENGINE AND ENGINE COOLING

  BOLT THAT HOLDS THE HEAD ON THE ENGINE GASKETS IS BROKEN. *AK

• 10/03/2012· POWER TRAIN,SERVICE BRAKES

  TL*THE CONTACT OWNS A 1990 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE BRACKET SUB-ASSEMBLY THAT HELD THE CLUTCH AND BRAKE PEDAL WAS FRACTURED. AS A RESULT, THE CONTACT WAS UNABLE TO DEPRESS THE BRAKE PEDAL OR THE CLUTCH. THE DEALER REPAIRED THE FAILURE AT LEAST THREE TIMES IN LESS THAN ONE YEAR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 150,000. ..UPDATED 11/14/12 *BF UPDATED 11/14/12

• 10/02/2001· ENGINE AND ENGINE COOLING,VISIBILITY

  PASSENGER'S SIDE EXTERIOR MIRROR WOULD SEVERELY VIBRATE WHEN TRAVELING AT 30MPH OR MORE. THIS CAUSED POOR VISIBILITY. DEALER NOTIFIED, AND WAS UNWILLING TO ASSIST ON THIS MATTER. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION ON THIS PROBLEM.*AK

• 09/29/1999· ENGINE AND ENGINE COOLING

  WHILE DRIVING AT 35 MPH ENGINE HEAD GASKET FAILED DUE TO THE COOLANT WHICH GOT INSIDE AND RUINED ENGINE. *AK

• 09/18/1995· ENGINE AND ENGINE COOLING

  REPLACED BOTH ENGINE HEAD GASKETS. *AK

• 09/13/2002· ENGINE AND ENGINE COOLINGFire

  WHILE TRAVELING ON THE HIGHWAY WITHOUT PRIOR WARNING. THE VEHICLE CAUGHT ON FIRE UNDERNEATH HOOD. THE DEALERSHIP IS AWARE OF THE PROBLEM. NLM

• 09/01/2000· TIRES

  THE FAILURE OCCURRED ON INTERSTATE 10 IN TEMPE, ARIZONA AT APPROXIMATELY 12 NOON. AT THE TIME I WAS A RESIDENT OF TEMPE, ARIZONA FOR 12 YEARS. THE FAILURE WAS A SUDDEN AND COMPLETE TREAD SEPARATION OF THE RIGHT REAR TIRE WITHOUT ANY WARNING WHATSOEVER. THE AGE OF THE TIRE AND TREAD WEAR IS UNKNOWN. I WAS THE ONLY OCCUPANT OF THE VEHICLE AT THE TIME. I MAINTAINED CONTROL OF THE VEHICLE AND BROUGHT IT TO A STOP WITHOUT DIFFICULTY. NO OTHER REPORT IS AVAILABLE. I PAID TO REPLACE THE TIRE AT A FIRESTONE DEALER. OTHER INFORMATION: I HAVE OBSERVED OTHER QUALITY PROBLEMS WITH THIS MODEL TIRE INCLUDING TIRES GETTING OUT OF BALANCE SOON AFTER PURCHASE AND PARTIAL TREAD SEPARATION ON TIRES WITH HEAVY WEAR.( DOT NUMBER: N/A TIRE SIZE: P235/75R15 )

• 08/26/1999· POWER TRAINCrash

  THE REAR AXLE BROKE AT 70MPH, RESULTING IN A COLLISION WHICH CAUSED MINOR INJURIES.*AK *ML

• 08/25/2000· ENGINE AND ENGINE COOLING

  CONSUMER STARTED UP THE CAR AND SAW A BIG PUFF OF SMOKE. TOOK VEHICLE TO A MECHANIC, AND THEY SAID IT WAS A BLOWN HEAD GASKET.*AK *SLC

• 08/22/2002· ENGINE AND ENGINE COOLING

  WHILE STARTING ENGINE REVVED A LITTLE AND COOLING FAN EXPLODED, PIECE OF FAN FLEW AS FAR AS 30 FEET AWAY, ALMOST INJURING A BYSTANDER. FAN PIERCED A HOLE IN BATTERY, ALLOWING ACID TO SPILL ONTO THE FLOOR. MECHANIC STATED THAT THIS WAS A POOR DESIGN IN COOLING FAN. AND A VERY DANGEROUS SITUATION.*AK

• 08/19/1998· SERVICE BRAKES, HYDRAULIC

  BRAKES FAILED CAUSING ACCIDENT. OHIO STATE POLICE REPORT.

• 08/09/1999· ENGINE AND ENGINE COOLING

  TOYOTA ISSUES AN "EXTENDED WARRANTY" FOR THE FAULTY HEAD GASKETS IN 1998-1994 4RUNNERS. WHEN THE HEAD GASKETS FAILED THEY WERE REPLACED UNDER THIS WARRANTY. HOWEVER, THE DAMAGE CASUED BY THE FAULTY HEAD GASKETS IS EXTENSIVE. AFTER INITAIL REPLACEMENT--TOYOT ADEALERSHIP CONTINUED TO FIND OIL FOULED PLUGS WHICH LET TO REPLACEMENT OF LOWER ENGINE BLOCK (DECEMBER 1998). ENGINE FAILED AGAIN IN JANUARY 5 1999-- AT WHICH POINT 2 CYLINDER HEADS, CAMSHAFTS, ENGINE GASKET, AND KNOWCK SENSOR WERE REPLACED. ENGINE HAS NOT OPERATED PROPERLY SINCE ORIGINAL HEAD GASKET FAILURE-- SLUGGISH, POOR ACCELERATION, INCONSISTENT IDLING SPEEDS... ENGINE HAS BEEN LOOKED AT AND WORKED ON AT AUTHORIZED TOYOTA DEALERSHIPS 12 TIMES TO DATE FOR HEAD GASKET RELATED ENGINE PROBLEMS. STILL UNRESOLVED, FOR THESE SYMPTOMS OIL GOULED PLUGS

• 08/08/2003· ENGINE AND ENGINE COOLING

  I PURCHASED MY 4RUNNER USED IN 1998. THE MILEAGE AT PURCHASE WAS ONLY 30K, AS IT HAD BEEN USED PRIMARILY FOR DRIVING IN INCLEMENT WEATHER. THE ORIGINAL OWNER INFORMED ME THAT A NOTICE HAD BEEN SENT BY TOYOTA REGARDING HEAD GASKET FAILURES (TSB #97121797017), AND THAT TOYOTA WOULD HONOR THE REPAIRS (IF NECESSARY) UP TO 100K MILES, REGARDLESS OF TIME SINCE ORIGINAL USE. THE TSB, HOWEVER, STATES THAT THE EXTENDED WARRANTY LASTS UNTIL 8 YEARS FROM ORIGINAL USE OR 100K MILES, WHICHEVER OCCURS FIRST. SINCE OCTOBER 2000, I HAVE EXPERIENCED INTERMITTENT LOW ENGINE IDLING (AND STALLING) AFTER DRIVING AT HIGH SPEEDS. ON AT LEAST FIVE DIFFERENT OCCASIONS, I HAVE ASKED THAT THE VEHICLE'S IDLE SPEED BE ADJUSTED AND THE THROTTLE PLATE BE CLEANED TO RESOLVE THIS PROBLEM. I DID NOT REALIZE UNTIL JUST RECENTLY THAT THE SOURCE OF THIS PROBLEM IS A LEAKY HEAD GASKET. THE TOYOTA DEALERSHIP I GO TO HERE IN GLENDALE, CA REPORTED THIS DIAGNOSIS AFTER I QUESTIONED THEM ON WHY THE VEHICLE NEEDED REPEATED IDLE SPEED ADJUSTMENTS. THE CURRENT MILEAGE OF THE VEHICLE IS 99K. I HAVE APPROACHED TOYOTA CUSTOMER SERVICE TO INQUIRE IF THEY WILL AUTHORIZE A HEAD GASKET REPLACEMENT FOR THE VEHICLE FREE OF CHARGE SINCE THE PROBLEM IS A PROBLEM THAT THEY HAVE BEEN AWARE OF AND PREVIOUSLY ISSUED AN EXTENDED WARRANTY COVERING IT. I HAVE BEEN TOLD THIS IS NOT POSSIBLE BECAUSE OF THE AGE OF THE VEHICLE. I FEEL THAT TOYOTA SHOULD AUTHORIZE THE REPAIR IN THIS CASE DESPITE THE AGE OF THE VEHICLE, AS THE ENGINE BEGAN EXHIBITING SYMPTOMS OF THE HEAD GASKET PROBLEM WELL BELOW THE 100K MILEAGE REQUIREMENT THAT TOYOTA ORIGINALLY STATED THAT THEY WERE WILLING TO REPAIR IN THE TSB. I DO NOT KNOW WHAT FURTHER I CAN DO REGARDING THIS MATTER, AND WOULD APPRECIATE ANY HELP THAT CAN BE PROVIDED.

• 08/08/2000· SERVICE BRAKES, HYDRAULICCrash

  ABS FAILED TO ACTIVATE DURING SNOW CAUSING THE VEHICLE TO SPEED UP RESULTING IN A COLLISION WITH A FENCE. *YH

• 08/01/1999· ENGINE AND ENGINE COOLING

  PUT 5000 MILES ON USED PURCHASED VEHICLE AND ENGINE BLEW

• 07/31/2003· ENGINE AND ENGINE COOLING

  CONSUMER STATES THAT THE VEHICLE HEAD GASKET HAS FAILED. DEALER NOTIFIED. *PH

• 07/29/1997· POWER TRAIN

  CLUTCH MOUNTING BRACKETS HAVE TORN TO THE POINT THAT THE CLUTCH WILL NOT RELEASE.

• 07/02/2001· POWER TRAIN,VEHICLE SPEED CONTROLCrash

  VEHICLE WAS AT A LIGHT AND CONSUMER STEPPED ON CLUTCH AND HEARD A SNAP. VEHICLE LURCHED FORWARD, AND HIT THE VEHICLE IN FRONT. CONSUMER PUT VEHICLE IN PARK POSITION, AND GOT UNDER THE DASHBOARD. NOTICED BRACKET THAT HOLDS THE CLUTCH PEDAL WAS BROKEN. DEALER DIDN'T WANT TO SEE THE VEHICLE UNLESS CONSUMER WAS PAYING TO REPAIR IT.*AK

• 07/02/1999· VEHICLE SPEED CONTROL,UNKNOWN OR OTHER

  ENGINE CHECK LIGHT COMES ON. WHEN VEHICLE IS IN PARK, AND IT IDLES AT 1500 RPMS. DEALER HAS SEEN VEHICLE 14 TIMES, AND PROBLEM STILL EXISTS. *AK

• 06/26/2003· ENGINE AND ENGINE COOLING

  ENGINE HEAD GASKET WAS REPLACED UNDER THE OWNER NOTIFICATION WARRANTY, BUT BLEW OUT 5000 MILES LATER.*AK

• 06/23/1998· VEHICLE SPEED CONTROL

  VEHICLE EXPERIENCED SUDDEN ACCELERATION RESULTING IN A VEHICLE COLLISION.

• 06/14/2011· ENGINE AND ENGINE COOLING

  FAN BLADE DISINTEGRATED AT HIGHWAY SPEED. DENTED HOOD, CRACKED BATTERY, RUINED SHROUD AND ALTERNATOR BELT. *TR

• 06/08/1999· ENGINE AND ENGINE COOLING

  ROD THROWN, ENGINE DESTROYED. WARRANTY HEAD WORK DONE LAST OCTOBER AFTER RECALL POSSIBLY RELATED. MASSIVE OIL LOSS SOMETIME IN LAST WEEK, POSSIBLY AT TIME OF ENGINE FAILURE.

• 06/02/1997· SERVICE BRAKES, HYDRAULICCrash

  DRIVER HIT THE BRAKES AND ABS BRAKES FAILED TOYOTA TRUCK, 4-RUNNER LOST CONTROL/ROLLED OVER, A BABY AND ADULT DRIVER FELL OUT OF THE CAR, RESULTING IN 2 INJURIES AND A FATALITY. *AK

• 05/15/2000· ENGINE AND ENGINE COOLING

  WHEN TRYING TO START VEHICLE AFTER IT HAS BEEN RUNNING ROUGHLY, WHITE SMOKE CAME OUT OF ENGINE. A TECHNICIAN HAD INFORMED CONSUMER THAT VEHICLE HAD A BLOWN HEAD GASKET. *AK

• 04/26/2018· UNKNOWN OR OTHER,SERVICE BRAKES

  CLUTCH/BRAKE PEDAL BRACKET BROKE/CRACKED AFTER PRESSING THE CLUTCH PEDAL. WAS ORIGINALLY DIAGNOSED AS A BAD CLUTCH AND ALMOST PULLED THE PLUG TO GET THE CLUTCH REPLACED. WOULD HAVE BEEN A LOAD OF WASTED MONEY ON A POOR DIAGNOSIS. PEDAL BRACKET CRACKED WITH CLUTCH PEDAL WAS PRESSED TO START THE CAR. HEARD LOUR CRACK, CAR STARTED, BUT WOULD NOT GO INTO GEAR.

• 04/20/2000· POWER TRAIN,ELECTRICAL SYSTEM

  THIS VEHICLE BEHAVES IN A VERY "LEMON" LIKE WAY. NUMEROUS ELECTRICAL FAILURES SINCE I HAVE OWNED THE VEHICLE. MAIN PROBLEM IS VEHICLE JUMPING IN AND OUT OF OVERDRIVE AT HIGHWAY CRUISING SPEEDS. (A CONSTANT PROBLEM.) TOYOTA SEEMS TO NOT WANT TO ACKNOWLEDGE THE PROBLEM, ALTHOUGH I KNOW OF AT LEAST ONE OTHER OWNER LOCALLY WHO HAS EXPERIENCED THE SAME PROBLEM. AT ONE TIME, A WIRING HARNESS WAS BLAMED AND A FIX WAS MADE THAT CURED THE PROBLEM FOR A COUPLE OF YEARS. VEHICLE CONSTANTLY LEAKS OIL, EVEN THOUGH THE LOCAL TOYOTA DEALERSHIP "FIXED" THESE PROBLEMS AS PART OF A RECALL IN LATE 1997. (PROBLEM NEVER STAYED FIXED.) ELECTRICAL SHORTS IN WIRING ALSO CAUSED SEVERAL INSTANCES OF BATTERY LOSS OF POWER SO BADLY THAT BATTERY HAD TO BE REPLACED NUMEROUS TIMES. TRANSMISSION HAS ALWAYS BEHAVED POORLY, ENGINE ALWAYS LEAKS OIL, AND ELECTRICAL PROBLEMS ARE ABUNDANT. *AK

• 04/19/2000· ENGINE AND ENGINE COOLING

  TOYOTA SENT EXT. NOTICE 03/98. GOOD FOR 12 MONTHS, UP TO 100K MILES. ENGINE HEAD GASKETS DID NOT FAIL IN THAT TIME, BUT 24 MOS LATER AT ONLY 62K MILES, WELL UNDER 100K. STILL, TOYOTA WON'T EXTEND HONORING THE 1998 EXTENSION THOUGH RECORDS ON YOUR NHT

• 04/12/2016· ENGINE

  THIS SPECIFIC TOYOTA FORERUNNER MODEL HAD A RECALL FOR GASKET FAILURE. WE HAD IT REPLACED AT APPX 74,000 MILES DONE BY TOYOTA AS A COURTESY RECALL. THIS TRUCK CURRENTLY HAS VERY LOW MILEAGE CONSIDERING THE AGE OF THE TRUCK, ABOUT 148,000 MILES. IT RECENTLY ALMOST CAUGHT FIRE OVERHEATING AFTER ANOTHER GASKET FAILURE. WE FEEL THAT EITHER THE ORIGINAL REPAIR WAS NOT PROPERLY COMPLETED OR ANOTHER FAULTY GASKET WAS INSTALLED. IT'S AMAZING THAT BOTH TIMES THE GASKET FAILED AT AROUND THE SAME MILEAGE, 75,000. THIS CAR HAS BEEN EXTREMELY WELL MAINTAINED AND GARAGED WITH A SINGLE OWNER.